Study on the correlation between volatile fatty acids and gas production in dry fermentation of kitchen waste

Science.gov (United States)

Li, Qiangqiang; Ma, Yunfeng; Du, Boying; Wang, Qi; Hu, Qiongqiong; Bian, Yushan

2018-02-01

In this study, continuous kitchen waste fermentation and anaerobic digestion experiments were conducted to analyze the gas production potential, and to study the correlation between gas production rate and volatile fatty acid (VFAs) and its component concentration. During the experiment, the total solid(TS) concentration of the reaction system was increased by adding the kitchen waste, analysis of kitchen waste dry fermentation process to start, run, imbalance and imbalance after recovery and the parameters in the process of realizing the change trend and influencing factors of dry fermentation process, pH and ammonia concentration.

Cell growth and resistance of Lactococcus lactis subsp. lactis TOMSC161 following freezing, drying and freeze-dried storage are differentially affected by fermentation conditions.

Science.gov (United States)

Velly, H; Fonseca, F; Passot, S; Delacroix-Buchet, A; Bouix, M

2014-09-01

To investigate the effects of fermentation parameters on the cell growth and on the resistance to each step of the freeze-drying process of Lactococcus lactis subsp. lactis TOMSC161, a natural cheese isolate, using a response surface methodology. Cells were cultivated at different temperatures (22, 30 and 38°C) and pH (5·6, 6·2 and 6·8) and were harvested at different growth phases (0, 3 and 6 h of stationary phase). Cultivability and acidification activity losses of Lc. lactis were quantified after freezing, drying, 1 and 3 months of storage at 4 and 25°C. Lactococcus lactis was not damaged by freezing but was sensitive to drying and to ambient temperature storage. Moreover, the fermentation temperature and the harvesting time influenced the drying resistance of Lc. lactis. Lactococcus lactis cells grown in a whey-based medium at 32°C, pH 6·2 and harvested at late stationary phase exhibited both an optimal growth and the highest resistance to freeze-drying and storage. A better insight on the individual and interaction effects of fermentation parameters made it possible the freeze-drying and storage preservation of a sensitive strain of technological interest. Evidence on the particularly damaging effect of the drying step and the high-temperature storage is presented. © 2014 The Society for Applied Microbiology.

Characterisation and detection of spoilage mould responsible for black spot in dry-cured fermented sausages.

Science.gov (United States)

Lozano-Ojalvo, Daniel; Rodríguez, Alicia; Cordero, Mirian; Bernáldez, Victoria; Reyes-Prieto, Mariana; Córdoba, Juan J

2015-02-01

Moulds responsible for black spot spoilage of dry-cured fermented sausages were characterised. For this purpose, samples were taken from those dry-cured fermented sausages which showed black spot alteration. Most of the mould strains were first tentatively identified as Penicillium spp. due to their morphological characteristics in different culture conditions, with one strain as Cladosporium sp. The Cladosporium strain was the only one which provoked blackening in culture media. This strain was further characterised by sequencing of ITS1-5.8S-ITS2 rRNA and β-tubulin genes. This mould strain was able to reproduce black spot formation in dry-cured fermented sausage 'salchichón' throughout the ripening process. In addition, a specific and sensitive real-time PCR method was also developed to detect Cladosporium oxysporum responsible for the black spot formation in sausages. This method could be of great interest for the meat industry to detect samples contaminated with this mould before spoilage of product avoiding economic losses for this sector.

Continuous dry fermentation of swine manure for biogas production

Energy Technology Data Exchange (ETDEWEB)

Chen, Chuang; Zheng, Dan [Biogas Institute of Ministry of Agriculture, Chengdu 610041 (China); Liu, Gang–Jin [Biogas Institute of Ministry of Agriculture, Chengdu 610041 (China); Bioprocess Control AB, Scheelevägen 22, 223 63 Lund (Sweden); Deng, Liang–Wei, E-mail: dengliangwei@caas.cn [Biogas Institute of Ministry of Agriculture, Chengdu 610041 (China); Laboratory of Development and Application of Rural Renewable Energy, Ministry of Agriculture, Chengdu 610041 (China); Southwest Collaborative Innovation Center of Swine for Quality & Safety, Chengdu 611130 (China); Long, Yan; Fan, Zhan–Hui [Biogas Institute of Ministry of Agriculture, Chengdu 610041 (China)

2015-04-15

Highlights: • Continuous dry fermentation of swine manure for biogas production is feasible. • The feedstock TS concentration exerted a significant impact on biogas production. • Influences of ammonia and digestate liquidity were investigated in this study. • The results showed that the feedstock TS of swine manure should not exceed 30%. - Abstract: A down plug-flow anaerobic reactor (DPAR) was designed for the feasibility study on continuous dry fermentation of swine manure without any additional stirring. Using fresh swine manure as the feedstock with TS concentration (w/w) of 20%, 25%, 30%, and 35%, stable volumetric biogas production rates of 2.40, 1.92, 0.911, and 0.644 L·(L d){sup −1} and biogas yields of 0.665, 0.532, 0.252, and 0.178 L g{sup −1}VS were obtained respectively, and the TS degradation rates were 46.5%, 45.4%, 53.2%, and 55.6%, respectively. With the increase of feedstock TS concentration, the concentration of ammonia nitrogen grew up to the maximum value of 3500 mg L{sup −1}. Biogas production was obviously inhibited when the concentration of ammonia nitrogen was above 3000 mg L{sup −1}. The maximal volumetric biogas production rate of 2.34 L·(L d){sup −1} and biogas yield of 0.649 L g{sup −1}VS were obtained with TS concentration of 25% at 25 °C without inhibition. Liquidity experiments showed that TS concentration of digestate could be less than 15.8%, and the flow rate of digestate more than 0.98 m s{sup −1} when the feedstock TS concentration was less than 35%, which indicated the digestate could be easily discharged from a DPAR. Therefore, it is feasible to conduct a continuous dry fermentation in a DPAR using fresh swine manure as the feedstock with TS concentration less than 35%, whereas the feedstock TS concentration should not exceed 30% to achieve the maximal biogas production rate and biogas yield.

Continuous dry fermentation of swine manure for biogas production

International Nuclear Information System (INIS)

Chen, Chuang; Zheng, Dan; Liu, Gang–Jin; Deng, Liang–Wei; Long, Yan; Fan, Zhan–Hui

2015-01-01

Highlights: • Continuous dry fermentation of swine manure for biogas production is feasible. • The feedstock TS concentration exerted a significant impact on biogas production. • Influences of ammonia and digestate liquidity were investigated in this study. • The results showed that the feedstock TS of swine manure should not exceed 30%. - Abstract: A down plug-flow anaerobic reactor (DPAR) was designed for the feasibility study on continuous dry fermentation of swine manure without any additional stirring. Using fresh swine manure as the feedstock with TS concentration (w/w) of 20%, 25%, 30%, and 35%, stable volumetric biogas production rates of 2.40, 1.92, 0.911, and 0.644 L·(L d) −1 and biogas yields of 0.665, 0.532, 0.252, and 0.178 L g −1 VS were obtained respectively, and the TS degradation rates were 46.5%, 45.4%, 53.2%, and 55.6%, respectively. With the increase of feedstock TS concentration, the concentration of ammonia nitrogen grew up to the maximum value of 3500 mg L −1 . Biogas production was obviously inhibited when the concentration of ammonia nitrogen was above 3000 mg L −1 . The maximal volumetric biogas production rate of 2.34 L·(L d) −1 and biogas yield of 0.649 L g −1 VS were obtained with TS concentration of 25% at 25 °C without inhibition. Liquidity experiments showed that TS concentration of digestate could be less than 15.8%, and the flow rate of digestate more than 0.98 m s −1 when the feedstock TS concentration was less than 35%, which indicated the digestate could be easily discharged from a DPAR. Therefore, it is feasible to conduct a continuous dry fermentation in a DPAR using fresh swine manure as the feedstock with TS concentration less than 35%, whereas the feedstock TS concentration should not exceed 30% to achieve the maximal biogas production rate and biogas yield

Lipid oxidative changes in traditional dry fermented sausage Petrovská klobása during storage

Directory of Open Access Journals (Sweden)

Šojić Branislav V.

2014-01-01

Full Text Available The influence of drying and ripeninig conditions (traditional and industrial in the production of dry fermented sausage Petrovská klobása, on fatty-acid composition and oxidative changes in lipids, during 7 months of storage, was investigated. During the storage period, the sum of unsaturated fatty acids and the content of free fatty acids were significantly higher (p<0.05, while the content of malondialdehyde was significantly lower in the sausage subjected to traditional conditions of drying and ripening. At the end of the storage period, contents of pentanal and hexanal in the sausage subjected to traditional conditions of drying and ripening (4.03 μg/g and 1.67 μg/g, respectively were significantly lower (p<0.05 in comparison with these contents in the sausage subjected to industrial conditions of drying and ripening. Traditional conditions of drying and ripening at lower temperatures have led to lower oxidative changes in lipids in traditional dry fermented sausage Petrovská klobása during storage period. [Projekat Ministarstva nauke Republike Srbije, br. TR31032

Quantitative microbial risk assessment of Salmonella in dry fermented sausage (salami) in Southern Brazil

DEFF Research Database (Denmark)

Corbellini, Luis Gustavo; Costa, Eduardo de Freitas; Cardoso, Marisa

2017-01-01

Dry fermented sausage (salami) is a very popular ready-to-eat product in Southern Brazil, of which the raw materials can be contaminated with pathogens such as Salmonella. This product can put consumers at risk if a failure occurs during the manufacturing process. To investigate this risk...... and heterogeneous). In general, it was observed that the mean exposure to Salmonella due to ingestion of a portion of contaminated salami was very low; "zero risks" (with no cases of salmonellosis among 100,000 consumed portions of salami) were found in 65% of the scenarios (265/405) assessed and low risks were...... low, selling dry fermented sausage before complete maturation of the product and failure in fermentation can pose a risk to the consumers from the studied region. It was found that a maturation period of 24 days can be considered safe, even in a situation with high initial levels of contamination....

Traditional low-alcoholic and non-alcoholic fermented beverages consumed in European countries: a neglected food group.

Science.gov (United States)

Baschali, Aristea; Tsakalidou, Effie; Kyriacou, Adamantini; Karavasiloglou, Nena; Matalas, Antonia-Leda

2017-06-01

Fermented beverages hold a long tradition and contribution to the nutrition of many societies and cultures worldwide. Traditional fermentation has been empirically developed in ancient times as a process of raw food preservation and at the same time production of new foods with different sensorial characteristics, such as texture, flavour and aroma, as well as nutritional value. Low-alcoholic fermented beverages (LAFB) and non-alcoholic fermented beverages (NAFB) represent a subgroup of fermented beverages that have received rather little attention by consumers and scientists alike, especially with regard to their types and traditional uses in European societies. A literature review was undertaken and research articles, review papers and textbooks were searched in order to retrieve data regarding the dietary role, nutrient composition, health benefits and other relevant aspects of diverse ethnic LAFB and NAFB consumed by European populations. A variety of traditional LAFB and NAFB consumed in European regions, such as kefir, kvass, kombucha and hardaliye, are presented. Milk-based LAFB and NAFB are also available on the market, often characterised as 'functional' foods on the basis of their probiotic culture content. Future research should focus on elucidating the dietary role and nutritional value of traditional and 'functional' LAFB and NAFB, their potential health benefits and consumption trends in European countries. Such data will allow for LAFB and NAFB to be included in national food composition tables.

Cardboard proportions and total solids contents as driving factors in dry co-fermentation of food waste.

Science.gov (United States)

Capson-Tojo, Gabriel; Trably, Eric; Rouez, Maxime; Crest, Marion; Bernet, Nicolas; Steyer, Jean-Philippe; Delgenès, Jean-Philippe; Escudié, Renaud

2018-01-01

This study evaluated the influence of the co-substrate proportions (0-60% of cardboard in dry basis) and the initial total solid contents (20-40%) on the batch fermentation performance. Maximum hydrogen yields were obtained when mono-fermenting food waste at high solids contents (89mlH 2 ·gVS -1 ). The hydrogen yields were lower when increasing the proportions of cardboard. The lower hydrogen yields at higher proportions of cardboard were translated into higher yields of caproic acid (up to 70.1gCOD·kgCOD bio -1 ), produced by consumption of acetic acid and hydrogen. The highest substrate conversions were achieved at low proportions of cardboard, indicating a stabilization effect due to higher buffering capacities in co-fermentation. Clostridiales were predominant in all operational conditions. This study opens up new possibilities for using the cardboard proportions for controlling the production of high added-value products in dry co-fermentation of food waste. Copyright © 2017 Elsevier Ltd. All rights reserved.

Effect of starter cultures combinations on lipolytic activity and ripening of dry fermented sausages

Directory of Open Access Journals (Sweden)

Enver Baris Bingol

2014-11-01

Full Text Available The effect of starter culture combinations on the quality of Turkish type dry fermented sausage (sucuk were evaluated during ripening and storage periods. Sucuk formulations were produced without (control and with three different starter culture combinations; i Staphylococcus carnosus+Pediococcus pentosaceus, ii Staphylococcus carnosus+ Lactobacillus sakei, and iii Staphylococcus carnosus+Pediococcus pentosaceus+Lactobacillus sakei. Analysis of microbiological, physico-chemical and lipase enzyme levels of samples were conducted until the 60th day. Interactions among the presence of lipolytic starter cultures, lipase enzyme levels and thiobarbituric acid reactive substances were also evaluated both in ripening and drying periods. There were apparent differences on microbiological and chemical properties between samples prepared with starters and control. It has been concluded that the use of lipolytic starter cultures in suitable combination would have positive effect on the acceleration of ripening and improvement of the quality of dry fermented sausages.

Change in enzyme production by gradually drying culture substrate during solid-state fermentation.

Science.gov (United States)

Ito, Kazunari; Gomi, Katsuya; Kariyama, Masahiro; Miyake, Tsuyoshi

2015-06-01

The influence of drying the culture substrate during solid-state fermentation on enzyme production was investigated using a non-airflow box. The drying caused a significant increase in enzyme production, while the mycelium content decreased slightly. This suggests that changes in the water content in the substrate during culture affect enzyme production in fungi. Copyright © 2014 The Society for Biotechnology, Japan. Published by Elsevier B.V. All rights reserved.

Solid-state fermentation from dried sweet sorghum stalk for bioethanol production

Energy Technology Data Exchange (ETDEWEB)

Almodares, A.; Etemadifar, Z.; Omidi, A. [Univ. of Isfahan, Biology Dept., Univ. of Isfahan, Isfahan (Iran, Islamic Republic of)], e-mail: aalmodares@yahoo.com

2012-11-01

Due to depletion of global crude oil, countries are interested to alternate fuel energy resources. Presently bioethanol as a source of energy has been a subject of great interest for the industrialized countries. Therefore, there is need for efficient bioethanol production with low cost raw material and production process. Among energy crops, sweet sorghum is the best candidate for bioethanol production. It has been identified as having higher drought tolerance, lower input cost and higher biomass yield than other energy crops. In addition it has wide adoptability and tolerance to abiotic stresses. Moreover due to the shortage of water in dry and hot countries there is a need to reduce water requirement for bioethanol production and solid state fermentation could be the best process for making bioethanol in these countries. The purpose of this study is to achieve the highest ethanol production with lowest amount of water in solid state fermentation using sweet sorghum stalk. In this study the sweet sorghum particles were used for solid state fermentation. Fermentation medium were: sweet sorghum particles with nutrient media, active yeast powder and different moisture contents. The fermentation medium was incubated for 2-3 days at 30 deg C temperature. The results showed sweet sorghum particles (15% w/w) fermented in medium containing 0.5% yeast inoculums, 73.5% moisture content and 3 days incubation period produced the highest amount of ethanol (13% w/w sorghum)

Viability of L. casei during fermentation in soymilk and freeze-dried soymilk; effect of cryoprotectant, rehydration and storage temperature

Directory of Open Access Journals (Sweden)

Kristina Mladenovska

2005-12-01

Full Text Available The aim of the work was to investigate the behaviour of L. casei and the effect of sorbitol on its viability during fermentation in soymilk drink. Values for pH, ranging from 6.82 to 3.42 in the soymilk drink without sorbitol and from 6.74 to 3.41 in the drink with sorbitol were noted during 72 h of fermentation at 25oC. The corresponding values for titratable acidity ranged from 0.071% to 0.758% and from 0.073% to 0.761%, respectively. Soymilk was found to support the growth of L. casei with improvement in viability for 0.24 log at the end of fermentation when sorbitol was added. Survival of L. casei and the effectiveness of sorbitol in improving viability during freeze-drying, subsequent rehydration and during a 5-week period of storage under different temperatures were also investigated. After freeze-drying, L. casei exhibited a survival percent of approximately 46%. Sorbitol improved the viability of L. casei by 0.51 log immediately after freeze-drying and by 1.30 log and 0.47 log during five weeks of storage at 25oC and 4oC, respectively. Further study revealed that the freeze-dried fermented soymilk rehydrated at 45oC was optimum for the recovery of L. casei with improvement in recovery for 0.68 log when sorbitol was added. A higher percent of survival was noted when the dried soymilk was stored at 4oC than at 25oC with improved viability at the end of 5 weeks storage for approximately 6 log for drinks with and without sorbitol. Fermented dried soymilk with sorbitol afforded significant tolerance of L. casei to acid stress. Generally, a stable probiotic diary product was prepared in which the concentration of L. casei remained above therapeutic level of 107 cfu/ml.

Listeria monocytogenes presence during fermentation, drying and storage of Petrovská klobása sausage

Science.gov (United States)

Janković, V.; Mitrović, R.; Lakićević, B.; Velebit, B.; Baltić, T.

2017-09-01

The majority of human listeriosis cases appear to be caused by consumption of ready-to-eat (RTE) foods contaminated at the time of consumption with high levels of Listeria monocytogenes. Although strategies to prevent growth of L. monocytogenes in RTE products are critical for reducing the incidence of human listeriosis, this pathogen is highly difficult to control in fermented sausage processing environments due to its high tolerance to low pH and high salt concentration. The aims of the present study were to investigate the occurrence, presence and elimination of L. monocytogenes in Petrovská klobása sausage during processing, fermentation, drying and storage. L. monocytogenes, which was detected at the beginning of the production cycle, disappeared before day 30. The pathogen decline was much faster in those sausages which were dried in controlled, industrial conditions than in those dried applying the traditional, household technique.

Lipid oxidative changes in traditional dry fermented sausage Petrovská klobása during storage

OpenAIRE

Šojić, Branislav V.; Petrović, Ljiljana S.; Mandić, Anamarija I.; Sedej, Ivana J.; Džinić, Natalija R.; Tomović, Vladimir M.; Jokanović, Marija R.; Tasić, Tatjana A.; Škaljac, Snežana B.; Ikonić, Predrag M.

2014-01-01

The influence of drying and ripeninig conditions (traditional and industrial) in the production of dry fermented sausage Petrovská klobása, on fatty-acid composition and oxidative changes in lipids, during 7 months of storage, was investigated. During the storage period, the sum of unsaturated fatty acids and the content of free fatty acids were significantly higher (p

Effects of protectant and rehydration conditions on the survival rate and malolactic fermentation efficiency of freeze-dried Lactobacillus plantarum JH287.

Science.gov (United States)

Lee, Sae-Byuk; Kim, Dong-Hwan; Park, Heui-Dong

2016-09-01

In this study, Lactobacillus plantarum JH287 was used as a malolactic fermentation starter in Campbell Early wine production. L. plantarum JH287 was first lyophilized, and the malolactic fermentation potential of freeze-dried L. plantarum JH287 was investigated. Different protective media and rehydration conditions were tested to improve the survival rate of freeze-dried L. plantarum JH287. Optimal protective medium contained 10 % sorbitol and 10 % skim milk. The optimal rehydration condition was a 1-h rehydration time conducted in the same protective media, and the combination of these two methods produced a survival rate of 86.37 %. In addition, a 77.71 % survival rate was achieved using freeze-dried samples that were stored at 4 °C for 2 months. Freeze-dried L. plantarum JH287 and Saccharomyces cerevisiae Fermivin were used to inoculate the Campbell Early grape must to decrease its malic acid content. Using this mixed-fermentation method, wine showed a decrease in malic acid content after 9 days of fermentation. GC-MS analysis detected 15 volatile ester compounds in the wine. A sensory evaluation showed that the taste and aroma of mix-fermented wine were better than those of the control that had not been inoculated with L. plantarum JH287.

Evaluation of the processing of dry biological ferment for gamma radiation

International Nuclear Information System (INIS)

Sabundjian, Ingrid Traete

2007-01-01

The developed work had with objectives to demonstrate if it had alteration in the growth of UFC in plate and in the viability of yeasts and total bacteria when dry biological ferment was dealt with by different doses to gamma radiation and under different times storage, to determine the D10 dose for total bacteria and yeasts in this product and to analyzed the processing of this product it promoted some benefit without causing unfeasibility of exactly. The different samples of dry biological ferment had been irradiated at IPEN in a Gammacell - 220 source at 0.5; 1; 2 and 3 kGy doses (dose rate of 3.51 kGy/h). This procedure referring samples to each dose of radiation had been after destined to the microbiological analysis and the test of viability while excessively the samples had been stored the ambient temperature (23 degree C). The increase of the dose of radiation caused a reduction in the counting of yeasts growth, of total bacteria growth and also in the frequency of viable yeast cells, demonstrated by FDA-EB fluorescent method. Beyond of radiation the storage time also it influenced in counting reduction of total bacteria and reduction of frequency of viable cells. According with the analysis of simple linear regression, the dose of radiation necessary to eliminate 90% of the yeast population was between 1.10 and 2.23 kGy and for the bacterial population varied between 2.31 and 2.95 kGy. These results demonstrated clearly the negative points of the application of ionizing radiation in dry biological ferment; therefore the interval of D10 found for total bacteria is superior to found for yeasts. Being thus, the use of this resource for the improvement of the product quality becomes impracticable, since to reduce significantly the bacterial population necessarily we have that to diminish the population of yeasts. With yeasts reduction of we will go significantly to modify the quality and the viability of product. (author)

Potential of bacteriocins from lab to improve microbial quality of dry-cured and fermented meat products.

Science.gov (United States)

Kęska, Paulina; Stadnik, Joanna; Zielińska, Dorota; Kołożyn-Krajewska, Danuta

2017-01-01

Meat and meat products are an important component of the daily diet. Nevertheless, they are perishable goods and are prone to microbial contamination, which leads to an increased risk to the health of consumers as well as economic losses in the meat industry. Fermentation has been used for thousands of years to preserve meat. As a result of extensive biochemical reactions occurring in meat during fermentation and ripening, the condi- tions inhibiting the growth of pathogenic and spoilage bacteria are formed. These changes are catalyzed by endogenous meat enzymes and exogenous enzymes derived from natural contaminating bacteria or starter cultures applied. In dry-cured and fermented meat products they are represented mainly by lactic acid bacte- ria (LAB) that produce a wide range of compounds, such as bacteriocins, directed against other microorgan- isms. The use of bactericidal peptides does not affect the sensory quality of foodstuffs, so that they attract attention as alternative means of preserving the stability and safety of dry-cured products.

Implantation ability of the potential probiotic strain, Lactobacillus reuteri PL519, in "Salchichón," a traditional Iberian dry fermented sausage.

Science.gov (United States)

Ruiz-Moyano, Santiago; Martín, Alberto; Benito, María José; Aranda, Emilio; Casquete, Rocío; Córdoba, María de Guia

2011-01-01

The purpose of this study was to investigate the potential of incorporating the probiotic L. reuteri PL519 into the manufacturing of Iberian dry fermented sausages, and to observe its effect on the sensory properties of these meat products. Specific polymerase chain reaction (PCR) was carried out to detect the presence of probiotic strain at high counts in the inoculated sausages. Changes due to probiotic inoculation on physicochemical parameters were determined and the impact on sensory quality evaluated. Dry fermented sausages inoculated with L. reuteri PL519 may be considered as functional products according to the counts of this strain found at the end of processing. Inoculation with L. reuteri PL519 increased the amount of acetic acid, protein, and lipid degradation products in dry fermented sausages. The differences observed in the descriptive sensorial analysis corresponded, however, to a little impact on overall acceptability since no significant changes were found between the control and L. reuteri PL519 batch in the hedonic test. Processing and marketing of Iberian dry fermented sausages with functional characteristics. © 2011 Institute of Food Technologists®

2-acetyl-1-pyrroline - key aroma compound in Mediterranean dried sausages

DEFF Research Database (Denmark)

Stahnke, Marie Louise Heller

2000-01-01

In a study characterising sausage types from various parts of Europe, ten Mediterranean and Northern European fermented, dried sausages were compared using static headspace gas chromatography-olfactometry and a sniffing panel of five members. The greatest difference between the Northern...

Dry fermented buffalo sausage with sage oil extract: Safety and quality

Directory of Open Access Journals (Sweden)

Ibrahim, Hayam M.

2010-03-01

Full Text Available Sage oil extract was added during the preparation of dry fermented buffalo meat sausage. Some chemical, microbial and sensory characteristics of sausages were evaluated during the ripening period. In particular, pH, lipid oxidation, biogenic amines and micro flora were analyzed. Results of this study pointed out that sage oil extract as natural antioxidant could be utilized in dry fermented sausage, prepared from buffalo meat, in order to obtain a final product within acceptable lipid oxidation and biogenic amine levels, as well as improved sensory quality.Extractos de aceite de salvia fueron añadidos a embutidos de carne de búfalo. Las características químicas, microbiológicas y sensoriales de los embutidos fueron evaluadas durante el periodo de maduración. En particular, pH, oxidación lipídica, aminas biogénicas y microflora fueron analizadas. Los resultados de este estudio indican que los extractos de aceite de salvia, como antioxidantes naturales, podrían ser utilizados en embutidos preparados con carnes de búfalo, con objeto de obtener un producto final con unos niveles de aminas biogénicas y de oxidación lipídica aceptable, así como con una calidad sensorial mejorada.

Characterization of lactic acid bacteria isolated from Bosnian artisanal dry fermented sausage (sudžuk during fermentation

Directory of Open Access Journals (Sweden)

Čolo Josip

2015-01-01

Full Text Available Bosnian sudžuk is a dry fermented sausage produced in a rural household near the town of Visoko in central Bosnia and Herzegovina. This kind of sausage was manufactured only from beef and spices in a traditional way without the addition of a starter cultures. To identify lactic acid bacteria (LAB, a total number of 160 Lstrains were isolated from five samples of Bosnian sudžuk collected over 28 days of fermentation. Preliminary identification by phenotypic tests and 16S rDNA sequencing were performed for all 160 of the Lisolates. Identification of Lstrains from traditionally produced Bosnian sausage at the species level revealed the presence of six genera: Lactococcus sp., Enterococcus sp., Leuconostoc sp., Lactobacillus sp., Pediococcus sp. and Weissella sp.. Among the 15 distinct species identified, the species Lactobacillus plantarum, Leuconostoc mesenteroides, Lactococcus lactis, Enterococcus faecalis and Enterococcus durans were present throughout the entire process of fermentation. Leuconostoc mesenteroides, Lactobacillus plantarum and Lactococcus lactis prevailed, with 21.8%, 19.3% and 13.1%, respectively, of total Lstrains during the entire fermentation process. Significant negative correlations (r = 0.892 and r = 0.829, respectively between the presence of Weissella sp. and Lactobacillus sp., and between the presence of Weissella sp. and Lactococcus sp. were recorded. Lactobacillus plantarum, Enterococcus durans and Leuconostoc mesenteroides were the best producers of aromogenic compounds while 32.3% of Lactobacillus plantarum and 28.6% of Leuconostoc mesenteroides were produced exopolysaccharides. [Projekat Ministarstva nauke Republike Srbije, br. 173019

Modeling the survival of Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella Typhimurium during fermentation, drying, and storage of soudjouk-style fermented sausage.

Science.gov (United States)

Hwang, Cheng-An; Porto-Fett, Anna C S; Juneja, Vijay K; Ingham, Steven C; Ingham, Barbara H; Luchansky, John B

2009-02-28

This study quantified and modeled the survival of Escherichia coli O157:H7, Listeria monocytogenes and Salmonella Typhimurium in soudjouk-style fermented sausage during fermentation, drying, and storage. Batter prepared from ground beef (20% fat), seasonings, starter culture, and dextrose was separately inoculated with a multi-strain mixture of each pathogen to an initial inoculum of ca. 6.5 log(10) CFU/g in the batter. The sausages were subsequently fermented at 24 degrees C with a relative humidity (RH) of 90% to 95% for 3 to 5 days to ca. pH 5.2, pH 4.9 or pH 4.6, then dried at 22 degrees C to a(w) 0.92, a(w) 0.89, or a(w) 0.86, respectively, and then stored at 4, 21, or 30 degrees C for up to 60 days. Lethality of the three pathogens was modeled as a function of pH, a(w) and/or storage temperature. During fermentation to pH 5.2 to pH 4.6, cell reductions ranged from 0 to 0.9 log(10) CFU/g for E. coli O157:H7, 0.1 to 0.5 log(10) CFU/g for L. monocytogenes, and 0 to 2.2 log(10) CFU/g for S. Typhimurium. Subsequent drying of sausages of pH 5.2 to pH 4.6 at 22 degrees C with 80% to 85% RH for 3 to 7 days to a(w) of 0.92 to a(w) 0.86 resulted in additional reductions that ranged from 0 to 3.5 log(10) CFU/g for E. coli O157:H7, 0 to 0.4 log(10) CFU/g for L. monocytogenes, and 0.3 to 2.4 log(10) CFU/g for S. Typhimurium. During storage at 4, 21, or 30 degrees C the reduction rates of the three pathogens were generally higher (pfermentation, drying, and storage. The applicability of the resulting models for fermented sausage was evaluated by comparing model predictions with published data. Pathogen reductions estimated by the models for E. coli O157:H7 and S. Typhimurium were comparable to 67% and 73% of published data, respectively. Due to limited published data for L. monocytogenes, the models for L. monocytogenes would need additional validations. Results of pathogen reductions from this study may be used as a reference to assist manufacturers of soudjouk

Continuous dry fermentation of swine manure for biogas production.

Science.gov (United States)

Chen, Chuang; Zheng, Dan; Liu, Gang-Jin; Deng, Liang-Wei; Long, Yan; Fan, Zhan-Hui

2015-04-01

A down plug-flow anaerobic reactor (DPAR) was designed for the feasibility study on continuous dry fermentation of swine manure without any additional stirring. Using fresh swine manure as the feedstock with TS concentration (w/w) of 20%, 25%, 30%, and 35%, stable volumetric biogas production rates of 2.40, 1.92, 0.911, and 0.644L · (Ld)(-1) and biogas yields of 0.665, 0.532, 0.252, and 0.178 L g(-)(1)VS were obtained respectively, and the TS degradation rates were 46.5%, 45.4%, 53.2%, and 55.6%, respectively. With the increase of feedstock TS concentration, the concentration of ammonia nitrogen grew up to the maximum value of 3500 mg L(-1). Biogas production was obviously inhibited when the concentration of ammonia nitrogen was above 3000 mg L(-1). The maximal volumetric biogas production rate of 2.34 L ·(Ld)(-1) and biogas yield of 0.649 L g(-1)VS were obtained with TS concentration of 25% at 25°C without inhibition. Liquidity experiments showed that TS concentration of digestate could be less than 15.8%, and the flow rate of digestate more than 0.98 m s(-1) when the feedstock TS concentration was less than 35%, which indicated the digestate could be easily discharged from a DPAR. Therefore, it is feasible to conduct a continuous dry fermentation in a DPAR using fresh swine manure as the feedstock with TS concentration less than 35%, whereas the feedstock TS concentration should not exceed 30% to achieve the maximal biogas production rate and biogas yield. Copyright © 2015 Elsevier Ltd. All rights reserved.

Multi-Residue studies of pesticides in fermented dried cocoa beans and selected cocoa products produced in Ghana

International Nuclear Information System (INIS)

Frimpong, S. K

2011-01-01

the organochlorine, organophosphorous and synthetic pyrethroids pesticides respectively. Multivariate analysis on the residue data obtained from fermented dried cocoa beans in R-mode and Q-mode grouped the detected pesticides into currently used, previously used and drift from neighbouring crops pesticides applications. It also grouped sampled cocoa beans into four major clusters based on similarities in crop storage and farm practices. Beta-HCH (18.7 μg/kg), Gamma-chlordane (152.0 μg/kg), Methamidophos (18.5 μg/kg), Profenofos (31.8 μg/kg), Allethrin (10.5 μg/kg), Cypermethrin (32.0 μg/kg) and Fenvalerate (14.6 μg/kg) were the average residues concentrations of pesticides that exceeded the Japanese maximum residue levels (MRLs). However, all the detected pesticides with exception of Allethrin were below the MRLs for European Union. From results recorded in semi-finished and finished cocoa beans products produced in Ghana, de-shelling and roasting temperatures drastically reduced the residue levels in the cocoa products, but these were not enough solution for pesticide residues in cocoa beans. And thus raises concern about the health implication of these chemicals for domestic consumption of these products. It is highly recommended that a national quality control laboratory be established to continually monitor pesticides efficacy in order to avoid overdose of pesticides application.[au

Effects of wheat dried distillers' grains with solubles and cinnamaldehyde on in vitro fermentation and protein degradation using the Rusitec technique.

Science.gov (United States)

Lia, Yangling; He, Maolong; Li, Chun; Forster, Robert; Beauchemin, Karen Anne; Yang, Wenzhu

2012-04-01

This study was conducted to evaluate the effect of wheat dried distillers' grains with solubles (DDGS) and cinnamaldehyde (CIN) on in vitro fermentation and microbial profiles using the rumen simulation technique. The control substrate (10% barley silage, 85% barley grain and 5% supplement, on dry matter basis) and the wheat DDGS substrate (30% wheat DDGS replaced an equal portion of barley grain) were combined with 0 and 300 mg CIN/l of culture fluid. The inclusion of DDGS increased (p fermentation pattern changed to greater acetate and less propionate proportions (p fermentability and potentially increase protein flows to the intestine. Supplementation of high-grain substrates with CIN reduced methane production and potentially increased the true protein reaching the small intestine; however, overall reduction of feed fermentation may lower the feeding value of a high-grain diet.

Drying process of fermented inulin fiber concentrate by Bifidobacterium bifidum as a dietary fiber source for cholesterol binder

Science.gov (United States)

Susilowati, Agustine; Aspiyanto, Ghozali, Muhammad

2017-11-01

Fermentation on inulin hydrolysate as fructooligosaccharides (FOS) by Bifidobacterium bifidum as a result of hydrolysis by inulase enzyme of Scopulariopsis sp.-CBS1 fungi has been performed to bind cholesterol. Their applications on preparation of fermented pour beverages was conducted via a series of concentration process using dead-end Stirred Ultrafiltration Cell (SUFC) mode at stirrer rotation of 400 rpm, room temperature and pressure of 40 psia for 0 minute (pre-concentration process) as concentrate (A) and 45 minutes as concentrate (B), and drying process using vacuum dryer at 30 °C and 22 cm Hg for 0, 8, 16, 24, 32, 40 and 48 hours. Based on optimization of Total Dietary Fiber (TDF), the best time of drying process was achieved for 40 hours. Long time of drying process would increase TDF and total solids, decreased total acids, and fluctuated dissolved protein and Cholesterol Binding Capacity (CBC). At the optimum condition of drying process was get fermented inulin fiber powder from concentration processes using both UF as pre process (0 minute) as concentrate (A) and UF for 45 minutes as concentrate (B) with compositions of total solids of 92.31 % and 93.67 %, TDF of 59.07 % (dry weight) and 69.28 %, total acids of 7.03 % and 7.5 %, dissolved protein of 3.95 mg/mL and 3.05 mg/mL, and CBC pH 2 15.71 mg/g and 16.8 mg/g, respectively. Concentration process through dead-end SUFC mode gave distribution of particles with better smoothness level than without through dead-end SUFC mode.

Fat Reduction and Replacement in Dry-Cured Fermented Sausage by Using High Pressure Processing Meat as Fat Replacer and Olive Oil

Directory of Open Access Journals (Sweden)

Bolumar Tomas

2015-09-01

Full Text Available The present paper describes the modification of the lipid fraction of dry-cured fermented sausage through fat reduction (35% and fat replacement of animal fat with olive oil (up to 10%. High pressure processing (HPP treated meat was employed as a novel fat replacer to reduce the fat content and as a new strategy to enable a stable incorporation of olive oil in dry-cured fermented sausages. Chemical (proximate composition and fatty acid profile, physical (water retention, structure formation and colour and sensorial (appearance, texture and flavour properties were evaluated. It is concluded that 35% of fat reduction is possible without reduction of consumer acceptability. Moreover, the addition of HPP-treated meat as a fat replacer resulted in good mimic of the fat particles together with good physical and sensory properties. Therefore, it resulted in an effective and clean alternative (no added-additives for fat reduction. However, the incorporation of olive oil either by direct addition (4.3% oil or within a HPP-created protein network (10% oil resulted in unacceptable products since the oil was not properly retained inside the sausage matrix. Further studies are needed to find processing strategies that permit a stable incorporation of liquid plant oils to dry-cured fermented sausage for the development of healthier and more sustainable dry-cured fermented meat products.

Impact of casing damaging on aflatoxin B1 concentration during the ripening of dry-fermented meat sausages.

Science.gov (United States)

Pleadin, Jelka; Kovačević, Dragan; Perković, Irena

2015-01-01

The aim of this article is to investigate the impact of casing damaging on the formation of aflatoxin B1 (AFB1) during the ripening of dry-fermented meat sausages. The level of AFB1 contamination was determined in 24 samples using the ELISA immunoassay throughout a six-month production period. While with intact casing samples no contamination was observed throughout the whole production process, in damaged casing samples AFB1 was detected in the ripening end-stages in the range of 1.62-4.49 μg/kg. The results showed that casing damaging occurring during long-term ripening of dry-fermented sausages can cause AFB1 contamination, possibly arising on the grounds of diffusion of this mycotoxin from the product surface to its interior.

COMPARISON OF COMMERCIAL DNA KITS AND TRADITIONAL DNA EXTRACTION PROCEDURE IN PCR DETECTION OF PORK IN DRY/FERMENTED SAUSAGES

Directory of Open Access Journals (Sweden)

Ivona Djurkin Kušec

2015-09-01

Full Text Available In the present study four commercially available DNA extraction kits (Wizard® Genomic DNA Purification Kit, High Pure PCR Template Kit, DNeasy mericon Food and GeneJET PCR Purification Kit, as well as standard phenol/chloroform isolation technique have been evaluated regarding their concentration, purity and suitability for amplification of porcine DNA in dry/fermented sausages. The isolates were assessed for quantity and quality using spectrophotometer (IMPLEN GmbH, Germany. To verify template usability and quality of isolated DNA, the polymerase chain reaction (PCR targeting at porcine cytochrome b by species specific primers was used. The comparison of extraction methods revealed satisfactory efficiency and purity of all extraction kits, while with standard phenol/chloroform isolation method high concentrations of DNA with low A260/280 were obtained. However, all the investigated techniques proved to be suitable for identification of porcine DNA in dry/fermented sausage. Thus, the standard phenol/chloroform DNA extraction method, as the cost-effective one, can be recommended as a good alternative to more expensive isolation kits when investigating the presence of pork DNA in dry/ fermented meat products.

Characterization of biomasses, concentrates, and permeates of dried powder of Kombucha fermentation of spinach (Amaranthus sp.) and broccoli (Brassica oleracea) with membrane microfiltration and freeze drying techniques for natural sources of folic acid

Science.gov (United States)

Nugraha, Tutun; Susilowati, Agustine; Aspiyanto, Lotulung, Puspa Dewi; Maryati, Yati

2017-11-01

Fermentation of spinach (Amaranthus sp) and Broccoli (Brassica oleracea) using Kombucha Culture has been shown to produce biomass that has the potential to become natural sources of folic acid. To produce the materials, following the fermentation, the biomass was filtered using membrane microfiltration (0.15 µm) at a pressure of 40 psia, at room temperature, yielding the concentrate and the permeate fractions. Following this step, freeze drying process was done on the biomass feeds, as well as on the concentrate and permeate fractions. For the freeze drying stage, the samples were frozen, and the condenser was kept at -50°C for 40 hours, while the pressure in the chamber was set at 200 Pa. Freeze drying results showed that the final products, have differences in compositions, as well as differences in the dominat monomers of folates. After water content was driven out, freeze drying increased the concentrations of folic acid in the dried products, and was found to be the highest in the concentrate fractions. Freeze drying has been shown to be capable of protecting the folates from heat and oxidative damages that typicaly occur with other types of drying. The final freeze dried concentrates of fermentation of spinach and broccoli were found to contain folic acid at 2531.88 µg/mL and 1626.94 µg/mL, total solids at 87.23% and 88.65 %, total sugar at 22.66 µg/mL and 25.13 µg/mL, total reducing sugar at 34.46 mg/mL and 15.22 mg/mL, as well as disolved protein concentrations at 0.93 mg/mL and 1.45 mg/mL. Liquid Chromatography Mass Spectometry (LC-MS) identification of the folates in the freeze dried concentrates of fermented spinach and broccoli was done using folic acid and glutamic acid standard solutions as the reference materials. The results showed the presence of folic acid and showed that the dominant monomers of molecules of folates with molecular weights of 441.44 Da. and 441.54 Da. for spinach and broccoli respectively. Moreover, the monomers of glutamic

Effects of Freeze-dried Mulberry on Antioxidant Activities and Fermented Characteristics of Yogurt during Refrigerated Storage

OpenAIRE

Sung, Jung-Min; Kim, Young-Boong; Kum, Jun-Seok; Choi, Yun-Sang; Seo, Dong-Ho; Choi, Hyun-Wook; Park, Jong-Dae

2015-01-01

This study investigated the effect of added freeze-dried mulberry fruit juice (FDMJ) (1, 3 and 5%) on the antioxidant activity and fermented characteristic of yogurt during refrigerated storage. A decrease in pH of yogurt and increase in acidity was observed during fermentation. The yogurts with FDMJ exhibited faster rate of pH reduction than control. Initial lactic acid bacteria count of yogurt was 6.49-6.94 Log CFU/g and increased above 9 Log CFU/g in control and 1% in FDMJ yogurt for 24 h....

Further development of the BEKON dry fermentation process for hygienisation of substrates in the fermenter according to BioAbfV; Weiterentwicklung der BEKON-Trockenfermentation ermoeglicht die Hygienisierung der Substrate gemaess BioAbfV im Fermenter

Energy Technology Data Exchange (ETDEWEB)

Liebeneiner, Rolf; Lutz, Peter [Bekon Energy Technologies GmbH und Co. KG, Unterfoehring (Germany)

2012-11-01

In the draft amendment to the BioAbfV (BMU, 2011), temperatures and times of residue to ensure hygienisation of substrates for thermophilic fermentation were revised on the basis of EU law on animal by-products and fertilizer law and on the basis of practical experience with the directive and recent research findings on hygienisation of biomass waste. To test the process, the required thermophilic process temperature of 50 must be ensured for the totality of substrates for a minimum time of residue. The fermentation substrates are then tested for phytohygiene and epidemic hygiene. BEKON developed their patented fermenter heating system into the world's first batch dry fermentation plant for hygienisation inside the fermenter, which was commissioned in 2010 at Spiez, Switzerland. The plant was capable of ensuring the required temperature levels and substrate hygienisation standards. The advanced thermophilic BEKON dry fermentation process thus ensures reliable hygienisation of substrates already inside the fermenter, without aerobic post-treatment of fermenation residues. This simplifies process monitoring in the subsequent composting stage. (orig.) [German] Im Entwurf zur Novellierung der BioAbfV (BMU, 2011) wurden die erforderlichen Temperaturen und Verweilzeiten zur Sicherstellung der Hygienisierung der Substrate fuer die thermophile Vergaerung ueberarbeitet. Grundlage hierfuer waren unter anderem sowohl neue und geaenderte rechtlicher Vorschriften des EU-Rechts ueber die tierischen Nebenprodukte und des Duengerechts, als auch Praxiserfahrungen seit Inkrafttreten der Verordnung und neue Forschungsergebnisse zur Hygienisierung von Bioabfaellen. Die Prozesspruefung muss dabei so vorgenommen werden, dass ueber einen zusammenhaengenden Zeitraum (der sogenannten Mindestverweilzeit) die geforderte thermophile Behandlungstemperatur von mindestens 50 C auf die gesamten Substrate einwirkt. Die seuchen- und phytohygienische Unbedenklichkeit der Gaersubstrate ist dabei

Novel technology development through thermal drying of encapsulated Kluyveromyces marxianus in micro- and nano-tubular cellulose in lactose fermentation and its evaluation for food production.

Science.gov (United States)

Papapostolou, Harris; Servetas, Yiannis; Bosnea, Loulouda A; Kanellaki, Maria; Koutinas, Athanasios A

2012-12-01

A novel technology development based on the production of a low-cost starter culture for ripening of cheeses and baking is reported in the present study. The starter culture comprises thermally dried cells of Kluyveromyces marxianus encapsulated in micro- and nano-tubular cellulose. For production of a low-cost and effective biocatalyst, whey was used as raw material for biomass production and thermal drying methods (convective, conventional, and vacuum) were applied and evaluated at drying temperatures ranging from 35 to 60 °C. The effect of drying temperature of biocatalysts on fermentability of lactose and whey was evaluated. Storage stability and suitability of biocatalysts as a commercial starter cultures was also assessed and evaluated. All thermally dried biocatalysts were found to be active in lactose and whey fermentation. In all cases, there was sugar conversion ranging from 92 to 100 %, ethanol concentration of up to 1.47 % (v/v), and lactic acid concentrations ranged from 4.1 to 5.5 g/l. However, convective drying of the encapsulated cells of K. marxianus in micro- and nano-tubular cellulose was faster and a more effective drying method while drying at 42 °C appear to be the best drying temperature in terms of cell activity, ethanol, and lactic acid formation. Storage of the biocatalysts for 3 months at 4 °C proved maintenance of its activity even though fermentation times increased by 50-100 % compared with the fresh dried ones.

Effect of spices commercial mixture with GDL on the quality of fermented dry-cured sausages

Directory of Open Access Journals (Sweden)

Miroslav Kročko

2016-06-01

Full Text Available The main fermented meat products are fermented sausages in which lactic acid bacteria (LAB are the essential agents of the ripening process. Their application as starter organisms ensures the dominance of the starter during the whole ripening process. However, when no starter cultures are used, direct addition of acids like a glucono-delta-lactone (GdL is preferred. The goal of this study was to determine the influence of commercial spices mixtur (containing GdL on selected technological parameters of fermented dry-cured sausages - Danube sausage in comparison with currently available conventional spices. Comparison was evaluated also with addition of starter cultures. Determinations of technological (value of pH, water activity, color and microbiological properties (count of Lactobacillus spp., Enterobacteriaceae family, yeasts and moulds were realized after 24 hours, 5 and 30 days. The sensory analysis of sausages was carried out after 30 days of ripening process. In sausages with the addition of commercial spice mixture in combination with starter culture were determined the lowest values of pH and aw at the end of ripening process (30 days. Bacteria of Enterobacteriaceae family were occurred in the samples with the addition of currently available conventional spices at the beginning of ripening, but after 5 days of ripening were bacteria of this family not detected. The counts of yeasts in analyzed samples were not detected. Counts of LAB at the end of ripening proccess (30 days were lower in coparison with result obtained after 5 days; however their count was comparable with count determined at the beginig of the ripening. Our results show, that the combination of starter culture and commercial spice mixture containig GdL may cause excesive sour taste and sensory defect of dry fermented meat products.

Continuous alcoholic fermentation of molasses

Energy Technology Data Exchange (ETDEWEB)

Kazimierz, J

1962-01-01

The first Polish plant for ontinuous alcohol fermentation of molasses is described. Continuous fermentation permits a better use of the installation, automatic control, and shorter fermentation time. It yields more CO/sub 2/ for dry ice manufacture and decreases corrosion of apparatus. From 22 to 24% mash is used, giving a yield of 61.1 of 100-proof alc./kg. sucrose and an average of 37 kg. of dry yeast/1000 l. alcohol

Effect of caliber size and fat level on the inactivation of E. coli O157:H7 in dry fermented sausages.

Science.gov (United States)

De Souza, James; Ahmed, Rafath; Strange, Philip; Barbut, Shai; Balamurugan, S

2018-02-02

Dry fermented sausages (DFS) have been subject to numerous validation studies, as pathogen reduction heavily relies on both ingredients and processing. In this study the effect of product caliber size (32, 55, 80mm), and fat level (low, 9.67%; high, 18.46% wt/wt) on the inactivation of E. coli O157:H7 during DFS production was examined. Sausages containing a five-strain cocktail of E. coli O157:H7 at 10 7 CFU/g were manufactured and monitored for changes in physicochemical properties and inoculated E. coli O157:H7 numbers were enumerated during the DFS production stages and log reduction rates were calculated. Significant (P0.05) different among sausages of different caliber size or fat levels. No significant (P>0.05) reduction in a w was observed during fermentation of the sausages. However, during the drying phase, sausages with larger caliber sizes required a significantly longer duration of drying to achieve the same a w of smaller caliber size sausages. For instance, to achieve an a w of ≤0.9, following 5days of fermentation/curing, 80mm caliber sausages required up to 27days of drying compared with 13 and 6days for 55 and 32mm caliber size sausages, respectively. Fat levels on the other hand did not significantly (P>0.05) effect the reduction of a w during drying of the sausages. During the fermentation stage there was a significant and rapid reduction in E. coli O157:H7 counts by about 1.1- to 1.4-log units, but was not significantly different among sausages of different caliber size and fat levels. Considering the whole process, only caliber size had a significant effect on log reduction of E. coli O157:H7. ANOVA of log reduction rates of E. coli O157:H7 among sausages of different caliber size and fat levels revealed no significant differences during the fermentation, however, during the drying of the sausages, log reduction rate of E. coli O157:H7 was significantly (PE. coli O157:H7 in high fat large caliber sausages was the lowest at -0.082±0.004 log

Effect of harvest time on fermentation profiles of maize ensiled in laboratory silos and determination of drying losses at 60°C

DEFF Research Database (Denmark)

Nielsen, Tina Skau; Kristensen, Niels Bastian; Weisbjerg, Martin Riis

2007-01-01

The objectives were to investigate the effect of premature ensiling of maize on alcohol fermentation in laboratory silos and the loss of fermentation products and glucose in silage following drying at 60°C for 48 h. During four consecutive weeks maize was harvested and ensiled for 60 days in vacuum-sealed...

Selection and evaluation of Debaryomyces hansenii isolates as potential bioprotective agents against toxigenic penicillia in dry-fermented sausages.

Science.gov (United States)

Núñez, Félix; Lara, María S; Peromingo, Belén; Delgado, Josué; Sánchez-Montero, Lourdes; Andrade, María J

2015-04-01

Biocontrol using autochthonous Debaryomyces hansenii isolates is a potentially suitable strategy for inhibiting toxigenic moulds in dry-cured meat products. The antifungal activity of 280 D. hansenii isolated from dry-cured meat products as well as the mode of action of the most active isolates against toxigenic penicillia were evaluated in this work. A 13.9% of the D. hansenii isolates showed inhibitory activity in a radial inhibition assay. The effects on penicillia growth of both the cell-free culture filtrate and volatile compounds from active yeast isolates were analysed. Penicillia growth inhibition by D. hansenii was probably based on additive or synergistic effects of several inhibiting factors such as competition for nutrient and space, and production of soluble or volatile compounds. When four D. hansenii isolates were tested on dry-fermented sausage, two of them produced a significantly growth reduction of the ochratoxigenic Penicillium verrucosum, keeping its counts under the level considered as hazardous for the mycotoxin presence. Therefore, the use of these two D. hansenii isolates during the processing of dry-fermented meat product could be a promising tool to control toxigenic moulds in the meat industry. Copyright © 2014 Elsevier Ltd. All rights reserved.

Production of ethanol and feed by high dry matter hydrolysis and fermentation of palm kernel press cake.

Science.gov (United States)

Jørgensen, Henning; Sanadi, Anand R; Felby, Claus; Lange, Niels Erik Krebs; Fischer, Morten; Ernst, Steffen

2010-05-01

Palm kernel press cake (PKC) is a residue from palm oil extraction presently only used as a low protein feed supplement. PKC contains 50% fermentable hexose sugars present in the form of glucan and mainly galactomannan. This makes PKC an interesting feedstock for processing into bioethanol or in other biorefinery processes. Using a combination of mannanase, beta-mannosidase, and cellulases, it was possible without any pretreatment to hydrolyze PKC at solid concentrations of 35% dry matter with mannose yields up to 88% of theoretical. Fermentation was tested using Saccharomyces cerevisiae in both a separate hydrolysis and fermentation (SHF) and simultaneous saccharification and fermentation (SSF) setup. The hydrolysates could readily be fermented without addition of nutrients and with average fermentation yields of 0.43 +/- 0.02 g/g based on consumed mannose and glucose. Employing SSF, final ethanol concentrations of 70 g/kg was achieved in 216 h, corresponding to an ethanol yield of 70% of theoretical or 200 g ethanol/kg PKC. Testing various enzyme mixtures revealed that including cellulases in combination with mannanases significantly improved ethanol yields. Processing PKC to ethanol resulted in a solid residue enriched in protein from 17% to 28%, a 70% increase, thereby potentially making a high-protein containing feed supplement.

Hepatoprotective Activity of Dried- and Fermented-Processed Virgin Coconut Oil

Directory of Open Access Journals (Sweden)

Z. A. Zakaria

2011-01-01

Full Text Available The present study aims to determine the hepatoprotective effect of MARDI-produced virgin coconut oils, prepared by dried- or fermented-processed methods, using the paracetamol-induced liver damage in rats. Liver injury induced by 3 g/kg paracetamol increased the liver weight per 100 g bodyweight indicating liver damage. Histological observation also confirms liver damage indicated by the presence of inflammations and necrosis on the respective liver section. Interestingly, pretreatment of the rats with 10, but not 1 and 5, mL/kg of both VCOs significantly (P<.05 reduced the liver damage caused by the administration of paracetamol, which is further confirmed by the histological findings. In conclusion, VCO possessed hepatoprotective effect that requires further in-depth study.

Bioethanol production from the dry powder of Jerusalem artichoke tubers by recombinant Saccharomyces cerevisiae in simultaneous saccharification and fermentation.

Science.gov (United States)

Wang, Yi-Zhou; Zou, Shan-Mei; He, Mei-Lin; Wang, Chang-Hai

2015-04-01

It has been found that recombinant Saccharomyces cerevisiae 6525 can produce high concentration of ethanol in one-step fermentation from the extract of Jerusalem artichoke tubers or inulin. However, the utilization rate of raw materials was low and the fermentation process was costly and complicated. Therefore, in this study, after the optimum processing conditions for ethanol production in fed-batch fermentation were determined in flask, the recombinant S. cerevisiae 6525 was first used to produce ethanol from the dry powder of Jerusalem artichoke tubers in 5-L agitating fermentor. After 72 h of fermentation, around 84.3 g/L ethanol was produced in the fermentation liquids, and the conversion efficiency of inulin-type sugars to ethanol was 0.453, or 88.6 % of the theoretical value of 0.511. This study showed high feasibility of bioethanol industrial production from the Jerusalem artichoke tubers and provided a basis for it in the future.

Fermentation of solid wastes in Switzerland; Feststoff-Vergaerung in der Schweiz. Schlussbericht 2007

Energy Technology Data Exchange (ETDEWEB)

Liesch, B.; Mueller, C.

2007-06-15

This final report for the Swiss Federal Office of Energy (SFOE) presents the results of a study on dry fermentation technologies. Information on the state-of-the-art of current dry fermentation systems is presented and the potential of implementing dry fermentation in Swiss agriculture is discussed. The study reveals that the current dry fermentation technologies provided by various enterprises are partly not suitable (complex, continuous operating digestion reactors, developed for handling municipal solid waste). Batch digestion reactors, however, are said by the authors to be mature for application in the Swiss agricultural area. Wet fermentation technologies are also quoted as being able to utilise organic substrates with high dry-matter content and are thus said to be economically more competitive than dry fermentation systems. Dry fermentation is quoted as being a technology with a high development potential. Details are presented on several continuous and non-continuous processes used. Also, the potential for the fermentation of solid wastes in Switzerland is reviewed. Experience made in Germany is also examined.

Consumer satisfaction with dry-cured ham in five European countries.

Science.gov (United States)

Resano, H; Pérez-Cueto, F J A; Sanjuán, A I; de Barcellos, M D; Grunert, K G; Verbeke, W

2011-04-01

The objective is to investigate consumer satisfaction with dry-cured ham in five European countries. A logistic regression model has been fitted using data collected through a cross-sectional web-based survey carried out in Belgium, Germany, Denmark, Poland and Greece during January 2008 (n=2437 of which 2156 were dry-cured ham consumers). Satisfaction was evaluated as overall satisfaction, as well as specific satisfaction with healthfulness, price, convenience and taste. The findings show that the main determinant of overall satisfaction is taste satisfaction, hence, producers are recommended to focus on matching sensory acceptability of dry-cured ham. No significant between-country differences were found, reflecting the wide availability of this product in all countries. Consumer characteristics influenced their level of satisfaction. Men, older (age > 52 years) and frequent consumers of dry-cured ham consumption were more likely to be satisfied with dry-cured ham. Consumers trust the butcher's advice and they preferred purchasing dry-cured ham at a butcher shop rather than in a supermarket. © 2010 The American Meat Science Association. Published by Elsevier Ltd. All rights reserved.

A double stage dry-wet-fermentation process for a fast and safe digestion of different kinds of organic material

International Nuclear Information System (INIS)

Busch, G.; Sieber, M.; Buschmann, J.; Burkhardat, M.

2009-01-01

The fermentation of organic material is a four-step-process. It is admissible to merge the first two steps (hydrolysis and acidification) to hydrolysis in general and the last two steps (aceto genesis and methano genesis) to methano genesis. The Brandenburg University of Technology in Cottbus has devised a double stage dry-wet-fermentation process for fast and safe anaerobic degradation. Using these processes, it is possible to decompose different kinds of organic material like renewable material (e. g. maize silage), waste (e. g. household-waste) and industrial material (e. g. glycerine). (Author)

Dry anaerobic digestion of cow manure and agricultural products in a full-scale plant: Efficiency and comparison with wet fermentation.

Science.gov (United States)

Chiumenti, Alessandro; da Borso, Francesco; Limina, Sonia

2018-01-01

For years, anaerobic digestion processes have been implemented for the management of organic wastes, agricultural residues, and animal manure. Wet anaerobic digestion still represents the most common technology, while dry fermentation, dedicated to the treatment of solid inputs (TS>20%) can be considered as an emerging technology, not in terms of technological maturity, but of diffusion. The first agricultural dry anaerobic digestion plant constructed in Italy was monitored from the start-up, for over a year. The plant was fed with manure and agricultural products, such as corn silage, triticale, ryegrass, alfalfa, and straw. Three Combined Heat and Power units, for a total installed power of 910kW e , converted biogas into thermal and electric energy. The monitoring included the determination of quality and quantity of input feedstocks, of digestate (including recirculation rate), of leachate, biogas quality (CH 4 , CO 2 , H 2 S), biogas yield, energy production, labor requirement for loading, and unloading operations. The results of the monitoring were compared to performance data obtained in several full scale wet digestion plants. The dry fermentation plant revealed a start-up phase that lasted several months, during which the average power resulted in 641kW e (70.4% of nominal power), and the last period the power resulted in 788kW e (86.6% of installed power). Improving the balance of the input, the dry fermentation process demonstrated biogas yields similar to wet anaerobic digestion, congruent to the energy potential of the biomasses used in the process. Furthermore, the operation of the plant required significant man labor, mainly related to loading and unloading of the anaerobic cells. Copyright © 2017 Elsevier Ltd. All rights reserved.

Antioxidant N-acetyltransferase Mpr1/2 of industrial baker's yeast enhances fermentation ability after air-drying stress in bread dough.

Science.gov (United States)

Sasano, Yu; Takahashi, Shunsuke; Shima, Jun; Takagi, Hiroshi

2010-03-31

During bread-making processes, yeast cells are exposed to multiple stresses. Air-drying stress is one of the most harmful stresses by generation of reactive oxygen species (ROS). Previously, we discovered that the novel N-acetyltransferase Mpr1/2 confers oxidative stress tolerance by reducing intracellular ROS level in Saccharomyces cerevisiae Sigma1278b strain. In this study, we revealed that Japanese industrial baker's yeast possesses one MPR gene. The nucleotide sequence of the MPR gene in industrial baker's yeast was identical to the MPR2 gene in Sigma1278b strain. Gene disruption analysis showed that the MPR2 gene in industrial baker's yeast is involved in air-drying stress tolerance by reducing the intracellular oxidation levels. We also found that expression of the Lys63Arg and Phe65Leu variants with enhanced enzymatic activity and stability, respectively, increased the fermentation ability of bread dough after exposure to air-drying stress compared with the wild-type Mpr1. In addition, our recent study showed that industrial baker's yeast cells accumulating proline exhibited enhanced freeze tolerance in bread dough. Proline accumulation also enhanced the fermentation ability after air-drying stress treatment in industrial baker's yeast. Hence, the antioxidant enzyme Mpr1/2 could be promising for breeding novel yeast strains that are tolerant to air-drying stress. Copyright 2010 Elsevier B.V. All rights reserved.

Evaluation palm empty fruit bunch and its fermented products as feed for ruminant animal by nutritional values characterisation and in-vitro dry matter digestibility

International Nuclear Information System (INIS)

Mat Rasol Awang; Wan Badrin Wan Husain; Tajuddin Osman; Mohd Sukri Mahmood; Norihan Zainal; Zal U'yun Wan Mahmod; Hassan Hamdani Mutaat; Yusri Atan

1995-01-01

Empty fruit bunch (EFB) fermented by Pleurotus sajor caju as ruminant feed has been investigated extensively. This paper evaluates products obtained from several manipulation. The manipulation includes pretreatment (soaked and mixed) of EFB with lime, variation of fermentation conditions: prolonged incubation period, varied incubation temperature and addition Palm Oil Sludge (POS) as additive; and post-fermentation manipulation such as harvesting mushroom out of the substratum. The fermented products from each of those manipulation were evaluated based on nutritional values and the pertinent in-vitro dry matter digestibility, whenever appropriate. The evaluated products were compared and discussed. 8 tabs

Use of two osmoethanol tolerant yeast strain to ferment must from Tempranillo dried grapes: effect on wine composition.

Science.gov (United States)

López de Lerma, N; Peinado, R A

2011-01-31

The must from Tempranillo dried grapes was divided into four batches to produce sweet wine. The first one was fortified with ethanol up to 12% (v/v) to avoid fermentation (traditional way). Other two batches were partially fermented with two osmoethanol tolerant Saccharomyces cerevisiae strains (X4 and X5). The last one was fermented with native yeast by spontaneous fermentation. Wines fermented partially with the strains X4 and X5 show high volatile acidity values (above 2g/L expressed as acetic acid), and a glycerol concentration around 20 g/L. Both strains also produce high amount of carboxylic acids and therefore the wines show a high ethyl ester concentration. Aromatic series were obtained for all the wines by grouping aroma compounds according to their odor descriptors. The series of the fermented wines with higher values in relation with the control wine were fruity, sweet and fatty, emphasizing the fruity series in the samples fermented with the X4 and X5 strains. The sensorial analysis of the wine samples by a tasting panel put in evidence that the musts fermented with the osmoethanol tolerant yeasts were better valued than the rest of the wine samples. The must fermented with the X4 strain obtained the maximum score in terms of aroma and flavour. So, the use of these osmoethanol tolerant S. cerevisiae strains could be a suitable alternative to produce sweet wines from must with high sugar concentration. The wines obtained this way are chemically and organoleptically more complex than those elaborated traditionally. Copyright © 2010 Elsevier B.V. All rights reserved.

FERMENTATION ACTIVITY OF LACTOSE-FERMENTATION YEAST IN WHEY-MALT WORT

Directory of Open Access Journals (Sweden)

E. V. Greek

2013-04-01

Full Text Available The main parameters of fermentation of whey-malt wort with the use of different strains of lactose-fermentation yeast was investigated experimentally. According to the findings of investigation of fermentive activity for different types of lactose-fermentation microorganisms in whey-malt wort it was found that the most active spirituous fermentation for all parameters was in wort fermented by microorganisms Zygosaccharomyces lactis 868-K and Saccharomyces lactis 95. High capacity for utilization of malt carbohydrates represented by easily metabolized carbohydrates of malt extract was determined. Also organoleptic analysis of fermented whey drinks derived from the renewed mixtures of dry whey and fermented malt and yeast Zygosaccharomyces lactis 868-K and Saccharomyces lactis 95 was carried out. It was found that the drink fermented with yeast Zygosaccharomyces lactis 868-K had intense refreshing flavor of rye bread with fruit tones. Intensity growth of aromatization for complex of sample with microorganisms Saccharomyces lactis 95, indicating high organoleptic indexes of the drink was observed.

Quality of fermented cassava flour processed into placali | Koko ...

African Journals Online (AJOL)

Fermented cassava flour was obtained from Yace variety. Cassava roots were washed, peeled and ground. After adding cassava inoculums at 8% (m/m), the pulp was allowed to ferment for 72 hours at ambient temperature. The fermented dough was removed, squeezed and oven-dried for 48 hours at 55 °C. The dried ...

Relationship between fermentation index and other biochemical changes evaluated during the fermentation of Mexican cocoa (Theobroma cacao) beans.

Science.gov (United States)

Romero-Cortes, Teresa; Salgado-Cervantes, Marco Antonio; García-Alamilla, Pedro; García-Alvarado, Miguel Angel; Rodríguez-Jimenes, Guadalupe del C; Hidalgo-Morales, Madeleine; Robles-Olvera, Víctor

2013-08-15

During traditional cocoa processing, the end of fermentation is empirically determined by the workers; consequently, a high variability on the quality of fermented cocoa beans is observed. Some physicochemical properties (such as fermentation index) have been used to measure the degree of fermentation and changes in quality, but only after the fermentation process has concluded, using dried cocoa beans. This would suggest that it is necessary to establish a relationship between the chemical changes inside the cocoa bean and the fermentation conditions during the fermentation in order to standardize the process. Cocoa beans were traditionally fermented inside wooden boxes, sampled every 24 h and analyzed to evaluate fermentation changes in complete bean, cotyledon and dried beans. The value of the fermentation index suggested as the minimal adequate (≥1) was observed at 72 h in all bean parts analyzed. At this time, values of pH, spectral absorption, total protein hydrolysis and vicilin-class globulins of fermented beans suggested that they were well fermented. Since no difference was found between the types of samples, the pH value could be used as a first indicator of the end of the fermentation and confirmed by evaluation of the fermentation index using undried samples, during the process. © 2013 Society of Chemical Industry.

Oxygen and diverse nutrients influence the water kefir fermentation process.

Science.gov (United States)

Laureys, David; Aerts, Maarten; Vandamme, Peter; De Vuyst, Luc

2018-08-01

Eight water kefir fermentation series differing in the presence of oxygen, the nutrient concentration, and the nutrient source were studied during eight consecutive backslopping steps. The presence of oxygen allowed the proliferation of acetic acid bacteria, resulting in high concentrations of acetic acid, and decreased the relative abundance of Bifidobacterium aquikefiri. Low nutrient concentrations resulted in slow water kefir fermentation and high pH values, which allowed the growth of Comamonas testosteroni/thiooxydans. Further, low nutrient concentrations favored the growth of Lactobacillus hilgardii and Dekkera bruxellensis, whereas high nutrient concentrations favored the growth of Lactobacillus nagelii and Saccharomyces cerevisiae. Dried figs, dried apricots, and raisins resulted in stable water kefir fermentation. Water kefir fermentation with dried apricots resulted in the highest pH and water kefir grain growth, whereas that with raisins resulted in the lowest pH and water kefir grain growth. Further, water kefir fermentation with raisins resembled fermentations with low nutrient concentrations, that with dried apricots resembled fermentations with normal nutrient concentrations, and that with fresh figs or a mixture of yeast extract and peptone resembled fermentations with high nutrient concentrations. Copyright © 2018 Elsevier Ltd. All rights reserved.

Pretreatment of Dried Distiller Grains with Solubles by Soaking in Aqueous Ammonia and Subsequent Enzymatic/Dilute Acid Hydrolysis to Produce Fermentable Sugars.

Science.gov (United States)

Nghiem, Nhuan P; Montanti, Justin; Kim, Tae Hyun

2016-05-01

Dried distillers grains with solubles (DDGS), a co-product of corn ethanol production in the dry-grind process, was pretreated by soaking in aqueous ammonia (SAA) using a 15 % w/w NH4OH solution at a solid/liquid ratio of 1:10. The effect of pretreatment on subsequent enzymatic hydrolysis was studied at two temperatures (40 and 60 °C) and four reaction times (6, 12, 24, and 48 h). Highest glucose yield of 91 % theoretical was obtained for the DDGS pretreated at 60 °C and 24 h. The solubilized hemicellulose in the liquid fraction was further hydrolyzed with dilute H2SO4 to generate fermentable monomeric sugars. The conditions of acid hydrolysis included 1 and 4 wt% acid, 60 and 120 °C, and 0.5 and 1 h. Highest yields of xylose and arabinose were obtained at 4 wt% acid, 120 °C, and 1 h. The fermentability of the hydrolysate obtained by enzymatic hydrolysis of the SAA-pretreated DDGS was demonstrated in ethanol fermentation by Saccharomyces cerevisiae. The fermentability of the hydrolysate obtained by consecutive enzymatic and dilute acid hydrolysis was demonstrated using a succinic acid-producing microorganism, strain Escherichia coli AFP184. Under the fermentation conditions, complete utilization of glucose and arabinose was observed, whereas only 47 % of xylose was used. The succinic acid yield was 0.60 g/g total sugar consumed.

Methylxanthine and catechin content of fresh and fermented cocoa beans, dried cocoa beans, and cocoa liquor

Directory of Open Access Journals (Sweden)

Pedro P. Peláez

2016-01-01

Full Text Available The theobromine and catechin content can affect the quality of cocoa liquor and is influenced by cacao variety, production area (PA, and fermentation, as well as the method of drying beans (FDB and cocoa liquor production (CLP. This study examined variationsin methylxanthine and catechin levels in fresh and fermented cocoa beans, dried cocoa grains, and in cocoa liquor from Trinitario, Criollo, and Forastero cacao varieties. A total of 123 cocoa bean samples from three Peruvian PAs at different altitudes, Tingo María (TM, San Alejandro (SA, and Curimana (CU, were evaluated. The theobromine (Tb and caffeine (Cf contents in fresh cocoa beans were affected by both cocoa type and PA. The caffeine content was higher in Trinitario cacao than in Criollo and Forastero varieties (p ≤ 0.05. The Tb and CF contents decreased in dry cocoa grain and was affected by FDB (p ≤ 0.05 (1.449 ± 0.004 to 1.140 ± 0.010 and 0.410 ± 0.03 to 0.165 ± 0.02 g Tb and C, respectively, per 100 g dry weight. Cocoa beans from Tingo María, which has thehighest altitude, had higher Tb and CF contents than those from other PAs. The catechin (C and epicatechin (EC contents were affected by the FDB and CLP, and were highestin fresh cocoa beans from the Tingo María area (range: 0.065 ± 0.01 to 0.020 ± 0.00 g C/100 g. The C and EC contents decreased during FDB and CLP (0.001 g C/100 g of cocoa liquor. Taken together, these results show that higher concentrations of Tb, Cf, C,and EC are present in fresh cocoa beans. Moreover, the cocoa variety influenced cocoa liquor quality. Overall, cocoa from the Tingo María PA had the most desirable chemical composition.

NIR technology for on-line determination of superficial a(w) and moisture content during the drying process of fermented sausages.

Science.gov (United States)

Collell, Carles; Gou, Pere; Arnau, Jacint; Muñoz, Israel; Comaposada, Josep

2012-12-01

Three different NIR equipment were evaluated based on their ability to predict superficial water activity (a(w)) and moisture content in two types of fermented sausages (with and without moulds on surface), using partial least squares (PLS) regression models. The instruments differed mainly in wavelength range, resolution and measurement configuration. The most accurate equipment was used in a new experiment to achieve robust models in sausages with different salt contents and submitted to different drying conditions. The models developed showed determination coefficients (R(2)(P)) values of 0.990, 0.910 and 0.984, and RMSEP values of 1.560%, 0.220% and 0.007% for moisture, salt and a(w) respectively. It was demonstrated that NIR spectroscopy could be a suitable non-destructive method for on-line monitoring and control of the drying process in fermented sausages. Copyright © 2012 Elsevier Ltd. All rights reserved.

Application of high pressure processing to reduce verotoxigenic E. coli in two types of dry-fermented sausage.

Science.gov (United States)

Omer, M K; Alvseike, O; Holck, A; Axelsson, L; Prieto, M; Skjerve, E; Heir, E

2010-12-01

The effect of high pressure processing (HPP) on the survival of verotoxigenic Escherichia coli (VTEC) in two types of Norwegian type dry-fermented sausages was studied. Two different types of recipes for each sausage type were produced. The sausage batter was inoculated with 6.8 log(10) CFU/g of VTEC O103:H25. After fermentation, drying and maturation, slices of finished sausages were vacuum packed and subjected to two treatment regimes of HPP. One group was treated at 600 MPa for 10 min and another at three cycles of 600 MPa for 200 s per cycle. A generalized linear model split by recipe type showed that these two HPP treatments on standard recipe sausages reduced E. coli by 2.9 log(10) CFU/g and 3.3 log(10) CFU/g, respectively. In the recipe with higher levels of dextrose, sodium chloride and sodium nitrite E. coli reduction was 2.7 log(10) CFU/g in both treatments. The data show that HPP has a potential to make the sausages safer and also that the effect depends somewhat on recipe. Copyright © 2010 The American Meat Science Association. Published by Elsevier Ltd. All rights reserved.

Sensory properties and fatty acids profiles of fermented dry sausages made of pork meat from various breeds

Science.gov (United States)

Parunović, N.; Radović, Č.; Savić, R.

2017-09-01

In this study, the parallel examinations on fatty acid profiles and sensory properties of fermented dry sausages are presented. Three types of kulen and sremska sausages were made, which varied depending on the percentage of meat and fat derived from different pig breeds: autochthonous (Swallow-Belly Mangalitsa and Moravka) and commercial (Swedish Landrace). In sausages made from meat of commercial pig breed, the highest cholesterol content was detected. However, sausage made from the Mangalitsa pork meat contained higher levels of monounsaturated fatty acid (MUFA) and unsaturated fatty acid (USFA), and lower saturated fatty acid levels (SFA).The level of polyunsaturated (PUFA) in sausage made of Landrace pork meat was significantly higher than levels in other types. These differences between fatty acids were mostly deriving by higher total n-6 PUFA content. In a sausage made of Mangulitsa meat, the values of atherogenic (IA) and thrombogenic (IT) health lipid indexes are lower. Kulen and sremska sausages made from the Mangalitsa pork meat was superior in terms of colour, odour, taste, after taste and overall acceptability. This study demonstrate that pig breed have an effect on the chemical content, fatty acids profiles and sensory properties of dry fermented sausages.

Selected Ion Flow Tube-Mass Spectrometry for Absolute Quantification of Aroma Compounds in the Headspace of Dry Fermented Sausages

Czech Academy of Sciences Publication Activity Database

Olivares, A.; Dryahina, Kseniya; Navarro, J. L.; Flores, M.; Smith, D.; Španěl, Patrik

2010-01-01

Roč. 82, č. 13 (2010), s. 5819-5829 ISSN 0003-2700 R&D Projects: GA ČR GA203/09/0256 Institutional research plan: CEZ:AV0Z40400503 Keywords : mass spectrometry * aroma compounds * dry fermented sausages Subject RIV: CF - Physical ; Theoretical Chemistry Impact factor: 5.874, year: 2010

Impact of fermentation, drying, roasting, and Dutch processing on epicatechin and catechin content of cacao beans and cocoa ingredients.

Science.gov (United States)

Payne, Mark J; Hurst, W Jeffrey; Miller, Kenneth B; Rank, Craig; Stuart, David A

2010-10-13

Low molecular weight flavan-3-ols are thought to be responsible, in part, for the cardiovascular benefits associated with cocoa powder and dark chocolate. The levels of epicatechin and catechin were determined in raw and conventionally fermented cacao beans and during conventional processing, which included drying, roasting, and Dutch (alkali) processing. Unripe cacao beans had 29% higher levels of epicatechin and the same level of catechin compared to fully ripe beans. Drying had minimal effect on the epicatechin and catechin levels. Substantial decreases (>80%) in catechin and epicatechin levels were observed in fermented versus unfermented beans. When both Ivory Coast and Papua New Guinea beans were subjected to roasting under controlled conditions, there was a distinct loss of epicatechin when bean temperatures exceeded 70 °C. When cacao beans were roasted to 120 °C, the catechin level in beans increased by 696% in unfermented beans, by 650% in Ivory Coast beans, and by 640% in Papua New Guinea fermented beans compared to the same unroasted beans. These results suggest that roasting in excess of 70 °C generates significant amounts of (-)-catechin, probably due to epimerization of (-)-epicatechin. Compared to natural cocoa powders, Dutch processing caused a loss in both epicatechin (up to 98%) and catechin (up to 80%). The epicatechin/catechin ratio is proposed as a useful and sensitive indicator for the processing history of cacao beans.

Pre-treatment and ethanol fermentation potential of olive pulp at different dry matter concentrations

Energy Technology Data Exchange (ETDEWEB)

Haagensen, Frank [Bioprocess Science and Technology group, Biocentrum-DTU, Building 227, Technical University of Denmark, 2800 Lyngby (Denmark); Skiadas, Ioannis V.; Gavala, Hariklia N.; Ahring, Birgitte K. [Bioprocess Science and Technology group, Biocentrum-DTU, Building 227, Technical University of Denmark, 2800 Lyngby (Denmark); Copenhagen Institute of Technology (Aalborg University Copenhagen), Section for Sustainable Biotechnology, Department of Biotechnology, Chemistry and Environmental Engineering, Lautrupvang 15, DK 2750 Ballerup (Denmark)

2009-11-15

Renewable energy sources have received increased interest from the international community with biomass being one of the oldest and the most promising ones. In the concept of exploitation of agro-industrial residues, the present study investigates the pre-treatment and ethanol fermentation potential of the olive pulp, which is the semi solid residue generated from the two-phase processing of the olives for olive oil production. Wet oxidation and enzymatic hydrolysis have been applied aiming at the enhancement of carbohydrates' bioavailability. Different concentrations of enzymes and enzymatic durations have been tested. Both wet oxidation and enzymic treatment were evaluated based on the ethanol obtained in a subsequent fermentation step by Saccharomyces cerevisiae and Thermoanaerobacter mathranii. It was found that a four-day hydrolysis time was adequate for a satisfactory release of glucose and xylose. The combination of wet oxidation and enzymatic hydrolysis resulted in the glucose and xylose concentration increase of 138 and 444%, respectively, compared to 33 and 15% with only enzymes added. However, the highest ethanol production was obtained when only enzymic pre-treatment was applied, implying that wet oxidation is not a recommended pre-treatment process for olive pulp at the conditions tested. It was also showed that increased dry matter concentration did not have a negative effect on the release of sugars, indicating that the cellulose and xylan content of the olive pulp is relatively easily available. The results of the experiments in batch processes clearly emphasize that the simultaneous saccharification and fermentation (SSF) mode is advantageous in comparison with the separate hydrolysis and fermentation (SHF) mode concerning process contamination. (author)

Physicochemical, biochemical and sensory properties for the characterization of Petrovská klobása (traditional fermented sausage

Directory of Open Access Journals (Sweden)

Ikonić Predrag M.

2010-01-01

Full Text Available A study was carried out on a typical homemade Petrovská klobasá in order to characterize this traditional dry-fermented sausage, to provide a basis for establishing the quality standard and protecting designation of origin. This paper reviews the chemical composition, some physicochemical, proteolytic and sensory parameters of Petrovská klobasá made by five manufacturers chosen as representatives. Beside the differences between sausages made by different manufacturers the main properties of this traditional product were though recognized. Compared to other dry-fermented sausages Petrovská klobasá is characterized by a high content of protein (23.36-30.45% and low contents of NaCl (2.99-3.28%. With some minor exceptions, the values of other chemical parameters are within the range of those observed for various dry-cured sausages. Weight loss during the processing is high (up to 45.71% and pH value (~ 5.4 corresponds to the values for this parameter in other European traditional fermented sausages. Contents of different nitrogen fractions show that Petrovská klobasá undergoes significant proteolytic changes. At the end of ripening, Petrovská klobasá is characterized by aromatic and spicy-hot flavor, dark-red color and hard consistency.

Mathematical modeling of ethanol production in solid-state fermentation based on solid medium' dry weight variation.

Science.gov (United States)

Mazaheri, Davood; Shojaosadati, Seyed Abbas; Zamir, Seyed Morteza; Mousavi, Seyyed Mohammad

2018-04-21

In this work, mathematical modeling of ethanol production in solid-state fermentation (SSF) has been done based on the variation in the dry weight of solid medium. This method was previously used for mathematical modeling of enzyme production; however, the model should be modified to predict the production of a volatile compound like ethanol. The experimental results of bioethanol production from the mixture of carob pods and wheat bran by Zymomonas mobilis in SSF were used for the model validation. Exponential and logistic kinetic models were used for modeling the growth of microorganism. In both cases, the model predictions matched well with the experimental results during the exponential growth phase, indicating the good ability of solid medium weight variation method for modeling a volatile product formation in solid-state fermentation. In addition, using logistic model, better predictions were obtained.

Industrial scale garage-type dry fermentation of municipal solid waste to biogas.

Science.gov (United States)

Qian, M Y; Li, R H; Li, J; Wedwitschka, H; Nelles, M; Stinner, W; Zhou, H J

2016-10-01

The objectives of this study was to through monitoring the 1st industrial scale garage-type dry fermentation (GTDF) MSW biogas plant in Bin County, Harbin City, Heilongjiang Province, China, to investigate its anaerobic digestion (AD) performance and the stability of process. After a monitoring period of 180days, the results showed that the volumetric biogas production of the digesters and percolate tank was 0.72 and 2.22m(3) (m(3)d)(-1), respectively, and the specific biogas yield of the feedstock was about 270m(3)CH4tVS(-1), which indicated that the GTDF is appropriate for the Chinese MSW. This paper also raised some problems aimed at improving the process stability and AD efficiency. Copyright © 2016. Published by Elsevier Ltd.

Microbiological, physicochemical and sensory parameters of dry fermented sausages manufactured with high hydrostatic pressure processed raw meat.

Science.gov (United States)

Omer, M K; Prieto, B; Rendueles, E; Alvarez-Ordoñez, A; Lunde, K; Alvseike, O; Prieto, M

2015-10-01

The aim of this trial was to describe physicochemical, microbiological and organoleptic characteristics of dry fermented sausages produced from high hydrostatic pressure (HHP) pre-processed trimmings. During ripening of the meat products pH, weight, water activity (aw), and several microbiological parameters were measured at zero, eight, fifteen days and after 6weeks. Sensory characteristics were estimated at day 15 and after six weeks by a test panel by using several sensory tests. Enterobacteriaceae were not detected in sausages from HHP-processed trimmings. Fermentation was little affected, but weight and aw of the HHP-processed sausages decreased faster during ripening. HHP-treated sausages were consistently less favoured than non HHP-treated sausages, but the strategy may be an alternative approach if the process is optimized. Copyright © 2015 Elsevier Ltd. All rights reserved.

The Performance of by Turns Fermentation- Dryer for Vanilla (Vanilla Planifolia Andrews Processing

Directory of Open Access Journals (Sweden)

Haerani Haerani

2011-05-01

Full Text Available The drying and fermentation are the processing steps which influence the quality of vanilla. Thus, an effort to produce instrument which can dry and ferment vanilla by turns automatically was done. Based on the test result on the instrument, it was known that the heater and heat-exchanger can function excellently. It can be seen from the increase of temperature after passing heater and heat-exchanger; and the decrease of air humidity in the drying chamber. The small differences of air flow speed between racks proved the uniformity of air flow speed in the drying chamber. The time and temperature control system showed temperature stability on drying process (i.e. 60°C and on fermentation process (i.e. 40°C; moreover, temperature response reached 60°C and did not exceed the setting time (maximum 30 minutes. The water percentage depletion from 88% to 55% is relatively slow (in 5 days fermentation-drying process. The depletion is appropriate with the recommendation for fermentation-drying vanilla processing.

Effect of acid whey and freeze-dried cranberries on lipid oxidation and fatty acid composition of nitrite-/nitrate-free fermented sausage made from deer meat

Directory of Open Access Journals (Sweden)

Małgorzata Karwowska

2017-01-01

Full Text Available Objective This study evaluated the effect of acid whey and freeze-dried cranberries on the physicochemical characteristics, lipid oxidation and fatty acid composition of nitrite-free fermented sausage made from deer meat and pork fat. Antioxidant interactions between acid whey and cranberry compounds were also explored. Methods Four formulations of fermented venison sausage were prepared: F1 (control, F2 (with 5% liquid acid whey, F3 (with 0.06% of freeze-dried cranberries, and F4 (with 5% liquid acid whey and 0.06% of freeze-dried cranberries. Each sample was analyzed for pH, water activity (aw, heme iron content, 2-thiobarbituric acid reactive substances (TBARS value and conjugated dienes at the end of the manufacturing process and at 30 and 90 days of refrigerated storage. Fatty acid composition was measured once at the end of the manufacturing process. Results At the end of ripening, all samples presented statistically different values for a pH range of 4.47 to pH 4.59. The sum of the unsaturated fatty acids was higher, while the conjugated diene and the TBARS values were lower in sausages with freeze-dried cranberries as compared to the control sausage. The highest content of heme iron (21.52 mg/kg at day 90 was found in the sausage formulation with the addition of freeze-dried cranberries, which suggests that the addition of cranberries stabilized the porphyrin ring of the heme molecule during storage and thereby reduced the release of iron. The use of liquid acid whey in combination with cranberries appears to not be justified in view of the oxidative stability of the obtained products. Conclusion The results suggest that the application of freeze-dried cranberries can lower the intensity of oxidative changes during the storage of nitrite-free fermented sausage made from deer meat.

Exploring consumer satisfaction with dry-cured ham in five European countries

DEFF Research Database (Denmark)

Resano, Helena; Perez-Cueto, Federico J. A.; Sanjuán, Ana

2011-01-01

This papers' objective is to investigate consumer satisfaction with dry-cured ham in five European countries. A logistic regression model has been fitted using data collected through a crosssectional web-based survey carried out in Belgium, Germany, Denmark, Poland and Greece during January 2008 (n......=2437 of which 2156 were dry-cured ham consumers). Satisfaction was evaluated as overall satisfaction, as well as specific satisfaction with healthfulness, price, convenience and taste. The findings show that the main determinant of overall satisfaction is taste satisfaction, hence, producers...... are recommended to focus on matching sensory acceptability of dry-cured ham. No significant between-country differences were found, reflecting the wide availability of this product in all countries. Consumer characteristics influenced their level of satisfaction. Men, older (age >52 years) and frequent consumers...

Sensory evaluation of dry-fermented sausage containing ground deodorized yellow mustard.

Science.gov (United States)

Li, Shuliu; Aliani, Michel; Holley, Richard A

2013-10-01

Ground deodorized yellow mustard is used as a binder and meat protein substitute in cooked processed meat products. Recent studies have shown that it has the potential to be used in uncooked processed meat products because of its natural antimicrobial properties. In the present study, ground deodorized yellow mustard was added to uncooked dry-fermented sausage during manufacture at 1% to 4% (w/w) and analyzed for its effects on starter cultures, physico-chemical properties, and consumer acceptability. Mustard had a nondose-dependent inhibitory effect on the Staphylococcus starter culture, had no effect on water activity or instrumental texture, and tended to accelerate sausage pH reduction. At 3% and 4% mustard, consumer scores on all sensory attributes as well as overall acceptability were significantly lower. The appearance and color of 3% and 4% mustard-treated sausages were liked slightly, whereas flavor, texture, and overall acceptability scores were reduced. The control without mustard and 1% mustard-treated sausages had similar sensory properties and were the most acceptable, while 2% mustard-treated sausages were given "like moderately" and "like slightly" descriptors. Sensory results mean that at concentrations necessary for mandated regulatory control of Escherichia coli O157:H7 in dry sausages, mustard may have a negative effect on consumer acceptance. © 2013 Institute of Food Technologists®

Inoculation of starter cultures in a semi-dry coffee (Coffea arabica) fermentation process.

Science.gov (United States)

Evangelista, Suzana Reis; Miguel, Maria Gabriela da Cruz Pedrozo; Cordeiro, Cecília de Souza; Silva, Cristina Ferreira; Pinheiro, Ana Carla Marques; Schwan, Rosane Freitas

2014-12-01

The aim of this study was to evaluate the use of yeasts as starter cultures in coffee semi-dry processing. Arabica coffee was inoculated with one of the following starter cultures: Saccharomyces cerevisiae UFLA YCN727, S. cerevisiae UFLA YCN724, Candida parapsilosis UFLA YCN448 and Pichia guilliermondii UFLA YCN731. The control was not inoculated with a starter culture. Denaturing gradient gel electrophoresis (DGGE) was used to assess the microbial population, and organic acids and volatile compounds were quantified by HPLC and HS-SPME/GC, respectively. Sensory analyses were evaluated using the Temporal Dominance of Sensations (TDS). DGGE analysis showed that the inoculated yeasts were present throughout the fermentation. Other yeast species were also detected, including Debaryomyces hansenii, Cystofilobasidium ferigula and Trichosporon cavernicola. The bacterial population was diverse and was composed of the following genera: Weissella, Leuconostoc, Gluconobacter, Pseudomonas, Pantoea, Erwinia and Klebsiella. Butyric and propionic acids, were not detected in any treatment A total of 47 different volatiles compounds have been identified. The coffee inoculated with yeast had a caramel flavor that was not detected in the control, as assessed by TDS. The use of starter cultures during coffee fermentation is an interesting alternative for obtaining a beverage quality with distinctive flavor. Copyright © 2014 Elsevier Ltd. All rights reserved.

Effect of freeze-dried leek powder (FDLP) and nitrite level on processing and quality characteristics of fermented sausages.

Science.gov (United States)

Tsoukalas, D S; Katsanidis, E; Marantidou, S; Bloukas, J G

2011-02-01

Fermented sausages were produced with 0.84% and 1.68% freeze-dried leek powder (FDLP), providing 75 and 150 mg/kg NaNO(3), respectively, and three levels of added nitrite (0, 75, and 150 mg/kg NaNO(2). A control treatment was also produced with 150 mg/kg NaNO(2). Sausages with FDLP were darker and yellower (pnitrite. Copyright © 2010 Elsevier Ltd. All rights reserved.

Current developments in Helector dry fermentation; Aktuelle Entwicklungen der Helector Trockenfermentation

Energy Technology Data Exchange (ETDEWEB)

Ziehmann, Gunnar [Helector GmbH, Hamburg (Germany)

2012-11-01

In 2008, the Helector GmbH acquired the Loock TNS {sup registered} process and took over Loock Biogasssysteme. Since then, the Helector GmbH has been constructing dry fermentation plants ad general contractor, making use of more than 20 years of experience with the Loock TNS {sup registered} process. Economic efficiency, emission reduction and environmental protection are ensured by constant further development. The single-stage batch process retained its advantages, i.e. simultaneous biogas production from the solid and liquid phase, process control mostly via water, no adding of fermentation residues, and effective degassing by a patented ventilation system. A newly developed lean gas management system was tested successfully in practice. The contribution presents preliminary operating experience. (orig.) [German] Im Jahr 2008 hat die Helector GmbH das Loock TNS {sup registered} -Verfahren als Technologietraeger erworben und das Ingenieurbuero Loock Biogasssysteme uebernommen. Seither errichtet die Helector GmbH Trockenfermentationsanlagen als Generalunternehmer. Hierbei wird die ueber 20-jaehrige Erfahrung mit dem Loock TNS {sup registered} -Verfahren genutzt und das System mit Nachdruck stetig weiterentwickelt. Diese Weiterentwicklungen tragen einen wesentlichen Anteil zur Wirtschaftlichkeit der Anlage bei und verbessern den Emissions- und Umweltschutz erheblich. Die Vorteile dieses einstufigen Batchverfahrens, vor allem die simultane Biogasgewinnung aus der festen und fluessigen Phase, die Prozesssteuerung vorwiegend ueber das Wasser, der Verzicht auf Beimischung von Gaerresten und die effektive Entgasung durch das patentierte Belueftungssystem, bleiben systemimmanent erhalten. Das neu entwickelte und nunmehr erstmals realisierte Schwachgasmanagementsystem hat sich in der Praxis als sehr erfolgreich erwiesen. In diesem Beitrag werden unter anderem erste Betriebserfahrungen hierzu vorgestellt. (orig.)

The relationship between fermented food intake and mortality risk in the European Prospective Investigation into Cancer and Nutrition-Netherlands cohort

NARCIS (Netherlands)

Praagman, J.; Dalmeijer, G.W.; Schouw, van der Y.T.; Soedamah-Muthu, S.S.; Verschuren, W.M.M.; Bueno-de Mesquita, H.B.; Geleijnse, J.M.; Beulens, J.W.J.

2015-01-01

The objective of the present study was to investigate the relationship between total and subtypes of bacterial fermented food intake (dairy products, cheese, vegetables and meat) and mortality due to all causes, total cancer and CVD. From the European Prospective Investigation into Cancer and

Combination of dry dark fermentation and mechanical pretreatment for lignocellulosic deconstruction: An innovative strategy for biofuels and volatile fatty acids recovery

International Nuclear Information System (INIS)

Motte, Jean-Charles; Sambusiti, Cecilia; Dumas, Claire; Barakat, Abdellatif

2015-01-01

Highlights: • A novel combination of solid-state fermentation and fine milling was developed. • Biological pretreatment produces valuable bioproducts (VFA and biohydrogen). • Solid-state dark fermentation improves considerably the milling efficiency. • Bioethanol yield was higher after a strong particle size reduction. • Substrate conversion was two times higher than conventional processes. - Abstract: In the present study, the feasibility of combining dry dark fermentation and mechanical pretreatment of wheat straw was studied in order to improve substrate valorization, save energy input, decrease the environmental impact and diversify biofuels and volatile fatty acids production. To this end, dark fermentation of wheat straw was performed at 55 °C and 35 °C under solid-state conditions (23% of total solid content) and it was considered as a biological pretreatment. Both biologically treated and raw straws were reduced at four particles size to cover the range of fine (50 < X < 500 μm) and ultrafine milling (<50 μm). Biological pretreatment led to a substrate conversion of 16% and 14%, mainly into volatile fatty acids and biohydrogen. Biological pretreatment improved the substrate grindability with a reduction of mean particle size up to 31% and a reduction of the milling specific energy consumption up to 35% compared to untreated straw. Finally, related to untreated straw, this combination of biological and mechanical treatments improved the bioethanol yield up to 83%, which leads to an enhancement of the overall substrate conversion up to 131%. Based on these high yields, this combination of dry biological–mechanical pretreatments appears more attractive and efficient in terms of bioproducts production, energy efficiency and environmental impact, compared to conventional pretreatments

Double stage dry-wet-fermentation - start-up of a pilot biogas plant

International Nuclear Information System (INIS)

Buschmann, Jeannette; Busch, Gunter; Burkhardt, Marko

2009-01-01

The Brandenburg University of Technology (BTU) has developed a double stage dry-wet fermentation process for fast and safe anaerobic degradation. Originally designed for treatment of organic wastes, this process allows using a wide variety of solid biodegradable materials. The dividing of hydrolysis and methanation in this process, allows an optimization of the different steps of biogas generation separately. The main advantages of the process are the optimum process control, an extremely stable process operation and a high gas productivity and quality. Compared to conventional processes, the retention times within the percolation stage (hydrolysis) are reduced considerably. In cooperation with the engineering and consulting company GICON, the technology was qualified further to an industrial scale. In 2007 a pilot plant, and, simultaneously, an industrial plant were built by GICON based on this double stage technology. Based on practical experience from the operation of laboratory fermentation plants, the commissioning of the pilot plant was planned, controlled and monitored by our institution. The start-up of a biogas plant of this type focuses mainly on the inoculation the of methane reactor. The growth of microbial populations and generation of a stable biocenosis within the methane reactor is essential and affects the duration of starting period as well as the methanation efficiency a long time afterwards. This paper concerns with start-up of a pilot biogas plant and discusses particular occurrences and effects during this period. (author)

Utilization of household food waste for the production of ethanol at high dry material content.

Science.gov (United States)

Matsakas, Leonidas; Kekos, Dimitris; Loizidou, Maria; Christakopoulos, Paul

2014-01-08

Environmental issues and shortage of fossil fuels have turned the public interest to the utilization of renewable, environmentally friendly fuels, such as ethanol. In order to minimize the competition between fuels and food production, researchers are focusing their efforts to the utilization of wastes and by-products as raw materials for the production of ethanol. household food wastes are being produced in great quantities in European Union and their handling can be a challenge. Moreover, their disposal can cause severe environmental issues (for example emission of greenhouse gasses). On the other hand, they contain significant amounts of sugars (both soluble and insoluble) and they can be used as raw material for the production of ethanol. Household food wastes were utilized as raw material for the production of ethanol at high dry material consistencies. A distinct liquefaction/saccharification step has been included to the process, which rapidly reduced the viscosity of the high solid content substrate, resulting in better mixing of the fermenting microorganism. This step had a positive effect in both ethanol production and productivity, leading to a significant increase in both values, which was up to 40.81% and 4.46 fold, respectively. Remaining solids (residue) after fermentation at 45% w/v dry material (which contained also the unhydrolyzed fraction of cellulose), were subjected to a hydrothermal pretreatment in order to be utilized as raw material for a subsequent ethanol fermentation. This led to an increase of 13.16% in the ethanol production levels achieving a final ethanol yield of 107.58 g/kg dry material. In conclusion, the ability of utilizing household food waste for the production of ethanol at elevated dry material content has been demonstrated. A separate liquefaction/saccharification process can increase both ethanol production and productivity. Finally, subsequent fermentation of the remaining solids could lead to an increase of the overall

Characterization of bioactive compounds from monascus purpureus fermented different cereal substrates

Directory of Open Access Journals (Sweden)

Eva Ivanišová

2017-01-01

Full Text Available Solid-state fermenting of cereals by Monascus is interesting strategy to produce cereals with more beneficial components.  The objective of this study was to determine selected primary and secondary metabolites in cereals (rice, wheat, barley, sorghum, corn, buckwheat fermented by Monascus purpreus and subsequently compare amount of these compounds with control sample (cereals without Monascus. In fermented cereals was determined higher protein, fat, reducing sugars, crude fiber and ash content with compare to non-fermented cereals. The antioxidant activity measured by DPPH assay, ABTS assay as well as reducing power assay was also higher in fermented Monascus cereals with the best results in rice (3.09 ±0.02; 62.9 ±2.24; 43.19 ±2.07 mg TEAC per g of dry weight. Sample of fermented rice contained the highest level of total polyphenols (15.31 ±3.62 mg GAE per g of dry weight, total flavonoids (1.65 mg QE per g of dry weight and total phenolic acids (9.47 ±0.56 mg CAE per g of dry weight. In fermented cereals was also determined higher contact of reducing sugars (highest value in rice 246.97 ±7.96 mg GE per g, proteins (highest value in buckwheat 28.47 ±1.24%, ash (highest value in sorghum 2.74 ±0.08% and fat (highest value in corn 4.89 ±0.03% with compare to non-fermented samples. Results of crude fiber content of both - fermented and non-fermented cereals were balanced with similar values. Results of this study shown that Monascus purpureus fermented cereal substrates might be a potential sources of several bioactive compounds in food products.

Characterization of the Factors that Influence Sinapine Concentration in Rapeseed Meal during Fermentation

Science.gov (United States)

Niu, Yanxing; Jiang, Mulan; Guo, Mian; Wan, Chuyun; Hu, Shuangxi; Jin, Hu; Huang, Fenghong

2015-01-01

We analyzed and compared the difference in sinapine concentration in rapeseed meal between the filamentous fungus, Trametes sp 48424, and the yeast, Saccharomyces cerevisiae, in both liquid and solid-state fermentation. During liquid and solid-state fermentation by Trametes sp 48424, the sinapine concentration decreased significantly. In contrast, the liquid and solid-state fermentation process by Saccharomyces cerevisiae just slightly decreased the sinapine concentration (P ≤ 0.05). After the solid-state fermented samples were dried, the concentration of sinapine in rapeseed meal decreased significantly in Saccharomyces cerevisiae. Based on the measurement of laccase activity, we observed that laccase induced the decrease in the concentration of sinapine during fermentation with Trametes sp 48424. In order to eliminate the influence of microorganisms and the metabolites produced during fermentation, high moisture rapeseed meal and the original rapeseed meal were dried at 90°C and 105°C, respectively. During drying, the concentration of sinapine in high moisture rapeseed meal decreased rapidly and we obtained a high correlation coefficient between the concentration of sinapine and loss of moisture. Our results suggest that drying and enzymes, especially laccase that is produced during the solid-state fermentation process, may be the main factors that affect the concentration of sinapine in rapeseed meal. PMID:25606856

Enzymatic hydrolysis and ethanol fermentation of high dry matter wet-exploded wheat straw at low enzyme loading

DEFF Research Database (Denmark)

Georgieva, T.I.; Hou, Xiaoru; Hilstrøm, Troels

2008-01-01

was the most efficient in enhancing overall convertibility of the raw material to sugars and minimizing generation of furfural as a by-product. For scale-up of the process, high dry matter (DM) concentrations of 15-20% will be necessary. However, high DM hydrolysis and fermentation are limited by high...... and a low enzyme loading of 10 FPU/g cellulose in an industrial acceptable time frame of 96 h. Cellulose and hemicellulose conversion from enzymatic hydrolysis were 70 and 68%, respectively, and an overall ethanol yield from SSF was 68%....

Aerobic Stability and Effects of Yeasts during Deterioration of Non-fermented and Fermented Total Mixed Ration with Different Moisture Levels

Directory of Open Access Journals (Sweden)

W. Hao

2015-06-01

Full Text Available The present experiment evaluated the influence of moisture level and anaerobic fermentation on aerobic stability of total mixed ration (TMR. The dynamic changes in chemical composition and microbial population that occur after air exposure were examined, and the species of yeast associated with the deterioration process were also identified in both non-fermented and fermented TMR to deepen the understanding of aerobic deterioration. The moisture levels of TMR in this experiment were adjusted to 400 g/kg (low moisture level, LML, 450 g/kg (medium moisture level, MML, and 500 g/kg (high moisture level, HML, and both non-fermented and 56-d-fermented TMR were subjected to air exposure to determine aerobic stability. Aerobic deterioration resulted in high losses of nutritional components and largely reduced dry matter digestibility. Non-fermented TMR deteriorated during 48 h of air exposure and the HML treatment was more aerobically unstable. On dry matter (DM basis, yeast populations significantly increased from 107 to 1010 cfu/g during air exposure, and Candida ethanolica was the predominant species during deterioration in non-fermented TMR. Fermented TMR exhibited considerable resistance to aerobic deterioration. Spoilage was only observed in the HML treatment and its yeast population increased dramatically to 109 cfu/g DM when air exposure progressed to 30 d. Zygosaccharomyces bailii was the sole yeast species isolated when spoilage occurred. These results confirmed that non-fermented and fermented TMR with a HML are more prone to spoilage, and fermented TMR has considerable resistance to aerobic deterioration. Yeasts can trigger aerobic deterioration in both non-fermented and fermented TMR. C. ethanolica may be involved in the spoilage of non-fermented TMR and the vigorous growth of Z. bailii can initiate aerobic deterioration in fermented TMR.

Aerobic Stability and Effects of Yeasts during Deterioration of Non-fermented and Fermented Total Mixed Ration with Different Moisture Levels.

Science.gov (United States)

Hao, W; Wang, H L; Ning, T T; Yang, F Y; Xu, C C

2015-06-01

The present experiment evaluated the influence of moisture level and anaerobic fermentation on aerobic stability of total mixed ration (TMR). The dynamic changes in chemical composition and microbial population that occur after air exposure were examined, and the species of yeast associated with the deterioration process were also identified in both non-fermented and fermented TMR to deepen the understanding of aerobic deterioration. The moisture levels of TMR in this experiment were adjusted to 400 g/kg (low moisture level, LML), 450 g/kg (medium moisture level, MML), and 500 g/kg (high moisture level, HML), and both non-fermented and 56-d-fermented TMR were subjected to air exposure to determine aerobic stability. Aerobic deterioration resulted in high losses of nutritional components and largely reduced dry matter digestibility. Non-fermented TMR deteriorated during 48 h of air exposure and the HML treatment was more aerobically unstable. On dry matter (DM) basis, yeast populations significantly increased from 10(7) to 10(10) cfu/g during air exposure, and Candida ethanolica was the predominant species during deterioration in non-fermented TMR. Fermented TMR exhibited considerable resistance to aerobic deterioration. Spoilage was only observed in the HML treatment and its yeast population increased dramatically to 10(9) cfu/g DM when air exposure progressed to 30 d. Zygosaccharomyces bailii was the sole yeast species isolated when spoilage occurred. These results confirmed that non-fermented and fermented TMR with a HML are more prone to spoilage, and fermented TMR has considerable resistance to aerobic deterioration. Yeasts can trigger aerobic deterioration in both non-fermented and fermented TMR. C. ethanolica may be involved in the spoilage of non-fermented TMR and the vigorous growth of Z. bailii can initiate aerobic deterioration in fermented TMR.

Fermentation process for alcoholic beverage production from mahua ...

African Journals Online (AJOL)

Ezedom Theresa

2013-09-25

Sep 25, 2013 ... Key words: Madhuca indica, ethanol, reducing sugar, fermentation. ... The mahua flowers obtained were cleaned and dried in hot air oven at 60°C ... methanol in the fermented sample was determined with the help of.

Effect of irradiation of frozen meat/fat trimmings on microbiological and physicochemical quality attributes of dry fermented sausages.

Science.gov (United States)

Chouliara, I; Samelis, J; Kakouri, A; Badeka, A; Savvaidis, I N; Riganakos, K; Kontominas, M G

2006-10-01

Changes in microbiological and physicochemical quality attributes resulting from the use of irradiation in the production of Greek dry fermented sausage were investigated as a function of fermentation/ripening time. Results showed that irradiating meat/fat trimmings at 2 or 4kGy prior to sausage production eliminated natural contamination with Listeria spp., and reduced pseudomonads, enterococci and pathogenic staphylococci, and enterobacteria, to less than 2 and 1logcfug(-1), respectively. Pseudomonads were very sensitive (>3.4 log reduction) to either radiation dose. Yeasts were the most resistant followed by inherent lactic acid bacteria; their reductions on the trimmings were radiation dose-dependent. Residual effects of irradiation were noted against enterococci, but not against gram-negatives which died off fast during fermentation even in non-irradiated samples. Growth of the starter bacteria, Lactobacillus pentosus and Staphylococcus carnosus, inoculated in the sausage batters post-irradiation was unaffected by the 2 or 4kGy pre-treatment of the trimmings. Irradiation had little or no effect at the end of ripening period (28 days) on pH, moisture content and color (parameters L(∗), a(∗), and b(∗)). Changes in TBA values were small but statistically significant with irradiated samples having higher TBA values than control samples.

The cocoa bean fermentation process: from ecosystem analysis to starter culture development.

Science.gov (United States)

De Vuyst, L; Weckx, S

2016-07-01

Cocoa bean fermentation is still a spontaneous curing process to facilitate drying of nongerminating cocoa beans by pulp removal as well as to stimulate colour and flavour development of fermented dry cocoa beans. As it is carried out on farm, cocoa bean fermentation is subjected to various agricultural and operational practices and hence fermented dry cocoa beans of variable quality are obtained. Spontaneous cocoa bean fermentations carried out with care for approximate four days are characterized by a succession of particular microbial activities of three groups of micro-organisms, namely yeasts, lactic acid bacteria (LAB) and acetic acid bacteria (AAB), which results in well-fermented fully brown cocoa beans. This has been shown through a plethora of studies, often using a multiphasic experimental approach. Selected strains of several of the prevailing microbial species have been tested in appropriate cocoa pulp simulation media to unravel their functional roles and interactions as well as in small plastic vessels containing fresh cocoa pulp-bean mass to evaluate their capacity to dominate the cocoa bean fermentation process. Various starter cultures have been proposed for successful fermentation, encompassing both cocoa-derived and cocoa nonspecific strains of (hybrid) yeasts, LAB and AAB, some of which have been implemented on farms successfully. © 2016 The Society for Applied Microbiology.

A Process Technology For Conversion Of Dried Cassava Chips Into ...

African Journals Online (AJOL)

“Gari”, made from fermented bitter Cassava roots (Manihot esculenta crantz) were successfully processed from already dried Cassava chips at 7% moisture level. Cassava mash at 67% moisture was prepared from dried Cassava chips. This was seeded severally with fresh cassava mash and fermented for 72hours.

Behavior of Salmonella spp., Listeria monocytogenes, and Staphylococcus aureus in Chouriço de Vinho, a dry fermented sausage made from wine-marinated meat.

Science.gov (United States)

Díez, J García; Patarata, L

2013-04-01

Portuguese chouriço de vinho is made by drying coarsely minced meat and fat that has been previously marinated with wine (usually red), salt, and garlic for 1 to 2 days at a low temperature (4 to 8 °C). This procedure may improve the microbiological safety of the product. The aim of this study was to evaluate the behavior of three pathogens in this product, Salmonella spp., Listeria monocytogenes, and Staphylococcus aureus, to establish the minimum period of drying and maturation necessary to render safe products. The pathogens were inoculated in the chouriço de vinho batter. A factorial design was used to study the following variables in the fermentation process: (i) the presence or absence of an indigenous Lactobacillus sakei starter culture; (ii) the presence or absence of fermentable carbohydrates; and (iii) the salt level (1.5 or 3%). The samples were analyzed 24 h after the preparation of the batter (at stuffing); after 7, 15, and 30 days of drying; and after 30 days of storage at 4 °C under vacuum. Under all of the conditions studied, the levels of the three pathogens decreased during the drying period. In the early stages of drying, the addition of L. sakei starter culture and/or carbohydrates resulted in lower levels of gram-positive pathogens. After 15 days of drying, populations of all pathogens decreased by ca. 2 log in all samples. At that sampling time, L. monocytogenes was undetectable in the chouriço de vinho with L. sakei starter culture and carbohydrates. The mean count of S. aureus after 15 days of drying was below 1 log CFU/g. After 30 days of drying, no pathogens were detected. The drying period could be shortened to 15 days when considering only the gram-positive pathogens studied and the use of a starter culture and carbohydrates. Due to the low infective dose of Salmonella spp., the product should be considered safe after 30 days, when this pathogen became undetectable.

Effects of Freeze-dried Mulberry on Antioxidant Activities and Fermented Characteristics of Yogurt during Refrigerated Storage

Science.gov (United States)

2015-01-01

This study investigated the effect of added freeze-dried mulberry fruit juice (FDMJ) (1, 3 and 5%) on the antioxidant activity and fermented characteristic of yogurt during refrigerated storage. A decrease in pH of yogurt and increase in acidity was observed during fermentation. The yogurts with FDMJ exhibited faster rate of pH reduction than control. Initial lactic acid bacteria count of yogurt was 6.49-6.94 Log CFU/g and increased above 9 Log CFU/g in control and 1% in FDMJ yogurt for 24 h. The total polyphenol and anthocyanin content of FDMJ yogurt was higher than that of control due to the presence of phytochemical contents in mulberry. Moreover, antioxidant activity such as DPPH and reducing power was highest 5% FDMJ yogurt. During cold storage, pH decreased or remained constant in all yogurts with values ranging from 4.08 to 4.78 units. In sensory evaluation, the score of 1% FDMJ yogurt was ranked higher when compared with other yogurts. It is proposed that mulberry fruit juice powder can be used to improve sensory evaluation and enhance functionality of yogurt. PMID:26877641

Effects of Freeze-dried Mulberry on Antioxidant Activities and Fermented Characteristics of Yogurt during Refrigerated Storage.

Science.gov (United States)

Sung, Jung-Min; Kim, Young-Boong; Kum, Jun-Seok; Choi, Yun-Sang; Seo, Dong-Ho; Choi, Hyun-Wook; Park, Jong-Dae

2015-01-01

This study investigated the effect of added freeze-dried mulberry fruit juice (FDMJ) (1, 3 and 5%) on the antioxidant activity and fermented characteristic of yogurt during refrigerated storage. A decrease in pH of yogurt and increase in acidity was observed during fermentation. The yogurts with FDMJ exhibited faster rate of pH reduction than control. Initial lactic acid bacteria count of yogurt was 6.49-6.94 Log CFU/g and increased above 9 Log CFU/g in control and 1% in FDMJ yogurt for 24 h. The total polyphenol and anthocyanin content of FDMJ yogurt was higher than that of control due to the presence of phytochemical contents in mulberry. Moreover, antioxidant activity such as DPPH and reducing power was highest 5% FDMJ yogurt. During cold storage, pH decreased or remained constant in all yogurts with values ranging from 4.08 to 4.78 units. In sensory evaluation, the score of 1% FDMJ yogurt was ranked higher when compared with other yogurts. It is proposed that mulberry fruit juice powder can be used to improve sensory evaluation and enhance functionality of yogurt.

The relationship between fermented food intake and mortality risk in the European Prospective Investigation into Cancer and Nutrition-Netherlands cohort.

Science.gov (United States)

Praagman, Jaike; Dalmeijer, Geertje W; van der Schouw, Yvonne T; Soedamah-Muthu, Sabita S; Monique Verschuren, W M; Bas Bueno-de-Mesquita, H; Geleijnse, Johanna M; Beulens, Joline W J

2015-02-14

The objective of the present study was to investigate the relationship between total and subtypes of bacterial fermented food intake (dairy products, cheese, vegetables and meat) and mortality due to all causes, total cancer and CVD. From the European Prospective Investigation into Cancer and Nutrition-Netherlands cohort, 34 409 Dutch men and women, aged 20-70 years who were free from CVD or cancer at baseline, were included. Baseline intakes of total and subtypes of fermented foods were measured with a validated FFQ. Data on the incidence and causes of death were obtained from the national mortality register. Cox proportional hazards models were used to analyse mortality in relation to the quartiles of fermented food intake. After a mean follow-up of 15 (sd 2·5) years, 2436 deaths occurred (1216 from cancer and 727 from CVD). After adjustment for age, sex, total energy intake, physical activity, education level, hypertension, smoking habit, BMI, and intakes of fruit, vegetables and alcohol, total fermented food intake was not found to be associated with mortality due to all causes (hazard ratio upper v. lowest quartile (HR(Q4 v. Q1)) 1·00, 95% CI 0·88, 1·13), cancer (HR(Q4 v. Q1) 1·02, 95% CI 0·86, 1·21) or CVD (HR(Q4 v. Q1) 1·04, 95 % CI 0·83, 1·30). Bacterial fermented foods mainly consisted of fermented dairy foods (78 %) and cheese (16%). None of the subtypes of fermented foods was consistently related to mortality, except for cheese which was moderately inversely associated with CVD mortality, and particularly stroke mortality (HR(Q4 v. Q1) 0·59, 95% CI 0·38, 0·92, P trend= 0·046). In conclusion, the present study provides no strong evidence that intake of fermented foods, particularly fermented dairy foods, is associated with mortality.

Is there a potential consumer market for low-sodium fermented sausages?

Science.gov (United States)

Dos Santos, Bibiana A; Campagnol, Paulo C B; da Cruz, Adriano G; Morgano, Marcelo A; Wagner, Roger; Pollonio, Marise A R

2015-05-01

The NaCl levels in dry fermented sausages were reduced by 50% or were substituted with KCl, CaCl2 , or a blend of KCl and CaCl2 (1:1). The quality, safety, and the potential consumer market of dry fermented sausages were assessed. Neither 50% reduction of the NaCl content nor the substitution of 50% of the NaCl with KCl influenced the fermentation and maturation process. However, when CaCl2 was used as the substitute salt (50%), there was a significant decrease in pH, an increase in the water activity, and a decrease in lactic acid and micrococcus bacterial counts. Overall, the sensory acceptance decreased in dry fermented sausages with reduced sodium content. However, cluster analysis and internal preference mapping revealed potential for commercialization of samples with 50% of the NaCl content substituted with KCl or with a mixture of KCl and CaCl2 (1:1). © 2015 Institute of Food Technologists®

Ferment first, then compost

Energy Technology Data Exchange (ETDEWEB)

Dany, Christian

2012-11-01

If communal organic waste is simply dumped, it is harmful to the environment. But if it is used to produce biogas, it can become a significant source of energy. Currently, there are two dry fermentation processes available. (orig.)

Bioethanol production from dried sweet sorghum stalk

Energy Technology Data Exchange (ETDEWEB)

Almodares, A.; Etemadifar, Z.; Ghoreishi, F.; Yosefi, F. [Biology Dept. Univ. of Isfahan, Isfahan (Iran, Islamic Republic of)], e-mail: aalmodares@yahoo.com

2012-11-01

Bioethanol as a renewable transportation fuel has a great potential for energy and clean environment. Among crops sweet sorghum is one of the best feedstock for ethanol production under hot and dry climatic conditions. Because it has higher tolerance to salt and drought comparing to sugarcane and corn that are currently used for bio-fuel production in the world. Generally mills are used to extract the juice from sweet sorghum stalks. Three roller mills extract around nearly 50 percent of the juice and more mills is needed to extract higher percentage of the juice. More over under cold weather the stalks become dry and juice is not extracted from the stalk, therefore reduce harvesting period. In this study stalks were harvested, leaves were stripped from the stalks and the stalks were chopped to nearly 4 mm length and sun dried. The dry stalks were grounded to 60 mesh powder by a mill. Fermentation medium consists of 15-35% (w/w) sweet sorghum powder, micronutrients and active yeast inoculum from 0.5-1% (w/w) by submerge fermentation method. The fermentation time and temperature were 48-72 hours and 30 deg, respectively. The results showed the highest amount of ethanol (14.5 % w/w sorghum) was produced with 10% sweet sorghum powder and 1% of yeast inoculum, three day fermentation at 30 deg.

Adaptation of continuous biogas reactors operating under wet fermentation conditions to dry conditions with corn stover as substrate.

Science.gov (United States)

Kakuk, Balázs; Kovács, Kornél L; Szuhaj, Márk; Rákhely, Gábor; Bagi, Zoltán

2017-08-01

Corn stover (CS) is the agricultural by-product of maize cultivation. Due to its high abundance and high energy content it is a promising substrate for the bioenergy sector. However, it is currently neglected in industrial scale biogas plants, because of its slow decomposition and hydrophobic character. To assess the maximum biomethane potential of CS, long-term batch fermentations were carried out with various substrate concentrations and particle sizes for 72 days. In separate experiments we adapted the biogas producing microbial community in wet fermentation arrangement first to the lignocellulosic substrate, in Continuous Stirred Tank Reactor (CSTR), then subsequently, by continuously elevating the feed-in concentration, to dry conditions in solid state fermenters (SS-AD). In the batch tests, the CSTR experiment, the daily substrate loading was gradually increased from 1 to 2 g vs /L/day until the system produced signs of overloading. Then the biomass was transferred to SS-AD reactors and the adaptation process was studied. Although the specific methane yields were lower in the SS-AD arrangement (177 mL CH 4 /g vs in CSTR vs. 105 mL in SS-AD), the benefits of process operational parameters, i.e. lower energy consumption, smaller reactor volume, digestate amount generated and simpler configuration, may compensate the somewhat lower yield. Copyright © 2017 The Authors. Published by Elsevier Ltd.. All rights reserved.

Antioxidant defense parameters as predictive biomarkers for fermentative capacity of active dried wine yeast.

Science.gov (United States)

Gamero-Sandemetrio, Esther; Gómez-Pastor, Rocío; Matallana, Emilia

2014-08-01

The production of active dried yeast (ADY) is a common practice in industry for the maintenance of yeast starters and as a means of long term storage. The process, however, causes multiple cell injuries, with oxidative damage being one of the most important stresses. Consequentially, dehydration tolerance is a highly appreciated property in yeast for ADY production. In this study we analyzed the cellular redox environment in three Saccharomyces cerevisiae wine strains, which show markedly different fermentative capacities after dehydration. To measure/quantify the effect of dehydration on the S. cerevisiae strains, we used: (i) fluorescent probes; (ii) antioxidant enzyme activities; (ii) intracellular damage; (iii) antioxidant metabolites; and (iv) gene expression, to select a minimal set of biochemical parameters capable of predicting desiccation tolerance in wine yeasts. Our results show that naturally enhanced antioxidant defenses prevent oxidative damage after wine yeast biomass dehydration and improve fermentative capacity. Based on these results we chose four easily assayable parameters/biomarkers for the selection of industrial yeast strains of interest for ADY production: trehalose and glutathione levels, and glutathione reductase and catalase enzymatic activities. Yeast strains selected in accordance with this process display high levels of trehalose, low levels of oxidized glutathione, a high induction of glutathione reductase activity, as well as a high basal level and sufficient induction of catalase activity, which are properties inherent in superior ADY strains. Copyright © 2014 WILEY-VCH Verlag GmbH & Co. KGaA, Weinheim.

Solid-state fermentation : modelling fungal growth and activity

NARCIS (Netherlands)

Smits, J.P.

1998-01-01

In solid-state fermentation (SSF) research, it is not possible to separate biomass quantitatively from the substrate. The evolution of biomass dry weight in time can therefore not be measured. Of the aiternatives to dry weight available, glucosamine content is most

Effect of Fermentation Methods on the Nutrient Profile and ...

African Journals Online (AJOL)

Objective: This study evaluated the effect of fermentation method on the nutrient profile and organoleptic characteristics of African oil bean seed (Pentaclethra macrophylla Benth). Materials and Methods: Dry and mature African oil bean seeds were cleaned, boiled, dehulled, cooked, sliced/pulverized and fermented to ugba ...

Bioactive compounds in different cocoa (Theobroma cacao, L cultivars during fermentation

Directory of Open Access Journals (Sweden)

Jaqueline Fontes Moreau Cruz

2015-06-01

Full Text Available One component that contribute to the flavor and aroma of chocolate are the polyphenols, which have received much attention due to their beneficial implications to human health. Besides bioactive action, polyphenols and methylxantines are responsible for astringency and bitterness in cocoa beans. Another important point is its drastic reduction during cocoa processing for chocolate production and the difference between cultivars. Thus, the present study aimed to evaluate the modifications in monomeric phenolic compounds and methylxanthines during fermentation of three cocoa cultivars grown in southern Bahia. Cocoa beans from three cultivars were fermented and sun dried and monomeric phenolic compounds and methylxantines were determinated. The results showed that each cultivar have different amounts of phenolic compounds and the behaviour of them is different during fermentation. The amount of methylxantines varied but there was not a pattern for methylxantines behavior during process. In addition a huge reduction in phenolic compounds could be observed after drying. Differently of phenolic compounds, methylxantines did not have great modification after sun drying. So, the differences observed in this study between cultivars, take to the conclusion that the compounds studied in those cocoa cultivars have different behavior during fermentation and drying, which consequently, give to these cultivars differences in sensory characteristics.

A Traditional Turkish Fermented Non-Alcoholic Beverage, “Shalgam”

Directory of Open Access Journals (Sweden)

Fatma Coskun

2017-10-01

Full Text Available Shalgam is a traditional Turkish beverage produced by lactic acid fermentation. Shalgam is also sold in markets in some European cities. In shalgam production, bulgur flour (formed during the crushing process, it is the part that remains under the sieve after breaking the outer shells of boiled dried wheat for processing, salt, water, purple carrot, turnip, and sometimes red beet is used. The traditional method of production can take 10–12 days. Commercial production takes 4–5 days. Shalgam is a probiotic food and a good source of nutrients. It helps regulate the pH of the digestive system. It contains β-carotene, group B vitamins, calcium, potassium, and iron. People also use it as a medicine because of its antiseptic agents. Shalgam consumption should be increased and become worldwide.

Impact of fermentation, drying, roasting and Dutch processing on flavan-3-ol stereochemistry in cacao beans and cocoa ingredients.

Science.gov (United States)

Hurst, W Jeffrey; Krake, Susann H; Bergmeier, Stephen C; Payne, Mark J; Miller, Kenneth B; Stuart, David A

2011-09-14

This paper reports a systematic study of the level of flavan-3-ol monomers during typical processing steps as cacao beans are dried, fermented and roasted and the results of Dutch-processing. Methods have been used that resolve the stereoisomers of epicatechin and catechin. In beans harvested from unripe and ripe cacao pods, we find only (-)-epicatechin and (+)-catechin with (-)-epicatechin being by far the predominant isomer. When beans are fermented there is a large loss of both (-)-epicatechin and (+)-catechin, but also the formation of (-)-catechin. We hypothesize that the heat of fermentation may, in part, be responsible for the formation of this enantiomer. When beans are progressively roasted at conditions described as low, medium and high roast conditions, there is a progressive loss of (-)-epicatechin and (+)-catechin and an increase in (-)-catechin with the higher roast levels. When natural and Dutch-processed cacao powders are analyzed, there is progressive loss of both (-)-epicatechin and (+)-catechin with lesser losses of (-)-catechin. We thus observe that in even lightly Dutch-processed powder, the level of (-)-catechin exceeds the level of (-)-epicatechin. The results indicate that much of the increase in the level of (-)-catechin observed during various processing steps may be the result of heat-related epimerization from (-)-epicatechin. These results are discussed with reference to the reported preferred order of absorption of (-)-epicatechin > (+)-catechin > (-)-catechin. These results are also discussed with respect to the balance that must be struck between the beneficial impact of fermentation and roasting on chocolate flavor and the healthful benefits of chocolate and cocoa powder that result in part from the flavan-3-ol monomers.

Impact of fermentation, drying, roasting and Dutch processing on flavan-3-ol stereochemistry in cacao beans and cocoa ingredients

Science.gov (United States)

2011-01-01

This paper reports a systematic study of the level of flavan-3-ol monomers during typical processing steps as cacao beans are dried, fermented and roasted and the results of Dutch-processing. Methods have been used that resolve the stereoisomers of epicatechin and catechin. In beans harvested from unripe and ripe cacao pods, we find only (-)-epicatechin and (+)-catechin with (-)-epicatechin being by far the predominant isomer. When beans are fermented there is a large loss of both (-)-epicatechin and (+)-catechin, but also the formation of (-)-catechin. We hypothesize that the heat of fermentation may, in part, be responsible for the formation of this enantiomer. When beans are progressively roasted at conditions described as low, medium and high roast conditions, there is a progressive loss of (-)-epicatechin and (+)-catechin and an increase in (-)-catechin with the higher roast levels. When natural and Dutch-processed cacao powders are analyzed, there is progressive loss of both (-)-epicatechin and (+)-catechin with lesser losses of (-)-catechin. We thus observe that in even lightly Dutch-processed powder, the level of (-)-catechin exceeds the level of (-)-epicatechin. The results indicate that much of the increase in the level of (-)-catechin observed during various processing steps may be the result of heat-related epimerization from (-)-epicatechin. These results are discussed with reference to the reported preferred order of absorption of (-)-epicatechin > (+)-catechin > (-)-catechin. These results are also discussed with respect to the balance that must be struck between the beneficial impact of fermentation and roasting on chocolate flavor and the healthful benefits of chocolate and cocoa powder that result in part from the flavan-3-ol monomers. PMID:21917164

Antibacterial profile of fermented seed extracts of ricinus communis ...

African Journals Online (AJOL)

The study was carried out to ascertain the antibacterial properties inherent in fermented seed extracts of Ricinus communis. Dry seeds of R. communis (Castor oil plant) were deshelled, grounded to powder, fermented, and then extracted both with alcohol and water using Soxhlet machine. Different concentrations of the ...

A fermented meat model system for studies of microbial aroma formation

DEFF Research Database (Denmark)

Tjener, Karsten; Stahnke, Louise Heller; Andersen, L.

2003-01-01

A fermented meat model system was developed, by which microbial formation of volatiles could be examined The model was evaluated against dry, fermented sausages with respect to microbial growth, pH and volatile profiles. Fast and slowly acidified sausages and models were produced using the starte......H, microbial growth and volatile profiles was similar to sausage production. Based on these findings, the model system was considered valid for studies of aroma formation of meat cultures for fermented sausage.......A fermented meat model system was developed, by which microbial formation of volatiles could be examined The model was evaluated against dry, fermented sausages with respect to microbial growth, pH and volatile profiles. Fast and slowly acidified sausages and models were produced using the starter...... cultures Pediococcus pentosaceus and Staphylococcus xylosus. Volatiles were collected and analysed by dynamic headspace sampling and GC MS. The analysis was primarily focused on volatiles arising from amino acid degradation and a total of 24 compounds, of which 19 were quantified, were used...

Analysis of process factors of dry fermented salami to control Listeria monocytogenes

Directory of Open Access Journals (Sweden)

Enrico Novelli

2017-01-01

Full Text Available Challenge tests are a clear opportunity for manufacturers interested in the evaluation of their management system with the aim to reduce the spread of foodborne pathogens. This is a main concern especially in ready-to-eat food in relation to the risk associated with Listeria monocytogenes. For small and medium-scale food industry the manufacturing practices and products formulation are characterised by a wider variability and poor repeatability. The use of ad hoc challenge test and the comparison among different processing systems are strongly required. This paper reports a preliminary comparison among different challenge tests (n=12 commissioned by three manufacturers of raw-fermented salami during a period of three years (2013-2016. The challenge tests were designed to evaluate the growth potential (δ of L. monocytogenes during the whole processing period of the salami. The doughs were prepared according to different formulations: the simplest formulation was represented by the use of salt, potassium nitrate, black pepper and starter cultures, while the most composited formulations also included the use of sugars and ascorbic acid in addition to nitrite salt. All the processing steps were conducted within an experimental laboratory dedicated for the processing of meat. After stuffing, the salami were dried and ripened under temperature and relative humidity control. The sugar inclusion can be considered as a protective factor, while the drying step at high temperature (above 20°C was associated with higher δ values (δ>0.5 log10 cfu/g. The addition of starter cultures, and the subsequent acidification highlighted the importance of pH as the parameter able to affect the L. monocytogenes growth.

Analysis of Process Factors of Dry Fermented Salami to Control Listeria Monocytogenes

Science.gov (United States)

Novelli, Enrico; Dal Santo, Lucia; Balzan, Stefania; Cardazzo, Barbara; Spolaor, Dino; Lombardi, Angiolella; Carraro, Lisa; Fasolato, Luca

2017-01-01

Challenge tests are a clear opportunity for manufacturers interested in the evaluation of their management system with the aim to reduce the spread of foodborne pathogens. This is a main concern especially in ready-to-eat food in relation to the risk associated with Listeria monocytogenes. For small and medium-scale food industry the manufacturing practices and products formulation are characterised by a wider variability and poor repeatability. The use of ad hoc challenge test and the comparison among different processing systems are strongly required. This paper reports a preliminary comparison among different challenge tests (n=12) commissioned by three manufacturers of raw-fermented salami during a period of three years (2013-2016). The challenge tests were designed to evaluate the growth potential (δ) of L. monocytogenes during the whole processing period of the salami. The doughs were prepared according to different formulations: the simplest formulation was represented by the use of salt, potassium nitrate, black pepper and starter cultures, while the most composited formulations also included the use of sugars and ascorbic acid in addition to nitrite salt. All the processing steps were conducted within an experimental laboratory dedicated for the processing of meat. After stuffing, the salami were dried and ripened under temperature and relative humidity control. The sugar inclusion can be considered as a protective factor, while the drying step at high temperature (above 20°C) was associated with higher δ values (δ>0.5 log10 cfu/g). The addition of starter cultures, and the subsequent acidification highlighted the importance of pH as the parameter able to affect the L. monocytogenes growth. PMID:28462203

Cross-cultural acceptance of a traditional yoghurt-like product made from fermented cereal.

Science.gov (United States)

Akissoé, Noël H; Sacca, Carole; Declemy, Anne-Laure; Bechoff, Aurelie; Anihouvi, Victor B; Dalodé, Générose; Pallet, Dominique; Fliedel, Géneviève; Mestres, Christian; Hounhouigan, Joseph D; Tomlins, Keith I

2015-07-01

Akpan is a traditional ready-to-drink fermented yoghurt-like cereal beverage consumed in urban and rural areas in Benin. With the aim of adapting the product to new local and export markets, this work maps African and European consumer preferences for different types of Akpan. A sensory profile of Akpan was created and consumer tests were conducted with 103 consumers of African origin and 74 consumers of European origin. Consumer acceptance was significantly correlated with fermented odour (r = -0.94) and milky taste (r = 0.92-0.97) attributes. Cluster analysis revealed different behaviour by African and European consumers with respect to acceptability of Akpan; European consumers did not like the sour taste and African consumers liked an intense sweet milky taste. This study provides information on how Akpan, and other fermented yoghurt-type cereal products, could be adapted to African and European consumer preferences. © 2014 Society of Chemical Industry.

Fermentation properties of low-quality red alga Susabinori Porphyra yezoensis by intestinal bacteria.

Science.gov (United States)

Muraoka, Toshihiko; Ishihara, Kenji; Oyamada, Chiaki; Kunitake, Hiromi; Hirayama, Izumi; Kimura, Takeshi

2008-07-01

Susabinori (Porphyra yezoensis), a red alga, is cultured and processed into a sheet-style dried food, nori, in Japan. But significant amounts of cultured susabinori, which has a low protein content is discarded because of its low quality. The protein content of nori has been reported to be correlated inversely with the carbohydrate content. In this study, we examined the relationship between the protein content and the fermentation of nori by means of bfidobacteria. nori with a low protein content (25% on dry base) was strongly fermented by bifidobacteria, whereas nori with a high protein content (41% on dry base) was not. nori with a low protein content contained large amounts of glycerol galactoside (GG, floridoside: 2-O-glycerol-alpha-D-galactoside, isofloridoside: 1-O-glycerol-alpha-D-galactoside), more than 10% w/w in the dried condition, and GG was the main substrate for fermentation by bifidobacteria. GG was not digested by digestive enzymes, and was not absorbed in the small intestine. These results suggest that GG can be used as a substrate for fermentation by bifidobacteria, and possibility of GG as a prebiotic.

Fermented fish in Africa: a study on processing, marketing and consumption

National Research Council Canada - National Science Library

Essuman, Kofi Manso

1992-01-01

...; and fermentation with salting but no drying. It was also observed in the study that, unlike in Southeast Asian countries, fermented fishery products in Africa are usually whole or in cut pieces, and are not a paste or sauce...

Influência da fermentação e secagem de amêndoas de cacau no teor de compostos fenólicos e na aceitação sensorial Influence of cocoa beans fermentation and drying on the polyphenol content and sensory acceptance

Directory of Open Access Journals (Sweden)

Priscilla Efraim

2010-05-01

Full Text Available Devido à importância das etapas de fermentação e secagem das sementes de cacau para as características sensoriais dos produtos finais obtidos, bem como para os teores de compostos fenólicos presentes, objetivou-se avaliar a influência do tempo de fermentação e do tipo de secagem de sementes de cacaueiro nos teores de compostos fenólicos, bem como nas características físicas, físico-químicas e sensoriais dos produtos obtidos. Os tempos de fermentação avaliados foram 3 e 7 dias e a secagem foi realizada naturalmente (ao sol e artificialmente (estufa com circulação de ar a 35 °C. Os teores de compostos fenólicos totais, flavan-3-óis e procianidinas foram quantificados durante a fermentação e ao término da secagem. Constatou-se que grande parte dos compostos fenólicos foi perdida durante a fermentação, sendo que as amêndoas fermentadas por 3 dias apresentaram teores maiores dos compostos fenólicos avaliados. Contudo, observou-se nessa condição uma significativa perda na qualidade sensorial. A secagem natural das amêndoas fermentadas permitiu maior retenção de polifenóis e também melhores resultados sensoriais em relação à secagem artificial. A avaliação sensorial realizada com uma bebida formulada com o liquor obtido dos diferentes tratamentos demonstrou que a amostra fermentada durante 7 dias apresentou as melhores notas sensoriais, sendo que o produto seco naturalmente foi o mais bem avaliado em relação aos demais.Due to the importance of the fermentation and drying stages in the sensory characteristics and in the phenolic content of cocoa products, the present study was carried out to evaluate the influence of the fermentation period and the type of drying of cocoa seeds, on the phenolic compounds content, as well as on the physical, physicochemical, and sensorial characteristics of the products. The periods of fermentation were 3 and 7 days and the fermented beans were dried naturally (sun drying and

Effect of storage and packaging on fatty acid composition and oxidation in dry fermented sausages made with added olive oil and antioxidants

OpenAIRE

Ansorena, D. (Diana); Astiasarán, I. (Iciar)

2004-01-01

Dry fermented sausages produced by a partial substitution of pork backfat with preemulsified olive oil were manufactured and stored (2 and 5 months) using different packing conditions (aerobic/ vacuum piece/ vacuum slices) in order to evaluate the intensity of the oxidation process. Also the effect of the addition of BHT and BHA to one of the modified batches was studied. Addition of olive oil, especially with antioxidants, was more effective than using vacuum storing methods in avoiding lipi...

Quality traits of fallow deer (Dama dama dry-cured hams

Directory of Open Access Journals (Sweden)

E. Piasentier

2011-03-01

Full Text Available Meat processing by drying, after salting or fermentation and before a long ripening period, is an ancient and widespread process, used to preserve meat from spoilage. Among the wide variety of dry meat products made in Europe, the most famous ones are made from pork (Italian and Spanish dry-cured hams, fermented sausages, but other interesting products are obtained from meat of different species: i.e., the “bresaola”, from bovine, horse, goat, etc. (Paleari et al., 2002. Deer meat and meat products are interesting in this picture, since they include the high degree of consumers’ appreciation for dried products and considering the growing interest for food obtained by natural husbandry and technology...

Preparation of hydrolytic liquid from dried distiller's grains with solubles and fumaric acid fermentation by Rhizopus arrhizus RH 7-13.

Science.gov (United States)

Liu, Huan; Yue, Xuemin; Jin, Yuhan; Wang, Meng; Deng, Li; Wang, Fang; Tan, Tianwei

2017-10-01

Fumaric acid production from lignocellulosic materials is an alternative chemicals production system. This work investigated the suitable conditions for hydrolysis of dried distiller's grains with solubles (DDGS). The hydrolytic liquid was subsequently used for the production of fumaric acid. After optimizing the hydrolysis conditions, the most suitable concentration of H 2 SO 4 (2%), hydrolysis temperature (120 °C), hydrolysis time (100min) and solid/liquid ratio (1:10) were obtained. The yield of monosaccharides reached 258 mg/g DDGS and 15.88 g/L glucose, 7.53 g/L xylose and 2.35 g/L arabinose were obtained in unprocessed hydrolytic liquid. The furfural inhibitor in the hydrolytic liquid was also detected and the yield of it was reducing progressively in the pretreatment process. The ferment ability of the hydrolytic liquid from DDGS was tested through the process of fumaric acid production by Rhizopus arrhizus RH 7-13. The unprocessed hydrolytic liquid was not appropriate for the fermentation process. The yield of fumaric acid from the concentrated processed hydrolytic liquid reached 18.93 g/L, which was close to the yield of fermenting 80 g/L glucose. This result indicated that the commonly used carbon resource glucose could to some extent be replaced by processed hydrolytic liquid. Copyright © 2017 Elsevier Ltd. All rights reserved.

Acceptability of prebiotic fiber-treated whey drink fermented with ...

African Journals Online (AJOL)

This work aimed to develop a fermented drink by diversifying the quantities of Lactobacillus acidophilus inoculum and prebiotic fiber in the form of inulin and using the total dry extract of whey and sucrose. After fermentation, the following measurements were made after 0, 7, 14, 21 and 28 days of storage at 6°C: titratable ...

Changes in physical and chemical characteristics of fermented cocoa(Theobroma cacaobeans with manual and semi-mechanized transfer, between fermentation boxes

Directory of Open Access Journals (Sweden)

Pedro. P. Peláez

2016-01-01

Full Text Available The aim of this study was to evaluate variation in the physical and chemical properties of fermented cocoa beans with cocoa beans transfer between wooden fermentation boxes manually (M and semi - mechanized (SM way. Mass temperature, moisture, pH, and total acidity of the cotyledon and pulp; the total polyphenol, anthocyanin, reducing sugar, theobromine, and caffeine content in fresh, fermented, and dried beans; and percentage of fermented beans and time required to move beans during fermentation were determined. The cocoa used grew in the Pachiza district of the San Martin region of Peru. Cocoa sampling w as each 0, 48, 72, 96, 120, 144, and 168 h of fermentation. The cocoa mass temperature was highest with both removal systems after 96 h of fermentation. M cotyledon and pulp samples had the highest moisture content and titratable acidity, while cotyledon a nd pulp pH with both systems were statistically equal. In contrast, fermented beans had a higher polyphenol, anthocyanin, reducing sugar, theobromine, and caffeine content with SM. SM produced the greatest amount of fermentation (91.67% and required the s hortest amount of time to move beans (78.56 min. In conclusion, the system of fermentation of cocoa beans with SM was faster and produced fermented grains with high chemical quality.

SILAGE CANE SUGAR ADDED WITH DRIED BREWER

Directory of Open Access Journals (Sweden)

W. J. R. Castro

2015-02-01

Full Text Available The objective of this experiment was to evaluate the fermentative parameters and chemical composition of silage cane sugar added with residue dried brewery. The experimental design was completely randomized with four treatments and four replications: 100% cane sugar; 90% of cane sugar + 10% residue dried brewer; 80% of cane sugar + 20% residue dried brewer and 70% cane sugar + 30% dried brewer based on natural matter, composed silages. The sugar cane was chopped in a stationary machine with forage particle size of approximately 2 cm, and homogenized manually with the additives. For storage chopped fresh weight were used in experimental silos capacity of about 4 liters. The results showed that the contents of dry matter and crude protein showed positive linear (P0.05 with mean value of 3.81, while for ether extract and ash results were positive linear (P0.05 for N ammonia presented average value of 4.18. It is concluded that the addition of brewer dehydrated improves the fermentation process of silage cane sugar, in addition to improving their nutritional characteristics.

The economics of ethanol production by extractive fermentation

Energy Technology Data Exchange (ETDEWEB)

Daugulis, A J; Axford, D B; McLellan, P J [Queen' s Univ., Kingston, ON (Canada)

1991-04-01

Extractive fermentation is a processing strategy in which reaction and recovery occur simultaneously in a fermentation vessel through the use of a water-immiscible solvent which selectively removes an inhibitory product. An ethanol-extractive fermentation process has been developed, incorporating continuous operation and the ability to ferment concentrated feedstocks. A detailed economic assessment of this process is provided relative to current technology for an annual capacity of 100 million litres of ethanol. Extractive fermentation provides significant economic advantages for both grass roots and retrofitted plants. Total production costs are estimated at 45{cents}/l for a conventional plant and 29.4{cents}/l for a retrofitted plant. The main cost saving achievable by extractive fermentation is in energy, used for evaporation and drying, since the process uses significantly less water in its conversion of concentrated feedstocks. Producing anhydrous ethanol without distillation is also a prospect. 15 refs., 5 fig., 10 tabs.

7 CFR 52.3188 - Work sheet for dried prunes.

Science.gov (United States)

2010-01-01

... for dried prunes. Size and kind of container Container mark or identification Label or brand Varietal... fermentation, scars, heat damage, insect injury, other means, mold, dirt, foreign material, insect infestation... fermentation, scars, heat damage, insect injury, other means, mold, dirt, foreign material, insect infestation...

Thermal drying of sewage plant sludge and its disposal; El secado termico de fangos de EDAR y su disposicion

Energy Technology Data Exchange (ETDEWEB)

Elias, X.

2002-07-01

Thermal drying is one more link in the sludge treatment chain. The thickeners transfer the wastes water contaminant to the primary sludge, which contains around 5% of dry matter (DM). Mechanical dehydration brings the proportion of DM up to between 20% and 40%. Thermal drying raises the proportion of DM to between 85% and 95%. These are the solutions that have been adopted in most of the European Union. The next step consists in eliminating the organic fraction, which makes up from 40% to 60% of the DM, from the sludge. This can be done by pyrolysis-gasification or incineration. Although incineration provides the energy needed to dry the sludge and also complies with the Directive that limits the disposal of fermentable matter on dumps, it inevitably leaves behind the inorganic waste presents in the sludge. Vitrification is a simple, complementary technology for making the inorganic fraction inert while allowing it to be valorized. It thus closes the cycle and achieves zero dumping. (Author) 28 refs.

Contribution of the microbial and meat endogenous enzymes to the free amino acid and amine contents of dry fermented sausages.

Science.gov (United States)

Hierro, E; de La Hoz, L; Ordóñez, J A

1999-03-01

The role of the starter culture and meat endogenous enzymes on the free amino acid and amine contents of dry fermented sausages was studied. Five batches of sausages were prepared. The control batch was manufactured with aseptic ingredients without microbial inoculation. The other four experimental batches were manufactured with aseptic ingredients inoculated with Lactobacillus plantarum 4045 or Micrococcus-12 or L. plantarum 4045 and Micrococcus-12 or L. plantarum 4045 and Staphylococcus sp. Their effects on pH, a(w), myofibrillar proteins, and free amino acid and amine contents were studied. Sausages inoculated only with L. plantarum 4045 or with this starter combined with a Micrococcaceae had the lowest pH as a result of carbohydrate fermentation. In all batches similar patterns were observed for myofibrillar proteins and free amino acids which could indicate that meat endogenous proteases play an important role in proteolytic phenomena. No changes were observed in the amine fraction, indicating that the strains used as starter cultures did not show amino acid decarboxylase activity.

Changes in physical and chemical characteristics of fermented cocoa (Theobroma cacao beans with manual and semi-mechanized transfer, between fermentation boxes

Directory of Open Access Journals (Sweden)

Pedro. P. Peláez

2016-06-01

Full Text Available The aim of this study was to evaluate variation in the physical and chemical properties of fermented cocoa beans with cocoa beans transfer between wooden fermentation boxes manually (M and semi-mechanized (SM way. Mass temperature, moisture, pH, and total acidity of the cotyledon and pulp; the total polyphenol, anthocyanin, reducing sugar, theobromine, and caffeine content in fresh, fermented, and dried beans; and percentage of fermented beans and time required to move beans during fermentation were determined. The cocoa used grew in the Pachiza district of the San Martin region of Peru. Cocoa sampling was each 0, 48, 72, 96, 120, 144, and 168 h of fermentation. The cocoa mass temperature was highest with both removal systems after 96 h of fermentation. M cotyledon and pulp samples had the highest moisture content and titratable acidity, while cotyledon and pulp pH with both systems were statistically equal. In contrast, fermented beans had a higher polyphenol, anthocyanin, reducing sugar, theobromine, and caffeine content with SM. SM produced the greatest amount of fermentation (91.67% and required the shortest amount of time to move beans (78.56 min. In conclusion, the system of fermentation of cocoa beans with SM was faster and produced fermented grains with high chemical quality.

The Antibacterial Potential of Fermented Taro and Its Development as a Food Preservative

National Research Council Canada - National Science Library

Muller, Wayne

2002-01-01

...: The antibacterial potential of the fermented taro and its development as a food preservative. In an attempt to understand the natural fermentation of taro to poi, bacteria have been isolated from freeze dried poi produced in Hawaii...

Technological Development of Brewing in Domestic Refrigerator Using Freeze-Dried Raw Materials

Directory of Open Access Journals (Sweden)

Angelika-Ioanna Gialleli

2017-01-01

Full Text Available Development of a novel directly marketable beer brewed at low temperature in a domestic refrigerator combined with yeast immobilization technology is presented in this study. Separately, freeze-dried wort and immobilized cells of the cryotolerant yeast strain Saccharomyces cerevisiae AXAZ-1 on tubular cellulose were used in low-temperature fermentation (2, 5 and 7 °C. The positive eff ect of tubular cellulose during low-temperature brewing was examined, revealing that freeze-dried immobilized yeast cells on tubular cellulose signifi cantly reduced the fermentation rates in contrast to freeze-dried free cells, although they are recommended for home-made beer production. Immobilization also enhanced the yeast resistance at low-temperature fermentation, reducing the minimum brewing temperature value from 5 to 2 °C. In the case of high-quality beer production, the eff ect of temperature and initial sugar concentration on the fermentation kinetics were assessed. Sensory enrichment of the produced beer was confi rmed by the analysis of the fi nal products, revealing a low diacetyl concentration, together with improved polyphenol content, aroma profi le and clarity. The proposed process for beer production in a domestic refrigerator can easily be commercialized and applied by dissolving the content of two separate packages in tap water; one package containing dried wort and the other dried immobilized cells on tubular cellulose suspended in tap water.

Technological Development of Brewing in Domestic Refrigerator Using Freeze-Dried Raw Materials.

Science.gov (United States)

Gialleli, Angelika-Ioanna; Ganatsios, Vassilios; Terpou, Antonia; Kanellaki, Maria; Bekatorou, Argyro; Koutinas, Athanasios A; Dimitrellou, Dimitra

2017-09-01

Development of a novel directly marketable beer brewed at low temperature in a domestic refrigerator combined with yeast immobilization technology is presented in this study. Separately, freeze-dried wort and immobilized cells of the cryotolerant yeast strain Saccharomyces cerevisiae AXAZ-1 on tubular cellulose were used in low-temperature fermentation (2, 5 and 7 °C). The positive effect of tubular cellulose during low-temperature brewing was examined, revealing that freeze-dried immobilized yeast cells on tubular cellulose significantly reduced the fermentation rates in contrast to freeze-dried free cells, although they are recommended for home-made beer production. Immobilization also enhanced the yeast resistance at low-temperature fermentation, reducing the minimum brewing temperature value from 5 to 2 °C. In the case of high-quality beer production, the effect of temperature and initial sugar concentration on the fermentation kinetics were assessed. Sensory enrichment of the produced beer was confirmed by the analysis of the final products, revealing a low diacetyl concentration, together with improved polyphenol content, aroma profile and clarity. The proposed process for beer production in a domestic refrigerator can easily be commercialized and applied by dissolving the content of two separate packages in tap water; one package containing dried wort and the other dried immobilized cells on tubular cellulose suspended in tap water.

Impact of yeast starter formulations on the production of volatile compounds during wine fermentation.

Science.gov (United States)

Romano, Patrizia; Pietrafesa, Rocchina; Romaniello, Rossana; Zambuto, Marianna; Calabretti, Antonella; Capece, Angela

2015-01-01

The most diffused starter formulation in winemaking is actually represented by active dry yeast (ADY). Spray-drying has been reported as an appropriate preservation method for yeast and other micro-organisms. Despite the numerous advantages of this method, the high air temperatures used can negatively affect cell viability and the fermentative performance of dried cells. In the present study, 11 wine S. cerevisiae strains (both indigenous and commercial) were submitted to spray-drying; different process conditions were tested in order to select the conditions allowing the highest strain survival. The strains exhibited high variability for tolerance to spray-drying treatment. Selected strains were tested in fermentation at laboratory scale in different formulations (free fresh cells, free dried cells, immobilized fresh cells and immobilized dried cells), in order to assess the influence of starter formulation on fermentative fitness of strains and aromatic quality of wine. The analysis of volatile fraction in the experimental wines produced by selected strains in different formulations allowed identification of > 50 aromatic compounds (alcohols, esters, ketones, aldehydes and terpenes). The results obtained showed that the starter formulation significantly influenced the content of volatile compounds. In particular, the wines obtained by strains in dried forms (as both free and immobilized cells) contained higher numbers of volatile compounds than wines obtained from fresh cells. Copyright © 2014 John Wiley & Sons, Ltd.

Biofuels for fuel cells: renewable energy from biomass fermentation

NARCIS (Netherlands)

Lens, P.N.L.; Westermann, P.; Haberbauer, M.; Moreno, A.

2005-01-01

This book has been produced under the auspices of the Network ‘Biomass Fermentation Towards Usage in Fuel Cells’. The Network comprises nine partners from eight European countries and is funded by the European Science Foundation. This volume includes a chapter, from each of the member institutions,

Determination of expected alcohol yield from molasses by laboratory fermentation

Energy Technology Data Exchange (ETDEWEB)

Medintseva, L L

1960-01-01

Molasses (750 g, 18 to 19% dry weight) in 31 media, supplemented with nutrients was fermented with the industrial yeast strain. The expected alcohol yield was calculated for 1 kg conventional starch as B = V/P..pi.. 0.95, where V is the amount of alcohol distilled from the fermented medium in ml, P is the weight of molasses in g, is the fermentable sugar content of the molasses in percent, and 0.95 is the conversion factor from sucrose to starch.

Effect of lactic acid bacteria starter culture fermentation of cassava ...

African Journals Online (AJOL)

The effects of lactic acid fermentation of cassava on the chemical and sensory characteristic of fufu flour were investigated. Two strains of Lactobacillus plantarum were used as starter cultures for the fermentation of cassava to fufu for 96 h. The resultant wet fufu samples were dried at 65oC in a cabinet dryer for 48 h and ...

Protein improvement in Gari by the use of pure cultures of microorganisms involved in the natural fermentation process.

Science.gov (United States)

Ahaotu, I; Ogueke, C C; Owuamanam, C I; Ahaotu, N N; Nwosu, J N

2011-10-15

The ability of microorganisms involved in cassava mash fermentation to produce and improve protein value by these microorganisms during fermentation was studied. Standard microbiological procedures were used to isolate, identify and determine the numbers of the organisms. Alcaligenes faecalis, Lactobacillus plantarum, Bacillus subtilis, Leuconostoc cremoris, Aspergillus niger, A. tamari, Geotrichum candidum and Penicillium expansum were isolated and identified from cassava waste water while standard analytical methods were used to determine the ability of the isolates to produce linamarase and the proximate composition, pH and titrable acidity of the fermenting mash. The linamarase activity of the isolates ranged from 0.0416 to 0.2618 micromol mL(-1) nmol(-1). Bacillus subtilis, A. niger, A. tamari and P. expansum did not express any activity for the enzyme. Protein content of mash fermented with mixed fungal culture had the highest protein value (15.4 mg/g/dry matter) while the raw cassava had the least value (2.37 mg/g/dry matter). The naturally fermented sample had the least value for the fermented samples (3.2 mg/g/dry matter). Carbohydrate and fat contents of naturally fermented sample were higher than values obtained from the other fermented samples. Microbial numbers of the sample fermented with mixed bacterial culture was highest and got to their peak at 48 h (57 x 10(8) cfu g(-1)). pH decreased with increase in fermentation time with the mash fermented by the mixed culture of fungi having the lowest pH of 4.05 at the end of fermentation. Titrable acidity increased with increase in fermentation time with the highest value of 1.32% at 96 h of fermentation produced by the mixed culture of fungi. Thus fermentation with the pure cultures significantly increased the protein content of mash.

A Dried Yeast Fermentate Prevents and Reduces Inflammation in Two Separate Experimental Immune Models

Directory of Open Access Journals (Sweden)

Malkanthi Evans

2012-01-01

Full Text Available Diverse and significant benefits against cold/flu symptoms and seasonal allergies have been observed with a dried fermentate (DF derived from Saccharomyces cerevisiae (EpiCor in multiple published randomized trials. To determine if DF may influence other immune conditions, two separate animal studies were conducted. Study 1 examined the ability of DF to prevent or reduce inflammation when given orally for 14 days to rats prior to receiving 1% carrageenan (localized inflammation model. DF significantly (P<0.05 reduced swelling at all time points (1, 2, 3, 6, 12, and 24 hours versus the control. Edema severity and PGE2 levels were reduced by approximately 50% and 25% (P<0.05, respectively. Study 2 examined the ability of DF to treat established inflammation induced by type-2 collagen in mice over 4 weeks (autoimmune arthritis model. Significantly reduced arthritis scores, antibody response to type-2 collagen, and interferon-gamma levels were observed compared to controls (all parameters P<0.05. DF favorably impacts multiple acute and potentially chronic immunologic inflammatory control mechanisms and should be further tested in clinical trials.

Ethanol fermentation of molasses by Saccharomyces cerevisiae cells immobilized onto sugar beet pulp

Directory of Open Access Journals (Sweden)

Vučurović Vesna M.

2012-01-01

Full Text Available Natural adhesion of Saccharomyces cerevisiae onto sugar beet pulp (SBP is a very simple and cheap immobilization method for retaining high cells density in the ethanol fermentation system. In the present study, yeast cells were immobilized by adhesion onto SBP suspended in the synthetic culture media under different conditions such as: glucose concentration (100, 120 and 150 g/l, inoculum concentration (5, 10 and 15 g/l dry mass and temperature (25, 30, 35 and 40°C. In order to estimate the optimal immobilization conditions the yeast cells retention (R, after each immobilization experiment was analyzed. The highest R value of 0.486 g dry mass yeast /g dry mass SBP was obtained at 30°C, glucose concentration of 150 g/l, and inoculum concentration of 15 g/l. The yeast immobilized under these conditions was used for ethanol fermentation of sugar beet molasses containing 150.2 g/l of reducing sugar. Efficient ethanol fermentation (ethanol concentration of 70.57 g/l, fermentation efficiency 93.98% of sugar beet molasses was achieved using S. cerevisiae immobilized by natural adhesion on SBP. [Projekat Ministarstva nauke Republike Srbije, br. TR-31002

Decomposition and hydrolysis of starch-containing raw materials and their fermentation to alcohol

Energy Technology Data Exchange (ETDEWEB)

Rolf, D D

1957-08-29

A mixture of 1000kg bruised mash (60.5% starch) and 2600 kg 0.1% H/sub 2/SO/sub 4/ was heated for 4 minutes to 180/sup 0/. After cooling to 60/sup 0/ it was neutralized by lime to pH 5.2 sugared with 50g kiln-dried malt, and then fermented for 48 hours. Alternatively, the mixture was heated to 180/sup 0/, sugared with 100 kg kiln-dried malt, and then fermented for 66 hours.

Optimization Of Freeze-Dried Starter For Yogurt By Full Factorial Experimental Design

Directory of Open Access Journals (Sweden)

Chen He

2015-12-01

Full Text Available With the rapidly development of fermented milk product, it is significant for enhancing the performance of starter culture. This paper not only investigated the influence of anti-freeze factors and freeze-drying protective agents on viable count, freeze-drying survival rate and yield of Lactobacillus bulgaricus (LB and Streptococcus thermophilus (ST, but also optimized the bacteria proportion of freeze-dried starter culture for yogurt by full factorial experimental design. The results showed as following: the freeze-drying protective agents or anti-freeze factors could enhanced survival rate of LB and ST; the freeze-dried LB and ST powders containing both of anti-freeze factors and freeze-drying protective agents had higher viable count and freeze-drying survival rate that were 84.7% and 79.7% respectively; In terms of fermentation performance, the best group of freeze-dried starter for yogurt was the compound of LB3 and ST2.

Thua nao: Thai fermented soybean

Directory of Open Access Journals (Sweden)

Ekachai Chukeatirote

2015-09-01

Full Text Available Thua nao is a traditionally fermented food in Thailand. It is manufactured by fermenting cooked soybeans with naturally occurring microbes. There are also similar products including natto in Japan, kinema in India, and chongkukjang in Korea. In Thailand, thua nao is widely consumed, especially by people in the northern part. The product is generally regarded as a protein supplement and widely used as a condiment. Two major types of thua nao can be distinguished; fresh and dried forms. To date, scientific information on thua nao is scarce and thus this article aims to document the updated knowledge of Thai thua nao.

The improvement of fermentation activity of yeast and mould by gamma irradiation on irradiated sago and onggok substrates

International Nuclear Information System (INIS)

Sjarief, Sri Hariani; Roselawati, M.L.

1995-01-01

For the purpose of increasing the product of fermentation and enzyme activity produced by microorganism, an experiment has been carried out using irradiated yeast and mould for fermenting irradiated sago (Metroxylon sago) and tapioca waste (onggok). Sago and onggok starches were irradiated with gamma-rays with a dose of 25 kGy. Onggok starch was irradiated on dried and wet conditions. Local isolated yeast and mould (R. oryza e) were irradiated in suspension with doses of 0.4 and 4 kGy. The measurement of enzymes activities such as amylase, AMG, cellulase and protease, and the fermentation products i.e. glucose and reductase d glucose were carried out for analyzing the influence of radiation on the fermentation process. The fermentation using yeast and onggok substrate produced glucose 28 % higher than sago. On the contrary, the fermentation of sago increased the production of reductase glucose by 7.3% higher than that of onggok. At the end of experiment, on the 14th. however, the activity of cellulase enzyme produced by irradiated mould in the fermentation with dried and wet onggok increase 13 to 15 times higher than the activity enzyme produced by the control. In a similar way fermentation of irradiated dry onggok produced amylase 57.9% higher than that on irradiated wet onggok. (author), 16 refs., 2 figs

Characteristics of cassava starch fermentation wastewater based on structural degradation of starch granules

Directory of Open Access Journals (Sweden)

Juliane Mascarenhas Pereira

2016-01-01

Full Text Available ABSTRACT: Sour cassava starch is a naturally modified starch produced by fermentation and sun drying, achieving the property of expansion upon baking. Sour cassava starch' bakery products can be prepared without the addition of yeast and it is gluten free. The fermentation process associated with this product has been well studied, but the wastewater, with high acidity and richness in other organic compounds derived from starch degradation, requires further investigation. In this study, the structure of solids present in this residue was studied, seeking to future applications for new materials. The solids of the wastewater were spray dried with maltodextrin (MD with dextrose equivalent (DE of 5 and 15 and the structure of the powder was evaluated by scanning electron microscopy. A regular structure with a network arrangement was observed for the dried material with MD of 5 DE, in contrast to the original and fermented starches structure, which suggests a regular organization of this new material, to be studied in future applications.

Fermentation of cereals - Influence on digestibility of nutrients in growing pigs

DEFF Research Database (Denmark)

Jørgensen, Henry; Sholly, Danielle; Pedersen, Anni Øyan

2010-01-01

) at a ratio of 1:2.75 (wt/wt). Four experimental diets consisting of either dry or fermented barley or wheat, supplemented with a protein mixture (not fermented) were formulated to contain recommended levels of nutrients. Eight pigs from two litters were surgically fitted with a T-cannula anterior to the ileo......-cecal junction and fed one of the four experimental diets according to a repeated 4 × 4 Latin-square design. The fermentation process was followed by measuring the changes in the major nutrients, microbial composition and organic acid concentrations. Fermentation caused a reduced concentration of carbohydrates...

Simultaneous Saccharification and Fermentation of Sugar Beet Pulp for Efficient Bioethanol Production.

Science.gov (United States)

Berłowska, Joanna; Pielech-Przybylska, Katarzyna; Balcerek, Maria; Dziekońska-Kubczak, Urszula; Patelski, Piotr; Dziugan, Piotr; Kręgiel, Dorota

2016-01-01

Sugar beet pulp, a byproduct of sugar beet processing, can be used as a feedstock in second-generation ethanol production. The objective of this study was to investigate the effects of pretreatment, of the dosage of cellulase and hemicellulase enzyme preparations used, and of aeration on the release of fermentable sugars and ethanol yield during simultaneous saccharification and fermentation (SSF) of sugar beet pulp-based worts. Pressure-thermal pretreatment was applied to sugar beet pulp suspended in 2% w/w sulphuric acid solution at a ratio providing 12% dry matter. Enzymatic hydrolysis was conducted using Viscozyme and Ultraflo Max (Novozymes) enzyme preparations (0.015-0.02 mL/g dry matter). Two yeast strains were used for fermentation: Ethanol Red ( S. cerevisiae ) (1 g/L) and Pichia stipitis (0.5 g/L), applied sequentially. The results show that efficient simultaneous saccharification and fermentation of sugar beet pulp was achieved. A 6 h interval for enzymatic activation between the application of enzyme preparations and inoculation with Ethanol Red further improved the fermentation performance, with the highest ethanol concentration reaching 26.9 ± 1.2 g/L and 86.5 ± 2.1% fermentation efficiency relative to the theoretical yield.

Simultaneous Saccharification and Fermentation of Sugar Beet Pulp for Efficient Bioethanol Production

Science.gov (United States)

Berłowska, Joanna; Balcerek, Maria; Dziekońska-Kubczak, Urszula; Patelski, Piotr; Dziugan, Piotr

2016-01-01

Sugar beet pulp, a byproduct of sugar beet processing, can be used as a feedstock in second-generation ethanol production. The objective of this study was to investigate the effects of pretreatment, of the dosage of cellulase and hemicellulase enzyme preparations used, and of aeration on the release of fermentable sugars and ethanol yield during simultaneous saccharification and fermentation (SSF) of sugar beet pulp-based worts. Pressure-thermal pretreatment was applied to sugar beet pulp suspended in 2% w/w sulphuric acid solution at a ratio providing 12% dry matter. Enzymatic hydrolysis was conducted using Viscozyme and Ultraflo Max (Novozymes) enzyme preparations (0.015–0.02 mL/g dry matter). Two yeast strains were used for fermentation: Ethanol Red (S. cerevisiae) (1 g/L) and Pichia stipitis (0.5 g/L), applied sequentially. The results show that efficient simultaneous saccharification and fermentation of sugar beet pulp was achieved. A 6 h interval for enzymatic activation between the application of enzyme preparations and inoculation with Ethanol Red further improved the fermentation performance, with the highest ethanol concentration reaching 26.9 ± 1.2 g/L and 86.5 ± 2.1% fermentation efficiency relative to the theoretical yield. PMID:27722169

Detailed monitoring of two biogas plants and mechanical solid-liquid separation of fermentation residues.

Science.gov (United States)

Bauer, Alexander; Mayr, Herwig; Hopfner-Sixt, Katharina; Amon, Thomas

2009-06-01

The Austrian "green electricity act" (Okostromgesetz) has led to an increase in biogas power plant size and consequently to an increased use of biomass. A biogas power plant with a generating capacity of 500 kW(el) consumes up to 38,000 kg of biomass per day. 260 ha of cropland is required to produce this mass. The high water content of biomass necessitates a high transport volume for energy crops and fermentation residues. The transport and application of fermentation residues to farmland is the last step in this logistic chain. The use of fermentation residues as fertilizer closes the nutrient cycle and is a central element in the efficient use of biomass for power production. Treatment of fermentation residues by separation into liquid and solid phases may be a solution to the transport problem. This paper presents detailed results from the monitoring of two biogas plants and from the analysis of the separation of fermentation residues. Furthermore, two different separator technologies for the separation of fermentation residues of biogas plants were analyzed. The examined biogas plants correspond to the current technological state of the art and have designs developed specifically for the utilization of energy crops. The hydraulic retention time ranged between 45.0 and 83.7 days. The specific methane yields were 0.40-0.43 m(3)N CH(4) per kg VS. The volume loads ranged between 3.69 and 4.00 kg VS/m(3). The degree of degradation was between 77.3% and 82.14%. The screw extractor separator was better suited for biogas slurry separation than the rotary screen separator. The screw extractor separator exhibited a high throughput and good separation efficiency. The efficiency of slurry separation depended on the dry matter content of the fermentation residue. The higher the dry matter content, the higher the proportion of solid phase after separation. In this project, we found that the fermentation residues could be divided into 79.2% fluid phase with a dry matter

Dried sausages fermented with Staphylococcus xylosus at different temperatures and with different ingredient levels

DEFF Research Database (Denmark)

Stahnke, Marie Louise Heller

1995-01-01

Sausages with added Staphylococcus xylosus were fermented at different temperatures and with different added levels of salt, glucose, nitrite, nitrate and Pediococcus pentosaceus in accordance with a six factor fractional design. The odour of the sausages was evaluated by a quantitative descriptive...... tested using multiple linear regression and analysis of variance. The study showed that salami odour was more pronounced in sausages fermented at low temperature than in sausages fermented at high temperature and added nitrite, glucose and P. pentosaceus. High temperature sausages had a more sour...

Bioactive Compounds of Chamber-Dried Blueberries at Controlled Temperature and Wines Obtained from Them

Directory of Open Access Journals (Sweden)

Juan Martin-Gomez

2017-01-01

Full Text Available The effects of chamber drying under controlled temperature and moisture conditions and fermentation process on blueberry juices to obtain three wines were studied in this work. Drying was carried out with a view to increase the sugar content and obtain wines with an ethanol content similar to a commercial grape wine or to obtain sweet wines. Analyses included color parameters; browning index; and anthocyanin, flavonols, flavan-3-ol derivatives, and tannin concentrations, as well as vitamin C concentration and antioxidant activity. Based on the results, drying increases color and the concentration of anthocyanins and tannins most probably by the effect of dehydration of the berries and diffusion of the colored compounds from the skin to the pulp due to the structural alterations in their skin. In addition, drying decreases flavonols, flavan-3-ol derivatives, and vitamin C concentrations. The browning index, anthocyanins, and tannins decreased with the fermentation time, and vitamin C was constant with the fermentation time. The sensory analysis showed that the wines with the best sensory characteristics were those with residual sugar, partial fermented wines 1 and 2.

Quality of Bread Supplemented with Antrodia
salmonea-Fermented Grains

Science.gov (United States)

Chien, Rao-Chi; Ulziijargal, Enkhjargal

2016-01-01

Summary Fermented grains of buckwheat, oat, embryo rice and wheat, which were prepared by solid-state fermentation with Antrodia salmonea, and the mycelium was used to substitute 7% of wheat flour to make bread. No difference in proximate composition, texture profile and contents of non-volatile taste components was observed among bread samples. White bread and bread supplemented with mycelium and fermented grains looked different. Bread supplemented with fermented grains had similar thermal properties, which differed from those of white bread and bread supplemented with mycelium. Bread supplemented with fermented grains contained substantial mass fractions (on dry mass basis) of adenosine (0.92–1.96 µg/g), ergosterol (24.53–30.12 µg/g), ergothioneine (2.16–3.18 µg/g) and γ-aminobutyric acid (2.20–2.45 µg/g). In addition, bread supplemented with mycelium contained lovastatin (0.43 µg/g). White bread and bread supplemented with fermented grains had similar sensory results. Overall, fermented grains could be incorporated into bread to provide beneficial effects. PMID:27904408

Quality of Bread Supplemented with Antrodia salmonea-Fermented Grains

Directory of Open Access Journals (Sweden)

Rao-Chi Chien

2016-01-01

Full Text Available Fermented grains of buckwheat, oat, embryo rice and wheat, which were prepared by solid-state fermentation with Antrodia salmonea, and the mycelium was used to substitute 7 % of wheat flour to make bread. No difference in proximate composition, texture profile and contents of non-volatile taste components was observed among bread samples. White bread and bread supplemented with mycelium and fermented grains looked different. Bread supplemented with fermented grains had similar thermal properties, which differed from those of white bread and bread supplemented with mycelium. Bread supplemented with fermented grains contained substantial mass fractions (on dry mass basis of adenosine (0.92–1.96 μg/g, ergosterol (24.53–30.12 μg/g, ergothioneine (2.16–3.18 μg/g and γ-aminobutyric acid (2.20–2.45 μg/g. In addition, bread supplemented with mycelium contained lovastatin (0.43 μg/g. White bread and bread supplemented with fermented grains had similar sensory results. Overall, fermented grains could be incorporated into bread to provide beneficial effects.

Effects of humus on acetone-butanol fermentations

Energy Technology Data Exchange (ETDEWEB)

Kovats, J

1963-01-01

Adding 6 to 8 g humus-rich soil dried at 80/sup 0/ to 100 cc sterilized molasses, containing 3.8 sucrose and 0.1% (NH/sub 4/)/sub 2/HPO/sub 4/, inoculated with acetone-butanol fermentative bacteria, increased acetone, butanol, and ethanol yields by 30, 50, and 40%, respectively. The acetone-to-butanol ratio increased from 1.85 to 2.1-2.3 in low and 2.6-2.8 in high sucrose-molasses concentrations. Yields of total organic solvents increased from 25 to 36-8% of the sucrose present. Inorganic salts from ashed humus soils were only 10 to 20% less effective in enhancing fermentation than the whole soil. It is postulated that the fermentation is enhanced by trace elements present in the soil.

Optimisation of the addition of carrot dietary fibre to a dry fermented sausage (sobrassada) using artificial neural networks.

Science.gov (United States)

Eim, Valeria S; Simal, Susana; Rosselló, Carmen; Femenia, Antoni; Bon, José

2013-07-01

An optimisation problem was formulated to maximise the amount of carrot dietary fibre (CDF) in a dry fermented sausage, while maintaining product quality, by using 0-12% CDF as the decision variable, and limiting values of several physico-chemical and textural parameters (moisture content, water activity, pH, colour, non-protein nitrogen, free fatty acid, compression work and hardness) as constraints. The evolution of each quality parameter during the ripening process was estimated by developing a multi-layer feed forward artificial neural network (ANN), taking into consideration the CDF concentration and the ripening time as independent variables. Results indicate an optimum CDF concentration of 4.9% with a good correlation between experimental and estimated values (mean relative error≤3.35%). Copyright © 2013 Elsevier Ltd. All rights reserved.

Effect of sodium ascorbate and sodium nitrite on protein and lipid oxidation in dry fermented sausages.

Science.gov (United States)

Berardo, A; De Maere, H; Stavropoulou, D A; Rysman, T; Leroy, F; De Smet, S

2016-11-01

The effects of sodium nitrite and ascorbate on lipid and protein oxidation were studied during the ripening process of dry fermented sausages. Samples were taken at day 0, 2, 8, 14, 21 and 28 of ripening to assess lipid (malondialdehyde) and protein (carbonyls and sulfhydryl groups) oxidation. Sodium ascorbate and nitrite were separately able to reduce the formation of malondialdehyde. Their combined addition resulted in higher amounts of carbonyl compounds compared to their separate addition or the treatment without any of both compounds. Moreover, sodium nitrite limited the formation of γ-glutamic semialdehyde whereas sodium ascorbate showed a pro-oxidant effect. A loss of thiol groups was observed during ripening, which was not affected by the use of sodium ascorbate nor sodium nitrite. In conclusion, sodium nitrite and ascorbate affected protein and lipid oxidation in different manners. The possible pro-oxidant effect of their combined addition on carbonyl formation might influence the technological and sensory properties of these products. Copyright © 2016 Elsevier Ltd. All rights reserved.

Comparison of fermentation of diets of variable composition and microbial populations in the rumen of sheep and Rusitec fermenters. I. Digestibility, fermentation parameters, and microbial growth.

Science.gov (United States)

Martínez, M E; Ranilla, M J; Tejido, M L; Ramos, S; Carro, M D

2010-08-01

Four ruminally and duodenally cannulated sheep and 8 Rusitec fermenters were used to determine the effects of forage to concentrate (F:C) ratio and type of forage in the diet on ruminal fermentation and microbial protein synthesis. The purpose of the study was to assess how closely fermenters can mimic the dietary differences found in vivo. The 4 experimental diets contained F:C ratios of 70:30 or 30:70 with either alfalfa hay or grass hay as the forage. Microbial growth was determined in both systems using (15)N as a microbial marker. Rusitec fermenters detected differences between diets similar to those observed in sheep by changing F:C ratio on pH; neutral detergent fiber digestibility; total volatile fatty acid concentrations; molar proportions of acetate, propionate, butyrate, isovalerate, and caproate; and amylase activity. In contrast, Rusitec fermenters did not reproduce the dietary differences found in sheep for NH(3)-N and lactate concentrations, dry matter (DM) digestibility, proportions of isobutyrate and valerate, carboxymethylcellulase and xylanase activities, and microbial growth and its efficiency. Regarding the effect of the type of forage in the diet, Rusitec fermenters detected differences between diets similar to those found in sheep for most determined parameters, with the exception of pH, DM digestibility, butyrate proportion, and carboxymethylcellulase activity. Minimum pH and maximal volatile fatty acid concentrations were reached at 2h and at 6 to 8h postfeeding in sheep and fermenters, respectively, indicating that feed fermentation was slower in fermenters compared with that in sheep. There were differences between systems in the magnitude of most determined parameters. In general, fermenters showed lower lactate concentrations, neutral detergent fiber digestibility, acetate:propionate ratios, and enzymatic activities. On the contrary, fermenters showed greater NH(3)-N concentrations, DM digestibility, and proportions of propionate

Hydrocarbons by fermenting the juice of the Jerusalem artichoke

Energy Technology Data Exchange (ETDEWEB)

Joud, F R

1976-02-13

The artichoke juice containing nonfermentable insulins is acidified to pH 3- and heated at 95/sup 0/ for 30 to 40 minutes to hydrolyze the insulins into fermentable sugars which are then fermented to ethanol. The ethanol is dried and reacted with H/sub 2/SO/sub 4/ to form C/sub 2/H/sub 4/ which is treated at 300/sup 0/ under pressure with a powdered Ni catalyst to form alkanes, alkenes, and alkynes.

Development of dry-cured sausages using spent-hen meat: manufacturing practices and product physical, chemical and microbiological quality

Directory of Open Access Journals (Sweden)

K. Boodhoo

2015-06-01

No Salmonella was detected in any samples analyzed. Counts of Staphylococcus spp. were high with 104/g to 108/g at the end of the fermentation/drying period. L. plantarum counts increasedduring the first five days of fermentation from 4.9 to 8.7 log10 CFU/g and remained practically at this level for the rest of the drying period. There was unwanted mould growth on the cel­lulose casings as from day 3. In all cases, the sausages lacked the compactness typical of dry-cured sausages. The meat and fat particles in the final sausages were not uniformly distributed. This may be due to the low melting point of the fat thereby caus­ing smearing of fat particles. Overall, the potential of using spent-layer meat for the manu­facture of dry-fermented sausage was shown to be technologi­cally feasible. However there is a need to optimize the process­ing steps, especially with regard to the starter culture, and the temperature and relative humidity of fermentation/drying, to improve the safety and quality of the sausages.

Hanseniaspora opuntiae, Saccharomyces cerevisiae, Lactobacillus fermentum, and Acetobacter pasteurianus predominate during well-performed Malaysian cocoa bean box fermentations, underlining the importance of these microbial species for a successful cocoa bean fermentation process.

Science.gov (United States)

Papalexandratou, Zoi; Lefeber, Timothy; Bahrim, Bakhtiar; Lee, Ong Seng; Daniel, Heide-Marie; De Vuyst, Luc

2013-09-01

Two spontaneous Malaysian cocoa bean box fermentations (one farm, two plantation plots) were investigated. Physical parameters, microbial community dynamics, yeast and bacterial species diversity [mainly lactic acid bacteria (LAB) and acetic acid bacteria (AAB)], and metabolite kinetics were monitored, and chocolates were produced from the respective fermented dry cocoa beans. Similar microbial growth and metabolite profiles were obtained for the two fermentations. Low concentrations of citric acid were found in the fresh pulp, revealing low acidity of the raw material. The main end-products of the catabolism of the pulp substrates glucose, fructose, and citric acid by yeasts, LAB, and AAB were ethanol, lactic acid, acetic acid, and/or mannitol. Hanseniaspora opuntiae, Lactobacillus fermentum, and Acetobacter pasteurianus were the prevalent species of the two fermentations. Saccharomyces cerevisiae, Lactobacillus plantarum, Lactobacillus pentosus, and Acetobacter ghanensis were also found during the mid-phase of the fermentation processes. Leuconostoc pseudomesenteroides and Acetobacter senegalensis were among the prevailing species during the initial phase of the fermentations. Tatumella saanichensis and Enterobacter sp. were present in the beginning of the fermentations and they could be responsible for the degradation of citric acid and/or the production of gluconic acid and lactic acid, respectively. The presence of facultative heterofermentative LAB during the fermentations caused a high production of lactic acid. Finally, as these fermentations were carried out with high-quality raw material and were characterised by a restricted microbial species diversity, resulting in successfully fermented dry cocoa beans and good chocolates produced thereof, it is likely that the prevailing species H. opuntiae, S. cerevisiae, Lb. fermentum, and A. pasteurianus were responsible for it. Copyright © 2013 Elsevier Ltd. All rights reserved.

Identification of small peptides arising from hydrolysis of meat proteins in dry fermented sausages.

Science.gov (United States)

López, Constanza M; Bru, Elena; Vignolo, Graciela M; Fadda, Silvina G

2015-06-01

In this study, proteolysis and low molecular weight (LMW) peptides (<3kDa) from commercial Argentinean fermented sausages were characterized by applying a peptidomic approach. Protein profiles and peptides obtained by Tricine-SDS-PAGE and RP-HPLC-MS, respectively, allowed distinguishing two different types of fermented sausages, although no specific biomarkers relating to commercial brands or quality were recognized. From electrophoresis, α-actin, myoglobin, creatine kinase M-type and L-lactate dehydrogenase were degraded at different intensities. In addition, a partial characterization of fermented sausage peptidome through the identification of 36 peptides, in the range of 1000-2100 Da, arising from sarcoplasmic (28) and myofibrillar (8) proteins was achieved. These peptides had been originated from α-actin, myoglobin, and creatine kinase M-type, but also from the hydrolysis of other proteins not previously reported. Although muscle enzymes exerted a major role on peptidogenesis, microbial contribution cannot be excluded as it was postulated herein. This work represents a first peptidomic approach for fermented sausages, thereby providing a baseline to define key peptides acting as potential biomarkers. Copyright © 2015 Elsevier Ltd. All rights reserved.

A two-step fermentation of distillers' grains using Trichoderma viride and Rhodopseudomonas palustris for fish feed.

Science.gov (United States)

Zhang, Jian; Zhang, Wen-Xue; Li, Shun-Zhou; You, Ling; Zhang, Chao; Sun, Chuan-Ze; Liu, Xiao-Bin

2013-10-01

It is important to provide added value or to make full use of the co-product of grains from ethanol production. In order to convert distillers' grains into a high-quality feed, the Trichoderma viride and Rhodopseudomonas palustris fermentation were combined and investigated in this study. The T. viride fermentation was carried out in an aerobic fermentation installation in favoring of the growth of the fungi and the degradation of the cellulose, and then the fermentation of R. palustris was performed to increase the content of protein with an anaerobic installation. After the two step fermentations, the true protein content of dried distiller' grains increased from 11.4 to 33.6 % (w/w) (the content of crude protein from 14.5 to 39.7 %), the crude fiber content decreased from 21.3 to 7.6 % (w/w), the crude fat content increased from 5.5 to 7.9 % (w/w), the crude ash decreased from 14.6 to 10.2 % (w/w), the total phosphorus content increased from 0.4 to 1.2 % (w/w), and the water content was 11.8 % (w/w). The dried and fermented grains contain the R. palustris viable count of 5.3 × 10¹¹ CFU/g dry matter. The results may support a new application of an active photosynthetic bacteria fish feed in fisheries industry and offer a reference for the further study of lignocellulosic materials as raw materials converting into high-quality feed.

Fermented feed for laying hens: effects on egg production, egg quality, plumage condition and composition and activity of the intestinal microflora.

Science.gov (United States)

Engberg, R M; Hammershøj, M; Johansen, N F; Abousekken, M S; Steenfeldt, S; Jensen, B B

2009-03-01

1. An experiment with a total of 480 hens (Babcock) was carried out from 16 to 38 weeks of age to evaluate the suitability of wet fermented feed (feed water ratio, 1:1.2-1:1.4) for layers, taking aspects of nutrition and gastrointestinal health into consideration. The production performance, egg shell quality, plumage condition, litter dry matter (DM) content, as well as the composition and activity of the intestinal microbial flora were analysed. 2. Fermented feed was characterised by a high concentration of lactic acid (160-250 mmol/kg feed) and a moderate level of acetic acid (20-30 mmol/kg feed), high numbers of lactic acid bacteria (log 9-10 CFU/g feed) and a pH of approximately 4.5. Feed fermentation reduced the concentration of dietary sugar from 32.1 to 7.3 g/kg DM and the phytate bound phosphorus from 2.7 to 1.9 g/kg DM. 3. Fermented feed seemed to loose attractiveness for the birds quite rapidly, resulting in a more aggressive behaviour and a poorer plumage condition than in birds given dry feed. The use of fermented feed reduced the litter DM content. 4. During the experimental period, the body weight gain of hens receiving fermented feed was 80 g higher than of hens fed the dry mash. Presumably because of an extended adaptation time to the feed, the onset of lay occurred later when hens were fed on fermented feed, resulting in non-significantly reduced total egg production (75 vs. 82%). 5. There was no significant difference between groups with respect to the total egg mass production (g/d/hen, 42 and 45 for fermented feed and dry mash, respectively). Throughout the experimental period, the feed DM intake of hens fed with fermented feed was lower than that of hens receiving the dry mash (110 vs. 125 g). From week 26 to 37, fermented feed improved the feed conversion as compared with the dry mash (g feed DM/g egg mass, 2.28 vs. 2.53). 6. The use of fermented feed increased egg weight in the period from 34 to 37 weeks (61.4 vs. 60.0) and increased shell

Round-Bale Silage Harvesting and Processing Effects on Overwintering Ability, Dry Matter Yield, Fermentation Quality, and Palatability of Dwarf Napiergrass (Pennisetum purpureum Schumach

Directory of Open Access Journals (Sweden)

Satoru Fukagawa

2017-02-01

Full Text Available Round-bale silage harvesting and processing methods were assessed to evaluate overwintering ability and dry matter (DM yield, fermentation quality and palatability of overwintered dwarf Napiergrass (Pennisetum purpureum Schumach in the two years following establishment in Nagasaki, Japan, in May 2013 using rooted tillers with a density of 2 plants/m2. In 2014, harvesting methods under no-wilting treatment were compared for flail-type harvesting with a round-baler (Flail/baler plot and mower conditioning with a round-baler (Mower/baler plot, which is common for beef-calf–producing farmers in the region. In 2015, the effect of ensilage with wilting was investigated only in the Mower/baler plot. Dwarf Napiergrass was cut twice, in early August (summer and late November (late autumn, each year. The winter survival rate was greater than 96% in May both years. The DM yield in the Mower/baler plot did not differ significantly for the first summer cutting or the annual total from the Flail/baler plot, but did show inferior yield for the second cutting. The fermentation quality of the second-cut plants, estimated using the V2-score, was higher in the Flail/baler plot than in the Mower/baler plot, possibly because of higher air-tightness, and the second-cut silage tended to have better fermentation quality than the first-cut silage in both harvesting plots. Wilting improved the fermentation quality of dwarf Napiergrass silage in summer, but not in autumn. The palatability of the silage, as estimated by alternative and voluntary intake trials using Japanese Black beef cattle, did not differ significantly between plots. The results suggest that dwarf Napiergrass can be better harvested using a mower conditioner with processing by a round-baler, an approach common to beef-calf–producing farmers, than with the flail/baler system, without reducing the persistence, yield, or palatability of the silage. Moreover, wilting treatment improved the fermentation

FERMENTATION PROCESS CHARACTERISTICS OF DIFFERENT MAIZE SILAGE HYBRIDS

Directory of Open Access Journals (Sweden)

Daniel Bíro

2009-03-01

Full Text Available The aim of this study was to detect the fermentation process differences in different hybrid maize silage. We conserved in laboratory conditions hybrids of whole maize plants with different length of the vegetative period (FAO number. Maize hybrids for silage were harvested in the vegetation stage of the milk-wax maturity of corn and the content of dry matter was from 377.7 to 422.8 g.kg-1. The highest content of dry matter was typical for silages made from the hybrids with FAO number 310 (400.0 g.kg-1 and FAO 300a (400.4 g.kg-1. The content of desirable lactic acid ranged from 23.7 g.kg-1 of dry matter (FAO 350 to 58.9 g.kg-1 of dry matter (FAO 420. We detected the occurrence of undesirable butyric acid in silages from hybrids FAO 250, 300b, 310 and 380. The highest content of total alcohols we found in silages made from hybrid with FAO number 240 (25.2 g.kg-1 of dry matter. Ammonia contents were in tested silages from 0.153 (FAO 270 to 0.223 g.kg-1 of dry matter (FAO 240. The lowest value of silage titration acidity we analyzed in silage made from hybrid FAO 420 (3.66. We observed in maize silages with different length of plant maturity tested in the experiment differences in content of lactic acid, total alcohols, titration acidity, pH and content of fermentation products.

Etude microbiologique des feuilles fermentées de manioc: "Ntoba Mbodi"

Directory of Open Access Journals (Sweden)

Bouanga Kalou, G.

2003-01-01

Full Text Available Microbiological Study of "Ntoba-Mbodi", Fermented Cassava Leaves. Some families and small processing units proceed by way of fermentation of the cassava leaves to make "ntoba mbodi", a dish with a particular taste and flavor. The fermentation process lastes 4 days and after that the product undergoes significant alteration. During fermentation, about 70% of the cyanogenic glucosides are eliminated compared to 82 to 94% by blanching, vapor cooking or sun drying. Thus fermentation can be considered as good in eliminating cyanide as these other methods. Contrary to other plant material whose fermentation leads to an increase in acidity, fermentation of cassava leaves leads to alkalinization, with the pH rising from 6.2 to 8.9. Microbiological analyses of the fermented cassava leaves reveal the unusual presence of Micrococcus varians, Bacillus macerans, Bacillus subtilis, Staphylococcus sciuri and Staphylococcus xylosus among the other usual microorganisms; however yeasts and Leuconostoc strains are not present. Among this micro-organisms, Bacillus macerans, Bacillus subtilis, Bacillus cereus, Staphylococcus xylosus and Erwinia spp. play an important role in with their polysaccharolytic enzymes.

Chemical Assessment of White Wine during Fermentation Process

Directory of Open Access Journals (Sweden)

Teodora Coldea

2014-05-01

Full Text Available There were investigated chemical properties of indigenous white wine varieties (Fetească albă, Fetească regală and Galbenă de Odobeşti during fermentation. The white wine making process took place at Wine Pilot Station of University of Agricultural Sciences and Veterinary Medicine Cluj-Napoca. We aimed to monitorize the evolution of fermentation process parameters (temperature, alcohol content, and real extract and the quality of the bottled white wine (total acidity, alcohol content, total sulfur dioxide, total dry extract. The results obtained were in accordance to Romanian Legislation.

Comparison of the fate of the top six non-O157 shiga-toxin producing Escherichia coli (STEC) and E. coli O157:H7 during the manufacture of dry fermented sausages.

Science.gov (United States)

Balamurugan, S; Ahmed, Rafath; Gao, Anli; Strange, Phil

2017-10-16

The study examined the relative fate of the top six non-O157 shiga-toxin producing Escherichia coli (STEC) and E. coli O157:H7 during the manufacture of dry fermented sausages (DFS). Three separate batches of sausages containing a five-strain cocktail for each serogroup and uninoculated control were manufactured and subjected to identical fermentation, maturation and dry curing conditions. Changes in physicochemical properties and inoculated STEC numbers were enumerated during the DFS production stages and log reduction and log reduction rates were calculated. Inoculation of very high concentrations (8logCFUg -1 ) of STEC in the sausage batter did not significantly (P>0.05) affect the changes in the pH, a w , moisture, protein, fat content compared to the uninoculated DFS. There was a significant (P0.05) from each other. These results indicate that the lethality of DFS production processes observed against E. coli O157:H7 would result in a similar inactivation of the top six non-O157 STEC. Crown Copyright © 2017. Published by Elsevier B.V. All rights reserved.

Fermentation Kinetic of Maize Straw-Gliricidia Feed Mixture Supplemented by Fermentable Carbohydrate Measured by In Vitro Gas Production

Science.gov (United States)

Yulistiani, D.; Nurhayati

2018-02-01

Utilization of crop by-products such as maize straw mixed with legume is expected to be able to overcome the limitation of forage availability during dry season and have similar nutritional value with grass. Addition of fermentable carbohydrate in this diet can be improved fermentability and reduced methane production. The objective of this study was to evaluate supplementation of ground corn grain or rice bran as fermentable carbohydrate in maize straw-gliricidiamixture. Treatment diets evaluated were: Maize straw + gliricidialeaf meal (Control/RO); Control + 10% ground maize grain (ROC); Control + 10% rice bran (RORB). Maize straw was chopped and ground then mixed with gliricidia leaf meal at ratio 60:40% DM. Maize straw-gliricidia mixture then supplemented either with ground corn grain or rice bran at 10% of DM basal diet (control). Sample was incubated for 48 hours, gas production was recorded at 4, 8,12, 16, 24, 36 and 48 hours. Study was conducted in randomized complete design. Results of the study showed that supplementation of fermentable carbohydrate from corn grain or rice bran was able to increased (Pfermentation and reduced methane production.

Effect of Time Lenght Fermentation to Katsuobushi Oxidation Rate As Fish Flavor Based

Science.gov (United States)

Amalia, U.; Rianingsih, L.; Wijayanti, I.

2018-02-01

Katsuobushi or dried smoked skipjack had a distinctive flavor and widely used in traditional Japanese cuisine. This study aimed to evaluate the oxidation rate of Katsuobushi with different lenght fermentation. The processing treatment of the product were the differences of fish boiling time (30 min and 60 min) and the lenght of fermentation: 1 week, 2 weeks and 3 weeks. The glutamic acid content, the oxidation rate (thiobarbituric acid and peroxide value) and Total Plate Count of katsuobushi were analyzed statistically using analysis of varians. Significant differences were found among 3 weeks of fermentation compare to 1 weeks fermentation (P fermentation was potential to be developed become basic ingredients for the fish flavor.

Manioc alcohol by continuous fermentation

Energy Technology Data Exchange (ETDEWEB)

Del Bianco, V; de Queiroz Araujo, N; Miceli, A; Souza e Silva, P C; da Silva Burle, J A

1976-01-01

EtOH was produced from dry cassava meal by first obtaining a glucose syrup by enzymic action, then fermenting the syrup with yeast. Bacillus subtilis amylase and Aspergillus awamori amyloglucosidase were prepared by growing the organisms on cassava meal. Both enzymes were used to saccharify the cassava starch to syrup. Saccharomyces cervisiae ATCC 1133 was then used in a continuous process to produce EtOH.

Solid state fermentation and production of rifamycin SV using Amycolatopsis mediterranei.

Science.gov (United States)

Nagavalli, M; Ponamgi, S P D; Girijashankar, V; Venkateswar Rao, L

2015-01-01

Production of Rifamycin SV from cheaper agro-industrial by-products using mutant strain of Amycolatopsis mediterranei OVA5-E7 in solid state fermentation (SSF) was optimized. Among the agro-based substrates used, ragi bran was found suitable for maximizing the yield of Rifamycin SV (1310 mg 100 g(-1) ds). The yield can be further enhanced to 19·7 g Kg(-1) of dry substrate by supplementing the substrate with deoiled cotton cake (10% w/w) using optimized fermentation parameters such as maintaining 80% moisture, pH 7·0, 30°C incubation temperature, inoculum 25% v/w and carrying the solid state fermenting for 9 days. Manipulating these seven specifications, the end product yield achieved in our experimentation was 20 g of Rifamycin SV Kg(-1) ds. Eventually, an overall 5-fold improvement in Rifamycin SV production was achieved. Antibiotics such as rifamycin are broad-spectrum antimicrobial drugs used in large-scale worldwide as human medicine towards controlling diseases. Amycolatopsis mediterranei strain which produces this antibiotic was earlier used in submerged fermentation yielded lower amounts of rifamycin. By employing cheaper agro-industrial by-products, we produced upto 20 g rifamycin SV per Kg dry substrate used under optimized solid state fermentation conditions. Keeping in view, the role of rifamycin in meeting the medical demands of world's increasing population; we successfully used an improved strain on cheaper substrates with optimized fermentation parameters and achieved a 5-fold improvement in rifamycin SV production. © 2014 The Society for Applied Microbiology.

PEI detoxification of pretreated spruce for high solids ethanol fermentation

International Nuclear Information System (INIS)

Cannella, David; Sveding, Per Viktor; Jørgensen, Henning

2014-01-01

Highlights: • High solids (30% dry matter) pretreatment, enzymatic hydrolysis and fermentation. • Horizontal rotary reactor for hydrolysis and fermentation. • In situ hydrolysates detoxification using inhibitors adsorbing PEI polymer. • 50% of inhibitors recovered as by-product, recyclability of PEI polymer up to 5 times. • 76% of maximum theoretical ethanol was fermented at final concentration of 51 g/kg. - Abstract: Performing the bioethanol production process at high solids loading is a requirement for economic feasibility at industrial scale. So far this has successfully been achieved using wheat straw and other agricultural residues at 30% of water insoluble solids (WIS), but for softwood species (i.e. spruce) this has been difficult to reach. The main reason behind this difference is the higher recalcitrance of woody substrates which require harsher pretreatment conditions, thus generating higher amounts of inhibitory compounds, ultimately lowering fermentation performances. In this work we studied ethanol production from spruce performing the whole process, from pretreatment to hydrolysis and fermentation, at 30% dry matter (equivalent to ∼20% WIS). Hydrolysis and fermentation was performed in a horizontal free fall mixing reactor enabling efficient mixing at high solids loadings. In batch simultaneous saccharification and fermentation (SSF), up to 76% cellulose to ethanol conversion was achieved resulting in a concentration of 51 g/kg of ethanol. Key to obtaining this high ethanol yield at these conditions was the use of a detoxification technology based on applying a soluble polyelectrolyte polymer (polyethylenimine, PEI) to absorb inhibitory compounds in the material. On average 50% removal and recovery of the main inhibitors (HMF, furfural, acetic acid and formic acid) was achieved dosing 1.5% w/w of soluble PEI. The use of PEI was compatible with operating the process at high solids loadings and enabled fermentation of hydrolysates, which

PEI detoxification of pretreated spruce for high solids ethanol fermentation

DEFF Research Database (Denmark)

Cannella, David; Sveding, Per Viktor; Jørgensen, Henning

2014-01-01

.e. spruce) this has been difficult to reach. The main reason behind this difference is the higher recalcitrance of woody substrates which require harsher pretreatment conditions, thus generating higher amounts of inhibitory compounds, ultimately lowering fermentation performances. In this work we studied...... ethanol production from spruce performing the whole process, from pretreatment to hydrolysis and fermentation, at 30% dry matter (equivalent to similar to 20% WIS). Hydrolysis and fermentation was performed in a horizontal free fall mixing reactor enabling efficient mixing at high solids loadings....... In batch simultaneous saccharification and fermentation (SSF), up to 76% cellulose to ethanol conversion was achieved resulting in a concentration of 51 g/kg of ethanol. Key to obtaining this high ethanol yield at these conditions was the use of a detoxification technology based on applying a soluble...

What is alcoholic fermentation? A study about the alcoholic fermentation conception through the history

Directory of Open Access Journals (Sweden)

C.A. F. Cardoso

2004-05-01

Full Text Available This work shows the historical development of the alcoholic fermentation conception, based on expe-rimental results obtained from European scientists, from Renascence to the beginning of 20th century(1930. From this, ve concepts were identied for the phenomenon: putrefactive, spiritual, chemical,biological and biochemical. The current conception of alcoholic fermentation was also evaluated. Forthis proposal, three groups of teachers were interviewed through the question? What is alcoholicfermentation? The P group (pilot, n=12 made of professionals that teach on secondary and highschools, group A composed of PhDs from the Center of Technology Education - NUTES (n=9 andgroup B from Department of Medical Biochemistry (called group B, n=41 both of Federal Universityof Rio de Janeiro, respectively. Key words associated with the fermentative process were identiedidentify in the interviewees answers. The group A components mentioned only six key words andpointed out the alcoholic fermentation products. Dierently, subjects from P and B groups cited ahigher number and also more unusual key words (n = 9 and 12, respectively. We also analyzedtheir answers throughout fermentative descriptive words (sugar, alcohol, carbon dioxide, anaerobic,yeast and ATP. These words were established after an evaluation of alcoholic fermentation conceptstated in the Biology/Biochemistry books most adopted in high schools and Universities. Our analysisshowed that group A used only three descriptive words (sugar, alcohol and yeast while componentsof group B used all the selected descriptive words. However, only one interviewee used all the sixwords together. From this analysis, we proposed that the chemical concept of alcoholic fermentationprevailed on the other concepts found on the historical research (spiritual, putrefactive, biological ebiochemical.

Immobilization of Cells and Enzymes for Fermented Dairy or Meat Products

Science.gov (United States)

Champagne, Claude P.; Lee, Byong H.; Saucier, Linda

Historically, we can find fermented products in almost all cultural backgrounds around the world. Notably, there are many different milk or meat-based foods and this chapter will focus on them (Kosikowski 1982; Wood 1998). Cheese, yoghurt, sour cream, kefir, or cultured butter are probably the most common fermented dairy products, but many regional varieties exist (Farnworth 2004). Fermented meats are typically found as dry sausages (Lüke 1998). Yeasts are mostly involved in the manufacture of bread and alcoholic beverages, which are basically cereal- or fruit-based products. In fermented meat and milk, the main microorganisms used are the lactic acid bacteria (LAB). Yeast and molds are rather involved in ripening. Therefore, the LAB will constitute the main focus of this chapter.

The Effect of Cocoa Beans Fermentation on Processed Chocolate In West Kalimantan

Directory of Open Access Journals (Sweden)

Jhon David H

2011-06-01

Full Text Available Research studies of fermentation effects on processed chocolate have been made. The purpose of this study was to see the effect of different levels of fermentation of cocoa preparations (pasta, fats and powder to the chemical quality and flavor. Harvested Cocoa beans will be treated fermentation. The treatment used was the time of fermentation namely: (A Non fermentation, (B Imperfect fermentation (4 days and (C Perfect fermentation (5 days. The parameters observed was: (a chemical quality namely water content, fat content, pH, (b organoleptic tests namely color, aroma, taste bitter (bitterness, texture. The results showed that fermentation of cocoa beans have real impact on levels of fat, water content and pH. Panelists gave the highest rankings for quality of organoleptic attributes of pasta, fat and chocolate powder from perfectly fermented beans. Processing of cocoa beans into refined products had levels of depreciation for each stage. 100 kg dried cocoa beans could produce 79.0 kilograms of chocolate paste, 48.7 kg of cocoa powder, and 26.5 kg of fat. Fermentation for 5 days is the best solution to improve the quality of processed chocolate.

Identification of Bacillus species occurring in Kantong, an acid fermented seed condiment produced in Ghana

DEFF Research Database (Denmark)

Kpikpi, Elmer Nayra; Thorsen, Line; Glover, Richard

2014-01-01

Kantong is a condiment produced in Ghana by the spontaneous fermentation of kapok tree (Ceiba pentandra) seeds with cassava flour as an additive. Fermentation is over a 48h period followed by a drying and a kneading process. Although lactic acid bacteria (LAB) have previously been identified other...

Vinegar rice (Oryza sativa L. produced by a submerged fermentation process from alcoholic fermented rice

Directory of Open Access Journals (Sweden)

Wilma Aparecida Spinosa

2015-03-01

Full Text Available Considering the limited availability of technology for the production of rice vinegar and also due to the potential consumer product market, this study aimed to use alcoholic fermented rice (rice wine (Oryza sativa L. for vinegar production. An alcoholic solution with 6.28% (w/v ethanol was oxidized by a submerged fermentation process to produce vinegar. The process of acetic acid fermentation occurred at 30 ± 0.3°C in a FRINGS® Acetator (Germany for the production of vinegar and was followed through 10 cycles. The vinegar had a total acidity of 6.85% (w/v, 0.17% alcohol (w/v, 1.26% (w/v minerals and 1.78% (w/v dry extract. The composition of organic acids present in rice vinegar was: cis-aconitic acid (6 mg/L, maleic acid (3 mg/L, trans-aconitic acid (3 mg/L, shikimic + succinic acid (4 mg/L, lactic acid (300 mg/L, formic acid (180 mg/L, oxalic acid (3 mg/L, fumaric acid (3 mg/L and itaconic acid (1 mg/L.

Solid state fermentation studies of citric acid production

African Journals Online (AJOL)

SERVER

2008-03-04

Mar 4, 2008 ... solid waste management, biomass energy conservation, production of high value products and little risk ... The carrier, sugarcane bagasse for solid state fermentation was procured from National Sugar Institute ... constant weight and designated as dry solid residue (DSR). The filtrate (consisting of biomass, ...

Cyanobacterial biomass as carbohydrate and nutrient feedstock for bioethanol production by yeast fermentation

DEFF Research Database (Denmark)

Möllers, K Benedikt; Canella, D.; Jørgensen, Henning

2014-01-01

cyanobacterium Synechococcus sp. PCC 7002 was fermented using yeast into bioethanol. Results: The cyanobacterium accumulated a total carbohydrate content of about 60% of cell dry weight when cultivated under nitrate limitation. The cyanobacterial cells were harvested by centrifugation and subjected to enzymatic...... cyanobacteria or microalgae. Importantly, as well as fermentable carbohydrates, the cyanobacterial hydrolysate contained additional nutrients that promoted fermentation. This hydrolysate is therefore a promising substitute for the relatively expensive nutrient additives (such as yeast extract) commonly used...... hydrolysis using lysozyme and two alpha-glucanases. This enzymatic hydrolysate was fermented into ethanol by Saccharomyces cerevisiae without further treatment. All enzyme treatments and fermentations were carried out in the residual growth medium of the cyanobacteria with the only modification being that p...

Quality, functionality, and shelf life of fermented meat and meat products: A review.

Science.gov (United States)

Kumar, Pavan; Chatli, M K; Verma, Akhilesh K; Mehta, Nitin; Malav, O P; Kumar, Devendra; Sharma, Neelesh

2017-09-02

Fermentation of meat is a traditional preservation method used widely for improving quality and shelf life of fermented meat products. Fermentation of meat causes a number of physical, biochemical, and microbial changes, which eventually impart functional properties, sensory characteristics, and nutritional aspects to these products and inhibit the growth of various pathogenic and spoilage microorganisms. These changes include acidification (carbohydrate catabolism), solubilization and gelation of myofibrillar and sarcoplasmic proteins of muscle, degradation of proteins and lipids, reduction of nitrate into nitrite, formation of nitrosomyoglobin, and dehydration. Dry-fermented sausages are increasingly being used as carrier of probiotics. The production of biogenic amines during fermentation can be controlled by selecting proper starter cultures and other preventive measures such as quality of raw materials, hygienic measures, temperature, etc.

Effect of weaning age on feed intake and ruminal fermentation patterns of calves fed a dry total mixed ration with ad libitum access to grass hay.

Science.gov (United States)

Van Ackeren, Caroline; Steingass, Herbert; Hartung, Karin; Funk, Rainer; Drochner, Winfried

2010-08-01

To study the effect of weaning age on average daily gain (ADG), dry matter intake (DMI) and ruminal fermentation, 10 rumen-cannulated male Holstein calves were randomly assigned to one of two treatments: (i) early weaned at 8 weeks of age (235 l milk); (ii) conventionally weaned at 12 weeks of age (347 l milk). Twice daily grass hay (9.0 MJ ME x kg(-1) DM) and a dry total mixed ration (TMR) (11.6 MJ ME x kg(-1) DM) containing 15% alfalfa hay and 85% concentrates were offered separately. Water was available ad libitum. Ruminal fluid was collected via cannulas at weeks 9, 11, 13 and 15, twice weekly just prior to as well as 1, 3, 5 and 7 h after morning feeding. Calves of both treatments achieved adequate ADG (947 vs. 959 g; p > 0.05). Just-weaned calves rapidly increased DMI (1.1-2.5 kg TMR and 2.4-3.6 kg TMR for early- and conventionally-weaned calves, respectively). From weeks 10-12 early-weaned calves consumed significantly more dry feed than conventionally-weaned calves (week 10: 2.5 vs. 1.6 kg/d; week 12: 3.4 vs. 2.4 kg/d). Early weaning stimulates DMI supporting ruminal fermentation intensity, indicated by lower ruminal pH. After weaning, only early-weaned calves achieved critical average ruminal pH (week 9: 5.7 vs. 6.0, p = 0.017; week 11: 5.9 vs. 6.2, p = 0.007). Experimental treatment did not affect the concentration of ruminal short-chain fatty acids (SCFA). For all calves, the effects of the concentrate-rich TMR were shown by a high SCFA level (daily average: 137-152 mmol x l(-1)) and an acetate to propionate to butyrate ratio between 51:36:9 and 54:33:10.

Physico-chemical characteristics and free fatty acid composition of dry fermented mutton sausages as affected by the use of various combinations of starter cultures and spices.

Science.gov (United States)

Zhao, Lihua; Jin, Ye; Ma, Changwei; Song, Huanlu; Li, Hui; Wang, Zhenyu; Xiao, Shan

2011-08-01

The microbiological, physico-chemical and free fatty acid composition of dry fermented mutton sausages were determined during ripening and storage. Three sausage mixtures (starter culture [SC], SC and black pepper [SC+BP] and SC, BP and cumin [SC+BP+C]) were compared with a control (CO). In general, the lactic acid bacteria populations in the SC+BP increased significantly to 9 log CFU/g and were higher than the CO (8 log CFU/g) (P0.05). Copyright © 2011 Elsevier Ltd. All rights reserved.

Diversity of yeasts involved in the fermentation of tchoukoutou, an opaque sorghum beer from Benin

OpenAIRE

Kayode, A.P.P.; Vieira-Dalode, G.; Linnemann, A.R.; Kotchoni, S.O.; Hounhouigan, A.J.D.; Boekel, van, M.A.J.S.; Nout, M.J.R.

2011-01-01

Opaque sorghum beers are traditional alcoholic beverages in several African countries. Known as tchoukoutou in Benin, the beer is often obtained from an uncontrolled fermentation. It is consumed in an actively fermenting state and has a sour taste. The present study characterized and identified the yeasts involved in the fermentation process of this type of beer using the phenotypical approach. Of 12 beers from 4 different locations, the mean values of the pH, titratable acidity, dry matter c...

Production of 6-pentyl-α-pyrone by trichoderma harzianum in solid-state fermentation.

Science.gov (United States)

de Souza Ramos, Aline; Fiaux, Sorele Batista; Leite, Selma Gomes Ferreira

2008-10-01

Many Trichoderma species are able to produce 6-pentyl-α-pyrone (6-PP), a lactone with coconut-like aroma. In the present work, several culture parameters were studied to enhance the production of 6-PP by Trichoderma harzianum 4040 in solid-state fermentation. Green coir powder added to a nutrient solution was used as support material for fermentation. A Plackett-Burman screening technique was applied, followed by a fractionary factorial design. The best culture conditions within the experimental domain studied were (100 g support)(-1): sucrose, 3 g; NaNO3, 0.24 g; (NH4)2SO4, 0.18 g; KH2PO4, 0.1 g; inoculum concentration, 2.2 × 10(6) spores; moisture level, 55%. The temperature established was 28°C. The fermentation under the selected conditions led to a 6-PP production six times higher (5.0 mg/g dry matter) than the initial one (0.8 mg/g dry matter) after seven days of cultivation.

Barley Distillers Dried Grains with Solubles (DDGS) as Feedstock for Production of Acetone, Butanol and Ethanol

NARCIS (Netherlands)

Houweling-Tan, G.B.N.; Sperber, B.L.H.M.; Wal, van der H.; Bakker, R.R.C.; Lopez Contreras, A.M.

2016-01-01

Distillers dried grains with solubles (DDGS) represent important co-product from commercial yeast fermentations, including bioethanol, from grains. In view of the current expansion of the bioethanol fermentation process, with the concomitant increase in production of DDGS, alternative applications

Characterization of very high gravity ethanol fermentation of corn mash. Effect of glucoamylase dosage, pre-saccharification and yeast strain

DEFF Research Database (Denmark)

Devantier, Rasmus; Pedersen, S; Olsson, Lisbeth

2005-01-01

Ethanol was produced from very high gravity mashes of dry milled corn (35% w/w total dry matter) under simultaneous saccharification and fermentation conditions. The effects of glucoamylase dosage, pre-saccharification and Saccharomyces cerevisiae strain on the growth characteristics such as the ......Ethanol was produced from very high gravity mashes of dry milled corn (35% w/w total dry matter) under simultaneous saccharification and fermentation conditions. The effects of glucoamylase dosage, pre-saccharification and Saccharomyces cerevisiae strain on the growth characteristics...... such as the ethanol yield and volumetric and specific productivity were determined. It was shown that higher glucoamylase doses and/or pre-saccharification accelerated the simultaneous saccharification and fermentation process and increased the final ethanol concentration from 106 to 126 g/kg although the maximal...... specific growth rate was decreased. Ethanol production was not only growth related, as more than half of the total saccharides were consumed and more than half of the ethanol was produced during the stationary phase. Furthermore, a high stress tolerance of the applied yeast strain was found to be crucial...

Streptomyces sp. TEM 33 possesses high lipolytic activity in solid-state fermentation in comparison with submerged fermentation.

Science.gov (United States)

Cadirci, Bilge Hilal; Yasa, Ihsan; Kocyigit, Ali

2016-01-01

Solid-state fermentation (SSF) is a bioprocess that doesn't need an excess of free water, and it offers potential benefits for microbial cultivation for bioprocesses and product development. In comparing the antibiotic production, few detailed reports could be found with lipolytic enzyme production by Streptomycetes in SSF. Taking this knowledge into consideration, we prefer to purify Actinomycetes species as a new source for lipase production. The lipase-producing strain Streptomyces sp. TEM 33 was isolated from soil and lipase production was managed by solid-state fermentation (SSF) in comparison with submerged fermentation (SmF). Bioprocess-affecting factors like initial moisture content, incubation time, and various carbon and nitrogen additives and the other enzymes secreted into the media were optimized. Lipase activity was measured as 1.74 ± 0.0005 U/g dry substrate (gds) by the p-nitrophenylpalmitate (pNPP) method on day 6 of fermentation with 71.43% final substrate moisture content. In order to understand the metabolic priority in SSF, cellulase and xylanase activity of Streptomyces sp. TEM33 was also measured. The microorganism degrades the wheat bran to its usable form by excreting cellulases and xylanases; then it secretes the lipase that is necessary for degrading the oil in the medium.

APPLICATION OF NISIN INTO SLOVAK FERMENTED SALAMI PÚCHOV

Directory of Open Access Journals (Sweden)

Andrea Laukova

2012-12-01

Full Text Available Púchov salami is favorite fermented salami among Slovak consumers. Nisin is the only bacteriocin accepted by European Commission for a commercial use as additive for food preservation (although not commonly used in meat products. Because of its possibility to prolonge shelf-life of the products and its antimicrobial activity, its effect in dry fermented Slovak salami Púchov experimentally inoculated with Listeria innocua Li1 strain was checked. The initial number of L. innocua Li1 in the inoculated salami mixtures was 104 CFU/g (log 10; 4.04  ± 0 07. After nisin addition, the count of Li1 strain in the meat samples (inoculated with Li1 and treated by nisin was 1.36±0.07 CFU/g; difference 2.68 logarithmic cycle was noted between Li and Li/Ni samples. At day 2, the difference 3.23 log cycle was detected between Li1 and Li/Ni samples (Li:5.46±0.08, Li/Ni: 2.14±0.07 CFU/g; at weeks 3, 4, it was 1.69 and 1.80 log cycle. Activity of nisin itself was not recovered from the experimental salamis by the analytical method; however, its inhibitory effect was shown by Li1 count decrease. The pH in  salamis during processing was almost at the same level (5.52, 5.53, 5.55. Water activity was not negatively influenced. Water content in Li/Ni salamis reached almost requested levels (maximum percentage of water requested is 34 %.doi:10.5219/218

Survival of experimentally induced Toxoplasma gondii tissue cysts in vacuum packed goat meat and dry fermented goat meat sausages.

Science.gov (United States)

Neumayerová, Helena; Juránková, Jana; Saláková, Alena; Gallas, Leo; Kovařčík, Kamil; Koudela, Břetislav

2014-05-01

Ingestion of raw or undercooked meat is a potential source of human toxoplasmosis. The aim of this study was to determine the viability of Toxoplasma gondii cysts in vacuum packed (VP) goat meat and in dry fermented sausages (DFS), and evaluate certain physical and chemical parameters, like water activity (aw), pH value, content of salt, dry matter and fat. A portion of muscle tissue from experimentally infected animals was used for production of VP meat with or without addition of 2.5% curing salt, and stored at 4 °C or at -20 °C. Results of bioassay showed that, samples of vacuum packed Toxoplasma positive meat without salt addition were alive after six weeks at 4 °C. Incubation at -20 °C supported the viability after 3 h, but not after 4 h. After 7 days in 2.5% of curing salt, samples of T. gondii VP goat meat were still viable, but not after 14 days at 4 °C. All the DFS samples were not positive for infective cysts which mean that, they do not pose a risk of T. gondii transmission. These data suggest that vacuum packaging increases the survival of T. gondii cysts. Copyright © 2013 Elsevier Ltd. All rights reserved.

THE PERFORMANCE OF FERMENTATED YIELD OF COCOA BEAN QUALITY IN WEST KALIMANTAN

Directory of Open Access Journals (Sweden)

Jhon David H

2014-02-01

Full Text Available Besides research aims to improve post-harvest handling through fermentaasi also to improve the quality of fermented cocoa beans so that the value the higher the cocoa product jula. The study was conducted in villages of the National program on Gapoktan GERNAS COCOA Joint Business Village District Pegadang Sekayam Sanggau Fermentation done with treatment for 5 days with a reversal of 1 time after 48 hours and followed by artificial drying for 8 hours and 12 hours of sun drying. Quality parameters are analyzed adjusted as required by SNI 01-2323-2002 which includes the general requirements: insect life, water content, bii smell and / or abnormal levels of broken seeds, kotora levels, levels of foreign objects, dirt mammals, and special requirements: size /100 gr, grade seed and seed fungi. Results The study concluded that meet the requirements of the Indonesian National Standard (SNI, 2002 and also the International Cocoa Standards. While the quality requirements based on the number of seeds g tiap100 the fermentation of cocoa beans from Pegadang Village, Sekayam, Sanggau located on I-D quality.

Amylolysis of raw corn by Aspergillus niger for simultaneous ethanol fermentation

Energy Technology Data Exchange (ETDEWEB)

Han, I.Y.; Steinberg, M.P.

1987-01-01

The novelty of this approach was hydrolysis of the raw starch in ground corn to fermentable sugars that are simultaneously fermented to ethanol by yeast in a nonsterile environment. Thus, the conventional cooking step can be eliminated for energy conservation. A koji of Aspergillus niger grown on whole corn for 3 days was the crude enzyme source. A ratio of 0.2 g dry koji/g total solids was found sufficient. Optimum pH was 4.2. Ethanol concentration was 7.7% (w/w) in the aqueous phase with 92% raw starch conversion. Agitation increased rate. Sacharification was the rate-limiting step. The initial ethanol concentration preventing fermentation was estimated to be 8.3% by weight. (Refs. 96).

Complex behaviour and predictability of the European dry spell regimes

Directory of Open Access Journals (Sweden)

X. Lana

2010-09-01

Full Text Available The complex spatial and temporal characteristics of European dry spell lengths, DSL, (sequences of consecutive days with rainfall amount below a certain threshold and their randomness and predictive instability are analysed from daily pluviometric series recorded at 267 rain gauges along the second half of the 20th century. DSL are obtained by considering four thresholds, R₀, of 0.1, 1.0, 5.0 and 10.0 mm/day. A proper quantification of the complexity, randomness and predictive instability of the different DSL regimes in Europe is achieved on the basis of fractal analyses and dynamic system theory, including the reconstruction theorem. First, the concept of lacunarity is applied to the series of daily rainfall, and the lacunarity curves are well fitted to Cantor and random Cantor sets. Second, the rescaled analysis reveals that randomness, persistence and anti-persistence are present on the European DSL series. Third, the complexity of the physical process governing the DSL series is quantified by the minimum number of nonlinear equations determined by the correlation dimension. And fourth, the loss of memory of the physical process, which is one of the reasons for the complex predictability, is characterized by the values of the Kolmogorov entropy, and the predictive instability is directly associated with positive Lyapunov exponents. In this way, new bases for a better prediction of DSLs in Europe, sometimes leading to drought episodes, are established. Concretely, three predictive strategies are proposed in Sect. 5. It is worth mentioning that the spatial distribution of all fractal parameters does not solely depend on latitude and longitude but also reflects the effects of orography, continental climate or vicinity to the Atlantic and Arctic Oceans and Mediterranean Sea.

Effect of replacing groundnut cake with urea fermented brewer's ...

African Journals Online (AJOL)

The effect o replacing groundnut cake with urea fermented brewer's dried grains at 0 25 50, 75 and 100 % graded levels in broiler chick starter diets was investigated. Five dietary treatments were formulated to be isonitrogenous and isocaloric to provide 23 % crude protein and 2900 kcal/kg metabolizable energy.

European Science Notes Information Bulletin. A Dedicated Issue: Biotechnology in Europe and Israel

Science.gov (United States)

1989-06-01

multidisciplinary scientific Other fermented foods, yeasts, vinegar effort to achieve industrial and environmental applica- PASTEUR ERA, 1865-1940...of developing the technology. technology lies in the fermentation industry, and it is the large corporations who are developing and exploiting West...organic acids is considered to be the leading European country in bio- via fermentation . In the postwar period, these strengths technology, followed

Estimating the effect of fermentation yeast on distillers grains protein

Science.gov (United States)

Distillers dried grains with solubles (DDGS) is the key co-product of bio-ethanol production from grains. Major factors affecting its quality and market values include protein quantity (concentration) and quality (amino acid composition). Yet, the effect of fermentation yeast on DDGS quality has no...

Demonstration-Scale High-Cell-Density Fermentation of Pichia pastoris.

Science.gov (United States)

Liu, Wan-Cang; Zhu, Ping

2018-01-01

Pichia pastoris has been one of the most successful heterologous overexpression systems in generating proteins for large-scale production through high-cell-density fermentation. However, optimizing conditions of the large-scale high-cell-density fermentation for biochemistry and industrialization is usually a laborious and time-consuming process. Furthermore, it is often difficult to produce authentic proteins in large quantities, which is a major obstacle for functional and structural features analysis and industrial application. For these reasons, we have developed a protocol for efficient demonstration-scale high-cell-density fermentation of P. pastoris, which employs a new methanol-feeding strategy-biomass-stat strategy and a strategy of increased air pressure instead of pure oxygen supplement. The protocol included three typical stages of glycerol batch fermentation (initial culture phase), glycerol fed-batch fermentation (biomass accumulation phase), and methanol fed-batch fermentation (induction phase), which allows direct online-monitoring of fermentation conditions, including broth pH, temperature, DO, anti-foam generation, and feeding of glycerol and methanol. Using this protocol, production of the recombinant β-xylosidase of Lentinula edodes origin in 1000-L scale fermentation can be up to ~900 mg/L or 9.4 mg/g cells (dry cell weight, intracellular expression), with the specific production rate and average specific production of 0.1 mg/g/h and 0.081 mg/g/h, respectively. The methodology described in this protocol can be easily transferred to other systems, and eligible to scale up for a large number of proteins used in either the scientific studies or commercial purposes.

Utilization of agroindustrial residues for lipase production by solid-state fermentation

OpenAIRE

Damaso, M?nica Caramez Triches; Passianoto, Mois?s Augusto; de Freitas, Sidin?a Cordeiro; Freire, Denise Maria Guimar?es; Lago, Regina Celi Araujo; Couri, Sonia

2008-01-01

The aim of this work was to produce lipases by solid-state fermentation (SSF) using, as substrate, agroindustrial residue supplemented with by-products from corn oil refining process or olive oil. For a group of ten fungi strains selected in the first steps, the lipase activity obtained by SSF varied from 7.7 to 58.6 U/g of dry substrate (gds). Among the evaluated strains, the Aspergillus niger mutant 11T53A14 was selected by presenting the best enzymatic production. For the fermentation test...

In Vitro Rumen Fermentation and Anti Mastitis Bacterial Activity of Diet Containing Betel Leaf Meal (Piper betle L.

Directory of Open Access Journals (Sweden)

A. A. Yamin

2013-08-01

Full Text Available The aims of this experiment was to study the inhibition effect of betel leaf meal (BLM addition into concentrate diet on mastitis causing bacteria and on rumen fermentation condition. The study consisted of five dietary treatments of BLM level in concentrate feed, i.e., 0%, 2%, 4%, 6%, and 8% and four replicates of each treatment. The treatment diets together with napier grass in ratio of 40 : 60 were fermented using rumen liquor. All treatments were examined their antibacterial activity before and after fermentation. After four hours fermentation, supernatant of each samples were analyzed for VFA, NH3, number of bacteria and protozoa. Dry matter (DM and organic matter (OM digestibility were analyzed after 48 h fermentation. The results showed that before fermentation, 8% BLM addition caused the bigest (P<0.05 inhibition diameter of Staphylococcus spp. growth compared to other lower levels. However after fermentation there were no significant differences among the addition levels of BLM. Two per cent of BLM addition produced higher VFA (P<0.05 than the other addition levels. Ammonia concentration, dry matter (DM and organic matter (OM digestibility were not different among the treatments. Addition of BLM significantly (P<0.01 decreased protozoa number, but did not affect bacterial count. It is concluded that the addition of 2% BLM in concentrate feed can be used effectively to inhibit the growth of mastitis causing bacteria (Staphylococcus spp. and does not disturb rumen fermentation condition.

Accelerated storage testing of freeze-dried Pseudomonas ...

African Journals Online (AJOL)

Erika-Chris

Full Length Research Paper ... was possible to compare rate constants of survival for the freeze-dried P. fluorescens ... studying and predicting the survival loss rate of the ... Erlenmeyer flask containing 3000 ml King B medium. ... The strain was grown in 20 L bioreactor (Biolafite) containing 15 L .... fermented banana media.

UTILIZATION OF MEMBRANE MICROFILTRATION IN PREPARATION OF HYDROLYZED VEGETABLE PROTEIN FROM FERMENTED RED BEAN (Phaseolus vulgaris L. EXTRACT AS FORTIFICATION AGENT

Directory of Open Access Journals (Sweden)

Sri Moerniati

2010-06-01

Full Text Available Preparation of Hydrolyzed Vegetable Protein (HVP as savory flavor from fermented red bean broth through stirred membrane cell using micro filtration membrane with pore size of 0.45 µm was performed to get fortified agent utilized in preparation of beans sauce. The objective of this work was to study an effect of pressure and kind of red bean broth extract on content of total protein, soluble protein and dry solid in the retentate and permeate as hydrolyzed vegetable protein used for fortified agent of red bean sauces. Preparation process of hydrolyzed vegetable protein was done using fixed rotary speed of 400 rpm, pressure of 20, 25 and 30 psi at room temperature. To investigate the effect of pressure on this separation, the feed were red bean broth extract fermented for 6, 8, 10 and 12 weeks, respectively. Fermentation process were conducted using salt fermentation with inoculum of Rhizopus-C1, salt and red bean ratios of 30:10:60%. The analysis of flux and contents of total protein, dissolved protein and dry solid in the retentate and permeate was carried out, and the result of experiment showed that interaction of Red bean broth extract with 6, 8, 10 and 12 weeks of fermentation and operation condition of microfiltration membrane separation tends to affect on flux and content of total protein, dissolved protein and dry solid in retentate and permeate. Red bean broth extract for 6 weeks fermentation resulted higher protein content in permeate as hydrolyzed vegetable protein than in retentate. Permeate at pressure of 25 psi gives flux value of 0.0217 mL/cm2.minute and contents of total protein of 1.31 %, dissolved protein of 6.9 mg/g, and dry solid of 2.6%, while retentate as hydrolyzed vegetable protein or fortified agent indicate contents of total protein of 1.52%, dissolved protein of 4.15 mg/g, and dry solid of 3.64%. It was found that micro filtration process was able to increase dissolved protein content of about 3 times.   Keywords

Evaluating the quality characteristics of kunun produced from dry ...

African Journals Online (AJOL)

STORAGESEVER

2008-07-04

Jul 4, 2008 ... The pH and total soluble solid of kunun prepared from dry ... locally fermented sweetened non-alcoholic beverage that is widely ... sugar were procured from a local market in Ogbomoso, Oyo state. ... ties of lactic acid bacteria.

Assessment of chemical and sensory quality of sugarcane alcoholic fermented beverage.

Science.gov (United States)

Resende Oliveira, Érica; Caliari, Márcio; Soares Soares Júnior, Manoel; Ribeiro Oliveira, Aryane; Cristina Marques Duarte, Renata; Valério de Barros Vilas Boas, Eduardo

2018-01-01

This study aimed to verify the technological feasibility, chemical quality and sensory acceptance of alcoholic fermented beverage obtained from sugarcane juice. A completely randomized design was applied. Sugar and alcohol content, phenolic (HPLC-MS) and volatile (GS-MS) compounds, pH, density, dry matter and acidity of the fermented beverage of sugarcane were quantified, as well as the acceptance of the product was carried out. The complete fermentation of sugarcane lasted 7 days, and it was obtained an alcohol content of 8.0% v/v. Titrable acidity of the beverage was of 67.31 meq L -1 , pH 4.03, soluble solids of 5 °Brix, reducing sugar of 0.07 g glucose 100 g -1 , density of 0.991 g cm -3 , reduced dry matter of 14.15 g L -1 , sulfates lower than 0.7 g K 2 SO 4  L -1 . Various phenolic compounds, among which, gallic acid (10.97%), catechin (1.73%), chlorogenic acid (3.52%), caffeic acid (1.49%), vanillic acid (0.28%), p -coumaric acid (0.24%), ferulic acid (6.63%), m -coumaric acid (0.36%), and o -coumaric acid (0.04%). Amongst aromatic compounds, were found mainly esters with fruity aromas (ethyl ester hexanoic acid and ethyl ester octanoic acid). The sugarcane juice can be commercialized as an alternative wine, as it presented adequate features to an alcoholic fermented beverage and was sensory accepted by consumers.

Influence of red wine fermentation oenological additives on inoculated strain implantation.

Science.gov (United States)

Duarte, Filomena L; Alves, Ana Claudia; Alemão, Maria Filomena; Baleiras-Couto, M Margarida

2013-06-01

Pure selected cultures of Saccharomyces cerevisiae starters are regularly used in the wine industry. A survey of S. cerevisiae populations during red wine fermentations was performed in order to evaluate the influence of oenological additives on the implantation of the inoculated strain. Pilot scale fermentations (500 L) were conducted with active dry yeast (ADY) and other commercial oenological additives, namely two commercial fermentation activators and two commercial tannins. Six microsatellite markers were used to type S. cerevisiae strains. The methodology proved to be very discriminating as a great diversity of wild strains (48 genotypes) was detected. Statistical analysis confirmed a high detection of the inoculated commercial strain, and for half the samples an effective implantation of ADY (over 80 %) was achieved. At late fermentation time, ADY strain implantation in fermentations conducted with commercial additives was lower than in the control. These results question the efficacy of ADY addition in the presence of other additives, indicating that further studies are needed to improve knowledge on oenological additives' use.

A fermented meat model system for studies of microbial aroma formation

DEFF Research Database (Denmark)

Tjener, Karsten; Stahnke, Louise Heller; Andersen, L.

2003-01-01

A fermented meat model system was developed, by which microbial formation of volatiles could be examined The model was evaluated against dry, fermented sausages with respect to microbial growth, pH and volatile profiles. Fast and slowly acidified sausages and models were produced using the starter......H, microbial growth and volatile profiles was similar to sausage production. Based on these findings, the model system was considered valid for studies of aroma formation of meat cultures for fermented sausage....... for multivariate data analysis. Growth of lactic acid bacteria was comparable for model and sausages, whereas survival of S. xylosus was better in the model. Multivariate analysis of volatiles showed that differences between fast and slowly acidified samples were identical for model and sausage. For both sausage...

Influence of physiological state of inoculum on volatile acidity production by Saccharomyces cerevisiae during high sugar fermentation

Directory of Open Access Journals (Sweden)

Marina Bely

2005-12-01

Full Text Available An approach consisting of controlling yeast inoculum to minimize volatile acidity production by Saccharomyces cerevisiae during the alcoholic fermentation of botrytized must was investigated. Direct inoculation of rehydrated active dry yeasts produced the most volatile acidity, while a yeast preparation pre-cultured for 24 hours reduced the final production by up to 23 %. Using yeasts collected from a fermenting wine as a starter must also reduced volatile acidity production. The conditions for preparing the inoculum affected the fermentation capacity of the first generation yeasts: fermentation duration, sugar to ethanol ratio, and wine composition. A pre-culture medium with a low sugar concentration (< 220 g/L is essential to limit volatile acidity production in high sugar fermentations.

Fermentative Aroma Compounds and Sensory Descriptors of Traditional Croatian Dessert Wine Prošek from Plavac mali cv.

Directory of Open Access Journals (Sweden)

Goran Zdunić

2010-01-01

Full Text Available Prošek is a traditional dessert wine from the coastal region of Croatia made from partially dried grapes. There is very little literature data about the chemical composition and sensory properties of Prošek, so an experimental production from the dried grapes of Plavac mali cultivar has been done using native and induced alcoholic fermentations. To determine the volatile compounds, gas chromatography with flame ionisation detector (GC/FID was used on the samples prepared with solid phase microextraction (SPME. Higher alcohols, esters, carbonyl compounds and volatile acids were determined in the wine samples. Wines were grouped according to the production method using principal component analysis (PCA. It was found that Prošek wines produced with native and induced alcoholic fermentation differ in their volatile compounds. Descriptive sensory analysis was applied to show the sensory properties of Prošek wine, whose characteristic aromas include those of dried fruit (raisins, red berries, honey, chocolate and vanilla. A significant difference depending on the type of fermentation was determined in two sensory attributes, strawberry jam aroma and fullness.

Purification and fermentation characteristics of exopolysaccharide from Fomitopsis castaneus Imaz.

Science.gov (United States)

Guo, Wenkui; Chi, Yujie

2017-12-01

Short-chain fatty acids (SCFAs), which are the end products of carbohydrate fermentation in the gut, mainly contribute to energy metabolism in mammals. The amount of SCFAs produced during fermentation is an important parameter that characterizes the fermentation capacity of a system. This paper reports on the fermentation characteristics of exopolysaccharides (EPS) isolated from Fomitopsis castaneus Imaz, a wood-rot fungal species. We isolated and purified the main EPS fraction by freeze drying and DEAE-Sepharose fast flow chromatography. We then analyzed the monosaccharide composition of EPS. The isolated EPS was mainly composed of glucose, galactose, rhamnose, mannose, and arabinose. The characteristic absorption peaks of sugar esters were also detected. Fresh fecal extracts from healthy adults and children were used as fermentation substrate to simulate the human intestinal environment (anaerobic conditions at 37°C) and study the fermentation characteristics of the purified EPS. Adding the isolated EPS to the fermentation system of the simulated intestinal environment increased the SCFAs content in the fecal extract of adults and children. However, the yield of SCFAs, particularly butyric acid, in the fermentation system of fecal extract in children was higher than that in adults. Furthermore, adding exogenous lactic acid bacteria, such as Enterococcus fecalis and Enterococcus fecium, to the fermentation system effectively increased the SCFAs concentration in the model intestinal system of the children. By contrast, adding E. fecalis, Lactobacillus rhamnosus, and E. fecium increased the content of the produced SCFAs in the system of adults. Those results indicate that EPS isolated from F. castaneus Imaz was effectively fermented in the simulated intestinal environments, and the fermentation capability was enhanced by adding microbial flora. Copyright © 2017 Elsevier B.V. All rights reserved.

Drying kinetics of fermented grape pomace: Determination of moisture effective diffusivity

Directory of Open Access Journals (Sweden)

Kricelle M. Deamici

Full Text Available ABSTRACT The aim of this study was to obtain the equilibrium moisture content of grape (variety ‘Tannat’ pomace through desorption isotherms, to evaluate the drying kinetics, determine the coefficient of effective diffusivity and physico-chemically characterize the grape pomace and the product obtained after drying. The desorption isotherms were determined at 50, 60 and 70 ºC and the experimental data were fitted using the GAB model (Gugghenheim, Anderson and de Boer. Drying was evaluated using a 22 factorial experimental design with three center points and effective diffusivity was obtained through the diffusion model of Fick’s second law. The grape pomace was characterized regarding the contents of moisture, protein, carbohydrates, lipids, ash and dietary crude fiber. The obtained isotherms showed sigmoid shape and the experimental data fitted well to the GAB model. The drying curves showed only a decreasing rate period. The effective diffusivity values were within the range for organic materials. Dry grape pomace showed high contents of protein and fiber and can be used in the development of new products, in order to increase the nutritional content and add value to this byproduct.

Kinetics of alcoholic fermentation during the culturing of bakers' yeast

Energy Technology Data Exchange (ETDEWEB)

Franz, B

1961-01-01

A synthesis was made of the effects of various factors on the rate of fermentation by Saccharomyces cerevisiae. The rate obeyed the Michaelis-Menten equation, was independent of the concentration of yeast, was maximal at 20/sup 0/ (0.61 ml ethanol/g dry yeast/h), was not significantly affected between pH 6.5 and 3.0 but declined at 3.0, was inhibited by ethanol at a rate proportional to the concentration squared (at ethanol = 12 volume %, the fermentation rate was practically zero), and was enhanced by the addition of phosphorus when a P-poor yeast was employed.

Changes in the protein fraction of Merluccius bilinearis muscle under lactic acid bacterial fermentation using a Lactobacillus Acidophilus starter culture (ESP

Directory of Open Access Journals (Sweden)

Luis J. Elizondo

2016-03-01

Full Text Available The effect of lactic acid bacterial fermentation on the protein fraction of Merluccius bilinearis muscle was evaluated. The non-protein fraction increased progressively with corresponding decreases in the percentage protein (dry weight indicating proteolytic activity during fermentation. Significant increases in the percentages of the amino acids cystine, isoleucine, phenylalanine and tyrosine were observed after two months of fermentation. Percentages of arginine decreased significantly after one week and again after two months of fermentation.

Between-cow variation in digestion and rumen fermentation variables associated with methane production.

Science.gov (United States)

Cabezas-Garcia, E H; Krizsan, S J; Shingfield, K J; Huhtanen, P

2017-06-01

A meta-analysis based on an individual-cow data set was conducted to investigate the effects of between-cow variation and related animal variables on predicted CH 4 emissions from dairy cows. Data were taken from 40 change-over studies consisting of a total of 637 cow/period observations. Animal production and rumen fermentation characteristics were measured for 154 diets in 40 studies; diet digestibility was measured for 135 diets in 34 studies, and ruminal digestion kinetics was measured for 56 diets in 15 studies. The experimental diets were based on grass silage, with cereal grains or by-products as energy supplements, and soybean or canola meal as protein supplements. Average forage:concentrate ratio across all diets on a dry matter basis was 59:41. Methane production was predicted from apparently fermented substrate using stoichiometric principles. Data were analyzed by mixed-model regression using diet and period within experiment as random effects, thereby allowing the effect of experiment, diet, and period to be excluded. Dry matter intake and milk yield were more repeatable experimental measures than rumen fermentation, nutrient outflow, diet digestibility, or estimated CH 4 yield. Between-cow coefficient of variation (CV) was 0.010 for stoichiometric CH 4 per mol of volatile fatty acids and 0.067 for predicted CH 4 yield (CH 4 /dry matter intake). Organic matter digestibility (OMD) also displayed little between-cow variation (CV = 0.013), indicating that between-cow variation in diet digestibility and rumen fermentation pattern do not markedly contribute to between cow-variation in CH 4 yield. Digesta passage rate was much more variable (CV = 0.08) between cows than OMD or rumen fermentation pattern. Increased digesta passage rate is associated with improved energetic efficiency of microbial N synthesis, which partitions fermented substrate from volatile fatty acids and gases to microbial cells that are more reduced than fermented carbohydrates. Positive

Effect of flocculation on performance of arming yeast in direct ethanol fermentation

Energy Technology Data Exchange (ETDEWEB)

Khaw Teik Seong; Katakura, Yoshio; Ninomiya, Kazuaki; Shioya, Suteaki [Osaka Univ. (Japan). Dept. of Biotechnology; Bito, Yohei; Katahira, Satoshi; Kondo, Akihiko [Kobe Univ. (Japan). Dept. of Chemical Science and Engineering; Ueda, Mitsuyoshi [Kyoto Univ. (Japan). Div. of Applied Life Sciences

2006-11-15

In the direct ethanol fermentation of raw starch by arming yeast with {alpha}-amylase and glucoamylase, it is preferable to use a flocculent yeast because it can be recovered without centrifugation. Three types of arming yeast system, I (nonflocculent), II (mildly flocculent), and III (heavily flocculent), were constructed and their fermentation performances were compared. With an increase in the degree of flocculation, specific ethanol production rate for soluble starch decreased (0.19, 0.17, and 0.12 g g-dry-cell{sup -1} h{sup -1} for systems I, II, and III, respectively), but that for raw starch did not decrease as much as expected (0.06, 0.06, and 0.04 g g-dry-cell{sup -1} h{sup -1} for systems I, II and III, respectively). Microscopic observation revealed that many starch granules were captured in the yeast flocs in system III during the direct ethanol fermentation of raw starch. It was suggested that the capture of starch granules increases apparent substrate concentration for amylolytic enzymes in arming yeast cell flocs; thus, the specific ethanol production rate of system III was kept at a level comparable to those of the other systems. (orig.)

Filtration, haze and foam characteristics of fermented wort mediated by yeast strain.

Science.gov (United States)

Douglas, P; Meneses, F J; Jiranek, V

2006-01-01

To investigate the influence of the choice of yeast strain on the haze, shelf life, filterability and foam quality characteristics of fermented products. Twelve strains were used to ferment a chemically defined wort and hopped ale or stout wort. Fermented products were assessed for foam using the Rudin apparatus, and filterability and haze characteristics using the European Brewing Convention methods, to reveal differences in these parameters as a consequence of the choice of yeast strain and growth medium. Under the conditions used, the choice of strain of Saccharomyces cerevisiae effecting the primary fermentation has an impact on all of the parameters investigated, most notably when the fermentation medium is devoid of macromolecular material. The filtration of fermented products has a large cost implication for many brewers and wine makers, and the haze of the resulting filtrate is a key quality criterion. Also of importance to the quality of beer and some wines is the foaming and head retention of these beverages. The foam characteristics, filterability and potential for haze formation in a fermented product have long been known to be dependant on the raw materials used, as well as other production parameters. The choice of Saccharomyces cerevisiae strain used to ferment has itself been shown here to influence these parameters.

Predicting the concentration of verotoxin-producing Escherichia coli bacteria during processing and storage of fermented raw-meat sausages.

Science.gov (United States)

Quinto, E J; Arinder, P; Axelsson, L; Heir, E; Holck, A; Lindqvist, R; Lindblad, M; Andreou, P; Lauzon, H L; Marteinsson, V Þ; Pin, C

2014-05-01

A model to predict the population density of verotoxigenic Escherichia coli (VTEC) throughout the elaboration and storage of fermented raw-meat sausages (FRMS) was developed. Probabilistic and kinetic measurement data sets collected from publicly available resources were completed with new measurements when required and used to quantify the dependence of VTEC growth and inactivation on the temperature, pH, water activity (aw), and concentration of lactic acid. Predictions were compared with observations in VTEC-contaminated FRMS manufactured in a pilot plant. Slight differences in the reduction of VTEC were predicted according to the fermentation temperature, 24 or 34°C, with greater inactivation at the highest temperature. The greatest reduction was observed during storage at high temperatures. A population decrease greater than 6 decimal logarithmic units was observed after 66 days of storage at 25°C, while a reduction of only ca. 1 logarithmic unit was detected at 12°C. The performance of our model and other modeling approaches was evaluated throughout the processing of dry and semidry FRMS. The greatest inactivation of VTEC was predicted in dry FRMS with long drying periods, while the smallest reduction was predicted in semidry FMRS with short drying periods. The model is implemented in a computing tool, E. coli SafeFerment (EcSF), freely available from http://www.ifr.ac.uk/safety/EcoliSafeFerment. EcSF integrates growth, probability of growth, and thermal and nonthermal inactivation models to predict the VTEC concentration throughout FRMS manufacturing and storage under constant or fluctuating environmental conditions.

Reduction of sodium and increment of calcium and ω-3 polyunsaturated fatty acids in dry fermented sausages: effects on the mineral content, lipid profile and sensory quality.

Science.gov (United States)

García-Íñiguez de Ciriano, Mikel; Berasategi, Izaskun; Navarro-Blasco, Iñigo; Astiasarán, Iciar; Ansorena, Diana

2013-03-15

A combined technological approach was applied in the development of healthier dry fermented sausages: a partial substitution of the pork back fat by pre-emulsified linseed oil and a partial replacement of sodium chloride with calcium ascorbate at two different levels, leading to low amounts of salt (14gSalt and 10gSalt, with 14 g and 10 g NaCl per kg of mixture, respectively). The developed products (14gSalt and 10gSalt) showed adequate results for a(w) (0.85 and 0.87) and pH (4.98 and 5.21), and low lipid oxidation values (1.4 × 10(-4) and 1.5 × 10(-5) g malondialdehyde (MDA) kg(-1)). The lipid modification led to a significantly higher supply of ω-3 (23.3 g kg(-1) ) compared to the control (3.2 g kg(-1) ). Simultaneously, reductions of 38% and 50% in sodium content and a calcium supply of 4 and 5.2 g kg(-1) were achieved in the 14gSalt and 10gSalt formulations, respectively, compared to the control products (26 g salt and 0.87 g kg(-1) Ca). Instrumental analysis of colour and texture and sensory studies demonstrated that the organoleptic quality of the new formulations was similar to that of traditional products. The developed dry fermented sausages showed healthier properties than traditional ones owing to their reduced sodium and higher calcium content and a significant supply of ω-3 fatty acids. © 2012 Society of Chemical Industry.

The influence of brewers' yeast addition on lactic acid fermentation of brewers' spent grain hydrolysate by Lactobacillus rhamnosus

OpenAIRE

Pejin, Jelena; Radosavljević, Miloš; Kocić-Tanackov, Sunčica; Đukić-Vuković, Aleksandra; Mladenović, Dragana; Mojović, Ljiljana

2015-01-01

In this study brewers' spent grain (BSG) hydrolysate was produced using optimal conditions. Hydrolysates were used for lactic acid fermentation by Lactobacillus rhamnosus ATCC 7469. The aim of this study was to evaluate possibilities of the BSG hydrolysate utilization as a substrate for lactic acid fermentation as well as the effect of dry brewers' yeast (1.0, 3.0, and 5.0 %) addition in hydrolysate on lactic acid fermentation parameters (L-(+)-lactic acid and reducing sugars concentration an...

Changes in biotin levels during production of natto, Japanese fermented soybean

Directory of Open Access Journals (Sweden)

Makoto Muratsugu

2017-09-01

Full Text Available The change of biotin level during production of natto (Japanese fermented soybean was investigated in this study.  The total biotin level was measured by an agar plate bioassay using Lactobacillus plantarum ATCC 8014.  The total biotin level decreased during water soaking, but increased after the fermentation of soybeans using Bacillus subtilis var. natto (B. natto and reached a maximum level.  The increase of total biotin was not affected by Asp, Arg, and Ile which promoted the growth of L. plantarum in high concentrations.  The peak level of biotin in the fermented soybeans was significantly higher than that of dry soybeans.  The fermented soybeans at the biotin peak level were adequate for food.  In addition, we detected 9 and 4 biotinylated polypeptides in the soybeans and B. natto used in this study, respectively.  We speculated that the increase of biotin level may depend on the increase of the 4 biotinylated polypeptides and free biotin in B. natto.

Novel Production Protocol for Small-scale Manufacture of Probiotic Fermented Foods

Science.gov (United States)

Westerik, Nieke; Wacoo, Alex Paul; Sybesma, Wilbert; Kort, Remco

2016-01-01

A novel dried bacterial consortium of Lactobacillus rhamnosus yoba 2012 and Streptococcus thermophilus C106 is cultured in 1 L of milk. This fresh starter can be used for the production of fermented milk and other fermented foods either at home or at small-scale in rural settings. For the fresh starter, 1 L of milk is pasteurized in a pan that fits into a larger pan containing water, placed on a source of heat. In this water bath, the milk is heated and incubated at 85 °C for 30 min. Thereafter, the milk is cooled down to 45 °C, transferred to a vacuum flask, inoculated with the dried bacteria and left for at least 16 hr between 30 °C and 45 °C. For the purpose of frequent home production, the fresh starter is frozen into ice cubes, which can be used for the production of small volumes of up to 2 L of fermented milk. For the purpose of small-scale production in resource-poor countries, pasteurization of up to 100 L of milk is conducted in milk cans that are placed in a large sauce pan filled with water and heated on a fire at 85 °C for 30 min, and subsequently cooled to 45 °C. Next, the 100 L batch is inoculated with the 1 L freshly prepared starter mentioned before. To assure an effective fermentation at a temperature between 30 and 45 °C, the milk can is covered with a blanket for 12 hr. For the production of non-dairy fermented foods, the fresh starter is left in a cheese cloth for 12 hr, and the drained-off whey can be subsequently used for the inoculation of a wide range of food raw materials, including vegetables and cereal-based foods. PMID:27684196

Changes in the protein fraction of Merluccius bilinearis muscle under lactic acid bacterial fermentation using a Lactobacillus Acidophilus starter culture (ESP)

OpenAIRE

Elizondo, Luis J.

2016-01-01

The effect of lactic acid bacterial fermentation on the protein fraction of Merluccius bilinearis muscle was evaluated. The non-protein fraction increased progressively with corresponding decreases in the percentage protein (dry weight) indicating proteolytic activity during fermentation. Significant increases in the percentages of the amino acids cystine, isoleucine, phenylalanine and tyrosine were observed after two months of fermentation. Percentages of arginine decreased significantly aft...

Dry fermentation in batch operation at Saalfeld; Trockenfermentation im Batchbetrieb in Saalfeld

Energy Technology Data Exchange (ETDEWEB)

Wittmaier, M. [Institut fuer Kreislaufwirtschaft, Bremen (Germany); Meisgeier, G. [BioFert GmbH, Saalfeld (Germany)

2007-07-01

Biological waste materials are commonly treated by aerobic composting. The resulting compost is used in agriculture, landscaping, horticulture etc. This use of compost as fertilizer saves resources and also has a climate protecting effect. If an additional fermentation stage is installed, renewable energy can be generated at the same time, which will enhance the climate protection effect. (orig.)

Effect of Protectants on the Fermentation Performance of Wine Yeasts Subjected to Osmotic Stress

Directory of Open Access Journals (Sweden)

Andrea Caridi

2003-01-01

Full Text Available During alcoholic fermentation of must from dried grapes, yeasts are subjected to very high sugar concentrations, besides other environmental stresses, and they modify their metabolic behaviour giving low ethanol yield and abnormally high acetic acid production. To investigate the protective effect of catechin, inositol, and SO2 on wine yeasts, three thermotolerant strains of Saccharomyces cerevisiae, selected for wine making of must from dried grapes, and three strains of Saccharomyces selected for the production of wine, were inoculated in a sample of must at very high osmotic strength. A significant (p<0.01 or p<0.05 relationship between the addition of 100 mg/L of catechin, inositol or SO2 to the grape must and the change in the metabolic behaviour of the yeasts was observed. Compared to the control and depending on strain and protectant, the fermentation rate after 3 days increased up to 55 %, the ethanol content of the wines increased up to 16 %, the unitary succinic acid production increased up to 55 %, the unitary acetic acid production decreased up to 53 %, and the unitary glycerol production decreased up to 69 %. So by adding catechin, inositol or SO2 to the grape must it is possible to minimise the abnormal fermentation performance that wine yeasts exhibit in wine making of must from dried grapes.

UTILIZATION OF BIOMOL AND TEA COMPOST SOLUTION FERMENTED BY THE FUNGUS Trichoderma spp. ON THE GROWTH OF SOYBEAN (Glycine Max (L. Merr. IN DRY LAND

Directory of Open Access Journals (Sweden)

Zurriyatun Solihah

2017-02-01

Full Text Available ABSTRACT The purpose of this research is to know whether the use of Biomol and Tea Compost solution fermented by Trichoderma spp. can increase the growth and development of soybean plants in dry land. The experiment was conducted in the field and was arranged according to a Split Plot Design with the main plot is Tea Compost Solution with 4 levels of treatment, i.e. at the rate of 0, 5, 10, or 15 liters/plot and the subplot is Biomol solution with 4 levels of treatment, i.e. 0, 5, 10, or 15 liters/plot. The treatments were repeated three times. The results showed that the use of the Biomol at the rate of 15 liters/plot and Tea Compost at the of 15 liters/plot can increase the growth and development of soybean plants mainly on plant height. In addition, Biomol and Tea Compost solution applied to soybean can  increase the weight of the wet and the dry berangkasan Keywords: Biomol, Tea Compost, Soybean, Trichoderma spp.

Comparison of in situ dry matter degradation parameters with in vitro ...

African Journals Online (AJOL)

Adem Kamalak

grains on rumen fermentation characteristics using the in vitro gas ..... Effect of chemical content and physical characteristics on nutritional value ... properties and in vitro dry matter on starch digestion of eight sorghum grain hybrids and maize.

Volatile emission in dry seeds as a way to probe chemical reactions during initial asymptomatic deterioration.

Science.gov (United States)

Mira, Sara; Hill, Lisa M; González-Benito, M Elena; Ibáñez, Miguel Angel; Walters, Christina

2016-03-01

The nature and kinetics of reactions in dry seeds determines how long the seeds survive. We used gas chromatography to assay volatile organic compounds (VOCs) emitted from seeds of three unrelated species as a means to non-invasively probe chemical changes during very dry, dry, and humid storage (seeds were dried to 5.5, 33, and 75% relative humidity at room temperature). VOCs emitted from seeds stored in humid conditions reflected fermentation-type reactions, with methanol and ethanol being predominant in Lactuca sativa and Carum carvi, and acetaldehyde and acetone being predominant in Eruca vesicaria. Dried C. carvi seeds continued to emit fermentation-type products, although at slower rates than the seeds stored in humid conditions. In contrast, drying caused a switch in VOC emission in L. sativa and E. vesicaria seeds towards higher emission of pentane and hexanal, molecules considered to be byproducts from the peroxidation of polyunsaturated fatty acids. Longevity correlated best with the rate of fermentation-type reactions and appeared unrelated to the rate of lipid peroxidation. Emission of VOCs decreased when seed species were mixed together, indicating that seeds adsorbed VOCs. Adsorption of VOCs did not appear to damage seeds, as longevity was not affected in seed mixtures. Collectively, the study shows similarity among species in the types of reactions that occur in dry seeds, but high diversity in the substrates, and hence the byproducts, of the reactions. Moreover, the study suggests that the most abundant VOCs arise from degradation of storage reserves within seed cells, and that these reactions and their byproducts are not, in themselves, damaging. © The Author 2016. Published by Oxford University Press on behalf of the Society for Experimental Biology.

Effect of mixing digested slurry on the rate of biogas production from dairy manure in batch fermenter

Energy Technology Data Exchange (ETDEWEB)

Kalia, A.K.; Singh, S.P.

2001-09-01

Forty kilograms of pure cattle dung and cattle dung mixed with 10% digested slurry obtained from a field biogas plant was batch fermented in horizontal biogas digesters for 15 weeks under field conditions with mean ambient temperature 20-23{sup o}C. Compared to 821 l of biogas from digester I, containing cattle dung alone, 1457 l of biogas was obtained from digester II, containing cattle dung mixed with 10% digested slurry. Mixing of slurry not only speeded up the gas production but also enhanced its rate from 108 l/kg dry matter to 158 l/kg dry matter. It also resulted in 36.1% distraction of total volatile solid in digester II, compared to 23.93% observed in digester I. Mixing digested slurry is recommended for raising biogas production from cattle dung in dry fermenters. (author)

Corrected: The influence of brewers' yeast addition on lactic acid fermentation of brewers' spent grain hydrolysate by Lactobacillus rhamnosus

OpenAIRE

Pejin, Jelena; Radosavljević, Miloš; Kocić-Tanackov, Sunčica; Đukić-Vuković, Aleksandra; Mladenović, Dragana; Mojović, Ljiljana

2016-01-01

Brewers' spent grain (BSG) hydrolysates were used for lactic acid (LA) fermentation by Lactobacillus rhamnosus ATCC 7469. The aim of this study was to evaluate possibilities of the BSG hydrolysate utilization as a substrate for LA fermentation as well as the effect of dry brewers' yeast addition in hydrolysate on lactic acid fermentation parameters (L-(+)-LA and reducing sugar concentration and number of viable cell-viability). Very high L. rhamnosus ATCC 7469 cell viability was achieved in a...

Dried culture of the fungus Aspergillus oryzae for saccharification in alcohol production

Energy Technology Data Exchange (ETDEWEB)

Drazhner, T M; Ashkinuzi, Z K; El' chits, S V

1963-01-01

Dried A. oryzae in place of malt in saccharification of starch-containing grain mash is known to save valuable grain, labor, and space. Laboratory tests showed adequate amylolytic, dextrinolytic, and maltase activity even after nine months storage. Treatment with 0.1% formalin for one hour or with the filtrate of a calcium hypochlorite solution containing 700 mg/l active chlorine for two hours prevented growth of contaminating microflora for 24 hours of fermentation and was not detrimental. Reduction of dried culture needed for saccharification from 8 to 10 to 3.5 to 4% by weight of the starch in the raw material was possible by 2 methods: (1) a l-stage addition at 40/sup 0/, or (2) a 2-stage introduction: 20 to 25% into the sugaring vessel at 57 to 59/sup 0/ and the rest into the fermentation vat after yeast is added. Method 2 avoids the viscosity problem. Alcohol yield was essentially the same as with malt. An industrial test for a 66-hour fermentation confirmed the advantages of the 2-stage method. Higher acidity of final broth did not affect the results because mold enzymes are more resistant to this factor than are those of malt. Nor is higher dry content, the result of breakdown of hemicellulose, cellulose, and pentosans by mold enzymes, a marked disadvantage.

Productivity and fermentability of Jerusalem artichoke according to harvesting date

Energy Technology Data Exchange (ETDEWEB)

Chabbert, N.; Arnoux, M.; Braun, Ph.; Galzy, P.; Guiraud, J.P.

1983-01-01

The amount of alcohol obtained per hectare of Jerusalem artichoke culture depends on the yield of tubers, the sugar content of the tubers and the fermentability of these sugars. Under Mediterranean climate conditions, the cultivar 'Violet commun' attained its maximum tuber production by 15 November, when the stems and leaves dried up, and then remained constant through the winter. The sugar content of the tubers varied little during this period. However, the sugar composition did vary with time: the polyfructosans were depolymerized. The fermentability of sugars without prior chemical hydrolysis was quite good with Kluyveromyces marxianus which showed high inulinase activity in contrast to Saccharomyces cerevisiae.

Productivity and fermentability of Jerusalem artichoke according to harvesting date

Energy Technology Data Exchange (ETDEWEB)

Chabbert, N.; Braun, P.; Guiraud, J.P.; Arnoux, M.; Galzy, P.

1983-01-01

The amount of alcohol obtained per hectare of Jerusalem artichoke culture depends on the yield of tubers, the sugar content of the tubers and the fermentability of these sugars. Under Mediterranean climate conditions, the cultivar Violet commun attained its maximum tuber production by 15 November, when the stems and leaves dried up, and then remained constant through the winter. The sugar content of the tubers varied little during this period. However, the sugar composition did vary with time: the polyfructosans were depolymerized. The fermentability of sugars without prior chemical hydrolysis was quite good with Kluyveromyces marxianus which showed high inulinase activity in contrast to Saccaromyces cerevisiae. 5 figures, 1 table.

Productivity and fermentability of Jerusalem artichoke according to harvesting date

Energy Technology Data Exchange (ETDEWEB)

Chabbert, M.; Braunt, Ph.; Guiraud, J.P.; Arnoux, M.; Galzy, P.

1983-01-01

The amount of alcohol obtained per hectare of Jerusalem artichoke culture depends on the yield of tubers, the sugar content of the tubers and the fermentability of these sugars. Under Mediterranean climate conditions, the cultivar 'Violet commun' attained its maximum tuber production by 15 November, when the stems and leaves dried up, and then remained constant through the winter. The sugar content of the tubers varied little during this period. However, the sugar composition did vary with time: the polyfructosans were depolymerized. The fermentability of sugars without prior chemical hydrolysis was quite good with Kluyveromyces marxianus which showed high inulinase activity in contrast to Saccharomyces cerevisiae. (Refs. 13).

Antioxidant Properties of Crude Extract, Partition Extract, and Fermented Medium of Dendrobium sabin Flower

Directory of Open Access Journals (Sweden)

Farahziela Abu

2017-01-01

Full Text Available Antioxidant properties of crude extract, partition extract, and fermented medium from Dendrobium sabin (DS flower were investigated. The oven-dried DS flower was extracted using 100% methanol (w/v, 100% ethanol (w/v, and 100% water (w/v. The 100% methanolic crude extract showed the highest total phenolic content (40.33 ± mg GAE/g extract and the best antioxidant properties as shown by DPPH, ABTS, and FRAP assays. A correlation relationship between antioxidant activity and total phenolic content showed that phenolic compounds were the dominant antioxidant components in this flower extract. The microbial fermentation on DS flower medium showed a potential in increasing the phenolic content and DPPH scavenging activity. The TPC of final fermented medium showed approximately 18% increment, while the DPPH of fermented medium increased significantly to approximately 80% at the end of the fermentation. Dendrobium sabin (DS flower showed very good potential properties of antioxidant in crude extract and partition extract as well as better antioxidant activity in the flower fermented medium.

A Traditional Turkish Fermented Non-Alcoholic Grape-Based Beverage, “Hardaliye”

Directory of Open Access Journals (Sweden)

Fatma Coskun

2017-01-01

Full Text Available Hardaliye is a non-alcoholic fermented beverage produced in a traditional way in Thrace, the European part of Turkey. The nutritional value of hardaliye is derived from the grapes and the fermentation process. Health benefits of hardaliye are also related to etheric oils present in mustard seeds. Hardaliye is a lactic acid fermented traditional beverage produced from grape juice and crushed grapes with the addition of different concentrations of whole/ground or heat-treated mustard seeds and sour cherry leaves. The color of hardaliye reflects the original color of the grapes and has a characteristic aroma. Dark red grape is preferred. Benzoic acid is used as preservative during production. Benzoic acid inhibits or decreases alcohol production by affecting the yeast. Fermentation occurs at room temperature for 7–10 days. If the ambient temperature is low, fermentation process can be extended until 20 days. Once fermented, the hardaliye is stored at 4 °C for three to four months. The hardaliye is consumed either fresh or aged. If it is aged, hardaliye may contain alcohol. The industrial production is just in small-scale and it must be developed. More studies are required to determine characteristic properties of hardaliye. Identification of the product properties will supply improvement for industrial production.

Characterization of very high gravity ethanol fermentation of corn mash. Effect of glucoamylase dosage, pre-saccharification and yeast strain

Energy Technology Data Exchange (ETDEWEB)

Devantier, R. [Starch, Applied Discovery, Research and Development, Novozymes A/S, Bagsvaerd (Denmark); Center for Microbial Biotechnology, BioCentrum-DTU, Technical Univ. of Denmark, Kgs Lyngby (Denmark); Pedersen, S. [Starch, Applied Discovery, Research and Development, Novozymes A/S, Bagsvaerd (Denmark); Olsson, L. [Center for Microbial Biotechnology, BioCentrum-DTU, Technical Univ. of Denmark, Kgs Lyngby (Denmark)

2005-09-01

Ethanol was produced from very high gravity mashes of dry milled corn (35% w/w total dry matter) under simultaneous saccharification and fermentation conditions. The effects of glucoamylase dosage, pre-saccharification and Saccharomyces cerevisiae strain on the growth characteristics such as the ethanol yield and volumetric and specific productivity were determined. It was shown that higher glucoamylase doses and/or pre-saccharification accelerated the simultaneous saccharification and fermentation process and increased the final ethanol concentration from 106 to 126 g/kg although the maximal specific growth rate was decreased. Ethanol production was not only growth related, as more than half of the total saccharides were consumed and more than half of the ethanol was produced during the stationary phase. Furthermore, a high stress tolerance of the applied yeast strain was found to be crucial for the outcome of the fermentation process, both with regard to residual saccharides and final ethanol concentration. The increased formation of cell mass when a well-suited strain was applied increased the final ethanol concentration, since a more complete fermentation was achieved. (orig.)

Selection of potential microorganism for sago starch fermentation

Directory of Open Access Journals (Sweden)

RUTH MELLIAWATI

2006-02-01

Full Text Available Fermentation process of sago starch for the production of bioproduct requires potential microorganism that have ability to hydrolyze sago starch. The purpose of this research was to get the potential of amylolytic microorganisms for their capability of amyloglucosidase activity and to know the sugar strains of the fermentation result. Eleven amylolytic microorganisms (9 strains of mold and 2 strains of yeast were obtained from the collection Research Centre for Biotechnology – Indonesian Institute of Sciences (LIPI, Cibinong-Bogor were used. The selection step was carried out based on their capability of starch hydrolysis to reducing sugar. The best result indicates that the production of reducing sugar reached the highest 18.485 ppm and amyloglucosidase activities was 3.583 units by KTU-1 strain. The highest total acid obtained was 5.85 mg/mL by Rhizopus IFO.R5442. The cell biomass was obtained between 0.5 to 1.74 g dry weight/100 mL and pH of the final fermentation (72 h were 3.57 to 8.38.

Effects of bacterial inoculants and an enzyme on the fermentation ...

African Journals Online (AJOL)

... the effects of bacterial inoculation and cellulase on the fermentation quality of ensiled whole-crop sweet sorghum (WCSS, Sorghum bicolor L. Moench). The WCSS (323 g dry matter (DM)/kg, 251 g water soluble carbohydrates (WSC)/kg DM, 43 g crude protein (CP)/kg DM and 439 g neutral detergent fibre (NDF)/kg DM) ...

Simultaneous determination of free amino acids in Pu-erh tea and their changes during fermentation.

Science.gov (United States)

Zhu, Yuchen; Luo, Yinghua; Wang, Pengpu; Zhao, Mengyao; Li, Lei; Hu, Xiaosong; Chen, Fang

2016-03-01

Pu-erh ripened tea is produced through a unique microbial fermentation process from the sun-dried leaves of large-leaf tea species (Camellia sinensis (Linn.) var. assamica (Masters) Kitamura) in Yunnan province of China. In this study, the changes of amino acid profiles during fermentation of Pu-erh tea were investigated, based on the improved HPLC-UV method with PITC pre-column derivatization for the simultaneous determination of twenty free amino acids. Results showed that aspartic acid, glutamic acid, arginine, alanine, theanine and tyrosine were the major amino acids in tea samples. Fermentation significantly influenced on the amino acid profiles. The total free amino acid contents significantly decreased during fermentation (pfermentation and then decreased gradually. The results provided the useful information for the manipulation of fermentation process according to the changes of amino acids and acrylamide contents in Pu-erh ripened tea. Copyright © 2015 Elsevier Ltd. All rights reserved.

Production of freeze-dried lactic acid bacteria starter culture for cassava fermentation into gari

CSIR Research Space (South Africa)

Yao, AA

2009-10-01

Full Text Available Sixteen lactic acid bacteria, eight Lactobacillus plantarum, three L. pentosus, two Weissella paramesenteroides, two L. fermemtum and one Leuconostoc mesenteroides ssp. mesenteroides were previously isolated from cassava fermentation and selected...

A strain of Saccharomyces cerevisiae evolved for fermentation of lignocellulosic biomass displays improved growth and fermentative ability in high solids concentrations and in the presence of inhibitory compounds

Directory of Open Access Journals (Sweden)

Hawkins Gary M

2011-11-01

Full Text Available Abstract Background Softwoods are the dominant source of lignocellulosic biomass in the northern hemisphere, and have been investigated worldwide as a renewable substrate for cellulosic ethanol production. One challenge to using softwoods, which is particularly acute with pine, is that the pretreatment process produces inhibitory compounds detrimental to the growth and metabolic activity of fermenting organisms. To overcome the challenge of bioconversion in the presence of inhibitory compounds, especially at high solids loading, a strain of Saccharomyces cerevisiae was subjected to evolutionary engineering and adaptation for fermentation of pretreated pine wood (Pinus taeda. Results An industrial strain of Saccharomyces, XR122N, was evolved using pretreated pine; the resulting daughter strain, AJP50, produced ethanol much more rapidly than its parent in fermentations of pretreated pine. Adaptation, by preculturing of the industrial yeast XR122N and the evolved strains in 7% dry weight per volume (w/v pretreated pine solids prior to inoculation into higher solids concentrations, improved fermentation performance of all strains compared with direct inoculation into high solids. Growth comparisons between XR122N and AJP50 in model hydrolysate media containing inhibitory compounds found in pretreated biomass showed that AJP50 exited lag phase faster under all conditions tested. This was due, in part, to the ability of AJP50 to rapidly convert furfural and hydroxymethylfurfural to their less toxic alcohol derivatives, and to recover from reactive oxygen species damage more quickly than XR122N. Under industrially relevant conditions of 17.5% w/v pretreated pine solids loading, additional evolutionary engineering was required to decrease the pronounced lag phase. Using a combination of adaptation by inoculation first into a solids loading of 7% w/v for 24 hours, followed by a 10% v/v inoculum (approximately equivalent to 1 g/L dry cell weight into 17

Determination of chemical composition, and storage on dried fermented goat milk product (Oggtt

Directory of Open Access Journals (Sweden)

Badriah O. Al-Abdulkarim

2013-06-01

Full Text Available A sample of dried fermented goat milk product (Oggtt obtained from the local market of Riyadh city in The Kingdom of Saudi Arabia, was stored for 6 months at 4 °C and subjected to chemical composition analysis before and after storage. The result showed that the sample moisture increased significantly (P ⩽ 0.05 after storage from 7% to 10%, total ash decreased non-significantly (P ⩽ 0.05 from 8% to 7.6%, total carbohydrates decreased non-significantly (P ⩽ 0.05 from 35.5% to 33.8%, protein increased non-significantly (P ⩽ 0.05 from 16 to 16.1 g/l, fat content was found to have the same values in all samples before and after storage at 5%, lactose increased (P ⩽ 0.05 non-significantly from 28.4% to 29%, acidity decreased (P ⩽ 0.05 significantly from 0.45% to 0.39%, and pH decreased (P ⩽ 0.05 non-significantly from 4.3% to 4%. On the other hand, mineral composition showed (P ⩽ 0.05 non-significant results before and after storage. Ca concentration decreased from 118 to 1149 mg/kg and K concentration increased from 185.8 to 1888 mg/kg. While Mg increased from 105 to 123 mg/kg, Zn increased from 8.3 to 8.6 mg/kg, Mn and Fe were found to have the same values of concentrations before and after storage which were 0.2 and 0.1 mg/kg, respectively. Accordingly, we can conclude that Oggtt is a stable product and have a good nutritional value in comparison to daily required amounts for healthy human life.

Effects of different microbes on fermenting feed for sea cucumber ( Apostichopus japonicus)

Science.gov (United States)

Jiang, Yan; Wang, Yingeng; Mai, Kangsen; Zhang, Zheng; Liao, Meijie; Rong, Xiaojun

2015-10-01

The effects of different microbes on fermenting feed for sea cucumber ( Apostichopus japonicus) were compared to select the optimal fermentation strain in this study. Saccharomgces cerevisae, Candida utilis, Bacillus subtilis and Geotrichum candidum were independently added into the experimental compound feed, while only saline was mixed with the control feed. The fermentation treatments were inoculated with 10% seed solution under the condition of 25°C and 70% water content, which lasted for 5 days to elucidate the optimal microbe strain for fermenting effect. Physicochemical indexes and sensorial characteristics were measured per day during the fermentation. The indexes included dry matter recovery (DMR), crude protein (CP), the percentage of amino acid nitrogen to total nitrogen (AA-N/tN), the percentage of ammonia nitrogen to total nitrogen (NH3-N/tN), and the ratio of fermentation strains and vibrios to the total microbes, color, smell and viscosity. The results showed that DMR, CP and AA-N/tN of the S. cerevisae group reached the highest level on day 3, but the ratio of fermentation strain was second to C. utilis group. In addition, its NH3-N/tN and the ratio of vibrios were maintained at low levels, and the sensory evaluation score including smell, color and viscosity was the highest in S. cerevisae group on day 3. Therefore, S. cerevisae could be the optimal strain for the feed fermentation for sea cucumber. This research developed a new production method of fermentation feed for sea cucumber.

PENGARUH BERBAGAI MERK DRIED YEAST (Saccharomyces sp. DAN pH AWAL FERMENTASI TERHADAP KARAKTERISTIK WINE SALAK

Directory of Open Access Journals (Sweden)

Ida Bagus Wayan Gunam

2017-09-01

Full Text Available The purpose of this research were to find out the effect of different of dried yeast and initial pH of fermentation on the characteristic of salacca wine, and to determine the appropriate of kind of dried yeast and initial pH of fermentation to produce salacca wine with the best characteristic. This research used Randomized Block Design with factorial pattern. The first factor was the kind of dried yeast brand that consisted of 3 kinds namely Lalvin, Levure and Alcotec. The second factor consisted of 5 levels of initial pH, namely 3.5; 4; 4.5; 5; and 5.5. Each treatment was done 2 times, in order to obtain 30 trial units. The data obtained was analyzed using ANOVA followed by Duncans test. Interactions between treatments had very significant effect on the ethanol content, reduction sugar content, and pH, but had significant effect on acid total content. The best treatment was to use the Alcotec brand dried yeast with a treatment of initial pH as 4, with the following characteristics: ethanol content 12.40%, negative content of methanol, reduction sugar content 5.87%, acid total content 0.20%, pH 3.5 after the fermentation, the color was enough pure yellow, the flavor was strong enough, the taste was strong enough, and rather liked over all acceptance.

Co-fermentation of cellobiose and xylose by mixed culture of recombinant Saccharomyces cerevisiae and kinetic modeling.

Science.gov (United States)

Chen, Yingying; Wu, Ying; Zhu, Baotong; Zhang, Guanyu; Wei, Na

2018-01-01

Efficient conversion of cellulosic sugars in cellulosic hydrolysates is important for economically viable production of biofuels from lignocellulosic biomass, but the goal remains a critical challenge. The present study reports a new approach for simultaneous fermentation of cellobiose and xylose by using the co-culture consisting of recombinant Saccharomyces cerevisiae specialist strains. The co-culture system can provide competitive advantage of modularity compared to the single culture system and can be tuned to deal with fluctuations in feedstock composition to achieve robust and cost-effective biofuel production. This study characterized fermentation kinetics of the recombinant cellobiose-consuming S. cerevisiae strain EJ2, xylose-consuming S. cerevisiae strain SR8, and their co-culture. The motivation for kinetic modeling was to provide guidance and prediction of using the co-culture system for simultaneous fermentation of mixed sugars with adjustable biomass of each specialist strain under different substrate concentrations. The kinetic model for the co-culture system was developed based on the pure culture models and incorporated the effects of product inhibition, initial substrate concentration and inoculum size. The model simulations were validated by results from independent fermentation experiments under different substrate conditions, and good agreement was found between model predictions and experimental data from batch fermentation of cellobiose, xylose and their mixtures. Additionally, with the guidance of model prediction, simultaneous co-fermentation of 60 g/L cellobiose and 20 g/L xylose was achieved with the initial cell densities of 0.45 g dry cell weight /L for EJ2 and 0.9 g dry cell weight /L SR8. The results demonstrated that the kinetic modeling could be used to guide the design and optimization of yeast co-culture conditions for achieving simultaneous fermentation of cellobiose and xylose with improved ethanol productivity, which is

Production of Extracellular Lipase from Aspergillus niger by Solid-State Fermentation

Directory of Open Access Journals (Sweden)

Janny Coca Armas

2006-01-01

Full Text Available Lipase production in Aspergillus niger J-1 was tested using both submerged fermentation (SmF and solid-state fermentation (SSF on a mineral culture medium and wheat bran, respectively. The optimization of the culture medium was carried out for both SmF and SSF. The maximum lipase activity, 1.46 IU/mL, was obtained during the submerged fermentation in a medium containing glucose at 2 % and olive oil at 2 % under conditions of 1 vvm and 450 m–1. However, 9.14 IU/g of dry solid substrate equivalent to 4.8 IU/mL of lipase activity was reached using solid-state fermentation process with a medium containing 0.75 % of ammonium sulphate and 0.34 % of urea. The optimum pH and temperature for enzymatic activity were pH=6 and 40 °C, respectively. The enzyme also exhibited 80 % of its initial activity in neutral and mildly acid media and at temperatures between 20 and 30 °C for a period of 24 hours.

Scientific Opinion on the safety of ‘heat-treated milk products fermented with Bacteroides xylanisolvens DSM 23964’ as a novel food

DEFF Research Database (Denmark)

Tetens, Inge; Poulsen, Morten

2015-01-01

Following a request from the European Commission, the EFSA NDA Panel was asked to carry out the additional assessment for ‘pasteurised milk products fermented with Bacteroides xylanisolvens DSM 23964’ as a novel food (NF) in the context of Regulation (EC) No 258/97. Pasteurised or ultra-high-temp......Following a request from the European Commission, the EFSA NDA Panel was asked to carry out the additional assessment for ‘pasteurised milk products fermented with Bacteroides xylanisolvens DSM 23964’ as a novel food (NF) in the context of Regulation (EC) No 258/97. Pasteurised or ultra......-high-temperature-treated milk is used for the fermentation process with B. xylanisolvens DSM 23964. After fermentation the product is heat treated for one hour at 75 °C to ensure the absence of viable B. xylanisolvens DSM 23964. The Panel considers the information provided on the identity and characterisation of B...

Effect of fermented, hardened, and dehulled of chickpea (Cicer arietinum) meals in digestibility and antinutrients in diets for tilapia (Oreochromis niloticus)

International Nuclear Information System (INIS)

Valdez-González, F.J.; Gutiérrez-Dorado, R.; García-Ulloa, M.; Cuevas-Rodríguez, B.; Rodríguez-González, H.

2018-01-01

Among the most typical feed sources for tilapia, plants represent a low-cost source in substituting for traditional high-cost feed ingredients. Fermentation, hardening and dehulling are common grains processing techniques to make plant nutrients available and more digestible to fish. Apparent digestibility coefficients (ADC) of dry matter and protein, and antinutrients (phytic acid and tannins) in fermented, hardened and dehulled chickpea (Cicer arietinum) meals were determined for juvenile Nile tilapia (Oreochromis niloticus). The highest ADC was obtained with processed (fermented, hardened and dehulled) chickpea meals compared with non-processed. Results indicated that fermentation increased the protein content by 13.1%, decreased the content of ash and phytic acid (47.5 and 45%, respectively), and increased the ingredient apparent digestibility of dry matter (ADM) by 23.2%, and the ingredient apparent digestibility of protein (ADP) by 41.9%. Dehulling meal increased the protein (5.7%) and lipid (6.4%) content of chickpea grains; decreased fiber, ash and tannin content (75.3%, 19.1%, and 84.5%, respectively); and increased ADM by 12.8%, and ADP by 10.4%. We conclude that fermented, hardened and dehulled chickpea meals represent a potential alternative in diets for juvenile O. niloticus.

Standard working procedures in production of traditionally fermented Sremska sausage

Directory of Open Access Journals (Sweden)

Vesković-Moračanin Slavica

2011-01-01

Full Text Available Investigations conducted within project "Techonological and protective characteristics of autochthonous strains of lactic acid bacteria isolated from traditional fermented sausages and possibilities for their implementation in the meat industry" (Project Number: 20127, financed on behalf of the Ministry for Science and Technology of the Republic of Serbia, have provided an answer on the characteristics of the quality of the used raw materials for the production of Sremska sausage - one of the most well-known Serbian traditionally fermented sausages (choice of meat, fatty tissue, additives and spices, and data have been registered in connection with the procedures of their processing, microclimatic conditions have been established (temperature, relative humidity, and air circulation during the entire process of production and fermentation, as well as the presence and types of microorganisms, primarily lactic acid bacteria (BMK, the carrier of lactic fermentation. The most important characteristics of the filling have been established, the smoking regimen, the regimens of fermentation, maturing, drying, as well as the parameters for quality and safety of the finished product. At the same time, the standard working procedure has been determined for the preparation of the meat, fatty tissue, the forming and inserting of the filling into the wrappers, as well as the characteristics of the finished products. The given standard working procedure should serve as a guideline for the meat industry in the production process of this traditional fermented sausage.

Thesis Abstract Fermented milk elaborated with Camellia sinensis.

Science.gov (United States)

Ribeiro, O A S; Silva, M I A; Boari, C A

2016-05-13

This study aimed to develop and to characterize fermented dairy beverage formulated with Camellia sinensis. The infusion was elaborated with the addiction of dehydrated leaves of C. sinensis in whey (1g/100g) which added in sweetened milk (10% sucrose w/w) coagulated by Streptococcus salivarius subspecies thermophilus and Lactobacillus delbrueckii subspecies bulgaricus in proportions of 10, 20, 30 and 40% (v/w). The control treatment consisted of yogurt added with sucrose (10% w/w). Analysis were performed to quantify dry mass, moisture, ash, protein, fat, sodium, acidity, total quantification of lactic acid bacteria, total antioxidant activity and viscosity at the initial time of production and at 15 and 30 days of storage. Chromatographic determination of volatile compounds and sensory tests of acceptance and consumption intention were conducted at the initial time of production. Dry matter content, moisture, ash and total count of lactic acid bacteria from fermented milk drink formulations were not significantly affected by the amount of infusion of C. sinensis. However, the content of protein, fat and sodium were significantly lower with the increase of the proportion of infusion incorporated into the product. Significant reduction in apparent viscosity occurs with the increase in the amount of infusion added. The total antioxidant activity of the formulations was significantly higher as higher were the amount of added infusion. The addition of infusion contributed to the diversification of volatile aroma and taste makers in the product. The formulation of fermented dairy drink with addition of 30% infusion C. sinensis was better evaluated in sensory tests, with greater acceptance and greater consumer intent of consumption.

SUPPLEMENTATION OF COFFEE HUSK FERMENTED WITH Pleurotus ostreatus: EFFECT ON PERFORMANCE AND BLOOD PROFILE OF GASTROINTESTINAL NEMATODES INFECTED GOAT

Directory of Open Access Journals (Sweden)

I. Badarina

2016-03-01

Full Text Available The aim of this study was to investigate the potency of coffee husk fermented with P.ostreatus as a natural anthelmintic supplement by measuring the performance and blood profile of goat suffered gastrointestinal nematodes infection. Eighteen local male goats of Kacang goat with body weight of 9.23 ± 1.71 kg and aged at ± 10 months were arranged into three treatments in completely randomized design. The treatments were T0 (group without chemical anthelmintic treatment and no supplementation of fermented coffee husk, T1 (without chemical anthelmintic treatment, but supplied with fermented coffee husk and T2 (group with chemical anthelmintic and no supplementation of fermented coffee husk. All goats were offered a basal diet in the ratio of 60% natural grasses along with 40% concentrate. Fermented coffee husk was added in the diet as much as 6% from the dry matter need. The result showed that there were no significant effect to dry matter intake, daily weight gain, PCV value and eosinophil counts (P>0.05. The supplementation of fermented coffee husk (T1 enhanced Hb and red blood cell (RBC value (P<0.05 while no significant difference to T2. There were no nematodes infection in T1 and T2 with the eggs count were zero while the animals in T0 were still infected. This result indicated that fermented coffee husk can be used as a promising natural anthelmintic supplement with the improvement of Hb value, RBC, egg counts and daily weight gain.

Comparison of volatiles and mosquito capture efficacy for three carbohydrate sources in a yeast-fermentation CO2 generator

Science.gov (United States)

Mosquito surveillance in remote areas with limited access to canisters of CO2 or dry ice will benefit from an effective alternative CO2 source. In this study, we document the differences in mosquito and non-mosquito capture rates from CO2 baited (dry ice or yeast fermentation of carbohydrates) CDC t...

Kinetics of methane fermentation yield in biogas reactors: Genetic variation and association with chemical composition in maize

International Nuclear Information System (INIS)

Grieder, Christoph; Mittweg, Greta; Dhillon, Baldev S.; Montes, Juan M.; Orsini, Elena; Melchinger, Albrecht E.

2012-01-01

Maize (Zea mays L.) is the most competitive crop for methane production in Germany. Methane fermentation yield per unit of dry matter (MFY) is a determinant of methane yield, but little information is available on this trait. Our objectives were to investigate the kinetics of MFY during fermentation of maize, estimate quantitative-genetic parameters for different traits related to MFY and examine the relationship of MFY with chemical composition and silage quality. Whole-plant material of 16 inbreds and their 32 testcrosses was analyzed for MFY over 35 days of fermentation using a discontinuous laboratory assay. Data were also generated on chemical composition and in vitro digestible organic matter (IVDOM). Significant genotypic variances and high heritabilities were observed for MFY at early fermentation stages (up to 5 days) probably due to different concentrations of easily degradable chemical components. However, genotypic variances and heritability of MFY reduced as fermentation progressed, because of complete or partial degradation of all chemical components. Further, there were strong correlations of MFY with chemical components at early fermentation stages but not at later stages. Therefore, MFY at later stages, which is closer to potential MFY, does not seem to be amenable to selection. High heritability of IVDOM and its strong correlation with MFY in testcrosses indicated its possible use for preliminary or indirect selection. Keeping in view the magnitude of genetic variance that was low for MFY and high for dry matter yield (DMY), the other component of methane yield, more emphasis on breeding for DMY seems appropriate. -- Highlights: ► We investigated methane fermentation yield (MFY) of diverse germplasm of maize. ► The kinetics of MFY and its correlations with chemical composition were examined. ► Genetic variance and heritability for MFY decreased with fermentation time. ► Complete fermentation (35 d) reduced correlations of MFY with chemical

Changes in the phenolic acid content during commercial dry-grind processing of corn to ethanol and DDGS

Science.gov (United States)

Nine fractions (ground corn-1, cooked slurry-2, liquefied slurry-3, fermented mash-4, whole stillage-5, thin stillage-6, condensed distillers soluble (CDS)-7, distillers wet grains (DWG)-8, and distillers dried grains with solubles (DDGS)-9) were collected from three commercial dry-grind bioethanol ...

Decontamination of biological ferment by gamma radiation

International Nuclear Information System (INIS)

Sabundjian, Ingrid T.; Salum, Debora C.; Silva, Priscila V.; Furgeri, Camilo; Duarte, Renato; Villavicencio, Anna Lucia C.H.

2007-01-01

Biological ferment is a product obtained from pure yeast (Saccharomyces cerevisiae) culture by a suitable technological process and employed to increase the size and porosity of the baker's products. Foods containing high microorganisms count indicate that Good Manufacturing Practices were not applied. The aim of this study was to observe the viability of Dry Biological Ferment after the radiation process using different doses of 60 Co gamma rays and different storage times. Dry baker's yeast Saccharomyces cerevisiae samples were purchased from a local supermarket in Sao Paulo (Brazil) and irradiated at IPEN in a Gammacell source at 0.5, 1.0, 2.0 and 3.0 kGy doses (dose-rate of 3.51 kGy/h) at room temperature (25 deg C). The fluorescent method was performed to observe the viability of yeast cells. The viability decrease with the increase of the radiation dose, as shown: the amount of the viable cell found in the non-irradiated samples (control) at 0 day was 87.2%; 30 days 67.7%; 60 days 77.4% and 90 days 60.1%. With 1.0 kGy at 0 day was 61.4%; 30 days 22.7%; 60 days 56.9% and 90 days 24.2%. With 3.0 kGy at 0 day was 57.00%; at the next periods the most of the cells become not viable. (author)

Study on Production and Properties of Kumiss of Herders in Mongolian Dry Steppe

OpenAIRE

ISHII, Satomi; HOSINO, Buho; KOMIYAMA, Hiroshi; UEHARA, Aritune; NURTAZIN, Sabyr

2014-01-01

Kumiss, prepared in dry inland Asia, is a carbonated beverage containing about 2% alcohol, prepared by fermenting raw horse milk with lactic acid bacteria and yeast. The quality of Kumiss is markedly influenced by factors affecting the quality of horse milk: grass eaten by horses, habitat and microclimate conditions of the herders’ home (temperature). The type of microorganisms and dominant flora in Kumiss vary among families. Many lactic acid bacteria involved in fermentation belong to Lacto...

Improving production of volatile fatty acids from food waste fermentation by hydrothermal pretreatment.

Science.gov (United States)

Yin, Jun; Wang, Kun; Yang, Yuqiang; Shen, Dongsheng; Wang, Meizhen; Mo, Han

2014-11-01

Food waste (FW) was pretreated by a hydrothermal method and then fermented for volatile fatty acid (VFAs) production. The soluble substance in FW increased after hydrothermal pretreatment (⩽200 °C). Higher hydrothermal temperature would lead to mineralization of the organic compounds. The optimal temperature for organic dissolution was 180 °C, at which FW dissolved 42.5% more soluble chemical oxygen demand than the control. VFA production from pretreated FW fermentation was significantly enhanced compared with the control. The optimal hydrothermal temperature was 160 °C with a VFA yield of 0.908 g/g VSremoval. Butyrate and acetate were the prevalent VFAs followed by propionate and valerate. FW fermentation was inhibited after 200 °C pretreatment. The VFAs were extracted from the fermentation broth by liquid-liquid extraction. The VFA recovery was 50-70%. Thus, 0.294-0.411 g VFAs could be obtained per gram of hydrothermally pretreated FW (in dry weight) by this method. Copyright © 2014 Elsevier Ltd. All rights reserved.

Development of an In Vivo and In Vitro Ileal Fermentation Method in a Growing Pig Model.

Science.gov (United States)

Montoya, Carlos A; de Haas, Edward S; Moughan, Paul J

2018-02-01

Substantial microbial fermentation may occur mainly in the lower small intestine (SI) of human adults, but there is no established methodology to determine this. The study aimed to develop a combined in vivo and in vitro methodology for ileal fermentation based on the pig as an animal model for digestion in human adults. Several aspects of a combined in vivo/in vitro ileal fermentation assay were evaluated. Male 9-wk-old pigs (n = 30; mean ± SD body weight: 23 ± 1.6 kg) were fed a human-type diet (143, 508, 45, 49, and 116 g/kg dry matter diet of crude protein, starch, total lipid, ash, and total dietary fiber) for 15 d. On day 15, pigs were killed, and the last third of the SI was collected to prepare an ileal digesta-based inoculum. Terminal jejunal digesta (last 50 cm of the second third of the SI) were collected as substrate for the assay to test the form of substrate (fresh or freeze-dried), origin (location in jejunum or SI) of the substrate, storage of the inoculum, incubation time (1.2-6.8 h), pH of the medium, and inoculum concentration (6-26 mg inoculum/100 mg substrate). The group of donor pigs used to prepare the inoculum, form of the substrate, origin of the substrate, origin of the inoculum (location in the SI), storage of the inoculum, incubation time, and inoculum concentration did not influence the in vitro ileal organic matter (OM) fermentability (P > 0.05). The in vitro ileal OM fermentability decreased when the pH of the medium increased from 5.5 to 7.5 (31% to 28%; P ≤ 0.05). Predicted (in vivo/in vitro) apparent ileal OM digestibility was similar to the value measured in vivo. Thirty-percent of the terminal jejunal digesta OM was fermented in the ileum. Fiber fermentation in the ileum can be studied using the optimized in vivo/in vitro ileal fermentation method.

Lipolytic Changes in Fermented Sausages Produced with Turkey Meat: Effects of Starter Culture and Heat Treatment.

Science.gov (United States)

Karsloğlu, Betül; Çiçek, Ümran Ensoy; Kolsarici, Nuray; Candoğan, Kezban

2014-01-01

In this study, the effects of two different commercial starter culture mixes and processing methodologies (traditional and heat process) on the lipolytic changes of fermented sausages manufactured with turkey meat were evaluated during processing stages and storage. Free fatty acid (FFA) value increased with fermentation and during storage over 120 d in all fermented sausage groups produced with both processing methodologies (p<0.05). After drying stage, free fatty acid values of traditional style and heat processed fermented sausages were between 10.54-13.01% and 6.56-8.49%, respectively. Thiobarbituric acid (TBA) values of traditionally processed fermented sausages were between 0.220-0.450 mg·kg(-1), and TBA values of heat processed fermented sausages were in a range of 0.405-0.795 mg·kg(-1). Oleic and linoleic acids were predominant fatty acids in all fermented sausages. It was seen that fermented sausage groups produced with starter culture had lower TBA and FFA values in comparison with the control groups, and heat application inhibited the lipase enzyme activity and had an improving effect on lipid oxidation. As a result of these effects, heat processed fermented sausages had lower FFA and higher TBA values than the traditionally processed groups.

Optimal Cultivation Time for Yeast and Lactic Acid Bacteria in Fermented Milk and Effects of Fermented Soybean Meal on Rumen Degradability Using Nylon Bag Technique

Directory of Open Access Journals (Sweden)

S. Polyorach

2016-09-01

Full Text Available The objectives of this study were to determine an optimal cultivation time for populations of yeast and lactic acid bacteria (LAB co-cultured in fermented milk and effects of soybean meal fermented milk (SBMFM supplementation on rumen degradability in beef cattle using nylon bag technique. The study on an optimal cultivation time for yeast and LAB growth in fermented milk was determined at 0, 4, 8, 24, 48, 72, and 96 h post-cultivation. After fermenting for 4 days, an optimal cultivation time of yeast and LAB in fermented milk was selected and used for making the SBMFM product to study nylon bag technique. Two ruminal fistulated beef cattle (410±10 kg were used to study on the effect of SBMFM supplementation (0%, 3%, and 5% of total concentrate substrate on rumen degradability using in situ method at incubation times of 0, 2, 4, 6, 12, 24, 48, and 72 h according to a Completely randomized design. The results revealed that the highest yeast and LAB population culture in fermented milk was found at 72 h-post cultivation. From in situ study, the soluble fractions at time zero (a, potential degradability (a+b and effective degradability of dry matter (EDDM linearly (p<0.01 increased with the increasing supplemental levels and the highest was in the 5% SBMFM supplemented group. However, there was no effect of SBMFM supplement on insoluble degradability fractions (b and rate of degradation (c. In conclusion, the optimal fermented time for fermented milk with yeast and LAB was at 72 h-post cultivation and supplementation of SBMFM at 5% of total concentrate substrate could improve rumen degradability of beef cattle. However, further research on effect of SBMFM on rumen ecology and production performance in meat and milk should be conducted using in vivo both digestion and feeding trials.

Impact of different spray-drying conditions on the viability of wine Saccharomyces cerevisiae strains.

Science.gov (United States)

Aponte, Maria; Troianiello, Gabriele Danilo; Di Capua, Marika; Romano, Raffaele; Blaiotta, Giuseppe

2016-01-01

Spray-drying (SD) is widely considered a suitable method to preserve microorganisms, but data regarding yeasts are still scanty. In this study, the effect of growing media, process variables and carriers over viability of a wild wine Saccharomyces (S.) cerevisiae LM52 was evaluated. For biomass production, the strain was grown (batch and fed-batch fermentation) in a synthetic, as well as in a beet sugar molasses based-medium. Drying of cells resuspended in several combinations of soluble starch and maltose was performed at different inlet and outlet temperatures. Under the best conditions-suspension in soluble starch plus maltose couplet to inlet and outlet temperatures of 110 and 55 °C, respectively-the loss of viability of S. cerevisiae LM52 was 0.8 ± 0.1 and 0.5 ± 0.2 Log c.f.u. g(-1) for synthetic and molasses-based medium, respectively. Similar results were obtained when S. cerevisiae strains Zymoflore F15 and EC1118, isolated from commercial active dry yeast (ADY), were tested. Moreover, powders retained a high vitality and showed good fermentation performances up to 6 month of storage, at both 4 and -20 °C. Finally, fermentation performances of different kinds of dried formulates (SD and ADY) compared with fresh cultures did not show significant differences. The procedure proposed allowed a small-scale production of yeast in continuous operation with relatively simple equipment, and may thus represent a rapid response-on-demand for the production of autochthonous yeasts for local wine-making.

Investigating the fermentation of cocoa by correlating denaturing gradient gel electrophoresis profiles and near infrared spectra

DEFF Research Database (Denmark)

Nielsen, Dennis Sandris; Snitkjær, Pia; van der Berg, Franciscus Winfried J

2008-01-01

demonstrating the microbial succession taking place during the fermentation. Subsequently the DGGE spectra were correlated to the NIR spectra using Partial Least Squares regression models (PLS2). Correlations of 0.87 (bacterial derived DGGE spectra) and 0.81 (yeast derived DGGE spectra) were obtained indicating......Raw cocoa has an astringent, unpleasant taste and flavour, and has to be fermented, dried and roasted in order to obtain the characteristic cocoa flavour and taste. During the fermentation microbial activity outside the cocoa beans induces biochemical and physical changes inside the beans...... of the beans and the chemical processes inside the beans have been carried out previously. Recently it has been shown that Denaturing Gradient Gel Electrophoresis (DGGE) offers an efficient tool for monitoring the microbiological changes taking place during the fermentation of cocoa. Near Infrared (NIR...

A fly in the ointment: evaluation of traditional use of plants to repel and kill blowfly larvae in fermented fish.

Directory of Open Access Journals (Sweden)

Hugo J de Boer

Full Text Available INTRODUCTION: In rural areas in Laos, fly larvae infestations are common in fermenting fish. Blowflies (Chrysomya megacephala, Diptera: Calliphoridae are attracted to oviposit (and/or larviposit onto fermenting fish which results in infestations with fly larvae. Knowledge of traditional use of plants to repel larvae during the production of fermented fish is common and widespread in Lao PDR. RESEARCH QUESTIONS: How effective are the most salient species in repelling, and killing fly larvae in fermenting fish? MATERIAL AND METHODS: The three plant species most frequently reported to repel fly larvae during an ethnobotanical survey throughout Lao PDR were tested for repellence and larvicidal activity of fly larvae infesting fermented fish. The lethality and repellence of Tadehagi triquetrum (L. H. Ohashi (Fabaceae, Uraria crinita (L. Desv. ex DC. (Fabaceae and Bambusa multiplex (Lour. Raeusch. ex Schult. & Schult. f. (Poaceae were tested in an experimental design using fermenting fish in Vientiane, Lao PDR. RESULTS: The repellent effect of fresh material of T. triquetrum and U. crinita, and the larvicidal effect of fresh B. multiplex, is significantly more effective than that of dried material of the same species, and the total effect (repellence and larvicidal effect combined for each of the three species was significantly more effective for fresh than for dry material. Fresh material of T. triquetrum, U. crinita, or B. multiplex added on top of the fermenting fish repelled 50%, 54%, 37%, and killed 22%, 28%, and 40% of fly larvae. The total effect was not significantly different per species at 72%, 82%, and 77%, respectively. DISCUSSION AND CONCLUSIONS: The three most salient species are effective in repelling and killing fly larvae in the production of fermented fish, and may be essential to augment food safety during traditional fermentation in open jars.

Determination of dry matter and organic matter content in input material for solid-matter fermentation

International Nuclear Information System (INIS)

Edelmann, W.

2008-01-01

This final report for the Swiss Federal Office of Energy (SFOE) presents and discusses the results of tests made on various samples of biogenous wastes taken from four fermentation plants in Switzerland. The aims of the tests made on the fermentation input materials that were sampled on a weekly basis are discussed. Various relevant data on the samples noted include the characterisation of the material and even weather data. The spread of the data acquired is discussed. The results obtained are examined in detail, including seasonal variations. The basic findings of the project are presented and differences between countryside and city areas as well as garden and catering wastes are discussed. A comprehensive appendix presents details on the data collected.

Fermentation based carbon nanotube multifunctional bionic composites

Science.gov (United States)

Valentini, Luca; Bon, Silvia Bittolo; Signetti, Stefano; Tripathi, Manoj; Iacob, Erica; Pugno, Nicola M.

2016-06-01

The exploitation of the processes used by microorganisms to digest nutrients for their growth can be a viable method for the formation of a wide range of so called biogenic materials that have unique properties that are not produced by abiotic processes. Here we produced living hybrid materials by giving to unicellular organisms the nutrient to grow. Based on bread fermentation, a bionic composite made of carbon nanotubes (CNTs) and a single-cell fungi, the Saccharomyces cerevisiae yeast extract, was prepared by fermentation of such microorganisms at room temperature. Scanning electron microscopy analysis suggests that the CNTs were internalized by the cell after fermentation bridging the cells. Tensile tests on dried composite films have been rationalized in terms of a CNT cell bridging mechanism where the strongly enhanced strength of the composite is governed by the adhesion energy between the bridging carbon nanotubes and the matrix. The addition of CNTs also significantly improved the electrical conductivity along with a higher photoconductive activity. The proposed process could lead to the development of more complex and interactive structures programmed to self-assemble into specific patterns, such as those on strain or light sensors that could sense damage or convert light stimulus in an electrical signal.

Combinatorial pretreatment and fermentation optimization enabled a record yield on lignin bioconversion.

Science.gov (United States)

Liu, Zhi-Hua; Xie, Shangxian; Lin, Furong; Jin, Mingjie; Yuan, Joshua S

2018-01-01

Lignin valorization has recently been considered to be an essential process for sustainable and cost-effective biorefineries. Lignin represents a potential new feedstock for value-added products. Oleaginous bacteria such as Rhodococcus opacus can produce intracellular lipids from biodegradation of aromatic substrates. These lipids can be used for biofuel production, which can potentially replace petroleum-derived chemicals. However, the low reactivity of lignin produced from pretreatment and the underdeveloped fermentation technology hindered lignin bioconversion to lipids. In this study, combinatorial pretreatment with an optimized fermentation strategy was evaluated to improve lignin valorization into lipids using R. opacus PD630. As opposed to single pretreatment, combinatorial pretreatment produced a 12.8-75.6% higher lipid concentration in fermentation using lignin as the carbon source. Gas chromatography-mass spectrometry analysis showed that combinatorial pretreatment released more aromatic monomers, which could be more readily utilized by lignin-degrading strains. Three detoxification strategies were used to remove potential inhibitors produced from pretreatment. After heating detoxification of the lignin stream, the lipid concentration further increased by 2.9-9.7%. Different fermentation strategies were evaluated in scale-up lipid fermentation using a 2.0-l fermenter. With laccase treatment of the lignin stream produced from combinatorial pretreatment, the highest cell dry weight and lipid concentration were 10.1 and 1.83 g/l, respectively, in fed-batch fermentation, with a total soluble substrate concentration of 40 g/l. The improvement of the lipid fermentation performance may have resulted from lignin depolymerization by the combinatorial pretreatment and laccase treatment, reduced inhibition effects by fed-batch fermentation, adequate oxygen supply, and an accurate pH control in the fermenter. Overall, these results demonstrate that combinatorial

Cross-cultural acceptance of a traditional yoghurt-like product made from fermented cereal

OpenAIRE

Akissoé, Noël H.; Sacca, Carole; Declemy, Anne-Laure; Bechoff, Aurelie; Anihouvi, Victor B.; Dalodé, Générose; Pallet, Dominique; Fliedel, Géneviève; Mestres, Christian; Hounhouigan, Joseph D.; Tomlins, Keith I.

2015-01-01

BACKGROUND: Akpan is a traditional ready-to-drink fermented yoghurt-like cereal beverage consumed in urban and rural areas in Benin. With the aim of adapting the product to new local and export markets, this work maps African and European consumer preferences for different types of Akpan.\\ud \\ud RESULTS: A sensory profile of Akpan was created and consumer tests were conducted with 103 consumers of African origin and 74 consumers of European origin. Consumer acceptance was significantly correl...

Effective survival of immobilized Lactobacillus casei during ripening and heat treatment of probiotic dry-fermented sausages and investigation of the microbial dynamics.

Science.gov (United States)

Sidira, Marianthi; Karapetsas, Athanasios; Galanis, Alex; Kanellaki, Maria; Kourkoutas, Yiannis

2014-02-01

The aim was the assessment of immobilized Lactobacillus casei ATCC 393 on wheat in the production of probiotic dry-fermented sausages and the investigation of the microbial dynamics. For comparison, sausages containing either free L. casei ATCC 393 or no starter culture were also prepared. During ripening, the numbers of lactobacilli exceeded 7 log cfu/g, while a drastic decrease was observed in enterobacteria, staphylococci and pseudomonas counts. Microbial diversity was further studied applying a PCR-DGGE protocol. Members of Lactobacillus, Leuconostoc, Lactococcus, Carnobacterium, Brochothrix, Bacillus and Debaryomyces were the main microbial populations detected. Microbiological and strain-specific multiplex PCR analysis confirmed that the levels of L. casei ATCC 393 in the samples after 66 days of ripening were above the minimum concentration for conferring a probiotic effect (≥ 6 log cfu/g). However, after heat treatment, this strain was detected at the above levels, only in sausages containing immobilized cells. © 2013.

Preservation of hatchery waste by lactic acid fermentation. 2. Large-scale fermentation and feeding trial to evaluate feeding value.

Science.gov (United States)

Deshmukh, A C; Patterson, P H

1997-09-01

Two waste streams from a Leghorn hatchery were preserved and recycled by fermentation with a by-product carbohydrate and extrusion processing into new feed ingredients that were evaluated with broiler chickens. Cockerel chicks (CC) and a 60:40 ratio of CC:shell waste (CC:SW) were fermented in 189-L barrels for 21 d following grinding, then mixing with a liquid culture (0.2%) and carbohydrate source at 15 and 16.66%, respectively. At 2 wk, pH was 4.44 and 5.09 for the CC and CC:SW products compared with higher values of 6.54 and 6.98 for the raw ingredients at the onset. Negligible hydrogen sulfide and no ammonia gas were recorded during the fermentation period. At 21 d, the fermented CC and CC:SW were extruded, dried, and ground to meals containing CP and TMEn levels of 47.4%, 3,187 kcal/kg, and 33.1%, 2,696 kcal/kg, respectively. Broiler chickens were fed a control diet and the CC (5 and 10%) and CC:SW (2.5 and 5%) ingredient diets with corn and soybean meal for 6 wk to evaluate feeding value and carcass yield. Body weight, gain and feed conversion at 42 d for birds fed diets supplemented with CC or CC:SW at all levels were comparable to those of the control. Diets supplemented with hatchery by-product had no negative effect on carcass measurements except ready to cook carcass and wing yield, which were significantly greater for the 10% CC:SW birds than for the control. These data indicate that nutrient dense hatchery by-products can be preserved with fermentation up to 21 d and support broiler live performance and carcass yield as dietary ingredients equal to or better than a corn-soybean meal control.

Effect of urea inclusion in diets containing corn dried distillers grains on feedlot cattle performance, carcass characteristics, ruminal fermentation, total tract digestibility, and purine derivatives-to-creatinine index.

Science.gov (United States)

Ceconi, I; Ruiz-Moreno, M J; DiLorenzo, N; DiCostanzo, A; Crawford, G I

2015-01-01

Increased availability of rapidly fermentable carbohydrates and a great proportion of corn-derived CP in the diet may result in a degradable intake protein (DIP) deficit. Therefore, ruminal DIP deficit may result from high dietary inclusion of processed corn grain and small to moderate inclusion of corn distillers grains (DG). Two experiments were conducted to evaluate the effect of increasing dietary DIP concentration through the inclusion of urea on feedlot cattle performance, carcass characteristics, ruminal fermentation, total tract digestibility, and purine derivatives-to-creatinine (PDC) index. In Exp. 1, 42 steers (428 ± 5 kg initial BW) were assigned randomly to 1 of 3 diets containing (DM basis) 0 (control [CON]), 0.4 (low urea [LU]), or 0.6% urea (high urea [HU]) to provide 6.4, 7.5, or 8.0% dietary DIP, respectively, and 12% high-moisture corn (HMC), 20% corn dried DG with solubles (DDGS), 10% ryegrass haylage, 2.9% dry supplement, and dry-rolled corn (DRC). Steers were fed ad libitum once daily using a Calan gate system. Carcass-adjusted final BW and DMI were similar among treatments (P ≥ 0.58). Carcass-adjusted ADG was greater (P ≤ 0.04) for the HU diet compared with the LU and CON diets and was similar (P = 0.73) between the LU and CON diets. Carcass-adjusted G:F was greater (P = 0.03) for the HU diet compared with the LU diet, tended (P = 0.09) to be greater compared with the CON diet, and was similar (P = 0.61) between the LU and CON diets. Carcass characteristics were similar (P ≥ 0.34) among treatments. In Exp. 2, 4 ruminally cannulated steers (347 ± 18 kg initial BW) were randomly assigned to a replicated 2 × 2 Latin square design. Steers were fed the same CON or HU diet used in Exp. 1 ad libitum once daily. Differences in the PDC index were used as indicators of differences in microbial CP synthesis. Ruminal pH, OM intake, and starch and CP digestibility were not affected by treatment (P ≥ 0.13). Digestibility of OM and NDF and

Incidence and distribution of filamentous fungi during fermentation, drying and storage of coffee (Coffea arabica L. beans Incidência e distribuição de fungos filamentosos durante a fermentação, secagem e armazenamento de frutos e grãos de café (Coffea arabica L.

Directory of Open Access Journals (Sweden)

Cristina Ferreira Silva

2008-09-01

Full Text Available The objective of this work was to isolate and characterize filamentous fungi present in different stages of harvest, fermentation, drying and storage of coffee beans processed by natural method. The cherries were hand-picked and then placed on a cement drying platform where they remained until reached 11% of humidity. Microbial counts were found in all samples during fermentation and drying of the coffee beans. Counts of fungi in the coffee cherries collected from the tree (time 0 were around 1.5 x 10³ CFU/g. This number increased slowly during the fermentation and drying reaching values of 2 x 10(5 CFU/g within 22 days of processing. Two hundred and sixty three isolates of filamentous fungi were identified. The distribution of species during fermentation and drying was very varied while there was a predominance of Aspergillus species during storage period. The genera found were Pestalotia (4, Paecelomyces (4, Cladosporium (26, Fusarium (34, Penicillium (81 and Aspergillus (112 and comprised 38 different species.O objetivo deste estudo foi isolar e caracterizar fungos filamentosos presentes em diferentes estágios de beneficiamento de café processado pelo método natural, incluindo: colheita, fermentação, secagem e armazenamento. O café cereja foi colhido manualmente e então colocado em uma plataforma de cimento, onde permaneceu até atingir 11% de umidade. A contagem microbiana foi realizada em todas as amostras durante a fermentação e secagem do café. A população de fungos filamentosos no café cereja ainda nos pés (tempo 0 foi em torno de 1,5 x 10³ UFC/g. Este número aumentou vagarosamente durante a fermentação e secagem, alcançando valores de 2 x 10(5 UFC/g em 22 dias do processamento. Duzentos e sessenta e três isolados de fungos filamentosos foram identificados. A distribuição das espécies durante fermentação e secagem foi bastante variada, mas no armazenamento dos grãos ocorreu o predomínio de espécies de

Sequential ethanol fermentation and anaerobic digestion increases bioenergy yields from duckweed.

Science.gov (United States)

Calicioglu, O; Brennan, R A

2018-06-01

The potential for improving bioenergy yields from duckweed, a fast-growing, simple, floating aquatic plant, was evaluated by subjecting the dried biomass directly to anaerobic digestion, or sequentially to ethanol fermentation and then anaerobic digestion, after evaporating ethanol from the fermentation broth. Bioethanol yields of 0.41 ± 0.03 g/g and 0.50 ± 0.01 g/g (glucose) were achieved for duckweed harvested from the Penn State Living-Filter (Lemna obscura) and Eco-Machine™ (Lemna minor/japonica and Wolffia columbiana), respectively. The highest biomethane yield, 390 ± 0.1 ml CH 4 /g volatile solids added, was achieved in a reactor containing fermented duckweed from the Living-Filter at a substrate-to-inoculum (S/I) ratio (i.e., duckweed to microorganism ratio) of 1.0. This value was 51.2% higher than the biomethane yield of a replicate reactor with raw (non-fermented) duckweed. The combined bioethanol-biomethane process yielded 70.4% more bioenergy from duckweed, than if anaerobic digestion had been run alone. Copyright © 2018 Elsevier Ltd. All rights reserved.

Determination of buffering capacity of selected fermented feedstuffs and the effect of dietary acid-base status on ruminal fluid pH

Directory of Open Access Journals (Sweden)

Lukáš Bujňák

2011-01-01

Full Text Available The aim of this study was to evaluate the buffering capacity of some fermented feedstuffs and the effect of dietary acid-base status on ruminal fluid pH. The first experiment was performed with different types (n = 24 of wet and dry fermented feedstuffs to determine the buffering capacity and buffer value index. The buffer value index of wet corn silages was more negative than for dry corn silages account on acid loss during drying. In the second experiment, the effects of different concentrations of lactic acid on base-buffering capacity, buffer value index and indicators of fermentation process were studied in two groups of corn silages (n = 21. Two groups of analyzed values were compared using unpaired t-test. Differences among the groups in base-buffering capacity (P P P > 0.05 correlation was found between ruminal pH and dietary buffer value index. These results confirmed that dietary acid-base status alone is not adequate as a predictor of the need for buffers in the diet of lactating cows. It is the first report about using of buffering capacity determination methods for evaluation of feedstuffs and dietary acid-base status in dairy cows.

Biofilm formation and ethanol inhibition by bacterial contaminants of biofuel fermentation.

Science.gov (United States)

Rich, Joseph O; Leathers, Timothy D; Bischoff, Kenneth M; Anderson, Amber M; Nunnally, Melinda S

2015-11-01

Bacterial contaminants can inhibit ethanol production in biofuel fermentations, and even result in stuck fermentations. Contaminants may persist in production facilities by forming recalcitrant biofilms. A two-year longitudinal study was conducted of bacterial contaminants from a Midwestern dry grind corn fuel ethanol facility. Among eight sites sampled in the facility, the combined liquefaction stream and yeast propagation tank were consistently contaminated, leading to contamination of early fermentation tanks. Among 768 contaminants isolated, 92% were identified as Lactobacillus sp., with the most abundant species being Lactobacillus plantarum, Lactobacillus casei, Lactobacillus mucosae, and Lactobacillus fermentum. Seven percent of total isolates showed the ability to form biofilms in pure cultures, and 22% showed the capacity to significantly inhibit ethanol production. However, these traits were not correlated. Ethanol inhibition appeared to be related to acetic acid production by contaminants, particularly by obligately heterofermentative species such as L. fermentum and L. mucosae. Published by Elsevier Ltd.

Potential of ensiling for efficient management of spent residue from solid state fermentation system

OpenAIRE

Roussos, Sevastianos; Raimbault, Maurice; Geoffroy, F.; Saucedo-Castaneda, G.; Lonsane, B.K.

1992-01-01

Studies on ensiling of spent solids from solid state fermentation process for production of cellulases by #Trichoderma harzianum$ showed that good quality ensiled solids can be obtained by using about 43% initial substrate dry matter with 0.3% ensiling additive. (Résumé d'auteur)

The extraction of anthocyanins and proanthocyanidins from grapes to wine during fermentative maceration is affected by the enological technique.

Science.gov (United States)

Busse-Valverde, Naiara; Gómez-Plaza, Encarna; López-Roca, Jose M; Gil-Muñoz, Rocio; Bautista-Ortín, Ana B

2011-05-25

The effect of three enological techniques (low temperature prefermentative maceration, must freezing with dry ice, and the use of a maceration enzyme) on the extraction of anthocyanins and proanthocyanidins from must to wine during fermentative maceration was studied to determine the extent to which these compounds are extracted and to assess the changes on their qualitative composition due to enological technique applied. The results showed that the dry ice treatment led to wines with high color intensity and high anthocyanin content, the maximum rate of extraction being observed the first 6 days of fermentative maceration. Regarding the effect of the different techniques on the quantitative and qualitative composition of proanthocyanidins, only the dry ice treatment seemed to favor the extraction of high molecular weight skin proanthocyanidins. The low temperature prefermentative maceration treatment led to the highest concentration of proanthocyanidins at the moment of pressing; however, this treatment, contrary to expectations, led to wines with the highest content of seed-derived proanthocyanidins. The use of the maceration enzyme also increased the concentration of proanthocyanidins during all of the fermentative process, as compared to a control wine, although the increase was not only due to skin proanthocyanidins but also seed proanthocyanidins. We have demonstrated in this study that maceration enzymes also facilitate seed phenolic extraction.

Improved fermentation performance to produce bioethanol from Gelidium amansii using Pichia stipitis adapted to galactose.

Science.gov (United States)

Sukwong, Pailin; Ra, Chae Hun; Sunwoo, In Yung; Tantratian, Sumate; Jeong, Gwi-Taek; Kim, Sung-Koo

2018-03-23

This study employed a statistical method to obtain optimal hyper thermal acid hydrolysis conditions using Gelidium amansii (red seaweed) as a source of biomass. The optimal hyper thermal acid hydrolysis using G. amansii as biomass was determined as 12% (w/v) slurry content, 358.3 mM H 2 SO 4 , and temperature of 142.6 °C for 11 min. After hyper thermal acid hydrolysis, enzymatic saccharification was carried out. The total monosaccharide concentration was 45.1 g/L, 72.2% of the theoretical value of the total fermentable monosaccharides of 62.4 g/L based on 120 g dry weight/L in the G. amansii slurry. To increase ethanol production, 3.8 g/L 5-hydroxymethylfurfural (HMF) in the hydrolysate was removed by treatment with 3.5% (w/v) activated carbon for 2 min and fermented with Pichia stipitis adapted to high galactose concentrations via separate hydrolysis and fermentation. With complete HMF removal and the use of P. stipitis adapted to high galactose concentrations, 22 g/L ethanol was produced (yield 0.50). Fermentation with total HMF removal and yeast adapted to high galactose concentrations increased the fermentation performance and decreased the fermentation time from 96 to 36 h compared to traditional fermentation.

Optimization of Fermentation Conditions for the Production of Bacteriocin Fermentate

Science.gov (United States)

2015-03-30

FERMENTATION CONDITIONS FOR THE PRODUCTION OF BACTERIOCIN “ FERMENTATE ” by Anthony Sikes Wayne Muller and Claire Lee March 2015...From - To) October 2010 – November 2013 4. TITLE AND SUBTITLE OPTIMIZATION OF FERMENTATION CONDITIONS FOR THE PRODUCTION OF BACTERIOCIN “ FERMENTATE ...nisin and pediocin. Whey + yeast extract was the best performing whey fermentation media. The nisin producer strain Lactococcus. lactis ssp. lactis was

Ethanol Production from Non-Food Tubers of Iles-iles (Amorphophallus campanulatus by Using Separated Hydrolysis and Fermentation

Directory of Open Access Journals (Sweden)

Kusmiyati Kusmiyati

2014-07-01

Full Text Available The decrease in production and the raise in needs have led to the rise in oil prices. This work investigated the possibility of Iles-iles (Amorphophallus campanulatus tuber flour, which is rich in carbohydrate con-tent, as a raw material to produce bioethanol. To obtain the maximum ethanol concentration, several parameters had been studied, such as: the concentration of α-amylase and β-amylase in liquefaction and sac-charification processes, respectively, the type of S. cerevisiae enzyme (pure, dry, wet and instant and weight of Diammonium phosphate (DAP as a nutrient for S. cerevisiae in fermentation. The result shows that the highest reducing sugar content (12.5% was achieved when 3.2 ml α-amylase/kg flour and 6.4 ml β-amylase/kg flour were used during liquefaction and saccharification processes. Since the concentration of α- and β-amylase increased, the reducing sugar obtained also increased. The higher sugar content resulted the higher the ethanol concentration in the fermentation broth. Furthermore, the highest concentration of ethanol (9 %v/v was obtained at 72 h fermentation using the dry S. cerevisiae, at 3.2 ml and 6.4 ml /kg flour of α-amylase and β-amylase enzymes, respectively. From the study of the effect of S. cerevisiae type, it was shown that dry S. cereviseae produced the highest ethanol concentration 10.2% (v/v at 72 h fermentation. The DAP was used as a nitrogen supply required by S. cerevisiae to growth and as a results can increase the ethanol concentration. The addition of DAP in the fermentation proved that 8.45% (v/v of ethanol was obtained. This result shows that the proposed tuber flour has the potential a raw material for bioethanol production. © 2014 BCREC UNDIP. All rights reservedReceived: 7th January 2014; Revised: 10th March 2014; Accepted: 18th March 2014[How to Cite: Kusmiyati, K. (2014. Ethanol Production from Non-Food Tubers of Iles-iles (Amorphophallus campanulatus by using Separated Hydrolysis and

Fermentative characteristics and nutritional value of elephant grass silage added with dehydrated banana peel

Directory of Open Access Journals (Sweden)

Lara Maria Santos Brant

2017-04-01

Full Text Available The aim of this study was to evaluate the fermentative losses and nutritional value of elephant grass silages with the increasing of inclusion levels of dehydrated banana peel. The experiment was conducted in a completely randomized design, with six treatments and four replications, being the silage exclusively from elephant grass, and five levels of inclusion of banana peel to the elephant grass silage, as the following - 5; 10; 15; 20 and 25%, being added based on natural matter. The addition of the banana peel in the silage reduced linearly (p < 0.05 the pH, the ammoniacal nitrogen and the losses of the fermentative process. In addition, the inclusion of banana peel increased linearly (p < 0.05 the dry matter and non-fibrous carbohydrates. On the other hand, the neutral detergent fiber and the acid detergent fiber were linearly reduced with the inclusion of the banana peel (p < 0.05, but there was no change in the dry matter digestibility in situ. The inclusion of dehydrated banana peel in elephant grass silage reduces the losses of the fermentation process with more consistent results at the 25% inclusion level, however, it reduces the silage nutritional value due to fibrous and protein quality.

Effect of yeast storage temperature and flour composition on fermentative activities of baker's yeast

Directory of Open Access Journals (Sweden)

Pejin Dušanka J.

2009-01-01

Full Text Available Baker's yeast is a set of living cells of Saccharomyces cerevisiae. It contains around 70-72% of water, 42-45% of proteins, around 40% of carbohydrates, around 7.5% of lipids (based on dry matter, and vitamin B-complex. On the basis of yeast cell analysis it can be concluded that yeast is a complex biological system which changes in time. The intensity of the changes depends on temperature. Yeast sample was stored at 4°C i 24°C for 12 days. During storage at 4°C, the content of total carbohydrates decreased from 48.81% to 37.50% (dry matter, whereas carbohydrate loss ranged from 40.81% to 29.28% at 24°C. The content of trehalose was 12.33% in the yeast sample stored at 4°C and 0.24% at 24°C. Loss of fermentative activity was 81.76% in the sample stored at 24°C for 12 days. The composition of five samples of 1st category flour was investigated. It was found that flours containing more reducing sugars and maltose enable higher fermentation activities. The flours with higher ash content (in the range 0.5-0.94% had higher contents of phytic acid. Higher ash and phytic contents in flour increased the yeast fermentative efficiency. In bakery industry, a range of ingredients has been applied to improve the product's quality such as surface active substances (emulsifiers, enzymes, sugars and fats. In the paper, the effect of some ingredients added to dough (margarine, saccharose, sodium chloride and malted barley on the yeast fermentative activity was studied. The mentioned ingredients were added to dough at different doses: 0.5, 1.0, 1.5 and 2.0%, flour basis. It was found that the investigated ingredients affected the fermentative activity of yeast and improved the bread quality.

Nutritive value and fermentation characteristics of alfalfa-mixed grass forage wrapped with minimal stretch film layers and stored for different lengths of time.

Science.gov (United States)

Coblentz, W K; Ogden, R K; Akins, M S; Chow, E A

2017-07-01

A key aspect of managing baled silages is to quickly achieve and then rigorously maintain anaerobic conditions within the silage mass. The concept of inserting an O 2 -limiting barrier (OB) into plastic commercial silage wraps has been evaluated previously, yielding mixed or inconclusive results. Our objective for this study was to maximize the challenge to a commercial polyethylene bale wrap, or the identical wrap containing an OB, by using minimal plastic (4 layers), and then extending storage periods as long as 357 d. Forty-eight 1.2 × 1.2-m large-round bales of alfalfa (Medicago sativa L.) and mixed grass forage (66.3 ± 8.66% alfalfa; DM basis) were made at 2 moisture concentrations [47.5 (ideal) or 36.1% (dry)], wrapped with 4 layers of plastic containing an OB or no OB, and then stored for 99, 243, or 357 d. After storage, yeast counts within the 0.15-m deep surface layer were not affected by treatment (mean = 5.85 log 10 cfu/g); mold counts could not be analyzed statistically because 26 bales were nondetectable at a 3.00 log 10 cfu/g detection limit, but means among detectable counts were numerically similar for OB (4.74 log 10 cfu/g) and no OB (4.77 log 10 cfu/g). Fermentation characteristics were most affected by initial bale moisture, resulting in a more acidic final pH for ideal compared with dry bales (5.52 vs. 6.00). This was facilitated by greater concentrations of total fermentation acids (3.80 vs. 1.45% of dry matter), lactic acid (2.24 vs. 0.71% of dry matter), and acetic acid (1.07 vs. 0.64% of dry matter) within ideal compared with dry silages. Plastic wrap type had no effect on final concentrations of any fermentation product. During fermentation and storage, we noted greater change in concentrations of fiber components and whole-plant ash within the 0.15-m deep surface layer than in the bale core, and these changes always differed statistically from 0 (no change) based on pre-ensiled baseline concentrations. Overall, concentrations of water

Heat-treatment, phytase and fermented liquid feeding affect the presence of inositol phosphates in ileal digesta and phosphorus digestibility in pigs fed a wheat and barley diet

DEFF Research Database (Denmark)

Blaabjerg, Karoline; Jørgensen, H.; Tauson, Anne-Helene

2010-01-01

The aim was to evaluate the effect of heat-treatment, microbial phytase addition and feeding strategy (dry feeding v. fermented liquid feeding) on degradation of phytate (myo-inositol hexakisphosphate, InsP6) and formation and further degradation of lower inositol phosphates (myo-inositol pentaki......The aim was to evaluate the effect of heat-treatment, microbial phytase addition and feeding strategy (dry feeding v. fermented liquid feeding) on degradation of phytate (myo-inositol hexakisphosphate, InsP6) and formation and further degradation of lower inositol phosphates (myo...... × 4 Latin square with four pigs fed four diets. A basal wheat/barley-based diet was fed either as non-heat-treated or heat-treated (steam-pelleted at 90°C). The heat-treatment resulted in an inactivation of plant phytase below detectable level. Diet 1 (non-heat-treated basal diet fed dry); diet 2...... (heat-treated basal diet fed dry); diet 3 (as diet 2 but with microbial phytase (750 FTU/kg as fed) fed dry); diet 4 (as diet 3 fed liquid (fermented for 17.5 h nighttime and 6.5 h daytime at 20°C with 50% residue in the tank)). Chromic oxide (Cr2O3) was included as marker and ATTD was determined both...

Biogenic amine profile in unripe Arabica coffee beans processed according to dry and wet methods.

Science.gov (United States)

Dias, Eduardo C; Pereira, Rosemary G F A; Borém, Flávio M; Mendes, Eulália; de Lima, Renato R; Fernandes, José O; Casal, Susana

2012-04-25

Immature coffee fruit processing contributes to a high amount of defective beans, which determines a significant amount of low-quality coffee sold in the Brazilian internal market. Unripe bean processing was tested, taking the levels of bioactive amines as criteria for evaluating the extent of fermentation and establishing the differences between processing methods. The beans were processed by the dry method after being mechanically depulped immediately after harvest or after a 12 h resting period in a dry pile or immersed in water. Seven bioactive amines were quantified: putrescine, spermine, spermidine, serotonin, cadaverine, histamine, and tyramine, with global amounts ranging from 71.8 to 80.3 mg/kg. The levels of spermine and spermidine were lower in the unripe depulped coffee than in the natural coffee. The specific conditions of dry and wet processing also influenced cadaverine levels, and histamine was reduced in unripe depulped coffee. A resting period of 12 h does not induce significant alteration on the beans and can be improved if performed in water. These results confirm that peeling immature coffee can decrease fermentation processes while providing more uniform drying, thus reducing the number of defects and potentially increasing beverage quality.

Effects of forage maize type and maturity stage on in vitro rumen fermentation characteristics.

NARCIS (Netherlands)

Cone, J.W.; Gelder, van A.H.; Schooten, van H.A.

2008-01-01

An experiment with forage maize plants representing early and late-ripening types of Dry Down and Stay Green cultivar types was conducted to study the effects of cultivar and maturity stage on in vitro rumen fermentation characteristics and to investigate the validity of the generally supposed

Electro-Fermentation - Merging Electrochemistry with Fermentation in Industrial Applications.

Science.gov (United States)

Schievano, Andrea; Pepé Sciarria, Tommy; Vanbroekhoven, Karolien; De Wever, Heleen; Puig, Sebastià; Andersen, Stephen J; Rabaey, Korneel; Pant, Deepak

2016-11-01

Electro-fermentation (EF) merges traditional industrial fermentation with electrochemistry. An imposed electrical field influences the fermentation environment and microbial metabolism in either a reductive or oxidative manner. The benefit of this approach is to produce target biochemicals with improved selectivity, increase carbon efficiency, limit the use of additives for redox balance or pH control, enhance microbial growth, or in some cases enhance product recovery. We discuss the principles of electrically driven fermentations and how EF can be used to steer both pure culture and microbiota-based fermentations. An overview is given on which advantages EF may bring to both existing and innovative industrial fermentation processes, and which doors might be opened in waste biomass utilization towards added-value biorefineries. Copyright © 2016 Elsevier Ltd. All rights reserved.

Antihypertensive activity of blueberries fermented by Lactobacillus plantarum DSM 15313 and effects on the gut microbiota in healthy rats.

Science.gov (United States)

Ahrén, Irini Lazou; Xu, Jie; Önning, Gunilla; Olsson, Crister; Ahrné, Siv; Molin, Göran

2015-08-01

The aim of the present animal study was to examine the anti-hypertensive capacity of two probiotic products combining blueberries and the tannase producing probiotic bacteria Lactobacillus plantarum DSM 15313 and to investigate if such an effect is linked to a change in the gut microbiota. Male Sprague Dawley rats were randomly divided into six groups of nine each. Three groups of the animals were treated with N(G)-nitro-L-arginine methyl ester (L-NAME) in the drinking water (40 mg/L) to induce a hypertensive state, and the other three groups were not treated with L-NAME (healthy rats). Two blueberry products differing in their phenolic acid content were tested and each rat received 2 g/day of the fermented blueberry powders for 4 weeks. The effects of the study products on the blood pressure, blood lipids, inflammatory markers, organ weights as well as caecal microbiota of the healthy (non-L-NAME-treated) rats were analyzed. After four weeks, healthy rats consuming freeze dried fermented blueberries with probiotics had a significant reduction in blood pressure compared to the control rats. In rats with L-NAME induced hypertension there was a significant reduction of the blood pressure after two weeks treatment. The probiotic product with a higher content of phenolic acids reduced ALAT in the healthy rats. Furthermore, ingestion of the probiotic blueberry products resulted in changes of the gut microbiota in the healthy rats. Blueberries fermented with the tannase producing bacteria L. plantarum DSM 15313 have anti-hypertensive properties and may reduce the risk for cardiovascular diseases. Copyright © 2014 Elsevier Ltd and European Society for Clinical Nutrition and Metabolism. All rights reserved.

Enzymatic saccharification of brown seaweed for production of fermentable sugars.

Science.gov (United States)

Sharma, Sandeep; Horn, Svein Jarle

2016-08-01

This study shows that high drying temperatures negatively affect the enzymatic saccharification yield of the brown seaweed Saccharina latissima. The optimal drying temperature of the seaweed in terms of enzymatic sugar release was found to be 30°C. The enzymatic saccharification process was optimized by investigating factors such as kinetics of sugar release, enzyme dose, solid loading and different blend ratios of cellulases and an alginate lyase. It was found that the seaweed biomass could be efficiently hydrolysed to fermentable sugars using a commercial cellulase cocktail. The inclusion of a mono-component alginate lyase was shown to improve the performance of the enzyme blend, in particular at high solid loadings. At 25% dry matter loading a combined glucose and mannitol concentration of 74g/L was achieved. Copyright © 2016 Elsevier Ltd. All rights reserved.

Controlling alchohol fermentations

Energy Technology Data Exchange (ETDEWEB)

Leedham, P A; Tubb, R S

1983-09-21

In the initial stages of a fermentation of carbohydrate to EtOH, the growth of the yeast is controlled by monitoring the pH of a fermenting liquid or wort and controlling the supply of O/sub 2/ in accordance with the pH. The temperature of the fermenting liquid is also controlled in dependence upon the pH. The control of the fermentation process is carried out automatically by an apparatus including a fermentation vessel, a pH sensor arranged to provide an output signal representative of the pH of the liquid in the vessel, memory means to store information on the required pH with regard to the fermentation time, means to inject O/sub 2/ into the fermenting liquid and control means to compare the output signal of the pH sensor at a particular time with that of the required pH at that time, and in the event of the pH of the fermenting liquid lagging behind that required, actuate the means to inject O/sub 2/ into the fermenting liquid to increase the O/sub 2/ content of the fermenting liquid.

Acetone-butyl alcohol fermentation of the cornstalk hydrolyzates prepared by the method of Riga

Energy Technology Data Exchange (ETDEWEB)

Nakhmanovich, N A; Shcheblykina, N A; Kalnina, V; Pelsis, D

1960-01-01

The possibility of use of waste instead of food products in the acetone-butyl alcohol fermentation was investigated. Crushed cornstalks hydrolyzed by the method of Riga were inverted at varying conditions. The hydrolyzate containing about 50% of reducing substances (RS), based on dry weight of cornstalks, was neutralized to pH 6.3-6.5, diluted with water to the final concentration 5.0-5.1% of RS filtered, and the filtrate sterilized. The resulting liquor (I) was mixed with the wheat meal mash containing 5% of sugar (starch calculated as glucose) and fermented. The utilization of I depended upon the regime of inversion; the optimal being 20 minutes at 115/sup 0/, hydrocoefficient 1:4. In this case the use of 40% of mash sugar in form of I did not impair the yield of fermentation. The use of corn instead of wheat meal decreased the yield of butanol and increased that of ethanol. The fermentation of the mixture of I (final concentration 3% RS) and corn gluten (final concentration 2%), mineral salts added, gave higher yields than did the fermentation of the wheat meal mash.

Value Added Products from Hemicellulose Utilization in Dry Mill Ethanol Plants

Energy Technology Data Exchange (ETDEWEB)

Rodney Williamson, ICPB; John Magnuson, PNNL; David Reed, INL; Marco Baez, Dyadic; Marion Bradford, ICPB

2007-03-30

The Iowa Corn Promotion Board is the principal contracting entity for this grant funded by the US Department of Agriculture and managed by the US Department of Energy. The Iowa Corn Promotion Board subcontracted with New Jersey Institute of Technology, KiwiChem, Pacific Northwest National Lab and Idaho National Lab to conduct research for this project. KiwiChem conducted the economic engineering assessment of a dry-mill ethanol plant. New Jersey Institute of Technology conducted work on incorporating the organic acids into polymers. Pacific Northwest National Lab conducted work in hydrolysis of hemicellulose, fermentation and chemical catalysis of sugars to value-added chemicals. Idaho National Lab engineered an organism to ferment a specific organic acid. Dyadic, an enzme company, was a collaborator which provided in-kind support for the project. The Iowa Corn Promotion Board collaborated with the Ohio Corn Marketing Board and the Minnesota Corn Merchandising Council in providing cost share for the project. The purpose of this diverse collaboration was to integrate the hydrolysis, the conversion and the polymer applications into one project and increase the likelihood of success. This project had two primary goals: (1) to hydrolyze the hemicellulose fraction of the distillers grain (DG) coproduct coming from the dry-mill ethanol plants and (2) convert the sugars derived from the hemicellulose into value-added co-products via fermentation and chemical catalysis.

[Physiological response to acetic acid stress of Acetobacter pasteuranus during vinegar fermentation].

Science.gov (United States)

Qi, Zhengliang; Yang, Hailin; Xia, Xiaole; Wang, Wu; Leng, Yunwei; Yu, Xiaobin; Quan, Wu

2014-03-04

The aim of the study is to propose a dynamic acetic acid resistance mechanism through analysis on response of cellular morphology, physiology and metabolism of A. pasteurianus CICIM B7003 during vinegar fermentation. Vinegar fermentation was carried out in a Frings 9 L acetator by strain B7003 and cultures were sampled at different cellular growth phases. Simultaneously, percentage of capsular polysaccharide versus dry cells weight, ratio of unsaturated fatty acids to saturated fatty acids, transcription of acetic acid resistance genes, activity of alcohol respiratory chain enzymes and ATPase were detected for these samples to assay the responses of bacterial morphology, physiology and metabolism. When acetic acid was existed, no obvious capsular polysaccharide was secreted by cells. As vinegar fermentation proceeding, percentage of capsular polysaccharide versus dry cells weight was reduced from 2.5% to 0.89%. Ratio of unsaturated fatty acids to saturated fatty acids was increased obviously which can improve membrane fluidity. Also transcription level of acetic acid resistance genes was promoted. Interestingly, activity of alcohol respiratory chain and ATPase was not inhibited but promoted obviously with acetic acid accumulation which could provide enough energy for acetic acid resistance mechanism. On the basis of the results obtained from the experiment, A. pasteurianus CICIM B7003 relies mainly on the cooperation of changes of extracellular capsular polysaccharide and membrane fatty acids, activation of acid resistance genes transcription, enhancement of activity of alcohol respiratory chain and rapid energy production to tolerate acidic environment.

Continuous high-solids corn liquefaction and fermentation with stripping of ethanol.

Science.gov (United States)

Taylor, Frank; Marquez, Marco A; Johnston, David B; Goldberg, Neil M; Hicks, Kevin B

2010-06-01

Removal of ethanol from the fermentor during fermentation can increase productivity and reduce the costs for dewatering the product and coproduct. One approach is to recycle the fermentor contents through a stripping column, where a non-condensable gas removes ethanol to a condenser. Previous research showed that this approach is feasible. Savings of $0.03 per gallon were predicted at 34% corn dry solids. Greater savings were predicted at higher concentration. Now the feasibility has been demonstrated at over 40% corn dry solids, using a continuous corn liquefaction system. A pilot plant, that continuously fed corn meal at more than one bushel (25 kg) per day, was operated for 60 consecutive days, continuously converting 95% of starch and producing 88% of the maximum theoretical yield of ethanol. A computer simulation was used to analyze the results. The fermentation and stripping systems were not significantly affected when the CO(2) stripping gas was partially replaced by nitrogen or air, potentially lowering costs associated with the gas recycle loop. It was concluded that previous estimates of potential cost savings are still valid. (c) 2010. Published by Elsevier Ltd. All rights reserved.

Effect of fermented feed on the microbial population of the gastrointestinal tracts of pigs

NARCIS (Netherlands)

Winsen, van R.L.; Urlings, B.A.P.; Lipman, L.J.A.; Snijders, J.M.A.; Keuzenkamp, D.; Verheijden, J.H.M.; Knapen, van F.

2001-01-01

An in vivo experiment was performed with pigs to study the inhibitory effect of fermented feed on the bacterial population of the gastrointestinal tract. Results demonstrated a significant positive correlation between pH and lactobacilli in the stomach contents of pigs in dry feed as well as in the

Enhanced amylase production by fusarium solani in solid state fermentation

International Nuclear Information System (INIS)

Bakri, Y.; Jawhar, M.; Arabi, M.I.E.

2014-01-01

The present study illustrates the investigation carried out on the production of amylase by Fusarium species under solid state fermentation. All the tested Fusarium species were capable of producing amylase. A selected F. solani isolate SY7, showed the highest amylase production in solid state fermentation. Different substrates were screened for enzyme production. Among the several agronomic wastes, wheat bran supported the highest yield of amylase (141.18 U/g of dry substrate) after 3 days of incubation. Optimisation of the physical parameters revealed the optimum pH, temperature and moisture level for amylase production by the isolate as 8.0, 25 C and 70%, respectively. The above results indicate that the production of amylase by F. solani isolate SY7 could be improved by a further optimisation of the medium and culture conditions. (author)

Combined moist airtight storage and feed fermentation of barley by the yeast Wickerhamomyces anomalus and a lactic acid bacteria consortium

Directory of Open Access Journals (Sweden)

Jenny eBorling Welin

2015-04-01

Full Text Available This study combined moist airtight storage of moist grain with pig feed fermentation. Starter cultures with the potential to facilitate both technologies were added to airtight stored moist crimped cereal grain, and the impact on storage microflora and the quality of feed fermentations generated from the grain was investigated. Four treatments were compared: three based on moist barley, either un inoculated (M, inoculated with Wickerhamomyces anomalus (W, or inoculated with W. anomalus and LAB starter culture, containing Pediococcus acidilactici DSM 16243, Pediococcus pentosaceus DSM 12834 and Lactobacillus plantarum DSM 12837 (WLAB; and one treatment based on dried barley (D. After 6 weeks of storage, four feed fermentations FM, FW, FWLAB, and FD, were initiated from M, W, WLAB and D, respectively, by mixing the grain with water to a dry matter content of 30%. Each treatment was fermented in batch initially for 7 days and then kept in a continuous mode by adding new feed daily with 50% back-slop. During the 6 week storage period, the average water activity decreased in M, W and WLAB from 0.96 to 0.85, and cereal pH decreased from approximately 6.0 at harvest to 4.5. Feed fermentation conferred a further pH decrease to 3.8 – 4.1. In M, W and WLAB, moulds and Enterobacteriaceae were mostly below detection limit, whereas both organism groups were detected in D. In fermented feed, Enterobacteriaceae were below detection limit in almost all conditions. Moulds were detected in FD, for most of the fermentation time in FM and at some sampling points in FW and FWLAB. Starter organisms, especially W. anomalus and L. plantarum comprised a considerable proportion of the yeast and LAB populations, respectively, in both stored grain and fermented feed. However, autochthonous Pichia kudriavzevii and Kazachstania exigua partially dominated the yeast populations in stored grain and fermented feed, respectively.

IN VITRO FERMENTATION EFFICIENCY OF MIXTURES OF Cynodon nlemfuensis, Leucaena leucocephala AND TWO ENERGY SOURCES (MAIZE OR SUGAR CANE MOLASSES

Directory of Open Access Journals (Sweden)

Juan Martin Estrada-Liévano

2009-07-01

Full Text Available The in vitro fermentation efficiency of Cynodon nlemfuensis forage (star grass and Leucaena leucocephala foliage (leucaena and two energy sources (i.e. maize and sugar cane molasses mixture was evaluated. Mixture samples (1 g DM were incubated for 24 h. All the mixtures were added with 500 mg of polyetilenglycol (PEG. Adding molasses to star grass increased dry matter true digestibility and carbohydrate fermentation (P

Comparison of in situ dry matter degradation parameters with in vitro ...

African Journals Online (AJOL)

Adem Kamalak

The rate and extent of fermentation of dry matter (DM) in the rumen are very important determinants ... kinetics of forages obtained by the in situ nylon bag technique and the in vitro gas production technique. (Blummel & Ørskov ..... not find any correlation between these parameters in barley and wheat straw. Beuvinik et al.

Effects of dietary fermented spent coffee ground on nutrient digestibility and nitrogen utilization in sheep.

Science.gov (United States)

Choi, Yongjun; Rim, Jong-Su; Na, Youngjun; Lee, Sang Rak

2018-03-01

The objective of the study was to determine the effect of fermented spent coffee ground (FSCG) on nutrient digestibility and nitrogen utilization in sheep. Fermentation of spent coffee ground (SCG) was conducted using Lactobacillus plantrum . Fermentation was performed at moisture content of 70% and temperature of 39°C with anaerobic air tension for 48 h. Four adult rams (initial body weight = 56.8±0.4 kg) were housed in a respiration-metabolism chamber and the treatments were: i) control (Basal diet; 0% SCG or FSCG), ii) 10% level of SCG, iii) 10% level of FSCG, and iv) 20% level of FSCG in 4×4 Latin square design. Each dietary experiment period lasted for 18-d with a 14-d of adaptation period and a 4-d of sample collection period. In SCG fermentation experimental result, acid detergent insoluble nitrogen (ADIN) concentration of FSCG (64.5% of total N) was lower than that of non-fermented SCG (78.8% of total N). Digestibility of dry matter and organic matter was similar among treatment groups. Although crude protein (CP) digestibility of the control was greater than FSCG groups (pdigestibility and nitrogen retention than non-fermented 10% SCG group (pdigestibility, thereby increasing CP digestibility and nitrogen utilization in sheep. Fermentation using microorganisms in feed ingredients with low digestibility could have a positive effect on improving the quality of raw feed.

Ethanol Production by Soy Fiber Treatment and Simultaneous Saccharification and Co-Fermentation in an Integrated Corn-Soy Biorefinery

Directory of Open Access Journals (Sweden)

Jasreen K. Sekhon

2018-05-01

Full Text Available Insoluble fiber (IF recovered from the enzyme-assisted aqueous extraction process (EAEP of soybeans is a fraction rich in carbohydrates and proteins. It can be used to enhance ethanol production in an integrated corn-soy biorefinery, which combines EAEP with traditional corn-based ethanol processing. The present study evaluated IF as a substrate for ethanol production. The effects of treatment of IF (soaking in aqueous ammonia (SAA, liquid hot water (LHW, and enzymatic hydrolysis, primarily simultaneous saccharification and co-fermentation (SSCF, as well as scaling up (250 mL to 60 L on ethanol production from IF alone or a corn and IF slurry were investigated. Enzymatic hydrolysis (pectinase, cellulase, and xylanase, each added at 5% soy solids during simultaneous saccharification and fermentation/SSCF was the best treatment to maximize ethanol production from IF. Ethanol yield almost doubled when SSCF of IF was performed with Saccharomyces cerevisiae and Escherichia coli KO11. Addition of IF in dry-grind corn fermentation increased the ethanol production rate (~31%, but low ethanol tolerance of E. coli KO11 was a limiting factor for employing SSCF in combination corn and IF fermentation. Nonlinear Monod modeling accurately predicted the effect of ethanol concentration on E. coli KO11 growth kinetics by Hanes-Woolf linearization. Collectively, the results from this study suggest a potential of IF as a substrate, alone or in dry-grind corn fermentation, where it enhances the ethanol production rate. IF can be incorporated in the current bioethanol industry with no added capital investment, except enzymes.

Production of fermentables and biomass by six temperate fuelcrops

Energy Technology Data Exchange (ETDEWEB)

Parrish, D.J.; Gammon, T.C.; Graves, B.

1985-12-01

Several potential fuelcrops have been studied individually, but relatively little work has been done to compare the various temperate species in side-by-side trials. The production has been examined of readily fermentable carbohydrates and biomass by six fuelcrop candidates: grain sorghum (Sorghum bicolor), Jerusalem articoke (Helianthus tuberosus), maize (Zea Mays), sugarbeet (Beta vulgaris), sweet potato (Ipomoea batatas) and sweet sorghum (Sorghum bicolor). A randomized complete block design with four replicates was employed at each of three locations that were somewhat diverse in soil type, elevation, growing season length, and 1980 rainfall distribution. Fermentables in the harvestable dry matter were determined colorimetrically following dilute acid plus enzymatic hydrolysis. Overall, sugarbeet was the most prolific producer of fermentables (7.4 Mg/ha); Jerusalem artichoke (5.8 Mg/ha), maize (4.8 Mg/ha) and sweet sorghum stems (5.8 Mg/ha) were statistically equivalent, while sweet potato (4.0 Mg/ha) and grain sorghum (3.8 Mg/ha) were less productive than the other candidates. The crops performed somewhat differently at each location, but the most striking site-specific differences were seen at the site with the coarsest textured soil and driest season. At that location, maize produced the least fermentables (0.6 Mg/ha). Biomass production generally reflected either the amount of time each species was actively growing or limiations to growth associated with drought. No general recommendations are made concerning a preferred temperature fuelcrop. Based on the studies, however, maize may not always be the fuelcrop of choice; others, especially sugarbeet and sweet sorghum (when harvested for grain also), may be superior to maize in productivity of fermentable substrates. 6 tabs., 13 refs.

Characterisation of the gastrointestinal bacterial community in pigs fed fermented liquid feed and dry feed

DEFF Research Database (Denmark)

Højberg, Ole; Knudsen, B.; Canibe, N.

2001-01-01

Feeding pigs with fermented liquid feed (FLF) has been shown to reduce the number of enteropathogens such as Salmonella and Brachyospira hyodysenteriae as well as coliform bacteria in general in the gastrointestinal tract (GIT). Also the commensal bacterial populations have been shown to respond...

Development of a Solid-State Fermentation System for Producing Bioethanol from Food Waste

Science.gov (United States)

Honda, Hiroaki; Ohnishi, Akihiro; Fujimoto, Naoshi; Suzuki, Masaharu

Liquid fermentation is the a conventional method of producing bioethanol. However, this method results in the formation of high concentrations waste after distillation and futher treatment requires more energy and is costly(large amounts of costly energy).Saccharification of dried raw garbage was tested for 12 types of Koji starters under the following optimum culture conditions: temperature of 30°C and initial moisture content of 50%.Among all the types, Aspergillus oryzae KBN650 had the highest saccharifying power. The ethanol-producing ability of the raw garbage was investigated for 72 strains of yeast, of which Saccharomyces cerevisiae A30 had the highest ethanol production(yield)under the following optimum conditions: 1 :1 ratio of dried garbage and saccharified garbage by weight, and initial moisture content of 60%. Thus, the solid-state fermentation system consisted of the following 4 processes: moisture control, saccharification, ethanol production and distillation. This system produced 0.6kg of ethanol from 9.6kg of garbage. Moreover the ethanol yield from all sugars was calculated to be 0.37.

High-efficiency removal of phytic acid in soy meal using two-stage temperature-induced Aspergillus oryzae solid-state fermentation.

Science.gov (United States)

Chen, Liyan; Vadlani, Praveen V; Madl, Ronald L

2014-01-15

Phytic acid of soy meal (SM) could influence protein and important mineral digestion of monogastric animals. Aspergillus oryzae (ATCC 9362) solid-state fermentation was applied to degrade phytic acid in SM. Two-stage temperature fermentation protocol was investigated to increase the degradation rate. The first stage was to maximize phytase production and the second stage was to realize the maximum enzymatic degradation. In the first stage, a combination of 41% moisture, a temperature of 37 °C and inoculum size of 1.7 mL in 5 g substrate (dry matter basis) favored maximum phytase production, yielding phytase activity of 58.7 U, optimized via central composite design. By the end of second-stage fermentation, 57% phytic acid was degraded from SM fermented at 50 °C, compared with 39% of that fermented at 37 °C. The nutritional profile of fermented SM was also studied. Oligosaccharides were totally removed after fermentation and 67% of total non-reducing polysaccharides were decreased. Protein content increased by 9.5%. Two-stage temperature protocol achieved better phytic acid degradation during A. oryzae solid state fermentation. The fermented SM has lower antinutritional factors (phytic acid, oligosaccharides and non-reducing polysaccharides) and higher nutritional value for animal feed. © 2013 Society of Chemical Industry.

Physicochemical Properties and Sensory Evaluation of Reduced Fat Fermented Functional Beef Sausage

Directory of Open Access Journals (Sweden)

Faleeha Hasan Hussein

2017-04-01

Full Text Available Background and Objective: Semi-dry fermented sausages were manufactured from beef meat in three types: without starter culture (control, inoculated with Lactobacillus casei and inoculated with Lactobacillus paracasei. Probiotic fermented sausages are safe and healthy meat products, which receive high commercial interest and growing market shares.Material and Methods: The physico–chemical characteristics (Protein, Moisture, Fat, Ash, Lactic acid value and pH, microbiological features (total aerobic, total mold and yeast andlactic acid bacteria count and sensory evaluation (color, flavor, texture and overall acceptability were analyzed after 0, 10, 20, 30, 40 and 45 days of refrigerated storage at 4°C.Results and Conclusion: There was a significant difference (p≤0.05 in moisture content, which decreased in all samples during the period of refrigerated storage. However, all other parameters such as protein, fat and ash increased. The lactic acid produced during the fermentation by lactic acid bacteria resulted in a decrease in the pH value of all samples, and improved sensory evaluation of the fermented sausage inoculated with Lactobacillus casei and Lactobacillus paracasei during the storage period. The best results were obtained in the fermented sausage inoculated with Lactobacillus paracasei in physico-chemical, microbial and sensory characteristics. Also we could preserve the product at 4°C for 45 days.Conflict of interest: The authors declare that there is no conflict of interest.

Characterization of fermented black soybean natto inoculated with Bacillus natto during fermentation.

Science.gov (United States)

Hu, Yongjin; Ge, Changrong; Yuan, Wei; Zhu, Renjun; Zhang, Wujiu; Du, Lijuan; Xue, Jie

2010-05-01

To make nutrients more accessible and further increase biological activity, cooked black soybeans were inoculated with Bacillus natto and fermented at 37 degrees C for 48 h. The changes in physiochemical properties of fermented black soybean natto were investigated. The inoculation procedure significantly increased moisture, viscosity, color, polyphenol compounds and anthocyanin, and significantly decreased hardness after 48 h fermentation. Fibrinolytic and caseinolytic protease, beta-glucosidase activities, TCA-soluble nitrogen, and ammonia nitrogen contents in the inoculated samples significantly increased as fermentation time increased. Genistin and daidzin concentrations gradually decreased with increased fermentation time. However, genistein and daidzein increased with fermentation time, which reached 316.8 and 305.2 microg g(-1) during 48 h fermentation, respectively. DPPH radical scavenging activities of the fermented black soybeans increased linearly with fermentation time and concentration. Compared with the soaked black soybeans and cooked black soybeans, the fermented black soybeans with B. natto resulted in higher scavenging activity towards DPPH radicals, which correlated well with the content of total phenols (r = 0.9254, P natto fermented by B. natto has the potential to become a functional food because of its high antioxidant activity.

Effects of restriction of silage fermentation with formic acid on milk production

Directory of Open Access Journals (Sweden)

S. JAAKKOLA

2008-12-01

Full Text Available The study was conducted to evaluate the effects of silage fermentation quality and type of supplementation on milk production. Thirty two Finnish Ayrshire dairy cows were used in a cyclic change-over experiment with four 21-day experimental periods and 4 × 2 × 2 factorial arrangement of treatments. Silage fermentation was modified with formic acid (FA, which was applied at the rates equivalent to 0 (FA0, 2 (FA2, 4 (FA4 or 6 (FA6 litres t-1 grass of pure formic acid (as 100% FA. Dietary treatments consisted of four silages, a protein supplementation (no supplement or rapeseed meal 1.8 kg d-1 and a glucogenic substrate (no supplement or propylene glycol 225 g d-1. Increasing the application rate of FA restricted silage fermentation curvilinearly, as evidenced by higher concentrations of ammonia N and butyric acid in FA4 than FA2 silage. Similarly the use of FA resulted in curvilinear changes in the silage dry matter intake and milk yield. The highest milk and protein yields were achieved with FA6, while the milk yield with FA2 was higher than with FA4. Interactions were observed between silage type and supplementation. Rapeseed meal increased milk yield irrespective of the extent of silage fermentation, but the magnitude of response was variable. Propylene glycol was most beneficial with restrictively fermented silages FA4 and FA6. In conclusion, restriction of silage fermentation with a high rate of formic acid is beneficial in milk production. Interactions between silage composition and concentrate types suggest that the responses to supplementary feeding depend on silage fermentation characteristics.;

Physicochemical Characteristics, in Vitro Fermentation Indicators, Gas Production Kinetics, and Degradability of Solid Herbal Waste as Alternative Feed Source for Ruminants

Directory of Open Access Journals (Sweden)

A. N. Kisworo

2017-08-01

Full Text Available The aims of this research were to study the nutrient and secondary metabolite contents of solid herbal wastes (SHW that were preserved by freeze drying, sun drying and silage, as well as to analyze their effects on in vitro fermentation indicators i.e., gas production kinetics and degradability of solid herbal waste. Physical and chemical properties on three forms of SHW (sun dry, freeze dry, and silage were characterized and then an in vitro gas production experiment was performed to determine the kinetics of gas production, methane production, NH3, microbial protein, and SHW degradability. Polyethylene glycol (PEG was added to the three treatments to determine the biological activity of tannins. Results showed that all three preparations of SHW still contained high nutrient and plant secondary metabolite contents. Gas production, methane, NH3, microbial protein, in vitro degradability of dry matter (IVDMD and organic matter (IVDOM of SHW silage were lower (P<0.05 compared to sun dry and freeze dry. These results were apparently due to the high content of secondary metabolites especially tannin. It can be concluded that solid herbal wastes (SHW can be used as an alternative feed ingredients for ruminants with attention to the content of secondary metabolites that can affect the process of fermentation and digestibility in the rumen.

Characterization of probiotic Lactobacillus spp. isolates from commercial fermented milks

OpenAIRE

Farahmand, Nasim

2015-01-01

The aim of this project was to study the identity of probiotic lactobacilli in fermented milk products from the United Kingdom/European markets during their survival during shelf-life. This in vitro study was also aimed at undertaking studies on some of the physiological probiotic criteria, such as resistance to stomach/intestine conditions and also possible functional properties of the isolates, such as antimicrobial activities, antibiotic resistance/susceptibility and antibiotic resistance ...

An ethnobotanical perspective on traditional fermented plant foods and beverages in Eastern Europe.

Science.gov (United States)

Sõukand, Renata; Pieroni, Andrea; Biró, Marianna; Dénes, Andrea; Dogan, Yunus; Hajdari, Avni; Kalle, Raivo; Reade, Benedict; Mustafa, Behxhet; Nedelcheva, Anely; Quave, Cassandra L; Łuczaj, Łukasz

2015-07-21

Fermented food and beverages represent an important part of the worldwide foodscape, medicinal food domain and domestic strategies of health care, yet relevant traditional knowledge in Europe is poorly documented. Review of primary ethnographic literature, archival sources and a few ad-hoc ethnobotanical field studies in seven selected Eastern European countries (Albania, Belarus, Bulgaria, Estonia, Hungary, Kosovo, and Poland) were conducted. Current or recently abandoned uses of 116 botanical taxa, belonging to 37 families in fermented food or medicinal food products were recorded. These findings demonstrate a rich bio-cultural diversity of use, and also a clear prevalence of the use of fruits of the tannin- and phenolic-rich Rosaceae species in alcoholic, lactic- and acetic acid fermented preparations. In the considered countries, fermentation still plays (or has played until recent years) a crucial role in folk cuisines and this heritage requires urgent and in-depth evaluation. Future studies should be aimed at further documenting and also bio-evaluating the ingredients and processes involved in the preparation of homemade fermented products, as this can be used to support local, community-based development efforts to foster food security, food sovereignty, and small-scale local food-based economies. Copyright © 2015 Elsevier Ireland Ltd. All rights reserved.

Control of bioflavour and safety in fermented sausages : first results of a European project

NARCIS (Netherlands)

Demeyer, D.; Raemaekers, M.; Rizzo, A.; Holck, A.; Smedt, A. de; Brink, B. ten; Hagen, B.; Montel, C.; Zanardi, E.; Murbrekk, E.; Leroy, F.; Vandendriessche, F.; Lorentsen, K.; Venema, K.; Sunesen, L.; Stahnke, L.; Vuyst, L. de; Talon, R.; Chizzolini, R.; Eerola, S.

2000-01-01

Four types of fermented sausages were prepared: two using Northern technology (Norway and Belgium) and two using Mediterranean technology (Belgium and Italy). Mediterranean sausages showed higher pH values and highest residual amounts of myosin and actin. Free fatty acid concentrations reflected the

Dynamics of chemical elements in the fermentation process of ethanol production

International Nuclear Information System (INIS)

Nepomuceno, N.; Fernandes, E.A.N.; Bacchi, M.A.

1997-01-01

Brazil has become the largest producer of biomass ethanol derived from sugar cane. The industrial production is based on the fermentation of sugar cane juice by yeast, inside of large volume vats, in a fed-batch process that recycles yeast cells. To study the dynamics of chemical elements in each operating cycle, five stages of the fermentation process were considered: must, yeast suspension, wine, non-yeast wine and yeast cream. For this, a mass balance of the terrigenous elements, Ce, Co, Cs, Eu, Fe, Hf, La, Na, Sc, Sm, and Th, and the sugar cane plant elements, Br, K, Rb, and Zn, were established in fermentation vats of an industrial scale unit, with sampling undertaken during different climatic conditions (dry and rainy periods). A similar distribution of the sugar cane characteristics elements was found for the stages analysed, while for the terrigenous elements a trend of accumulation in the yeast cream was observed. Preferential absorption of Br, K, Rb, and Zn by yeast cells was indicated by the smaller concentrations observed in yeast suspension than in yeast cream. (author)

Effects of varying forage particle size and fermentable carbohydrates on feed sorting, ruminal fermentation, and milk and component yields of dairy cows.

Science.gov (United States)

Maulfair, D D; Heinrichs, A J

2013-05-01

Ration sorting is thought to affect ruminal fermentation in such a manner that milk yield milk and components are often decreased. However, the influence of ruminally degradable starch on ration sorting has not been studied. Therefore, the objective of this experiment was to evaluate the interactions between forage particle size (FPS) and ruminally fermentable carbohydrates (RFC) for dry matter intake (DMI), ration sorting, ruminal fermentation, chewing activity, and milk yield and components. In this study, 12 (8 ruminally cannulated) multiparous, lactating Holstein cows were fed a total mixed ration that varied in FPS and RFC. Two lengths of corn silage were used to alter FPS and 2 grind sizes of corn grain were used to alter RFC. It was determined that increasing RFC increased ruminating time and did not affect eating time, whereas increasing FPS increased eating time and did not affect ruminating time. Ruminal fermentation did not differ by altering either FPS or RFC. However, increasing FPS tended to increase mean and maximum ruminal pH and increasing RFC tended to decrease minimum ruminal pH. Particle size distribution became more diverse and neutral detergent fiber content of refusals increased over time, whereas starch content decreased, indicating that cows were sorting against physically effective neutral detergent fiber and for RFC. Selection indices determined that virtually no interactions occurred between FPS and RFC and that despite significant sorting throughout the day, by 24h after feeding cows had consumed a ration very similar to what was offered. This theory was reinforced by particle fraction intakes that very closely resembled the proportions of particle fractions in the offered total mixed ration. An interaction between FPS and RFC was observed for DMI, as DMI decreased with increasing FPS when the diet included low RFC and did not change when the diet included high RFC. Dry matter intake increased with RFC for long diets and did not change

Effect of temperature on continuous dry fermentation of swine manure.

Science.gov (United States)

Deng, Liangwei; Chen, Chuang; Zheng, Dan; Yang, Hongnan; Liu, Yi; Chen, Ziai

2016-07-15

Laboratory-scale experiments were performed on the dry digestion of solid swine manure in a semi-continuous mode using 4.5 L down plug-flow anaerobic reactors with an organic loading rate of 3.46 kg volatile solids (VS) m(-3) d(-1) to evaluate the effects of temperature (15, 25 and 35 °C). At 15 °C, biogas production was the poorest due to organic overload and acidification, with a methane yield of 0.036 L CH4 g(-1) VS added and a volumetric methane production rate of 0.125 L CH4 L(-1) d(-1). The methane yield and volumetric methane production rate at 25 °C (0.226 L CH4 g(-1) VS added and 0.783 L CH4 L(-1) d(-1), respectively) were 6.24 times higher than those at 15 °C. However, the methane yield (0.237 L CH4 g(-1) VS added) and the volumetric methane production rate (0.821 L CH4 L(-1) d(-1)) at 35 °C were only 4.86% higher than those at 25 °C, which indicated similar results were obtained at 25 °C and 35 °C. The lower biogas production at 35 °C in dry digestion compared with that in wet digestion could be attributed to ammonia inhibition. For a single pig farm, digestion of solid manure is accomplished in small-scale domestic or small-farm bioreactors, for which operating temperatures of 35 °C are sometimes difficult to achieve. Considering biogas production, ammonia inhibition and net energy recovery, an optimum temperature for dry digestion of solid swine manure is 25 °C. Copyright © 2016 Elsevier Ltd. All rights reserved.

Effects of different ratios and storage periods of liquid brewer's yeast mixed with cassava pulp on chemical composition, fermentation quality and in vitro ruminal fermentation.

Science.gov (United States)

Kamphayae, Sukanya; Kumagai, Hajime; Angthong, Wanna; Narmseelee, Ramphrai; Bureenok, Smerjai

2017-04-01

This study aims to evaluate the chemical composition, fermentation quality and in vitro ruminal fermentation of various ratios and storage periods of liquid brewer's yeast (LBY) mixed with cassava pulp (CVP). Four mixtures of fresh LBY and CVP were made (LBY0, LBY10, LBY20, and LBY30 for LBY:CVP at 0:100, 10:90, 20:80, and 30:70, respectively) on a fresh matter basis, in 500 g in plastic bags and stored at 30 to 32°C. After storage, the bags were opened weekly from weeks 0 to 4. Fermentation quality and in vitro gas production (IVGP) were determined, as well as the dry matter (DM), organic matter (OM), crude protein (CP), ether extract (EE), neutral detergent fiber, acid detergent fiber and acid detergent lignin contents. The contents of CP and EE increased, whereas all other components decreased, in proportion to LBY inclusion (pcontents gradually decreased in weeks 3 and 4 (pcontents were lowest in week 0. The pH, ammonia nitrogen per total nitrogen (NH 3 -N/TN) and V-score in each mixture and storage period demonstrated superior fermentation quality (pH≤4.2, NH 3 -N/TN≤12.5%, and V-score>90%). The pH increased and NH 3 -N/TN decreased, with proportionate increases of LBY, whereas the pH decreased and NH 3 -N/TN increased, as the storage periods were extended (pcontent, while decreasing IVGP, without decreasing fermentation quality and IVOMD. In addition, a preservation period of up to four weeks can guarantee superior fermentation quality in all types of mixtures. Therefore, we recommend limiting the use of CVP as a feed ingredient, given its low nutritional value and improving feed quality with the inclusion of LBY.

Ammonia fiber expansion (AFEX) pretreatment, enzymatic hydrolysis, and fermentation on empty palm fruit bunch fiber (EPFBF) for cellulosic ethanol production.

Science.gov (United States)

Lau, Ming J; Lau, Ming W; Gunawan, Christa; Dale, Bruce E

2010-11-01

Empty palm fruit bunch fiber (EPFBF), a readily available cellulosic biomass from palm processing facilities, is investigated as a potential carbohydrate source for cellulosic ethanol production. This feedstock was pretreated using ammonia fiber expansion (AFEX) and enzymatically hydrolyzed. The best tested AFEX conditions were at 135 °C, 45 min retention time, water to dry biomass loading of 1:1 (weight ratio), and ammonia to dry biomass loading of 1:1 (weight ratio). The particle size of the pretreated biomass was reduced post-AFEX. The optimized enzyme formulation consists of Accellerase (84 μL/g biomass), Multifect Xylanase (31 μL/g biomass), and Multifect Pectinase (24 μL/g biomass). This mixture achieved close to 90% of the total maximum yield within 72 h of enzymatic hydrolysis. Fermentation on the water extract of this biomass affirms that nutrients solely from the pretreated EPFBF can support yeast growth for complete glucose fermentation. These results suggest that AFEX-treated EPFBF can be used for cellulosic biofuels production because biomass recalcitrance has been overcome without reducing the fermentability of the pretreated materials.

Independent Origins of Yeast Associated with Coffee and Cacao Fermentation.

Science.gov (United States)

Ludlow, Catherine L; Cromie, Gareth A; Garmendia-Torres, Cecilia; Sirr, Amy; Hays, Michelle; Field, Colburn; Jeffery, Eric W; Fay, Justin C; Dudley, Aimée M

2016-04-04

Modern transportation networks have facilitated the migration and mingling of previously isolated populations of plants, animals, and insects. Human activities can also influence the global distribution of microorganisms. The best-understood example is yeasts associated with winemaking. Humans began making wine in the Middle East over 9,000 years ago [1, 2]. Selecting favorable fermentation products created specialized strains of Saccharomyces cerevisiae [3, 4] that were transported along with grapevines. Today, S. cerevisiae strains residing in vineyards around the world are genetically similar, and their population structure suggests a common origin that followed the path of human migration [3-7]. Like wine, coffee and cacao depend on microbial fermentation [8, 9] and have been globally dispersed by humans. Theobroma cacao originated in the Amazon and Orinoco basins of Colombia and Venezuela [10], was cultivated in Central America by Mesoamerican peoples, and was introduced to Europeans by Hernán Cortés in 1530 [11]. Coffea, native to Ethiopia, was disseminated by Arab traders throughout the Middle East and North Africa in the 6(th) century and was introduced to European consumers in the 17(th) century [12]. Here, we tested whether the yeasts associated with coffee and cacao are genetically similar, crop-specific populations or genetically diverse, geography-specific populations. Our results uncovered populations that, while defined by niche and geography, also bear signatures of admixture between major populations in events independent of the transport of the plants. Thus, human-associated fermentation and migration may have affected the distribution of yeast involved in the production of coffee and chocolate. Copyright © 2016 Elsevier Ltd. All rights reserved.

Genetic diversity for fermentable carbohydrates production in alfalfa

Energy Technology Data Exchange (ETDEWEB)

Castonguay, Y.; Bertrand, A.; Duceppe, M.O.; Dube, M.P.; Michaud, R. [Agriculture and Agri-Food Canada, Quebec City, PQ (Canada)

2009-07-01

Alfalfa has many attributes that renders it suitable for bioethanol production, including its adaptability to diverse environmental conditions without any need for nitrogen fertilizer. However research is needed to develop biofuel-type alfalfa with improved biomass production and standability, increased persistence, and better cell wall degradability. The ethanol conversion rates from alfalfa biomass could be increased by genetically improving the accumulation of readily fermentable non-structural carbohydrates (NSC). This presentation reported on a screening project where genotypes with superior cell wall degradability were identified. NSC accumulation within 300 genotypes was randomly selected within six genetic backgrounds from Europe and North America. Biochemical analyses of dried stems revealed a large genetic variability for NSC content, with concentrations ranging from 20 to 100 mg per g DW. NSC variability was considerably higher in a genetic background of European origin compared to the other populations, therefore emphasizing the potential for genetic improvement for that trait. A modified commercial enzymatic cocktail known as AcceleraseTM 1000 Genencor is being developed to optimize the degradation of alfalfa biomass. DNA extracted from genotypes with the highest and lowest cell wall degradability or NSC accumulation will be pooled and used for bulk segregant analysis of DNA polymorphisms using the PCR-based sequence-related amplified polymorphism technique. It was concluded that the commercial release of biofuel-type alfalfa can be accelerated if the genetic markers associated with these traits can be identified.

Reduction of acrylamide in whole-wheat bread by combining lactobacilli and yeast fermentation.

Science.gov (United States)

Nasiri Esfahani, Behnaz; Kadivar, Mahdi; Shahedi, Mohammad; Soleimanian-Zad, Sabihe

2017-11-01

This study mainly focuses on a strategy for reducing acrylamide content in whole-wheat bread by combining lactobacilli and yeast in sourdough breadmaking. Combinations of sourdough (fermented dough using different Lactobacillus strains including Lactobacillus plantarum PTCC 1896 [probiotic], L. sakei DSM 20,017, L. rhamnosus DSM 20,021, and L. delbrueckii DSM 20,081) and yeast, in comparison with yeast alone, were used for breadmaking. The results showed that acrylamide levels in breads fermented using sourdough+yeast were in all cases much lower (6.9-20 μg/kg on a dry weight basis [d.b.]) than those in the yeast-only fermented bread (47.6 μg/kg d.b.). Significant (p bread (r = 0.925, p breads and either the reducing sugar or free amino acid contents in dough samples. According to the different effects of Lactobacillus strains, it could be concluded that the acrylamide reducing potential of lactobacilli was strain-specific, with L. rhamnosus being the most effective. This suggests that sourdough fermentation with appropriate Lactobacillus strains can be used as an advantageous technology to reduce the acrylamide content of whole-wheat breads.

Physicochemical and Organoleptic Properties of Dried Synbiotics Yoghurt from Lesser Yam Tubers (Dioscoreaesculenta L.

Directory of Open Access Journals (Sweden)

Winarti Sri

2016-01-01

Full Text Available There are many variations of Yam (Dioscorea spp. which spread out in the world including Indonesia. Those variations could be categorized based on their shape, size, colour, and flavour of their tuber. The genus of Dioscorea spp. has more than 600 species, such as Dioscorea hispida, Dioscorea esculenta (lesser yam, Discorea bulbifera, Dioscorea alata (purple yam, Dioscorea opposita (white yam, Dioscorea villosa (yellow yam, Dioscorea altassima, and Dioscorea elephantipes. At the present, the utilization of yam tubers is seen to be limited. The purpose of the research was to evaluate the properties/characteristics of dried synbiotics yoghurt from lesser yam tubers. The treatment on this study was performed by the number of substitution of lesser yam tubers and the fermentation time. The results show that the dried synbiotics yoghurt that most preferred by consumers was G2F3 (lesser yam 40% and fermentation time 22 hours with an average value 3.65. It is followed by the total LAB (lactic acid bacteria 8,15 log cfu/g, pH 4.27, total lactic acid 1.02%, yield of dried synbiotic yoghurt 32.30%, and total soluble protein 4.53%.

The influence of process parameters in production of lipopeptide iturin A using aerated packed bed bioreactors in solid-state fermentation.

Science.gov (United States)

Piedrahíta-Aguirre, C A; Bastos, R G; Carvalho, A L; Monte Alegre, R

2014-08-01

The strain Bacillus iso 1 co-produces the lipopeptide iturin A and biopolymer poly-γ-glutamic acid (γ-PGA) in solid-state fermentation of substrate consisting of soybean meal, wheat bran with rice husks as an inert support. The effects of pressure drop, oxygen consumption, medium permeability and temperature profile were studied in an aerated packed bed bioreactor to produce iturin A, diameter of which was 50 mm and bed height 300 mm. The highest concentrations of iturin A and γ-PGA were 5.58 and 3.58 g/kg-dry substrate, respectively, at 0.4 L/min after 96 h of fermentation. The low oxygen uptake rates, being 23.34 and 22.56 mg O2/kg-dry solid substrate for each air flow rate tested generated 5.75 W/kg-dry substrate that increased the fermentation temperature at 3.7 °C. The highest pressure drop was 561 Pa/m at 0.8 L/min in 24 h. This is the highest concentration of iturin A produced to date in an aerated packed bed bioreactor in solid-state fermentation. The results can be useful to design strategies to scale-up process of iturin A in aerated packed bed bioreactors. Low concentration of γ-PGA affected seriously pressure drop, decreasing the viability of the process due to generation of huge pressure gradients with volumetric air flow rates. Also, the low oxygenation favored the iturin A production due to the reduction of free void by γ-PGA production, and finally, the low oxygen consumption generated low metabolic heat. The results show that it must control the pressure gradients to scale-up the process of iturin A production.

Cellulase Recycling after High-Solids Simultaneous Saccharification and Fermentation of Combined Pretreated Corncob

Energy Technology Data Exchange (ETDEWEB)

Du, Ruoyu [State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin (China); Su, Rongxin, E-mail: surx@tju.edu.cn [State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin (China); Collaborative Innovation Center of Chemical Science and Engineering, Tianjin (China); Tianjin Key Laboratory of Membrane Science and Desalination Technology, Tianjin University, Tianjin (China); Zhang, Mingjia [State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin (China); Qi, Wei [State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin (China); Collaborative Innovation Center of Chemical Science and Engineering, Tianjin (China); Tianjin Key Laboratory of Membrane Science and Desalination Technology, Tianjin University, Tianjin (China); He, Zhimin [State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin (China)

2014-06-26

Despite the advantageous prospect of second-generation bioethanol, its final commercialization must overcome the primary cost impediment due to enzyme assumption. To solve this problem, this work achieves high-concentration ethanol fermentation and multi-round cellulase recycling through process integration. The optimal time and temperature of the re-adsorption process were determined by monitoring the adsorption kinetics of cellulases. Both glucose and cellobiose inhibited cellulase adsorption. After 96 h of ethanol fermentation, 40% of the initial cellulase remained in the broth, from which 62.5% of the cellulase can be recycled and reused in fresh substrate re-adsorption for 90 min. Under optimum conditions, i.e., pH 5.0, dry matter loading of 15 wt%, cellulase loading of 45 FPU/g glucan, two cycles of fermentation and re-adsorption can yield twofold increased ethanol outputs and reduce enzyme costs by over 50%. The ethanol concentration in each cycle can be achieved at levels >40 g/L.

Cellulase recycling after high-solids simultaneous saccharification and fermentation of combined pretreated corncob

Directory of Open Access Journals (Sweden)

Ruoyu eDu

2014-06-01

Full Text Available Despite the advantageous prospect of second-generation bioethanol, its final commercialization must overcome the primary cost impediment due to enzyme assumption. To solve this problem, this work achieves high-concentration ethanol fermentation and multi-round cellulase recycling through process integration. The optimal time and temperature of the re-adsorption process were determined by monitoring the adsorption kinetics of cellulases. Both glucose and cellobiose inhibited cellulase adsorption. After 96 h of ethanol fermentation, 40% of the initial cellulase remained in the broth, from which 62.5% of the cellulase can be recycled and reused in fresh substrate re-adsorption for 90 min. Under optimum conditions, i.e., pH 5.0, dry matter loading of 15 wt%, cellulase loading of 45 FPU/g glucan, two cycles of fermentation and re-adsorption can yield two-fold increased ethanol outputs and reduce enzyme costs by over 50%. The ethanol concentration in each cycle can be achieved at levels greater than 40 g/L.

Cellulase Recycling after High-Solids Simultaneous Saccharification and Fermentation of Combined Pretreated Corncob

International Nuclear Information System (INIS)

Du, Ruoyu; Su, Rongxin; Zhang, Mingjia; Qi, Wei; He, Zhimin

2014-01-01

Despite the advantageous prospect of second-generation bioethanol, its final commercialization must overcome the primary cost impediment due to enzyme assumption. To solve this problem, this work achieves high-concentration ethanol fermentation and multi-round cellulase recycling through process integration. The optimal time and temperature of the re-adsorption process were determined by monitoring the adsorption kinetics of cellulases. Both glucose and cellobiose inhibited cellulase adsorption. After 96 h of ethanol fermentation, 40% of the initial cellulase remained in the broth, from which 62.5% of the cellulase can be recycled and reused in fresh substrate re-adsorption for 90 min. Under optimum conditions, i.e., pH 5.0, dry matter loading of 15 wt%, cellulase loading of 45 FPU/g glucan, two cycles of fermentation and re-adsorption can yield twofold increased ethanol outputs and reduce enzyme costs by over 50%. The ethanol concentration in each cycle can be achieved at levels >40 g/L.

Aminogenesis control in fermented sausages manufactured with pressurized meat batter and starter culture.

Science.gov (United States)

Latorre-Moratalla, M L; Bover-Cid, S; Aymerich, T; Marcos, B; Vidal-Carou, M C; Garriga, M

2007-03-01

The application of high hydrostatic pressure (200MPa) to meat batter just before sausage fermentation and the inoculation of starter culture were studied to improve the safety and quality of traditional Spanish fermented sausages (fuet and chorizo). Higher amounts of biogenic amines were formed in chorizo than in fuet. Without interfering with the ripening performance in terms of acidification, drying and proteolysis, hydrostatic pressure prevented enterobacteria growth but did not affect Gram-positive bacteria significantly. Subsequently, a strong inhibition of diamine (putrescine and cadaverine) accumulation was observed, but that of tyramine was not affected. The inoculated decarboxylase-negative strains, selected from indigenous bacteria of traditional sausages, were resistant to the HHP treatment, being able to lead the fermentation process, prevent enterococci development and significantly reduce enterobacteria counts. In sausages manufactured with either non-pressurized or pressurized meat batter, starter culture was the most protective measure against the accumulation of tyramine and both diamines.

Continuous cider fermentation with co-immobilized yeast and Leuconostoc oenos cells.

Science.gov (United States)

Nedovic; Durieuxb; Van Nedervelde L; Rosseels; Vandegans; Plaisant; Simon

2000-06-01

Ca-alginate matrix was used to co-immobilize Saccharomyces bayanus and Leuconostoc oenos in one integrated biocatalytic system in order to perform simultaneously alcoholic and malo-lactic fermentation of apple juice to produce cider, in a continuous packed bed bioreactor. The continuous process permitted much faster fermentation compared with the traditional batch process. The flavor formation was also better controlled. By adjusting the flow rate of feeding substrate through the bioreactor, i.e. its residence time, it was possible to obtain either "soft" or "dry" cider. However, the profile of volatile compounds in the final product was modified comparatively to the batch process, especially for higher alcohols, isoamylacetate, and diacetyl. This modification is due to different physiology states of yeast in two processes. Nevertheless, the taste of cider was quite acceptable.

Effects of low-level gamma irradiation on the characteristics of fermented pork sausage during storage

International Nuclear Information System (INIS)

Kim, I.S.; Jo, C.; Lee, K.H.; Lee, E.J.; Ahn, D.U.; Kang, S.N.

2012-01-01

The effect of gamma irradiation (0.5, 1, 2, and 4 kGy) on the quality of vacuum-packaged dry fermented sausages during refrigerated storage was evaluated. At Day 0 of irradiation, the pH, redness (CIE a ⁎ ), yellowness (CIE b ⁎ ), 2-thiobarbituric acid-reactive substances (TBARS) and volatile basic nitrogen (VBN) values of samples irradiated at 2 and 4 kGy were higher (p ⁎ values (lightness) were lower than those of the non-irradiated control (p ⁎ , CIE a ⁎ and CIE b ⁎ -value of samples were not significantly influenced by irradiation. The CIE a ⁎ , and CIE b ⁎ -values of samples irradiated at 2 and 4 kGy decreased with the increase of storage time. The VBN, TBARS, and CIE L ⁎ -values of samples irradiated at 4 kGy were not changed significantly during refrigerated storage for 90 days (p>0.05). The total plate counts (TPC) and lactic acid bacteria (LAB) in the samples irradiated at 4 kGy were significantly lower (p<0.01) than those with lower irradiation doses. At the end of storage, the TPC, coliform, and LAB in the samples were not increased after irradiation at 1, 0.5 and 1 kGy, respectively. TPC and LAB were not detected in samples irradiated at 4 kGy at Day 90. In addition, no coliform bacteria were found in samples irradiated at 1 kGy during refrigerated storage. Sensory evaluation indicated that the rancid flavor of samples irradiated at 4 kGy was significantly higher, but aroma and taste scores were lower than those of the control at Day 3 of storage. Irradiation of dry fermented sausages at 2 kGy was the best conditions to prolong the shelf-life and decrease the rancid flavor without significant quality deterioration. - Highlights: ► Effect of gamma irradiation on the quality of vacuum-packaged dry fermented sausages during refrigerated storage was evaluated. ► At Day 90, the TPC, coliform, and LAB in the dry fermented sausages were not increased after irradiation at 2, 0.5 and 4 kGy, respectively. ► TPC and LAB were not detected in

Effects of two sources of tannins (Quercus L. and Vaccinium vitis idaea L. on rumen microbial fermentation: an in vitro study

Directory of Open Access Journals (Sweden)

Adam Cieslak

2014-04-01

Full Text Available The aim of the experiment was to determine the effect of different sources of tannins on the in vitro rumen fermentation with focus on methane production. In the experiment, a rumen simulation system (RUSITEC equipped with 4 fermenters (1 L was used in three replicated runs (6 d of adaptation and 4 d of sampling to study the effects of Quercus cortex extract (QC, Vaccinium vitis idaea (VVI dried leaf extract and a mixture of VVI/QC on rumen microbial fermentation. Fermenters were fed 10.9 g/d of dry matter (DM of a 600:400 forage:concentrate diet. Treatments were control, QC (2.725 mL, VVI leaves 0.080 g and mixture of QC/VVI (1.362 mL+0.040 g and were randomly assigned to fermenters within periods. The equivalent of 2.5 g of tannins/kg dietary DM from three sources of tannins was evaluated. All tannin sources decreased CH4 and ammonia concentrations, as well as protozoa and methanogen counts (P<0.001. Vaccinium vitis idaea and QC/VVI tended (P=0.005 to reduce the acetate to propionate ratio. There were no changes in nutrient digestion. Results suggest that these sources of tannins, especially VVI have the potential to reduce rumen CH4 production and ammonia concentration without negative effects on in vitro DM digestibility, total volatile fatty acids and pH.

Fermentation of cassava and other vegetable substances

Energy Technology Data Exchange (ETDEWEB)

Stanton, W R; Wallbridge, A J

1972-06-07

The fermentation consists of a process in which a mucoraceous fungus of the genera Rhizopus, Mucor, or Acrinomucor or a fungus of the genus Monilia is fermented on a solid or paste like substrate which is a mixture of an edible protein-deficient vegetable material known as cassava, of which the carbohydrate is mainly starch and a compound containing N in nonproteinaceous form and assimilable by the fungus to synthesize protein. Thus, tubers obtained from M. esculenta (M. utilissima are peeled, dried, and ground to give a tapioca flour. The N source is prepared by dissolving 45.8g NH/sub 4/NO/sub 3/ and 8 g KH/sub 2/PO/sub 4/ in 200 to 300 ml distilled H/sub 2/O and to this is added inculum, 15 ml of a spore suspension of R stolonifer. The mixture is stirred into 1 kg of milled cassava flour and 300 ml of H/sub 2/O is added, so that the final moisture level is 45 +- 3%. The pH is 5.4 to 6.7 and the mixture is mixed with a machine for 10 to 12 minutes to give a stiff paste. The dough is extruded as a spaghetti 3 to 5 mm diam and strands are cut into 10 cm lengths. The strands are packed into shallow fermentation trays, which are covered with a loose fitting Al lid and placed in fermentor. Temperature is kept at 30/sup 0/ and relative humidity is kept at 95 to 97% for 72 hours. Fermentation is stopped by cooking or by deep freezing. The protein content is raised by the process from 0.2 to 4%. The initial toxicity of the cassava is also reduced.

Gaseous emissions during the solid state fermentation of different wastes for enzyme production at pilot scale.

Science.gov (United States)

Maulini-Duran, Caterina; Abraham, Juliana; Rodríguez-Pérez, Sheila; Cerda, Alejandra; Jiménez-Peñalver, Pedro; Gea, Teresa; Barrena, Raquel; Artola, Adriana; Font, Xavier; Sánchez, Antoni

2015-03-01

The emissions of volatile organic compounds (VOC), CH4, N2O and NH3 during the solid state fermentation process of some selected wastes to obtain different enzymes have been determined at pilot scale. Orange peel+compost (OP), hair wastes+raw sludge (HW) and winterization residue+raw sludge (WR) have been processed in duplicate in 50 L reactors to provide emission factors and to identify the different VOC families present in exhaust gaseous emissions. Ammonia emission from HW fermentation (3.2±0.5 kg Mg(-1) dry matter) and VOC emission during OP processes (18±6 kg Mg(-1) dry matter) should be considered in an industrial application of these processes. Terpenes have been the most emitted VOC family during all the processes although the emission of sulphide molecules during HW SSF is notable. The most emitted compound was dimethyl disulfide in HW and WR processes, and limonene in the SSF of OP. Copyright © 2014 Elsevier Ltd. All rights reserved.

THE DEPENDENCE OF GLYCEROL ACCUMULATION AND STARCH HYDROLYZATES FERMENTATION FROM WORT CONCENTRATION

Directory of Open Access Journals (Sweden)

Оliynichuk S. Т.

2015-08-01

Full Text Available The purpose of this work is to study the dependence of ethanol accumulation by-products and secondary products (glycerol and propionic acid during the fermentation in the case of increasing the wort concentration from 12 to 21% by weight of sugar as an example of commonly used in the alcohol industry the commercial dry yeast company “Danisco” and experimental osmophilic strain Saccharomyces cerevisiae DS-02-E, isolated from a concentrated (80% DM of rye malt wort which spontaneously fermented. The enzyme preparations “AMYLEX 4T”, “ALPHALASE AFP” and “DIAZYME SSF” were used for the liquefaction and saccharification of starch wort. The finished industrial of both yeast strains were added to the fermentation flasks in an amount of 10% by volume of the primary wort. In the mature brew the unfermented carbohydrates content was determined by colorimetric method with anthrone reagent, alcohol — by glass areometer-alcoholometer, acidity — potentiometrically, the concentration of dry matter — by areometer, glycerol content — by photocolorimetry method. In the brew distillate a volatile impurities content, namely propionic acid, was determined using gas chromatography. Statistical processing of the results of three series of experiments were carried out by calculating the arithmetical mean value of 5 measurements, their standard deviations and errors. To determine the probable differences between the mean values were used Student’s t test. Differences were considered statistically significant at P < 0.05. Reduction for accumulation of glycerol (between 38 till 53% at higher concentrations of nutrient medium in the case of the yeast Saccharomyces cerevisiae DS-02-E as compared with commercial dry yeast, reduction the formation of unwanted by-product of fermentation — propionic acid (up to 34%, a better ability of the experimental strain to accumulate sugar of wort and to accumulate ethanol (up to 0.1–0.25% vol. were shown. It

Biomass production and small-scale testing of freeze-dried lactic acid bacteria starter strains for cassava fermentations

CSIR Research Space (South Africa)

Edward, VA

2011-03-01

Full Text Available Based on their predominance in Gari fermentations, as well as suitable technological properties, Lactobacillus plantarum, Lactobacillus fermentum, Weissella paramesenteroides and Leuconostoc mesenteroides strains were investigated...

Dual effect of soluble materials in pretreated lignocellulose on simultaneous saccharification and co-fermentation process for the bioethanol production.

Science.gov (United States)

Qin, Lei; Li, Xia; Liu, Li; Zhu, Jia-Qing; Guan, Qi-Man; Zhang, Man-Tong; Li, Wen-Chao; Li, Bing-Zhi; Yuan, Ying-Jin

2017-01-01

In this study, wash liquors isolated from ethylenediamine and dry dilute acid pretreated corn stover were used to evaluate the effect of soluble materials in pretreated biomass on simultaneous saccharification and co-fermentation (SSCF) for ethanol production, respectively. Both of the wash liquors had different impacts on enzymatic hydrolysis and fermentation. Enzymatic conversions of glucan and xylan monotonically decreased as wash liquor concentration increased. Whereas, with low wash liquor concentrations, xylose consumption rate, cell viability and ethanol yield were maximally stimulated in fermentation without nutrient supplementary. Soluble lignins were found as the key composition which promoted sugars utilization and cell viability without nutrient supplementary. The dual effects of soluble materials on enzymatic hydrolysis and fermentation resulted in the reduction of ethanol yield as soluble materials increased in SSCF. Copyright © 2016 Elsevier Ltd. All rights reserved.

Market power in the European electricity market - The impacts of dry weather and additional transmission capacity

International Nuclear Information System (INIS)

Lise, Wietze; Hobbs, Benjamin F.; Hers, Sebastiaan

2008-01-01

This paper uses a static computational game theoretic model of a fully opened European electricity market and can take strategic interaction among electricity-producing firms into account. The model is run for a number of scenarios: first, in the baseline under perfect competition, the prices differ due to the presence of various generation technologies and a limited ability to exchange electricity among countries. In addition, when large firms exercise market power, the model runs indicate that prices are the highest in countries where the number of firms is low. Second, dry weather would increase the prices in the hydro-rich Nordic countries followed by the Alpine countries. The price response would be about 20% higher with market power. Third, more transmission capacity would lower the prices in countries with high prices and it also reduces the impact of market power. Hence, more transmission capacity can improve market competitiveness. (author)

Market power in the European electricity market-The impacts of dry weather and additional transmission capacity

Energy Technology Data Exchange (ETDEWEB)

Lise, Wietze [IBS Research and Consultancy, Agahamami Cadessi 1/6, Aga Han, Cihangir, 34433 Beyoglu, Istanbul (Turkey); Energy Markets and International Environmental Policy Group, ECN Policy Studies, Energy Research Centre of the Netherlands, Amsterdam (Netherlands)], E-mail: wietze.lise@ibsresearch.com; Hobbs, Benjamin F. [Department of Geography and Environmental Engineering, Johns Hopkins University, Baltimore, MD 21218 (United States); Hers, Sebastiaan [Energy Markets and International Environmental Policy Group, ECN Policy Studies, Energy Research Centre of the Netherlands, Amsterdam (Netherlands)

2008-04-15

This paper uses a static computational game theoretic model of a fully opened European electricity market and can take strategic interaction among electricity-producing firms into account. The model is run for a number of scenarios: first, in the baseline under perfect competition, the prices differ due to the presence of various generation technologies and a limited ability to exchange electricity among countries. In addition, when large firms exercise market power, the model runs indicate that prices are the highest in countries where the number of firms is low. Second, dry weather would increase the prices in the hydro-rich Nordic countries followed by the Alpine countries. The price response would be about 20% higher with market power. Third, more transmission capacity would lower the prices in countries with high prices and it also reduces the impact of market power. Hence, more transmission capacity can improve market competitiveness.

Market power in the European electricity market - The impacts of dry weather and additional transmission capacity

Energy Technology Data Exchange (ETDEWEB)

Lise, Wietze [IBS Research and Consultancy, Agahamami Cadessi 1/6, Aga Han, Cihangir, 34433 Beyoglu, Istanbul (Turkey); Energy Markets and International Environmental Policy Group, ECN Policy Studies, Energy Research Centre of the Netherlands, Amsterdam (Netherlands); Hobbs, Benjamin F. [Department of Geography and Environmental Engineering, Johns Hopkins University, Baltimore, MD 21218 (United States); Hers, Sebastiaan [Energy Markets and International Environmental Policy Group, ECN Policy Studies, Energy Research Centre of the Netherlands, Amsterdam (Netherlands)

2008-04-15

This paper uses a static computational game theoretic model of a fully opened European electricity market and can take strategic interaction among electricity-producing firms into account. The model is run for a number of scenarios: first, in the baseline under perfect competition, the prices differ due to the presence of various generation technologies and a limited ability to exchange electricity among countries. In addition, when large firms exercise market power, the model runs indicate that prices are the highest in countries where the number of firms is low. Second, dry weather would increase the prices in the hydro-rich Nordic countries followed by the Alpine countries. The price response would be about 20% higher with market power. Third, more transmission capacity would lower the prices in countries with high prices and it also reduces the impact of market power. Hence, more transmission capacity can improve market competitiveness. (author)

Invited review: Essential oils as modifiers of rumen microbial fermentation.

Science.gov (United States)

Calsamiglia, S; Busquet, M; Cardozo, P W; Castillejos, L; Ferret, A

2007-06-01

Microorganisms in the rumen degrade nutrients to produce volatile fatty acids and synthesize microbial protein as an energy and protein supply for the ruminant, respectively. However, this fermentation process has energy (losses of methane) and protein (losses of ammonia N) inefficiencies that may limit production performance and contribute to the release of pollutants to the environment. Antibiotic ionophores have been very successful in reducing these energy and protein losses in the rumen, but the use of antibiotics in animal feeds is facing reduced social acceptance, and their use has been banned in the European Union since January 2006. For this reason, scientists have become interested in evaluating other alternatives to control specific microbial populations to modulate rumen fermentation. Essential oils can interact with microbial cell membranes and inhibit the growth of some gram-positive and gram-negative bacteria. As a result of such inhibition, the addition of some plant extracts to the rumen results in an inhibition of deamination and methanogenesis, resulting in lower ammonia N, methane, and acetate, and in higher propionate and butyrate concentrations. Results have indicated that garlic oil, cinnamaldehyde (the main active component of cinnamon oil), eugenol (the main active component of the clove bud), capsaicin (the active component of hot peppers), and anise oil, among others, may increase propionate production, reduce acetate or methane production, and modify proteolysis, peptidolysis, or deamination in the rumen. However, the effects of some of these essential oils are pH and diet dependent, and their use may be beneficial only under specific conditions and production systems. For example, capsaicin appears to have small effects in high-forage diets, whereas the changes observed in high-concentrate diets (increases in dry matter intake and total VFA, and reduction in the acetateto-propionate ratio and ammonia N concentration) may be beneficial

Dry-grind processing using amylase corn and superior yeast to reduce the exogenous enzyme requirements in bioethanol production.

Science.gov (United States)

Kumar, Deepak; Singh, Vijay

2016-01-01

Conventional corn dry-grind ethanol production process requires exogenous alpha and glucoamylases enzymes to breakdown starch into glucose, which is fermented to ethanol by yeast. This study evaluates the potential use of new genetically engineered corn and yeast, which can eliminate or minimize the use of these external enzymes, improve the economics and process efficiencies, and simplify the process. An approach of in situ ethanol removal during fermentation was also investigated for its potential to improve the efficiency of high-solid fermentation, which can significantly reduce the downstream ethanol and co-product recovery cost. The fermentation of amylase corn (producing endogenous α-amylase) using conventional yeast and no addition of exogenous α-amylase resulted in ethanol concentration of 4.1 % higher compared to control treatment (conventional corn using exogenous α-amylase). Conventional corn processed with exogenous α-amylase and superior yeast (producing glucoamylase or GA) with no exogenous glucoamylase addition resulted in ethanol concentration similar to control treatment (conventional yeast with exogenous glucoamylase addition). Combination of amylase corn and superior yeast required only 25 % of recommended glucoamylase dose to complete fermentation and achieve ethanol concentration and yield similar to control treatment (conventional corn with exogenous α-amylase, conventional yeast with exogenous glucoamylase). Use of superior yeast with 50 % GA addition resulted in similar increases in yield for conventional or amylase corn of approximately 7 % compared to that of control treatment. Combination of amylase corn, superior yeast, and in situ ethanol removal resulted in a process that allowed complete fermentation of 40 % slurry solids with only 50 % of exogenous GA enzyme requirements and 64.6 % higher ethanol yield compared to that of conventional process. Use of amylase corn and superior yeast in the dry-grind processing industry

Microbial Ecology and Process Technology of Sourdough Fermentation.

Science.gov (United States)

De Vuyst, Luc; Van Kerrebroeck, Simon; Leroy, Frédéric

2017-01-01

From a microbiological perspective, sourdough is to be considered as a specific and stressful ecosystem, harboring yeasts and lactic acid bacteria (LAB), that is used for the production of baked goods. With respect to the metabolic impact of the sourdough microbiota, acidification (LAB), flavor formation (LAB and yeasts), and leavening (yeasts and heterofermentative LAB species) are most noticeable. Three distinct types of sourdough fermentation processes can be discerned based on the inocula applied, namely backslopped ones (type 1), those initiated with starter cultures (type 2), and those initiated with a starter culture followed by backslopping (type 3). A sourdough-characteristic LAB species is Lactobacillus sanfranciscensis. A sourdough-characteristic yeast species is Candida humilis. Although it has been suggested that the microbiota of a specific sourdough may be influenced by its geographical origin, region specificity often seems to be an artefact resulting from interpretation of the research data, as those are dependent on sampling, isolation, and identification procedures. It is however clear that sourdough-adapted microorganisms are able to withstand stress conditions encountered during their growth. Based on the technological setup, type 0 (predoughs), type I (artisan bakery firm sourdoughs), type II (industrial liquid sourdoughs), and type III sourdoughs (industrial dried sourdoughs) can be distinguished. The production of all sourdoughs, independent of their classification, depends on several intrinsic and extrinsic factors. Both the flour (type, quality status, etc.) and the process parameters (fermentation temperature, pH and pH evolution, dough yield, water activity, oxygen tension, backslopping procedure and fermentation duration, etc.) determine the dynamics and outcome of (backslopped) sourdough fermentation processes. Copyright © 2017 Elsevier Inc. All rights reserved.

Evaluation of nutritive value of palm kernel cake fermented with molds as source of protein in ruminant

Directory of Open Access Journals (Sweden)

Wisri Puastuti

2014-06-01

Full Text Available The objective of the research was to improve the nutritive value of PKC through fermentation and to evaluate its degradation characteristics in the rumen and post rumen digestibility as a protein feed source for ruminants. PKC was fermented using Aspergillus niger, Trichoderma viridae and Aspergillus oryzae. To evaluate the in sacco rumen degradability, 2 rumen fistulated females Fries Holstein 3.5 years old were used. Samples were incubated in the rumen for 0, 4, 8, 12, 16, 24, 48 and 72 hours. Determination of dry matter (DM degradation characteristics value and crude protein (CP in the rumen was calculated based on formula y = a + b (1 - e-ct. The experiments were conducted using a completely randomized design with four replicates. The results showed that fermentation increased protein content of the PKC by 79.21% with the highest increase from fermentation using Aspergillus oryzae (88.34%. DM and CP degradability ​in the rumen and post rumen of fermented PKC was affected by type of mold used for fermentation. Fermentation increased the amount of water soluble DM (a of fermented PKC with average of 46.7%, but the value of insoluble but degradable fraction in the rumen (b was decreased. Fermentation by molds resulited in the reduction of fraction of insoluble CP but degradable (b in the rumen by 50.42%. PKC fermentation by Aspergillus oryzae resulted in the higest CP degradability in the rumen and post rumen. It can be concluded that PKC has a high content of degradable CP in the rumen even without fermentation. Protein source from PKC fermented using Aspergillus oryzae categorized as the best source of feed protein in terms of increasing CP content and digestibility.

Influence of pre-fermentation cold maceration treatment on aroma compounds of Cabernet Sauvignon wines fermented in different industrial scale fermenters.

Science.gov (United States)

Cai, Jian; Zhu, Bao-Qing; Wang, Yun-He; Lu, Lin; Lan, Yi-Bin; Reeves, Malcolm J; Duan, Chang-Qing

2014-07-01

The influence of pre-fermentation cold maceration (CM) on Cabernet Sauvignon wines fermented in two different industrial-scale fermenters was studied. CM treatment had different effects on wine aroma depending on the types of fermenter, being more effective for automatic pumping-over tank (PO-tank) than automatic punching-down tank (PD-tank). When PO-tank was used, CM-treated wine showed a decrease in some fusel alcohols (isobutanol and isopentanol) and an increase in some esters (especially acetate esters). However, no significant changes were detected in these compounds when PD-tank was used. Ethyl 2-hexenoate and diethyl succinate were decreased, while geranylacetone was increased by the CM treatment in both fermenters. β-Damascenone was increased by the CM treatment in PO-tank fermented wines but decreased in PD-tank fermented wines. The fruity, caramel and floral aroma series were enhanced while chemical series were decreased by the CM treatment in PO-tank fermented wines. The content of (Z)-6-nonen-1-ol in the final wines was positively correlated to CM treatment. Copyright © 2014 Elsevier Ltd. All rights reserved.

GUT FERMENTATION SYNDROME

African Journals Online (AJOL)

boaz

individuals who became intoxicated after consuming carbohydrates, which became fermented in the gastrointestinal tract. These claims of intoxication without drinking alcohol, and the findings on endogenous alcohol fermentation are now called Gut. Fermentation Syndrome. This review will concentrate on understanding ...

Production of xylose, furfural, fermentable sugars and ethanol from agricultural residues

Energy Technology Data Exchange (ETDEWEB)

Singh, A.; Das, K.; Sharma, D.K.

1984-02-01

With the developing shortage of petroleum, reliance on biomass as a source of chemicals and fuels will increase. In the present work, bagasse and rice husk were subjected to dilute acid (H2SO4) hydrolysis using pressurised water to obtain furfural and fermentable sugars. Various process conditions such as particle size, solid-liquid ratio, acid concentration, reaction time and temperature have been studied to optimise yields of furfural, xylose and other fermentable sugars. The use of particle sizes smaller than 495 mu m did not further increase the yield of reducing sugars. A solid-liquid ratio of 1:15 was found to be the most suitable for production of reducing sugars. Hydrolysis using 0.4% H2SO4 at 453 K resulted in selective yields (g per 100 g of dried agricultural residues) of xylose from bagasse (22.5%) and rice husk (21.5%). A maximum yield of furfural was obtained using 0.4% H2SO4 at 473 K from bagasse (11.5%) and rice husk (10.9%). It was also found that hydrolysis using 1% H2SO4 at 493 K resulted in maximum yields of total reducing sugar from bagasse (53.5%) and rice husk (50%). The reducing sugars obtained were fermented to ethanol after removal of furfural. The effect of furfural on the fermentation of sugars to ethanol was also studied. Based on these studies, an integrated two-step process for the production of furfural and fermentable sugars could be envisaged. In the first step, using 0.4% H2SO4 at 473 K, furfural could be obtained, while in the second step, the use of 1% H2SO4 at 493 K should result in the production of fermentable sugars. (Refs. 22).

Substitution of wheat dried distillers grains with solubles for barley grain or barley silage in feedlot cattle diets: intake, digestibility, and ruminal fermentation.

Science.gov (United States)

Li, Y L; McAllister, T A; Beauchemin, K A; He, M L; McKinnon, J J; Yang, W Z

2011-08-01

The objective of this study was to evaluate the effects of substituting wheat dried distillers grains with solubles (DDGS) for barley grain and barley silage on intake, digestibility, and ruminal fermentation in feedlot beef cattle. Eight ruminally cannulated Angus heifers (initial BW 455 ± 10.8 kg) were assigned to a replicated 4 × 4 Latin square design with 4 treatments: control, low (25%), medium (30%), and high (35%) wheat DDGS (DM basis). The diets consisted of barley silage, barley concentrate, and wheat DDGS in ratios of 15:85:0 (CON), 10:65:25 (25DDGS), 5:65:30 (30DDGS), and 0:65:35 (35DDGS; DM basis), respectively. The diets were formulated such that wheat DDGS was substituted for both barley grain and barley silage to evaluate whether wheat DDGS can be fed as a source of both energy (grain) and fiber in feedlot finishing diets. Intakes (kg/d) of DM and OM were not different, whereas those of CP, NDF, ADF, and ether extract (EE) were greater (P Ruminal pH and total VFA concentrations were not different (P > 0.15) between 25DDGS and CON diets. Replacing barley silage with increasing amounts of wheat DDGS (i.e., from 25DDGS to 35DDGS) linearly reduced (P ruminal pH tended (P=0.10) to linearly decrease, and ruminal pH status decreased with longer (P=0.04) duration of pH 0.19) ruminal VFA and NH(3)-N concentrations. Results indicated that wheat DDGS can be effectively used to replace both barley grain and silage at a moderate amount to meet energy and fiber requirements of finishing cattle. However, when silage content of the diet is low (ruminal pH status even though the rapidly fermentable starch content of the diet is considerably reduced. © 2011 American Society of Animal Science. All rights reserved.

[Solid-state fermentation with Penicillium sp. PT95 for carotenoid production].

Science.gov (United States)

Han, J; Xu, J

1999-04-01

A preliminary study on solid-state fermentation (SSF) with Penicillium sp PT95 for carotenoid production was performed. The results showed that the production of carotenoid in sclerotia of PT95 was more efficient in corn meal medium than in either wheat bran medium or cottonseed hull medium. Addition of nitrogen and carbon sources as well as vegetable oil to media was required for increasing the dry weight of sclerotia and carotenoid yield. Among several tested compounds for nitrogen and carbon sources, sodium nitrate and maltose were the best. Through orthogonal experiments, the optimum culture medium was obtained by supplement of NaNO3 3g, maltose 10 g, soybean oil 2.5 g to per liter of salt solution. Under the optimum culture conditions, the sclerotia dry weight increased from 5.36 g to 9.70 g per 100 g dry substrate, the carotenoid yield from 2149 micrograms to 5260 micrograms per 100 g dry substrate, the proportion of beta-carotene in carotenoids from 61.4% to 71.3%.

By-products resulting from lignocellulose pretreatment and their inhibitory effect on fermentations for (bio)chemicals and fuels

NARCIS (Netherlands)

Pol, van der E.C.; Bakker, R.R.; Baets, P.; Eggink, G.

2014-01-01

Lignocellulose might become an important feedstock for the future development of the biobased economy. Although up to 75 % of the lignocellulose dry weight consists of sugar, it is present in a polymerized state and cannot be used directly in most fermentation processes for the production of

In situ prebiotics for weaning piglets: In vitro production and fermentation of potato galactorhamnogalacturonan

DEFF Research Database (Denmark)

Strube, Mikael Lenz; Ravn, Helle Christine; Ingerslev, Hans-Christian

2015-01-01

Post weaning diarrhea (PWD) in pigs is a leading cause of economic loss in pork production worldwide. The current practice of using antibiotics and zinc to treat PWD is unsustainable due to the potential of antibiotic resistance and ecological disturbance, and novel methods are required...... product, with a minimal enzyme dose in a simulated upper GI-model extracting 26.9 % of initial dry matter. The fiber was rich in galactose and galacturonic acid and was fermented at 2.5, 5 or 10 g/L in a glucose-free media inoculated with the gut contents of piglet terminal ileum. Fermentations of 5 g....... For animal studies, a dosage corresponding to the 5 g/L treatment is suggested....

Gamma-aminobutyric acid fermentation with date residue by a lactic acid bacterium, Lactobacillus brevis.

Science.gov (United States)

Hasegawa, Momoko; Yamane, Daisuke; Funato, Kouichi; Yoshida, Atsushi; Sambongi, Yoshihiro

2018-03-01

Dates are commercially consumed as semi-dried fruit or processed into juice and puree for further food production. However, the date residue after juice and puree production is not used, although it appears to be nutrient enriched. Here, date residue was fermented by a lactic acid bacterium, Lactobacillus brevis, which has been generally recognized as safe. Through degradation of sodium glutamate added to the residue during the fermentation, γ-aminobutyric acid (GABA), which reduces neuronal excitability, was produced at the conversion rate of 80-90% from glutamate. In order to achieve this GABA production level, pretreatment of the date residue with carbohydrate-degrading enzymes, i.e., cellulase and pectinase, was necessary. All ingredients used for this GABA fermentation were known as being edible. These results provide us with a solution for the increasing commercial demand for GABA in food industry with the use of date residue that has been often discarded. Copyright © 2017 The Society for Biotechnology, Japan. Published by Elsevier B.V. All rights reserved.

Zygomycota associated with traditional meju, a fermented soybean starting material for soy sauce and soybean paste

NARCIS (Netherlands)

Hong, S.B.; Kim, D.H.; Lee, M.; Baek, S.Y.; Kwon, S.; Houbraken, J.; Samson, R.A.

2012-01-01

Various zygomycota species were detected during a study of the mycobiota of meju, a brick of dried fermented soybeans, used in Korean cuisine. Two hundred and sixty-eight strains were isolated from 98 finished meju products collected in various regions of Korea from 2009 to 2011, and 96 strains were

Impact of operating conditions on performance of a novel gas double-dynamic solid-state fermentation bioreactor (GDSFB).

Science.gov (United States)

Chen, Hongzhang; Li, Yanjun; Xu, Fujian

2013-11-01

A self-designed novel solid-state fermentation (SSF) bioreactor named "gas double-dynamic solid-state fermentation bioreactor (GDSFB)" showed great success in processes for the production of several valuable products. For the present study, a simple GDSFB (2 L in volume) was designed to investigate the impact of exhaust time on SSF performance. Both air pressure and vent aperture significantly influenced the exhaust time. The production of cellulase by Penicillium decumbens JUA10 was studied in this bioreactor. When the vent aperture was maintained at 0.2 cm, the highest FPA activity of 17.2 IU/g dry solid-state medium was obtained at an air pressure of 0.2 MPa (gauge pressure). When the air pressure was maintained at 0.2 MPa, a vent aperture of 0.3 cm gave the highest FPA activity of 18.0 IU/g dry solid-state medium. Further analysis revealed that the exhaust time was a crucial indicator of good performance in GDSFB.

Effect of processing on proteolysis and biogenic amines formation in a Portuguese traditional dry-fermented ripened sausage "Chouriço Grosso de Estremoz e Borba PGI".

Science.gov (United States)

Roseiro, L C; Gomes, A; Gonçalves, H; Sol, M; Cercas, R; Santos, C

2010-01-01

The influence of alternative drying environmental conditions on the proteolysis of a traditional Portuguese fermented sausage was evaluated, in relation to different ripening periods. Traditional sausages (batch T) had lower pH than counterparts (batch M), with differences (Palanine>taurine>serine>valine and taurine>alanine>leucine>serine>valine sequences in the former product from batches T and M, respectively, and, coincidently, the same sequence for both batches in the later (serine>leucine>alanine>proline>valine). Such effect on FAA concentrations led to a distinct (Psweet, bitter, acidic and aged sensorial attributes between batches, in S8 and S9 products. BA typical quantitative sequences varied between batches according to the ripening stage, with differences in S6 and S7 end products also reflecting the distinct microbial development rates and profiles observed. Overall, the total BA mean concentration was higher (P<0.05) in products from batch T.

Effects of dietary addition of cellulase and a Saccharomyces cerevisiae fermentation product on nutrient digestibility, rumen fermentation and enteric methane emissions in growing goats.

Science.gov (United States)

Lu, Qi; Wu, Jian; Wang, Min; Zhou, Chuanshe; Han, Xuefeng; Odongo, Edwin Nicholas; Tan, Zhiliang; Tang, Shaoxun

2016-01-01

This study was designed to assess the effectiveness of dietary cellulase (243 U/g, derived from Neocallimastix patriciarum) and a Saccharomyces cerevisiae fermentation product (yeast product) on ruminal fermentation characteristics, enteric methane (CH4) emissions and methanogenic community in growing goats. The experiment was conducted in a 5 × 5 Latin square design using five Xiangdong black wether goats. The treatments included a Control and two levels of cellulase (0.8 g and 1.6 g/kg dry matter intake (DMI), i.e. 194 U/kg and 389 U/kg DMI, respectively) crossed over with two levels (6 g or 12 g/kg DMI) of the yeast product. There were no significant differences regarding feed intake, apparent digestibility of organic matter, neutral detergent fibre and acid detergent fibre among all the treatments. In comparison with the Control, the ruminal ammonia N concentration was decreased (p = 0.001) by cellulase and yeast product addition. The activities of carboxymethylcellulase and xylanase were decreased after cellulase addition. Moreover, dietary cellulase and yeast product addition led to a significant reduction (p cellulase and yeast fermentation product can reduce the production of CH4 energy and mitigate the enteric CH4 emissions to a certain degree.

Pequi cake composition, hydrolysis and fermentation to bioethanol

Directory of Open Access Journals (Sweden)

A. L. Macedo

2011-03-01

Full Text Available Pequizeiro (Caryocar brasiliense Camb fruits have been evaluated as a potential raw material for the newly established biodiesel industry. This scenario demands applications using the solid co-product derived from the extraction of pequi oil, called cake or meal. This study analyses the acid hydrolysis of carbohydrates present in the pequi meal in order to obtain fermentable sugars and evaluates their conversion to bioethanol. There was 27% starch in the pequi meal. The use of a CCRD experimental design type to study the acid saccharification of pequi meal results in 61.6% conversion of its starch content to reducing sugars. Positive and significant linear effects were observed for H2SO4 concentration and temperature factors, while the quadratic effect of H2SO4 concentration and the linear effect of solid-liquid ratio were negative. Even, with non-optimized fermentative condition using 1% of dried baker's yeast in conical flasks, it was possible to obtain a value equivalent to 53 L of ethanol per ton of hydrolyzed pequi meal.

Lactose fermentation by engineered Saccharomyces cerevisiae capable of fermenting cellobiose.

Science.gov (United States)

Liu, Jing-Jing; Zhang, Guo-Chang; Oh, Eun Joong; Pathanibul, Panchalee; Turner, Timothy L; Jin, Yong-Su

2016-09-20

Lactose is an inevitable byproduct of the dairy industry. In addition to cheese manufacturing, the growing Greek yogurt industry generates excess acid whey, which contains lactose. Therefore, rapid and efficient conversion of lactose to fuels and chemicals would be useful for recycling the otherwise harmful acid whey. Saccharomyces cerevisiae, a popular metabolic engineering host, cannot natively utilize lactose. However, we discovered that an engineered S. cerevisiae strain (EJ2) capable of fermenting cellobiose can also ferment lactose. This finding suggests that a cellobiose transporter (CDT-1) can transport lactose and a β-glucosidase (GH1-1) can hydrolyze lactose by acting as a β-galactosidase. While the lactose fermentation by the EJ2 strain was much slower than the cellobiose fermentation, a faster lactose-fermenting strain (EJ2e8) was obtained through serial subcultures on lactose. The EJ2e8 strain fermented lactose with a consumption rate of 2.16g/Lh. The improved lactose fermentation by the EJ2e8 strain was due to the increased copy number of cdt-1 and gh1-1 genes. Looking ahead, the EJ2e8 strain could be exploited for the production of other non-ethanol fuels and chemicals from lactose through further metabolic engineering. Copyright © 2016 Elsevier B.V. All rights reserved.

Value addition of vegetable wastes by solid-state fermentation using Aspergillus niger for use in aquafeed industry.

Science.gov (United States)

Rajesh, N; Imelda-Joseph; Raj, R Paul

2010-11-01

Vegetable waste typically has high moisture content and high levels of protein, vitamins and minerals. Its value as an agricultural feed can be enhanced through solid-state fermentation (SSF). Two experiments were conducted to evaluate the nutritional status of the products derived by SSF of a mixture of dried vegetable waste powder and oil cake mixture (soybean flour, wheat flour, groundnut oil cake and sesame oil cake at 4:3:2:1 ratio) using fungi Aspergillus niger S(1)4, a mangrove isolate, and A. niger NCIM 616. Fermentation was carried out for 9 days at 35% moisture level and neutral pH. Significant (p<0.05) increase in crude protein and amino acids were obtained in both the trials. The crude fat and crude fibre content showed significant reduction at the end of fermentation. Nitrogen free extract (NFE) showed a gradual decrease during the fermentation process. The results of the study suggest that the fermented product obtained on days 6 and 9 in case of A. niger S(1)4 and A. niger NCIM 616 respectively contained the highest levels of crude protein. Copyright © 2010 Elsevier Ltd. All rights reserved.

Quality and Composition of Red Wine Fermented with Schizosaccharomyces pombe as Sole Fermentative Yeast, and in Mixed and Sequential Fermentations with Saccharomyces cerevisiae

Directory of Open Access Journals (Sweden)

Felipe Palomero

2014-01-01

Full Text Available This work examines the physiology of Schizosaccharomyces pombe (represented by strain 938 in the production of red wine, as the sole fermentative yeast, and in mixed and sequential fermentations with Saccharomyces cerevisiae 796. For further comparison, fermentations in which Saccharomyces cerevisiae was the sole fermentative yeast were also performed; in these fermentations a commercial lactic acid bacterium was used to perform malolactic fermentation once alcoholic fermentation was complete (unlike S. cerevisiae, the Sc. pombe performs maloalcoholic fermentation and therefore removes malic acid without such help. Relative density, acetic, malic and pyruvic acid concentrations, primary amino nitrogen and urea concentrations, and pH of the musts were measured over the entire fermentation period. In all fermentations in which Sc. pombe 938 was involved, nearly all the malic acid was consumed from an initial concentration of 5.5 g/L, and moderate acetic acid concentrations below 0.4 g/L were formed. The urea content of these wines was notably lower, showing a tenfold reduction when compared with those that were made with S. cerevisiae 796 alone. The sensorial properties of the different final wines varied widely. The wines fermented with Sc. pombe 938 had maximum aroma intensity and quality, and they were preferred by the tasters.

Protein concentrations of sweet soysauces from Rhizopus oryzae and R. oligosporus fermentation without moromi fermentation

Directory of Open Access Journals (Sweden)

NOOR SOESANTI HANDAJANI

2007-07-01

Full Text Available Soy sauce was produce from soybean that fermented with koji/tempeh fungi and thenfermented under salt solution or moromi fermentation. The objectives of this experiment was to compare of protein (total and soluble content of sweet soy sauce that produced from soybean fermented with Rhizopus oryzae and R. oligosporus without moromi fermentation to the sweet soysauce with moromi fermentation one. The total and soluble proteins of sweet soy sauces that produce from soybean without moromi fermentation were higher that sweet soy sauces that produce with moromi fermentation. Soluble protein of sweet soy sauce that produced from soybean fermented with R. oligosporus without moromi fermentation was 8.2% and meet to the highest quality of sweet soy sweet sauce based on Indonesia Industrial Standard. Soluble protein of sweet soy sauce that produced from soybean fermented with R. oryzae without moromi fermentation was 4.1% and meet to the medium quality of sweet soy sweet sauce based on Indonesia Industrial Standard.

Microencapsulation and Fermentation of Lactobacillus acidophilus LA-5 and Bifidobacterium BB-12

Directory of Open Access Journals (Sweden)

Maryam Yari

2015-09-01

Full Text Available Because of poor survival of probiotic bacteria, microencapsulation evolved from the immobilized cell culture technology used in the biotechnological industry. Two probiotic strains, Bifidobacterium (BB-12 and Lactobacillus acidophilus (LA-5 were immobilized in calcium alginate by extrusion method. Encapsulation parameters and efficacy of this method were evaluated. Growth factors of these two bacteria were also measured by culturing in 10-L fermenter. Growth curves were obtained with respect to optical density and dry biomass weight. Encapsulation yield was over than 60% in each experiment. Scanning electron microscopy (SEM of Entrapment of cells in alginate matrix and cross-sections of dried bead were obtained and illustrated. Bifidobacterium have been shown better biotechnological properties.

Anthology of dry storage solutions

Energy Technology Data Exchange (ETDEWEB)

Allimann, Nathalie; Otton, Camille [AREVA, Paris (France)

2012-03-15

Around 35,000 PWR, BWR or Veer used fuel elements with various enrichment value up to 5%, various cooling time down to 2 years and various burn-ups up to 60,000 Mwd/tU are currently stored in AREVA dry storage solutions. These solutions are delivered in the United States, in Japan and in many European countries like Belgium, Switzerland, Italy, Armenia and Germany. With more than 1000 dry storage solutions delivered all over the world AREVA is the leader on this market. Dealing with dry storage is not an easy task. Products have to be flexible, to be adapted to customer needs and to the national regulations which may stipulate very strict tests such as airplane crash or simulation of earthquake. To develop a dry storage solution for a foreign country means to deal with its national competent authorities. All the national competent authorities do not have the same requirements. Storage conditions may also be different.

Anthology of dry storage solutions

International Nuclear Information System (INIS)

Allimann, Nathalie; Otton, Camille

2012-01-01

Around 35,000 PWR, BWR or Veer used fuel elements with various enrichment value up to 5%, various cooling time down to 2 years and various burn-ups up to 60,000 Mwd/tU are currently stored in AREVA dry storage solutions. These solutions are delivered in the United States, in Japan and in many European countries like Belgium, Switzerland, Italy, Armenia and Germany. With more than 1000 dry storage solutions delivered all over the world AREVA is the leader on this market. Dealing with dry storage is not an easy task. Products have to be flexible, to be adapted to customer needs and to the national regulations which may stipulate very strict tests such as airplane crash or simulation of earthquake. To develop a dry storage solution for a foreign country means to deal with its national competent authorities. All the national competent authorities do not have the same requirements. Storage conditions may also be different

Steam pretreatment of dry and ensiled industrial hemp for ethanol production

Energy Technology Data Exchange (ETDEWEB)

Sipos, Balint; Reczey, Kati [Budapest University of Technology and Economics, Department of Applied Biotechnology and Food Science, Szt. Gellert ter 4., H-1111 Budapest (Hungary); Kreuger, Emma; Bjoernsson, Lovisa [Lund University, Department of Biotechnology, P.O. Box 124, SE-221 00 Lund (Sweden); Svensson, Sven-Erik [Swedish University of Agricultural Sciences, Department of Agriculture - Farming Systems, Technology and Product Quality, P.O. Box 104, SE-230 53 Alnarp (Sweden); Zacchi, Guido [Lund University, Department of Chemical Engineering, P.O. Box 124, SE-221 00 Lund (Sweden)

2010-12-15

Biomass can be converted into liquid and gaseous biofuels with good efficiency. In this study, the conversion of industrial hemp (Cannabis sativa L.), a biomass source that can be cultivated with a high biomass yield per hectare, was used. Steam pretreatment of dry and ensiled hemp was investigated prior to ethanol production. The pretreatment efficiency was evaluated in terms of sugar recovery and polysaccharide conversion in the enzymatic hydrolysis step. For both materials, impregnation with 2% SO{sub 2} followed by steam pretreatment at 210 C for 5 min were found to be the optimal conditions leading to the highest overall yield of glucose. Simultaneous saccharification and fermentation experiments carried out with optimised pretreatment conditions resulted in ethanol yields of 163 g kg{sup -1} ensiled hemp (dry matter) (71% of the theoretical maximum) and 171 g kg{sup -1} dry hemp (74%), which corresponds to 206-216 l Mg{sup -1} ethanol based on initial dry material. (author)

Fermented sausage production using E. faecium as starter culture: Physicochemical and microbiological profile, sensorial acceptance and cellular viability

Directory of Open Access Journals (Sweden)

Catharina Calochi Pires de Carvalho

2017-09-01

Full Text Available Fermented sausages are defined as a mixture of lean meat and fat, curing salts, sucrose and spices, stuffed in a natural or artificial casing and submitted to fermentation and air-drying process. Starter culture and ripening process may affect the quality and acceptability of the final product. Current research evaluates the use of Enterococcus faecium as starter culture in fermented sausage production and its physicochemical and microbiological profile during maturation process, coupled to sausage sensory acceptance after ripening. Enterococcus faecium showed 10.9 log CFU g-1 and remained viable after the ripening period with 8.32 log CFU g-1. Fermented sausage was monitored during the ripening period by physicochemical (pH control, water activity and weight loss and microbiological (analysis of coagulase-positive Staphylococcus, coliforms and Salmonella spp. analyses. All tests complied with standards established by Brazilian legislation and did not interfere in final product quality. Results showed that E. faecium was resistant to curing salt and sodium chloride, maintaining its viability during ripening and conferring beneficial effects on fermented sausage technological characteristics. E. faecium also proved to be in vitro resistant to simulate passage through the human digestive tract. Fermented sausage containing E. faecium had better sensory acceptance than commercial sausage evaluated.

Solid substrate fermentation

Energy Technology Data Exchange (ETDEWEB)

Tengerdy, R P

1985-04-01

Solid Substrate Fermentation (SSF) describes the microbiological tranformation of biological materials in their natural state, in contrast with liquid or submerged fermentations which are carried out in dilute solutions or slurries. The most important industrial microorganisms used in SSF are filamentous fungi and the critical factors in their growth are the control of the moisture level and the temperature. Traditionally, most SSFs are conducted in shallow trays (so that heat build up is avoided) and stacked in a moist chamber, however, the modern SSF should be able to mix large amounts of substrate for a uniform fermentation, maximum automization scale-up of the process, continuous operation and fermentation control and a promising new design is the Helical screw fermenter. At the present time SSF is used in the production of foods (e.g. mushrooms and oriental foods) in municipal, agricultural and industrial solid waste disposal and in the production of enzymes and speciality chemicals but it does not seem likely that it will replace prevalent liquid fermentation technologies. 29 references.

Enhancement of the proline and nitric oxide synthetic pathway improves fermentation ability under multiple baking-associated stress conditions in industrial baker's yeast.

Science.gov (United States)

Sasano, Yu; Haitani, Yutaka; Hashida, Keisuke; Ohtsu, Iwao; Shima, Jun; Takagi, Hiroshi

2012-04-01

During the bread-making process, industrial baker's yeast, mostly Saccharomyces cerevisiae, is exposed to baking-associated stresses, such as air-drying and freeze-thaw stress. These baking-associated stresses exert severe injury to yeast cells, mainly due to the generation of reactive oxygen species (ROS), leading to cell death and reduced fermentation ability. Thus, there is a great need for a baker's yeast strain with higher tolerance to baking-associated stresses. Recently, we revealed a novel antioxidative mechanism in a laboratory yeast strain that is involved in stress-induced nitric oxide (NO) synthesis from proline via proline oxidase Put1 and N-acetyltransferase Mpr1. We also found that expression of the proline-feedback inhibition-less sensitive mutant γ-glutamyl kinase (Pro1-I150T) and the thermostable mutant Mpr1-F65L resulted in an enhanced fermentation ability of baker's yeast in bread dough after freeze-thaw stress and air-drying stress, respectively. However, baker's yeast strains with high fermentation ability under multiple baking-associated stresses have not yet been developed. We constructed a self-cloned diploid baker's yeast strain with enhanced proline and NO synthesis by expressing Pro1-I150T and Mpr1-F65L in the presence of functional Put1. The engineered strain increased the intracellular NO level in response to air-drying stress, and the strain was tolerant not only to oxidative stress but also to both air-drying and freeze-thaw stresses probably due to the reduced intracellular ROS level. We also showed that the resultant strain retained higher leavening activity in bread dough after air-drying and freeze-thaw stress than that of the wild-type strain. On the other hand, enhanced stress tolerance and fermentation ability did not occur in the put1-deficient strain. This result suggests that NO is synthesized in baker's yeast from proline in response to oxidative stresses that induce ROS generation and that increased NO plays an important

Enhancement of the proline and nitric oxide synthetic pathway improves fermentation ability under multiple baking-associated stress conditions in industrial baker's yeast

Directory of Open Access Journals (Sweden)

Sasano Yu

2012-04-01

Full Text Available Abstract Background During the bread-making process, industrial baker's yeast, mostly Saccharomyces cerevisiae, is exposed to baking-associated stresses, such as air-drying and freeze-thaw stress. These baking-associated stresses exert severe injury to yeast cells, mainly due to the generation of reactive oxygen species (ROS, leading to cell death and reduced fermentation ability. Thus, there is a great need for a baker's yeast strain with higher tolerance to baking-associated stresses. Recently, we revealed a novel antioxidative mechanism in a laboratory yeast strain that is involved in stress-induced nitric oxide (NO synthesis from proline via proline oxidase Put1 and N-acetyltransferase Mpr1. We also found that expression of the proline-feedback inhibition-less sensitive mutant γ-glutamyl kinase (Pro1-I150T and the thermostable mutant Mpr1-F65L resulted in an enhanced fermentation ability of baker's yeast in bread dough after freeze-thaw stress and air-drying stress, respectively. However, baker's yeast strains with high fermentation ability under multiple baking-associated stresses have not yet been developed. Results We constructed a self-cloned diploid baker's yeast strain with enhanced proline and NO synthesis by expressing Pro1-I150T and Mpr1-F65L in the presence of functional Put1. The engineered strain increased the intracellular NO level in response to air-drying stress, and the strain was tolerant not only to oxidative stress but also to both air-drying and freeze-thaw stresses probably due to the reduced intracellular ROS level. We also showed that the resultant strain retained higher leavening activity in bread dough after air-drying and freeze-thaw stress than that of the wild-type strain. On the other hand, enhanced stress tolerance and fermentation ability did not occur in the put1-deficient strain. This result suggests that NO is synthesized in baker's yeast from proline in response to oxidative stresses that induce ROS

Enhancement of the proline and nitric oxide synthetic pathway improves fermentation ability under multiple baking-associated stress conditions in industrial baker's yeast

Science.gov (United States)

2012-01-01

Background During the bread-making process, industrial baker's yeast, mostly Saccharomyces cerevisiae, is exposed to baking-associated stresses, such as air-drying and freeze-thaw stress. These baking-associated stresses exert severe injury to yeast cells, mainly due to the generation of reactive oxygen species (ROS), leading to cell death and reduced fermentation ability. Thus, there is a great need for a baker's yeast strain with higher tolerance to baking-associated stresses. Recently, we revealed a novel antioxidative mechanism in a laboratory yeast strain that is involved in stress-induced nitric oxide (NO) synthesis from proline via proline oxidase Put1 and N-acetyltransferase Mpr1. We also found that expression of the proline-feedback inhibition-less sensitive mutant γ-glutamyl kinase (Pro1-I150T) and the thermostable mutant Mpr1-F65L resulted in an enhanced fermentation ability of baker's yeast in bread dough after freeze-thaw stress and air-drying stress, respectively. However, baker's yeast strains with high fermentation ability under multiple baking-associated stresses have not yet been developed. Results We constructed a self-cloned diploid baker's yeast strain with enhanced proline and NO synthesis by expressing Pro1-I150T and Mpr1-F65L in the presence of functional Put1. The engineered strain increased the intracellular NO level in response to air-drying stress, and the strain was tolerant not only to oxidative stress but also to both air-drying and freeze-thaw stresses probably due to the reduced intracellular ROS level. We also showed that the resultant strain retained higher leavening activity in bread dough after air-drying and freeze-thaw stress than that of the wild-type strain. On the other hand, enhanced stress tolerance and fermentation ability did not occur in the put1-deficient strain. This result suggests that NO is synthesized in baker's yeast from proline in response to oxidative stresses that induce ROS generation and that increased NO

Defective quiescence entry promotes the fermentation performance of bottom-fermenting brewer's yeast.

Science.gov (United States)

Oomuro, Mayu; Kato, Taku; Zhou, Yan; Watanabe, Daisuke; Motoyama, Yasuo; Yamagishi, Hiromi; Akao, Takeshi; Aizawa, Masayuki

2016-11-01

One of the key processes in making beer is fermentation. In the fermentation process, brewer's yeast plays an essential role in both the production of ethanol and the flavor profile of beer. Therefore, the mechanism of ethanol fermentation by of brewer's yeast is attracting much attention. The high ethanol productivity of sake yeast has provided a good basis from which to investigate the factors that regulate the fermentation rates of brewer's yeast. Recent studies found that the elevated fermentation rate of sake Saccharomyces cerevisiae species is closely related to a defective transition from vegetative growth to the quiescent (G 0 ) state. In the present study, to clarify the relationship between the fermentation rate of brewer's yeast and entry into G 0 , we constructed two types of mutant of the bottom-fermenting brewer's yeast Saccharomyces pastorianus Weihenstephan 34/70: a RIM15 gene disruptant that was defective in entry into G 0 ; and a CLN3ΔPEST mutant, in which the G 1 cyclin Cln3p accumulated at high levels. Both strains exhibited higher fermentation rates under high-maltose medium or high-gravity wort conditions (20° Plato) as compared with the wild-type strain. Furthermore, G 1 arrest and/or G 0 entry were defective in both the RIM15 disruptant and the CLN3ΔPEST mutant as compared with the wild-type strain. Taken together, these results indicate that regulation of the G 0 /G 1 transition might govern the fermentation rate of bottom-fermenting brewer's yeast in high-gravity wort. Copyright © 2016 The Society for Biotechnology, Japan. Published by Elsevier B.V. All rights reserved.

Yeasts and lactic acid bacteria microbiota from masau (Ziziphus mauritiana) fruits and their fermented fruit pulp in Zimbabwe

NARCIS (Netherlands)

Nyanga, L.K.; Nout, M.J.R.; Gadaga, T.H.; Theelen, R.M.C.; Boekhout, T.; Zwietering, M.H.

2007-01-01

Masau are Zimbabwean wild fruits, which are usually eaten raw and/ or processed into products such as porridge, traditional cakes, mahewu and jam. Yeasts, yeast-like fungi, and lactic acid bacteria present on the unripe, ripe and dried fruits, and in the fermented masau fruits collected from

Viability of L. casei during fermentation in soymilk and freeze-dried soymilk; effect of cryoprotectant, rehydration and storage temperature

OpenAIRE

Kristina Mladenovska; Tanja Petreska Ivanovska; Maja Jurhar Pavlova; Milena Petrovska; Angela Delova; Lidija Petrusevska Tozi; Lela Acevska

2005-01-01

The aim of the work was to investigate the behaviour of L. casei and the effect of sorbitol on its viability during fermentation in soymilk drink. Values for pH, ranging from 6.82 to 3.42 in the soymilk drink without sorbitol and from 6.74 to 3.41 in the drink with sorbitol were noted during 72 h of fermentation at 25oC. The corresponding values for titratable acidity ranged from 0.071% to 0.758% and from 0.073% to 0.761%, respectively. Soymilk was found to support the growth of L. case...

In vitro digestion and fermentation characteristics of canola co-products simulate their digestion in the pig intestine.

Science.gov (United States)

Woyengo, T A; Jha, R; Beltranena, E; Zijlstra, R T

2016-06-01

Canola co-products are sources of amino acid and energy in pig feeds, but their fermentation characteristics in the pig intestine are unknown. Thus, we determined the in vitro fermentation characteristics of the canola co-products Brassica juncea solvent-extracted canola meal (JSECM), Brassica napus solvent-extracted canola meal (NSECM), B. napus expeller-pressed canola meal (NEPCM) and B. napus cold-pressed canola cake (NCPCC) in comparison with soybean meal (SBM). Samples were hydrolysed in two steps using pepsin and pancreatin. Subsequently, residues were incubated in a buffer solution with fresh pig faeces as inocula for 72 h to measure gas production. Concentration of volatile fatty acids (VFA) per gram of dry matter (DM) of feedstuff was measured in fermented solutions. Apparent ileal digestibility (AID) and apparent hindgut fermentation (AHF) of gross energy (GE) for feedstuffs were obtained from pigs fed the same feedstuffs. On DM basis, SBM, JSECM, NSECM, NEPCM and NCPCC contained 15, 19, 22, 117 and 231 g/kg ether extract; and 85, 223, 306, 208 and 176 g/kg NDF, respectively. In vitro digestibility of DM (IVDDM) of SBM (82.3%) was greater (Pfermentation characteristics of canola co-products and SBM simulated their fermentation in the small and large intestine of pigs, respectively. The 30% greater VFA production for JSECM than NSECM due to lower lignified fibre of JSECM indicates that fermentation characteristics differ between canola species. The NSECM had the highest fermentability followed by NEPCM and then NCPCC, indicating that fat in canola co-products can limit their fermentability in the hindgut.

Soybean meal fermented by Aspergillus awamori increases the cytochrome P-450 content of the liver microsomes of mice.

Science.gov (United States)

Kishida, T; Ataki, H; Takebe, M; Ebihara, K

2000-04-01

The effect of soybean meal fermented by Aspergillus awamori on the acute lethality of acetaldehyde, pentobarbital sleeping time, and cytochrome P-450 content of the hepatic microsomes was studied in mice. Most of the daidzin and genistin in soybean meal (SBM) were converted into the respective aglycones, daidzein and genistein, by fermentation. In experiment 1, mice were fed isonitrogenic test diets with one of the following five protein sources for 28 d: casein, SBM, fermented and hot-air-dried SBM (FSBM-HD), fermented and freeze-dried SBM (FSBM-FD), or methanol-extracted FSBM-FD (FSMB-FD-R). The acute lethality of acetaldehyde in mice fed the FSBM-FD diet was significantly lower than that in mice fed the SBM, FSBM-HD, or FSBM-FD-R diet. In experiments 2 and 3, mice were fed isonitrogenic test diets with one of the following four protein sources for 28 d: casein, SBM, FSBM-FD, and FSBM-FD-R. The pentobarbital sleeping time was significantly shorter and the cytochrome P-450 content was significantly higher in the mice fed the FSBM-FD diet than the respective value in mice fed the other test diets. In experiment 4, mice were fed one of eight diets which contained different levels of aglycone obtained by varying the proportion of FSBM-FD and FSBM-FD-R, for 28 d. The cytochrome P-450 content in hepatic microsomes increased as the dietary level of isoflavonoid aglycones increased, but there was a saturation phenomenon. These results suggest that soy isoflavonoid aglycones are more potent inducers of cytochrome P-450 than isoflavonoid glycosides.

A bilberry drink with fermented oatmeal decreases postprandial insulin demand in young healthy adults

Directory of Open Access Journals (Sweden)

Björck Inger ME

2011-05-01

Full Text Available Abstract Background in traditional medicine, blueberries have been used to facilitate blood glucose regulation in type 2 diabetes. Recent studies in diabetic mice have indicated facilitated glycaemic regulation following dietary supplementation with extracts from European blueberries, also called bilberries, (Vaccinium myrtillus. The purpose of the present study was to investigate the impact of fermented oat meal drinks containing bilberries or rosehip (Rosa canina on glycaemic and insulinaemic responses. Methods glycaemic and insulinaemic responses in young healthy adults were measured in two series. In series 1, two drinks based on oat meal (5%, fermented using Lactobacillus plantarum 299v, and added with fruit (10%; bilberries (BFOMD or rose hip (RFOMD respectively, were studied. In series 2, BFOMD was repeated, additionally, a drink enriched with bilberries (47% was tested (BBFOMD. As control a fermented oat meal drink (FOMD was served. Results in series 1 the bilberry- and rosehip drinks, gave high glucose responses similar to that after the reference bread. However, the insulin index (II after the BFOMD was significantly lower (II = 65 (P Conclusion a fermented oat meal drink added with bilberries induced a lower insulin response than expected from the glycaemic response. The mechanism for the lowered acute insulin demand is still unclear, but may be related to some bio-active component present in the bilberries, or to the fermented oat meal base.

Effect of initial ph on growth characteristics and fermentation properties of Saccharomyces cerevisiae.

Science.gov (United States)

Liu, Xingyan; Jia, Bo; Sun, Xiangyu; Ai, Jingya; Wang, Lihua; Wang, Cheng; Zhao, Fang; Zhan, Jicheng; Huang, Weidong

2015-04-01

As the core microorganism of wine making, Saccharomyces cerevisiae encounter low pH stress at the beginning of fermentation. Effect of initial pH (4.50, 3.00, 2.75, 2.50) on growth and fermentation performance of 3 S. cerevisiae strains Freddo, BH8, Nº.7303, different tolerance at low pH, chosen from 12 strains, was studied. The values of yeast growth (OD600 , colony forming units, cell dry weight), fermentation efficiency (accumulated mass loss, change of total sugar concentration), and fermentation products (ethanol, glycerol, acetic acid, and l-succinic acid) at different pH stress were measured. The results showed that the initial pH of must was a vital factor influencing yeast growth and alcoholic fermentation. Among the 3 strains, strain Freddo and BH8 were more tolerant than Nº.7303, so they were affected slighter than the latter. Among the 4 pH values, all the 3 strains showed adaptation even at pH 2.50; pH 2.75 and 2.50 had more vital effect on yeast growth and fermentation products in contrast with pH 4.50 and 3.00. In general, low initial pH showed the properties of prolonging yeast lag phase, affecting accumulated mass loss, changing the consumption rate of total sugar, increasing final content of acetic acid and glycerol, and decreasing final content of ethanol and l- succinic acid, except some special cases. Based on this study, the effect of low pH on wine products would be better understood and the tolerance mechanism of low pH of S. cerevisiae could be better explored in future. © 2015 Institute of Food Technologists®

Production and optimization of carotenoid-enriched dried distiller's grains with solubles by Phaffia rhodozyma and Sporobolomyces roseus fermentation of whole stillage.

Science.gov (United States)

Ananda, Nanjundaswamy; Vadlani, Praveen V

2010-11-01

Whole stillage--a co-product of grain-based ethanol--is used as an animal feed in the form of dried distiller's grain with solubles (DDGS). Since animals cannot synthesize carotenoids and animal feed is generally poor in carotenoids, about 30-120 ppm of total carotenoids are added to animal feed to improve animal health, enhance meat color and quality, and increase vitamin A levels in milk and meat. The main objective of this study was to produce carotenoid (astaxanthin and β-carotene)-enriched DDGS by submerged fermentation of whole stillage. Mono- and mixed cultures of red yeasts, Phaffia rhodozyma (ATCC 24202) and Sporobolomyces roseus (ATCC 28988), were used to produce astaxanthin and β-carotene. Media optimization was carried out in shake flasks using response surface methodology (RSM). Macro ingredients, namely whole stillage, corn steep liquor and glycerol, were fitted to a second-degree polynomial in RSM. Under optimized conditions, astaxanthin and β-carotene yields in mixed culture and P. rhodozyma monoculture were 5 and 278, 97, and 275 μg/g, respectively, while S. roseus produced 278 μg/g of β-carotene. Since the carotenoid yields are almost twice the quantity used in animal feed, the carotenoid-enriched DDGS has potential application as "value-added animal feed or feed blends."

Influence of meat source, pH and production time on zinc protoporphyrin IX formation as natural colouring agent in nitrite-free dry fermented sausages.

Science.gov (United States)

De Maere, Hannelore; Chollet, Sylvie; De Brabanter, Jos; Michiels, Chris; Paelinck, Hubert; Fraeye, Ilse

2018-01-01

Nitrite is commonly used in meat products due to its plural technological advantages. However, it is controversial because of its detrimental side effects on health. Within the context of nitrite reduction, zinc protoporphyrin IX (Zn(II)PPIX) formation in meat products as natural red colouring agent has been suggested. This investigation presents the evaluation of naturally occurring pigments, namely Zn(II)PPIX, protoporphyrin IX (PPIX) and heme in nitrite-free dry fermented sausages in function of time, meat source (pork, horsemeat and a combination of both meat sources) and pH condition. In function of time, Zn(II)PPIX and PPIX were formed and heme content decreased. Higher pH conditions promoted Zn(II)PPIX and PPIX formation, whereas the influence of pH on heme was less clear. The use of horsemeat also promoted Zn(II)PPIX formation. Moreover, even similar amounts were formed when it was combined with pork. Product redness, however, could not be related to Zn(II)PPIX formation. Copyright © 2017 Elsevier Ltd. All rights reserved.

Enzymes in Fermented Fish.

Science.gov (United States)

Giyatmi; Irianto, H E

Fermented fish products are very popular particularly in Southeast Asian countries. These products have unique characteristics, especially in terms of aroma, flavor, and texture developing during fermentation process. Proteolytic enzymes have a main role in hydrolyzing protein into simpler compounds. Fermentation process of fish relies both on naturally occurring enzymes (in the muscle or the intestinal tract) as well as bacteria. Fermented fish products processed using the whole fish show a different characteristic compared to those prepared from headed and gutted fish. Endogenous enzymes like trypsin, chymotrypsin, elastase, and aminopeptidase are the most involved in the fermentation process. Muscle tissue enzymes like cathepsins, peptidases, transaminases, amidases, amino acid decarboxylases, glutamic dehydrogenases, and related enzymes may also play a role in fish fermentation. Due to the decreased bacterial number during fermentation, contribution of microbial enzymes to proteolysis may be expected prior to salting of fish. Commercial enzymes are supplemented during processing for specific purposes, such as quality improvement and process acceleration. In the case of fish sauce, efforts to accelerate fermentation process and to improve product quality have been studied by addition of enzymes such as papain, bromelain, trypsin, pepsin, and chymotrypsin. © 2017 Elsevier Inc. All rights reserved.

Near infra-red characterization of changes in flavan-3-ol derivatives in cocoa (Theobroma cacao L.) as a function of fermentation temperature.

Science.gov (United States)

Hue, Clotilde; Brat, Pierre; Gunata, Ziya; Samaniego, Ivan; Servent, Adrien; Morel, Gilles; Kapitan, André; Boulanger, Renaud; Davrieux, Fabrice

2014-10-15

Flavan-3-ols were successfully extracted from cocoa by the Fast-Prep device and analyzed by HPLC-DAD, and their identifications were confirmed by injection of authentic standards. (-)-Epicatechin was the most abundant component with an average of 9.4 mg/g dried cocoa powder. More than 700 cocoa samples were used to calibrate the NIRS. An efficient calibration model was developed to accurately determine any flavan-3-ol compound of ground dried cocoa beans (SEP = 2.33 mg/g in the case of total flavan-3-ols). This performance enabled NIRS to be used as an efficient and easy-to-use tool for estimating the level of targeted compounds. The analysis of the PLS loadings of the model and pure epicatechin spectra gave proof that NIRS was calibrated on an indirect strong correlation resulting in the changes in flavan-3-ols during fermentation and their interaction with some major components, such as proteins. Total flavan-3-ol concentration fell from an average of 33.3 mg/g for unfermented samples to an average of 6.2 mg/g at the end of fermentation. Changes in flavan-3-ol content were dependent upon the origin and highly correlated to the fermentation level expressed as the sum of temperatures (average R(2) = 0.74), a good marker of the fermentation process and of the heterogeneity of the batch.

Efficacy of different methanolic plant extracts on anti-methanogenesis, rumen fermentation and gas production kinetics in vitro.

Science.gov (United States)

Sirohi, S K; Goel, N; Pandey, P

2012-01-01

The present study was carried out to evaluate the effect of methanolic extracts of three plants, mehandi (Lawsonia inermis), jaiphal (Myristica fragrans) and green chili (Capsicum annuum) on methanogenesis, rumen fermentation and fermentation kinetic parameters by in vitro gas production techniques. Single dose of each plant extract (1 ml / 30 ml buffered rumen fluid) and two sorghum fodder containing diets (high and low fiber diets) were used for evaluating the effect on methanogenesis and rumen fermentation pattern, while sequential incubations (0, 1, 2, 3, 6 9, 12, 24, 36, 48, 60, 72 and 96 h) were carried out for gas production kinetics. Results showed that methane production was reduced, ammonia nitrogen was increased significantly, while no significant effect was found on pH and protozoal population following addition of different plant extracts in both diets except mehandi. Green chili significantly reduced digestibility of dry matter, total fatty acid and acetate concentration at incubation with sorghum based high and low fiber diets. Among all treatments, green chili increased potential gas production, while jaiphal decreased the gas production rate constant significantly. The present results demonstrate that methanolic extracts of different plants are promising rumen modifying agents. They have the potential to modulate the methane production, potential gas production, gas production rate constant, dry matter digestibility and microbial biomass synthesis.

Probiotic fermented dairy products

OpenAIRE

Adnan Tamime; Rajka Božanić; Irena Rogelj

2003-01-01

Fermented dairy products are the most popular vehicle used in theindustry for the implantation of the probiotic microflora in humans. Therefore this paper provides an overview of new knowledge on probiotic fermented dairy products. It involves historical developments, commercial probiotic microorganisms and products, and their therapeutic properties, possibilities of quality improvement of different types of newly developed fermented dairy products together with fermented goat’s milk products.

Dried sausages fermented with Staphylococcus xylosus at different temperatures and with different ingredient levels

DEFF Research Database (Denmark)

Waade, C.; Waade, Charlotte

1997-01-01

Sausages with added Staphylococcus xylosus were fermented at different temperatures and with different added levels of salt, glucose, nitrite, nitrate and Pediococcus pentosaceus in accordance with a six-factor fractional design. The amounts of individual amino acids were measured and the effects...... that the amounts of the volatile compounds, 2-methyl propanal, 2- and 3-methyl butanal, were inversely correlated with the amounts of valine, isoleucine and leucine, respectively, indicating that those volatiles were degradation products of the latter. (C) 1997 Elsevier Science Ltd....

Glycerol production by fermenting yeast cells is essential for optimal bread dough fermentation.

Science.gov (United States)

Aslankoohi, Elham; Rezaei, Mohammad Naser; Vervoort, Yannick; Courtin, Christophe M; Verstrepen, Kevin J

2015-01-01

Glycerol is the main compatible solute in yeast Saccharomyces cerevisiae. When faced with osmotic stress, for example during semi-solid state bread dough fermentation, yeast cells produce and accumulate glycerol in order to prevent dehydration by balancing the intracellular osmolarity with that of the environment. However, increased glycerol production also results in decreased CO2 production, which may reduce dough leavening. We investigated the effect of yeast glycerol production level on bread dough fermentation capacity of a commercial bakery strain and a laboratory strain. We find that Δgpd1 mutants that show decreased glycerol production show impaired dough fermentation. In contrast, overexpression of GPD1 in the laboratory strain results in increased fermentation rates in high-sugar dough and improved gas retention in the fermenting bread dough. Together, our results reveal the crucial role of glycerol production level by fermenting yeast cells in dough fermentation efficiency as well as gas retention in dough, thereby opening up new routes for the selection of improved commercial bakery yeasts.

Increasing the yeast yield in alcohol fermentation

Energy Technology Data Exchange (ETDEWEB)

Pelc, A; Vamos, E; Varga, L; Gavalya, S; Dolanszky, F

1964-02-01

The yeast and ethanol yields (the latter being based on the substrate) are enhanced by adding the substrate (molasses) gradually to the suspension of inoculating yeast during the main fermentation period, passing air through the mash, ceasing both substrate addition and aeration at the end of the main period, and allowing the process to come to an end. This way 12 to 14 kg yeast (dry weight)/100 l ethanol could be obtained within 16 to 24 hours and the yeast obtained could be used as the inoculum for the next charge. For example: 11 to 16 kg yeast (or 18 to 25 l yeast suspension from the preceding charge, containing 18 to 20% dry matter) is kept in 30 to 35 l H/sub 2/SO/sub 4/ (0.74 g/100 ml) for 1 hour, diluted with H/sub 2/O and 30 kg sterile molasses to 300 l, kept at 30 to 32/sup 0/ with mild aeration for 2 hours, 1900 l 30/sup 0/ H/sub 2/O added, then 1 m/sup 3/ air/m/sup 2//hour is passed through the mixture, with the addition of 270 kg sterile molasses, and a solution of 8 kg superphosphate and 5 kg (NH/sub 4/)/sub 2/SO/sub 4/ in 100 l H/sub 2/O, the latter being added in 5 portions over 2 hours. Molasses (600 kg) is added during the main period, maintaining the pH at 5 (H/sub 2/SO/sub 4/), and the temperature at 30/sup 0/, then aeration is ceased and the mixture kept until fermentation proceeds. The 3000 l medium contains 9.6% ethanol and 1.38% yeast, respectively.

Optimization of Bacillus aerius strain JS-786 cell dry mass and its antifungal activity against Botrytis cinerea using response surface methodology

Directory of Open Access Journals (Sweden)

Shafi Jamil

2017-01-01

Full Text Available The optimization of fermentation conditions is necessary for field application of biological control agents. The present study was designed to optimize the fermentation conditions for the Bacillus aerius strain, JS-786 in terms of cell dry mass and its antifungal activity against Botrytis cinerea with response surface methodology. A strain of bacteria with strong antifungal activity was isolated from the phyllosphere of tomato plant and identified as B. aerius JS-786 based on the sequence homology of its 16S rRNA gene. After the success of preliminary antifungal activity tests, response surface methodology was used to optimize the fermentation conditions (medium pH, gelatin percentage, incubation period, rotatory speed and incubation temperature to maximize the cell dry mass and antifungal activity against B. cinerea. A 25 factorial central composite design was employed and multiple response optimization was used to determine the desirability of the operation. The results of regression analysis showed that at the individual level, all of the experimental parameters were significant for cell dry mass; significant results were obtained for antifungal activity pH, incubation period, rotatory speed and incubation temperature. The interactive effect of the incubation period, rotatory speed and incubation temperature was significant. Maximum cell dry mass (8.7 g/L and inhibition zone (30.4 mm were obtained at pH 6.4, gelatin 3.2%, incubation period 36.92 h, rotatory speed 163 rpm, and temperature 33.5°C. This study should help to formulate a more rational and cost-effective biological product both in terms of bacterial growth and antifungal activity.

Effect of fermentation media on the production, efficacy and storage stability of Metarhizium brunneum microsclerotia formulated as a prototype granule

Science.gov (United States)

New liquid fermentation techniques for the production of the bioinsecticidal fungus Metarhizium brunneum strain F-52 have resulted in the formation of microsclerotia (MS), a compact, melonized-hyphal structure capable of surviving desiccation and formulation as dry granules. When rehydrated, these M...

EFFECT OF FERMENTED CACAO POD SUPPLEMENTATION ON SHEEP RUMEN MICROBIAL FERMENTATION

Directory of Open Access Journals (Sweden)

S. Wulandari

2015-09-01

Full Text Available The objective of this research was to improve beneficial value of cacao pod as sheep feedingredients comprising up to 50% total feed. This research was conducted in two stages. Stage 1 wascacao pod fermentation. Completely randomized design with 3x3 factorial patterns was used in thisstage, in which factor I was microbial inoculum dosage of 0%, 0.05% and 0.1% and factor II wasincubation period of 0, 3 and 6 days. Result demonstrated that six-day fermentation with 0.05%microbial inoculum could lower cacao NDF, ADF and theobromine. The optimum inoculum dosage andfermentation time from stage 1 was applied to stage 2. Stage 2 was rumen microbial fermentation test.This research administrated 3x3 of latin square design. In period I sheep were fed with CF0 (nonfermentedcomplete feed, in period II sheep were given CF 1 (complete feed containing fermentedcacao pod and in period III sheep were given CF2 (fermented complete feed based cacao pod. Resultdemonstrated that pH value of sheep microbial liquid in treatment of CF0, CF1 and CF2 was in normalpH range and did not affect volatile fatty acids (VFA and ammonia. In conclusion, supplementing up to 50% of feed with complete feed containing fermented or non-fermented cacao pod did not affect theprocess of rumen microbial fermentation.

Enhanced viability of Lactobacillus reuteri for probiotics production in mixed solid-state fermentation in the presence of Bacillus subtilis.

Science.gov (United States)

Zhang, Yi-Ran; Xiong, Hai-Rong; Guo, Xiao-Hua

2014-01-01

In order to develop a multi-microbe probiotic preparation of Lactobacillus reuteri G8-5 and Bacillus subtilis MA139 in solid-state fermentation, a series of parameters were optimized sequentially in shake flask culture. The effect of supplementation of B. subtilis MA139 as starters on the viability of L. reuteri G8-5 was also explored. The results showed that the optimized process was as follows: water content, 50 %; initial pH of diluted molasses, 6.5; inocula volume, 2 %; flask dry contents, 30∼35 g/250 g without sterilization; and fermentation time, 2 days. The multi-microbial preparations finally provided the maximum concentration of Lactobacillus of about 9.01 ± 0.15 log CFU/g and spores of Bacillus of about 10.30 ± 0.08 log CFU/g. Compared with pure fermentation of L. reuteri G8-5, significantly high viable cells, low value of pH, and reducing sugar in solid substrates were achieved in mixed fermentation in the presence of B. subtilis MA139 (P fermentation showed the significantly higher antimicrobial activity against E. coli K88 (P solid-state fermentation with low cost. Moreover, the viability of L. reuteri G8-5 could be significantly enhanced in the presence of B. subtilis MA139 in solid-state fermentation, which favored the production of probiotics for animal use.

An optimization study of solid-state fermentation: xanthophylls extraction from marigold flowers.

Science.gov (United States)

Luis, Navarrete-Bolaños José; Hugo, Jiménez-Islas; Enrique, Botello-Alvarez; Ramiro, Rico-Martínez; Octavio, Paredes-López

2004-09-01

Marigold flowers are the main natural source of xanthophylls, and marigold saponified extract is used as an additive in several food and pharmaceutical industries. In this work, the use of a solid-state fermentation (ensilage) process for increasing the yield of xanthophylls extracted from fermented marigold flowers was examined. The process consisted of a mixed culture of three microorganisms (Flavobacterium IIb, Acinetobacter anitratus, and Rhizopus nigricans), part of the normal microbiota associated with the marigold flower. These microorganisms had been previously isolated, and were identified as relevant for the ensilage process due to their capacity to produce cellulolytic enzymes. Based on experimental design strategies, optimum operation values were determined for aeration, moisture, agitation, and marigold-to-inoculum ratio in the proposed solid-state fermentation equipment, leading to a xanthophylls yield of 17.8-g/kg dry weight. The optimum achieved represents a 65% increase with respect to the control. HPLC analysis indicated conservation of extracted oleoresin. Based on the experimental results, interactions were identified that could be associated with the heat and mass-transfer reactions taking place within the bioreactor. The insight gained allows conditions that limit growth and metabolic activity to be avoided.

A field survey on coffee beans drying methods of Indonesian small holder farmers

Science.gov (United States)

Siagian, Parulian; Setyawan, Eko Y.; Gultom, Tumiur; Napitupulu, Farel H.; Ambarita, Himsar

2017-09-01

Drying agricultural product is a post-harvest process that consumes significant energy. It can affect the quality of the product. This paper deals with literature review and field survey of drying methods of coffee beans of Indonesia farmers. The objective is to supply the necessary information on developing continuous solar drier. The results show that intermittent characteristic of sun drying results in a better quality of coffee beans in comparison with constant convective drying. In order to use energy efficiently, the drying process should be divided into several stages. In the first stage when the moist content is high, higher drying air temperature is more effective. After this step, where the moist content is low, lower drying air temperature is better. The field survey of drying coffee beans in Sumatera Utara province reveals that the used drying process is very traditional. It can be divided into two modes and depend on the coffee beans type. The Arabica coffee is firstly fermented and dried to moisture content of 80% using sun drying method, then followed by Green House model of drying up to moisture content about 12%. The latter typically spends 3 days of drying time. On the other hand, The Robusta coffee is dried by exposing to the sun directly without any treatment. After the coffee beans dried follow by peeled process. These findings can be considered to develop a continuous solar drying that suitable for coffee beans drying.

Effect of Crude Protein Levels in Concentrate and Concentrate Levels in Diet on Fermentation

Directory of Open Access Journals (Sweden)

Dinh Van Dung

2014-06-01

Full Text Available The effect of concentrate mixtures with crude protein (CP levels 10%, 13%, 16%, and 19% and diets with roughage to concentrate ratios 80:20, 60:40, 40:60, and 20:80 (w/w were determined on dry matter (DM and organic matter (OM digestibility, and fermentation metabolites using an in vitro fermentation technique. In vitro fermented attributes were measured after 4, 24, and 48 h of incubation respectively. The digestibility of DM and OM, and total volatile fatty acid (VFA increased whereas pH decreased with the increased amount of concentrate in the diet (p<0.001, however CP levels of concentrate did not have any influence on these attributes. Gas production reduced with increased CP levels, while it increased with increasing concentrate levels. Ammonia nitrogen (NH3-N concentration and microbial CP production increased significantly (p<0.05 by increasing CP levels and with increasing concentrate levels in diet as well, however, no significant difference was found between 16% and 19% CP levels. Therefore, 16% CP in concentrate and increasing proportion of concentrate up to 80% in diet all had improved digestibility of DM and organic matter, and higher microbial protein production, with improved fermentation characteristics.

The opportunities for obtaining of the biogas on methane fermentation from marine algae biomass and water plant biomass

OpenAIRE

Jachniak Ewa; Chmura Joanna; Kuglarz Mariusz; Wiktor Józef

2018-01-01

The aim of the research was to try to obtain of the biogas on a laboratory scale from marine algae biomass and water plant biomass. The research was conducted in 2016 year and samples were taken from the Polish coast of the Baltic Sea. In laboratory work, algae and plant species were first identified. The next, in order to subject them to methane fermentation processes and to obtain biogas,partial mechanical treatment of the biomass was conducted. Dry matter content and dry organic matter con...

Fermentation performance optimization in an ectopic fermentation system.

Science.gov (United States)

Yang, Xiaotong; Geng, Bing; Zhu, Changxiong; Li, Hongna; He, Buwei; Guo, Hui

2018-07-01

Ectopic fermentation systems (EFSs) were developed for wastewater treatment. Previous studies have investigated the ability of thermophilic bacteria to improve fermentation performance in EFS. Continuing this research, we evaluated EFS performance using principle component analysis and investigated the addition of different proportions of cow dung. Viable bacteria communities were clustered and identified using BOX-AIR-based repetitive extragenic palindromic-PCR and 16S rDNA analysis. The results revealed optimal conditions for the padding were maize straw inoculated with thermophilic bacteria. Adding 20% cow dung yielded the best pH values (6.94-8.56), higher temperatures, increased wastewater absorption, improved litter quality, and greater microbial quantities. The viable bacteria groups were enriched by the addition of thermophilic consortium, and exogenous strains G21, G14, G4-1, and CR-15 were detected in fermentation process. The proportion of Bacillus species in treatment groups reached 70.37% after fermentation, demonstrating that thermophilic bacteria, especially Bacillus, have an important role in EFS, supporting previous predictions. Copyright © 2018 Elsevier Ltd. All rights reserved.

Growth performance, rumen fermentation, nutrient utilization, and metabolic profile of dairy heifers limit-fed distillers dried grains with ad libitum forage.

Science.gov (United States)

Manthey, A K; Anderson, J L

2018-01-01

The objective of this study was to determine the effects of feeding a corn- and soybean-product-based concentrate mix or distillers dried grains with solubles concentrate mix with ad libitum grass hay to dairy heifers. A 16-wk randomized complete block design study was conducted using 24 heifers [18 Holstein and 6 Brown Swiss; 219 ± 2 d of age (±standard deviation); 230 ± 4 kg of body weight] to evaluate the effect of diet on dry matter intake (DMI), growth performance, rumen fermentation, metabolic profile, and nutrient digestibility. Treatments were (1) corn and soybean product concentrate mix, and (2) distillers-dried-grains-with-solubles-based concentrate mix (DDG). Both concentrate mixes were limit-fed at 0.8% of body weight and grass hay was offered ad libitum. Heifers were individually fed using Calan gates and orts were recorded daily at feeding. Heifers were weighed every 2 wk and ration concentrate mix offered was adjusted accordingly. Frame measurements and body condition score were recorded every 2 wk. Rumen fluid was collected via esophageal tubing during wk 12 and 16 for pH, ammonia N, and volatile fatty acid analysis. Jugular blood samples were collected every 4 wk for metabolite and metabolic hormone analysis. Total-tract digestibility of nutrients was evaluated during wk 16 by fecal grab sampling. No treatment by week interactions were observed for any of the growth measurements and growth measurements and DMI did not differ between treatments. A treatment by time interaction was observed for rumen butyrate percentage with heifers fed DDG having a greater percentage. Total volatile fatty acid concentration, acetate molar percentage, and acetate:propionate decreased with the DDG treatment, whereas propionate molar percentage increased. No treatment by week interactions were observed for any of the metabolites or metabolic hormones measured. A tendency was observed for glucose and plasma urea nitrogen concentration to decrease with DDG. Plasma

Spray-dried adjunct cultures of autochthonous non-starter lactic acid bacteria.

Science.gov (United States)

Peralta, Guillermo H; Bergamini, Carina V; Audero, Gabriela; Páez, Roxana; Wolf, I Verónica; Perotti, M Cristina; Hynes, Erica R

2017-08-16

Spray-drying of lactic cultures provides direct-to-vat starters, which facilitate their commercialization and use. However, this process may alter the metabolic activity and deteriorate technological features. In this work, we assessed the influence of spray-drying on the survival and aroma production of two strains of mesophilic lactobacilli: Lactobacillus paracasei 90 and Lactobacillus plantarum 91, which have already been characterized as good adjunct cultures. The spray-drying was carried out using a laboratory scale spray and the dried cultures were monitored during the storage for the survival rate. The dried cultures were applied to two cheese models: sterile cheese extract and miniature soft cheese. The influence on the carbohydrate metabolism and the production of organic acids and volatile compounds was determined. Both strains retained high levels of viable counts in the powder after drying and during the storage at 5°C for twelve months. In addition, they also remained at high level in both cheese models during incubation or ripening. Similar profiles of carbohydrate fermentation and bioformation of volatile compounds were observed in the cheese extracts for each of the strains when tested as both fresh and dried cultures. In addition, the ability of Lb. paracasei 90 to increase the production of acetoin and diacetyl remarkably in cheese models was also confirmed for the spray-dried culture. Copyright © 2017 Elsevier B.V. All rights reserved.

Glycerol production by fermenting yeast cells is essential for optimal bread dough fermentation.

Directory of Open Access Journals (Sweden)

Elham Aslankoohi

Full Text Available Glycerol is the main compatible solute in yeast Saccharomyces cerevisiae. When faced with osmotic stress, for example during semi-solid state bread dough fermentation, yeast cells produce and accumulate glycerol in order to prevent dehydration by balancing the intracellular osmolarity with that of the environment. However, increased glycerol production also results in decreased CO2 production, which may reduce dough leavening. We investigated the effect of yeast glycerol production level on bread dough fermentation capacity of a commercial bakery strain and a laboratory strain. We find that Δgpd1 mutants that show decreased glycerol production show impaired dough fermentation. In contrast, overexpression of GPD1 in the laboratory strain results in increased fermentation rates in high-sugar dough and improved gas retention in the fermenting bread dough. Together, our results reveal the crucial role of glycerol production level by fermenting yeast cells in dough fermentation efficiency as well as gas retention in dough, thereby opening up new routes for the selection of improved commercial bakery yeasts.

Bioconversion and enzymatic activities of neurospora sitophila grown under solid state and submerged fermentation on Sago Hamps

International Nuclear Information System (INIS)

Shojaosadati, S. A.; Vikineswary, S.; Looi, C. C.

2000-01-01

N.Sitophila was grown under controlled conditions of solid state and submerged fermentation on Sago Hampas. The optimum conditions of protein enrichment previously established for sugar beet pulp was used for this study. Under this condition the protein content of Sago Hampas under solid state increased from 1.4 to 14.45% (W/W) whereas for Sago Hampas and Sago starch, the protein content under submerged condition increased from 1.4% (W/W) and 0.7% (W/W) to 18.56% (W/W) and 43/16% (W/W) based on dry weight of product respectively. The cellulase, a-amylase and glucoamylase activities of N.Sitophila under solid state condition on Sago Hampas were, 9.0, 0.6 and 11.8 U/g of wet fermented solid respectively. the enzymatic activities were also measured under submerged fermentation using both Sago Hampas and Sago starch as substrate

Ethanol production from banana peels using statistically optimized simultaneous saccharification and fermentation process.

Science.gov (United States)

Oberoi, Harinder Singh; Vadlani, Praveen V; Saida, Lavudi; Bansal, Sunil; Hughes, Joshua D

2011-07-01

Dried and ground banana peel biomass (BP) after hydrothermal sterilization pretreatment was used for ethanol production using simultaneous saccharification and fermentation (SSF). Central composite design (CCD) was used to optimize concentrations of cellulase and pectinase, temperature and time for ethanol production from BP using SSF. Analysis of variance showed a high coefficient of determination (R(2)) value of 0.92 for ethanol production. On the basis of model graphs and numerical optimization, the validation was done in a laboratory batch fermenter with cellulase, pectinase, temperature and time of nine cellulase filter paper unit/gram cellulose (FPU/g-cellulose), 72 international units/gram pectin (IU/g-pectin), 37 °C and 15 h, respectively. The experiment using optimized parameters in batch fermenter not only resulted in higher ethanol concentration than the one predicted by the model equation, but also saved fermentation time. This study demonstrated that both hydrothermal pretreatment and SSF could be successfully carried out in a single vessel, and use of optimized process parameters helped achieve significant ethanol productivity, indicating commercial potential for the process. To the best of our knowledge, ethanol concentration and ethanol productivity of 28.2 g/l and 2.3 g/l/h, respectively from banana peels have not been reported to date. Copyright © 2011 Elsevier Ltd. All rights reserved.

Enhancement of nutritive value of tea leaf waste by solid-state fermentation with Lentinus sajor–caju

Directory of Open Access Journals (Sweden)

Abdullah-Al-Mahin

2016-12-01

Full Text Available Nutritional value of tea leaf waste was improved significantly (p<0.05 by solid-state fermentation for 8 weeks with a white rot fungus, Pleurotus sajor-caju. The proximate analysis revealed that crude protein, ash, cellulose-lignin ratio and reducing sugar contents were increased by 2001.53, 117.62, 31.38, and 619.10%, respectively. In contrary, crude fiber, lipid, carbohydrate, lignin, cellulose and hemicelluloses contents were decreased by 40.70, 71.87, 47.65, 35.63, 15.26, and 61.03%, respectively. Ascorbic acid and carotenoid were also increased by 129.17 and 398.79%, respectively. At 7 weeks of fermentation, the crude tea leaf waste extract showed very high CMCase, avicelase, cellobiase and amylase activity, moderate pectinase and poor xylanase activity. Furthermore, In-vitro dry matter digestibility was increased by 50.35% at the end of fermentation. Therefore, it was concluded that P. sajor-caju efficiently degraded tea leaf waste and improved its nutritive value.

The correlation between mannanase and cellulase activities towards fibre content of palm oil sludge fermented with Aspergillus niger

Directory of Open Access Journals (Sweden)

T. Purwadaria

1998-12-01

Full Text Available Enzyme (mannanase and cellulase activities and fibre (hemicellulose, cellulose and lignin contents were determined during the fermentation course of palm oil sludge with Aspergillus niger TL (wild type and A. niger ES I (an asporogenous mutant. The analyses were carried out at the incubation time of 3 and 4 days of aerobic fennentation and at 2 days of anaerobic fermentation afterward. The correlations between mamlanase activity with hemicellulose content and cellulose activity with cellulose content were calculated by linear regression . The activities of matutanase and cellulase are increasing during the aerobic fennentation, while in the anaerobic fennentation the enzyme activities are decreasing due to instability of the enzymes. The enzyme activities of ESI are higher than the TL. The regression coefficient is highly significant for correlation between mamlanase and hemicellulose content of fermented product by ESI (r = 0.83; P0 .05 . Marutanase and cellulase activities were also detected after the fermented product dried at 60°C which indicated the enzymes are quite stable .

Solid-state Fermentation of Xylanase from Penicillium canescens 10-10c in a Multi-layer-packed Bed Reactor

Science.gov (United States)

Assamoi, Antoine A.; Destain, Jacqueline; Delvigne, Frank; Lognay, Georges; Thonart, Philippe

Xylanase is produced by Penicillium canescens 10-10c from soya oil cake in static conditions using solid-state fermentation. The impact of several parameters such as the nature and the size of inoculum, bed-loading, and aeration is evaluated during the fermentation process. Mycelial inoculum gives more production than conidial inoculum. Increasing the quantity of inoculum enhances slightly xylanase production. Forced aeration induces more sporulation of strain and reduces xylanase production. However, forced moistened air improves the production compared to production obtained with forced dry air. In addition, increasing bed-loading reduces the specific xylanase production likely due to the incapacity of the Penicillium strain to grow deeply in the fermented soya oil cake mass. Thus, the best cultivation conditions involve mycelial inoculum form, a bed loading of 1-cm height and passive aeration. The maximum xylanase activity is obtained after 7 days of fermentation and attains 10,200 U/g of soya oil cake. These levels are higher than those presented in the literature and, therefore, show all the potentialities of this stock and this technique for the production of xylanase.

Acetone-butanol-ethanol (ABE) fermentation in an immobilized cell trickle bed reactor.

Science.gov (United States)

Park, C H; Okos, M R; Wankat, P C

1989-06-05

Acetone-butanol-ethanol (ABE) fermentation was successfully carried out in an immobilized cell trickle bed reactor. The reactor was composed of two serial columns packed with Clostridium acetobutylicum ATCC 824 entrapped on the surface of natural sponge segments at a cell loading in the range of 2.03-5.56 g dry cells/g sponge. The average cell loading was 3.58 g dry cells/g sponge. Batch experiments indicated that a critical pH above 4.2 is necessary for the initiation of cell growth. One of the media used during continuous experiments consisted of a salt mixture alone and the other a nutrient medium containing a salt mixture with yeast extract and peptone. Effluent pH was controlled by supplying various fractions of the two different types of media. A nutrient medium fraction above 0.6 was crucial for successful fermentation in a trickle bed reactor. The nutrient medium fraction is the ratio of the volume of the nutrient medium to the total volume of nutrient plus salt medium. Supplying nutrient medium to both columns continuously was an effective way to meet both pH and nutrient requirement. A 257-mL reactor could ferment 45 g/L glucose from an initial concentration of 60 g/L glucose at a rate of 70 mL/h. Butanol, acetone, and ethanol concentrations were 8.82, 5.22, and 1.45 g/L, respectively, with a butanol and total solvent yield of 19.4 and 34.1 wt %. Solvent productivity in an immobilized cell trickle bed reactor was 4.2 g/L h, which was 10 times higher than that obtained in a batch fermentation using free cells and 2.76 times higher than that of an immobilized CSTR. If the nutrient medium fraction was below 0.6 and the pH was below 4.2, the system degenerated. Oxygen also contributed to the system degeneration. Upon degeneration, glucose consumption and solvent yield decreased to 30.9 g/L and 23.0 wt %, respectively. The yield of total liquid product (40.0 wt %) and butanol selectivity (60.0 wt %) remained almost constant. Once the cells were degenerated

Aircraft-crash-protected roof design for the European SBWR

International Nuclear Information System (INIS)

Posta, B.A.; Kadar, I.; Rao, A.S.

1995-01-01

The European utility requirement document (EURD) places significant emphasis on aircraft crash protection of the reactor building - Alternative concepts were evaluated for protecting the dry-well head and the fuel pool from the effect of the spalling concrete for the General Electric Company's European simplified boiling water reactor (ESBWR) designs

Stabilization process in Saccharomyces intra and interspecific hybrids in fermentative conditions.

Science.gov (United States)

Pérez-Través, Laura; Lopes, Christian A; Barrio, Eladio; Querol, Amparo

2014-12-01

We evaluated the genetic stabilization of artificial intra- (Saccharomyces cerevisiae) and interspecific (S. cerevisiae × S. kudriavzevii) hybrids under wine fermentative conditions. Large-scale transitions in genome size and genome reorganizations were observed during this process. Interspecific hybrids seem to need fewer generations to reach genetic stability than intraspecific hybrids. The largest number of molecular patterns recovered among the derived clones was observed for intraspecific hybrids, particularly for those obtained by rare-mating. Molecular marker analyses revealed that unstable clones could change during the industrial process to obtain active dry yeast. When no changes in molecular markers and ploidy were observed after this process, no changes in genetic composition were confirmed by comparative genome hybridization, considering the clone as a stable hybrid. According to our results, under these conditions, fermentation steps 3 and 5 (30-50 generations) would suffice to obtain genetically stable interspecific and intraspecific hybrids, respectively. Copyright© by the Spanish Society for Microbiology and Institute for Catalan Studies.

Verification for the presence of inhibitory substances in poultry meat after the consumption of the feed mixture supplemented with fermented feed

Directory of Open Access Journals (Sweden)

Ivona Kožárová

2016-12-01

Full Text Available The European Union has an obligation to ensure that feed produced in the European Union is safe for animals and also humans by ensuring food of animal origin is safe and wholesome. An increasing demand for safe, wholesome and nutritious animal products has led to the search for alternative substances in animal feed. Fermented feed has gained a lot of popularity in many animal diets today. They meet the demand for animal nutrition due to the formation of target substances with the desired properties. As some of them are attracting attention as potential antimicrobial agents that inhibit the growth of certain microorganisms, and the products of animal origin are controlled for the presence of residues of inhibitory (antimicrobial substances, the aim of this work was to verify the presence of inhibitory substances in poultry meat (muscle, heart, liver, kidneys of broiler chickens after the consumption of the feed mixture with addition of fermented feed (wheat bran fermented with the strain Umbelopsis isabellina CCF 2412 in a dose of 10 % of the total amount of the feed. The detection of residues was performed by two approved microbiological screening methods, the screening test for the detection of antibiotic residues (STAR and the Premi®Test. Both methods detected the positive results and pre-identified the presence of residues of the inhibitory substances not only in the meat of broiler chickens but also in the investigated fermented feed. Due to the antimicrobial potential of the fermented feed and the possible presence of the false-positive results, each positive result must be confirmed by a confirmatory analysis. 

Effect of pH buffering capacity and sources of dietary sulfur on rumen fermentation, sulfide production, methane production, sulfate reducing bacteria, and total Archaea in in vitro rumen cultures.

Science.gov (United States)

Wu, Hao; Meng, Qingxiang; Yu, Zhongtang

2015-06-01

The effects of three types of dietary sulfur on in vitro fermentation characteristics, sulfide production, methane production, and microbial populations at two different buffer capacities were examined using in vitro rumen cultures. Addition of dry distilled grain with soluble (DDGS) generally decreased total gas production, degradation of dry matter and neutral detergent fiber, and concentration of total volatile fatty acids, while increasing ammonia concentration. High buffering capacity alleviated these adverse effects on fermentation. Increased sulfur content resulted in decreased methane emission, but total Archaea population was not changed significantly. The population of sulfate reducing bacteria was increased in a sulfur type-dependent manner. These results suggest that types of dietary sulfur and buffering capacity can affect rumen fermentation and sulfide production. Diet buffering capacity, and probably alkalinity, may be increased to alleviate some of the adverse effects associated with feeding DDGS at high levels. Copyright © 2015 Elsevier Ltd. All rights reserved.

Effects of including saponins (Micro-aid®) on intake, rumen fermentation, and digestibility in steers fed low-quality prairie hay

Science.gov (United States)

Sixteen ruminally-cannulated crossbred steers (529 ± 45 kg initial body weight, BW) were used to evaluate in situ dry matter (DM), neutral detergent fiber (aNDF), and N degradation characteristics of low quality prairie hay, blood urea nitrogen (BUN) and rumen fermentation parameters in steers provi...

Lactic acid fermentation of human urine to improve its fertilizing value and reduce odour emissions.

Science.gov (United States)

Andreev, N; Ronteltap, M; Boincean, B; Wernli, M; Zubcov, E; Bagrin, N; Borodin, N; Lens, P N L

2017-08-01

During storage of urine, urea is biologically decomposed to ammonia, which can be lost through volatilization and in turn causes significant unpleasant smell. In response, lactic acid fermentation of urine is a cost-effective technique to decrease nitrogen volatilization and reduce odour emissions. Fresh urine (pH = 5.2-5.3 and NH 4 + -N = 1.2-1.3 g L -1 ) was lacto-fermented for 36 days in closed glass jars with a lactic acid bacterial inoculum from sauerkraut juice and compared to untreated, stored urine. In the lacto-fermented urine, the pH was reduced to 3.8-4.7 and the ammonium content by 22-30%, while the pH of the untreated urine rose to 6.1 and its ammonium content increased by 32% due to urea hydrolysis. The concentration of lactic acid bacteria in lacto-fermented urine was 7.3 CFU ml -1 , suggesting that urine is a suitable growth medium for lactic acid bacteria. The odour of the stored urine was subjectively perceived by four people to be twice as strong as that of lacto-fermented samples. Lacto-fermented urine induced increased radish germination compared to stored urine (74-86% versus 2-31%). Adding a lactic acid bacterial inoculum to one week old urine in the storage tanks in a urine-diverting dry toilet reduced the pH from 8.9 to 7.7 after one month, while the ammonium content increased by 35%, probably due to the high initial pH of the urine. Given that the hydrolyzed stale urine has a high buffering capacity, the lactic acid bacterial inoculum should be added to the urine storage tank of a UDDT before urine starts to accumulate there to increase the efficiency of the lactic acid fermentation. Copyright © 2017 Elsevier Ltd. All rights reserved.

Feeding Aspergillus oryzae Fermentation Culture (AOFC to Growing Sheep: 1. The Effect of AOFC on Rumen Fermentation

Directory of Open Access Journals (Sweden)

Darwinsyah Lubis

2002-10-01

Full Text Available Cultures of fungi, especially Aspergillus oryzae, have been of interest to animal nutritionists to increase feed efficiency. Many experiments have been done and showed positive results on rumen fermentation and productivity of ruminants. This paper reports the results of an in vivo study on feeding Aspergillus oryzae, fermentation culture (AOFC to growing sheep. ‘Onggok’ (tapioca processing waste was used as media for AO cultivation after being enriched with a mineral mixture. Commercial concentrate (GT-03 was fed to 15 growing sheep supplemented with 0% (C0, 5% (C1, and 10% (C2 AOFC (w/w. Chopped fresh King grass was used as a basal diet. The 3 treatments were randomly allotted to the sheep according to randomized block design with 5 replications. The study was carried out for 14 weeks. Digestion trial was conducted in the last 10 days of experiment. All feed and fecal samples were analyzed for nutrients. Rumen fluid was sampled at the mid experimental period. Analyses were done on rumen pH, ammonia content, (VFA volatile fatly acids concentration, and also total digestive tract digestibility of dry and organic matter, crude protein, and total fiber (NDF. Differences in treatment means were analyzed by Duncan’s MRT. Feeding AOFC resulted in increased (P<0.05 digestibility of crude protein from 59.6% in control sheep to 65.5% in sheep fed concentrate with 10% AOFC supplementation. The same pattern also occurred for NDF, but no effect was found on dry and organic matter. Higher fiber digestibility with AOFC supplementation was in line with an increase (P<0.05 in cellulolytic bacteria population in the rumen. VFA produced also increased (P<0.05, as well as individual acids content, primarily acetate and propionate. No differences (P<0.05 were detected in rumen pH and ammonia content. It appears that AOFC is more suitable for the purpose of meat production.

Characterization of thermophilic fungal community associated with pile fermentation of Pu-erh tea.

Science.gov (United States)

Zhang, Wei; Yang, Ruijuan; Fang, Wenjun; Yan, Liang; Lu, Jun; Sheng, Jun; Lv, Jie

2016-06-16

This study aimed to characterize the thermophilic fungi in pile-fermentation process of Pu-erh tea. Physicochemical analyses showed that the high temperature and low pH provided optimal conditions for propagation of fungi. A number of fungi, including Blastobotrys adeninivorans, Thermomyces lanuginosus, Rasamsonia emersonii, Aspergillus fumigatus, Rhizomucor pusillus, Rasamsonia byssochlamydoides, Rasamsonia cylindrospora, Aspergillus tubingensis, Aspergillus niger, Candida tropicalis and Fusarium graminearum were isolated as thermophilic fungi under combination of high temperature and acid culture conditions from Pu-erh tea pile-fermentation. The fungal communities were analyzed by PCR-DGGE. Results revealed that those fungi are closely related to Debaryomyces hansenii, Cladosporium cladosporioides, A. tubingensis, R. emersonii, R. pusillus, A. fumigatus and A. niger, and the last four presented as dominant species in the pile process. These four preponderant thermophilic fungi reached the order of magnitude of 10(7), 10(7), 10(7) and 10(6)copies/g dry tea, respectively, measured by real-time quantitative PCR (q-PCR). The results indicate that the thermophilic fungi play an important role in Pu-erh tea pile fermentation. Copyright © 2016 Elsevier B.V. All rights reserved.

Fermentation performance of engineered and evolved xylose-fermenting Saccharomyces cerevisiae strains

DEFF Research Database (Denmark)

Sonderegger, M.; Jeppsson, M.; Larsson, C.

2004-01-01

Lignocellulose hydrolysate is an abundant substrate for bioethanol production. The ideal microorganism for such a fermentation process should combine rapid and efficient conversion of the available carbon sources to ethanol with high tolerance to ethanol and to inhibitory components in the hydrol......Lignocellulose hydrolysate is an abundant substrate for bioethanol production. The ideal microorganism for such a fermentation process should combine rapid and efficient conversion of the available carbon sources to ethanol with high tolerance to ethanol and to inhibitory components...... in the hydrolysate. A particular biological problem are the pentoses, which are not naturally metabolized by the main industrial ethanol producer Saccharomyces cerevisiae. Several recombinant, mutated, and evolved xylose fermenting S. cerevisiae strains have been developed recently. We compare here the fermentation...

Fermentation characteristics and nutritional quality of elephant grass silage added the buriti fruit peel

Directory of Open Access Journals (Sweden)

Raimundo Ribeiro Ferreira

2017-05-01

Full Text Available The objective of this research was to evaluated the inclusion of buriti fruit peel as additive on the fermentation profile, losses, chemical composition and degradability of elephant grass silage. We used a completely randomized design with five levels of buriti fruit peel (0, 50, 100, 200 and 400 g kg-1. The silos were opened after 28 days of storage. In situ degradability monitoring was conducted using a split-plot design in which four animals represented the blocks and silage supplemented with five levels of buriti fruit peel represented the treatments. The use of the additive in elephant silage increased dry matter (DM (P < 0.001, ether extract (EE (P < 0.001, ash (P < 0.001, neutral detergent fiber (NDF (P < 0.001 and acid detergent fiber (ADF (P= 0.0000. The pH (P= 0.0000, N-NH3 (P = 0.024 and there was a decrease in gas losses (P < 0.001, effluent losses and dry matter recovery (P = 0.218 not were influenced by the addition of buriti fruit peel. The inclusion of buriti fruit peel linearly reduced the ruminal degradability DM of soluble fraction (a (P < 0.001 and potentially degradable insoluble fraction (b (P < 0.001. The DM content increase with the addition of the buriti fruit peel to the elephant grass silage promotes improvements in the fermentation process, reduces losses of nutrients and ruminal disappearance of dry matter and does not significantly change the chemical composition with the inclusion of 166.7 g kg-1 of the buriti fruit peel.

In vitro batch fecal fermentation comparison of gas and short-chain fatty acid production using "slowly fermentable" dietary fibers.

Science.gov (United States)

Kaur, Amandeep; Rose, Devin J; Rumpagaporn, Pinthip; Patterson, John A; Hamaker, Bruce R

2011-01-01

Sustained colonic fermentation supplies beneficial fermentative by-products to the distal colon, which is particularly prone to intestinal ailments. Blunted/delayed initial fermentation may also lead to less bloating. Previously, we reported that starch-entrapped alginate-based microspheres act as a slowly fermenting dietary fiber. This material was used in the present study to provide a benchmark to compare to other "slowly fermentable" fibers. Dietary fibers with previous reports of slow fermentation, namely, long-chain inulin, psyllium, alkali-soluble corn bran arabinoxylan, and long-chain β-glucan, as well as starch-entrapped microspheres were subjected to in vitro upper gastrointestinal digestion and human fecal fermentation and measured over 48 h for pH, gas, and short-chain fatty acids (SCFA). The resistant fraction of cooked and cooled potato starch was used as another form of fermentable starch and fructooligosaccharides (FOS) served as a fast fermenting control. Corn bran arabinoxylan and long-chain β-glucan initially appeared slower fermenting with comparatively low gas and SCFA production, but later fermented rapidly with little remaining in the final half of the fermentation period. Long-chain inulin and psyllium had slow and moderate, but incomplete, fermentation. The resistant fraction of cooked and cooled potato starch fermented rapidly and appeared similar to FOS. In conclusion, compared to the benchmark slowly fermentable starch-entrapped microspheres, a number of the purported slowly fermentable fibers fermented fairly rapidly overall and, of this group, only the starch-entrapped microspheres appreciably fermented in the second half of the fermentation period. Consumption of dietary fibers, particularly commercial prebiotics, leads to uncomfortable feelings of bloating and flatulence due to their rapid degradation in our large intestine. This article employs claimed potential slowly fermenting fibers and compares their fermentation rates

Development of pilot-scale fermentation and stabilization processes for the production of microsclerotia of the entomopathogenic fungus Metarhizium brunneun strain F52

Science.gov (United States)

Using 100L stirred-tank bioreactors, we evaluated the effect of fermentation parameters and drying protocols on the production and stabilization of microsclerotia (MS) of the entomopathogenic fungus Metarhizium brunneum (formerly M. anisopliae F52). Results showed that stirred-tank bioreactors can ...

Ammonium carboxylate production from sugarcane trash using long-term air-lime pretreatment followed by mixed-culture fermentation.

Science.gov (United States)

Nachiappan, Balasubramaniyan; Fu, Zhihong; Holtzapple, Mark T

2011-03-01

Sugarcane trash (ST) was converted to ammonium carboxylates using a novel bioprocessing strategy known as long-term air-lime pretreatment/mixed-culture fermentation. At mild conditions (50°C, 5 weeks, 1-atm air, and excess lime loading of 0.4 g Ca(OH)(2)/(g dry biomass)), air-lime pretreatment of ST had moderate delignification (64.4%) with little loss in polysaccharides. Without employing detoxification, sterility, expensive nutrients, or costly enzymes, the feedstock (80% treated ST/20% chicken manure) was fermented to primarily ammonium acetate (>75%) and butyrate by a mixed culture of marine microorganisms at 55°C. In the best four-stage countercurrent fermentation, the product yield was 0.36 g total acids/(g VS fed) and the substrate conversion was 64%. Model predictions indicate both high acid concentrations (>47.5 g/L) and high substrate conversions (>70%) are possible at industrial scale. Copyright © 2010 Elsevier Ltd. All rights reserved.

Pretreatment of grass waste using combined ionizing radiation-acid treatment for enhancing fermentative hydrogen production.

Science.gov (United States)

Yang, Guang; Wang, Jianlong

2018-05-01

In this study, the combined ionizing radiation-acid pretreatment process was firstly applied to enhance hydrogen fermentation of grass waste. Results showed that the combined pretreatment synergistically enhanced hydrogen fermentation of grass waste. The SCOD and soluble polysaccharide contents of grass waste increased by 1.6 and 2.91 times after the combined pretreatment, respectively. SEM observation and crystallinity test showed the combined pretreatment effectively disrupted the grass structure. Owing to the more favorable substrate conditions, the hydrogen yield achieved 68 mL/g-dry grass added after the combined pretreatment, which was 161.5%, 112.5% and 28.3% higher than those from raw, ionizing radiation pretreated and acid pretreated grass waste, respectively. The VS removal also increased from 13.9% to 25.6% by the combined pretreatment. Microbial community analysis showed that the abundance of dominant hydrogen producing genus Clostridium sensu stricto 1 increased from 37.9% to 69.4% after the combined pretreatment, which contributed to more efficient hydrogen fermentation. Copyright © 2018 Elsevier Ltd. All rights reserved.

Modelling ethanol production from cellulose: separate hydrolysis and fermentation versus simultaneous saccharification and fermentation

NARCIS (Netherlands)

Drissen, R.E.T.; Maas, R.H.W.; Tramper, J.; Beeftink, H.H.

2009-01-01

In ethanol production from cellulose, enzymatic hydrolysis, and fermentative conversion may be performed sequentially (separate hydrolysis and fermentation, SHF) or in a single reaction vessel (simultaneous saccharification and fermentation, SSF). Opting for either is essentially a trade-off between

Alcoholic fermentation of whey

Energy Technology Data Exchange (ETDEWEB)

Beach, A S; Holland, J W

1958-09-10

The lactose of whey and other milk products is rapidly fermented to ethanol by means of Candida pseudotropicalis strain XI. The fermentation is complete in about 12 hours and yields about 45% ethanol based on the weight of lactose. Conditions favoring the fermentation and inhibiting lactic acid production include pH 4.5, 30/sup 0/, and continuous aeration.

Application of exopolysaccharides to optimize the performance of ceramic bodies in the unidirectional dry pressing process

OpenAIRE

Caneira I.; Machado-Moreira, B.; Dionísio, A.; Godinho, V.; Neves, O.; Dias, Diamantino; Sáiz-Jiménez, Cesáreo; Miller, A. Z.

2015-01-01

Ceramic industry represents an important sector of economic activity in the European countries and involves complex and numerous manufacturing processes. The unidirectional dry pressing process includes milling and stirring of raw materials (mainly clay and talc minerals) in aqueous suspensions, followed by spray drying to remove excess water obtaining spray-dried powders further subjected to dry pressing process (conformation). However, spray-dried ceramic powders exhibit an important variab...

Natural drying treatments during seasonal storage of wood for bioenergy in different European locations

International Nuclear Information System (INIS)

Roeser, Dominik; Mola-Yudego, Blas; Sikanen, Lauri; Prinz, Robert; Gritten, David; Emer, Beatrice; Vaeaetaeinen, Kari; Erkkilae, Ari

2011-01-01

Research into the methods of producing high quality wood chips for a rapidly growing energy sector is becoming increasingly important. For example, small wood chip heating plants require high quality wood chips to ensure efficient operation, thereby minimizing maintenance costs. Moisture content is considered to be an important quality parameter regarding wood based fuels. The objective of this study is to investigate methods to promote the natural drying of wood for bioenergy purposes. The effects on the drying process through covering the wood piles and partial debarking of stems were tested in order to identify methods to reduce the moisture content of the woody material in the storage. Drying trials were established in Finland, Italy and Scotland, utilizing tree species typically used for energy purposes in each area. The results show that natural drying is a viable and effective method to enhance the energy efficiency of wood based fuel products in all the regions studied. Furthermore, by adapting current harvesting methods and storage procedures even better results can be achieved. In addition, the results also indicate that broadleaved trees dry more effectively, if some partial debarking is carried out and that covering of piles is of utmost importance in Scotland and Finland. -- Highlights: → Natural drying is an effective method to enhance efficiency in the wood-fuel chains → Broadleaved trees dry more effectively when partial debarking is done → In Scotland and Finland a method for covering of piles is of utmost importance.

Evaluation of aroma enhancement for "Ecolly" dry white wines by mixed inoculation of selected Rhodotorula mucilaginosa and Saccharomyces cerevisiae.

Science.gov (United States)

Wang, Xing-Chen; Li, Ai-Hua; Dizy, Marta; Ullah, Niamat; Sun, Wei-Xuan; Tao, Yong-Sheng

2017-08-01

To improve the aroma profile of Ecolly dry white wine, the simultaneous and sequential inoculations of selected Rhodotorula mucilaginosa and Saccharomyces cerevisiae were performed in wine making of this work. The two yeasts were mixed in various ratios for making the mixed inoculum. The amount of volatiles and aroma characteristics were determined the following year. Mixed fermentation improved both the varietal and fermentative aroma compound composition, especially that of (Z)-3-hexene-1-ol, nerol oxide, certain acetates and ethyls group compounds. Citrus, sweet fruit, acid fruit, berry, and floral aroma traits were enhanced by mixed fermentation; however, an animal note was introduced upon using higher amounts of R. mucilaginosa. Aroma traits were regressed with volatiles as observed by the partial least-square regression method. Analysis of correlation coefficients revealed that the aroma traits were the multiple interactions of volatile compounds, with the fermentative volatiles having more impact on aroma than varietal compounds. Copyright © 2017 Elsevier Ltd. All rights reserved.

Amenability of European silver fir (Abies alba Mill.) to preservative treatment by the full-cell process in longitudinal, tangential, radial and triplex flow pathways on the base of wood drying

Energy Technology Data Exchange (ETDEWEB)

Usta, Ilker [Wood Products Industrial Engineering, Hacettepe University, 06532-Beytepe, Ankara (Turkey)

2006-08-15

This paper discusses the effects of wood drying upon treatability (as determined by preservative uptake and gain-in-weight retention) of European silver fir on the two moisture content (MC) levels which were designed to be above and below the fibre saturation point (FSP). The treatability behaviour was investigated for individual flow pathways: longitudinal (L, along the stem), tangential (T, along the growth rings) and radial (R, along the rays), and also for the triplex (t, cumulative of all three directions: all faces left open). As the FSP was observed 32.7%, MC of the experimental samples-for each flow path-nominated to around 50% and 9% by recommended kiln drying schedule using a conventional kiln. The samples were then treated with a 2.5% concentration of commercial Tanalith C of CCA (chromium/copper/arsenic) via a mild schedule of full-cell impregnation process using a model pressure treatment plant. Treatability of European silver fir was noticed in different behaviour in either flow paths before and after drying. According to the experimental results, MC regulate the preservative uptake (as the percentage of void volume filled with preservative, VVF%) along the grain (L) and VVF% was improved by kiln drying process effectively, however, it was seemed to be contradictory across the grain (in both T and R). In the cumulative form (t), treatability-in either above or below the FSP-was appeared to be slightly greater than that for L due to support of the longitudinal flow. Therefore, it could be suggested that wood material which is subjected to be used in constructional purposes has to be initially dried to below the FSP, and - for efficient preservative treatment - it has to be treated with all faces unsealed (free from any pre-coating and/or painting). This shall be more ideal which in turn influences the quality of treated wood allowing better performance in its service life. (author)

Degradability of dry matter and crude protein of dry grains and wet grain silages from different processing corn hybrids (Zea mays

Directory of Open Access Journals (Sweden)

Wagner dos Reis

2013-03-01

Full Text Available The objective of this work was to evaluate the effect of processing two corn hybrids conserved, dry and humid grains, the dry matter (DM and crude protein (CP degradability in situ. The particle size was determined and difference was verified in MGD (Medium Geometric Diameter of processed ingredients. Three sheep were used with rumen canulated, in a completely randomized design, using a factorial outline 2 x 2 x 3, being two corn hybrid, two conservation methods and three processing forms (whole, coarsely and finely ground, with five times of incubation (3, 6, 12, 24 and 48 hours. The fraction A in SDC (silage of dent corn of DM was superior to GDC (grain of dent corn in all of the particles size. The ensiling process increased the DM solubility, reducing the fraction B in comparison to dry grain. The values regarding the fractions DP and DE the 5% per hour of the protein, were larger for SDC and GDC, it presents a decreasing when the incubation time advances. The fermentation rate was superior for SDC and GDC. The ensiling process has positive effect in the decreasing of DM and CP in comparison to GDC.

Effects of Branched-chain Amino Acids on Ruminal Fermentation of Wheat Straw

OpenAIRE

Hui Ling Zhang; Yong Chen; Xiao Li Xu; Yu Xia Yang

2013-01-01

This study investigates the effects of three branched-chain amino acids (BCAA; valine, leucine, and isoleucine) on the in vitro ruminal fermentation of wheat straw using batch cultures of mixed ruminal microorganisms. BCAA were added to the buffered ruminal fluid at a concentration of 0, 2, 4, 7, or 10 mmol/L. After 72 h of anaerobic incubation, pH, volatile fatty acids (VFA), and ammonia nitrogen (NH3-N) in the ruminal fluid were determined. Dry matter (DM) and neutral detergent fiber (NDF) ...

EFSA Panel on Biological Hazards (BIOHAZ); Scientific Opinion on Scientific Opinion on risk based control of biogenic amine formation in fermented foods

DEFF Research Database (Denmark)

Hald, Tine

A qualitative risk assessment of biogenic amines (BA) in fermented foods was conducted, using data from the scientific literature, as well as from European Union-related surveys, reports and consumption data. Histamine and tyramine are considered as the most toxic and food safety relevant...... chromatography (HPLC)-based methods enable simultaneous and high sensitivity quantification of all BA in foods, hence are best suited for monitoring and control purposes. Monitoring of BA concentrations in fermented foods during the production process and along the food chain would be beneficial for controls...... and further knowledge. Further research on BA in fermented foods is needed; particularly on toxicity and associated concentrations, production process-based control measures, further process hygiene and/or food safety criteria development, and validation of analysis methods....

Nutritive value and fermentation quality of palisadegrass and stylo mixed silages.

Science.gov (United States)

da Silva, Juliana S; Ribeiro, Karina G; Pereira, Odilon G; Mantovani, Hilário C; Cecon, Paulo R; Pereira, Rosana C; Silva, Janaina de L

2018-01-01

The nutritive value and fermentation quality of palisadegrass (Brachiaria brizantha cv. Xaraes) and stylo (Stylosanthes capitata × S. macrocephala cv. Campo Grande) mixed silages were evaluated. The experiment was analyzed in a factorial scheme (5 × 2) in a completely randomized design using increasing levels of stylo (0, 25, 50, 75 and 100% on a fresh matter basis) on palisadegrass silages, with and without microbial inoculants (MI). With the increased ratio of stylo in mixed silages, dry matter (DM), crude protein (CP), acid detergent fiber (ADF), and lignin content increased in silages. The presence of MI promoted lower DM content, and higher neutral detergent fiber corrected for ash and protein, ADF and lignin content. The acid detergent insoluble nitrogen content and the lactic acid bacteria populations were not affected by treatments. The in vitroDM digestibility was affected by the interaction of levels of the stylo and MI. The pH, NH 3 -N/total nitrogen and butyric acid concentrations decreased with increasing levels of stylo. Better nutritive value and quality of fermentation was found in the silage containing higher proportions of this stylo mixed with palisadegrass. The microbial inoculant evaluated did not alter the nutritive value or quality of the fermentation of the silages in this experiment. © 2017 Japanese Society of Animal Science.

Monensin and Nisin Affect Rumen Fermentation and Microbiota Differently In Vitro

Directory of Open Access Journals (Sweden)

Junshi Shen

2017-06-01

Full Text Available Nisin, a bacteriocin, is a potential alternative to antibiotics to modulate rumen fermentation. However, little is known about its impacts on rumen microbes. This study evaluated the effects of nisin (1 and 5 μM on in vitro rumen fermentation characteristics, microbiota, and select groups of rumen microbes in comparison with monensin (5 μM, one of the most commonly used ionophores in ruminants. Nisin had greater effects than monensin in inhibiting methane production and decreasing acetate/propionate ratio. Unlike monensin, nisin had no adverse effect on dry matter digestibility. Real-time PCR analysis showed that both monensin and nisin reduced the populations of total bacteria, fungi, and methanogens, while the population of protozoa was reduced only by monensin. Principal component analysis of bacterial 16S rRNA gene amplicons showed a clear separation between the microbiota shaped by monensin and by nisin. Comparative analysis also revealed a significant difference in relative abundance of some bacteria in different taxa between monensin and nisin. The different effects of monensin and nisin on microbial populations and bacterial communities are probably responsible for the discrepancy in their effects on rumen fermentation. Nisin may have advantages over monensin in modulating ruminal microbial ecology and reducing ruminant methane production without adversely affecting feed digestion, and thus it may be used as a potential alternative to monensin fed to ruminants.

Study On The Application Of Hydrogel Prepared By Radiation Technique For Fermentation Of Sawdust

International Nuclear Information System (INIS)

Le Thuy Trang; Nguyen Huynh Phuong Uyen; Vo Thu Ha; Le Quang Luan

2011-01-01

The super water-adsorption hydrogels was successfully preparation by radiation crosslinking CMC in paste condition and radiation grafting acrylic acid into starch. The hydrogel with 76.36% gel fraction and 91.13% swelling degree were obtained by irradiation of CMC 20% at 20 kGy, while the hydrogel with 65.3% gel fraction and 234 swelling degree was acrylic acid and starch at 4 kGy. The supplementation of hydrogels prepared by radiation technique showed a higher cellulose degradation effect of waste of cattle after fermenting 30 and 45 days. The optimum condition was determined by mixing 1% (w/w) dried hydrogel in 99% (w/w) waste of cattle. The fermented sawdust using hydrogel prepared by radiation technique showed a better effect on the growth of F1 Chinese cabbage (Brassica Pe-tsai Bailey L.). (author)

TRADITIONAL FERMENTED FOODS OF LESOTHO

Directory of Open Access Journals (Sweden)

Tendekayi H. Gadaga

2013-06-01

Full Text Available This paper describes the traditional methods of preparing fermented foods and beverages of Lesotho. Information on the preparation methods was obtained through a combination of literature review and face to face interviews with respondents from Roma in Lesotho. An unstructured questionnaire was used to capture information on the processes, raw materials and utensils used. Four products; motoho (a fermented porridge, Sesotho (a sorghum based alcoholic beverage, hopose (sorghum fermented beer with added hops and mafi (spontaneously fermented milk, were found to be the main fermented foods prepared and consumed at household level in Lesotho. Motoho is a thin gruel, popular as refreshing beverage as well as a weaning food. Sesotho is sorghum based alcoholic beverage prepared for household consumption as well as for sale. It is consumed in the actively fermenting state. Mafi is the name given to spontaneously fermented milk with a thick consistency. Little research has been done on the technological aspects, including the microbiological and biochemical characteristics of fermented foods in Lesotho. Some of the traditional aspects of the preparation methods, such as use of earthenware pots, are being replaced, and modern equipment including plastic utensils are being used. There is need for further systematic studies on the microbiological and biochemical characteristics of these these products.

Effects of degradable protein and non-fibre carbohydrates on microbial growth and fermentation in the rumen simulating fermenter (Rusitec

Directory of Open Access Journals (Sweden)

Xiang H. Zhao

2015-05-01

Full Text Available A rumen simulation technique (Rusitec apparatus with eight 800 ml fermentation vessels was used to investigate the effects of rumen degradable protein (RDP level and non-fibre carbohydrate (NFC type on ruminal fermentation, microbial growth, and populations of ruminal cellulolytic bacteria. Treatments consisted of two NFC types (starch and pectin supplemented with 0 g/d (low RDP or 1.56 g/d (high RDP sodium caseinate. Apparent disappearance of dry matter and organic matter was greater for pectin than for starch treatment (P<0.01 with low or high RDP. A NFC × RDP interaction was observed for neutral detergent fibre disappearance (P=0.01, which was lower for pectin than for starch only under low RDP conditions. Compared with starch, pectin treatment increased the copy numbers of Ruminococcus albus (P≤0.01 and Ruminococcus flavefaciens (P≤0.09, the molar proportion of acetate (P<0.01, the acetate:propionate ratio (P<0.01, and methane production (P<0.01, but reduced the propionate proportion (P<0.01. Increasing dietary RDP increased the production of total VFA (P=0.01, methane (P<0.01, ammonia N (P<0.01, and microbial N (P<0.01. Significant NFC × RDP interaction and interaction tendency were observed for ammonia N production (P=0.01 and daily N flow of total microorganisms (P=0.07, which did not differ under low RDP conditions, but pectin produced greater microbial N and less ammonia N than starch with increased RDP. Results showed NFC type, RDP level, and their interaction affected ruminal fermentation and microbial growth, and under sufficient ruminal degradable N pectin had greater advantage in microbial N synthesis than starch in vitro.

A Quantitative Microbiological Risk Assessment for Salmonella in Pigs for the European Union

DEFF Research Database (Denmark)

Snary, Emma L.; Swart, Arno N.; Simons, Robin R. L.

2016-01-01

,000 and 1 in 10 million servings given consumption of one of the three product types considered (pork cuts, minced meat, and fermented ready‐to‐eat sausages). Further analyses of the farm‐to‐consumption QMRA suggest that the vast majority of human risk derives from infected pigs with a high concentration......A farm‐to‐consumption quantitative microbiological risk assessment (QMRA) for Salmonella in pigs in the European Union has been developed for the European Food Safety Authority. The primary aim of the QMRA was to assess the impact of hypothetical reductions of slaughter‐pig prevalence...

Fermentation of sugar-beet molasses

Energy Technology Data Exchange (ETDEWEB)

Malchenko, A L; Krishtul, F B

1956-08-25

Sugar-beet molasses is fermented with yeast separated from the mash, sterilized, and reactivated. To reduce sugar losses and hasten fermentation, the yeast is removed from the mash as the cells fall to the bottom during the fermentation process.

Ethanol fermentation with Kluyveromyces marxianus from Jerusalem artichoke grown in salina and irrigated with a mixture of seawater and freshwater.

Science.gov (United States)

Yuan, W J; Zhao, X Q; Ge, X M; Bai, F W

2008-12-01

To study fuel ethanol fermentation with Kluyveromyces marxianus ATCC8554 from Jerusalem artichoke (Helianthus tuberosus) grown in salina and irrigated with a mixture of seawater and freshwater. The growth and ethanol fermentation of K. marxianus ATCC8554 were studied using inulin as substrate. The activity of inulinase, which attributes to the hydrolysis of inulin, the main carbohydrate in Jerusalem artichoke, was monitored. The optimum temperatures were 38 degrees C for growth and inulinase production, and 35 degrees C for ethanol fermentation. Aeration was not necessary for ethanol fermentation with the K. marxianus from inulin. Then, the fresh Jerusalem artichoke tubers grown in salina and irrigated with 25% and 50% seawater were further examined for ethanol fermentation with the K. marxianus, and a higher ethanol yield was achieved for the Jerusalem artichoke tuber irrigated with 25% seawater. Furthermore, the dry meal of the Jerusalem artichoke tubers irrigated with 25% seawater was examined for ethanol fermentation at three solid concentrations of 200, 225 and 250 g l(-1), and the highest ethanol yield of 0.467, or 91.5% of the theoretical value of 0.511, was achieved for the slurry with a solid concentration of 200 g l(-1). Halophilic Jerusalem artichoke can be used for fuel ethanol production. Halophilic Jerusalem artichoke, not competing with grain crops for arable land, is a sustainable feedstock for fuel ethanol production.

SOLID-STATE FERMENTATIVE PRODUCTION AND BIOACTIVITY OF FUNGAL CHITOSAN

Directory of Open Access Journals (Sweden)

Barry Aigbodion Omogbai

2013-10-01

Full Text Available Chitosan production was investigated using a laboratory-scale solid substrate fermentation (SSF technique with four species of fungi: Penicillium expansum, Aspergillus niger, Rhizopus oryzae and Fusarium moniliforme.The peak growth for the organisms was after 16 days. Aspergillus niger had the highest growth with a maximal dry cell biomass of 15.8g/kg after 16 days cultivation on corn straw under solid substrate fermentation. This was closely followed by Rhizopus oryzae (14.6g/kg, Penicillium expansum (13.8g/kg and Fusarium moniliforme (10.6g/kg respectively. The fungus Rhizopus oryzae had the highest chitosan production with a maximum of 8.57g/kg in 16 days under solid substrate fermentation (SSF with a medium containing corn straw. Aspergillus niger showed a modest chitosan yield of 6.8g/kg. Penicillium expansum and Fusarium moniliforme had low chitosan yields of 4.31g/kg and 3.1g/kg respectively. The degree of deacetylation of fungal chitosans ranged between 75.3-91.5% with a viscosity of 3.6-7.2 centipoises (Cp.Chitosan extracted from Rhizopus oryzae was found to have antibacterial activity on some bacterial isolates. At a concentration of 50mg/L, Rhizopus oryzae chitosan paralleled crab chitosan in susceptibility testing against some food-borne bacterial pathogens. Escherichia coli, Salmonella typhi, Pseudomonas aeruginosa and Bacillus subtilis showed inhibition rates of 83.2%, 67.9%, 63.8% and 62.4% respectively in response to 50mg/l Rhizopus oryzae chitosan in 24 h. The rate of inhibition (% increased with increase in chitosan concentration.