WorldWideScience

Sample records for oil press cakes

  1. Bioactive properties of faveleira (Cnidoscolus quercifolius) seeds, oil and press cake obtained during oilseed processing.

    Science.gov (United States)

    Ribeiro, Penha Patrícia Cabral; Silva, Denise Maria de Lima E; Assis, Cristiane Fernandes de; Correia, Roberta Targino Pinto; Damasceno, Karla Suzanne Florentino da Silva Chaves

    2017-01-01

    To the best of our knowledge, this is the first report in the literature concerning the bioactive properties of faveleira products. This work focuses on the physicochemical evaluation of faveleira oil, as well as it investigates the bioactive properties of faveleira seeds, faveleira oil and the press cake obtained during the oilseed processing. The seeds were cold pressed and the following tests were performed: physicochemical characteristics (acidity, peroxide values, moisture and volatile matter, density and viscosity) and fatty acid profile of faveleira oil; total phenolic and flavonoid content of faveleira seed and press cake; antibacterial activity of seed, oil and press cake; and antioxidant activity (DPPH radical scavenging activity, reducing power assay, total antioxidant capacity, superoxide radical scavenging assay and oxygen radical absorbance capacity) of seed, oil and press cake. Our work demonstrated that the faveleira seed oil has low acidity (0.78 ± 0.03% oleic acid) and peroxide value (1.13 ± 0.12 mEq/1000g), associated with the relevant concentration of linoleic acid (53.56%). It was observed that important phenolics (398.89 ± 6.34 mg EAG/100 g), especially flavonoids (29.81 ± 0.71 mg RE/g) remain in the press cake, which indicates that the by-product of the faveleira oilseed production constitutes a rich residual source of bioactive compounds. No bacterial growth inhibition was detected, but all samples including faveleira seeds, press cake, oil and its fractions have potent antioxidant activities, mainly the press cake, with oxygen radical absorbance capacity of 28.39 ± 4.36 μM TE/g. Our results also show that faveleira oil has potential to be used as edible oil and the press cake should be used to contain the most antioxidants from seed.

  2. Development of a hull-less pumpkin (Cucurbita pepo L.) seed oil press-cake spread.

    Science.gov (United States)

    Radočaj, Olga; Dimić, Etelka; Vujasinović, Vesna

    2012-09-01

    A stable, oil-based spread rich in the omega-3 (ω-3) and omega-6 (ω-6) fatty acids was developed using a hull-less pumpkin seed (Cucurbita pepo L.) oil press-cake, a by-product of the pumpkin oil pressing process, along with cold-pressed hemp oil. Response surface methodology (RSM) was applied to investigate the effects of two factors, as the formulation's compositional variables: a commercial stabilizer (X(1) ) and cold-pressed hemp oil (X(2) ) added to the pumpkin seed oil press-cake in the spread formulations. A central composite, 2-factorial experimental design on 5 levels was used to optimize the spreads where model responses were ω-3 fatty acids content, spreadability (hardness), oil separation, and sensory evaluation. The selected responses were significantly affected by both variables (P spreads resembled commercial peanut butter, both in appearance, texture and spreadability; were a source of ω-3 fatty acids and with no visual oil separation after 1 mo of storage. An optimum spread was produced using 1.25% (w/w) of stabilizer and 80% of hemp oil (w/w, of the total added oil) which had 0.97 g of ω-3 fatty acids per serving size; penetration depth of 68.4 mm; oil separation of 9.2% after 3 mo of storage; and a sensory score of 17.5. A use of by-products generated from different food processing technologies, where the edible waste is successfully incorporated as a value-added ingredient, has become a very important area of research to support global sustainability efforts. This study contributes to the knowledge of a product design process for oil-based spread development, where oil press-cake, a by-product of the oil pressing process of the naked pumpkin seeds, was used and where results have demonstrated that a new product can be successfully developed and potentially manufactured as a functional food. © 2012 Institute of Food Technologists®

  3. Extraction of oil and minor lipids from cold-press rapeseed cake with supercritical CO2

    Directory of Open Access Journals (Sweden)

    E. Uquiche

    2012-09-01

    Full Text Available This study examines the extraction of oil from cold-press rapeseed cake using Supercritical CO2(SC-CO2. The effects of pressure (20, 30, and 40 MPa, temperature (40, 50, and 60 ºC, and extraction time (60, 90, and 120 min on oil yield and composition (tocopherols and carotenoids were studied using response surface design. The results indicated that pressure influenced the most the yield of oil, followed by temperature and extraction time. Extraction time had no effect on oil composition. Extraction pressure and temperature did not affect the tocopherol concentration of the oil to a great extent, whereas temperature had no affect in its carotenoid concentration. A comparison was made between the relative qualities of oil extracted with SC-CO2at 40 MPa and 60 ºC and with n-hexane. Neither solvent affected the unsaponifiable matter content or the composition of phytosterols (mainly β-sitosterol, campesterol and brassicasterol of the oils, although there was a significant difference (p<0.05 in tocopherol. Extraction with SC-CO2at 40 MPa and 60 ºC is recommended to obtain rapeseed-oil enriched with tocopherols and carotenoids as important functional components.

  4. Cultivation of three medicinal mushroom species on olive oil press cakes containing substrates

    Directory of Open Access Journals (Sweden)

    Andrej GREGORI

    2015-12-01

    Full Text Available Olive oil press cakes (OOPC represent a waste that has a negative impact on environment. OOPC have little or no use and because of that solutions for their alternative use are sought after. In our experiments we investigated substrate mixtures composed of different proportions of OOPC, wheat bran, crushed corn seeds and beech sawdust for cultivation of Ganoderma lucidum, Lentinula edodes and Grifola frondosa fruiting bodies. The increasing amount of OOPC in fruiting bodies cultivation substrates resulted in decreasing production of fruiting bodies. Results show, that although OOPC in small portion can be successfully used as a medicinal mushroom fruiting bodies cultivating substrate, their use is rational only, if no other substrate composing materials can be found or when OOPC usage solves the problem of its deposition.

  5. Valorisation of Jatropha curcas: Solubilisation of proteins and sugars from the NaOH extracted de-oiled press cake

    NARCIS (Netherlands)

    Kootstra, A.M.J.; Beeftink, H.H.; Sanders, J.P.M.

    2011-01-01

    In this study, we investigated the possibilities for increasing the valorisation of de-oiled Jatropha press cake (DO-JPC). The studied raw material is the by-product of the alkaline protein extraction of the DO-JPC: NaOH Extracted DO-JPC (NEDO-JPC). Protein solubilisation of NEDO-JPC was performed

  6. Pyrolysis of Jatropha curcas pressed cake for bio-oil production in a fixed-bed system

    International Nuclear Information System (INIS)

    Jourabchi, Seyed Amirmostafa; Gan, Suyin; Ng, Hoon Kiat

    2014-01-01

    Highlights: • The pyrolysis of Jatropha curcas waste in a fixed-bed rig was studied. • Yield, calorific value, water content and acidity of bio-oil were compared. • Empirical correlations for bio-oil yield and specifications were developed. • Optimisation of bio-oil production based on combined specifications was achieved. - Abstract: This study investigated the effects of pyrolysis parameters on the yield and quality of bio-oil from Jatropha curcas pressed cake. This biomass was pyrolysed in a fixed-bed reactor over a temperature range of 573.15 K to 1073.15 K and a nitrogen linear speed range of 7.8 × 10 −5 m/s to 6.7 × 10 −2 m/s. The heating rate and biomass grain size were 50 K/min and <2 mm, respectively. The bio-oils were tested for the gross calorific value, water content and acidity. The pyrolysis process was simulated using Thermo-Gravimetric Analysis (TGA) and Differential Scanning Calorimeter (DSC) for mass and energy balances analyses. Empirical correlations between the bio-oil specifications and pyrolysis parameters were developed using linear and nonlinear multiple regression methods for process optimisation. At optimum pyrolysis conditions, above 50% of the waste is converted to bio-oil with less than 30% water content, a gross calorific value of 15.12 MJ/kg and a pH of 6.77

  7. Pyrolysis of safflower (Charthamus tinctorius L.) seed press cake in a fixed-bed reactor: part 2. Structural characterization of pyrolysis bio-oils.

    Science.gov (United States)

    Sensöz, Sevgi; Angin, Dilek

    2008-09-01

    Biomass in the form of agricultural residues is becoming popular among new renewable energy sources, especially given its wide potential and abundant usage. Pyrolysis is the most important process among the thermal conversion processes of biomass. In this study, the various characteristics of bio-oils acquired under different pyrolysis conditions from safflower seed press cake (SPC) were identified. The elemental analyses and calorific values of the bio-oils were determined, and then the chemical compositions of the bio-oils were investigated using chromatographic and spectroscopic techniques such as column chromatography, (1)H NMR, FTIR and GC. The fuel properties of the bio-oil such as kinematic viscosity, flash point, density, water content and ASTM distillation were also determined. Chemical compositions of bio-oils showed that some quantities of hydrocarbons were present, while oxygenated and polar fractions dominated. The bio-oils obtained from safflower seed press cake were presented as an environmentally friendly feedstock candidate for biofuels and chemicals.

  8. Effects of hemp (Cannabis sativa L.) seed oil press-cake and decaffeinated green tea leaves (Camellia sinensis) on functional characteristics of gluten-free crackers.

    Science.gov (United States)

    Radočaj, Olga; Dimić, Etelka; Tsao, Rong

    2014-03-01

    A mixture, simplex centroid, 2 components experimental design was used to evaluate the addition of hemp seed oil press-cake and decaffeinated green tea leaves, as functional ingredients to assess nutritional characteristics and antioxidant properties of gluten-free crackers. All samples with added hemp flour had much better nutritional qualities than the brown rice flour crackers in terms of higher protein, crude fibers, minerals, and essential fatty acids content. Likewise, all samples with added decaffeinated green tea leaves had much better antioxidant properties than crackers with no added green tea leaves. All crackers with added hemp flour had a significantly increased fiber content (39% to 249%) and decreased carbohydrate content (8.4% to 42.3%), compared to the brown rice flour crackers. All samples had antioxidant properties, even without the addition of green tea leaves. Optimization of the responses was conducted based on the maximized values for protein, fibers, omega-3 fatty acids content, as well as for the antioxidant activity and overall score. The suggested values for the addition of the hemp oil press-cake was 20% (total flour weight) with 4 g of decaffeinated green tea leaves that would provide protein content of 14.1 g/100 g; fibers content of 8.4 g/100 g; omega-3 fatty acids content of 3.2 g/100 g; antioxidant activity measured via 2,2-diphenyl-1-picrylhydrazyl value of 30.3 μmol TE/g d.w.; and an overall score of 8.9. This formulation has demonstrated potential application in the baking industry and marketing of these gluten-free crackers as a value-added functional product. Hemp seed oil press-cake as a by-product of cold-pressed oil processing and brown rice flour were used to design a functional gluten-free snack-type product-savory crackers. All crackers were high in minerals, fibers, and omega-3 fatty acids with a desirable omega-6/omega-3 fatty acids ratio. Green tea leaves were added to improve antioxidant activity, which greatly

  9. Jatropha press cake as organic fertilizer in lettuce cultivation

    Directory of Open Access Journals (Sweden)

    José R. Mantovani

    Full Text Available ABSTRACT In biodiesel production, vegetable press cake is obtained as waste, and a suitable destination for jatropha press cake would be the use in agriculture as organic fertilizer. This study aimed to evaluate the effect of jatropha press cake on soil fertility attributes and on lettuce production and accumulation of nutrients in the shoots. The experiment was conducted in pots in a greenhouse, in a randomized block design with eight treatments and five replicates. The treatments consisted of doses of jatropha press cake equivalent to 0, 0.5, 1.0, 2.0, 4.0, 8.0, 16.0 and 32.0 t ha-1. Portions of 5.5 dm3 of soil received limestone, phosphate fertilizer and the doses of jatropha press cake, and remained incubated for 30 days. After incubation, soil samples were collected, each pot received one lettuce seedling and the experiment was carried out for 45 days. The organic fertilization with jatropha press cake increased the contents of nutrients in the soil, especially K+, but caused increment in soil acidity and electrical conductivity. The use of jatropha press cake as organic fertilizer decreased lettuce production and accumulation of nutrients in the shoots.

  10. Biogas production from Jatropha curcas press-cake.

    Science.gov (United States)

    Staubmann, R; Foidl, G; Foidl, N; Gübitz, G M; Lafferty, R M; Arbizu, V M; Steiner, W

    1997-01-01

    Seeds of the tropical plant Jatropha curcas (purge nut, physic nut) are used for the production of oil. Several methods for oil extraction have been developed. In all processes, about 50% of the weight of the seeds remain as a press cake containing mainly protein and carbohydrates. Investigations have shown that this residue contains toxic compounds and cannot be used as animal feed without further processing. Preliminary experiments have shown that the residue is a good substrate for biogas production. Biogas formation was studied using a semicontinous upflow anaerobic sludge blanket (UASB) reactor; a contact-process and an anaerobic filter each reactor having a total volume of 110 L. A maximum production rate of 3.5 m3 m"3 d"1 was obtained in the anaerobic filter with a loading rate of 13 kg COD m~3 d"1. However, the UASB reactor and the contact-process were not suitable for using this substrate. When using an anaerobic filter with Jatropha curcas seed cake as a substrate, 76% of the COD was degraded and 1 kg degraded COD yielded 355 L of biogas containing 70% methane.

  11. Biogas production from Jatropha curcas press-cake

    Energy Technology Data Exchange (ETDEWEB)

    Staubmann, R.; Guebitz, G.M.; Lafferty, R.M. [Graz Technical Univ. (Austria)] [and others

    1997-12-31

    Seeds of the tropical plant Jatropha curcas (purge nut, physic nut) are used for the production of oil. Several methods for oil extraction have been developed. In all processes, about 50% of the weight of the seeds remain as a press cake containing mainly protein and carbohydrates. Investigations have shown that this residue contains toxic compounds and cannot be used as animal feed without further processing. Preliminary experiments have shown that the residue is a good substrate for biogas production. Biogas formation was studied using a semicontinous upflow anaerobic sludge blanket (UASB) reactor; a contact-process and an anaerobic filter each reactor having a total volume of 110 L. A maximum production rate of 3.5 m{sup 3} m{sup -3} d{sup -1} was obtained in the anaerobic filter with a loading rate of 13 kg COD m{sup -3} d{sup -1}. However, the UAS reactor and the contact-process were not suitable for using this substrate. When using an anaerobic filter with Jatropha curcas seed cake as a substrate, 76% of the COD was degraded and 1 kg degraded COD yielded 355 L of biogas containing 70% methane. 28 refs., 3 figs., 4 tabs.

  12. Optimization of the texture of fat-based spread containing hull-less pumpkin (Cucurbita pepo L.) seed press-cake

    OpenAIRE

    Radočaj Olga F.; Dimić Etelka B.; Vujasinović Vesna B.

    2011-01-01

    Hull-less pumpkin seed press-cake, a by-product of the pumpkin oil pressing process, was used to formulate a fat-based spread which resembled commercial peanut butter; both in the appearance and in texture. In this study, response surface methodology was used to investigate the effects of a commercial stabilizer and cold-pressed hemp oil added to the pumpkin seed press-cake, on the texture of the formulations using instrumental texture profile analysis. The responses were significantly ...

  13. Utilisation of Jatropha press cake as substrate in biomass and lipase production from Aspergillus niger 65I6 and Rhizomucor miehei CBS 360.62

    NARCIS (Netherlands)

    Ilmi, Miftahul; Hidayat, C.; Hastuti, P.; Heeres, Hero; van der Maarel, Marc

    Jatropha curcas L. is a tropical plant that grows well on poor soils in arid regions and produces oil-rich, unedible seeds. The oil from these seeds can be used in the production of biodiesel. In addition, the press-cake waste that is left after oil extraction contains approximately 40% of protein.

  14. Apparent and true ileal and total tract digestibility of fat in canola press-cake or canola oil and effects of increasing dietary fat on amino acid and energy digestibility in growing pigs.

    Science.gov (United States)

    Zhou, X; Beltranena, E; Zijlstra, R T

    2017-06-01

    Digestibility of remaining oil in canola press-cake (CPC) may be lower than that of extracted, liquid canola oil (CO) because oil may be partly entrapped in the CPC matrix. To determine true digestibility of fat in ingredients, endogenous fat losses should be estimated. Dietary fat may interact with digestion of other dietary components. To test these hypotheses, 10 ileal-cannulated pigs (initial BW, 25.4 kg) were fed 10 diets for 8 periods in a 10 × 8 Youden square. A basal diet was formulated based on wheat, barley, and canola meal. The 4 CPC and 4 CO test diets were prepared by replacing identical portion of basal diet with 10%, 20%, 30%, or 40% CPC, or 1.5%, 3.0%, 4.5%, or 6.0% CO, respectively, to match the fat content of CPC diet with CO diet at each fat level. An N-free diet based on corn starch was prepared to measure basal endogenous losses of AA. Apparent total tract digestibility (ATTD) and apparent ileal digestibility (AID) of acid-hydrolyzed ether extract (AEE) were calculated for each diet. True ileal digestibility (TID) and true total tract (TTTD) digestibility of AEE in CPC and CO, and total endogenous losses of AEE were estimated by regressing apparent digestible AEE (g/kg of DMI) against dietary AEE intake (g/kg of DM) at the total tract and distal ileum, respectively. The mean AID and ATTD of AEE in CPC diets were 78.9% and 61.5%, which were lower ( digestible AEE content in CPC and CO diets increased linearly ( 0.05) total tract or ileal endogenous losses of AEE. The TID and TTTD of AEE in CPC were 92.3% and 94.5%, respectively, lower ( digestibility (SID) of CP, Lys, Met, Thr, and Trp, and quadratically increased ( digestibility of AEE in CPC than in CO indicates that fat digestibility of CPC should be considered to predict its nutritional value accurately. Dietary inclusion of CO may increase digestibility of CP and energy originating from the balance of the diet.

  15. Sunflower press cake as a substrate for eicosapentaenoic acid production by representatives of the genus Mortierella

    CSIR Research Space (South Africa)

    Jacobs, A

    2010-05-01

    Full Text Available Long chain omega-3 fatty acids such as eicosapentaenoic acid (EPA) are essential for the regulation of critical biological functions in humans and other mammals. EPA production via solid state fermentation of sunflower press cake was investigated...

  16. Alpha amylase from a fungal culture grown on oil cakes and its properties

    OpenAIRE

    Ramachandran,Sumitra; Patel,Anil K.; Nampoothiri,Kesavan Madhavan; Chandran,Sandhya; Szakacs,George; Soccol,Carlos Ricardo; Pandey,Ashok

    2004-01-01

    Solid-state fermentation was carried out for the production of alpha-amylase using Aspergillus oryzae. Different oil cakes such as coconut oil cake (COC) sesame oil cake (SOC), groundnut oil cake (GOC), palm kernel cake (PKC) and olive oil cake (OOC) were screened to be used as substrate for the enzyme production and also compared with wheat bran (WB). GOC was found to be the best producer of the enzyme among these. Combination of WB and GOC (1:1) resulted higher enzyme titres than the indivi...

  17. LDPE/PHB blends filled with castor oil cake

    Science.gov (United States)

    Burlein, Gustavo A.; Rocha, Marisa C. G.

    2015-05-01

    The response surface methodology (RSM) is a collection of mathematical techniques useful for developing, improving and optimizing process. In this study, RSM technique was applied to evaluate the effect of the components proportion on the mechanical properties of low density polyethylene (LDPE)/ poly (3-hydroxy-butyrate) (PHB) blends filled with castor oil cake (CC). The blends were prepared by melt mixing in a twin screw extruder. Low density polyethylene, poly (3-hydroxy-butyrate) and castor oil pressed cake were represented by the input variables designated as LDPE, PHB and CC, respectively. As it was desirable to consider the largest LDPE content in the ternary system, the components of the mixture were subjected to the following constraints: 0.7 ≤ LDPE ≤ 1.0, 0≤ PHB≤0.3 e 0 ≤ CC ≤0.3. The mechanical properties of the different mixtures were determined by conventional ASTM tests and were evaluated through analysis of variance performed by the Minitab software. Some polynomial equations were tested in order to describe the mechanical behavior of the samples. The quadratic model in pseudo components was selected for describing the tensile behavior because it was the most efficient from a statistical point of view (p-value ≤ 0.05; coefficient of determination (r2) close to 1 and variation inflation factor (VIF) values PHB or CC. The tensile strength values of binary mixtures of LDPE lie in the range from 8.9 to 10 MPa. As some commercial grades of LDPE have mechanical strength in this range, it may be inferred that the addition of a certain amount of PHB or CC to LDPE may be considered as a possibility for obtaining LDPE based materials with increased susceptibility to biodegradation. The cubic model in pseudo components was selected for describe the flexural strength of the samples because it was the most adequate from a statistical point of view. However, the linear model in pseudo components was the most efficient to describe the flexural modulus

  18. Effects of de-oiled palm kernel cake based fertilizers on sole maize ...

    African Journals Online (AJOL)

    A study was conducted to determine the effect of de-oiled palm kernel cake based fertilizer formulations on the yield of sole maize and cassava crops. Two de-oiled palm kernel cake based fertilizer formulations A and B were compounded from different proportions of de-oiled palm kernel cake, urea, muriate of potash and ...

  19. Producing bio-pellets from sunflower oil cake for use as an energy source

    Energy Technology Data Exchange (ETDEWEB)

    Kobayashi, Yuichi; Kato, Hitoshi; Kanai, Genta; Togashi, Tatsushi [National Agricultural Research Center (Japan)], E-mail: kobay@affrc.go.jp

    2008-07-01

    Pellet fuels were produced from ground sunflower oil cake using a pelletizer. The length, hardness, and powder characteristics of dried pellets depend on the initial water content of the oil cake. The appropriate values of water contents were 19.9 - 21.0% w.b. Oil cake pellets were found to contain 6.07% ash and 20.99 MJ/kg caloric value, which are within the standard range of wood pellets. Combustion experiments using a commercial pellet stove demonstrate that oil cake pellets burn as well as wood pellets. Oil cake pellets are useful as a fuel alternative to wood pellets. (author)

  20. Low density polyethylene (LDPE) / poli (3-hydroxy-butyrate) (PHB) blends filled with castor oil cake

    International Nuclear Information System (INIS)

    Rocha, M.C.G.; Oliveira, C.I.R. de; Sanches, M.C.; Coelho, N.N.

    2014-01-01

    Blends of PHB and LDPE were prepared by melt mixing in a Haake internal mixer. Castor oil pressed cake was used as filler for the blends. In order to improve the interfacial adhesion between the filler and the polymers, a mercerization process with 5% NaOH solution was employed. This process was evaluated by several techniques such as: X-Ray diffraction, infrared spectroscopy and scanning electron microscopy (SEM). The mechanical properties were evaluated by traditional tensile stress-strain tests (ASTM D- 638). The obtained results showed that the mercerization process leads to better adhesion properties. The Young Modulus of the blends presented a tendency to increase with the addition of the castor oil cake.(author)

  1. Natural cold pressed oils as cosmetic products

    Directory of Open Access Journals (Sweden)

    Małgorzata Ligęza

    2016-12-01

    Full Text Available Background. It seems that patients may ask general practitioners about natural cosmetics applied on the skin regarding their safety and suitability. Objectives. The aim of the study was to analyze natural cold pressed oils as potential cosmetic products. Material and methods. Cold pressed oils obtained from selected seeds and fruit stones were analyzed, including: chokeberry seed oil, blackcurrant seed oil, elderberry seed oil, raspberry seed oil, apricot seed oil, tomato seed oil, strawberry seed oil, broccoli seed oil, Nigella sativa seed oil, hemp oil, safflower seed oil, Silybum marianum seed oil and coconut oil. 80 adult volunteers assessed the cosmetic properties of the analyzed oils. Each of the volunteers tested 2 to 4 different oils, by applying them on the skin. In addition, patch tests with all analyzed oils were performed on 23 individuals. Results. The majority of tested oils were positively evaluated by the participants: in the opinion of the participants, oil extracted from safflower had the best appearance (100% positive opinions, coconut oil had the best smell (70% positive opinions, while black currant seed oil showed the best absorbency (85% positive opinions. No irritation was observed within the analyzed product group, albeit one allergic reaction to apricot seed oil was observed with patch testing. Conclusions . Based on the achieved results, it could be suggested that natural cold pressed oils can be applied to the skin as cosmetics. Our observations may be helpful for general practitioners when choosing natural cosmetics.

  2. Optimization of the texture of fat-based spread containing hull-less pumpkin (Cucurbita pepo L. seed press-cake

    Directory of Open Access Journals (Sweden)

    Radočaj Olga F.

    2011-01-01

    Full Text Available Hull-less pumpkin seed press-cake, a by-product of the pumpkin oil pressing process, was used to formulate a fat-based spread which resembled commercial peanut butter; both in the appearance and in texture. In this study, response surface methodology was used to investigate the effects of a commercial stabilizer and cold-pressed hemp oil added to the pumpkin seed press-cake, on the texture of the formulations using instrumental texture profile analysis. The responses were significantly affected by both variables tested in a central composite, two factorial experimental design on five levels. Strong and firm spreads, without visible oil separation were formed and had an appearance and texture comparable to commercial peanut butter. In terms of the primary food texture attributes such as hardness, cohesiveness and adhesiveness, determined by the instrumental texture analysis, the optimum combination of variables with 1-1.2% of added stabilizer and 20- 40% of added hemp oil (in the oil phase produced desirable spreads.

  3. Anaerobic digestion of Jatropha curcas L. press cake and effects of an iron-additive.

    Science.gov (United States)

    Schmidt, Thomas

    2011-11-01

    Oil production from Jatropha curcas L. seeds generates large amounts of Jatropha press cake (JPC) which can be utilized as a substrate for biogas production. The objective of this work was to investigate anaerobic mono-digestion of JPC and the effects of an iron additive (IA) on gas quality and process stability during the increase of the organic loading rate (OLR). With the increase of the OLR from 1.3 to 3.2 g(VS) L(-1) day(-1), the biogas yield in the reference reactor (RR) without IA decreased from 512 to 194 L(N) kg(VS) (-1) and the CH₄ concentration decreased from 69.3 to 44.4%. In the iron additive reactor (IAR), the biogas yield decreased from 530 to 462 L(N) kg(VS) (-1) and the CH₄ concentration decreased from 69.4 to 61.1%. The H₂S concentration in the biogas was reduced by addition of the IA to values below 258 ppm in the IAR while H₂S concentration in the RR increased and exceeded the detection limit of 5000 ppm. The acid capacity (AC) in the RR increased to more than 20 g L(-1), indicating an accumulation of organic acids caused by process instability. AC values in the IAR remained stable at values below 5 g L(-1). The results demonstrate that JPC can be used as sole substrate for anaerobic digestion up to an OLR of 2.4 g(VS) l(-1) day(-1). The addition of IA has effectively decreased the H(2)S content in the biogas and has improved the stability of the anaerobic process and the biogas quality.

  4. Use of baru (Brazilian almond) waste from physical extraction of oil to produce gluten free cakes.

    Science.gov (United States)

    Pineli, Lívia de Lacerda de Oliveira; de Aguiar, Lorena Andrade; de Oliveira, Guilherme Theodoro; Botelho, Raquel Braz Assunção; Ibiapina, Maria do Desterro Ferreira Pereira; de Lima, Herbert Cavalcanti; Costa, Ana Maria

    2015-03-01

    The extraction of oil from baru almonds produces a waste that carries part of their nutritional qualities and antioxidants. It can be used to produce partially deffated baru flour (PDBF). We aimed to evaluate the applicability of PDBF and the effect of the addition of xanthan gum (XG) to produce gluten free cakes. Cakes were prepared with 100% wheat flour (WF cake) and with 100% PDBF and four different levels of XG (0%-PDBF cake, 0.1%-X1, 0.2%-X2 and 0.3%-X3 cakes), and evaluated for composition, antioxidants, moisture, specific volume, texture and sensory acceptance. PDBF cakes showed lower carbohydrate values, but higher protein, lipids, calories and antioxidant contents. They were rich in fiber, as well as iron, zinc and copper. The replacement of WF by PDBF resulted in an increased hardness and adhesiveness and a decreased cohesiveness, elasticity and moisture. Chewiness of X2 cake was similar to that of WF cake. X2 and X3 cakes showed specific volume closer to that of WF cake. No difference was found among the treatments for texture and appearance acceptances. Flavor of X2 and X3 cakes were more accepted than WF cake. Acceptance of all cakes were in the liking region of hedonic scale. PBDF associated to XG is a feasible option to substitute WF in gluten free cake, improving its nutritional quality.

  5. Experimental assessment of toxic phytochemicals in Jatropha curcas: oil, cake, bio-diesel and glycerol.

    Science.gov (United States)

    Pradhan, Subhalaxmi; Naik, S N; Khan, M Ashhar I; Sahoo, P K

    2012-02-01

    Jatropha curcas seed is a rich source of oil; however, it can not be utilised for nutritional purposes due to presence of toxic and anti-nutritive compounds. The main objective of the present study was to quantify the toxic phytochemicals present in Indian J. curcas (oil, cake, bio-diesel and glycerol). The amount of phorbol esters is greater in solvent extracted oil (2.8 g kg⁻¹) than in expeller oil (2.1 g kg⁻¹). Liquid chromatography-mass spectroscopy analysis of the purified compound from an active extract of oil confirmed the presence of phorbol esters. Similarly, the phorbol esters content is greater in solvent extracted cake (1.1 g kg⁻¹) than in cake after being expelled (0.8 g kg⁻¹). The phytate and trypsin inhibitory activity of the cake was found to be 98 g kg⁻¹ and 8347 TIU g⁻¹ of cake, respectively. Identification of curcin was achieved by sodium dodecyl sulfate-polyacrylamide gel electrophoresis and the concentration of curcin was 0.95 g L⁻¹ of crude concentrate obtained from cake. Higher amounts of phorbol esters are present in oil than cake but bio-diesel and glycerol are free of phorbol esters. The other anti-nutritional components such as trypsin inhibitors, phytates and curcin are present in cake, so the cake should be detoxified before being used for animal feed. Copyright © 2011 Society of Chemical Industry.

  6. Phytochemical Composition, Antioxidant Activity, and the Effect of the Aqueous Extract of Coffee (Coffea arabica L.) Bean Residual Press Cake on the Skin Wound Healing.

    Science.gov (United States)

    Affonso, Regina Celis Lopes; Voytena, Ana Paula Lorenzen; Fanan, Simone; Pitz, Heloísa; Coelho, Daniela Sousa; Horstmann, Ana Luiza; Pereira, Aline; Uarrota, Virgílio Gavicho; Hillmann, Maria Clara; Varela, Lucas Andre Calbusch; Ribeiro-do-Valle, Rosa Maria; Maraschin, Marcelo

    2016-01-01

    The world coffee consumption has been growing for its appreciated taste and its beneficial effects on health. The residual biomass of coffee, originated in the food industry after oil extraction from coffee beans, called coffee beans residual press cake, has attracted interest as a source of compounds with antioxidant activity. This study investigated the chemical composition of aqueous extracts of coffee beans residual press cake (AE), their antioxidant activity, and the effect of topical application on the skin wound healing, in animal model, of hydrogels containing the AE, chlorogenic acid (CGA), allantoin (positive control), and carbopol (negative control). The treatments' performance was compared by measuring the reduction of the wound area, with superior result ( p coffee AE (78.20%) with respect to roasted coffee AE (53.71%), allantoin (70.83%), and carbopol (23.56%). CGA hydrogels reduced significantly the wound area size on the inflammatory phase, which may be associated with the well known antioxidant and anti-inflammatory actions of that compound. The topic use of the coffee AE studied improved the skin wound healing and points to an interesting biotechnological application of the coffee bean residual press cake.

  7. Phytochemical Composition, Antioxidant Activity, and the Effect of the Aqueous Extract of Coffee (Coffea arabica L. Bean Residual Press Cake on the Skin Wound Healing

    Directory of Open Access Journals (Sweden)

    Regina Celis Lopes Affonso

    2016-01-01

    Full Text Available The world coffee consumption has been growing for its appreciated taste and its beneficial effects on health. The residual biomass of coffee, originated in the food industry after oil extraction from coffee beans, called coffee beans residual press cake, has attracted interest as a source of compounds with antioxidant activity. This study investigated the chemical composition of aqueous extracts of coffee beans residual press cake (AE, their antioxidant activity, and the effect of topical application on the skin wound healing, in animal model, of hydrogels containing the AE, chlorogenic acid (CGA, allantoin (positive control, and carbopol (negative control. The treatments’ performance was compared by measuring the reduction of the wound area, with superior result (p<0.05 for the green coffee AE (78.20% with respect to roasted coffee AE (53.71%, allantoin (70.83%, and carbopol (23.56%. CGA hydrogels reduced significantly the wound area size on the inflammatory phase, which may be associated with the well known antioxidant and anti-inflammatory actions of that compound. The topic use of the coffee AE studied improved the skin wound healing and points to an interesting biotechnological application of the coffee bean residual press cake.

  8. Catalytic flash pyrolysis of oil-impregnated-wood and jatropha cake using sodium based catalysts

    KAUST Repository

    Imran, Ali; Bramer, Eddy A.; Seshan, Kulathuiyer; Brem, Gerrit

    2015-01-01

    Catalytic pyrolysis of wood with impregnated vegetable oil was investigated and compared with catalytic pyrolysis of jatropha cake making use of sodium based catalysts to produce a high quality bio-oil. The catalytic pyrolysis was carried out in two

  9. Characterization of virgin walnut oils and their residual cakes produced from different varieties.

    Science.gov (United States)

    Ojeda-Amador, Rosa M; Salvador, María Desamparados; Gómez-Alonso, Sergio; Fregapane, Giuseppe

    2018-06-01

    This study addresses the composition and properties of different walnut varieties (Chandler, Hartley and Lara), in particular their virgin oils and residual cakes obtained by screw pressing employing different cultivars. Among nuts, walnut (Juglans regia L.) exhibits interesting nutritional value, mainly due to their high content in linoleic acid, phenolic and tocopherol compounds, which show antioxidant and other healthy properties. Valuable results related to fatty acid profile and minor components were observed. Virgin walnut oil is a rich source in linoleic acid (60-62%) and γ-tocopherol (517-554 mg/kg). Moreover, walnuts show a very high content in total phenolic compounds (10,045-12,474 mg/kg; as gallic acid), which contribute to a great antioxidant activity (105-170 mmol/kg for DPPH, and 260-393 mmol/kg for ORAC), being the hydrolysable tannins (2132-4204 mg/kg) and flavanols (796-2433 mg/kg) their main phenolic groups. Aldehydes account for the highest contribution to aromatic volatiles in virgin walnut oil (about 35% of total). As expected, polar phenolic compounds concentrate in the residual cake, after the separation of the oily phase, reaching a content of up to 19,869 mg/kg, leading to potential added value and applications as source of bioactive compounds to this by-product. Copyright © 2018 Elsevier Ltd. All rights reserved.

  10. Design and testing of a solar photovoltaic operated multi-seeds oil press

    Energy Technology Data Exchange (ETDEWEB)

    Mpagalile, J.J. [Department of Food Science and Technology, Sokoine University of Agriculture, P.O. Box 3006, Morogoro (Tanzania); Hanna, M.A.; Weber, R. [Industrial Agricultural Products Center, University of Nebraska, 209 L.W. Chase Hall, Lincoln, NE 68583-0730 (United States)

    2006-10-15

    Oil expression tests were conducted to evaluate the performance of a novel oil expeller designed and fabricated to operate on a 200W solar photovoltaic (PV) power system as a sole power source. The oil press was designed to press oilseeds meal with intermediate moisture content of 12+/-1% (w.b.) and 0.5-2mm particle sizes. Freshly grated coconuts and ground peanuts were used to determine the oil expression efficiency of the press. The oilseed samples were pressed for 12min with a maximum pressure of 3.0MPa being reached at 6min of pressing for peanuts and 8min of pressing for coconuts. The pressure was then held for the rest of the pressing time. The press attained an average oil expression efficiency of 73% for coconuts and 70% for peanuts. The force-vs.-deformation studies indicated that peanut press meal was compacted at a higher rate as compared to coconuts. The observation on the energy consumption indicated that there was a significant increase (P<0.05) in the specific energy requirement for both coconuts and peanuts after 6min of pressing, which resulted from the solidification of the press cake. An average specific energy of 36.55 and 20.35Wh/kg was recorded for peanuts and coconuts, respectively, after 12min of pressing. (author)

  11. Press Oil Final Release Survey

    Energy Technology Data Exchange (ETDEWEB)

    Whicker, Jeffrey Jay [Los Alamos National Lab. (LANL), Los Alamos, NM (United States); Ruedig, Elizabeth [Los Alamos National Lab. (LANL), Los Alamos, NM (United States)

    2017-05-11

    There are forty-eight 55 gallon barrels filled with hydraulic oil that are candidates for release and recycle. This oil needs to be characterized prior to release. Principles of sampling as provided in MARSAME/MARSSIM approaches were used as guidance for sampling.

  12. Sampling and analysis plan for ORNL filter press cake waste from the Liquid and Gaseous Waste Operations Department

    International Nuclear Information System (INIS)

    Bartling, M.H.; Bayne, C.K.; Cunningham, G.R.

    1994-09-01

    This document defines the sampling and analytical procedures needed for the initial characterization of the filter press cake waste from the Process Waste Treatment Plant (PWTP) at the Oak Ridge National Laboratory (ORNL). It is anticipated that revisions to this document will occur as operating experience and sample results suggest appropriate changes be made. Application of this document will be controlled through the ORNL Waste Management and Remedial Action Division. The sampling strategy is designed to ensure that the samples collected present an accurate representation of the waste process stream. Using process knowledge and preliminary radiological activity screens, the filter press cake waste is known to contain radionuclides. Chemical characterization under the premise of this sampling and analysis plan will provide information regarding possible treatments and ultimately, disposal of filter press cake waste at an offsite location. The sampling strategy and analyses requested are based on the K-25 waste acceptance criteria and the Nevada Test Site Defense Waste Acceptance Criteria, Certification, and Transfer Requirements [2, NVO-325, Rev. 1]. The sampling strategy will demonstrate that for the filter press cake waste there is (1) an absence of RCRA and PCBs wastes, (2) an absence of transuranic (TRU) wastes, and (3) a quantifiable amount of radionuclide activity

  13. Production of ethanol and feed by high dry matter hydrolysis and fermentation of palm kernel press cake.

    Science.gov (United States)

    Jørgensen, Henning; Sanadi, Anand R; Felby, Claus; Lange, Niels Erik Krebs; Fischer, Morten; Ernst, Steffen

    2010-05-01

    Palm kernel press cake (PKC) is a residue from palm oil extraction presently only used as a low protein feed supplement. PKC contains 50% fermentable hexose sugars present in the form of glucan and mainly galactomannan. This makes PKC an interesting feedstock for processing into bioethanol or in other biorefinery processes. Using a combination of mannanase, beta-mannosidase, and cellulases, it was possible without any pretreatment to hydrolyze PKC at solid concentrations of 35% dry matter with mannose yields up to 88% of theoretical. Fermentation was tested using Saccharomyces cerevisiae in both a separate hydrolysis and fermentation (SHF) and simultaneous saccharification and fermentation (SSF) setup. The hydrolysates could readily be fermented without addition of nutrients and with average fermentation yields of 0.43 +/- 0.02 g/g based on consumed mannose and glucose. Employing SSF, final ethanol concentrations of 70 g/kg was achieved in 216 h, corresponding to an ethanol yield of 70% of theoretical or 200 g ethanol/kg PKC. Testing various enzyme mixtures revealed that including cellulases in combination with mannanases significantly improved ethanol yields. Processing PKC to ethanol resulted in a solid residue enriched in protein from 17% to 28%, a 70% increase, thereby potentially making a high-protein containing feed supplement.

  14. Kinetic study of oil extraction from olive foot cake

    Directory of Open Access Journals (Sweden)

    Lamrous, O.

    2006-06-01

    Full Text Available The kinetics of oil extraction from olive foot cake can be explained by a model based on two stages. The first step corresponds to a simple washing of the oil from the particle surface. In the second step, the extraction is controlled by two mechanisms: slow diffusion from broken cells and very slow diffusion from intact cells.The kinetic coefficients of this mathematical model are calculated using the experimental results obtained from hexane and commercial ethyl alcohol for different particle sizes.La cinética de extracción de aceite de orujo puede ser explicada por un modelo basado en dos etapas. La primera etapa corresponde a un simple lavado del aceite de la superficie de las partículas. En la segunda etapa, la extracción esta controlada por dos mecanismos: difusión lenta desde las células rotas y difusión muy lenta desde las células intactas.Los coeficientes cinéticas de este modelo matemático se calculan usando los resultados experimentales obtenidos con hexano y alcohol etílico comercial para diferentes tamaños de partícula.

  15. Oil extraction from olive foot cake with acidic hexane

    Directory of Open Access Journals (Sweden)

    Kmieciak, S.

    1991-02-01

    Full Text Available The use of acidic hexane as a solvent increases the extracted oil yield from olive foot cake. Two extraction procedures are studied: open air extraction at room temperature and Soxhlet exhaustive extraction. The additional yield is about 5% for a 2.5% acetic acid content in case of open air extraction and turns out to be 9% for 7.5% acetic acid content in the Soxhlet procedure. An analysis of the extracted oil shows a light increase of the acidity of oil. The improved yield may be attributed to the action of acetic acid on the decomposition of intercellular structures and binding of some polar lipids. The phospholipids content of oil extracted with 7.5% acidic hexane is found to be 25 times more than with pure hexane.

    El uso de hexano ácido como disolvente aumenta el rendimiento de aceite extraído de orujo de aceituna. Se han estudiado dos procedimientos de extracción: extracción al aire libre a temperatura ambiente y extracción exhaustiva en Soxhlet. En el caso de extracción al aire libre el rendimiento adicional es alrededor del 5% para un contenido del 2'5% en ácido acético y llega a ser en el procedimiento en Soxhlet del 9% para un contenido en ácido acético del 7'5%. Un análisis del aceite extraído mostró un ligero aumento de la acidez del aceite. La mejora del rendimiento puede ser atribuida a la acción del ácido acético sobre la descomposición de estructuras intercelulares y uniones de lípidos polares. Se ha encontrado que el contenido en fosfolípidos del aceite extraído con el 7*5% de hexano ácido es 25 veces mayor que con hexano puro.

  16. Optimization of palm oil extraction from Decanter cake of small crude palm oil mill by aqueous surfactant solution using RSM

    Science.gov (United States)

    Ahmadi Pirshahid, Shewa; Arirob, Wallop; Punsuvon, Vittaya

    2018-04-01

    The use of hexane to extract vegetable oil from oilseeds or seed cake is of growing concern due to its environmental impact such as its smelling and toxicity. In our method, used Response Surface Methodology (RSM) was applied to study the optimum condition of decanter cake obtained from small crude palm oil with aqueous surfactant solution. For the first time, we provide an optimum condition of preliminary study with decanter cake extraction to obtain the maximum of oil yield. The result from preliminary was further used in RSM study by using Central Composite Design (CCD) that consisted of thirty experiments. The effect of four independent variables: the concentration of Sodium Dodecyl Sulfate (SDS) as surfactant, temperature, the ratio by weight to volume of cake to surfactant solution and the amount of sodium chloride (NaCl) on dependent variables are studied. Data were analyzed using Design-Expert 8 software. The results showed that the optimum condition of decanter cake extraction were 0.016M of SDS solution concentration, 73°C of extraction temperature, 1:10 (g:ml) of the ratio of decanter cake to SDS solution and 2% (w/w) of NaCl amount. This condition gave 77.05% (w/w) oil yield. The chemical properties of the extracted palm oil from this aqueous surfactant extraction are further investigated compared with the hexane extraction. The obtained result showed that all properties of both extractions were nearly the same.

  17. [Use of flour from sunflower oil cake in the biosynthesis of antigungal antibiotics].

    Science.gov (United States)

    Sukharevich, V M; Shvetsova, N N; Prodan, S I; Malkov, M A

    1977-04-01

    The possibility of replacing soybean meal and corn-steep liquor by food wastes of the oilpress industry and the meal of the sunflower oil cake in particular is discussed as applied to the fermentation media for production of antifungal antibiotics, such as levorin, mycoheptin, amphotericin. The studies showed that replacement of soybean meal by sunflower oil cake meal with simultaneous increasing of the amount of carbohydrates in the medium increased the levorin levels by 60--70 per cent as compared to the media used at present. When soybean meal and corn-steep liquor were simultaneously replaced by sunflower oil cake meal in amounts of 3--4 per cent the levels of mycoheptin in the fermentation broth increased by 30--65 per cent respectively. Replacement of soybean meal and corn-steep liquor by 3 per cent of sunflow oil cake meal in the medium used presently increased the amphotericin levels by 27 percent as compared to the control. Therefore, sunflower oil cake meal is a substitute of full value for soybean meal and corn-steep liquor in the fermentation media for production of antifungal antibiotics.

  18. Effect of vegetable de-oiled cake-diesel blends on diesel engine

    Energy Technology Data Exchange (ETDEWEB)

    Raj, C.S. [Bharathiyar College of Engineering and Technology, Karaikal (India). MGR Educational and Research Inst.; Arivalagar, A.; Sendilvelan, S. [MGR Univ., Chennai (India). MGR Educational and Research Inst.; Arul, S. [Panimalar College of Engineering, Channai (India)

    2009-07-01

    This study evaluated the use of coconut oil methyl ester (COME) as a blending agent with the vegetable de-oiled cakes used in biodiesel production. Different proportions of the de-oiled cake were combined with diesel in order to investigate performance, emissions, and combustion characteristics. The experiments were conducted on a 4-stroke single cylinder, air-cooled diesel engine. Fuel flow rates were measured and a thermocouple was used to measure exhaust gas temperatures. A combustion analyzer was used to measure cylinder pressure and heat release rates. Brake thermal efficiency, brake power, and specific fuel consumption performance was monitored. Results of the study showed that rates of heat release were reduced for the de-oiled cake blended fuels as a result of the change in fuel molecular weight. The variation of NOx with load for neat diesel blends was examined. There was no variation of NOx emission up to 50 per cent of load for all blended oils, and it increased with load. Smoke density was reduced for all blends. Soot production was decreased by the oxygen present in the de-oiled cake. The study showed that fossil fuel oil consumption decreased by 14 to 15 per cent when the de-oiled biodiesel was used at low loads, and 4 to 5 per cent at peak loads. 10 refs., 4 tabs., 9 figs.

  19. Catalytic flash pyrolysis of oil-impregnated-wood and jatropha cake using sodium based catalysts

    NARCIS (Netherlands)

    Ali Imran, A.; Bramer, Eduard A.; Seshan, Kulathuiyer; Brem, Gerrit

    2016-01-01

    Catalytic pyrolysis of wood with impregnated vegetable oil was investigated and compared with catalytic pyrolysis of jatropha cake making use of sodium based catalysts to produce a high quality bio-oil. The catalytic pyrolysis was carried out in two modes: in-situ catalytic pyrolysis and post

  20. Lead biotransformation potential of allochthonous Bacillus sp. SKK11 with sesame oil cake in mine soil

    Science.gov (United States)

    This study was aimed at assessing the potential of allochthonous Bacillus sp. SKK11 and sesame oil cake extract for transformation of Pb in mine soil. The bacteria were isolated from a brackish environment and identified as Bacillus sp. based on partial 16S rDNA sequences. The isolate SKK11 exhibite...

  1. Residues in cottonseed oil and cake resulting from the combined application of DDT and dimethoate

    International Nuclear Information System (INIS)

    El Zorgani, G.A.; Ahmed, M.M.

    1981-01-01

    Cotton plants were treated with a combination of DDT and dimethoate under conditions of local agricultural practice to study the fate and magnitude of both chemicals in the cottonseed and related products. GLC and nuclear (using 14 C-DDT) techniques were used. DDT residues in the crude oil averaged 0.115 mg/kg; mainly as p,p'-DDT while residues in the cake were not detected. Dimethoate and dimethoxon in the crude oil were 0.13 and 0.01 mg/kg respectively. The cake contained 0.14 mg/kg dimethoate and 0.01 mg/kg dimethoxon. By simulating commercial oil processing in the laboratory using 14 C-DDT fortified oil samples it was found that alkali treatment and bleaching removed only 7% of the total residue, while deodorization effected removal of 40-50% of the residue. (author)

  2. Chemical composition and oxidative stability of jussara (Euterpe edulis M.) oil extracted by cold and hot mechanical pressing

    International Nuclear Information System (INIS)

    Da Cunha, A.L.A.; Freitas, S.P.; Godoy, R.L.O.; Cabral, L.M.C.; Tonon, R.V.

    2017-01-01

    The aim of this work was to evaluate the effect of mechanical pressing on jussara oil yield, oxidative stability and carotenoid profile with or without heat application. Firstly, jussara pulp was centrifuged for juice extraction, and the resulting cake was dried until reaching 10% moisture content. Then, oil extraction was performed in an expeller press at 25 ºC (cold pressing) and at 50 ºC (hot pressing). The process performance was evaluated by the oil yield, and the crude jussara oil was characterized for fatty acid composition, acid value, carotenoid profile and oxidative stability. Jussara oil contained 74% unsaturated fatty acids, mainly oleic and linoleic acids (48% and 24%, respectively). The oil yield was almost twice as high for the hot process as compared to the cold one. Additionally, hot pressing resulted in 25% higher total carotenoid content as compared to cold pressing, with β-carotene as the most abundant one. Hot and cold pressing showed no difference in oil oxidative stability and fatty acid composition. [es

  3. Degradation of Jatropha curcas phorbol esters derived from Jatropha oil cake and their tumor-promoting activity.

    Science.gov (United States)

    Nakao, Motoyuki; Hasegawa, Go; Yasuhara, Tadashi; Ishihara, Yoko

    2015-04-01

    Large amount of oil cake is generated during biodiesel production from Jatropha seeds. Although Jatropha oil cake is rich in plant nutrients, presence of toxic phorbol esters restricts the usage of oil cake as a fertilizer. The objective of this study is to evaluate the components and tumor promoting activity of phorbol esters in Jatropha oil cake-supplemented soil and plants grown in the treated soil. Contents and their biological activity of Jatropha phorbol esters in soil and plants were sequentially analyzed by high-performance liquid chromatography (HPLC) and in vitro cell transformation assay, respectively. Disappearance of Jatropha phorbol-ester-specific peaks were followed with HPLC during incubation of Jatropha oil cake with soil for five weeks. Along with the degradation of Jatropha phorbol ester in soil, tumor-promoting activity in the sample was also attenuated and ultimately disappeared. Jatropha phorbol esters and tumor promoting activity were not detected from mustard spinach grown in the Jatropha oil cake-supplemented soil. In addition, the esterase KM109 degrades DHPB (see definition below; Jatropha phorbol ester) and reduced its tumor-promoting activity. From these data, we conclude: (1) components and tumor promoting activity of Jatropha phorbol esters in the oil cake disappeared completely by incubation with soil for five-week, (2) Jatropha phorbol esters did not transfer into plants grown in the Jatropha oil cake-supplemented soil, and (3) DHPB can be degraded by esterase from soil bacterium. These observations are useful for utilization of Jatropha oil cake as a fertilizer. Copyright © 2014 Elsevier Inc. All rights reserved.

  4. Non-edible Oil Cakes as a Novel Substrate for DPA Production and Augmenting Biocontrol Activity of Paecilomyces variotii.

    Science.gov (United States)

    Arora, Kalpana; Sharma, Satyawati; Krishna, Suresh B N; Adam, Jamila K; Kumar, Ashwani

    2017-01-01

    The present study investigated the use of waste non-edible oil cakes (Jatropha, Karanja, Neem, and Mahua) as a substrate for the growth of Paecilomyces variotii and dipicolinic acid (DPA) production. Previous researches proved the efficacy of DPA in suppressing certain pathogens that are deleterious to the plants in the rhizosphere. DPA production was statistical optimized by amending non-edible oil cakes in growing media as nitrogen and sugars (Dextrose, Glucose, and Lactose) as carbon source. Plackett-Burman design (PBD), indicated that Jatropha cake, Karanja cake, and Dextrose were the most significant components ( p edible oil cakes as a substrate offer an efficient and viable approach for DPA production by P. variotii .

  5. Radiocaesium activity in rape oil and in rape cake after a wet deposition event

    Energy Technology Data Exchange (ETDEWEB)

    Chaiko, Y.; Rappe-George, M.; Bengtsson, S. [Department of Soil and Environment (Sweden)

    2014-07-01

    After a release of radionuclides in agricultural areas there can be concerns on the levels of radionuclides in food products produced. The uptake of radionuclides via the above ground plant parts is a very important transport route into the food chain for humans as caesium is relatively mobile inside plants. In the production of rape oil the use of a processing factor (Pf) is used to estimate the activity concentration of radioactivity in the final oil product based on the activity concentration in rape seeds. The processing factor has been estimated to be 0.004 for caesium in rape oil by IAEA, and is based on a limited numbers of studies (1). In this project we analysed the activity concentration of radiocaesium ({sup 134}Cs) in rape oil and in rape cake from rape seeds contaminated after a wet deposition event with {sup 134}Cs. With the information of activity concentration of {sup 134}Cs in rape oil and in rape cake, we calculated the Pf-value and confirm or suggest new enhanced Pf-value. We analysed the activity concentration of {sup 134}Cs in rape oil and in rape cake from spring oilseed rape seeds (Brassica napus L.) that had been contaminated experimentally by wet deposited {sup 134}Cs in an earlier experiment by Bengtsson et al. (2013). The estimation of activity concentration of {sup 134}Cs in rape oil and in rape cake was achieved by performing extraction of the oil (and other extractable compounds) from the seeds based on the Randall extraction method (Randall, 1974) using petroleum ether as extraction chemical. The extracted oil and the rape cake samples were weighed and the activity concentration was measured with High-Purity Germanium (HPGe) detectors. Pf-values were calculated by dividing the measured activity concentration in rape oil after extraction by the activity concentration in oilseed rape seeds before extraction. Results from the present study will be presented at the international conference on radioecology and environmental radioactivity

  6. Oil cakes - a by-product of agriculture industry as a fortificant in bakery products.

    Science.gov (United States)

    Behera, Satyabadi; Indumathi, K; Mahadevamma, S; Sudha, M L

    2013-11-01

    Groundnut cake (GNC) and soybean cake (SBC) by-product of agriculture industry had protein and protein digestibility in the range of 42.7-50.5 and 71.3-76.8%, respectively. Polyphenols present in GNC and SBC were cholorogenic acid, syringic acid and p-coumaric acid. The number of bands separated in soybean meal was greater than the bands observed in GNC flour as seen in SDS-PAGE pattern, respectively. SEM of groundnut flour showed distension of protein bodies due to roasting of the oil cakes. The water absorption of wheat flour GNC blends decreased from 59.2 to 57.3% and increased in wheat flour SBC blends from 59.2 to 68.3% with an increase in oil cake from 0 to 20%. With increase in either GNC or SBC, the biscuits became harder. Addition of glycerol monostearate and sodium stearoyl lactylate in combination with 20% blend of GNC/SBC decreased the breaking strength values and increased the sensory parameters of the biscuits. Nutritionally rich biscuits were thus prepared by incorporating GNC/SBC.

  7. The influence of different pretreatment methods on biogas production from Jatropha curcas oil cake.

    Science.gov (United States)

    Jabłoński, Sławomir Jan; Kułażyński, Marek; Sikora, Ilona; Łukaszewicz, Marcin

    2017-12-01

    Drought and pest resistance, together with high oil content in its seeds, make Jatropha curcas a good oil source for biodiesel. Oil cake from J. curcas is not suitable for animal feeding and thus may be profitably used for additional energy production by conversion into biogas; however, the anaerobic digestion process must be optimized to obtain good efficiency. We subjected oil cake to thermal and acidic pretreatment to deactivate protease inhibitors and partially hydrolyze phytate. We then digested the samples in batch conditions to determine the effects of pretreatment on biogas production. Thermal pretreatment changed the kinetics of anaerobic digestion and reduced protease inhibitor activity and the concentration of phytate; however, biogas production efficiency was not affected (0.281 m 3  kg -1 ). To evaluate the possibility of recirculating water for SSF hydrolysis, ammonium nitrogen recovery from effluent was evaluated by its precipitation in the form of struvite (magnesium ammonium phosphate).Concentration of ammonium ions was reduced by 53% (to 980 mg L -1 ). We propose a water-saving concept based on percolation of J. curcas cake using anaerobic digestion effluent and feeding that percolate into a methanogenic bioreactor. Copyright © 2016 Elsevier Ltd. All rights reserved.

  8. Various Extraction Methods Influence the Adhesive Properties of Dried Distiller’s Grains and Solubles, and Press Cakes of Pennycress (Thlaspi arvense L. and Lesquerella [Lesquerella fendleri (A. Gary S. Watson], in the Fabrication of Lignocellulosic Composites

    Directory of Open Access Journals (Sweden)

    Brent Tisserat

    2018-04-01

    Full Text Available Lignocellulosic composite (LC panels were fabricated using an adhesive matrix prepared from three different agricultural by-products: dried distillers grains with solubles (DDGS, pennycress (Thlaspi arvense L. press cake (PPC, or lesquerella [Lesquerella fendleri (A. Gary S. Watson] press cake (LPC reinforced with Paulownia elongata L. wood (PW particles. The goal in this study was to assess the mechanical properties of composites utilizing these low-cost matrix materials, which were subjected to various oil extraction methods. Three types of oil extraction methods were utilized: ethanol, supercritical CO2, and hexane, in order to generate matrix materials. These matrix materials were mixed with equal proportions of PW and hot pressed to generate panels. Overall, hexane extraction was the best method to enhance the mechanical properties of the matrices used to fabricate lignocellulosic composites. LPC’s produced a matrix that gave the resulting composite superior flexural properties compared to composites generated from DDGS and PPC matrices. The mechanical properties of composites generated from soy products (soybean meal flour or soy protein isolate were similar to those derived from DDGS, PPC, or LPC. The dimensional stability properties of LCs were improved when the hexane extraction method was employed, unlike with the other extraction methods that were used to generate matrices.

  9. Effects of Cooking and Screw-Pressing on Functional Properties of Protein in Milkweed (Asclepias spp.) Seed Meals and Press Cakes

    Science.gov (United States)

    This study determined the effects of oil processing conditions on functional properties of milkweed seed proteins to evaluate their potential for value-added uses. Flaked milkweed seeds were cooked at 82 degrees C (180 degrees F) for 30, 60 or 90 min in the seed conditioner, and then screw-pressed ...

  10. Catalytic flash pyrolysis of oil-impregnated-wood and jatropha cake using sodium based catalysts

    KAUST Repository

    Imran, Ali

    2015-11-24

    Catalytic pyrolysis of wood with impregnated vegetable oil was investigated and compared with catalytic pyrolysis of jatropha cake making use of sodium based catalysts to produce a high quality bio-oil. The catalytic pyrolysis was carried out in two modes: in-situ catalytic pyrolysis and post treatment of the pyrolysis vapors. The in-situ catalytic pyrolysis was carried out in an entrained flow reactor system using a premixed feedstock of Na2CO3 and biomass and post treatment of biomass pyrolysis vapor was conducted in a downstream fixed bed reactor of Na2CO3/γ-Al2O3. Results have shown that both Na2CO3 and Na2CO3/γ-Al2O3 can be used for the production of a high quality bio-oil from catalytic pyrolysis of oil-impregnated-wood and jatropha cake. The catalytic bio-oil had very low oxygen content, water content as low as 1wt.%, a neutral pH, and a high calorific value upto 41.8MJ/kg. The bio-oil consisted of high value chemical compounds mainly hydrocarbons and undesired compounds in the bio-oil were either completely removed or considerably reduced. Increasing the triglycerides content (vegetable oil) in the wood enhanced the formation of hydrocarbons in the bio-oil. Post treatment of the pyrolysis vapor over a fixed bed of Na2CO3/γ-Al2O3 produced superior quality bio-oil compared to in-situ catalytic pyrolysis with Na2CO3. This high quality bio-oil may be used as a precursor in a fractionating process for the production of alternative fuels. © 2015 Elsevier B.V.

  11. A comparative study on the decomposition of edible and non-edible oil cakes in the Gangetic alluvial soil of West Bengal.

    Science.gov (United States)

    Mondal, Sudeshna; Das, Ritwika; Das, Amal Chandra

    2014-08-01

    An experiment has been conducted under laboratory conditions to investigate the effect of decomposition of two edible oil cakes, viz. mustard cake (Brassica juncea L) and groundnut cake (Arachis hypogaea L), and two non-edible oil cakes, viz. mahua cake (Madhuca indica Gmel) and neem cake (Azadirachta indica Juss), at the rate of 5.0 t ha(-1) on the changes of microbial growth and activities in relation to transformations and availability of some plant nutrients in the Gangetic alluvial (Typic Haplustept) soil of West Bengal, India. Incorporation of oil cakes, in general, highly induced the proliferation of total bacteria, actinomycetes, and fungi, resulting in greater retention and availability of oxidizable C, N, and P in soil. As compared to untreated control, the highest stimulation of total bacteria and actinomycetes was recorded with mustard cake (111.9 and 84.3 %, respectively) followed by groundnut cake (50.5 and 52.4 %, respectively), while the fungal colonies were highly accentuated due to the incorporation of neem cake (102.8 %) in soil. The retention of oxidizable organic C was highly increased due to decomposition of non-edible oil cakes, more so under mahua cake (14.5 %), whereas edible oil cakes and groundnut cake in particular exerted maximum stimulation (16.7 %) towards the retention of total N in soil. A similar trend was recorded towards the accumulation of available mineral N in soil and this was more pronounced with mustard cake (45.6 %) for exchangeable NH4 (+) and with groundnut cake (63.9 %) for soluble NO3 (-). The highest retention of total P (46.9 %) was manifested by the soil when it was incorporated with neem cake followed by the edible oil cakes; while the available P was highly induced due to the addition of edible oil cakes, the highest being under groundnut cake (23.5 %) followed by mustard cake (19.6 %).

  12. Preparation of a new gamma irradiated PVC-Olive oil cake plastic composite material

    International Nuclear Information System (INIS)

    Messaud, F.A.; Almsmary, Y.A.; Elwerfalli, S.M.; Benayad, S.M.; Haraga, S.O.; Benfaid, N.A.; Kabar, Y.M.

    2003-01-01

    This paper dealt with the investigation on preparing new plastic composite material, utilizing polyvinyl chloride polymer (a commercial product in abu-kammash chemical complex) and olive oil cake (a waste of many olive oil production factories), followed by gamma irradiation (26.3 Kg ry) o induce crosslinking of the polymer. The new material possess good, electrical and mechanical properties as compared to plastic products of (PVC plastic pipe factory), and which could be used as new construction anti corrosive material, such as special roofing and partitioning or household goods

  13. Use of palm oil decanter cake as a new substrate for the production of bio-oil by vacuum pyrolysis

    International Nuclear Information System (INIS)

    Dewayanto, Nugroho; Isha, Ruzinah; Nordin, Mohd Ridzuan

    2014-01-01

    Highlights: • Vacuum pyrolysis has been employed to produce bio-oil from palm oil waste. • Effect of the pyrolysis temperature was investigated in this study. • Bio-oil properties of cellulosic and oily based material were determined. • Bio-oil from decanter cake has potential to be used as fuel. - Abstract: The present study was carried out to investigate the potential of palm oil decanter cake (PDC) for bio-oil production at various temperatures by vacuum pyrolysis. PDC was first dried in oven at 105 °C for 24 h to remove moisture and ground to particle size of 0.85–2 mm. Pyrolysis experiments were carried out at 400, 450, 500, 550 and 600 °C, with heating rate of 15 °C/min. The highest yield of bio-oil (22.12 wt%) was obtained at pyrolysis temperature of 500 °C. The chemical characterization of bio-oil was studied using 1 H NMR, FTIR, CHNS analyzer and GC–MS. The other properties like pH, calorific value and thermal volatilization were also determined. The pH value recorded to be 6.38, which is found to be higher as compared to other bio-oils. The calorific value of PDC bio-oil found to be 36.79 MJ/kg, which is slightly lower than that of conventional liquid fuel such as gasoline and diesel fuel. However, the bio-oil obtained from PDC has better fuel characteristics than that of bio-oil derived from palm kernel shell (PKS)

  14. Abu Dhabi presses oil development program

    International Nuclear Information System (INIS)

    Anon.

    1992-01-01

    This paper reports that Abu Dhabi Co. for Onshore Operations (ADCO), the biggest oil producer in the United Arab Emirates, reports 1991 was a successful year despite the Persian Gulf war. Meantime, Abu Dhabi's Zakum, the second largest oil field in the Persian Gulf, boosted production to more than 300,000 b/d, and officials said production will rise further when a platform complex is recommissioned in 1993

  15. Antibacterial effect of citrus press-cakes dried by high speed and far-infrared radiation drying methods

    Science.gov (United States)

    Samarakoon, Kalpa; Senevirathne, Mahinda; Lee, Won-Woo; Kim, Young-Tae; Kim, Jae-Il; Oh, Myung-Cheol

    2012-01-01

    In this study, the antibacterial effect was evaluated to determine the benefits of high speed drying (HSD) and far-infrared radiation drying (FIR) compared to the freeze drying (FD) method. Citrus press-cakes (CPCs) are released as a by-product in the citrus processing industry. Previous studies have shown that the HSD and FIR drying methods are much more economical for drying time and mass drying than those of FD, even though FD is the most qualified drying method. The disk diffusion assay was conducted, and the minimum inhibitory concentration (MIC) and minimum bactericidal concentration (MBC) were determined with methanol extracts of the dried CPCs against 11 fish and five food-related pathogenic bacteria. The disk diffusion results indicated that the CPCs dried by HSD, FIR, and FD prevented growth of all tested bacteria almost identically. The MIC and MBC results showed a range from 0.5-8.0 mg/mL and 1.0-16.0 mg/mL respectively. Scanning electron microscopy indicated that the extracts changed the morphology of the bacteria cell wall, leading to destruction. These results suggest that CPCs dried by HSD and FIR showed strong antibacterial activity against pathogenic bacteria and are more useful drying methods than that of the classic FD method in CPCs utilization. PMID:22808341

  16. Application of Gamma Radiation on Bio-oil Produced from Pyrolysis of Soybean Cake

    International Nuclear Information System (INIS)

    Pichestapong, P.; Injarean, U.; Prapakornrattana, P.; Charoen, K.

    2014-01-01

    Soybean cake residue from soy milk making can be pyrolysed to produce pyrolysis liquid or bio-oil which has potency to be used as liquid fuel. Pyrolysis of soybean cake residue with the application of gamma irradiation was investigated in a batch reactor at 450°C for 1.5 hr under nitrogen flow 250 cc/min. Feed of soybean cake residue was exposed to gamma radiation at the doses of 200 to 1,000 kGy before pyrolysing. It was found that pyrolysis liquid yield increased significantly by 12.9 to 19.3 % at the irradiation doses of 400 kGy and higher. The increment was mainly due to the increasing of aqueous phase in the pyrolysis liquid. The heating value of organic phase in the pyrolysis liquid was 7,890 kcal/kg. The organic phase from the unexposed feed was also irradiated at 20-100 kGy. The viscosity of irradiated organic phase was found to increase with the increasing irradiation dose. Irradiated organic phase was distilled at temperatures 200 and 250°C. It was found that the first distilled fraction (<200°C) corresponding to gasoline fraction increased with the increasing irradiation dose while the second distilled fraction (200-250°C) corresponding to kerosene fraction seems to decrease. The composition of organic phase was also determined by GC-MS.

  17. Characterisation of Blighia sapida (Sapindaceae) seed oil and defatted cake from Benin.

    Science.gov (United States)

    Djenontin, Sebastien Tindo; Wotto, Valentin D; Lozano, Paul; Pioch, Daniel; Sohounhloue, Dominique K C

    2009-01-01

    A sample of Blighia sapida seeds collected in Benin has been analysed and the results are compared to the scarcely available literature data. The chemical analysis of seed oil shows a saponification value of 145 and an iodine value of 66, consistent with the high mono-unsaturated fatty acids (FAs) content (63.8 wt%). The most interesting feature is the prominent concentration of eicosenoic acid (48.4 wt%). Arachidic acid being the main component within the saturated group, the C20 FAs fraction accounts for 68.4 wt%, thus making the peculiar composition of this oil. Among the unsaponifiable fraction (2.4 wt%), the major sterol is stigmasterol (54.6 wt%), surprisingly over passing beta-sitosterol. Tocols (338 ppm) contains mainly alpha- and gamma-tocopherol. Regarding the defatted cake, results show the prominent position of starch and a noticeable amount of proteins and fibers (44.2, 22.4, 15.6 wt%, respectively). Seventeen amino acids were identified together with valuable minerals (total ashes 3.5 wt%). Possible uses of oil and defatted cake are discussed.

  18. Meat quality assessment from young goats fed for long periods with castor de-oiled cake.

    Science.gov (United States)

    Oliveira, C H A; Silva, A M; Silva, L M; van Tilburg, M F; Fernandes, C C L; Moura, A A; Moreno, F B M B; Monteiro-Moreira, A C O; Moreira, R A; Bezerra, F J; Rondina, D

    2015-08-01

    Diet can influence both the qualitative and quantitative traits of ruminant meat. This study evaluated the effects of castor de-oiled cake on the meat of mixed-breed male goat kids. After 165days of diet treatment, no alterations (p>0.05) were observed in the in vivo performance, anatomic components, dissection and proximate composition of the Longissimus dorsi muscle, as well as in the color and pH of the carcasses. However, diet had an effect (pgoats led to alterations in meat quality, without compromising its consumption qualities. Copyright © 2015 Elsevier Ltd. All rights reserved.

  19. Analysis of the technology of production of pressed sunflower oil at LLC Chernozemye and recommendations for improving its efficiency

    Directory of Open Access Journals (Sweden)

    A. N. Ostrikov

    2017-01-01

    Full Text Available The description of the technological scheme of the stock-preparation shop, press shop and cleaning of worm-press oil at Chernozemye LLC, with an analysis of the main types of technological equipment operation and evaluation of problematic production sites is given. It has been established that during hulling and following separation into fractions in separators and sifts, favorable conditions are created for oiling the husks by contacting it while passing through a sieve together with a high-oiled crushed kernel and oilseed dust. To reduce the oil content of husks in the scheme, it is recommended to use hydrocyclones that direct the husk for the subsequent separation of the particles of the kernel and oil dust carried along with the husk. It was also revealed that the greatest content of waxes and waxlike substances in the oil, which significantly affect the transparency of commercial sunflower oil, is contained in the husks lipids, which partially pass into the oil during the processing of seeds. The content of waxes in oils is the higher, the more husk is contained in the kernel, and the higher the temperature of the pulp entering the pressing. In this case, the ratio of oleic and linoleic acids in low-oil varieties is 1:1, in high-oil varieties is 1:3. The heterogeneity of the grinding of the oil seed meal, resulting from the hulling of seeds, makes it difficult to uniformly moisten, warm and dry the pulp in the conditioner. The structure of the finished pulp is influenced by the primary structure of the oil seed meal, obtained during the process of grinding the seeds. The intensive coloring of the pulp, oil cake and ground oil-cake during the drying of oil seed meal is due to the high temperature (above 100 °C in the conditioner, which leads to an intensive course of the sugar-amino reactions, an increase in the total content of nitrogen and phosphorus. And this changes color and increases raw materials losses.

  20. Alpha amylase from a fungal culture grown on oil cakes and its properties

    Directory of Open Access Journals (Sweden)

    Sumitra Ramachandran

    2004-06-01

    Full Text Available Solid-state fermentation was carried out for the production of alpha-amylase using Aspergillus oryzae. Different oil cakes such as coconut oil cake (COC sesame oil cake (SOC, groundnut oil cake (GOC, palm kernel cake (PKC and olive oil cake (OOC were screened to be used as substrate for the enzyme production and also compared with wheat bran (WB. GOC was found to be the best producer of the enzyme among these. Combination of WB and GOC (1:1 resulted higher enzyme titres than the individual substrates. Maximum amount of enzyme (9196 U/gds was obtained when SSF was carried out using WB + GOC, having initial moisture of 64% and supplemented with lactose and ammonium nitrate (1% each at 30ºC for 72h using 2 mL spore suspension (6x10(7spores/ml. Partial purification of the enzyme using ammonium sulphate fractionation resulted in 2.4-fold increase in the activity. The enzyme showed molecular weight of 68 KDa by SDS-PAGE. Except Mn, all other metal ions such as Ca, K, Na, Mg were found to be inhibitory for the enzyme activity. The enzyme was optimally active at 50(0C and pH 5.0.Fermentação no Estado Sólido foi empregada na produção de alfa-amilase usando Aspergillus niger. Diferentes tipos de torta foram utilizadas, como torta de óleo de coco (COC, torta de de óleo de amendoim (GOC torta de óleo de sesamo (SOC, torta de palma (PKC e torta de óleo de oliva (OOC foram selecionadas para serem usadas como substratos para produção de enzima e comparadas com o farelo de trigo (WB, GOC foi escolhido por ser o que produziu maiores concentrações de enzima. A combinação WB e GOC (1:1 resultou em maiores títulos da enzima quando em comparação com os substratos individuais. A máxima concentração de enzima (9196 U/ gms foi obtida quando a FES foi conduzida utilizando WB + GOC, com umidade de 64% e suplementada com lactose e nitrato de amônia (1% cada a 300C por 72 horas utilizando 2 mL de uma suspensão de esporo (6x107sporos/ml. A purifica

  1. Solid-State Fermentation Reduces Phytic Acid Level, Improves the Profile of Myo-Inositol Phosphates and Enhances the Availability of Selected Minerals in Flaxseed Oil Cake

    Science.gov (United States)

    2017-01-01

    Summary Flaxseed oil cake was subjected to fermentation with Rhizopus oligosporus (DSM 1964 and ATCC 64063), and the phytate (InsP6) content, myo-inositol phosphate profile and in vitro bioavailability of essential minerals were studied. Flaxseed oil cake had a phytate mass fraction of 13.9 mg/g. A 96-hour fermentation of flaxseed oil cake by R. oligosporus DSM 1964 and R. oligosporus ATCC 64063 decreased the InsP6 content by 48 and 33%, respectively. The strains had different phytate-degrading activities: fermentation of flaxseed oil cake with R. oligosporus DSM 1964 was more advantageous, yielding InsP3-5 as a predominating myo-inositol compound, while fermentation with R. oligosporus ATCC 64603 produced predominantly InsP5-6. Solid-state fermentation of flaxseed oil cake enhanced in vitro bioavailability of calcium by 14, magnesium by 3.3 and phosphorus by 2–4%. PMID:29089855

  2. Non-edible Oil Cakes as a Novel Substrate for DPA Production and Augmenting Biocontrol Activity of Paecilomyces variotii

    Directory of Open Access Journals (Sweden)

    Ashwani Kumar

    2017-05-01

    Full Text Available The present study investigated the use of waste non-edible oil cakes (Jatropha, Karanja, Neem, and Mahua as a substrate for the growth of Paecilomyces variotii and dipicolinic acid (DPA production. Previous researches proved the efficacy of DPA in suppressing certain pathogens that are deleterious to the plants in the rhizosphere. DPA production was statistical optimized by amending non-edible oil cakes in growing media as nitrogen and sugars (Dextrose, Glucose, and Lactose as carbon source. Plackett-Burman design (PBD, indicated that Jatropha cake, Karanja cake, and Dextrose were the most significant components (p < 0.05 of the media and were further optimized using response surface methodology (RSM. Jatropha cake, Karanja cake, and Dextrose at the concentration of 12.5, 4.5, and 10 g/l, respectively, yielded 250 mg/l of DPA, which was 2.5 fold more than that obtained from basal medium. HPLC analysis of the optimized medium (peak at retention time of 30 min confirmed the enhanced DPA production by P. variotii. The scanning electron microscopy (SEM images showed that optimized medium impose a stress like condition (due to less C:N ratio for the fungus and generated more spores as compared to the basal medium in which carbon source is easily available for the mycelial growth. The antimicrobial activity of the fungal extract was tested and found to be effective even at 10−2 dilution after 72 h against two plant pathogens, Fusarium oxysporum and Verticillium dahlia. Statistical experimental design of this study and the use of non-edible oil cakes as a substrate offer an efficient and viable approach for DPA production by P. variotii.

  3. Utilization of coconut oil cake for the production of lipase using Bacillus coagulans VKL1.

    Science.gov (United States)

    Gowthami, Palanisamy; Muthukumar, Karuppan; Velan, Manickam

    2015-01-01

    The overproduction of enzymes was performed by manipulating the medium components. In our study, solvent-tolerant thermophilic lipase-producing Bacillus coagulans was isolated from soil samples and a stepwise optimization strategy was employed to increase the lipase production using coconut oil cake basal medium. In the first step, the influence of pH, temperature, carbon source, nitrogen source and inducers on lipase activity was investigated by the One-Factor-At-A-Time (OFAT) method. In the second step, the three significant factors resulted from OFAT were optimized by the statistical approach (CCD).The optimum values of olive oil (0.5%), Tween 80 (0.6%) and FeSO4 (0.05%) was found to be responsible for a 3.2-fold increase in the lipase production identified by Central Composite Design.

  4. Model-free pyrolysis kinetics of sunflower seed and its de-oiled cake

    International Nuclear Information System (INIS)

    Özsin, Gamzenur; Kilic, Murat; Pütün, Ersan; Pütün, Ayşe E.

    2015-01-01

    Sunflower seed wastes from oil production are a potential biomass source for bio- energy production due to extensive and excessive oil production from sunflower seeds. Considering global energy requirement, pyrolysis seems a promising route for utilisation of such industrial biomass wastes. To develop, scale-up and operate pyrolysis plants efficiently, a fundamental understanding of pyrolysis behaviour and kinetics is essential. In this study, sunflower seeds and their waste cakes after extraction were evaluated as a potential biomass feedstock in pyrolysis process. In order to enlighten pyrolytic degradation behaviours, samples were pyrolysed under dynamic conditions from room temperature to 1000 °C using multiple heating rates. The main degradation regimes of the structures were characterized by high weight loss rates. Reaction kinetics was investigated with respect to conversion degree. It is anticipated that this study will be beneficial in optimizing the thermochemical processes, which may be utilize industrial biomass wastes. (full text)

  5. Different Oils and Health Benefit Statements Affect Physicochemical Properties, Consumer Liking, Emotion, and Purchase Intent: A Case of Sponge Cake.

    Science.gov (United States)

    Poonnakasem, Naratip; Pujols, Kairy Dharali; Chaiwanichsiri, Saiwarun; Laohasongkram, Kalaya; Prinyawiwatkul, Witoon

    2016-01-01

    Effects of different oils on physicochemical properties, consumer liking, emotion, and purchase intent of sponge cakes were evaluated. Three healthy oils (extra virgin coconut oil, EVCO; extra virgin olive oil, EVOO; rice bran oil, RBO) compared with butter (the control), were used at 20% (w/w, wheat flour basis) in sponge cake formulations. Five positive (calm, good, happy, pleased, satisfied) and 3 negative (guilty, unsafe, worried) emotion terms, selected from the EsSense Profile(®) with slight modification using an online (N = 234) check-all-that-apply questionnaire, were used for consumer testing. Consumers (N = 148) evaluated acceptability of 9 sensory attributes on a 9-point hedonic scale, 8 emotion responses on a 5-point rating scale, and purchase intent on a binomial scale. Overall liking, emotion, and purchase intent were evaluated before compared with after health benefit statement of oils had been given to consumers. Overall liking and positive emotion (except calm) scores of sponge cake made with EVCO were higher than those made with EVOO and RBO. Specific volume, expansion ratio, and moisture content of control, EVCO, and EVOO were not significantly different, but higher than RBO sponge cake. JAR results showed that sponge cake made with RBO had the least softness that was reflected by the highest hardness (6.61 to 9.69 compared with. 12.76N). Oil (EVCO/EVOO/RBO) health benefit statement provided to consumer significantly increased overall liking, positive emotion, and purchase intent scores while decreased negative emotion scores. Overall liking and pleased emotion were critical attributes influencing purchase intent (odds ratio = 2.06 to 3.75), whereas calm and happy became not critical after health benefit statement had been given. © 2015 Institute of Food Technologists®

  6. Effect of Inoculum Dosage Aspergillus niger and Rhizopus oryzae mixture with Fermentation Time of Oil Seed Cake (Jatropha curcas L) to the content of Protein and Crude Fiber

    Science.gov (United States)

    Kurniati, T.; Nurlaila, L.; Iim

    2017-04-01

    Jatropha curcas L already widely cultivated for its seeds pressed oil used as an alternative fuel. This plant productivity per hectare obtained 2.5-5 tonnes of oil/ha / year and jatropha seed cake from 5.5 to 9.5 tonnes/ha/year, nutrient content of Jatropha curcas seed L potential to be used as feed material, However, the constraints faced was the low crude protein and high crude protein. The purpose of the research was to determine the dosage of inoculum and fermentation time of Jatropha seed cake by a mixture of Aspergillus niger and Rhizopus oryzae on crude protein and crude fibre. The study was conducted by an experimental method using a Completely Randomised Design (CRD) factorial design (3×3). The treatment consisted of a mixture of three dosage levels of Aspergillus niger and Rhizopus oryzae (= 0.2% d1, d2 and d3 = 0.3% = 0.4%) and three levels of fermentation time (w1 = 72 hours, 96 hours and w2 = w3 = 120 hours) each repeated three times. The parameters measured were crude protein and crude fibre. The results showed that dosages of 0.3% (Aspergillus niger Rhizopus oryzae 0.15% and 0.15%) and 72 hours (d2w1) is the dosage and the optimal time to generate the highest crude protein content of 21.11% and crude fibre amounted to 21.36%.

  7. Development of a novel cup cake with unique properties of essential oil of betel leaf (Piper betle L.) for sustainable entrepreneurship.

    Science.gov (United States)

    Roy, Arnab; Guha, Proshanta

    2015-08-01

    Betel vine (Piper betle L.) is a root climber with deep green heart shaped leaves. It belongs to the Piperaceae family. There is a huge wastage of the leaves during glut season and it can be reduced by various means including extraction of medicinal essential oil which can be considered as GRAS (generally recognized as safe) materials. Therefore, attempts were made to develop a novel cup cake by incorporating essential oil of betel leaf. The textural properties of the cakes were measured by texture analyzer instrument; whereas the organoleptic properties were adjudged by human preferences using sensory tables containing 9-point hedonic scale. Price estimation was done considering all costs and charges. Finally, all parameters of the developed cake were compared with different cup cakes available in the market for ascertaining consumer acceptability of the newly developed product in terms of quality and market price. Results revealed that the Novel cup cake developed with 0.005 % (v/w) essential oil of betel leaf occupied the 1st place among the four developed novel cup cakes. However, it occupied 4th place among the nine cup cakes in the overall preference list prepared based on the textural and organoleptic qualities, though its market price was calculated to be comparable to all the leading cupcakes available in the market. This indicates that manufacturing of novel cup cake with essential oil of betel leaf would be a profitable and self-sustaining entrepreneurship.

  8. Low density polyethylene (LDPE) / poli (3-hydroxy-butyrate) (PHB) blends filled with castor oil cake; Misturas de polietileno de baixa densidade (PEBD) e poli(3-hidroxibutirato) (PHB) carregados com torta de mamona (TM)

    Energy Technology Data Exchange (ETDEWEB)

    Rocha, M.C.G.; Oliveira, C.I.R. de; Sanches, M.C.; Coelho, N.N., E-mail: mrocha@iprj.uerj.br [Universidade do Estado do Rio de Janeiro (IP/UERJ), Rio de Janeiro, RJ (Brazil). Instituto Politecnico

    2014-07-01

    Blends of PHB and LDPE were prepared by melt mixing in a Haake internal mixer. Castor oil pressed cake was used as filler for the blends. In order to improve the interfacial adhesion between the filler and the polymers, a mercerization process with 5% NaOH solution was employed. This process was evaluated by several techniques such as: X-Ray diffraction, infrared spectroscopy and scanning electron microscopy (SEM). The mechanical properties were evaluated by traditional tensile stress-strain tests (ASTM D- 638). The obtained results showed that the mercerization process leads to better adhesion properties. The Young Modulus of the blends presented a tendency to increase with the addition of the castor oil cake.(author)

  9. Antimicrobial effect of cinnamon (Cinnamomum verum J. Presl bark essential oil in cream-filled cakes and pastries

    Directory of Open Access Journals (Sweden)

    M. Vazirian

    2015-11-01

    Full Text Available Background and objectives: Food poisoning has been always a major concern in health system of every community and cream-filled products are one of the most widespread food poisoning causes in humans. In present study, we examined the preservative effect of the cinnamon oil in cream-filled cakes. Methods: Antimicrobial activity of Cinnamomum verum J. Presl (Cinnamon bark essential oil was examined against five food-borne pathogens (Staphylococcus aureus, Escherichia coli, Candida albicans, Bacillus cereus and Salmonella typhimurium to investigate its potential for use as a natural preservative in cream-filled baked goods. Chemical constituents of the oil were determined by gas chromatography/mass spectrometry. For evaluation of preservative sufficiency of the oil, pathogens were added to cream-filled cakes manually and 1 μL/mL of the essential oil was added to all samples except the blank.  Results: Chemical constituents of the oil were determined by gas chromatography/mass spectrometry and twenty five components were identified where cinnamaldehyde (79.73%, linalool (4.08%, cinnamaldehyde para-methoxy (2.66%, eugenol (2.37% and trans-caryophyllene (2.05% were the major constituents. Cinnamon essential oil showed strong antimicrobial activity against selected pathogens in vitro and the minimum inhibitory concentration values against all tested microorganisms were determined as 0.5 μL/disc except for S. aureus for which, the oil was not effective in tested concentrations. After baking, no observable microorganism was observed in all susceptible microorganisms count in 72h stored samples.  Conclusion: It was concluded that by analysing the sensory quality of the preserved food, cinnamon oil may be considered as a natural preservative in food industry, especially for cream-filled cakes and pastries.

  10. Phenolic extracts of coconut oil cake: a potential alternative for synthetic antioxidants

    Directory of Open Access Journals (Sweden)

    Kapila Nalawatta SENEVIRATNE

    2016-01-01

    Full Text Available Abstract Limitations of natural antioxidants include relatively low antioxidant activity, narrow range of food systems where the antioxidants are effective and limited thermal stability compared to synthetic antioxidants. In the present study, the phenolic extract of coconut oil cake (COCE was tested for antioxidant activity-related food stabilization. Heat stabilities of COCE and synthetic antioxidants were determined by measuring the indubbction time of sunflower oil enriched with heat-treated antioxidants. In the β-carotene-linoleate emulsion used for testing antioxidant activity, COCE can retain 96 ± 2% of initial colour intensity while BHT can retain 89 ± 2% of initial colour intensity at 60 µg mL–1 concentration after two hours. TBARS contents (MDA equivalents / kg of meat in COCE-treated and control pork samples after 14 days was 2.80 ± 0.57 and 22.55 ± 2.30 respectively. Heat stability varies in the order butylated hydroxytoluene (BHT < (butylated hydroxyanisole (BHA < COCE < tertiary butylhydroxyquinone (TBHQ. The results of these experiments suggest that COCE is a versatile and thermally stable natural antioxidant mixture effective in stabilizing many food systems.

  11. Low pressure catalytic co-conversion of biogenic waste (rapeseed cake) and vegetable oil.

    Science.gov (United States)

    Giannakopoulou, Kanellina; Lukas, Michael; Vasiliev, Aleksey; Brunner, Christoph; Schnitzer, Hans

    2010-05-01

    Zeolite catalysts of three types (H-ZSM-5, Fe-ZSM-5 and H-Beta) were tested in the catalytic co-conversion of rapeseed cake and safflower oil into bio-fuel. This low pressure process was carried out at the temperatures of 350 and 400 degrees Celsius. The yields and compositions of the product mixtures depended on the catalyst nature and the process temperatures. The produced organic phases consisted mainly of hydrocarbons, fatty acids and nitriles. This mixture possessed improved characteristics (e.g. heating value, water content, density, viscosity, pH) compared with the bio-oils, making possible its application as a bio-fuel. The most effective catalyst, providing the highest yield of organic liquid phase, was the highly acidic/wide-pore H-Beta zeolite. The products obtained on this catalyst demonstrated the highest degree of deoxygenation and the higher HHV (Higher Heating Value). The aqueous liquid phase contained water-soluble carboxylic acids, phenols and heterocyclic compounds. Copyright 2009 Elsevier Ltd. All rights reserved.

  12. Chemical Composition of Iran's Pistacia atlantica Cold-Pressed Oil

    Directory of Open Access Journals (Sweden)

    M. Saber-Tehrani

    2013-01-01

    Full Text Available The lipid fraction of Pistacia atlantica seeds was extracted for the first time by means of cold-press technique and analyzed for its chemical composition. The fatty acids, sterols, triacylglycerols (TAG, tocopherols, polyphenols, and pigments were identified and their concentrations were determined by means of reversed-phase high-performance liquid chromatography (RP-HPLC and gas chromatography (GC. Because of its high content of unsaturated fatty acids, it might prove to be of value in diets and it may be used as edible cooking or salad oils or for margarine manufacture. Pistacia atlantica seed oil has the unique sterols and tocopherols content providing source of natural antioxidants. The main triacylglycerols were SLL + PLO, SOL + POO, OOLn + PLL, OOO, and SOO. This paper examined the phenolic fraction of Pistacia atlantica seed oil. Moreover, caffeic acid followed by cinnamic acid, pinoresinol, vanillin, p-Coumaric acid, ferulic acid, and o-Coumaric acid was also determined. This paper presents the first investigation of chlorophyll's and carotene's composition in Pistacia atlantica seed oil. Furthermore, pheophytin a was the major component, followed by luteoxanthin, neoxanthin, violaxanthin, lutein, lutein isomers, chlorophyll a, chlorophyll a′, and pheophytin a′ were also determined.

  13. Preparation and characterization of activated carbon from castor de-oiled cake

    Directory of Open Access Journals (Sweden)

    Viviana M. Ospina-Guarín

    2014-01-01

    Full Text Available Biomass residues have been used to produce activated carbons. On this process, the activation method and the raw composition determine the properties as porosity and surface area of the charcoal. After the extraction of castor oil, there is a solid byproduct (cake of low added value, which was used in the production of activated carbon to add value to this waste. For this purpose two traditional methods were used, first, physical activation using as activating agents steam, CO2 and mixture of both, and additionally chemical activation using K2CO3 as the activating agent. Some activated carbons were characterized using N2 adsorption isotherms, BET surface areas varied between 255.98 (m2/g and 1218.43 (m2/g. By SEM and EDS analysis was possible to observe that materials obtained by the two types of activation are principally amorphous and morphological characteristics of the carbon obtained by physical activation are very different from those obtained by chemical activation. Finally, through impregnation of inorganic phases of Ni and Mo was revealed that the high dispersion characteristics, these carbonaceous materials will have potential to be used as catalyst support.

  14. Assessment of process control parameters in the biochemical methane potential of sunflower oil cake

    International Nuclear Information System (INIS)

    Raposo, F.; Borja, R.; Rincon, B.; Jimenez, A.M.

    2008-01-01

    A laboratory-scale study was conducted on the batch anaerobic digestion of sunflower oil cake (SuOC), solid waste derived from the extraction process of sunflower oil. A multi-reactor system was used to compare methane production from this waste at inoculum to substrate ratios (ISRs) of 3.0, 2.0, 1.5, 1.0, 0.8 and 0.5 (expressed as volatile solids (VS) basis). The tests were carried out at mesophilic temperature (35 deg. C) and run against a control of inoculum without substrate. The results obtained in the biochemical methane potential (BMP) tests showed that the ultimate methane yield (Y M,ult ) decreased considerably from 227±23 to 107±11 ml CH 4 at standard temperature and pressure (STP) conditions g -1 VS added when the ISR decreased from 3.0 to 0.5, showing a clear influence of the ISR on the methane yield coefficient. The biodegradability (BD) of the waste also decreased from 86% to 41% when the ISR varied from 3.0 to 0.5. A net total ammonia nitrogen (TAN) yield of 39.2 mg N g -1 VS added was obtained, and this value was not influenced by the ISRs assayed, which demonstrated the appropriate operation of the hydrolytic-acidogenic stage of the overall digestion process. A clear imbalance of the methanogenic process was observed at the lowest ISRs studied (0.5 and 0.8) due to a considerable increase in CODs and TVFA in the digestates. The profile of VFA was also influenced by the ISR, typical of the proteinaceous substrates

  15. Experimental assessment of toxic phorbol ester in oil, biodiesel and seed cake of Jatropha curcas and use of biodiesel in diesel engine

    International Nuclear Information System (INIS)

    Prasad, Lalit; Pradhan, Subhalaxmi; Das, L.M.; Naik, S.N.

    2012-01-01

    Highlights: ► In the present study toxic phorbol esters were detected in oil and seed cake of Jatropha curcas but not detected in biodiesel using high performance liquid chromatography (HPLC). ► The quantity of phorbol esters in Jatropha curcas oil and cake were amounted to be 2.12 ± 0.02 mg/g and 0.6 ± 0.01 mg/g respectively. ► As jatropha oil is a potential source for biodiesel preparation, huge amount of oil and cake will be generated and hence need to be handled carefully. ► Upon engine study exhaust pollutant such as hydrocarbon, smoke opacity and carbon monoxide reduced substantially. - Abstract: The present study deals with estimation of toxic phorbol esters in Jatropha curcas oil, cake and biodiesel and performance emission of different blends of biodiesel in diesel engine. The jatropha seed was collected from Chattishgarh, India and oil content of the seed kernel was 56.5%, determined by soxhlet apparatus. The oil was subjected to biodiesel preparation by twin step method of acid esterification followed by alkali transesterification. The total conversion of jatropha oil methyl ester (JOME) after reaction was 96.05% from proton nuclear magnetic resonance ( 1 H NMR) studies. The phorbol esters content of oil, cake and biodiesel was determined by high performance liquid chromatography (HPLC, Waters). The phorbol esters content of the oil was more (2.26 ± 0.01 mg/g) than the cake (0.6 ± 0.01 mg/g) but no phorbol esters peak was detected in biodiesel. The performance and emission study of the fuel blends (JB2, JB5 and JB10) with conventional diesel were tested for their use as substitute fuel for a single cylinder direct injection diesel engine at constant speed (1500 rpm). The emissions such as CO, HC and smoke opacity decreased whereas NO x and BSCF increased with biodiesel blends.

  16. PEMBUATAN PEPTON DARI BUNGKIL KEDELAI DAN KHAMIR DENGAN ENZIM PAPAIN UNTUK MEDIA PERTUMBUHAN BAKTERI [Peptone Production From Soybean Press Cake and Yeast By Papain Enzyme For The Bacterial Growth Media

    Directory of Open Access Journals (Sweden)

    Fachraniah1

    2002-12-01

    Full Text Available Peptone can be produced from soybean press cake and yeast by enzymatic hydrolysis with papain. The activity of papain used in this experiment against casein is indicated by Vm (2000 unit and Km (0.8%. The process condition for soybean press cake was : [S] = 3.72%, [E] = 0.4%, 60 0C, pH 6.2-6.3, 5 hours, while for yeast was [S] = 4.76%, [E] = 0.2%, 60 0C, pH 5.8-5.9, 5 hours. The yield of the hydrolysis process of soybean press cake peptone was 12.1%, while that of yeast was 18.9%. The peptone obtained was brownish yellow in color with moisture content of 3 and 5%, ash content 6 and 7 %, total protein 9 and 11%, solubility 98%, amino nitrogen 1.9 and 2.82, and AN/TN ratio = 26.47 and 27.62%, respectively. The chromatographic pattern of the peptone using gel filtration column of Superdex-75 appeared to be the same as that of the commercial soy pepton. Growth test with E. coli, S. aureus, and B. subtilis showed that soybean press cake and yeast peptone could be used as component in media for microbial growth.

  17. The Effect of Processing on 14C- Chlofenvinphos Residues in Maize Oil and Bioavailability of its Cake Residues on Rats

    International Nuclear Information System (INIS)

    Mahdy, F.; El-Maghraby, S.

    2008-01-01

    Maize seed obtained from 14 C-chlofenvinphos treated plants contained 0.12 % of the applied dose. The insecticide residues in crude oil, methanol and coke amounted to 10 %, 6 % and 69 %, respectively of original residues inside the seeds.The 14 C activity in the crude oil could be a gradual reduced by the refining processes. The alkali treatment and bleaching steps are more effective steps in the refining processes remove about (63 %). The refined oil contained only about 17 % of the 14 C-residues originally present. The major residues in processed oil contain parent compound, in addition to five metabolites of the insecticide. When rats fed the extracted seeds (cake), the bound residues were found to be considerably bioavailable. After feeding rats for 5 days with the cake, a substantial amount of 14 C-residues was eliminated in the urine (59.5 %), while about 20 % was excreted in the feces. About 15 % of the radioactivity was distribution among various organs

  18. Solvent extraction of jojoba oil from pre-pressed jojoba meal

    Directory of Open Access Journals (Sweden)

    El Haron, Dalia E.

    2004-06-01

    Full Text Available The solvent extraction process of jojoba oil from the meal cake obtained after the mechanical pressing of jojoba seeds was studied. Commercial hexane and petroleum ether were used as solvents and the extraction was carried out at temperatures ranging from 30 to 55 °C using solvent-to-solid ratios, R between 2 and 15 L/kg. The equilibrium compositions of the solvent and solid phases were determined. Based on the equilibrium data, the partition coefficient or distribution ratio, D of the oil between both phases was estimated. Also, the number of extraction stages necessary to achieve a certain degree of oil recovery has been determined using different hexane-to-meal ratios. Jojoba oil was also tested for its physical and chemical properties including chemical composition, percentage fatty acid, peroxide value, flash point, fire point, pour point, refractive index, saponification and iodine values. The stability of jojoba oil during storage at room temperature and during heat treatment was also studied.Se ha estudiado el proceso de extracción con disolventes del aceite contenido en la harina residual del prensado mecánico de las semillas de jojoba. Como disolventes se han utilizado hexano técnico y éter de petróleo, habiéndose efectuado extracciones a temperaturas comprendidas entre 30 ºC y 55 ºC , con relaciones de disolvente a sólido, R, de entre 12 y 15 L/kg. Se han determinado las composiciones del extracto y del residuo sólido en el equilibrio y a partir de los datos de equilibrio, se ha estimado el coeficiente de partición o cociente de distribución, D, del aceite entre ambas fases. Asimismo, se ha determinado el número de etapas de extracción necesarias para conseguir un cierto grado de recuperación del aceite, utilizando diferentes relaciones entre hexano y harina. También se han determinado las propiedades físicas y químicas del aceite de jojoba, incluyendo la composición química, el porcentaje de ácidos grasos

  19. Celebratory Cakes

    Science.gov (United States)

    Mahoney, Ellen

    2012-01-01

    Cakes are no longer the simple desserts they once were. The cake has evolved into an elaborate, sculptural form that represents a special occasion. Sculptural cake forms have become expressive designs using three-dimensional shapes, an array of surface textures, and a range of colors. The use of cakes in the artwork of David Gilhooly, Wayne…

  20. Esterification of oil adsorbed on palm decanter cake into methyl ester using sulfonated rice husk ash as heterogeneous acid catalyst

    Science.gov (United States)

    Hindryawati, Noor; Erwin, Maniam, Gaanty Pragas

    2017-02-01

    Palm Decanter cake (PDC) which is categorized as the waste from palm oil mill has been found to contain residual crude palm oil. The oil adsorbed on the PDC (PDC-oil) can be extracted and potentially used as feedstock for biodiesel production. Feedstock from waste like PDC-oil is burdened with high free fatty acids (FFAs) which make the feedstock difficult to be converted into biodiesel using basic catalyst. Therefore, in this study, a solid acid, RHA-SO3H catalyst was synthesized by sulfonating rice husk ash (RHA) with concentrated sulfuric acid. The RHA-SO3H prepared was characterized with TGA, FTIR, BET, XRD, FE-SEM, and Hammett indicators (methyl red, bromophenol blue, and crystal violet). PDC was found to have about 11.3 wt. % oil recovered after 1 hour extraction using ultrasound method. The presence of sulfonate group was observed in IR spectrum, and the surface area of RHA-SO3H was reduced to 37 m2.g-1 after impregnation of sulfonate group. The RHA-SO3H catalyst showed that it can work for both esterification of free fatty acid which is present in PDC-oil, and transesterification of triglycerides into methyl ester. The results showed highest methyl ester content of 70.2 wt.% at optimal conditions, which was 6 wt.% catalyst amount, methanol to oil molar ratio of 17:1 for 5 hours at 120 °C.

  1. Cold pressed versus refined winterized corn oils: quality, composition and aroma

    International Nuclear Information System (INIS)

    Aydeniz Güneşer, B.; Yılmaz, E.; Ok, S.

    2017-01-01

    The aims of this study were to characterize and compare cold pressed and fully refined winterized corn oils. Free fatty acidity (FFA), peroxide (PV) and p-anisidin (p-AV) values, saponification number, total carotenoid and phenolic contents of cold pressed corn oils were higher than that of the refined winterized corn oils. Linoleic and oleic acids (approximately 53-54% and 30-31%, respectively) were detected as the major fatty acids in both oil samples. Fifteen different sterols with a majority of β-sitosterol, campesterol, and stigmasterol were quantified in both oil samples. Although phenolic compounds were not quantified in the refined winterized oil samples, some flavonoids (hesperidin, rutin) and phenolic acids (gallic, syringic, rosmaniric and trans-ferulic) were detected in the cold pressed oil samples. This study concludes that cold pressed corn oils could be superior in terms of bioactive compounds but still need some quality improvements for sensory attributes. [es

  2. Fungal production of single cell oil using untreated copra cake and evaluation of its fuel properties for biodiesel.

    Science.gov (United States)

    Khot, Mahesh; Gupta, Rohini; Barve, Kadambari; Zinjarde, Smita; Govindwar, Sanjay; Kumar, Ameeta Ravi

    2015-04-01

    This study evaluated the microbial conversion of coconut oil waste, a major agro-residue in tropical countries, into single cell oil (SCO) feedstock for biodiesel production. Copra cake was used as a low-cost renewable substrate without any prior chemical or enzymatic pretreatment for submerged growth of an oleaginous tropical mangrove fungus, Aspergillus terreus IBB M1. The SCO extracted from fermented biomass was converted into fatty acid methyl esters (FAMEs) by transesterification and evaluated on the basis of fatty acid profiles and key fuel properties for biodiesel. The fungus produced a biomass (8.2 g/l) yielding 257 mg/g copra cake SCO with ~98% FAMEs. The FAMEs were mainly composed of saturated methyl esters (61.2%) of medium-chain fatty acids (C12-C18) with methyl oleate (C18:1; 16.57%) and methyl linoleate (C18:2; 19.97%) making up the unsaturated content. A higher content of both saturated FAMEs and methyl oleate along with the absence of polyunsaturated FAMEs with ≥4 double bonds is expected to impart good fuel quality. This was evident from the predicted and experimentally determined key fuel properties of FAMEs (density, kinematic viscosity, iodine value, acid number, cetane number), which were in accordance with the international (ASTM D6751, EN 14214) and national (IS 15607) biodiesel standards, suggesting their suitability as a biodiesel fuel. The low cost, renewable nature, and easy availability of copra cake, its conversion into SCO without any thermochemical pretreatment, and pelleted fungal growth facilitating easier downstream processing by simple filtration make this process cost effective and environmentally favorable.

  3. Development a method for producing vegetable oil from safflower seeds by pressing in the field of ultrasound

    Directory of Open Access Journals (Sweden)

    S. T. Antipov

    2015-01-01

    Full Text Available The article shows the prospects of production in agriculture safflower seeds for food and extract biologically active components. The physicochemical composition of safflower, which is rich in unsaturated fatty acids. Safflower oil has a soothing and moisturizing effect, provides a barrier function of the skin, therefore, fatty oil is promising in terms of scientific evidence use in medical practice. In the article the task of developing a set of processes to extract oil from the seeds of safflower and effective use. The ways of processing safflower seed to obtain oil. It is the most productive and promising method for processing seeds of safflower scheme press extruder. Described compression step in the processing of safflower seeds scheme press extruder. Crucial processing technology safflower seeds have two fundamental rheological characteristics of viscosity and elasticity, which depend on the structure of the raw material, the molecular weight distribution, and processing conditions such as temperature, pressure and flow rate. The dependence of the density of its safflower cake moisture concluded that with humidity increase the particle density increases, due to the swelling of colloids grain. Furthermore, the dependence of shear stress and the effective viscosity versus shear rate, it is concluded that with increasing shear rate influence of temperature on the viscosity gradient weakens. The article shows the study of the prospects of the extrusion process in the presence of the ultrasound field and the creation of equipment that takes into account these properties. The use of ultrasound significantly reduces energy consumption and necessary to prevent the molding ion safflower seeds, improves product quality.

  4. Hydrothermal liquefaction of de-oiled Jatropha curcas cake using Deep Eutectic Solvents (DESs) as catalysts and co-solvents.

    Science.gov (United States)

    Alhassan, Yahaya; Kumar, Naveen; Bugaje, Idris M

    2016-01-01

    Biomass liquefaction using ionic liquids (ILs) as catalysts has received appreciable attention, in renewable fuels and chemicals production, recently. However, issues associated with the production cost, long reaction time and use of volatile solvents are undeniably challenging. Thus, Deep Eutectic Solvents (DESs) emerged as promising and potential ILs substitutes. The hydrothermal liquefaction of de-oiled Jatropha curcas cake was catalyzed by four synthesized DESs as catalysts and co-solvents for selective extraction. Proximate and ultimate analyses including ash, moisture and carbon contents of bio-crude produced varied slightly. The higher heating values found ranges from 21.15 ± 0.82 MJ/kg to 24.30 ± 0.98 MJ/kg. The bio-crude yields obtained using ChCl-KOH DES was 43.53 wt% and ChCl-p-TsOH DES was 38.31 wt%. Bio-crude yield using ChCl-FeCl3 DES was 30.80 wt%. It is suggested that, the selectivity of bio-crude could be improved, by using DESs as catalyst and co-solvent in HTL of biomass such as de-oiled J. curcas cake. Copyright © 2015 Elsevier Ltd. All rights reserved.

  5. Cold-pressed and hot-pressed rapeseed oil: The effects of roasting and seed moisture on the antioxi- dant activity, canolol, and tocopherol level.

    Science.gov (United States)

    Siger, Aleksander; Józefiak, Marta; Górnaś, Paweł

    2017-01-01

    The paper looks at the levels of canolol, tocopherols and antioxidant activity in cold-pressed and hot-pressed rapeseed oils produced from seeds of various moisture levels (5%, 7.5%, and 10%). The paper also considers the effects of seed roasting on the levels of these compounds. The material used for the tests was rapeseed cv. Adrianna. The quality of the oils obtained is determined using peroxide and acid values. The levels of canolol and tocopherols are analyzed using HPLC. The DPPH radical-scavenging activity method for oil samples and phenolic extract from oils was used. It has been demonstrated that the oils produced from rapeseeds with a 5% moisture content, and   in particular from cold-pressed oils, were characterized by the lowest peroxide values. Cold-pressed oils produced from rapeseeds with a 5% moisture content were characterized by higher levels of tocopherols and plastochromanol-8. In the case of hot-pressed oils, the highest levels of tocopherols were found in oils pro- duced from seeds with a 7.5% moisture content, and the greatest amount of PC-8 (more than 4 mg/100 g) was found in oils produced from seeds with a 10% moisture content. Hot-pressed oils have been shown to have higher levels of these compounds than cold-pressed oils. Both roasting and hot pressing led to an increase in the amount of canolol in the oils investigated. When analysing the antioxidant activity of the oils and phenolic extracts it was shown that phenolic compounds are responsible for approx. 10% of total antioxidant activity. Various levels of biologically active compounds were shown to be present in the rapeseed oil obtained from raw materials of a varying moisture content. The type of pressing process (cold-pressing or hot-pressing) and whether the seeds have undergone roasting has also been shown to affect the resulting oil and the level of native antioxidants it contains.

  6. Pyrolysis of de-oiled seed cake of Jatropha Curcas and catalytic steam reforming of pyrolytic bio-oil to hydrogen.

    Science.gov (United States)

    Renny, Andrew; Santhosh, Viswanathan; Somkuwar, Nitin; Gokak, D T; Sharma, Pankaj; Bhargava, Sanjay

    2016-11-01

    The aim of this work was to study the pyrolysis of de-oiled seed cake of Jatropha Curcas and catalytic steam reforming of pyrolytic bio-oil to hydrogen. As per literature, presence of heavy nitrogenous and oxygenated compounds leads to catalyst deactivation. Here, an attempt has been made to tune pyrolytic reactions to optimize the N and O content of the pyrolytic bio-oil. Bio-oil conversion and hydrogen yield decreased as reaction progressed, which attributes to temporary loss of catalytic activity by blockage of catalyst pores by carbon deposition. Further, retention of steam reforming activity after repetitive steam activation suggests long-term catalyst usage. Copyright © 2016 Elsevier Ltd. All rights reserved.

  7. Optimization of the protein concentration process from residual peanut oil-cake

    Directory of Open Access Journals (Sweden)

    Gayol, M. F.

    2013-12-01

    Full Text Available The objective of this study was to find the best process conditions for preparing protein concentrate from residual peanut oil-cake (POC. The study was carried out on POC from industrial peanut oil extraction. Different protein extraction and precipitation conditions were used: water/ flour ratio (10:1, 20:1 and 30:1, pH (8, 9 and 10, NaCl concentration (0 and 0.5 M, extraction time (30, 60 and 120 min, temperature (25, 40 and 60 °C, extraction stages (1, 2 and 3, and precipitation pH (4, 4.5 and 5. The extraction and precipitation conditions which showed the highest protein yield were 10:1 water/flour ratio, extraction at pH 9, no NaCl, 2 extraction stages of 30 min at 40 °C and precipitation at pH 4.5. Under these conditions, the peanut protein concentrate (PC contained 86.22% protein, while the initial POC had 38.04% . POC is an alternative source of protein that can be used for human consumption or animal nutrition. Therefore, it adds value to an industry residue.El objetivo de este trabajo fue encontrar las mejores condiciones para obtener un concentrado de proteínas a partir de la torta residual de maní (POC. El estudio se llevó a cabo en POC provenientes de la extracción industrial de aceite de maní. Se utilizaron distintas condiciones para la extracción y precipitación de proteínas: relación agua / harina (10:1, 20:1 y 30:1, pH de extracción (8, 9 y 10, concentración de NaCl (0 y 0,5 M, tiempo de extracción (30, 60 y 120 min, temperatura (25, 40 y 60 °C, número de etapas de extracción (1, 2 y 3, y el pH de precipitación (4, 4,5 y 5. Las condiciones de extracción y de precipitación que mostraron mayor rendimiento de proteína fueron: relación de 10:1 en agua / harina, pH de extracción de 9, en ausencia de NaCl, 2 etapas de extracción de 30 min cada una a 40 °C y el pH de precipitación de 4,5. En estas condiciones, el concentrado de proteína de maní (PC fue de 86,22%, mientras que el porcentaje de proteínas de

  8. Magnetic/non-magnetic argan press cake nanocellulose for the selective extraction of sudan dyes in food samples prior to the determination by capillary liquid chromatograpy.

    Science.gov (United States)

    Benmassaoud, Yassine; Villaseñor, María J; Salghi, Rachid; Jodeh, Shehdeh; Algarra, Manuel; Zougagh, Mohammed; Ríos, Ángel

    2017-05-01

    Two methods for the determination of Sudan dyes (Sudan I, Sudan II, Sudan III and Sudan IV) in food samples, by solid phase extraction - capillary liquid chromatography, are proposed. Both methods use nanocellulose (NC) extracted from bleached argan press cake (APC), as a nano-adsorbent recycled from an agricultural waste material. One of the methods involves the dispersion of NC in food sample extracts, along with the waste and eluents being separated by centrifugation. In the other method, NC was modified by magnetic iron nanoparticles before using it in the extraction of Sudan dyes. The use of a magnetic component in the extraction process allows magnetic separation to replace the centrifugation step in a convenient and economical way. The two proposed methods allows the determination of Sudan dye amounts at the 0.25-2.00µgL -1 concentration range. The limit of detections, limit of quantifications and standard deviations achieved were lower than 0.1µgL -1 , 0.20µgL -1 and 3.46% respectively, when using NC as a nano-adsorbent, and lower than 0.07µgL -1 , 0.23µgL -1 and 2.62%, respectively, with the magnetic nanocellulose (MNC) was used. Both methods were applied to the determination of Sudan dyes in barbeque and ketchup sauce samples, obtaining recoveries between 93.4% and 109.6%. Copyright © 2017 Elsevier B.V. All rights reserved.

  9. Biosorption of eriochrome black t and astrazon fggl blue using almond and cotton seed oil cake biomass in a batch mode

    International Nuclear Information System (INIS)

    Safa, Y.

    2014-01-01

    In the present research study, the biosorption of Eriochrome Black T (EBT) and Astrazon FGGL blue (A-FGGL) onto novel biomasses Almond (Prunus dulcis) oil cake and Cotton seed oil cake respectively was investigated in the batch mode using different process parameters like pH, particle size, biosorbent dose, initial dye concentration, contact time and temperature. Maximum biosorption capacity was observed at pH 3 for EBT onto almond oil cake and pH2 for Astrazon FGGL blue onto cotton seed oil cake.The biosorption capacity was efficient at the smallest particle size of biosorbent. The amount of dye sorbed (mg/g) decreased with the decrease in biosorbent dose and increased with increase in initial dye concentration and temperature. Optimum contact time for equilibrium to achieve was found to be 120 and 180 minutes for EBT and A-FGGL blue, respectively. The Langmuir isotherm model was best fitted to experimental data. The biosorption followed the pseudo-second order kinetic model suggesting a chemisorption mechanism. The positive value of deltaH showed the endothermic nature of the process. In this research, the influence of electrolytes, heavy metals and surfactants on the removal of dyes was also examined. (author)

  10. Physicochemical studies on sunflower oil blended with cold pressed tiger nut oil during deep frying process

    Directory of Open Access Journals (Sweden)

    Ali Rehab, F. M.

    2012-10-01

    Full Text Available Sunflower oils were blended with different levels of cold pressed tiger nut oil. Blended oils were obtained by mixing tiger nut oil with sunflower oil at the volume ratios of 0:100, 10: 90, 20: 80, 30: 70, 40: 60, 50:50 and 100: 0. The effects of deep frying on physico-chemical parameters (Free Fatty Acid (FFA, Peroxide Value (PV, thiobarbituric acid value (TBA, iodine value, Total Polar Compounds (TPC, color and viscosity were evaluated over 30 hours of the frying process. The total phenolic content of native oils was determined. GLC analysis was performed to illustrate the fatty acid composition of sunflower oil, tiger nut oil and binary mixtures of them as well as their oxidation rates. The pure and blended oils were heated at 180 °C ± 5 °C, then frozen French fried potatoes were fried every 30 min. Oil samples were taken every 5 h and the entire continuous frying period was 30 h. The results showed that fresh sunflower oil had significantly the highest value of COX (7.25; while tiger nut oil had significantly the lowest (2.24. Mixing sunflower oil with different levels of tiger nut oil led to an increase in its stability against oxidation. The phenolic content of cold pressed tiger nut oil was about 3.3 times as high as that of sunflower oil. The analytical data showed that the lowest deterioration during the frying process occurred in tiger nut oil and the highest in sunflower. The changes in the physico-chemical parameters were controlled and significantly (P < 0.05 decreased when tiger nut /sunflower oil (W/W proportions were varied between 20/80 to 50/50. The obtained results indicate that mixing sunflower oil with cold pressed tiger nut oil increased the stability and hence improved the quality of sunflower oil during the frying process.

    Aceites de girasol se mezclaron con diferentes niveles de aceite de chufa prensado en frío. Se obtuvieron mezclas de aceite de chufa con girasol en las proporciones: 0:100, 10: 90, 20: 80, 30

  11. Roasting pumpkin seeds and changes in the composition and oxidative stability of cold-pressed oils.

    Science.gov (United States)

    Raczyk, Marianna; Siger, Aleksander; Radziejewska-Kubzdela, Elżbieta; Ratusz, Katarzyna; Rudzińska, Magdalena

    2017-01-01

    Pumpkin seed oil is valuable oil for its distinctive taste and aroma, as well as supposed health- promoting properties. The aim of this study was to investigate how roasting pumpkin seeds influences the physicochemical properties of cold-pressed oils. The fatty acid composition, content of phytosterols, carotenoids and tocopherols, oxidative stability and colour were determined in oils after cold pressing and storage for 3 months using GC-FID, GCxGC-ToFMS, HPLC, Rancimat and spectrophotometric methods. The results of this study indicate that the seed-roasting and storage process have no effect on the fatty acid composition of pumpkin seed oils, but does affect phytosterols and tocopherols. The carotenoid content decreased after storage. The colour of the roasted oil was darker and changed significantly during storage. Pumpkin oil obtained from roasted seeds shows better physicochemical properties and oxidative stability than oil from unroasted seeds.

  12. Evaluation of Castor Oil Cake Starch and Recovered Glycerol and Development of "Green" Composites Based on Those with Plant Fibers.

    Science.gov (United States)

    Guimarães, José Luis; Trindade Cursino, Ana Cristina; Ketzer Saul, Cyro; Sierrakowski, Maria Rita; Ramos, Luiz Pereira; Satyanarayana, Kestur Gundappa

    2016-01-27

    Continuous efforts are being made in some countries for the recovery of crude glycerin (RG/CG) and castor oil cake (COC), the two byproducts of biodiesel production. These are expected to help, not only in addressing environmental safety, but also in adding value to those byproducts, which otherwise may go to waste. Finding ways to utilize those byproducts underlines the main objective of this study. This paper presents the evaluation of (i) COC, glycerin and banana and sugarcane fibers for moisture content; (ii) COC for structural and thermal properties; and (iii) CG for its chemical characteristics. The possibility of using COC and CG with the selected fibers as reinforcement in the development of bio-composites is attempted through thermo-molding. Results revealed enhanced mechanical properties for these composites. The obtained results are discussed in terms of the observed morphology.

  13. Effects of microwave roasting on the yield and composition of cold pressed orange seed oils

    International Nuclear Information System (INIS)

    Aydeniz Güneşer, B.; Yilmaz, E.

    2017-01-01

    The aim of this study was to valorize orange (Citrus sinensis) seeds, which are generated as waste. This study presents data about raw orange seed, the meal gained after cold pressing, and characterization data of the cold pressed seed oils. Furthermore, the effects of microwave roasting of the seds compared to regular roasting (control) were determined. The oil yield of orange seed cold pressing was around 52.93–62.99%. After cold pressing, 13.57–17.97% oil remained in the meal together with 20.68–25.61% protein. Hence, pressed meals could be valorized for different purposes. Except for turbidity, the color b* value, free acidity, the p-anisidine value and antioxidant capacity, there was no significant difference between the two oil samples for the measured physicochemical properties. Six different fatty acids were quantified and the major fatty acids were linoleic, palmitic and oleic acids. The fatty acid composition of the orange seed oil can be accepted as nutritionally balanced. Among the fifteen sterols quantified, β-sitosterol was dominant (around 77–78%). Likewise, the α-tocopherol content of the samples was not significantly different. The thermal onset and peak temperatures, and enthalpies for crystallization and melting were also reported. This study showed that good quality orange seed oils can be produced by cold pressing, and the oils could be used in food and non-food applications. [es

  14. Solar drying in greenhouse of mixture of olive mill wastewater and olive cake in Morocco

    International Nuclear Information System (INIS)

    Lakhytar, H.; Ismaili-Alaoui, M.; Perraud-Gaime, L.; Macarie, H.; Roussos, S.

    2009-01-01

    Morocco is a country which produces olive oil extensively and this industry within the country is currently under huge expansion. This particular industry, which is usually realized with triphasic processes using the technique of pressing, generates tons of wastes: olive mill wastewater (OMWW) (liquid waste) and olive cake (solid waste). (Author)

  15. Evaluation of pressed shredded empty fruit bunch (EFB)-palm oil ...

    African Journals Online (AJOL)

    Pressed-shredded empty fruit bunches (EFB) and palm oil mill effluent (POME) anaerobic sludge from a 500 m3 closed anaerobic digester system was utilized for the co-composting treatment. Scanning electron microscopy (SEM) analysis showed that the shredding-pressing treatment on EFB gave better results in ...

  16. Processing of commercial peanut cake into food-grade meal and its utilization in preparation of cookies.

    Science.gov (United States)

    Tate, P V; Chavan, J K; Patil, P B; Kadam, S S

    1990-04-01

    The commercial cake produced during expeller pressing of peanuts was extracted with n-hexane, and 80% ethanol followed by sieving through 80 mesh, to remove residual oil, pigments, bitter taste and fibrous material. The processed meal exhibited comparable composition with defatted peanut flour prepared in the laboratory by solvent extraction of full-fat peanut meal. However, the processed cake meal exhibited low methionine content and in vitro protein digestibility as compared with defatted peanut flour. The processed cake meal can be blended with wheat flour to the extent of 10% (w/w) to prepare acceptable cookies with improved protein and mineral contents.

  17. HDO of guaiacol over NiMo catalyst supported on activated carbon derived from castor de-oiled cake

    Directory of Open Access Journals (Sweden)

    Viviana Ospina

    2015-05-01

    Full Text Available Physical and chemical activation methods were used to prepare two different activated carbons (ACs from castor de-oiled cake. H2O/CO2 mixture was used as the physical activating agent, and for chemical activation potassium carbonate (K2CO3 was used. For both materials, textural and chemical properties were characterized by N2 adsorption–desorption isotherms, thermogravimetric analysis (TGA, Fourier Transform Infrared Spectroscopy (FTIR, thermal programmed reduction (TPR, X-ray fluorescence (XRF, and scanning electron microscopy (SEM. The ACs were used as supports for NiMo sulfide catalysts, which were prepared by wetness impregnation and in-situ sulfided for the hydrodeoxygenation (HDO of guaiacol (GUA as a model compound of bio-oil. The HDO reaction was carried out in a typical batch reactor at 5 MPa of H2 and 350 °C. Under the same test conditions, commercial catalysts were also tested in the reaction. Although the commercial catalysts displayed higher GUA conversion, the prepared catalysts showed higher activity and non-oxygenated and saturated products yield.

  18. Feasibility and comparative studies of thermochemical liquefaction of Camellia oleifera cake in different supercritical organic solvents for producing bio-oil

    International Nuclear Information System (INIS)

    Chen, Hongmei; Zhai, Yunbo; Xu, Bibo; Xiang, Bobin; Zhu, Lu; Li, Ping; Liu, Xiaoting; Li, Caiting; Zeng, Guangming

    2015-01-01

    Highlights: • Thermochemical liquefaction of COC was a prominent process for producing bio-oil. • Type of solvent affected the yield and composition of bio-oil considerably. • Liquefaction of COC in SCEL at 300 °C was preferred for producing bio-oil. - Abstract: Thermochemical liquefaction of Camellia oleifera cake (COC) for producing bio-oil was conducted in supercritical methanol (SCML), ethanol (SCEL) and acetone (SCAL), respectively. GC–MS, elemental analysis and ICP-OES were used to characterize properties of bio-oil. Results showed that thermochemical liquefaction of COC was a prominent process for generating bio-oil. Increase of temperature was beneficial to the increase of bio-oil yield, and yield of bio-oil followed the sequence of SCAL > SCEL > SCML. In spite of the highest bio-oil yield, the lowest calorific value and highest contents of Zn, Pb, Cd, Ni, Fe, Mn, and Cr were found in bio-oil from SCAL. Though SCML has very similar bio-oil composition and calorific value with SCEL, higher bio-oil yield and lower contents of heavy metals could be obtained with SCEL, especially in bio-oil from SCEL at 300 °C. Moreover, the origin of ethanol could make the bio-oil product totally renewable. Therefore, liquefaction of COC in SCEL at 300 °C could have great potential in generating bio-oil

  19. Adhesion and cleaning of foods with complex structure: Effect of oil content and fluoropolymer coating characteristics on the detachment of cake from baking surfaces

    OpenAIRE

    Magens, Ole; Liu, Y; Hofmans, JFA; Nelissen, JA; Wilson, David Ian

    2017-01-01

    The effect of surface coating on the detachment of a complex microstructured food material, was investigated using an improved version of the millimanipulation device described by Ali et al. (2015 $\\textit{Food & Bioproducts Processing}$, Vol. 93, 256–268). The test material was baked sponge cake batter, which contains approximately 27 vol% bubbles in a ‘continuous’ phase of emulsified oil in a flour/syrup suspension. Detachment in the dry state was studied for aluminium, 304 stainless steel ...

  20. Combined effect of soil amendment with oil cakes and seed priming in the control of root rot fungi of leguminous and non-leguminous crops

    International Nuclear Information System (INIS)

    Rafi, H.; Dawar, S.; Tariq, M.

    2016-01-01

    Organic amendments of soil help in proper aeration, rising of temperature and water holding capacity which results in better uptake of nutrients with root system gets extensive establishment. In this study, effects of soil amendment with oil seed cakes including mustard (Brassica campestris L.), cotton (Gossypium hirsutum L.), almond (Prunus amygdalus L.) and black seed (Nigella sativa L.) cakes at the rate of 0.1 and 1% w/w and priming of seeds with Acacia nilotica (L.) Willd. ex Delile and Sapindus mukorossi (L.) leaves extracts and microbial antagonists (Trichoderma harzianum and Rhizobium melilotii) was observed on the growth of plants and in the suppression of root infecting fungi. The results obtained showed that combined effect of bio-priming of seeds with T. harzianum spore suspension and amendment of soil with mustard cake at the rate of 1% was found to be most effective for the growth of leguminous and non-leguminous crop plants (peanut, chickpea, okra and sunflower) and for the reduction of root infecting fungi like Macrophomina phaseolina, Fusarium spp followed by R. meliloti primed seeds in combination with cotton, almond and black seed cakes amendment respectively as compared to control (non treated seeds and soil). (author)

  1. Study of volatile oil component of petal and herbal and extraction of seed oil in Borage by Cold Press method

    Directory of Open Access Journals (Sweden)

    esfandiar Hassani Moghadam

    2010-03-01

    Full Text Available There is a few reported about the volatile oil component of petal, herbal and component of seed oil of borage. This research worked carried out for analysis and identification the volatile oil in herbals, petals, and seed oil compositions of Borago officinalis L. in Lorestan province. Material and methods: Extraction of essential oil from petals carried out using steam distillation by Clevenger apparatus. The new SPME-GC/MS method is used for extraction and identification of volatile oil compounds in the herbal of borage. The oil of the seeds was extracted using a Cold-press method. The identification of chemical composition of extracted oil was carried out by GC/MS apparatus. Results: In petals of Borage only Carvacerol component, and in the herbal of Borage three components Carvacrol, Bisabolone oxide and 2-Phenylethyl benzoate, extracted and identified respectively. In the seed oil of borage 16 different components were separated and identified. The following components had the highest amount in seed oil: Hexadecane, N, N-dimethylethanolamine, Beta-d-glycoside, 3, 6-glucurono-methyl, Benzaldehde, 4-methyl 3-Hydroxytetrahydrofuran, Hexadecanoic acid, Heptanoic acid, Gamma butyrolactone and Ethyl octadec-9-enoate are the major components respectively. These components contain 63.4% of all components in borage seed oil and the 7 residual components only 9.5% all of the components in borage seed oil. Also one unknown (27.1% component identified. Conclusion: Using result obtained from this research the volatile oil a few amounts of the borage chemical composition. The results show that the seed oil of this species can be used for medicinal preparation. Cold Press method was found to be rapid and simple for identification of seeds oil components.

  2. Transesterification of mustard (Brassica nigra) seed oil with ethanol: Purification of the crude ethyl ester with activated carbon produced from de-oiled cake

    International Nuclear Information System (INIS)

    Fadhil, Abdelrahman B.; Abdulahad, Waseem S.

    2014-01-01

    Highlights: • Biodiesel ethyl ester has been developed from mustard seed oil. • Variables affect the transesterification were investigated. • Dry washing using the activated carbon produced from the extraction remaining was applied to purify the ethyl esters. • Properties of the produced fuels were measured. • Blending of the produced ethyl ester with petro diesel was also investigated. - Abstract: The present study reports the production of mustard seed oil ethyl esters (MSOEE) through alkali-catalyzed transesterification with ethanol using potassium hydroxide as a catalyst. The influence of the process parameters such as catalyst concentration, ethanol to oil molar ratio, reaction temperature, reaction duration and the catalyst type was investigated so as to find out the optimal conditions for the transesterification process. As a result, optimum conditions for production of MSOEE were found to be: 0.90% KOH wt/wt of oil, 8:1 ethanol to oil molar ratio, a reaction temperature of 60 °C, and a reaction time of 60 min. Dry washing method with (2.50% wt.) of the activated carbon that was produced from the de-oiled cake was used to purify the crude ethyl ester from the residual catalyst and glycerol. The transesterification process provided a yield of 94% w/w of ethyl esters with an ester content of 98.22% wt. under the optimum conditions. Properties of the produced ethyl esters satisfied the specifications prescribed by the ASTM standards. Blending MSOEE with petro diesel was also investigated. The results showed that the ethyl esters had a slight influence on the properties of petro diesel

  3. Effects of de-oiled palm kernel cake based fertilizers on sole maize ...

    African Journals Online (AJOL)

    AJL

    2012-03-08

    Mar 8, 2012 ... formulations on the yield of sole maize and cassava crops. Two de-oiled palm ..... establishment of nitrogen fixing bacteria in the rhizosphere. Microb ... Biological, and Social Sciences Research, 2nd Edition. Optimal Publ.

  4. Influence of press temperature on the properties of binderless particleboard made from oil palm trunk

    International Nuclear Information System (INIS)

    Hashim, Rokiah; Said, Norafizah; Lamaming, Junidah; Baskaran, Mohana; Sulaiman, Othman; Sato, Masatoshi; Hiziroglu, Salim; Sugimoto, Tomoko

    2011-01-01

    Research highlights: → Influence of press temperature on binderless particleboard of oil palm trunk. → Modulus of rupture increased with increasing press temperature. → The internal bond strength of samples meets JIS standard. → Water absorption and thickness swelling improved. → Increasing pressing temperature improve properties of the boards. -- Abstract: The objective of this investigation was to evaluate the properties of binderless particleboard manufactured from oil palm trunk as a function of press temperature. Particleboard samples were manufactured with a target density of 0.80 g/cm 3 using press temperatures of 160 o C, 180 o C and 200 o C. The modulus of rupture, internal bond strength, water absorption and thickness swelling of the boards were determined based on Japanese Industrial Standards (JIS). Thermal gravimetric analysis, Fourier transform infrared spectroscopy and field-emission scanning electron microscopy coupled with energy dispersive X-ray analysis were employed to characterize the properties of the raw materials and the manufactured panels. The moduli of rupture of the samples were observed to increase with increasing press temperature, but they did not meet the standard values. However, the internal bond strength of the samples attained satisfactory values according to the JIS standard for all three temperature levels. Water absorption and thickness swelling of the boards decreased with increasing pressing temperature. Based on the findings in this study, increasing the pressing temperature may be considered a potential way of improving the properties of binderless particleboard.

  5. EXTRACTION OF OIL FROM PRESSED PALM OIL (Elaes guineensis FIBERS USING SUPERCRITICAL CO2

    Directory of Open Access Journals (Sweden)

    Luiz F. FRANÇA

    1997-12-01

    Full Text Available Residual fibers from palm oil production are a good source of carotene, since they contain more than 5% of the original oil, with about 5000 ppm of carotenoids. As carotenoids are thermosensitive molecules, supercritical CO2 can be used for oil recovery, because this technique employs low temperatures. In this work results of oil extraction experiments from pressed palm oil fibers are shown. Fibers were from AGROPALMA, an industry which is located in Tailândia (Pará, Brazil. Extractions were carried out at 200, 250 and 300 bar and at temperatures of 45 and 55oC. Oil was analyzed by UV/vis spectrophotometry for total carotene determination. Results showed a large increase in extraction rate from 200 to 250 bar and a small variation from 250 to 300 bar. The total amount of carotenes did not increase in the course of extraction at 300 bar, but it showed a large increase at 200 and at 250 bar. Free fatty acids are present in amounts larger than those found in commercial oils.As fibras residuais do processo de produção de óleo de palma (óleo de dendê, podem ser uma boa fonte de carotenos, pois contém, ainda, mais de 5% do óleo original, com cerca de 5.000 ppm de carotenóides. Como os carotenóides são moléculas termodegradáveis, é importante um estudo do emprego de CO2 supercrítico na extração deste óleo, visto que esta é uma técnica que emprega baixas temperaturas. Neste trabalho são mostrados os resultados de experimentos de extração do óleo das fibras prensadas de dendê, feitas a 200, 250 e 300 bar e temperaturas de 45 e 55oC. As fibras prensadas foram obtidas da produção industrial da indústria AGROPALMA, localizada em Tailândia (Pará, Brasil. O óleo obtido foi analisado por espectrofotometria UV/vis para a determinação do teor de carotenos totais. Os resultados mostram um aumento na taxa de extração entre 200 e 250 bar, mas esta variação foi pequena entre 250 e 300 bar. O teor de carotenos totais não aumenta

  6. Relative Coagulation Effectiveness of Jatropha curcas Press Cake (Physic Nut and Aluminium Sulphate in Purifying Domestic Sewage

    Directory of Open Access Journals (Sweden)

    Kamoru Akanni ADENIRAN

    2016-09-01

    Full Text Available An investigation was conducted on the relative effectiveness of using press cake of dried Jatropha curcas (Physic nut seed and alum (Aluminium sulphate for the purification of domestic sewage. The experimental design used was Completely Randomized Design (CRD replicated three times. Physical and chemical properties of domestic sewage were investigated before and after the purification exercise. Treatments imposed included: the control culture (no alum and Jatropha, 10 mg/l of Aluminium Sulphate (alum treatment, 80 mg/l of J. curcas treatment, 100 mg/l of J. curcas treatment and 120 mg/l of J. curcas treatment. The results showed that for the total dissolved solids, cultured tanks treated with 80 mg/l of J. curcas reduced the sewage concentration from 30.1 mg/l to 23.20 mg/l, Biological Oxygen Demand (BOD was reduced from 30.55 mg/l to 30.10 mg/l, increased acidity from 5.33 mg/l to 5.66 mg/l, reduced alkalinity from 6.35 mg/l to 6.0 mg/l, reduced pH from 7.6 to 6.55, and likewise 10 mg/l of alum also reduced pH from 7.6 to 6.55. The cultured tanks treated with 120 mg/l of J. curcas performed best in reducing turbidity and Chemical Oxygen Demand (COD of the sewage. The turbidity was reduced from 5.99 NTU to 5.6 NTU; 120 mg/l of J. curcas also reduced total hardness from 9.6 mg/l to 7.15 mg/l, total solids from 55.6 mg/l to 55.17 mg/l. Cultured tanks treated with 10 mg/l of alum reduced total dissolved solids from 30.1 mg/l to 24.30 mg/l, while those treated with 80 mg/l of J. curcas reduced it from 30.1 mg/l to 23.20 mg/l, 100 mg/l and 120 mg/l of J. curcas reduced it to 25.20 mg/l. Total suspended solids increased from 25.5 mg/l to 30.96 mg/l for 10 mg/l of alum, to 30.22 mg/l for 80 mg/l of J. curcas, 30.26 mg/l for 100 mg/l of J. curcas and 30.38 mg/l for 120 mg/l of J. curcas. Conductivity increased withion the study period from 525 μS/cm to 830 μS/cm for 10 mg/l of alum, to 590 μS/cm for 80 mg/l of J. curcas, 634 μS/cm for 100 mg/l of J

  7. Effect of seed quality on oxidative stability of cold-pressed sunflower oil

    Directory of Open Access Journals (Sweden)

    Dimić Etelka B.

    2015-01-01

    Full Text Available The objective of this study was to investigate the impact of the storage time, content of the husk and impurities in the seed mass on the oxidative stability of the cold pressed sunflower oil. The oxidative stability of oil was analyzed by the RSM (Response Surface Methodology, where the response value (output of the model was the content of oxidation products measured via specific absorbance at 232 nm for conjugated dienes and 270 nm for conjugated trienes. Analyses were performed on the fresh oil samples and oil samples tempered under the Schaal-Oven’s test conditions (96 h at 63±2ºC. It was concluded that the seed storage time had significant impact on the primary (A1%232nm and secondary (A1%270nm oil oxidation products, both before (b1-p<0,001; b1-p=0,021 and after (b1-p=0,048; b1-p=0,033 the heating of oil. The content of impurities and husks in the seeds used for pressing also had an influence of the conjugated dienes and trienes contents in both, fresh and heated oil samples. However, their impact was not statistically significant. Interaction of seed storage time, the content of impurities and husks also exert some effect on the values of these quality parameters in the fresh oil as well as in the oil after the heat treatment, even though their influence is not significant. The obtained results have shown that the cold pressed sunflower oil had a good oxidative stability at temperatures up to 63±2ºC.

  8. Evaluation of Some Medicinal Herbs Cold Pressed Oils According Their Physicochemical Properties with Chemometry

    OpenAIRE

    Üstün Argon, Zeliha; Gökyer, Ali; Gümüş, Zinar Pınar; Büyükhelvacıgil, Mevlüt

    2017-01-01

    In thisstudy, we investigated the effects of cold pressed oil on physicochemical propertiesof milk thistle (Silybum marianum), aniseseed (Pimpinella anisum), fennel seed(Foeniculum vulgare), terebinth (Pistacia terebinthus), coriander (Coriandrum sativum) and nettle seed (Urtica dioica). Selected oils from CentralAnatolia Regions, were investigated in terms of the fatty acid methyl esters (FAME)compositions, peroxide value (PV), free fatty acid (FFA), refraction index (RI)at 40 ° C and oilsee...

  9. Chemical characterization of a variety of cold-pressed gourmet oils available on the Brazilian market.

    Science.gov (United States)

    Cicero, Nicola; Albergamo, Ambrogina; Salvo, Andrea; Bua, Giuseppe Daniel; Bartolomeo, Giovanni; Mangano, Valentina; Rotondo, Archimede; Di Stefano, Vita; Di Bella, Giuseppa; Dugo, Giacomo

    2018-07-01

    Different specialty extra virgin oils, produced by cold-pressing fruits/nuts (olive, pequi, palm, avocado, coconut, macadamia and Brazil nut) and seeds (grapeseed and canola), and retailed in the Brazilian region of Minas Gerais, were chemically characterized. Specifically, for each type of oil, the fatty acid composition was elucidated by GC-FID, the contents of selected polyphenols and squalene were determined respectively by UHPLC-MS and UHPLC-PDA, whereas minerals were explored by means of ICP-MS. Olive oil was confirmed to have the highest MUFA content due to a valuable level of oleic acid, while oils from grapeseed, Brazil nut and canola were marked by nutritionally important PUFA levels. The highest SFA content found in coconut oil was mainly due to the high levels of lauric acid, known for its advantageous HDL-raising effects. As for polyphenols, gourmet oils from palm, coconut and canola showed higher levels of phenolic acids (e.g. p-hydroxybenzoic, ferulic, syringic, acids) than olive oil, which was though characterized by peculiar antioxidants, such as tyrosol and hydroxytyrosol. Also, olive oil had the highest amount of squalene, followed by the oil from Brazil nut. Finally, all the investigated oils had very low levels (order of μg/kg) of pro-oxidant elements, such as Cu, Fe and Mn. Overall, these findings may fill the gaps still present in literature on certain compositional aspects of commercially available gourmet oils. Copyright © 2018 Elsevier Ltd. All rights reserved.

  10. Press freedom, oil exports, and risk for natural disasters: a challenge for climato-economic theory?

    Science.gov (United States)

    Arantes, Joana; Grace, Randolph C; Kemp, Simon

    2013-10-01

    Does the interaction between climactic demands, monetary resources, and freedom suggest a more general relationship between the environmental challenges that human societies face and their resources to meet those challenges? Using data on press freedom (Van de Vliert 2011a), we found no evidence of a similar interaction with natural resources (as measured by oil exports) or risk for natural disasters.

  11. Walnut and almond oil screw-press extraction at industrial scale: Effects of process parameters on oil yield and quality

    Directory of Open Access Journals (Sweden)

    M. L. Martínez

    2018-01-01

    Full Text Available Walnut and almond kernels are highly nutritious mainly due to their high oil contents. In this study, 32 factorial experimental designs were used to optimize processes for oil extraction by screw-pressing at industrial scale. Experimental designs included seed moisture content (SMC, and restriction die (RD as the main processing parameters. Theoretical models were scanned against experimental data in order to optimize oil extraction conditions. The response variables analyzed were oil yield (OY, fine solid content (FC in oil, and oil quality parameters. Fitted models for OY indicated maximum predicted values similar to the highest experimental values. Walnut oil extractions showed a maximum OY (84.5 ± 2.3 % at 7.21% SMC, and 10 mm RD. For almond kernels, maximum OY (71.9 ± 3.5% was obtained at 9.42% SMC, and 12 mm RD. Chemical quality parameters from both oils were in the ranges stated in Codex (FAO/WHO standards for virgin (non-refined oils.

  12. Walnut and almond oil screw-press extraction at industrial scale: Effects of process parameters on oil yield and quality

    International Nuclear Information System (INIS)

    Martínez, M. L.; Bordón, M.G.; Bodoira, R. M.; Penci, M.C.; Ribotta, P.D.; Maestri, D.M.

    2017-01-01

    Walnut and almond kernels are highly nutritious mainly due to their high oil contents. In this study, 32 factorial experimental designs were used to optimize processes for oil extraction by screw-pressing at industrial scale. Experimental designs included seed moisture content (SMC), and restriction die (RD) as the main processing parameters. Theoretical models were scanned against experimental data in order to optimize oil extraction conditions. The response variables analyzed were oil yield (OY), fine solid content (FC) in oil, and oil quality parameters. Fitted models for OY indicated maximum predicted values similar to the highest experimental values. Walnut oil extractions showed a maximum OY (84.5 ± 2.3 %) at 7.21% SMC, and 10 mm RD. For almond kernels, maximum OY (71.9 ± 3.5%) was obtained at 9.42% SMC, and 12 mm RD. Chemical quality parameters from both oils were in the ranges stated in Codex (FAO/WHO) standards for virgin (non-refined) oils. [es

  13. Plausible exploitation of Jatropha de-oiled seed cake for lipase and phytase production and simultaneous detoxification by Candida parapsilosis isolated from poultry garbage.

    Science.gov (United States)

    Kannoju, Balakrishna; Ganapathiwar, Swaruparani; Nunavath, Hanumalal; Sunkar, Bindu; Bhukya, Bhima

    2017-02-01

    Jatropha de-oiled seed cake was explored to utilize as a basic nutrient source for Candida parapsilosis, isolated from poultry garbage and selected based on the production of lipase and phytase enzymes under submerged fermentation. At optimized parameters under solid-state fermentation, lipase and phytase activities were recorded as 1056.66±2.92 and 833±2.5U/g of substrate (U/g), respectively. Besides enzyme production, complete elimination of phorbol esters and significant phytate reduction from 6.51±0.01 to 0.43±0.01g/100g of seed cake were noted after 3days incubation. Curcin and trypsin inhibition activity were reduced significantly from 26.33±0.43 to 0.56±0.02mg/100g and 229.33±2.02 to 11.66±0.28U/g, respectively after 5days incubation. Saponins were reduced from 5.56±0.19 to 1.95±0.01g/100g of seed cake after 7days incubation. Copyright © 2016 Elsevier Ltd. All rights reserved.

  14. Effect of varying levels of formaldehyde treatment of mustard oil cake on rumen fermentation, digestibility in wheat straw based total mixed diets in vitro

    Science.gov (United States)

    Mahima; Kumar, Vinod; Tomar, S. K.; Roy, Debashis; Kumar, Muneendra

    2015-01-01

    Aim: The aim of the current study was to protect the protein in mustard cake by different levels of formaldehyde treatment with a view to optimize the level of formaldehyde. Materials and Methods: Different levels of formaldehyde treatment (0, 1, 1.5 and 2% of crude protein) containing concentrate and roughages diet in 40:60 ratio were tested for their effect on nutrients digestibility, in vitro ammonia release, in vitro gas production and change in protein fractions. Non-significant (p≤0.05) effect on pH, microbial biomass, partitioning factor, total gas production (TGP), TGP per g dry matter and TGP per g digestible dry matter (ml/g) was observed in almost all the treatments. Results: Total volatile fatty acids at 2% formaldehyde treatment level of mustard cake was lower (p<0.05) as compared to other groups, while in vitro dry matter digestibility and in vitro organic matter digestibility were reported to be low in 1% formaldehyde treated group. Conclusion: On a holistic view, it could be considered that formaldehyde treatment at 1.5% level was optimal for protection of mustard oil cake protein. PMID:27047133

  15. Effect of varying levels of formaldehyde treatment of mustard oil cake on rumen fermentation, digestibility in wheat straw based total mixed diets in vitro

    Directory of Open Access Journals (Sweden)

    Mahima

    2015-04-01

    Full Text Available Aim: The aim of the current study was to protect the protein in mustard cake by different levels of formaldehyde treatment with a view to optimize the level of formaldehyde. Materials and Methods: Different levels of formaldehyde treatment (0, 1, 1.5 and 2% of crude protein containing concentrate and roughages diet in 40:60 ratio were tested for their effect on nutrients digestibility, in vitro ammonia release, in vitro gas production and change in protein fractions. Non-significant (p≤0.05 effect on pH, microbial biomass, partitioning factor, total gas production (TGP, TGP per g dry matter and TGP per g digestible dry matter (ml/g was observed in almost all the treatments. Results: Total volatile fatty acids at 2% formaldehyde treatment level of mustard cake was lower (p<0.05 as compared to other groups, while in vitro dry matter digestibility and in vitro organic matter digestibility were reported to be low in 1% formaldehyde treated group. Conclusion: On a holistic view, it could be considered that formaldehyde treatment at 1.5% level was optimal for protection of mustard oil cake protein.

  16. Avocado oil extraction processes: method for cold-pressed high-quality edible oil production versus traditional production

    Directory of Open Access Journals (Sweden)

    Giacomo Costagli

    2015-10-01

    Full Text Available Nowadays the avocado fruit (Persea americana Mill. is widely regarded as an important fruit for its nutritional values, as it is rich in vital human nutrients. The avocado fruit is mainly sold fresh on the market, which however trades also a relevant quantity of second-grade fruits with a relatively high oil content. Traditionally, this oil is extracted from dried fruits by means of organic solvents, but a mechanical method is also used in general in locations where drying systems and/or solvent extraction units cannot be installed. These traditional processes yield a grade of oil that needs subsequent refining and is mainly used in the cosmetic industry. In the late 1990s, in New Zeland, a processing company with the collaboration of Alfa Laval began producing cold-pressed avocado oil (CPAO to be sold as edible oil for salads and cooking. Over the last fifteen years, CPAO production has increased in many other countries and has led to an expansion of the market which is set to continue, given the growing interest in highquality and healthy food. Avocado oil like olive oil is extracted from the fruit pulp and in particular shares many principles of the extraction process with extra-vergin olive oil. We conducted a review of traditional and modern extraction methods with particular focus on extraction processes and technology for CPAO production.

  17. Procedure of dewatering by pressing of biomass pulp, especially a peat cake. Saett att genom pressning avvattna en kaka av biomassa, foeretraedesvis en torvkaka

    Energy Technology Data Exchange (ETDEWEB)

    Eriksson, S

    1988-05-24

    The pulp is dewatered by pressing above 90 degrees C, the pulp water being displaced by warmer water under successively increased pressure. A device designed like a closed washing press is used. The pulp is subjected to dewatering, washing or displacement by warmer water and thus heating, and calendering. (O.S.).

  18. Evening primrose (Oenothera paradoxa) cake as an unconventional protein source.

    Science.gov (United States)

    Golabczak, J; Py, R

    2003-01-01

    An efficient procedure of a protein isolate production from the evening primrose cake was developed. The cake is a by-product of oil extraction from seeds by using the cold pressing method. The evening primrose cake contains 22.7% of protein. Its content in the protein isolate derived from the cake is 74%. Proteins present in evening primrose seeds are rich in Trp (7%) and Met (3%), but Lys-deficient (1.3%) as compared to the FAO protein standard. Apart from the proteins, the protein isolate contains 8.5% (w/w per s.s.) dietary fiber, that negatively affects its digestibility. To enhance the bio-availability of the protein isolate, it was partially hydrolyzed with commercial preparations of trypsin and other proteases (Alcalase and Flavourzyme, Novozymes. Denmark). The most advanced proteolysis (52%) was achieved by 6 h digestion of 2% protein suspension with a mixture of Flavourzyme and Alcalase (350 and 600 U per g of protein, respectively) at 50 degrees C and pH 9.0.

  19. Optimization of Pumpkin Oil Recovery by Using Aqueous Enzymatic Extraction and Comparison of the Quality of the Obtained Oil with the Quality of Cold-Pressed Oil

    Directory of Open Access Journals (Sweden)

    Beata Roszkowska

    2016-01-01

    Full Text Available The study was carried out to optimize pumpkin oil recovery in the process of aqueous extraction preceded by enzymatic maceration of seeds, as well as to compare the quality of the obtained oil to the quality of cold-pressed pumpkin seed oil. Hydrated pulp of hulless pumpkin seeds was macerated using a 2 % (by mass cocktail of commercial pectinolytic, cellulolytic and proteolytic preparations (Rohapect® UF, Rohament® CL and Colorase® 7089. The optimization procedure utilized response surface methodology based on Box-Behnken plan of experiment. The optimized variables of enzymatic pretreatment were pH, temperature and maceration time. The results showed that the pH value, temperature and maceration time of 4.7, 54 °C and 15.4 h, respectively, were conducive to maximize the oil yield up to 72.64 %. Among these variables, the impact of pH was crucial (above 73 % of determined variation for oil recovery results. The oil obtained by aqueous enzymatic extraction was richer in sterols, squalene and tocopherols, and only slightly less abundant in carotenoids than the cold-pressed one. However, it had a lower oxidative stability, with induction period shortened by approx. 30 % in relation to the cold-pressed oil.

  20. Optimization of Pumpkin Oil Recovery by Using Aqueous Enzymatic Extraction and Comparison of the Quality of the Obtained Oil with the Quality of Cold-Pressed Oil

    Science.gov (United States)

    Roszkowska, Beata; Czaplicki, Sylwester; Tańska, Małgorzata

    2016-01-01

    Summary The study was carried out to optimize pumpkin oil recovery in the process of aqueous extraction preceded by enzymatic maceration of seeds, as well as to compare the quality of the obtained oil to the quality of cold-pressed pumpkin seed oil. Hydrated pulp of hulless pumpkin seeds was macerated using a 2% (by mass) cocktail of commercial pectinolytic, cellulolytic and proteolytic preparations (Rohapect® UF, Rohament® CL and Colorase® 7089). The optimization procedure utilized response surface methodology based on Box- -Behnken plan of experiment. The optimized variables of enzymatic pretreatment were pH, temperature and maceration time. The results showed that the pH value, temperature and maceration time of 4.7, 54 °C and 15.4 h, respectively, were conducive to maximize the oil yield up to 72.64%. Among these variables, the impact of pH was crucial (above 73% of determined variation) for oil recovery results. The oil obtained by aqueous enzymatic extraction was richer in sterols, squalene and tocopherols, and only slightly less abundant in carotenoids than the cold-pressed one. However, it had a lower oxidative stability, with induction period shortened by approx. 30% in relation to the cold-pressed oil. PMID:28115898

  1. Micro-pressing of rapeseed (Brassica napus L. and Arabidopsis thaliana seeds for evaluation of the oil extractability

    Directory of Open Access Journals (Sweden)

    Savoire Raphaëlle

    2010-03-01

    Full Text Available Pressing is a crucial step in the crushing process of rapeseed seeds, regarding its major effect on the oil extraction yield, the energy consumption and the quality of the meal. In order to study and model in a rigorous way the behaviour of rapeseed seeds, and the oil extraction during pressing, the potential of a micro-pressing technique using a instrumented micro press adapted to quantities of seeds as low as 10 g for rapeseed and 3 g for Arabidopsis thaliana was examined and discussed. Using a phenomenological model, data from the pressing process and the material behaviour (compressibility modules were obtained with a good precision, highlighting small differences between samples. The well-known positive effect of the temperature on the oil extraction yield was confirmed with A. thaliana. Micro-pressing of ground and cooked rapeseed seeds did not lead to the results usually reported in the literature for continuous pressing. The results strongly suggest that the performance of the static micro-pressing is related to the macro-and micro-structure of seeds and is less sensitive to the moisture than continuous pressing. Further experiments are needed to confirm that the micro-pressing could be an effective tool for predicting the extractability of oil and therefore, contribute to plant breeding programmes in the future.

  2. The Composition, Antioxidant and Antibacterial Activities of Cold-Pressed and Distilled Essential Oils of Citrus paradisi and Citrus grandis (L. Osbeck

    Directory of Open Access Journals (Sweden)

    Ming-Chiu Ou

    2015-01-01

    Full Text Available The chemical composition and functional activities of cold-pressed and water distilled peel essential oils of Citrus paradisi (C. paradisi and Citrus grandis (L. Osbeck (C. grandis were investigated in present study. Yields of cold-pressed oils were much higher than those of distilled oils. Limonene was the primary ingredient of essential oils of C. paradisi (cold 92.83%; distilled 96.06% and C. grandis (cold 32.63%; distilled 55.74%. In addition, C. grandis oils obtained were rich in oxygenated or nitrogenated compounds which may be involved in reducing cardiovascular diseases or enhancing sleep effectiveness. The order of free radical scavenging activities of 4 citrus oils was distilled C. paradisi oil > cold-pressed C. paradisi oil > distilled C. grandis oil > cold-pressed C. grandis oil. Cold-pressed C. grandis oil exhibited the lowest activity in all antioxidative assays. The order of antimicrobial activities of 4 citrus oils was distilled C. grandis oil, cold-pressed C. paradisi oil > distilled C. paradisi oil > cold-pressed C. paradisi oil. Surprisingly, distilled C. grandis oil exhibited better antimicrobial activities than distilled C. paradisi oil, especially against Escherichia coli and Salmonella enterica subsp. The results also indicated that the antimicrobial activities of essential oils may not relate to their antioxidative activities.

  3. Quantitative analysis of γ-oryzanol content in cold pressed rice bran oil by TLC-image analysis method

    OpenAIRE

    Sakunpak, Apirak; Suksaeree, Jirapornchai; Monton, Chaowalit; Pathompak, Pathamaporn; Kraisintu, Krisana

    2014-01-01

    Objective: To develop and validate an image analysis method for quantitative analysis of γ-oryzanol in cold pressed rice bran oil. Methods: TLC-densitometric and TLC-image analysis methods were developed, validated, and used for quantitative analysis of γ-oryzanol in cold pressed rice bran oil. The results obtained by these two different quantification methods were compared by paired t-test. Results: Both assays provided good linearity, accuracy, reproducibility and selectivity for dete...

  4. Potentials of enhancing the physicochemical and functional characteristics of Nigella sativa oil by using the screw pressing technique for extraction

    International Nuclear Information System (INIS)

    Hamed, S.F.; Shaaban, H.A.; Ramadan, A.A.; Edris, A.E.

    2017-01-01

    In the current investigation the crude oil of Nigella sativa was extracted from seeds using hydraulic and screw pressing techniques. Different parameters were evaluated in order to find out the appropriate technique to enhance the physicochemical and functional-related characteristics of the extracted crude oil. Results showed that the acid and peroxide values were significantly lower in the screw pressed oil (SPO) than in the hydraulic pressed oil (HPO). The total phenolic content of the SPO was significantly higher than that of HPO. Evaluation of the oxidative stability using the Rancimat test showed that SPO recorded a much higher oxidative stability index (40.07 h) than HPO (0.51 h). The yield of the volatile oil fraction and its contents of thymoquinone isolated from the SPO were higher than that from the HPO. Biological evaluation revealed that the SPO had significantly higher antimicrobial activity than HPO against Listeria monocytogenes and Staphylococcus aureus at 40 μL/well. [es

  5. Conjoint effect of oil-seed cakes and Pseudomonas fluorescens on the growth of chickpea in relation to the management of plant-parasitic nematodes

    Directory of Open Access Journals (Sweden)

    Rose Rizvi

    2012-12-01

    Full Text Available Soil application of organics has been explored as an alternative means of organic management of plant-parasitic nematodes. Efficiency of different oil-seed cakes of neem (Azadirachta indica, castor (Ricinus communis, groundnut (Arachis hypogaea, linseed (Linum usitatissimum, sunflower (Helianthus annuus and soybean (Glycine max were evaluated in field conditions with association of Pseudomonas fluorescens in relation to growth parameters of chickpea and population of plant-parasitic nematodes. Their efficacious nature was highly effective in reducing the population of these dominant soil nematodes. Significant improvement was observed in plant-growth parameters such as plant weight, percent pollen fertility, pod numbers, root-nodulation and chlorophyll content of chickpea, seemed to be due to reduction in disease incidence and might be due to growth promoting substances secreted by P. fluorescens. The multiplication rate of nematodes was less in the presence of P. fluorescens as compared to its absence. Most effective combination of P. fluorescens was observed with neem cake.

  6. First stage of bio-jet fuel production: non-food sunflower oil extraction using cold press method

    Directory of Open Access Journals (Sweden)

    Xianhui Zhao

    2014-06-01

    Full Text Available As a result of concerning petroleum price increasing and environmental impact, more attention is attracted to renewable resources for transportation fuels. Because not conflict with human and animal food resources, non-food vegetable oils are promising sources for developing bio-jet fuels. Extracting vegetable oil from oilseeds is the first critical step in the pathway of bio-jet fuel production. When sunflower seeds are de-hulled, there are always about 5%–15% broken seed kernels (fine meat particles left over as residual wastes with oil content up to 48%. However, the oil extracted from these sunflower seed residues is non-edible due to its quality not meeting food standards. Genetically modified sunflower grown on margin lands has been identified one of sustainable biofuel sources since it doesn't compete to arable land uses. Sunflower oils extraction from non-food sunflower seeds, sunflower meats, and fine sunflower meats (seed de-hulling residue was carried out using a cold press method in this study. Characterization of the sunflower oils produced was performed. The effect of cold press rotary frequency on oil recovery and quality was discussed. The results show that higher oil recovery was obtained at lower rotary frequencies. The highest oil recovery for sunflower seeds, sunflower meats, and fine sunflower meats in the tests were 75.67%, 89.74% and 83.19% respectively. The cold press operating conditions had minor influence on the sunflower oil quality. Sunflower meat oils produced at 15 Hz were preliminarily upgraded and distilled. The properties of the upgraded sunflower oils were improved. Though further study is needed for the improvement of processing cost and oil recovery, cold press has shown promising to extract oil from non-food sunflower seeds for future bio-jet fuel production.

  7. Use of Plackett-Burman design for rapid screening of nitrogen and carbon sources for the production of lipase in solid state fermentation by Yarrowia lipolytica from mustard oil cake (Brassica napus

    Directory of Open Access Journals (Sweden)

    Sarat Babu Imandi

    2013-09-01

    Full Text Available Mustard oil cake (Brassica napus, the residue obtained after extraction of mustard oil from mustard oil seeds, was investigated for the production of lipase under solid state fermentation (SSF using the marine yeast Yarrowia lipolytica NCIM 3589. Process parameters such as incubation time, biomass concentration, initial moisture content, carbon source concentration and nitrogen source concentration of the medium were optimized. Screening of ten nitrogen and five carbon sources has been accomplished with the help of Plackett-Burman design. The highest lipase activity of 57.89 units per gram of dry fermented substrate (U/gds was observed with the substrate of mustard oil cake in four days of fermentation.

  8. Low-cost and eco-friendly synthesis of silver nanoparticles using coconut (Cocos nucifera) oil cake extract and its antibacterial activity.

    Science.gov (United States)

    Govarthanan, Muthusamy; Seo, Young-Seok; Lee, Kui-Jae; Jung, Ik-Boo; Ju, Ho-Jong; Kim, Jae Su; Cho, Min; Kamala-Kannan, Seralathan; Oh, Byung-Taek

    2016-12-01

    The present study reports the simple, inexpensive, eco-friendly synthesis of silver nanoparticles (AgNPs) using coconut oil cake extract. Scanning electron microscopy-energy dispersive spectroscopy peak at 3 keV confirmed the presence of silver. Transmission electron micrograph showed that nanoparticles are mostly circular with an average size of 10-70 nm. The results of the X-ray powder diffraction analysis (2θ = 46.2, 67.4 and 76.8) indicated the crystal nature of the AgNPs. Fourier transform infrared spectroscopy analysis indicates that proteins present in the oilcake extract could be responsible for the reduction of silver ions. The synthesized AgNPs (1-4 mm) reduced the growth rate of multi-antibiotic-resistant bacteria such as Aeromonas sp., Acinetobacter sp. and Citrobacter sp. isolated from livestock wastewater.

  9. [STUDY OF THE IMPACT OF WHEAT GERM CAKE OIL AND FLOUR ON INDICES OF ENERGY EXCHANGE IN STUDENTS AND TEACHERS OF HIGH SCHOOL].

    Science.gov (United States)

    Esaulenko, I E; Rodionova, N S; Popov, E S; Melikhova, E P; Khatuaev, R O

    2015-01-01

    There were obtained data which confirm the increase of efficiency of gas exchange processes in students and teachers of the engineering high school in the daily use of at least 3.5 g of wheat germ oil and 50 g of wheat germ cake flour without the correction of the basic ration. The study of the exhaled gas-air mixture showed in all age groups the gain in the concentration of carbon dioxide and the decline of concentration of oxygen by the 0.20-0.30%. There was established the increase of blood oxygenation level in all subjects. There was demonstrated the relationship between the depth of the alteration of these parameters with age, and regular physical activity in studied cases.

  10. Evaluation of Castor Oil Cake Starch and Recovered Glycerol and Development of “Green” Composites Based on Those with Plant Fibers

    Science.gov (United States)

    Guimarães, José Luis; Trindade Cursino, Ana Cristina; Ketzer Saul, Cyro; Sierrakowski, Maria Rita; Ramos, Luiz Pereira; Satyanarayana, Kestur Gundappa

    2016-01-01

    Continuous efforts are being made in some countries for the recovery of crude glycerin (RG/CG) and castor oil cake (COC), the two byproducts of biodiesel production. These are expected to help, not only in addressing environmental safety, but also in adding value to those byproducts, which otherwise may go to waste. Finding ways to utilize those byproducts underlines the main objective of this study. This paper presents the evaluation of (i) COC, glycerin and banana and sugarcane fibers for moisture content; (ii) COC for structural and thermal properties; and (iii) CG for its chemical characteristics. The possibility of using COC and CG with the selected fibers as reinforcement in the development of bio-composites is attempted through thermo-molding. Results revealed enhanced mechanical properties for these composites. The obtained results are discussed in terms of the observed morphology. PMID:28787878

  11. Optimized extraction of polyphenolic antioxidant compounds from Brazil nut (Bertholletia excelsa) cake and evaluation of the polyphenol profile by HPLC.

    Science.gov (United States)

    Gomes, Suellen; Torres, Alexandre G

    2016-06-01

    The solid residue (cake) of pressed Brazil nut oil has high energy value and contains high levels of nutrients and bioactive compounds, such as polyphenols. However, little is known about these components in this by-product. Extraction is the first step in investigating the phenolic compounds in Brazil nut cake because extraction conditions might impact the yields of phenolic compounds and antioxidant capacity. The aim of this study was to select the best phenolic compound extraction conditions for Brazil nut cake by using factorial experimental design and to characterize the phenolic compounds in the extract. The optimal extraction of antioxidant phenolic compounds from Brazil nut cake was achieved under the following conditions: ethanol-water (40:60; v/v); 2.5 min homogenization; and 1 h extraction at 60 °C. The phenolic compound profile of the Brazil nut cake extract using the optimized extraction was determined by high-performance liquid chromatography with photodiode array detection. Six phenolic acids (gallic acid, protocatechuic acid, 2,4-dihydroxybenzoic acid, p-hydroxybenzoic acid, p-coumaric acid and sinapic acid) and one flavonoid ((+)-catechin) were identified, and the contents of the phenolic compounds varied from 70.0 to 421 mg kg(-1) . Knowledge of the potential bioactivity of Brazil nut cake identified in the present study might promote its use in the food industry. © 2015 Society of Chemical Industry. © 2015 Society of Chemical Industry.

  12. Production, characterization and anticancer activity of Candida bombicola sophorolipids by means of solid state fermentation of sunflower oil cake and soybean oil

    Directory of Open Access Journals (Sweden)

    Rashad, M. M.

    2014-06-01

    Full Text Available The production of sophorolipids by Candida bombicola NRRL Y- 17069 grown in a mixture of sunflower oil cake and crude soybean oil as economic substrates with different fermentation techniques was studied. The highest yield (49.5 g·100 g−1 substrates was obtained from solid state fermentation after employing a new concept for extraction by methanol (E I followed by ethyl acetate (E II, then partially purified with hexane (E III. The course of time of fermentation was also studied, and E I extracted of the 12th day showed the minimum surface tension (45 mN·m−1 at a critical micelle dilution (CMD of 10% concentration. The produced sophorolipids were characterized and confirmed by FTIR and 1H NMR spectroscopy. The anticancer activity of the produced compounds was assessed against MCF-7, HepG2, A549, HCT116 cancer cell lines and the results revealed that E III and E IV (a mixture of E I & E III act as promising anticancer agents in HepG2 and A549 by inhibiting urokinase and histone deacetylase activities.Se estudió la producción de soforolípidos por Candida bombicola NRRL Y- 17069 cultiva con diferentes técnicas de fermentación en una mezcla de torta de girasol y aceite de soja crudo, como sustratos económicos. El rendimiento más alto (49,5 g·100 g−1 de sustrato se obtuvo por fermentación en estado sólido después de extraer con metanol (IE seguido de acetato de etilo (EII, y de purificación parcial con hexano (EIII. También se estudió el tiempo de fermentación, considerando que el extracto IE de 12 días mostró una tensión superficial mínima (45 mN·m−1 a una dilución micelar crítica (CMD de concentración 10 %. Los soforolípidos producidos se caracterizaron y se confirmaron mediante espectroscopia FTIR y RMN de 1H. La actividad anticancerígena de los compuestos producidos se evaluó en células MCF-7, HepG2, A549, líneas celulares de cáncer de HCT116 y los resultados revelaron que EIII y EIV (una mezcla de EI y EIII

  13. Irradiation effect on chemical components of oil palm empty fruit bunch and palm press fibre

    International Nuclear Information System (INIS)

    Zainon Othman; Mat Rasol Awang; Hassan Hamdani Mutaat; Tamikazu Kume; Hitoshi Ito; Shinpei Matsuhashi; Ishigaki, I.

    1998-01-01

    Physico-chemical properties of empty fruit bunch (EFB) and palm press fibre (PPF), which are major by-products of the oil palm industries, were studied for upgrading their utilisation as animal feed by radiation-fermentation process. Comparative analyses of raw EFB and PPF from 3 different mills showed significant variations in some of their chemical components. Significant differences were also observed between the chemical components of EFB and PPF samples. The water holding capacities (WHC) of both EFB and PPF suggested their suitability for use as fermentation media. Gamma irradiation of up to 50 kGy have little effect on the components of both EFB and PPF. Irradiation dose of 25 kGy appeared to produce enhancement effect on cellulase hydrolysis of holocellulose and alpha-cellulose of EFB but a retarding effect on hydrolysis of PPF

  14. Utilization of palm oil decanter cake as a novel substrate for biosurfactant production from a new and promising strain of Ochrobactrum anthropi 2/3.

    Science.gov (United States)

    Noparat, Pongsak; Maneerat, Suppasil; Saimmai, Atipan

    2014-03-01

    A biosurfactant-producing bacterium, isolate 2/3, was isolated from mangrove sediment in the south of Thailand. It was evaluated as a potential biosurfactant producer. The highest biosurfactant production (4.52 g/l) was obtained when the cells were grown on a minimal salt medium containing 25 % (v/v) palm oil decanter cake and 1 % (w/v) commercial monosodium glutamate as carbon and nitrogen sources, respectively. After microbial cultivation at 30 °C in an optimized medium for 96 h, the biosurfactant produced was found to reduce the surface tension of pure water to 25.0 mN/m with critical micelle concentrations of 8.0 mg/l. The stability of the biosurfactant at different salinities, pH and temperature and also its emulsifying activity was investigated. It is an effective surfactant at very low concentrations over a wide range of temperatures, pH and salt concentrations. The biosurfactant obtained was confirmed as a glycolipid type biosurfactant by using a biochemical test, fourier-transform infrared spectroscopy, MNR and mass spectrometry. The crude biosurfactant showed a broad spectrum of antimicrobial activity and also had the ability to emulsify oil and enhance polyaromatic hydrocarbons solubility.

  15. Quantitative analysis of γ–oryzanol content in cold pressed rice bran oil by TLC–image analysis method

    Directory of Open Access Journals (Sweden)

    Apirak Sakunpak

    2014-02-01

    Conclusions: The TLC-densitometric and TLC-image analysis methods provided a similar reproducibility, accuracy and selectivity for the quantitative determination of γ-oryzanol in cold pressed rice bran oil. A statistical comparison of the quantitative determinations of γ-oryzanol in samples did not show any statistically significant difference between TLC-densitometric and TLC-image analysis methods. As both methods were found to be equal, they therefore can be used for the determination of γ-oryzanol in cold pressed rice bran oil.

  16. Design and construction of a prototype for the continuous extraction of Sacha Inchi seed oil with a cold pressing process

    Directory of Open Access Journals (Sweden)

    Nelson Ramiro Gutiérrez Suquillo

    2017-03-01

    Full Text Available This work presents the design of an oil extractor from the Sacha Inchi seed with an extruder screw mechanism allows a maximum yield of 34% through a continuous cold extraction process at working temperatures below 45 ° C. The temperature is a critical parameter because when it exceeds 50 ° C, the oil decreases its nutritional value by the loss of its most important properties such as: Omega 3 (48%, Omega 6 (36%, Omega 9 (8%, digestibility (96%, vitamin A and E. The methodology used for the development of the work was the concurrent and simultaneous design according to the recommendations of National Instruments. The prototype consists of the extruder screw, pressure chamber, feed chamber, sieve and filter. The advantage of modular design is the flexibility it offers, so that when changing certain components it is possible to use the prototype to extract oil of different types and sizes of seeds. The products obtained from this mechanism are: 33.34% of oil and the solid residue known as Cake in 66.66% which has many applications in the field of human food and pets. Due to the processing of a food product, the requirements of ISO 22005 were applied for the design and implementation of the prototype.

  17. Some chemical properties of irradiated empty fruit bunch and palm press fiber of oil palm byproducts

    International Nuclear Information System (INIS)

    Matsuhashi, Shinpei; Kume, Tamikazu; Othman, Z.BT.; Awang, M.R.

    1992-01-01

    Effect of irradiation and alkali treatment for digestibility of oil palm by-products by commercial enzymes was investigated to obtain the informations about formation of carbohydrate polymers or sugar components for producing animal feed from cellulosic by-products. According to the colorimetric analysis, produced reducing sugar from holocellulose of Empty Fruit Bunch (EFB) and Palm Press Fiber (PPF) by Cellulase ONOZUKA 3S were about ten times higher than those from raw samples. The results show that the digestibility of EFB and PPF increased significantly by delignification. The differences of digestibility between irradiated and unirradiated samples were shown clearly by the combination of enzymatic degradation and the HPLC analysis. By irradiation, digestibility of EFB was significantly increased. Higher dose is more effective for the digestion of EFB by enzyme. Alkali treatment is also quite effective to enzymatic degradation. The difference of neutral sugar component was observed between alkali treated and untreated samples. These results suggest that the combination of alkali treatment and irradiation is effective for digestion by enzyme. The analysis of products by HPLC after enzymatic degradation is useful method to examine the digestibility and the sugar composition of oil palm by-products. (author)

  18. Apple Coffee Cake

    Science.gov (United States)

    ... this page: https://medlineplus.gov/recipe/applecoffeecake.html Apple Coffee Cake To use the sharing features on ... time: 50 minutes Number of Servings: 20 Tart apples and raisins make for a moist, delicious cake. ...

  19. In-situ Alkaline Transesterification of Jatropha Curcas Seed Oil for Production of Biodiesel and Nontoxic Jatropha Seed Cake

    OpenAIRE

    Nazir, Novizar; Mangunwidjaja, Djumali; Setyaningsih, Dwi; Yuliani, Sri; Yarmo, Mohd. Ambar; Salimon, Jumat; Ramli, Nazaruddin

    2014-01-01

    The production of fatty acid methyl ester (FAME) by direct in situ alkaline-catalyzed transesterification of the triglycerides (TG) in Jatropha curcas seeds was examined. The experimental results showed that the amount of Jatropha curcas seed oil dissolved in methanol was approximately 83% of the total oil and the conversion of this oil could achieve 98% under the following conditions: less than 2% moisture content in Jatropha curcas seed flours, 0.3–0.335 mm particle size, 0.08 mol/L NaOH co...

  20. Quantitative analysis of γ-oryzanol content in cold pressed rice bran oil by TLC-image analysis method.

    Science.gov (United States)

    Sakunpak, Apirak; Suksaeree, Jirapornchai; Monton, Chaowalit; Pathompak, Pathamaporn; Kraisintu, Krisana

    2014-02-01

    To develop and validate an image analysis method for quantitative analysis of γ-oryzanol in cold pressed rice bran oil. TLC-densitometric and TLC-image analysis methods were developed, validated, and used for quantitative analysis of γ-oryzanol in cold pressed rice bran oil. The results obtained by these two different quantification methods were compared by paired t-test. Both assays provided good linearity, accuracy, reproducibility and selectivity for determination of γ-oryzanol. The TLC-densitometric and TLC-image analysis methods provided a similar reproducibility, accuracy and selectivity for the quantitative determination of γ-oryzanol in cold pressed rice bran oil. A statistical comparison of the quantitative determinations of γ-oryzanol in samples did not show any statistically significant difference between TLC-densitometric and TLC-image analysis methods. As both methods were found to be equal, they therefore can be used for the determination of γ-oryzanol in cold pressed rice bran oil.

  1. Comparative review of the nutritional value of cold-pressed pumpkin (Cucurbita pepo L. seed oil of different origins

    Directory of Open Access Journals (Sweden)

    Rabrenovic Biljana B.

    2016-01-01

    Full Text Available The objective of this study was to investigate the nutritional value of seven samples of cold pressed a pumpkin oil of different origins and influence of seed origin on the content of the most important bioactive components. Four samples of a pumpkin oil is obtained by cold pressing of the seeds of domestic and Austrian varieties, and three samples of cold pressed oils were obtained from the seeds of unknown origin, taken by free choice in the market. As indicators of the nutritional values are determined by the composition and content of fatty acids, tocopherols and sterols. In the composition of the fatty acid were oleic dominant (34,2±0,09 - 43,9±0,04% and linolenic fatty acid (30,8±0,09 - 46,9±0,015%. This study confirmed that the oil pumpkin dominant ?+?-tocopherol, whose contents ranged from 34,65±0,03 to 44,59±0,69 mg/100g. We determine the composition and content of ?7 phytosterols, especially for specific oil pumpkins. Was detected five ?7 sterol: Spinasterol, ?7,22,25-stigmastatrienol, ?7,25-stigmastadienol, ?7-stigmasterol and ?7-avenasterol. Dominant its content was ?7,22-stigmastadienol or Spinasterol with 39,98 to 50,31% of the total content of sterols.

  2. Hypocholesterolemic impact of newly isolated sophorolipids produced by microbial conversion of safflower oil cake in rats fed high-fat and cholesterol diet

    International Nuclear Information System (INIS)

    Nooman, M.U.; Mahmoud, M.H.; Al-kashef, A.S.; Rashad, M. M.

    2017-01-01

    The present study aims to produce low cost sophorolipids, and to evaluate their potential hypocholesterolemic impact. Sophorolipids were produced by Candida bombicola grown on safflower oil cake, extracted by methanol followed by ethyl acetate with a yield of 24.4 and 48.3 g·100 g−1 mixed substrate, respectively. Their structure was confirmed by FTIR and 1H NMR and proven to be safe when subjected to an acute toxicity test. A biological experiment was done on 42 male albino rats classified into six groups for 4 weeks following an induction period for hypercholesterolemia of 8 weeks. The two extracts and their mixture were examined for their hypocholesterolemic effect compared to rosuvastatin. The results revealed a reduction in total cholesterol, low density lipoprotein cholesterol, atherogenic index, liver transaminases’ activity and malondialdehyde. They also revealed an elevation in high density lipoprotein cholesterol and antioxidant enzymes which was more efficient than rosuvastatin. Histopathological examination confirmed these results. In conclusion, the newly isolated sophorolipids are powerful hypocholesterolemic compounds which are even more efficient and safer than rosuvastatin. [es

  3. Hypocholesterolemic impact of newly isolated sophorolipids produced by microbial conversion of safflower oil cake in rats fed high-fat and cholesterol diet

    Directory of Open Access Journals (Sweden)

    M. U. Nooman

    2017-09-01

    Full Text Available The present study aims to produce low cost sophorolipids, and to evaluate their potential hypocholesterolemic impact. Sophorolipids were produced by Candida bombicola grown on safflower oil cake, extracted by methanol followed by ethyl acetate with a yield of 24.4 and 48.3 g·100 g-1 mixed substrate, respectively. Their structure was confirmed by FTIR and 1H NMR and proven to be safe when subjected to an acute toxicity test. A biological experiment was done on 42 male albino rats classified into six groups for 4 weeks following an induction period for hypercholesterolemia of 8 weeks. The two extracts and their mixture were examined for their hypocholesterolemic effect compared to rosuvastatin. The results revealed a reduction in total cholesterol, low density lipoprotein cholesterol, atherogenic index, liver transaminases’ activity and malondialdehyde. They also revealed an elevation in high density lipoprotein cholesterol and antioxidant enzymes which was more efficient than rosuvastatin. Histopathological examination confirmed these results. In conclusion, the newly isolated sophorolipids are powerful hypocholesterolemic compounds which are even more efficient and safer than rosuvastatin.

  4. Phytase production by solid-state fermentation of groundnut oil cake by Aspergillus niger: A bioprocess optimization study for animal feedstock applications.

    Science.gov (United States)

    Buddhiwant, Priyanka; Bhavsar, Kavita; Kumar, V Ravi; Khire, Jayant M

    2016-08-17

    This investigation deals with the use of agro-industrial waste, namely groundnut oil cake (GOC), for phytase production by the fungi Aspergillus niger NCIM 563. Plackett-Burman design (PBD) was used to evaluate the effect of 11 process variables and studies here showed that phytase production was significantly influenced by glucose, dextrin, distilled water, and MgSO4 · 7H2O. The use of response surface methodology (RSM) by Box-Behnken design (BBD) of experiments further enhanced the production by a remarkable 36.67-fold from the original finding of 15 IU/gds (grams of dry substrate) to 550 IU/gds. This is the highest solid-state fermentation (SSF) phytase production reported when compared to other microorganisms and in fact betters the best known by a factor of 2. Experiments carried out using dried fermented koji for phosphorus and mineral release and also thermal stability have shown the phytase to be as efficient as the liquid enzyme extract. Also, the enzyme, while exhibiting optimal activity under acidic conditions, was found to have significant activity in a broad range of pH values (1.5-6.5). The studies suggest the suitability of the koji supplemented with phytase produced in an SSF process by the "generally regarded as safe" (GRAS) microorganism A. niger as a cost-effective value-added livestock feed when compared to that obtained by submerged fermentation (SmF).

  5. Detailed characterization of bio-oil from pyrolysis of non-edible seed-cakes by Fourier Transform Infrared Spectroscopy (FTIR) and gas chromatography mass spectrometry (GC-MS) techniques.

    Science.gov (United States)

    Sugumaran, Vatsala; Prakash, Shanti; Ramu, Emmandi; Arora, Ajay Kumar; Bansal, Veena; Kagdiyal, Vivekanand; Saxena, Deepak

    2017-07-15

    Bio-oil obtained from pyrolysis is highly complicated mixture with valued chemicals. In order to reduce the complexity for unambiguous characterization of components present in bio-oil, solvent extractions using different solvents with increasing polarity have been adopted. The fractions have been analyzed by Fourier transform infrared (FTIR) spectroscopy for identifying the functional groups and Gas chromatography-mass spectrometry (GC-MS), for detailed characterization of components present in various fractions, thereby providing in-depth information at molecular level of various components in bio-oil. This paper reveals the potential of the analytical techniques in identification and brings out the similarities as well as differences in the components present in the bio-oil obtained from two non-edible oil seed-cakes, viz., Jatropha and Karanjia. Copyright © 2017 Elsevier B.V. All rights reserved.

  6. A Factorial Analysis Study on Enzymatic Hydrolysis of Fiber Pressed Oil Palm Frond for Bioethanol Production

    Science.gov (United States)

    Hashim, F. S.; Yussof, H. W.; Zahari, M. A. K. M.; Illias, R. M.; Rahman, R. A.

    2016-03-01

    Different technologies have been developed to for the conversion of lignocellulosic biomass to suitable fermentation substrates for bioethanol production. The enzymatic conversion of cellulose seems to be the most promising technology as it is highly specific and does not produce substantial amounts of unwanted byproducts. The effects of agitation speed, enzyme loading, temperature, pH and reaction time on the conversion of glucose from fiber pressed oil palm frond (FPOPF) for bioethanol production were screened by statistical analysis using response surface methodology (RSM). A half fraction two-level factorial analysis with five factors was selected for the experimental design to determine the best enzymatic conditions that produce maximum amount of glucose. FPOPF was pre-treated with alkaline prior to enzymatic hydrolysis. The enzymatic hydrolysis was performed using a commercial enzyme Cellic CTec2. From this study, the highest yield of glucose concentration was 9.736 g/L at 72 hours reaction time at 35 °C, pH 5.6, and 1.5% (w/v) of enzyme loading. The model obtained was significant with p-value model had a maximum point which is likely to be the optimum point and possible for the optimization process.

  7. Influence of Volume Deformation Rate on the Intensity of Oil-Bearing Crop Pressing-out in Relation to Rape Extrudate

    Science.gov (United States)

    Slavnov, E. V.; Petrov, I. A.

    2015-07-01

    The influence of the volume deformation rate on the intensity of piston pressing-out of oil has been investigated. The results of pressing by a piston moving with different speeds are presented. Mathematical simulation is carried out for the stage of pressing-out after the termination of sample loading, when oil release occurs due to the accumulated deformations of the skeleton. It has been assumed that in mechanical pressing there remains the least residual content of oil. A dimensionless complex representing the ratio of the characteristic times of loading to the material response (the process of pressing) has been obtained. The dependence of the rate of oil pressing-out at the stage of pressure relaxation on the dimensionless complex has been determined.

  8. Method of Determining the Filtration Properties of oil-Bearing Crops in the Process of Their Pressing by the Example of Rape-oil Extrusion

    Science.gov (United States)

    Slavnov, E. V.; Petrov, I. A.

    2014-07-01

    A method of determining the change in the fi ltration properties of oil-bearing crops in the process of their pressing by repeated dynamic loading is proposed. The use of this method is demonstrated by the example of rape-oil extrusion. It was established that the change in the mass concentration of the oil in a rape mix from 0.45 to 0.23 leads to a decrease in the permeability of the mix by 101.5-102 times depending on the pressure applied to it. It is shown that the dependence of the permeability of this mix on the pressure applied to it is nonmonotone in character.

  9. Sustainable Agriculture: enhancing the 'neem cake'

    International Nuclear Information System (INIS)

    Mariani, Susanna

    2015-01-01

    The 'neem cake' is the scrap processing of the industrial chain producing neem oil and azadirachtin. The ENEA Technical Unit Environment and Sustainable Development Innovation the Agro-Industrial System, developed a promising experiment to promote the use of 'neem cake' as an insecticide, and fertilizer of low cost in sustainable agriculture. [it

  10. Physicochemical characterization and quality of cold-pressed peanut oil obtained from organically produced peanuts from Macedonian Virginia” variety

    Energy Technology Data Exchange (ETDEWEB)

    Kostadinovic Velickovska, S.; Mitrev, S.; Mihajlov, L.

    2016-07-01

    The physicochemical characterization and quality of cold pressed peanut edible oil from the “Virginia” variety, organically produced from the region of Macedonia, were examined in this work for the first time. The fatty acid composition of the oil showed almost equal levels of oleic and linoleic acids with an abundance of 34.19±0.01 and 36.13±0.01%, respectively. The most dominant saturated fatty acid was palmitic acid with a level of 10.06±0.00%. The level of tocopherols and other vitamin-E-related compounds was in strong agreement with the antioxidant activity of the oils measured by the DPPH assay. Almost equal amounts of α and γ tocopherols indicated an antioxidant potential of 288.63±59.78 mg·L−1 α-tocopherol. Phytosterols, as minor compounds present in the oils, can be additional antioxidants responsible for the health benefits of this oil in human nutrition. The four major pytosterols were β-sitosterol (1812.21±22.17 mg·kg−1 oil), champesterol (320.55±17.07 mg·kg−1 oil), Δ5-avenasterol (236.16±14.18 mg·kg−1) and stigmasterol (133.12±12.51 mg·kg−1 oil). Induction time, Peroxide number, FFA and specific extinction (K232 and K270, values 1.82 and 0.22) gave us an indication of the oxidative stability of cold pressed peanut oil. (Author)

  11. A Simplified Model of an Offset Ram Press for Sunflower Oil ...

    African Journals Online (AJOL)

    This paper presents the theoretical analysis of a simplified model of a ram press. The design of the ram press is based on the classical slider-crank mechanism. A force analysis of the press was performed for several successive positions of the driving lever (handle) and for a range of values of certain dimensionless ...

  12. Physical, chemical and microbiological properties of mixed hydrogenated palm kernel oil and cold-pressed rice bran oil as ingredients in non-dairy creamer

    Directory of Open Access Journals (Sweden)

    Kunakorn Katsri

    2014-02-01

    Full Text Available The physical, chemical and microbiological properties of hydrogenated palm kernel oil (PKO and cold-pressed rice bran oil (RBOas ingredients in the production of liquid and powdered non-dairy creamer (coffee whitener were studied. The mixing ratios between hydrogenated PKO and cold-pressed RBO were statistically designed as of 100:0, 90:10,80:20, 70:30, 60:40, 50:50, 40:60, 30:70, 20:80, 10:90 and 0:100.The color, absorbanceand viscosity of the mixtures were investigated. As the ratio of cold-pressed RBO increased, the color became darker (L*of 93.06 to 86.25 and the absorbance significantly increased, while the viscosity of the mixtures of 20:80, 10:90 and 0:100 (54 cp. were the highest amongst the ratios tested.The hydrogenated PKO and cold-pressed RBO mixtures were further chemically tested for fatty acids, -oryzanol, -tocopherol, trans-fat contents andantioxidant activity. There were 10 fatty acids present in hydrogenated PKO with saturated fatty acid being the most predominant. Comparatively, there were only 5 fatty acids found in cold-pressed RBO with monounsaturated fatty acid being the major fatty acid. -Oryzanol and -tocopherol contents were higher with increasingcold-pressed RBO from 0-100% (0 to 1,155.00 mg/100g oil and 0.09 to 30.82 mg/100g oil, respectively. Antioxidant activity was increased with increasing cold-pressed RBO from 0-100% (9.26 to 94.24%.The pure hydrogenated PKO contained higher trans-fat content than that of the 90:10 and 80:20 mixtures (2.73, 1.93 and 1.85mg/100g oil,respectively while other samples had no trans-fat. No microorganisms were present in any of the samples.Therefore, substitution of hydrogenated PKO by cold-pressed RBO from 30-100% would offer more nutritional values and better chemical and physical properties of non-dairy creamer.

  13. Development and Evaluation of Oil-based Mud Cake Removal Liquid System%油基泥饼解除液体系研制及性能评价

    Institute of Scientific and Technical Information of China (English)

    许定达; 熊邦泰; 王卫平; 潘蕾茗; 万刚; 赵林

    2016-01-01

    针对东海油田钻井过程中油基钻井液在井壁和筛管上形成的泥饼难以清除等复杂问题,室内经过有机溶剂、有机酸、增溶剂等处理剂优化筛选,研制出一套油基泥饼解除液体系,其配方为:55%5#白油+45%增溶剂 HZRJ+5.5%有机酸 HTS+5%有机溶剂 RJ;通过 API 滤失实验、配伍性实验、渗透率恢复值实验对体系迚行了性能评价,结果表明该体系具有良好的泥饼解除效果和较强的储层保护能力,且与钻井液及储层岩石、原油具有较好的配伍性。%To solve the problem that mud cake formed on the wellbore wall and the creen pipe during drilling with oil-based drilling fluid in the East China Sea Oilfield was difficultly removed, organic solvents, acids and solubilizing agents were screened, a set of oil-based mud cake removal fluid system was developed, the formula was as follows:55% 5 # white oil + 45% solubilizer HZRJ + 5.5% organic HTS + 5% organic solvent RJ; Its performance evaluation was carried out by API filtration test, compatibility test, permeability recovery experiment. The evaluation results show that the system has good mud cake removal effect and strong reservoir protection, and good compatibility with the drilling fluid, reservoir rock and crude oil.

  14. Enzymatic Hydrolysis of Pretreated Fibre Pressed Oil Palm Frond by using Sacchariseb C6

    Science.gov (United States)

    Hashim, F. S.; Yussof, H. W.; Zahari, M. A. K. M.; Rahman, R. A.; Illias, R. M.

    2017-06-01

    Enzymatic hydrolysis becomes a prominent technology for conversion of cellulosic biomass to its glucose monomers that requires an action of cellulolytic enzymes in a sequential and synergistic manner. In this study, the effect of agitation speed, glucan loading, enzyme loading, temperature and reaction time on the production of glucose from fibre pressed oil palm frond (FPOPF) during enzymatic hydrolysis was screened by a half factorial design 25-1 using Response Surface Methodology (RSM). The FPOPF sample was first delignified by alkaline pretreatment at 4.42 (w/v) sodium hydroxide for an hour prior to enzymatic hydrolysis using commercial cellulase enzyme, Sacchariseb C6. The effect of enzymatic hydrolysis on the structural of FPOPF has been evaluated by Scanning Electron Microscopy (SEM) analysis. Characterization of raw FPOPF comprised of 4.5 extractives, 40.7 glucan, 26.1 xylan, 26.2 lignin and 1.8 ash, whereas for pretreated FPOPF gave 0.3 extractives, 61.4 glucan, 20.4 xylan, 13.3 lignin and 1.3 ash. From this study, it was found that the best enzymatic hydrolysis condition yielded 33.01 ± 0.73 g/L of glucose when performed at 200 rpm of agitation speed, 60 FPU/mL of enzyme loading, 4 (w/w) of glucan loading, temperature at 55 □ and 72 hours of reaction time. The model obtained was significant with p-value enzymatic hydrolysis from pretreated FPOPF produce high amount of glucose that enhances it potential for industrial application. This glucose can be further used to produce high-value products.

  15. Polyphenolic Compounds and Antioxidant Activity of Cold-Pressed Seed Oil from Finola Cultivar of Cannabis sativa L.

    Science.gov (United States)

    Smeriglio, Antonella; Galati, Enza M; Monforte, Maria T; Lanuzza, Francesco; D'Angelo, Valeria; Circosta, Clara

    2016-08-01

    The aim of this study was to characterize the polyphenolic compounds and antioxidant activity of cold-pressed seed oil from Finola cultivar of industrial hemp (Cannabis sativa L.). Several methodologies have been employed to evaluate the in vitro antioxidant activity of Finola hempseed oil (FHSO) and both lipophilic (LF) and hydrophilic fractions (HF). The qualitative and quantitative composition of the phenolic fraction of FHSO was performed by HPLC analyses. From the results is evident that FHSO has high antioxidative activity, as measured by DPPH radical (146.76 mmol of TE/100 g oil), inhibited β-carotene bleaching, quenched a chemically generated peroxyl radical in vitro and showed high ferrous ion chelating activity. Reactivity towards 2,2'-azino-bis (3-ethylbenzothiazoline-6-sulfonic acid) radical cation and ferric-reducing antioxidant power values were 695.2 µmol of TE/100g oil and 3690.6 µmol of TE/100 g oil respectively. FHSO contains a significant amount of phenolic compounds of which 2780.4 mg of quercetin equivalent/100 g of total flavonoids. The whole oil showed higher antioxidant activity compared with LF and HF. Our findings indicate that the significant antioxidant properties shown from Finola seed oil might generally depend on the phenolic compounds, especially flavonoids, such as flavanones, flavonols, flavanols and isoflavones. Copyright © 2016 John Wiley & Sons, Ltd. Copyright © 2016 John Wiley & Sons, Ltd.

  16. PHYSICOCHEMICAL CHARACTERISTICS, PESTICIDE RESIDUE AND AFLATOXIN CONTAMINATION OF COLD PRESSED PUMPKIN SEED (Cucurbita pepo L. OILS FROM CENTRAL ANATOLIA REGION OF TURKEY

    Directory of Open Access Journals (Sweden)

    FATMA NUR ARSLAN

    2017-06-01

    Full Text Available In this study, physicochemical characteristics, pesticide residues and aflatoxin contaminations of cold pressed pumpkin seed (Cucurbita pepo L. oils cultivated in four different central Anatolia regions of Turkey, were investigated. Lab-scale screw press machine was used to produce cold pressed pumpkin seed oils and the oil contents were found between 42.8%−47.4% for naked seeds. The physicochemical characteristic (refractive index, viscosity, color value, triglyceride profile analysis, peroxide value, iodine value, free fatty acid, saponification number, unsaponified matter, specific extinction values at 232 and 270 nm of cold pressed oils were determined by using different analytical techniques. The results showed that there was a non-significant difference between cold pressed pumpkin seed oils from different regions, in terms of physicochemical characteristics. The contents of pesticide residue and aflatoxin B1, B2, G1 and G2 contamination were determined by using validated UHPLC-MS/MS method. The chlorpyrifos pesticide residue was detected under the limit value declared by official authorities for the quality assessment of edible oils. Aflatoxins weren’t detected in any of studied pumpkin seed oils. Therefore, in food industry the positive effect of screw-pressing application could be useful for preservation of bioactive compounds during edible oil production and also enhancing of their functional properties.

  17. Microbial inhibitory and radical scavenging activities of cold-pressed terpeneless Valencia orange (Citrus sinensis) oil in different dispersing agents.

    Science.gov (United States)

    Chalova, Vesela I; Crandall, Philip G; Ricke, Steven C

    2010-04-15

    Due to their low solubility in water, oil-based bioactive compounds require dispersion in a surface-active agent or appropriate solvents to ensure maximum contact with microorganisms. These combinations, however, may change their physical and/or chemical characteristics and consequently alter the desired functionality. The objective of this study was to determine the impact of selected dispersing agents, ethanol, dimethyl sulfoxide (DMSO), and Tween-80, on cold-pressed terpeneless (CPT) Valencia orange oil to function as a free radical scavenger and an antimicrobial food additive. When dissolved in ethanol or DMSO, the orange oil fraction had similar minimum inhibitory concentrations (MIC) for Listeria monocytogenes ATCC 19 115 (0.3% and 0.25% v/v respectively), which were significantly lower (P orange oil (up to 3%) in an aqueous solution of 0.1% Tween-80 yielded no inhibitory activities against any of the test bacteria. However, the 1% natural orange oil dispersed in Tween-80 exhibited 56.86% 2,2-diphenyl-1-picryl hydrazyl (DPPH) radical inhibition versus 18.37% and 16.60% when the same level of orange oil was dissolved in DMSO or ethanol, respectively. At the same orange oil concentration, the oil/Tween-80 suspension yielded 57.92% neutralization of hydroxyl radicals. This represents 71.37% of the mannitol antioxidant activity, which was used as a positive control. These findings suggest that Tween-80 is an appropriate dispersing agent only if the antioxidant functionality is desired. If both antimicrobial and antioxidant properties are needed, the CPT Valencia orange oil should be dispersed in either DMSO or ethanol. (c) 2010 Society of Chemical Industry.

  18. Basic Cake Decorating Workbook.

    Science.gov (United States)

    Bogdany, Mel

    Included in this student workbook for basic cake decorating are the following: (1) Drawings of steps in a basic way to ice a layer cake, how to make a paper cone, various sizes of flower nails, various sizes and types of tin pastry tubes, and special rose tubes; (2) recipes for basic decorating icings (buttercream, rose paste, and royal icing);…

  19. Simultaneous Cake Cutting

    DEFF Research Database (Denmark)

    Balkanski, Eric; Branzei, Simina; Kurokawa, David

    2014-01-01

    We introduce the simultaneous model for cake cutting (the fair allocation of a divisible good), in which agents simultaneously send messages containing a sketch of their preferences over the cake. We show that this model enables the computation of divisions that satisfy proportionality — a popular...

  20. Filter cake breaker systems

    Energy Technology Data Exchange (ETDEWEB)

    Garcia, Marcelo H.F. [Poland Quimica Ltda., Duque de Caxias, RJ (Brazil)

    2004-07-01

    Drilling fluids filter cakes are based on a combination of properly graded dispersed particles and polysaccharide polymers. High efficiency filter cakes are formed by these combination , and their formation on wellbore walls during the drilling process has, among other roles, the task of protecting the formation from instantaneous or accumulative invasion of drilling fluid filtrate, granting stability to well and production zones. Filter cake minimizes contact between drilling fluid filtrate and water, hydrocarbons and clay existent in formations. The uniform removal of the filter cake from the entire interval is a critical factor of the completion process. The main methods used to breaking filter cake are classified into two groups, external or internal, according to their removal mechanism. The aim of this work is the presentation of these mechanisms as well their efficiency. (author)

  1. Effect of extruded wheat flour as a fat replacer on batter characteristics and cake quality.

    Science.gov (United States)

    Román, Laura; Santos, Isabel; Martínez, Mario M; Gómez, Manuel

    2015-12-01

    The effects of three levels of fat replacement (1/3, 2/3, and 3/3) by extruded flour paste and the effects of the presence of emulsifier on layer cake batter characteristics and final cake quality were studied. Replacement of oil by extruded flour paste modified the batter density and microscopy, reducing the number of air bubbles and increasing their size, while emulsifier incorporation facilitated air entrapment in batter. Emulsifier addition also increased the elastic and viscous moduli of the batter, while oil reduction resulted in a less structured batter. Emulsifier incorporation leads to good quality cakes, minimizing the negative effect of oil reduction, maintaining the volume and reducing the hardness of cakes. Furthermore, consumer acceptability of the reduced fat cakes was improved by the addition of emulsifier. Thus, the results confirmed the positive effect of partial oil substitution (up to 2/3) by extruded flour paste on the quality of reduced fat cakes when emulsifier was incorporated.

  2. Chemical composition and oxidative stability of jussara (Euterpe edulis M.) oil extracted by cold and hot mechanical pressing; Composición química y estabilidad oxidativa del aceite de jussara (Euterpe edulis M.) extraído mediante prensado mecánico en frío y en caliente

    Energy Technology Data Exchange (ETDEWEB)

    Da Cunha, A.L.A.; Freitas, S.P.; Godoy, R.L.O.; Cabral, L.M.C.; Tonon, R.V.

    2017-07-01

    The aim of this work was to evaluate the effect of mechanical pressing on jussara oil yield, oxidative stability and carotenoid profile with or without heat application. Firstly, jussara pulp was centrifuged for juice extraction, and the resulting cake was dried until reaching 10% moisture content. Then, oil extraction was performed in an expeller press at 25 ºC (cold pressing) and at 50 ºC (hot pressing). The process performance was evaluated by the oil yield, and the crude jussara oil was characterized for fatty acid composition, acid value, carotenoid profile and oxidative stability. Jussara oil contained 74% unsaturated fatty acids, mainly oleic and linoleic acids (48% and 24%, respectively). The oil yield was almost twice as high for the hot process as compared to the cold one. Additionally, hot pressing resulted in 25% higher total carotenoid content as compared to cold pressing, with β-carotene as the most abundant one. Hot and cold pressing showed no difference in oil oxidative stability and fatty acid composition. [Spanish] El objetivo de este estudio fue evaluar el efecto del calor sobre el rendimiento del aceite, la estabilidad oxidativa y el perfil de carotenoides del aceite de Jussara extraído por prensado mecánico. En primer lugar, se centrifugó la pulpa de jussara para la extracción del zumo, y la torta resultante se secó para alcanzar el contenido de humedad de 10%. Posteriormente, la extracción del aceite se realizó en una prensa a 25 °C (prensado en frío) y a 50 °C (prensado en caliente). El desarrollo del proceso fue evaluado mediante el rendimiento de aceite y en bruto y éste se caracterizó mediante la composición en ácidos grasos, índice de acidez, perfil de carotenoides y la estabilidad oxidativa. El aceite de jussara presentó un 74% de ácidos grasos insaturados, principalmente ácidos oleico y linoleico (48% y 24%, respectivamente). El rendimiento del aceite para el proceso en caliente fue casi el doble, en comparaci

  3. Recovery potential of cold press byproducts obtained from the edible oil industry: physicochemical, bioactive, and antimicrobial properties.

    Science.gov (United States)

    Karaman, Safa; Karasu, Salih; Tornuk, Fatih; Toker, Omer Said; Geçgel, Ümit; Sagdic, Osman; Ozcan, Nihat; Gül, Osman

    2015-03-04

    Physicochemical, bioactive, and antimicrobial properties of different cold press edible oil byproducts (almond (AOB), walnut (WOB), pomegranate (POB), and grape (GOB)) were investigated. Oil, protein, and crude fiber content of the byproducts were found between 4.82 and 12.57%, between 9.38 and 49.05%, and between 5.87 and 45.83%, respectively. GOB had very high crude fiber content; therefore, it may have potential for use as a new dietary fiber source in the food industry. As GOB, POB, and WOB oils were rich in polyunsaturated fatty acids, AOB was rich in monounsaturated fatty acids. Oil byproducts were also found to be rich in dietary mineral contents, especially potassium, calcium, phosphorus, and magnesium. WOB had highest total phenolic (802 ppm), flavonoid (216 ppm), and total hydrolyzed tannin (2185 ppm) contents among the other byproducts. Volatile compounds of all the byproducts are mainly composed of terpenes in concentration of approximately 95%. Limonene was the dominant volatile compound in all of the byproducts. Almond and pomegranate byproduct extracts showed antibacterial activity depending on their concentration, whereas those of walnut and grape byproducts showed no antibacterial activity against any pathogenic bacteria tested. According to the results of the present study, walnut, almond, pomegranate, and grape seed oil byproducts possess valuable properties that can be taken into consideration for improvement of nutritional and functional properties of many food products.

  4. Effects of seed preparation and oil pressing on milkweed (Asclepias spp.) protein functional properties

    Science.gov (United States)

    The effects of seed cooking and oil processing conditions on functional properties of milkweed seed proteins were determined to identify potential value-added uses for the meal. Milkweed seeds were flaked and then cooked in the seed conditioner at 82°C for 30, 60 or 90 min. Oil was extracted by scre...

  5. Studies on the effects of storage stability of bio-oil obtained from pyrolysis of Calophyllum inophyllum deoiled seed cake on the performance and emission characteristics of a direct-injection diesel engine.

    Science.gov (United States)

    Rajamohan, Sakthivel; Kasimani, Ramesh

    2018-04-19

    The highly unbalanced nature of bio-oil composition poses a serious threat in terms of storage and utilization of bio-oil as a viable fuel in engines. So it becomes inevitable to study the variations in physicochemical properties of the bio-oil during storage to value its chemical instability, for designing stabilization methodologies. The present study aims to investigate the effects of storage stability of bio-oil extracted from pyrolyzing Calophyllum inophyllum (CI) deoiled seed cake on the engine operating characteristics. The bio-oil is produced in a fixed bed reactor at 500 °C under the constant heating rate of 30 °C/min. All the stability analysis methods involve an accelerated aging procedure based on standards established by ASTM (D5304 and E2009) and European standard (EN 14112). Gas chromatography-mass spectrometry was employed to analytically characterize the unaged and aged bio-oil samples. The results clearly depict that stabilizing Calophyllum inophyllum bio-oil with 10% (w/w) methanol improved its stability than that of the unstabilized sample thereby reducing the aging rate of bio-oil to 0.04 and 0.13 cst/h for thermal and oxidative aging respectively. Engine testing of the bio-oil sample revealed that aged bio-oil samples deteriorated engine performance and increased emission levels at the exhaust. The oxidatively aged sample showed the lowest BTE (24.41%), the highest BSEC (20.14 MJ/kWh), CO (1.51%), HC (132 ppm), NOx (1098 ppm) and smoke opacity (34.8%).

  6. Enzyme-aided cold pressing of flaxseed (Linum usitatissimum L.: Enhancement in yield, quality and phenolics of the oil

    Directory of Open Access Journals (Sweden)

    Anwar, F.

    2013-12-01

    Full Text Available The effect of different enzyme preparations (Viscozyme L, Kemzyme, and Feedzyme on the yield and physicochemical and antioxidant properties of cold pressed flaxseed oil were assessed. The oil yield (35.2-38.0% from enzyme-treated cold pressed flaxseeds (ETCPF, although lower than Soxhlet extracted oil (SEO yield, was considerably higher when compared with the control (32.5% while the contents of protein, fiber, and ash were unaffected by the enzymatic treatment. Most of the physicochemical parameters such as refractive index, density, iodine number, free fatty acid contents, saponification value, color and fatty acid profile did not vary significantly among the ETCPF oil, SEO and the control. Interestingly, the oxidation status in terms of peroxide value, para-anisidine value, conjugated dienes and triens and induction period (Rancimat method as well as the sensory score of the ETCPF oil were superior compared with the control. An appreciably higher amount of tocopherols (350-400 mg kg–1 was determined in the ETCPF oil, compared to the control (270 mg kg–1, showing an increase of 22.8-32.5% in the recovery of total tocopherols. Moreover, ETCPF oil exhibited greater antioxidant activity as well as total phenolics and individual phenolic acid content. This study advocates the exploration of enzyme-assisted cold pressing as a viable alternative to conventional cold-pressing for improving not only the extraction yield but also the functional food quality of flaxseed-like high-value oils.Se evalúa el efecto de diferentes preparaciones enzimáticas (Viscozyme L, Kemzyme y Feedzyme sobre el rendimiento y propiedades fisicoquímicas y antioxidantes de aceites de lino prensados en frío. El rendimiento en aceite (35,2-38,0% de las semillas de lino prensadas en frío (ETCPF, y tratadas con enzimas, aunque menor que el rendimiento mediante Soxhlet (SEO, fue considerablemente mayor en comparación con el control (32,5%, mientras que el contenido de

  7. Physicochemical studies on sunflower oil blended with cold pressed tiger nut oil during the deep frying process; Estudios fisicoquimicos sobre mezclas de aceite de girasol con aceite de chufa prensado en frio durante el proceso de fritura

    Energy Technology Data Exchange (ETDEWEB)

    Al Rehah, F. M.; Anany, A. M.

    2012-07-01

    Sunflower oils were blended with different levels of cold pressed tiger nut oil. Blended oils were obtained by mixing tiger nut oil with sunflower oil at the volume ratios of 0:100, 10: 90, 20: 80, 30: 70, 40: 60, 50:50 and 100: 0. The effects of deep frying on physico-chemical parameters (Free Fatty Acid (FFA), Peroxide Value (PV), thiobarbituric acid value (TBA), iodine value, Total Polar Compounds (TPC), color and viscosity) were evaluated over 30 hours of the frying process. The total phenolic content of native oils was determined. GLC analysis was performed to illustrate the fatty acid composition of sunflower oil, tiger nut oil and binary mixtures of them as well as their oxidation rates. The pure and blended oils were heated at 180 degree centigrade {+-} 5 degree centigrade, then frozen French fried potatoes were fried every 30 min. Oil samples were taken every 5 h and the entire continuous frying period was 30 h. The results showed that fresh sunflower oil had significantly the highest value of COX (7.25); while tiger nut oil had significantly the lowest (2.24). Mixing sunflower oil with different levels of tiger nut oil led to an increase in its stability against oxidation. The phenolic content of cold pressed tiger nut oil was about 3.3 times as high as that of sunflower oil. The analytical data showed that the lowest deterioration during the frying process occurred in tiger nut oil and the highest in sunflower. The changes in the physico-chemical parameters were controlled and significantly (P < 0.05) decreased when tiger nut /sunflower oil (W/W) proportions were varied between 20/80 to 50/50. The obtained results indicate that mixing sunflower oil with cold pressed tiger nut oil increased the stability and hence improved the quality of sunflower oil during the frying process. (Author) 68 refs.

  8. Characterization of sunflower oils obtained separately by pressing and subsequent solvent extraction from a new line of seeds rich in phytosterols and conventional seeds

    Directory of Open Access Journals (Sweden)

    Aguirre Marta R.

    2014-11-01

    Full Text Available In this study we evaluate the chemical composition of sunflower oils obtained separately by pressing and subsequent solvent extraction from a new seeds rich in phytosterols (IASP-18 and conventional seeds (HA-89. Results have shown that the total content of oil was much lower in the IASP-18 (18.1% than in the conventional (37.5% seeds. The extraction yield obtained by pressing was as low as 3% in the IASP-18 seeds and 37.5% in HA-89, while in the solvent extraction it was of the same order (~18 wt% on seeds extracted by pressing for the two types of seeds. No significant changes in the fatty acid composition were found between the oils extracted by the two procedures, but the pressed oils presented significantly lower acidity and larger content of the unsaponifiable fraction. Expressed as free sterols, the total sterols were 37–38% more concentrated in the oils extracted with solvent, reaching amounts of 13 700 and 6500 mg/kg in the IASP-18 and HA-89 oils, respectively. No substantial differences were found in the composition of total sterols analysed as free sterols between the oils extracted with the two procedures, but the contents of free sterols and sterol glycosides were much higher in the oils extracted with solvent.

  9. Preparation and properties of binderless boards from Jatropha curcas L. seed cake

    NARCIS (Netherlands)

    Hidayat, H.; Keijsers, E.R.P.; Prijanto, U.; Dam, J.E.G. van; Heeres, H.J.

    The potential of Jatropha curcas L. seed cake after oil extraction (expelling of seeds followed by hexane extraction) as a raw material for binderless boards was investigated. The composition of the de-oiled seed cake was investigated using a range of techniques (proximate-, ultimate analyses,

  10. Preparation and properties of binderless boards from Jatropha curcas L. seed cake

    NARCIS (Netherlands)

    Hidayat, H.; Keijsers, E.R.P.; Prijanto, U.; Dam, van J.E.G.; Heeres, H.J.

    2014-01-01

    The potential of Jatropha curcas L. seed cake after oil extraction (expelling of seeds followed by hexane extraction) as a raw material for binderless boards was investigated. The composition of the de-oiled seed cake was investigated using a range of techniques (proximate-, ultimate analyses,

  11. Let them eat cake!

    OpenAIRE

    Samson, Audrey; Gallardo, Francisco; FRAUD, -

    2017-01-01

    Let them eat cake!' is a food-led event serving an edible imaginary of a Facebook profile. In early 2012, Facebook conducted massive scale emotional contagion by manipulating the emotional expressions in the News Feeds of 689,003 users. This exemplifies how the governability and the biopolitics of everyday life flow through the many layers of shared images, liked videos, protocols, and hyperlinks, all orchestrated by the Facebook News Feed algorithm. 'Let them eat cake!' proposes a gustatory ...

  12. Avocado oil extraction processes: method for cold-pressed high-quality edible oil production versus traditional production

    OpenAIRE

    Giacomo Costagli; Matteo Betti

    2015-01-01

    Nowadays the avocado fruit (Persea americana Mill.) is widely regarded as an important fruit for its nutritional values, as it is rich in vital human nutrients. The avocado fruit is mainly sold fresh on the market, which however trades also a relevant quantity of second-grade fruits with a relatively high oil content. Traditionally, this oil is extracted from dried fruits by means of organic solvents, but a mechanical method is also used in general in locations where drying systems and/or sol...

  13. Effect of dietary treatment with olive oil by-product (olive cake on physico-chemical, sensory and microbial characteristics of beef during storage

    Directory of Open Access Journals (Sweden)

    Raffaella Branciari

    2015-12-01

    Full Text Available Several studies have demonstrated that the use of natural preservatives through animal diets could increase the shelf life of meat and meat products since many plant-derived substances show antioxidant and antimicrobial properties. The aim of this work was to study the effect of olive cake dietary supplementation on beef oxidative stability and antimicrobial activity during storage. Beef cattle were randomly divided into three homogeneous groups that were assigned to one of the three diets: a commercial unified based diet administered for 90 days until slaughter (CTR, CTR diet supplemented with 0.5% olive cake administered for 90 days until slaughter (OC1, and CTR diet supplemented with 0.5% olive cake and administered for 60 days followed by the administration of the CTR diet for 30 days until slaughter (OC2. Beefsteaks were overwrapped with oxygen-permeable packaging and analysed at four different storage times (zero, three, six and nine days. At the four sampling times considered from all of the samples, total viable count (TVC, Enterobacteriaceae counts, colour coordinates (CIE L*a*b* colour system, peroxide value (PV, thiobarbituric reactive substances (TBARS determinations and descriptive sensory analyses were performed. No differences in TVC and Enterobacteriaceae count were detected among the groups over all of the sampling times considered. Differences were recorder among groups for PV, TBARS, colour and sensory analysis. The addition of olive cake in the animal diet had an effect on lipid oxidation reducing the level of PV, TBARS and retarding colour deterioration and the development of off odour in OC meat during storage.

  14. Value-added potential of expeller-pressed canola oil refining: characterization of sinapic acid derivatives and tocopherols from byproducts.

    Science.gov (United States)

    Chen, Yougui; Thiyam-Hollander, Usha; Barthet, Veronique J; Aachary, Ayyappan A

    2014-10-08

    Valuable phenolic antioxidants are lost during oil refining, but evaluation of their occurrence in refining byproducts is lacking. Rapeseed and canola oil are both rich sources of sinapic acid derivatives and tocopherols. The retention and loss of sinapic acid derivatives and tocopherols in commercially produced expeller-pressed canola oils subjected to various refining steps and the respective byproducts were investigated. Loss of canolol (3) and tocopherols were observed during bleaching (84.9%) and deodorization (37.6%), respectively. Sinapic acid (2) (42.9 μg/g), sinapine (1) (199 μg/g), and canolol (344 μg/g) were found in the refining byproducts, namely, soap stock, spent bleaching clay, and wash water, for the first time. Tocopherols (3.75 mg/g) and other nonidentified phenolic compounds (2.7 mg sinapic acid equivalent/g) were found in deodistillates, a byproduct of deodorization. DPPH radical scavenging confirmed the antioxidant potential of the byproducts. This study confirms the value-added potential of byproducts of refining as sources of endogenous phenolics.

  15. Analytical characterization of products obtained from slow pyrolysis of Calophyllum inophyllum seed cake: study on performance and emission characteristics of direct injection diesel engine fuelled with bio-oil blends.

    Science.gov (United States)

    Rajamohan, Sakthivel; Kasimani, Ramesh

    2018-04-01

    This paper aims to analyse the characteristics and properties of the fractions obtained from slow pyrolysis of non-edible seed cake of Calophyllum inophyllum (CI). The gas, bio-oil and biochar obtained from the pyrolysis carried out at 500 °C in a fixed bed batch type reactor at a heating rate of 30 °C/min were characterized by various analytical techniques. Owing to the high volatile content of CI biomass (72.61%), it was selected as the raw material in this present investigation. GC-MS and FT-IR analysis of bio-oil showed the presence of higher amount of oxygenated compounds, phenol derivatives, esters, acid and furans. The physicochemical properties of the bio-oil were tested as per ASTM norms which imply that bio-oil is a highly viscous liquid with lower heating value as compared to that of diesel fuel. The chemical composition of evolved gas was analysed by using GC testing which revealed the presence of combustible components. The FT-IR characterization of biochar showed the presence of aliphatic and aromatic hydrocarbons whereas the elevated amount of carbon in biochar indicates its potential to be used as solid fuel. The performance and emission characteristics of CI engine were assessed with different CI bio-oil blends and compared with baseline diesel fuel. The results showed that addition of bio-oil leads to decreased brake thermal efficiency and increased brake specific energy consumption. Meanwhile, increase in blend ratio reduces harmful pollutants such as oxides of nitrogen and smoke in the exhaust. From the engine testing, it is suggested to employ 20% of CI bio-oil blends in CI engine to obtain better operation.

  16. Physical and mechanical properties of parallel strand lumber made from hot pre-pressed long strand oil palm trunk waste

    Science.gov (United States)

    Fridiyanti, Inayah; Massijaya, M. Y.

    2018-03-01

    This research was focused on the utilization of oil palm trunk waste as a Parallel Strand Lumber (PSL) raw material. This research aimed to analyze the effect of adhesive types and glue spreads to the physical and mechanical properties of PSL. The adhesive types used were isocyanate and urea formaldehyde adhesives. The glue spreads used were 150 g/m2 and 300 g/m2. The research results showed that the moisture content of PSL ranged from 9.30% to 11.80%. The PSL density ranged from 0.64 to 0.78 g/cm3. The volume shrinkage ranged from 5.69 to 7.17%. Modulus of Elasticity (MOE) parallel to the grain and edge side ranged from 51.6 × 103 to 98.3 × 103 kg/cm2, and 62.1 × 103 to 99.9 × 103 kg/cm2, respectively. The Modulus of Rupture (MOR) parallel to the grain and edge side ranged from 269 to 724 kg/cm2 and 342 to 728 kg/cm2, respectively. The PSL hardness perpendicular to the grain, parallel to the grain and the edge side ranged from 135 to 300 kg/cm2, 87 to 321 kg/cm2, and 128 to 251 kg/cm2, respectively. The compressive strength ranged from 181 to 231 kg/cm2. The best adhesive and glue spreads of PSL was isocyanate with glue spread 300 g/m2. PSL made from hot pre-pressed long strand of oil palm trunk waste bonded by isocyanate fulfill JAS 1152: 2007. However, those of bonded by urea formaldehyde failed to fulfill the standard. The physical and mechanical properties of PSL made from oil palm trunk were better compared to those of solid oil palm trunk.

  17. The thermo-mechano-chemical twin-screw reactor, a new perspective for the biorefinery of sunflower whole plant: aqueous extraction of oil and other biopolymers, and production of biodegradable fiberboards from cake

    Directory of Open Access Journals (Sweden)

    Evon Philippe

    2016-09-01

    Full Text Available Biorefinery of sunflower whole plant was performed successfully using a thermo-mechano-chemical twin-screw reactor. This led to the aqueous extraction of oil and other biopolymers like proteins, pectins and non pectic sugars. It resulted in the overall fractionation of biomass, thus allowing a complete valorization of the input. This biorefinery process was not only efficient but it was also environment-friendly. In addition, it contributed to the production of different end products for various industrial applications. Firstly, the hydrophilic phase will be recycled to the process. Secondly, the densest oil-in-water emulsion is a promising candidate for the formulation of cosmetic creams. Thirdly, the upper hydrophobic phase will be usable for the waterproofing treatment of the surface of agromaterials by coating. Its demixing will also lead to the production of proteins with tensioactive properties. These will serve for the food industry. Lastly, the cake was a mixture of plasticized proteins and lignocellulosic fibers. It was thus considered as a natural composite. Its molding into cohesive fiberboards was conducted successfully using both thermopressing and compression molding processes. The self-bonded boards with high density will be suitable for use as load bearing boards in dry conditions (floor underlayers, interior partitions, furniture, etc.. Positioned in walls and ceilings, boards with medium and low density will contribute to the heat insulation of buildings. In addition, the bulk cake will be also usable as a loose fill insulation material. As proposed, this flow chart thus allows a valorization for all fractions originating from the twin-screw reactor.

  18. Effects of Variety and Hydration of Rice Flour on Cake Making Properties

    OpenAIRE

    長沼, 誠子; NAGANUMA, Seiko

    1993-01-01

    The pysicochemical characteristics and sensory attributes of rice layer cake were investigated to study the effects of rice variety and rice flour treatment on cake making properties. The rice layer cake were made from rice flour ground from 4 rice varieties (Sasanishiki, Akitakomachi, Kiyonishiki and Akihikari), water, sugar, oil, and baking powder. The treatment of rice frour with water before adding other ingredients improved appearance, texture and palatability of the baking products. The...

  19. Effect of varying levels of formaldehyde treatment of mustard oil cake on rumen fermentation, digestibility in wheat straw based total mixed diets in vitro

    OpenAIRE

    Mahima,; Kumar, Vinod; Tomar, S. K.; Roy, Debashis; Kumar, Muneendra

    2015-01-01

    Aim: The aim of the current study was to protect the protein in mustard cake by different levels of formaldehyde treatment with a view to optimize the level of formaldehyde. Materials and Methods: Different levels of formaldehyde treatment (0, 1, 1.5 and 2% of crude protein) containing concentrate and roughages diet in 40:60 ratio were tested for their effect on nutrients digestibility, in vitro ammonia release, in vitro gas production and change in protein fractions. Non-significant (p≤0....

  20. Degradation rates of phorbol esters in Jatropha curcas L. oil and pressed seeds under different storage conditions.

    Science.gov (United States)

    Phasukarratchai, Naphatsarnan; Damrongsiri, Seelawut; Tongcumpou, Chantra

    2017-03-01

    Phorbol esters (PEs), found in Jatropha curcas crude oil (JCO) and J. curcas pressed seeds (JPS), are known as bioactive compounds in agricultural and pharmaceutical applications. The degradation rates of PEs in JCO and JPS under various conditions is important for the utilisation of PEs. Thus the objective of this study was to determine the PE degradation rates in JCO and JPS under different storage conditions. PE degradation rates were found to be first-order reactions. The slowest degradation rate was at 0.9 × 10 -3 d -1 for both JCO and JPS unexposed to light at 4 °C. Light intensity (1097 lx and 4690 lx, representing diffused sunlight and fluorescent lighting, respectively) and temperature (25 to 35 °C) were the significant degradation factors. Light exposure led to 280% to 380% higher degradation rates in JCO than in JPS due to light penetration through the transparent oil. Dried and sterilised JPS showed an 80% to 90% lower PE degradation rate than untreated JPS under all storage conditions since biodegradation was assembly limited. The PEs were unstable under the studied conditions, especially when exposed to light and room temperature. To protect against PE degradation, a material should be stored in a light-protected container and below 4 °C. © 2016 Society of Chemical Industry. © 2016 Society of Chemical Industry.

  1. Layer-Cake Earth

    Science.gov (United States)

    Tedford, Rebecca; Warny, Sophie

    2006-01-01

    In this article, the authors offer a safe, fun, effective way to introduce geology concepts to elementary school children of all ages: "coring" layer cakes. This activity introduces the concepts and challenges that geologists face and at the same time strengthens students' inferential, observational, and problem-solving skills. It also addresses…

  2. Press of the market, forces to the oil companies to redefine their direction

    International Nuclear Information System (INIS)

    Anon

    1998-01-01

    In search of strategies to face the new setting, the oil companies have assumed positions that are erected on three fundamental points: The decisive influence of the history on the present. The oligopoly essential role and the importance of the corporate instinct of survival, If one thinks thoroughly, the petroleum business it is full with paradoxes, coarse with seeing that the objective is to sell a raw matter under a registered name, fact that of for yes, it is already contradictory. It is not the only thing. The activity is developed vertically through signatures integrated. However, most of signatures look toward the external market to establish prices that finally will be transferred to the processes of exploration, refinement, commercialization and sale. This way the things, how sense has to lean on in the vertical structure? It is also difficult to understand for that is not believed a business separated from exploration and extraction, if this it is the stage that bigger value contributes to the final product. In spite of it, such operations are always tied to the refinement tasks and marketing. The author continues making several positions of the current tendencies of the petroleum industry

  3. Sesamin and sesamolin as unexpected contaminants in various cold-pressed plant oils: NP-HPLC/FLD/DAD and RP-UPLC-ESI/MS(n) study.

    Science.gov (United States)

    Górnaś, Paweł; Siger, Aleksander; Pugajeva, Iveta; Segliņa, Dalija

    2014-04-01

    Thirteen cold-pressed oils (Japanese quince seed, black caraway, flaxseed, rapeseed, hemp, peanut, sunflower, pumpkin, hazelnut, poppy, walnut, almond and sesame oil) manufactured by the same company over a 2-year period (2011-12) were assessed for lipophilic compounds. The presence of sesamin and sesamolin, two characteristic lignans of sesame oil, were detected in all tested plant oils. Both lignans were identified by NP-HPLC/FLD/DAD and confirmed by a RP-UPLC-ESI/MS(n) method. The lowest amount of sesamin and sesamolin was found for Japanese quince seed oil (0.10 and 0.27 mg/100 g), and the highest, excluding sesame oil, for almond oil (36.21 and 105.42 mg/100 g, respectively). The highly significant correlation between sesamolin and sesamin concentrations was found in all samples tested (r = 0.9999; p products manufactured by the same company can contribute to a lesser regard for the quality of the final product. Moreover, less attention paid to the quality of final product can be related to the health risks of consumers especially sensitive to allergens. Therefore, proper cleaning of processing equipment is needed to prevent cross-contact of cold-pressed oils.

  4. Sustainable Agriculture: enhancement of the 'neem cake'

    International Nuclear Information System (INIS)

    Susanna, Mariani

    2015-01-01

    The 'neem cake' scrap processing of the industrial chain producing neem oil and azadirachtin. The ENEA laboratories have developed a promising trial to promote the use of neem cake as a low-cost insecticide and fertilizer in sustainable agriculture. [it

  5. Yellow cake product practice

    International Nuclear Information System (INIS)

    Bosina, B.

    1980-01-01

    The flow sheets of uranium ore processing plants at present operating throughout the world terminate with the production of yellow cake. The demands of the refineries on the quality of this commodity have become more stringent with time. The impurity content of yellow cake depends to a considerable extent on the nature of the technical operations preceding precipitation. As a rule the purity of the final product is greater when the uranium is precipitated from re-extractants or regenerators consisting of weakly basic resins. An analysis of 80 uranium precipitation flow sheets demonstrates the advantages of using ammonia, while to some extent use is made of caustic soda, magnesium oxide, hydrogen peroxide or calcium oxide; precipitation is carried out in one or two stages at high temperature. Use of a particular chemical is governed by its availability, price, effect on the environment, degree of filtrate utilization, etc. It may be anticipated that the perfecting of precipitation flow sheets will be directed towards achieving maximum concentration of uranium in the solutions before precipitation, reduction in the volume of liquid flows through the equipment, an improvement in the filtration qualities of the precipitate, etc. The paper gives the flow sheet for precipitation of uranium by means of gaseous ammonia from sulphate-carbonate solutions. For drying yellow cake use has been made of spray driers. The dry product is easily sampled and transported. (author)

  6. Characterization and Comparison of Fast Pyrolysis Bio-oils from Pinewood, Rapeseed Cake, and Wheat Straw Using 13C NMR and Comprehensive GC × GC

    NARCIS (Netherlands)

    Negahdar, Leila; Gonzalez-Quiroga, Arturo; Otyuskaya, Daria; Toraman, Hilal E.; Liu, Li; Jastrzebski, Johann T B H; Van Geem, Kevin M.; Marin, Guy B.; Thybaut, Joris W.; Weckhuysen, Bert M.

    2016-01-01

    Fast pyrolysis bio-oils are feasible energy carriers and a potential source of chemicals. Detailed characterization of bio-oils is essential to further develop its potential use. In this study, quantitative 13C nuclear magnetic resonance (13C NMR) combined with comprehensive two-dimensional gas

  7. A Comparison of the Volatile Components of Cold Pressed Hamlin and Valencia (Citrus sinensis (L. Osbeck Orange Oils Affected by Huanglongbing

    Directory of Open Access Journals (Sweden)

    Brittany M. Xu

    2017-01-01

    Full Text Available Volatiles from huanglongbing (HLB symptomatic and asymptomatic cold pressed orange oils from Florida Hamlin and Valencia fruit were assessed. Qualitative gas-liquid chromatography studies showed the presence of several compounds (β-longifolene, perillene, and 4-decenal which are not commonly identified in Citrus sinensis (L. Osbeck oils. Oils derived from huanglongbing symptomatic fruit had lower concentrations of linalool, decanal, citronellol, neral, geranial, carvone, dodecanal, and 2-decenal and higher concentrations of citronellal compared to asymptomatic fruit. A comparison to historic literature of orange oil investigations before HLB was of issue in Florida orange crops showed lower levels of linalool, decanal, neral, and geranial in Hamlin peel oil samples, as well as higher levels of dodecanal. Valencia peel oil samples showed lower concentrations of linalool and increased concentration of citronellol and dodecanal. As a result of huanglongbing (HLB phenomena, the concentrations of several important volatiles found in Hamlin and Valencia peel oil profiles have changed compared to historic values. Differences in volatile concentrations of symptomatic and asymptomatic HLB affected peel oil compounds in orange fruit are identified.

  8. Effects of dietary cold-pressed turnip rapeseed oil and butter on serum lipids, oxidized LDL and arterial elasticity in men with metabolic syndrome

    Directory of Open Access Journals (Sweden)

    Wallenius Marja

    2010-12-01

    Full Text Available Abstract Background Rapeseed oil is the principal dietary source of monounsaturated and n-3 polyunsaturated fatty acids in the Northern Europe. However, the effect of rapeseed oil on the markers of subclinical atherosclerosis is not known. The purpose of this study was to compare the effects of dietary intake of cold-pressed turnip rapeseed oil (CPTRO and butter on serum lipids, oxidized LDL and arterial elasticity in men with metabolic syndrome. Methods Thirty-seven men with metabolic syndrome completed an open and balanced crossover study. Treatment periods lasted for 6 to 8 weeks and they were separated from each other with an eight-week washout period. Subjects maintained their normal dietary habits and physical activity without major variations. The daily fat adjunct consisted either of 37.5 grams of butter or 35 mL of VirginoR CPTRO. Participants were asked to spread butter on bread on the butter period and to drink CPTRO on the oil period. The fat adjunct was used as such without heating or frying. Results Compared to butter, administration of CPTRO was followed by a reduction of total cholesterol by 8% (p Conclusion Cold-pressed turnip rapeseed oil had favourable effects on circulating LDL cholesterol and oxidized LDL, which may be important in the management of patients at high cardiovascular risk. Trial registration ClinicalTrial.gov NCT01119690

  9. ;Green; carbon with hierarchical three dimensional porous structure derived from - Pongamia pinnata seed oil extract cake and NiCo2O4-Ni(OH)2/Multiwall carbon nanotubes nanocomposite as electrode materials for high performance asymmetric supercapacitor

    Science.gov (United States)

    Chaitra, K.; Narendra, Reddy; Venkatesh, Krishna; Nagaraju, N.; Kathyayini, Nagaraju

    2017-07-01

    Herein, we report for the first time synthesis and electrochemical supercapacitance performance of 3-D hierarchical porous "Green" carbon derived from Pongamia pinnata seed oil extract cake and its activation using different amounts of KOH. Also, nanocomposites of multiwalled carbon nanotubes (MWCNT) with various weight percentages of Ni and Co were prepared by hydrothermal method. Physico-chemical properties of "Green" carbon and nanocomposites were analyzed by Powder X-ray Diffraction, Brunner Emmett Teller surface area, Scanning Electron Microscopy-Elemental Dispersive Spectrum, Transmission Electron Microscopy and Raman techniques. KOH activated carbon was found associated with combination of micropores & mesopores while the nanocomposite with mixture of spinel NiCo2O4 and Ni(OH)2. Porous carbon activated with 2:1::KOH:C (KC2) and the nanocomposite with 1:1 Ni & Co (NC1) exhibited excellent electrochemical performance in three electrode system. Further, fabricated asymmetric supercapacitor (AS) device Ni-Co-MWCNT (NC1)//KC2 exhibited specific capacitance (Cs) of 177 F/g as determined by cyclic voltammetry at 10 mV/s and retained 90% even at 3000th cycle in life cycle test conducted at high current density of 50 A/g. In order to evaluate its practical performance, the AS device was charged to 1.8 V at 5 A/g and used successfully to power a calculator for more than 1 h.

  10. Biological pretreatment and ethanol production from olive cake

    DEFF Research Database (Denmark)

    Jurado, Esperanza; Gavala, Hariklia N.; Baroi, George Nabin

    2010-01-01

    Olive oil is one of the major Mediterranean products, whose nutritional and economic importance is well-known. However the extraction of olive oil yields a highly contaminating residue that causes serious environmental concerns in the olive oil producing countries. The olive cake (OC) coming out...... of the three-phase olive oil production process could be used as low price feedstock for lignocellulosic ethanol production due to its high concentration in carbohydrates. However, the binding of the carbohydrates with lignin may significantly hinder the necessary enzymatic hydrolysis of the polymeric sugars...... before ethanol fermentation. Treatment with three white rot fungi, Phaneroachaete chrysosporium, Ceriporiopsis subvermispora and Ceriolopsis polyzona has been applied on olive cake in order to investigate the potential for performing delignification and thus enhancing the efficiency of the subsequent...

  11. Optimization of the process of pressing safflower seeds in an ultrasonic field

    Directory of Open Access Journals (Sweden)

    S. T. Antipov

    2017-01-01

    Full Text Available The article gives a mathematical description of the process of pressing safflower seeds in an ultrasonic field in the form of a regression equation found by static methods on the basis of experiments and described by a polynomial of the second degree. As the main factors influencing the efficiency of the process, the ultrasound frequency, the amplitude of the ultrasound, the pressure and the press created in the green chamber were selected. And as a criterion for assessing the effect of the selected parameters, the residual oil content of the cake is used. To assess the adequacy of the mathematical model, the variance analysis (ANOVA of the experiment in the Design Expert v. 10 and the regression equation is obtained, the analysis of which allowed us to identify the factors that most influenced the process under consideration. Found that when the pressure in the press to a value higher than 14 MPa, a further increase in efficiency was observed together with increased values as the ultrasound frequency and its amplitude. The maximum and most effective value residual oil content in oil cake obtained in the frequency 35-40 Hz and amplitude of more than 40 mm and the pressure in the press from 10 to 11 MPa. which are obviously directly dependent on the behavior of grain and movement of its internal parts during the supply of the ultrasound. Graphical interpretation of the equation is represented by curves of equal values and response surfaces for input parameters. A numerical and graphical optimization procedure is also proposed to predict the optimal level of input factors and to obtain the maximum yield of oil relative to the mass of the original feed. To test the adequacy of the model, the results of a number of parallel experiments are presented that fall within the calculated confidence intervals for all quality criteria.

  12. Characteristics of rose hip (Rosa canina L.) cold-pressed oil and its oxidative stability studied by the differential scanning calorimetry method.

    Science.gov (United States)

    Grajzer, Magdalena; Prescha, Anna; Korzonek, Katarzyna; Wojakowska, Anna; Dziadas, Mariusz; Kulma, Anna; Grajeta, Halina

    2015-12-01

    Two new commercially available high linolenic oils, pressed at low temperature from rose hip seeds, were characterised for their composition, quality and DPPH radical scavenging activity. The oxidative stability of oils was assessed using differential scanning calorimetry (DSC). Phytosterols, tocopherols and carotenoids contents were up to 6485.4; 1124.7; and 107.7 mg/kg, respectively. Phenolic compounds determined for the first time in rose hip oil totalled up to 783.55 μg/kg, with a predominant presence of p-coumaric acid methyl ester. Antiradical activity of the oils reached up to 3.00 mM/kg TEAC. The acid, peroxide and p-anisidine values as well as iron and copper contents indicated good quality of the oils. Relatively high protection against oxidative stress in the oils seemed to be a result of their high antioxidant capacity and the level of unsaturation of fatty acids. Copyright © 2015 Elsevier Ltd. All rights reserved.

  13. Development a method for producing vegetable oil from safflower seeds by pressing in the field of ultrasound

    OpenAIRE

    S. T. Antipov; S. V. Shakhov; A. N. Martekha; A. A. Berestovoy

    2015-01-01

    The article shows the prospects of production in agriculture safflower seeds for food and extract biologically active components. The physicochemical composition of safflower, which is rich in unsaturated fatty acids. Safflower oil has a soothing and moisturizing effect, provides a barrier function of the skin, therefore, fatty oil is promising in terms of scientific evidence use in medical practice. In the article the task of developing a set of processes to extract oil from the seeds of saf...

  14. Equilibrium Analysis in Cake Cutting

    DEFF Research Database (Denmark)

    Branzei, Simina; Miltersen, Peter Bro

    2013-01-01

    Cake cutting is a fundamental model in fair division; it represents the problem of fairly allocating a heterogeneous divisible good among agents with different preferences. The central criteria of fairness are proportionality and envy-freeness, and many of the existing protocols are designed...... to guarantee proportional or envy-free allocations, when the participating agents follow the protocol. However, typically, all agents following the protocol is not guaranteed to result in a Nash equilibrium. In this paper, we initiate the study of equilibria of classical cake cutting protocols. We consider one...... of the simplest and most elegant continuous algorithms -- the Dubins-Spanier procedure, which guarantees a proportional allocation of the cake -- and study its equilibria when the agents use simple threshold strategies. We show that given a cake cutting instance with strictly positive value density functions...

  15. Comparison the physicochemical properties of bunch press fibre cellulose and cyclone fibre cellulose of waste from industry Crude Palm Oil (CPO

    Directory of Open Access Journals (Sweden)

    Irfan Gustian

    2013-10-01

    Full Text Available Normal 0 false false false EN-US X-NONE X-NONE Study on comparison the physicochemical properties of bunch press fibre cellulose (Bpfc and cyclone fibre cellulose (Cfc wastes from industry Crude Palm oil (CPO have been performed. The physicochemical properties both of celluloses have been done such as the average degree of polymerization (DP, solubility properties, functional group analysis, thermal properties and X-ray diffraction patterns. The average degrees of polymerization (DP have been obtained 2195 and 567 for Bpfc and Cfc. Bunch press fibre cellulose and cyclone fibre cellulose were soluble in cupriethylenediamine (CED. FT-IR analysis showed the same pattern of spectrum but different intensities. Thermal stability of bunch press fibre cellulose and cyclone fibre cellulose remains stable up to a temperature of 250 °C. Glass transition bunch press fibre cellulose greater than the glass transition cyclone fibre cellulose and X-ray diffraction pattern shows the same pattern and intensity varies.

  16. Nutritional value of yellow-seeded winter rapeseed cakes for growing pigs

    Directory of Open Access Journals (Sweden)

    Ewa Święch

    2016-08-01

    Full Text Available Objective of the study was to compare the composition and nutritional value of a winter brown- (BRC and three yellow-seeded (YRC cold-pressed rapeseed cakes as the components of pigs’ diets, and to assess their effects on colonic bacterial fermentation and the relative weight of organs. In experiment 1, the standardised ileal digestibility (SID of protein and amino acids (AA of cakes was determined in 12 male cannulated pigs. Each diet was fed to six pigs during three seven-day periods. Ileal digesta was collected during the last three days of the period. In experiment 2, five groups each containing six female pigs with initial body weights (BW of 20 kg were fed on diets containing BRC, YRC, or soyabean oil meal (SBM as the main protein source. The apparent total tract digestibility (ATTD of nutrients and growth performance were measured untill 60 kg BW was reached, and short chain fatty acids (SCFA concentrations in the colon, as well as the weight of the liver, kidney, heart, and thyroid, were recorded. The main differences between BRC and YRC were found in higher content of fat and protein, lower amounts of fibre and glucosinolates (Gls, and higher ATTD of fibre in YRC. Protein and AA SID, ATTD of nutrients, total SCFA colonic concentration, and growth performance did not significantly differ. The chemical composition of the three YRC was not uniform, the greatest differences were found among the amounts of Gls. The relative weights of the thyroid and heart were greater in pigs fed BRC than in YRC and SBM diets. Thyroid weight was positively correlated with dietary progoitrin, alkenyl Gls, and total Gls, whereas heart weight was positively correlated with progoitrin and alkenyl Gls. It was concluded that winter yellow-seeded rapeseed is a better raw material for cold-pressing than brown-seeded due to having lower Gls and fibre content. 

  17. Microwave-assisted extraction of herbacetin diglucoside from flax (Linum usitatissimum L.) seed cakes and its quantification using an RP-HPLC-UV system.

    Science.gov (United States)

    Fliniaux, Ophélie; Corbin, Cyrielle; Ramsay, Aina; Renouard, Sullivan; Beejmohun, Vickram; Doussot, Joël; Falguières, Annie; Ferroud, Clotilde; Lamblin, Frédéric; Lainé, Eric; Roscher, Albrecht; Grand, Eric; Mesnard, François; Hano, Christophe

    2014-03-10

    Flax (Linum usitatissimum L.) seeds are widely used for oil extraction and the cold-pressed flaxseed (or linseed) cakes obtained during this process constitute a valuable by-product. The flavonol herbacetin diglucoside (HDG) has been previously reported as a constituent of the flaxseed lignan macromolecule linked through ester bonds to the linker molecule hydroxymethylglutaric acid. In this context, the development and validation of a new approach using microwave-assisted extraction (MAE) of HDG from flaxseed cakes followed by quantification with a reverse-phase HPLC system with UV detection was purposed. The experimental parameters affecting the HDG extraction yield, such as microwave power, extraction time and sodium hydroxide concentration, from the lignan macromolecule were optimized. A maximum HDG concentration of 5.76 mg/g DW in flaxseed cakes was measured following an irradiation time of 6 min, for a microwave power of 150 W using a direct extraction in 0.1 M NaOH in 70% (v/v) aqueous methanol. The optimized method was proven to be rapid and reliable in terms of precision, repeatability, stability and accuracy for the extraction of HDG. Comparison with a conventional extraction method demonstrated that MAE is more effective and less time-consuming.

  18. Optimization of a sponge cake formulation with inulin as fat replacer: structure, physicochemical, and sensory properties.

    Science.gov (United States)

    Rodríguez-García, Julia; Puig, Ana; Salvador, Ana; Hernando, Isabel

    2012-02-01

    The effects of several fat replacement levels (0%, 35%, 50%, 70%, and 100%) by inulin in sponge cake microstructure and physicochemical properties were studied. Oil substitution for inulin decreased significantly (P cake structure development during baking. Cryo-SEM micrographs of cake crumbs showed a continuous matrix with embedded starch granules and coated with oil; when fat replacement levels increased, starch granules appeared as detached structures. Cakes with fat replacement up to 70% had a high crumb air cell values; they were softer and rated as acceptable by an untrained sensory panel (n = 51). So, the reformulation of a standard sponge cake recipe to obtain a new product with additional health benefits and accepted by consumers is achieved. Practical Application:  In this study, fat is replaced by inulin in cakes, which is a fiber mainly obtained from chicory roots. Sponge cake formulations with reductions in fat content up to 70% are achieved. These high-quality products can be labeled as "reduced in fat" according to U.S. FDA (2009) and EU regulations (European-Union 2006). © 2012 Institute of Food Technologists®

  19. Feeding olive cake to ewes improves fatty acid profile of milk and cheese

    DEFF Research Database (Denmark)

    Vargas-Bello-Pérez, E.; Vera, R. R.; Aguilar, C.

    2013-01-01

    Olive oil extraction yields a residual cake rich in oil that can be used in animal diets as a source of monounsaturated fat. Milk and cheese from sheep are high in saturated fatty acids (FA) thus, it was hypothesized that supplementing olive cake to lactating ewes would result in naturally enhanced...... milk and cheese with healthier FA profiles for human consumption. Nine lactating ewes were randomly assigned to a replicated (n= s3) 3. ×. 3 Latin square design. Diets were supplemented with 0, 10 or 25% of dry olive cake. Except for total solids, dry matter intake, milk yield and milk composition were...... not affected by dietary treatments. Oleic acid, n-6/. n-3 ratio and monounsaturated FA gradually increased (P. olive cake was increased in dietary treatments. Overall, FA profile of milk and cheese...

  20. Parameters Affecting the Extraction Process of Jatropha Curcas Oil Using a Single Screw Extruder

    OpenAIRE

    Siregar, Ali Nurrakhmad; Ghani, Jaharah A; Che Haron, Che Hassan; Rizal, Muhammad

    2015-01-01

    The most commonly used technique to separate oil and cake from J. curcas seeds is mechanical extraction. It uses simple tools such as a piston and a screw extruder to produce high pressure, driven by hand or by engine. A single screw extruder has one screw rotating inside the barrel and materials simultaneously flow from the feed to the die zone. The highest oil yield can be obtained by a well-designed oil press as well as finding the optimum conditions for all parameters involved during the ...

  1. Nutritional evaluation of groundnut oil cake in formulated diets for rohu, Labeo rohita (Hamilton fingerlings after solid state fermentation with a tannase producing yeast, Pichia kudriavzevii (GU939629 isolated from fish gut

    Directory of Open Access Journals (Sweden)

    Koushik Ghosh

    2015-11-01

    Full Text Available De-oiled groundnut oil cake (GOC was bio-processed through solid state fermentation (SSF for 15 days at 34 ± 1 °C by a tannase producing yeast, Pichia kudriavzevii (GU939629 isolated from the gut of a freshwater carp, Cirrhinus cirrhosus. SSF of GOC was effective in significantly (P < 0.05 reducing crude fibre content and antinutritional factors (e.g., tannin, phytic acid and trypsin inhibitor, whereas enhancing crude protein, lipid, ash, total free amino acids and fatty acids. Bio-processing revealed significant increase in the levels of argenine, histidine, isoleusine, lysine, methyonine and threonine in the GOC. Eight isonitrogenous (37.5% and isocaloric (18.8 kJ g−1 experimental diets were prepared incorporating raw (R1–R4 and fermented (F1–F4 GOC at 20%, 30%, 40% and 50% levels by weight replacing fishmeal and other feed ingredients into a fishmeal-based reference diet (RD and fed to rohu, Labeo rohita, fingerlings (initial weight 3.24 ± 0.11 g for 80 days. In general, diets with SSF-processed GOC produced significantly better performance than the raw GOC in terms of growth, feed utilization, nutrient digestibility, carcass composition and digestive enzyme activity. Rohu fingerlings fed the diet F3 containing 40% fermented GOC resulted in best performance in terms of weight gain (final weight 7.08 ± 0.06 g, specific growth rate (% day−1, protein efficiency ratio and apparent net protein utilization. Highest protein (14.93 ± 0.51% and lipid deposition in the carcass were also recorded in the group of fish reared on diet F3. In comparison to the FM based reference diet, the present study explored the possibility of replacing 45–55% of FM through incorporation of 40–50% (w/w SSF-processed GOC in the diets for rohu fingerlings.

  2. Simultaneous allergen inactivation and detoxification of castor bean cake by treatment with calcium compounds

    International Nuclear Information System (INIS)

    Fernandes, K.V.; Deus-de-Oliveira, N.; Godoy, M.G.; Guimarães, Z.A.S.; Nascimento, V.V.; Melo, E.J.T. de; Freire, D.M.G.; Dansa-Petretski, M.; Machado, O.L.T.

    2012-01-01

    Ricinus communis L. is of great economic importance due to the oil extracted from its seeds. Castor oil has been used for pharmaceutical and industrial applications, as a lubricant or coating agent, as a component of plastic products, as a fungicide or in the synthesis of biodiesel fuels. After oil extraction, a castor cake with a large amount of protein is obtained. However, this by-product cannot be used as animal feed due to the presence of toxic (ricin) and allergenic (2S albumin) proteins. Here, we propose two processes for detoxification and allergen inactivation of the castor cake. In addition, we establish a biological test to detect ricin and validate these detoxification processes. In this test, Vero cells were treated with ricin, and cell death was assessed by cell counting and measurement of lactate dehydrogenase activity. The limit of detection of the Vero cell assay was 10 ng/mL using a concentration of 1.6 × 10 5 cells/well. Solid-state fermentation (SSF) and treatment with calcium compounds were used as cake detoxification processes. For SSF, Aspergillus niger was grown using a castor cake as a substrate, and this cake was analyzed after 24, 48, 72, and 96 h of SSF. Ricin was eliminated after 24 h of SSF treatment. The cake was treated with 4 or 8% Ca(OH) 2 or CaO, and both the toxicity and the allergenic properties were entirely abolished. A by-product free of toxicity and allergens was obtained

  3. Determination of Juice Removal Difficulty from Mash Cake in Cassava Mash Dewatering Operation

    Directory of Open Access Journals (Sweden)

    Oladele Peter KOLAWOLE

    2012-08-01

    Full Text Available Cassava processing equipment operators have limited knowledge; this militates against the success recorded in the research so far in cassava mash dewatering. New dewatering schemes to make food processing economical to handle are in progress. Common dewatering processes use a variety of mechanical means such as screw presses and belt presses. Experiments were conducted using three samples of TMS 4(2 1425 variety while evaluating the difficulty of separating juice from mash cake. Average specific cake resistance (a of 5×1011 m/kg was obtained confirming that it is moderately easy to dewatering.

  4. [Purification of waste water from olive-oil pressing plants using hydrophytes. Preliminary study on the use of Eichornia crassipes].

    Science.gov (United States)

    Ferrara, L; Forgione, P; Schettino, O; Rullo, V

    1989-04-01

    The use of Eichornia crassipes has been tested in order to depurate the waste water from olive oil factories. The control of some parameter variations during the treatment, such as COD, total azote, dissolved oxygen and pH, has given encouraging results about the depurative efficacy of employed hydrophytae. Particularly indicative is, in this regard, COD rejection of about 60%.

  5. Physicochemical characterization and quality of cold-pressed peanut oil obtained from organically produced peanuts from Macedonian “Virginia” variety

    Directory of Open Access Journals (Sweden)

    Kostadinović Veličkovska, S.

    2016-03-01

    Full Text Available The physicochemical characterization and quality of cold pressed peanut edible oil from the “Virginia” variety, organically produced from the region of Macedonia, were examined in this work for the first time. The fatty acid composition of the oil showed almost equal levels of oleic and linoleic acids with an abundance of 34.19±0.01 and 36.13±0.01%, respectively. The most dominant saturated fatty acid was palmitic acid with a level of 10.06±0.00%. The level of tocopherols and other vitamin-E-related compounds was in strong agreement with the antioxidant activity of the oils measured by the DPPH assay. Almost equal amounts of α and γ tocopherols indicated an antioxidant potential of 288.63±59.78 mg·L−1 α-tocopherol. Phytosterols, as minor compounds present in the oils, can be additional antioxidants responsible for the health benefits of this oil in human nutrition. The four major pytosterols were β-sitosterol (1812.21±22.17 mg·kg−1 oil, champesterol (320.55±17.07 mg·kg−1 oil, Δ5-avenasterol (236.16±14.18 mg·kg−1 and stigmasterol (133.12±12.51 mg·kg−1 oil. Induction time, Peroxide number, FFA and specific extinction (K232 and K270, values 1.82 and 0.22 gave us an indication of the oxidative stability of cold pressed peanut oil.Se ha abordado por primera vez, en este trabajo, la caracterización físico-química y la calidad de aceite comestible de maní prensado en frío de la variedad “Virginia”, de producción ecológica y procedente de la región de Macedonia La composición de ácidos grasos del aceite mostró casi los mismos niveles de los ácidos oleico y linoleico: 34,19±0,01 y 36,13±0,01%, respectivamente. El ácido graso saturado dominante fué el palmítico, 10,06±0,00%. El nivel de tocoferoles y otros compuestos relacionados con la vitamina-E estaba en estrecha relación con la actividad antioxidante de los aceites medidos mediante el ensayo de DPPH. Casi igual cantidad de α y γ tocoferol indic

  6. Analysis of Chemical Compositions of 15 Different Cold-Pressed Oils Produced in Turkey: A Case Study of Tocopherol and Fatty Acid Analysis

    Directory of Open Access Journals (Sweden)

    Veysel U. Celenk

    2017-10-01

    Full Text Available Many people tend to prefer natural foods and supplements nowadays. Considering this tendency, this study assessed the most significant in quality and purity parameters tocopherol and fatty acid compositions of cold-pressed oils, namely black cumin, sesame, sunflower, poppy, pomegranate, nettle, pumpkin, grape, safflower, flax, canola seed, wheat germ, peanut, hazelnut, and walnut. This study deals with the sample preparation and validation of tocopherols using an HPLC-FLD method for simultaneous determination of α-β-γ-, and δ-tocopherols, and analysis of fatty acid methyl esters (FAME with using GC-FID. The validated HPLC method was applied for the tocopherols’ analysis and measurement uncertainty was calculated for tocopherols and some fatty acids. The obtained data were evaluated by using principal component analysis to show the relationship between quality parameters and seed oils. Wheat germ, hazelnut, safflower, and sunflower oils have the highest tocopherol contents respectively with a predominance of α-tocopherol. Seed oils’ fatty acid compositions were classified according to proportions of oleic, linoleic, and other fatty acids. This study shows that the evaluated seeds are valuable sources of natural antioxidants and some specific and polyunsaturated fatty acids. The applied method can also be helpful for the industry to obtain quality analysis approach.

  7. Tea and cake [second edition

    OpenAIRE

    Wood, Philippa; MacLellan, Tamar

    2011-01-01

    Tea & Cake is an edited version of the original book produced by Philippa Wood in 2007. The book takes a nostalgic look at childhood memories of ‘baking with mother’ or special tea-time treats. The book combines ink-jet printing with typewritten text and rubber stamps; doilly end-papers and embroidered traycloth covers.

  8. Decanter cake as a feedstock for biodiesel production: A first report

    International Nuclear Information System (INIS)

    Maniam, Gaanty Pragas; Hindryawati, Noor; Nurfitri, Irma; Jose, Rajan; Ab. Rahim, Mohd Hasbi; Dahalan, Farrah Aini; Yusoff, Mashitah M.

    2013-01-01

    Highlights: • Decanter cake as a potential waste feedstock for biodiesel production. • Ultrasound-aided transesterification achieving nearly 86% conversion in 1 h. • Boiler ash, a waste product, was successfully used as a catalyst. - Abstract: Decanter cake (DC), with an oil content of 11.5 ± 0.18 wt.%, was subjected to ultrasound-aided transesterification using boiler ash as a base catalyst, petroleum ether and hexane as co-solvents. Optimization work revealed that at MeOH:oil mass ratio of 6:1 and 2.3 wt.% catalyst (based on DC weight) with 1:2 co-solvents:DC mass ratio as the optimal reaction conditions. Both decanter cake and boiler ash, waste materials from oil palm mill, were successfully utilized to produce methyl ester (biodiesel) with highest conversion of 85.9 wt.% in a 1 h reaction period at 55 °C

  9. Studies on drying kinetics of olive foot cake

    Directory of Open Access Journals (Sweden)

    Hamlat, M. S.

    2002-06-01

    Full Text Available The olive foot cake is a very important by-product of olive oil industry since it can contain until 12 % of oil which can be extracted using solvent. The used solvent is often immiscible with water. This is the reason why its effect is limited by the moisture of olive foot cake making its drying imperative. In this paper, we present the behaviour of olive foot cake subjected to convective drying. The experimental results show that the drying rate versus moisture presents only one period of decreasing rate. The influence of the main parameters on drying kinetics is studied.El orujo es un importante subproducto de la industria del aceite de oliva ya que puede contener hasta el 12 % del aceite, el cual puede ser extraído usando un disolvente apropiado. El uso del disolvente es a menudo inmiscible con el agua. Esta es la razón por la que su efecto está limitado por la humedad del orujo, haciendo su secado imperativo. En este artículo se presenta el comportamiento del orujo sometido a un secado por convección. Los resultados experimentales mostraron que la velocidad de secado frente a la humedad, presenta un solo período de disminución de dicha velocidad. Se ha estudiado la influencia de los principales parámetros sobre la cinética de secado.

  10. “Gold” Pressed Essential Oil: An Essay on the Volatile Fragment from Citrus Juice Industry By-Products Chemistry and Bioactivity

    Directory of Open Access Journals (Sweden)

    V. N. Kapsaski-Kanelli

    2017-01-01

    Full Text Available Present essay explores the potentials of Citrus juice industry’s by-products as alternative bioactive natural products resources. Four crude Cold Pressed Essential Oils (CPEOs, derived from orange, lemon, grapefruit, and mandarin, were studied. All CPEOs were subjected to water distillation, in order to obtain the volatile fragment, which was further fractionated with respect to distillation period in two parts, concluding to eight samples. These samples along with the four original CPEOs were assessed in relation to their phytochemical content and their repellent and larvicidal properties against Asian Tiger Mosquito. The volatiles recovery rates ranged from 74% to 88% of the CPEO. Limonene presented a significant increase in all samples ranging from 8% to 52% of the respective CPEO’s content and peaked in mandarin’s 2nd volatile fragment which comprised 97% of the essential oil. The refinement process presented clear impacts on both bioassays: a significant increase in larvicidal potency was observed, annotated best by the improvement by 1100% and 1300% of the grapefruit volatile fractions; repellence testing provided only one significant result, the decrease of landings by 50% as a response to mandarin’s second volatile fraction. The applied methodology thus may be considered for the improvement of Citrus juice industry’s by-products chemistry and bioactivity.

  11. Effects of addition of different fibers on rheological characteristics of cake batter and quality of cakes.

    Science.gov (United States)

    Aydogdu, Ayca; Sumnu, Gulum; Sahin, Serpil

    2018-02-01

    The aim of this study was to investigate the effects of addition of dietary fibers on rheological properties of batter and cake quality. Wheat flour was replaced by 5 and 10% (wt%) oat, pea, apple and lemon fibers. All cake batters showed shear thinning behavior. Incorporation of fibers increased consistency index (k), storage modulus (G') and loss modulus (G″). As quality parameters, specific volume, hardness, weight loss, color and microstructure of cakes were investigated. Cakes containing oat and pea fibers (5%) had similar specific volume and texture with control cakes which contained no fiber. As fiber concentration increased, specific volume decreased but hardness increased. No significant difference was found between weight loss of control cake and cakes with oat, pea and apple fibers. Lemon fiber enriched cakes had the lowest specific volume, weight loss and color difference. When microstructural images were examined, it was seen that control cake had more porous structure than fiber enriched cakes. In addition, lemon and apple fiber containing cakes had less porous crumb structure as compared to oat and pea containing ones. Oat and pea fiber (5%) enriched cakes had similar physical properties (volume, texture and color) with control cakes.

  12. JOJOBA: an oil plant for arid or semi-arid regions

    Energy Technology Data Exchange (ETDEWEB)

    Marull, J E

    1978-01-01

    Jojoba (Simmondsia chinesis) grows in regions with a rainfall of 250 to 450 mm, producing 4.5 kg seeds/tree after 36 months and attaining an average production of 13.8 kg seeds/tree when full grown. Productivity can be maintained for up to 100 years. Planting density is about 1600 plants/ha, at distances of 1.50 x 3.00 m. The seeds contain 50% edible oil, and the press-cake 35% proteins. The characteristics of the oil are listed.

  13. Jojoba, an oil plant for arid or semi-arid regions

    Energy Technology Data Exchange (ETDEWEB)

    Marull, J E

    1978-01-01

    Jojoba (Simmondsia chinensis) grows in regions with a rainfall of 250-450 mm, producing 4.5 kg seeds/tree after 36 months and attaining an average production of 13.8 kg seeds/tree when full grown. Productivity can be maintained for up to 100 years. Planting density is about 1600 plants/ha, at distances of 1.50 x 3.00 m. The seeds contain 50% edible oil, and the press-cake 35% proteins. The characteristics of the oil are listed.

  14. Biotechnological applications for the utilisation of wastes from palm oil mills

    Energy Technology Data Exchange (ETDEWEB)

    Cheah, S C; Ma, A N; Ooi, L C.L.; Ong, A S.H.

    1988-05-01

    The milling of oil palm fruits produces about two-and-a-half to three times as much effluent as oil does. It also generates a large amount of lignocellulosic wastes, mainly in the form of empty fruit bunches, press cake fibres and nut shell. Research efforts at PORIM have been directed towards the utilisation of these wastes as a means to solve the problem of environmental pollution as well as for the generation of economic returns for the mills. We have studied a thermophilic contact process for the anaerobic digestion of palm oil mill effluent and its potential for generating biogas for energy uses. Our work has also shown that the condensate derived from the fruit sterilisation process during milling is amenable to fermentation for the production of single cell protein (SCP) and exo-enzymes. The enzymes produced have been applied for oil clarification, oil recovery from press cake fibers and saccharification of the fibers for the production of sugar feedstocks. This paper will also introduce the concept of integrated waste management for the palm oil mill through the implementation of these technologies.

  15. Impurities enhance caking in lactose powder

    DEFF Research Database (Denmark)

    Carpin, M.; Bertelsen, H.; Dalberg, A.

    2017-01-01

    Caking of lactose and other dry ingredients is a common problem in the dairy and food industries. The lactose production process includes different purification steps, depending on the type of lactose produced. The aim of this study was therefore to investigate how the remaining impurities (i.......e. non-lactose components) affect the caking tendency of the final powder. The results from a combination of different methods, including dynamic vapor sorption, characterization of the physicochemical composition and assessment of caking with a ring shear tester, suggested humidity caking. Larger...... amounts of impurities in the lactose powder resulted in enhanced moisture sorption and greater caking tendency. These findings emphasize the importance of controlling the washing and purification steps throughout the production process in order to limit caking in the final product...

  16. Temperature dependence of refractive index and of electrical impedance of grape seed (Vitis vinifera, Vitis labrusca oils extracted by Soxhlet and mechanical pressing

    Directory of Open Access Journals (Sweden)

    Vieira, D. S.

    2015-09-01

    Full Text Available In this report, the temperature dependence of the refractive index and electric impedance of vegetable oil grape seeds extracted from Vitis vinifera (v. Cabernet and Vitis labrusca (v. Bordo are investigated by means of experimental techniques. The seeds were collected from wineries located in two cities in the south of Brazil. In both extraction methods, the seeds were dried at 40.0 °C and at 80.0 °C, respectively, before the oil extraction. From optical microscopy and refractometry results, one can see that the grape seed oil extracted by mechanical pressing shows a linear dependence between the refractive index and temperature and has no birefringent residues. From the fitting of the EIS (Electrical Impedance Spectroscopy data, an equivalent electric circuit composed of a parallel RC in series with a resistor is proposed. The circuit model is in good agreement with the experimental data and provides the electrical permittivity of the vegetable oils investigated.Se investiga mediante técnicas experimentales la dependencia del índice de refracción y la impedancia eléctrica de aceites vegetales extraídos de semillas de uva Vitis vinifera (v. Cabernet y Vitis labrusca (v. Bordo. Las semillas fueron recolectadas de bodegas situadas en dos ciudades al sur de Brasil. Antes de la extracción del aceite, mediante dos métodos de extracción, las semillas fueron secadas a 40,0 °C y 80,0 °C. De los resultados de refractometria y microscopía óptica, se comprueba que el aceite de semilla de uva extraída por prensado mecánico obedece a una relación lineal del índice de refracción con la temperatura y no presentan resíduos birrefringentes. Con los datos de impedancia eléctrica, se propone un circuito eléctrico equivalente formado por una resistencia y un condensador en paralelo, a su vez ligado a otra resistencia en serie. El modelo de circuito tiene una alta correlación con los datos experimentales y permite obtener la constante diel

  17. Cold-pressed pumpkin seed (Cucurbita pepo L. oils from the central Anatolia region of Turkey: Characterization of phytosterols, squalene, tocols, phenolic acids, carotenoids and fatty acid bioactive compounds

    Directory of Open Access Journals (Sweden)

    G. Akin

    2018-03-01

    Full Text Available There is a growing interest in cold-pressed oils because they present high contents of bioactive compounds. These oils have the characteristic properties of seeds and are specific products of their regions. The aim of this study was to determine the compositions and contents of fatty acids, phytosterols, squalene, tocols, phenolic acids, carotenoids and phenolic bioactives, and the free radical scavenging as well as antioxidant activities of cold-pressed pumpkin (Cucurbita pepo L. seed oils. Oil samples from raw pumpkin seeds cultivated in four different central Anatolia regions of Turkey were prepared using a laboratory screw-pressing machine. The results indicate that cold-pressed pumpkin seed oils (PSO have excellent quality with high contents of polyunsaturated fatty acids (%ΣPUFAs (53.60 ±0.06-53.73 ±0.05, total phytosterols (782.1±9.7–805.2 ±11.3 mg/100 g oil, squalene (591.3±10.6–632.5±11.4 mg/100 g oil, tocols (97.79 ±0.76?94.29 ±0.34 mg/100 g oil, phenolic acids (22.73 ±0.41–23.98 ±0.46 mg/100 g oil, carotenoids (6.95 ±0.03–7.60 ±0.03 mg/100 g oil, total phenolics (3.96 ±0.13 –5.82±0.15 mg GAE/100 g, free radical-scavenging activity (5.70 ±0.13?7.35 ±0.15 mg GAE/100 g and total antioxidant activity (26.67±0.97-38.89±1.41 mg GAE/100 g values. Thus, this study demonstrates that the cold- pressed PSOs from the central Anatolia regions of Turkey are an excellent source of natural bioactive compounds, free of chemical contaminants and nutritious.

  18. An observational study of the effect of vibration on the caking of suspensions in oily vehicles.

    Science.gov (United States)

    Jain, Rohit; Bork, Olaf; Alawi, Fadil; Nanjan, Karthigeyan; Tucker, Ian G

    2016-11-30

    An oily suspension of penethamate (PNT) that was physically stable on storage, caked solidly during road/air transport. This paper reports on the caking behaviour of PNT oily suspension formulations exposed to vibrations in a lab-based test designed to simulate road/air transport. The lab-test was used to study the effects of container type (glass v PET) and formulation (oil, surfactant type and concentration) on the physical stability of suspension under vibration. Redispersibility of the sediment was lower at longer vibrations times and at higher intensity of vibration. Caking on vibration was strongly influenced by the type of container (caking in glass but not in PET) possibly due to tribo-charging of particles. Caking on vibration was dependent on the formulation: type and concentration of surfactant; type of oil. The physical stability of oily suspensions, and the effect of vibration are two areas which have been largely neglected in the pharmaceutical literature. This paper discusses some potential mechanisms for the observations but studies using fully characterised materials are required. Finally we conclude that static testing of physical stability of oily suspensions is not sufficient and that a vibrational stress test is required. Copyright © 2016 Elsevier B.V. All rights reserved.

  19. Physical and chemical composition and in situ degradability of macauba palm cake and leaves

    Directory of Open Access Journals (Sweden)

    Vanda Patrícia Barros Ferreira

    2013-12-01

    Full Text Available Macauba palm coconuts are rich in essential nutrients for animal feed formulation and after oil extraction, a large amount of residual biomass is produced, which must be used rationally to environmental preservation. This study aimed to determine the nutritional value of macauba palm (Acrocomia aculeata, cake and leaves, for its physical and chemical composition, dry matter (DM in vitro digestibility (IVD and in situ degradability. The test of in situ degradability was done using three rumen fistulated cattle. Analytical determinations were performed in the laboratory of Animal Nutrition of Instituto de Zootecnia, Nova Odessa-SP, Brazil. Six replicates were used for each analytical determination and were calculated the standard error. Macauba cake chemically assessed showed a low protein content (CP 4.5% and high content of acid detergent fibre (ADF 39.7% and average levels of neutral detergent fibre (NDF 52.5%. ADF and NDF were the macauba palm cake majority fractions compared NDF and ADF (respectively of cocoa cake (37.6 and 45.5%, sunflower cake (28.2 and 38.4%, corn meal (11.3 and 20.2% and peanut cake (15.4 and 21.0. Macauba palm leaves had a good protein content (12.0% and fiber content comparable to tropical grass of good nutritional value. They can be used with no restriction on ruminants’ diets. The macauba palm cake high levels of lignin (16.5% justify the low dry matter IVD percentage (48%, while the leaves had 58%.of IVD. Macauba leaves total digestible nutrients (TDN 59.0% is similar to TDN usually observed for forages. Macauba cake can be considered (TDN = 64.0% similar to energetic food, due to the fat content (6.4%, however the high content of lignin (16.5% can limit its consumption. Macauba palm cake showed high ruminal degradability of DM and CP (fraction a = 51.3 and 59.9, respectively, while macauba palm leaves hah low solubility of DM and CP (fraction a = 3.18 and 5.28, respectively. Thus, the higher CP macauba leaves

  20. Packing a cake into a box

    KAUST Repository

    Skopenkov, Mikhail

    2011-01-01

    Given a triangular cake and a box in the shape of its mirror image, how can the cake be cut into a minimal number of pieces so that it can be put into the box? The cake has icing, so we are not allowed to put it into the box upside down. V. G. Boltyansky asked this question in 1977 and showed that three pieces always suffice. In this paper we provide examples of cakes that cannot be cut into two pieces to be put into the box. This shows that three is the answer to Boltyansky's question. We also give examples of cakes which can be cut into two pieces. © THE MATHEMATICAL ASSOCIATION OF AMERICA.

  1. Packing a cake into a box

    KAUST Repository

    Skopenkov, Mikhail

    2011-05-01

    Given a triangular cake and a box in the shape of its mirror image, how can the cake be cut into a minimal number of pieces so that it can be put into the box? The cake has icing, so we are not allowed to put it into the box upside down. V. G. Boltyansky asked this question in 1977 and showed that three pieces always suffice. In this paper we provide examples of cakes that cannot be cut into two pieces to be put into the box. This shows that three is the answer to Boltyansky\\'s question. We also give examples of cakes which can be cut into two pieces. © THE MATHEMATICAL ASSOCIATION OF AMERICA.

  2. Simultaneous allergen inactivation and detoxification of castor bean cake by treatment with calcium compounds

    Directory of Open Access Journals (Sweden)

    K.V. Fernandes

    2012-11-01

    Full Text Available Ricinus communis L. is of great economic importance due to the oil extracted from its seeds. Castor oil has been used for pharmaceutical and industrial applications, as a lubricant or coating agent, as a component of plastic products, as a fungicide or in the synthesis of biodiesel fuels. After oil extraction, a castor cake with a large amount of protein is obtained. However, this by-product cannot be used as animal feed due to the presence of toxic (ricin and allergenic (2S albumin proteins. Here, we propose two processes for detoxification and allergen inactivation of the castor cake. In addition, we establish a biological test to detect ricin and validate these detoxification processes. In this test, Vero cells were treated with ricin, and cell death was assessed by cell counting and measurement of lactate dehydrogenase activity. The limit of detection of the Vero cell assay was 10 ng/mL using a concentration of 1.6 x 10(5 cells/well. Solid-state fermentation (SSF and treatment with calcium compounds were used as cake detoxification processes. For SSF, Aspergillus niger was grown using a castor cake as a substrate, and this cake was analyzed after 24, 48, 72, and 96 h of SSF. Ricin was eliminated after 24 h of SSF treatment. The cake was treated with 4 or 8% Ca(OH2 or CaO, and both the toxicity and the allergenic properties were entirely abolished. A by-product free of toxicity and allergens was obtained.

  3. Simultaneous allergen inactivation and detoxification of castor bean cake by treatment with calcium compounds

    Energy Technology Data Exchange (ETDEWEB)

    Fernandes, K.V.; Deus-de-Oliveira, N. [Laboratório de Química e Função de Proteínas e Peptídeos, Centro de Biociências e Biotecnologia, Universidade Estadual do Norte Fluminense Darcy Ribeiro, Rio de Janeiro, RJ (Brazil); Godoy, M.G. [Laboratório de Biotecnologia Microbiana, Instituto de Química, Universidade Federal do Rio de Janeiro, Rio de Janeiro, RJ (Brazil); Guimarães, Z.A.S. [Laboratório de Biologia Celular e Tecidual, Centro de Biociências e Biotecnologia, Universidade Estadual do Norte Fluminense Darcy Ribeiro, Rio de Janeiro, RJ (Brazil); Nascimento, V.V. [Laboratório de Química e Função de Proteínas e Peptídeos, Centro de Biociências e Biotecnologia, Universidade Estadual do Norte Fluminense Darcy Ribeiro, Rio de Janeiro, RJ (Brazil); Melo, E.J.T. de [Laboratório de Biologia Celular e Tecidual, Centro de Biociências e Biotecnologia, Universidade Estadual do Norte Fluminense Darcy Ribeiro, Rio de Janeiro, RJ (Brazil); Freire, D.M.G. [Laboratório de Biotecnologia Microbiana, Instituto de Química, Universidade Federal do Rio de Janeiro, Rio de Janeiro, RJ (Brazil); Dansa-Petretski, M.; Machado, O.L.T. [Laboratório de Química e Função de Proteínas e Peptídeos, Centro de Biociências e Biotecnologia, Universidade Estadual do Norte Fluminense Darcy Ribeiro, Rio de Janeiro, RJ (Brazil)

    2012-08-24

    Ricinus communis L. is of great economic importance due to the oil extracted from its seeds. Castor oil has been used for pharmaceutical and industrial applications, as a lubricant or coating agent, as a component of plastic products, as a fungicide or in the synthesis of biodiesel fuels. After oil extraction, a castor cake with a large amount of protein is obtained. However, this by-product cannot be used as animal feed due to the presence of toxic (ricin) and allergenic (2S albumin) proteins. Here, we propose two processes for detoxification and allergen inactivation of the castor cake. In addition, we establish a biological test to detect ricin and validate these detoxification processes. In this test, Vero cells were treated with ricin, and cell death was assessed by cell counting and measurement of lactate dehydrogenase activity. The limit of detection of the Vero cell assay was 10 ng/mL using a concentration of 1.6 × 10{sup 5} cells/well. Solid-state fermentation (SSF) and treatment with calcium compounds were used as cake detoxification processes. For SSF, Aspergillus niger was grown using a castor cake as a substrate, and this cake was analyzed after 24, 48, 72, and 96 h of SSF. Ricin was eliminated after 24 h of SSF treatment. The cake was treated with 4 or 8% Ca(OH){sub 2} or CaO, and both the toxicity and the allergenic properties were entirely abolished. A by-product free of toxicity and allergens was obtained.

  4. Potent Inhibition of Pseudogymnoascus destructans, the Causative Agent of White-Nose Syndrome in Bats, by Cold-Pressed, Terpeneless, Valencia Orange Oil.

    Science.gov (United States)

    Boire, Nicholas; Zhang, Sean; Khuvis, Joshua; Lee, Rick; Rivers, Jennifer; Crandall, Philip; Keel, M Kevin; Parrish, Nicole

    2016-01-01

    The causative agent of White-nose Syndrome (WNS), Pseudogymnoascus destructans, has been shown to be fatal to several species of bats in North America. To date, no compounds or chemical control measures have been developed which eliminates the growth of the fungus in the environment or in affected animals. In the current study, we evaluated the activity of cold-pressed, terpeneless orange oil (CPT) against multiple isolates of P. destructans in vitro. For all assays, a modified Kirby-Bauer disk diffusion assay was used. Standardized spore suspensions were prepared, adjusted to a specific optical density, and used to plate fungal lawns. Plates were incubated at either 15°C or 4°C for up to 6 months and checked at regular intervals for growth. Once controls had grown, zones of inhibition were measured (mm) on test plates and compared to those obtained using current antifungal drugs. All P. destructans isolates were completely inhibited by 100% CPT (10 μL) at 1 month of incubation regardless of temperature (4°C and 15°C). Complete inhibition persisted up to 6 months following a single exposure at this concentration. Of the standard antifungals, only amphotericin B demonstrated any activity, resulting in zone diameters ranging from 58 mm to 74 mm. CPT, at the highest concentration tested (100%), had no significant effect against a variety of other environmental organisms including various filamentous fungi, bacteria and aerobic actinomycetes. Given that CPT is relatively non-toxic, the possibility exists that the all-natural, mixture could be used as an environmental pre-treatment to eradicate P. destructans from bat habitats. Additional studies are needed to assess any undesirable effects of CPT on bat behavior and health and overall impacts on other members of the interconnected ecosystem(s).

  5. Potent Inhibition of Pseudogymnoascus destructans, the Causative Agent of White-Nose Syndrome in Bats, by Cold-Pressed, Terpeneless, Valencia Orange Oil.

    Directory of Open Access Journals (Sweden)

    Nicholas Boire

    Full Text Available The causative agent of White-nose Syndrome (WNS, Pseudogymnoascus destructans, has been shown to be fatal to several species of bats in North America. To date, no compounds or chemical control measures have been developed which eliminates the growth of the fungus in the environment or in affected animals. In the current study, we evaluated the activity of cold-pressed, terpeneless orange oil (CPT against multiple isolates of P. destructans in vitro. For all assays, a modified Kirby-Bauer disk diffusion assay was used. Standardized spore suspensions were prepared, adjusted to a specific optical density, and used to plate fungal lawns. Plates were incubated at either 15°C or 4°C for up to 6 months and checked at regular intervals for growth. Once controls had grown, zones of inhibition were measured (mm on test plates and compared to those obtained using current antifungal drugs. All P. destructans isolates were completely inhibited by 100% CPT (10 μL at 1 month of incubation regardless of temperature (4°C and 15°C. Complete inhibition persisted up to 6 months following a single exposure at this concentration. Of the standard antifungals, only amphotericin B demonstrated any activity, resulting in zone diameters ranging from 58 mm to 74 mm. CPT, at the highest concentration tested (100%, had no significant effect against a variety of other environmental organisms including various filamentous fungi, bacteria and aerobic actinomycetes. Given that CPT is relatively non-toxic, the possibility exists that the all-natural, mixture could be used as an environmental pre-treatment to eradicate P. destructans from bat habitats. Additional studies are needed to assess any undesirable effects of CPT on bat behavior and health and overall impacts on other members of the interconnected ecosystem(s.

  6. Cold pressed versus refined winterized corn oils: quality, composition and aroma; Aceites de maiz prensados en frío Vs. refinado y winterizado: calidad, composición y aroma

    Energy Technology Data Exchange (ETDEWEB)

    Aydeniz Güneşer, B.; Yılmaz, E.; Ok, S.

    2017-07-01

    The aims of this study were to characterize and compare cold pressed and fully refined winterized corn oils. Free fatty acidity (FFA), peroxide (PV) and p-anisidin (p-AV) values, saponification number, total carotenoid and phenolic contents of cold pressed corn oils were higher than that of the refined winterized corn oils. Linoleic and oleic acids (approximately 53-54% and 30-31%, respectively) were detected as the major fatty acids in both oil samples. Fifteen different sterols with a majority of β-sitosterol, campesterol, and stigmasterol were quantified in both oil samples. Although phenolic compounds were not quantified in the refined winterized oil samples, some flavonoids (hesperidin, rutin) and phenolic acids (gallic, syringic, rosmaniric and trans-ferulic) were detected in the cold pressed oil samples. This study concludes that cold pressed corn oils could be superior in terms of bioactive compounds but still need some quality improvements for sensory attributes. [Spanish] Los objetivos de este estudio fueron caracterizar y comparar los aceites de maíz prensados en frío y los totalmente winterizados y refinados. Los valores de acidez libre (FFA), peróxidos (PV) y p-anisidina (p-AV), índice de saponificación, contenido total de carotenoides y compuestos fenólicos de los aceites de maíz prensados en frío fueron superiores a los de los aceites de maíz refinados. Los ácidos linoleico y oleico (aproximadamente 53-54% y 30-31%, respectivamente) fueron los ácidos grasos mayoritarios en ambas muestras de aceite. Quince esteroles diferentes fueron cuantificados en ambos aceites siendo los mayoritarios β-sitosterol, campesterol y estigmasterol. Aunque los compuestos fenólicos no se cuantificaron en las muestras refinadas de aceites winterizados, se detectaron algunos flavonoides (hesperidina, rutina) y ácidos fenólicos (gálico, siríngico, rosmarínico y trans-ferúlico) en muestras de aceite prensado en frío. En este estudio se concluye que los

  7. Detoxification and anti-nutrients reduction of Jatropha curcas seed cake by Bacillus fermentation.

    Science.gov (United States)

    Phengnuam, Thanyarat; Suntornsuk, Worapot

    2013-02-01

    Jatropha curcas seed cake is a by-product generated from oil extraction of J. curcas seed. Although it contains a high amount of protein, it has phorbol esters and anti-nutritional factors such as phytate, trypsin inhibitor, lectin and saponin. It cannot be applied directly in the food or animal feed industries. This investigation was aimed at detoxifying the toxic and anti-nutritional compounds in J. curcas seed cake by fermentation with Bacillus spp. Two GRAS (generally recognized as safe) Bacillus strains used in the study were Bacillus subtilis and Bacillus licheniformis with solid-state and submerged fermentations. Solid-state fermentation was done on 10 g of seed cake with a moisture content of 70% for 7 days, while submerged fermentation was carried out on 10 g of seed cake in 100 ml distilled water for 5 days. The fermentations were incubated at the optimum condition of each strain. After fermentation, bacterial growth, pH, toxic and anti-nutritional compounds were determined. Results showed that B. licheniformis with submerged fermentation were the most effective method to degrade toxic and anti-nutritional compounds in the seed cake. After fermentation, phorbol esters, phytate and trypsin inhibitor were reduced by 62%, 42% and 75%, respectively, while lectin could not be eliminated. The reduction of phorbol esters, phytate and trypsin inhibitor was related to esterase, phytase and protease activities, respectively. J. curcas seed cake could be mainly detoxified by bacterial fermentation and the high-protein fermented seed cake could be potentially applied to animal feed. Copyright © 2012 The Society for Biotechnology, Japan. Published by Elsevier B.V. All rights reserved.

  8. Moisture-induced caking of beverage powders.

    Science.gov (United States)

    Chávez Montes, Edgar; Santamaría, Nadia Ardila; Gumy, Jean-Claude; Marchal, Philippe

    2011-11-01

    Beverage powders can exhibit caking during storage due to high temperature and moisture conditions, leading to consumer dissatisfaction. Caking problems can be aggravated by the presence of sensitive ingredients. The caking behaviour of cocoa beverage powders, with varying amounts of a carbohydrate sensitive ingredient, as affected by climate conditions was studied in this work. Sorption isotherms of beverage powders were determined at water activities (a(w) ) ranging from 0.1 to 0.6 in a moisture sorption analyser by gravimetry and fitted to the Brunauer-Emmett-Teller (BET) or the Guggenheim-Anderson-de Boer (GAB) equation. Glass transition temperatures (T(g) ) at several a(w) were analysed by differential scanning calorimetry and fitted to the Gordon-Taylor equation. Deduced T(g) = f(a(w) ) functions helped to identify stability or caking zones. Specific experimental methods, based on the analysis of mechanical properties of powder cakes formed under compression, were used to quantify the degree of caking. Pantry tests complemented this study to put in evidence the visual perception of powder caking with increasing a(w) . The glass transition approach was useful to predict the risks of caking but was limited to products where T(g) can be measured. On the other hand, quantification of the caking degree by analysis of mechanical properties allowed estimation of the extent of degradation for each product. This work demonstrated that increasing amounts of a carbohydrate sensitive ingredient in cocoa beverages negatively affected their storage stability. Copyright © 2011 Society of Chemical Industry.

  9. Optimization of suspensions filtration with compressible cake

    Directory of Open Access Journals (Sweden)

    Janacova Dagmar

    2016-01-01

    Full Text Available In this paper there is described filtering process for separating reaction mixture after enzymatic hydrolysis to process the chromium tanning waste. Filtration of this mixture is very complicated because it is case of mixture filtration with compressible cake. Successful process strongly depends on mathematical describing of filtration, calculating optimal values of pressure difference, specific resistant of filtration cake and temperature maintenance which is connected with viscosity change. The mathematic model of filtration with compressible cake we verified in laboratory conditions on special filtration device developed on our department.

  10. Mineralogical characterization of uranium yellow cake concentrates

    International Nuclear Information System (INIS)

    Hausen, D.M.

    1992-01-01

    Uranium yellow cake concentrates have been analyzed and characterized mineralogically by means of differential thermal analysis, X-ray diffraction, infrared spectra and wet chemical methods. On the basis of mineralogical methods of characterization, the following four major structural types of yellow cake may be classified: Uranyl Hydroxide Hydrate, UO 2 (OH) 2 nH 2 O; Basic Uranyl Sulfate Hydrate, (UO 2 ) x (SO 4 ) y (OH) s(x-y ).nH 2 O; Sodium Para-Uranate, Na 5 U 7 O 24 and Uranyl Peroxide Hydrate, UO 4 .nH 2 O. In this paper conditions of yellow cake preparation and characterization are described, along with discussion of significance of structural types to the physical and chemical properties of yellow cake production

  11. Wafer Cakes of Improved Amino Acid Structure

    Directory of Open Access Journals (Sweden)

    Roksolana Boidunyk

    2017-11-01

    Full Text Available The article presents the results of the study of the amino acid composition of newly developed wafer cakes with adipose fillings combined with natural additives. The appropriateness of the using non-traditional raw materials (powder of willow herb, poppy oilcake, carob, as well as skimmed milk powder in order to increase the biological value of wafer cakes and improve their amino acid composition is proven.

  12. EFISIENSI PENGGUNAAN TELUR DALAM PEMBUATAN SPONGE CAKE

    OpenAIRE

    Ida Ayu Putu Hemy Ekayani

    2011-01-01

    Penelitian ini bertujuan untuk membuat kue berpori (spong cake) dengan kualitas baik  dengan menggunakan jumlah telur minimal yang dibantu dengan penggunaan baking powder secara optimal untuk menurunkan biaya produksi yang disebabkan oleh mahalnya harga telur. Penelitian ini merupakan penelitian laboratorium (eksperimen). Analisis data dilakukan secara deskriptif. Hasil penelitian menunjukkan bahwa kualitas sponge cake terbaik dihasilkan dari dua variasi rancangan variasi kadar baking powder ...

  13. Extraction and purification of yellow cake

    International Nuclear Information System (INIS)

    Yousif, E.H.

    2006-01-01

    This dissertation has reviewed current studies on production and purification of yellow cake from uranium ores by both acid and alkaline leaching processes. It comprises three chapters, the first one deal with uranium minerals, uranium deposits, geology of uranium and uranium isotopes. The second chapter covers mining and milling methods, uranium leaching chemistry, precipitation, and purification of uranium concentrate by solvent extraction and possible impurities that commonly interfered with yellow cake. The last chapter presented ongoing literature review.(Author)

  14. Pengaruh Pengurangan Kadar Air dan Penggunaan Bahan Pengikat Kadar Air dalam Pembuatan Cake Bengkuang

    Directory of Open Access Journals (Sweden)

    Wilsa Hermianti

    2016-12-01

    Full Text Available Yam contains a high water content ranging from 86-90% therefore when be processed to be a product such as cake will also result a high water content and cause the product is not durable. By the nature characteristics of the yam was then made utilization efforts became yam cake in order to develop yam processing, increase value added, and diversify food processing based on raw materials of local potential in Padang City. Yam can be used by processing them into a semi wet food such as cake with a dominant amount of yam up to 50% of the cake batter, but only had a shelf life for 3 days. To increase the shelf-life study was carried out water content reduction of raw materials and using of a binder in the making of yam cake. The treatment of water content reduction of yam was done using juicer and pressing. A comparison as a control was performed without reduction of water content. The use of water content binder was conducted with the addition of coconut, cornstarch, and rice flour. Yam cake formulas using binder of water content  with cornstarch and reduction the water content of raw material by pressing showed optimal results with a preferred value of organoleptic panelist, the water content 28.50%, carbohydrate 56.31%, protein 6.13%, fat 10.23%, energy 341.86 kcal/100g, dietary fiber 5.98%, calcium 27.77 mg/100g, and 5.92% inulin, storability for 5 days at room temperature and 4 weeks at refrigerator temperature.ABSTRAKBengkuang mengandung kadar air yang tinggi berkisar 86-90% sehingga jika diolah untuk menjadi produk berupa cake akan memberikan kadar air yang juga tinggi dan menyebabkan produk menjadi tidak tahan lama. Dengan sifat alami bengkuang tersebut maka dilakukan upaya pemanfaatannya menjadi cake bengkuang dalam rangka pengembangan olahan dari bengkuang, peningkatan nilai tambah, dan diversifikasi olahan pangan berbasis bahan baku lokal yang cukup potensi di kota Padang. Bengkuang dapat dimanfaatkan dengan mengolahnya menjadi pangan

  15. Press Start

    Science.gov (United States)

    Harteveld, Casper

    This level sets the stage for the design philosophy called “Triadic Game Design” (TGD). This design philosophy can be summarized with the following sentence: it takes two to tango, but it takes three to design a meaningful game or a game with a purpose. Before the philosophy is further explained, this level will first delve into what is meant by a meaningful game or a game with a purpose. Many terms and definitions have seen the light and in this book I will specifically orient at digital games that aim to have an effect beyond the context of the game itself. Subsequently, a historical overview is given of the usage of games with a serious purpose which starts from the moment we human beings started to walk on our feet till our contemporary society. It turns out that we have been using games for all kinds of non-entertainment purposes for already quite a long time. With this introductory material in the back of our minds, I will explain the concept of TGD by means of a puzzle. After that, the protagonist of this book, the game Levee Patroller, is introduced. Based on the development of this game, the idea of TGD, which stresses to balance three different worlds, the worlds of Reality, Meaning, and Play, came into being. Interested? Then I suggest to quickly “press start!”

  16. From Baking a Cake to Solving the Schrodinger Equation

    OpenAIRE

    Olszewski, Edward A.

    2005-01-01

    The primary emphasis of this study has been to explain how modifying a cake recipe by changing either the dimensions of the cake or the amount of cake batter alters the baking time. Restricting our consideration to the genoise, one of the basic cakes of classic French cuisine, we have obtained a semi-empirical formula for its baking time as a function of oven temperature, initial temperature of the cake batter, and dimensions of the unbaked cake. The formula, which is based on the Diffusion e...

  17. Preparation of food supplements from oilseed cakes.

    Science.gov (United States)

    Sunil, L; Appaiah, Prakruthi; Prasanth Kumar, P K; Gopala Krishna, A G

    2015-05-01

    Oilseed cakes have been in use for feed preparation. Being rich in proteins, antioxidants, fibers, vitamins and minerals, oilseed cakes have been considered ideal for food supplementation. These oilseed cakes can be processed and made more palatable and edible by suitable treatments and then incorporated as food supplements for human consumption. Rice bran pellets (RBP), stabilized rice bran (SRB), coconut cake (CC) and sesame cake (SC) were taken up for the study. These were mixed with distilled water and cooked in such a way to separate the cooked solid residue and liquid extract followed by freeze drying to get two products from each. The raw, cooked dried residue and extract were analyzed for various parameters such as moisture (0.9-27.4 %), fat (2.1-16.1 %), ash (3.3-9.0 %), minerals (2.6-633.2 mg/100 g), total dietary fiber (23.2-58.2 %), crude fiber (2.7-10.5 %), protein (3.2-34.0 %), and the fat further analyzed for fatty acid composition, oryzanol (138-258 mg/100 g) and lignan (99-113 mg/100 g) contents and also evaluated sensory evaluation. Nutritional composition of products as affected by cooking was studied. The cooked products (residue and extract) showed changes in nutrients content and composition from that of the starting cakes and raw materials, but retained more nutrients in cooked residue than in the extract. The sensory evaluation of cooked residue and extract showed overall higher acceptability by the panelists than the starting cakes and raw materials. On the basis of these findings it can be concluded that these cooked residue and extract products are highly valuable for food supplementation than the raw ones.

  18. Quality of products containing defatted groundnut cake flour.

    Science.gov (United States)

    Purohit, Chitra; Rajyalakshmi, Peram

    2011-02-01

    Defatted groundnut cake obtained from commercial oil processing units and that prepared in laboratory oil expeller (LOE) were analyzed for quality parameters. Defatted groundnut cake flour (DGCF) was incorporated at 15-100% levels in laddoo, chutney powder, fryums (deep fried crisp and crunchy item), biscuits, noodles and extruded snacks. The products were studied for sensory, physico-chemical and shelf-life quality. DGCF was creamish white with bulk density of 0.55 ± 0.03 g/ml, water absorption capacity 135.6 ± 1.97 ml %, oil absorption capacity 100.3 ± 1.16 ml % and foam capacity 33 ± 1%. Protein, fat and ash contents were 51.6 ± 0.06, 4.5 ± 0.05 and 4.2 ± 0.11%, respectively. Tannins and aflatoxin B1 were not detected. The increase of protein due to incorporation of DGCF into the products ranged from 5.5 to 21.9%. Shelf-life studies indicated the maximum storability for 90 days for all the products except laddoo, which could be stored for 30 days at ambient temperature (28 ± 2°C). All the products were acceptable and the order of preference for the products as indicated by adults (fryums, chutney powder, extruded snacks, noodles, biscuits and laddoo) and children (biscuits, laddoo, extruded snacks, fryums, noodles and chutney powder) varied.

  19. Recovery of low temperature heat in oil mills

    Directory of Open Access Journals (Sweden)

    Carré Patrick

    2012-11-01

    Full Text Available Energy consumption in oil mills is a major item of costs and a sensitive point in the production of biofuels. To improve their performance, industrials can recover lowtemperature heat thanks to a new technology of heat exchangers suitable for treating granular solid materials. Information about the energy requirements of the rapeseed crushing being not readily available, the article gives a detailed assessment of consumption items (per ton of seed: 263 MJ for preparation operations and 284 MJ for solvent extraction. These exchangers used as pre-conditioners saves about 55 MJ.t−1 of heat by use of steam condensates. We could go further in use of these devices on the one hand to recover heat from press cake and meal, and secondly to use recovered energy to dry and warm up the seeds before pre-pressing. In this configuration, the energy savings could reach 38% of current needs.

  20. Chemical composition and resistance to oxidation of high-oleic rapeseed oil pressed from microwave pre-treated intact and de-hulled seeds

    International Nuclear Information System (INIS)

    Rękas, A.; Wroniak, M.; Siger, A.; Ścibisz, I.

    2017-01-01

    The influence of a microwave (MV) pre-treatment (3, 6, 9 min, 800W) on the physicochemical properties of high-oleic rapeseed oil prepared from intact (HORO) and de-hulled seeds (DHORO) was investigated in this study. A control DHORO contained higher levels of total tocopherols and carotenoids, while higher concentrations of total phenolic compounds and chlorophylls were detected in the HORO. The MV pre-treatment caused a decrease in the unsaturated fatty acids content that was more evident for the DHOROs. The microwaving time significantly affected phytochemical contents and the color of both types of oils. A vast increase in canolol concentration was noticeable following 9 min of microwaving, which increased 506- and 155-fold in the HORO and DHORO, respectively. At the same time, the antioxidant capacity of oil produced from MV pre-treated seeds for 9 min was nearly 4 times higher than that of the control oil for both types of oils. [es

  1. Toxic compound, anti-nutritional factors and functional properties of protein isolated from detoxified Jatropha curcas seed cake.

    Science.gov (United States)

    Saetae, Donlaporn; Suntornsuk, Worapot

    2010-12-28

    Jatropha curcas is a multipurpose tree, which has potential as an alternative source for biodiesel. All of its parts can also be used for human food, animal feed, fertilizer, fuel and traditional medicine. J. curcas seed cake is a low-value by-product obtained from biodiesel production. The seed cake, however, has a high amount of protein, with the presence of a main toxic compound: phorbol esters as well as anti-nutritional factors: trypsin inhibitors, phytic acid, lectin and saponin. The objective of this work was to detoxify J. curcas seed cake and study the toxin, anti-nutritional factors and also functional properties of the protein isolated from the detoxified seed cake. The yield of protein isolate was approximately 70.9%. The protein isolate was obtained without a detectable level of phorbol esters. The solubility of the protein isolate was maximal at pH 12.0 and minimal at pH 4.0. The water and oil binding capacities of the protein isolate were 1.76 g water/g protein and 1.07 mL oil/g protein, respectively. The foam capacity and stability, including emulsion activity and stability of protein isolate, had higher values in a range of basic pHs, while foam and emulsion stabilities decreased with increasing time. The results suggest that the detoxified J. curcas seed cake has potential to be exploited as a novel source of functional protein for food applications.

  2. Toxic Compound, Anti-Nutritional Factors and Functional Properties of Protein Isolated from Detoxified Jatropha curcas Seed Cake

    Directory of Open Access Journals (Sweden)

    Worapot Suntornsuk

    2010-12-01

    Full Text Available Jatropha curcas is a multipurpose tree, which has potential as an alternative source for biodiesel. All of its parts can also be used for human food, animal feed, fertilizer, fuel and traditional medicine. J. curcas seed cake is a low-value by-product obtained from biodiesel production. The seed cake, however, has a high amount of protein, with the presence of a main toxic compound: phorbol esters as well as anti-nutritional factors: trypsin inhibitors, phytic acid, lectin and saponin. The objective of this work was to detoxify J. curcas seed cake and study the toxin, anti-nutritional factors and also functional properties of the protein isolated from the detoxified seed cake. The yield of protein isolate was approximately 70.9%. The protein isolate was obtained without a detectable level of phorbol esters. The solubility of the protein isolate was maximal at pH 12.0 and minimal at pH 4.0. The water and oil binding capacities of the protein isolate were 1.76 g water/g protein and 1.07 mL oil/g protein, respectively. The foam capacity and stability, including emulsion activity and stability of protein isolate, had higher values in a range of basic pHs, while foam and emulsion stabilities decreased with increasing time. The results suggest that the detoxified J. curcas seed cake has potential to be exploited as a novel source of functional protein for food applications.

  3. From baking a cake to solving the diffusion equation

    Science.gov (United States)

    Olszewski, Edward A.

    2006-06-01

    We explain how modifying a cake recipe by changing either the dimensions of the cake or the amount of cake batter alters the baking time. We restrict our consideration to the génoise and obtain a semiempirical relation for the baking time as a function of oven temperature, initial temperature of the cake batter, and dimensions of the unbaked cake. The relation, which is based on the diffusion equation, has three parameters whose values are estimated from data obtained by baking cakes in cylindrical pans of various diameters. The relation takes into account the evaporation of moisture at the top surface of the cake, which is the dominant factor affecting the baking time of a cake.

  4. Pyrolysis of Waste Castor Seed Cake: A Thermo-Kinetics Study

    Directory of Open Access Journals (Sweden)

    Abdullahi Muhammad Sokoto

    2018-03-01

    Full Text Available Biomass pyrolysis is a thermo-chemical conversion process that is of both industrial and ecological importance. The efficient chemical transformation of waste biomass to numerous products via pyrolysis reactions depends on process kinetic rates; hence the need for kinetic models to best design and operate the pyrolysis. Also, for an efficient design of an environmentally sustainable pyrolysis process of a specific lignocellulosic waste, a proper understanding of its thermo-kinetic behavior is imperative. Thus, pyrolysis kinetics of castor seed de-oiled cake (Ricinus communis using thermogravimetric technique was studied. The decomposition of the cake was carried out in a nitrogen atmosphere with a flow rate of 100mL min-1 from ambient temperature to 900 °C. The results of the thermal profile showed moisture removal and devolatilization stages, and maximum decomposition of the cake occurred at a temperature of 200-400 °C. The kinetic parameters such as apparent activation energy, pre-exponential factor, and order of reaction were determined using Friedman (FD, Kissinger-Akahira-Sunose (KAS, and Flynn-Wall-Ozawa (FWO kinetic models. The average apparent activation energy values of 124.61, 126.95 and 129.80 kJmol-1 were calculated from the slopes of the respective models. The apparent activation energy values obtained depends on conversion, which is an evidence of multi-step kinetic process during the pyrolytic decomposition of the cake. The kinetic data would be of immense benefit to model, design and develop a suitable thermo-chemical system for the conversion of waste de-oil cake to energy carrier.

  5. Property Assessment of Sponge Cake Added with Egg Replacer

    OpenAIRE

    Yaqiang He; Linlin Wang; Qian Lu

    2015-01-01

    Chicken egg which is always used in sponge cake production is likely to deteriorate during storage or transportation. This weakness prevents the wide use of chicken egg in sponge cake making. In order to solve this problem, egg replacer has been developed. In this study, effect of egg replacer on the property of sponge cake was analyzed. The result indicated egg replacer could improve the yield rate and specific volume of sponge cake. However, high content of egg replacer would negatively imp...

  6. Évaluation de l’impact de 6 matières grasses (palme et non-palme) sur les caractéristiques instrumentales et sensorielles d’une matrice de type cake

    OpenAIRE

    Delacharlerie, Sophie; Poncelet, Céline; Chèné, Christine; Sindic, Marianne

    2012-01-01

    Six types of fats (oils, shortenings and margarines) from different vegetable (hydrogenated or not) or animal origins have been studied in a cake model. Cakes have been characterized through Texture Profile Analysis and sensory evaluation. Texture analysis shows that studied fats can be classified in two main categories, giving different texture characteristics: liquid oils on one hand and fats containing a solid fraction on the other. Descriptive sensory evaluation leads to th...

  7. Biodegradation of shea nut cake by indigenous soil bacteria ...

    African Journals Online (AJOL)

    Yeast extracts enhanced growth. Pseudomanas strain G9 degraded 71.25% shea nut cake, while Pseudomonas strain G38 degraded 50.35% shea nut cake within 48 h. Pseudomonas G9 can be used to degrade shea nut cake. G9 and G38 are different species of Pseudomonas and molecular typing such as PCR can be ...

  8. Investigation of the structure of filter cakes from bore flushing

    Energy Technology Data Exchange (ETDEWEB)

    Hartmann, A; Oezerler, M; Marx, C; Hartmann, A; Oezerler, M; Marx, C; Poege, S; Young, F

    1985-01-01

    After a description of the tasks and functions of the filter cake in bores, the requirements for filter cakes are explained. The aim of the investigation is finding a correlation between the filter cake structures and the prehistory of flushing. The technique of preparing the samples and previous results from investigations with electron microscopes are introduced and discussed.

  9. First results of the CAKE experiment

    International Nuclear Information System (INIS)

    Chiarusi, T.; Bottazzi, E.; Cecchini, S.; Di Ferdinando, D.; Giacomelli, G.; Kumar, A.; Patrizii, L.; Togo, V.; Valieri, C.

    2003-01-01

    We present the preliminary results of the cosmic abundances below the knee energies (CAKE) experiment for the study of the primary cosmic-ray composition and for the search of exotic particles in the primary cosmic radiation. CAKE uses CR39[reg] and Lexan nuclear track detectors, which were calibrated with beams of 158 A GeV Pb ions and 1 A GeV Fe ions at the CERN and BNL accelerators, respectively. Results based on the analysis of a first data sample are shown

  10. First results of the CAKE experiment

    CERN Document Server

    Chiarusi, T; Cecchini, S; Di Ferdinando, D; Giacomelli, G; Kumar, A; Patrizii, L; Togo, V; Valieri, C

    2003-01-01

    We present the preliminary results of the cosmic abundances below the knee energies (CAKE) experiment for the study of the primary cosmic- ray composition and for the search of exotic particles in the primary cosmic radiation. CAKE uses CR39** registered trademark and Lexan nuclear track detectors, which were calibrated with beams of 158 A Ge V Pb ions and 1 A GeV Fe ions at the CERN and BNL accelerators, respectively. Results based on the analysis of a first data sample are shown.

  11. Use of palm kernel cake for animal feed

    Directory of Open Access Journals (Sweden)

    Kuprasert, S.

    2001-11-01

    Full Text Available Palm kernel cake (PKC, a by-product from the palm-oil industry, has the potential for use as a feed ingredient. Crude protein, fiber and metabolizable energy contents of PKC are 12-18%, 18-13% and 1,940- 2,490 kcal/kg, respectively. Availability of amino acid in PKC are approximately 60-70% for chickens and 65-70% for pigs. With fat supplementation, PKC can be used up to 20% in broiler diet and can be increased to 30-40% with further addition of methionine and lysine. For the diets of pullets and laying hen, PKC can be used 30% and 20% respectively if supplemented with fat, methionine and lysine. PKC can be used 30% in diet for grower (30-60 kg and 50% in diet for finisher pigs (60-90 kg., respectively, if supplemented with lysine and cane molasses.

  12. Antifungal activity of olive cake extracts

    OpenAIRE

    Ghandi H. Anfoka; Khalil I. Al-Mughrabi; Talal A. Aburaj; Wesam Shahrour

    2001-01-01

    Powdered, dried olive (Olea europaea) cake was extracted with hexane, methanol and butanol. Six phenolic compounds, coumaric acid, ferulic acid, oleuropein, caffeic acid, protocatechuic acid and cinnamic acid, were isolated from these extracts after fractionation. The fractions were tested for their antifungal activity against Verticillium sp., Fusarium oxysporum, Rhizopus sp., Penicillium italicum, Rhizoctonia solani, Stemphylium solani, Cladosporium sp., Mucor sp., Colletotrichu...

  13. EFISIENSI PENGGUNAAN TELUR DALAM PEMBUATAN SPONGE CAKE

    Directory of Open Access Journals (Sweden)

    Ida Ayu Putu Hemy Ekayani

    2011-07-01

    Full Text Available Penelitian ini bertujuan untuk membuat kue berpori (spong cake dengan kualitas baik  dengan menggunakan jumlah telur minimal yang dibantu dengan penggunaan baking powder secara optimal untuk menurunkan biaya produksi yang disebabkan oleh mahalnya harga telur. Penelitian ini merupakan penelitian laboratorium (eksperimen. Analisis data dilakukan secara deskriptif. Hasil penelitian menunjukkan bahwa kualitas sponge cake terbaik dihasilkan dari dua variasi rancangan variasi kadar baking powder dan telur yakni resep pertama dengan formulasi tepung terigu 100 gram, baking powder 6 gram, telur 100 gram, lemak 75 gram, dan tanpa penambahaan air; dan resep ke dua dengan formulasi tepung terigu 100 gram, baking powder 2 gram, telur 80 gram, lemak 75 gram, dan air 16 gram. Jumlah telur yang digunakaan dalam kedua resep tersebut cukup jauh berkurang dari resep umum yang menggunakan 180 gram telur untuk 100 gram tepung terigu. Temuan penelitian ini akan berimplikasi pada sponge cake dengan harga yang lebih murah, tetapi dengan kualitas yang tetap relatif baik dapat dihadirkan ke pasar.   Kata-kata kunci: spong cake,  kualitas, baking powder, biaya produksi

  14. Indirect Revelation Mechanisms for Cake Cutting

    DEFF Research Database (Denmark)

    Branzei, Simina; Miltersen, Peter Bro

    We consider discrete protocols for the classical Steinhaus cake cutting problem. Under mild technical conditions, we show that any deterministic strategy-proof protocol in the standard Robertson-Webb query model is dictatorial, that is, there is a fixed agent to which the protocol allocates...

  15. Making the yellow cake go round

    International Nuclear Information System (INIS)

    1969-01-01

    'Yellow cake' is the name given to uranium oxide (U 3 O 8 ) by the mining profession. Ore containing about a million tons of it and capable of processing at reasonable cost has to be found by 1980 if reserves are to be kept in balance. Many areas of the world are favourable for exploration and experts are confident that additional resources exist. (author)

  16. A Dictatorship Theorem for Cake Cutting

    DEFF Research Database (Denmark)

    Branzei, Simina; Miltersen, Peter Bro

    2015-01-01

    We consider discrete protocols for the classical Steinhaus cake cutting problem. Under mild technical conditions, we show that any deterministic strategy-proof protocol in the standard Robertson-Webb query model is dictatorial, that is, there is a fixed agent to which the protocol allocates the e...

  17. Gravimetric Analysis of Uranium in Yellow Cake

    International Nuclear Information System (INIS)

    Srinuttrakul, Wannee; Jantha, Suwat

    2007-08-01

    Full text: The gravimetric analysis of uranium in yellow cake is composed of several stages. The analysis takes a long time, which is the disadvantage of this method. However, this gravimetric method provides accurate result for determining the major content of sample. Uranium is the main composition of yellow cake, while Thorium, rare earths and other elements are minor and trace elements. In this work, anion exchange resin was used to separate uranium from other elements to yield highly pure uranium suitable for precipitation. This pure uranium was burnt to U3O8, a form that is stable enough to be weighed. From the optimal condition, the recovery of U3O8 after separating uranium from rare earths and iron is 99.85 ± 0.21%. The application of anion exchange separation was used to analyze uranium in yellow cake obtained from monazite digestion process. It was found that U3O8 in yellow cake is 78.85 ± 2.03%

  18. Temperature dependence of refractive index and of electrical impedance of grape seed (Vitis vinifera, Vitis labrusca) oils extracted by Soxhlet and mechanical pressing

    OpenAIRE

    Vieira, D. S.; Menezes, M.; Gonçalves, G.; Mukai, H.; Lenzi, E. K.; Pereira, N. C.; Fernandes, P. R.G.

    2015-01-01

    In this report, the temperature dependence of the refractive index and electric impedance of vegetable oil grape seeds extracted from Vitis vinifera (v. Cabernet) and Vitis labrusca (v. Bordo) are investigated by means of experimental techniques. The seeds were collected from wineries located in two cities in the south of Brazil. In both extraction methods, the seeds were dried at 40.0 °C and at 80.0 °C, respectively, before the oil extraction. From optical microscopy and refractometry result...

  19. [Investigation of the effect of oil and flour from wheat germ meal on lipid metabolism of students and teachers of the university].

    Science.gov (United States)

    Rodionova, N S; Isaev, V A; Vishnyakov, A B; Popov, E S; Safonova, N V; Srorublyovtsev, S A

    2016-01-01

    The results of investigation of alimentary correction of lipid metabolism under the admin­istration of processed products from wheat germ - oil (with the content of policosanol at least 1.5-8.0 mg/100 g, vitamin E - 180-200 mg/100 g, PUFA - 60-65%) and cake flour (with the content of protein - 30-35%, oil with analogue composition -5-7%, digestible carbohydrates - 45-47%, fiber - 18-26%, vitamins B1, B3, B6, B9, E, PP, minerals and trace elements - Zn, Mn, K, Fe, Se, P) are presented. Volunteers among teachers and students of the university aged 16 to 65 years daily consumed wheat germ oil obtained by cold pressing in an amount of 3.5 g, regardless of the meal within 30 days. Then a part of them (30 persons) consumed daily 50 g of oil cake obtained after pressing oil, which provided the intake of the same amount of oil (3.5 g). Lipid metabolism param­eters were monitored in experiment participants before receiving the processed products of wheat germ, after germ meal intake and beyond 30 and 60 days after consumption of wheat germ. Data analysis was carried out on three age groups: 16-24, 25-44 and 45- 65 years. All participants of the experiment showed a reduction in total cholesterol level by 6-8%, increasing the concentration of HDL cholesterol by 3-24%, lowering LDL cholesterol concentrations by 4-21%, reduction of triglyceride concentration by 12-24%, a positive correction of atherogenic factor values by for 10-25%. Prolonged action of the investigated foods was established: lipid metabolism parameters in the tested group were better than in the control group after 30 days of intake discontinuation of oil or wheat germ flour, the positive adjustment effect disappeared 60 days after consuming the products. The findings demonstrate a positive effect on the normalization of lipid metabolism when cake flour of wheat germ was administered in daily food ration, similar to the effect of oil intake, which is important for the prevention of cardiovascular diseases

  20. PEMANFAATAN TEPUNG SINGKONG SEBAGAI SUBSTITUSI TERIGU UNTUK VARIASI CAKE

    Directory of Open Access Journals (Sweden)

    Risa Panti Ariani

    2016-08-01

    Full Text Available Abstrak Tujuan penelitian ini untuk memperoleh variasi cake dari tepung singkong dengan mensubstitusi terigu. Karena terigu merupakan produk impor olahan dari gandum, sebagai usaha mendukung peningkatan ketahanan pangan. Penelitian ini menggunakan metode penelitian eksperimental semu di laboratorium karena keterbatasan untuk mengontrol semua variabel yang relevan. Instrumen pengumpulan data menggunakan lembar observasi untuk memperoleh data uji kualitas dari panelis terlatih, sedangkan data uji selera diperoleh dari masyarakat umum untuk mengetahui keberterimaan variasi cake singkong. Analisis data penelitian dilakukan secara deskriptif kualitatif. Hasil penelitian memperoleh kualitas cake singkong pada kriteria yang sempurna pada, (a pound cake dengan substitusi 80% bahan utama, (b roll cake dengan substitusi 100% bahan utama, tetapi kualitas tekstur terendah, (c chiffon cake dengan substitusi 100% bahan utama, serta pengembangan (volume maksimal, (d bolu kukus dengan substitusi 80% bahan utama, tetapi kualitas aroma terendah, (e sponge cake dengan substitusi 80% bahan utama, tetapi semua kriteria terendah, (f brownies dengan substitusi 100% bahan utama, serta semua kriteria tertinggi, (g fruit cake menggunakan buah-buahan lokal dengan substitusi 100% bahan utama, serta semua kriteria tertinggi, dan (g rainbow cake dengan substitusi 100% bahan utama, tetapi kualitas tekstur terendah. Secara umum keberterimaan masyarakat sangat menyukai variasi cake singkong, tetapi sponge cake dan rainbow cake memperoleh keberterimaan terendah. Dengan demikian 8 jenis cake dapat menggunakan tepung singkong sebagai substitusi terigu untuk mendukung peningkatan ketahanan pangan. Kata kunci: tepung singkong, variasi cake, substitusi terigu Abstract The purpose of this study to obtain a cake variation of substituting wheat with cassava flour. Because wheat is imported products processed from wheat, in an effort to support increased food security. This study uses a

  1. DPPH radical scavenging activity of a mixture of fatty acids and peptide-containing compounds in a protein hydrolysate of Jatropha curcas seed cake.

    Science.gov (United States)

    Phengnuam, Thanyarat; Goroncy, Alexander K; Rutherfurd, Shane M; Moughan, Paul J; Suntornsuk, Worapot

    2013-12-04

    Jatropha curcas, a tropical plant, has great potential commercial relevance as its seeds have high oil content. The seeds can be processed into high-quality biofuel producing seed cake as a byproduct. The seed cake, however, has not gotten much attention toward its potential usefulness. This work was aimed to determine the antioxidant activity of different fractions of a protein hydrolysate from J. curcas seed cake and to elucidate the molecular structures of the antioxidants. Seed cake was first processed into crude protein isolate and the protein was hydrolyzed by Neutrase. The hydrolysate obtained from 1 h of Neutrase hydrolysis showed the strongest antioxidant activity against DPPH radical (2,2-diphenyl-1-picrylhydrazyl). After a purification series of protein hydrolysate by liquid chromatography, chemicals acting as DPPH radical inhibitors were found to be a mixture of fatty acids, fatty acid derivatives, and a small amount of peptides characterized by mass spectrometry and nuclear magnetic resonance (NMR) spectroscopy.

  2. Enumeration, identification and decontamination of microorganisms on empty fruit bunches (EFB) and palm press fibre (PPF) from selected palm oil mills in the Peninsular Malaysia

    International Nuclear Information System (INIS)

    Foziah Ali; Muhammad Lebai Juri; Mat Rasol Awang

    1998-01-01

    The PPF and EFB temporarily disposed into the environment at the mill are heavily contaminated with micro-organisms, therefore require decontamination prior to utilisation. The current methods for decontaminating PPF and EFB has been briefly reviewed (Mat Rasol et. al.,1987). They suggested that these by-products can be effectively decontaminated by gamma-irradiation and the resulting sterilised by-products could subsequently be used for conversion into animals feeds by fermentation with fungi or chemical stock. The primary objectives of the investigation are: a) to enumerate contaminating microorganisms on PPF and EFB collected from various oil palm mills in the Peninsular Malaysia, and b) to establish the inactivation curves of the PPF and EFB from the selected palm oil mills

  3. Optimization and validation of a method using UHPLC-fluorescence for the analysis of polycyclic aromatic hydrocarbons in cold-pressed vegetable oils.

    Science.gov (United States)

    Silva, Simone Alves da; Sampaio, Geni Rodrigues; Torres, Elizabeth Aparecida Ferraz da Silva

    2017-04-15

    Among the different food categories, the oils and fats are important sources of exposure to polycyclic aromatic hydrocarbons (PAHs), a group of organic chemical contaminants. The use of a validated method is essential to obtain reliable analytical results since the legislation establishes maximum limits in different foods. The objective of this study was to optimize and validate a method for the quantification of four PAHs [benzo(a)anthracene, chrysene, benzo(b)fluoranthene, benzo(a)pyrene] in vegetable oils. The samples were submitted to liquid-liquid extraction, followed by solid-phase extraction, and analyzed by ultra-high performance liquid chromatography. Under the optimized conditions, the validation parameters were evaluated according to the INMETRO Guidelines: linearity (r2 >0.99), selectivity (no matrix interference), limits of detection (0.08-0.30μgkg -1 ) and quantification (0.25-1.00μgkg -1 ), recovery (80.13-100.04%), repeatability and intermediate precision (analysis of PAHs in the vegetable oils evaluated. Copyright © 2016. Published by Elsevier Ltd.

  4. Pleurotus pulmonarius cultivation on amended palm press fibre waste

    African Journals Online (AJOL)

    In the last few decades, rapid global demand for edible oils has resulted in a significant increase in the land area of oil crop cultivation. In the process of extraction of palm oil from oil palm fruit, biomass materials such as palm pressed fibre (PPF) are generated as waste products. This research was undertaken to evaluate ...

  5. Induced migration of fines during waterflooding in communicating layer-cake reservoirs

    DEFF Research Database (Denmark)

    Yuan, Hao; Shapiro, Alexander

    2011-01-01

    to more crossflow between layers and lowers the water sweep efficiency. However, this ratio facilitates the fluid diversion caused by the fines migration, leading to a more efficient enhanced oil recovery. The positive contribution from the mobility ratio to the increased oil recovery due to fines...... give rise to reduction of the permeability in water swept zones, which subsequently leads to the diversion of water flow from the initially more permeable layers to the less permeable ones. As a result, the displacement is more even, the water cut at the producer is decreased, and the oil recovery...... is increased. On the other hand, more energy for the pressure drop is required to maintain a constant flow rate. These effects are studied within a new upscaling model developed previously (Zhang et al., 2011). In a communicating layer cake reservoir, higher end-point mobility ratio (water to oil) leads...

  6. Exothermic potential of sodium nitrate salt cake

    International Nuclear Information System (INIS)

    Beitel, G.A.

    1977-06-01

    High-Level radioactive liquid waste is being reduced to a liquid slurry by an evaporation and crystallization process and stored in the existing single-shell tanks. Continuous pumping of the waste storage tank will reduce the present 30 to 50% moisture to the minimum possible. The reduced waste is a relatively immobile salt cake consisting predominantly of sodium nitrate (NaNO 3 ) with lesser amounts of sodium nitrite (NaNO 2 ), sodium metaaluminate (NaAlO 2 ), and sodium hydroxide (NaOH). Trace amounts of fission products, transuranics, and a broad spectrum of organic materials in small but unknown amounts are also present. A program was initiated in 1973 to determine whether or not conditions exist which could lead to an exothermic reaction in the salt cake. Results of the latest series of tests conducted to determine the effects of mass and pressure are summarized. Hanford salt cake, as stored, cannot support combustion, and does not ignite when covered with a burning volatile hydrocarbon

  7. Production of staphylococcal enterotoxin A in cream-filled cake.

    Science.gov (United States)

    Anunciaçao, L L; Linardi, W R; do Carmo, L S; Bergdoll, M S

    1995-07-01

    Cakes were baked with normal ingredients and filled with cream, inoculated with different size enterotoxigenic-staphylococcal inocula. Samples of the cakes were incubated at room temperature and put in the refrigerator. Samples of cake and filling were taken at different times and analyzed for staphylococcal count and presence of enterotoxin. The smaller the inoculum, the longer the time required for sufficient growth (10(6)) to occur for production of detectable enterotoxin. Enterotoxin added to the cake dough before baking (210 degrees C, 45 min) did not survive the baking. The presence of enterotoxin in the contaminated cream filling indicated this as the cause of staphylococcal food poisoning from cream-filled cakes. Refrigeration of the cakes prevented the growth of the staphylococci.

  8. The research on new production technique of yellow cake

    International Nuclear Information System (INIS)

    Wang Zhaoguo; Lin Cirong; Pan Haichun; Wang Haita

    2001-01-01

    As a new production technique of yellow cake, resorption with loaded resin-elution with acid ammonium nitrate-precipitation in two steps is studied. The results show that the produced yellow cake by the new production technique has better performance of settlement, filtration and dehydration. Each index of yellow cake accords with the first grade level issued by CNNC without washing, uranium and water content are 70% and 25%, respectively

  9. Effect of wheat flour characteristics on sponge cake quality.

    Science.gov (United States)

    Moiraghi, Malena; de la Hera, Esther; Pérez, Gabriela T; Gómez, Manuel

    2013-02-01

    To select the flour parameters that relate strongly to cake-making performance, in this study the relationship between sponge cake quality, solvent retention capacity (SRC) profile and flour physicochemical characteristics was investigated using 38 soft wheat samples of different origins. Particle size average, protein, damaged starch, water-soluble pentosans, total pentosans, SRC and pasting properties were analysed. Sponge cake volume and crumb texture were measured to evaluate cake quality. Cluster analysis was applied to assess differences in flour quality parameters among wheat lines based on the SRC profile. Cluster 1 showed significantly higher sponge cake volume and crumb softness, finer particle size and lower SRC sucrose, SRC carbonate, SRC water, damaged starch and protein content. Particle size, damaged starch, protein, thickening capacity and SRC parameters correlated negatively with sponge cake volume, while total pentosans and pasting temperature showed the opposite effect. The negative correlations between cake volume and SRC parameters along with the cluster analysis results indicated that flours with smaller particle size, lower absorption capacity and higher pasting temperature had better cake-making performance. Some simple analyses, such as SRC, particle size distribution and pasting properties, may help to choose flours suitable for cake making. Copyright © 2012 Society of Chemical Industry.

  10. Cellars, stone wine and oil presses in the territory of Kelin (5th-3rd centuries BC: the case of la Alcantarilla ravine (Requena, Valencia

    Directory of Open Access Journals (Sweden)

    David Quixal Santos

    2016-11-01

    Full Text Available Archaeological evidences date the expansion of grape vineyards in the territory of the Iberian Iron Age city of Kelin from the 5th to 3rd centuries BC; although the origins are documented in the 7th BC. One of the singularities of this territory is the existence of outdoors stone structures for the production of wine and oil. All are located in a specific area of the territory (la Alcantarilla and Los Morenos ravines (Requena, Valencia, and are associated with archaeological materials that allow date them as Iberian. In this paper we approach the rural settlement pattern in la Alcantarilla ravine and we present in detail the archaeological sites of Rambla de la Alcantarilla and Solana de Cantos 2.

  11. Contact Allergy to Neem Oil.

    NARCIS (Netherlands)

    de Groot, Anton; Jagtman, Berend A; Woutersen, Marjolijn

    2018-01-01

    A case of allergic contact dermatitis from neem oil is presented. Neem oil (synonyms: Melia azadirachta seed oil [INCI name], nim oil, margosa oil) is a vegetable (fixed) oil obtained from the seed of the neem tree Azadirachta indica by cold pressing. Contact allergy to neem oil has been described

  12. News/Press Releases

    Data.gov (United States)

    Office of Personnel Management — A press release, news release, media release, press statement is written communication directed at members of the news media for the purpose of announcing programs...

  13. Production of Itaconic Acid from Jatropha curcas Seed Cake by Aspergillus terreus

    Directory of Open Access Journals (Sweden)

    Amina M. AHMED EL-IMAM

    2013-02-01

    Full Text Available Submerged substrate fermentation of Jatropha seed cake, a by-product of oil extraction from Jatropha curcas seed was carried out using Aspergillus terreus for the production of itaconic acid. The Jatropha seed cake was initially converted into fermentable sugars by dilute acid hydrolysis using 50% sulphuric acid. The rate of hydrolysis was 1.04 gL-1. The fermentation process was carried out at room temperature, agitation of 400 rpm and three physico-chemical parameters (pH, inoculum size and substrate concentration were varied. Itaconic acid and glucose assays were carried out by spectrophotometry and Dinitrosalicylic acid methods respectively daily. Maximum yield of itaconic acid was 48.70 gL-1 at 5 ml of inoculum size, 50 g substrate concentration and pH 1.5. The residual glucose concentration increased for the first two days of fermentation after which it began to decrease as the itaconic acid concentration increased. The least concentration of itaconic acid observed was 6.00 gL-1, obtained after 24 hours of fermentation with 4 ml inoculum size, 50 g substrate concentration and at pH 1.5. The findings of this work indicate that Jatropha curcas seed cake is a suitable substrate for itaconic acid production.

  14. Reciprocating pellet press

    Science.gov (United States)

    Jones, Charles W.

    1981-04-07

    A machine for pressing loose powder into pellets using a series of reciprocating motions has an interchangeable punch and die as its only accurately machines parts. The machine reciprocates horizontally between powder receiving and pressing positions. It reciprocates vertically to press, strip and release a pellet.

  15. The Global University Press

    Science.gov (United States)

    Dougherty, Peter J.

    2012-01-01

    The modern world's understanding of American university press has long been shaped by university-press books. American university-press books are good international advertisements for the universities whose logos grace their spines. The growth of transnational scholarship and the expansion of digital communications networks are converging in ways…

  16. Application of diethanolamide surfactant derived from palm oil to improve the performance of biopesticide from neem oil

    Science.gov (United States)

    Nisya, F. N.; Prijono, D.; Nurkania, A.

    2017-05-01

    The purpose of this research was to improve the performance of organic pesticide derived from neem plant using diethanolamide surfactant (DEA) derived from palm oil in controlling armyworms. The pesticide was made of neem oil. Neem oil is a neem plant product containing several active components, i.e. azadirachtin, salanin, nimbin, and meliantriol which act as a pesticide. DEA surfactant acts as a wetting, dispersing and spreading agent in neem oil pesticide. The neem oil was obtained by pressing neem seeds using a screw press machine and a hydraulic press machine. DEA surfactant was synthesized from methyl esters of palm oil olein. Pesticide formulation was conducted by stirring the ingredients by using a homogenizer at 5,000 rpm for 30 minutes. Surfactant was added to the formulation by up to 5%. Glycerol, as an emulsifier, was added in to pesticide formulations of neem oil. The efficacy of the pesticides in controlling armyworms fed soybean leaves in laboratory was measured at six concentrations, i.e. 10, 13, 16, 19, 22, and 25 ml/L. Results showed that the neem oil used in this study had a density of 0.91 g/cm3, viscosity of 58.94 cPoise, refractive index of 1.4695, surface tension of 40.69 dyne/cm, azadirachtin content of 343.82-1.604 ppm. Meanwhile, the azadirachtin content of neem seed cake was 242.20 ppm. It was also found that palmitic (31.4%) and oleic (22.5%) acids were the main fatty acids contained in neem oil. As the additive material used in neem oil in this study, diethanolamide surfactant had a pH of 10.6, density of 0.9930 g/cm3, viscosity of 708.20 cP, and surface tension of 25.37 dyne/cm. Results of CMC, contact angle, and droplet size analyzes showed that diethanolamide surfactant could be added into insecticide formulation by 5%. Results of LC tests showed that on Spodoptera litura the LC50 and LC95 values were 13 and 22 ml/L, respectively. Neem oil was found to inhibit the development of Spodoptera litura and its larval molting process.

  17. Cake filtration modeling: Analytical cake filtration model and filter medium characterization

    Energy Technology Data Exchange (ETDEWEB)

    Koch, Michael

    2008-05-15

    Cake filtration is a unit operation to separate solids from fluids in industrial processes. The build up of a filter cake is usually accompanied with a decrease in overall permeability over the filter leading to an increased pressure drop over the filter. For an incompressible filter cake that builds up on a homogeneous filter cloth, a linear pressure drop profile over time is expected for a constant fluid volume flow. However, experiments show curved pressure drop profiles, which are also attributed to inhomogeneities of the filter (filter medium and/or residual filter cake). In this work, a mathematical filter model is developed to describe the relationship between time and overall permeability. The model considers a filter with an inhomogeneous permeability and accounts for fluid mechanics by a one-dimensional formulation of Darcy's law and for the cake build up by solid continuity. The model can be solved analytically in the time domain. The analytic solution allows for the unambiguous inversion of the model to determine the inhomogeneous permeability from the time resolved overall permeability, e.g. pressure drop measurements. An error estimation of the method is provided by rewriting the model as convolution transformation. This method is applied to simulated and experimental pressure drop data of gas filters with textile filter cloths and various situations with non-uniform flow situations in practical problems are explored. A routine is developed to generate characteristic filter cycles from semi-continuous filter plant operation. The model is modified to investigate the impact of non-uniform dust concentrations. (author). 34 refs., 40 figs., 1 tab

  18. Effect of Palm Kernel Cake Replacement and Enzyme ...

    African Journals Online (AJOL)

    A feeding trial which lasted for twelve weeks was conducted to study the performance of finisher pigs fed five different levels of palm kernel cake replacement for maize (0%, 40%, 40%, 60%, 60%) in a maize-palm kernel cake based ration with or without enzyme supplementation. It was a completely randomized design ...

  19. Quality Properties of Cakes Containing Gamma-Irradiated Egg White

    International Nuclear Information System (INIS)

    Lee, J.W.; Seo, J.H.; Ahn, H.J; Byun, M.W; Kim, Y.H.; Choi, J.M.; Yook, H.S.

    2003-01-01

    As a research on the practical approaches of gamma irradiation for the reduction of egg allergy, cakes including gamma-irradiated egg white were manufactured, and rheological characteristics and sensory qualities of the cakes were evaluated. Egg white was separated from whole egg and then gamma-irradiated with the absorbed dose of 10 or 20 kGy

  20. Secondary Aluminum Processing Waste: Salt Cake Characterization and Reactivity

    Science.gov (United States)

    Thirty-nine salt cake samples were collected from 10 SAP facilities across the U.S. The facilities were identified by the Aluminum Association to cover a wide range of processes. Results suggest that while the percent metal leached from the salt cake was relatively low, the leac...

  1. Potential treatments to reduce phorbol esters levels in jatropha seed cake for improving the value added product.

    Science.gov (United States)

    Sadubthummarak, Umapron; Parkpian, Preeda; Ruchirawat, Mathuros; Kongchum, Manoch; Delaune, R D

    2013-01-01

    Jatropha seed cake contains high amounts of protein and other nutrients, however it has a drawback due to toxic compounds. The aim of this study was to investigate the methods applied to detoxify the main toxin, phorbol esters in jatropha seed cake, to a safe and acceptable level by maintaining the nutritional values. Phorbol esters are tetracyclic diterpenoids-polycyclic compounds that are known as tumor promoters and hence exhibited the toxicity within a broad range of species. Mismanagement of the jatropha waste from jatropha oil industries would lead to contamination of the environment, affecting living organisms and human health through the food chain, so several methods were tested for reducing the toxicity of the seed cake. The results from this investigation showed that heat treatments at either 120°C or 220°C for 1 hour and then mixing with adsorbing bentonite (10%), nanoparticles of zinc oxide (100 μg/g) plus NaHCO3 at 4%, followed by a 4-week incubation period yielded the best final product. The remaining phorbol esters concentration (0.05-0.04 mg/g) from this treatment was less than that reported for the nontoxic jatropha varieties (0.11-0.27 mg/g). Nutritional values of the seed cake after treatment remained at the same levels found in the control group and these values were crude protein (20.47-21.40 + 0.17-0.25%), crude lipid (14.27-14.68 + 0.13-0.14%) and crude fiber (27.33-29.67 + 0.58%). A cytotoxicity test conducted using L929 and normal human dermal fibroblast cell lines confirmed that most of the toxic compounds, especially phorbol esters, were shown as completely eliminated. The results suggested that the detoxification of phorbol esters residues in the jatropha seed cake was possible while it also retained nutritional values. Therefore, the methods to detoxify phorbol esters are necessary to minimize the toxicity of jatropha seed cake. Further, it is essential to reduce the possible environmental impacts that may be generated

  2. WordPress Bible

    CERN Document Server

    Brazell, Aaron

    2010-01-01

    The WordPress Bible provides a complete and thorough guide to the largest self hosted blogging tool. This guide starts by covering the basics of WordPress such as installing and the principles of blogging, marketing and social media interaction, but then quickly ramps the reader up to more intermediate to advanced level topics such as plugins, WordPress Loop, themes and templates, custom fields, caching, security and more. The WordPress Bible is the only complete resource one needs to learning WordPress from beginning to end.

  3. Current Strategies for the Detoxification of Jatropha curcas Seed Cake: A Review.

    Science.gov (United States)

    Gomes, Taisa G; Hadi, Sámed I I A; Costa Alves, Gabriel S; Mendonça, Simone; De Siqueira, Felix G; Miller, Robert N G

    2018-03-21

    Jatropha curcas is an important oilseed plant, with considerable potential in the development of biodiesel. Although Jatropha seed cake, the byproduct of oil extraction, is a residue rich in nitrogen, phosphorus, potassium, and carbon, with high protein content suitable for application in animal feed, the presence of toxic phorbol esters limits its application in feed supplements and fertilizers. This review summarizes the current methods available for detoxification of this residue, based upon chemical, physical, biological, or combined processes. The advantages and disadvantages of each process are discussed, and future directions involving genomic and proteomic approaches for advancing our understanding of biodegradation processes involving microorganisms are highlighted.

  4. Effects of irradiation on hygiene quality of moon cake

    International Nuclear Information System (INIS)

    Zhang Fengjiao; Chen Bin; Guo Yaping; Gao Meixu; Li Haipeng; Sun Baozhong

    2007-01-01

    To explore the influence of controllable conditions with different doses of irradiation and store time on the safe and the quality of Moon Cake, the indexes including peroxide value, acid value, mould, coli group coliform group, total numbers of colony and taste of Moon Cake were concerned about. The results show that the peroxide value were increased and acid value were decreased gradually with the increased value of 60 Co γ-irradiation. Meanwhile, the microorganism growth in the moon cake were controlled. It is concluded that the taste of Moon Cake was not changed and the shelf life of ones were prolonged by 3 months when doses of irradiation was 8 kGy, in addition, Tea-polyphenols could prevent the lipid in Moon Cake from lipid oxidation effectively. (authors)

  5. Application of Fourier-transform mid infrared spectroscopy for the monitoring of pound cakes quality during storage.

    Science.gov (United States)

    Nhouchi, Zeineb; Karoui, Romdhane

    2018-06-30

    The aim of the present study was to investigate the ability of MIR and texture analyzer to evaluate the quality of pound cake samples produced with palm oil and rapeseed oil throughout storage. The MIR spectra analyzed by using principal component analysis (PCA) showed a clear separation of pound cakes as a function of the storage time and the nature of the used oil in the recipe. By applying partial least square regression (PLSR), excellent prediction was obtained for hardness (R 2  = 0.91; RPD = 2.26), while an approximate qualitative prediction was found for springiness (R 2  = 0.73; RPD = 2.07), cohesiveness (R 2  = 0.67; RPD = 1.31) and resilience (R 2  = 0.65; RPD = 1.24). It could be concluded that the MIR spectroscopy could be used as a rapid and non-destructive technique for monitoring texture of pound cakes throughout storage as well as for the prediction of their hardness. Copyright © 2018 Elsevier Ltd. All rights reserved.

  6. Improvement of Protein Digestibility in Jatropha curcas Seed Cakes by Gamma Irradiation

    International Nuclear Information System (INIS)

    Sudprasert, Wanwisa; Pakkong, Pannee; Thiengtham, Jamroen; Chandang, Pipatpong

    2011-06-01

    Full text: The effect of gamma radiation on protein digestibility of Jatropha curcas press cake was investigated using in vitro digestibility technique. Six varieties of Jatropha curcas seeds were subjected to cobalt-60 gamma radiation at doses of 10-100 kGy. All treated seeds were defatted by screw press. In vitro protein digest abilities in defatted seeds were assayed using trinitrobenzene sulphonic acid (TNBS) method, by which the contents of alpha amino induced from the function of enzymes were determined using L-alanine as a reference standard. It was found that irradiation treatment at 60 kGy significantly increased the protein digestibility by 15-92%. Also, the results showed that moisture, crude protein, fat and ash contents were unchanged by irradiation, whereas fiber was significantly decreased (p < 0.05). Therefore, irradiation could serve as a possible processing method for protein utilization improvement in defatted Jatropha curcas seeds before using as a protein supplement in animal feed

  7. Pequi cake composition, hydrolysis and fermentation to bioethanol

    Directory of Open Access Journals (Sweden)

    A. L. Macedo

    2011-03-01

    Full Text Available Pequizeiro (Caryocar brasiliense Camb fruits have been evaluated as a potential raw material for the newly established biodiesel industry. This scenario demands applications using the solid co-product derived from the extraction of pequi oil, called cake or meal. This study analyses the acid hydrolysis of carbohydrates present in the pequi meal in order to obtain fermentable sugars and evaluates their conversion to bioethanol. There was 27% starch in the pequi meal. The use of a CCRD experimental design type to study the acid saccharification of pequi meal results in 61.6% conversion of its starch content to reducing sugars. Positive and significant linear effects were observed for H2SO4 concentration and temperature factors, while the quadratic effect of H2SO4 concentration and the linear effect of solid-liquid ratio were negative. Even, with non-optimized fermentative condition using 1% of dried baker's yeast in conical flasks, it was possible to obtain a value equivalent to 53 L of ethanol per ton of hydrolyzed pequi meal.

  8. Application of soil washing system to the volume reduction of radioactively contaminated soils and automated treatment of sludge cake

    International Nuclear Information System (INIS)

    Mouri, Mitsuo; Tsuchida, Mitsuru; Baba, Naoki; Nakajima, Takuma

    2013-01-01

    The pilot plant study was intended to evaluate; a) the removal efficiency of radioactive Cs, b) the volume reduction rate of feed soils, c) the volumetric rate and concentration rate of discharged sludge cake, and d) the effect of radiation exposure reduction by automated filter press unit and automated packing unit of sludge cake. As a result of this study, following observations were made; 1) the radioactive Cs content of clean sands ranged 882∼2,940 Bq/kg as compared to the feed soils of 8,790 to 26,270 Bq/kg, 2) the removal efficiency of radioactive Cs ranged 84∼92% of feed soils, 3) the volume reduction rate of feed soils ranged 70∼86% (ave. 82%), and 4) the automated filter press unit and the automated packing system of sludge cake were helpful for workers in reducing radiation exposure. It is concluded that soil washing system can effectively reduce volume of radioactively contaminated soils and can be practically used in Fukushima for remediation of soils. (author)

  9. Uranium Yellow Cake accident - Wichita, Kansas

    International Nuclear Information System (INIS)

    Borchert, H.R.

    1987-01-01

    A tractor and semi trailer containing Uranium Yellow Cake, had overturned on I-235, Wichita, Kansas on Thursday, March 22, 1979. The truck driver and passenger were transported, with unknown injuries, to the hospital by ambulance. The shipment consisted of 54 drums of Uranium Ore Concentrate Powder. Half of the drums were damaged or had their lids off. Since it was raining at the time of the accident, plastic was used to cover the barrels and spilled material in an attempt to contain the yellow cake. A bulldozer was used to construct a series of dams in the median and the ditch to contain the run-off water from the contaminated area. Adverse and diverse weather conditions hampered the clean up operations over the next several days. The contaminated water and soil were shipped back to the mine for reintroduction into the milling process. The equipment was decontaminated prior to being released from the site. The clean up personnel wore protective clothing and respiratory protection equipment, if necessary. All individuals were surveyed and decontaminated prior to exiting the area

  10. Walnut and almond oil screw-press extraction at industrial scale: Effects of process parameters on oil yield and quality; Extracción de aceite de nuez y almendra a escala industrial: efecto de parámetros del proceso sobre el rendimiento y la calidad del aceite

    Energy Technology Data Exchange (ETDEWEB)

    Martínez, M. L.; Bordón, M.G.; Bodoira, R. M.; Penci, M.C.; Ribotta, P.D.; Maestri, D.M.

    2017-07-01

    Walnut and almond kernels are highly nutritious mainly due to their high oil contents. In this study, 32 factorial experimental designs were used to optimize processes for oil extraction by screw-pressing at industrial scale. Experimental designs included seed moisture content (SMC), and restriction die (RD) as the main processing parameters. Theoretical models were scanned against experimental data in order to optimize oil extraction conditions. The response variables analyzed were oil yield (OY), fine solid content (FC) in oil, and oil quality parameters. Fitted models for OY indicated maximum predicted values similar to the highest experimental values. Walnut oil extractions showed a maximum OY (84.5 ± 2.3 %) at 7.21% SMC, and 10 mm RD. For almond kernels, maximum OY (71.9 ± 3.5%) was obtained at 9.42% SMC, and 12 mm RD. Chemical quality parameters from both oils were in the ranges stated in Codex (FAO/WHO) standards for virgin (non-refined) oils. [Spanish] La nuez y almendra son frutos sumamente nutritivos debido a su alto contenido de aceite. Mediante un diseño experimental de tipo factorial 32 se optimizó el proceso de extracción de estos aceites con prensa de tornillo a escala industrial. Las variables de proceso analizadas fueron el contenido de humedad de la semilla (CHS) y el diámetro de reducción (DR). Los modelos ajustados para rendimiento de aceite (RA) indicaron valores máximos predichos similares a los valores experimentales. Las extracciones de aceite de nuez mostraron un RA máximo (84,5 ± 2,3%) a 7,21% CHS, y 10 mm DR. Para almendra, se obtuvo un máximo de RA (71,9 ± 3,5%) con 9,42% de CHS y 12 mm de DR. Los parámetros de calidad química de ambos aceites se encontraban en los rangos establecidos en las normas del Codex (FAO / OMS) para aceites vírgenes (no refinados).

  11. Oils

    Energy Technology Data Exchange (ETDEWEB)

    Fabbri, S

    1909-11-29

    Mineral, shale, and like oils are treated successively with sulfuric acid, milk of lime, and a mixture of calcium oxide, sodium chloride, and water, and finally a solution of naphthalene in toluene is added. The product is suitable for lighting, and for use as a motor fuel; for the latter purpose, it is mixed with a light spirit.

  12. Feasibility analysis of heat pump dryer to dry hawthorn cake

    Energy Technology Data Exchange (ETDEWEB)

    Wang, D.C., E-mail: wdechang@163.com [College of Electromechanical Engineering, Qingdao University, Qingdao 266071 (China); Zhang, G.; Han, Y.P.; Zhang, J.P.; Tian, X.L. [College of Electromechanical Engineering, Qingdao University, Qingdao 266071 (China)

    2011-08-15

    Highlights: {yields} A heat pump dryer (HPD) is effectively proposed to dry hawthorn cake-likely materials. {yields} Low drying temperature and high COP of heat pump are obtained in drying beginning. {yields} HPD is more effective, economic than a traditional hot air dryer. {yields} Feasibility of the HPD is also validated by the operation economy estimation. - Abstract: A heat pump dryer (HPD) would be an economic, environmentally friendly, hygienic drying machine used to dry some food, such as hawthorn cakes. Based on the production process of the hawthorn cake, a HPD is proposed and its basic principle is introduced. The experimental drying curves of the hawthorn cake using the heat pump drying method and the traditional hot air drying method are compared and analyzed. The drying process of hawthorn cakes is similar to that of the other drying materials. The higher drying temperature causes a faster drying process. But in the initial stage of the heat pump drying process, the water content of the hawthorn cake is not sensitive to the drying temperature, so a lower drying air temperature can be available in order to get a higher coefficient of performance (COP) of the heat pump (HP). The experimental results and the economic analysis indicate that the HPD is feasibly used to dry hawthorn cakes.

  13. Feasibility analysis of heat pump dryer to dry hawthorn cake

    International Nuclear Information System (INIS)

    Wang, D.C.; Zhang, G.; Han, Y.P.; Zhang, J.P.; Tian, X.L.

    2011-01-01

    Highlights: → A heat pump dryer (HPD) is effectively proposed to dry hawthorn cake-likely materials. → Low drying temperature and high COP of heat pump are obtained in drying beginning. → HPD is more effective, economic than a traditional hot air dryer. → Feasibility of the HPD is also validated by the operation economy estimation. - Abstract: A heat pump dryer (HPD) would be an economic, environmentally friendly, hygienic drying machine used to dry some food, such as hawthorn cakes. Based on the production process of the hawthorn cake, a HPD is proposed and its basic principle is introduced. The experimental drying curves of the hawthorn cake using the heat pump drying method and the traditional hot air drying method are compared and analyzed. The drying process of hawthorn cakes is similar to that of the other drying materials. The higher drying temperature causes a faster drying process. But in the initial stage of the heat pump drying process, the water content of the hawthorn cake is not sensitive to the drying temperature, so a lower drying air temperature can be available in order to get a higher coefficient of performance (COP) of the heat pump (HP). The experimental results and the economic analysis indicate that the HPD is feasibly used to dry hawthorn cakes.

  14. Chip compacting press; Jido kirikuzu asshukuki

    Energy Technology Data Exchange (ETDEWEB)

    Oura, K. [Yuken Kogyo Co. Ltd., Kanagawa (Japan)

    1998-08-15

    The chips exhausted from various machine tools are massy, occupy much space and make working environment worse by staying added cutting oil to lower part. The chips are exhausted as a result of machining and have not constant quality. Even if used material is same the chips have various shapes and properties by kinds and machining methods of used machine tools, and are troublesome materials from a standpoint of their treatment. Pressing and solidification of the chips have frequently been tried. A chip compacting press introduced in this paper, a relatively cheap chip compacting press aimed for relatively small scale chip treatment, and has such characteristics and effects as follows. Chips are pressed and solidified by each raw material, so fractional management can be easily conducted. As casting metal chips and curled chips of iron and aluminum can be pressed to about 1/3 to 1/5 and about 1/40, respectively, space saving can be conducted. Chip compacting pressing upgrades its transporting efficiency to make possible to reduce its transporting cost. As chip solidification controls its oxidation and most cutting oil are removed, chips are easy to recycle. 2 figs., 1 tab.

  15. Optimization of Protein Hydrolysate Production Process from Jatropha curcas Cake

    OpenAIRE

    Waraporn Apiwatanapiwat; Pilanee Vaithanomsat; Phanu Somkliang; Taweesiri Malapant

    2009-01-01

    This was the first document revealing the investigation of protein hydrolysate production optimization from J. curcas cake. Proximate analysis of raw material showed 18.98% protein, 5.31% ash, 8.52% moisture and 12.18% lipid. The appropriate protein hydrolysate production process began with grinding the J. curcas cake into small pieces. Then it was suspended in 2.5% sodium hydroxide solution with ratio between solution/ J. curcas cake at 80:1 (v/w). The hydrolysis reactio...

  16. Antifungal activities of ethanolic extract from Jatropha curcas seed cake.

    Science.gov (United States)

    Saetae, Dolaporn; Suntornsuk, Worapot

    2010-02-01

    Phorbol ester extraction was carried out from Jatropha curcas seed cake, a by-product from the bio-diesel fuel industry. Four repeated extractions from 5 g J. curcas seed cake using 15 ml of 90% (v/v) ethanol and a shaking speed of 150 rev/min gave the highest yield of phosbol esters. The ethanolic extract of J. curcas seed cake showed antifungal activities against important phytofungal pathogens: Fusarium oxysporum, Pythium aphanidermatum, Lasiodiplodia theobromae, Curvularia lunata, Fusarium semitectum, Colletotrichum capsici and Colletotrichum gloeosporiodes. The extract contained phorbol esters mainly responsible for antifungal activities. The extract could therefore be used as an antifungal agent for agricultural applications.

  17. Utilization of Bamboo Charcoal as Additives in Cakes

    Directory of Open Access Journals (Sweden)

    Ronald O. Ocampo

    2015-12-01

    Full Text Available Charcoal has been used for healing various diseases, as antidote to poisoning and as purifying agent to filtered water. This study is conducted to utilize charcoal as additives in making cakes. Specifically, it is intended to determine the acceptable level of charcoal when used as additives in the production of brownies, dark brown chocolate, and chiffon cakes. It can be concluded that an addition of 1 tablespoon of bamboo charcoal gave the highest sensory evaluation to brownies and 3 tablespoon to dark brown chocolate .The control ( no charcoal added is still the best treatment for chiffon cake.

  18. Hot-pressed geopolymer

    DEFF Research Database (Denmark)

    Ranjbar, Navid; Mehrali, Mohammad; Maheri, Mahmoud R.

    2017-01-01

    This research explores the use of simultaneous heating and pressing techniques in order to enhance the mechanical properties of fly ash (FA) based geopolymer under relatively low temperature conditions to ensure minimum-porosity. Four effective parameters of pressing force, alkali activator...

  19. Quality of pies obtained of the extraction of sunflower and crambe oil for biodiesel under different temperatures; Qualidade das tortas obtidas na extracao do oleo de girassol e crambe para biodiesel sob diferentes temperaturas

    Energy Technology Data Exchange (ETDEWEB)

    Bischoff, Tabata Zingano; Prado, Naimara Vieira do; Coelho, Silvia Renata Machado; Bischoff, Teodato Zingano [Universidade Estadual do Oeste do Parana (UNIOESTE), PR (Brazil)], emails: tabatazbi@yahoo.com.br, nai_mara@hotmail.com, srmcoelho@unioeste.br, teodato_zb@hotmail.com; Figueiredo, Paulo Roberto Abreu de [Instituto Agronomico do Parana (IAPAR), Londrina, PR (Brazil)

    2011-07-01

    Sunflower and crambe are viable alternatives to ethanol. Used in food production, the sunflower crop has economic, rustic and does not require specialized machinery. The crambe oil is concentrated enough, it is feasible to farm and is not edible. The extraction efficiencies of these oils gives to the heating and moisture content of grain. The aim of this study was to evaluate temperatures of oil extraction in sunflower and crambe as pies obtained. For oil extraction and acquisition of pies, we used a high pressure extruder press. The sunflower seed and crambe were extruded without heating and at temperatures of 50 and 70 deg C with three replicates for each treatment, estimated to be the pie, the amount of fat, protein and moisture. Increasing the temperature, we observed a reduction of moisture in sunflower cake, but this did not occur in seeds of crambe. For sunflower, the higher levels of lipids occurred for pie without heating, and for crambe, the higher levels of lipids occurred at 50 deg C. As for the protein, was found in both cultures, the highest level at 70 deg C. It is concluded that the extraction temperature alters the composition of oilseed cakes. (author)

  20. Physicochemical Evaluation of Seeds and Oil of Nontraditional Oil Seeds

    Directory of Open Access Journals (Sweden)

    Adam Ismail Ahmed

    2015-08-01

    Full Text Available The present work was conducted in the Laboratory of Biochemistry and Food science department, Faculty of Natural Resources and Environmental Studies, University of Kordofan, in order to evaluate some nontraditional oil seeds these are i.e. Marula (Sclerocarya birrea, Roselle (Hibiscus sabdariffa L. seeds and Christ’s thorn (Zizyphus spina-christi seeds. The seeds of the roselle and Christ’s thorn fruits were procured from Elobeid local market, North Kordofan State, while marula fruits were obtained from Elnuhod, West Kordofan State. The proximate composition of the seeds, cake and christ’s thorn pulp was done. Some chemical and physical properties were performed for the extracted oil. The results revealed that proximate composition of the seeds and cake differ statistically among the studied materials. Significant differences were observed among the oil extracted from these species; moreover, these oils differ significantly in color and viscosity only.

  1. Sensorial, chemical and microbiological quality of anchovy cake

    African Journals Online (AJOL)

    Jane

    2011-08-29

    Aug 29, 2011 ... Key words: Anchovy cake, shelf-life, chemical, sensorial, microbiological, Engraulis encrasicolus. ... The ingredients shown in Table 1 except the fish were mixed with ... products which can satisfy consumers sensationally and.

  2. Mycoflora and mycotoxin production in oilseed cakes during farm storage.

    Science.gov (United States)

    Lanier, Caroline; Heutte, Natacha; Richard, Estelle; Bouchart, Valerie; Lebailly, Pierre; Garon, David

    2009-02-25

    Agricultural activities involve the use of oilseed cakes as a source of proteins for livestock. Because the storage of oilseed cakes could induce the development of molds and the production of mycotoxins, a survey was conducted during the 5 months of farm storage. Mycoflora was studied by microscopic examinations, and the presence of Aspergillus fumigatus was confirmed by polymerase chain reaction. A multimycotoxin method was developed to quantify seven mycotoxins (aflatoxin B(1), alternariol, fumonisin B(1), gliotoxin, ochratoxin A, T-2 toxin, and zearalenone) in oilseed cakes by high-performance liquid chromatography coupled to mass spectrometry. Among 34 fungal species identified, A. fumigatus and Aspergillus repens were observed during 5 and 4 months, respectively. Gliotoxin, an immunosuppressive mycotoxin, was quantified in oilseed cakes up to 45 microg/kg, which was associated with the presence of toxigenic isolates of A. fumigatus.

  3. 2.4.2. Water processing of cake

    International Nuclear Information System (INIS)

    Nazarov, Sh.B.; Safiev, Kh.S.; Mirsaidov, U.

    2008-01-01

    The cake water processing carried out with the purpose of extraction ofalkali components, in particular calcium chlorides and sodium, formed atbaking of raw materials with calcium chloride and by acid processingextracted the aluminium and iron compounds

  4. Oils

    Energy Technology Data Exchange (ETDEWEB)

    Cobbett, G T.B.

    1907-07-08

    Crude petroleum having a density of 850 to 900 is purified with sulfuric acid, decanted, mixed with benzine or petrol, and again treated with sulfuric acid and decanted. The remaining acid and coloring-matter are removed by washing with water, or treating with oxalic acid, zinc carbonate, lead carbonate, calcium carbonate, or oxide of zinc. The product is used as a fuel for internal-combustion engines. Specifications No. 28,104, A.D. 1906, and No. 12,606, A.D. 1907, are referred to. According to the Provisional Specification, the process is applicable to shale or schist oil.

  5. Optimization of Jatropha curcas pure vegetable oil production parameters for cooking energy

    Directory of Open Access Journals (Sweden)

    X. Aboubakar

    2017-12-01

    Full Text Available The extraction of vegetable oil from Jatropha from the Tanzanian variety with a fat content of 33.84 ± 2.58% and a moisture content of 5.4 ± 1.97%, was made using two methods: the traditional and the mechanical extraction method. The traditional consists in extracting the oil from the paste using boiling water as a solvent. While the mechanical consists of directly pressing the seeds of Jatropha using a ram press called Bielenberg press, to extract the oil contained in the seeds dried or heated before. The net yield of oil extraction by the traditional method was 22.02 ± 2.1%, with a oil cake percentage of 67.02 ± 3.3% and the ratio water/paste in mass adopted was 0.36. Mechanical extraction has an average raw yield of 26.15 ± 2.74%, with a recovery rate of 74.71%. After decanting for 10 days and filtration, the net yield was 15.39 ± 2.82% with a decantation and filtration rate of 58.67 ± 7.24%. The oil produced by traditional method has a water and volatile content of 1.01 ± 0.05% and a density of 0.884. The one produced by mechanical extraction has 0.19 ± 0.09% and a density of 0.891. The result of combustion test using two burners and one stove showed that the combustion rates were: 0.177 ± 0.034 g/min for the burner using one flame and 1.06 ± 0.04 g/min for the six flame burner and finally 3.07 ± 0, 4 g/min for the ten-flame stove. This ten-flame stove allowed 3 L of water to be boiled at 100 °C for 32 min, although during combustion it was observed a release of black fumes which indicates incomplete combustion with Jatropha in this Stove. The cost of the liter of Jatropha oil obtained is higher compared to fossil fuels such as petroleum (500 FCFA per liter and gas oil (624F CFA per liter. It would be possible to use vegetable oil from Jatropha as a cooking fuel. Keywords: Vegetable oil, Jatropha, Traditional extraction, Mechanical extraction, Bielenberg press

  6. Nutritional and energy values of sunflower cake for broilers

    Directory of Open Access Journals (Sweden)

    Eveline Berwanger

    2014-12-01

    Full Text Available The study aimed to determine the nutritional and energy values of sunflower cake for broilers through two experiments. The first study evaluated the energy values by the method of total excreta collection, using 100 broiler chicks 21–31 days old, divided into five treatments of 0%, 10%, 20%, 30% and 40% inclusion sunflower cake will reference a diet. The second experiment evaluated the influence of the period and the quantity supplied of sunflower cake on digestibility of amino acids by a forcedfeeding technique. Eighteen cockerels were used, divided into three treatments, which consisted of supplying 15 g of sunflower cake, 30 g of sunflower cake (15 g at intervals of 12 hours and 30 g of sunflower cake (15 g at intervals of 24 hours, and an additional six roosters were fasted for correction of metabolic and endogenous losses. The samples were sent for amino acid analysis by HPLC in the Evonik Laboratory (Germany, and chemical and energy analysis to Unioeste Laboratory. The values of apparent metabolizable energy (AME, metabolization coefficient (AMC, apparent metabolizable energy corrected for nitrogen balance (AMEn, metabolization coefficient corrected for nitrogen balance (AMCn for sunflower cake were 2211.68 kcal.kg-1, 2150.54 kcal.kg-1, 45.47% and 44.73%, respectively. The amount of food provided in the feeding method changed the assessment of true digestibility of amino acids (TDCA, and when only 15 g was used, the values of true digestibility coefficients were underestimated. The lysine, histidine and threonine amino acids were at lower TDCA, and arginine and methionine showed the highest TDCA for sunflower cake.

  7. Proximate Analysis Of Castor Seeds And Cake | Annongu | Journal ...

    African Journals Online (AJOL)

    Amino acid profile analysis of un-decorticated and decorticated seed and cake compared with soybeans as standard plant protein indicated that the cake is deficient in some indispensable amino acids like lysine (4.11), iso-leucine (3.09), tryptophan (0) compared with 6.30, 7.90 and 1.30 lysine, iso-leucine and tryptopha in ...

  8. WordPress Bible

    CERN Document Server

    Brazell, Aaron

    2011-01-01

    Get the latest word on the biggest self-hosted blogging tool on the marketWithin a week of the announcement of WordPress 3.0, it had been downloaded over a million times. Now you can get on the bandwagon of this popular open-source blogging tool with WordPress Bible, 2nd Edition. Whether you're a casual blogger or programming pro, this comprehensive guide covers the latest version of WordPress, from the basics through advanced application development. If you want to thoroughly learn WordPress, this is the book you need to succeed.Explores the principles of blogging, marketing, and social media

  9. Two layer powder pressing

    International Nuclear Information System (INIS)

    Schreiner, H.

    1979-01-01

    First, significance and advantages of sintered materials consisting of two layers are pointed out. By means of the two layer powder pressing technique metal powders are formed resulting in compacts with high accuracy of shape and mass. Attributes of basic powders, different filling methods and pressing techniques are discussed. The described technique is supposed to find further applications in the field of two layer compacts in the near future

  10. Fungi in cake production chain: Occurrence and evaluation of growth potential in different cake formulations during storage.

    Science.gov (United States)

    Morassi, Letícia L P; Bernardi, Angélica O; Amaral, Alexandra L P M; Chaves, Rafael D; Santos, Juliana L P; Copetti, Marina V; Sant'Ana, Anderson S

    2018-04-01

    This study aimed to determine the prevalence and populations of fungi in cake production chain. Besides, the growth potential of twelve fungal strains in different cake formulations was evaluated. Raw materials from two different batches (n=143), chocolate cakes (n=30), orange cakes (n=20), and processing environment air samples (n=147) were analyzed. Among the raw materials, wheat flour (3.2±0.3 log CFU per g) and corn meal (3.8±0.8 log CFU per g) belonging to batch #1 showed significant higher fungal counts (pcakes were Aspergillus flavus (28.15%), Penicillium citrinum (18.45%), Penicillium paxilli (14.56%), and Aspergillus niger (6.8%), which were also detected in the raw materials and processing environment air. Only Penicillium glabrum and Penicillium citrinum showed visible mycelium (>3mm) in the free of preservative cake formulation at 19th and 44th days of storage at 25°C, respectively. Revealing the biodiversity of fungi in ingredients, air and final products, as well as challenging final products with representative fungal strains may assist to implement effective controlling measures as well as to gather data for the development of more robust cake formulations. Copyright © 2017 Elsevier Ltd. All rights reserved.

  11. [Design and application of a cake-shaping apparatus for drug-separated moxibustion].

    Science.gov (United States)

    Zhu, Ai-Jun; Lu, Xiao-Dong

    2008-08-01

    Acupuncturist makes herbal cakes with traditional manual way, with such disadvantages as slow in making, varying in thickness and size of the cake. When the patients are treated with medical cake-separated moxibustion, they will be unevenly affected by the heat and the patient easily suffers from burning. These hinder clinically wide application of cake-separated moxibustion. With practice of many years, the authors design and make a kind of manual cake-shaping apparatus which can rapidly and conveniently make uniform medical cake, with simple technique, ingenious structure and normal material.

  12. Effect of coal soluble constituents on caking property of coal

    Energy Technology Data Exchange (ETDEWEB)

    Hengfu Shui; Mingdong Zheng; Zhicai Wang; Xunming Li [Anhui University of Technology, Maanshan (China). School of Chemistry and Chemical Engineering, Key Laboratory of Anhui Educational Department

    2007-07-15

    Three cokemaking bituminous coals were extracted by the CS{sub 2}/NMP mixed solvents with different content of NMP, and the effect of the amount and the component of coal soluble constituents on the caking property of the extracted residues of coals were investigated in this study. The CS{sub 2}/NMP mixed solvent (1:1 by volume) was found to give the maximal extraction yields for the three coals, and the fat coal gave the highest extraction yield of 78.6% (daf) corresponding to its highest caking index of 101. It was found that for coking coal, when the extraction yield got to the maximum of 25.3% in the 1:1 by volume of CS{sub 2}/NMP mixed solvent, the residue extracted still had caking property with the caking index of 19. This means parts of the caking constituents of coal are un-extractible because of covalent bonding or strong associative cross-links. The soluble components extracted by the CS{sub 2}/NMP mixed solvent and their effects on the caking indexes of the residues at a similar extraction yield quite differed depending on the NMP content in the mixed solvent. The coal solubles extracted by the CS{sub 2}/NMP mixed solvent with NMP less than 50% contained less light constituents with less of oxygen groups. This may lead to the decrease in the caking indexes for the residues obtained at the similar extraction yields compared to those of the CS{sub 2}/NMP mixed solvent with NMP more than 50%. 11 refs., 5 figs., 3 tabs.

  13. Deoiledjatropha seed cake is a useful nutrient for pullulan production

    Directory of Open Access Journals (Sweden)

    Choudhury Anirban

    2012-03-01

    Full Text Available Abstract Background Ever increasing demand for fossil fuels is a major factor for rapid depletion of these non-renewable energy resources, which has enhanced the interest of finding out alternative sources of energy. In recent years jatropha seed oil has been used extensively for production of bio-diesel and has shown significant potential to replace petroleum fuels at least partially. De-oiled jatropha seed cake (DOJSC which comprises of approximately 55 to 65% of the biomass is a byproduct of bio-diesel industry. DOJSC contains toxic components like phorbol esters which restricts its utilization as animal feed. Thus along with the enhancement of biodiesel production from jatropha, there is an associated problem of handling this toxic byproduct. Utilization of DOJSC as a feed stock for production of biochemicals may be an attractive solution to the problem. Pullulan is an industrially important polysaccharide with several potential applications in food, pharmaceuticals and cosmetic industries. However, the major bottleneck for commercial utilization of pullulan is its high cost. A cost effective process for pullulan production may be developed using DOJSC as sole nutrient source which will in turn also help in utilization of the byproduct of bio-diesel industry. Results In the present study, DOJSC has been used as a nutrient for production of pullulan, in place of conventional nutrients like yeast extract and peptone. Process optimization was done in shake flasks, and under optimized conditions (8% DOJSC, 15% dextrose, 28°C temperature, 200 rpm, 5% inoculum, 6.0 pH 83.98 g/L pullulan was obtained. The process was further validated in a 5 L laboratory scale fermenter. Conclusion This is the first report of using DOJSC as nutrient for production of an exopolysaccharide. Successful use of DOJSC as nutrient will help in finding significant application of this toxic byproduct of biodiesel industry. This in turn also have a significant impact on

  14. Fluidized bed treatment of rapeseed meal and cake as possibility for the production of canolol

    Directory of Open Access Journals (Sweden)

    Pudel Frank

    2014-01-01

    Full Text Available Canolol (2,6-dimethoxy-4-vinylphenol, 4-vinylsyringol, which is formed by thermally initiated CO2splitting off from sinapic acid, possesses a high antioxidant potential. Furthermore different positive physiological properties are described. Due to rapeseed’s high content of phenolic acids, particularly sinapic acid, it is obvious to produce canolol as by-product of rapeseed processing. Roasting of rapeseed meal or cake in a fluidized bed followed by extraction with supercritical carbon dioxide of the formed canolol represents a production procedure which not impairs the commercial oil mill process. This article summarizes results from the roasting process with rapeseed meal and cake in fluidized bed equipments of different design and size showing that it is a suitable technique to transform sinapic acid into canolol. The achieved canolol contents are at 500 mg/kg in minimum, if the material is rapidly cooled-down after reaching the optimal temperature of 165 °C. Further roasting leads to a fast reduction of the canolol content. In addition it could be observed, that the sinapic acid content is not decreasing in the same amount as the canolol content increases. Sinapic acid seems to be “reproduced” during roasting. The reaction mechanisms of the described phenomena are not known.

  15. Development of a method and technology for obtaining vegetable oil from safflower seeds

    Directory of Open Access Journals (Sweden)

    S. T. Antipov

    2017-01-01

    Full Text Available The article is designed and engineered compact line for processing grain safflower, which used the equipment of the increased efficiency, implementing progressive processes with application of modern physical methods of treatment. This line includes bucket Elevator (Noria, a receiving hopper , the air-sieve separator , intermediate tank, Trier (osgoodby and qualitronic, stone-dividing machine and separator for separation of Caucalis lappula, screw conveyor, intermediate bunker, peeler, oil press machines, the device for the deposition of oil (the sump, pump, frame filter. The process of collapse in the grinding pilot plant, in which the destruction of the epithelial layer of the shell is due to the fact that the compression stress in the impact zone exceeds the limit of elastic deformation of the shell of the grain. Conducted sieve analysis, which was studied granulometric composition fed to the compression of the particles of safflower seed , in this case to characterize the granulometric composition of the raw material, consisting of particles of irregular shape, used the concept of equivalent diameter. As a result of the experiments was the dependence of the equivalent particle diameter from the diameter of the sieve. Since the degree of extraction of safflower seed are hugely influenced by the moisture source of the product, was therefore carried out experimental studies of compaction with different moisture content of the seeds , and with the addition of Luz-Ki. From the analysis of graphic dependences were established a range of optimum moisture safflower seed 8,5--10%, providing the lowest residual oil content and hence the greatest yield of oil. Also managed to significantly increase the efficiency of extraction of oil by adding safflower seed pre-milled husks, which allowed to obtain cake with a residual oil content of 12% when you multiply pre-pressing and to 6% at the final extraction

  16. Potentials of biodegraded cashew pomace for cake baking.

    Science.gov (United States)

    Aderiye, B I; Igbedioh, S O; Caurie, S A

    1992-04-01

    The use of biodegraded cashew pomace processed into flour for cake baking was investigated. The physico-chemical changes during the submerged fermentation of the pomace and the organoleptic qualities of the composite cake were also monitored. There was an increase of about 50% in protein content of the pomace after 96 h of fermentation. However, a reduction of about 61% in the total microbial count after 24 h was due to the toxic effect of the organic acids on the microbial cells during fermentation. The cashew flour had high crude fibre (ca. 20-33%) and carbohydrate (ca. 16-47%) values. The composite cake made from a 10:90 combination of 96 h-degraded cashew flour/wheat flour respectively was the most accepted. The cake which had a specific volume of 0.53 ml/g lost 11.1% moisture when 38 g of its batter was exposed to 190 degrees C for 10 minutes. This cake had a calorie value of 293.8/100 g and may be useful in feeding diabetic patients who require low carbohydrate foods.

  17. Designing a Clean Label Sponge Cake with Reduced Fat Content.

    Science.gov (United States)

    Eslava-Zomeño, Cristina; Quiles, Amparo; Hernando, Isabel

    2016-10-01

    The fat in a sponge cake formulation was partially replaced (0%, 30%, 50%, and 70%) with OptiSol™5300.This natural functional ingredient derived from flax seeds, rich in fiber and alpha-linoleic acid, provides a natural substitute for guar and xanthan gums, avoiding E-numbers on labels. The structure and some physicochemical properties of the formulations were examined, sensory analysis was conducted and changes in starch digestibility due to adding this ingredient were determined. Increasing quantities of OptiSol™5300 gave harder cakes, with less weight loss during baking, without affecting the final cake height. There were no significant differences (P > 0.05) in texture, flavor and overall acceptance between the control and the 30% substitution cake, nor in the rapidly digestible starch values. Consequently, replacing up to 30% of the fat with OptiSol™5300 gives a new product with health benefits and a clean label that resembles the full-fat sponge cake. © 2016 Institute of Food Technologists®.

  18. Preparation Of Pure Vanadium Pentoxide From Red Cake

    International Nuclear Information System (INIS)

    ZAREH, M.M.; EL-HAZEK, M.N; BU ZAID, A.H.M; MOHAMED, H.S.

    2010-01-01

    The red cake, extracted from petroleum ash by acid leaching, contains some impurities such as iron, nickel, zinc, Cr and Cu. For purification the red cake, vanadium in the red cake was taken into solution by treating the red cake with soda ash solution at 90 o C, S /L 1/10 and leaching time of 6 h. The obtained leaching efficiency of vanadium reached 99 %. The solution was clarified by filtration and slurred with solid ammonium sulphate (50g/l) and ammonium chloride (50 g/l). The pH of the slurry was kept at 8-9 by adding ammonium hydroxide. Ammonium metavanadate was crystallized from the slurry at room temperature and during the crystallization step, the slurry was kept under mild agitation. The reaction between the sodium vanadate and ammonium sulphate led to the formation of ammonium metavanadate (AMV) 98.35 % (atomic adsorption techniques). The AMV crystals were separated from the residual liquor by filtration, washed with 5% ammonium chloride solution then dried at 100 o C. Over 98.35 % of the vanadium contained in the red cake was recovered by this way as AMV. Thermal decomposition of AMV at 350 o C 1 h yielded 99.32 % pure vanadium pentoxide.

  19. ALUMINUM BOX BUNDLING PRESS

    Directory of Open Access Journals (Sweden)

    Iosif DUMITRESCU

    2015-05-01

    Full Text Available In municipal solid waste, aluminum is the main nonferrous metal, approximately 80- 85% of the total nonferrous metals. The income per ton gained from aluminum recuperation is 20 times higher than from glass, steel boxes or paper recuperation. The object of this paper is the design of a 300 kN press for aluminum box bundling.

  20. DSS / Press Room

    Science.gov (United States)

    Defense Security Service, U.S. Department of Defense Site Map | A-Z Index | Facebook | Twitter Locations Press Room Organizational Structure Careers at DSS Doing Business with DSS Frequently Asked Classification System (NCCS) National Industrial Security System (NISS) ODAA Business Management System (OBMS

  1. OAS :: Press Releases

    Science.gov (United States)

    subscriptions Videos Photos Live Webcast Social Media Facebook @oasofficial Facebook Twitter @oas_official Social Media Facebook Twitter Newsletters Press and Communications Department Contact us at: +1 (202) 370 Rights Actions against Corruption C Children Civil Registry Civil Society Contact Us Culture Cyber

  2. bbPress complete

    CERN Document Server

    Wynne, Rhys

    2013-01-01

    A concise guide, written in an easy-to-follow format.This book is aimed at ambitious website or blog owners looking to add a forum to their site quickly and easily. Basic experience in WordPress and with managing a website is expected. Knowledge of HTML and PHP will be a bonus, though it isn't necessary.

  3. Effect of Pre-gelatinized Wheat Starch on Physical and Rheological Properties of Shortened Cake Batter and Cake Texture

    Directory of Open Access Journals (Sweden)

    F. Ebrahimi

    2016-10-01

    Full Text Available The focus of this study was the effect of 1.5%, 3% and 4.5% pre-gelatinized wheat starch (based on the total weight of cake batter on improving the qualitative properties of shortened cake batter. Specific volume and viscosity of the shortened cake batter were measured for controls, 1.5%, 3% and 4.5% gelatinized starch; some important properties such as texture and sensory evaluation were examined. By increasing pre-gelatinized wheat starch used in the batter, a significant difference was observed in the rheological properties of the batter. Cake batter properties were found improved compared to the control samples. The sample with 3% pre-gelatinized starch had a lower viscosity than other treatments. The treatment with 4.5% pre-gelatinized starch had the lowest specific volume compared to other treatments. The overall results showed that the shortened cake with 3% pre-gelatinized starch was the best treatment in terms of texture and sensory evaluation factors.

  4. A novel laboratory scale method for studying heat treatment of cake flour

    OpenAIRE

    Chesterton, AKS; Wilson, David Ian; Sadd, PI; Moggridge, Geoffrey Dillwyn

    2014-01-01

    A lab-scale method for replicating the time–temperature history experienced by cake flours undergoing heat treatment was developed based on a packed bed configuration. The performance of heat-treated flours was compared with untreated and commercially heat-treated flour by test baking a high ratio cake formulation. Both cake volume and AACC shape measures were optimal after 15 min treatment at 130 °C, though their values varied between harvests. Separate oscillatory rheometry tests of cake ba...

  5. Hydrological methods preferentially recover cesium from nuclear waste salt cake

    International Nuclear Information System (INIS)

    Brooke, J.N.; Hamm, L.L.

    1997-01-01

    The Savannah River Site is treating high level radioactive waste in the form of insoluble solids (sludge), crystallized salt (salt cake), and salt solutions. High costs and operational concerns have prompted DOE to look for ways to improve the salt cake treatment process. A numerical model was developed to evaluate the feasibility of pump and treat technology for extracting cesium from salt cake. A modified version of the VAM3DCG code was used to first establish a steady-state flow field, then to simulate 30 days of operation. Simulation results suggest that efficient cesium extraction can be obtained with low displacement volumes. The actual extraction process will probably be less impressive because of nonuniform properties. 2 refs., 2 figs

  6. Influence of Hydraulic Retention Time on Biogas Production from Frozen Seafood Wastewater using Decanter Cake as Anaerobic Co-digestion Material

    OpenAIRE

    Thaniya Kaosol; Narumol Sohgrathok

    2012-01-01

    In this research, an anaerobic co-digestion using decanter cake from palm oil mill industry to improve the biogas production from frozen seafood wastewater is studied using Continuously Stirred Tank Reactor (CSTR) process. The experiments were conducted in laboratory-scale. The suitable Hydraulic Retention Time (HRT) was observed in CSTR experiments with 24 hours of mixing time using the mechanical mixer. The HRT of CSTR process impacts on the efficiency of biogas production. The best perform...

  7. Experimental study of filter cake formation on different filter media

    International Nuclear Information System (INIS)

    Saleem, M.

    2009-01-01

    Removal of particulate matter from gases generated in the process industry is important for product recovery as well as emission control. Dynamics of filtration plant depend on operating conditions. The models, that predict filter plant behaviour, involve empirical resistance parameters which are usually derived from limited experimental data and are characteristics of the filter media and filter cake (dust deposited on filter medium). Filter cake characteristics are affected by the nature of filter media, process parameters and mode of filter regeneration. Removal of dust particles from air is studied in a pilot scale jet pulsed bag filter facility resembling closely to the industrial filters. Limestone dust and ambient air are used in this study with two widely different filter media. All important parameters like pressure drop, gas flow rate, dust settling, are recorded continuously at 1s interval. The data is processed for estimation of the resistance parameters. The pressure drop rise on test filter media is compared. Results reveal that the surface of filter media has an influence on pressure drop rise (concave pressure drop rise). Similar effect is produced by partially jet pulsed filter surface. Filter behaviour is also simulated using estimated parameters and a simplified model and compared with the experimental results. Distribution of cake area load is therefore an important aspect of jet pulse cleaned bag filter modeling. Mean specific cake resistance remains nearly constant on thoroughly jet pulse cleaned membrane coated filter bags. However, the trend can not be confirmed without independent cake height and density measurements. Thus the results reveal the importance of independent measurements of cake resistance. (author)

  8. Bioenergy and biofertilizer : improvement of biogas production from filter cake

    Energy Technology Data Exchange (ETDEWEB)

    Fonte, A.H. [Environmental Bioremediation Group, Research and Development Agency, GeoCuba, Camaguey (Cuba); Alvarez, R.C. [Provincial Direction of Soils, Camaguey (Cuba)

    2000-07-01

    The anaerobic digestion of sugar mill filter cake (SMFC) was studied using a natural zeolite to intensify the biogas production. The anaerobic digestion (AD) of agricultural waste mixtures in certain proportions is the underlying basis of biogas generation. Earlier studies have shown that certain inert materials can act as stimulators in biogas production when used in conjunction with AD. This study involved three experiments using filter cake from different sugar mills using three doses of zeolite to determine how they stimulate biogas production. Another objective of the study was to determine if the mud of the digester containing the added zeolite has an impact on plants and soil. The study was conducted under glass house conditions using a brown soil with carbonates with neutral pH and high contents of P{sub 2}O{sub 5}, K{sub 2}O and organic matter. It was concluded that it is possible to increase the biogas yield and to improve AD behaviour of the filter cake by using a zeolite adapted to unique operating conditions. The amount of yield depends on the origin of the filter cake, the stimulator dose and age. Results were in the order of 20-40 per cent biogas production. Fresh filter cake was found to produce more biogas. The mud of the anaerobic digestion of the filter cake containing zeolite positively impacted on the agronomic behaviour of the sorghum in relation to P{sub 2}O{sub 5}, K{sub 2}O and organic matter content. 19 refs., 4 tabs.

  9. Navy Bean Flour Particle Size and Protein Content Affect Cake Baking and Batter Quality(1).

    Science.gov (United States)

    Singh, Mukti; Byars, Jeffrey A; Liu, Sean X

    2015-06-01

    Whole navy bean flour and its fine and coarse particle size fractions were used to completely replace wheat flour in cakes. Replacement of wheat flour with whole bean flour significantly increased the protein content. The protein content was adjusted to 3 levels with navy bean starch. The effect of navy bean flour and its fractions at 3 levels of protein on cake batter rheology and cake quality was studied and compared with wheat flour samples. Batters prepared from navy bean flour and its fractions had higher viscosity than the cake flour. Reducing the protein content by addition of starch significantly lowered the viscosity of cake batters. The whole navy bean flour and coarse bean fraction cakes were softer than cakes made with wheat flour but had reduced springiness. Principal component analysis showed a clear discrimination of cakes according to protein. It also showed that low protein navy bean flour cakes were similar to wheat flour cakes. Navy bean flour with protein content adjusted to the level of cake (wheat) flour has potential as a healthy alternative in gluten-free cakes. Published 2015. This article is a U.S. Government work and is in the public domain in the USA.

  10. Dynamic optimization of a dead-end filtration trajectory: non-ideal cake filtration

    NARCIS (Netherlands)

    Blankert, B.; Kattenbelt, C.; Betlem, Bernardus H.L.; Roffel, B.

    2007-01-01

    A control strategy aimed at minimizing energy consumption is formulated for non-ideal dead-end cake filtration with an inside-out hollow fiber ultrafiltration membrane system. The non-ideal behavior was assumed to originate from cake compression, non-linear cake resistance and a variable pump

  11. Soils washing for removal of heavy oil: Naval Air Engineering Center, Lakehurst, NJ

    International Nuclear Information System (INIS)

    Nash, J.H.; Traver, R.P.

    1991-01-01

    With the recognition that large tracts of land are currently unusable as a result of either accidental spills or past industrial practices (such as oil field development), the USEPA Office of Research and Development evaluated soil washing as an alternative remedial technology for heavy oil contaminated soil at a site located on the Naval Air Engineering Center (NAEC), Lakehurst, New Jersey. The researchers used a self-contained, 100-pound-per-hour soil washer. Electrical, pneumatic, and fluid-pumping capabilities were provided by the trailer-mounted system at a remote No. 6 type oil spill site at the Navy base. Chloroform extracts of the contaminated sandy soil recovered a 0.91 gram/milliliter, 950 centistoke viscosity, dark brown, non-PCB oil. By using a surfactant/solvent solution at ambient temperatures, contaminant levels on the soil were reduced from 3.8% (38,000 milligram/kilogram-RCRA hazardous waste designation) to as low as 0.035% (350 milligram/kilogram) oil concentration. Supplemental laboratory evaluations extending the pilot field evaluations showed at elevated temperatures (120F) that residual oil contamination was less than 0.01% (100 milligram/kilogram). This final oil concentration in the treated soil would be defined as clean under the New Jersey Environmental Cleanup and Responsibilities Act (ECRA). A continuous belt press filter was used to recover the oil in a 47% solids cake that could be used as a secondary fuel feed to a waste boiler. The wash water solution was treated and recycled permitting economical operations

  12. Leaching of sodium carbonate cakes by nitric acid

    International Nuclear Information System (INIS)

    Troyanker, L.S.; Nikonov, V.N.

    1977-01-01

    The interaction has been studied of soda cakes of fluorite-rare-earth concentrate with nitric acid. The effect of a number of factors on extraction of REE into a nitric solution has been considered: the final acidity of the pulp, the duration of leaching, and the ratio between solid and liquid phases. The effect of adding aluminium nitrate into the pulp has also been studied. It has been shown that three-stage counterflow leaching of soda cakes with nitric acid increases REE extraction approximately by 10%

  13. Thermal Inactivation of Salmonella Enteritidis Inoculated to Cake and Chicken

    Directory of Open Access Journals (Sweden)

    Ceyda Dadalı

    2018-04-01

    Full Text Available In this study, thermal inactivation of Salmonella Enteritidis inoculated to the cake dough and a whole raw chicken was investigated. The cake dough was inoculated with 6.15 log-cfu/g S. Enteritidis then, thermal treatment was applied at 160°C top-bottom fan cooking mode. The initial count of S. Enteritidis showed reductions 1.49 log-cfu/g, 2.06 log-cfu/g and 4.29 log-cfu/g in the samples from the cold point location from the geometric center of the cake at 5, 7 and 10 minutes of thermal treatment, respectively. Although S. Enteritidis is not detected at the end of 15 minutes of heat treatment, the center of the cake temperature has reached 85.69°C and the cake sample is uncooked and its sensory properties are not acceptable. The cake that is safe and favorable with the sensory properties to the consumers was obtained by heat treatment for 30 minutes. After the cold point of a whole raw chicken was inoculated with 7.29 log-cfu/g S. Enteritidis, thermal treatment was applied at 220°C top-bottom fan cooking mode. The temperature at the cold point of 35 and 45 minutes heat-treated chickens reached 59.33 and 74.08°C, respectively, and 1.93 log-cfu/g and 5.33 log-cfu /g S. Enteritidis reduction caused in the samples respectively. S. Enteritidis cells were not detected in the whole chicken heat treated at 220°C for 60 minutes. The cakes, heat treated at 160°C top-bottom fan cooking mode for 30 minutes, were stored at two different storage temperatures as 4°C and 25°C for 72 hours. The whole chicken, heat treated at 220°C top-bottom fan cooking mode for 60 minutes, was stored at 4°C for 72 hours. S. Enteritidis cells were not detected in the cake and the whole chicken samples after the storage period.

  14. A Cryptographic Moving-Knife Cake-Cutting Protocol

    Directory of Open Access Journals (Sweden)

    Yoshifumi Manabe

    2012-02-01

    Full Text Available This paper proposes a cake-cutting protocol using cryptography when the cake is a heterogeneous good that is represented by an interval on a real line. Although the Dubins-Spanier moving-knife protocol with one knife achieves simple fairness, all players must execute the protocol synchronously. Thus, the protocol cannot be executed on asynchronous networks such as the Internet. We show that the moving-knife protocol can be executed asynchronously by a discrete protocol using a secure auction protocol. The number of cuts is n-1 where n is the number of players, which is the minimum.

  15. Cake properties in ultrafiltration of TiO2 fine particles combined with HA: in situ measurement of cake thickness by fluid dynamic gauging and CFD calculation of imposed shear stress for cake controlling.

    Science.gov (United States)

    Du, Xing; Qu, Fangshu; Liang, Heng; Li, Kai; Chang, Haiqing; Li, Guibai

    2016-05-01

    In this study, the cake buildup of TiO2 fine particles in the presence of humid acid (HA) and cake layer controlling during ultrafiltration (UF) were investigated. Specifically, we measured the cake thickness using fluid dynamic gauging (FDG) method under various solution conditions, including TiO2 concentration (0.1-0.5 g/L), HA concentration (0-5 mg/L, total organic carbon (TOC)), and pH values (e.g., 4, 6 and 10), and calculated the shear stress distribution induced by stirring using computational fluid dynamics (CFD) to analyze the cake layer controlling conditions, including the operation flux (50-200 L m(-2) h(-1)) and TiO2 concentration (0.1-0.5 g/L). It was found that lower TiO2/HA concentration ratio could lead to exceedingly severe membrane fouling because of the formation of a relatively denser cake layer by filling the voids of cake layer with HA, and pH was essential for cake layer formation owing to the net repulsion between particles. Additionally, it was observed that shear stress was rewarding for mitigating cake growth under lower operation flux as a result of sufficient back-transport forces, and exhibited an excellent performance on cake layer controlling in lower TiO2 concentrations due to slight interaction forces on the vicinity of membrane.

  16. Effects of microwave roasting on the yield and composition of cold pressed orange seed oils; Efectos del tostado en microondas sobre el rendimiento y la composición de aceites de semillas de naranja prensados en frío.

    Energy Technology Data Exchange (ETDEWEB)

    Aydeniz Güneşer, B.; Yilmaz, E.

    2017-07-01

    The aim of this study was to valorize orange (Citrus sinensis) seeds, which are generated as waste. This study presents data about raw orange seed, the meal gained after cold pressing, and characterization data of the cold pressed seed oils. Furthermore, the effects of microwave roasting of the seds compared to regular roasting (control) were determined. The oil yield of orange seed cold pressing was around 52.93–62.99%. After cold pressing, 13.57–17.97% oil remained in the meal together with 20.68–25.61% protein. Hence, pressed meals could be valorized for different purposes. Except for turbidity, the color b* value, free acidity, the p-anisidine value and antioxidant capacity, there was no significant difference between the two oil samples for the measured physicochemical properties. Six different fatty acids were quantified and the major fatty acids were linoleic, palmitic and oleic acids. The fatty acid composition of the orange seed oil can be accepted as nutritionally balanced. Among the fifteen sterols quantified, β-sitosterol was dominant (around 77–78%). Likewise, the α-tocopherol content of the samples was not significantly different. The thermal onset and peak temperatures, and enthalpies for crystallization and melting were also reported. This study showed that good quality orange seed oils can be produced by cold pressing, and the oils could be used in food and non-food applications. [Spanish] El objetivo de este estudio fue revalorizar las semillas de naranja (Citrus sinensis), que se generan como residuos. Se presentan datos sobre la semilla de naranja cruda, sus harinas obtenidas después del prensado en frío y sobre la caracterización de los aceites de semillas prensadas en frío. Además, se determinaron los efectos del tostado en microondas de las semillas frente al tostado tradicional. El rendimiento del aceite de prensado en frío fue de 52,93–62,99%. Después de prensado en frío, 13,57–17,97% del aceite permanece en las

  17. Myths About Press Freedom

    Directory of Open Access Journals (Sweden)

    Kaarle Nordenstreng

    2007-06-01

    Full Text Available This article intends to rectify three popular beliefs related to press freedom: (1 that the idea of a free marketplace of ideas with a self-righting truth belongs to original liberalism, (2 that UNESCO’s primary mission is to promote freedom of information, and (3 that the Universal Declaration of Human Rights provides legal safeguards for the media. These beliefs are shown, on the basis of the legacy of liberalism and documents of the international community, to be misleading myths. Instead of accurate readings of the idea of freedom, they serve as ideological positions which are harmful to democracy. The Millennium Declaration provides further proof that the international community has a much more balanced view of freedom of information than that typically held by media professionals. Therefore it is important to liberate the concept of press freedom from its ideological baggage.

  18. Removal of chloride from fly ash produced in hazardous waste incineration by leaching and displacement washing in a vertical filter press.

    Science.gov (United States)

    Kinnarinen, Teemu; Huhtanen, Mikko; Penttilä, Mika; Häkkinen, Antti

    2013-02-01

    Fly ash is generated in large quantities by waste incineration processes. Chloride is commonly present in the fly ash produced by the incineration of hazardous materials, such as polyvinylchloride plastic. Major difficulties related to the disposal and handling of fly ash include the high concentration of easily leachable chlorides, heavy metals and toxic compounds. In order to avoid adverse environmental effects from the disposal of fly ash, the content of soluble chlorides must be reduced. One of the most effective options for chloride removal is leaching and displacement washing in a filter press. The primary aim of this study was to obtain efficient removal of chloride from fly ash by utilizing a leaching and displacement washing process, carried out in a filter press. The secondary objective was to obtain high filtration capacities and low filter cake moisture contents. The slurry was prepared by mixing fly ash with water at an ash:water ratio of 1:2 and filtered to separate the solids from the liquid. After solid-liquid separation, most of the dissolved residual chloride was removed from the filter cake by washing the cake with fresh water in the second stage of separation. It was possible to remove up to 98% of the total chloride and to obtain sufficient filtration capacities. The residual moisture content of the filter cakes varied from 22 to 35 wt%, which meant that the cakes could be disposed of in landfill, or possibly utilized as a construction material.

  19. Press point on prices

    International Nuclear Information System (INIS)

    Schilansky, J.L.

    2005-06-01

    This document presents information and statistical data on the prices of the crude oils, refining and petroleum products, at the date of the 28 June 2005: evolution of the barrel price, supply and demand, geo-policy, consumption, diesel and gasoline, prices at the service station. (A.L.B.)

  20. A review of United States yellow cake precipitation practice

    International Nuclear Information System (INIS)

    Litz, J.E.; Coleman, R.B.

    1980-01-01

    The various process flowsheets used to produce concentrated uranium solutions are reviewed. The choices of flowsheets are affected by ore alkalinity, uranium mineralization, and the impurities solubilized during leaching. The techniques used to precipitate yellow cake from concentrated uranium solutions are reviewed. Consideration is given to precipitation chemistry, reagent requirements, and process equipment and costs for precipitation, dewatering, drying and calcining. (author)

  1. The replacement value of groundnut cake with cooked Bambara ...

    African Journals Online (AJOL)

    Seventy five day-old Anak 2000 broiler chicks were randomly allotted to five dietary treatments 1, 2, 3, 4 and 5 in which groundnut cake (GNC) was replaced by cooked bambara groundnut meal (CBGM) at 0, 25, 50, 75 and 100% levels of inclusion for both starter and finisher phases. Replacement levels of cooked bambara ...

  2. Significance of starch properties and quantity on sponge cake volume

    Science.gov (United States)

    We evaluated the qualitative and quantitative effects of wheat starch on sponge cake (SC) baking quality. Twenty wheat flours, including soft white and club wheat of normal, partial waxy and waxy endosperm, and hard wheat, were tested for amylose content, pasting properties, and SC baking quality. S...

  3. Antioxidative Polyphenols from Defatted Oilseed Cakes: Effect of Solvents

    Directory of Open Access Journals (Sweden)

    Sue-Siang Teh

    2014-02-01

    Full Text Available Defatted hemp, flax and canola seed cakes were extracted with different solvent systems namely methanol, ethanol, acetone, methanol 80%, acetone 80% and mixed solvent of methanol:acetone:water (MAW, 7:7:6, v/v/v. Each extract was analyzed for antioxidant capacity using ferric reducing/antioxidant power (FRAP and 2,2-diphenyl-1-picrylhydrazyl (DPPH radical scavenging assays. MAW exhibited the highest extraction of phenolic and flavonoid contents in the seed cakes, followed by acetone 80% and methanol 80%. The antioxidant capacity was proportional to the polyphenols recovery in the extracts. Canola seed cakes possessed the highest recovery of polyphenols and antioxidant capacity, followed by hemp and flax seed cakes. MAW extract of canola contained total phenolic content, 2104.67 ± 2.52 mg GAE/100 g fresh weight; total flavonoids, 37.79 ± 0.04 mg LUE/100 g fresh weight; percentage inhibition of DPPH•, 33.03 ± 0.38%; FRAP assay, 8.78 ± 0.07 μmol Fe (II/g fresh weight. Identification of individual polyphenol compounds were performed HPLC. MAW extract of canola had the highest (P < 0.05 concentration of all individual polyphenols except gallic acid and catechin. Highest concentration of quercetin and luteolin in MAW extract of hemp was obtained among all solvent systems.

  4. The effect of filter cake viscoelasticity on filtration

    DEFF Research Database (Denmark)

    Christensen, Morten Lykkegaard

    , it is difficult to use the existing mathematical filtration models to simulate and optimise the filtration process. Activated sludge as well as synthetic model particles has been filtrated in this project. The study shows that compression of the formed filter cake is a time dependent process, and not only...

  5. Occurrence of mycotoxins and associated mycoflora in peanut cake ...

    African Journals Online (AJOL)

    Bacteria isolated from peanut cake product were Eschericha coli, Klebsiella spp. and Clostridium spp. The fungal isolates include Aspergillus flavus, Aspergillus parasiticus, Aspergillus spp., Fusarium spp., and Penicillium spp. being the dominant microflora in decreasing frequency of occurrence. High concentrations of ...

  6. Utilisation of enzyme supplemented groundnut cake based diets by ...

    African Journals Online (AJOL)

    A total of 300, twenty weeks old laying hens were used in a feeding trial to evaluate the utilisation of Peanut meal popularly called groundnut cake (GNC) based diets supplemented with enzymes by laying hens. Five dietary treatments were formulated to meet standard nutrient requirements of layers viz: 1. maize- soya ...

  7. Effects of partial replacement of soyabean meal or groundnut cake ...

    African Journals Online (AJOL)

    160 unsexed Nera day old chicks were weighed and randomly divided into 8 experimental groups such that there were 2 replicates of 10 birds each per diet. Eight diets were formulated for the starter and finisher phases. The first four diets had groundnut cake as the protein source and were gradually replaced by sunflower ...

  8. Effect of dietary substitution with solvent extracted neem seed cake ...

    African Journals Online (AJOL)

    STORAGESEVER

    2009-07-06

    Jul 6, 2009 ... Nutritional indices (true nitrogen digestibility, biological value and protein ... Salt. 0.50. 0.50. 0.50. 0.50. -. 0.50. Vitamin Premix2. 0.20. 0.20. 0.20 ... WNSC = Water processed neem seed cake, MNSC = Methanol processed neem seed ... were given ad libitum and pre-measured quantity of food calculated.

  9. Synthetic salt cake standards for analytical laboratory quality control

    International Nuclear Information System (INIS)

    Schilling, A.E.; Miller, A.G.

    1980-01-01

    The validation of analytical results in the characterization of Hanford Nuclear Defense Waste requires the preparation of synthetic waste for standard reference materials. Two independent synthetic salt cake standards have been prepared to monitor laboratory quality control for the chemical characterization of high-level salt cake and sludge waste in support of Rockwell Hanford Operations' High-Level Waste Management Program. Each synthetic salt cake standard contains 15 characterized chemical species and was subjected to an extensive verification/characterization program in two phases. Phase I consisted of an initial verification of each analyte in salt cake form in order to determine the current analytical capability for chemical analysis. Phase II consisted of a final characterization of those chemical species in solution form where conflicting verification data were observed. The 95 percent confidence interval on the mean for the following analytes within each standard is provided: sodium, nitrate, nitrite, phosphate, carbonate, sulfate, hydroxide, chromate, chloride, fluoride, aluminum, plutonium-239/240, strontium-90, cesium-137, and water

  10. Cake kidney: a rare anomaly of renal fusion

    Directory of Open Access Journals (Sweden)

    Guilherme Lippi Ciantelli

    2012-06-01

    Full Text Available ABSTRACT The cake kidney is a rare congenital anomaly of the urinogenital tract that can be diagnosed at any age. Few more than 20 cases have been described in the literature. The authors describe in this article another case of this rare malformation. Key-words: kidney, congenital abnormalities, rare diseases.

  11. Nutritional evaluation of fermented palm kernel cake using red tilapia

    African Journals Online (AJOL)

    The use of palm kernel cake (PKC) and other plant residues in fish feeding especially under extensive aquaculture have been in practice for a long time. On the other hand, the use of microbial-based feedstuff is increasing. In this study, the performance of red tilapia raised on Trichoderma longibrachiatum fermented PKC ...

  12. Effect of replacing groundnut cake with urea fermented brewer's ...

    African Journals Online (AJOL)

    The effect o replacing groundnut cake with urea fermented brewer's dried grains at 0 25 50, 75 and 100 % graded levels in broiler chick starter diets was investigated. Five dietary treatments were formulated to be isonitrogenous and isocaloric to provide 23 % crude protein and 2900 kcal/kg metabolizable energy.

  13. How does particle size influence caking in lactose powder?

    DEFF Research Database (Denmark)

    Carpin, Melanie Anne; Bertelsen, H.; Dalberg, A.

    2017-01-01

    Particle size distribution (PSD) is known to influence product properties such as flowability and compressibility. When producing crystalline lactose, different steps can affect the PSD of the final powder. The aim of this study was to investigate the influence of PSD on caking and the mechanisms...

  14. 175 Years of Linear Programming - Minimax and Cake Topography

    Indian Academy of Sciences (India)

    Home; Journals; Resonance – Journal of Science Education; Volume 4; Issue 7. 175 Years of Linear Programming - Minimax and Cake Topography. Vijay Chandru M R Rao. Series Article Volume 4 Issue 7 July 1999 pp 4-13. Fulltext. Click here to view fulltext PDF. Permanent link:

  15. Degradation of Crude Protein in Groundnut Cake, Guinea Grass ...

    African Journals Online (AJOL)

    Three West African dwarf rams fitted with rumen cannula, were used in a completely randomized design for degradation of crude protein (CP) of groundnut cake (GNC), Panicum maximum, rumen epithelial scraping (RES), and diets containing increasing levels of RES. Concentrate diets were formulated such that 0% (A), ...

  16. Characterization of pecan nut expeller cake and effect of storage on its microbiological and oxidative quality

    International Nuclear Information System (INIS)

    Marchetti, L.; Romero, L.; Andrés, S.C.; Califano, A.N.

    2017-01-01

    Pecan nut expeller cake (PNEC), a by-product of pecan oil extraction, was characterized and the effect of packaging and storage conditions was investigated. Samples were packaged under vacuum or in normal atmosphere and stored (10 or 20 ºC) for 12 months. Its composition, water and oil absorption, fatty acids profile, lipid oxidation (thiobarbituric acid reactive substances, TBARS), antioxidant activity [Diphenyl-1-(2,4,6-trinitrophenyl)hydrazyl] radical, DPPH● and [(2,2′-azinobis-(3-ethylbenzothiazoline-6-sulfonic acid)] radical cation, ABTS●+), and microbiological quality were analyzed. PNEC showed high lipid and fiber contents (51.4 and 21.6 g/100g, respectively) with good water and oil absorption capacity. Vacuum storage at 10 ºC preserved antioxidant capacity (TBARS: malondialdehyde= 0.23 mg/kg, IC50 DPPH = 9.0 mg/mL, and IC50 ABTS = 21 mg/mL after one year storage). Extremely low mold and yeast levels were found in PNEC in low permeability vacuum packages, regardless of the storage temperature. Thus, PNEC could retain suitable quality attributes for up to 12 months using the right combination of packaging and temperature. [es

  17. Characterization of pecan nut expeller cake and effect of storage on its microbiological and oxidative quality

    Directory of Open Access Journals (Sweden)

    L. Marchetti

    2018-01-01

    Full Text Available Pecan nut expeller cake (PNEC, a by-product of pecan oil extraction, was characterized and the effect of packaging and storage conditions was investigated. Samples were packaged under vacuum or in normal atmosphere and stored (10 or 20 ºC for 12 months. Its composition, water and oil absorption, fatty acids profile, lipid oxidation (thiobarbituric acid reactive substances, TBARS, antioxidant activity [Diphenyl-1-(2,4,6-trinitrophenylhydrazyl] radical, DPPH● and [(2,2′-azinobis-(3-ethylbenzothiazoline-6-sulfonic acid] radical cation, ABTS●+, and microbiological quality were analyzed. PNEC showed high lipid and fiber contents (51.4 and 21.6 g/100g, respectively with good water and oil absorption capacity. Vacuum storage at 10 ºC preserved antioxidant capacity (TBARS: malondialdehyde= 0.23 mg/kg, IC50 DPPH = 9.0 mg/mL, and IC50 ABTS = 21 mg/mL after one year storage. Extremely low mold and yeast levels were found in PNEC in low permeability vacuum packages, regardless of the storage temperature. Thus, PNEC could retain suitable quality attributes for up to 12 months using the right combination of packaging and temperature.

  18. Respiratory symptoms and sensitization in bread and cake bakers.

    Science.gov (United States)

    Smith, T A; Smith, P W

    1998-07-01

    This purpose of this study was to examine the relationship between exposure to wheat flour, soya flour and fungal amylase and the development of work-related symptoms and sensitization in bread and cake bakery employees who have regular exposure to these substances. The study populations consisted of 394 bread bakery workers and 77 cake bakery workers whose normal jobs involved the sieving, weighing and mixing of ingredients. The groups were interviewed with the aim of identifying the prevalence, nature and pattern of any work-related respiratory symptoms. They were also skin-prick tested against the common bakery sensitizing agents, i.e., wheat flour, soya flour, rice flour and fungal amylase. The results of personal sampling for sieving, weighing and mixing operations at the bakeries from which the study groups were taken were collated in order to determine typical exposures to total inhalable dust from the ingredients, expressed as 8 hour time-weighted average exposures. Data from the health surveillance and collated dust measurements were compared with the aim of establishing an exposure-response relationship for sensitization. The prevalence of work-related symptoms in bread bakery and cake bakery ingredient handlers was 20.4% and 10.4% respectively. However, in a large proportion of those reporting symptoms in connection with work, the symptoms were intermittent and of short duration. It is considered that the aetiology of such symptoms is likely to be due to a non-specific irritant effect of high total dust levels, rather than allergy. None of the cake bakers and only 3.1% of the bread bakers had symptoms which were thought to be due to allergy to baking ingredients. Using skin-prick testing as a marker of sensitization, the prevalence of positive tests to wheat flour was 6% for the bread bakers and 3% for the cake bakers. Comparable prevalences for soya flour were 7% and 1% respectively. However, the prevalence of positive skin-prick tests to fungal amylase

  19. Effect of selected spices on chemical and sensory markers in fortified rye-buckwheat cakes.

    Science.gov (United States)

    Przygodzka, Małgorzata; Zieliński, Henryk; Ciesarová, Zuzana; Kukurová, Kristina; Lamparski, Grzegorz

    2016-07-01

    The aim of this study was to find out the effect of selected spices on chemical and sensorial markers in cakes formulated on rye and light buckwheat flour fortified with spices. Among collection of spices, rye-buckwheat cakes fortified individually with cloves, nutmeg, allspice, cinnamon, vanilla, and spice mix revealed the highest sensory characteristics and overall quality. Cakes fortified with cloves, allspice, and spice mix showed the highest antioxidant capacity, total phenolics, rutin, and almost threefold higher available lysine contents. The reduced furosine content as well as free and total fluorescent intermediatory compounds were observed as compared to nonfortified cakes. The FAST index was significantly lowered in all cakes enriched with spices, especially with cloves, allspice, and mix. In contrast, browning index increased in compare to cakes without spices. It can be suggested that clove, allspice, vanilla, and spice mix should be used for production of safety and good quality cakes.

  20. Rheological, physical, and sensory attributes of gluten-free rice cakes containing resistant starch.

    Science.gov (United States)

    Tsatsaragkou, Kleopatra; Papantoniou, Maria; Mandala, Ioanna

    2015-02-01

    In this study the effect of resistant starch (RS) addition on gluten-free cakes from rice flour and tapioca starch physical and sensorial properties was investigated. Increase in RS concentration made cake batters less elastic (drop of G'(ω), G''(ω) values) and thinner (viscosity decreased). Cakes specific volume increased with an increase in RS level and was maximized for 15 g/100 g RS, although porosity values were significantly unaffected by RS content. Crumb grain analysis exhibited a decrease in surface porosity, number of pores and an increase in average pore diameter as RS concentration increased. During storage, cake crumb remained softer in formulations with increasing amounts of RS. Sensory evaluation of cakes demonstrated the acceptance of all formulations, with cake containing 20 g/100 g RS mostly preferred. Gluten-free cakes with improved quality characteristics and high nutritional value can be manufactured by the incorporation of RS. © 2015 Institute of Food Technologists®

  1. Valorization of By-Products from Palm Oil Mills for the Production of Generic Fermentation Media for Microbial Oil Synthesis.

    Science.gov (United States)

    Tsouko, Erminda; Kachrimanidou, Vasiliki; Dos Santos, Anderson Fragoso; do Nascimento Vitorino Lima, Maria Eduarda; Papanikolaou, Seraphim; de Castro, Aline Machado; Freire, Denise Maria Guimarães; Koutinas, Apostolis A

    2017-04-01

    This study demonstrates the production of a generic nutrient-rich feedstock using by-product streams from palm oil production that could be used as a substitute for commercial fermentation supplements. Solid-state fermentations of palm kernel cake (PKC) and palm-pressed fiber (PPF) were conducted in tray bioreactors and a rotating drum bioreactor by the fungal strain Aspergillus oryzae for the production of crude enzymes. The production of protease was optimized (319.3 U/g) at an initial moisture content of 55 %, when PKC was used as the sole substrate. The highest free amino nitrogen (FAN) production (5.6 mg/g) obtained via PKC hydrolysis using the crude enzymes produced via solid-state fermentation was achieved at 50 °C. Three initial PKC concentrations (48.7, 73.7, and 98.7 g/L) were tested in hydrolysis experiments, leading to total Kjeldahl nitrogen to FAN conversion yields up to 27.9 %. Sequential solid-state fermentation followed by hydrolysis was carried out in the same rotating drum bioreactor, leading to the production of 136.7 U/g of protease activity during fermentation and 196.5 mg/L of FAN during hydrolysis. Microbial oil production was successfully achieved with the oleaginous yeast strain Lipomyces starkeyi DSM 70296 cultivated on the produced PKC hydrolysate mixed with commercial carbon sources, including glucose, xylose, mannose, galactose, and arabinose.

  2. Progress in hot pressing

    International Nuclear Information System (INIS)

    Brodhag, C.; Thevenot, F.

    1988-01-01

    An experimental technique is described to study hot pressing of ceramics under conditions of controlled temperature and pressure during both the heating and final sintering stages. This method gives a better control of the final microstructure of the material. Transformation mechanisms can be studied during initial heating stage (impurity degasing, reaction, phase transformation, mechanical behavior of intergranular phase...) using computer control and graphical data representations. Some examples will be given for different systems studied in our laboratory: B (α, β, amorphous), B 12 O 2 (reaction of B + B 2 O 3 ), Si 3 N 4 ( + additives), TiN, Al 2 O 3 + AlON,ZrC

  3. Fertilization with filter cake and micronutrients in plant cane

    Directory of Open Access Journals (Sweden)

    Jaqueline Cristiane Adorna

    2013-06-01

    Full Text Available The response of sugarcane to application of micronutrients is still not very well known. In view of the need for this information, the aim of this study was to evaluate the application of the micronutrients Zn, Cu, Mn, Fe, B, and Mo to plant cane in three soils, with and without application of filter cake. This study consisted of three experiments performed in the State of São Paulo, Brazil, (in Igaraçu do Tiete, on an Oxisol; in Santa Maria da Serra, on an Entisol, both in the 2008/2009 growing season; and in Mirassol, on an Ultisol, in the 2009/2010 growing season in a randomized block design with four replications with a 8 x 2 factorial combination of micronutrients (1 - no application/control, 2 - addition of Zn, 3 - addition of Cu, 4 - addition of Mn 5 - addition of Fe, 6 - addition of B, 7 - addition of Mo, 8 - Addition of Zn, Cu, Mn, Fe, B, and Mo and filter cake (0 and 30 t ha-1 of filter cake in the furrow at planting. The application of filter cake was more efficient than of Borax in raising leaf B concentration to sufficiency levels for sugarcane in the Entisol, and it increased mean stalk yield in the Oxisol. In areas without filter cake application, leaf concentrations were not affected by the application of Zn, Cu, Mn, Fe, B, and Mo in the furrow at planting; however, Zn and B induced an increase in stalk and sugar yield in micronutrient-poor sandy soil.

  4. New insights into comparison between synthetic and practical municipal wastewater in cake layer characteristic analysis of membrane bioreactor.

    Science.gov (United States)

    Zhou, Lijie; Zhuang, Wei-Qin; Wang, Xin; Yu, Ke; Yang, Shufang; Xia, Siqing

    2017-11-01

    In previous studies, cake layer analysis in membrane bioreactor (MBR) was both carried out with synthetic and practical municipal wastewater (SMW and PMW), leading to different results. This study aimed to identify the comparison between SMW and PMW in cake layer characteristic analysis of MBR. Two laboratory-scale anoxic/oxic MBRs were operated for over 90days with SMW and PMW, respectively. Results showed that PMW led to rough cake layer surface with particles, and the aggravation of cake layer formation with thinner and denser cake layer. Additionally, inorganic components, especially Si and Al, in PMW accumulated into cake layer and strengthened the cake layer structure, inducing severer biofouling. However, SMW promoted bacterial metabolism during cake layer formation, thus aggravated the accumulation of organic components into cake layer. Therefore, SMW highlighted the organic components in cake layer, but weakened the inorganic functions in practical MBR operation. Copyright © 2017 Elsevier Ltd. All rights reserved.

  5. EFFECTS OF TEMPERATURE AND AIRFLOW ON VOLUME DEVELOPMENT DURING BAKING AND ITS INFLUENCE ON QUALITY OF CAKE

    OpenAIRE

    NURUL ATIQAH SANI; FARAH SALEENA TAIP; SITI MAZLINA MUSTAPA KAMAL; NORASHIKIN AB. AZIZ

    2014-01-01

    Volume and texture of cake are among the important parameters in measuring the quality of cake. The processing conditions play important roles in producing cakes of good quality. Recent studies focused more on the formulation and the manipulation of baking temperature, humidity and time instead of airflow condition. The objective of this study was to evaluate the effects of baking temperature and airflow on the volume development of cake and final cake quality such as volume development, firm...

  6. Potentials of enhancing the physicochemical and functional characteristics of Nigella sativa oil by using the screw pressing technique for extraction; Mejoras potenciales de las características físico-químicas y funcionales del aceite de Nigella sativa mediante extracción con prensa de tornillo

    Energy Technology Data Exchange (ETDEWEB)

    Hamed, S.F.; Shaaban, H.A.; Ramadan, A.A.; Edris, A.E.

    2017-07-01

    In the current investigation the crude oil of Nigella sativa was extracted from seeds using hydraulic and screw pressing techniques. Different parameters were evaluated in order to find out the appropriate technique to enhance the physicochemical and functional-related characteristics of the extracted crude oil. Results showed that the acid and peroxide values were significantly lower in the screw pressed oil (SPO) than in the hydraulic pressed oil (HPO). The total phenolic content of the SPO was significantly higher than that of HPO. Evaluation of the oxidative stability using the Rancimat test showed that SPO recorded a much higher oxidative stability index (40.07 h) than HPO (0.51 h). The yield of the volatile oil fraction and its contents of thymoquinone isolated from the SPO were higher than that from the HPO. Biological evaluation revealed that the SPO had significantly higher antimicrobial activity than HPO against Listeria monocytogenes and Staphylococcus aureus at 40 μL/well. [Spanish] En la presente investigación se extrajo el aceite crudo de Nigella sativa de las semillas utilizando técnicas hidráulicas y de prensado de tornillo. Se evaluaron diferentes parámetros para conocer la técnica apropiada que potencie las características fisicoquímicas y funcionales del aceite extraído. Los resultados mostraron que los valores de ácido y peróxido fueron significativamente más bajos en el aceite de presión con tornillo (SPO) que en el aceite prensado hidráulico (HPO). El contenido fenólico total del SPO fue significativamente mayor que el de HPO. La evaluación de la estabilidad oxidativa mediante Rancimat demostró que el aceite SPO tiene un índice de estabilidad oxidativa mucho más alto (40,07 h) que el HPO (0,51 h). El rendimiento de la fracción volátil y su contenido de timoquinona aislada del aceite SPO fueron superiores a los del HPO. La evaluación biológica reveló que el aceite SPO tenía una actividad antimicrobiana

  7. Olive oil adulterated with hazelnut oils: simulation to identify possible risks to allergic consumers

    NARCIS (Netherlands)

    Arlorio, M.; Coisson, J. D.; Bordiga, M.; Travaglia, F.; Garino, C.; Zuidmeer, L.; van Ree, R.; Giuffrida, M. G.; Conti, A.; Martelli, A.

    2010-01-01

    According to European Union Regulation EC 1531/2001, olive oil labelled as oextra-virgino should be cold-pressed and contain no refined oil or oil from other oleaginous seeds or nuts. Adulteration of extra virgin olive oil (EVOO) with hazelnut oil (HAO) is a serious concern both for oil suppliers

  8. ISS Expedition 08 Press Kit

    Data.gov (United States)

    National Aeronautics and Space Administration — Press kit for ISS mission Expedition 08 from 10/2003-04/2004. Press kits contain information about each mission overview, crew, mission timeline, benefits, and media...

  9. WordPress multisite administration

    CERN Document Server

    Longren, Tyler

    2013-01-01

    This is a simple, concise guide with a step-by-step approach, packed with screenshots and examples to set up and manage a network blog using WordPress.WordPress Multisite Administration is ideal for anyone wanting to familiarize themselves with WordPress Multisite. You'll need to know the basics about WordPress, and having at least a broad understanding of HTML, CSS, and PHP will help, but isn't required.

  10. Treatment of the press residues of pressed grapes on an industrial scale

    Energy Technology Data Exchange (ETDEWEB)

    1978-04-24

    EtOH and tartaric acid are recovered from press residues of grapes by distillation and concentration of the EtOH and extraction of the dried residue after removal of seeds with a mixture of H/sub 2/O and mineral acid. Vegetable oil is extracted from the seeds. Collidal substances are coagulated by roasting prior to extraction of tartaric acid. The grape skins are recovered in flake form.

  11. Four Theories of the Press.

    Science.gov (United States)

    Siebert, Fred S.; And Others

    A systematic understanding of the press requires an understanding of the social and political structures within which the press operates. This book discusses four theories that have determined the kind of press the Western world has had: authoritarian, libertarian, socially responsible, and Soviet communist. Each chapter discusses press…

  12. Évaluation de l’impact de 6 matières grasses (palme et non-palme sur les caractéristiques instrumentales et sensorielles d’une matrice de type cake

    Directory of Open Access Journals (Sweden)

    Delacharlerie Sophie

    2012-03-01

    Full Text Available Six types of fats (oils, shortenings and margarines from different vegetable (hydrogenated or not or animal origins have been studied in a cake model. Cakes have been characterized through Texture Profile Analysis and sensory evaluation. Texture analysis shows that studied fats can be classified in two main categories, giving different texture characteristics: liquid oils on one hand and fats containing a solid fraction on the other. Descriptive sensory evaluation leads to the same conclusions. On the contrary, hedonic sensory evaluation shows no difference between the different fats. The results in this paper indicate also that shortenings classical solid fat content can be reduced, without impact on the final product characteristics. This paper shows thus that the nutritional profile of bakery products can be improved, without sacrificing the sensory quality. Notably, the palm oil content (and thus the saturated fatty acids content reduction of today shortenings could be an answer to nutritional and environmental concerns.

  13. Relative importance of moisture migration and amylopectin retrogradation for pound cake crumb firming.

    Science.gov (United States)

    Luyts, A; Wilderjans, E; Van Haesendonck, I; Brijs, K; Courtin, C M; Delcour, J A

    2013-12-15

    Moisture migration largely impacts cake crumb firmness during storage at ambient temperature. To study the importance of phenomena other than crumb to crust moisture migration and to exclude moisture and temperature gradients during baking, crustless cakes were baked using an electrical resistance oven (ERO). Cake crumb firming was evaluated by texture analysis. First, ERO cakes with properties similar to those baked conventionally were produced. Cake batter moisture content (MC) was adjusted to ensure complete starch gelatinisation in the baking process. In cakes baked conventionally, most of the increase in crumb firmness during storage was caused by moisture migration. Proton nuclear magnetic resonance ((1)H NMR) showed that the population containing protons of crystalline starch grew during cake storage. These and differential scanning calorimetry (DSC) data pointed to only limited amylopectin retrogradation. The limited increase in amylopectin retrogradation during cake storage cannot solely account for the significant firming of ERO cakes and, hence, other phenomena are involved in cake firming. Copyright © 2013 Elsevier Ltd. All rights reserved.

  14. Parameters Affecting the Extraction Process of Jatropha curcas Oil Using a Single Screw Extruder

    Directory of Open Access Journals (Sweden)

    Ali Nurrakhmad Siregar

    2015-07-01

    Full Text Available The most commonly used technique to separate oil and cake from J. curcas seeds is mechanical extraction. It uses simple tools such as a piston and a screw extruder to produce high pressure, driven by hand or by engine. A single screw extruder has one screw rotating inside the barrel and materials simultaneously flow from the feed to the die zone. The highest oil yield can be obtained by a well-designed oil press as well as finding the optimum conditions for all parameters involved during the extraction process. The influence of the parameters in a single screw extruder was studied using finite element analysis and computational fluid dynamics simulation with ANSYS POLYFLOW. The research focused on predicting the velocity, pressure and shear rate in the metering section that influenced the screw rotational speed and mass flow rate. The obtained results revealed that increasing the screw rotational speed will increase the pressure, velocity and shear rate. Meanwhile, increasing the mass flow rate results in decreasing the pressure while the velocity and shear rate remain constant.

  15. Production of Sporotrichum thermophile xylanase by solid state fermentation utilizing deoiled Jatropha curcas seed cake and its application in xylooligosachharide synthesis.

    Science.gov (United States)

    Sadaf, Ayesha; Khare, S K

    2014-02-01

    De-oiled Jatropha curcas seed cake, a plentiful by-product of biodiesel industry was used as substrate for the production of a useful xylanase from Sporotrichum thermophile in solid state fermentation. Under the optimized conditions, 1025U xylanase/g (deoiled seed cake) was produced. The xylanase exhibited half life of 4h at 45°C and 71.44min at 50°C respectively. It was stable in a broad pH range of 7.0-11.0. Km and Vmax were 12.54mg/ml and 454.5U/ml/min respectively. S. thermophile xylanase is an endoxylanase free of exoxylanase activity, hence advantageous for xylan hydrolysis to produce xylooligosachharides. Hydrolysis of oat spelt xylan by S. thermophile xylanase yielded 73% xylotetraose, 15.4% xylotriose and 10% xylobiose. The S. thermophile endoxylanase thus seem potentially useful in the food industries. Copyright © 2013 Elsevier Ltd. All rights reserved.

  16. Which Freedom of the Press?

    DEFF Research Database (Denmark)

    Rytter, Jens Elo

    2010-01-01

    The article surveys the historical and current meaning of "Freedom of the Press" in constitutional and human rights law. Two different conceptions exist, the narrow one defining freedom of the press as the freedom of every one to publish without prior restraint, the broader one defining it as a...... privileged freedom of the organised press to gather and report on information of public interest. These two conceptions have very different answers to the question of whether the press should enjoy some privilege to be exempt from ordinary legislation when such legislation restricts the access of the press to inform...

  17. Palm kernel cake extract exerts hepatoprotective activity in heat-induced oxidative stress in chicken hepatocytes.

    Science.gov (United States)

    Oskoueian, Ehsan; Abdullah, Norhani; Idrus, Zulkifli; Ebrahimi, Mahdi; Goh, Yong Meng; Shakeri, Majid; Oskoueian, Armin

    2014-10-02

    Palm kernel cake (PKC), the most abundant by-product of oil palm industry is believed to contain bioactive compounds with hepatoprotective potential. These compounds may serve as hepatoprotective agents which could help the poultry industry to alleviate adverse effects of heat stress on liver function in chickens. This study was performed to evaluate the hepatoprotective potential of PKC extract in heat-induced oxidative stress in chicken hepatocytes. The nature of the active metabolites and elucidation of the possible mechanism involved were also investigated. The PKC extract possessed free radical scavenging activity with values significantly (p < 0.05) lower than silymarin as the reference antioxidant. Heat-induced oxidative stress in chicken hepatocyte impaired the total protein, lipid peroxidation and antioxidant enzymes activity significantly (p < 0.05). Treatment of heat-induced hepatocytes with PKC extract (125 μg/ml) and silymarin as positive control increased these values significantly (p < 0.05). The real time PCR and western blot analyses revealed the significant (p < 0.05) up-regulation of oxidative stress biomarkers including TNF-like, IFN-γ and IL-1β genes; NF-κB, COX-2, iNOS and Hsp70 proteins expression upon heat stress in chicken hepatocytes. The PKC extract and silymarin were able to alleviate the expression of all of these biomarkers in heat-induced chicken hepatocytes. The gas chromatography-mass spectrometry analysis of PKC extract showed the presence of fatty acids, phenolic compounds, sugar derivatives and other organic compounds such as furfural which could be responsible for the observed hepatoprotective activity. Palm kernel cake extract could be a potential agent to protect hepatocytes function under heat induced oxidative stress.

  18. WordPress for dummies

    CERN Document Server

    Sabin-Wilson, Lisa

    2014-01-01

    The bestselling WordPress guide, fully updated to cover the 2013 enhancements WordPress has millions of users, and this popular guide has sold more than 105,000 copies in its previous editions. With the newest releases of WordPress, author and WordPress expert Lisa Sabin-Wilson has completely updated the book to help you use and understand all the latest features. You'll learn about both the hosted WordPress.com version and the more flexible WordPress.org, which requires third-party hosting. Whether you're switching to WordPress from another blogging platform or just beginning to blog, you'll

  19. 21 CFR 184.1472 - Menhaden oil.

    Science.gov (United States)

    2010-04-01

    ... 21 Food and Drugs 3 2010-04-01 2009-04-01 true Menhaden oil. 184.1472 Section 184.1472 Food and... Substances Affirmed as GRAS § 184.1472 Menhaden oil. (a) Menhaden oil. (1) Menhaden oil is prepared from fish of the genus Brevoortia, commonly known as menhaden, by cooking and pressing. The resulting crude oil...

  20. Product Evaluation Task Force Phase Two report for centrifuge cake

    International Nuclear Information System (INIS)

    Francis, A.J.; Davies, A.

    1990-01-01

    It has been proposed that all Intermediate Level Wastes arising at Sellafield should be encapsulated prior to ultimate disposal. The Product Evaluation Task Force (PETF) was set up to investigate possible encapsulants and to produce and adequate data base to justify the preferred matrices. Three possible types of encapsulants for Centrifuge Cake;- Inorganic cements, Polymer cements, and Polymers, are evaluated using the Kepner Tregoe decision analysis technique. This technique provides a methodology for scoring and ranking alternative options and evaluating any risks associated with an option. The analysis shows that for all four stages of waste management operations ie. Storage Transport, handling and emplacement Disposal, and Process, cement matrices are considerably superior to other potential matrices. A matrix, consisting of nine parts Blast Furnace Slag (BFS) to one part Ordinary Portland Cement (OPC) is recommended as the preferred matrix for Phase 3 studies on Centrifuge Cake. (author)

  1. Toxic effects of chlorinated cake flour in rats.

    Science.gov (United States)

    Cunningham, H M; Lawrence, G A; Tryphonas, L

    1977-05-01

    Four experiments were conducted using weanling Wistar rats to determine whether chlorinated cake flour or its constituents were toxic. Levels of 0.2 and 1.0% chlorine added to unbleached cake flour significantly (p less than 0.01) reduced growth rate by 20.7 and 85.2% and increased liver weight relative to body weight by 16.7 and 25.3%, respectively. Lipids extracted from flour chlorinated at the same levels had similar effects. Rat chow diets containing 0.2 and 0.6% chlorine in the form of chlorinated wheat gluten reduced growth rate and increased liver weight as a percentage of body weight. A rat chow diet containing 0.2% chlorine as chlorinated flour lipids increased absolute liver weight by 40%, kidney by 20%, and heart by 10% compared to pair-fed controls.

  2. Characterization of sponge cake baking in an instrumented pilot oven

    OpenAIRE

    Alain Sommier; Elisabeth Dumoulin; Imen Douiri; Christophe Chipeau

    2012-01-01

    The quality of baked products is the complex, multidimensional result of a recipe, and a controlled heating process to produce the desired final properties such as taste, colour, shape, structure and density. The process of baking a sponge cake in a convective oven at different air temperatures (160-180-220 °C) leading to the same loss of mass was considered in this study. A special mould was used which allowed unidirectional heat transfer in the batter. Instrumentation was developed specific...

  3. Refining of yellow cake by solvent extraction. Pakistan status report

    International Nuclear Information System (INIS)

    Yunus, M.; Muzaffar, A.; Qureshi, M.T.; Qazi, N.K.; Khan, J.R.; Chughtai, N.A.; Zaidi, S.M.H.

    1980-01-01

    The paper describes the pilot-plant studies made at the Pakistan Institute of Nuclear Science and Technology, Rawalpindi, on refining yellow cake. The process units mainly consist of digestion and filtration, solvent extraction, precipitation and filtration, and calcining and reduction. Extraction parameters, such as free acidity in terms of nitrate ion concentration, throughputs and AF index, have been studied in some detail. Product of satisfactory chemical purity, as confirmed by spectrochemical analysis, was produced by this method. (author)

  4. Feeding behavior in lambs fed diets containing crambe cake

    Directory of Open Access Journals (Sweden)

    Mirna Adriane Syperreck

    2016-09-01

    Full Text Available It was evaluated the feeding behavior of lambs fed diets containing 30% sorghum silage and 70% crambe cake (30:70 diet, and 70% sorghum silage and 30% crambe cake (70:30 diet under voluntary and controlled consumption. The experimental design used was a 4 × 4 Latin square, with four animals, four periods, and four treatments; feeding behavior was determined by observation. The results indicated that animals fed the 30:70 diet showed higher DM and NDF (g day-1 than those fed the 70:30 diet. Animals fed the 70:30 diet showed longer feeding times (h kg-1 DM, mastication (min kg-1 DM and min kg-1 NDF, rumination (min day-1 and min kg-1 DM, and the largest number of mericics chewing per bolus; however, a higher feed efficiency (g DM h-1 was observed in the 30:70 diet group. Furthermore, animals feeding voluntarily had higher DM intake and chewed for longer. Therefore, the combined results indicated that crambe cake could be used in the diet of sheep without affecting feeding behavior.

  5. Conversion of Hanford salt cake to glass: laboratory studies

    International Nuclear Information System (INIS)

    Schulz, W.W.; Dressen, A.L.; Hobbick, C.W.; Kupfer, M.J.

    1976-05-01

    Approximately 140 million liters of solid salt cake (mainly NaNO 3 ), produced by evaporation of aged, alkaline high-level wastes, will be stored in underground tanks when the present Hanford Waste Management Program is completed in the early 1980's. These solid wastes can be converted to silicate-based glasses by melting them either at 1200 to 1300 0 C with appropriate amounts of sand and lime (soda-lime formulation) or at 1000 to 1100 0 C with appropriate amounts of Columbia River basalt and B 2 O 3 (basalt formulation). Both formulations yield dense, immobile glasses of low water leachability (10 -7 to 10 -6 g cm -2 day -1 ) suitable for terminal storage. The soda-lime formulation is presently preferred over the basalt formulation because it can accommodate more salt cake (50 wt percent versus 30 to 40 wt percent) while yielding a glass whose volume is 10 to 20 percent less than the volume of the salt cake in the melt charge

  6. CRAMBE CAKE (Crambe abyssinica hochst ON LAMB DIETS

    Directory of Open Access Journals (Sweden)

    Érika Breda Canova

    2015-02-01

    Full Text Available The use of alternative feedstuffs in animal diet, such as residues derived from the biodiesel production aims to increase productivity and reduce costs in animal production. Them aim of this study was to evaluate the substitution effect of 0, 22, 44 and 64% of soybean meal protein by Crambe cake (Crambe abyssinica Hochst protein in lamb diet. In the in vivo experiment, 20 lambs were used and evaluated the apparent digestibility, nitrogen balance and voluntary DM intake. The replacement of the protein resulted in a linear decrease in apparent digestibility coefficient (ADC of dry matter (DM, organic matter (OM, ether extract (EE, gross energy (GE, acid detergent fiber (ADF, neutral detergent fiber (NDF, cellulose (CEL and the percentage of total digestible nutrients (TDN, which resulted in decreased daily DM intake. The blood level of urea, glucose, alanine aminotransferase (ALT and aspartate aminotransferase (AST were not affected. In vitro gas production technique (GP evaluation of diets showed a significantly decrease (P<0.05 of the total gas and methane production without altering the true degradability of DM and OM and the partition factor (PF. Replacement of soybean meal protein by the Crambe cake protein decreased digestibility of the fiber fraction of the diet, the voluntary intake of DM and methane, without altering rumen fermentation. Crambe cake can be utilized as lamb's food, because, despite reduced intake, assure a large energy intake and similarity to soybean meal protein.

  7. SIFAT ORGANOLEPTIK SUBTITUSI TEPUNG KIMPUL DALAM PEMBUATAN CAKE

    Directory of Open Access Journals (Sweden)

    Taufik Rafika

    2014-01-01

    Full Text Available Organoleptic properties of kimpul flour substitution in the cake making. Kimpul is a one of tuber food source, which contains carbohidrate, protein, fat, some mineral and vitamins. The aims of this research is to find out the sensory properties (hedonic quality and hedonic of the kimpul cake flour substitution. This experimental research uses a completely-randomized design using an analysis of variance. The results analysis of the hedonic quality of color, texture and flavor obtain the highest mean rates at the amount of 40% substitution of kimpul flour, and the results  were not significantly different between treatments. The hedonic test of color, flavor, and texture obtain the highest mean rates at the amount of 80% substitution of kimpul flour.   Kimpul merupakan sumber pangan umbi-umbian yang mengandung karbo­hidrat, protein, lemak, beberapa mineral dan vitamin. Tujuan dari penelitian ini adalah  mengetahui sifat sensori (mutu hedonik dan hedonik cake subtitusi tepung kimpul. Penelitian eksperimen ini menggunakan metode rancangan acak lengkap  mengguna­kan analisis sidik ragam (Analysis of Variance. Hasil analisis uji mutu hedonik warna, tekstur dan rasa memperoleh rerata tertinggi pada jumlah substitusi tepung kimpul 40% yang tidak berbeda antar perlakuan. Uji hedonik (uji tingkat kesukaan warna, rasa, dan tekstur  memperoleh rerata tertinggi pada jumlah subtitusi tepung kimpul 80%.

  8. Physicochemical and Sensory Characteristics of Sponge Cakes with Rubus coreanus Powder.

    Science.gov (United States)

    Lee, Jun Ho

    2015-09-01

    To develop new type of sponge cake, the effects of partial (0~40%) replacement with Rubus coreanus powder (RCP) on the quality characteristics of sponge cakes were investigated. The pH level and moisture content ranged from 4.05~8.23 and 28.49~36.59, respectively, and significantly decreased upon addition of RCP (PBaking loss rate and cake firmness significantly increased with higher RCP content in the formulation, whereas morphological characteristics of cakes such as height, volume, and symmetry indices significantly decreased (P<0.05). For crumb color values, L*- and b*-values significantly decreased while a*-value significantly increased as a result of RCP substitution (P<0.05). Hedonic sensory results indicated that sponge cakes supplemented with 30~40% RCP showed the most favorable acceptance scores for most of the sensory attributes evaluated. Overall, Rubus coreanus sponge cake could be developed with comparable physicochemical qualities without sacrificing consumer acceptability.

  9. Structural development of sucrose-sweetened and sucrose-free sponge cakes during baking.

    Science.gov (United States)

    Baeva, Marianna Rousseva; Terzieva, Vesselina Velichkova; Panchev, Ivan Nedelchev

    2003-06-01

    The influence of sucrose, wheat starch and sorbitol upon the heat- and mass-exchanging processes forming the structure of sponge cake was studied. Under the influence of wheat starch and sorbitol the structure of the sucrose-free sponge cake was formed at more uniform total moisture release. This process was done at lower temperatures and smoother change of the sponge cake height with respect to the sucrose-sweetened sponge cake. The porous and steady structure of both cakes was finally formed at identical time--between 18th and 19th minute, at the applied conditions for baking of each batter (metal pan with diameter 15.4 cm and depth 6.2 cm containing 300 g of batter and placed in an electric oven "Rahovetz-02", Bulgaria for 30 min at 180 degrees C). The water-losses at the end of baking (10.30% and 10.40% for the sucrose-sweetened cake and sucrose-free cake, respectively) and the final temperatures reached in the crumb central layers (96.6 degrees C and 96.3 degrees C for the sucrose-sweetened cake and sucrose-free cake, respectively) during baking of both samples were not statistically different. The addition of wheat starch and sorbitol in sucrose-free sponge cake lead to the statistically different values for the porosity (76.15% and 72.98%) and the volume (1014.17 cm3 and 984.25 cm3) of the sucrose-sweetened and sucrose-free sponge cakes, respectively. As a result, the sucrose-free sponge cake formed during baking had a more homogeneous and finer microstructure with respect to that ofthe sucrose-sweetened one.

  10. WordPress For Dummies

    CERN Document Server

    Sabin-Wilson, Lisa

    2011-01-01

    The bestselling guide to WordPress, fully updated to help you get your blog going! Millions of bloggers rely on WordPress, the popular, free blogging platform. This guide covers all the features and improvements in the most up-to-date version of WordPress. Whether you are switching to WordPress from another blogging platform or just starting your first blog, you'll find the advice in this friendly guide gets you up to speed on both the free-hosted WordPress.com version and WordPress.org, which requires the purchase of web hosting services, and figure out which version is best for you. You'll b

  11. Direct Estimate of Cocoa Powder Content in Cakes by Colorimetry and Photoacoustic Spectroscopy

    Science.gov (United States)

    Dóka, O.; Bicanic, D.; Kulcsár, R.

    2014-12-01

    Cocoa is a very important ingredient in the food industry and largely consumed worldwide. In this investigation, colorimetry and photoacoustic spectroscopy were used to directly assess the content of cocoa powder in cakes; both methods provided satisfactory results. The calibration curve was constructed using a series of home-made cakes containing varying amount of cocoa powder. Then, at a later stage, the same calibration curve was used to quantify the cocoa content of several commercially available cakes. For self-made cakes, the relationship between the PAS signal and the content of cocoa powder was linear while a quadratic dependence was obtained for the colorimetric index (brightness) and total color difference ().

  12. Dominant thermogravimetric signatures of lignin in cashew shell as compared to cashew shell cake.

    Science.gov (United States)

    Gangil, Sandip

    2014-03-01

    Dominant thermogravimetric signatures related to lignin were observed in cashew shell as compared to these signatures in cashew shell cake. The phenomenon of weakening of lignin from cashew shell to cashew shell cake was explained on the basis of changes in the activation energies. The pertinent temperature regimes responsible for the release of different constituents of both the bio-materials were identified and compared. The activation energies of cashew shell and cashew shell cake were compared using Kissinger-Akahira-Sunose method. Thermogravimetric profiling of cashew shell and cashew shell cake indicated that these were different kinds of bio-materials. Copyright © 2013 Elsevier Ltd. All rights reserved.

  13. WordPress Top Plugins

    CERN Document Server

    Corbin, Brandon

    2010-01-01

    Time flies when you're having fun. This is the right way to describe this WordPress Top Plugins book by Brandon Corbin. With real world examples and by showing you the perks of having these plugins installed on your websites, the author is all set to captivate your interest from start to end. Regardless of whether this is your first time working with WordPress, or you're a seasoned WordPress coding ninja, WordPress Top Plugins will walk you through finding and installing the best plugins for generating and sharing content, building communities and reader base, and generating real advertising r

  14. Hypocholesterolemic impact of newly isolated sophorolipids produced by microbial conversion of safflower oil cake in rats fed high-fat and cholesterol diet; Efecto hipocolesterolémico de soforolípidos recién aislados producidos por la conversión microbiana de la torta de aceite de cártamo en ratas alimentadas con una dieta rica en grasas y colesterol

    Energy Technology Data Exchange (ETDEWEB)

    Nooman, M.U.; Mahmoud, M.H.; Al-kashef, A.S.; Rashad, M. M.

    2017-07-01

    The present study aims to produce low cost sophorolipids, and to evaluate their potential hypocholesterolemic impact. Sophorolipids were produced by Candida bombicola grown on safflower oil cake, extracted by methanol followed by ethyl acetate with a yield of 24.4 and 48.3 g·100 g−1 mixed substrate, respectively. Their structure was confirmed by FTIR and 1H NMR and proven to be safe when subjected to an acute toxicity test. A biological experiment was done on 42 male albino rats classified into six groups for 4 weeks following an induction period for hypercholesterolemia of 8 weeks. The two extracts and their mixture were examined for their hypocholesterolemic effect compared to rosuvastatin. The results revealed a reduction in total cholesterol, low density lipoprotein cholesterol, atherogenic index, liver transaminases’ activity and malondialdehyde. They also revealed an elevation in high density lipoprotein cholesterol and antioxidant enzymes which was more efficient than rosuvastatin. Histopathological examination confirmed these results. In conclusion, the newly isolated sophorolipids are powerful hypocholesterolemic compounds which are even more efficient and safer than rosuvastatin. [Spanish] El presente estudio tiene como objetivo producir soforolípidos de bajo costo, evaluando su potencial impacto hipocolesterolémico. Los soforolípidos fueron producidos por Candida bombicola cultivada en torta de aceite de cártamo, extraída con metanol seguido de acetato de etilo con un rendimiento de 24,4 y 48,3 g·100 g−1 de sustrato mixto, respectivamente. Su estructura fue confirmada por FTIR y 1H RMN y demostró ser segura cuando se sometió a prueba de toxicidad aguda. Un experimento biológico se realizó con 42 ratones albinos machos clasificados en seis grupos, durante 4 semanas, después de un período de inducción al hipercolesterolemia de 8 semanas. Se examinaron los dos extractos y su mezcla para determinar su efecto hipocolesterolémico en

  15. Indre spenninger og ytre press

    DEFF Research Database (Denmark)

    Ibsen, Bjarne

    2011-01-01

    Anmeldelse af bogen 'Norsk idrett. Indre spenninger og ytre press' redigeret af Dag Vidar Hanstad, Gunnar Breivik, Mari Kristin Sisjord og Hans B. Skaset og udgivet af forlaet akilles.......Anmeldelse af bogen 'Norsk idrett. Indre spenninger og ytre press' redigeret af Dag Vidar Hanstad, Gunnar Breivik, Mari Kristin Sisjord og Hans B. Skaset og udgivet af forlaet akilles....

  16. BuddyPress theme development

    CERN Document Server

    Lister, Tammie

    2013-01-01

    This book is a hands-on tutorial guide to using BuddyPress.This book is great for designers and developers who are looking to learn how to develop BuddyPress themes. It's assumed that the reader has some understanding of Wordpress and is familiar with CSS and HTML.

  17. [Effects of herb cake-separated moxibustion on spleen in immunosuppressive rabbits:a morphology study].

    Science.gov (United States)

    Tian, Yuefeng; Wu, Aihua; Wang, Jun; Shan, Zengtian

    2016-10-12

    To observe the influence of different methods of moxibustion on spleen morphology in cyclophosphamide-induced immunosuppressive rabbits. A total of 50 rabbits were randomly assigned into a blank group, a model group, a herbal cake-separated moxibustion group, a moxibustion group and a sham cake-separated moxibustion group, 10 rabbits in each group. Except the blank group, the rabbits in each group were treated with intraperitoneal injection of cyclophosphamide (60 mg/kg), once a day, for 7 consecutive days to establish immunosuppressive model. After the model establishment, the rabbits in the herbal cake-separated moxibustion group were treated with herbal cake-separated moxibustion at "Shenque" (CV 8), "Guanyuan" (CV 4), "Zusanli" (ST 36), "Pishu" (BL 20) and "Shenshu" (BL 23); the moxa cone was placed on the herbal cake which was made of Liuwei Dihuang decoction, three cones for each acupoint. The rabbits in the moxibustion group were treated with moxa stick moxibustion which contained equal moxa of three moxa cones. The rabbits in the sham cake-separated moxibustion group were treated with cake which was made of flour. The acupoint selection in the above three groups was identical, and the intervention was given once every other day for totally 10 times. The rabbits in the blank group and model group were immobilized for identical time without any intervention. After treatment, the rabbits were sacrificed to collect the spleen. With routine HE staining, the morphology changes of spleen were observed under microscope. In addition, the white pulp, splenic corpuscle and the counts of lymphatic cells of lymphatic sheath around the arteries were observed. Compared with the blank group, the average size of white pulp and the radius of splenic corpuscle were reduced (both P 0.05). Compared with the model group, the averagesize of white pulp and the radius of splenic corpuscle were significantly increased in the herbal cake-separated moxibustion group and moxibustion

  18. Microbial protein and blood parameters of goats fed with licury cake

    Directory of Open Access Journals (Sweden)

    Máikal Souza Borja

    2014-02-01

    Full Text Available The objective of this study was to determine the ideal level of licury cake in the diet of Boer goats through microbial synthesis estimated based on the presence of purine derivatives in the urine and on blood urea and glucose parameters. Twenty uncastrated one-year-old ¾ Boer goats with an average body weight of 18 kg were distributed in a completely randomized design. Each animal was confined to a one m2 suspended stall with access to water ad libitum. The diets were formulated in accordance with the NRC (2007, and the ingredients were: 50% Tifton-85 (Cynodon sp hay, corn meal, soybean meal, premixed vitamin and mineral supplement, and licury cake. The treatments were: 1 0% of the goat’s total diet composed of licury cake (DM basis, 2 15% of the total diet composed of licury cake, 3 30% of the diet composed of licury cake, and 4 45% of the diet composed of licury cake. The experiment lasted for 17 days. The first 10 days were used to adapt the animals to the diets and facilities. The inclusion of the licury cake in the goat’s diets reduced the levels of blood nitrogen and glucose. Urinary excretion decreased linearly with the inclusion of licury cake in the diet. The inclusion of licury cake in the goat’s diets also caused a linear reduction in the excretion of allantoin, xanthine and hypoxanthine and total purine derivative (PD in urine samples. Based on the microbial protein production and blood parameters of goats fed with licury cake, up to 15% of the goat diet may be composed of licury cake.

  19. Head First WordPress

    CERN Document Server

    Siarto, Jeff

    2010-01-01

    Whether you're promoting your business or writing about your travel adventures, Head First WordPress will teach you not only how to make your blog look unique and attention-grabbing, but also how to dig into the more complex features of WordPress 3.0 to make your website work well, too. You'll learn how to move beyond the standard WordPress look and feel by customizing your blog with your own URL, templates, plugin functionality, and more. As you learn, you'll be working with real WordPress files: The book's website provides pre-fab WordPress themes to download and work with as you follow al

  20. Analysis of Bioactive Components of Oilseed Cakes by High-Performance Thin-Layer Chromatography-(Bioassay Combined with Mass Spectrometry

    Directory of Open Access Journals (Sweden)

    Sue-Siang Teh

    2015-03-01

    Full Text Available Hemp, flax and canola seed cakes are byproducts of the plant oil extraction industry that have not received much attention in terms of their potential use for human food instead of animal feed. Thus, the bioactivity profiling of these oilseed cakes is of interest. For their effect-directed analysis, planar chromatography was combined with several (bioassays, namely 2,2-diphenyl-1-picrylhydrazyl scavenging, acetylcholine esterase inhibition, planar yeast estrogen screen, antimicrobial Bacillus subtilis and Aliivibrio fischeri assays. The streamlined high-performance thin-layer chromatography (HPTLC-bioassay method allowed the discovery of previously unknown bioactive compounds present in these oilseed cake extracts. In contrast to target analysis, the direct link to the effective compounds allowed comprehensive information with regard to selected effects. HPTLC-electrospray ionization-mass spectrometry via the elution-head based TLC-MS Interface was used for a first characterization of the unknown effective compounds. The demonstrated bioactivity profiling on the feed/food intake side may guide the isolation of active compounds for production of functional food or for justified motivation of functional feed/food supplements.

  1. Smashing WordPress Themes Making WordPress Beautiful

    CERN Document Server

    Hedengren, Thord Daniel

    2011-01-01

    The ultimate guide to WordPress Themes - one of the hottest topics on the web today WordPress is so much more than a blogging platform, and Smashing WordPress Themes teaches readers how to make it look any way they like - from a corporate site, to a photography gallery and moreWordPress is one of the hottest tools on the web today and is used by sites including The New York Times, Rolling Stone, flickr, CNN, NASA and of course Smashing MagazineBeautiful full colour throughout - web designers expect nothing lessSmashing Magazine will fully support this book by by promoting it through their webs

  2. Characterization and mosquitocidal potential of neem cake-synthesized silver nanoparticles: genotoxicity and impact on predation efficiency of mosquito natural enemies.

    Science.gov (United States)

    Chandramohan, Balamurugan; Murugan, Kadarkarai; Panneerselvam, Chellasamy; Madhiyazhagan, Pari; Chandirasekar, Ramachandran; Dinesh, Devakumar; Kumar, Palanisamy Mahesh; Kovendan, Kalimuthu; Suresh, Udaiyan; Subramaniam, Jayapal; Rajaganesh, Rajapandian; Aziz, Al Thabiani; Syuhei, Ban; Alsalhi, Mohamad Saleh; Devanesan, Sandhanasamy; Nicoletti, Marcello; Wei, Hui; Benelli, Giovanni

    2016-03-01

    Mosquitoes (Diptera: Culicidae) serve as important vectors for a wide number of parasites and pathogens of huge medical and veterinary importance. Aedes aegypti is a primary dengue vector in tropical and subtropical urban areas. There is an urgent need to develop eco-friendly mosquitocides. In this study, silver nanoparticles (AgNP) were biosynthesized using neem cake, a by-product of the neem oil extraction from the seed kernels of Azadirachta indica. AgNP were characterized using a variety of biophysical methods, including UV-vis spectrophotometry, FTIR, SEM, EDX, and XRD analyses. Furthermore, the neem cake extract and the biosynthesized AgNP were tested for acute toxicity against larvae and pupae of the dengue vector Ae. aegypti. LC50 values achieved by the neem cake extract ranged from 106.53 (larva I) to 235.36 ppm (pupa), while AgNP LC50 ranged from 3.969 (larva I) to 8.308 ppm (pupa). In standard laboratory conditions, the predation efficiency of a Carassius auratus per day was 7.9 (larva II) and 5.5 individuals (larva III). Post-treatment with sub-lethal doses of AgNP, the predation efficiency was boosted to 9.2 (larva II) and 8.1 individuals (larva III). The genotoxic effect of AgNP was studied on C. auratus using the comet assay and micronucleus frequency test. DNA damage was evaluated on peripheral erythrocytes sampled at different time intervals from the treatment; experiments showed no significant damages at doses below 12 ppm. Overall, this research pointed out that neem cake-fabricated AgNP are easy to produce, stable over time, and can be employed at low dosages to reduce populations of dengue vectors, with moderate detrimental effects on non-target mosquito natural enemies.

  3. Dynamics of acoustic-convective drying of sunflower cake

    Science.gov (United States)

    Zhilin, A. A.

    2017-10-01

    The dynamics of drying sunflower cake by a new acoustic-convective method has been studied. Unlike the conventional (thermal-convective) method, the proposed method allows moisture to be extracted from porous materials without applying heat to the sample to be dried. Kinetic curves of drying by the thermal-convective and acoustic-convective methods were obtained and analyzed. The advantages of the acoustic-convective extraction of moisture over the thermal-convective method are discussed. The relaxation times of drying were determined for both drying methods. An intermittent drying mode which improves the efficiency of acoustic-convective extraction of moisture is considered.

  4. Cake Flour Is Not Just Any Old White Powder: A Fun Take-Home Experiment

    Science.gov (United States)

    McMullen, Kevin; Rasmus, C.; Virtue, Melinda; Slik, Kate; Wrigley, Colin

    2014-01-01

    Baking cakes with different recipes can provide an exercise in the application of the scientific method, illustrating the need to vary only one ingredient at a time for correct derivation of conclusions. This experiment, most likely to be performed at home, compares a cake flour with flours from durum wheat, rice and cornflour (gluten-free…

  5. Changes in chemical composition and antioxidative properties of rye ginger cakes during their shelf-life.

    Science.gov (United States)

    Zieliński, Henryk; del Castillo, Maria Dolores; Przygodzka, Małgorzata; Ciesarova, Zuzana; Kukurova, Kristina; Zielińska, Danuta

    2012-12-15

    Changes in chemical composition and antioxidative properties of rye ginger cakes during their shelf-life were investigated in this study. In particular, the changes in antioxidants content, antioxidative and reducing capacity, and Maillard reaction development in rye ginger cakes after long-term storage were addressed. Ginger cakes produced according to the traditional and current recipe were stored for 5 years at room temperature in a dark place. The total phenolic compounds (TPC), inositol hexaphosphate (IP6), reduced (GSH) and oxidised glutathione (GSSG) contents, antioxidant and reducing capacity and Maillard reaction products (MRPs) were determined in ginger cakes after storage and then compared to those measured after baking. After long-term storage a decrease in TPC and IP6 contents in cakes was noted. In contrast, an increase in antioxidative and reducing capacity of stored cakes was observed. Long-term storage induced formation of furosine, advanced and final Maillard reaction products and caused changes in both reduced and oxidised forms of glutathione. After long-term storage the modest changes in furosine, FAST index and browning in ginger cake formulated with dark rye flour may suggest that this product is the healthiest among others. Therefore, traditional rye ginger cakes can be considered as an example of a healthy food that is also relatively stable during long term storage as noted by the small chemical changes observed in its composition. Copyright © 2012 Elsevier Ltd. All rights reserved.

  6. The applicability of fluoride volatility process to producing UF6 from yellow cake

    International Nuclear Information System (INIS)

    Xia Dechang

    2005-01-01

    The schematic diagrams producing UF 6 from yellow cake are showed in this paper. The characteristics and process improvements of the fluoride volatility process are explained. The applicability of the fluoride volatility process to producing UF 6 from yellow cake is discussed. (authors)

  7. Quality characteristics of egg-reduced pound cakes following WPI and emulsifier incorporation

    NARCIS (Netherlands)

    Paraskevopoulou, A.; Donsouzi, S.; Nikiforidis, C.V.; Kiosseoglou, V.

    2015-01-01

    The effect of partial (50 wt%) or total liquid egg replacement by whey proteins in combination with emulsifiers, i.e. hydroxypropylmethylcellulose (HPMC) and sodium stearoyl-2-lactylate (SSL), on the quality of pound cakes was investigated. Cakes containing whey protein isolate (WPI) solutions of

  8. Effect of transglutaminase on some properties of cake enriched with various protein sources.

    Science.gov (United States)

    Alp, H; Bilgiçli, N

    2008-06-01

    The effect of transglutaminase (TG) enzyme addition (0% and 0.09%) on batter and cake properties, prepared with different protein sources (nonfat dry milk [NFDM], soy flour, and soymilk) and flour types (type A with 11.4% protein and type B with 8.6% protein), was investigated. Specific gravity and pH of cake batters were determined, and physical and chemical analysis of the cake samples was performed. Soy products improved cake weight, volume, softness, protein, and fat contents. NFDM increased the crust redness and crumb lightness more than the other protein sources. TG enzyme addition affected the volume, softness, crust, and crumb color of the cake samples significantly (P flour B with lower protein gave more puffed, symmetrical, and softer cake samples. TG had a potential application with different protein sources in cake production. Especially interactions between TG with soy flour and TG and wheat flour with high protein content were important in cake formulations due to the softening effect on crumb.

  9. Nitrogen mineralization from anaerobically digested centrifuge cake and aged air-dried biosolids.

    Science.gov (United States)

    Kumar, Kuldip; Hundal, Lakhwinder S; Cox, Albert E; Granato, Thomas

    2014-09-01

    This study was conducted to estimate nitrogen (N) mineralization of anaerobically digested centrifuge cake from the Stickney Water Reclamation Plant (SWRP) and Calumet Water Reclamation Plant (CWRP), lagoon-aged air-dried biosolids from the CWRP, and Milorganite at three rates of application (0, 12.5 and 25 Mg ha(-1)). The N mineralized varied among biosolids as follows: Milorganite (44%) > SWRP centrifuge cake (35%) > CWRP centrifuge cake (31%) > aged air-dried (13%). The N mineralized in the SWRP cake (32%) and CWRP aged air-dried biosolids (12%) determined from the 15N study were in agreement with the first study. The N mineralization value for centrifuge cake biosolids observed in our study is higher than the value given in the Part 503 rule and Illinois Part 391 guidelines. These results will be used to fine-tune biosolids application rate to match crop N demand without compromising yield while minimizing any adverse effect on the environment.

  10. Effect of sunflower cake supplementation on meat quality of indigenous goat genotypes of South Africa.

    Science.gov (United States)

    Xazela, N M; Chimonyo, M; Muchenje, V; Marume, U

    2012-01-01

    The effect of four castrated goat genotypes and sunflower cake supplementation on goat meat quality was determined. Supplemented Boer (BOR) and Xhosa-Boer cross (XBC) goats had significantly higher (Pgoats had higher pH24 (Pgoats. For each genotype, the sunflower cake supplemented and non-supplemented goats had similar a* values, except for the XLE goats. In the XLE goats, the a* values were lower in the sunflower cake supplemented goats. Sunflower cake supplemented BOR goats had higher L*values than their non-supplemented counterparts (Pgoats also had higher b* values as compared to their non-supplemented counterparts. In comparison with the Boer goat, the XLE and NGN goats had lower CDM, L* and WBF values but generally had higher CL and a* values. Sunflower cake supplementation improved meat quality attributes of the goats. Copyright © 2011 Elsevier Ltd. All rights reserved.

  11. Effects of shading time on quality of matcha and matcha cake

    Directory of Open Access Journals (Sweden)

    LI Hui

    2014-12-01

    Full Text Available Effects of shading time on the quality of Matcha and the Matcha cake.It showed that shading could help the systhesis of nitrogen compounds such as amino acids,caffeine chlorophyll and protein,but couldn′t favor accumulation of tea polyphenol and polysaccharides.The more shading time was,the more chlorophyll content would be,and the more green of Matcha color would be.After Matcha cake was baked,the green color reduced.The colors of Macha cake are greener with longer shading time.Thus,the length of Shading time has obvious effect on the green tea and the tea cake quality,We can adjust the Matcha cake taste,flavor and color by adding Matcha from different shading time.

  12. Numerical modelling of powder caking at REV scale by using DEM

    Science.gov (United States)

    Guessasma, Mohamed; Silva Tavares, Homayra; Afrassiabian, Zahra; Saleh, Khashayar

    2017-06-01

    This work deals with numerical simulation of powder caking process caused by capillary condensation phenomenon. Caking consists in unwanted agglomeration of powder particles. This process is often irreversible and not easy to predict. To reproduce mechanism involved by caking phenomenon we have used the Discrete Elements Method (DEM). In the present work, we mainly focus on the role of capillary condensation and subsequent liquid bridge formation within a granular medium exposed to fluctuations of ambient relative humidity. Such bridges cause an attractive force between particles, leading to the formation of a cake with intrinsic physicochemical and mechanical properties. By considering a Representative Elementary Volume (REV), the DEM is then performed by means of a MULTICOR-3D software tacking into account the properties of the cake (degree of saturation) in order to establish relationships between the microscopic parameters and the macroscopic behaviour (tensile strength).

  13. Numerical modelling of powder caking at REV scale by using DEM

    Directory of Open Access Journals (Sweden)

    Guessasma Mohamed

    2017-01-01

    Full Text Available This work deals with numerical simulation of powder caking process caused by capillary condensation phenomenon. Caking consists in unwanted agglomeration of powder particles. This process is often irreversible and not easy to predict. To reproduce mechanism involved by caking phenomenon we have used the Discrete Elements Method (DEM. In the present work, we mainly focus on the role of capillary condensation and subsequent liquid bridge formation within a granular medium exposed to fluctuations of ambient relative humidity. Such bridges cause an attractive force between particles, leading to the formation of a cake with intrinsic physicochemical and mechanical properties. By considering a Representative Elementary Volume (REV, the DEM is then performed by means of a MULTICOR-3D software tacking into account the properties of the cake (degree of saturation in order to establish relationships between the microscopic parameters and the macroscopic behaviour (tensile strength.

  14. Science coverage and the press

    International Nuclear Information System (INIS)

    Hawkes, N.

    1992-01-01

    The writer, a journalist, summarizes the discussion of the Chilton Seminar, February 1992, and discusses the problems of bridging the incomprehension gap between scientists and lay readers of the press. (Author)

  15. Hot-pressing steatite bodies

    International Nuclear Information System (INIS)

    Aparicio Arroyo, E.

    1967-01-01

    Requirements for some special nuclear engineering ceramic shapes are: big size, impervious, dimensional accuracy and good mechanical and dielectric properties. Limitations of te conventional methods and advantages of te hot pressing techniques for the manufacturing of these shapes are discussed. Hot pressing characteristics of a certain steatite powder are studied. Occurrence of an optimum densification temperature just above the tale decomposition range is found. Experimental data show that the height/diameter ratio of the specimen has no effect on the sintering conditions. Increasing darkness from the graphite mould is detected above the optimum temperature. The hot-pressed steatite is compared with a fired dry-pressed sample of the same composition. (Author) 13 refs

  16. Radiolytic gas generation in salt cake technical task plan

    International Nuclear Information System (INIS)

    Walker, D.D.; Crawford, C.L.; Bibler, N.E.

    1993-01-01

    High-level radioactive wastes are stored in large, steel tanks in the Savannah River Site Tank Farms. The liquid levels in these tanks are monitored to detect leakage of waste out of tanks or leakage of liquids into the tanks. Recent unexplained level fluctuations in high-level waste (HLW) tanks have caused High Level Waste Engineering (HLWE) to develop a program to better understand tank level behavior. Interim Waste Technology (IWT) has been requested by HLWE to obtain data which will lead to a better understanding of the radiolytic generations of gases in salt cake. The task described below will provide data from laboratory experiments with simulated wastes which can be used in tank level fluctuation modeling. The following experimental programs have been formulated to meet the task requirements of the customer: (A) determine whether radiolytically generated gas bubbles can be trapped in salt cake; (B) determine the composition of gases produced by radiolysis; (C) determine the yield of radiolysis gases as a function of radiation dose; (D) determine bubble distribution

  17. Energy requirements during sponge cake baking: Experimental and simulated approach

    International Nuclear Information System (INIS)

    Ureta, M. Micaela; Goñi, Sandro M.; Salvadori, Viviana O.; Olivera, Daniela F.

    2017-01-01

    Highlights: • Sponge cake energy consumption during baking was studied. • High oven temperature and forced convection mode favours oven energy savings. • Forced convection produced higher weight loss thus a higher product energy demand. • Product energy demand was satisfactorily estimated by the baking model applied. • The greatest energy efficiency corresponded to the forced convection mode. - Abstract: Baking is a high energy demanding process, which requires special attention in order to know and improve its efficiency. In this work, energy consumption associated to sponge cake baking is investigated. A wide range of operative conditions (two ovens, three convection modes, three oven temperatures) were compared. Experimental oven energy consumption was estimated taking into account the heating resistances power and a usage factor. Product energy demand was estimated from both experimental and modeling approaches considering sensible and latent heat. Oven energy consumption results showed that high oven temperature and forced convection mode favours energy savings. Regarding product energy demand, forced convection produced faster and higher weight loss inducing a higher energy demand. Besides, this parameter was satisfactorily estimated by the baking model applied, with an average error between experimental and simulated values in a range of 8.0–10.1%. Finally, the energy efficiency results indicated that it increased linearly with the effective oven temperature and that the greatest efficiency corresponded to the forced convection mode.

  18. The yellow cake accident at the Ezeiza Airport

    International Nuclear Information System (INIS)

    Rodriguez, C.E.; Puntarulo, L.J.; Canibano, J.A.

    1989-01-01

    In January 1987 several drums containing yellow cake fell from about six meters during the loading operation of a Boeing 747 T-100 cargo aircraft. As a result of the accident, about 50% of the 38 drums involved lost their lids and a fraction of the radioactive content was released on an area of about 200 meters squared. Small amounts of yellow cake were dispersed down wind until about 100 meters from the accident place. The shipment was prepared for transport in standard 200 liter steel drums fulfilling the applicable Transport Regulations and the accident was the consequence of an erroneous operation during the cargo associated with a mechanical failure of the cargo lift. In order to avoid human contamination, immediate action was taken by the airport emergency team and in the meantime, the specialized groups of the National Atomic Energy Commission and the Federal Fire Brigades, were convened to take care of the decontamination and radiological evaluation problems. This paper describes the accidental sequences, the accident scenery, the countermeasures taken, the recovery and decontamination actions, and finally, as a conclusion, a brief description of the toxic and radiological aspects of the accident's mode

  19. Combating desertification - fuel oil from jatropha plants in Africa: a systematic approach applied by a GTZ-supported project in Mali, West Africa

    International Nuclear Information System (INIS)

    Henning, R.K.

    1995-01-01

    The use of plant oil as an engine fuel has a long and eventful history, and technical developments have largely been completed. The economic conditions, however, do not yet suffice to produce a breakthrough for plant oil use as fuel in most industrialized and developing countries. The approach applied by a pilot project in Mali and described in this paper tries to overcome these economic drawbacks. The primary aim of the project is not the use of plant oil from Jatropha as a fuel per se, but rather to make that fuel use into an incentive that would activate a system combining ecologic, economic and income-generating effects, the latter specifically for women. These effects could materialize only if the non-edible oil of the jatropha plant can find an economically viable use. Since jatropha trees (Jatropha curcas L.) not only bear oil-rich seed, but can also be planted in the form of hedges to protect gardens and fields from foraging animals while warding off soil erosion, this would seem to be a case of positive correlation between energy production and agricultural production: the more energy that is produced by the hedgerows of jatropha, the more food production is strengthened. Of particular importance here is the recycling of the oil cake as organic fertilizer. The technologies used in the jatropha system are the well-known hand-driven or mechanically driven oil presses and with precombustion chambers diesel engines. While various makes, the latter are already available on the local market, the presses can be produced locally at affordable prices. The project's activities focus, accordingly, on training and disseminating the relevant know-how. They do this by using local, often non-governmental institutions and by offering advice to farmers and rural communities interested in the jatropha system. The economic analysis using the UNIDO COMFAR III program shows very positive impacts if both direct and indirect effects are considered. Even in a completely non

  20. Combating desertification - fuel oil from jatropha plants in Africa: a systematic approach applied by a GTZ-supported project in Mali, West Africa

    Energy Technology Data Exchange (ETDEWEB)

    Henning, R K [Projet Pourghere, Deutsche Gesellschaft fuer technische Zusammenarbeit (GTZ), Bamako (Mali)

    1995-12-01

    The use of plant oil as an engine fuel has a long and eventful history, and technical developments have largely been completed. The economic conditions, however, do not yet suffice to produce a breakthrough for plant oil use as fuel in most industrialized and developing countries. The approach applied by a pilot project in Mali and described in this paper tries to overcome these economic drawbacks. The primary aim of the project is not the use of plant oil from Jatropha as a fuel per se, but rather to make that fuel use into an incentive that would activate a system combining ecologic, economic and income-generating effects, the latter specifically for women. These effects could materialize only if the non-edible oil of the jatropha plant can find an economically viable use. Since jatropha trees (Jatropha curcas L.) not only bear oil-rich seed, but can also be planted in the form of hedges to protect gardens and fields from foraging animals while warding off soil erosion, this would seem to be a case of positive correlation between energy production and agricultural production: the more energy that is produced by the hedgerows of jatropha, the more food production is strengthened. Of particular importance here is the recycling of the oil cake as organic fertilizer. The technologies used in the jatropha system are the well-known hand-driven or mechanically driven oil presses and with precombustion chambers diesel engines. While various makes, the latter are already available on the local market, the presses can be produced locally at affordable prices. The project`s activities focus, accordingly, on training and disseminating the relevant know-how. They do this by using local, often non-governmental institutions and by offering advice to farmers and rural communities interested in the jatropha system. The economic analysis using the UNIDO COMFAR III program shows very positive impacts if both direct and indirect effects are considered. Even in a completely non

  1. Cellulase Activity in Solid State Fermentation of Palm Kernel Cake with Trichoderma sp.

    Directory of Open Access Journals (Sweden)

    Massaud, M. B. N.

    2012-01-01

    Full Text Available Aims: The effect of different types of fungal inocula to the cellulase activity measured on palm kernel cake (PKC was studied. Methodology and Results: Isolate Pro-A1 which was identified as Trichoderma sp. was selected as a potential producer of cellulase via solid state fermentation technique (SSF. Two types of PKCs were used; raw PKC (containing residual oil and defatted PKC. The PKCs were inoculated with different concentrations of conidia and varying amounts (g of solid mycelia plugs (SMP for SSF. The effect of ultrafiltered crude fungal filtrate (CFF as inocula was also being tested. The highest cellulase activity of 2.454 FPU/mL was detected with 60% (wt/wt SMP applied to the raw PKC. Conversely, 2.059 FPU/mL of cellulase activity was measured when 80% (wt/wt of SMP was applied to the defatted PKC which is 62.3% higher than the untreated defatted PKC; and more than 100% increase in enzymatic activity compared to raw PKC. The cellulase activity in the SSF inoculated with 8 x 106 conidia /mL and 12 x 106 conidia /mL were 1.704 FPU/mL for raw PKC and 1.856 FPU/mL for defatted PKC, an enhancement of about 46% from uninoculated batch. Inoculation with CFF bears corresponding maximum improvement of the cellulase activity on both PKCs of 13.58% (raw and 2.86% (defatted. Conclusion, significance and impact of study: The current study proves that Trichoderma sp. in the form of SMP can enhance the cellulase activity on PKCs effectively with more than 100% increment. Fungal conidia are also a better choice in enhancing cellulase activity of Trichoderma sp. permitted that the PKC used is devoid of oil. From this study, Trichoderma sp. holds the potential of converting lignocellulosic materials into products of commercial and industrial values such as glucose and other biofuels.

  2. Mathematical modelling of wet paper pressing

    NARCIS (Netherlands)

    Bežanovic, D.

    2005-01-01

    The aim of this project is to reduce energy costs in paper production by optimising the process in the press section of a paper machine. In this press section water is squeezed as it passes through the press nip. In a modern press section the moisture content of the sheet after three or four presses

  3. Study on Sensory Quality, Antioxidant Properties, and Maillard Reaction Products Formation in Rye-Buckwheat Cakes Enhanced with Selected Spices

    Directory of Open Access Journals (Sweden)

    Małgorzata Przygodzka

    2015-01-01

    Full Text Available The effect of selected spices included in the recipe of rye-buckwheat cakes on sensory quality, nutritional value, and Maillard reaction (MR products formation was addressed in this study. The cakes with cloves, nutmeg, allspice, cinnamon, vanilla, and spice mix addition revealed the highest overall quality values. Cakes enriched with cloves, allspice, and spice mix showed the highest rutin content and almost threefold higher available lysine contents whereas cakes enhanced with mix, cloves, and cinnamon were the richest source of phenolic compounds. The highest antioxidant capacity showed cakes with cloves and spice mix. The furosine, a marker of early stage of MR, was decreased in cakes with cloves, allspice, spice mix, and vanilla whereas fluorescent intermediatory compounds were reduced in cakes enhanced with cloves, allspice, and cinnamon. In contrast, browning index was increased as compared to cakes without spices. The FAST index was significantly lowered in all cakes enriched with spices, especially with cloves, allspice, and mix addition. The presence of cloves, allspice, and vanilla in cake formula was the most efficient in acrylamide strategy. It can be suggested that cloves, allspice, and vanilla might be used for production of safety and good quality cakes.

  4. Effect of banana peel cellulose as a dietary fiber supplement on baking and sensory qualities of butter cake

    Directory of Open Access Journals (Sweden)

    Chiraporn Sodchit

    2013-12-01

    Full Text Available Banana peels are a waste product of the banana industry that have caused an environmental problem. Conversion of banana peels to a food ingredient might be an alternative way of value-adding to this waste. This study aimed to extract cellulose from banana peels and use it as an ingredient in butter cake to increase dietary fiber content and to improve cake quality. The selection and optimization of extraction conditions of cellulose from banana peels employed chemical extractions. Banana peel cellulose (BPC was added to butter cake at 3 levels; 1.5, 3.0 and 4.5% w/w of flour compared with 3.0% commercial cellulose (CC and the control (no cellulose added. The sensory, chemical, physical and microbiological properties of the butter cakes were then determined. The odor, tenderness and moistness acceptance scores of the butter cake by 50 panelists ranged from “like moderately” to “like very much”, indicating that addition of BPC improved the sensory quality of the cake. The butter cake with added CC and BPC had significantly higher (pd”0.05 moisture and fiber contents than those of the control. Microorganism levels found in the butter cake conformed to the butter cake standard (OTOP standard product of Thailand 459/2549. The optimum concentration of added BPC was 1.5%. Thus, the addition of BPC extracted from banana peels to butter cake increased the fiber content and improve the cake quality.

  5. Utilization of deoiled Jatropha curcas seed cake for production of xylanase from thermophilic Scytalidium thermophilum.

    Science.gov (United States)

    Joshi, Chetna; Khare, S K

    2011-01-01

    Jatropha curcas is a major biodiesel crop. Large amount of deoiled cake is generated as by-product during biodiesel production from its seeds. Deoiled J. curcas seed cake was assessed as substrate for the production of xylanase from thermophilic fungus Scytalidium thermophilum by solid-state fermentation. The seed cake was efficiently utilized by S. thermophilum for its growth during which it produced good amount of heat stable extracellular xylanase. The solid-state fermentation conditions were optimized for maximum xylanase production. Under the optimized conditions viz. deoiled seed cake supplemented with 1% oat-spelt xylan, adjusted to pH 9.0, moisture content 1:3 w/v, inoculated with 1×10(6) spores per 5 g cake and incubated at 45 °C, 1455 U xylanase/g deoiled seed cake was obtained. The xylanase was useful in biobleaching of paper pulp. Solid-state fermentation of deoiled cake appears a potentially viable approach for its effective utilization. Copyright © 2010 Elsevier Ltd. All rights reserved.

  6. Effects of sucrose reduction on the structural characteristics of sponge cake

    Directory of Open Access Journals (Sweden)

    Rosane Souza Cavalcante

    Full Text Available ABSTRACTThe consumption of reduced-calorie cakes has been increasing, however this has presented challenges to be overcome concerning the formation of their structure when the sucrose is substituted by alternative sweeteners, gums or thickening agents. The present study evaluated the internal characteristics of cakes with a reduction in sucrose, and the effects of its substitution on starch gelatinisation. Starting with a pre-established formulation, the sucrose was gradually substituted by a 1.0% mixture of sucralose in a 1.5% xanthan gum solution. In the substituted cake mix, the apparent viscosity and its thermal properties were evaluated using differential scanning calorimetry (DSC. Specific volume (SV and cell count (CC were evaluated in the cakes. As the sucrose content decreased (52.17 to 10.00%, the specific volume (1.94 to 0.7 mL/g, cell count (36.2 to 4.0 cell/cm2 and the apparent viscosity of the batter (337.56 to 631.40 cP were also reduced. The results showed that substituting the sucrose contributed greatly to the formation of defects in the cake structure (holes. From the data obtained, and thermograms of standard cake batters and those with a reduction in sucrose, it can be concluded that sucralose reduced the temperature of starch gelatinisation, speeding the process and causing compaction of the cake structure during baking, favouring the formation of bubbles throughout the batter.

  7. Application of Combined Cake Filtration-Complete Blocking Model to Ultrafiltration of Skim Milk

    Directory of Open Access Journals (Sweden)

    Mansoor Kazemimoghadam

    2017-10-01

    Full Text Available Membrane ultrafiltration (UF is widely used in dairy industries like milk concentration and dehydration processes. The limiting factor of UF systems is fouling which is defined as the precipitation of solutes in the form of a cake layer on the surface of the membrane. In this study, the combined cake filtration-complete blocking model was compared to cake filtration mechanism for flux data through ultrafiltration of skim milk at constant flow rate. The resistance data also was modeled using cake filtration model and standard blocking model. The effect of different trans-membrane pressures and temperatures on flux decline was then investigated. Based on the results obtained here, the combined complete blocking-cake formation model was in excellent agreement with experimental data. The cake filtration model also provided good data fits and can be applied to solutions whose solutes tend to accumulate on the surface of the membrane in the form of a cake layer. With increasing pressure, the differences between the model and experimental data increased.

  8. Sustainable management of root-knot disease of tomato by neem cake and Glomus fasciculatum

    Directory of Open Access Journals (Sweden)

    Rose Rizvi

    2015-12-01

    Full Text Available A pot experiment was conducted during winter season of 2009–2010 in the department of Botany, AMU, Aligarh, India, to determine the nematicidal potential of organic matter, neem cake at third level of dose, and bioagent, Glomus fasciculatum in terms of various growth parameters of tomato, when inoculated individually as well as concomitantly with respect to root-knot development. Neem cake and G. fasciculatum showed potential for sustainable management while providing nutrient sources for proper plant growth. Disease intensity of root-knot nematode decreased while increasing the doses of neem cake along with the G. fasciculatum. Chlorophyll contents have been found to be increased in single and combined application as well. There is a progressive increase in growth parameters raised in soil amended with 10, 20, and 30 g neem cake/kg soil and inoculated with G. fasciculatum. Significant improvement in the plant growth was observed when G. fasciculatum and neem cake were inoculated simultaneously. Neem cake plus G. fasciculatum reduced the nematodes’ multiplication and root-galling, and increased the plant growth of tomato as compared to unamended and Meloidogyne incognita-inoculated plants. Mycorrhyzation and agronomic parameters were increased due to application of G. fasciculatum alone, but enhanced further when inoculated with neem cake.

  9. Nutrition quality of extraction mannan residue from palm kernel cake on brolier chicken

    Science.gov (United States)

    Tafsin, M.; Hanafi, N. D.; Kejora, E.; Yusraini, E.

    2018-02-01

    This study aims to find out the nutrient residue of palm kernel cake from mannan extraction on broiler chicken by evaluating physical quality (specific gravity, bulk density and compacted bulk density), chemical quality (proximate analysis and Van Soest Test) and biological test (metabolizable energy). Treatment composed of T0 : palm kernel cake extracted aquadest (control), T1 : palm kernel cake extracted acetic acid (CH3COOH) 1%, T2 : palm kernel cake extracted aquadest + mannanase enzyme 100 u/l and T3 : palm kernel cake extracted acetic acid (CH3COOH) 1% + enzyme mannanase 100 u/l. The results showed that mannan extraction had significant effect (P<0.05) in improving the quality of physical and numerically increase the value of crude protein and decrease the value of NDF (Neutral Detergent Fiber). Treatments had highly significant influence (P<0.01) on the metabolizable energy value of palm kernel cake residue in broiler chickens. It can be concluded that extraction with aquadest + enzyme mannanase 100 u/l yields the best nutrient quality of palm kernel cake residue for broiler chicken.

  10. Utilisation of preharvest dropped apple peels as a flour substitute for a lower glycaemic index and higher fibre cake.

    Science.gov (United States)

    Jun, Yujin; Bae, In Young; Lee, Suyong; Lee, Hyeon Gyu

    2014-02-01

    Fibre-enriched materials (FEMs) obtained from preharvest dropped apple peels were utilised as a source of dietary fibre in baked cakes and their effects on the textural/nutritional qualities and starch digestibility (glucose release behaviour, starch digestion fraction, predicted glycaemic index) of the cakes were evaluated. When FEMs were incorporated into the cake formulation (3 g and 6 g of dietary fibre per serving (100 g)), the volume of the cakes seemed to be reduced and their texture become harder. However, 3 g of FEMs did not degrade the cake qualities. The use of FEMs in cakes significantly reduced the levels of rapidly digestible starch and slowly digestible starch, while the levels of resistant starch increased. Additionally, the cake samples prepared with FEMs exhibited a lower predicted glycaemic index. This study may give rise to multi-functional bakery products with acceptable quality and low glycaemic index.

  11. Conférence de presse | Press Conference

    CERN Multimedia

    CERN. Geneva; Bejar Alonso, Isabel

    2018-01-01

    10:00-11:00 Conférence de presse en présence de Lucio Rossi, chef du projet LHC à Haute Luminosité et Isabel Bejar Alonso, chargée de la configuration, de la qualité et des ressources du projet LHC à Haute Luminosité.

  12. Investing in a Large Stretch Press

    Science.gov (United States)

    Choate, M.; Nealson, W.; Jay, G.; Buss, W.

    1986-01-01

    Press for forming large aluminum parts from plates provides substantial economies. Study assessed advantages and disadvantages of investing in large stretch-forming press, and also developed procurement specification for press.

  13. Improvements on heap leaching process for a refractory uranium ore and yellow cake precipitation process

    International Nuclear Information System (INIS)

    Feng Jianke

    2013-01-01

    Some problems such as formed harden matrix, ore heap compaction, poor permeability, and agglomeration of absorption resin occur during extracting uranium from a refractory uranium ore by heap leaching process. After some measures were taken, i.e. spraying a new ore heap by low concentration acid, two or more ore heaps in series leaching, turning ores in ore heap, the permeability was improved, acid consumption was reduced. Through precipitate circulation and aging, the yellow cake slurry in amorphous or microlite form was transformed to crystal precipitate, thus uranium content in yellow cake was improved, and water content in yellow cake was lowered with good economic benefits. (author)

  14. A new technique for production of yellow cake with double precipitation

    International Nuclear Information System (INIS)

    Li Jianhua; Zeng Yijun; Li Shangyuan; Kong Guiying

    1997-01-01

    The author presents a new technique for production of yellow cake with double precipitation, thus solving a series of problems for precipitating uranium with traditional double precipitation. The new technique can not only remove ferric ions and sulfate radicals but also make solid-liquid separation easy, utilize effectively the sulfuric acid produced in ferric ions precipitation process, and increase uranium concentration of leaching liquor. To take it as producing yellow cake will save investment, simplify operation, and cut down the consumption of raw materials and energies. It is more competitive than ion-exchange or solvent extraction in the process of extracting-purifying and preparing yellow cake

  15. Effect of neem cake/fertilizers on symbiotic and non-symbiotic N2 fixing bacteria

    International Nuclear Information System (INIS)

    Akhtar, S.; Solangi, A.H.; Gilani, G.; Pirzada, M.H.

    2002-01-01

    Neem cake amendment in soil at 1.3% no adverse effect on the population of four symbiotic Rhizobium species viz., japonicum, R. leguminosarum, R. Phaseoli and R. Fredii and three non-symbiotic free living nitrogen fixers bacteria viz., Pseudomonas diazotrophicus, Klebsiella planticola and Enterobacter cloacae. Neem cake extracted with n-hexane stimulated the growth of Rhizobium species in vitro, whereas Neem cake expeller extracted neither inhibited nor stimulated the growth of Rhizobium species except for R. Fredii, whose was slightly retarded. The fertilizers (urea, NPK and DAP) had no adverse effect on these bacteria even at the dosage ten times higher the recommended dose. (author)

  16. WordPress 3 Cookbook

    CERN Document Server

    Shreves, Ric

    2011-01-01

    This is a Packt Cookbook, which means it contains step-by-step instructions to achieve a particular goal or solve a particular problem. There are plenty of screenshots and explained practical tasks to make comprehension quick and easy. This book is not specifically for developers or programmers; rather it can be used by anyone who wants to get more out of their WordPress blog by following step-by-step instructions. A basic knowledge of PHP/XHTML/CSS/WordPress is desirable but not necessary.

  17. Radiolytic gas generation in Salt Cake Quality Assurance Plan

    International Nuclear Information System (INIS)

    Walker, D.D.

    1993-01-01

    High-level radioactive wastes are stored in large, steel tanks in the Savannah River Site's Tank Farms. The liquid levels in these tanks are monitored to detect leakage of waste out of tanks or leakage of liquids into the tanks. Recent unexplained level fluctuations in high-level waste (HLW) tanks have caused High Level Waste Engineering (HLWE) to develop a program to better understand tank level behavioral Interim Waste Technology (IWT) has been requested by HLWE to obtain data which will lead to a better understanding of the radiolytic generation of gases in salt cake. A task plan has been written in response to this request. This document details the controls necessary to ensure the quality of the results of the activities described in the task plan

  18. Food and biomass production in small oil expression facilities

    Energy Technology Data Exchange (ETDEWEB)

    Kato, H.; Kanai, G.; Yakushido, K. [National Agricultural Research Center, Tsukuba (Japan). Biomass Production and Processing Research Team

    2010-07-01

    This paper reported on a study in which rapeseeds were separated into high quality seed for food oil and low quality seed for biofuels. A laboratory-scale oilseed screw press was then used to examine the effects of choke opening and seed preheating on the rapeseed pressing performance and the quality of food oil and biofuels oil. Oil recovery and chlorophyll content was found to increase as maximum pressure increased. In terms of pressing performance, the rapeseed heated by microwaves yielded more oil and chlorophyll than without heating. The NEB ratio of microwave heating press with an 8.0 mm choke opening was advantageous. Rapeseed oil extracted from low quality seeds was found to have a high acid value. The quality of oil extracted by oilseed screw press was found to be good and met the requirements of the Codex Alimentarius for edible oils.

  19. MIKROENKAPSULASI Lactobacillus sp. DENGAN TEKNIK EMULSI DAN APLIKASINYA PADA DODOL SIRSAK [Microencapsulation of Lactobacillus sp. using Emulsion Technique and Its Application in Soursop Sweet Cakes

    Directory of Open Access Journals (Sweden)

    Anis Usfah Prastu Jati

    2015-12-01

    Full Text Available Two probiotic strains Lactobacillus acidophilus 2B4 and L. rhamnosus R23 were microencapsulated by an emulsion technique using sodium alginate and vegetable oil. The present study aimed to enhance probiotic survival on their application in the production of soursop sweet cakes (dodol sirsak and their stability during storage at room temperature. The probiotic biomasses were mixed with 3% sodium alginate and then added dropwise into a mixture of soybean oil and Tween 80. The microencapsulation technique applied resulted in excellent survival (95-96% for both Lactobacillus sp. strains. Encapsulation significantly improved the survival of probiotics (P<0.05 during exposure to heat process (60, 65, and 70°C for 20 min, low pH (pH 2 and bile salt (0.5%. Encapsulation did not alter the ability of both probiotics in inhibiting the growth of Escherichia coli ATCC 25922. The viability of encapsulated strains in soursop sweet cakes were improved to the adequate number, i.e. 6 Log CFU g-1 up to 3 and 2 weeks storage, as compared to that of controls survivors, i.e. 4.3 and 2.5 Log CFU g-1, for L. acidophilus 2B4 and L. rhamnosus R23, respectively, during a week of storage.

  20. Biocompounds from rapeseed oil industry co-stream as active ingredients for skin care applications.

    Science.gov (United States)

    Rivera, D; Rommi, K; Fernandes, M M; Lantto, R; Tzanov, T

    2015-10-01

    Despite the great number of substances produced by the skincare industry, very few of them seem to truly have an effect on the skin. Therefore, given the social implications surrounding physical appearance, the search for new bioactive compounds to prevent or attenuate skin ageing and enhance self-image is a priority of current research. In this context, being rich in valuable compounds, such as proteins, phenolics, lipids and vitamins, this study is focused on the potential activity of rapeseed press cake hydrolysates to be used as raw materials for skincare applications. In this study, the protein-rich press residue from the rapeseed oil industry was converted enzymatically into short-chain biologically active peptides using four protease products with varying substrate specificity - Alcalase 2.4L FG, Protex 6L, Protamex and Corolase 7089. The antioxidant, anti-wrinkle and anti-inflammatory activities of the obtained hydrolysates were evaluated in vitro while their biocompatibility with human skin fibroblasts was tested. All hydrolysates were biocompatible with skin fibroblasts after 24 h of exposure, while the non-hydrolysed extract induced cell toxicity. Alcalase 2,4L FG and Protex 6L-obtained hydrolysates were the most promising extracts showing improved bioactivities suitable for skin anti-ageing formulations, namely antioxidant activity, inhibiting approximately 80% cellular reactive oxidative species, anti-inflammatory and anti-wrinkle properties, inhibiting around 36% of myeloperoxidase activity and over 83% of elastase activity. The enzymatic technology applied to the rapeseed oil industry costream results in the release of bioactive compounds suitable for skincare applications. © 2015 Society of Cosmetic Scientists and the Société Française de Cosmétologie.

  1. Law and the Student Press.

    Science.gov (United States)

    Stevens, George E.; Webster, John B.

    Court cases and legal decisions involving the student press in the late 1960s and early 1970s are brought together in this book in order to show how the law has been applied to school officials and student journalists in high school, college, and the underground. The ten chapters cover the following topics: censorship, libel, obscenity, contempt,…

  2. Local and international press digest

    CERN Multimedia

    2008-01-01

    The following are the top stories in the Maltese and the international press today. The Times gives prominence to the Prime Minister's flying visit to Geneva yesterday, where he signed a research cooperation agreement with CERN, the European nuclear research organisation.

  3. A new hot pressing technique

    International Nuclear Information System (INIS)

    Carcey, J.

    1975-01-01

    An original hot pressing method which may be applied to ceramics, metals, and refractory powders is described. The products obtained are fine grained polycristalline materials, with homogeneous structure, very high density, unstrained and of very large dimensions (several square meters). This process equally applies to composite materials including powders, fibers, etc.. [fr

  4. Investigation of dielectric properties of different cake formulations during microwave and infrared-microwave combination baking.

    Science.gov (United States)

    Sakiyan, Ozge; Sumnu, Gulum; Sahin, Serpil; Meda, Venkatesh

    2007-05-01

    Dielectric properties can be used to understand the behavior of food materials during microwave processing. Dielectric properties influence the level of interaction between food and high frequency electromagnetic energy. Dielectric properties are, therefore, important in the design of foods intended for microwave preparation. In this study, it was aimed to determine the variation of dielectric properties of different cake formulations during baking in microwave and infrared-microwave combination oven. In addition, the effects of formulation and temperature on dielectric properties of cake batter were examined. Dielectric constant and loss factor of cake samples were shown to be dependent on formulation, baking time, and temperature. The increase in baking time and temperature decreased dielectric constant and loss factor of all formulations. Fat content was shown to increase dielectric constant and loss factor of cakes.

  5. PUMPKIN CAKE AND PUMPKIN SLUDGE USE EFFICIENCY IN CHICKEN-ROILERS FEEDING

    OpenAIRE

    Shkrygunov K. I.; Lipova E. A.; Dikusarov V. G.; Soshkin Y. V.

    2013-01-01

    The article presents the results of the research devoted to the poultry feeding with pumpkin cake and pumpkin sludge technology development and implementation – feeding stuff by-products at pumpkin seeds processing

  6. Filtration of Nanoparticles: Evolution of Cake Structure and Pressure-Drop

    DEFF Research Database (Denmark)

    Elmøe, Tobias Dokkedal; Tricoli, Antonio; Grunwaldt, Jan-Dierk

    2009-01-01

    The detailed three-dimensional accumulation of deposits and the build-up of pressuredrop during filtration of compressible gases laden with nanoparticles (diameter dp=50 nm) through capillaries (1–4 micron radius) was investigated by Langevin dynamics (LD) at Peclet number, Pe, 0.01–10. At low Pe...... with constant solid volume fraction began to form, accompanied with build-up of pressuredrop which was in excellent agreement with classic cake filtration theory. An expression for the solid volume fraction of the cake (fsd,c) was obtained as a sole function of Pe. In addition, the filtration efficiency became...... 1 after clogging, since the cake acts as a perfectly efficient filter. Penetration of nanoparticles takes place until the onset of cake filtration at high Pe (1–10) while for smaller ones (0.01–0.1) it is negligible at the employed capillary radii and length (10 micron). Analytical expressions...

  7. Biodiesel and biohydrogen production from cotton-seed cake in biorefinery concept

    NARCIS (Netherlands)

    Panagiotopoulos, I.A.; Pasias, S.; Bakker, R.R.C.; Vrije, de G.J.; Papayannakos, N.; Claassen, P.A.M.; Koukios, E.G.

    2013-01-01

    Biodiesel production from cotton-seed cake (CSC) and the pretreatment of the remaining biomass for dark fermentative hydrogen production was investigated. The direct conversion to biodiesel with alkali free fatty acids neutralization pretreatment and alkali transesterification resulted in a

  8. Virgin almond oil: Extraction methods and composition

    Energy Technology Data Exchange (ETDEWEB)

    Roncero, J.M.; Alvarez-Orti, M.; Pardo-Gimenez, A.; Gomez, R.; Rabadan, A.; Pardo, J.E.

    2016-07-01

    In this paper the extraction methods of virgin almond oil and its chemical composition are reviewed. The most common methods for obtaining oil are solvent extraction, extraction with supercritical fluids (CO2) and pressure systems (hydraulic and screw presses). The best industrial performance, but also the worst oil quality is achieved by using solvents. Oils obtained by this method cannot be considered virgin oils as they are obtained by chemical treatments. Supercritical fluid extraction results in higher quality oils but at a very high price. Extraction by pressing becomes the best option to achieve high quality oils at an affordable price. With regards chemical composition, almond oil is characterized by its low content in saturated fatty acids and the predominance of monounsaturated, especially oleic acid. Furthermore, almond oil contains antioxidants and fat-soluble bioactive compounds that make it an oil with interesting nutritional and cosmetic properties.

  9. Virgin almond oil: Extraction methods and composition

    International Nuclear Information System (INIS)

    Roncero, J.M.; Alvarez-Orti, M.; Pardo-Gimenez, A.; Gomez, R.; Rabadan, A.; Pardo, J.E.

    2016-01-01

    In this paper the extraction methods of virgin almond oil and its chemical composition are reviewed. The most common methods for obtaining oil are solvent extraction, extraction with supercritical fluids (CO2) and pressure systems (hydraulic and screw presses). The best industrial performance, but also the worst oil quality is achieved by using solvents. Oils obtained by this method cannot be considered virgin oils as they are obtained by chemical treatments. Supercritical fluid extraction results in higher quality oils but at a very high price. Extraction by pressing becomes the best option to achieve high quality oils at an affordable price. With regards chemical composition, almond oil is characterized by its low content in saturated fatty acids and the predominance of monounsaturated, especially oleic acid. Furthermore, almond oil contains antioxidants and fat-soluble bioactive compounds that make it an oil with interesting nutritional and cosmetic properties.

  10. Pengembangan Produksi Biogas Dari Limbah Pembuatan Biodiesel Jarak Pagar (Jatropha Curcas Seed Cake)

    OpenAIRE

    Yufidani, Y; Jos, Bakti; Sumardiono, Siswo

    2013-01-01

    Biogas is a fermentation process using anaerobic bacteria to convert organic compounds into gas with high composition of methane. Use of jatropha curcas as a biodiesel's resources remains a problems, seed cake of jatropha curcas contains phorbol esters that is toxic. This research focused on getting an optimum yield of biogas production from jatropha curcas seed cake using additive material to reach optimum C/N ratio. Optimum C/N ratio on biogas production was range 20-30, but jatropha curcas...

  11. Basic Studies on Sponge Cake Making as a Teaching Material of Food Preparation

    OpenAIRE

    Shiratsuti, Hiroko; Ikawa, Yoshiko

    1994-01-01

    The purpose of this study is to investigate about the basic condition for sponge cake making usable as a teaching material of food preparation. The results were as follows : 1. Egg foams were stable under high concentration of sucrose and low temperature. The cake with 34% sucrose showed a good appearance. 2. Substituting starch for wheat flour was effective to keep low viscosity of batters. 3. The data for the baking process indicated the importance of the first and second stages in baking, ...

  12. Study of the behaviour of the yellow cake dissolution in simulated lung fluid

    International Nuclear Information System (INIS)

    Souza Mansur, E. de.

    1988-01-01

    An in vitro study was performed to determine the solubility of the yellow cake produced in a Brazilian uranium mill to permit classification of the inhaled material and to aid bioassay interpretation. The powder was taken from 6 different lots of yellow cake produced during 10 weeks mill operation period. Dissolution fractions and half-times were obtained using simulated lung fluid in a shaker bath at 37 0 C for 30 days. Uranium concentration were determined by neutron activation analysis. (author)

  13. Studi Pembuatan Rainbow Cake Menggunakan Pati Sagu (Metroxylon SP.) Lokal Riau

    OpenAIRE

    ', Arnizam; Pato, Usman; Johan, Vonny Setiaries

    2015-01-01

    This study aim was to analyze the differences in the sensory assessment of the rainbow cake with the addition of 30% sago starch and 100% rainbow cake using wheat flour. This study used a Completely Randomized Design (CRD) with two treatments and eight replication thus obtained 16 experimental units. The treatments were TS1 (100% wheat flour, 0% sago starch) and TS2 (70% wheat flour, 30% sago starch). The parameters observed were descriptive test which includes assessing the attributes of ten...

  14. New cost-effective bioconversion process of palm kernel cake into bioinsecticides based on Beauveria bassiana and Isaria javanica.

    Science.gov (United States)

    do Nascimento Silva, Jaqueline; Mascarin, Gabriel Moura; Dos Santos Gomes, Isabel Cristina; Tinôco, Ricardo Salles; Quintela, Eliane Dias; Dos Reis Castilho, Leda; Freire, Denise Maria Guimarães

    2018-03-01

    The present study aimed to add value to palm oil by-products as substrates to efficiently produce conidia of Beauveria bassiana and Isaria javanica (Hypocreales: Cordycipitaceae) for biological control of the whitefly Bemisia tabaci (Hemiptera: Aleyrodidae), through a solid-state fermentation process using palm kernel cake and palm fiber as nutrient source and solid matrix, respectively. The optimum culture conditions yielded high concentrations of viable conidia after air-drying, when the fungi were grown on palm kernel cake (B. bassiana 7.65 × 10 9 and I. javanica 2.91 × 10 9  conidia g -1 dry substrate) after 6 days under optimal growth conditions set to 60% substrate moisture and 32 °C. Both fungal strains exhibited high efficacy against third-instar whitefly nymphs, inducing mortality up to 62.9 and 56.6% by B. bassiana and I. javanica, respectively, assessed after 9 days post-application in a screenhouse. Furthermore, we noted that insect mortality was strongly correlated with high atmospheric moisture, while B. bassiana appeared to require shorter accumulative hours under high moisture to kill whitefly nymphs compared to I. javanica. Our results underpin a feasible and cost-effective mass production method for aerial conidia, using palm kernel as the main substrate in order to produce efficacious fungal bioinsecticides against an invasive whitefly species in Brazil. Finally, our fermentation process may offer a sustainable and cost-effective means to produce eco-friendly mycoinsecticides, using an abundant agro-industrial by-product from Brazil that will ultimately assist in the integrated management of agricultural insect pests.

  15. 2006 marketplace survey of trans-fatty acid content of margarines and butters, cookies and snack cakes, and savory snacks.

    Science.gov (United States)

    Albers, Matthew J; Harnack, Lisa J; Steffen, Lyn M; Jacobs, David R

    2008-02-01

    In recent years, newer technologies have been developed to reduce the trans-fat content of fats and oils used in manufacturing food products. To examine the implications of these changes on foods in the marketplace, a survey was conducted to assess current levels of trans and saturated fat in three food categories: margarines and butters; cookies and snack cakes; and savory snacks. A sampling of products from each category was conducted at a Wal-Mart Supercenter in the Minneapolis-St Paul, MN, metropolitan area in July of 2006. All information was obtained from product labels, except price, which was recorded from price listings on product shelving. Most margarines and butters (21 of 29), cookies and snack cakes (34 of 44), and savory snacks (31 of 40) were labeled as containing 0 g trans fat. However, some products contained substantial amounts of trans fat. Most notably, 3 of 40 savory snack products were labeled as containing > or =3 g trans fat. Significant inverse correlations were found between product price and the saturated and trans-fat content of margarines (r=-0.45) and savory snacks (r=-0.32). In conclusion, it appears that the food industry has made progress in reducing the trans-fat content in a variety of products. Nonetheless, consumers need to read product labels because the trans-fat content of individual products can vary considerably. Products that are lower in trans and saturated fat tend to cost more, which may be a barrier to their purchase for price-conscious consumers.

  16. Detoxification of Jatropha curcas kernel cake by a novel Streptomyces fimicarius strain.

    Science.gov (United States)

    Wang, Xing-Hong; Ou, Lingcheng; Fu, Liang-Liang; Zheng, Shui; Lou, Ji-Dong; Gomes-Laranjo, José; Li, Jiao; Zhang, Changhe

    2013-09-15

    A huge amount of kernel cake, which contains a variety of toxins including phorbol esters (tumor promoters), is projected to be generated yearly in the near future by the Jatropha biodiesel industry. We showed that the kernel cake strongly inhibited plant seed germination and root growth and was highly toxic to carp fingerlings, even though phorbol esters were undetectable by HPLC. Therefore it must be detoxified before disposal to the environment. A mathematic model was established to estimate the general toxicity of the kernel cake by determining the survival time of carp fingerling. A new strain (Streptomyces fimicarius YUCM 310038) capable of degrading the total toxicity by more than 97% in a 9-day solid state fermentation was screened out from 578 strains including 198 known strains and 380 strains isolated from air and soil. The kernel cake fermented by YUCM 310038 was nontoxic to plants and carp fingerlings and significantly promoted tobacco plant growth, indicating its potential to transform the toxic kernel cake to bio-safe animal feed or organic fertilizer to remove the environmental concern and to reduce the cost of the Jatropha biodiesel industry. Microbial strain profile essential for the kernel cake detoxification was discussed. Copyright © 2013 Elsevier B.V. All rights reserved.

  17. Development of gluten-free cakes with the addition of methylcellulose and xanthan gum

    Directory of Open Access Journals (Sweden)

    Viviane Borges Vallejos

    2015-06-01

    Full Text Available The removal of gluten results in many baking problems and many gluten-free products currently available in the market are of low quality. The addition of hydrocolloids, however, is an option to improve technological characteristics. The objective of this study was to evaluate the influence of the addition of methylcellulose and xanthan gum on the technological characteristics of gluten-free cakes made with 100% rice flour. Cakes using hydrocolloids at different concentrations were developed through an experimental design that evaluated technological features such as specific volume, crumb hardness and overall quality score. Mathematical models were obtained to describe the hardness and the score of cakes as a function of the addition of xanthan and methylcellulose. The smallest value of crumb hardness of the cakes was obtained when concentrations of 0.4% xanthan and 2% methylcellulose were added. With regards to the score, the highest value was obtained with the lowest levels of hydrocolloids, whose formulation contained 0.2% xanthan gum and 1% methylcellulose. It can be concluded that the addition of xanthan gum and methylcellulose enabled the development of a gluten-free cake with a softer crumb that presents technological quality attributes similar to that of a wheat cake.

  18. Sensory evaluation and nutritional value of cakes prepared with whole flaxseed flour

    Directory of Open Access Journals (Sweden)

    Érica Aguiar Moraes

    2010-12-01

    Full Text Available The objective of this study was to evaluate the nutritional value, the oxidative stabilitiy, and consumer acceptance of cakes containing four different concentrations of flaxseed flour (5, 15, 30 and 45% as partial replacement for wheat flour. The oxidative stability of polyunsaturated fatty acids was evaluated through the lipid peroxidation test (TBARS in the flour and cakes. Linolenic acid was determined by gas chromatography as well as contents of protein, lipid, ash, and dietary fiber. Consumer acceptance was assessed using a structured hedonic scale of nine points. The oxidative stability of lipid flaxseeds was not affected by the heat treatment during flour processing and cake baking. Cakes made with 5, 15, and 30% of flaxseed flour, the most accepted by consumers, had dietary fiber levels ranging from 3.5 to 6.2 g and linolenic acid ranging from 445 to 2,500 mg.100 g-1 of the product. The cakes received claims of good and excellent source of dietary fiber and linolenic acid, respectively, both are bioactive compounds. The use of up to 30% of flaxseed flour in the preparation of cakes is a useful strategy to optimize the consumption of food rich in functional ingredients.

  19. The Application of Dragon Fruit Peels as a Dye in Red Velvet Cake

    Directory of Open Access Journals (Sweden)

    Dianka Wahyuningtias

    2015-11-01

    Full Text Available Red Dragon fruit peel that has a high antioxidant content is very useful and suitable processed into natural coloring in household industry are easily processed. One product to apply it is the Red Velvet Cake. Red Velvet Cake is basically uses natural coloring from the bits fruit and instant food coloring. This discussion will create a research that is attempting to replace the instant food coloring and natural food coloring from the bit that is commonly used in Red Velvet Cake by making use of the Dragon fruit that is considered to be food wastes. This research aims to provide a new alternative natural food coloring in the Red Velvet Cake. Experimental research is used by doing experiments and planned and systematic testing to Red Velvet Cake, and by collecting primary data and secondary data as well. All data is presented in a descriptive with SPSS. From the results of mean average can be inferred that the Red Velvet Cake using natural food coloring from Red Dragon fruit is acceptable to the community.

  20. Ripe Banana Flour as a Source of Antioxidants in Layer and Sponge Cakes.

    Science.gov (United States)

    Segundo, Cristina; Román, Laura; Lobo, Manuel; Martinez, Mario M; Gómez, Manuel

    2017-12-01

    About one-fifth of all bananas harvested become culls that are normally disposed of improperly. However, ripe banana pulp contains significant amounts of fibre and polyphenol compounds as well as a high content of simple sugars (61.06 g/100 g), making it suitable for sucrose replacement in bakery products. This work studied the feasibility of incorporating ripe banana flour (20 and 40% of replacement) in cake formulation. Physical, nutritional and sensory attributes of sponge and layer cakes were evaluated. The inclusion of ripe banana flour generally led to an increased batter consistency that hindered cake expansion, resulting in a slightly lower specific volume and higher hardness. This effect was minimised in layer cakes where differences in volume were only evident with the higher level of replacement. The lower volume and higher hardness contributed to the decline of the acceptability observed in the sensory test. Unlike physical attributes, the banana flour inclusion significantly improved the nutritional properties of the cakes, bringing about an enhancement in dietary fibre, polyphenols and antioxidant capacity (up to a three-fold improvement in antioxidant capacity performance). Therefore, results showed that sugar replacement by ripe banana flour enhanced the nutritional properties of cakes, but attention should be paid to its inclusion level.

  1. Application of extruded broken bean flour for formulation of gluten-free cake blends

    Directory of Open Access Journals (Sweden)

    Luciana de Oliveira Froes Gomes

    2015-06-01

    Full Text Available The aim of this study was to determine the physical and microbiological characteristics of extruded broken beans flour, in addition to developing mixtures for gluten-free cake with these flours, evaluating their technological and sensory quality. Gluten-free formulations were prepared with 45%, 60% and 75% of extruded broken beans. All analyzes of the flours and mixtures for cakes were performed according to standard techniques found in the literature. Sensory analyzes of cakes applied the 9-point structured hedonic scale. Results were submitted to variance analysis and comparison of means test (Tukey, p<0.05. The use of extruded broken beans improved the water absorbed and water solubility index of the mixtures for gluten-free cake, and for the lower viscosity and retrogradation when compared to the standard formulation. All cakes were accepted (rate ≥ 7 for all the analyzed attributes. From the technological and sensory standpoints, the development of gluten-free cake mixtures is feasible with up to 75% of extruded broken beans.

  2. Acceptance and purchase intent of US consumers for nonwheat rice butter cakes.

    Science.gov (United States)

    Sae-Eaw, A; Chompreeda, P; Prinyawiwatkul, W; Haruthaithanasan, V; Suwonsichon, T; Saidu, J E; Xu, Z

    2007-03-01

    This study evaluated consumer acceptance and purchase intent of nonwheat butter cake formulations prepared with Thai jasmine rice flour. Three nonwheat rice butter cakes were prepared with varying amounts of powdered emulsifier (propylene glycol ester:diacetyl tartaric acid ester of monoglyceride, 8:2) at 0% (product A), 7.5% (product B), and 15% (product C) of the margarine content (15%) in the cake formulation. A commercial wheat-based butter cake served as the control. Consumers (n= 400) evaluated acceptability of 9 sensory attributes using a 9-point hedonic scale. Overall acceptance and purchase intent were determined with a binomial (yes/no) scale. At least 81% of consumers accepted products B and C, of which 42.1% and 47%, respectively, would purchase the products if commercially available. Product A was neither liked nor disliked with an overall liking score of 5.39. The butter cake products were differentiated by textural acceptability (overall texture, softness, and moistness) with a canonical correlation of 0.71 to 0.79. Overall liking and taste influenced overall acceptance and purchase intent. Odor influenced purchase intent (P= 0.0014), but not overall acceptance. The odds ratio of overall liking was 3.462 for purchase intent, indicating the probability of the product being purchased is 3.462 times higher (than not being purchased, P flour with Thai jasmine rice flour for production of butter cake products acceptable to American consumers.

  3. The role and function of chlorine in the preparation of high-ratio cake flour.

    Science.gov (United States)

    Gough, B M; Whitehouse, M E; Greenwood, C T

    1978-01-01

    The literature on the role of chlorine treatment of flour for use in high-ratio cake production is discussed in relation to current knowledge of cereal chemistry and cake technology. A brief perspective of the present use of chlorine in high-ratio cake flours is included. Investigations of the uptake of gaseous chlorine by flour and its distribution among and chemical action upon the major flour components (water, protein, lipid, and carbohydrate) are assessed. The physical effects of chlorination as demonstrated by experiments with batters and cakes and by physicochemical observations of flour and its fractions are also considered. The characteristics of the starch in flour appear to be critical in high-ratio cakes. Chlorine treatment modifies the gelatinization behavior of the starch granules yet does not change their gelatinization temperature not is there evidence of chemical attack upon the starch molecules. Therefore, it is suggested that chlorine effects the necessary changes in starch behavior by reacting with the noncarbohydrate surface contaminants on the granules. Alternative methods of improving high-ratio cake flours are mentioned, particularly heat-treatment processes.

  4. Replacement of eggs with soybean protein isolates and polysaccharides to prepare yellow cakes suitable for vegetarians.

    Science.gov (United States)

    Lin, Muyang; Tay, Siang Hong; Yang, Hongshun; Yang, Bao; Li, Hongliang

    2017-08-15

    To evaluate the feasibility of substituting eggs in yellow cake by a mixture of soybean proteins, plant polysaccharides, and emulsifiers, the batter properties, including specific gravity and viscosity; cake properties, including specific volume, texture, colour, moisture, microstructures, and structural properties of starch and glutens of the replaced cake and traditional cake containing egg, were evaluated. Replacing eggs with a soy protein isolate and 1% mono-, di-glycerides yielded a similar specific volume, specific gravity, firmness and moisture content (1.92 vs. 2.08cm 3 /g, 0.95 vs. 1.03, 319.8 vs. 376.1g, and 28.03% vs. 29.01%, respectively) compared with the traditional cakes baked with eggs. Structurally, this formulation comprised dominant gliadin aggregates in the size range of 100-200nm and glutenin networking structures containing fewer but larger porosities. The results suggest that a mixture of soybean proteins and emulsifier is a promising substitute for eggs in cakes. Copyright © 2017 Elsevier Ltd. All rights reserved.

  5. Importance of consumer perceptions in fiber-enriched food products. A case study with sponge cakes.

    Science.gov (United States)

    Tarrega, Amparo; Quiles, Amparo; Morell, Pere; Fiszman, Susana; Hernando, Isabel

    2017-02-22

    Sponge cakes enriched with fiber from different sources (maltodextrin, wheat, apple, blackcurrant and a mixture of potato and Plantago ovata) were studied. Profiling of the different cakes was carried out, first using a check-all-that-apply (CATA) question then evaluating the consumers' likings using a hedonic scale. The consumers also completed a nutrition knowledge (NK) questionnaire that was used to classify them according to their NK level. The instrumental texture of the cakes was evaluated by the texture profile analysis (TPA) method. The consumers' response was not linked to their NK level, but it mainly depended on the importance they gave to the cakes' distinctive sensory characteristics. In general, liking increased for samples considered easy to chew, spongy, soft and sweet, and decreased for samples perceived as tasteless, dry or having a fruity or an odd flavor. The sponge cakes containing maltodextrin or wheat fiber, which mostly resembled a conventional cake, were the most liked in general. Those containing the other three fibers were rejected by part of the consumers, for being tasteless in the case of potato plus Plantago ovata fiber, for being dry and doughy in the case of apple fiber and for having an odd flavor in the case of blackcurrant fiber.

  6. The effect of different emulsifiers on the eggless cake properties containing WPC.

    Science.gov (United States)

    Khalilian Movahhed, Mohammad; Mohebbi, Mohebbat; Koocheki, Arash; Milani, Elnaz

    2016-11-01

    The possibility of complete replacement of egg proteins with whey protein concentrate (WPC) and improvement in quality by different emulsifiers was evaluated. Three emulsifiers, including polyglycerol ester (PGE), distilled mono glyceride (DMG) and lecithin were used to bake eggless cakes, containing 8% (w/w) WPC. The response surface analysis was applied to study the effect of emulsifiers on the eggless cake properties. The emulsifiers, individually and interactively, improved the properties of the eggless cakes significantly. The PGE and DMG decreased the batter density, however lecithin increased it. All emulsifiers increased the porosity and volume of the eggless cakes, but decreased the hardness and gumminess of crumb and improved the sensory acceptance. The indices used for optimization of formulation were water activity, moisture content, hardness, gumminess, volume, porosity and total acceptance. The optimum quality of the eggless cake can be achieved from a combination of 0.5 PGE, 0.25 DMG and 0.5% lecithin. The experimental and predicted responses of the optimized eggless cake had a good resemblance.

  7. A press for the theater

    Directory of Open Access Journals (Sweden)

    Luciana Penna França

    2017-12-01

    Full Text Available Understanding the history of the amateur theater at the end of the XIXth century and the beginning of the XXth is possible, largely, because of the newspapers dedicated to the “theatrical affairs”. Such publications are important for the quantity and the diversity, revealing not only the place occupied by the theater in the capital, but also for the recognition of the press as a means of disclosure of plays, public education and opinion, artist projection, etc, not to mention personal affairs and requests, and the exchange of favors among managers and journalists. Even more, the press production of the dramatic amateurs clubs demonstrate the understanding of its role in the dissemination of ways to act and think beyond the stage and in the everyday life.

  8. Effect of different flours on quality of legume cakes to be baked in microwave-infrared combination oven and conventional oven.

    Science.gov (United States)

    Ozkahraman, Betul Canan; Sumnu, Gulum; Sahin, Serpil

    2016-03-01

    The objective of this study was to compare the quality of legume cakes baked in microwave-infrared combination (MW-IR) oven with conventional oven. Legume cake formulations were developed by replacing 10 % wheat flour by lentil, chickpea and pea flour. As a control, wheat flour containing cakes were used. Weight loss, specific volume, texture, color, gelatinization degree, macro and micro-structure of cakes were investigated. MW-IR baked cakes had higher specific volume, weight loss and crust color change and lower hardness values than conventionally baked cakes. Larger pores were observed in MW-IR baked cakes according to scanning electron microscope (SEM) images. Pea flour giving the hardest structure, lowest specific volume and gelatinization degree was determined to be the least acceptable legume flour. On the other hand, lentil and chickpea flour containing cakes had the softest structure and highest specific volume showing that lentil and chickpea flour can be used to produce functional cakes.

  9. Pressing technology for large bottoms

    International Nuclear Information System (INIS)

    Jilek, L.

    1986-01-01

    The technology has been selected of a circular plate bent into the shape of a trough, for pressing bottoms of pressure vessels from a circular plate of large diameter. The initial sheet is first bent in the middle by heating with the edges remaining straight. These are then welded longitudinally by electroslag welding and the circular shape is flame cut. The result will be a plate with a straight surface in the middle with raised edges which may be pressed into the desired shape. In this manner it is also possible to press pressure vessel bottoms with tube couplings from plates which are thickened in the middle and drilled; additional welding is then eliminated. Deformation from heat treatment may be avoided by the use of a fixture in the shape of a ring with a groove into which is fixed the edge of the bottom. During hardening of the bottom it will be necessary to care for the withdrawal of vapours and gases which would hamper uniform cooling. Bottom hardening with the grill and the cupola downwards has been proven. Deformation which occurs during treatment may to a certain extent be removed by calibration which cannot, however, be made without special fixtures and instruments. (J.B.)

  10. Modularity of Pressing Tools for Screw Press Producing Solid Biofuels

    Directory of Open Access Journals (Sweden)

    Miloš Matúš

    2012-01-01

    Full Text Available This paper focuses on the development of the newly-patented structure of a screw briquetting machine for compacting biomass into a solid biofuel. The design of the machine is based on the results of a comprehensive study of the complicated process of biomass compaction. The patented structure meets two main goals: the elimination of axial forces, leading to increased lifetime of the bearings, and the new modular design of a pressing chamber and tools with their geometry based on the application of a mathematical model.

  11. Marketing in Germany: A market research for a start-up business of cake making/decorating business in Frankfurt

    OpenAIRE

    Bondar, Kristina

    2016-01-01

    The research problem was to make a market analysis of cake making/decorating business in Frankfurt, Germany. Based on the research process, customers’ attitudes towards cake making/decorating companies were found out. The main objective of the thesis was to know targeted customer behavior and opinions towards a business idea of initiating business in cake making/decorating, in order to find out if it will be profitable or not. This thesis consists of four sections: Introduction, Market ...

  12. Effectiveness of sal deoiled seed cake as an inducer for protease production from Aeromonas sp. S1 for its application in kitchen wastewater treatment.

    Science.gov (United States)

    Saini, Vandana; Bhattacharya, Amrik; Gupta, Anshu

    2013-08-01

    The present study is an attempt to demonstrate the feasibility of sal (Shorea robusta) deoiled cake--a forest-based industrial by-product--as a cheaper media supplement for augmented protease production from Aeromonas sp. S1 and application of protease in the treatment of kitchen wastewater. Under optimized conditions, protease production could successfully be enhanced to 5.13-fold (527.5 U mL(-1)) on using sal deoiled seed cake extract (SDOCE), as medium additive, compared to an initial production of 102.7 U mL(-1) in its absence. The culture parameters for optimum production of protease were determined to be incubation time (48 h), pH (7.0), SDOCE concentration (3 % (v/v)), inoculum size (0.3-0.6 % (v/v)), and agitation rate (100 rpm). The enzyme was found to have an optimum pH and temperature of 8.0 and 60 °C, respectively. The protease preparation was tested for treatment of organic-laden kitchen wastewater. After 96 h of wastewater treatment under static condition, enzyme preparation was able to reduce 74 % biological oxygen demand, 37 % total suspended solids, and 41 % oil and grease. The higher and improved level of protease obtained using sal deoiled seed cake-based media hence offers a new approach for value addition to this underutilized biomass through industrial enzyme production. The protease produced using this biomass could also be used as pretreatment tool for remediation of organic-rich food wastewater.

  13. Inhibitory effects of cinnamon and clove essential oils on mold growth on baked foods.

    Science.gov (United States)

    Ju, Jian; Xu, Xiaomiao; Xie, Yunfei; Guo, Yahui; Cheng, Yuliang; Qian, He; Yao, Weirong

    2018-02-01

    This study evaluated the minimum inhibition concentration (MIC) and minimum lethal concentration (MLC) of cinnamon and clove essential oils against mold growth on green bean cake and finger citron crisp cake, and also examined the effects of these two essential oils and their application methods on the shelf life of the baked products in normal and vacuum packages by accelerated storage test. The results showed that the MIC of cinnamon and clove essential oils against molds were 0.21-0.83 and 0.21-1.67μL/mL, respectively and the MLC were 0.42-0.83 and 0.83-1.67μL/mL, respectively. In normal package cinnamon and clove essential oils could prolong the shelf life of green bean cake 9-10 and 3-4days, respectively and could prolong the shelf life of finger citron crisp cake 5-6 and 2-3days, respectively. And in vacuum package they were 15-16, 8-9, 10-12 and 7-9days, respectively in turn. Copyright © 2017. Published by Elsevier Ltd.

  14. Characterization of sponge cake baking in an instrumented pilot oven

    Directory of Open Access Journals (Sweden)

    Alain Sommier

    2012-10-01

    Full Text Available The quality of baked products is the complex, multidimensional result of a recipe, and a controlled heating process to produce the desired final properties such as taste, colour, shape, structure and density. The process of baking a sponge cake in a convective oven at different air temperatures (160-180-220 °C leading to the same loss of mass was considered in this study. A special mould was used which allowed unidirectional heat transfer in the batter. Instrumentation was developed specifically for online measurement of weight loss, height variation and transient temperature profile and pressure in the product. This method was based on measuring heat fluxes (commercial sensors to account for differences in product expansion and colour. In addition, measurement of height with a camera was coupled to the product mass to calculate changes in density over time. Finally, combining this information with more traditional measurements gave a better understanding of heat and mass transfer phenomena occurring during baking.

  15. Can acceptable quality angel food cakes be made using pasteurized shell eggs? The effects of processing factors on functional properties of angel food cakes

    Science.gov (United States)

    Due to recent incidences of Salmonella contamination, the market for pasteurized shell eggs is rapidly growing. One objection to using pasteurized shell eggs is the belief that they will produce unacceptable baked product (e.g., angel food cakes). In the present study, shell eggs were pasteurized us...

  16. Production of yellow cake from rock phosphate deposits and its characterization

    International Nuclear Information System (INIS)

    Zumrawi, N. S.

    2002-05-01

    This study was carried out mainly to produce uranium trioxide (UO 3 ), with the standard of commercial specifications from rock phosphate deposits in eastern part of Nuba mountains, south Kurdufan state. A simplified hydrometallurgical procedure has been adopted for production of yellow cake from the ore. Elemental analysis has shown that the ore is rich in Ca and deficient in elements of potential interest such as Fe, Cu and Zn. Uranium content in ore, phosphoric acid and purified yellow cake (UO 3 ) obtained with different precipitants was analyzed using alpha-spectrometry. On the average, the activity concentration of uranium in ore corresponds to 82 ± 24 ppm (0.10%). From the data of pregnant liquor, it was observed that the addition of KCIO 3 as an oxidant improves the dissolution of uranium from the ore by almost 20%. Data has also indicated that the yellow cake purified by hydrogen peroxide has higher concentration of uranium by 44.5% over the one purified by TBP extraction. Undesirable impurities in yellow cake as dictated by the function to which it is intended for were analyzed and compared with international standard specifications set for commercial products. Uranium as U 3 O 8 was found to be 53% in yellow cake initially obtained as ammonium diuranate and purified by hydrogen peroxide and 38% in one, which is purified by TBP extraction. With the exception of Cr concentration, the values of the other critical impurities ( V, Mn, Co, Cu, Sr, Zr, Pb, Fe, Cl, Br, I) in UO 3 precipitated by hydrogen peroxide are either typical or lower than those internationally specified as standards for commercial products. Among the impurities considered Cd, Th and Mo were undetectable. The most salient point to be mentioned here regarding impurities is that Cd, which is most undesirable in yellow cake because of its high neutron absorption cross section, was undetectable in both types of yellow cakes ( i.e. purified by TBP extraction and by hydrogen peroxide). (Author)

  17. WordPress Website Development

    OpenAIRE

    Lassila, Joonas

    2016-01-01

    The aim of this Bachelor’s thesis was to develop a WordPress mobile-first style website for the customer, Pohjois-Suomen Pesis. The main purpose of the development was to learn website designing principles and create a responsive website for the mobile and desktop platforms. The development process began defining the requirements of the website and creating the requirements document. Then next step was learning how to design a website layout and to choose the colour scheme for the site. T...

  18. Smashing WordPress Beyond the Blog

    CERN Document Server

    Hedengren, Thord Daniel

    2012-01-01

    The ultimate guide to WordPress, from the world's most popular resource for web designers and developers As one of the hottest tools on the web today for creating a blog, WordPress has evolved to be much more that just a blogging platform and has been pushed beyond its original purpose. With this new edition of a perennially popular WordPress resource, Smashing Magazine offers you the information you need so you can maximize the potential and power of WordPress. WordPress expert Thord Daniel Hedengren takes you beyond the basic blog to show you how to leverage the capabilities of WordPress to

  19. Teach yourself visually WordPress

    CERN Document Server

    Majure, Janet

    2012-01-01

    Get your blog up and running with the latest version of WordPress WordPress is one of the most popular, easy-to-use blogging platforms and allows you to create a dynamic and engaging blog, even if you have no programming skills or experience. Ideal for the visual learner, Teach Yourself VISUALLY WordPress, Second Edition introduces you to the exciting possibilities of the newest version of WordPress and helps you get started, step by step, with creating and setting up a WordPress site. Author and experienced WordPress user Janet Majure shares advice, insight, and best practices for taking full

  20. Oil output's changing fortunes

    International Nuclear Information System (INIS)

    Eldridge, D.

    1994-01-01

    The Petroleum Economist, previously the Petroleum Press Service, has been making annual surveys of output levels of petroleum in all the oil-producing countries since its founding in 1934. This article documents trends and changes in the major oil-producing countries output from 1934 until the present. This analysis is linked with the political and historical events accompanying these changes, notably the growth of Middle Eastern oil production, the North Sea finds and most recently, Iraq's invasion of Kuwait in 1990. (UK)

  1. determining the optimum combination of palm kernel cake

    African Journals Online (AJOL)

    user

    Twenty (20) female grasscutters at 14 months of age were used for the study, which lasted for ten ... commercial production of grasscutter would boost efforts .... Range test (Steel and Torrie, 1980). .... based on oil palm by-products in Malaysia.

  2. Prediction of Pressing Quality for Press-Fit Assembly Based on Press-Fit Curve and Maximum Press-Mounting Force

    Directory of Open Access Journals (Sweden)

    Bo You

    2015-01-01

    Full Text Available In order to predict pressing quality of precision press-fit assembly, press-fit curves and maximum press-mounting force of press-fit assemblies were investigated by finite element analysis (FEA. The analysis was based on a 3D Solidworks model using the real dimensions of the microparts and the subsequent FEA model that was built using ANSYS Workbench. The press-fit process could thus be simulated on the basis of static structure analysis. To verify the FEA results, experiments were carried out using a press-mounting apparatus. The results show that the press-fit curves obtained by FEA agree closely with the curves obtained using the experimental method. In addition, the maximum press-mounting force calculated by FEA agrees with that obtained by the experimental method, with the maximum deviation being 4.6%, a value that can be tolerated. The comparison shows that the press-fit curve and max press-mounting force calculated by FEA can be used for predicting the pressing quality during precision press-fit assembly.

  3. Sequentially Integrated Optimization of the Conditions to Obtain a High-Protein and Low-Antinutritional Factors Protein Isolate from Edible Jatropha curcas Seed Cake.

    Science.gov (United States)

    León-López, Liliana; Dávila-Ortiz, Gloria; Jiménez-Martínez, Cristian; Hernández-Sánchez, Humberto

    2013-01-01

    Jatropha curcas seed cake is a protein-rich byproduct of oil extraction which could be used to produce protein isolates. The purpose of this study was the optimization of the protein isolation process from the seed cake of an edible provenance of J. curcas by an alkaline extraction followed by isoelectric precipitation method via a sequentially integrated optimization approach. The influence of four different factors (solubilization pH, extraction temperature, NaCl addition, and precipitation pH) on the protein and antinutritional compounds content of the isolate was evaluated. The estimated optimal conditions were an extraction temperature of 20°C, a precipitation pH of 4, and an amount of NaCl in the extraction solution of 0.6 M for a predicted protein content of 93.3%. Under these conditions, it was possible to obtain experimentally a protein isolate with 93.21% of proteins, 316.5 mg 100 g(-1) of total phenolics, 2891.84 mg 100 g(-1) of phytates and 168 mg 100 g(-1) of saponins. The protein content of the this isolate was higher than the content reported by other authors.

  4. Dehydrated olive-waste cake as a source of high value-added bioproduct: Drying kinetics, physicochemical properties, and bioactive compounds

    Directory of Open Access Journals (Sweden)

    Elsa Uribe

    2014-09-01

    Full Text Available Olive (Olea europaea L. oil processing produces significant amount of waste that can be utilized for the production of high value-added ingredients for various industrial applications. In this work, the effects of temperature on drying kinetics and quality indexes of the olive-waste cake during convective dehydration (40-90 °C were investigated. Results on effective moisture diffusivity, physicochemical parameters, fatty acid profile, total phenolic, flavonoid, and flavanol contents as well as antioxidant capacity are also reported. Most of the fatty acids increased their content with respect to control sample with a temperature increase, i.e. oleic and linoleic acids increased 48% and 43% at 70 and 40 °C, respectively. Total flavanol content increased with temperature (48-62 mg catechin equivalents [CTE] 100 g-1 DM except for 80 °C. Total phenolic and total flavonoid contents were highly correlated to antioxidant capacity (0.923 < r < 0.992, except for 70 and 80 °C, the rest of the samples maintained their initial antioxidant capacity by ORAC analysis. Thus, these parameters show that dried olive-waste cake has a high bioactive compounds with potential use as additives for the food or other industries.

  5. Thermal Properties of Extruded Injection-Molded Poly (lactic acid) and Milkweed Composites: Degradation Kinectics and Enthalpic Relaxation

    Science.gov (United States)

    In order to determine the degree of compatibility between Poly (lactic Acid) (PLA) and different biomaterials, PLA was compounded with milkweed fiber, a new crop oil seed. After oil extraction, the remaining cake retained approximately 10% residual oil and 47% protein. The pressed seed cake (10% mo...

  6. Feasibility study of sucrose and fat replacement using inulin and rebaudioside A in cake formulations.

    Science.gov (United States)

    Majzoobi, Mahsa; Mohammadi, Mahshid; Mesbahi, Gholamreza; Farahnaky, Asgar

    2018-02-20

    Cake is a popular food around the world, however, it is considered as unhealthy due to its high fat and sucrose content. To satisfy customers' demand for a low fat and sucrose cake, in this research both sucrose and fat content of the cake were reduced by using rebaudioside A (Reb A; as a natural sucrose replacer) and inulin (as a natural fat replacer) at 0%, 25%, 50%, 75%, and 100%. The water content of different formulation was adjusted to obtain a constant batter viscosity similar to the control (3,757 cP). By reducing sucrose and fat content up to 50%, water activity increased and the cakes became more asymmetrical. However, other physical properties including baking weight loss, height, volume, crust color, and texture were similar to those of the control. Higher levels of replacement (75% and 100%) resulted in remarkable loss of different quality attributes. These samples showed higher water activity and baking loss, lower volume, harder texture, darker color, and highly asymmetrical shape. Thus, successful reduction of both fat and sucrose in cakes is possible by using inulin and Reb A at replacement levels no more than 50%. Customers' demand for healthy and yet tasty and high-quality foods is increasing around the world. Therefore, finding applicable and safe methods to produce such products is of great interest in the food manufacturing to satisfy customers. Health conscious customers avoid consumption of cakes because it contains high sucrose and fat content. Many studies have been performed to reduce either fat or sucrose content, while a few studies are available to show the reduction of both fat and sucrose in the same product. This study indicates the results of an applicable method to reduce fat and sucrose content of cakes simultaneously. Using rebaudioside A (as a natural sucrose replacer) and inulin (as a natural fat replacer) up to 50% of sucrose and fat content of cakes were reduced and the resulting cake had very similar physical properties to

  7. Pellet presses for remote fuel fabrication

    International Nuclear Information System (INIS)

    Densley, P.J.

    1978-01-01

    Two types of mechanical presses are being tested from the remote operation and remote maintenance aspects. Results will be used to recommend the type of press and design considerations required for operation in a remotely operated and maintained process line

  8. Effect of ingredients on rheological, physico-sensory, and nutritional characteristics of omega-3-fatty acid enriched eggless cake.

    Science.gov (United States)

    Abhay Kumar, N; Prasada Rao, U J S; Jeyarani, T; Indrani, D

    2017-10-01

    The effect of defatted soya flour (DS), flax seed powder (FS) in combination (DSFS) with emulsifiers such as glycerol monostearate, GMS (DSFSG) and sodium stearoyl-2-lactylate, SSL (DSFSS) on the rheological, physico-sensory, protein subunit composition by sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE), fatty acid profile, and nutritional characteristics of eggless cake was studied. Use of DSFS, DSFSG, and DSFSS increased the amylograph peak viscosity, hot and cold paste viscosities similar to the egg. Addition of DSFS, DSFSG, and DSFSS increased viscosity of eggless cake batter; cake volume and the overall quality score (OQS) of eggless cake. Among these, highest improvement in OQS was brought about by DSFSG. According to SDS-PAGE results, the improvement by DSFSG is due to crosslinking of wheat-soya-flax proteins similar to wheat-egg proteins crosslinking. The eggless cake with DSFSG was found to be rich in omega-3-fatty acid as it contained 0.6% of linolenic acid compared to 0.1% each of cake with egg and eggless cake. As eggs are significant source of cholesterol, there has been an increased interest in search of ingredients that can replace egg in cakes. Hence, recent trend in the baking industry is to produce eggless cake using a combination of different ingredients and additives. However, there is no scientific information on the interaction of non-egg protein with wheat protein in building up the structure and also to improve the nutritional quality with respect to protein and fatty acids profiles of eggless cake. The information generated on the use of combination of defatted soya flour and flax seed along with emulsifiers will be helpful for the commercial manufacture of omega-3-fatty acid rich eggless cake with desired quality attributes. © 2017 Wiley Periodicals, Inc.

  9. Evaluation of the effectiveness of olive cake residue as an expansive soil stabilizer

    Science.gov (United States)

    Nalbantoglu, Zalihe; Tawfiq, Salma

    2006-08-01

    The quantity of the by-product olive cake residue generated in most parts of the Mediterranean countries continues to increase and expected to double in amount within 10 15 years. This increase intensifies the problems associated with the disposal of this by-product. Olive cake residue has a potential for use as a soil stabilizer and large volumes can be beneficially used. This study is directed toward determining if olive cake residue can be utilized to increase the strength and stability of expansive soils which constitute a costly natural hazard to lightweight structures on shallow foundations. A series of laboratory tests using engineering properties, such as Atterberg limits, moisture-density relationship (compaction), swell, unconfined compressive strength were undertaken to evaluate the effectiveness and performance of the olive cake residue as a soil stabilizer. Test results indicate that an addition of only 3% burned olive waste into the soil causes a reduction in plasticity, volume change and an increase in the unconfined compressive strength. However, it was observed that the presence of burned olive waste in the soil greater than 3% caused an increase in the compressibility and a decrease in the unconfined compressive strength. Test results indicate that the use of olive waste in soil stabilization gives greater benefits to the environment than simply disposing of the by-product, olive cake residue.

  10. In vitro starch digestibility and predicted glycemic index of microwaved and conventionally baked pound cake.

    Science.gov (United States)

    Sánchez-Pardo, María Elena; Ortiz-Moreno, Alicia; Mora-Escobedo, Rosalva; Necoechea-Mondragón, Hugo

    2007-09-01

    The present study compares the effect of baking process (microwave vs conventional oven) on starch bioavailability in fresh pound cake crumbs and in crumbs from pound cake stored for 8 days. Proximal chemical analysis, resistant starch (RS), retrograded starch (RS3) and starch hydrolysis index (HI) were evaluated. The empirical formula suggested by Granfeldt was used to determine the predicted glycemic index (pGI). Pound cake, one of Mexico's major bread products, was selected for analysis because the quality defects often associated with microwave baking might be reduced with the use of high-fat, high-moisture, batted dough. Differences in product moisture, RS and RS3 were observed in fresh microwave-baked and conventionally baked pound cake. RS3 increased significantly in conventionally baked products stored for 8 days at room temperature, whereas no significantly changes in RS3 were observed in the microwaved product. HI values for freshly baked and stored microwaved product were 59 and 62%, respectively (P > 0.05), whereas the HI value for the conventionally baked product decreased significantly after 8 days of storage. A pound cake with the desired HI and GI characteristics might be obtained by adjusting the microwave baking process.

  11. Impact of potassium bromate and potassium iodate in a pound cake system.

    Science.gov (United States)

    Wilderjans, Edith; Lagrain, Bert; Brijs, Kristof; Delcour, Jan A

    2010-05-26

    This study investigates the impact of the oxidants potassium bromate and potassium iodate (8, 16, 32, 64, and 128 micromol/g dry matter of egg white protein) on pound cake making. The impact of the oxidants on egg white characteristics was studied in a model system. Differential scanning calorimetry showed that the oxidants caused egg white to denature later. During heating in a rapid visco analyzer, the oxidants caused the free sulfhydryl (SH) group levels to decrease more intensively and over a smaller temperature range. The oxidants made the proteins more resistant to decreases in protein extractability in sodium dodecyl sulfate containing buffer during cake recipe mixing and less resistant to such decreases during cake baking. We assume that, during baking, the degree to which SH/disulfide exchange and SH oxidation can occur depends on the properties of the protein at the onset of the process. In our view, the prevention of extractability loss during mixing increased the availability of SH groups and caused more such loss during baking. During cooling, all cakes baked with added oxidants showed less collapse. On the basis of the presented data, we put forward that only those protein reactions that occur during baking contribute to the formation of a network that supports final cake structure and prevents collapse.

  12. Evaluation of dry heat treatment of soft wheat flour for the production of high ratio cakes.

    Science.gov (United States)

    Keppler, S; Bakalis, S; Leadley, C E; Sahi, S S; Fryer, P J

    2018-05-01

    An accurate method to heat treat flour samples has been used to quantify the effects of heat treatment on flour functionality. A variety of analytical methods has been used such as oscillatory rheology, rheomixer, solvent retention capacity tests, and Rapid Visco Analysis (RVA) in water and in aqueous solutions of sucrose, lactic acid, and sodium carbonate. This work supports the hypothesis that heat treatment facilitates the swelling of starch granules at elevated temperature. Results furthermore indicated improved swelling ability and increased interactions of flour polymers (in particular arabinoxylans) of heat treated flour at ambient conditions. The significant denaturation of the proteins was indicated by a lack of gluten network formation after severe heat treatments as shown by rheomixer traces. Results of these analyses were used to develop a possible cake flour specification. A method was developed using response surfaces of heat treated flour samples in the RVA using i) water and ii) 50% sucrose solution. This can uniquely characterise the heat treatment a flour sample has received and to establish a cake flour specification. This approach might be useful for the characterisation of processed samples, rather than by baking cakes. Hence, it may no longer be needed to bake a cake after flour heat treatment to assess the suitability of the flour for high ratio cake production, but 2 types of RVA tests suffice. Copyright © 2018 The Authors. Published by Elsevier Ltd.. All rights reserved.

  13. Fuzzy Logic-based expert system for evaluating cake quality of freeze-dried formulations.

    Science.gov (United States)

    Trnka, Hjalte; Wu, Jian X; Van De Weert, Marco; Grohganz, Holger; Rantanen, Jukka

    2013-12-01

    Freeze-drying of peptide and protein-based pharmaceuticals is an increasingly important field of research. The diverse nature of these compounds, limited understanding of excipient functionality, and difficult-to-analyze quality attributes together with the increasing importance of the biosimilarity concept complicate the development phase of safe and cost-effective drug products. To streamline the development phase and to make high-throughput formulation screening possible, efficient solutions for analyzing critical quality attributes such as cake quality with minimal material consumption are needed. The aim of this study was to develop a fuzzy logic system based on image analysis (IA) for analyzing cake quality. Freeze-dried samples with different visual quality attributes were prepared in well plates. Imaging solutions together with image analytical routines were developed for extracting critical visual features such as the degree of cake collapse, glassiness, and color uniformity. On the basis of the IA outputs, a fuzzy logic system for analysis of these freeze-dried cakes was constructed. After this development phase, the system was tested with a new screening well plate. The developed fuzzy logic-based system was found to give comparable quality scores with visual evaluation, making high-throughput classification of cake quality possible. © 2013 Wiley Periodicals, Inc. and the American Pharmacists Association.

  14. Bubble structure evaluation method of sponge cake by using image morphology

    Science.gov (United States)

    Kato, Kunihito; Yamamoto, Kazuhiko; Nonaka, Masahiko; Katsuta, Yukiyo; Kasamatsu, Chinatsu

    2007-01-01

    Nowadays, many evaluation methods for food industry by using image processing are proposed. These methods are becoming new evaluation method besides the sensory test and the solid-state measurement that have been used for the quality evaluation recently. The goal of our research is structure evaluation of sponge cake by using the image processing. In this paper, we propose a feature extraction method of the bobble structure in the sponge cake. Analysis of the bubble structure is one of the important properties to understand characteristics of the cake from the image. In order to take the cake image, first we cut cakes and measured that's surface by using the CIS scanner, because the depth of field of this type scanner is very shallow. Therefore the bubble region of the surface has low gray scale value, and it has a feature that is blur. We extracted bubble regions from the surface images based on these features. The input image is binarized, and the feature of bubble is extracted by the morphology analysis. In order to evaluate the result of feature extraction, we compared correlation with "Size of the bubble" of the sensory test result. From a result, the bubble extraction by using morphology analysis gives good correlation. It is shown that our method is as well as the subjectivity evaluation.

  15. Quantitative evaluation method of the bubble structure of sponge cake by using morphology image processing

    Science.gov (United States)

    Tatebe, Hironobu; Kato, Kunihito; Yamamoto, Kazuhiko; Katsuta, Yukio; Nonaka, Masahiko

    2005-12-01

    Now a day, many evaluation methods for the food industry by using image processing are proposed. These methods are becoming new evaluation method besides the sensory test and the solid-state measurement that are using for the quality evaluation. An advantage of the image processing is to be able to evaluate objectively. The goal of our research is structure evaluation of sponge cake by using image processing. In this paper, we propose a feature extraction method of the bobble structure in the sponge cake. Analysis of the bubble structure is one of the important properties to understand characteristics of the cake from the image. In order to take the cake image, first we cut cakes and measured that's surface by using the CIS scanner. Because the depth of field of this type scanner is very shallow, the bubble region of the surface has low gray scale values, and it has a feature that is blur. We extracted bubble regions from the surface images based on these features. First, input image is binarized, and the feature of bubble is extracted by the morphology analysis. In order to evaluate the result of feature extraction, we compared correlation with "Size of the bubble" of the sensory test result. From a result, the bubble extraction by using morphology analysis gives good correlation. It is shown that our method is as well as the subjectivity evaluation.

  16. Degree of roasting of carob flour affecting the properties of gluten-free cakes and cookies.

    Science.gov (United States)

    Román, Laura; González, Ana; Espina, Teresa; Gómez, Manuel

    2017-06-01

    Carob flour is a product rich in fibre obtained from by-products of the locust bean gum extraction processing. The flour is commercialised with different degrees of roasting in order to improve its organoleptic characteristics. In this study, carob flour with three different roasting degrees was used to replace rice flour (15%) in gluten-free cakes and cookies. The influence of this replacement was studied on the psychochemical characteristics and acceptability of the final products. The incorporation of carob flour increased the viscosity of cake batters and increased the solid elastic-like behaviour of the cookie doughs, indicating a stronger interaction among the formula ingredients. The inclusion of carob flour, with a low time of roasting, did not lead to any significant differences in the specific volume and hardness of the cakes, but reduced cake staling and the thickness and width of the cookies. Darker colours were obtained when carob flour was incorporated into the product. The acceptability of cakes was only reduced with the addition of highly roasted carob flour, while in the case of cookies there was a decline in the acceptability of all carob flour cookies, which was mostly perceived with the highest roasting degree, something mainly attributed to the bitter taste of the products.

  17. Feeding behavior of lactating cows fed palm kernel cake in the diet

    Directory of Open Access Journals (Sweden)

    Leidiane Reis Pimentel

    2015-02-01

    Full Text Available This study aimed to evaluate the effect of including of palm kernel cake on feeding behavior of lactating crossbred cows. Twelve crossbred Holstein x Zebu cows were distributed in three 4 x 4 latin squares, with the following treatments: control; inclusion of 5%; inclusion of 10%; inclusion of 15% palm kernel cake in the diet dry matter. The animals were observed during four periods as to feeding behavior, 24 hours in each period. There was no effect of inclusion of palm kernel cake (p > 0.05 on time spent on eating, ruminating and idling. The feeding efficiencies of dry matter and corrected neutral detergent fiber, total digestible nutrients, and the rumination efficiency of corrected neutral detergent fiber were not influenced (p > 0.05. There was a linear increase with the inclusion of palm kernel cake (p 0.05. The inclusion of palm kernel cake in diets for dairy cows causes no change in behavior activities and efficiencies of feeding and rumination, until the 15% level of inclusion.

  18. Effect of pretreatment on purple-fleshed sweet potato flour for cake making

    Science.gov (United States)

    Hutasoit, M. S.; Julianti, E.; Lubis, Z.

    2018-02-01

    The purple-fleshed sweet-potato (PFSP) flour was produced by varying pretreatment of washed chips: dipping in 0.5 and 1.0% (w/v) citric acid solution for 30 min, dipping in 0.5 and 1.0% (w/v) citric acid solution for 30 min and followed by steam blanching for 5 min. The pretreatment effect on cake quality was investigated. The results showed that PFSP flour produced from pretreatment with dipping in 0.5% citric acid for 30 min followed by steam blanching for 5 min had higher lightness (L*) value and lower browning index, higher hedonic value of color and aroma and baking expansion. The specific volume of cake from pretreated flour, untreated flour and wheat flour were 44.87, 43.83, and 50.43cm3/g, respectively. The sensory evaluation of cake indicated that cake from pretreated PFSP flour was acceptable compare to those of cake from wheat flour.

  19. Palm kernel cake obtained from biodiesel production in diets for goats: feeding behavior and physiological parameters.

    Science.gov (United States)

    de Oliveira, R L; de Carvalho, G G P; Oliveira, R L; Tosto, M S L; Santos, E M; Ribeiro, R D X; Silva, T M; Correia, B R; de Rufino, L M A

    2017-10-01

    The objective of this study was to evaluate the effects of the inclusion of palm kernel (Elaeis guineensis) cake in diets for goats on feeding behaviors, rectal temperature, and cardiac and respiratory frequencies. Forty crossbred Boer male, non-castrated goats (ten animals per treatment), with an average age of 90 days and an initial body weight of 15.01 ± 1.76 kg, were used. The goats were fed Tifton 85 (Cynodon spp.) hay and palm kernel supplemented at the rates of 0, 7, 14, and 21% of dry matter (DM). The feeding behaviors (rumination, feeding, and idling times) were observed for three 24-h periods. DM and neutral detergent fiber (NDF) intake values were estimated as the difference between the total DM and NDF contents of the feed offered and the total DM and NDF contents of the orts. There was no effect of palm kernel cake inclusion in goat diets on DM intake (P > 0.05). However, palm kernel cake promoted a linear increase (P kernel cakes had no effects (P > 0.05) on the chewing, feeding, and rumination efficiency (DM and NDF) or on physiological variables. The use up to 21% palm kernel cake in the diet of crossbred Boer goats maintained the feeding behaviors and did not change the physiological parameters of goats; therefore, its use is recommended in the diet of these animals.

  20. Criticality considerations for salt-cake disolution in DOE waste tanks

    International Nuclear Information System (INIS)

    Trumble, E.F.; Niemer, K.A.

    1995-01-01

    A large amount of high-level waste is being stored in the form of salt cake at the Savannah River site (SRS) in large (1.3 x 106 gal) underground tanks awaiting startup of the Defense Waste Processing Facility (DWPF). This salt cake will be dissolved with water, and the solution will be fed to DWPF for immobilization in borosilicate glass. Some of the waste that was transferred to the tanks contained enriched uranium and plutonium from chemical reprocessing streams. As water is added to these tanks to dissolve the salt cake, the insoluble portion of this fissile material will be left behind in the tank as the salt solution is pumped out. Because the salt acts as a diluent to the fissile material, the process of repeated water addition, salt dissolution, and salt solution removal will act as a concentrating mechanism for the undissolved fissile material that will remain in the tank. It is estimated that tank 41 H at SRS contains 20 to 120 kg of enriched uranium, varying from 10 to 70% 235 U, distributed nonuniformly throughout the tank. This paper discusses the criticality concerns associated with the dissolution of salt cake in this tank. These concerns are also applicable to other salt cake waste tanks that contain significant quantities of enriched uranium and/or plutonium