WorldWideScience

Sample records for oil palm shell

  1. Fast pyrolysis of oil palm shell (OPS)

    Science.gov (United States)

    Abdullah, Nurhayati; Sulaiman, Fauziah; Aliasak, Zalila

    2015-04-01

    Biomass is an important renewable source of energy. Residues that are obtained from harvesting and agricultural products can be utilised as fuel for energy generation by conducting any thermal energy conversion technology. The conversion of biomass to bio oil is one of the prospective alternative energy resources. Therefore, in this study fast pyrolysis of oil palm shell was conducted. The main objective of this study was to find the optimum condition for high yield bio-oil production. The experiment was conducted using fixed-bed fluidizing pyrolysis system. The biomass sample was pyrolysed at variation temperature of 450°C - 650°C and at variation residence time of 0.9s - 1.35s. The results obtained were further discussed in this paper. The basic characteristic of the biomass sample was also presented here. The experiment shows that the optimum bio-oil yield was obtained at temperature of 500°C at residence time 1.15s.

  2. Exploratory Study of Palm Oil Fuel Ash as Partial Cement Replacement in Oil Palm Shell Lightweight Aggregate Concrete

    OpenAIRE

    Muthusamy, K.; Z. Nur Azzimah

    2014-01-01

    In Malaysia, issue of environmental pollution resulting from disposal of Palm Oil Fuel Ash (POFA) which is a by-product from palm oil mill has initiated research to incorporate this waste in Oil Palm Shell (OPS) lightweight aggregate concrete production. The current study investigates the effect of palm oil fuel ash content as partial cement replacement towards compressive strength OPS lightweight aggregate concrete. Several OPS lightweight aggregate concrete mixes were produced by replacing ...

  3. Utilization of Palm Oil Fuel Ash as Binder in Lightweight Oil Palm Shell Geopolymer Concrete

    Directory of Open Access Journals (Sweden)

    Michael Yong Jing Liu

    2014-01-01

    Full Text Available Traditionally fly ash (FA has been used to replace cement as binder in the geopolymer concrete. The utilization of palm oil industrial waste materials known as palm oil fuel ash (POFA and oil palm shell (OPS that are abundantly available in South East Asia as binder and coarse aggregate in geopolymer concrete would give an added advantage in both the environmental and economic aspects. The mechanical properties of the OPS geopolymer concrete (OPSGC through the use of POFA, FA, and OPS are investigated and reported. A total of ten OPSGC mixtures were prepared with varying percentages of POFA and FA such as 0, 10, 20, 40, and 100%. The specimens prepared with two alkaline solution to binder (AK/B ratios of 0.35 and 0.55 were oven cured at 65°C for 48 hours. The experimental results showed that the highest compressive strength of 30 MPa was obtained for the mix with 20% replacement of FA by POFA and AK/B ratio of 0.55, which underwent oven curing. Further, the mix of up to 20% POFA (with AK/B ratio of 0.55 can be categorized as structural lightweight concrete. An increase of the POFA content beyond 20% decreases the mechanical properties, and hence this mix is recommended to be used.

  4. Palm Oil

    Science.gov (United States)

    Palm oil is obtained from the fruit of the oil palm tree. Palm oil is used for preventing vitamin A deficiency, cancer, ... blood pressure, high cholesterol, and cyanide poisoning. Palm oil is used for weight loss and increasing the ...

  5. The oil palm SHELL gene controls oil yield and encodes a homologue of SEEDSTICK.

    Science.gov (United States)

    Singh, Rajinder; Low, Eng-Ti Leslie; Ooi, Leslie Cheng-Li; Ong-Abdullah, Meilina; Ting, Ngoot-Chin; Nagappan, Jayanthi; Nookiah, Rajanaidu; Amiruddin, Mohd Din; Rosli, Rozana; Manaf, Mohamad Arif Abdul; Chan, Kuang-Lim; Halim, Mohd Amin; Azizi, Norazah; Lakey, Nathan; Smith, Steven W; Budiman, Muhammad A; Hogan, Michael; Bacher, Blaire; Van Brunt, Andrew; Wang, Chunyan; Ordway, Jared M; Sambanthamurthi, Ravigadevi; Martienssen, Robert A

    2013-08-15

    A key event in the domestication and breeding of the oil palm Elaeis guineensis was loss of the thick coconut-like shell surrounding the kernel. Modern E. guineensis has three fruit forms, dura (thick-shelled), pisifera (shell-less) and tenera (thin-shelled), a hybrid between dura and pisifera. The pisifera palm is usually female-sterile. The tenera palm yields far more oil than dura, and is the basis for commercial palm oil production in all of southeast Asia. Here we describe the mapping and identification of the SHELL gene responsible for the different fruit forms. Using homozygosity mapping by sequencing, we found two independent mutations in the DNA-binding domain of a homologue of the MADS-box gene SEEDSTICK (STK, also known as AGAMOUS-LIKE 11), which controls ovule identity and seed development in Arabidopsis. The SHELL gene is responsible for the tenera phenotype in both cultivated and wild palms from sub-Saharan Africa, and our findings provide a genetic explanation for the single gene hybrid vigour (or heterosis) attributed to SHELL, via heterodimerization. This gene mutation explains the single most important economic trait in oil palm, and has implications for the competing interests of global edible oil production, biofuels and rainforest conservation.

  6. Potassium hydroxide catalyst supported on palm shell activated carbon for transesterification of palm oil

    Energy Technology Data Exchange (ETDEWEB)

    Baroutian, Saeid; Aroua, Mohamed Kheireddine; Raman, Abdul Aziz Abdul; Sulaiman, Nik Meriam Nik [Department of Chemical Engineering, Faculty of Engineering, University of Malaya, 50603 Kuala Lumpur (Malaysia)

    2010-11-15

    In this study, potassium hydroxide catalyst supported on palm shell activated carbon was developed for transesterification of palm oil. The Central Composite Design (CCD) of the Response Surface Methodology (RSM) was employed to investigate the effects of reaction temperature, catalyst loading and methanol to oil molar ratio on the production of biodiesel using activated carbon supported catalyst. The highest yield was obtained at 64.1 C reaction temperature, 30.3 wt.% catalyst loading and 24:1 methanol to oil molar ratio. The physical and chemical properties of the produced biodiesel met the standard specifications. This study proves that activated carbon supported potassium hydroxide is an effective catalyst for transesterification of palm oil. (author)

  7. Non-tenera Contamination and the Economic Impact of SHELL Genetic Testing in the Malaysian Independent Oil Palm Industry

    OpenAIRE

    Ooi, Leslie C.-L.; Low, Eng-Ti L.; Abdullah, Meilina O.; Nookiah, Rajanaidu; Ting, Ngoot C.; Nagappan, Jayanthi; Manaf, Mohamad A. A.; Chan, Kuang-Lim; Halim, Mohd A.; Azizi, Norazah; Omar, Wahid; Murad, Abdul J.; Lakey, Nathan; Ordway, Jared M.; Favello, Anthony

    2016-01-01

    Oil palm (Elaeis guineensis) is the most productive oil bearing crop worldwide. It has three fruit forms, namely dura (thick-shelled), pisifera (shell-less) and tenera (thin-shelled), which are controlled by the SHELL gene. The fruit forms exhibit monogenic co-dominant inheritance, where tenera is a hybrid obtained by crossing maternal dura and paternal pisifera palms. Commercial palm oil production is based on planting thin-shelled tenera palms, which typically yield 30% more oil than dura p...

  8. Sulfonation of phenols extracted from the pyrolysis oil of oil palm shells for enhanced oil recovery.

    Science.gov (United States)

    Awang, Mariyamni; Seng, Goh Meng

    2008-01-01

    The cost of chemicals prohibits many technically feasible enhanced oil recovery methods to be applied in oil fields. It is shown that by-products from oil palm processing can be a source of valuable chemicals. Analysis of the pyrolysis oil from oil palm shells, a by-product of the palm oil industry, reveals a complex mixture of mainly phenolic compounds, carboxylic acids, and aldehydes. The phenolic compounds were extracted from the pyrolysis oil by liquid-liquid extraction using alkali and an organic solvent and analyzed, indicating the presence of over 93% phenols and phenolic compounds. Simultaneous sulfonation and alkylation of the pyrolysis oil was carried out to produce surfactants for application in oil fields. The lowest measured surface tension and critical micelle concentration was 30.2 mNm(-1) and 0.22 wt%, respectively. Displacement tests showed that 7-14% of the original oil in place was recovered by using a combination of surfactants and xanthan (polymer) as additives.

  9. CHARACTERIZATION OF BIO-OIL FROM PALM KERNEL SHELL PYROLYSIS

    Directory of Open Access Journals (Sweden)

    R. Ahmad

    2014-12-01

    Full Text Available Pyrolysis of palm kernel shell in a fixed-bed reactor was studied in this paper. The objectives were to investigate the effect of pyrolysis temperature and particle size on the products yield and to characterize the bio-oil product. In order to get the optimum pyrolysis parameters on bio-oil yield, temperatures of 350, 400, 450, 500 and 550 °C and particle sizes of 212–300 µm, 300–600 µm, 600µm–1.18 mm and 1.18–2.36 mm under a heating rate of 50 °C min-1 were investigated. The maximum bio-oil yield was 38.40% at 450 °C with a heating rate of 50 °C min-1 and a nitrogen sweep gas flow rate of 50 ml min-1. The bio-oil products were analysed by Fourier transform infra-red spectroscopy (FTIR and gas chromatography–mass spectroscopy (GCMS. The FTIR analysis showed that the bio-oil was dominated by oxygenated species. The phenol, phenol, 2-methoxy- and furfural that were identified by GCMS analysis are highly suitable for extraction from the bio-oil as value-added chemicals. The highly oxygenated oils need to be upgraded in order to be used in other applications such as transportation fuels.

  10. Exploratory Study of Oil Palm Shell as Partial Sand Replacement in Concrete

    Directory of Open Access Journals (Sweden)

    K. Muthusamy

    2013-03-01

    Full Text Available Malaysia being one of the world largest palm oil producers has been disposing oil palm shell, which is a by-product from palm oil mill thus causing negative impact to the environment. At the same time, extensive mining of natural river sand in large amount to meet the increasing demand of concrete production for the use in rapidly developing construction industry has posed the risk of natural aggregate depletion and ecological imbalance in future. The effect of finely Crushed Oil Palm Shell (COPS as partial sand replacement material in concrete mix towards density and compressive strength was investigated in this study. Total of five mixes consisting various content of crushed oil palm shell as partial sand replacement ranging from 0, 25, 50, 75 and 100% were prepared in form of cubes. All the specimens were water cured before tested at 7, 14 and 28 days. Compressive strength was conducted in accordance to BSEN 12390. Generally, the compressive strength and density decrease with the increase in the crushed oil palm shell replacement level. Between 50 to 75% replacement, the mix produced possess lower density enabling it to be categorized as lightweight concrete and has the potential to be used as non-load bearing structure. The application in structural concrete material is suited for mix consisting around 25% of crushed oil palm shell.

  11. Effect of temperature on energy potential of pyrolysis products from oil palm shells

    Directory of Open Access Journals (Sweden)

    Lina María Romero Millán

    2016-06-01

    Full Text Available Context: Taking into account that near 220 000 tons of oil palm shells are produced every year in Colombia, as a waste of the Elaeis Guineensis palm oil transformation process, the aim of this work is to determine the energy potential of oil palm shells, when transformed through slow pyrolysis process.Methods: Using a fixed bed lab scale reactor, different oil palm shells pyrolysis tests were performed between 300°C and 500°C. The effect of the temperature in the process product yield and in the energy content of produced solids and gases were analyzed.Results: With a maximum mass yield of 50%, the char is considered the main product of oil palm shells pyrolysis, containing up to 73% of the raw biomass energy. The heating value of char raised with the temperature, from 29,6 MJ/kg at 300°C to 31,34 MJ/kg at 500°C. Moreover, the gas produced in the established temperature range had up to 13% of the energy content of the raw biomass, with a heating value near 12,5 MJ/m3.Conclusions: According to the results, slow pyrolysis can be considered an interesting process for the valorization of residual biomass as oil palm shells, through the production of solids and gases that can be used as fuels, or as precursor of other value-added products.

  12. Structural Lightweight Concrete Production by Using Oil Palm Shell

    Directory of Open Access Journals (Sweden)

    Habibur Rahman Sobuz

    2014-01-01

    Full Text Available Conventional building materials are widely used in a developing country like Malaysia. This type of material is costly. Oil palm shell (OPS is a type of farming solid waste in the tropical region. This paper aims to investigate strength characteristics and cost analysis of concrete produced using the gradation of OPS 0–50% on conventional coarse aggregate with the mix proportions 1 : 1.65 : 2.45, 1 : 2.5 : 3.3, and 1 : 3.3 : 4.2 by the weight of ordinary Portland cement, river sand, crushed stone, and OPS as a substitution for coarse aggregate. The corresponding w/c ratios were used: 0.45, 0.6, and 0.75, respectively, for the defined mix proportions. Test results indicate that compressive strength of concrete decreased as the percentage of the OPS increased in each mix ratio. Other properties of OPS concrete, namely, modulus of rupture, modulus of elasticity, splitting tensile strength, and density, were also determined and compared to the corresponding properties of conventional concrete. Economic analysis also indicates possible cost reduction of up to 15% due to the use of OPS as coarse aggregate. Finally, it is concluded that the use of OPS has great potential in the production of structural lightweight concrete.

  13. Exploratory Study of Palm Oil Fuel Ash as Partial Cement Replacement in Oil Palm Shell Lightweight Aggregate Concrete

    Directory of Open Access Journals (Sweden)

    K. Muthusamy

    2014-07-01

    Full Text Available In Malaysia, issue of environmental pollution resulting from disposal of Palm Oil Fuel Ash (POFA which is a by-product from palm oil mill has initiated research to incorporate this waste in Oil Palm Shell (OPS lightweight aggregate concrete production. The current study investigates the effect of palm oil fuel ash content as partial cement replacement towards compressive strength OPS lightweight aggregate concrete. Several OPS lightweight aggregate concrete mixes were produced by replacing various percentage of POFA ranging from 10, 20, 30, 40 and 50%, respectively by weight of cement. All the mixes were cast in form of cubes and then subjected to water curing until the testing date. The compressive strength test is conducted in accordance to BSEN 12390 (2009 at 7 and 28 days. From the results, it was observed that the combination of appropriate POFA content would enhance the compressive strength of OPS lightweight aggregate concrete. Specimen produced using 20% POFA as partial cement replacement exhibit higher value of compressive strength than that of control OPS lightweight aggregate concrete. However, mixes consisting POFA up to 50% is also suitable for structural application.

  14. Non-tenera Contamination and the Economic Impact of SHELL Genetic Testing in the Malaysian Independent Oil Palm Industry.

    Science.gov (United States)

    Ooi, Leslie C-L; Low, Eng-Ti L; Abdullah, Meilina O; Nookiah, Rajanaidu; Ting, Ngoot C; Nagappan, Jayanthi; Manaf, Mohamad A A; Chan, Kuang-Lim; Halim, Mohd A; Azizi, Norazah; Omar, Wahid; Murad, Abdul J; Lakey, Nathan; Ordway, Jared M; Favello, Anthony; Budiman, Muhammad A; Van Brunt, Andrew; Beil, Melissa; Leininger, Michael T; Jiang, Nan; Smith, Steven W; Brown, Clyde R; Kuek, Alex C S; Bahrain, Shabani; Hoynes-O'Connor, Allison; Nguyen, Amelia Y; Chaudhari, Hemangi G; Shah, Shivam A; Choo, Yuen-May; Sambanthamurthi, Ravigadevi; Singh, Rajinder

    2016-01-01

    Oil palm (Elaeis guineensis) is the most productive oil bearing crop worldwide. It has three fruit forms, namely dura (thick-shelled), pisifera (shell-less) and tenera (thin-shelled), which are controlled by the SHELL gene. The fruit forms exhibit monogenic co-dominant inheritance, where tenera is a hybrid obtained by crossing maternal dura and paternal pisifera palms. Commercial palm oil production is based on planting thin-shelled tenera palms, which typically yield 30% more oil than dura palms, while pisifera palms are female-sterile and have little to no palm oil yield. It is clear that tenera hybrids produce more oil than either parent due to single gene heterosis. The unintentional planting of dura or pisifera palms reduces overall yield and impacts land utilization that would otherwise be devoted to more productive tenera palms. Here, we identify three additional novel mutant alleles of the SHELL gene, which encode a type II MADS-box transcription factor, and determine oil yield via control of shell fruit form phenotype in a manner similar to two previously identified mutant SHELL alleles. Assays encompassing all five mutations account for all dura and pisifera palms analyzed. By assaying for these variants in 10,224 mature palms or seedlings, we report the first large scale accurate genotype-based determination of the fruit forms in independent oil palm planting sites and in the nurseries that supply them throughout Malaysia. The measured non-tenera contamination rate (10.9% overall on a weighted average basis) underscores the importance of SHELL genetic testing of seedlings prior to planting in production fields. By eliminating non-tenera contamination, comprehensive SHELL genetic testing can improve sustainability by increasing yield on existing planted lands. In addition, economic modeling demonstrates that SHELL gene testing will confer substantial annual economic gains to the oil palm industry, to Malaysian gross national income and to Malaysian

  15. Non-tenera Contamination and the Economic Impact of SHELL Genetic Testing in the Malaysian Independent Oil Palm Industry

    Science.gov (United States)

    Ooi, Leslie C.-L.; Low, Eng-Ti L.; Abdullah, Meilina O.; Nookiah, Rajanaidu; Ting, Ngoot C.; Nagappan, Jayanthi; Manaf, Mohamad A. A.; Chan, Kuang-Lim; Halim, Mohd A.; Azizi, Norazah; Omar, Wahid; Murad, Abdul J.; Lakey, Nathan; Ordway, Jared M.; Favello, Anthony; Budiman, Muhammad A.; Van Brunt, Andrew; Beil, Melissa; Leininger, Michael T.; Jiang, Nan; Smith, Steven W.; Brown, Clyde R.; Kuek, Alex C. S.; Bahrain, Shabani; Hoynes-O’Connor, Allison; Nguyen, Amelia Y.; Chaudhari, Hemangi G.; Shah, Shivam A.; Choo, Yuen-May; Sambanthamurthi, Ravigadevi; Singh, Rajinder

    2016-01-01

    Oil palm (Elaeis guineensis) is the most productive oil bearing crop worldwide. It has three fruit forms, namely dura (thick-shelled), pisifera (shell-less) and tenera (thin-shelled), which are controlled by the SHELL gene. The fruit forms exhibit monogenic co-dominant inheritance, where tenera is a hybrid obtained by crossing maternal dura and paternal pisifera palms. Commercial palm oil production is based on planting thin-shelled tenera palms, which typically yield 30% more oil than dura palms, while pisifera palms are female-sterile and have little to no palm oil yield. It is clear that tenera hybrids produce more oil than either parent due to single gene heterosis. The unintentional planting of dura or pisifera palms reduces overall yield and impacts land utilization that would otherwise be devoted to more productive tenera palms. Here, we identify three additional novel mutant alleles of the SHELL gene, which encode a type II MADS-box transcription factor, and determine oil yield via control of shell fruit form phenotype in a manner similar to two previously identified mutant SHELL alleles. Assays encompassing all five mutations account for all dura and pisifera palms analyzed. By assaying for these variants in 10,224 mature palms or seedlings, we report the first large scale accurate genotype-based determination of the fruit forms in independent oil palm planting sites and in the nurseries that supply them throughout Malaysia. The measured non-tenera contamination rate (10.9% overall on a weighted average basis) underscores the importance of SHELL genetic testing of seedlings prior to planting in production fields. By eliminating non-tenera contamination, comprehensive SHELL genetic testing can improve sustainability by increasing yield on existing planted lands. In addition, economic modeling demonstrates that SHELL gene testing will confer substantial annual economic gains to the oil palm industry, to Malaysian gross national income and to Malaysian

  16. Natural weathering studies of oil palm trunk lumber (OPTL) green polymer composites enhanced with oil palm shell (OPS) nanoparticles.

    Science.gov (United States)

    Islam, Md Nazrul; Dungani, Rudi; Abdul Khalil, Hps; Alwani, M Siti; Nadirah, Wo Wan; Fizree, H Mohammad

    2013-01-01

    In this study, a green composite was produced from Oil Palm Trunk Lumber (OPTL) by impregnating oil palm shell (OPS) nanoparticles with formaldehyde resin. The changes of physical, mechanical and morphological properties of the OPS nanoparticles impregnated OPTL as a result of natural weathering was investigated. The OPS fibres were ground with a ball-mill for producing nanoparticles before being mixed with the phenol formaldehyde (PF) resin at a concentration of 1, 3, 5 and 10% w/w basis and impregnated into the OPTL by vacuum-pressure method. The treated OPTL samples were exposed to natural weathering for the period of 6 and 12 months in West Java, Indonesia according to ASTM D1435-99 standard. Physical and mechanical tests were done for analyzing the changes in phenol formaldehyde-nanoparticles impregnated (PF-NPI) OPTL. FT-IR and SEM studies were done to analyze the morphological changes. The results showed that both exposure time of weathering and concentration of PF-NPI had significant impact on physical and mechanical properties of OPTL. The longer exposure of samples to weathering condition reduced the wave numbers during FT-IR test. However, all these physical, mechanical and morphological changes were significant when compared with the untreated samples or only PF impregnated samples. Thus, it can be concluded that PF-NP impregnation into OPTL improved the resistance against natural weathering and would pave the ground for improved products from OPTL for outdoor conditions.

  17. Activated carbons from African oil palm waste shells and fibre for hydrogen storage

    Directory of Open Access Journals (Sweden)

    Liliana Giraldo

    2013-06-01

    Full Text Available We prepared a series of activated carbons by chemical activation with two strong bases in-group that few use, and I with waste from shell and fibers and oil-palm African. Activated carbons are obtained with relatively high surface areas (1605 m2/g. We study the textural and chemical properties and its effect on hydrogen storage. The activated carbons obtained from fibrous wastes exhibit a high hydrogen storage capacity of 6.0 wt % at 77 K and 12 bar.

  18. Engineering and sustainability aspect of palm oil shell powder in cement

    Science.gov (United States)

    Karim, Mohammad Razaul; Hossain, Md. Moktar; Yusoff, Sumiani Binti

    2017-06-01

    Palm oil shell (POS) is a waste material which significantly produced in palm oil mills. In current practice, this waste is dumped in open land or landfill sites or is used as fuel to run a steam turbine of a boiler, which leads to environmental pollutions. The characterization, engineering and sustainability aspect of this waste for using in cement-based applications lead to reduce the emission of carbon dioxide and cost, save natural resources for cement production and also sustainable usage of waste material. The characterization was carried out using particle size analyzer, XRF, SEM and total organic carbon analyzer. ASTM standard methods were used to observe the setting time and water for normal consistency. The compressive strength of palm oil shell powder (POSP) blended cement was explored with the water to cement and cement to sand ratio of 0.40 and 0.50, respectively up to 40% replacement levels of OPC. Result found that the setting time and water demand were increased, but compressive strength was decreased to replacement levels. However, the incorporation of POSP in cement was reduced 9.6% of CO2 emission, 25 % of the cost and save natural resource, i.e. limestone, clay, iron ore, silica shale and gypsum of 35.1%, 4.95%, 0.9%, 4.05 % and 1.2 %, respectively at 30% replacement level of OPC. The results of this extensive study on POSP characterization, effect on basic cement properties and sustainability aspect provide the guidance for using the POSP at industrial scale for cement production.

  19. Effect of nitric acid treatment on activated carbon derived from oil palm shell

    Science.gov (United States)

    Allwar, Allwar; Hartati, Retno; Fatimah, Is

    2017-03-01

    The primary object of this work is to study the effect of nitric acid on the porous and morphology structure of activated carbon. Production of activated carbon from oil palm shell was prepared with pyrolysis process at temperature 900°C and by introduction of 10 M nitric acid. Determination of surface area, pore volume and pore size distribution of activated carbon was conducted by the N2 adsorption-desorption isotherm at 77 K. Morphology structure and elemental micro-analysis of activated carbon were estimated by Scanning Electron Microscopy (SEM) and energy dispersive X-ray (EDX), respectively. The result shows that activated carbon after treating with nitric acid proved an increasing porous characteristics involving surface area, pore volume and pore size distribution. It also could remove the contaminants including metals and exhibit an increasing of pores and crevices all over the surface.

  20. Separation of oil palm shell and kernel by using kaolinite media

    Directory of Open Access Journals (Sweden)

    Sukpong Sirinupong

    2003-05-01

    Full Text Available The objective of this research is to investigate the possibility of using kaolinite from Ranong province as media in the oil palm shell and kernel separation process by means of heavy media separation. The effect of specific gravity of the slurry, type and amount of dispersant and type of clays on suspension of media and efficiency of separation were studied. It was found that the specific gravity of oil palm shell and kernel are 1.40 and 1.20 respectively. While the average specific gravity of kaolinite grade MRD-B85, RANONG-325 and commercial clay from Univanich Group. PCL., are 2.54, 2.65 and 2.46 respectively. It was apparent that the viscosity of clay slurry increased with the specific gravity of the slurry. For MRD-B85 and RANONG- 325 clays which have the average particle sizes of 10 and 12 microns, the pH of their slurries of about 5.84 and 6.33 respectively were obtained and at these conditions stability of the slurry rarely occurred and they could not be used for separation. However, these clays can also be utilized as media when dispersant such asCalgon or sodium silicate is applied to their slurries. It was found that the efficiency of separation depends on specific gravity and viscosity of the slurry, type and particle size of kaolinite and dosage of dispersant. The optimum separating conditions for MRD-B85 clay were the dosage of Calgon of 0.15% (or 1.5 kg/t of clay at the specific gravity of the slurry of 1.20-1.24 (27-32% Solids in which a pH of 6.14 and viscosity of 104 cP to very low value (could not be measured were obtained. Thus, kernel yielded 97.57-100% and shell contamination of 1.48-6.32% was achieved. While sodium silicate was applied to the slurry about 0.15% at the specific gravity of 1.22, pH of 6.74 and viscosity of 238 cP were obtained and kernel could be recovered 100% with shell contamination of 8.36%. When 0.15% Calgon or 0.25% sodium silicate was introduced to the RANONG-325 clay slurry at the specific gravity

  1. Palm oil mill effluent treatment using coconut shell – based activated carbon: Adsorption equilibrium and isotherm

    Directory of Open Access Journals (Sweden)

    Kaman Sherlynna Parveen Deshon

    2017-01-01

    Full Text Available The current ponding system applied for palm oil mill effluent (POME treatment often struggle to comply with the POME discharge limit, thus it has become a major environmental concern. Batch adsorption study was conducted for reducing the Chemical Oxygen Demand (COD, Total Suspended Solids (TSS and Color of pre-treated POME using coconut shell-based activated carbon (CS-AC. The CS-AC showed BET surface area of 744.118 m2/g, with pore volume of 04359cm3/g. The adsorption uptake was studied at various contact time and POME initial concentration. The CS-AC exhibited good ability with average percentage removal of 70% for COD, TSS and Color. The adsorption uptake increased over time and attained equilibrium in 30 hours. The equilibrium data were analyzed using the Langmuir, Freundlich, Temkin and Dubinin–Radushkevich isotherm models. Based on the coefficient regression and sum of squared errors, the Langmuir isotherm described the adsorption of COD satisfactorily, while best described the TSS and Color adsorption; giving the highest adsorption capacity of 10.215 mg/g, 1.435 mg/g, and 63.291 PtCo/g respectively. The CS-AC was shown to be a promising adsorbent for treating POME and was able to comply with the Environmental Quality Act (EQA discharge limit. The outcome of treated effluent using CS-AC was shown to be cleaner than the industrial biologically treated effluent, achieved within shorter treatment time.

  2. Enhancement of durability properties of heat-treated oil palm shell species lightweight concrete

    Science.gov (United States)

    Yew, Ming Kun; Yew, Ming Chian; Saw, Lip Huat; Ang, Bee Chin; Lee, Min Lee; Lim, Siong Kang; Lim, Jee Hock

    2017-04-01

    Oil palm shell (OPS) are non-hazardous waste materials and can be used as alternative coarse aggregates to substitute depleting conventional raw materials. A study on preparing the OPS species (dura and tenera) lightweight concrete (LWC) using with and without heat-treated OPS aggregate has been investigated. Two different species of OPS coarse aggregate are subjected to heat treatment at 65 and 130 °C with duration of 1 hour. The results reveal that the slump value of the OPSC increases significantly with an increase in temperature of heat treatment of the tenera OPS aggregates. It is found that the maximum achievable 28-days and 180-days compressive strength is 45.6 and 47.5 MPa, respectively. Furthermore, rapid chloride penetration test (RCPT) and water absorption tests were performance to signify the effects of heat-treated on OPS species LWC. The use of heat-treated OPS LWC induced the advantageous of reducing the permeability and capillary porosity as well as water absorption. Hence, the findings of this study are of primary importance as they revealed the heat treatment on OPS species LWC can be used as a new environmentally friendly method to enhance the durability of OPSLWC.

  3. An Experimental Study of Briquetting Process of Torrefied Rubber Seed Kernel and Palm Oil Shell

    Directory of Open Access Journals (Sweden)

    M. Fadzli Hamid

    2016-01-01

    Full Text Available Torrefaction process of biomass material is essential in converting them into biofuel with improved calorific value and physical strength. However, the production of torrefied biomass is loose, powdery, and nonuniform. One method of upgrading this material to improve their handling and combustion properties is by densification into briquettes of higher density than the original bulk density of the material. The effects of critical parameters of briquetting process that includes the type of biomass material used for torrefaction and briquetting, densification temperature, and composition of binder for torrefied biomass are studied and characterized. Starch is used as a binder in the study. The results showed that the briquette of torrefied rubber seed kernel (RSK is better than torrefied palm oil shell (POS in both calorific value and compressive strength. The best quality of briquettes is yielded from torrefied RSK at the ambient temperature of briquetting process with the composition of 60% water and 5% binder. The maximum compressive load for the briquettes of torrefied RSK is 141 N and the calorific value is 16 MJ/kg. Based on the economic evaluation analysis, the return of investment (ROI for the mass production of both RSK and POS briquettes is estimated in 2-year period and the annual profit after payback was approximately 107,428.6 USD.

  4. An Experimental Study of Briquetting Process of Torrefied Rubber Seed Kernel and Palm Oil Shell.

    Science.gov (United States)

    Hamid, M Fadzli; Idroas, M Yusof; Ishak, M Zulfikar; Zainal Alauddin, Z Alimuddin; Miskam, M Azman; Abdullah, M Khalil

    2016-01-01

    Torrefaction process of biomass material is essential in converting them into biofuel with improved calorific value and physical strength. However, the production of torrefied biomass is loose, powdery, and nonuniform. One method of upgrading this material to improve their handling and combustion properties is by densification into briquettes of higher density than the original bulk density of the material. The effects of critical parameters of briquetting process that includes the type of biomass material used for torrefaction and briquetting, densification temperature, and composition of binder for torrefied biomass are studied and characterized. Starch is used as a binder in the study. The results showed that the briquette of torrefied rubber seed kernel (RSK) is better than torrefied palm oil shell (POS) in both calorific value and compressive strength. The best quality of briquettes is yielded from torrefied RSK at the ambient temperature of briquetting process with the composition of 60% water and 5% binder. The maximum compressive load for the briquettes of torrefied RSK is 141 N and the calorific value is 16 MJ/kg. Based on the economic evaluation analysis, the return of investment (ROI) for the mass production of both RSK and POS briquettes is estimated in 2-year period and the annual profit after payback was approximately 107,428.6 USD.

  5. Microwave-enhanced CO2 gasification of oil palm shell char.

    Science.gov (United States)

    Lahijani, Pooya; Zainal, Zainal Alimuddin; Mohamed, Abdul Rahman; Mohammadi, Maedeh

    2014-04-01

    CO2 gasification of oil palm shell (OPS) char to produce CO through the Boudouard reaction (C + CO2 ↔ 2CO) was investigated under microwave irradiation. A microwave heating system was developed to carry out the CO2 gasification in a packed bed of OPS char. The influence of char particle size, temperature and gas flow rate on CO2 conversion and CO evolution was considered. It was attempted to improve the reactivity of OPS char in gasification reaction through incorporation of Fe catalyst into the char skeleton. Very promising results were achieved in our experiments, where a CO2 conversion of 99% could be maintained during 60 min microwave-induced gasification of iron-catalyzed char. When similar gasification experiments were performed in conventional electric furnace, the superior performance of microwave over thermal driven reaction was elucidated. The activation energies of 36.0, 74.2 and 247.2 kJ/mol were obtained for catalytic and non-catalytic microwave and thermal heating, respectively. Copyright © 2014 Elsevier Ltd. All rights reserved.

  6. Removal of Heavy Metal Ions with Acid Activated Carbons Derived from Oil Palm and Coconut Shells

    Directory of Open Access Journals (Sweden)

    Mokhlesur M. Rahman

    2014-05-01

    Full Text Available In this work, batch adsorption experiments were carried out to investigate the suitability of prepared acid activated carbons in removing heavy metal ions such as nickel(II, lead(II and chromium(VI. Acid activated carbons were obtained from oil palm and coconut shells using phosphoric acid under similar activation process while the differences lie either in impregnation condition or in both pretreatment and impregnation conditions. Prepared activated carbons were modified by dispersing hydrated iron oxide. The adsorption equilibrium data for nickel(II and lead(II were obtained from adsorption by the prepared and commercial activated carbons. Langmuir and Freundlich models fit the data well. Prepared activated carbons showed higher adsorption capacity for nickel(II and lead(II. The removal of chromium(VI was studied by the prepared acid activated, modified and commercial activated carbons at different pH. The isotherms studies reveal that the prepared activated carbon performs better in low concentration region while the commercial ones in the high concentration region. Thus, a complete adsorption is expected in low concentration by the prepared activated carbon. The kinetics data for Ni(II, Pb(II and Cr(VI by the best selected activated carbon fitted very well to the pseudo-second-order kinetic model.

  7. Indonesia's palm oil subsector

    OpenAIRE

    Larson, Donald F.

    1996-01-01

    Debate on Indonesia's palm oil policy was stimulated by a sharp increase in cooking oil prices in 1994-95 and a resulting increase in the export tax rate on crude palm oil. Palm oil has been one of the fastest growing subsectors in Indonesia. Using a quantitative model, the author analyzes the effect of government policies, including the export tax, buffer stock operations by the BULOG (the national logistics agency), and directed sales from public estates. The author acknowledges the export ...

  8. Oil palm seed distribution

    Directory of Open Access Journals (Sweden)

    Durand-Gasselin Tristan

    2005-03-01

    Full Text Available For a tropical plant, the oil palm commodity chain has the peculiarity of possessing a major seed production sector for reasons that are primarily genetic. This seed sector has numerous original aspects. Breeders are also propagators and usually also distribute their seeds. Oil palm seeds are semi-recalcitrant: they display pseudo-dormancy. Achieving seed germination is difficult and requires lengthy treatments and special installations. This restriction greatly influences seed distribution and the role of the different stakeholders in the commodity chain. It was only once it had been discovered how the “sh” gene functioned, which controls shell thickness, and when it became necessary to produce “tenera” seeds derived from exclusively “dura x pisifera” crosses, that a true seed market developed. In addition it is difficult to organize seed distribution to smallholders. This is partly due to difficulties that the profession, or a State-run organization, has in controlling middlemen networks, and partly to the absence of any protective systems (UPOV, plant breeder certificate, etc. that generally oblige breeders to preserve and propagate parents in their own installations. In fact there are major inequalities in the access to seeds between agroindustry and smallholders. Another peculiarity of the oil palm seed market is the virtually total absence of guarantees for buyers: the quality of the research conducted by breeders, the seed production strategies necessary for transferring genetic progress, and the technical quality of production. The only guarantee today comes from the relations of confidence established year after year between breeders/distributors and growers. In this fields, research can lead to some proposals: molecular biology offers some interesting prospects for certifying seed quality and social science develop effective communication methods.

  9. Production of phenol-rich bio-oil during catalytic fixed-bed and microwave pyrolysis of palm kernel shell.

    Science.gov (United States)

    Omoriyekomwan, Joy Esohe; Tahmasebi, Arash; Yu, Jianglong

    2016-05-01

    Catalytic fixed-bed and microwave pyrolysis of palm kernel shell using activated carbon (AC) and lignite char (LC) as catalysts and microwave receptors are investigated. The effects of process parameters including temperature and biomass:catalyst ratio on the yield and composition of pyrolysis products were studied. The addition of catalyst increased the bio-oil yield, but decreased the selectivity of phenol in fixed-bed. Catalytic microwave pyrolysis of PKS significantly enhanced the selectivity of phenol production. The highest concentration of phenol in bio-oil of 64.58 %(area) and total phenolics concentration of 71.24 %(area) were obtained at 500°C using AC. Fourier transform infrared spectroscopy (FTIR) results indicated that concentration of OH, CH, CO and CO functional groups in char samples decreased after pyrolysis. Scanning electron microscopy (SEM) analysis clearly indicated the development of liquid phase in biomass particles during microwave pyrolysis, and the mechanism is also discussed.

  10. ISOLATION AND CHARACTERIZATION OF MANNANOLYTIC THERMOPHILIC BACTERIA FROM PALM OIL SHELL AND THEIR MANNANASE ENZYME PRODUCTION PROPERTIES

    Directory of Open Access Journals (Sweden)

    T RESNAWATI P URWADARIA

    2005-01-01

    Full Text Available A mannanolytic thermophilic bacterium (L-07 was isolated from palm oil shell after 2 days of enrichment in liquid medium supplemented with 1% palm kernel meal as mannan source. Sequence analysis of 16S-rRNA indicated that L-07 was similar (98% to Geobacillus stearothermophilus, a species of thermophilic aerobi c bacteria. We found that G. stearothermophilus L-07 produced extracellular β -1,4-mannanases, but no β -manosidase and α -galactosidase activities. The growth of L-07 reached its maximum (3.0 x 106 cell/ml at 12-20 hours, while the highest β -mannanase activity (0.52 U/ml was observed in culture medium after 36 hours of cultivation at 60oC. The medium containing locust bean gum was the best for producing extracellular β -1,4-mannanases compared with kolang kaling , konjak , and palm kernel meal. SDS-PAGE and zymogram analysis demonstrated that crude mannanase complex of L-07 from locust bean gum containing medium comprised three active bands with molecular weight of 85, 73 and 50 kDa.

  11. Characterization of Activated Carbons from Oil-Palm Shell by CO2 Activation with No Holding Carbonization Temperature

    Directory of Open Access Journals (Sweden)

    S. G. Herawan

    2013-01-01

    Full Text Available Activated carbons can be produced from different precursors, including coals of different ranks, and lignocellulosic materials, by physical or chemical activation processes. The objective of this paper is to characterize oil-palm shells, as a biomass byproduct from palm-oil mills which were converted into activated carbons by nitrogen pyrolysis followed by CO2 activation. The effects of no holding peak pyrolysis temperature on the physical characteristics of the activated carbons are studied. The BET surface area of the activated carbon is investigated using N2 adsorption at 77 K with selected temperatures of 500, 600, and 700°C. These pyrolysis conditions for preparing the activated carbons are found to yield higher BET surface area at a pyrolysis temperature of 700°C compared to selected commercial activated carbon. The activated carbons thus result in well-developed porosities and predominantly microporosities. By using this activation method, significant improvement can be obtained in the surface characteristics of the activated carbons. Thus this study shows that the preparation time can be shortened while better results of activated carbon can be produced.

  12. Physical Properties of Biomass Fuel Briquette from Oil Palm Residues

    African Journals Online (AJOL)

    Physical Properties of Biomass Fuel Briquette from Oil Palm Residues. ... Journal of Applied Sciences and Environmental Management ... Keywords: Palm kernel shell; Mesocarp fibre; Briquette; Biomass solid fuel; proximate analysis.

  13. The effect of different parameters on the development of compressive strength of oil palm shell geopolymer concrete.

    Science.gov (United States)

    Kupaei, Ramin Hosseini; Alengaram, U Johnson; Jumaat, Mohd Zamin

    2014-01-01

    This paper presents the experimental results of an on-going research project on geopolymer lightweight concrete using two locally available waste materials--low calcium fly ash (FA) and oil palm shell (OPS)--as the binder and lightweight coarse aggregate, respectively. OPS was pretreated with three different alkaline solutions of sodium hydroxide (NaOH), potassium hydroxide, and sodium silicate as well as polyvinyl alcohol (PVA) for 30 days; afterwards, oil palm shell geopolymer lightweight concrete (OPSGPC) was cast by using both pretreated and untreated OPSs. The effect of these solutions on the water absorption of OPS, and the development of compressive strength in different curing conditions of OPSGPC produced by pretreated OPS were investigated; subsequently the influence of NaOH concentration, alkaline solution to FA ratio (A/FA), and different curing regimes on the compressive strength and density of OPSGPC produced by untreated OPS was inspected. The 24-hour water absorption value for OPS pretreated with 20% and 50% PVA solution was about 4% compared to 23% for untreated OPS. OPSGPC produced from OPS treated with 50% PVA solution produced the highest compressive strength of about 30 MPa in ambient cured condition. The pretreatment with alkaline solution did not have a significant positive effect on the water absorption of OPS aggregate and the compressive strength of OPSGPC. The result revealed that a maximum compressive strength of 32 MPa could be obtained at a temperature of 65°C and curing period of 4 days. This investigation also found that an A/FA ratio of 0.45 has the optimum amount of alkaline liquid and it resulted in the highest level of compressive strength.

  14. The Effect of Different Parameters on the Development of Compressive Strength of Oil Palm Shell Geopolymer Concrete

    Directory of Open Access Journals (Sweden)

    Ramin Hosseini Kupaei

    2014-01-01

    Full Text Available This paper presents the experimental results of an on-going research project on geopolymer lightweight concrete using two locally available waste materials—low calcium fly ash (FA and oil palm shell (OPS—as the binder and lightweight coarse aggregate, respectively. OPS was pretreated with three different alkaline solutions of sodium hydroxide (NaOH, potassium hydroxide, and sodium silicate as well as polyvinyl alcohol (PVA for 30 days; afterwards, oil palm shell geopolymer lightweight concrete (OPSGPC was cast by using both pretreated and untreated OPSs. The effect of these solutions on the water absorption of OPS, and the development of compressive strength in different curing conditions of OPSGPC produced by pretreated OPS were investigated; subsequently the influence of NaOH concentration, alkaline solution to FA ratio (A/FA, and different curing regimes on the compressive strength and density of OPSGPC produced by untreated OPS was inspected. The 24-hour water absorption value for OPS pretreated with 20% and 50% PVA solution was about 4% compared to 23% for untreated OPS. OPSGPC produced from OPS treated with 50% PVA solution produced the highest compressive strength of about 30 MPa in ambient cured condition. The pretreatment with alkaline solution did not have a significant positive effect on the water absorption of OPS aggregate and the compressive strength of OPSGPC. The result revealed that a maximum compressive strength of 32 MPa could be obtained at a temperature of 65°C and curing period of 4 days. This investigation also found that an A/FA ratio of 0.45 has the optimum amount of alkaline liquid and it resulted in the highest level of compressive strength.

  15. Biomass-based palm shell activated carbon and palm shell carbon molecular sieve as gas separation adsorbents.

    Science.gov (United States)

    Sethupathi, Sumathi; Bashir, Mohammed Jk; Akbar, Zinatizadeh Ali; Mohamed, Abdul Rahman

    2015-04-01

    Lignocellulosic biomass has been widely recognised as a potential low-cost source for the production of high added value materials and proved to be a good precursor for the production of activated carbons. One of such valuable biomasses used for the production of activated carbons is palm shell. Palm shell (endocarp) is an abundant by-product produced from the palm oil industries throughout tropical countries. Palm shell activated carbon and palm shell carbon molecular sieve has been widely applied in various environmental pollution control technologies, mainly owing to its high adsorption performance, well-developed porosity and low cost, leading to potential applications in gas-phase separation using adsorption processes. This mini-review represents a comprehensive overview of the palm shell activated carbon and palm shell carbon molecular sieve preparation method, physicochemical properties and feasibility of palm shell activated carbon and palm shell carbon molecular sieve in gas separation processes. Some of the limitations are outlined and suggestions for future improvements are pointed out.

  16. Development, identification and validation of CAPS marker for SHELL trait which governs dura, pisifera and tenera fruit forms in oil palm (Elaeis guineensis Jacq.).

    Science.gov (United States)

    Babu, B Kalyana; Mathur, R K; Kumar, P Naveen; Ramajayam, D; Ravichandran, G; Venu, M V B; Babu, S Sparjan

    2017-01-01

    The oil palm fruit forms (dura, pisifera and tenera) governed by the shell thickness gene (Sh) plays a major role in identification of fruit type and also influences palm oil yield. Identification of desired fruit type is a major asset to the breeders and oil palm workers for applications in breeding, seed certification and to reduce time, space and money spent on identification of fruit form. In the present study, we developed Sh gene specific primer pairs and bulk segregant analysis was done using 300 genomic and 8 genic SSR markers. We identified one cleaved amplified polymorphic site (CAPS) marker for differentiation of oil palm fruit type which produced two alleles (280 and 250bp) in dura genotypes, three alleles in tenera genotypes (550, 280, and 250bp) and one allele in pisifera genotypes (550bp). The shell allele sequencing results showed that two SNPs were present, of which SNP2 contributed for variation of fruit forms. The nucleotide 'A' was present in only dura genotypes, where as 'T' was present only in pisifera genotypes, which in turn led to the change of amino acid lysine to aspargine. The identified CAPS marker was validated on 300 dura, 25 pisifera and 80 tenera genotypes, 80 dura/ pisifera cross progenies and 60 lines of tenera/ tenera cross progeny. Association mapping of marker data with phenotypic data of eight oil yield related traits resulted in identification of seven significant QTLs by GLM approach, four by MLM approach at a significant threshold (P) level of 0.001. Significant QTLs were identified for fruit to bunch and oil to bunch traits, which explained R2 of 12.9% and 11.5% respectively. The CAPS marker used in the present study facilitate selection and timely distribution of desirable high yielding tenera sprouts to the farmers instead of waiting for 4-5 years. This saves a lot of land, time and money which will be a major breakthrough to the oil palm community.

  17. Global oil palm suitability assessment

    OpenAIRE

    Pirker, J.; Mosnier, A

    2015-01-01

    The palm oil boom of recent years has brought about both positive - economic development - and negative impacts - deforestation, habitat losses and increased GHG emissions - in the main producer countries in South-East Asia. As global demand for palm oil is still increasing, governments of developing and emerging countries increasingly promote oil palm cultivation as a major contributor to economic development, but there are concerns about the potential negative impacts of oil palm expansion ...

  18. Valorization of palm oil (mill) residues. Identifyin and solving the challenges

    NARCIS (Netherlands)

    Elbersen, H.W.; Meesters, K.P.H.; Bakker, R.R.C.

    2013-01-01

    This report explains in brief how the palm oil production system is set-up and how by-products of palm oil extraction (Empty Fruit Bunch (EFB), Mesocarp Fibre, Shells and Palm Oil Mill Effluent (POME)) are generated in the Palm oil Mill and what the composition of each stream is. Then the options ar

  19. Optimization and characterization of bio-oil produced by microwave assisted pyrolysis of oil palm shell waste biomass with microwave absorber.

    Science.gov (United States)

    Mushtaq, Faisal; Abdullah, Tuan Amran Tuan; Mat, Ramli; Ani, Farid Nasir

    2015-08-01

    In this study, solid oil palm shell (OPS) waste biomass was subjected to microwave pyrolysis conditions with uniformly distributed coconut activated carbon (CAC) microwave absorber. The effects of CAC loading (wt%), microwave power (W) and N2 flow rate (LPM) were investigated on heating profile, bio-oil yield and its composition. Response surface methodology based on central composite design was used to study the significance of process parameters on bio-oil yield. The coefficient of determination (R(2)) for the bio-oil yield is 0.89017 indicating 89.017% of data variability is accounted to the model. The largest effect on bio-oil yield is from linear and quadratic terms of N2 flow rate. The phenol content in bio-oil is 32.24-58.09% GC-MS area. The bio-oil also contain 1,1-dimethyl hydrazine of 10.54-21.20% GC-MS area. The presence of phenol and 1,1-dimethyl hydrazine implies that the microwave pyrolysis of OPS with carbon absorber has the potential to produce valuable fuel products.

  20. INCREASING ADSORPTION OF ACTIVATED CARBON FROM PALM OIL SHELL FOR ADSORB H2S FROM BIOGAS PRODUCTION BY IMPREGNATION

    Directory of Open Access Journals (Sweden)

    Wasan Phooratsamee

    2014-01-01

    Full Text Available Biogas is the combustible gas produced through a biological process, known as anaerobic digestion which is the process operated at low-temperature and without air. Biogas consists of 55-80% CH4, 20-45% CO2 with trace amount of H2S and other impurities. Common H2S removal technologies from biogas fall into one of adsorption on a solid such as iron oxide based materials, activated carbon or impregnated activated carbon. Conventionally, activated carbon is produced from biomass residues and agricultural residues such as palm oil shell which promising approach for the production of cheap. It is so due to the palm oil shell carries a large amount of carbon content which it is the main composition of activated carbon. Therefore, it is usable as raw material for producing impregnated activated carbon and used as adsorbents. The aim of this study is a produce the activated carbon from palm oil shells by chemical activation using ZnCl2 and optimal conditions after impregnated them with NaOH, KI and K2CO3 for H2S absorption from biogas product. In this research, production of activated carbon involved three stages; (i carbonization of raw material in an inert atmosphere which was carbonized in a muffle furnace at 600°C for 1 h; (ii secondly activation of char product from the first stages at fixed bed reactor (stainless steel with 54.1 mm internal diameter and 320 mm length which was studied to observe the effect of char product: Chemical agent ratio (ZnCl2, 1:1 to 1:3, which there are activated at 700°C activation temperature for 2 h; and (iii finally alkali impregnated activated carbon which were immersed 1:3 ratio in 500 mL of 1 N NaOH, KI and K2CO3 solutions and stirred for 30 min. The result showed that the surface area and the pore volume increased progressively with increasing the char product: Chemical agent ratio. The maximum

  1. Impact resistance performance of green construction material using light weight oil palm shells reinforced bamboo concrete slab

    Science.gov (United States)

    Muda, Z. C.; Usman, F.; Beddu, S.; Alam, M. A.; Thiruchelvam, S.; Sidek, L. M.; Basri, H.; Saadi, S.

    2013-06-01

    This paper investigate the performance of lightweight oil palm shells (OPS) concrete with varied bamboo reinforcement content for the concrete slab of 300mm x 300mm size reinforced with different thickness subjected to low impact projectile test. A self-fabricated drop-weight impact test rig with a steel ball weight of 1.2 kg drop at 1 m height has been used in this research work. The main variables for the study is to find the relationship of the impact resistance against the amount of bamboo reinforcement and slab thickness. A linear relationship has been established between first and ultimate crack resistance against bamboo diameters and slab thickness by the experiment. The linear relationship has also been established between the service (first) crack and ultimate crack resistance against the bamboo reinforcement diameter for a constant spacing for various slab thickness using 0.45 OPS and 0.6 OPS bamboo reinforced concrete. The increment in bamboo diameter has more effect on the first crack resistance than the ultimate crack resistance. The linear relationship has also been established between the service (first) crack and ultimate crack resistance against the various slab thickness. Increment in slab thickness of the slab has more effect on the crack resistance as compare to the increment in the diameter of the bamboo reinforcement.

  2. Palm oil and palm olein frying applications.

    Science.gov (United States)

    Ismail, Razali

    2005-01-01

    Several million tones of palm oil and palm olein are used annually in the world for frying. This paper will discuss their frying performances in three major applications - industrial production of potato chips/crisps, industrial production of pre-fried frozen French fries and in fast food outlets. In the first study, about four tones of potato chips were continuously fried 8 hours a day and five days a week. The palm olein used (with proper management) performed well and was still in excellent condition and usable at the end of the trial. This was reflected in its low free fatty acid (FFA) content of around 0.23%, peroxide value of 4 meq/kg, anisidine value of 16, low polar and polymer contents of 10% and 2%, respectively, induction period (OSI) of 21 hours and high content of tocopehrols and tocotrienols of 530 ppm even after >1900 hours. In the second study in which an average 12 tones pre-fried frozen French fries were continuously fried a day for 5 days a week, palm oil performed excellently as reflected by its low FFA of 0.34%, food oil sensor reading of 1.1, low polar and polymer contents of 17% and 2.8%, respectively, over the 12 days of trial. In the third study in which palm shortening, palm oil and palm olein were simultaneously used to intermittently fry chicken parts in the laboratory simulating the conditions in fast food outlets, the three frying oils also performed very satisfactorily as reflected by their reasonably low FFA of 180 degrees C, and polar and polymer contents of <25% and <6%, respectively, after 5 days of consecutive frying. All the quality indicators did not exceed the maximum discard points for frying oils/fats in the three applications, while the fried food product was well accepted by the in-house train sensory panel using a-nine point hedonic score.

  3. Development, identification and validation of CAPS marker for SHELL trait which governs dura, pisifera and tenera fruit forms in oil palm (Elaeis guineensis Jacq.)

    Science.gov (United States)

    Babu, B. Kalyana; Mathur, R. K.; Kumar, P. Naveen; Ramajayam, D.; Ravichandran, G.; Venu, M. V. B.; Babu, S. Sparjan

    2017-01-01

    The oil palm fruit forms (dura, pisifera and tenera) governed by the shell thickness gene (Sh) plays a major role in identification of fruit type and also influences palm oil yield. Identification of desired fruit type is a major asset to the breeders and oil palm workers for applications in breeding, seed certification and to reduce time, space and money spent on identification of fruit form. In the present study, we developed Sh gene specific primer pairs and bulk segregant analysis was done using 300 genomic and 8 genic SSR markers. We identified one cleaved amplified polymorphic site (CAPS) marker for differentiation of oil palm fruit type which produced two alleles (280 and 250bp) in dura genotypes, three alleles in tenera genotypes (550, 280, and 250bp) and one allele in pisifera genotypes (550bp). The shell allele sequencing results showed that two SNPs were present, of which SNP2 contributed for variation of fruit forms. The nucleotide ‘A’ was present in only dura genotypes, where as ‘T’ was present only in pisifera genotypes, which in turn led to the change of amino acid lysine to aspargine. The identified CAPS marker was validated on 300 dura, 25 pisifera and 80 tenera genotypes, 80 dura/ pisifera cross progenies and 60 lines of tenera/ tenera cross progeny. Association mapping of marker data with phenotypic data of eight oil yield related traits resulted in identification of seven significant QTLs by GLM approach, four by MLM approach at a significant threshold (P) level of 0.001. Significant QTLs were identified for fruit to bunch and oil to bunch traits, which explained R2 of 12.9% and 11.5% respectively. The CAPS marker used in the present study facilitate selection and timely distribution of desirable high yielding tenera sprouts to the farmers instead of waiting for 4–5 years. This saves a lot of land, time and money which will be a major breakthrough to the oil palm community. PMID:28192462

  4. The Potential of Palm Oil Waste Biomass in Indonesia in 2020 and 2030

    Science.gov (United States)

    Hambali, E.; Rivai, M.

    2017-05-01

    During replanting activity in oil palm plantation, biomass including palm frond and trunk are produced. In palm oil mills, during the conversion process of fresh fruit bunches (FFB) into crude palm oil (CPO), several kinds of waste including empty fruit bunch (EFB), mesocarp fiber (MF), palm kernel shell (PKS), palm kernel meal (PKM), and palm oil mills effluent (POME) are produced. The production of these wastes is abundant as oil palm plantation area, FFB production, and palm oil mills spread all over 22 provinces in Indonesia. These wastes are still economical as they can be utilized as sources of alternative fuel, fertilizer, chemical compounds, and biomaterials. Therefore, breakthrough studies need to be done in order to improve the added value of oil palm, minimize the waste, and make oil palm industry more sustainable.

  5. Activated carbons from waste of oil-palm kernel shells, sawdust and tannery leather scraps and application to chromium(VI), phenol, and methylene blue dye adsorption.

    Science.gov (United States)

    Montoya-Suarez, Sergio; Colpas-Castillo, Fredy; Meza-Fuentes, Edgardo; Rodríguez-Ruiz, Johana; Fernandez-Maestre, Roberto

    2016-01-01

    Phenol, chromium, and dyes are continuously dumped into water bodies; the adsorption of these contaminants on activated carbon is a low-cost alternative for water remediation. We synthesized activated carbons from industrial waste of palm oil seed husks (kernel shells), sawdust, and tannery leather scraps. These materials were heated for 24 h at 600, 700 or 800°C, activated at 900°C with CO2 and characterized by proximate analysis and measurement of specific surface area (Brunauer-Emmett-Teller (BET) and Langmuir), and microporosity (t-plot). Isotherms showed micropores and mesopores in activated carbons. Palm seed activated carbon showed the highest fixed carbon content (96%), and Langmuir specific surface areas up to 1,268 m2/g, higher than those from sawdust (581 m2/g) and leather scraps (400 m2/g). The carbons were applied to adsorption of Cr(VI), phenol, and methylene blue dye from aqueous solutions. Phenol adsorption on activated carbons was 78-82 mg/g; on palm seed activated carbons, Cr(VI) adsorption at pH 7 was 0.35-0.37 mg/g, and methylene blue adsorption was 40-110 mg/g, higher than those from sawdust and leather scraps. Activated carbons from palm seed are promising materials to remove contaminants from the environment and represent an alternative application for vegetal wastes instead of dumping into landfills.

  6. Yield gaps in oil palm

    NARCIS (Netherlands)

    Woittiez, Lotte S.; Wijk, van Mark T.; Slingerland, Maja; Noordwijk, van Meine; Giller, Ken E.

    2017-01-01

    Oil palm, currently the world's main vegetable oil crop, is characterised by a large productivity and a long life span (≥25 years). Peak oil yields of 12 t ha−1 yr−1 have been achieved in small plantations, and maximum theoretical yields as calculated with simulation models are 18.5 t oil ha−1 yr−1,

  7. Mixing of acacia bark and palm shells to increase caloric value of palm shells white charcoal briquette

    Science.gov (United States)

    Kurniawan, Edy Wibowo; Amirta, Rudianto; Budiarso, Edy; Arung, Enos Tangke

    2017-06-01

    Indonesia is greatly rich in biomass resources. Acacia bark waste utilization as a source of biomass is still very low, where as 10-20% of the potential of the wood. On the other hand waste palm shells have been partly utilized as boiler fuel oil plant as much as 62.4%, but the rest is still a waste pile or to the hardening of the estate path. This study aims to determine the effect of mixing an acacia bark with palm shells to increase the calorific value of palm shell white charcoal briquettes. The study was conducted by making white charcoal briquettes mixing 7% the acacia bark against of palm shells. As well as white charcoal briquettes control without any acacia bark. Then molds the briquettes in pyrolysis temperature at 600 ° C, 700 ° C and 800 ° C for pyrolysis time within 2 hours, 4 hours, and 6 hours. And the results of briquettes analysis in calorific value. The results showed that the caloric value of palm shell white charcoal briquettes increased from 29691.14 Kcal / kg to 31941.50 Kcal / kg.

  8. Coconut, date and oil palm genomics

    Science.gov (United States)

    A review of genomics research is presented for the three most economically important palm crops, coconut (Cocos nucifera), date palm (Phoenix dactylifera) and oil palm (Elaeis guineensis), encompassing molecular markers studies of genetic diversity, genetic mapping, quantitative trait loci discovery...

  9. Production of bio-based phenolic resin and activated carbon from bio-oil and biochar derived from fast pyrolysis of palm kernel shells.

    Science.gov (United States)

    Choi, Gyung-Goo; Oh, Seung-Jin; Lee, Soon-Jang; Kim, Joo-Sik

    2015-02-01

    A fraction of palm kernel shells (PKS) was pyrolyzed in a fluidized bed reactor. The experiments were performed in a temperature range of 479-555 °C to produce bio-oil, biochar, and gas. All the bio-oils were analyzed quantitatively and qualitatively by GC-FID and GC-MS. The maximum content of phenolic compounds in the bio-oil was 24.8 wt.% at ∼500 °C. The maximum phenol content in the bio-oil, as determined by the external standard method, was 8.1 wt.%. A bio-oil derived from the pyrolysis of PKS was used in the synthesis of phenolic resin, showing that the bio-oil could substitute for fossil phenol up to 25 wt.%. The biochar was activated using CO2 at a final activation temperature of 900 °C with different activation time (1-3 h) to produce activated carbon. Activated carbons produced were microporous, and the maximum surface area of the activated carbons produced was 807 m(2)/g.

  10. Economics of alternative palm oil processing technologies in Imo State

    African Journals Online (AJOL)

    Economics of alternative palm oil processing technologies in Imo State. ... This study was designed to analyse the costs and returns of alternative palm oil processing ... Output of Palm oil and consequently net returns would increase if palm oil ...

  11. PALM KERNEL SHELL AS AGGREGATE FOR LIGHT

    African Journals Online (AJOL)

    of cement, sand, gravel andpalm kernel shells respectively gave the highest compressive strength of ... Keywords: Aggregate, Cement, Concrete, Sand, Palm Kernel Shell. ... delivered to the jOb Slte in a plastic ... structures, breakwaters, piers and docks .... related to cement content at a .... sheet and the summary is shown.

  12. Biodiesel production from palm oil

    Directory of Open Access Journals (Sweden)

    Kiatsimkul, P.

    2001-11-01

    Full Text Available Methyl ester was produced from many sources of oil palm products, namely used frying oil, RBD palm oil, degummed and deacidified palm oil, palm stearin and superhard palm stearin. Production process was a conventional transesterification batch process using methanol as reactant and sodium hydroxide as catalyst. Production procedure consisted of oil preparation, solvent preparation, reaction step, glycerol separation, washing step and finishing step. Thin layer chromatograph was used to determine the composition of product and nearly 100% methyl ester was obtained at a suitable condition. Molar ratio of oil: methanol was about 1:6, which equal to 20% by weight of methanol. Sodium hydroxide was 0.5-1 %wt. of oil. The production temperature was 60-80ºC, mixing time was only 15-30 minutes and reaction time was 3-4 hours. Many fuel properties of methyl ester were very close to high-speed diesel such as viscosity, density, heating value and boiling point range. Pour point of methyl ester was higher than diesel owing to the high composition of saturated methyl ester that has a high melting point.

  13. Sustainability in the Malaysian palm oil industry

    OpenAIRE

    Choong, CG; McKay, A

    2014-01-01

    With a rapidly growing world population, the demand for palm oil is increasing. In 2010, palm oil accounted for 36.5% of the world's vegetable oil production and it is projected to be the leading vegetable oil in the world by 2016. As the Malaysian palm oil industry is committed to delivering sustainable palm oil products to meet customer demand, this research was to enable identification and prioritisation of areas for improvement. As an example, the Roadmap of Malaysian Palm Oil Industry 20...

  14. Transgenic oil palm: production and projection.

    Science.gov (United States)

    Parveez, G K; Masri, M M; Zainal, A; Majid, N A; Yunus, A M; Fadilah, H H; Rasid, O; Cheah, S C

    2000-12-01

    Oil palm is an important economic crop for Malaysia. Genetic engineering could be applied to produce transgenic oil palms with high value-added fatty acids and novel products to ensure the sustainability of the palm oil industry. Establishment of a reliable transformation and regeneration system is essential for genetic engineering. Biolistic was initially chosen as the method for oil palm transformation as it has been the most successful method for monocotyledons to date. Optimization of physical and biological parameters, including testing of promoters and selective agents, was carried out as a prerequisite for stable transformation. This has resulted in the successful transfer of reporter genes into oil palm and the regeneration of transgenic oil palm, thus making it possible to improve the oil palm through genetic engineering. Besides application of the Biolistics method, studies on transformation mediated by Agrobacterium and utilization of the green fluorescent protein gene as a selectable marker gene have been initiated. Upon the development of a reliable transformation system, a number of useful targets are being projected for oil palm improvement. Among these targets are high-oleate and high-stearate oils, and the production of industrial feedstock such as biodegradable plastics. The efforts in oil palm genetic engineering are thus not targeted as commodity palm oil. Due to the long life cycle of the palm and the time taken to regenerate plants in tissue culture, it is envisaged that commercial planting of transgenic palms will not occur any earlier than the year 2020.

  15. Research advancements in palm oil nutrition*

    Science.gov (United States)

    May, Choo Yuen; Nesaretnam, Kalanithi

    2014-01-01

    Palm oil is the major oil produced, with annual world production in excess of 50 million tonnes. About 85% of global palm oil produced is used in food applications. Over the past three decades, research on nutritional benefits of palm oil have demonstrated the nutritional adequacy of palm oil and its products, and have resulted in transitions in the understanding these attributes. Numerous studies have demonstrated that palm oil was similar to unsaturated oils with regards to effects on blood lipids. Palm oil provides a healthy alternative to trans-fatty acid containing hydrogenated fats that have been demonstrated to have serious deleterious effects on health. The similar effects of palm oil on blood lipids, comparable to other vegetable oils could very well be due to the structure of the major triglycerides in palm oil, which has an unsaturated fatty acid in the stereospecific numbers (sn)-2 position of the glycerol backbone. In addition, palm oil is well endowed with a bouquet of phytonutrients beneficial to health, such as tocotrienols, carotenoids, and phytosterols. This review will provide an overview of studies that have established palm oil as a balanced and nutritious oil. PMID:25821404

  16. Transpiration in an oil palm landscape: effects of palm age

    Science.gov (United States)

    Röll, A.; Niu, F.; Meijide, A.; Hardanto, A.; Hendrayanto; Knohl, A.; Hölscher, D.

    2015-10-01

    Oil palm (Elaeis guineensis Jacq.) plantations cover large and continuously increasing areas of humid tropical lowlands. Landscapes dominated by oil palms usually consist of a mosaic of mono-cultural, homogeneous stands of varying age, which may be heterogeneous in their water use characteristics. However, studies on the water use characteristics of oil palms are still at an early stage and there is a lack of knowledge on how oil palm expansion will affect the major components of the hydrological cycle. To provide first insights into hydrological landscape-level consequences of oil palm cultivation, we derived transpiration rates of oil palms in stands of varying age, estimated the contribution of palm transpiration to evapotranspiration, and analyzed the influence of fluctuations in environmental variables on oil palm water use. We studied 15 two- to 25-year old stands in the lowlands of Jambi, Indonesia. A sap flux technique with an oil palm specific calibration and sampling scheme was used to derive leaf-, palm- and stand-level water use rates in all stands under comparable environmental conditions. Additionally, in a two- and a 12-year old stand, eddy covariance measurements were conducted to derive evapotranspiration rates. Water use rates per leaf and palm increased 5-fold from an age of 2 years to a stand age of approx. 10 years and then remained relatively constant. A similar trend was visible, but less pronounced, for estimated stand transpiration rates of oil palms; they varied 12-fold, from 0.2 mm day-1 in a 2-year old to 2.5 mm day-1 in a 12-year old stand, showing particularly high variability in transpiration rates among medium-aged stands. Comparing sap flux and eddy-covariance derived water fluxes suggests that transpiration contributed 8 % to evapotranspiration in the 2-year old stand and 53 % in the 12-year old stand, indicating variable and substantial additional sources of evaporation, e.g., from the soil, the ground vegetation and from trunk

  17. Transpiration in an oil palm landscape: effects of palm age

    Directory of Open Access Journals (Sweden)

    A. Röll

    2015-06-01

    Full Text Available Oil palm (Elaeis guineensis Jacq. plantations cover large and continuously increasing areas of humid tropical lowlands. Landscapes dominated by oil palms usually consist of a mosaic of mono-cultural, homogeneous stands of varying age, which may be heterogeneous in their water use characteristics. However, studies on the water use characteristics of oil palms are still at an early stage and there is a lack of knowledge on how oil palm expansion will affect the major components of the hydrological cycle. To provide first insights into hydrological landscape-level consequences of oil palm cultivation, we derived transpiration rates of oil palms in stands of varying age, estimated the contribution of palm transpiration to evapotranspiration, and analyzed the influence of fluctuations in environmental variables on oil palm water use. We studied 15 two- to 25 year old stands in the lowlands of Jambi, Indonesia. A sap flux technique with an oil palm specific calibration and sampling scheme was used to derive leaf-, palm- and stand-level water use rates in all stands under comparable environmental conditions. Additionally, in a two- and a 12 year old stand, eddy covariance measurements were conducted to derive evapotranspiration rates. Water use rates per leaf and palm increased 5-fold from an age of two years to a stand age of approx. 10 years and then remained relatively constant. A similar trend was visible, but less pronounced, for estimated stand transpiration rates of oil palms; they varied 12-fold, from 0.2 mm day−1 in a 2 year old to 2.5 mm day−1 in a 12 year old stand, showing particularly high variability in transpiration rates among medium-aged stands. Confronting sap flux and eddy-covariance derived water fluxes suggests that transpiration contributed 8 % to evapotranspiration in the 2 year old stand and 53 % in the 12 year old stand, indicating variable and substantial additional sources of evaporation, e.g. from the soil, the ground

  18. Adsorption of colour, TSS and COD from palm oil mill effluent (POME using acid-washed coconut shell activated carbon: Kinetic and mechanism studies

    Directory of Open Access Journals (Sweden)

    Sia Yong Yin

    2017-01-01

    Full Text Available The disposal of palm oil mill effluent (POME without proper treatment before being discharged into natural water sources has become undesirable because of high concentration of suspended solid (SS, oil and grease (O&G, chemical oxygen demand (COD and biological oxygen demand (BOD. This study investigated the feasibility of removing colour, total suspended solid (TSS and COD using acid-washed coconut shell based activated carbon (CSAC through the evaluation of the adsorption uptake as well as the adsorption kinetics and mechanism. The percentage removal of colour, TSS and COD from POME onto CSAC were 61%, 39%, 66%, respectively achieved within 48 hours of contact time. The kinetic models studied were pseudo-first-order (PFO, pseudo-second-order (PSO, and Elovich models. The intra-particle diffusion (IPD model was studied to interpret the adsorption diffusion mechanism. The adsorption of colour, TSS and COD onto CSAC were best interpreted by the PSO model, and well fitted by the Elovich model. The IPD and Boyd plots indicated that IPD and film diffusion controlled the adsorption of colour, TSS and COD onto the CSAC.

  19. How will oil palm expansion affect biodiversity?

    OpenAIRE

    Fitzherbert, E.B.; Struebig, M.J.; Morel, A.; Danielsen, F.; Brühl, C.A.; Donald, P.F.; Phalan, B.

    2008-01-01

    Metadata only record This article explores the impacts of oil palm expansion on biodiversity and tropical deforestation. Oil palm plantations support substantially less biodiversity than natural forest or even other tree crops. Because regions with favorable conditions for oil palm plantations tend to be areas of critical importance for biodiversity, the rising international demand for vegetable oils and biofuels could prompt further wide-scale tropical deforestation and large losses of bi...

  20. Commercially available alternatives to palm oil.

    Science.gov (United States)

    Hinrichsen, Nils

    2016-04-01

    Since several years there has been a demand for food products free of palm oil, noticeable in the Western European market. Alternatives based on liquid oils, fully hydrogenated fats, and exotic fats like shea and sal etc., have been developed by the research groups of several specialty oils and fats suppliers. This article describes the advantages and disadvantages of those products and compares them to similar products based on palm oil. It is also discussed how reasonable the replacement of palm products would be, since sustainable and 3-MCPD/glycidolester-reduced palm based specialty oils are also available on the market.

  1. Palm oil and the heart: A review.

    Science.gov (United States)

    Odia, Osaretin J; Ofori, Sandra; Maduka, Omosivie

    2015-03-26

    Palm oil consumption and its effects on serum lipid levels and cardiovascular disease in humans is still a subject of debate. Advocacy groups with varying agenda fuel the controversy. This update intends to identify evidence-based evaluations of the influence of palm oil on serum lipid profile and cardiovascular disease. Furthermore, it suggests a direction for future research. The sources of information were based on a PubMed, Google Scholar, African Journal online and Medline search using key words including: palm oil, palmitic acid, saturated fatty acids and heart disease. Published animal and human experiments on the association of palm oil and its constituents on the serum lipid profile and cardiovascular disease were also explored for relevant information. These papers are reviewed and the available evidence is discussed. Most of the information in mainstream literature is targeted at consumers and food companies with a view to discourage the consumption of palm oil. The main argument against the use of palm oil as an edible oil is the fact that it contains palmitic acid, which is a saturated fatty acid and by extrapolation should give rise to elevated total cholesterol and low-density lipoprotein cholesterol levels. However, there are many scientific studies, both in animals and humans that clearly show that palm oil consumption does not give rise to elevated serum cholesterol levels and that palm oil is not atherogenic. Apart from palmitic acid, palm oil consists of oleic and linoleic acids which are monounsaturated and polyunsaturated respectively. Palm oil also consists of vitamins A and E, which are powerful antioxidants. Palm oil has been scientifically shown to protect the heart and blood vessels from plaques and ischemic injuries. Palm oil consumed as a dietary fat as a part of a healthy balanced diet does not have incremental risk for cardiovascular disease. Little or no additional benefit will be obtained by replacing it with other oils rich in mono

  2. Hydrogen rich gas from oil palm biomass as a potential source of renewable energy in Malaysia

    Energy Technology Data Exchange (ETDEWEB)

    Mohammed, M.A.A.; Salmiaton, A.; Wan Azlina, W.A.K.G.; Mohammad Amran, M.S.; Fakhru' l-Razi, A. [Department of Chemical and Environmental Engineering, Faculty of Engineering, Universiti Putra Malaysia, 43400 UPM Serdang, Selangor (Malaysia); Taufiq-Yap, Y.H. [Centre of Excellence for Catalysis Science and Technology and Department of Chemistry, Faculty of Science, University Putra Malaysia, 43400 UPM Serdang, Selangor (Malaysia)

    2011-02-15

    Oil palm is one of the major economic crops in many countries. Malaysia alone produces about 47% of the world's palm oil supply and can be considered as the world's largest producer and exporter of palm oil. Malaysia also generates huge quantity of oil palm biomass including oil palm trunks, oil palm fronds, empty fruit bunches (EFB), shells and fibers as waste from palm oil fruit harvest and oil extraction processing. At present there is a continuously increasing interest in the utilization of oil palm biomass as a source of clean energy. One of the major interests is hydrogen from oil palm biomass. Hydrogen from biomass is a clean and efficient energy source and is expected to take a significant role in future energy demand due to the raw material availability. This paper presents a review which focuses on different types of thermo-chemical processes for conversion of oil palm biomass to hydrogen rich gas. This paper offers a concise and up-to-date scenario of the present status of oil palm industry in contributing towards sustainable and renewable energy. (author)

  3. Life Cycle Assessment for the Production of Oil Palm Seeds

    OpenAIRE

    Muhamad, Halimah; Ai, Tan Yew; Khairuddin, Nik Sasha Khatrina; Amiruddin, Mohd Din; May, Choo Yuen

    2014-01-01

    The oil palm seed production unit that generates germinated oil palm seeds is the first link in the palm oil supply chain, followed by the nursery to produce seedling, the plantation to produce fresh fruit bunches (FFB), the mill to produce crude palm oil (CPO) and palm kernel, the kernel crushers to produce crude palm kernel oil (CPKO), the refinery to produce refined palm oil (RPO) and finally the palm biodiesel plant to produce palm biodiesel. This assessment aims to investigate the life c...

  4. How will oil palm expansion affect biodiversity?

    Science.gov (United States)

    Fitzherbert, Emily B; Struebig, Matthew J; Morel, Alexandra; Danielsen, Finn; Brühl, Carsten A; Donald, Paul F; Phalan, Ben

    2008-10-01

    Oil palm is one of the world's most rapidly increasing crops. We assess its contribution to tropical deforestation and review its biodiversity value. Oil palm has replaced large areas of forest in Southeast Asia, but land-cover change statistics alone do not allow an assessment of where it has driven forest clearance and where it has simply followed it. Oil palm plantations support much fewer species than do forests and often also fewer than other tree crops. Further negative impacts include habitat fragmentation and pollution, including greenhouse gas emissions. With rising demand for vegetable oils and biofuels, and strong overlap between areas suitable for oil palm and those of most importance for biodiversity, substantial biodiversity losses will only be averted if future oil palm expansion is managed to avoid deforestation.

  5. Commercially available alternatives to palm oil

    OpenAIRE

    Hinrichsen, Nils

    2016-01-01

    Since several years there has been a demand for food products free of palm oil, noticeable in the Western European market. Alternatives based on liquid oils, fully hydrogenated fats, and exotic fats like shea and sal etc., have been developed by the research groups of several specialty oils and fats suppliers. This article describes the advantages and disadvantages of those products and compares them to similar products based on palm oil. It is also discussed how reasonable the replacement of...

  6. Palm Oil Milling Wastes and Sustainable Development

    Directory of Open Access Journals (Sweden)

    A. C. Er

    2011-01-01

    Full Text Available Problem statement: Palm oil milling generates solid wastes, effluent and gaseous emissions. The aim of this study is to assess the progress made in waste management by the Malaysian palm oil milling sector towards the path of sustainable development. Sustainable development is defined as the utilization of renewable resources in harmony with ecological systems. Inclusive in this definition is the transition from low value-added to higher value-added transformation of wastes into resources. Approach: A longitudinal study was carried out from 2003-2010 via, initially a field survey and subsequently a key informant approach with observation as a complementation for both. Results: Solid wastes, inclusive of solid wastes derived from air emissions and palm oil mil effluent, have a utility function with zero wastage. The principal source of effluent is palm oil mill effluent. Treated palm oil mill effluent is utilized for cropland application by plantation-based palm oil mills. However, independent mills discharge treated palm oil mill effluent in accordance to environmental parameters into receiving waterways. Methane is also released by palm oil mill effluent. Biogas from palm oil mill effluent and biomass energy from solid wastes are potential sources of renewable energy in Malaysia. Conclusion: In general, the wastes from palm oil milling are returned to the field for cropland application, utilized in-house or in the plantation, or sold to third parties. Thus, there is progress made towards sustainable development. The addition of new technologies and replacement of old mills will help to reduce the carbon footprint. However, at this juncture, the feed-in tariff for renewable energy is not financially attractive. If the biogas and biomass renewable energy sector were to take-off, enhancement in the value chain would occur and in tandem further progress towards sustainable development can be attained.

  7. Cryopreservation of oil palm (Elaeis guineensis Jacq.).

    Science.gov (United States)

    Teixeira da Silva, Jaime A; Engelmann, Florent

    2017-08-01

    Oil palm (Elaeis guineensis Jacq.), a tropical plant, is the leading source of edible oil. This review deals with the cryopreservation of oil palm as a way to preserve this important tropical germplasm. Somatic embryos have been the most popular source of material for cryopreservation as they are propagules that are effectively produced during micropropagation. In contrast, fewer studies exist on the cryopreservation of pollen, zygotic embryos, seeds, kernels and embryogenic cell suspensions. This review highlights the ideal protocols, in detail, in a bid to offer guidance for further advances in oil palm cryopreservation. Copyright © 2017 Elsevier Inc. All rights reserved.

  8. Cryopreservation of oil palm (Elaeis guineensis Jacq.)

    OpenAIRE

    da Silva, J. A. T.; Engelmann, Florent

    2017-01-01

    Oil palm (Elaeis guineensis Jacq.), a tropical plant, is the leading source of edible oil. This review deals with the cryopreservation of oil palm as a way to preserve this important tropical germplasm. Somatic embryos have been the most popular source of material for cryopreservation as they are propagules that are effectively produced during micropropagation. In contrast, fewer studies exist on the cryopreservation of pollen, zygotic embryos, seeds, kernels and embryogenic cell suspensions....

  9. Potential Oil Palm Industry Development in Riau

    Directory of Open Access Journals (Sweden)

    Almasdi Syahza

    2013-08-01

    Full Text Available Oil palm is one of Indonesia’s main commodities that play a role in the growth of the national economy. It has a considerable contribution in generating foreign exchange and employment. Development of Indonesia’s CPO processing industry and its derivatives is in line with the growth of plantation area and production of oil palm as a source of raw materials. Until 2011, Indonesia’s oil palm plantation area reached 2,103,175 ha with an FFB production of 36,809,252 tons. Meanwhile, oil palm mill (OPM processing capacity was 30,019,200 tons only. The analysis showed the regional carrying capacity (RCC was 1.584. Each FFB should be processed in less than 8 hours or RCC for OPM must be smaller than 1 (RCC, 1. Higher production of oil palm plantations in Riau is the potency to increase the OPM. The results of calculations by land development and farm productivity, Riau region is still lacking of 16 OPM units with a capacity of 60 tons / hour or identical to 21 OPM units at a capacity of 45 tons / hour. The deficiency in OPM impacts the price and income of oil palm farmers in rural areas. High demand for OPM in Riau is a business opportunity for investors to develop an OPM and industry of products derived from oil palm.

  10. Correlation, path coefficient analysis and heritability for agronomic characters of oil palm (Elaeis guineensis Jacq.

    Directory of Open Access Journals (Sweden)

    Chaumongkol, Y.

    2001-11-01

    Full Text Available A study of correlation, path coefficient analysis and heritablity for some agronomic characters of oil palm was investigated during February 1998 to January 2002. The oil palm population used in this experiment was derived from F1 tenera hybrids which were collected from various oil palm plantations in Southern Thailand. One good performance bunch (i.e., big bunch, thin shell was selected from each plantation and four to six seeds per selected bunch were used for cultivation. One thousand thirty eight plants were grown at Klong Hoi Khong Research Station, Faculty of Natural Resources, Prince of Songkla University, Songkhla, in 1989. Forty five palms consisted of Dura, Tenera and Pisifera types with 18, 18 and 9 plants respectively, were selected by randomization and tagged for investigation. The oil palm bunch yield and yield component characters were observed from individual palm for 4 years (February 1998 to January 2002. The bunch composition characters were analysed from a single bunch of each palm, sampled between June to October 1999. The results showed that in F2 plants of oil palm, the correlation and the path coefficient between characters relating to oil yield and %oil/bunch varied according to oil palm types (Dura, Tenera and Pisifera. In Dura and Tenera palms, the characters which gave highly positive correlation with a large direct and indirect positive effects on oil yield and %oil/bunch were total bunch weight, %oil/bunch, %fruit/bunch and %oil/fruit. In case of Pisifera palms, the characters which gave highly positive correlation with a large direct and indirect positive effects on oil yield and %oil/bunch were total bunch weight, number of bunches, single bunch weight, %oil/bunch and %fruit/bunch. However, from all investigated characters in F2 plants, only %mesocarp/fruit, %oil/fruit and %fruit/bunch showed the high values of broad sense heritabilities.

  11. Advances in biofuel production from oil palm and palm oil processing wastes: A review

    Directory of Open Access Journals (Sweden)

    Jundika C. Kurnia

    2016-03-01

    Full Text Available Over the last decades, the palm oil industry has been growing rapidly due to increasing demands for food, cosmetic, and hygienic products. Aside from producing palm oil, the industry generates a huge quantity of residues (dry and wet which can be processed to produce biofuel. Driven by the necessity to find an alternative and renewable energy/fuel resources, numerous technologies have been developed and more are being developed to process oil-palm and palm-oil wastes into biofuel. To further develop these technologies, it is essential to understand the current stage of the industry and technology developments. The objective of this paper is to provide an overview of the palm oil industry, review technologies available to process oil palm and palm oil residues into biofuel, and to summarise the challenges that should be overcome for further development. The paper also discusses the research and development needs, technoeconomics, and life cycle analysis of biofuel production from oil-palm and palm-oil wastes.

  12. Advances in biofuel production from oil palm and palm oil processing wastes: A review

    OpenAIRE

    Kurnia, Jundika C.; Sachin V. Jangam; Saad Akhtar; Agus P. Sasmito; Mujumdar,Arun S.

    2016-01-01

    Over the last decades, the palm oil industry has been growing rapidly due to increasing demands for food, cosmetic, and hygienic products. Aside from producing palm oil, the industry generates a huge quantity of residues (dry and wet) which can be processed to produce biofuel. Driven by the necessity to find an alternative and renewable energy/fuel resources, numerous technologies have been developed and more are being developed to process oil-palm and palm-oil wastes into biofuel. To further...

  13. Boron toxicity in oil palm (Elaeis guineensis)

    Energy Technology Data Exchange (ETDEWEB)

    Rajaratnam, J.A.

    1973-01-01

    Potted oil palms were treated with fertilizer of borate-46 at several concentrations and the plants were observed for boron toxicity effects. Toxicity symptoms were apparent at high rates but not at rates equivalent to typical Malaysian soils.

  14. Present and future position of palm oil industry in Malasia

    Energy Technology Data Exchange (ETDEWEB)

    Kato, Akio

    1988-04-20

    This paper introduces the present and future problems on the palm oil industry in Malaysia. The author was dispatched as an expert to the Malaysia Palm Oil Laboratory which is a governmental investigation organization. The cultivation area of oil palms were increased with the production of palm oil in 1990 - 1985. The oil mills produce average 20,000 tons/year of raw palm oil. 38 refining factories of the approved 75 factories are in work. The treatment capability of raw palm oil is 8.86 million tons/year. The palm oil is a solid vegetable oil at room temperature. For use the palm oil is fractionated into liquid palm olein, solid palm stearin, and palm oil with an intermediate melting point. About 90% of palm oil is edible. The leaves contain about 0.49% of alpha-tocopherol. The future problems to be solved lie in that the palm oil is improved to have a high liquid content, the production cost is reduced, and new uses for the palm oil are developed. (15 tabs, 37 refs)

  15. LIFE CYCLE ASSESSMENT FOR OIL PALM BASED PLYWOOD: A GATE-TO-GATE CASE STUDY

    Directory of Open Access Journals (Sweden)

    M. Shamim Ahmad

    2014-01-01

    generation and usage of electricity from the grid. The ways to mitigate the environmental impacts are by using substitutes for inorganic chemical adhesives such as groundnut shell lignin adhesive, modified phenol formaldehyde adhesive and developing wood adhesive made from pyrolisis oil of oil palm biomass, establishing a collecting centre for oil palm trunk transportation and efficient use of oil palm biomass as an energy source. The study helped establishing baseline information for the complete environmental profile of the palm oil industry from cradle to grave which starts at the oil palm germinated seeds to the production of palm plywood.

  16. IMPACT OF CPO EXPORT DUTIES ON MALAYSIAN PALM OIL INDUSTRY

    Directory of Open Access Journals (Sweden)

    Ibragimov Abdulla

    2014-01-01

    Full Text Available In January 2013, Malaysia reduced the export duty structure to be in line with the Indonesia’s duty structure. Both countries export crude and processed palm oil. Since Malaysia and Indonesia are close competitors and they compete in the same market, a change in export duty rate in one country will affect the other. Indonesia, as the world’s biggest palm oil producer, has drastically widened the values between the crude palm oil and refined palm oil export taxes since October 2011, to encourage more downstream investments and production of refined palm oil products. Under the revised export duty structure, crude palm oil and crude palm kernel oil are cheaper for downstream activities in Indonesia. The new structure is expected to reduce Malaysia’s competitiveness in the world market as its export duty is relatively higher. A high export duty results in high price of crude palm oil which is the raw material for processed palm oil. The research questions are: (i What are the likely future trends of crude palm oil exports under the new crude palm oil export duties? Will it increase, reduce or stabilize? (ii What are the likely future trends of processed palm oil exports? Will it increase exponentially, stabilize or reduce? To answer these questions, a system dynamics model was developed for the Malaysian palm oil. Application of the system dynamics model provides a framework to understand the feedback structure and how changes in variables impact the behavior of the palm oil industry. This research suggests that with low crude palm oil export duties crude palm oil domestic price, profitability of plantation owners, immature crop, mature crop, total planted area, production and exports of crude palm oil increase, however exports of processed palm oil decrease.

  17. European Policies towards Palm Oil - Sorting Out some Facts

    OpenAIRE

    Pehnelt, Gernot; Vietze, Christoph

    2009-01-01

    This paper analyses the role of palm oil and its sustainability from different perspectives. We consider the role of palm oil within the GHG context. We discuss the impact of palm oil on biodiversity and analyse how palm oil can contribute to economic growth and development in tropical countries. Finally, based on this analysis, we assess the current concerns about and politics towards palm oil with special focus on the EU. Palm oil is a low-energy and low-fertilizer crop that offers much hig...

  18. Characterization of Palm Oil as Biodiesel

    Science.gov (United States)

    Gorey, Neeraj; Ghosh, Shankha; Srivastava, Priyank; Kumar, Vivek

    2017-08-01

    The various sources of energy from which mechanical energy is obtained are non-renewable and are thus considered to be unsustainable. These sources include the various fossil fuels like the petroleum, coal and the natural gas. The burning of fossil fuels led to the production of the greenhouse gases increasing the levels of CO2 in the atmosphere. The adverse effects are the global warming and the ozone layer depletion. In a nation like India, where consumable oils are still transported in, it is advantageous to investigate the likelihood of utilising such non-palatable oils as a part of CI motors which are not by and by used as cooking oil. Palm oil (otherwise called dendê oil, from Portuguese) is a consumable vegetable oil got from the monocarp (ruddy mash) of the product of the oil palms. The major objective is to provide a cheap and effective alternative to diesel. This paper is an exploration of the capability of the palm oil as a practical, modest and effective hotspot for the generation of biodiesel. the paper is based on the characterisation of palm oil compare to diesel.

  19. Health promoting effects of phytonutrients found in palm oil.

    Science.gov (United States)

    Loganathan, R; Selvaduray, K R; Nesaretnam, K; Radhakrishnan, A K

    2010-08-01

    The oil palm tree, Elaeis guineesis, is the source of palm oil, otherwise known as the "tropical golden oil". To date, Malaysia and Indonesia are the leading producers of palm oil. Palm oil is widely used for domestic cooking in Malaysia. Palm oil is a rich source of phytonutrients such as tocotrienols, tocopherol, carotene, phytosterols, squalene, coenzyme Q10, polyphenols, and phospholipids. Although the phytonutrients constitute only about 1% of its weight in crude palm oil, these are the main constituents through which palm oil exhibits its nutritional properties. Among the major health promoting properties shown to be associated with the various types of phytonutrients present in palm oil are anti-cancer, cardio-protection and anti-angiogenesis, cholesterol inhibition, brain development and neuro protective properties, antioxidative defence mechanisms, provitamin A activity and anti-diabetes.

  20. A case study of pyrolysis of oil palm wastes in Malaysia

    Science.gov (United States)

    Abdullah, Nurhayati; Sulaiman, Fauziah; Aliasak, Zalila

    2013-05-01

    Biomass seems to have a great potential as a source of renewable energy compared with other sources. The use of biomass as a source of energy could help to reduce the wastes and also to minimize the dependency on non-renewable energy, hence minimize environmental degradation. Among other types of biomass, oil palm wastes are the major contribution for energy production in Malaysia since Malaysia is one of the primary palm oil producers in the world. Currently, Malaysia's plantation area covers around 5 million hectares. In the oil palm mill, only 10% palm oil is produced and the other 90% is in the form of wastes such as empty fruit bunches (EFB), oil palm shells (OPS), oil palm fibre (OPFb) and palm oil mill effluent (POME). If these wastes are being used as a source of renewable energy, it is believed that it will help to increase the country's economy. Recently, the most potential and efficient thermal energy conversion technology is pyrolysis process. The objective of this paper is to review the current research on pyrolysis of oil palm wastes in Malaysia. The scope of this paper is to discuss on the types of pyrolysis process and its production. At present, most of the research conducted in this country is on EFB and OPS by fast, slow and microwave-assisted pyrolysis processes for fuel applications.

  1. Factors affecting oil palm production in Ondo state of Nigeria

    African Journals Online (AJOL)

    sola

    Regression analysis showed that only two of the variables; level of education ... were predicted to have significant relationship with the yield of oil palm. ..... Table 5: Multiple Regression analysis of factors affecting oil palm production in.

  2. development of motorized development of motorized oil palm fruit ...

    African Journals Online (AJOL)

    eobe

    Cameroon, Sierra Leone, Nigeria, Malaysia and. Indonesia. Nigeria used .... of the oil palm fruits relevant to their behaviour ..... industrial raw material development as well as food security ... industry, local consumption and for export. Oil palm.

  3. Dry Separation of Palm Kernel and Palm Shell Using a Novel Five-Stage Winnowing Column System

    Directory of Open Access Journals (Sweden)

    Rohaya Mohamed Halim

    2016-04-01

    Full Text Available The conventional separation system for the recovery of palm kernel from its palm shell–kernel mixture using water as process media generates a considerable amount of waste effluent that harms the environment. The aim of this study is to develop a dry separation process for the recovery of palm kernel by using winnowing columns. A commercial system consisting of a series of five winnowing columns was developed and installed at a local palm oil mill. The system parameters, including column height, blower capacity, airflow rate and mesh screen size for shell removal, were studied and optimized to ensure good separation of kernel and shell in the column to enable collection of different sizes of kernel and shell at each column outlet. The performance of the separation process was evaluated in terms of its kernel losses, dirt content and kernel recovery rate. The average kernel losses based on oil palm fresh fruit bunches processed were found to vary from 0.11 to 0.30 wt %, with most of the values obtained being below the targeted limit of 0.30 wt %. The dirt content was in the range 4.56–6.03 wt %, which was mostly below the targeted limit of 5.5 wt %. The kernel recovery rate was in the range 5.69–6.89 wt %, with most of the values achieving the minimum targeted limit of 6.00 wt %. The system operates under completely dry conditions and, therefore, produces zero waste effluent.

  4. Urea adsorption by activated carbon prepared from palm kernel shell

    Science.gov (United States)

    Ooi, Chee-Heong; Sim, Yoke-Leng; Yeoh, Fei-Yee

    2017-07-01

    Dialysis treatment is crucial for patients suffer from renal failure. The dialysis system removes the uremic toxin to a safe level in a patient's body. One of the major limitations of the current hemodialysis system is the capability to efficiently remove uremic toxins from patient's body. Nanoporous materials can be applied to improve the treatment. Palm kernel shell (PKS) biomass generated from palm oil mills can be utilized to prepare high quality nanoporous activated carbon (AC) and applied for urea adsorption in the dialysis system. In this study, AC was prepared from PKS via different carbonization temperatures and followed by carbon dioxide gas activation processes. The physical and chemical properties of the samples were studied. The results show that the porous AC with BET surface areas ranging from 541 to 622 m2g-1 and with total pore volumes varying from 0.254 to 0.297 cm3g-1, are formed with different carbonization temperatures. The equilibrium constant for urea adsorption by AC samples carbonized at 400, 500 and 600 °C are 0.091, 0.287 and 0.334, respectively. The increase of carbonization temperatures from 400 to 600 °C resulted in the increase in urea adsorption by AC predominantly due to increase in surface area. The present study reveals the feasibility of preparing AC with good porosity from PKS and potentially applied in urea adsorption application.

  5. Contemporary land-use transitions: The global oil palm expansion

    DEFF Research Database (Denmark)

    Kongsager, Rico; Reenberg, Anette

    The present report aims at providing an overview of the magnitude and geographical distribution of oil palm cultivation. It also considers recent trends in the palm oil market and the future prospects for palm oil. By way of background, we briefly summarize the agroecological characteristics of o...

  6. Assessing the environmental impact of palm oil produced in Thailand

    NARCIS (Netherlands)

    Saswattecha, K.; Kroeze, C.; Jawjit, W.; Hein, L.G.

    2015-01-01

    There are several concerns related to the increasing production of palm oil in Southeast Asia, including pollution, greenhouse gas emissions and land conversion. The RSPO (Roundtable on Sustainable Palm Oil) certification standard provides an incentive for reducing environmental impacts of palm oil

  7. Assessing the environmental impact of palm oil produced in Thailand

    NARCIS (Netherlands)

    Saswattecha, K.; Kroeze, C.; Jawjit, W.; Hein, L.G.

    2015-01-01

    There are several concerns related to the increasing production of palm oil in Southeast Asia, including pollution, greenhouse gas emissions and land conversion. The RSPO (Roundtable on Sustainable Palm Oil) certification standard provides an incentive for reducing environmental impacts of palm oil

  8. Life Cycle Assessment for the Production of Oil Palm Seeds.

    Science.gov (United States)

    Muhamad, Halimah; Ai, Tan Yew; Khairuddin, Nik Sasha Khatrina; Amiruddin, Mohd Din; May, Choo Yuen

    2014-12-01

    The oil palm seed production unit that generates germinated oil palm seeds is the first link in the palm oil supply chain, followed by the nursery to produce seedling, the plantation to produce fresh fruit bunches (FFB), the mill to produce crude palm oil (CPO) and palm kernel, the kernel crushers to produce crude palm kernel oil (CPKO), the refinery to produce refined palm oil (RPO) and finally the palm biodiesel plant to produce palm biodiesel. This assessment aims to investigate the life cycle assessment (LCA) of germinated oil palm seeds and the use of LCA to identify the stage/s in the production of germinated oil palm seeds that could contribute to the environmental load. The method for the life cycle impact assessment (LCIA) is modelled using SimaPro version 7, (System for Integrated environMental Assessment of PROducts), an internationally established tool used by LCA practitioners. This software contains European and US databases on a number of materials in addition to a variety of European- and US-developed impact assessment methodologies. LCA was successfully conducted for five seed production units and it was found that the environmental impact for the production of germinated oil palm was not significant. The characterised results of the LCIA for the production of 1000 germinated oil palm seeds showed that fossil fuel was the major impact category followed by respiratory inorganics and climate change.

  9. Characteristic Drying Curve of Oil Palm Fibers

    Directory of Open Access Journals (Sweden)

    Ifa Puspasari

    2014-03-01

    Full Text Available The drying of crushed oil palm fronds was studied in a fluidized bed dryer assisted with mechanical agitation at different inlet air temperature, superficial air velocity, bed loading and agitation speed. The drying kinetics of the fibers under various drying conditions could be described by a single characteristic drying curve. A combined exponential and power law model is proposed to represent the characteristic drying curve which described both the increasing rate and the falling rate periods. The proposed model is also tested for drying kinetics of oil palm empty fruit bunch from previous researcher. It was found that the characteristic curve for both oil palm fronds and empty fruit bunch fibers has similar shape and that the proposed model is acceptable for describing the complete drying characteristics of the fibers.

  10. Bio-oils from Pyrolysis of Oil Palm Empty Fruit Bunches

    Directory of Open Access Journals (Sweden)

    Mohamad A. Sukiran

    2009-01-01

    Full Text Available Problem Statement: The palm oil industry generates an abundance of oil palm biomass such as the mesocarp fibre, shell, empty fruit bunch (EFB, frond, trunk and palm oil mill effluent (POME. For 80 million tonnes of fresh fruit bunch (FFB processed last year, the amount of oil palm biomass was more than 25 million tones. The objectives of this study were to: (i Determine the effect of various pyrolysis parameters on product yields and (ii Characterise liquid product obtained under different condition. Approach: In this study, pyrolysis of oil palm Empty Fruit Bunches (EFB was investigated using quartz fluidized fixed bed reactor. The effects of pyrolysis temperatures, particle sizes and heating rates on the yield of the products were investigated. The temperature of pyrolysis and heating rate were varied in the range 300-700 °C and 10-100 °C min1 respectively. The particle size was varied in the range of Results: Under the experimental conditions, the maximum bio-oil yield was 42.28% obtained at 500 ºC, with a heating rate of 100 ºC min-1 and particle size of 91-106 µm. The calorific values of bio-oil ranged from 20-21 MJ kg-1. A great range of functional groups of phenol, alcohols, ketones, aldehydes and carboxylic acids were indicated in FTIR spectrum. Conclusion: The chemical characterisation results showed that the bio-oil obtained from oil palm EFB maybe a potentially valuable source as fuel or chemical feedstocks.

  11. for palm kernel oil extraction

    African Journals Online (AJOL)

    user

    OEE), ... designed (CRD) experimental approach with 4 factor levels and 2 replications was used to determine the effect of kernel .... palm kernels in either a continuous or batch mode ... are fed through the hopper; the screw conveys, crushes,.

  12. Production and physico-chemical characterization of biochar from palm kernel shell

    Science.gov (United States)

    Kong, S. H.; Loh, S. K.; Bachmann, Robert T.; Choo, Y. M.; Salimon, J.; Rahim, S. Abdul

    2013-11-01

    As the world's second largest producer and exporter of palm oil, Malaysia's palm oil industry leaves behind huge amounts of biomass waste from its plantation and milling activities such as empty fruit bunch, palm kernel shell (PKS), palm frond and palm trunk. Generally, most of the waste generated is disposed of via open dumping, used as solid fuel in boilers, or used as fertilizers. To enhance the use of the abundant biomass generated by the oil palm industry in Malaysia, conversion of biomass to biochar could be a promising alternative. Biochar has the strength in improving long term soil productivity and capable of sequestering carbon in soils to reduce the emission of carbon dioxide to atmosphere. This research project aims to investigate and optimize the use of PKS for biochar production through slow pyrolysis by using the Biochar Experimenter's Kit (BEK) from All Power Labs, California. PKS was pyrolyzed at 400 °C for an hour. Biochar and the pyrolysis by-products were then collected. The biochar was then selectively characterized for its physicochemical properties such as proximate and ultimate analysis, pH, water holding capacity and BET surface area.

  13. Ecosystem functions of oil palm plantations - a review

    OpenAIRE

    Dislich, Claudia; Keyel, Alexander C.; Salecker, Jan; Kisel, Yael; Meyer, Katrin M.; Corre, Marife D.; Faust, Heiko; Hess, Bastian; Knohl, Alexander; Kreft, Holger; Meijide, Ana; Nurdiansyah, Fuad; Otten, Fenna; Pe'er, Guy; Steinebach, Stefanie

    2015-01-01

    Oil palm plantations have expanded rapidly in the last decades. This large-scale land-use change has had great impacts on both the areas converted to oil palm and their surroundings. Howev-er, research on the impacts of oil palm agriculture is scattered and patchy, and no clear overview ex-ists. Here, we address this gap through a systematic and comprehensive literature review of all ecosys-tem functions in oil palm plantations. We compare ecosystem functions in oil palm plantations to those ...

  14. By-products of palm oil extraction and refining

    Directory of Open Access Journals (Sweden)

    Tan Yew-Ai

    2006-01-01

    Full Text Available This paper outlines the utilisation of by-products resulting from the extraction and refining of palm oil. It summarises research by the Malaysian Palm Oil Board (MPOB directed at producing zero waste from the palm oil industry. MPOB regards by-products of the palm oil industry not as waste but resources. It will be evident that by-products from the palm oil industry can be and have been used extensively and that the research carried out is relevant to both the milling and refining sectors.

  15. Physicochemical Properties of Palm Kernel Oil

    Directory of Open Access Journals (Sweden)

    Amira P. Olaniyi

    2014-09-01

    Full Text Available Physicochemical analyses were carried out on palm kernel oil (Adin and the following results were obtained: Saponification value; 280.5±56.1 mgKOH/g, acid value; 2.7±0.3 mg KOH/g, Free Fatty Acid (FFA; 1.35±0.15 KOH/g, ester value; 277.8±56.4 mgKOH/g, peroxide value; 14.3±0.8 mEq/kg; iodine value; 15.86±4.02 mgKOH/g, Specific Gravity (S.G value; 0.904, refractive index; 1.412 and inorganic materials; 1.05%. Its odour and colour were heavy burnt smell and burnt brown, respectively. These values were compared with those obtained for groundnut and coconut oils. It was found that the physico-chemical properties of palm kernel oil are comparable to those of groundnut and coconut oils except for the peroxide value (i.e., 14.3±0.8 mEq which was not detectable in groundnut and coconut oils. Also the odour of both groundnut and coconut oils were pleasant while that of the palm kernel oil was not as pleasant (i.e., heavy burnt smell.

  16. Governing the palm oil sector through finance

    NARCIS (Netherlands)

    Pramudya, E.P.; Hospes, O.; Termeer, C.J.A.M.

    2016-01-01

    By analysing the roles performed by the Indonesian state since 1945 in arranging finance schemes for palm oil development, this article aims to answer two questions: what were these different roles? And to what extent do these roles prioritise or balance economic growth, environmental protection and

  17. Simulation of oil palm growth and yield.

    NARCIS (Netherlands)

    Kraalingen, van D.W.G.; Breure, C.J.; Spitters, C.J.T.

    1989-01-01

    A dynamic model is presented to simulate growth and yield formation of oil palm (Elaeis quineensis Jacq.) in dependence of weather data and plant characteristics. From incoming amounts of light, light interception of the foliage and photosynthetic characteristics of individual leaflets, daily rates

  18. Simulation of oil palm growth and yield.

    NARCIS (Netherlands)

    Kraalingen, van D.W.G.; Breure, C.J.; Spitters, C.J.T.

    1989-01-01

    A dynamic model is presented to simulate growth and yield formation of oil palm (Elaeis quineensis Jacq.) in dependence of weather data and plant characteristics. From incoming amounts of light, light interception of the foliage and photosynthetic characteristics of individual leaflets, daily rates

  19. Future prospects for palm oil refining and modifications

    Directory of Open Access Journals (Sweden)

    Gibon Véronique

    2009-07-01

    Full Text Available Palm oil is rich in minor components that impart unique nutritional properties and need to be preserved. In this context, refining technologies have been improved, with the dual temperature deodorizer, the double condensing unit and the ice condensing system. The DOBI is a good tool to assess quality of the crude palm oil and its ability to be properly refined. Specially refined oils open a market for new high quality products (golden palm oil, red palm oil, white soaps, etc.. Palm oil is a good candidate for the multi-step dry fractionation process, aiming to the production of commodity oils and specialty fats (cocoa butter replacers. New technological developments allow quality and yield improvements. Palm oil and fractions are also valuable feedstock for enzymatic interesterification in which applications are for commodity oil (low-trans margarines and shortenings and for special products (cocoa butter equivalents, infant formulation, ….

  20. Potential Development of Liquid Smoke from Oil Palm Solid Waste as Biofungicides

    Directory of Open Access Journals (Sweden)

    Asri Gani

    2014-05-01

    Full Text Available This research investigated the potential utilization of solid waste from palm oil industry for liquid smoke production in Aceh Province, Indonesia. The liquid smoke can be applied as bio fungicides in agricultural field. Preliminary experiment on the use of liquid smoke as fungicide at Colletotrichum capsisi fungus which causes anthracnose disease on red pepper was also conducted. The survey on the existing potential/availability of palm oil mill in Aceh shows that there are 30 palm oil mills in eight districts with a total of production capacity 1020 ton/hour. Assuming that 10% of palm oil kernel shells are pyrolized into liquid smoke, Aceh province could produce about 23,868 ton of liquid smoke per year. The preliminary test result towards Colletotrichum capsisi fungus shows that the liquid smoke can be used as fungicides.

  1. 21 CFR 172.861 - Cocoa butter substitute from coconut oil, palm kernel oil, or both oils.

    Science.gov (United States)

    2010-04-01

    ... 21 Food and Drugs 3 2010-04-01 2009-04-01 true Cocoa butter substitute from coconut oil, palm... substitute from coconut oil, palm kernel oil, or both oils. The food additive, cocoa butter substitute from coconut oil, palm kernel oil, or both oils, may be safely used in food in accordance with the...

  2. Nutrition & health implications of palm oil in Indian diets.

    Science.gov (United States)

    Ghafoorunissa

    1995-11-01

    To boost the edible oil production and attain self-sufficiency, one of the long-term strategies undertaken by the Indian government is promotion of palm oil production through oil palm cultivation. Compared to other traditional oils (except coconut oil) used in India, palm oil and palmolein have high saturated fatty acids and low linoleic acid levels. Studies conducted to evaluate the nutritional and health implications of substituting other oils with palmolein show that despite having low linoleic acid, the use of palm oil may not adversely affect the linoleic acid status of Indian population. Substitution of groundnut oil with palmolein in cereal based lactovegetarian diets providing about 30 per cent total fat calories, doubles the saturated fatty acids and reduces by half the linoleic acid content. The effects of this substitution in volunteers from the middle income group did not raise serum cholesterol and aggregability of platelets indicating that palm oil may not produce the deleterious effects associated with saturated fatty acids. The tocols present in palm oil are natural biological antioxidants and can therefore augment the antioxidant potential of Indian diets. Red palm oil is the richest natural source of carotenes which are powerful biological antioxidants. The major carotene in red palm oil is beta-carotene. Therefore, red palm oil can be used to prevent vitamin A deficiency which is widespread in India.

  3. PREPARATION OF ACTIVATED CARBON FROM PALM OIL SHELL BY CHEMICAL ACTIVATION WITH Na2CO3 AND ZnCl2 AS IMPRENATED AGENTS FOR H2S ADSORPTION

    Directory of Open Access Journals (Sweden)

    Kanokorn Hussaro

    2014-01-01

    Full Text Available Hydrogen Sulfide (H2S, rotten-egg is one of the major environmental pollutants having its sources in natural and anthropogenic activities. It’s had smell gas produced by anaerobic digestion in acid condition from organic and inorganic compounds containing sulphur, presents dual problems of its toxicity and foul ordour. One of methods of its removal is adsorption. Activated carbon is a widely used adsorbent in the treatment of air pollution. Adsorption type and capacity are primarily based on the physical properties of pores, namely the surface area. Convetionnally, activated carbon is produced from biomass residues, wood coal and agricultural residuces. Today, one promising approach for the production of cheap and efficient activated carbon is used of waste from palm oil mill industries, which is palm oil shell. Palm oil shell is available in large quantities of approximately 0.53 million tonnes annually in Thailand. Palm oil shell is a by-products of the palm oil industry and was used as a raw material in this study due to its high carbon content, high density and low ash content. Normally, H2S in biogas, which is found the range between as low as about 50-10,000 ppm depending on the feed material composition to prodction, can cause corrosion to engine and metal substance via of SO2 from combustion. H2S must be removed from biogas product prior to further utilization. Therefore, in these research the usage of palm oil shell is especially important due to its high value added for produced activated carbon adsorbent for H2S adsorption in biogas product. In this study, fixed bed reactor (stainless steel with 54.1 mm internal diameter and 320 mm length was studied to observe the effect of char product: Chemical agent ratio (Na2CO3 and ZnCl2, 1:1 to 1:3, which there are activated at 700°C activation temperature for 2 h on the chemical and physical properties

  4. A Survey on the Usage of Biomass Wastes from Palm Oil Mills on Sustainable Development of Oil Palm Plantations in Sarawak

    Science.gov (United States)

    Phang, K. Y.; Lau, S. W.

    2017-06-01

    As one of the world’s largest palm oil producers and exporters, Malaysia is committed to sustainable management of this industry to address the emerging environmental challenges. This descriptive study aims to evaluate the oil palm planters’ opinions regarding the usage of biomass wastes from palm oil mills and its impact on sustainable development of oil palm plantations in Sarawak. 253 planters across Sarawak were approached for their opinions about the usage of empty fruit bunch (EFB), palm oil mill effluent (POME), mesocarp fibre (MF), and palm kernel shell (PKS). This study revealed that the planters had generally higher agreement on the beneficial application of EFB and POME in oil palm plantations. This could be seen from the higher means of agreement rating of 3.64 - 4.22 for EFB and POME, compared with the rating of 3.19 - 3.41 for MF and PKS in the 5-point Likert scale (with 5 being the strongest agreement). Besides, 94.7 percent of the planters’ companies were found to comply with the Environmental Impact Assessment (EIA) requirements where nearly 38 percent carried out the EIA practice twice a year. Therefore high means of agreement were correlated to the compliance of environmental regulations, recording a Likert rating of 3.89 to 4.31. Lastly, the usage of EFB and POME also gained higher Likert scale point of 3.76 to 4.17 against MF and PKS of 3.34 to 3.49 in the evaluation of the impact of sustainability in oil palm plantations. The planters agreed that the usage of EFB and POME has reduced the environmental impact and improved the sustainable development, and its application has been improved and increased by research and development. However the planters were uncertain of the impact of usage of biomass wastes with respect to the contribution to social responsibility and company image in terms of transparency in waste management.

  5. Oil palm mapping for Malaysia using PALSAR-2 dataset

    Science.gov (United States)

    Gong, P.; Qi, C. Y.; Yu, L.; Cracknell, A.

    2016-12-01

    Oil palm is one of the most productive vegetable oil crops in the world. The main oil palm producing areas are distributed in humid tropical areas such as Malaysia, Indonesia, Thailand, western and central Africa, northern South America, and central America. Increasing market demands, high yields and low production costs of palm oil are the primary factors driving large-scale commercial cultivation of oil palm, especially in Malaysia and Indonesia. Global demand for palm oil has grown exponentially during the last 50 years, and the expansion of oil palm plantations is linked directly to the deforestation of natural forests. Satellite remote sensing plays an important role in monitoring expansion of oil palm. However, optical remote sensing images are difficult to acquire in the Tropics because of the frequent occurrence of thick cloud cover. This problem has led to the use of data obtained by synthetic aperture radar (SAR), which is a sensor capable of all-day/all-weather observation for studies in the Tropics. In this study, the ALOS-2 (Advanced Land Observing Satellite) PALSAR-2 (Phased Array type L-band SAR) datasets for year 2015 were used as an input to a support vector machine (SVM) based machine learning algorithm. Oil palm/non-oil palm samples were collected using a hexagonal equal-area sampling design. High-resolution images in Google Earth and PALSAR-2 imagery were used in human photo-interpretation to separate oil palm from others (i.e. cropland, forest, grassland, shrubland, water, hard surface and bareland). The characteristics of oil palms from various aspects, including PALSAR-2 backscattering coefficients (HH, HV), terrain and climate by using this sample set were further explored to post-process the SVM output. The average accuracy of oil palm type is better than 80% in the final oil palm map for Malaysia.

  6. Will oil palm's homecoming spell doom for Africa's great apes?

    Science.gov (United States)

    Wich, Serge A; Garcia-Ulloa, John; Kühl, Hjalmar S; Humle, Tatanya; Lee, Janice S H; Koh, Lian Pin

    2014-07-21

    Expansion of oil palm plantations has led to extensive wildlife habitat conversion in Southeast Asia [1]. This expansion is driven by a global demand for palm oil for products ranging from foods to detergents [2], and more recently for biofuels [3]. The negative impacts of oil palm development on biodiversity [1, 4, 5], and on orangutans (Pongo spp.) in particular, have been well documented [6, 7] and publicized [8, 9]. Although the oil palm is of African origin, Africa's production historically lags behind that of Southeast Asia. Recently, significant investments have been made that will likely drive the expansion of Africa's oil palm industry [10]. There is concern that this will lead to biodiversity losses similar to those in Southeast Asia. Here, we analyze the potential impact of oil palm development on Africa's great apes. Current great ape distribution in Africa substantially overlaps with current oil palm concessions (by 58.7%) and areas suitable for oil palm production (by 42.3%). More importantly, 39.9% of the distribution of great ape species on unprotected lands overlaps with suitable oil palm areas. There is an urgent need to develop guidelines for the expansion of oil palm in Africa to minimize the negative effects on apes and other wildlife. There is also a need for research to support land use decisions to reconcile economic development, great ape conservation, and avoiding carbon emissions.

  7. Microporous activated carbons prepared from palm shell by thermal activation and their application to sulfur dioxide adsorption.

    Science.gov (United States)

    Guo, Jia; Lua, Aik Chong

    2002-07-15

    Textural characterization of activated carbons prepared from palm shell by thermal activation with carbon dioxide (CO(2)) gas is reported in this paper. Palm shell (endocarp) is an abundant agricultural solid waste from palm-oil processing mills in many tropical countries such as Malaysia, Indonesia, and Thailand. The effects of activation temperature on the textural properties of the palm-shell activated carbons, namely specific surface area (BET method), porosity, and microporosity, were investigated. The activated carbons prepared from palm shell possessed well-developed porosity, predominantly microporosity, leading to potential applications in gas-phase adsorption for air pollution control. Static and dynamic adsorption tests for sulfur dioxide (SO(2)), a common gaseous pollutant, were carried out in a thermogravimetric analyzer and a packed column configuration respectively. The effects of adsorption temperature, adsorbate inlet concentration, and adsorbate superficial velocity on the adsorptive performance of the prepared activated carbons were studied. The palm-shell activated carbon was found to have substantial capability for the adsorption of SO(2), comparable to those of some commercial products and an adsorbent derived from another biomass.

  8. Fine tuning of process parameters for improving briquette production from palm kernel shell gasification waste.

    Science.gov (United States)

    Bazargan, Alireza; Rough, Sarah L; McKay, Gordon

    2017-05-05

    Palm kernel shell biochars (PKSB) ejected as residues from a gasifier have been used for solid fuel briquette production. With this approach, palm kernel shells can be used for energy production twice: first, by producing rich syngas during gasification; second, by compacting the leftover residues from gasification into high calorific value briquettes. Herein, the process parameters for the manufacture of PKSB biomass briquettes via compaction are optimized. Two possible optimum process scenarios are considered. In the first, the compaction speed is increased from 0.5 to 10 mm/s, the compaction pressure is decreased from 80 Pa to 40 MPa, the retention time is reduced from 10 s to zero, and the starch binder content of the briquette is halved from 0.1 to 0.05 kg/kg. With these adjustments, the briquette production rate increases by more than 20-fold; hence capital and operational costs can be reduced and the service life of compaction equipment can be increased. The resulting product satisfactorily passes tensile (compressive) crushing strength and impact resistance tests. The second scenario involves reducing the starch weight content to 0.03 kg/kg, while reducing the compaction pressure to a value no lower than 60 MPa. Overall, in both cases, the PKSB biomass briquettes show excellent potential as a solid fuel with calorific values on par with good-quality coal. CHNS: carbon, hydrogen, nitrogen, sulfur; FFB: fresh fruit bunch(es); HHV: higher heating value [J/kg]; LHV: lower heating value [J/kg]; PKS: palm kernel shell(s); PKSB: palm kernel shell biochar(s); POME: palm oil mill effluent; RDF: refuse-derived fuel; TGA: thermogravimetric analysis.

  9. Palm oil and the heart:A review

    Institute of Scientific and Technical Information of China (English)

    Osaretin; J; Odia; Sandra; Ofori; Omosivie; Maduka

    2015-01-01

    Palm oil consumption and its effects on serum lipid levels and cardiovascular disease in humans is still a subject of debate. Advocacy groups with varying agenda fuel the controversy. This update intends to identify evidence-based evaluations of the influence of palm oil on serum lipid profile and cardiovascular disease. Furthermore, it suggests a direction for future research. The sources of information were based on a Pub Med, Google Scholar, African Journal online and Medline search using key words including: palm oil, palmitic acid, saturated fatty acids and heart disease. Published animal and human experiments on the association of palm oil and its constituents on the serum lipid profile and cardiovascular disease were also explored for relevant information. These papers are reviewed and the available evidence is discussed. Most of the information in mainstream literature is targeted at consumers and food companies with a view to discourage the consumption of palm oil. The main argument against the use of palm oil as an edible oil is the fact that it contains palmitic acid, which is a saturated fatty acid and by extrapolation should give rise to elevated total cholesterol and low-density lipoprotein cholesterol levels. However, there are many scientific studies, both in animals and humans that clearly show that palm oil consumption does not give rise to elevated serum cholesterol levels and that palm oil is not atherogenic. Apart from palmitic acid, palm oil consists of oleic and linoleic acids which are monounsaturated and polyunsaturated respectively. Palm oil also consists of vitamins A and E, which are powerful antioxidants. Palm oil has been scientifically shown to protect the heart and blood vessels from plaques and ischemic injuries. Palm oil consumed as a dietary fat as a part of a healthy balanced diet does not have incremental risk for cardiovascular disease. Little or no additional benefit will be obtained by replacing it with other oils rich in

  10. Compressive Strength of Concrete Containing Palm Kernel Shell Ash

    Directory of Open Access Journals (Sweden)

    FADELE Oluwadamilola A

    2016-12-01

    Full Text Available This study examined the influence of varying palm kernel shell ash content, as supplementary cementitious material (SCM at specified water/cement ratios and curing ages on the compressive strength of concrete cubes samples. Palm kernel shell ash was used as a partial replacement for ordinary Portland cement (OPC up to 30% at 5% intervals using mix ratio 1:2:4. River sand with particles passing 4.75mmBS sieve and crushed aggregate of 20mm maximum size were used while the palm kernel shell ash used was ofparticles passing through 212μm BS sieve. The compressive strength of the test cubes (100mm were tested at 5 different curing ages of 3, 7, 14, 28 and 56 days. The result showed that test cube containing Palm kernel shell ash gained strength over a longer curing period compared with ordinary Portlandcement concrete samples and the strength varies with percentagePKSAcontent in the cube samples. The results showed that at 28 days test cubes containing 5%, 10%, 15%, 20%, 25% and 30% PKSA content achieved compressive strength of 26.1 MPa, 22.53MPa, 19.43 MPa, 20.43 MPa, 16.97 MPa and 16.5MPa compared to 29MPa of Ordinary Portland cement concrete cubes. It was concluded that for structural concrete works requiring a characteristic strength of 25Mpa,5% palm kernel shell ash can effectively replace ordinary Portland cement while up to 15% PKSA content can be used for concrete works requiring 20Mpa strength at 28 days

  11. Oil palm deserves government attention in Brazil

    Science.gov (United States)

    Moreira, José R.; Goldemberg, José

    2015-07-01

    Englund et al (2015 Environ. Res. Lett. 10 044002) have recently analyzed biodiesel production from oil palm plantations as one possible way to mitigate climate change while providing cost effective results. They show that data for detailed quantification of biological carbon sequestration is available allowing a high confidence evaluation of positive impacts when oil palm plantation for food and biodiesel production is carried out in degraded, cultivated soil, and also with some varieties of natural vegetation in the Amazon. Nevertheless, economic risk associated with the future price of fossil fuels and uncertainties related with carbon subsidy are barriers. Here we discuss the assumptions under which such controversial proposal is based and suggest further analysis for Brazilian decision makers.

  12. Modulation of human lipids and lipoproteins by dietary palm oil and palm olein: a review.

    Science.gov (United States)

    Sundram, K

    1997-03-01

    Several human clinical trials have now evaluated palm oil's effects on blood lipids and lipoproteins. These studies suggest that palm oil and palm olein diets do not raise plasma TC and LDL-cholesterol levels to the extent expected from its fatty acid composition. With maximum substitution of palm oil in a Western type diet some coronary heart disease risk factors were beneficially modulated: HDL2-cholesterol was significantly increased while the apolipoprotein B/A1 ratio was beneficially lowered by palm oil. Comparison of palm olein with a variety of monounsaturated edible oils including rapeseed, canola, and olive oils has shown that plasma and LDL-cholesterol were not elevated by palm olein. To focus these findings, specific fatty acid effects have been evaluated. Myristic acid may be the most potent cholesterol raising saturated fatty acid. Palmitic acid effects were largely comparable to the monounsaturated oleic acid in normolipidaemic subjects while trans fatty acids detrimentally increased plasma cholesterol, LDL-cholesterol, lipoprotein Lp(a) and lowered the beneficial HDL-cholesterol. Apart from these fatty acids there is evidence that the tocotrienols in palm oil products may have a hypocholesterolaemic effect. This is mediated by the ability of the tocotrienols to suppress HMG-CoA reductase. These new findings on palm oil merit a scientific reexamination of the classical saturated fat-lipid hypothesis and its role in lipoprotein regulation.

  13. PRODUCTION OF PALM OIL WITH METHANE AVOIDANCE AT PALM OIL MILL: A CASE STUDY OF CRADLE-TO-GATE LIFE CYCLE ASSESSMENT

    OpenAIRE

    Chiew Wei Puah; Yuen May Choo; Soon Hock Ong

    2013-01-01

    The study discusses a case study of cradle to gate life cycle assessment for the production of Crude Palm Oil (CPO) with methane avoidance at palm oil mill. The improved milling process enables total utilization of the oil palm fruit to produce alow oil palm based food source. The minimal modification in the mill includes cleaning of Fresh Fruit Bunches (FFB) and obtaining the low oil food source from the aqueous stream. The oil palm fruit processing plant enables the significant reduction of...

  14. Water footprints of products of oil palm plantations and palm oil mills in Thailand.

    Science.gov (United States)

    Suttayakul, Phetrada; H-Kittikun, Aran; Suksaroj, Chaisri; Mungkalasiri, Jitti; Wisansuwannakorn, Ruthairat; Musikavong, Charongpun

    2016-01-15

    The water footprint (WF) of fresh fruit bunches (FFBs) from oil palm plantations and crude palm oil (CPO) from palm oil mills in southern and eastern Thailand were determined over 25 years. Climatic conditions, soil characteristics, and the characteristics of oil palm growth were considered. The WF of FFBs was 1063 m(3)/ton (t) on average. Green, blue, and grey waters comprised of 68, 18, and 14% of total WF, respectively. The oil palm plantations in Thailand required smaller amounts of indirect blue water. The average WF for producing a ton of CPO of seven mills was 5083 m(3). Most of the waters used in the mills originated from indirect green, blue and grey waters from the plantations. The direct blue water used in the mills had less impact on the total WF, lower than 1% of the total WF. Average percentages of green, blue, and grey waters of 69, 16, and 15% of total WF were determined for the mills, respectively. The water deprivation of the FFBs and CPO ranged from 0.73-12.9 and 3.44-58.3 m(3)H2Oeq/t, respectively. In 2013, the CPO production in Thailand including green, blue, and grey waters from plantation and blue water from mills required 11,343 million m(3) water. If the oil palm variety Suratthani 7 is used in the plantation, it would increase the yield from 15.2 to 22.8 t FFBs/ha-year and decrease the WF to 888 m(3)/t FFBs. The average value of the oil extraction rate (OER) of mills was 18.1%. With an increase in the OER of 1%, a reduction of the WF of 250 m(3)/t CPO or 5.1% of total WF could be obtained.

  15. Feasibility study of gasification of oil palm fronds

    OpenAIRE

    Sulaiman, S. A.; S. Balamohan; M.N.Z. Moni; S.M. Atnaw; Mohamed, A O

    2015-01-01

    Considering the large and consistent supply, oil palm fronds could be a promising source of biomass energy through gasification. There is very scarce information on the characteristics of oil palm fronds, which is vital in deciding if such biomass is technically suitable for gasification. In the present work, the feasibility of oil palm fronds for biomass gasification is studied. The study is conducted experimentally via standard tests to determine their thermochemical characteristics. Ultim...

  16. Oil palm genetic improvement and sustainable development

    Directory of Open Access Journals (Sweden)

    Cochard Benoît

    2005-03-01

    Full Text Available Genetic improvement of the oil palm may have a role to play in the sustainability of this crop. Given the criticism aimed at this commodity chain, notably due to the extension of oil palm plantations to the detriment of forests, providing very high-yielding planting material might be a solution, particularly as world demand is continually increasing. This crop is mostly managed by agroindustrialists, but the smallholder sector is developing. It happens that this sector is classed as a sustainable type of agriculture by numerous NGOs, which are also asking plant breeders to take the specificities of smallholdings into consideration. Oil palm genetic improvement takes numerous criteria into account, many of which fit in with sustainable agriculture. For example, this crop is subject to pressure from different pests and diseases. In each case, a genetic hence eco-friendly approach has been taken and, in particular, vascular wilttolerant planting material has been a successfully produced. Moreover, for the future of this crop, planting material needs to be developed that requires fewer inputs, and consideration has to be given to extending this crop in less favourable zones, by developing planting material that consumes less water. Lastly, it is important to disseminate genetically diversified planting material.

  17. Oil palm natural diversity and the potential for yield improvement.

    Science.gov (United States)

    Barcelos, Edson; Rios, Sara de Almeida; Cunha, Raimundo N V; Lopes, Ricardo; Motoike, Sérgio Y; Babiychuk, Elena; Skirycz, Aleksandra; Kushnir, Sergei

    2015-01-01

    African oil palm has the highest productivity amongst cultivated oleaginous crops. Species can constitute a single crop capable to fulfill the growing global demand for vegetable oils, which is estimated to reach 240 million tons by 2050. Two types of vegetable oil are extracted from the palm fruit on commercial scale. The crude palm oil and kernel palm oil have different fatty acid profiles, which increases versatility of the crop in industrial applications. Plantations of the current varieties have economic life-span around 25-30 years and produce fruits around the year. Thus, predictable annual palm oil supply enables marketing plans and adjustments in line with the economic forecasts. Oil palm cultivation is one of the most profitable land uses in the humid tropics. Oil palm fruits are the richest plant source of pro-vitamin A and vitamin E. Hence, crop both alleviates poverty, and could provide a simple practical solution to eliminate global pro-vitamin A deficiency. Oil palm is a perennial, evergreen tree adapted to cultivation in biodiversity rich equatorial land areas. The growing demand for the palm oil threatens the future of the rain forests and has a large negative impact on biodiversity. Plant science faces three major challenges to make oil palm the key element of building the future sustainable world. The global average yield of 3.5 tons of oil per hectare (t) should be raised to the full yield potential estimated at 11-18t. The tree architecture must be changed to lower labor intensity and improve mechanization of the harvest. Oil composition should be tailored to the evolving needs of the food, oleochemical and fuel industries. The release of the oil palm reference genome sequence in 2013 was the key step toward this goal. The molecular bases of agronomically important traits can be and are beginning to be understood at the single base pair resolution, enabling gene-centered breeding and engineering of this remarkable crop.

  18. Oil palm natural diversity and the potential for yield improvement

    Science.gov (United States)

    Barcelos, Edson; Rios, Sara de Almeida; Cunha, Raimundo N. V.; Lopes, Ricardo; Motoike, Sérgio Y.; Babiychuk, Elena; Skirycz, Aleksandra; Kushnir, Sergei

    2015-01-01

    African oil palm has the highest productivity amongst cultivated oleaginous crops. Species can constitute a single crop capable to fulfill the growing global demand for vegetable oils, which is estimated to reach 240 million tons by 2050. Two types of vegetable oil are extracted from the palm fruit on commercial scale. The crude palm oil and kernel palm oil have different fatty acid profiles, which increases versatility of the crop in industrial applications. Plantations of the current varieties have economic life-span around 25–30 years and produce fruits around the year. Thus, predictable annual palm oil supply enables marketing plans and adjustments in line with the economic forecasts. Oil palm cultivation is one of the most profitable land uses in the humid tropics. Oil palm fruits are the richest plant source of pro-vitamin A and vitamin E. Hence, crop both alleviates poverty, and could provide a simple practical solution to eliminate global pro-vitamin A deficiency. Oil palm is a perennial, evergreen tree adapted to cultivation in biodiversity rich equatorial land areas. The growing demand for the palm oil threatens the future of the rain forests and has a large negative impact on biodiversity. Plant science faces three major challenges to make oil palm the key element of building the future sustainable world. The global average yield of 3.5 tons of oil per hectare (t) should be raised to the full yield potential estimated at 11–18t. The tree architecture must be changed to lower labor intensity and improve mechanization of the harvest. Oil composition should be tailored to the evolving needs of the food, oleochemical and fuel industries. The release of the oil palm reference genome sequence in 2013 was the key step toward this goal. The molecular bases of agronomically important traits can be and are beginning to be understood at the single base pair resolution, enabling gene-centered breeding and engineering of this remarkable crop. PMID:25870604

  19. Oil palm natural diversity and the potential for yield improvement

    Directory of Open Access Journals (Sweden)

    Edson eBarcelos

    2015-03-01

    Full Text Available African oil palm has the highest productivity amongst cultivated oleaginous crops. Species can constitute a single crop capable to fulfil the growing global demand for vegetable oils, which is estimated to reach 240 million tons by 2050. Two types of vegetable oil are extracted from the palm fruit on commercial scale. The crude palm oil and kernel palm oil have different fatty acid profiles, which increases versatility of the crop in industrial applications. Plantations of the current varieties have economic life-span around 25-30 years and produce fruits around the year. Thus, predictable annual palm oil supply enables marketing plans and adjustments in line with the economic forecasts. Oil palm cultivation is one of the most profitable land uses in the humid tropics. Oil palm fruits are the richest plant source of pro-vitamin A and vitamin E. Hence, crop both alleviates poverty, and could provide a simple practical solution to eliminate global pro-vitamin A deficiency. Oil palm is a perennial, evergreen tree adapted to cultivation in biodiversity rich equatorial land areas. The growing demand for the palm oil threatens the future of the rain forests and has a large negative impact on biodiversity. Plant science faces three major challenges to make oil palm the key element of building the future sustainable world. The global average yield of 3.5 tons of oil per hectare (t should be raised to the full yield potential estimated at 11-18t. The tree architecture must be changed to lower labor intensity and improve mechanization of the harvest. Oil composition should be tailored to the evolving needs of the food, oleochemical and fuel industries. The release of the oil palm reference genome sequence in 2013 was the key step towards this goal. The molecular bases of agronomically important traits can be and are beginning to be understood at the single base pair resolution, enabling gene-centered breeding and engineering of this remarkable crop.

  20. Poor prospects for avian biodiversity in Amazonian oil palm.

    Science.gov (United States)

    Lees, Alexander C; Moura, Nárgila G; de Almeida, Arlete Silva; Vieira, Ima C G

    2015-01-01

    Expansion of oil palm plantations across the humid tropics has precipitated massive loss of tropical forest habitats and their associated speciose biotas. Oil palm plantation monocultures have been identified as an emerging threat to Amazonian biodiversity, but there are no quantitative studies exploring the impact of these plantations on the biome's biota. Understanding these impacts is extremely important given the rapid projected expansion of oil palm cultivation in the basin. Here we investigate the biodiversity value of oil palm plantations in comparison with other dominant regional land-uses in Eastern Amazonia. We carried out bird surveys in oil palm plantations of varying ages, primary and secondary forests, and cattle pastures. We found that oil palm plantations retained impoverished avian communities with a similar species composition to pastures and agrarian land-uses and did not offer habitat for most forest-associated species, including restricted range species and species of conservation concern. On the other hand, the forests that the oil palm companies are legally obliged to protect hosted a relatively species-rich community including several globally-threatened bird species. We consider oil palm to be no less detrimental to regional biodiversity than other agricultural land-uses and that political pressure exerted by large landowners to allow oil palm to count as a substitute for native forest vegetation in private landholdings with forest restoration deficits would have dire consequences for regional biodiversity.

  1. Time series ARIMA models for daily price of palm oil

    Science.gov (United States)

    Ariff, Noratiqah Mohd; Zamhawari, Nor Hashimah; Bakar, Mohd Aftar Abu

    2015-02-01

    Palm oil is deemed as one of the most important commodity that forms the economic backbone of Malaysia. Modeling and forecasting the daily price of palm oil is of great interest for Malaysia's economic growth. In this study, time series ARIMA models are used to fit the daily price of palm oil. The Akaike Infromation Criterion (AIC), Akaike Infromation Criterion with a correction for finite sample sizes (AICc) and Bayesian Information Criterion (BIC) are used to compare between different ARIMA models being considered. It is found that ARIMA(1,2,1) model is suitable for daily price of crude palm oil in Malaysia for the year 2010 to 2012.

  2. IMPACT OF CPO EXPORT DUTIES ON MALAYSIAN PALM OIL INDUSTRY

    OpenAIRE

    Ibragimov Abdulla; Fatimah Mohamed Arshad; B. K. Bala; Kusairi Mohd Noh; Muhammad Tasrif

    2014-01-01

    In January 2013, Malaysia reduced the export duty structure to be in line with the Indonesia’s duty structure. Both countries export crude and processed palm oil. Since Malaysia and Indonesia are close competitors and they compete in the same market, a change in export duty rate in one country will affect the other. Indonesia, as the world’s biggest palm oil producer, has drastically widened the values between the crude palm oil and refined palm oil export taxes since October 2011...

  3. BIODIESEL FUELS FROM PALM OIL, PALM OIL METHYLESTER ...

    African Journals Online (AJOL)

    a

    energy source is renewable, it could reduce the risk of unavailability of fossil diesel and could to a large extent reduce pollution effects resulting from their wastes. ... engine and decline in diesel supply, there is need to produce vegetable oils ...

  4. Energetic Efficiency of red palm oil

    Directory of Open Access Journals (Sweden)

    Byron Jiménez

    2013-11-01

    Full Text Available The main goal of this paper is to determine the energy efficiency in the production of red palm oil (Elaeis guineensis by using the biophysical indicator EROI, postulated by the Ecological Economics. This indicator is applied to compare the energy used in the preparation of synthetic fertilizers (to fill its nutritional demands versus the energy contained in the oil. In 2009, there were 195.550 hectares of land planted with African palm in Ecuador (INEC, 2011. In addition, between 2002 and 2009, there were 2,7 million tons of red oil (FEDEPAL, 2010. It is determined that for each unit of energy consumed, 4.82 units of energy are contained in the red oil. The energy used in making pesticides for cultivation, consumed in transportation, refining, and post harvest is excluded because this other energy would drastically reduce the absolute data of the indicator, which is already inefficient for the high energy consumption it requires to generate the energy contained in the oil. On the other hand, agroecology has proven to be more efficient in the generation of energy per unit of invested energy (Altieri et. al., 2010; Moore, 2004.

  5. Comparative alteration in atherogenic indices and hypocholesteremic effect of palm oil and palm oil mill effluent in normal albino rats

    OpenAIRE

    Ajiboye, John A.; Erukainure, Ochuko L; Lawal, Babatunde A.; Nwachukwu, Viola A.; Tugbobo-Amisu, Adesewa O.; Okafor, Ebelechukwu N.

    2015-01-01

    The comparative hypocholesteremic effect of feeding palm oil and palm oil mill effluent (POME) was investigated in male albino rats. Diets were prepared and designed to contain 50% of energy as carbohydrate, 35% as fat, and 15% as protein. Groups of six rats were each fed one of these diets, while a group was fed pelletized mouse chow which served as the control. Feeding on palm oil and POME led to a significant increase (p 

  6. A Qualitative Approach of Identifying Major Cost Influencing Factors in Palm Oil Mills and the Relations towards Production Cost of Crude Palm Oil

    OpenAIRE

    2011-01-01

    Problem statement: The oil palm industry, which heavily depends on the world market, is an export oriented industry. Worlds palm oil consumption was growing over the years. In addition, Indonesia and Malaysia dominated the oil palm industry. The oil palm industry in Malaysia is very competitive and become one of the major economic sectors contributing to the total revenue of the country. In year 2009, there was a total of 22.40 million tons of oil palm products including p...

  7. Potential of palm oil utilisation in aquaculture feeds.

    Science.gov (United States)

    Ng, Wing-Keong

    2002-01-01

    One key ingredient used in the formulation of aquafeed is fish oil, which is produced from small marine pelagic fish and represents a finite fishery resource. At the present time, global fish oil production has reached a plateau and is not expected to increase beyond current levels. Recent estimates suggest that fish oils may be unable to meet demands from the rapidly growing aquaculture industry by as early as 2005. Therefore, there is currently great interest within the aquafeed industry in evaluating alternatives to fish oils. The ever-expanding oil palm cultivation in Malaysia and other tropical countries offers the possibility of an increased and constant availability of palm oil products for aquafeed formulation. Research into the use of palm oil in aquafeed begun around the mid-1990s and this review examines some of the findings from these studies. The use of palm oil in fish diets has generally shown encouraging results. Improved growth, feed efficiency, protein utilisation, reproductive performance and higher concentrations of alpha-tocopherol in fish fillets have been reported. Recent evidence for the ability of palm oil to substitute for fish oil in catfish diets is reviewed. The potential of palm oil use in aquafeed and future experimental directions are suggested. The aquaculture feed industry offers a great avenue to increase and diversify the use of palm oil-based products.

  8. Minimizing the biodiversity impact of Neotropical oil palm development.

    Science.gov (United States)

    Gilroy, James J; Prescott, Graham W; Cardenas, Johann S; Castañeda, Pamela González del Pliego; Sánchez, Andrés; Rojas-Murcia, Luis E; Medina Uribe, Claudia A; Haugaasen, Torbjørn; Edwards, David P

    2015-04-01

    Oil palm agriculture is rapidly expanding in the Neotropics, at the expense of a range of natural and seminatural habitats. A key question is how this expansion should be managed to reduce negative impacts on biodiversity. Focusing on the Llanos of Colombia, a mixed grassland-forest system identified as a priority zone for future oil palm development, we survey communities of ants, dung beetles, birds and herpetofauna occurring in oil palm plantations and the other principal form of agriculture in the region--improved cattle pasture--together with those of surrounding natural forests. We show that oil palm plantations have similar or higher species richness across all four taxonomic groups than improved pasture. For dung beetles, species richness in oil palm was equal to that of forest, whereas the other three taxa had highest species richness in forests. Hierarchical modelling of species occupancy probabilities indicated that oil palm plantations supported a higher proportion of species characteristic of forests than did cattle pastures. Across the bird community, occupancy probabilities within oil palm were positively influenced by increasing forest cover in a surrounding 250 m radius, whereas surrounding forest cover did not strongly influence the occurrence of other taxonomic groups in oil palm. Overall, our results suggest that the conversion of existing improved pastures to oil palm has limited negative impacts on biodiversity. As such, existing cattle pastures of the Colombian Llanos could offer a key opportunity to meet governmental targets for oil palm development without incurring significant biodiversity costs. Our results also highlight the value of preserving remnant forests within these agricultural landscapes, protecting high biodiversity and exporting avian 'spill-over' effects into oil palm plantations.

  9. Devolatilization studies of oil palm biomass for torrefaction process optimization

    Science.gov (United States)

    Daud, D.; Abd Rahman, A.; Shamsuddin, A. H.

    2013-06-01

    Torrefaction of palm biomass, namely Empty Fruit Bunch (EFB) and Palm Kernel Shell (PKS), was conducted using thermogravimetric analyser (TGA). The experiment was conducted in variation of temperatures of 200 °C, 260 °C and 300 °C at a constant residence time of 30 minutes. During the torrefaction process, the sample went through identifiable drying and devolatilization stages from the TGA mass loss. The percentage of volatile gases released was then derived for each condition referring to proximate analysis results for both biomass. It was observed an average of 96.64% and 87.53 % of the total moisture is released for EFB and PKS respectively. In all cases the volatiles released was observed to increase as the torrefaction temperature was increased with significant variation between EFB and PKS. At 300°C EFB lost almost half of its volatiles matter while PKS lost slightly over one third. Results obtained can be used to optimise condition of torrefaction according to different types of oil palm biomass.

  10. Mating Compatibility and Restriction Analysis of Ganoderma Isolates from Oil Palm and Other Palm Hosts.

    Science.gov (United States)

    Jing, Chan Jer; Seman, Idris Abu; Zakaria, Latiffah

    2015-12-01

    Mating compatibility and restriction analyses of Internal Transcribed Spacer (ITS) regions were performed to determine the relations between Ganoderma boninense, the most common species associated with basal stem rot in oil palm and Ganoderma isolates from infected oil palm, two ornamental palms, sealing wax palm (Cyrtostachys renda) and MacArthur palm (Ptychosperma macarthurii), an isolate from coconut stump (Cocos nucifera), Ganoderma miniatocinctum, Ganoderma zonatum and Ganoderma tornatum. The results showed that G. boninense was compatible with Ganoderma isolates from oil palm, G. miniatocinctum and G. zonatum, Ganoderma isolates from sealing wax palm, MacArthur palm and coconut stump. G. boninense was not compatible with G. tornatum. Therefore, the results suggested that the G. boninense, G. miniatocinctum, G. zonatum, and Ganoderma isolates from oil palm, ornamental palms and coconut stump could represent the same biological species. In performing a restriction analysis of the ITS regions, variations were observed in which five haplotypes were generated from the restriction patterns. An unweighted pair-group method with arithmetic averages (UPGMA) cluster analysis showed that all the Ganoderma isolates were grouped into five primary groups, and the similarity values of the isolates ranged from 97% to 100%. Thus, a restriction analysis of the ITS regions showed that G. boninense and the Ganoderma isolates from other palm hosts were closely related. On the basis of the mating compatibility test and the restriction analysis of the ITS regions performed in this study, a diverse group of Ganoderma species from oil palm and other palm hosts are closely related, except for G. tornatum and Ganoderma isolates from tea and rubber.

  11. Material-mass Balance of Smallholder Oil Palm Processing in the Niger Delta, Nigeria

    Directory of Open Access Journals (Sweden)

    Elijah I. Ohimain

    2013-03-01

    Full Text Available This study evaluates the material-mass balance of smallholder oil palm processing in Niger Delta Nigeria. Ten smallholder oil palm processing mills were randomly sampled. Measuring scale was used to measure the weight of the Fresh Fruit Bunch (FFB and all the processing intermediates/products including Threshed Fresh Fruit (TFF, Palm Pressed Fibre (PPF, Palm Kernel Shell (PKS, Empty Fruit Bunch (EFB, Crude Palm Oil (CPO, chaff and nut. During the study period (13-22 April 2012, 8 of the mills processed 90-400 bunches of Dura variety, while the remaining 2 mills processed 65-200 bunches of Tenera variety. During the batch processing of Dura variety, the proportion of the intermediate products computed in relation to the weight of the FFB (100% are as follows; TFF (66.0-75.0%, mesocarp (44.8-51.1%, nuts (19.0-27.5%, kernel (5.7-7.2%, water in mesocarp (9.0-12.1% and water in nut (2.4-3.4%, EFB (23.7-32.4%, chaff (0.8-2.4%, Palm Kernel Shell (PKS (10.0-18.8%, Palm Press Fibre (PPF (23.2-28.1% and Crude Palm Oil (CPO (9.4-12.8%. For the Tenera varieties, the compositions are as follows; TFF (70.9-72.9%, mesocarp (56.4-58.0%, nuts (14.5-14.9%, kernel (5.5-5.6%, water in mesocarp (10.1-10.4% and water in the nut (1.9-2.1%, EFB (25.7-28.2%, chaff (0.9-1.4%, PKS (6.8-7.5%, (19.1-20.3% and CPO (26.0-28.2%. This result shows that Tenera produces more oil and less wastes compared to the Dura variety. The solid wastes fractions are used as energy sources during the processing of oil palm and as filling materials for upgrading access roads to palm plantations. Except the huge volume of wastes (71.8-90.6% generated by smallholder oil palm processors is effectively utilized, the process will be unsustainable.

  12. Indonesia palm oil production without deforestation and peat conversion by 2050

    NARCIS (Netherlands)

    Afriyanti, Dian; Kroeze, Carolien; Saad, Asmadi

    2016-01-01

    Palm oil is a promising source of cooking oil and biodiesel. The demand for palm oil has been increasing worldwide. However, concerns exist surrounding the environmental and socio-economic sustainability of palm oil production. Indonesia is a major palm oil producing country. We explored scenario

  13. Indonesia palm oil production without deforestation and peat conversion by 2050

    NARCIS (Netherlands)

    Afriyanti, Dian; Kroeze, Carolien; Saad, Asmadi

    2016-01-01

    Palm oil is a promising source of cooking oil and biodiesel. The demand for palm oil has been increasing worldwide. However, concerns exist surrounding the environmental and socio-economic sustainability of palm oil production. Indonesia is a major palm oil producing country. We explored

  14. Variability and performance evaluation of introgressed Nigerian dura x Deli dura oil palm progenies.

    Science.gov (United States)

    Noh, A; Rafii, M Y; Mohd Din, A; Kushairi, A; Norziha, A; Rajanaidu, N; Latif, M A; Malek, M A

    2014-04-03

    Twelve introgressed oil palm (Elaeis guineensis) progenies of Nigerian dura x Deli dura were evaluated for bunch yield, yield attributes, bunch quality components and vegetative characters at the Malaysian Palm Oil Board Research Station, in Keratong, Pahang, Malaysia. Analysis of variance revealed significant to highly significant genotypic differences, indicating sufficient genetic variability among the progenies for bunch yield and its attributes, vegetative characters and bunch quality components, except fruit to bunch ratio. Fresh fruit bunch yield ranged from 167 kg·palm(-1)·year(-1) in PK1330 to 212 kg·palm(-1)·year(-1) in PK1351, with a mean yield of 192 kg·palm(-1)·year(-1). Among the progeny, PK1313 had the highest oil to bunch ratio (19.36%), due to its high mesocarp to fruit ratio, fruit to bunch ratio and low shell to fruit ratio. Among the progenies, PK1313 produced the highest oil yield of 31.4 kg·palm(-1)·year(-1), due to a high mesocarp to fruit ratio (61.2%) and a low shell to fruit ratio (30.7%), coupled with high fruit to bunch ratio (65.6%). PK1330 was found promising for selection, as it had desirable vegetative characters, including smaller petiole cross section (27.15 cm2), short rachis length (4.83 m), short palm height (1.85 m), and the lowest leaf number (164.6), as these vegetative characters are prerequisites for selecting palms for high density planting and high yield per hectare. The genetic variability among the progenies was found to be high, indicating ample scope for further breeding, followed by selection.

  15. Palm oil mill effluent treatment and utilization to ensure the sustainability of palm oil industries.

    Science.gov (United States)

    Hasanudin, U; Sugiharto, R; Haryanto, A; Setiadi, T; Fujie, K

    2015-01-01

    The purpose of this study was to evaluate the current condition of palm oil mill effluent (POME) treatment and utilization and to propose alternative scenarios to improve the sustainability of palm oil industries. The research was conducted through field survey at some palm oil mills in Indonesia, in which different waste management systems were used. Laboratory experiment was also carried out using a 5 m(3) pilot-scale wet anaerobic digester. Currently, POME is treated through anaerobic digestion without or with methane capture followed by utilization of treated POME as liquid fertilizer or further treatment (aerobic process) to fulfill the wastewater quality standard. A methane capturing system was estimated to successfully produce renewable energy of about 25.4-40.7 kWh/ton of fresh fruit bunches (FFBs) and reduce greenhouse gas (GHG) emissions by about 109.41-175.35 kgCO2e/tonFFB (CO2e: carbon dioxide equivalent). Utilization of treated POME as liquid fertilizer increased FFB production by about 13%. A palm oil mill with 45 ton FFB/hour capacity has potential to generate about 0.95-1.52 MW of electricity. Coupling the POME-based biogas digester and anaerobic co-composting of empty fruit bunches (EFBs) is capable of adding another 0.93 MW. The utilization of POME and EFB not only increases the added value of POME and EFB by producing renewable energy, compost, and liquid fertilizer, but also lowers environmental burden.

  16. Transesterification of Palm Oil for the Production of Biodiesel

    Directory of Open Access Journals (Sweden)

    Khalizani Khalid

    2011-01-01

    Full Text Available Problem statement: Palm oil is known as an important source of edible oil with significant values of renewable energy. Depletion of petroleum had captured much attention on producing biodiesel from the palm oil. Approach: The most concerning methods for the production of biodiesel were discussed, namely transesterification (alkali and acid, enzymetic approach and supercritical alcohol. Results: The results showed the vis-a-vis of the methods for possible consideration of research. Conclusion: Concerning the importance of this vegetable oil, the contribution of palm oil towards diminution of fossil fuel, possible methods for the production of biodiesel and the opportunity for the futures is very much important.

  17. Improving environmental sustainability of Thai palm oil production in 2050

    NARCIS (Netherlands)

    Saswattecha, Kanokwan; Kroeze, Carolien; Jawjit, Warit; Hein, Lars

    2017-01-01

    Palm oil production has increased in Thailand with considerable environmental impacts. The aim of this study is to analyse possibilities to examine how the environmental sustainability of Thai palm oil production can be improved in the coming decades. To this end, we integrated a sectoral and a l

  18. Functional palm oil-based margarine by enzymatic interesterification

    DEFF Research Database (Denmark)

    Ibrahim, Nuzul Amri Bin; Xu, Xuebing

    Palm stearin, palm kernel and fish oils were blended to a various composition ratios and enzymatically interesterified by Lipozyme TL IM lipase (Thermomyces lanuginosa) using a continuous packed bed reactor. The ratio of the oils ranged from 60-90%, 10-40% and 0-10% respectively. The enzyme was a...

  19. OIL PALM FIBERS AS PAPERMAKING MATERIAL: POTENTIALS AND CHALLENGES

    Directory of Open Access Journals (Sweden)

    Wan Rosli Wan Daud

    2011-02-01

    Full Text Available This paper reviews the physical and chemical characteristics of fibers from the stem, fronds, and empty fruit bunches of oil palm tree in relation to their papermaking properties. Challenges regarding the use of this nonwood material for papermaking are raised, and possible solutions to them are given. A vision for the complete utilization of oil palm biomass is also outlined.

  20. Palm Kernel Shells as a Dust Control Palliative on an Unpaved Road

    Directory of Open Access Journals (Sweden)

    Peter Ndoke NDOKE

    2006-07-01

    Full Text Available An assessment of the effectiveness of the use palm kernel shells as a dust control palliative on an unpaved road has been carried out. The palm kernel shells were able to reduce the quantity of dust generated from the road to about 75% a few days after the application. It was then suggested that with the absence of funds for road maintenance works organic materials like palm kernel shells could be used as palliatives.

  1. Recycled palm oil spoilage: Correlation between physicochemical properties and oleophilicity

    Science.gov (United States)

    Kadir, Ili Afiqa Ab; Zubairi, Saiful Irwan; Jurid, Lailatul Syema

    2016-11-01

    Palm oil is widely used for domestic and commercial frying due to its techno-economic advantages as compared to other vegetable oils. However, if the oil is used beyond its recommended usage cycle, it might lead to oil spoilage. Therefore this study focuses on the comprehensive analysis of chemical and physical properties of recycled palm oil. Recycled palm oil was prepared by frying potato strips up to 4 batches; 5 cycles for each batch) was carried out with potato (g)-to-oil (ml) ratio of 3/20 prior to physico-chemical analysis (moisture content, color measurement, viscosity, density and iodine value. From 5 tests used to indicate physico-chemical properties of recycled palm oil, only color measurement, viscosity and IV shows results accordingly to theories. Whereas moisture content and density were not comply to theories. With increasing frying times, recycled palm oil color has been darker due to chemical reaction that occurs during frying. The trend line illustrates that with increasing frying times, recycled palm oil lightness decreases. It also means that its color has been darker. Meanwhile, b* rate increase indicating that recycled palm oil show tendency towards green color. Whereas, a* rate decreased, showing low tendency towards red color. Viscosity and moisture content increase with frying cycle. This situation occurred might be due to formation of hydrolysis products which are volatile while frying process. But the remaining non-volatile compounds among the hydrolysis products might also accumulate in palm oil and thus affect the total oil/fat chemical changes. Meanwhile the density of palm oil was quite constant at 0.15 g/cm3 except for cycle 2 with 0.17 g/cm3. The result obtained from this experiment were comply with previous study that stated frying batch number is a significant variable (a = 0.05) affecting the density of oil only after 20 frying batch. The contact angle of recycled palm oil on PHBV thin film was more than 90 °. Hence it shows

  2. Collective action in a smallholder oil palm production system in Indonesia: The key to sustainable and inclusive smallholder palm oil?

    NARCIS (Netherlands)

    Jelsma, Idsert; Slingerland, Maja; Giller, Ken E.; Bijman, Jos

    2017-01-01

    Indonesian smallholder oil palm generally yield much less than corporate plantations. We analysed a smallholder oil palm production system in West Sumatra which outperformed its nucleus estate plantation, consistently producing yields far above the national average for over 25 years. Its

  3. KARAKTERISTIK MINYAK CAMPURAN RED PALM OIL DENGAN PALM KERNEL OLEIN (Characteristics of Oil Blends from Red Palm Oil and Palm Kernel Olein

    Directory of Open Access Journals (Sweden)

    Maria Ulfah

    2016-10-01

    Full Text Available Characteristics of oil blends has been produced from red palm oil (RPO and palm kernel olein (PKOo with seven ratios with a total of 100, namely A (0:100, B (25:75, C (40:60, D (50:50, E (60:40, F (75:25 and G (100:0 v/v investigated with randomized complete block design. The result showed that different of ratio levels RPO and PKOo have some effects on peroxide value, saponification value, melting point, cloud point and β-carotene content from RPO-PKOo oil blends, but has not effect on free fatty acid content. Higher level of PKOo content on formulas oil blends were decreased of saponification value and melting point, but was increased of cloud point. The best of RPOPKOo oil blends has been obtained at ratio 50:50 (v/v, with 459.52 ppm β-carotene, 1.35 meq/kg peroxide value, 0.09 % free fatty acid, 202.60 saponification value, 24.15 oC melting point and 7.15 oC cloud point. Fatty acids composition were 1.24 % capric acid, 29.00 % lauric acid, 10.09 % miristic acid, 23.10 % palmitic acid, 5.84 linoleic acid, 27.30 % oleic acid and 3.43 % stearic acid. Keywords: Red palm oil, palm kernel olein, oil blends, chemical and physical properties ABSTRAK Sifat-sifat minyak campuran yang dihasilkan dari red palm oil (RPO dan palm kernel olein (PKOo dengan tujuh tingkat rasio yang totalnya 100, yaitu A (0:100, B (25:75, C (40:60, D (50:50, E (60:40, F (75:25 dan G (100:0 (v/v dikaji menggunakan rancangan acak lengkap kelompok. Hasil penelitian menunjukkan bahwa rasio RPO:PKOo mempengaruhi angka peroksida, angka penyabunan, melting point, cloud point dan kadar β-karoten dari minyak campuran RPO-PKOo yang dihasilkan, namun tidak mempengaruhi kadar asam lemak bebas. Peningkatan jumlah PKOo yang ditambahkan dalam minyak campuran RPO-PKOo, akan menurunkan angka penyabunan dan melting point, namun akan menaikkan cloud point. Produk minyak campuran RPO-PKOo terbaik diperoleh pada rasio 50:50 (v/v, dengan kadar β-karoten 459,52 ppm, angka peroksida 1,35 meq

  4. Molecular defense response of oil palm to Ganoderma infection.

    Science.gov (United States)

    Ho, C-L; Tan, Y-C

    2015-06-01

    Basal stem rot (BSR) of oil palm roots is due to the invasion of fungal mycelia of Ganoderma species which spreads to the bole of the stem. In addition to root contact, BSR can also spread by airborne basidiospores. These fungi are able to break down cell wall components including lignin. BSR not only decreases oil yield, it also causes the stands to collapse thus causing severe economic loss to the oil palm industry. The transmission and mode of action of Ganoderma, its interactions with oil palm as a hemibiotroph, and the molecular defence responses of oil palm to the infection of Ganoderma boninense in BSR are reviewed, based on the transcript profiles of infected oil palms. The knowledge gaps that need to be filled in oil palm-Ganoderma molecular interactions i.e. the associations of hypersensitive reaction (HR)-induced cell death and reactive oxygen species (ROS) kinetics to the susceptibility of oil palm to Ganoderma spp., the interactions of phytohormones (salicylate, jasmonate and ethylene) at early and late stages of BSR, and cell wall strengthening through increased production of guaiacyl (G)-type lignin, are also discussed.

  5. Exploring Opportunities for Sustainability in the Malaysian Palm Oil Industry

    DEFF Research Database (Denmark)

    Padfield, Rory; Hansen, Sune Balle; Preece, Christopher

    2011-01-01

    The global thirst for vegetable oil can be regarded as one of the greatest environmental challenges of the 21st Century and interest has intensified with the prospect of biofuels. Palm oil has risen to become the dominant player on the vegetable oil market – and the main recipient of environmental...... scrutiny. Focusing specifically on the Malaysian context, this paper analyses the major environmental, social and economic impacts associated with palm oil production. Drawing on recently published research, publicly available data and a comparison made with a recent sustainability initiative undertaken...... by the hydropower industry – an equally controversial and highly scrutinised sector – it is argued that the full extent of the impacts of palm oil should be acknowledged by those on both sides of the debate. Moreover, it is argued that by moving towards a less polarised version of the palm oil narrative and one...

  6. The Factors Influencing on Consumption of Palm Cooking Oil in Indonesia

    OpenAIRE

    Ermy Teti; Sakti Hutabarat; Asriati Nofionna

    2011-01-01

    Cooking oil is one of the most sensitive basic needs in Indonesia. The aims of the researchare to analyze factors influencing consumption of cooking oil, the cooking oil price, and theCrude Palm Oil price in Indonesia. Using simultaneous equation model, the study show thatpalm cooking oil consumption is significantly affected by domestic palm cooking oil priceand number of population. Whilst palm cooking oil price is significantly influenced by thecooking palm oil production and the domestic ...

  7. Nutritional imbalance in smallholder oil palm plantations in Indonesia

    NARCIS (Netherlands)

    Woittiez, L.S.

    2017-01-01

    Oil palm (Elaeis guineensis Jacq.) is an exceptionally efficient producer of vegetable oil. Its potential production is estimated to
    be well over 10 tons of oil per hectare per year, at least three times more than the second most efficient vegetable oil producer,
    canola. The cultivation of

  8. Utilization of waste crab shell (Scylla serrata) as a catalyst in palm olein transesterification.

    Science.gov (United States)

    Boey, Peng-Lim; Maniam, Gaanty Pragas; Hamid, Shafida Abd

    2009-01-01

    Aquaculture activity has increased the population of crab, hence increasing the generation of related wastes, particularly the shell. In addition, the number of molting process in crabs compounds further the amount of waste shell generated. As such, in the present work, the application of the waste crab shell as a source of CaO in transesterification of palm olein to biodiesel (methyl ester) was investigated. Preliminary XRD results revealed that thermally activated crab shell contains mainly CaO. Parametric study has been investigated and optimal conditions were found to be methanol/oil mass ratio, 0.5:1; catalyst amount, 4 wt. %; and reaction temperature, 338 K. As compared to laboratory CaO, the catalyst from waste crab shell performs well, thus creating another low-cost catalyst source for producing biodiesel as well as adding value to the waste crab shell. Reusability of crab shell CaO has also been studied and the outcome confirmed that the catalyst is capable to be reutilized up to 11 times, without any major deterioration.

  9. The hidden carbon liability of Indonesian palm oil

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2008-05-15

    This report highlights the urgent need for global palm oil consumers and investors to support Unilever's call for an immediate moratorium on deforestation and peatland clearance in Indonesia. This report focuses on Unilever, which shares major institutional investors with other leading corporations including Nestle, Procter and Gamble and Kraft. Not only do these corporations share investors, they also share growing carbon liability within their raw material supply chains through the expansion in the palm oil sector in Indonesia. Unilever has recognised the global problems associated with palm oil expansion and the need for drastic reform to this sector. Unilever has taken a bold move in calling for an immediate moratorium on deforestation and peatland clearance. While Unilever's position is strengthened by its status as the largest palm oil consumer in the world, this report shows how, unless companies like Nestle, Procter and Gamble and Kraft support its call for a halt to deforestation, the palm oil industry will continue to present a massive carbon liability over the coming years. This report uses Unilever's palm oil supply chains as a case study to help quantify the carbon liability and collateral risks associated with the Indonesian palm oil sector. It shows how, by buying palm oil from suppliers who account for more than one-third of Indonesia's palm oil production, Unilever and its competitors are increasing their potential carbon liability and thus leaving investors exposed to potentially significant levels of hidden risk, compromising long-term financial and brand stability.

  10. The Feasibility of Palm Kernel Shell as a Replacement for Coarse Aggregate in Lightweight Concrete

    Science.gov (United States)

    Itam, Zarina; Beddu, Salmia; Liyana Mohd Kamal, Nur; Ashraful Alam, Md; Issa Ayash, Usama

    2016-03-01

    Implementing sustainable materials into the construction industry is fast becoming a trend nowadays. Palm Kernel Shell is a by-product of Malaysia’s palm oil industry, generating waste as much as 4 million tons per annum. As a means of producing a sustainable, environmental-friendly, and affordable alternative in the lightweight concrete industry, the exploration of the potential of Palm Kernel Shell to be used as an aggregate replacement was conducted which may give a positive impact to the Malaysian construction industry as well as worldwide concrete usage. This research investigates the feasibility of PKS as an aggregate replacement in lightweight concrete in terms of compressive strength, slump test, water absorption, and density. Results indicate that by using PKS for aggregate replacement, it increases the water absorption but decreases the concrete workability and strength. Results however, fall into the range acceptable for lightweight aggregates, hence it can be concluded that there is potential to use PKS as aggregate replacement for lightweight concrete.

  11. A Qualitative Approach of Identifying Major Cost Influencing Factors in Palm Oil Mills and the Relations towards Production Cost of Crude Palm Oil

    Directory of Open Access Journals (Sweden)

    Elaine L.Y. Man

    2011-01-01

    Full Text Available Problem statement: The oil palm industry, which heavily depends on the world market, is an export oriented industry. Worlds palm oil consumption was growing over the years. In addition, Indonesia and Malaysia dominated the oil palm industry. The oil palm industry in Malaysia is very competitive and become one of the major economic sectors contributing to the total revenue of the country. In year 2009, there was a total of 22.40 million tons of oil palm products including palm oil, palm kernel oil, palm kernel cake, oleo-chemicals and finished products, equivalent to RM 49.59 billion of export revenue. However, cost of production for Crude Palm Oil (CPO varies in a big gap. Therefore, it is essential to identify the major cost influencing factors in the production of CPO. Approach: The study system started with collection of Fresh Fruits Bunches (FFB from oil palm plantation to the production of CPO at palm oil mills. Two palm oil mills of different production capacity were chosen for this study. Statistical analysis was done to identify the major cost influencing factors of production cost for CPO. Results: The production cost of CPO for small scale palm oil mills preferably lied between RM 45 to RM 50 per metric tons while large scale palm oil mills lied below RM 45 per metric tons. Conclusion: Palm oil mills with higher production capacity were efficient in producing CPO than lower production capacity palm oil mills. Thus, the production cost of CPO was lower compared to that of small scale palm oil mills.

  12. Cogeneration potential in the Columbian palm oil industry: Three case studies

    Energy Technology Data Exchange (ETDEWEB)

    Teixeira, F.N.; Lora, E. [Federal University of Itajuba/Excellence Group in Thermal and Distributed Generation, Itajuba-MG (Brazil); Yanez, E. [CENIPALMA (Colombia); Castillo, E. [UIS, (Colombia); Arrieta, F.R.P.

    2007-07-15

    The palm oil mills are characterized by the availability of considerable amounts of by-products of high-energy value such as empty fruit bunches (EFB), fibers, shells and liquid effluents with high content of organics called palm oil mill effluent (POME). A palm oil mill produces residues equivalent to almost three times the amount of oil produced by biomass, showing a huge potential for increasing the power efficiency of the plants and installed power, mainly by the use of by-products in cogeneration plants with high steam parameters and by reducing steam consumption in process. The objective of this paper is to present the results of the study about the cogeneration potential for three representative palm oil mills located in two important palm oil producing regions in Colombia (South-America), fifth palm oil producers of the world. The sizing of the cogeneration system was made assuming it operation during the greatest possible number of hours throughout the year (based on the seasonal availability of fruit) considering parameters for the steam at 2 MPa and 350 C, using a condensing-extraction turbine. The balance of mass and energy was made by using the Gate Cycle Enter Software, version 5.51, to estimate the potential of electricity generation. The results showed that for fresh fruit bunch (FFB) processing capacities between 18 and 60 t FFB h{sup -1}, it is possible to have surplus power ranging between 1 and 7 MW, if the plants are self-sufficient in electric energy and steam for process. With an average Capacity Factor (approximately 0.4), it is possible to expect a generation index of 75 and 160 kWh t{sup -1} FFB when the processing plant is operating or shutdown, respectively, 3 or 4 times better than when a traditional system with a back-pressure steam turbines is used. This analysis used up to 60% of EFB produced in plant as fuel, considering its value as fertilizer for the palm crop. Several economic conditions were considered to estimate the economic

  13. PRODUCTION OF PALM OIL WITH METHANE AVOIDANCE AT PALM OIL MILL: A CASE STUDY OF CRADLE-TO-GATE LIFE CYCLE ASSESSMENT

    Directory of Open Access Journals (Sweden)

    Chiew Wei Puah

    2013-01-01

    Full Text Available The study discusses a case study of cradle to gate life cycle assessment for the production of Crude Palm Oil (CPO with methane avoidance at palm oil mill. The improved milling process enables total utilization of the oil palm fruit to produce alow oil palm based food source. The minimal modification in the mill includes cleaning of Fresh Fruit Bunches (FFB and obtaining the low oil food source from the aqueous stream. The oil palm fruit processing plant enables the significant reduction of Greenhouse Gas (GHG such as methane and carbon dioxide emissions by avoiding the formation of liquid biomass in the form of Palm Oil Mill Effluent (POME. The attributional Life Cycle Assessment (LCA shows the improved milling process contributes to significant reduction of GHG emission from palm oil mills as compared to the process of capturing biogas from POME. The palm based food source contains phytonutrients, namely carotenoids, tocols (tocopherol and tocotrienols and water soluble polyphenols.

  14. Palm oil: a healthful and cost-effective dietary component.

    Science.gov (United States)

    Ong, A S H; Goh, S H

    2002-03-01

    Palm oil is an excellent choice for food manufacturers because of its nutritional benefits and versatility. The oil is highly structured to contain predominantly oleic acid at the sn2-position in the major triacylglycerols to account for the beneficial effects described in numerous nutritional studies. Oil quality and nutritional benefits have been assured for the variety of foods that can be manufactured from the oil directly or from blends with other oils while remaining trans-free. The oxidative stability coupled with the cost-effectiveness is unparalleled among cholesterol-free oils, and these values can be extended to blends of polyunsaturated oils to provide long shelf-life. Presently the supply of genetic-modification-free palm oil is assured at economic prices, since the oil palm is a perennial crop with unparalleled productivity. Numerous studies have confirmed the nutritional value of palm oil as a result of the high monounsaturation at the crucial 2-position of the oil's triacylglycerols, making the oil as healthful as olive oil. It is now recognized that the contribution of dietary fats to blood lipids and cholesterol modulation is a consequence of the digestion, absorption, and metabolism of the fats. Lipolytic hydrolysis of palm oil glycerides containing predominantly oleic acid at the 2 position and palmitic and stearic acids at the 1 and 3 positions allows for the ready absorption of the 2-monoacrylglycerols while the saturated free fatty acids remain poorly absorbed. Dietary palm oil in balanced diets generally reduced blood cholesterol, low-density lipoprotein (LDL) cholesterol, and triglycerides while raising the high-density lipoprotein (HDL) cholesterol. Improved lipoprotein(a) and apo-A1 levels were also demonstrated from palm oil diets; an important benefits also comes from the lowering of blood triglycerides (or reduced fat storage) as compared with those from polyunsaturated fat diets. Virgin palm oil also provides carotenes apart from

  15. Comparison of Acoustic Characteristics of Date Palm Fibre and Oil Palm Fibre

    Directory of Open Access Journals (Sweden)

    Lamyaa Abd ALRahman

    2014-02-01

    Full Text Available This study investigated and compared the acoustic characteristics of two natural organic fibres: date palm fibre and oil palm fibre, these materials eligible for acoustical absorption. During the processing stage, both fibre sheets are treated with latex. The two fibres are compressed after latex treatment Circular samples (100 mm in diameter and 28 mm, based on the measurement tube requirements are cut out of the sheets. The density of the date palm fibre sheet is 150 kg/m3 for a 50 mm thickness and 130 kg/m3 for a 30 mm thickness. In contrast, the density of oil palm fibre is 75 kg/m3 for a 50 mm thickness and 65 kg/m3 for a 30 mm thickness. An impedance tube was used to test the thicknesses of both samples based on international standards. The results show that the date palm fibre exhibits two Acoustic Absorption Coefficient (AAC peaks: 0.93 at 1356 Hz and 0.99 at 4200-4353 Hz for the 50-mm-thick sample. In contrast, the 30-mm-thick sample has a single AAC peak of 0.83 at 2381.38-2809.38 Hz. However, the 50-mm-thick oil palm fibre has an AAC peak of 0.75 at 1946.88-2178.13 Hz and the 30-mm-thick oil palm fibre has an acoustic absorption coefficient peak 0.59 at 3225-3712.5 Hz. Thus, the date palm fibre has a higher acoustic absorption coefficient for high and low frequencies than does oil palm fibre. Both fibres are promising for use as sound absorber materials to protect against environmental noise pollution.

  16. Isothermal Crystallization Kinetics of Palm Oil with Additives

    Directory of Open Access Journals (Sweden)

    N. Su

    2015-04-01

    Full Text Available This study investigates the isothermal crystallization kinetics of palm oil with additives by Differential Scanning Calorimetry (DSC. The induction time of nucleation and crystallization are obtained by simulating the crystal process using the Gompertz model. The equilibrium melting temperature is obtained via the Hoffman-Weeks methods. The Gibbs free energy of nucleation was calculated by using the Fisher-Turnbull equation and the equilibrium melting temperature. The results indicate that the span 85 has an inhibition effect on nucleation and crystallization kinetics of palm oil. The span 85 can raise the equilibrium melting temperature of palm oil. The span 85 can obviously delay the induction time of nucleation and crystallization at 0.01 and 0.1% level. Although span 85 at 0.05% concentration level also can delay the induction time, it exhibits an effect of promoting nucleation. However, the crystal is uncomplicated in the system containing additives compared to the pure palm oil.

  17. How Unilever palm oil suppliers are burning up Borneo

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2008-04-15

    New evidence shows expansion by Unilever palm oil suppliers is driving species extinction in Central Kalimantan, and fuelling climate change. In November 2007, Greenpeace released 'Cooking the Climate', an 82-page report summarizing the findings of a two-year investigation that revealed how the world's largest food, cosmetic and biofuel companies were driving the wholesale destruction of Indonesia's rainforests and peatlands through growing palm oil consumption. This follow-up report provides further evidence of the expansion of the palm oil sector in Indonesia into remaining rainforests, orang-utan habitat and peatlands in Kalimantan. It links the majority of the largest producers in Indonesia to Unilever, probably the largest palm oil corporate consumer in the world.

  18. MIX DESIGN FOR OIL-PALM-BOILER CLINKER (OPBC) CONCRETE

    African Journals Online (AJOL)

    DEPT OF AGRICULTURAL ENGINEERING

    Keywords: Oil-Palm-Boiler Clinker (OPBC), Solid Waste, Mix Design, Lightweight Concrete, ... pality. These solid wastes and by-products, ... alternative to the conventional concrete materi- ... to produce steam to generate electricity for the.

  19. Accelerated in vitro propagation of elite oil palm genotypes (Elaeis ...

    African Journals Online (AJOL)

    Usuario

    2016-12-14

    Dec 14, 2016 ... published, since researches are conducted by companies with commercial interests ..... Corley RHV, Lee CH, Law IH, Wong CY (1986). Abnormal flower ... Clones with High Bunch Index for Recloning at Malaysian Palm Oil.

  20. Oil palm plantation effects on water quality in Kalimantan, Indonesia

    Science.gov (United States)

    Carlson, K. M.; Curran, L. M.

    2011-12-01

    Global demand for palm oil has stimulated a 7-fold increase in oil palm (Elaeis guineensis) plantation area in Indonesia since 1990. Expansion will continue as Indonesia plans to double current production by 2020. Oil palm fertilizers, effluent from oil palm mills, and erosion from land clearing and roads threaten river water quality near plantations. These rivers provide essential ecosystem services including water for drinking, cooking, and washing. Robust empirical measurements of plantation expansion impacts on water resources are necessary to discern the effects of agribusiness on local livelihoods and ecosystems. In Ketapang District, West Kalimantan, Indonesian Borneo, we evaluated the effects of land cover change on water quality by assessing water chemistry in streams draining four end-member watersheds ( ~600-1900 ha watershed-1): Logged forest, mixed agro-forest dominated by rubber and upland rice fallows, young oil palm forest (0-5 years), and old oil palm forest (10-15 years). To assess land cover change, we used CLASLite software to derive fractional cover from a time series (1989-2008) of Landsat data. Nearest neighbor classification and post-classification change detection yielded classes including primary forest, logged forest, secondary forest regrowth, smallholder agriculture, and oil palm. Stream water quality (temperature, dissolved oxygen, turbidity, optical chlorphyll, and pH) and quantity (discharge) were quantified with the YSI 6600-V2 sonde. The sonde was deployed in each stream for month-long intervals 2-3 times from 2009-2010. Such extended deployment captures episodic events such as intense storms and allows examination of interdiel dynamics by sampling continuously and at high frequency, every 10 minutes. We find that across the Ketapang District study region (~12,000 km2), oil palm has cleared mostly forests (49%) and agroforests (39%). What are the impacts of such land cover changes on water quality? Compared to forests and

  1. The Kalimantan Border Oil Palm Mega-project

    Energy Technology Data Exchange (ETDEWEB)

    Wakker, E. [AIDEnvironment, Amsterdam (Netherlands)

    2006-04-15

    A few years ago, the Indonesian government and sections of the palm oil industry united in the Indonesian Palm Oil Commission (IPOC) to undertake efforts to restore the atrocious public image that the palm oil industry had earned abroad for its role in the demise of Indonesia's tropical rainforests, the massive forest fires and haze in 1997-1998, and for the widespread conflicts between plantation companies and local communities. If IPOC succeeded in restoring the palm oil industry's image abroad, it was shattered again after June 2005 when the Indonesian Minister of Agriculture revealed details of a government plan to develop the world's largest oil palm plantation in a 5-10 kilometer band along the border of Kalimantan and Malaysia. To finance the USD 567 million plantation project, the Indonesian President and Chamber of Commerce and Industry (KADIN) had already met up with the Chinese government and private sector several times, resulting in Memoranda of Understanding between (among other) the Artha Graha and Sinar Mas groups from Indonesia and the Chinese CITIC group and Chinese Development Bank (CDB). The oil palm mega-project, launched in Indonesia under the banner of 'bringing prosperity, security and environmental protection to the Kalimantan border area', turned sour when a business plan developed by the Indonesian State Plantation Corporation (PTPN) began to circulate. This document contained a map that showed beyond doubt how the 1.8 million hectare oil palm project would trash the primary forests of three National Parks, cut through rugged slopes and mountains utterly unsuitable for oil palm cultivation and annihilate the customary rights land of the indigenous Dayak communities in the border area. This report describes what has come of the Kalimantan border oil palm mega-plan since it was announced, who is involved and what research, lobby and campaigning has led to so far. In particular, this study aims to inform civil

  2. Cultivation of oyster mushroom (Pleurotus ostreatus on oil palm residues

    Directory of Open Access Journals (Sweden)

    Tongwised, A.

    2001-11-01

    Full Text Available This study is aimed to use oil palm residues to cultivate the oyster mushroom, Pleurotus ostreatus, which is one of the most important mushrooms cultivated worldwide. Spawn was prepared on sorghum seeds and inoculated on substrate in plastic bags. Oil palm fronds were cut and used to grow Pleurotus ostreatus. The first fructification occurred 20 days after waterring. The biological efficiency reached at 28.6%. When sawdust of para rubber logs was added to the cut oil palm fronds at the rate of 1:1 (vol : vol., the biological efficiency reached at 39.3%.Supplementary material at the rate of 5% was also added into the combination of cut oil palm frond and sawdust. The result showed that rice bran, corn meal or oil palm-kernel meal give yields between 142.2-165.0 g/bag (B.E. = 42.8-49.6, which were not statistically different. Oil palm pericarp waste was also used as main substrate for P. ostreatus cultivation. The average yield obtained during 40 days havesting period was 112.6 g/bag (B.E. = 64.3%. Addition of sawdust or rice bran into pericarp waste decreased the yield of the basidiocarps. Palm-kernel meal at the rate of 5-20% was used as a supplement material. Addition of 20% palmkernel meal into sawdust supported higher yield. The biological efficiency reached 55.8%. From the above results, four formulae of the substrate were prepared. Treatment of oil palm pericarp waste + 3% rice bran + 3% corn meal + 0.75% Ca(OH2 supported higher yield of the basidiocarps. The average yield obtained from 950 g of substrate was 190.2 g during 60 days havesting (B.E. = 57.2%. Using 6% palm-kernel substitute 3% rice bran + 3% corn meal supported the same yield (B.E. = 56.2% Using sawdust as the main substrate, the yield achieved was less than that obtained with oil palm pericarp waste. The average yield from treatment of sawdust + 3% rice bran + 3% corn meal + 0.75% Ca (OH2 was 154.0 g/bag (B.E. = 46.3% while treatment of sawdust + 6% palm-kernel meal + 0

  3. Oil palm expansion in Indonesia : serving people, planet and profit?

    OpenAIRE

    Susanti, A.

    2016-01-01

    This study aimed to provide a more holistic understanding of how drivers at various levels interplay and continue to feed the expansion of oil palm plantations with its associated land use/cover change (LUCC) particularly deforestation, local economic development and people’s livelihoods. Recent studies suggested that the underlying causes and drivers of deforestation lie beyond the forest and forestry sector. The expansion of oil palm plantations in Indonesia has severely influenced the LUCC...

  4. Utilization of Palm Oil Clinker as Cement Replacement Material

    Directory of Open Access Journals (Sweden)

    Jegathish Kanadasan

    2015-12-01

    Full Text Available The utilization of waste materials from the palm oil industry provides immense benefit to various sectors of the construction industry. Palm oil clinker is a by-product from the processing stages of palm oil goods. Channelling this waste material into the building industry helps to promote sustainability besides overcoming waste disposal problems. Environmental pollution due to inappropriate waste management system can also be drastically reduced. In this study, cement was substituted with palm oil clinker powder as a binder material in self-compacting mortar. The fresh, hardened and microstructure properties were evaluated throughout this study. In addition, sustainability component analysis was also carried out to assess the environmental impact of introducing palm oil clinker powder as a replacement material for cement. It can be inferred that approximately 3.3% of cement production can be saved by substituting palm oil clinker powder with cement. Reducing the utilization of cement through a high substitution level of this waste material will also help to reduce carbon emissions by 52%. A cleaner environment free from pollutants can be created to ensure healthier living. Certain industries may benefit through the inclusion of this waste material as the cost and energy consumption of the product can be minimized.

  5. Oil palm for biodiesel in Brazil—risks and opportunities

    Science.gov (United States)

    Englund, Oskar; Berndes, Göran; Persson, U. Martin; Sparovek, Gerd

    2015-04-01

    Although mainly used for other purposes, and historically mainly established at the expense of tropical forests, oil palm can be the most land efficient feedstock for biodiesel. Large parts of Brazil are suitable for oil palm cultivation and a series of policy initiatives have recently been launched to promote oil palm production. These initiatives are however highly debated both in the parliament and in academia. Here we present results of a high resolution modelling study of opportunities and risks associated with oil palm production for biodiesel in Brazil, under different energy, policy, and infrastructure scenarios. Oil palm was found to be profitable on extensive areas, including areas under native vegetation where establishment would cause large land use change (LUC) emissions. However, some 40-60 Mha could support profitable biodiesel production corresponding to approximately 10% of the global diesel demand, without causing direct LUC emissions or impinging on protected areas. Pricing of LUC emissions could make oil palm production unprofitable on most lands where conversion would impact on native ecosystems and carbon stocks, if the carbon price is at the level 125/tC, or higher.

  6. Feasibility study of gasification of oil palm fronds

    Directory of Open Access Journals (Sweden)

    S.A. Sulaiman

    2015-12-01

    Full Text Available Considering the large and consistent supply, oil palm fronds could be a promising source of biomass energy through gasification. There is very scarce information on the characteristics of oil palm fronds, which is vital in deciding if such biomass is technically suitable for gasification. In the present work, the feasibility of oil palm fronds for biomass gasification is studied. The study is conducted experimentally via standard tests to determine their thermochemical characteristics. Ultimate analysis is conducted to determine the contents of carbon, nitrogen, hydrogen and sulphide in oil palm fronds. Proximate analysis is performed to identify the burning characteristics of the biomass. The energy content in the fronds is determined by using a bomb calorie meter and is around 18 MJ/kg. The ignitability of the fronds is also studied experimentally to assess the ease to start-up combustion of the fronds. The characteristics of the flame of the resulting syngas from gasification of oil palm fronds are qualitatively studied. Simulated syngas composition study reveals potentials of 22% CO, 1.3% H2, 18.5% CO2 and traces of CH4. The study is extended to computer simulation to predict composition of the syngas. It is found from this work that oil palm fronds are feasible for gasification and has a good potential as a renewable energy source.

  7. Predicting fresh fruit bunch yield of oil palm

    Directory of Open Access Journals (Sweden)

    Nilnond, C.

    2001-11-01

    Full Text Available This study aimed to develop the simulation model for predicting fresh fruit bunch (FFB yield of oil palm through multiple linear regression analysis. Two experiments were conducted at the oil palm plantation of Agricultural and Technology College, Krabi province. Six-year-old Tenera hybrid palms were used for the experiments. These palms were planted in Tha-sae soil series (Typic Paleudults; Fine loamy mixedwith spacing of 9x9x9 m. In the first experiment, 151 Tenera palms were selected and marked randomly throughout an area of plantation about 16 ha. For each selected palm, FFB yield and yield component characters (FFB number and bunch weight were recorded at every harvesting time for four consecutive years (June 1993 to May 1997. The results showed that the FFB number and bunch weight could be used to predict the FFB oil palm yield. In the second experiment, nine plots of Tenera hybrid palms were arranged. The plot size was 0.48 ha and had twenty palms per plot for data collection for three consecutive years (January 1994 to December 1996. These data included leaf nutrient (N, P, K, Mg and B contents in the 17th frond, the fresh fruit bunch (FFB yield and the amount of rainfall. The results showed that N, P, K, Mg and B contents in the leaves, the amount of rainfall and FFB yield in the previous year, together with the N, P, K, Mg and B contents in the leaves (in the predicting year could be used to predict the FFB oil palm yield.

  8. EXPERIMENTAL STUDY OF PALM OIL MILL EFFLUENT AND OIL PALM FROND WASTE MIXTURE AS AN ALTERNATIVE BIOMASS FUEL

    Directory of Open Access Journals (Sweden)

    S. HASSAN, L. S. KEE

    2013-12-01

    Full Text Available Palm oil mill effluent (POME sludge generated from palm oil mill industry and oil palm frond (OPF from oil palm plantation are considered biomass wastes that can be fully utilized as a renewable energy sources. In this study, an attempt has been made to convert these residues into solid biomass fuel. The study was conducted by developing experimental testing on the POME and OPF mixture. The performance of each sample with different weight percentage was investigated using standard tests. The biomass mixture was converted into compressed form of briquette through a simple process. The properties of the briquettes were observed and compared at different weight percentage following standard testing methods included ultimate and proximate analyses, burning characteristics, dimensional stability and crack analysis. Experimental results showed that POME sludge and OPF mixture is feasible as an alternative biomass fuel, with briquette of 90:10 POME sludge to OPF ratio has a good combination of properties as an overall.

  9. SSR mining in oil palm EST database: application in oil palm germplasm diversity studies

    Indian Academy of Sciences (India)

    Ngoot-Chin Ting; Noorhariza Mohd Zaki; Rozana Rosli; Eng-Ti Leslie Low; Maizura Ithnin; Suan-Choo Cheah; Soon-Guan Tan; Rajinder Singh

    2010-08-01

    This study reports on the detection of additional expressed sequence tags (EST) derived simple sequence repeat (SSR) markers for the oil palm. A large collection of 19243 Elaeis guineensis ESTs were assembled to give 10258 unique sequences, of which 629 ESTs were found to contain 722 SSRs with a variety of motifs. Dinucleotide repeats formed the largest group (45.6%) consisting of 66.9% AG/CT, 21.9% AT/AT, 10.9% AC/GT and 0.3% CG/CG motifs. This was followed by trinucleotide repeats, which is the second most abundant repeat types (34.5%) consisting of AAG/CTT (23.3%), AGG/CCT (13.7%), CCG/CGG (11.2%), AAT/ATT (10.8%), AGC/GCT (10.0%), ACT/AGT (8.8%), ACG/CGT (7.6%), ACC/GGT (7.2%), AAC/GTT (3.6%) and AGT/ACT (3.6%) motifs. Primer pairs were designed for 405 unique EST-SSRs and 15 of these were used to genotype 105 E. guineensis and 30 E. oleifera accessions. Fourteen SSRs were polymorphic in at least one germplasm revealing a total of 101 alleles. The high percentage (78.0%) of alleles found to be specific for either E. guineensis or E. oleifera has increased the power for discriminating the two species. The estimates of genetic differentiation detected by EST-SSRs were compared to those reported previously. The transferability across palm taxa to two Cocos nucifera and six exotic palms is also presented. The polymerase chain reaction (PCR) products of three primer-pairs detected in E. guineensis, E. oleifera, C. nucifera and Jessinia bataua were cloned and sequenced. Sequence alignments showed mutations within the SSR site and the flanking regions. Phenetic analysis based on the sequence data revealed that C. nucifera is closer to oil palm compared to J. bataua; consistent with the taxanomic classification.

  10. Ethyl ester production from (RBD palm oil

    Directory of Open Access Journals (Sweden)

    Oscar Mauricio Martínez Ávila

    2010-07-01

    Full Text Available This work develops a methodology for obtaining ethyl esters from RBD (refined, bleached and deodorised palm oil by evaluating the oil’s transesterification and separation. Two catalysts were first tested (KOH and NaOH by studying the effect of water presence on the reaction. The separation process was then evaluated by using water and water-salt and water-acid mixtures, establishing the agent offering the best results and carrying out the purification stage. Raw materials and products were characterised for comparing the latter with those obtained by traditional means and verifying the quality of the esters so produced; minimum differences were found bet-ween both. The proposed methodology thus allows esters to be used as raw material in petrochemical industry applications. A more profitable process can be obtained compared to those used today, given the amounts of separation agent so established (1% H3PO4 solution, in water. The overall process achieved 74.4% yield, based on the oil being used.

  11. Catalytic processes towards the production of biofuels in a palm oil and oil palm biomass-based biorefinery.

    Science.gov (United States)

    Chew, Thiam Leng; Bhatia, Subhash

    2008-11-01

    In Malaysia, there has been interest in the utilization of palm oil and oil palm biomass for the production of environmental friendly biofuels. A biorefinery based on palm oil and oil palm biomass for the production of biofuels has been proposed. The catalytic technology plays major role in the different processing stages in a biorefinery for the production of liquid as well as gaseous biofuels. There are number of challenges to find suitable catalytic technology to be used in a typical biorefinery. These challenges include (1) economic barriers, (2) catalysts that facilitate highly selective conversion of substrate to desired products and (3) the issues related to design, operation and control of catalytic reactor. Therefore, the catalytic technology is one of the critical factors that control the successful operation of biorefinery. There are number of catalytic processes in a biorefinery which convert the renewable feedstocks into the desired biofuels. These include biodiesel production from palm oil, catalytic cracking of palm oil for the production of biofuels, the production of hydrogen as well as syngas from biomass gasification, Fischer-Tropsch synthesis (FTS) for the conversion of syngas into liquid fuels and upgrading of liquid/gas fuels obtained from liquefaction/pyrolysis of biomass. The selection of catalysts for these processes is essential in determining the product distribution (olefins, paraffins and oxygenated products). The integration of catalytic technology with compatible separation processes is a key challenge for biorefinery operation from the economic point of view. This paper focuses on different types of catalysts and their role in the catalytic processes for the production of biofuels in a typical palm oil and oil palm biomass-based biorefinery.

  12. Development and Validation of a High-Density SNP Genotyping Array for African Oil Palm.

    Science.gov (United States)

    Kwong, Qi Bin; Teh, Chee Keng; Ong, Ai Ling; Heng, Huey Ying; Lee, Heng Leng; Mohamed, Mohaimi; Low, Joel Zi-Bin; Apparow, Sukganah; Chew, Fook Tim; Mayes, Sean; Kulaveerasingam, Harikrishna; Tammi, Martti; Appleton, David Ross

    2016-08-01

    High-density single nucleotide polymorphism (SNP) genotyping arrays are powerful tools that can measure the level of genetic polymorphism within a population. To develop a whole-genome SNP array for oil palms, SNP discovery was performed using deep resequencing of eight libraries derived from 132 Elaeis guineensis and Elaeis oleifera palms belonging to 59 origins, resulting in the discovery of >3 million putative SNPs. After SNP filtering, the Illumina OP200K custom array was built with 170 860 successful probes. Phenetic clustering analysis revealed that the array could distinguish between palms of different origins in a way consistent with pedigree records. Genome-wide linkage disequilibrium declined more slowly for the commercial populations (ranging from 120 kb at r(2) = 0.43 to 146 kb at r(2) = 0.50) when compared with the semi-wild populations (19.5 kb at r(2) = 0.22). Genetic fixation mapping comparing the semi-wild and commercial population identified 321 selective sweeps. A genome-wide association study (GWAS) detected a significant peak on chromosome 2 associated with the polygenic component of the shell thickness trait (based on the trait shell-to-fruit; S/F %) in tenera palms. Testing of a genomic selection model on the same trait resulted in good prediction accuracy (r = 0.65) with 42% of the S/F % variation explained. The first high-density SNP genotyping array for oil palm has been developed and shown to be robust for use in genetic studies and with potential for developing early trait prediction to shorten the oil palm breeding cycle.

  13. Palm oil based surfactant products for petroleum industry

    Science.gov (United States)

    Permadi, P.; Fitria, R.; Hambali, E.

    2017-05-01

    In petroleum production process, many problems causing reduced production are found. These include limited oil recovery, wax deposit, asphaltene deposit, sludge deposit, and emulsion problem. Petroleum-based surfactant has been used to overcome these problems. Therefore, innovation to solve these problems using surfactant containing natural materials deserves to be developed. Palm oil-based surfactant is one of the potential alternatives for this. Various types of derivative products of palm oil-based surfactant have been developed by SBRC IPB to be used in handling problems including surfactant flooding, well stimulation, asphaltene dissolver, well cleaning, and wax removal found in oil and gas industry.

  14. Palm olein oil produces less lipid peroxidation products than soya bean oil.

    Science.gov (United States)

    Zaiton, Z; Merican, Z; Khalid, B A; Mohamed, J B; Baharom, S

    1997-06-01

    The soleus muscles of hyperthyroid rats were used to investigate the effect of palm olein oil and soya bean oil on the production of lipid peroxidation products. It was found that palm olein oil but not soya bean oil significantly decreased malonaldehyde and conjugated diene levels of the soleus muscles of hyperthyroid rats. These findings suggest that palm olein per se produces less lipid peroxidation products than soya bean oil. Such an assay method gives a composite net picture of the propensity of an oil to produce lipid peroxidation products.

  15. Catalytic pyrolysis of palm kernel shell waste in a fluidized bed.

    Science.gov (United States)

    Kim, Sung Won; Koo, Bon Seok; Lee, Dong Hyun

    2014-09-01

    The catalytic pyrolysis of palm kernel shell was investigated in a fluidized bed with zsm-5 and equilibrium FCC (Ecat) catalysts. Catalytic pyrolysis oil yields were remarkably reduced and gas yields were increased due to the higher catalytic reaction of primary volatiles compared to non-catalytic pyrolysis. Char yields were affected by temperature and the pore structure of the catalysts. The pyrolysis oil was characterized by lower H/C and O/C molar ratios due to aromatization and deoxygenation of volatiles by the catalysts. The catalytic pyrolysis oils contained more oxygen and nitrogen and less sulfur than petroleum oils. The oils had a high concentration of nitriles, with a carbon number distribution similar to fatty acids. The catalytic pyrolysis oils featured high nitriles yield with Ecat and high aromatics yield in the light fraction with zsm-5, due to characteristics of the catalyst. The catalytic pyrolysis oils showed potentials as feedstocks for bio-diesel and chemicals. Copyright © 2014 Elsevier Ltd. All rights reserved.

  16. Population density of oil palm pollinator weevil Elaeidobius kamerunicus based on seasonal effect and age of oil palm

    Science.gov (United States)

    Daud, Syarifah Nadiah Syed Mat; Ghani, Idris Abd.

    2016-11-01

    The pollinating weevil, Elaedobius kamerunicus (EK) has been known to be the most efficient insect pollinator of oil palm, and has successfully improved the oil palm pollination and increased the yield. Its introduction has greatly reduced the need for assisted pollination. The purpose of this study was to identify the population density of oil palm pollinator weevil EK using the concept of pollinator force and to relate the population density with the seasonal effect and the age of oil palm at Lekir Oil Palm Plantation Batu 14, Perak, Peninsular Malaysia. The pollinator force of the weevil was sustained at a range between 3095.2 to 19126.1 weevils per ha. The overall mean of weevil per spikelet shows that the range of weevil was between 13.51 and 54.06 per spikelet. There was no correlation between rainfall and population density of EK. However, positive correlation was obtained between weevil density and the number of anthesising female inflorescence of oil palm (r= 0.938, ppollinator force per spikelete and the Fresh fruit Bunch (FFB), fruit set or fruit to bunch ratio.

  17. Palm oil and derivatives: fuels or potential fuels?

    Directory of Open Access Journals (Sweden)

    Pioch Daniel

    2005-03-01

    Full Text Available Scientific and technical information including field trials about uses of palm oil as fuel has been available for more than half a century now. Several ways were investigated, from the simple mixture with petroleum Diesel fuel, to more sophisticated solutions. The quality of vegetable oils in natura as fuel is difficult to assess because of interferences between properties of the triacylglycerols – the main components – and those of the many minor components, their content varying significantly from sample to sample. A methodology set up at Cirad allowed to investigate separately natural triacylglycerols alone and the effect of minor components. In addition to these laboratory experiments, engine test at bench and field trials performed in palm oil producing countries, show that this oil is among the best oils as fuel; palm kernel oil whose chemical and physical properties are very close to those of the best of the series investigated, namely copra oil, should display also very interesting properties as Diesel biofuel. Both oils do require external adaptation of the engine when using an indirect injection type engine but even heavier adaptations for a direct injection model. Thus for use as Diesel fuel palm and palm kernel oils are suitable for captive fleets or for engine gensets, to balance the adaptation cost by a scale-up effect either on the number of identical engines or on the nominal vegetable oil consumption per set. Direct use of palm et palm kernel oils fits very well with technical and economical conditions encountered in remote areas. It is also possible to mix palm oil to Diesel fuel either as simple blend or as micro-emulsion. Out of the direct use, palm oil methyl or ethyl ester, often referred to as biodiesel, displays properties similar to those of petroleum Diesel fuel. This technical solution which is suitable to feed all kinds of standard compression ignited engines requires a chemical plant for carrying out the

  18. Agroecological practices in oil palm plantations: examples from the field

    Directory of Open Access Journals (Sweden)

    Bessou Cécile

    2017-05-01

    Full Text Available Palm oil is nowadays the first vegetable oil consumed worldwide. Given the world population growth and the increasing demand in fat for food and fuel, the increase in oil palm production is expected to continue. It is thus important to find ways of reducing the ecological impact of oil palm plantations at both the agroecosystem and the mill supply area levels, by improving agricultural practices and land uses. This is where agroecology can play a very critical role. The present article gathers short stories on agroecological practices currently taking place in oil palm plantations in South-East Asia. Such stories notably highlight the importance of the various palm co-products and how appropriate recycling strategies can allow for reducing external inputs to both the field and the mill. Besides limiting environmental impacts thanks to such savings, several co-products used as organic amendments can even help to maintain or enhance soil quality. Other stories explored agroecological practices developed for biological controls. Although integrated pest management has been applied in palm plantations for a long time, the underlying mechanisms are still not fully deciphered and practices still need to be improved. More knowledge is needed in order to better account for the holistic role of biodiversity and arbitrate trade-offs between practices and ecosystem services, at both plantation and landscape levels.

  19. Applications of Supercritical Fluid Extraction (SFE of Palm Oil and Oil from Natural Sources

    Directory of Open Access Journals (Sweden)

    Mohd Omar Ab Kadir

    2012-02-01

    Full Text Available Supercritical fluid extraction (SFE, which has received much interest in its use and further development for industrial applications, is a method that offers some advantages over conventional methods, especially for the palm oil industry. SC-CO2 refers to supercritical fluid extraction (SFE that uses carbon dioxide (CO2 as a solvent which is a nontoxic, inexpensive, nonflammable, and nonpolluting supercritical fluid solvent for the extraction of natural products. Almost 100% oil can be extracted and it is regarded as safe, with organic solvent-free extracts having superior organoleptic profiles. The palm oil industry is one of the major industries in Malaysia that provides a major contribution to the national income. Malaysia is the second largest palm oil and palm kernel oil producer in the World. This paper reviews advances in applications of supercritical carbon dioxide (SC-CO2 extraction of oils from natural sources, in particular palm oil, minor constituents in palm oil, producing fractionated, refined, bleached, and deodorized palm oil, palm kernel oil and purified fatty acid fractions commendable for downstream uses as in toiletries and confectionaries.

  20. Applications of supercritical fluid extraction (SFE) of palm oil and oil from natural sources.

    Science.gov (United States)

    Akanda, Mohammed Jahurul Haque; Sarker, Mohammed Zaidul Islam; Ferdosh, Sahena; Manap, Mohd Yazid Abdul; Ab Rahman, Nik Norulaini Nik; Ab Kadir, Mohd Omar

    2012-01-01

    Supercritical fluid extraction (SFE), which has received much interest in its use and further development for industrial applications, is a method that offers some advantages over conventional methods, especially for the palm oil industry. SC-CO₂ refers to supercritical fluid extraction (SFE) that uses carbon dioxide (CO₂) as a solvent which is a nontoxic, inexpensive, nonflammable, and nonpolluting supercritical fluid solvent for the extraction of natural products. Almost 100% oil can be extracted and it is regarded as safe, with organic solvent-free extracts having superior organoleptic profiles. The palm oil industry is one of the major industries in Malaysia that provides a major contribution to the national income. Malaysia is the second largest palm oil and palm kernel oil producer in the World. This paper reviews advances in applications of supercritical carbon dioxide (SC-CO₂) extraction of oils from natural sources, in particular palm oil, minor constituents in palm oil, producing fractionated, refined, bleached, and deodorized palm oil, palm kernel oil and purified fatty acid fractions commendable for downstream uses as in toiletries and confectionaries.

  1. Study on Fired Clay Bricks by Replacing Clay with Palm Oil Waste: Effects on Physical and Mechanical Properties

    Science.gov (United States)

    Kadir, A. A.; Sarani, N. A.; Abdullah, M. M. A. B.; Perju, M. C.; Sandu, A. V.

    2017-06-01

    Palm oil is one of the major agricultural industries in Malaysia. Due to the poor management system, the discarded palm oil waste has always been linked to the environment issues. During processing of palm oil, a considerable amount of solid waste by-products in the form of fibres, shells, empty fruit bunches and fly ashes are produce rapidly. Therefore, this study was conducted to incorporate 1%, 5% and 10% of palm oil waste into fired clay brick. Samples of brick were fired at 1050°C temperature with heating rates of 1°C/min. Manufactured bricks were tested with physical and mechanical properties including firing shrinkage, dry density, water absorption and compressive strength. The results demonstrated that the replacement of 1% up to 5% of palm oil waste had improved several properties, although, a decrease of performance in certain aspects has also been observed. As a result, palm oil waste can be utilized in an environmentally safe way into fired clay brick thus providing adequate properties of fired clay brick.

  2. Toward Sustainability in Concrete Industry by Using Of Solid Wastes from Palm Oil Industry

    Directory of Open Access Journals (Sweden)

    Pordesari Alireza Javadi

    2016-01-01

    Full Text Available Nowadays, one of the most important construction materials is concrete. By the advances of the industries in the urban areas, concrete is considered as one of the highest demands. As a result, the large amount of unprocessed materials is needed for making concrete. In the meantime, the agricultural wastes and solid material disposal are giving serious damages to the environment. As a result, by employing the agricultural wastes as a cementitious material, the undesirable impacts of the concrete industry to the environment will be dramatically decreased. That’s because the source of these newly developed concretes is both reliable and environmental friendly. In this study, the utilization of agricultural wastes as a complementary cementitious material for producing the concrete is explained. In addition, it discusses the possibility of deploying the agricultural wastes by considering their engineering, physical and chemical properties. In addition, the successful use of agricultural wastes from oil palm industry such as oil palm shell, palm oil fuel ash and palm oil fibre in the concrete mixture was reported.

  3. Climate, soil and land-use based land suitability evaluation for oil palm production in Ghana

    NARCIS (Netherlands)

    Rhebergen, Tiemen; Fairhurst, Thomas; Zingore, Shamie; Fisher, Myles; Oberthür, Thomas; Whitbread, Anthony

    2016-01-01

    In the past decade, oil palm (Elaeis guineensis Jacq.) has become the world's most important oil crop. The large demand for palm oil has resulted in a rapid expansion of oil palm cultivation across the globe. Because of the dwindling availability of land in Southeast Asia, most expansion of the i

  4. Linking Agricultural Trade, Land Demand and Environmental Externalities: Case of Oil Palm in South East Asia

    OpenAIRE

    Othman, Jamal

    2003-01-01

    Reduction of support measures affecting soybean oil in the major soybean producing countries, as a consequence of WTO rules, coupled with rising demand for palm oil in non-traditional palm oil importing countries may lead to pronounced increases in agricultural land demand for oil palm expansion in Malaysia and Indonesia – two main palm oil producing and exporting countries. However, it is expected that the effects on agricultural land demand and consequently impact upon the environment will ...

  5. Preparation and Characterization of Activated Carbon from Palm Kernel Shell

    Science.gov (United States)

    Andas, J.; Rahman, M. L. A.; Yahya, M. S. M.

    2017-08-01

    In this study, a high quality of activated carbon (AC) was successfully synthesized from palm kernel shell (PKS) via single step KOH activation. Several optimal conditions such as impregnation ratio and activation temperature were investigated. The prepared activated carbon under the optimum condition of impregnation ratio (1:1.5 raw/KOH) and activation temperature (800 °C) was characterized using Na2S2O3 volumetric method, CHNS/O analysis and Scanning Electron Microscope (SEM). Na2S2O3 volumetric showed an iodine number of 994.83 mgg-1 with yield % of 8.931 %. CHNS/O analysis verified an increase in C content for KOH-AC (61.10 %) in comparison to the raw PKS (47.28 %). Well-formation of porous structure was evidenced through SEM for KOH-AC. From this study, it showed a successful conversion of agricultural waste into value added porous material under benign condition.

  6. Synthesis of polyhydroxyalkanoate from palm oil and some new applications.

    Science.gov (United States)

    Sudesh, Kumar; Bhubalan, Kesaven; Chuah, Jo-Ann; Kek, Yik-Kang; Kamilah, Hanisah; Sridewi, Nanthini; Lee, Yan-Fen

    2011-03-01

    Polyhydroxyalkanoate (PHA) is a potential substitute for some petrochemical-based plastics. This biodegradable plastic is derived from microbial fermentation using various carbon substrates. Since carbon source has been identified as one of the major cost-absorbing factors in PHA production, cheap and renewable substrates are currently being investigated as substitutes for existing sugar-based feedstock. Plant oils have been found to result in high-yield PHA production. Malaysia, being the world's second largest producer of palm oil, is able to ensure continuous supply of palm oil products for sustainable PHA production. The biosynthesis and characterization of various types of PHA using palm oil products have been described in detail in this review. Besides, by-products and waste stream from palm oil industry have also demonstrated promising results as carbon sources for PHA biosynthesis. Some new applications in cosmetic and wastewater treatment show the diversity of PHA usage. With proper management practices and efficient milling processes, it may be possible to supply enough palm oil-based raw materials for human consumption and other biotechnological applications such as production of PHA in a sustainable manner.

  7. Palm oil boom in Indonesia: from plantation to downstream products and biodiesel

    Energy Technology Data Exchange (ETDEWEB)

    Santosa, Sri J. [Department of Chemistry, Faculty of Mathematics and Natural Sciences, Gadjah Mada University, Yogyakarta (Indonesia)

    2008-06-15

    Indonesia has been the biggest producer of palm oil (PO) in the world since 2005. The total production in 2007 was 17.0 and 1.9 million tons of crude palm oil (CPO) and crude palm kernel oil (CPKO), respectively. More than 70% of the CPO was exported and 87% of the domestic consumption was used for food. The production and subsequent refining and fractionation of CPO and CPKO generated biomass by-products that consists of trunk, frond, empty fruit bunch (EFB), fiber, shell, and palm kernel meal (PKM), and discharged wastes of palm oil mill effluent (POME) as well as palm fatty acid distillate (PFAD). The amount of by-products and wastes produced has been growing very rapidly and efforts to diversify and improve their utilization are a great challenge. As claimed in many research reports, the by-products and wastes could be potentially utilized as sources of energy, animal feed, chemicals, paper pulp, advanced materials, medicines and food ingredients. A more important role may be played by PO as the Indonesian Government took further steps in 2006 to become the world's largest producer of biodiesel. As a starting point, Presidential Instruction No. 1/2006 for the Production and Use of Biofuel as Alternative Fuel was issued in January 2006. Responding to this Presidential Instruction, at least 15 companies are planning to establish new larger biodiesel refineries to enhance the currently produced 82.5 million L of biodiesel. It is planned to start production in 2008/2009 with two new refineries that have a total capacity of ca. 1,600 million L/year. (Abstract Copyright [2008], Wiley Periodicals, Inc.)

  8. Sustainability of smallholder palm oil production in Indonesia

    OpenAIRE

    Bertule, Maija; Degn, Lasse Twiggs

    2009-01-01

    Palm oil is a widely used commodity and is part of a number of daily products. It is the most used vegetable oil, not just for food consumption, but also for soap and cosmetics. Recently the search for co2 neutral fuels have spurred demand for palm oil to be used in diesel cars. The large demand have led to a dramatic increase in production in Malaysia and Indonesia, and those two producers make up over total production. This dramatic increase in plantations have led to severe environmental p...

  9. Bunch yield of interspecific hybrids of American oil palm with oil palm in the juvenile phase

    Directory of Open Access Journals (Sweden)

    Rui Alberto Gomes Junior

    2016-07-01

    Full Text Available To identify superior genotypes, 42 progenies of interspecific hybrids between American oil palm and oil palm were evaluated in an area with incidence of bud rot. The following variables were assessed: total bunch yield (TBY, number of bunches (NB and mean bunch weight (MBW from the third to the sixth year of cultivation and estimates of genetic parameters obtained by REML/BLUP procedures. High heritability values of the evaluated traits were observed. The gain estimates for TBY were 14.49% for the selection of the five best progenies and 33.36% for the selection of the five best trees, considering multiplication by cloning. A medium correlation was observed between TBY and NB (r2 = 0.33±0.021, a high correlation between TBY and MBW (r2 = 0.53±0.019 and a negative high correlation between NB and MBW (r2 = –0.60±0.018. The results indicate a high expectation of gains with selection for TBY.

  10. Combustion characteristics of Malaysian oil palm biomass, sub-bituminous coal and their respective blends via thermogravimetric analysis (TGA).

    Science.gov (United States)

    Idris, Siti Shawalliah; Rahman, Norazah Abd; Ismail, Khudzir

    2012-11-01

    The combustion characteristics of Malaysia oil palm biomass (palm kernel shell (PKS), palm mesocarp fibre (PMF) and empty fruit bunches (EFB)), sub-bituminous coal (Mukah Balingian) and coal/biomass blends via thermogravimetric analysis (TGA) were investigated. Six weight ratios of coal/biomass blends were prepared and oxidised under dynamic conditions from temperature 25 to 1100°C at four heating rates. The thermogravimetric analysis demonstrated that the EFB and PKS evolved additional peak besides drying, devolatilisation and char oxidation steps during combustion. Ignition and burn out temperatures of blends were improved in comparison to coal. No interactions were observed between the coal and biomass during combustion. The apparent activation energy during this process was evaluated using iso-conversional model free kinetics which resulted in highest activation energy during combustion of PKS followed by PMF, EFB and MB coal. Blending oil palm biomass with coal reduces the apparent activation energy value.

  11. Risks and opportunities from key importers pushing for sustainability: the case of Indonesian palm oil

    National Research Council Canada - National Science Library

    Jafari, Yaghoob; Othman, Jamal; Witzke, Peter; Jusoh, Sufian

    2017-01-01

    Growing concerns in the major importing countries on the socio-environmental sustainability of oil palm farming may affect the import demand of palm oil and hence the economy of the exporting countries...

  12. Evaluation of the Effect of Oil Palm on some Physical and Chemical ...

    African Journals Online (AJOL)

    Keywords : Evaluation, oil palm, soil physical properties, soil chemical properties. INTRODUCTION ... investigating long-term changes under oil palm was conducted by Tinker (1963) .... The region has a humid, tropical climate with total annual ...

  13. Tool Wear Characteristics of Oil Palm Empty Fruit Bunch Particleboard

    Science.gov (United States)

    Ratnasingam, Jegatheswaran; Chew Tek, Tee; Farrokhpayam, Saied Reza

    A series of machining experiments on the Oil-Palm Empty Fruit Bunch (OPEFB) particleboard were carried out using a CNC router, to evaluate the tool wearing properties of the composite in comparison to the conventional wood-material particleboard. A single-fluted tungsten-carbide router bit (12 mm φ, 18 000 rpm), with a rake angle of 15° was used in this experiment, in which the depth of cut was 1.5 mm and feed speed was 4.5 m min-1. The router bit machined the edge of the board, moving along the full length before returning to repeat the cycle. The tool was examined for the extent of wear after complete failure had occurred. The result found that the wear pattern was similar in the oil-palm based particleboard and the wood-based particleboard, but the former was twice more abrasive compared to the latter. Microscopic examination of the cutter edge revealed greater incidence of micro-fracture when cutting the oil-palm based particleboard, indicating the presence of hard impurities in the composite. From an economic perspective, the tooling cost for machining oil-palm based particleboard is estimated to be twice of the cost for machining wood-based particleboard. This study shows that the machining properties of oil-palm based particleboard will be a primary concern, if the board is to find widespread application as a potential substitute for wood-based particleboard.

  14. Genomic Selection in Commercial Perennial Crops: Applicability and Improvement in Oil Palm (Elaeis guineensis Jacq.).

    Science.gov (United States)

    Kwong, Qi Bin; Ong, Ai Ling; Teh, Chee Keng; Chew, Fook Tim; Tammi, Martti; Mayes, Sean; Kulaveerasingam, Harikrishna; Yeoh, Suat Hui; Harikrishna, Jennifer Ann; Appleton, David Ross

    2017-06-06

    Genomic selection (GS) uses genome-wide markers to select individuals with the desired overall combination of breeding traits. A total of 1,218 individuals from a commercial population of Ulu Remis x AVROS (UR x AVROS) were genotyped using the OP200K array. The traits of interest included: shell-to-fruit ratio (S/F, %), mesocarp-to-fruit ratio (M/F, %), kernel-to-fruit ratio (K/F, %), fruit per bunch (F/B, %), oil per bunch (O/B, %) and oil per palm (O/P, kg/palm/year). Genomic heritabilities of these traits were estimated to be in the range of 0.40 to 0.80. GS methods assessed were RR-BLUP, Bayes A (BA), Cπ (BC), Lasso (BL) and Ridge Regression (BRR). All methods resulted in almost equal prediction accuracy. The accuracy achieved ranged from 0.40 to 0.70, correlating with the heritability of traits. By selecting the most important markers, RR-BLUP B has the potential to outperform other methods. The marker density for certain traits can be further reduced based on the linkage disequilibrium (LD). Together with in silico breeding, GS is now being used in oil palm breeding programs to hasten parental palm selection.

  15. Will Improved Palm Oil Yields suffice to the Development of Sustainable Biodiesel Feedstock in indonesia?

    OpenAIRE

    Palmén, Carl; Silveira, Semida; Khatiwada, Dilip

    2015-01-01

    By the expansion of oil palm plantations, Indonesia has become a world leading producer of crude palm oil. However, Indonesia has also been largely criticized due to issues of land use change and deforestation. The country now promotes the use of palm oil for biodiesel production as part of policies to achieve renewable energy targets. Currently yields on palm oil plantations are far from optimal. Do new policies promoting biodiesel production address the issue of yields properly? This study ...

  16. Palm Oil as a Transnational Crisis in South-East Asia

    OpenAIRE

    Pye, Oliver

    2009-01-01

    "This paper discusses the recent palm oil expansion as a multiple crisis of climate change, biodiversity loss, and (failed) development. It draws on recent research on the Malaysian 'Palm Oil Industrial Complex' and on transnational campaign coalitions around palm oil to explore the transnational dimensions of the palm oil crisis. It argues that a new campaign coalition around the issue of agrofuel policies in the European Union has emerged that links social and environmental s...

  17. FAKTOR-FAKTOR YANG MEMPENGARUHI EKSPOR CRUDE PALM OIL INDONESIA DALAM PERDAGANGAN INTERNASIONAL

    National Research Council Canada - National Science Library

    fakhrus radifan

    2014-01-01

    Abstrak ___________________________________________________________________ Crude Palm Oil merupakan salah satu komoditas perkebunan ekspor unggulan yang mampu memberikan kontribusi dan sebagai salah...

  18. The Role of Markets, Technology, and Policy in Generating Palm-Oil Demand in Indonesia

    OpenAIRE

    Gaskell, Joanne C.

    2015-01-01

    Indonesia produces more palm oil and consumes more palm oil per capita than any country in the world. This article examines the processes through which Indonesia has promoted palm-oil consumption and some of the consequences of that promotion. Partial equilibrium modelling shows that Indonesia's remarkable increase in palm-oil consumption since 1985 is not largely attributable to population and income growth. Instead, much of this consumption growth has resulted from substitution away from co...

  19. Physical Properties of Biomass Fuel Briquette from Oil Palm ...

    African Journals Online (AJOL)

    ADOWIE PERE

    of fuel briquettes in this study in order to supplement the energy mix of the nation. ... the fuel briquettes from PKS and MF (especially 350 µm series) could serve as alternative ... Keywords: Palm kernel shell; Mesocarp fibre; Briquette; Biomass solid fuel; proximate ... physical properties of fuel briquettes produced from.

  20. Indonesia palm oil production without deforestation and peat conversion by 2050.

    Science.gov (United States)

    Afriyanti, Dian; Kroeze, Carolien; Saad, Asmadi

    2016-07-01

    Palm oil is a promising source of cooking oil and biodiesel. The demand for palm oil has been increasing worldwide. However, concerns exist surrounding the environmental and socio-economic sustainability of palm oil production. Indonesia is a major palm oil producing country. We explored scenarios for palm oil production in Indonesia until 2050, focusing on Sumatra, Kalimantan and Papua. Our scenarios describe possible trends in crude palm oil production in Indonesia, while considering the demand for cooking oil and biodiesel, the available land for plantations, production capacity (for crude palm oil and fresh fruit bunches) and environmentally restricting conditions. We first assessed past developments in palm oil production. Next, we analysed scenarios for the future. In the past 20years, 95% of the Indonesian oil palm production area was in Sumatra and Kalimantan and was increasingly cultivated in peatlands. Our scenarios for the future indicate that Indonesia can meet a considerable part of the global and Asian demand for palm oil, while avoiding further cultivation of peatlands and forest. By 2050, 264-447Mt crude palm oil may be needed for cooking oil and biodiesel worldwide. In Indonesia, the area that is potentially suitable for oil palm is 17 to 26Mha with a potential production rate of 27-38t fresh fruit bunches/ha, yielding 130-176Mt crude palm oil. Thus Indonesia can meet 39-60% of the international demand. In our scenarios this would be produced in Sumatra (21-26%), Kalimantan (12-16%), and Papua (2%). The potential areas include the current oil palm plantation in mineral lands, but exclude the current oil palm plantations in peatlands.

  1. Greenhouse gas reductions through enhanced use of residues in the life cycle of Malaysian palm oil derived biodiesel

    DEFF Research Database (Denmark)

    Hansen, Sune Balle; Olsen, Stig Irving; Ujang, Zaini

    2012-01-01

    on methane potentials from empty fruit bunches. Methane capture from the anaerobic digestion of palm oil mill effluent was found to result in the highest GHG reductions. Among the solid residues, energy extraction from shells was found to constitute the biggest GHG savings per ton of residue, whereas energy......This study identifies the potential greenhouse gas (GHG) reductions, which can be achieved by optimizing the use of residues in the life cycle of palm oil derived biodiesel. This is done through compilation of data on existing and prospective treatment technologies as well as practical experiments...

  2. Options to reduce environmental impacts of palm oil production in Thailand

    NARCIS (Netherlands)

    Saswattecha, Kanokwan; Kroeze, Carolien; Jawjit, Warit; Hein, Lars

    2016-01-01

    There is an increasing demand for palm oil worldwide. In Thailand, oil palm is being promoted by the government but this expansion is associated with several environmental impacts. We identified 26 options for reducing the environmental impact of palm oil production in Thailand, and assessed their c

  3. A participatory diagnostic study of the oil palm (Elaeis guineensis) seed system in Benin

    NARCIS (Netherlands)

    Akpo, E.; Vissoh, P.V.; Tossou, R.C.; Crane, T.; Kossou, D.K.; Richards, P.; Stomph, T.J.; Struik, P.C.

    2012-01-01

    A participatory diagnostic study of the oil palm (Elaeis guineensis Jacq.) seed system (OPSS) was conducted along a gradient of rainfall and distance to the oil palm research centre across the oil palm growing belt of Benin. The objective was to identify, jointly with key actors, the constraints in

  4. Oil palm expansion drives avifaunal decline in the Pucallpa region of Peruvian Amazonia

    Directory of Open Access Journals (Sweden)

    Alicia Srinivas

    2016-07-01

    Full Text Available Oil palm is one of the world’s most rapidly expanding crops, replacing humid forests across tropical regions. Studies examining the effect of this land conversion on biodiversity have tended to focus predominantly on Southeast Asia, where the majority of the world’s oil palm is produced. Because the Amazon possesses the greatest area of suitable land for oil palm expansion, oil palm is considered an emerging threat to Amazonian biodiversity. This is the first study to examine how oil palm agriculture affects avian diversity within the context of Western Amazonia. We used mist nets to conduct avifaunal surveys of forest and oil palm habitat in the Pucallpa region of Peruvian Amazonia. Bird species richness, species evenness, and overall abundance were all significantly higher in the forest than in oil palm habitat. Strikingly, less than 5% of all captured species were common to both forest and oil palm habitat. The species absent from the oil palm plantations were disproportionately habitat specialists, forest interior birds, birds with high sensitivity to disturbance, and insectivores and frugivores. The results suggest that oil palm is particularly poor habitat for Amazonian birds, and that the species that are persist on them are of lower conservation value. Given the apparent lack of diversity on oil palm plantations, preventing further conversion of forests to oil palm should be prioritized.

  5. Comparative alteration in atherogenic indices and hypocholesteremic effect of palm oil and palm oil mill effluent in normal albino rats.

    Science.gov (United States)

    Ajiboye, John A; Erukainure, Ochuko L; Lawal, Babatunde A; Nwachukwu, Viola A; Tugbobo-Amisu, Adesewa O; Okafor, Ebelechukwu N

    2015-09-01

    The comparative hypocholesteremic effect of feeding palm oil and palm oil mill effluent (POME) was investigated in male albino rats. Diets were prepared and designed to contain 50% of energy as carbohydrate, 35% as fat, and 15% as protein. Groups of six rats were each fed one of these diets, while a group was fed pelletized mouse chow which served as the control. Feeding on palm oil and POME led to a significant increase (p < 0.05) in serum total cholesterol, triglyceride, and vLDL. Feeding on POME led to significant increase (p < 0.05) in cholesterol, triglyceride and LDL levels in brain tissues. Increased hepatic LDL level was also observed in POME fed rats. Except for hepatic triglyceride and tissues HDL level, a rather reduced level of the studied lipids was observed in the serum and tissues of palm oil fed rats compared to POME. These results indicate the protective potentials of palm oil against cardiovascular disease, as well as hyperlipidemia that characterize obesity and hypertension; as compared to its effluent.

  6. Comparative alteration in atherogenic indices and hypocholesteremic effect of palm oil and palm oil mill effluent in normal albino rats

    Directory of Open Access Journals (Sweden)

    John A. Ajiboye

    2015-09-01

    Full Text Available The comparative hypocholesteremic effect of feeding palm oil and palm oil mill effluent (POME was investigated in male albino rats. Diets were prepared and designed to contain 50% of energy as carbohydrate, 35% as fat, and 15% as protein. Groups of six rats were each fed one of these diets, while a group was fed pelletized mouse chow which served as the control. Feeding on palm oil and POME led to a significant increase (p < 0.05 in serum total cholesterol, triglyceride, and vLDL. Feeding on POME led to significant increase (p < 0.05 in cholesterol, triglyceride and LDL levels in brain tissues. Increased hepatic LDL level was also observed in POME fed rats. Except for hepatic triglyceride and tissues HDL level, a rather reduced level of the studied lipids was observed in the serum and tissues of palm oil fed rats compared to POME. These results indicate the protective potentials of palm oil against cardiovascular disease, as well as hyperlipidemia that characterize obesity and hypertension; as compared to its effluent.

  7. Life Cycle Assessment of Sago Palm, Oil Palm, and Paddy Cultivated on Peat Land

    Directory of Open Access Journals (Sweden)

    Saptarining Wulan

    2015-07-01

    Full Text Available The continuously increasing population growth more than food agriculture growth on the existing land, has been encouraging to this research. The land use competition for agriculture and housing purposes have caused the land use change from forest to agriculture and housing. Within forested landscapes food production, commodity agriculture, biodiversity, resource extraction and other land uses are also competing for space. The forest land use change (deforestation is one of the climate change causes. The impact of climate change among others is the uncertain climate, such as the long drought period, flood, and the extreme temperature that cause decreasing in agriculture production. Therefore, at present, many people use the marginal land, such as peat land for agriculture cultivation to increase the food agriculture production and to achieve the domestic and export demand. Indonesia has a huge peat land and the fourth biggest in the world after Rusia, Canada, and America. The focus of this study is comparing the life cycle assessment of three agriculture commodities: sago palm, oil palm, and paddy cultivated on peat land. The purpose of this research is to contribute a recommendation of the most sustainable commodity from the aspect carbon dioxide (CO2 emission among three food agriculture commodities include oil palm and paddy that currently as excellent commodities, and sago palm, the neglected indigenous plant, which are cultivated on peat land. The method applied for this research to analyze the environmental aspect using life cycle assessment (LCA started from seedling, plantation, harvesting, transportation, and production process. The analysis result reveals that sago palm is the most environmental friendly. The lowest CO2 emission (ton/ha/year is sago palm (214.75 ± 23.49 kg CO2 eq, then paddy (322.03 ± 7.57 kg CO2 eq and the highest CO2 emission (ton/ha/year is oil palm (406.88 ± 97.09 kg CO2 eq.

  8. BVOC fluxes from oil palm canopies in South East Asia

    Science.gov (United States)

    Misztal, P. K.; Cape, J. N.; Langford, B.; Nemitz, E.; Helfter, C.; Owen, S.; Heal, M. R.; Hewitt, C. N.; Fowler, D.

    2009-04-01

    Fluxes by virtual disjunct eddy covariance were measured for the first time in South-East Asia in 2008 from an oil palm plantation. Malaysia and Indonesia account for more than 80% of world oil palm production. Our in situ findings suggest much higher isoprene emissions from oil palms than from rainforest, which is consistent with earlier lab-based predictions of emissions from oil palms (Wilkinson et al., 2006). 50% of global biogenic VOC emissions are estimated to derive from tropical rainforests (Guenther et al., 1995) although in fact a large portion of the emission may derive from oil palms in the tropics. Isoprene and monoterpenes are regarded as the most important biogenic VOCs for the atmospheric chemistry. Overall, maximum isoprene emissions from oil palms were recorded at 11:00 local time, with a mean value of 13 mg m-2 h-1. At the rainforest, the maximum fluxes of isoprene were observed later in the day, at about 13:00 with an average of 2.5 mg m-2 h-1. Initial flux results for total monoterpenes indicate that their mass emission ratio with respect to isoprene was about 1:9 at the rainforest and 1:18 at the oil palm plantation. The results are presented with reference to temperature, photosynthetic radiation and meteorological drivers as well as in comparison with CO2 and H2O fluxes. Empirical parameters in the Guenther algorithm for MEGAN (Guenther et al, 2006), which was originally designed for the Amazon region, have been optimised for this oil palm study. The emission factor obtained from eddy covariance measurements was 18.8 mg m-2 h-1, while the one obtained from leaf level studies at the site was 19.5 mg m-2 h-1. Isoprene fluxes from both Amazonia (Karl et al., 2007) and from rainforest in Borneo 2008 seem to be much lower than from oil palms. This can have consequences for atmospheric chemistry of land use change from rainforest to oil palm plantation, including formation of ozone, SOA and particles and indirect effects on the removal rate of

  9. Synthesis And Characterization of Biodiesel From Nigerian Palm Kernel oil.

    Directory of Open Access Journals (Sweden)

    IGBOKWE, J. O.

    2016-07-01

    Full Text Available Biodiesel was produced from Nigerian Palm kernel oil through direct base- catalyzed transesterification process using methanol and sodium hydroxide as alcohol and catalyst respectively. The transesterification process involved 1 liter of Palm kernel oil, 200ml of methanol, 1.0% NaOH, reaction temperature of 65 degree Celsius and reaction time of 90mins and an average biodiesel yield of 87.67% was obtained. The produced biodiesel was blended with diesel fuel at a ratio of 20% biodiesel to 80% diesel fuel (by volume. The neat biodiesel and its blend were characterized using the ASTM methods. The results showed that the properties of the neat palm kernel oil biodiesel and its blend fall within the American Society for Testing and Materials (ASTM specifications for Biodiesel fuels hence confirming their suitability as alternative fuels for modern diesel engines.

  10. Torrefaction of Pelletized Oil Palm Empty Fruit Bunches

    CERN Document Server

    Nyakuma, Bemgba Bevan; Johari, Anwar; Abdullah, Tuan Amran Tuan; Oladokun, Olagoke

    2015-01-01

    The torrefaction of oil palm Empty Fruit Bunch (EFB) briquettes was examined in this study. The results indicate that temperature significantly influenced the mass yield, energy yield and heating value of oil palm empty fruit bunch (OPEFB) briquettes during torrefaction. The solid uniform compact nature of EFB briquettes ensured a slow rate of pyrolysis or devolatization which enhanced torrefaction. The mass yield decreased from 79.70 % to 43.03 %, energy yield from 89.44 % to 64.27 % during torrefaction from 250 {\\deg}C to 300 {\\deg}C. The heating value (HHV) of OPEFB briquettes improved significantly from 17.57 MJ/kg to 26.24 MJ/kg after torrefaction at 300 {\\deg}C for 1 hour. Fundamentally, the study has highlighted the effects of pelletization and torrefaction on solid fuel properties of oil palm EFB briquettes and its potential as a solid fuel for future thermal applications.

  11. Optimization of the cemical interesterification reaction of palm oil

    OpenAIRE

    Renato Grimaldi; Lireny Aparecida Guaraldo Gonçalves; Marlene Yumi Ando

    2005-01-01

    The Brazilian market has been showing a growing concern with nutritional values of oil components of foods. Chemical interesterification is a promising alternative to the current processes of modifying the consistency of oils. Chemical interesterification of deodorized palm oil was studied on a laboratory scale. The best results were obtained with 0.4% MeONa and heating for 20 min at 100 °C. These conditions are based on the largest variation in triacylglycerols as compared to a control. ...

  12. Integrated Bali Cattle Development Model Under Oil Palm Plantation

    Directory of Open Access Journals (Sweden)

    Rasali Hakim Matondang

    2015-09-01

    Full Text Available Bali cattle have several advantages such as high fertility and carcass percentage, easy adaptation to the new environment as well. Bali cattle productivity has not been optimal yet. This is due to one of the limitation of feed resources, decreasing of grazing and agricultural land. The aim of this paper is to describe Bali cattle development integrated with oil palm plantations, which is expected to improve productivity and increase Bali cattle population. This integration model is carried out by raising Bali cattle under oil palm plantation through nucleus estate scheme model or individual farmers estates business. Some of Bali cattle raising systems have been applied in the integration of palm plantation-Bali cattle. One of the intensive systems can increase daily weight gain of 0.8 kg/head, calfcrop of 35% per year and has the potency for industrial development of feed and organic fertilizer. In the semi-intensive system, it can improve the production of oil palm fruit bunches (PFB more than 10%, increase harvested-crop area to 15 ha/farmer and reduce the amount of inorganic fertilizer. The extensive system can produce calfcrop ³70%, improve ³30% of PFB, increase business scale ³13 cows/farmer and reduce weeding costs ³16%. Integrated Bali cattle development may provide positive added value for both, palm oil business and cattle business.

  13. Optimization of Palm Oil Plantation Revitalization in North Sumatera Indonesia

    Directory of Open Access Journals (Sweden)

    Juliza Hidayati

    2015-01-01

    Full Text Available The idea of making North Sumatera  as a barometer of national oil palm industry require efforts commodities and agro-industry development of oil palm. One effort that can be done is by successful execution plantation revitalization. The plantation Revitalization is an effort to accelerate the development of smallholder plantations, through expansion and replanting by help of palm estate company as business partner and bank financed plantation revitalization fund. Business partner agreement obliged and bound to make at least the same smallholder plantation productivity with business partners, so that the refund rate to banks become larger and prosperous people as a plantation owner. Generally low productivity of smallholder plantations under normal potential caused a lot of old and damaged plants with plant material at random. The purpose of revitalizing oil palm plantations which are to increase their competitiveness through increased farm productivity. The research aims to identify potential criteria in influencing plantation productivity improvement priorities to be observed and followed up in order to improve the competitiveness of destinations and make North Sumatera barometer of national palm oil can be achieved. Research conducted with Analytical Network Process (ANP, to find the effect of dependency relationships between factors or criteria with the knowledge of the experts in order to produce an objective opinion and relevant depict the actual situation. 

  14. An Investigation of Sustainable Power Generation from Oil Palm Biomass: A Case Study in Sarawak

    OpenAIRE

    Nasrin Aghamohammadi; Stacy Simai Reginald; Ahmad Shamiri; Ali Akbar Zinatizadeh; Li Ping Wong; Nik Meriam Binti Nik Sulaiman

    2016-01-01

    Sarawak is the largest state in Malaysia, with 22% of the nation's oil palm plantation area, making it the second largest contributor to palm biomass production. Despite the enormous amount of palm biomass in the state, the use of biomass as fuel for power generation remains low. This study is designed to investigate the sustainability of power generation from palm biomass specifically in Sarawak by conducting a survey among the palm oil mill developers. To conduct this investigation, several...

  15. PREPARATION OF VARIOUS TYPES OF PULP FROM OIL PALM LIGNOCELLULOSIC RESIDUES

    Institute of Scientific and Technical Information of China (English)

    RyoheiTanaka; LehCheuPeng; WanRosliWanDaud

    2004-01-01

    Oil palm, Elaeis Guineensis, (Figure 1) is one of the most important plants in Malaysia. It produces palm oil and palm kernel oil, which is widely being used in food and other industries such as detergents and cosmetics. Malaysia is the world's largest producer and exporter of the oil, so that the country's economy is very much dependent on these oil products. Although oil from the palm tree is an excellent product for the country, residues from oil palm have not been used sufficiently. In this 10-15 years, development in new technologies for utilizing this lignocellulosic waste is categorized as one of the most important issues in science policy of Malaysia. Here we would like to introduce recent situation of palm oil and oil palm lignocellulosic residues at the first part of this paper. In the second part, our recent studies on the preparation of pulps for different purposes will be summarized.

  16. Oil palm biomass-based adsorbents for the removal of water pollutants--a review.

    Science.gov (United States)

    Ahmad, Tanweer; Rafatullah, Mohd; Ghazali, Arniza; Sulaiman, Othman; Hashim, Rokiah

    2011-07-01

    This article presents a review on the role of oil palm biomass (trunks, fronds, leaves, empty fruit bunches, shells, etc.) as adsorbents in the removal of water pollutants such as acid and basic dyes, heavy metals, phenolic compounds, various gaseous pollutants, and so on. Numerous studies on adsorption properties of various low-cost adsorbents, such as agricultural wastes and its based activated carbons, have been reported in recent years. Studies have shown that oil palm-based adsorbent, among the low-cost adsorbents mentioned, is the most promising adsorbent for removing water pollutants. Further, these bioadsorbents can be chemically modified for better efficiency and can undergo multiple reuses to enhance their applicability at an industrial scale. It is evident from a literature survey of more than 100 recent papers that low-cost adsorbents have demonstrated outstanding removal capabilities for various pollutants. The conclusion is been drawn from the reviewed literature, and suggestions for future research are proposed.

  17. Preparation, characterization, and dye removal study of activated carbon prepared from palm kernel shell.

    Science.gov (United States)

    García, Juan Rafael; Sedran, Ulises; Zaini, Muhammad Abbas Ahmad; Zakaria, Zainul Akmar

    2017-04-08

    Palm oil mill wastes (palm kernel shell (PKS)) were used to prepare activated carbons, which were tested in the removal of colorants from water. The adsorbents were prepared by 1-h impregnation of PKS with ZnCl2 as the activating agent (PKS:ZnCl2 mass ratios of 1:1 and 2:1), followed by carbonization in autogenous atmosphere at 500 and 550 °C during 1 h. The characterization of the activated carbons included textural properties (porosity), surface chemistry (functional groups), and surface morphology. The dye removal performance of the different activated carbons was investigated by means of the uptake of methylene blue (MB) in solutions with various initial concentrations (25-400 mg/L of MB) at 30 °C, using a 0.05-g carbon/50-mL solution relationship. The sample prepared with 1:1 PKS:ZnCl2 and carbonized at 550 °C showed the highest MB adsorption capacity (maximum uptake at the equilibrium, q max = 225.3 mg MB / g adsorbent), resulting from its elevated specific surface area (BET, 1058 m(2)/g) and microporosity (micropore surface area, 721 m(2)/g). The kinetic experiments showed that removals over 90% of the equilibrium adsorptions were achieved after 4-h contact time in all the cases. The study showed that palm oil mill waste biomass could be used in the preparation of adsorbents efficient in the removal of colorants in wastewaters.

  18. Development and validation of a bi-directional allele-specific PCR tool for differentiation in nurseries of dura, tenera and pisifera oil palms

    Directory of Open Access Journals (Sweden)

    Paola A. Reyes

    2015-04-01

    Full Text Available Oil palm (Elaeis guineensis Jacq. fruits are classified by shell thickness into three types: dura, pisifera, and tenera, the last one being the product of a dura × pisifera cross. The palm oil industry relies on the use of high-yield tenera plant material for production; however, it is usually generated with female infertile pisifera, so early identification of this trait is very important to oil production and breeding programs. Recently, the mapping and sequencing of the SHELL gene, which is responsible for endocarp formation in oil palms, made it possible to identify two mutations (type SNP, single nucleotide polymorphism that affect its function and that are useful to developing molecular markers for predicting shell thickness. The aim of this study was to standardize PCR-based methodologies in order to detect the SNP observed in codon 30 and validate it under our E. guineensis biological collections. We achieved the differentiation of SHELL alleles with both allele specific PCR and CAPS with the restriction enzyme HindIII in homozygous and heterozygous plants that contained the described mutation, and the prediction was correlated with the phenotype observed in oil palm fruits. These methodologies facilitated the discrimination of plants by fruit type in nursery and pre-nursery stages 24 months before production started, thereby reducing the time and area used in oil palm breeding programs.

  19. Inhibition of palm oil oxidation by zeolite nanocrystals.

    Science.gov (United States)

    Tan, Kok-Hou; Awala, Hussein; Mukti, Rino R; Wong, Ka-Lun; Rigaud, Baptiste; Ling, Tau Chuan; Aleksandrov, Hristiyan A; Koleva, Iskra Z; Vayssilov, Georgi N; Mintova, Svetlana; Ng, Eng-Poh

    2015-05-13

    The efficiency of zeolite X nanocrystals (FAU-type framework structure) containing different extra-framework cations (Li(+), Na(+), K(+), and Ca(2+)) in slowing the thermal oxidation of palm oil is reported. The oxidation study of palm oil is conducted in the presence of zeolite nanocrystals (0.5 wt %) at 150 °C. Several characterization techniques such as visual analysis, colorimetry, rheometry, total acid number (TAN), FT-IR spectroscopy, (1)H NMR spectroscopy, and Karl Fischer analyses are applied to follow the oxidative evolution of the oil. It was found that zeolite nanocrystals decelerate the oxidation of palm oil through stabilization of hydroperoxides, which are the primary oxidation product, and concurrently via adsorption of the secondary oxidation products (alcohols, aldehydes, ketones, carboxylic acids, and esters). In addition to the experimental results, periodic density functional theory (DFT) calculations are performed to elucidate further the oxidation process of the palm oil in the presence of zeolite nanocrystals. The DFT calculations show that the metal complexes formed with peroxides are more stable than the complexes with alkenes with the same ions. The peroxides captured in the zeolite X nanocrystals consequently decelerate further oxidation toward formation of acids. Unlike the monovalent alkali metal cations in the zeolite X nanocrystals (K(+), Na(+), and Li(+)), Ca(2+) reduced the acidity of the oil by neutralizing the acidic carboxylate compounds to COO(-)(Ca(2+))1/2 species.

  20. Chicken meat nutritional value when feeding red palm oil, palm oil or rendered animal fat in combinations with linseed oil, rapeseed oil and two levels of selenium.

    Science.gov (United States)

    Nyquist, Nicole F; Rødbotten, Rune; Thomassen, Magny; Haug, Anna

    2013-05-09

    Chicken meat nutritional value with regard to fatty acid composition and selenium content depends on the choice of dietary oil and selenium level used in the chickens' feed. The objective of this study was to investigate the effect of replacing commonly used rendered animal fat as a dietary source of saturated fatty acids and soybean oil as a source of unsaturated fatty acids, with palm oil and red palm oil in combinations with rapeseed oil, linseed oil and two levels of selenium enriched yeast on chicken breast meat nutritional value. The study also wished to see whether red palm oil had a cholesterol lowering effect on chicken plasma.204 male, newly hatched broiler chickens were randomly divided into twelve dietary treatment groups, and individually fed one out of six dietary fat combinations combined with either low (0.1 mg Se /kg feed) or high (1 mg Se/kg feed) dietary selenium levels. Linseed oil, independent of accompanying dietary fat source, lead to increased levels of the n-3 EPA, DPA and DHA and reduced levels of the n-6 arachidonic acid (AA). The ratio between AA/EPA was reduced from 19/1 in the soybean oil dietary groups to 1.7/1 in the linseed oil dietary groups. Dietary red palm oil reduced total chicken plasma cholesterol levels. There were no differences between the dietary groups with regard to measured meat antioxidant capacity or sensory evaluation. Chicken meat selenium levels were clearly influenced by dietary selenium levels, but were not influenced by feed fatty acid composition. High dietary selenium level lead to marginally increased n-3 EPA and higher meat fat % in breast muscle but did not influence the other LC PUFA levels. Chicken breast meat nutritional value from the soybean oil and low selenium dietary groups may be regarded as less beneficial compared to the breast meat from the linseed oil and high selenium dietary groups. Replacing rendered animal fat with palm oil and red palm oil had no negative effects on chicken muscle

  1. Kinetic Study on Pyrolysis of Oil Palm Frond

    Science.gov (United States)

    Soon, V. S. Y.; Chin, B. L. F.; Lim, A. C. R.

    2016-03-01

    The pyrolysis of oil palm frond is studied using thermogravimetric analysis (TGA) equipment. The present study investigates the thermal degradation behaviour and determination of the kinetic parameters such as the activation energy (EA ) and pre-exponential factor (A) values of oil palm frond under pyrolysis condition. The kinetic data is produced based on first order rate of reaction. In this study, the experiments are conducted at different heating rates of 10, 20, 30, 40 and 50 K/min in the temperature range of 323-1173 K under non-isothermal condition. Argon gas is used as an inert gas to remove any entrapment of gases in the TGA equipment.

  2. Remotely sensed evidence of tropical peatland conversion to oil palm

    OpenAIRE

    Koh, Lian Pin; Miettinen, Jukka; Liew, Soo Chin; Ghazoul, Jaboury

    2011-01-01

    Rising global demands for food and biofuels are driving forest clearance in the tropics. Oil-palm expansion contributes to biodiversity declines and carbon emissions in Southeast Asia. However, the magnitudes of these impacts remain largely unquantified until now. We produce a 250-m spatial resolution map of closed canopy oil-palm plantations in the lowlands of Peninsular Malaysia (2 million ha), Borneo (2.4 million ha), and Sumatra (3.9 million ha). We demonstrate that 6% (or ≈880,000 ha) of...

  3. Exports of Palm Oil from Ghana: A Demand Analysis

    OpenAIRE

    John K.M. Kuwornu; Darko, Francis A.; Osei-Asare, Yaw B.; Irene S. Egyir

    2009-01-01

    Studies have shown that the economy of Ghana cannot afford to rely solely on cocoa exports. It is imperative to diversify the export base of the Ghanaian economy. In this respect, the palm oil sub-sector of the agricultural sector, which until the early part of the 20th century was the major agricultural export commodity of Ghana, needs to be considered for promotion. Currently the palm oil industry faces the challenge of bleak export potential. This study examines trends in the quantity expo...

  4. Greenhouse gas reductions through enhanced use of residues in the life cycle of Malaysian palm oil derived biodiesel

    DEFF Research Database (Denmark)

    Hansen, Sune Balle; Olsen, Stig Irving; Ujang, Zaini

    2012-01-01

    This study identifies the potential greenhouse gas (GHG) reductions, which can be achieved by optimizing the use of residues in the life cycle of palm oil derived biodiesel. This is done through compilation of data on existing and prospective treatment technologies as well as practical experiments...... on methane potentials from empty fruit bunches. Methane capture from the anaerobic digestion of palm oil mill effluent was found to result in the highest GHG reductions. Among the solid residues, energy extraction from shells was found to constitute the biggest GHG savings per ton of residue, whereas energy...... extraction from empty fruit bunches was found to be the most significant in the biodiesel production life cycle. All the studied waste treatment technologies performed significantly better than the conventional practices and with dedicated efforts of optimized use in the palm oil industry, the production...

  5. Modification of palm oil for anti-inflammatory nutraceutical properties.

    Science.gov (United States)

    Zainal, Zaida; Longman, Andrea J; Hurst, Samantha; Duggan, Katrina; Hughes, Clare E; Caterson, Bruce; Harwood, John L

    2009-07-01

    Palm oil is one of the most important edible oils in the world. Its composition (rich in palmitate and oleate) make it suitable for general food uses but its utility could be increased if its fatty acid quality could be varied. In this study, we have modified a palm olein fraction by transesterification with the n-3 polyunsaturated fatty acids, alpha-linolenate or eicosapentaenoic acid (EPA). Evaluation of the potential nutritional efficacy of the oils was made using chondrocyte culture systems which can be used to mimic many of the degenerative and inflammatory pathways involved in arthritis. On stimulation of such cultures with interleukin-1alpha, they showed increased expression of cyclooxygenase-2, the inflammatory cytokines tumour necrosis factor-alpha (TNF-alpha), IL-1alpha and IL-1beta and the proteinase ADAMTS-4. This increased expression was not affected by challenge of the cultures with palm olein alone but showed concentration-dependent reduction by the modified oil in a manner similar to EPA. These results show clearly that it is possible to modify palm oil conveniently to produce a nutraceutical with effective anti-inflammatory properties.

  6. Palm oil industry in Ecuador. Good business for small farmers?

    Directory of Open Access Journals (Sweden)

    Lesley P. Potter

    2013-10-01

    Full Text Available Ecuador is the second largest producer in Latin America of crude palm oil and is the seventh largest producer worldwide, but with yields per hectare still lower than Colombia and Costa Rica. Although producers with over 1 000 hectares have the leadership in the palm oil industry, 87% of producers produce with less than 50 hectares. Moreover, the deforestation rate in Ecuador is ranked by FAO as the ninth highest in the world and the highest in South America. The African palm plantations have been criticized for causing deforestation and worsening work conditions. However, government sectors see the oil palm companies as a source of employment and development for poor regions. This fieldwork shows that there is a difference in perception among small farmers. Farmers from Quinindé-La Concordia were satisfied with the income they earn and the rising prices of land planted with palm. Farmers in San Lorenzo, in contrast, are not happy since the survey shows that a disease devastated trees and as a result, land prices have fallen in San Lorenzo.

  7. 77 FR 19663 - Notice of Data Availability Concerning Renewable Fuels Produced from Palm Oil Under the RFS...

    Science.gov (United States)

    2012-04-02

    ... AGENCY Notice of Data Availability Concerning Renewable Fuels Produced from Palm Oil Under the RFS... Produced from Palm Oil under the RFS Program'' (the notice is herein referred to as the ``palm oil NODA... comment on EPA's analyses of palm oil used as a feedstock to produce biodiesel and renewable diesel...

  8. 77 FR 8254 - Notice of Data Availability Concerning Renewable Fuels Produced From Palm Oil Under the RFS...

    Science.gov (United States)

    2012-02-14

    ... types of biofuel shows that biodiesel and renewable diesel produced from palm oil have estimated... AGENCY Notice of Data Availability Concerning Renewable Fuels Produced From Palm Oil Under the RFS... Produced From Palm Oil Under the RFS Program'' (the notice is herein referred to as the ``palm oil...

  9. Pollution Control: How Feasible is Zero Discharge Concepts in Malaysia Palm Oil Mills

    OpenAIRE

    Yahaya S. Madaki

    2013-01-01

    Many palm oil mills in Malaysia still discharged either partially treated or raw palm oil mill effluent (POME) into nearby rivers. Either partially treated or untreated POME depletes a water body of its oxygen and suffocates aquatic life. Vast amounts of biogas are also generated during anaerobic digestion of POME. This paper presented the key findings from the survey mailed to 86 palm oil mills located in Sarawak and Sabah. The survey results provide an overview of the position of the palm o...

  10. Understanding the oil palm change in Nong Khai Province: the farmers perspectives and the policy processes of the oil palm plantations

    OpenAIRE

    Sethaputra, Kampree

    2014-01-01

    Since 2005, the Thai government has, as a matter of policy, been seeking to increase production of biodiesel from oil palms. As a result, the number of oil palm plantations in the Northeast region has been growing, particularly in Nong Khai province. Nong Khai is a relatively remote, predominantly agricultural area and is the field site for this research. However, oil palm production is a complex and hotly contested issue both globally and in Thailand and it has ardent critics and supporters....

  11. Investigation on the Use of Palm Olein as Lubrication Oil

    Directory of Open Access Journals (Sweden)

    U. RATCHEL

    2006-01-01

    Full Text Available The research work is on the possibility of producing lubricating oil from vegetable oil with palm olein as a case study. The sample analysed was obtained from Vandeikya Local Government Area of Benue State. Some of the physical and chemical properties such as viscosity, flash/fire point, pour point and specific gravity were analysed. This sample was bleached to remove the red colour (carotene and gummy materials. The bleached sample was tested to determine the above mentioned properties. Comparison of the crude palm olein and the bleached sample with the conventional lubricants obtained from Elf Plc, Kaduna and Unipetrol Plc, Kaduna was made. Finally, it was discovered that the crude palm olein and the bleached sample exhibit a good base as a lubricant.

  12. Bioactive Compounds of Palm Fatty Acid Distillate (PFAD from Several Palm Oil Refineries

    Directory of Open Access Journals (Sweden)

    Teti Estiasih

    2013-09-01

    Full Text Available This research studied the characteristics of Palm Fatty Acids Distillates (PFADs from several palm oil refineries. It was aimed to know the potency of PFAD as bioactive compounds source, including vitamin E (mainly tocotrienols, phytosterols, squalene and possibly co-enzyme Q10 and polycosanol. Sampling was conducted at 6 palm oil refineries. The results showed that PFAD was dominated by free fatty acids of 85-95% with low oxidation level indicated by peroxide value of 1-10 meq/kg and anisidin value of 6-31. Bioactive compounds found were vitamin E 60-200 ppm, phytosterols 400-7500 ppm and squalene 400-2800 ppm, meanwhile polycosanol and co-enzyme Q10 were not found. Vitamin E was dominated by tocotrienols and γ tocotrienol was the major vitamin E, followed by α and δ tocotrienols. Phytosterols in PFADs from several palm oil refineries had variety in quantity and composition. Generally it was dominated by &beta sitosterol, followed by stigmasterol and campesterol

  13. Development of young oil palm tree recognition using Haar- based rectangular windows

    Science.gov (United States)

    Daliman, S.; Abu-Bakar, S. A. R.; Nor Azam, S. H. Md

    2016-06-01

    This paper presents development of Haar-based rectangular windows for recognition of young oil palm tree based on WorldView-2 imagery data. Haar-based rectangular windows or also known as Haar-like rectangular features have been popular in face recognition as used in Viola-Jones object detection framework. Similar to face recognition, the oil palm tree recognition would also need a suitable Haar-based rectangular windows that best suit to the characteristics of oil palm tree. A set of seven Haar-based rectangular windows have been designed to better match specifically the young oil palm tree as the crown size is much smaller compared to the matured ones. Determination of features for oil palm tree is an essential task to ensure a high successful rate of correct oil palm tree detection. Furthermore, features that reflects the identification of oil palm tree indicate distinctiveness between an oil palm tree and other objects in the image such as buildings, roads and drainage. These features will be trained using support vector machine (SVM) to model the oil palm tree for classifying the testing set and subimages of WorldView-2 imagery data. The resulting classification of young oil palm tree with sensitivity of 98.58% and accuracy of 92.73% shows a promising result that it can be used for intention of developing automatic young oil palm tree counting.

  14. CREATING THE STANDARD FOR SPECIFIC ENERGY CONSUMPTION AT PALM OIL INDUSTRY

    Directory of Open Access Journals (Sweden)

    Alfa Firdaus

    2016-02-01

    Full Text Available There is currently no standard for the Specific Energy Consumption (SEC in the palm oil industry. SEC is a value that can be used as an indicator to measure the optimization level in the use of energy. Indonesia as one of the largest palm oil producing countries requires a standard for energy intensity in the palm oil industry. SEC in palm oil mill is defined in the amount of energy per unit of production (kWh/kg. The classifying method that has been used in this study is K-means cluster analysis with the measurement samples in 14 palm oil mills for 12 months of period. This study has suggested the SEC standard for Indonesian palm oil industry and it is expected to be SEC reference for other studies in the palm oil industry.

  15. Suitability of online 3D visualization technique in oil palm plantation management

    Science.gov (United States)

    Mat, Ruzinoor Che; Nordin, Norani; Zulkifli, Abdul Nasir; Yusof, Shahrul Azmi Mohd

    2016-08-01

    Oil palm industry has been the backbone for the growth of Malaysia economy. The exports of this commodity increasing almost every year. Therefore, there are many studies focusing on how to help this industry increased its productivity. In order to increase the productivity, the management of oil palm plantation need to be improved and strengthen. One of the solution in helping the oil palm manager is by implementing online 3D visualization technique for oil palm plantation using game engine technology. The potential of this application is that it can helps in fertilizer and irrigation management. For this reason, the aim of this paper is to investigate the issues in managing oil palm plantation from the view of oil palm manager by interview. The results from this interview will helps in identifying the suitable issues could be highlight in implementing online 3D visualization technique for oil palm plantation management.

  16. Use of calcium oxide in palm oil methyl ester production

    Directory of Open Access Journals (Sweden)

    Kulchanat Prasertsit

    2014-04-01

    Full Text Available Introducing an untreated calcium oxide (CaO as a solid heterogeneous catalyst for biodiesel production from palm oil by transesterification was studied in this work. The four studied parameters were methanol to oil molar ratio, CaO catalyst concentration, reaction time, and water content. The results for palm oil show that when the water content is higher than 3%wt and the amount of CaO greater than 7%wt soap formation from saponification occurs. A higher methanol to oil molar ratio requires a higher amount of CaO catalyst to provide the higher product purity. The appropriate methanol to CaO catalyst ratio is about 1.56. Commercial grade CaO gives almost the same results as AR grade CaO. In addition, reusing commercial grade CaO for about 5 to 10 repetitions without catalyst regeneration drops the percentage of methyl ester purity approximately 5 to 10%, respectively.

  17. Large estragole fluxes from oil palms in Borneo

    Science.gov (United States)

    During two field campaigns (OP3 and ACES), which ran in Borneo in 2008, we measured large emissions of estragole in ambient air above oil palm canopies flower enclosures. However, we did not detect this compound at a nearby rainforest. Estragole is a known attractant of the Afric...

  18. Determinants of profitability of smallholder palm oil processing units ...

    African Journals Online (AJOL)

    ... of profitability of smallholder palm oil processing units in Ogun state, Nigeria. ... as well as their geographical spread covering the entire land space of the state. ... The F-ratio value is statistically significant (P<0.01) implying that the model is ...

  19. Oil palm expansion in Indonesia : serving people, planet and profit?

    NARCIS (Netherlands)

    Susanti, A.|info:eu-repo/dai/nl/343704676

    2016-01-01

    This study aimed to provide a more holistic understanding of how drivers at various levels interplay and continue to feed the expansion of oil palm plantations with its associated land use/cover change (LUCC) particularly deforestation, local economic development and people’s livelihoods. Recent

  20. Response of Palm Oil Sludge on Sexual Reproductive Biology and ...

    African Journals Online (AJOL)

    doris

    Experiment on the influence of different rates of palm oil sludge (0, 4000lit/ha, 8000lit/ha, ... practice is gradually phased out so as to facilitate continuous cropping system to meet ... principally used for human consumption and livestock feed.

  1. Clean technology for the crude palm oil industry in Thailand

    NARCIS (Netherlands)

    Chavalparit, O.

    2006-01-01

    The aims of this study were to assess the potential contribution of clean(er) technology to improve the environmental performance of the crude palm oil industry inThailand, to analyse implementation barriers for clea

  2. The application of foliar analysis in oil palm cultivation

    NARCIS (Netherlands)

    Broeshart, H.

    1955-01-01

    The chemical analysis of leaves was studied as an indication of fertilizer requirements of the oil-palm in the former Belgian Congo. Position and age of the leaf both markedly influenced chemical composition. Leaflets from the same position in leaf and plant must be compared. The age of the whole

  3. Oil palm expansion without enclosure: smallholders and environmental narratives

    NARCIS (Netherlands)

    Castellanos Navarrete, A.; Jansen, K.

    2015-01-01

    Recent debates on land grabbing and biofuels tend to link oil palm expansion to rural dispossession, environmental degradation and rural resistance. In this paper, we examine to what extent ‘enclosure’, a central concept in two critiques – ‘environmentalism of the poor’ and ‘green grabbing’ – is int

  4. Oil palm expansion in Indonesia : serving people, planet and profit?

    NARCIS (Netherlands)

    Susanti, A.

    2016-01-01

    This study aimed to provide a more holistic understanding of how drivers at various levels interplay and continue to feed the expansion of oil palm plantations with its associated land use/cover change (LUCC) particularly deforestation, local economic development and people’s livelihoods. Recent stu

  5. Quantifying nitrogen losses in oil palm plantations: models and challenges

    Science.gov (United States)

    Pardon, Lénaïc; Bessou, Cécile; Saint-Geours, Nathalie; Gabrielle, Benoît; Khasanah, Ni'matul; Caliman, Jean-Pierre; Nelson, Paul N.

    2016-09-01

    Oil palm is the most rapidly expanding tropical perennial crop. Its cultivation raises environmental concerns, notably related to the use of nitrogen (N) fertilisers and the associated pollution and greenhouse gas emissions. While numerous and diverse models exist to estimate N losses from agriculture, very few are currently available for tropical perennial crops. Moreover, there is a lack of critical analysis of their performance in the specific context of tropical perennial cropping systems. We assessed the capacity of 11 models and 29 sub-models to estimate N losses in a typical oil palm plantation over a 25-year growth cycle, through leaching and runoff, and emissions of NH3, N2, N2O, and NOx. Estimates of total N losses were very variable, ranging from 21 to 139 kg N ha-1 yr-1. On average, 31 % of the losses occurred during the first 3 years of the cycle. Nitrate leaching accounted for about 80 % of the losses. A comprehensive Morris sensitivity analysis showed the most influential variables to be soil clay content, rooting depth, and oil palm N uptake. We also compared model estimates with published field measurements. Many challenges remain in modelling processes related to the peculiarities of perennial tropical crop systems such as oil palm more accurately.

  6. Simulating potential growth and yield of oil palm with PALMSIM

    NARCIS (Netherlands)

    Hoffmann, M.P.; Vera, A.C.; Wijk, van M.T.; Giller, K.E.; Oberthur, R.; Donough, C.; Whitbread, A.M.; Fisher, M.J.

    2014-01-01

    The growing demand for palm oil can be met by reducing the gap between potential yield and actual yield. Simulation models can quantify potential yield, and therefore indicate the scope for intensification. A relatively simple physiological approach was used to develop PALMSIM, which is a model that

  7. Acetic acid based oil palm biomass refining process

    NARCIS (Netherlands)

    Harmsen, P.F.H.; Keijsers, E.R.P.; Lips, S.J.J.; Dam, van J.E.G.; Engelen-Smit, N.P.E.

    2011-01-01

    The invention relates to a process for refining a biomass from empty fruit bunches of oil palm with a dry matter content of 5-95 wt.%, based on the total wt. of the biomass, where the process comprises the subsequent stages of (a) water extn. under atm. pressure conditions and at pH of 5-7, (b) pre

  8. Simulating potential growth and yield of oil palm with PALMSIM

    NARCIS (Netherlands)

    Hoffmann, M.P.; Vera, A.C.; Wijk, van M.T.; Giller, K.E.; Oberthur, R.; Donough, C.; Whitbread, A.M.; Fisher, M.J.

    2014-01-01

    The growing demand for palm oil can be met by reducing the gap between potential yield and actual yield. Simulation models can quantify potential yield, and therefore indicate the scope for intensification. A relatively simple physiological approach was used to develop PALMSIM, which is a model that

  9. The application of foliar analysis in oil palm cultivation

    NARCIS (Netherlands)

    Broeshart, H.

    1955-01-01

    The chemical analysis of leaves was studied as an indication of fertilizer requirements of the oil-palm in the former Belgian Congo. Position and age of the leaf both markedly influenced chemical composition. Leaflets from the same position in leaf and plant must be compared. The age of the whole pa

  10. Sustainable biogas and biomass utilization in Malaysian palm oil industry

    Energy Technology Data Exchange (ETDEWEB)

    Wakisaka, Minato; Shirai, Yoshihito (Graduate School of Life Science and Systems Engineering, Kyushu Institute of Technology, Kitakyushu (Japan)); Yacob, Shahrakbah (Advanced Agriecological Research Sdn Bhd, Selangor (Malaysia)); Ali Hassan, M. (Dept. of Bioprocess Technology, Faculty of Biotechnology and Biomolecular Sciences, University Putra Malaysia, Serdang (Malaysia))

    2007-07-01

    Palm oil industry in Malaysia is producing palm oil more than 12 million tones every year, while yielding more than 14 million of empty fruit bunch (EFB) and 25 million tones of palm oil mill effluent (POME). In the POME treatment, huge anaerobic ponds (lagoon) are adopted, generating large amount of methane, more than 20 times global warming effect than CO{sub 2}. The objective of this research is to estimate actual methane emission from the POME treatment and to find out any possibility to utilize generated methane as an energy source under the Clean Development Mechanism (CDM). Methane emission of 0.238 kg CH{sub 4} per kg COD removed or 12.36 kg CH{sub 4} per tone POME are obtained from actual mill operation throughout annual measurement. This indicates that more than 200,000 tones of methane, which is equivalent to 4 million tones of carbon dioxide, are estimated to be emitted from whole Malaysia. 500 tones of methane fermentor installed to palm oil mill to prevent GHG emission under the CDM. By this, lagoon system as major source of local environment pollution necessary no more, thus obtaining another 3 to 4 times large land area than mill. Our proposal is to establish novel industry utilizing biogas energy for value added material or energy conversion of excess biomass, thus enabling reduction of GHG and local environment pollution and sustainable development of local community. (orig.)

  11. Comparison Study of Thermal Insulation Characteristics from Oil Palm Fibre

    Directory of Open Access Journals (Sweden)

    Hassan S.

    2014-07-01

    Full Text Available In this study, investigation was conducted to study the use of solid biomass from palm oil mill as insulation material. The experimental study concentrates on using oil palm fiber to determine the unidirectional thermal conductivity, k. The experiment was conducted at different temperature ranges and packing density. The values of k obtained were found to be 0.2 W/m.K to 0.069 W/m.K for a packing density between 66 kg/m3 to 110 kg/m3, and at a temperature between 40ºC to 70ºC. Comparisons were made with others common insulating materials, and it was found that the experimental k values for oil palm waste insulation was lower by between 4 to 56 times for rockwool and between 7 to 57 times for glass fiber at low temperatures. The value k of oil palm fiber however showed an increase at higher temperatures and was lower at lower packing densities. Although not being able to match the k values of common insulators at higher temperatures, other factors such as cost and environmental benefits of using waste material should be taken into consideration and hence encouraging its use as at least a supplement to existing insulation materials

  12. Economic potential of the oil palm (Elaeis guineensis Jacq

    Directory of Open Access Journals (Sweden)

    Juan Sierra Márquez

    2017-04-01

    Full Text Available The objective of this research was to highlight the economic importance of the optimal use of products and byproducts of oil palm. In Colombia, productive crops per hectare can generate, over one year, an average of 3.14 tons of oil, and up to 21.68 t of solid and liquid waste when the plant is on a productive stage. These data allowed the researcher to estimate that more than nine million of t of solid and liquid waste was produced from the 450 131 ha present in 2014, in Colombia; the produced biomass was used to generate energy and steam, releasing carbon dioxide back again into the environment. These residues have great potential in many industries, some to be developed, therefore, it is of special importance to try to maximize the use of waste produced by oil palm production, to generate economic and environmental benefits. An example of this is the palm kernel cake, with a nutritional potential in animal feed, fiber in the biocompound industry, biomass and stipe in the timber industry, glycerol, biodiesel, and liquid effluents in the chemical and biotechnological industry. The use of these raw materials may help to establish a positive balance in the cultivation of this species of oil palm in the country.

  13. A sub-canopy structure for simulating oil palm in the Community Land Model (CLM-Palm): phenology, allocation and yield

    OpenAIRE

    Fan, Y.; Roupsard, O.; M. Bernoux; Le Maire, G.; Panferov, O.; Kotowska, M. M.; Knohl, A

    2015-01-01

    In order to quantify the effects of forests to oil palm conversion occurring in the tropics on land–atmosphere carbon, water and energy fluxes, we develop a new perennial crop sub-model CLM-Palm for simulating a palm plant functional type (PFT) within the framework of the Community Land Model (CLM4.5). CLM-Palm is tested here on oil palm only but is meant of generic interest for other palm crops (e.g., coconut). The oil palm has monopodial morphology and sequential phenology of around 40 stac...

  14. Large estragole fluxes from oil palms in Borneo

    Directory of Open Access Journals (Sweden)

    P. K. Misztal

    2010-05-01

    Full Text Available During two field campaigns (OP3 and ACES, which ran in Borneo in 2008, we measured large emissions of estragole (methyl chavicol; IUPAC systematic name 1-allyl-4-methoxybenzene; CAS number 140-67-0 in ambient air above oil palm canopies (0.81 mg m−2 h−1 and 3.2 ppbv for mean midday fluxes and mixing ratios respectively and subsequently from flower enclosures. However, we did not detect this compound at a nearby rainforest. Estragole is a known attractant of the African oil palm weevil (Elaeidobius kamerunicus, which pollinates oil palms (Elaeis guineensis. There has been recent interest in the biogenic emissions of estragole but it is normally not included in atmospheric models of biogenic emissions and atmospheric chemistry despite its relatively high potential for secondary organic aerosol formation from photooxidation and high reactivity with OH radical. We report the first direct canopy-scale measurements of estragole fluxes from tropical oil palms by the virtual disjunct eddy covariance technique and compare them with previously reported data for estragole emissions from Ponderosa pine. Flowers, rather than leaves, appear to be the main source of estragole from oil palms; we derive a global estimate of estragole emissions from oil palm plantations of ~0.5 Tg y−1. The observed ecosystem mean fluxes (0.44 mg m−2 h−1 and mean ambient volume mixing ratios (3.0 ppbv of estragole are the highest reported so far. The value for midday mixing ratios is not much different from the total average as, unlike other VOCs (e.g. isoprene, the main peak occurred in the evening rather than in the middle of the day. Despite this, we show that the estragole flux can be parameterised using a modified G06 algorithm for emission. However, the model underestimates the afternoon peak even though a similar approach works well for isoprene. Our measurements suggest that this biogenic

  15. Large estragole fluxes from oil palms in Borneo

    Science.gov (United States)

    Misztal, P. K.; Owen, S. M.; Guenther, A. B.; Rasmussen, R.; Geron, C.; Harley, P.; Phillips, G. J.; Ryan, A.; Edwards, D. P.; Hewitt, C. N.; Nemitz, E.; Siong, J.; Heal, M. R.; Cape, J. N.

    2010-05-01

    During two field campaigns (OP3 and ACES), which ran in Borneo in 2008, we measured large emissions of estragole (methyl chavicol; IUPAC systematic name 1-allyl-4-methoxybenzene; CAS number 140-67-0) in ambient air above oil palm canopies (0.81 mg m-2 h-1 and 3.2 ppbv for mean midday fluxes and mixing ratios respectively) and subsequently from flower enclosures. However, we did not detect this compound at a nearby rainforest. Estragole is a known attractant of the African oil palm weevil (Elaeidobius kamerunicus), which pollinates oil palms (Elaeis guineensis). There has been recent interest in the biogenic emissions of estragole but it is normally not included in atmospheric models of biogenic emissions and atmospheric chemistry despite its relatively high potential for secondary organic aerosol formation from photooxidation and high reactivity with OH radical. We report the first direct canopy-scale measurements of estragole fluxes from tropical oil palms by the virtual disjunct eddy covariance technique and compare them with previously reported data for estragole emissions from Ponderosa pine. Flowers, rather than leaves, appear to be the main source of estragole from oil palms; we derive a global estimate of estragole emissions from oil palm plantations of ~0.5 Tg y-1. The observed ecosystem mean fluxes (0.44 mg m-2 h-1) and mean ambient volume mixing ratios (3.0 ppbv) of estragole are the highest reported so far. The value for midday mixing ratios is not much different from the total average as, unlike other VOCs (e.g. isoprene), the main peak occurred in the evening rather than in the middle of the day. Despite this, we show that the estragole flux can be parameterised using a modified G06 algorithm for emission. However, the model underestimates the afternoon peak even though a similar approach works well for isoprene. Our measurements suggest that this biogenic compound may have an impact on regional atmospheric chemistry that previously has not been

  16. Large estragole fluxes from oil palms in Borneo

    Directory of Open Access Journals (Sweden)

    P. K. Misztal

    2010-01-01

    Full Text Available During two field campaigns (OP3 and ACES, which ran in Borneo in 2008, we measured large emissions of estragole (methyl chavicol; IUPAC systematic name 1-allyl-4-methoxybenzene; CAS number 140-67-0 in ambient air above oil palm canopies (0.81 mg m−2 h−1 and 3.2 ppbv for mean midday fluxes and mixing ratios, respectively and subsequently from flower enclosures. However, we did not detect this compound at a nearby rainforest. Estragole is a known attractant of the African oil palm weevil (Elaeidobius kamerunicus, which pollinates oil palms (Elaeis guineensis. There has been recent interest in the biogenic emissions of estragole but it is normally not included in atmospheric models of biogenic emissions and atmospheric chemistry despite its relatively high potential for secondary organic aerosol formation from photooxidation and high reactivity with OH radical. We report the first direct canopy-scale measurements of estragole fluxes from tropical oil palms by the virtual disjunct eddy covariance technique and compare them with previously reported data for estragole emissions from Ponderosa pine. Flowers, rather than leaves, appear to be the main source of estragole from oil palms; we derive a global estimate of estragole emissions from oil palm plantations of ~0.5 Tg y−1. The observed ecosystem mean fluxes (0.44 mg m−2 h−1 and mean ambient volume mixing ratios (3.0 ppbv of estragole are the highest reported so far. The value for midday mixing ratios is not much different from the total average as, unlike other VOCs (e.g. isoprene, the main peak occurred in the evening rather than in the middle of the day. Despite this, we show that the estragole flux can be parameterised using a combination of a modified G06 algorithm for emission and a canopy resistance approach for deposition. However, the model underestimates the afternoon peak even though a similar approach works

  17. Oil palm biomass as an adsorbent for heavy metals.

    Science.gov (United States)

    Vakili, Mohammadtaghi; Rafatullah, Mohd; Ibrahim, Mahamad Hakimi; Abdullah, Ahmad Zuhairi; Salamatinia, Babak; Gholami, Zahra

    2014-01-01

    Many industries discharge untreated wastewater into the environment. Heavy metals from many industrial processes end up as hazardous pollutants of wastewaters.Heavy metal pollution has increased in recent decades and there is a growing concern for the public health risk they may pose. To remove heavy metal ions from polluted waste streams, adsorption processes are among the most common and effective treatment methods. The adsorbents that are used to remove heavy metal ions from aqueous media have both advantages and disadvantages. Cost and effectiveness are two of the most prominent criteria for choosing adsorbents. Because cost is so important, great effort has been extended to study and find effective lower cost adsorbents.One class of adsorbents that is gaining considerable attention is agricultural wastes. Among many alternatives, palm oil biomasses have shown promise as effective adsorbents for removing heavy metals from wastewater. The palm oil industry has rapidly expanded in recent years, and a large amount of palm oil biomass is available. This biomass is a low-cost agricultural waste that exhibits, either in its raw form or after being processed, the potential for eliminating heavy metal ions from wastewater. In this article, we provide background information on oil palm biomass and describe studies that indicate its potential as an alternative adsorbent for removing heavy metal ions from wastewater. From having reviewed the cogent literature on this topic we are encouraged that low-cost oil-palm-related adsorbents have already demonstrated outstanding removal capabilities for various pollutants.Because cost is so important to those who choose to clean waste streams by using adsorbents, the use of cheap sources of unconventional adsorbents is increasingly being investigated. An adsorbent is considered to be inexpensive when it is readily available, is environmentally friendly, is cost-effective and be effectively used in economical processes. The

  18. Development of an aerial counting system in oil palm plantations

    Science.gov (United States)

    Zulyma Miserque Castillo, Jhany; Laverde Diaz, Rubbermaid; Rueda Guzmán, Claudia Leonor

    2016-07-01

    This paper proposes the development of a counting aerial system capable of capturing, process and analyzing images of an oil palm plantation to register the number of cultivated palms. It begins with a study of the available UAV technologies to define the most appropriate model according to the project needs. As result, a DJI Phantom 2 Vision+ is used to capture pictures that are processed by a photogrammetry software to create orthomosaics from the areas of interest, which are handled by the developed software to calculate the number of palms contained in them. The implemented algorithm uses a sliding window technique in image pyramids to generate candidate windows, an LBP descriptor to model the texture of the picture, a logistic regression model to classify the windows and a non-maximum suppression algorithm to refine the decision. The system was tested in different images than the ones used for training and for establishing the set point. As result, the system showed a 95.34% detection rate with a 97.83% precision in mature palms and a 79.26% detection rate with a 97.53% precision in young palms giving an FI score of 0.97 for mature palms and 0.87 for the small ones. The results are satisfactory getting the census and high-quality images from which is possible to get more information from the area of interest. All this, achieved through a low-cost system capable of work even in cloudy conditions.

  19. SUSTAINABILITY OF SUSTAINABLE PALM OIL: A MARKET INTEGRATION ANALYSIS

    OpenAIRE

    Diana Chalil

    2016-01-01

    Crude Palm Oil (CPO) is the biggest consumed vegetable oil in the world. The increase in CPO production raises concern on the environmental impact even outside the producing countries. As a response to this matter, the EU has made a requirement to only import certified CPO (CSPO). India and China, the two biggest importers in the world, are less restrictive to the environmental issues, and their demands are more influenced by CPO price levels. These countries are the main export markets for I...

  20. Palm oil and derivatives: fuels or potential fuels?

    OpenAIRE

    Pioch Daniel; Vaitilingom Gilles

    2005-01-01

    Scientific and technical information including field trials about uses of palm oil as fuel has been available for more than half a century now. Several ways were investigated, from the simple mixture with petroleum Diesel fuel, to more sophisticated solutions. The quality of vegetable oils in natura as fuel is difficult to assess because of interferences between properties of the triacylglycerols – the main components – and those of the many minor components, their content varying significant...

  1. Biodiesel fuels from palm oil, palm oil methylester and ester-diesel blends

    Directory of Open Access Journals (Sweden)

    C.M.A.O. Martins

    2003-06-01

    Full Text Available Because of increasing cost and environmental pollution effects of fossil fuels, palm oil, its methylester and ester-diesel blends were analyzed comparatively with diesel for their fuel properties that will make them serve as alternatives to diesel in diesel engines. Equally, the samples were comparatively analyzed for their trace metal composition in relation to corrosion. Also the bond structure/stability of the samples in relation to diesel were monitored with a Fourier transform infrared spectrometer. Results confirmed that most methylester blends with diesel fell within the grade 2D while the oil, methylester and 90:10 blend fell into 4D grade diesel fuels. From bond structure/stability comparison, all the samples were stable at 28 oC and had similarity in structure with diesel. All samples are commercializable. The trace metal composition of most samples was below that of the diesel with exception of Mn, Pb and Zn. The total acid numbers of all samples were below that of diesel and would not cause corrosion. It is recommended that processing of these samples should be done to conserve fossil fuel and as alternative diesel fuels in diesel engines.

  2. Estimating primary productivity of tropical oil palm in Malaysia using remote sensing technique and ancillary data

    Science.gov (United States)

    Kanniah, K. D.; Tan, K. P.; Cracknell, A. P.

    2014-10-01

    The amount of carbon sequestration by vegetation can be estimated using vegetation productivity. At present, there is a knowledge gap in oil palm net primary productivity (NPP) at a regional scale. Therefore, in this study NPP of oil palm trees in Peninsular Malaysia was estimated using remote sensing based light use efficiency (LUE) model with inputs from local meteorological data, upscaled leaf area index/fractional photosynthetically active radiation (LAI/fPAR) derived using UK-DMC 2 satellite data and a constant maximum LUE value from the literature. NPP values estimated from the model was then compared and validated with NPP estimated using allometric equations developed by Corley and Tinker (2003), Henson (2003) and Syahrinudin (2005) with diameter at breast height, age and the height of the oil palm trees collected from three estates in Peninsular Malaysia. Results of this study show that oil palm NPP derived using a light use efficiency model increases with respect to the age of oil palm trees, and it stabilises after ten years old. The mean value of oil palm NPP at 118 plots as derived using the LUE model is 968.72 g C m-2 year-1 and this is 188% - 273% higher than the NPP derived from the allometric equations. The estimated oil palm NPP of young oil palm trees is lower compared to mature oil palm trees (trees contribute to lower oil palm LAI and therefore fPAR, which is an important variable in the LUE model. In contrast, it is noted that oil palm NPP decreases with respect to the age of oil palm trees as estimated using the allomeric equations. It was found in this study that LUE models could not capture NPP variation of oil palm trees if LAI/fPAR is used. On the other hand, tree height and DBH are found to be important variables that can capture changes in oil palm NPP as a function of age.

  3. EXPERIMENTAL JUSTIFICATION OF IDENTITY FEATURE CHOICE OF PALM OILS

    Directory of Open Access Journals (Sweden)

    Zh. V. Kadolich

    2015-01-01

    Full Text Available The method of thermally activated current spectroscopy was used for identification of two popular types of palm oils. The spectrum of thermally stimulated currents represents sufficiently intensive (up to 10-11 А current peaks conditioned by differences in fatty-acid composition of oils. Introduction of representation on unstable associates, in which coordination bonds connect molecules of fat acid’s glycerides, allow interpret the experimental data about the current response at oil specimens heating. The current’s peaks location in a certain temperature range of TSC spectrum can be considered as an identify feature of investigated vegetable oils

  4. Production of haploids and doubled haploids in oil palm

    Directory of Open Access Journals (Sweden)

    Croxford Adam E

    2010-10-01

    Full Text Available Abstract Background Oil palm is the world's most productive oil-food crop despite yielding well below its theoretical maximum. This maximum could be approached with the introduction of elite F1 varieties. The development of such elite lines has thus far been prevented by difficulties in generating homozygous parental types for F1 generation. Results Here we present the first high-throughput screen to identify spontaneously-formed haploid (H and doubled haploid (DH palms. We secured over 1,000 Hs and one DH from genetically diverse material and derived further DH/mixoploid palms from Hs using colchicine. We demonstrated viability of pollen from H plants and expect to generate 100% homogeneous F1 seed from intercrosses between DH/mixoploids once they develop female inflorescences. Conclusions This study has generated genetically diverse H/DH palms from which parental clones can be selected in sufficient numbers to enable the commercial-scale breeding of F1 varieties. The anticipated step increase in productivity may help to relieve pressure to extend palm cultivation, and limit further expansion into biodiverse rainforest.

  5. Biodiesel production via transesterification of palm olein using waste mud crab (Scylla serrata) shell as a heterogeneous catalyst.

    Science.gov (United States)

    Boey, Peng-Lim; Maniam, Gaanty Pragas; Hamid, Shafida Abd

    2009-12-01

    A recent rise in crab aquaculture activities has intensified the generation of waste shells. In the present study, the waste shells were utilized as a source of calcium oxide to transesterify palm olein into methyl esters (biodiesel). Characterization results revealed that the main component of the shell is calcium carbonate which transformed into calcium oxide when activated above 700 degrees C for 2 h. Parametric studies have been investigated and optimal conditions were found to be methanol/oil mass ratio, 0.5:1; catalyst amount, 5 wt.%; reaction temperature, 65 degrees C; and a stirring rate of 500 rpm. The waste catalyst performs equally well as laboratory CaO, thus creating another low-cost catalyst source for producing biodiesel. Reusability results confirmed that the prepared catalyst is able to be reemployed up to 11 times. Statistical analysis has been performed using a Central Composite Design to evaluate the contribution and performance of the parameters on biodiesel purity.

  6. Ergonomic Risk Assessment on Oil Palm Industry Workers

    Directory of Open Access Journals (Sweden)

    Baba Mohd DEROS

    2016-03-01

    Full Text Available Background: This study was an investigation conducted at two oil palm plantations in Slim River District, Perak, Malaysia on the prevalence of back pain among workers in the Malaysian oil palm industry. Many manual handling activities and tasks performed were not designed ergonomically, thus a high prevalence of musculoskeletal disorders was found among oil palm fresh fruit bunches (FFBs manual workers. The three main objectives of this study were to determine the level of employee awareness on health and safety of manual handling tasks; to recognize the musculoskeletal symptom on the workers body parts; and to analyze their working postures and identify the relevant risk factors.Methods: Modified Nordic questionnaire was used to collect data in 2012 at two oil palm plantations located in Slim River District, Perak, Malaysia. Later, Rapid Entire Body Assessment (REBA analysis was conducted for high risk working postures. Seventy workers participated in the study.Results: 81.4% of workers were aware on the correct methods to perform the manual handling tasks. The upper back and lower back pain were experienced by 87.1% and 94.3% of the workers respectively.Conclusion: Manual workers have high level (81.4% health and safety awareness on manual handling tasks but failed to practice it. As a result, 87.1% of them are sufferring from lower back and 94.3% from upper back pain. FFBs loading activity into the lorry is a high risk and changes needed to be done immediately. The two major risk factors identified were awkward lifting postures and repetitive lifting of FFBs. Keywords: Oil palm industry, Ergonomics, Posture, Musculoskeletal pain, workers

  7. Modification of oil palm wood using acetylation and impregnation process

    Science.gov (United States)

    Subagiyo, Lambang; Rosamah, Enih; Hesim

    2017-03-01

    The purpose of this study is chemical modification by process of acetylation and impregnation of oil palm wood to improve the dimensional stability. Acetylation process aimed at substituting the hydroxyl groups in a timber with an acetyl group. By increasing the acetyl groups in wood is expected to reduce the ability of wood to absorb water vapor which lead to the dimensions of the wood becomes more stable. Studies conducted on oil palm wood (Elaeis guineensis Jacq) by acetylation and impregnation method. The results showed that acetylated and impregnated wood oil palm (E. guineensis Jacq) were changed in their physical properties. Impregnation with coal ashfly provide the greatest response to changes in weight (in wet conditions) and after conditioning (dry) with the average percentage of weight gain of 198.16% and 66.41% respectively. Changes in volume indicates an increase of volume in the wet condition (imbibition) with the coal ashfly treatment gave highest value of 23.04 %, whereas after conditioning (dry) the highest value obtained in the treatment of gum rosin:ethanol with a volume increase of 13:44%. The highest changes of the density with the coal ashfly impregnation in wet condition (imbibition) in value of 142.32% and after conditioning (dry) of 57.87%. The result of reduction in water absorption (RWA) test showed that in the palm oil wood samples most stable by using of gum rosin : ethanol of 0.97%, whereas the increase in oil palm wood dimensional stability (ASE) is the best of 59.42% after acetylation with Acetic Anhydride: Xylene.

  8. Remotely sensed evidence of tropical peatland conversion to oil palm.

    Science.gov (United States)

    Koh, Lian Pin; Miettinen, Jukka; Liew, Soo Chin; Ghazoul, Jaboury

    2011-03-22

    Rising global demands for food and biofuels are driving forest clearance in the tropics. Oil-palm expansion contributes to biodiversity declines and carbon emissions in Southeast Asia. However, the magnitudes of these impacts remain largely unquantified until now. We produce a 250-m spatial resolution map of closed canopy oil-palm plantations in the lowlands of Peninsular Malaysia (2 million ha), Borneo (2.4 million ha), and Sumatra (3.9 million ha). We demonstrate that 6% (or ≈880,000 ha) of tropical peatlands in the region had been converted to oil-palm plantations by the early 2000s. Conversion of peatswamp forests to oil palm led to biodiversity declines of 1% in Borneo (equivalent to four species of forest-dwelling birds), 3.4% in Sumatra (16 species), and 12.1% in Peninsular Malaysia (46 species). This land-use change also contributed to the loss of ≈140 million Mg of aboveground biomass carbon, and annual emissions of ≈4.6 million Mg of belowground carbon from peat oxidation. Additionally, the loss of peatswamp forests implies the loss of carbon sequestration service through peat accumulation, which amounts to ≈660,000 Mg of carbon annually. By 2010, 2.3 million ha of peatswamp forests were clear-felled, and currently occur as degraded lands. Reforestation of these clearings could enhance biodiversity by up to ≈20%, whereas oil-palm establishment would exacerbate species losses by up to ≈12%. To safeguard the region's biodiversity and carbon stocks, conservation and reforestation efforts should target Central Kalimantan, Riau, and West Kalimantan, which retain three-quarters (3.9 million ha) of the remaining peatswamp forests in Southeast Asia.

  9. An Experimental Study on Effect of PalmShell Waste Additive to Cement Strenght Enhancement

    Directory of Open Access Journals (Sweden)

    Adi Novriansyah

    2017-03-01

    Full Text Available Enhancing the cement strength through attaching chemical additive has been popular to meet the required condition for a particular well-cementing job. However, due to a low oil-price phenomenon, pouring and additive should be reconsidered because it can raise the cost and make the project become uneconomic. Another additive material in nanocomposite form will be introduced through this experimental study. The nanocomposite material consist of silica nanoparticle, known as “Nanosilica” and a palm-shell-waste, which is abundant in Indonesia. Before making a nanocomposite, the palm-shell should be burned to obtain a charcoal form, ground and sieved to attain a uniform size.   The study focuses on the two parameters, compressive strength and shear bond strength, which can reflect the strength of the cement. These values are obtained by performing a biaxial loading test to the cement sample. Various samples with different concentration of nanocomposite should be prepared and following the mixing, drying, and hardening process before the loading test is carried out. The result from the test shows a positive indication for compressive strength and shear bond strength values, according to the representative well cementing standards. Increasing the nanocomposite concentration on the cement will increase these values. Furthermore, an investigation on the temperature effect confirms that the sample with 700oC burning temperature have highest compressive-strength and shear-bond-strength values. This is a potential opportunity utilizing a waste-based material to produce another product with higher economic value.

  10. Recovery of Palm Oil and Valuable Material from Oil Palm Empty Fruit Bunch by Sub-critical Water.

    Science.gov (United States)

    Ahmad Kurnin, Nor Azrin; Shah Ismail, Mohd Halim; Yoshida, Hiroyuki; Izhar, Shamsul

    2016-01-01

    Oil palm empty fruit bunch (EFB) is one of the solid wastes produced in huge volume by palm oil mill. Whilst it still contains valuable oil, approximately 22.6 million tons is generated annually and treated as solid waste. In this work, sub-critical water (sub-cw) was used to extract oil, sugar and tar from spikelet of EFB. The spikelet was treated with sub-cw between 180-280°C and a reaction time of 2 and 5 minutes. The highest yield of oil was 0.075 g-oil/g-dry EFB, obtained at 240°C and reaction time of 5 minutes. Astonishingly, oil that was extracted through this method was 84.5% of that obtained through Soxhlet method using hexane. Yield of oil extracted was strongly affected by the reaction temperature and time. Higher reaction temperature induces the dielectric constant of water towards the non-polar properties of solvent; thus increases the oil extraction capability. Meanwhile, the highest yield of sugar was 0.20 g-sugar/g-dry EFB obtained at 220°C. At this temperature, the ion product of water is high enough to enable maximum sub-critical water hydrolysis reaction. This study showed that oil and other valuable material can be recovered using water at sub-critical condition, and most attractive without the use of harmful organic solvent.

  11. Devolatilization Studies of Oil Palm Biomass for Torrefaction Process through Scanning Electron Microscopy

    Science.gov (United States)

    Daud, D.; Abd. Rahman, A.; Shamsuddin, A. H.

    2016-03-01

    In this work, palm oil biomass consisting of empty fruit bunch (EFB), mesocarp fibre and palm kernel shell (PKS) were chosen as raw material for torrefaction process. Torrefaction process was conducted at various temperatures of 240 °C, 270 °C and 300 °C with a residence time of 60 minutes. The morphology of the raw and torrefied biomass was then observed through Scanning Electron Microscopy (SEM) images. Also, through this experiment the correlation between the torrefaction temperatures with the volatile gases released were studied. From the observation, the morphology structure of the biomass exhibited inter-particle gaps due to the release of volatile gases and it is obviously seen more at higher temperatures. Moreover, the change of the biomass structure is influenced by the alteration of the lignocellulose biomass.

  12. The Impacts of Oil Palm on Recent Deforestation and Biodiversity Loss

    OpenAIRE

    Varsha Vijay; Pimm, Stuart L.; Clinton N Jenkins; Smith, Sharon J.

    2016-01-01

    Palm oil is the most widely traded vegetable oil globally, with demand projected to increase substantially in the future. Almost all oil palm grows in areas that were once tropical moist forests, some of them quite recently. The conversion to date, and future expansion, threatens biodiversity and increases greenhouse gas emissions. Today, consumer pressure is pushing companies toward deforestation-free sources of palm oil. To guide interventions aimed at reducing tropical deforestation due to...

  13. TRANSFORMATION VERSUS STAGNATION IN THE OIL PALM INDUSTRY: A COMPARISON BETWEEN MALAYSIA AND NIGERIA

    OpenAIRE

    Kajisa, Kei; Maredia, Mywish K.; Boughton, Duncan

    1997-01-01

    This paper contrasts the successful transformation of the oil palm sector in Malaysia with the stagnation of the oil palm sector in Nigeria, and examines the factors determining the different paths that the oil palm sectors took in these two countries with the aim of drawing lessons for future development and transfer strategy in Nigeria. Comparing two countries in different regions is not easy, especially when Nigeria has been in political chaos and the agro-climatic environments for oil-pal...

  14. LIFE CYCLE ASSESSMENT FOR OIL PALM BASED PLYWOOD: A GATE-TO-GATE CASE STUDY

    OpenAIRE

    M. Shamim Ahmad; Vijaya Subramaniam; Halimah Mohammad; Anis Mokhtar; B. S. Ismail

    2014-01-01

    Life Cycle Assessment (LCA) is an important tool for identifying potential environmental impacts associated with the production of palm based plywood. This study is to make available the life cycle inventory for gate-to-gate data so that the environmental impact posed by oil palm based plywood production can be assessed. Conducting an LCA on the palm based plywood that are derived from the wastes of the oil palm industry is a first step towards performing green environmental product. Therefor...

  15. Phenology of the oil palm interspecific hybrid Elaeis oleifera × Elaeis guineensis

    OpenAIRE

    Paola Hormaza; Eloina Mesa Fuquen; Hernán Mauricio Romero

    2012-01-01

    Oil palm is one of the most important oil crops in the world. Because of its high productivity and perennial nature, it has been expanding quickly. Commercial plantations consist mostly of the African palm E. guineensis Jacq. However, producers in Latin America are increasingly planting the O × G interspecific hybrid, a cross between African palm (E. guineensis) and the American palm (E. oleifera (Kunth) Cortés). This interspecific hybrid has emerged as a promising solution to diseases such a...

  16. Greenhouse gas emissions and energy balance of palm oil biofuel

    Energy Technology Data Exchange (ETDEWEB)

    de Souza, Simone Pereira; Pacca, Sergio [Graduate Program on Environmental Engineering Science, School of Engineering of Sao Carlos, University of Sao Paulo, Rua Arlindo Bettio, 1000 Sao Paulo (Brazil); de Avila, Marcio Turra; Borges, Jose Luiz B. [Brazilian Agricultural Research Corporation (Embrapa - Soja) (Brazil)

    2010-11-15

    The search for alternatives to fossil fuels is boosting interest in biodiesel production. Among the crops used to produce biodiesel, palm trees stand out due to their high productivity and positive energy balance. This work assesses life cycle emissions and the energy balance of biodiesel production from palm oil in Brazil. The results are compared through a meta-analysis to previous published studies: Wood and Corley (1991) [Wood BJ, Corley RH. The energy balance of oil palm cultivation. In: PORIM intl. palm oil conference - agriculture; 1991.], Malaysia; Yusoff and Hansen (2005) [Yusoff S, Hansen SB. Feasibility study of performing an life cycle assessment on crude palm oil production in Malaysia. International Journal of Life Cycle Assessment 2007;12:50-8], Malaysia; Angarita et al. (2009) [Angarita EE, Lora EE, Costa RE, Torres EA. The energy balance in the palm oil-derived methyl ester (PME) life cycle for the cases in Brazil and Colombia. Renewable Energy 2009;34:2905-13], Colombia; Pleanjai and Gheewala (2009) [Pleanjai S, Gheewala SH. Full chain energy analysis of biodiesel production from palm oil in Thailand. Applied Energy 2009;86:S209-14], Thailand; and Yee et al. (2009) [Yee KF, Tan KT, Abdullah AZ, Lee KT. Life cycle assessment of palm biodiesel: revealing facts and benefits for sustainability. Applied Energy 2009;86:S189-96], Malaysia. In our study, data for the agricultural phase, transport, and energy content of the products and co-products were obtained from previous assessments done in Brazil. The energy intensities and greenhouse gas emission factors were obtained from the Simapro 7.1.8. software and other authors. These factors were applied to the inputs and outputs listed in the selected studies to render them comparable. The energy balance for our study was 1:5.37. In comparison the range for the other studies is between 1:3.40 and 1:7.78. Life cycle emissions determined in our assessment resulted in 1437 kg CO{sub 2}e/ha, while our analysis

  17. Stability analysis of oil yield in oil palm (Elaeis guineensis) progenies in different environments.

    Science.gov (United States)

    Rafii, M Y; Jalani, B S; Rajanaidu, N; Kushairi, A; Puteh, A; Latif, M A

    2012-10-04

    We evaluated 38 dura x pisifera (DP) oil palm progenies in four locations in Malaysia for genotype by environment interaction and genotypic stability studies. The DP progenies derived from crosses between pisifera palms of AVROS, Serdang S27B, Serdang 29/36, and Lever Cameroon were chosen to be the males' parent and Deli dura palms designated as females' parent. All the locations differed in terms of soil physical and chemical properties, and the soil types ranged from coastal clay to inland soils. The genotype by environment interaction and stability of the individual genotypes were analyzed for oil yield trait using several stability techniques. A genotype by environment interaction was detected for oil yield and it had a larger variance component than genotypic variance (σ(2)(gl)/σ(2)(g) = 139.7%). Genotype by environment interaction of oil yield was largely explained by a non-linear relationship between genotypic and environmental values. Overall assessment of individual genotypic stability showed that seven genotypes were highly stable and had consistent performance over the environments for the oil yield trait [total individual genotype stability scored more than 10 and mean oil yielded above the average of the environment (genotype means are more than 34.37 kg·palm(-1)·year(-1))]. These genotypes will be useful for oil palm breeding and tissue culture programs for developing high oil yielding planting materials with stable performance.

  18. Hydrological and economic effects of oil palm cultivation in Indonesian peatlands

    Directory of Open Access Journals (Sweden)

    Elham Sumarga

    2016-06-01

    Full Text Available Oil palm has increasingly been established on peatlands throughout Indonesia. One of the concerns is that the drainage required for cultivating oil palm in peatlands leads to soil subsidence, potentially increasing future flood risks. This study analyzes the hydrological and economic effects of oil palm production in a peat landscape in Central Kalimantan. We examine two land use scenarios, one involving conversion of the complete landscape including a large peat area to oil palm plantations, and another involving mixed land use including oil palm plantations, jelutung (jungle rubber; (Dyera spp. plantations, and natural forest. The hydrological effect was analyzed through flood risk modeling using a high-resolution digital elevation model. For the economic analysis, we analyzed four ecosystem services: oil palm production, jelutung production, carbon sequestration, and orangutan habitat. This study shows that after 100 years, in the oil palm scenario, about 67% of peat in the study area will be subject to regular flooding. The flood-prone area will be unsuitable for oil palm and other crops requiring drained soils. The oil palm scenario is the most profitable only in the short term and when the externalities of oil palm production, i.e., the costs of CO2 emissions, are not considered. In the examined scenarios, the social costs of carbon emissions exceed the private benefits from oil palm plantations in peat. Depending upon the local hydrology, income from jelutung, which can sustainably be grown in undrained conditions and does not lead to soil subsidence, outweighs that from oil palm after several decades. These findings illustrate the trade-offs faced at present in Indonesian peatland management and point to economic advantages of an approach that involves expansion of oil palm on mineral lands while conserving natural peat forests and using degraded peat for crops that do not require drainage.

  19. Effect of Feeding Soybean and Palm Blended Oil on Laying Performance and Egg Quality

    Directory of Open Access Journals (Sweden)

    Niwat MUANGKEOW

    2011-01-01

    Full Text Available The effect of blended dietary oil on the laying performance of hens and the fatty acid profiles of eggs produced by 21 to 40 wk old Dekalb Brown laying hens were investigated. The experimental design was a completely randomized design using a 4 × 2 factorial arrangement with one control. The different oil sources did not influence egg production, egg weight, egg mass, feed intake, feed efficiency, Haugh unit or egg shell thickness. However lipid profile of the egg yolk changed as a function of dietary lipid sources. The fatty acid composition of egg yolks produced by the laying hens was analyzed. The fatty acid profile of eggs can be modified by varying the lipid composition of their diet. High inclusion levels of dietary palm olein oil (POO or blended oil (POO plus soybean oil - SBO concentrations of total saturated fatty acid (SFA in egg yolks decreased, with SFA = 24.8167 - 0.63Oil, r2 = 0.66 (P < 0.05. Eggs laid by hens fed the diet containing a high portion of soybean oil had a large amount of n-6 polyunsaturated fatty acids (PUFA, whereas egg laid by hens fed the diet containing POO or blended oil 25 % POO plus 75 % SBO at 1.5 % level of inclusion had a high percentage of n-3 PUFA and n-9 family. The addition of blended palm olein oil plus soybean oil decreased the concentration of saturated fatty acids while increased the concentrations of monounsaturated fatty acid, a-linolenic and docosahexaenoic acid (DHA. It did not promote the enrichment of the eggs with PUFA.

  20. Re-esterified palm oils, compared to native palm oil, do not alter fat absorption, postprandial lipemia or growth performance in broiler chicks.

    Science.gov (United States)

    Vilarrasa, E; Tres, A; Bayés-García, L; Parella, T; Esteve-Garcia, E; Barroeta, A C

    2014-08-01

    Re-esterified palm oils are obtained from the chemical esterification of palm acid oils (rich in free fatty acids) with glycerol, both economically interesting by-products from oil refining and biodiesel industries, respectively. Thus, re-esterified palm oils could be an economically interesting alternative to native palm oil in broiler chick diets. However, because they may have different physicochemical properties than have their corresponding native oil, we assessed the effect of fatty acid (FA) positional distribution within acylglycerol molecules and the effect of acylglycerol composition on FA apparent absorption, and their possible consequences on the evolution of postprandial lipemia and growth performance in broiler chicks. Seventy-two 1-day-old female broiler chicks were randomly distributed into 18 cages. The three treatments used were the result of a basal diet supplemented with 6 wt% of native palm oil (N-TAG), re-esterified palm oil (E-TAG), or re-esterified palm oil high in mono- and diacylglycerols (E-MDAG). Chemical esterification raised the fraction of palmitic acid at the sn-2 position from 9.63 mol% in N-TAG oil to 17.9 mol% in E-TAG oil. Furthermore, E-MDAG oil presented a high proportion of mono- (23.1 wt%) and diacylglycerols (51.2 wt%), with FA mainly located at the sn-1,3 positions, which resulted in a lower gross-energy content and an increased solid-fat index at the chicken's body temperature. However, re-esterified palm oils did not alter fat absorption, postprandial lipemia, or growth performance, compared to native palm oil, so they can be used as alternative fat sources in broiler chick diets.

  1. Improved Method for the Qualitative Analyses of Palm Oil Carotenes Using UPLC.

    Science.gov (United States)

    Ng, Mei Han; Choo, Yuen May

    2016-04-01

    Palm oil is the richest source of natural carotenes, comprising 500-700 ppm in crude palm oil (CPO). Its concentration is found to be much higher in oil extracted from palm-pressed fiber, a by-product from the milling of oil palm fruits. There are 11 types of carotenes in palm oil, excluding the cis/trans isomers of some of the carotenes. Qualitative separation of these individual carotenes is particularly useful for the identification and confirmation of different types of oil as the carotenes profile is unique to each type of vegetable oil. Previous studies on HPLC separation of the individual palm carotenes reported a total analyses time of up to 100 min using C30 stationary phase. In this study, the separation was completed in <5 min. The qualitative separation was successfully carried out using a commonly used stationary phase, C18.

  2. Comprehensive analysis of lipid composition in crude palm oil using multiple lipidomic approaches.

    Science.gov (United States)

    Cheong, Wei Fun; Wenk, Markus R; Shui, Guanghou

    2014-05-20

    Palm oil is currently the leading edible oil consumed worldwide. Triacylglycerol (TAG) and diacylglycerol (DAG) are the dominant lipid classes in palm oil. Other lipid classes present in crude palm oil, such as phospholipids and galactolipids, are very low in abundance. These low-abundance lipids constitute key intermediates in lipid biosynthesis. In this study, we applied multiple lipidomic approaches, including high-sensitivity and high-specificity multiple reaction monitoring, to comprehensively quantify individual lipid species in crude palm oil. We also established a new liquid chromatography-coupled mass spectrometry method that allows direct quantification of low-abundance galactolipids in palm oil without the need for sample pretreatment. As crude palm oil contains large amounts of neutral lipids, our direct-detection method circumvents many of the challenges encountered with conventional lipid quantification methods. This approach allows direct measurement of lipids with no hassle during sample preparation and is more accurate and precise compared with other methods.

  3. Sorption Kinetics for the Removal of Cadmium and Zinc onto Palm Kernel Shell Based Activated Carbon

    Directory of Open Access Journals (Sweden)

    Muhammad Muhammad

    2010-12-01

    Full Text Available The kinetics and mechanism of cadmium and zinc adsorption on palm kernel shell based activated carbons (PKSAC have been studied. A series of batch laboratory studies were conducted in order to investigate the suitability of palm kernel shell based activated carbon (PKSAC for the removal of cadmium (cadmium ions and zinc (zinc ions from their aqueous solutions. All batch experiments were carried out at pH 7.0 and a constant temperature of 30+-1°C using an incubator shaker that operated at 150 rpm. The kinetics investigated includes the pseudo first order, the pseudo-second order and the intraparticle diffusion models. The pseudo-second order model correlate excellently the experimental data, suggesting that chemisorption processes could be the rate-limiting step. Keywords: adsorption, cadmium, kinetics, palm kernel shell, zinc

  4. Effects of palm and sunflower oils on serum cholesterol and fatty liver in rats.

    Science.gov (United States)

    Go, Ryeo-Eun; Hwang, Kyung-A; Kim, Ye-Seul; Kim, Seung-Hee; Nam, Ki-Hoan; Choi, Kyung-Chul

    2015-03-01

    Palm oil is a common cooking ingredient used in the commercial food industry as the second largest consumed vegetable oil in the world. Because of its lower cost and highly saturated nature, it usually maintains a solid form at room temperature and is used as a cheap substitute for butter. However, there has been a growing health concern about palm oil because of the link between dietary fats and coronary heart disease. Palm oil contains ∼49% saturated fat, a relatively high concentration compared with other vegetable oils. Consequently, high intakes of saturated fat from palm oil induce a larger increase in plasma concentrations of total cholesterol and low-density lipoproteins. In the present study, we examined the hyperlipidemia of palm oil and the risk of cardiovascular disease (CVD) using a rat model in comparison with sunflower oil with a relatively low level of saturated fat. On in vivo examination using Sprague-Dawley (SD) rats for 22 days, there were no significant differences in serum lipid levels, suggesting that palm oil may not cause hyperlipidemia and elevate CVD risk. However, liver samples obtained from SD rats fed with palm oil showed a lot of large lipid inclusions stained with the Oil Red O working solution, but not much lipid accumulation was observed in rats treated with sunflower oil. In addition, lipid accumulation in the mixed oil group fed the combination of palm and sunflower (1:1) oil was shown to be at an intermediary level between the palm oil group and sunflower oil group. Taken together, these results indicate that palm oil, a highly saturated form of vegetable oil, may induce dysfunction of the liver lipid metabolism before affecting serum lipid levels. On the other hand, sunflower oil, a highly unsaturated vegetable oil, was shown to be well metabolized in liver.

  5. Oil palm biotechnologies are definitely out of infancy

    Directory of Open Access Journals (Sweden)

    Rival Alain

    2010-11-01

    Full Text Available Although biotechnologies and sustainable development are often considered as antagonists, there is increasing evidence for a role for this approach in the ecological intensification of oil palm cultivation. Ecological intensification is based on the understanding of how nature functions so as to exploit its resources without destroying it. Living organisms are supported by the genome (DNA through the action of the transcriptome (RNAs, proteome, metabolome, and ionome, the four basic pillars of functional genomics. These pillars represent the sum of all the expressed genes, proteins, metabolites, and elements within an organism. The dynamic response and interaction of these biochemical “omes” defines how a living system functions, and its study, systems biology, is now one of the biggest challenges in life sciences. In oil palm, as in many major crops, functional genomics is still at its beginning, although there are no reasons why oil palm should not rapidly benefit from the fast progresses generated by automated and high-throughput technologies. The success of sequencing projects on model plants has created a widespread interest in exploring the structure and expression patterns of the genome. Indeed, several institutions have now achieved the full sequencing of the oil palm genome, paving the way for the rapid evolution of various genomics-based approaches. Oil palm breeding has provided an average 1% of genetic gain per year since the early 1960s and such an impressive increase in oil yield will be maintained in future generations with a major contribution from biotechnology. Indeed, the recent adoption of biotechnological approaches has already proven very useful in major areas such as cloning of outstanding material, identity checking of progenies/mother palms, identification and characterization of genes underlying agricultural traits, etc. Phenotypic differences among individuals are partly the result of quantitative differences in

  6. Breeding the oil palm (Elaeis guineensis Jacq. for climate change

    Directory of Open Access Journals (Sweden)

    Rival Alain

    2017-01-01

    Full Text Available Breeding the oil palm (Elaeis guineensis Jacq. for climate change requires multidisciplinary and collaborative research by nature: indeed – besides genetics and structural and functional genomics – almost all disciplines related to life sciences are involved. Research work also relies on the identification of genetic variation in the strategies of response to stress developed by the plant: this implies the exploration of resources provided by natural variation, germplasm collections, selected genitors from breeding programs together with material of interest collected from smallholders. The phenotyping of selected plant material under biotic/abiotic stress will involve new methods for high-throughput phenotyping and genomic approaches will be followed for the identification of genes underlying the variation of traits which will be used as selection targets. Also, improvements in understanding how climate change may influence chemical and physical processes in soils, how this may affect nutrient availability, and how the plant responds to changed availability of nutrients will also influence oil palm breeding programs. Molecular approaches and tools have great potential to optimize patterns of plant breeding, especially for perennial species. In recent years, there has been an exponential increase in molecular resources and methods aimed at identifying polymorphisms which control the traits of interest and exploring the mechanisms linking these polymorphisms to phenotypes. With genomic resources becoming increasingly available for the oil palm (sequencing, resequencing and chips development the exploration of the genetic basis of complex traits such as oil yield or resistance to disease is now possible. Consequently the availability and sharing of such a large amount of data is currently reshaping most of oil palm breeding strategies.

  7. Dissipation of the fungicide hexaconazole in oil palm plantation.

    Science.gov (United States)

    Maznah, Zainol; Halimah, Muhamad; Ismail, Sahid; Idris, Abu Seman

    2015-12-01

    Hexaconazole is a potential fungicide to be used in the oil palm plantation for controlling the basal stem root (BSR) disease caused by Ganoderma boninense. Therefore, the dissipation rate of hexaconazole in an oil palm agroecosystem under field conditions was studied. Two experimental plots were treated with hexaconazole at the recommended dosage of 4.5 g a.i. palm(-1) (active ingredient) and at double the recommended dosage (9.0 g a.i. palm(-1)), whilst one plot was untreated as control. The residue of hexaconazole was detected in soil samples in the range of 2.74 to 0.78 and 7.13 to 1.66 mg kg(-1) at the recommended and double recommended dosage plots, respectively. An initial relatively rapid dissipation rate of hexaconazole residues occurred but reduced with time. The dissipation of hexaconazole in soil was described using first-order kinetics with the value of coefficient regression (r (2) > 0.8). The results indicated that hexaconazole has moderate persistence in the soil and the half-life was found to be 69.3 and 86.6 days in the recommended and double recommended dosage plot, respectively. The results obtained highlight that downward movement of hexaconazole was led by preferential flow as shown in image analysis. It can be concluded that varying soil conditions, environmental factors, and pesticide chemical properties of hexaconazole has a significant impact on dissipation of hexaconazole in soil under humid conditions.

  8. Simple Arm Muscle Model for Oil Palm Harvesting Process

    Directory of Open Access Journals (Sweden)

    Rahman Aliff

    2017-01-01

    Full Text Available Arm are essential in order to perform manual material handling work that normally involves lifting, handling, placing, push and pull, carrying and moving heavy loads. When these work elements are performed over prolonged periods repeatedly, it will expose workers arm to awkward posture and possible ergonomic risk factor. For example, work element that requires repetitions frequently may lead the arm to face physical stress and mental fatigue. The situation can be extremely risky if the worker task requires higher focus or time consumable. These issues are unavoidable in palm oil harvesting process since the workers are still using manual handling when harvesting the fresh fruit bunch (FFB. The worker using a chisel to harvest the young palms and a sickle mounted on a bamboo or aluminum pole to harvest taller palms. When perform this work element combining with heavy physical workload, it may lead to work-related muscle disorders (WSMDs. This study was conducted to identify the force reaction and inverse dynamic analysis during oil palm harvesting process using ergonomics software called Anybody Technology. Inverse dynamic analysis is a technique for figuring strengths and/or moments of power (torques taking into account the kinematics (movement of a body and the body’s inertial properties.

  9. Morphology and protein molecular weight analysis from three variant of oil palm pollen; Dura, Pisifera, and Tenera

    Science.gov (United States)

    Priambodo, R.; Witarto, A. B.; Salamah, A.; Setiorini, Triyono, D.; Bowolaksono, A.

    2017-07-01

    Oil palm is a plant that widely cultivated in Indonesia, with an area of about 11 million hectares in 2014. There are three main variants that most cultivated; Dura, Pisifera, and Tenera. Oil palm pollen was spread through the wind. The very wide area of oil palm plantation and those characteristics of oil palm pollen dispersion makes oil palm pollen may give negative effect to the people around plantation, such as an allergy. The research on the morphology and protein characters of the oil palm pollen from three variants has not done yet. This research aims to observe the morphology and protein character from three variants of oil palm pollen. The study begins with the pollen collection from three variants of oil palm. Oil palm pollen was observed using the light and scanning electron microscope. Oil palm pollen protein was extracted and the molecular weight of these proteins was analyzed. The result of this research was the morphology character from three variants of oil palm pollen have successfully been observed. Those three variant of oil palm have no differences structures; triangular shaped with round edge, tricolpate with connected colpus aperture, psilate exine ornamentation at the front side and peripheral side, while at the back side has microreticulate exine ornamentation. Three variants of oil palm pollen protein show the same characteristics. The molecular weight of the protein was ranged from 10-00 KDa. The information can be useful for the next research to figure out component of proteins inside the oil palm pollen.

  10. Neural Network in Modeling Malaysian Oil Palm Yield

    Directory of Open Access Journals (Sweden)

    Zuhaimy Ismail

    2011-01-01

    Full Text Available Problem statement: Forecasting of palm oil yield has become an important element in the management of oil palm industry for proper planning and decision making. The importance of yield forecasting has led us to explore modeling of palm oil yield for Malaysia using the most recent development of Artificial Neural Network (ANN. The main issue in yield forecasting is to predict the future value with the minimum error. Approach: Artificial neural networks are computing systems containing many interconnected nonlinear neurons, capable of extracting linear and nonlinear regularity in a given data set. It is an artificial intelligence model originally designed to replicate the human brains learning process, a network with many elements or neurons that are connected by communications channels or connectors. The ANN can perform a particular function when certain values are assigned to the connections or weights between elements. In this study, a secondary data set from the Malaysian Palm Oil Board (MPOB on the foliar nutrient composition, fertilizer trials and Fresh Fruit Bunch (FFB yield were taken and analyzed. The foliar nutrient composition variables are the nitrogen N, phosphorus P, potassium K, calcium Ca and magnesium Mg concentration, while the fertilizer trials data are the N, P, K and Mg fertilizers and are measured in kg per palm per year. The foliar composition data was presented in the form of measured values whiles the fertilizer data in ordinal levels, from zero to three. Results: Two experiments were conducted to demonstrate the implementation ANN and for both experiment, the result demonstrated that the number of hidden nodes produces an effect to the overall forecast performance of the ANN architecture. From the first experiment, it shows that the number of runs does not affect the ANN performance, but changing the momentum to learning rates, due to shows a significant improvement in the forecast result. The experimental result will be

  11. The Impacts of Oil Palm on Recent Deforestation and Biodiversity Loss.

    Science.gov (United States)

    Vijay, Varsha; Pimm, Stuart L; Jenkins, Clinton N; Smith, Sharon J

    2016-01-01

    Palm oil is the most widely traded vegetable oil globally, with demand projected to increase substantially in the future. Almost all oil palm grows in areas that were once tropical moist forests, some of them quite recently. The conversion to date, and future expansion, threatens biodiversity and increases greenhouse gas emissions. Today, consumer pressure is pushing companies toward deforestation-free sources of palm oil. To guide interventions aimed at reducing tropical deforestation due to oil palm, we analysed recent expansions and modelled likely future ones. We assessed sample areas to find where oil palm plantations have recently replaced forests in 20 countries, using a combination of high-resolution imagery from Google Earth and Landsat. We then compared these trends to countrywide trends in FAO data for oil palm planted area. Finally, we assessed which forests have high agricultural suitability for future oil palm development, which we refer to as vulnerable forests, and identified critical areas for biodiversity that oil palm expansion threatens. Our analysis reveals regional trends in deforestation associated with oil palm agriculture. In Southeast Asia, 45% of sampled oil palm plantations came from areas that were forests in 1989. For South America, the percentage was 31%. By contrast, in Mesoamerica and Africa, we observed only 2% and 7% of oil palm plantations coming from areas that were forest in 1989. The largest areas of vulnerable forest are in Africa and South America. Vulnerable forests in all four regions of production contain globally high concentrations of mammal and bird species at risk of extinction. However, priority areas for biodiversity conservation differ based on taxa and criteria used. Government regulation and voluntary market interventions can help incentivize the expansion of oil palm plantations in ways that protect biodiversity-rich ecosystems.

  12. The Impacts of Oil Palm on Recent Deforestation and Biodiversity Loss.

    Directory of Open Access Journals (Sweden)

    Varsha Vijay

    Full Text Available Palm oil is the most widely traded vegetable oil globally, with demand projected to increase substantially in the future. Almost all oil palm grows in areas that were once tropical moist forests, some of them quite recently. The conversion to date, and future expansion, threatens biodiversity and increases greenhouse gas emissions. Today, consumer pressure is pushing companies toward deforestation-free sources of palm oil. To guide interventions aimed at reducing tropical deforestation due to oil palm, we analysed recent expansions and modelled likely future ones. We assessed sample areas to find where oil palm plantations have recently replaced forests in 20 countries, using a combination of high-resolution imagery from Google Earth and Landsat. We then compared these trends to countrywide trends in FAO data for oil palm planted area. Finally, we assessed which forests have high agricultural suitability for future oil palm development, which we refer to as vulnerable forests, and identified critical areas for biodiversity that oil palm expansion threatens. Our analysis reveals regional trends in deforestation associated with oil palm agriculture. In Southeast Asia, 45% of sampled oil palm plantations came from areas that were forests in 1989. For South America, the percentage was 31%. By contrast, in Mesoamerica and Africa, we observed only 2% and 7% of oil palm plantations coming from areas that were forest in 1989. The largest areas of vulnerable forest are in Africa and South America. Vulnerable forests in all four regions of production contain globally high concentrations of mammal and bird species at risk of extinction. However, priority areas for biodiversity conservation differ based on taxa and criteria used. Government regulation and voluntary market interventions can help incentivize the expansion of oil palm plantations in ways that protect biodiversity-rich ecosystems.

  13. STEAM EXPLOSION PULPING OF OIL PALM EMPTY FRUIT BUNCH FIBER

    Directory of Open Access Journals (Sweden)

    Xiwen Wang,

    2012-01-01

    Full Text Available Steam explosion pulping was evaluated for oil palm empty fruit bunches fiber. The fiber morphology was observed by SEM and TEM. Results indicated that lignin was molten and the cell wall damaged after the steam explosion pulping and that the fiber was partly separated at the same time. The results of handsheet tests showed that the steam exploded pulp had a high yield (78.2%, good physical properties (especially for ring crush 8.6 N•m/g, and low effluent load (SS=910 mg/L; BOD5=3952 mg/L; CODCr=8140 mg/L. The SEP pulp from oil palm EFB fiber was very suitable for packaging paper when combined with American OCC pulp.

  14. DNA polymorphism among Fusarium oxysporum f.sp. elaeidis populations from oil palm, using a repeated and dispersed sequence "Palm".

    Science.gov (United States)

    Mouyna, I; Renard, J L; Brygoo, Y

    1996-07-31

    A worldwide collection, of 76 F. oxysporum f.sp. elaeidis isolates (Foe), and of 21 F. oxysporum isolates from the soil of several palm grove was analysed by RFLP. As a probe, we used a random DNA fragment (probe 46) from a genomic library of a Foe isolate. This probe contains two different types of sequence, one being repeated and dispersed in the genome "Palm", the other being a single-copy sequence. All F. oxysporum isolates from the palm-grove soils were non-pathogenic to oil palm. They all had a simple restriction pattern with one band homologous to the single-copy sequence of probe 46. All Foe isolates were pathogenic to oil palm and they all had complex patterns due to hybridization with "Palm". This repetitive sequence reveals that Foe isolates are distinct from the other F. oxysporum palm-grove soils isolates. The sequence can reliably discriminate pathogenic from non-pathogenic oil palm isolates. Based on DNA fingerprint similarities, Foe populations were divided into ten groups consisting of isolates with the same geographic origin. Isolates from Brazil and Ecuador were an exception to that rule as they had the same restriction pattern as a few isolates from the Ivory Coast, suggesting they may originated from Africa.

  15. Oil Palm Tree Detection with High Resolution Multi-Spectral Satellite Imagery

    Directory of Open Access Journals (Sweden)

    Panu Srestasathiern

    2014-10-01

    Full Text Available Oil palm tree is an important cash crop in Thailand. To maximize the productivity from planting, oil palm plantation managers need to know the number of oil palm trees in the plantation area. In order to obtain this information, an approach for palm tree detection using high resolution satellite images is proposed. This approach makes it possible to count the number of oil palm trees in a plantation. The process begins with the selection of the vegetation index having the highest discriminating power between oil palm trees and background. The index having highest discriminating power is then used as the primary feature for palm tree detection. We hypothesize that oil palm trees are located at the local peak within the oil palm area. To enhance the separability between oil palm tree crowns and background, the rank transformation is applied to the index image. The local peak on the enhanced index image is then detected by using the non-maximal suppression algorithm. Since both rank transformation and non-maximal suppression are window based, semi-variogram analysis is used to determine the appropriate window size. The performance of the proposed method was tested on high resolution satellite images. In general, our approach uses produced very accurate results, e.g., about 90 percent detection rate when compared with manual labeling.

  16. Breeding the oil palm (Elaeis guineensis Jacq.) for climate change

    OpenAIRE

    Rival Alain

    2017-01-01

    Breeding the oil palm (Elaeis guineensis Jacq.) for climate change requires multidisciplinary and collaborative research by nature: indeed – besides genetics and structural and functional genomics – almost all disciplines related to life sciences are involved. Research work also relies on the identification of genetic variation in the strategies of response to stress developed by the plant: this implies the exploration of resources provided by natural variation, germplasm collections, selecte...

  17. Auto Guided Oil Palm Planter by using multi-GNSS

    Science.gov (United States)

    Nur Aini, I.; W, Aimrun; Amin, M. S. M.; Ezrin, M. H.; Shafri, H. Z.

    2014-06-01

    Planting is one of the most important operations in plantation because it could affect the total area of productivity since it is the starting point in cultivation. In oil palm plantation, lining and spacing of oil palm shall be laid out and coincided with the topographic area and a system of drains. Conventionally, planting of oil palm will require the polarization process in order to prevent and overcome the lack of influence of the sun rise and get a regular crop row. Polarization is done after the completion of the opening area by using the spike wood with 1 m length painted at the top and 100 m length of wire. This process will generally require at least five persons at a time to pull the wire and carry the spikes while the other two persons will act as observer and spikes craftsmen respectively with the ability of the team is 3ha/day. Therefore, the aim of this project is to develop the oil palm planting technique by using multi- GNSS (Global Navigation Satellite System). Generally, this project will involve five main steps mainly; design of planting pattern by using SOLIDWORKS software, determine the boundary coordinate of planting area, georeference process with ArcGIS, stakeout process with Tracy software and finally marking up the location with the wooden spikes. The results proved that the multi- GNSS is capable to provide the high accuracy with less than 1 m in precise positioning system without augmentation data. With the ability of one person, time taken to complete 70 m × 50 m planting area is 290 min, which is 25 min faster than using GPS (Global Positioning System) only.

  18. Process Optimization for Ethyl Ester Production in Fixed Bed Reactor Using Calcium Oxide Impregnated Palm Shell Activated Carbon (CaO/PSAC

    Directory of Open Access Journals (Sweden)

    A Buasri

    2012-11-01

    Full Text Available : The continuous production of ethyl ester was studied by using a steady-state fixed bed reactor (FBR. Transesterification of palm stearin (PS and waste cooking palm oil (WCPO with ethanol in the presence of calcium oxide impregnated palm shell activated carbon (CaO/PSAC solid catalyst was investigated. This work was determined the optimum conditions for the production of ethyl ester from PS and WCPO in order to obtain fatty acid ethyl ester (FAEE with the highest yield. The effects of reaction variables such as residence time, ethanol/oil molar ratio, reaction temperature, catalyst bed height and reusability of catalyst in a reactor system on the yield of biodiesel were considered. The optimum conditions were the residence time 2-3 h, ethanol/oil molar ratio 16-20, reaction temperature at 800C, and catalyst bed height 300 mm which yielded 89.46% and 83.32% of the PS and WCPO conversion, respectively. CaO/PSAC could be used repeatedly for 4 times without any activation treatment and no obvious activity loss was observed. It has potential for industrial application in the transesterification of triglyceride (TG. The fuel properties of biodiesel were determined. Keywords: biodiesel, calcium oxide, ethyl ester, fixed bed reactor, palm shell activated carbon

  19. Promoting sustainable palm oil: viewed from a global networks and flows perspective

    NARCIS (Netherlands)

    Oosterveer, P.J.M.

    2015-01-01

    Global demand for palm oil is increasing to fulfil worldwide needs for cooking oil, food ingredients, biofuels, soap and other chemicals. In response, palm oil production is rapidly expanding which promotes economic growth in producing countries but also leads to serious environmental and social pro

  20. Promoting sustainable palm oil: viewed from a global networks and flows perspective

    NARCIS (Netherlands)

    Oosterveer, P.J.M.

    2015-01-01

    Global demand for palm oil is increasing to fulfil worldwide needs for cooking oil, food ingredients, biofuels, soap and other chemicals. In response, palm oil production is rapidly expanding which promotes economic growth in producing countries but also leads to serious environmental and social

  1. Dual resonant frequencies effects on an induction-based oil palm fruit sensor.

    Science.gov (United States)

    Harun, Noor Hasmiza; Misron, Norhisam; Mohd Sidek, Roslina; Aris, Ishak; Wakiwaka, Hiroyuki; Tashiro, Kunihisa

    2014-11-19

    As the main exporter in the oil palm industry, the need to improve the quality of palm oil has become the main interest among all the palm oil millers in Malaysia. To produce good quality palm oil, it is important for the miller to harvest a good oil palm Fresh Fruit Bunch (FFB). Conventionally, the main reference used by Malaysian harvesters is the manual grading standard published by the Malaysian Palm Oil Board (MPOB). A good oil palm FFB consists of all matured fruitlets, aged between 18 to 21 weeks of antheses (WAA). To expedite the harvesting process, it is crucial to implement an automated detection system for determining the maturity of the oil palm FFB. Various automated detection methods have been proposed by researchers in the field to replace the conventional method. In our preliminary study, a novel oil palm fruit sensor to detect the maturity of oil palm fruit bunch was proposed. The design of the proposed air coil sensor based on the inductive sensor was further investigated mainly in the context of the effect of coil diameter to improve its sensitivity. In this paper, the sensitivity of the inductive sensor was further examined with a dual flat-type shape of air coil. The dual air coils were tested on fifteen samples of fruitlet from two categories, namely ripe and unripe. Samples were tested within 20 Hz to 10 MHz while evaluations on both peaks were done separately before the gap between peaks was analyzed. A comparative analysis was conducted to investigate the improvement in sensitivity of the induction-based oil palm fruit sensor as compared to previous works. Results from the comparative study proved that the inductive sensor using a dual flat-type shape air coil has improved by up to 167%. This provides an indication in the improvement in the coil sensitivity of the palm oil fruit sensor based on the induction concept.

  2. Conservation value and permeability of neotropical oil palm landscapes for orchid bees.

    Directory of Open Access Journals (Sweden)

    George Livingston

    Full Text Available The proliferation of oil palm plantations has led to dramatic changes in tropical landscapes across the globe. However, relatively little is known about the effects of oil palm expansion on biodiversity, especially in key ecosystem-service providing organisms like pollinators. Rapid land use change is exacerbated by limited knowledge of the mechanisms causing biodiversity decline in the tropics, particularly those involving landscape features. We examined these mechanisms by undertaking a survey of orchid bees, a well-known group of Neotropical pollinators, across forest and oil palm plantations in Costa Rica. We used chemical baits to survey the community in four regions: continuous forest sites, oil palm sites immediately adjacent to forest, oil palm sites 2 km from forest, and oil palm sites greater than 5 km from forest. We found that although orchid bees are present in all environments, orchid bee communities diverged across the gradient, and community richness, abundance, and similarity to forest declined as distance from forest increased. In addition, mean phylogenetic distance of the orchid bee community declined and was more clustered in oil palm. Community traits also differed with individuals in oil palm having shorter average tongue length and larger average geographic range size than those in the forest. Our results indicate two key features about Neotropical landscapes that contain oil palm: 1 oil palm is selectively permeable to orchid bees and 2 orchid bee communities in oil palm have distinct phylogenetic and trait structure compared to communities in forest. These results suggest that conservation and management efforts in oil palm-cultivating regions should focus on landscape features.

  3. Strengths and weaknesses of the smallholder oil palm sector in Cameroon

    OpenAIRE

    Nkongho Raymond N.; Feintrenie Laurène; Levang Patrice

    2014-01-01

    The present study is an evaluation of the current strengths and weaknesses of the oil palm smallholder sector in Cameroon, or more precisely of the non-industrial sector, as some holdings owned by elites can reach hundreds of hectares. A randomized sample of oil palm producers was chosen after categorization into elites, migrants, natives and company workers (past and present) in four palm oil production basins in the Southern part of the ...

  4. Strengths and weaknesses of the smallholder oil palm sector in Cameroon

    OpenAIRE

    Nkongho, R. N.; Feintrenie, L.; Levang, Patrice

    2014-01-01

    The present study is an evaluation of the current strengths and weaknesses of the oil palm smallholder sector in Cameroon, or more precisely of the non-industrial sector, as some holdings owned by elites can reach hundreds of hectares. A randomized sample of oil palm producers was chosen after categorization into elites, migrants, natives and company workers (past and present) in four palm oil production basins in the Southern part of the country. 176 semi-structured questionnaires were admin...

  5. Dual Resonant Frequencies Effects on an Induction-Based Oil Palm Fruit Sensor

    Directory of Open Access Journals (Sweden)

    Noor Hasmiza Harun

    2014-11-01

    Full Text Available As the main exporter in the oil palm industry, the need to improve the quality of palm oil has become the main interest among all the palm oil millers in Malaysia. To produce good quality palm oil, it is important for the miller to harvest a good oil palm Fresh Fruit Bunch (FFB. Conventionally, the main reference used by Malaysian harvesters is the manual grading standard published by the Malaysian Palm Oil Board (MPOB. A good oil palm FFB consists of all matured fruitlets, aged between 18 to 21 weeks of antheses (WAA. To expedite the harvesting process, it is crucial to implement an automated detection system for determining the maturity of the oil palm FFB. Various automated detection methods have been proposed by researchers in the field to replace the conventional method. In our preliminary study, a novel oil palm fruit sensor to detect the maturity of oil palm fruit bunch was proposed. The design of the proposed air coil sensor based on the inductive sensor was further investigated mainly in the context of the effect of coil diameter to improve its sensitivity. In this paper, the sensitivity of the inductive sensor was further examined with a dual flat-type shape of air coil. The dual air coils were tested on fifteen samples of fruitlet from two categories, namely ripe and unripe. Samples were tested within 20 Hz to 10 MHz while evaluations on both peaks were done separately before the gap between peaks was analyzed. A comparative analysis was conducted to investigate the improvement in sensitivity of the induction-based oil palm fruit sensor as compared to previous works. Results from the comparative study proved that the inductive sensor using a dual flat-type shape air coil has improved by up to 167%. This provides an indication in the improvement in the coil sensitivity of the palm oil fruit sensor based on the induction concept.

  6. Monitoring of oil palm plantations and growth variations with a dense vegetation model

    DEFF Research Database (Denmark)

    Teng, Khar Chun; Koay, Jun Yi; Tey, Seng Heng

    2014-01-01

    -PACT) and Fresnel Phase Corrections. The iterative solutions of the radiative transfer model are computed with input based on ground truth measurements of physical parameters of oil palm plantations in the state of Perak, Malaysia, and compared with the SAR images obtained from RADARSAT2. Preliminary results...... are analyzed for dominant scattering mechanisms as well as monitoring of growth variation of oil palm trees for further development of operation models for long term monitoring of oil palm plantations....

  7. Statistical Optimization of Fermentation Conditions for Cellulase Production from Palm Oil Mill Effluent

    OpenAIRE

    Jamal I. Daoud; Md. Z. Alam

    2010-01-01

    Problem statement: Palm oil mill effluent discharged by the oil palm industries is considered as the mixed of high polluted effluent which is abundant (about 20 million tonnes year-1) and its effect contributes to the serious environmental problems through the pollution of water bodies. Approach: The aim of this study was to identify the potential of low cost substrate such as Palm Oil Mill Effluent (POME) for the production of cellulase enzyme by liquid state bioconversion. The filamentous f...

  8. An Evaluation of Holistic Sustainability Assessment Framework for Palm Oil Production in Malaysia

    OpenAIRE

    Chye Ing Lim; Wahidul Biswas

    2015-01-01

    Palm oil based biodiesel offers an alternative energy source that can reduce current dependence on conventional fossil fuels and may reduce greenhouse gas (GHG) emissions depending on the type of feedstock and processes used. In the Malaysian context, the palm oil industry not only provides high-yield, renewable feedstock to the world, it brings socio-economic development to the Malaysian rural community and contributes to the national income. However, the sustainability of palm oil remains c...

  9. Role of Methane Capture for Sustainable Biodiesel Production from Palm Oil: A Life Cycle Assessment Approach

    OpenAIRE

    Hermawan Prasetya; Yandra Arkeman; Erliza Hambali

    2013-01-01

    Palm Oil Mill Effluent (POME) is one of the major wastes generated by palm oil milling which is a part of palm oil diesel production chain. POME contain of methane (about 60-70 %), which contribute to Greenhouse Gas (GHG) Emission. Due to reduction GHG emission is one of indicator bioenergy sustainability, some alternatives have been implementing to reduction it. One of the alternatives is implementing of methane capture technology which able to capture and/or utilize it for energy source. In...

  10. Bacterial diversity of oil palm Elaeis guineensis basal stems

    Science.gov (United States)

    Amran, Afzufira; Jangi, Mohd Sanusi; Aqma, Wan Syaidatul; Yusof, Nurul Yuziana Mohd; Bakar, Mohd Faizal Abu; Isa, Mohd Noor Mat

    2016-11-01

    Oil palm, Elaeis guineensis is one of the major industrial production crops in Malaysia. Basal stem rot, caused by the white fungus, Ganoderma boninense, is a disease that reduces oil palm yields in most production areas of the world. Understanding of bacterial community that is associated with Ganoderma infection will shed light on how this bacterial community contributes toward the severity of the infection. In this preliminary study, we assessed the bacterial community that inhabit the basal stems of E. guineensis based on 16S rRNA gene as a marker using next generation sequencing platform. This result showed that a total of 84,372 operational taxonomic-units (OTUs) were identified within six samples analyzed. A total 55,049 OTUs were assigned to known taxonomy whereas 29,323 were unassigned. Cyanobacteria, Bacteroidetes, Firmicutes and Proteobacteria were the most abundant phyla found in all six samples and the unique taxonomy assigned for each infected and healthy samples were also identified. The findings from this study will further enhance our knowledge in the interaction of bacterial communities against Ganoderma infection within the oil palm host plant and for a better management of the basal stems rot disease.

  11. Development and Characterization of Liposomal Doxorubicin Hydrochloride with Palm Oil

    Directory of Open Access Journals (Sweden)

    Bahareh Sabeti

    2014-01-01

    Full Text Available The usage of natural products in pharmaceuticals has steadily seen improvements over the last decade, and this study focuses on the utilization of palm oil in formulating liposomal doxorubicin (Dox. The liposomal form of Dox generally minimizes toxicity and enhances target delivery actions. Taking into account the antiproliferative and antioxidant properties of palm oil, the aim of this study is to design and characterize a new liposomal Dox by replacing phosphatidylcholine with 5% and 10% palm oil content. Liposomes were formed using the freeze_thaw method, and Dox was loaded through pH gradient technique and characterized through in vitro and ex vivo terms. Based on TEM images, large lamellar vesicles (LUV were formed, with sizes of 438 and 453 nm, having polydispersity index of 0.21 ± 0.8 and 0.22 ± 1.3 and zeta potentials of about −31 and −32 mV, respectively. In both formulations, the entrapment efficiency was about 99%, and whole Dox was released through 96 hours in PBS (pH = 7.4 at 37°C. Comparing cytotoxicity and cellular uptake of LUV with CaelyxR on MCF7 and MDA-MBA 231 breast cancer cell lines indicated suitable uptake and lower IC50 of the prepared liposomes.

  12. Development and characterization of liposomal doxorubicin hydrochloride with palm oil.

    Science.gov (United States)

    Sabeti, Bahareh; Noordin, Mohamed Ibrahim; Mohd, Shaharuddin; Hashim, Rosnani; Dahlan, Afendi; Javar, Hamid Akbari

    2014-01-01

    The usage of natural products in pharmaceuticals has steadily seen improvements over the last decade, and this study focuses on the utilization of palm oil in formulating liposomal doxorubicin (Dox). The liposomal form of Dox generally minimizes toxicity and enhances target delivery actions. Taking into account the antiproliferative and antioxidant properties of palm oil, the aim of this study is to design and characterize a new liposomal Dox by replacing phosphatidylcholine with 5% and 10% palm oil content. Liposomes were formed using the freeze_thaw method, and Dox was loaded through pH gradient technique and characterized through in vitro and ex vivo terms. Based on TEM images, large lamellar vesicles (LUV) were formed, with sizes of 438 and 453 nm, having polydispersity index of 0.21 ± 0.8 and 0.22 ± 1.3 and zeta potentials of about -31 and -32 mV, respectively. In both formulations, the entrapment efficiency was about 99%, and whole Dox was released through 96 hours in PBS (pH = 7.4) at 37°C. Comparing cytotoxicity and cellular uptake of LUV with Caelyx(R) on MCF7 and MDA-MBA 231 breast cancer cell lines indicated suitable uptake and lower IC50 of the prepared liposomes.

  13. Biochemical characterisation during seed development of oil palm (Elaeis guineensis).

    Science.gov (United States)

    Kok, Sau-Yee; Namasivayam, Parameswari; Ee, Gwendoline Cheng-Lian; Ong-Abdullah, Meilina

    2013-07-01

    Developmental biochemical information is a vital base for the elucidation of seed physiology and metabolism. However, no data regarding the biochemical profile of oil palm (Elaeis guineensis Jacq.) seed development has been reported thus far. In this study, the biochemical changes in the developing oil palm seed were investigated to study their developmental pattern. The biochemical composition found in the seed differed significantly among the developmental stages. During early seed development, the water, hexose (glucose and fructose), calcium and manganese contents were present in significantly high levels compared to the late developmental stage. Remarkable changes in the biochemical composition were observed at 10 weeks after anthesis (WAA): the dry weight and sucrose content increased significantly, whereas the water content and hexose content declined. The switch from a high to low hexose/sucrose ratio could be used to identify the onset of the maturation phase. At the late stage, dramatic water loss occurred, whereas the content of storage reserves increased progressively. Lauric acid was the most abundant fatty acid found in oil palm seed starting from 10 WAA.

  14. Catalytic Cracking of Palm Oil Over Zeolite Catalysts: Statistical Approach

    Directory of Open Access Journals (Sweden)

    F. A. A. Twaiq and S. Bhatia

    2012-08-01

    Full Text Available The catalytic cracking of palm oil was conducted in a fixed bed micro-reactor over HZSM-5, zeolite ? and ultrastable Y (USY zeolite catalysts. The objective of the present investigation was to study the effect of cracking reaction variables such as temperature, weight hourly space velocity, catalyst pore size and type of palm oil feed of different molecular weight on the conversion, yield of hydrocarbons in gasoline boiling range and BTX aromatics in the organic liquid product.  Statistical Design of Experiment (DOE with 24 full factorial design was used in experimentation at the first stage.  The nonlinear model and Response Surface Methodology (RSM were utilized in the second stage of experimentation to obtain the optimum values of the variables for maximum yields of hydrocarbons in gasoline boiling range and aromatics.  The HZSM-5 showed the best performance amongst the three catalysts tested.  At 623 K and WHSV of 1 h-1, the highest experimental yields of gasoline and aromatics were 28.3 wt.% and 27 wt.%, respectively over the HZSM-5 catalyst.  For the same catalyst, the statistical model predicted that the optimum yield of gasoline was 28.1 wt.% at WHSV of 1.75 h-1 and 623 K.  The predicted optimum yield of gasoline was 25.5 wt.% at 623 K and WHSV of 1 h-1.KEY WORDS: Catalytic Cracking, Palm Oil, Zeolite, Design Of Experiment, Response Surface Methodology.

  15. Crystallization Kinetics of Fully Hydrogenated Palm Oil in Sunflower Oil Mixtures

    NARCIS (Netherlands)

    Kloek, W.; Walstra, P.; Vliet, van T.

    2000-01-01

    The crystallization kinetics of mixtures of fully hydrogenated palm oil (HP) in sunflower oil (SF) was studied. The thermal properties and phase behavior of this model system were characterized by means of differential scanning calorimetry and X-ray diffraction. From the melting enthalpy and clear p

  16. Crystallization Kinetics of Fully Hydrogenated Palm Oil in Sunflower Oil Mixtures

    NARCIS (Netherlands)

    Kloek, W.; Walstra, P.; Vliet, van T.

    2000-01-01

    The crystallization kinetics of mixtures of fully hydrogenated palm oil (HP) in sunflower oil (SF) was studied. The thermal properties and phase behavior of this model system were characterized by means of differential scanning calorimetry and X-ray diffraction. From the melting enthalpy and clear

  17. Towards more efficient selection for oil yield in the oil palm (Elaeis guineensis Jacquin)

    NARCIS (Netherlands)

    Vossen, van der H.A.M.

    1974-01-01

    Detailed studies are made of the variability and heritability of a number of components of oil yield in the oil palm using published data of the breeding programme of the NIFOR in Nigeria and results of a number of experiments carried out at the OPRC in Ghana during the period 1965-1971.

  18. Towards more efficient selection for oil yield in the oil palm (Elaeis guineensis Jacquin)

    NARCIS (Netherlands)

    Vossen, van der H.A.M.

    1974-01-01

    Detailed studies are made of the variability and heritability of a number of components of oil yield in the oil palm using published data of the breeding programme of the NIFOR in Nigeria and results of a number of experiments carried out at the OPRC in Ghana during the period 1965-1971. Estimations

  19. Age of oil palm plantations causes a strong change in surface biophysical variables

    Science.gov (United States)

    Sabajo, Clifton; le Maire, Guerric; Knohl, Alexander

    2016-04-01

    Over the last decades, Indonesia has experienced dramatic land transformations with an expansion of oil palm plantations at the expense of tropical forests. As vegetation is a modifier of the climate near the ground these large-scale land transformations are expected to have major impacts on the surface biophysical variables i.e. surface temperature, albedo, and vegetation indices, e.g. the NDVI. Remote sensing data are needed to assess such changes at regional scale. We used 2 Landsat images from Jambi Province in Sumatra/Indonesia covering a chronosequence of oil palm plantations to study the 20 - 25 years life cycle of oil palm plantations and its relation with biophysical variables. Our results show large differences between the surface temperature of young oil palm plantations and forest (up to 9.5 ± 1.5 °C) indicating that the surface temperature is raised substantially after the establishment of oil palm plantations following the removal of forests. During the oil palm plantation lifecycle the surface temperature differences gradually decreases and approaches zero around an oil palm plantation age of 10 years. Similarly, NDVI increases and the albedo decreases approaching typical values of forests. Our results show that in order to assess the full climate effects of oil palm expansion biophysical processes play an important role and the full life cycle of oil palm plantations need to be considered.

  20. Environmental Performance of the Milling Process Of Malaysian Palm Oil Using The Life Cycle Assessment Approach

    OpenAIRE

    Vijaya Subramaniam; Ma A. Ngan; Choo Y. May; Nik M.K. Sulaiman

    2008-01-01

    Malaysia is currently the world leader in the production and export of palm oil. This study has a gate to gate system boundary. The inventory data collection starts at the oil palm fresh fruit bunch hoppers when the fresh fruit bunch is received at the mill up till the production of the crude palm oil in the storage tanks at the mill. The plantation phase and land use for the production of oil palm fresh fruit bunch is not included in this system boundary. This gate to gate case study of 12 m...

  1. Trading Fat for Forests: On Palm Oil, Tropical Forest Conservation, and Rational Consumption

    National Research Council Canada - National Science Library

    Isenhour, Cindy

    2014-01-01

      The longstanding butter vs margarine debate has recently become more complex as the links between margarine, industrial palm oil plantations, and tropical deforestation are made increasingly clear...

  2. Effect of oil palm on the Plecoptera and Trichoptera (Insecta) assemblages in streams of eastern Amazon.

    Science.gov (United States)

    de Paiva, Carina Kaory Sasahara; de Faria, Ana Paula Justino; Calvão, Lenize Batista; Juen, Leandro

    2017-08-01

    The production of oil palm is expected to increase in the Amazon region. However, expansion of oil palm plantation leads to significant changes in the physical structure of aquatic ecosystems, mainly through the reduction of riparian vegetation that is essential for aquatic biodiversity. Here, we evaluated the effects of oil palm on the physical habitat structure of Amazonian stream environments and assemblages of Plecoptera and Trichoptera (PT), ​both found in these streams. We compared streams sampled in oil palm plantations (n = 13) with natural forest areas ("reference" streams, n = 8), located in the eastern Amazon, Brazil. Our results showed that oil palm streams were more likely to be in close proximity to roads, had higher pH values, and higher amounts of fine substrate deposited in the channel than reference streams. Further, these environmental changes had important effects on the aquatic invertebrate assemblages, reducing the abundance and richness of PT. Nevertheless, the genera composition of the assemblages did not differ between reference and oil palm (PERMANOVA, pseudo-F (1,19) = 1.891; p = 0.111). We conclude that oil palm production has clear negative impacts on aquatic environments and PT assemblages in Amazonian streams. We recommend that oil palm producers invest more in planning of road networks to avoid the construction of roads near to the riparian vegetation. This planning can minimize impacts of oil palm production on aquatic systems in the Amazon.

  3. Palm oil – strategic source of renewable energy in Indonesia and Malaysia

    OpenAIRE

    Prokurat, Sergiusz

    2013-01-01

    This paper seeks to answer the question of how the global industry of palm oil is affecting the economies and natural environments of its two main producers – Indonesia and Malaysia. The first section examines the contemporary uses of palm oil in a variety of products and industries. It also sets out to describe the global palm oil market. The second section takes a historical perspective, analysing the origins of palm oil cultivation and trade and its rapid rise to global prominence. The thi...

  4. THE DIVERSITY OF EPIPHYTIC FERN ON THE OIL PALM TREE (Elaeis guineensis Jacq. IN PEKANBARU, RIAU

    Directory of Open Access Journals (Sweden)

    Nery Sofiyanti

    2015-02-01

    Full Text Available Oil palm (Elaeis guineensis is one  main commodity in Riau Province. Morphologically, the trunk of oil palm  has suitable environment for the growth of epiphytic fern, due to its broaden base of petiole that may accumulate organic and anorganic debrish. The objective of this study was to investigate the diversity of epiphytic fern on the oil palm tree. A total of 125 oil palm trees from seven  study sites in Pekanbaru, Riau were observed. The number of epiphytic ferns identified in this study was 16 species belongs to six families.

  5. Economic potential of the oil palm (Elaeis guineensis Jacq)

    OpenAIRE

    Juan Sierra Márquez; Lucellys Sierra Márquez; Jesus Olivero-Verbel

    2017-01-01

    The objective of this research was to highlight the economic importance of the optimal use of products and byproducts of oil palm. In Colombia, productive crops per hectare can generate, over one year, an average of 3.14 tons of oil, and up to 21.68 t of solid and liquid waste when the plant is on a productive stage. These data allowed the researcher to estimate that more than nine million of t of solid and liquid waste was produced from the 450 131 ha present in 2014, in Colombia; the produc...

  6. Processing Practices of small-scale palm oil producers in the Kwaebibirem District, Ghana: A Diagnostic study

    NARCIS (Netherlands)

    Osei-Amponsah, C.; Visser, L.E.; Adjei-Nsiah, S.; Struik, P.C.; Sakyi-Dawson, O.; Stomph, T.J.

    2012-01-01

    Ghana produces about 2,000,000 metric tons of oil palm fruits annually, and small-scale processors contribute about 60% of crude palm oil production. The country is not self-sufficient in the fats and oils needed for industrial use and home consumption. A large percentage of the palm oil produced by

  7. Factors impacting the formation of monochloropropanediol (MCPD) fatty acid diesters during palm (Elaeis guineensis) oil production.

    Science.gov (United States)

    Craft, Brian D; Nagy, Kornél; Sandoz, Laurence; Destaillats, Frédéric

    2012-01-01

    Recently, organic and inorganic chlorinated compounds were detected in crude and commercially refined palm oils. Further, the predominant formation mechanism of monochloropropanediol (MCPD) diesters at high temperatures (>170-180°C) was revealed. The present study involved the development and comparison of solutions to mitigate MCPD diester levels in oils from various stages of palm oil production. Partially refined palm oil samples and oil extracted from fresh palm fruits were submitted to bench-top deodorisation experiments. Application of glycerol and ethanol as refining aids during the deodorisation of refined-bleached palm oil proved to be moderately effective; about 25%-35% reduction of MCPD diester levels was achieved. Washing crude palm oil with ethanol-water (1:1) prior to deodorisation was also an effective strategy yielding an ∼30% reduction of MCPD diester contents. Washing palm fruit pulp before oil extraction, however, was most impactful, resulting in a 95% reduction of MCPD diesters when compared to the deodorised control oil. This suggests that intervention upstream in the process chain is most efficient in reducing levels of these contaminants in refined oils. Following the study, a root-cause analysis was performed in order to map the parameters potentially responsible for the occurrence of MCPD diesters in refined palm oil and related fractions.

  8. Utilization of oil palm as a source of renewable energy in Malaysia

    Energy Technology Data Exchange (ETDEWEB)

    Sumathi, S.; Chai, S.P.; Mohamed, A.R. [School of Chemical Engineering, Engineering Campus, Universiti Sains Malaysia, 14300 Nibong Tebal, Pulau Pinang (Malaysia)

    2008-12-15

    Malaysia is currently the world's largest producer and exporter of palm oil. Malaysia produces about 47% of the world's supply of palm oil. Malaysia also accounts the highest percentage of global vegetable oils and fats trade in year 2005. Besides producing oils and fats, at present there is a continuous increasing interest concerning oil palm renewable energy. One of the major attentions is bio-diesel from palm oil. Bio-diesel implementation in Malaysia is important because of environmental protection and energy supply security reasons. This palm oil bio-diesel is biodegradable, non-toxic, and has significantly fewer emissions than petroleum-based diesel (petro-diesel) when burned. In addition to this oil, palm is also a well-known plant for its other sources of renewable energy, for example huge quantities of biomass by-products are developed to produce value added products such as methane gas, bio-plastic, organic acids, bio-compost, ply-wood, activated carbon, and animal feedstock. Even waste effluent; palm oil mill effluent (POME) has been converted to produce energy. Oil palm has created many opportunities and social benefits for the locals. In the above perspective, the objective of the present work is to give a concise and up-to-date picture of the present status of oil palm industry enhancing sustainable and renewable energy. This work also aims to identify the prospects of Malaysian oil palm industry towards utilization of oil palm as a source of renewable energy. (author)

  9. Reaction kinetics of free fatty acids esterification in palm fatty acid distillate using coconut shell biochar sulfonated catalyst

    Science.gov (United States)

    Hidayat, Arif; Rochmadi, Wijaya, Karna; Budiman, Arief

    2015-12-01

    Recently, a new strategy of preparing novel carbon-based solid acids has been developed. In this research, the esterification reactions of Palm Fatty Acid Distillate (PFAD) with methanol, using coconut shell biochar sulfonated catalyst from biomass wastes as catalyst, were studied. In this study, the coconut shell biochar sulfonated catalysts were synthesized by sulfonating the coconut shell biochar using concentrated H2SO4. The kinetics of free fatty acid (FFA) esterification in PFAD using a coconut shell biochar sulfonated catalyst was also studied. The effects of the mass ratio of catalyst to oil (1-10%), the molar ratio of methanol to oil (6:1-12:1), and the reaction temperature (40-60°C) were studied for the conversion of PFAD to optimize the reaction conditions. The results showed that the optimal conditions were an methanol to PFAD molar ratio of 12:1, the amount of catalyst of 10%w, and reaction temperature of 60°C. The proposed kinetic model shows a reversible second order reaction and represents all the experimental data satisfactorily, providing deeper insight into the kinetics of the reaction.

  10. PREPARATION OF VARIOUS TYPES OF PULP FROM OIL PALM LIGNOCELLULOSIC RESIDUES

    Institute of Scientific and Technical Information of China (English)

    Ryohei Tanaka; Leh Cheu Peng; Wan Rosli Wan Daud

    2004-01-01

    @@ INTRODUCTION Oil palm, Elaeis Guineensis, (Figure 1) is one of the most important plants in Malaysia. It produces palm oil and palm kernel oil, which is widely being used in food and other industries such as detergents and cosmetics. Malaysia is the world′s largest producer and exporter of the oil, so that the country′s economy is very much dependent on these oil products. Although oil from the palm tree is an excellent product for the country, residues from oil palm have not been used sufficiently. In this 10~15 years, development in new technologies for utilizing this lignocellulosic waste is categorized as one of the most important issues in science policy of Malaysia.

  11. Organoleptic Study of Deacidified and Deodourised Palm Oil

    Directory of Open Access Journals (Sweden)

    Umesh Kapil

    2014-11-01

    Full Text Available Deficiency of vitamin A has long been identified as a serious and preventable nutritional disorder, associated with increased risk of mortality and morbidity amongst children. The present study was conducted with the objectives (i to perform organoleptic testing of food products cooked in Deacidified and Deodourised Palm oil (DDPO, by sensory evaluation method and (ii to compare the characteristics of these food products with the same products cooled in routinely used oil. Eleven commonly used weaning food items were prepared with routinely used oil (Group a. The same recipes were also prepared with DDPO (Group B. A food testing panel conducted with sensory evaluation for assessing the acceptability of the various food items. It was observed that with respect to all characteristics there was no significant difference in the recipes made with the two types of oil. Results indicated that DDPO can be used in India for preparation of weaning foods which are routinely given to young children.

  12. Impact of savanna conversion to oil palm plantations on C stocks dynamics and soil fertility

    Science.gov (United States)

    Quezada, Juan Carlos; Guillaume, Thomas; Buttler, Alexandre; Ruegg, Johanna

    2017-04-01

    Large-scale expansion of oil palm cultivation on forested land in South-East Asia during the last decades lead to high negative environmental impacts. Because rainforests store high amount of C, their conversion to oil palm plantations results in large net CO2 emissions. Oil palm cultivation in tropical ecosystems such as savanna that store less C than forests is seen as an alternative to reduce greenhouse gas emissions of future oil palm development. While this option is more and more frequently mentioned, few data are available on the effective gain in C storage. Furthermore negative impact on soil organic carbon and soil fertility could offset gains of C storage in oil palm biomass. Here, we present results on aboveground and belowground C stocks and soil nutrient dynamics over a full rotation cycle of oil palm plantations established on tropical savanna grasslands. Three natural savanna grasslands as reference sites and 9 oil palm plantations ranging from two to twenty-seven years old were selected in the Llanos in Colombia. Oxisols were sampled down to 70 cm in each management zones of oil palm plantations (weeded circle, interrow, frond piles and harvesting path). Taking advantages of a shift from C4 to C3 vegetation, we quantified savanna-derived soil organic carbon (SOC) decomposition and oil palm-derived SOC stabilization rates and how they were affected by management practices (mineral fertilization, organic amendments, etc.). Results show that, in opposite to forest conversion, C storage increases when savannas are converted to oil palm plantations. Because soil C storage was very low in natural conditions, SOC changes had little effects on overall C storage. Substitution of savanna-derived SOC by oil palm-derived SOC was very fast in the topsoil and highest under frond pile and weeded circle where C and nutrients inputs are highest. However, stabilization of oil palm-derived SOC compensated loss of savanna-derived SOC rather than increased SOC stocks

  13. Effects of linseed oil and palm oil on growth performance, tibia fatty acid and biomarkers of bone metabolism in broilers.

    Science.gov (United States)

    Zhong, X; Gao, S; Wang, J J; Dong, L; Huang, J; Zhang, L L; Wang, T

    2014-01-01

    1. This study was conducted to determine the effects of different dietary fat sources on growth performance, tibia fatty acids and biomarkers of bone metabolism in broilers. 2. One-d-old commercial Arbor Acres broilers were fed with a maize-soya bean basal diet for 42 d, supplemented with oils according to the following 5 treatments: lard (lard group); linseed oil (linseed oil group); palm oil (palm oil group); linseed oil + palm oil (60:40 or 40:60 w/w, LP-1 group and LP-2 group, respectively). 3. No significant differences in weight gain, feed intake and gain/feed ratio were observed between the lard and linseed oil groups. Birds fed on palm oil had significantly greater weight gain and feed intake than those fed on lard or linseed oil. Growth performance in LP-1 and LP-2 was significantly greater than that of single-oil groups. 4. Tibia growth and bone characteristics were not influenced by supplementation with lard, linseed oil, or palm oil alone, but broilers fed on a mixture of fats had significantly greater tibia weight and length compared to broilers fed on linseed oil. Bone mineral density in tibia was significantly increased in LP-1 and LP-2 groups. 5. Supplementation of linseed oil alone or in combination with palm oil enhanced apparent digestibility of calcium, reduced serum calcium and increased tibia calcium concentrations. Moreover, supplementation with linseed oil alone or in combination with palm oil had a positive effect on biomarkers of bone growth. 6. The combination of linseed and palm oils was beneficial for growth performance, tibia growth and biomarkers of bone metabolism.

  14. Combustion performance evaluation of air staging of palm oil blends.

    Science.gov (United States)

    Mohd Jaafar, Mohammad Nazri; Eldrainy, Yehia A; Mat Ali, Muhammad Faiser; Wan Omar, W Z; Mohd Hizam, Mohd Faizi Arif

    2012-02-21

    The problems of global warming and the unstable price of petroleum oils have led to a race to develop environmentally friendly biofuels, such as palm oil or ethanol derived from corn and sugar cane. Biofuels are a potential replacement for fossil fuel, since they are renewable and environmentally friendly. This paper evaluates the combustion performance and emission characteristics of Refined, Bleached, and Deodorized Palm Oil (RBDPO)/diesel blends B5, B10, B15, B20, and B25 by volume, using an industrial oil burner with and without secondary air. Wall temperature profiles along the combustion chamber axis were measured using a series of thermocouples fitted axially on the combustion chamber wall, and emissions released were measured using a gas analyzer. The results show that RBDPO blend B25 produced the maximum emission reduction of 56.9% of CO, 74.7% of NOx, 68.5% of SO(2), and 77.5% of UHC compared to petroleum diesel, while air staging (secondary air) in most cases reduces the emissions further. However, increasing concentrations of RBDPO in the blends also reduced the energy released from the combustion. The maximum wall temperature reduction was 62.7% for B25 at the exit of the combustion chamber.

  15. Evaluation of Palm Oil as a Suitable Vegetable Oil for Vitamin A Fortification Programs.

    Science.gov (United States)

    Pignitter, Marc; Hernler, Natalie; Zaunschirm, Mathias; Kienesberger, Julia; Somoza, Mark Manuel; Kraemer, Klaus; Somoza, Veronika

    2016-06-21

    Fortification programs are considered to be an effective strategy to mitigate vitamin A deficiency in populations at risk. Fortified vegetable oils rich in polyunsaturated fatty acids were shown to be prone to oxidation, leading to limited vitamin A stability. Thus, it was hypothesized that fortified oils consisting of mainly saturated fatty acids might enhance the stability of vitamin A. Mildly (peroxide value: 1.0 meq O₂/kg) and highly (peroxide value: 7.5 meq O₂/kg) oxidized palm oil was stored, after fortification with 60 International Units/g retinyl palmitate, in 0.5 L transparent polyethylene terephthalate bottles under cold fluorescent lighting (12 h/day) at 32 °C for 57 days. An increase of the peroxide value by 15 meq O₂/kg, which was also reflected by a decrease of α-tocopherol congener by 15%-18%, was determined independent of the initial rancidity. The oxidative deterioration of the highly oxidized palm oil during storage was correlated with a significant 46% decline of the vitamin A content. However, household storage of mildly oxidized palm oil for two months did not induce any losses of vitamin A. Thus, mildly oxidized palm oil may be recommended for vitamin A fortification programs, when other sources of essential fatty acids are available.

  16. Evaluation of Palm Oil as a Suitable Vegetable Oil for Vitamin A Fortification Programs

    Directory of Open Access Journals (Sweden)

    Marc Pignitter

    2016-06-01

    Full Text Available Fortification programs are considered to be an effective strategy to mitigate vitamin A deficiency in populations at risk. Fortified vegetable oils rich in polyunsaturated fatty acids were shown to be prone to oxidation, leading to limited vitamin A stability. Thus, it was hypothesized that fortified oils consisting of mainly saturated fatty acids might enhance the stability of vitamin A. Mildly (peroxide value: 1.0 meq O2/kg and highly (peroxide value: 7.5 meq O2/kg oxidized palm oil was stored, after fortification with 60 International Units/g retinyl palmitate, in 0.5 L transparent polyethylene terephthalate bottles under cold fluorescent lighting (12 h/day at 32 °C for 57 days. An increase of the peroxide value by 15 meq O2/kg, which was also reflected by a decrease of α-tocopherol congener by 15%–18%, was determined independent of the initial rancidity. The oxidative deterioration of the highly oxidized palm oil during storage was correlated with a significant 46% decline of the vitamin A content. However, household storage of mildly oxidized palm oil for two months did not induce any losses of vitamin A. Thus, mildly oxidized palm oil may be recommended for vitamin A fortification programs, when other sources of essential fatty acids are available.

  17. Evaluation of Palm Oil as a Suitable Vegetable Oil for Vitamin A Fortification Programs

    Science.gov (United States)

    Pignitter, Marc; Hernler, Natalie; Zaunschirm, Mathias; Kienesberger, Julia; Somoza, Mark Manuel; Kraemer, Klaus; Somoza, Veronika

    2016-01-01

    Fortification programs are considered to be an effective strategy to mitigate vitamin A deficiency in populations at risk. Fortified vegetable oils rich in polyunsaturated fatty acids were shown to be prone to oxidation, leading to limited vitamin A stability. Thus, it was hypothesized that fortified oils consisting of mainly saturated fatty acids might enhance the stability of vitamin A. Mildly (peroxide value: 1.0 meq O2/kg) and highly (peroxide value: 7.5 meq O2/kg) oxidized palm oil was stored, after fortification with 60 International Units/g retinyl palmitate, in 0.5 L transparent polyethylene terephthalate bottles under cold fluorescent lighting (12 h/day) at 32 °C for 57 days. An increase of the peroxide value by 15 meq O2/kg, which was also reflected by a decrease of α-tocopherol congener by 15%–18%, was determined independent of the initial rancidity. The oxidative deterioration of the highly oxidized palm oil during storage was correlated with a significant 46% decline of the vitamin A content. However, household storage of mildly oxidized palm oil for two months did not induce any losses of vitamin A. Thus, mildly oxidized palm oil may be recommended for vitamin A fortification programs, when other sources of essential fatty acids are available. PMID:27338464

  18. Regioisomerism of triacylglycerols in lard, tallow, yolk, chicken skin, palm oil, palm olein, palm stearin, and a transesterified blend of palm stearin and coconut oil analyzed by tandem mass spectrometry.

    Science.gov (United States)

    Kallio, H; Yli-Jokipii, K; Kurvinen, J P; Sjövall, O; Tahvonen, R

    2001-07-01

    Triacylglycerols (TAG) of lard, tallow, egg yolk, chicken skin, palm oil, palm olein, palm stearin, and a transesterified blend of palm stearin and coconut oil (82:18) were investigated by chemical ionization and collision-induced dissociation tandem mass spectrometry. Accurate molecular level information of the regioisomeric structures of individual TAGs was achieved. When existing in a TAG molecule of lard, palmitic acid occupied 90-100% of the sn-2 position. Within the major fatty acid combinations in tallow TAGs, the secondary position sn-2 was preferentially occupied in the decreasing order by oleoyl > palmitoyl > stearoyl residues, the order in saturated TAGs being myristoyl > stearoyl = palmitoyl. TAGs in egg yolk were more asymmetric than in chicken skin, with linoleic acid highly specifically attached in the yolk sn-2 carbon. Nearly 50% of yolk TAGs contained 52 carbon atoms with two or three double bonds. Linoleic, oleic, and palmitic acids were in the sn-2 location in decreasing quantities in palm oil and its fractions. Triacylglycerols of equal molecular weight behaved similarly in the fractionation process. Randomization of the parent oil TAGs was seen in the transesterified oil. The tandem mass spectrometric analysis applied provided detailed information of the distribution of fatty acids in individual combinations in TAGs.

  19. Nitrogen management is essential to prevent tropical oil palm plantations from causing ground-level ozone pollution

    OpenAIRE

    C. N. Hewitt; MacKenzie, A. R.; Di Carlo, P.; C. F. Di Marco; J. R. Dorsey; Evans, M,; Fowler, D; M. W. Gallagher; J. R. Hopkins; Jones, C. E.; Langford, B.; Lee, J. D.; A. C. Lewis; S. F. Lim; McQuaid, J.

    2009-01-01

    More than half the world's rainforest has been lost to agriculture since the Industrial Revolution. Among the most widespread tropical crops is oil palm (Elaeis guineensis): global production now exceeds 35 million tonnes per year. In Malaysia, for example, 13% of land area is now oil palm plantation, compared with 1% in 1974. There are enormous pressures to increase palm oil production for food, domestic products, and, especially, biofuels. Greater use of palm oil for biofuel production is p...

  20. A novel biobased polyester plasticizer prepared from palm oil and its plasticizing effect on poly (vinyl chloride)

    OpenAIRE

    Jia Puyou; Zhang Meng; Hu Lihong; Zhou Yonghong

    2016-01-01

    In this study, palm oil was the first time to convert into a novel polyester plasticizer for polyvinyl chloride (PVC). In the first stage, palm oil was converted into palm oil monoglyceride (POM) by alcoholysis with glycerol. Next, a novel palm oil monoglycerides based polyester plasticizer (POMP) was synthesized from POM and maleic anhydride through esterification and condensation reaction. The structure of POMP was characterized with FTIR, 1H NMR and GPC. Then PVC blends were prepared using...

  1. Stability of Silica- and Enzyme-Treated Palm Oil Under Deep Frying Conditions.

    Science.gov (United States)

    Karim, Nur Azwani Ab; Noor, Ahmadilfitri Md; Lee, Yee-Ying; Lai, Oi-Ming

    2015-12-01

    The oxidative and thermal stability of low diglycerides palm oil produced via silica treatment (sPO) and enzymatic treatment (ePO) compared with standard quality palm oil (SQ) and premium quality palm oil (PQ) was investigated. Both of the oils displayed better oxidative stability compared with SQ as well as significantly higher (P oils showed slower drops in their IP values. The darkening effect after frying was significantly (P 0.05 in the rate of FFA formation between sPO and PQ. The anisidine value and peroxide values were lowest in sPO, followed by ePO, PQ, and SQ.

  2. Fermentation assisted byproduct recovery in the palm oil industry

    Energy Technology Data Exchange (ETDEWEB)

    Stanton, W.R.

    1983-05-01

    The production of palm oil from Elaeis guineensis is a leading natural product industry in Malaysia, giving rise to a number of residues, including a rich, fruity liquor from the pulp. The liquor, of which 7-10 million tonnes a year are currently produced, has some 6% organic solids, including 0.7-1.0% or more of oil which physical processing has failed to extract. Present anaerobic digestion processes exploit only the energy and fertiliser value. Methods are described in this paper for thermophilic, microbially assisted digestion for component separation and recovery, exploiting the widely used techniques for fruit juice extraction involving enzymic breakdown of starch, pectin and other cell components. Anaerobiosis and acidogenesis help protect and release residual oil, concomitantly preserving the solids against rancidity and spoilage by ensilage. The separated wet solids are nutritive (17% protein on dry matter), biologically safe and attractive to livestock. Downstream use of the liquor is aided by the thermophilic digestion. (Refs. 33).

  3. Pembuatan Mayones dengan Menggunakan Minyak Sawit Merah (Red palm oil) dan Minyak Zaitun (Olea europaea) Serta Uji Daya Terimanya

    OpenAIRE

    Afika, Henny

    2017-01-01

    Mayonnaise is a vegetable oil-based-food product. The vegetable oil that can be used as the ingredients of mayonnaise such as red palm oil and olive oil. Red palm oil contains high level of carotenoids as a source of vitamin A. This study aimed to determine the acceptance of mayonnaise combined with red palm oil and olive oil and its nutrition contents. This study used experimental design to make mayonnaise combined with three different ratio of red palm oil and olive oil (r...

  4. Palm oil as a fuel for agricultural diesel engines: Comparative testing against diesel oil

    OpenAIRE

    Teerawat Apichato; Gumpon Prateepchaikul1

    2003-01-01

    Due to unstable oil price situation in the world market, many countries have been looking for alternative energy sources to substitute for petroleum. Vegetable oil is one of the alternatives which can be used as fuel in automotive engines either in the form of straight vegetable oil, or in the form of ethyl or methyl ester. This paper presents a comparative performance testing of diesel engine using diesel oil and refined palm oil over 2,000 hours of continuous running time. Short-term perfor...

  5. A high performance liquid chromatography method for determination of furfural in crude palm oil.

    Science.gov (United States)

    Loi, Chia Chun; Boo, Huey Chern; Mohammed, Abdulkarim Sabo; Ariffin, Abdul Azis

    2011-09-01

    A modified steam distillation method was developed to extract furfural from crude palm oil (CPO). The collected distillates were analysed using high performance liquid chromatography (HPLC) coupled with an ultraviolet diode detector at 284nm. The HPLC method allowed identification and quantification of furfural in CPO. The unique thermal extraction of CPO whereby the fresh fruit bunches (FFB) are first subjected to steam treatment, distinguishes itself from other solvent-extracted or cold-pressed vegetable oils. The presence of furfural was also determined in the fresh palm oil from FFB (without undergoing the normal extraction process), palm olein, palm stearin, olive oil, coconut oil, sunflower oil, soya oil and corn oil. The chromatograms of the extracts were compared to that of standard furfural. Furfural was only detected in CPO. The CPO consignments obtained from four mills were shown to contain 7.54 to 20.60mg/kg furfural.

  6. Development narratives, notions of forest crisis, and boom of oil palm plantations in Indonesia

    NARCIS (Netherlands)

    Susanti, Ari; Maryudi, Ahmad

    2016-01-01

    Indonesia experienced massive deforestation in the last decades where rapid oil palm expansion has been considered as one of the main drivers. This article shows that the process of deforestation and the rapid oil palm expansion cannot be viewed in isolation from broader development contexts. Variou

  7. Benefits and costs of oil palm expansion in Central Kalimantan, Indonesia, under different policy scenarios

    NARCIS (Netherlands)

    Sumarga, Elham; Hein, Lars

    2016-01-01

    Deforestation and oil palm expansion in Central Kalimantan province are among the highest in Indonesia. This study examines the physical and monetary impacts of oil palm expansion in Central Kalimantan up to 2025 under three policy scenarios. Our modelling approach combines a spatial logistic reg

  8. Benefits and costs of oil palm expansion in Central Kalimantan, Indonesia, under different policy scenarios

    NARCIS (Netherlands)

    Sumarga, Elham; Hein, Lars

    2016-01-01

    Deforestation and oil palm expansion in Central Kalimantan province are among the highest in Indonesia. This study examines the physical and monetary impacts of oil palm expansion in Central Kalimantan up to 2025 under three policy scenarios. Our modelling approach combines a spatial logistic

  9. Telecoupled governance of land use change: Sustainable palm oil conservation benefits limited by preferential certification

    Science.gov (United States)

    Heilmayr, R.; Carlson, K. M.; Gibbs, H.; Noojipady, P.; Burns, D.; Morton, D. C.; Walker, N.; Paoli, G.; Kremen, C.

    2016-12-01

    Dozens of trans-national corporations have made public commitments to purchase only zero-deforestation palm oil, a commodity responsible for substantial tropical forest loss. Eco-certification is a basic requirement of most such forest-related procurement policies, and >20% of palm oil was certified in 2015.While the impact of certification on deforestation in oil palm plantations has never been tested, such evaluation is critical to inform improvements of voluntary sustainability initiatives. Here, we use a new, comprehensive data set of Roundtable on Sustainable Palm Oil (RSPO) certified and non-certified oil palm plantation boundaries (191,561 km2) in Indonesia, the leading global producer of palm oil to generate robust spatio-temporal estimates of certification's impact on deforestation and fires from 2000-2014. We find that certification reduced forest cover loss embodied in RSPO certified palm oil through two mechanisms. Certification had a significant protective effect, which lowered plantation deforestation rates by 29%.However, due to preferential certification of plantations developed before 2000, little forest was available for protection; forest area conserved totaled 56±4.9 km2. Our models suggest that increased adoption of RSPO certification may reduce the ability of palm oil companies to selectively certify previously cleared regions, and consequently strengthen the role of certification in protecting the tropical forests at greatest risk from agricultural encroachment. We reflect upon the complex interactions between traditional government policies, and emerging market-based governance structures in this telecoupled system.

  10. Development narratives, notions of forest crisis, and boom of oil palm plantations in Indonesia

    NARCIS (Netherlands)

    Susanti, Ari|info:eu-repo/dai/nl/343704676; Maryudi, Ahmad

    2016-01-01

    Indonesia experienced massive deforestation in the last decades where rapid oil palm expansion has been considered as one of the main drivers. This article shows that the process of deforestation and the rapid oil palm expansion cannot be viewed in isolation from broader development contexts.

  11. Exploring land use changes and the role of palm oil production in Indonesia and Malaysia

    NARCIS (Netherlands)

    Wicke, B.|info:eu-repo/dai/nl/306645955; Sikkema, R.|info:eu-repo/dai/nl/110609913; Dornburg, V.|info:eu-repo/dai/nl/189955007; Faaij, A.P.C.|info:eu-repo/dai/nl/10685903X

    2011-01-01

    This study compiles and analyses national-level data on land use change (LUC) and its causes in Indonesia and Malaysia over the past 30 years. The study also explores the role that palm oil has played in past LUC and that projected growth in palm oil production may play in LUC until 2020 and

  12. Exploring land use changes and the role of palm oil production in Indonesia and Malaysia

    NARCIS (Netherlands)

    Wicke, B.; Sikkema, R.; Dornburg, V.; Faaij, A.P.C.

    2011-01-01

    This study compiles and analyses national-level data on land use change (LUC) and its causes in Indonesia and Malaysia over the past 30 years. The study also explores the role that palm oil has played in past LUC and that projected growth in palm oil production may play in LUC until 2020 and suggest

  13. Land use change effects of oil palm expansion on ecosystem services in Tapi river basin, Thailand

    NARCIS (Netherlands)

    Saswattecha, K.; Hein, L.G.; Kroeze, C.; Jawjit, Warit

    2016-01-01

    The last decades have shown a strong increase in oil palm production in Thailand. This is increasingly leading to land conversion including loss of forest habitat. However the specific direct and indirect land use effects of oil palm expansion in Thailand are as yet insufficiently understood. We sel

  14. Efficient transformation of oil palm protoplasts by PEG-mediated transfection and DNA microinjection.

    Directory of Open Access Journals (Sweden)

    Mat Yunus Abdul Masani

    Full Text Available BACKGROUND: Genetic engineering remains a major challenge in oil palm (Elaeis guineensis because particle bombardment and Agrobacterium-mediated transformation are laborious and/or inefficient in this species, often producing chimeric plants and escapes. Protoplasts are beneficial as a starting material for genetic engineering because they are totipotent, and chimeras are avoided by regenerating transgenic plants from single cells. Novel approaches for the transformation of oil palm protoplasts could therefore offer a new and efficient strategy for the development of transgenic oil palm plants. METHODOLOGY/PRINCIPAL FINDINGS: We recently achieved the regeneration of healthy and fertile oil palms from protoplasts. Therefore, we focused on the development of a reliable PEG-mediated transformation protocol for oil palm protoplasts by establishing and validating optimal heat shock conditions, concentrations of DNA, PEG and magnesium chloride, and the transfection procedure. We also investigated the transformation of oil palm protoplasts by DNA microinjection and successfully regenerated transgenic microcalli expressing green fluorescent protein as a visible marker to determine the efficiency of transformation. CONCLUSIONS/SIGNIFICANCE: We have established the first successful protocols for the transformation of oil palm protoplasts by PEG-mediated transfection and DNA microinjection. These novel protocols allow the rapid and efficient generation of non-chimeric transgenic callus and represent a significant milestone in the use of protoplasts as a starting material for the development of genetically-engineered oil palm plants.

  15. The drive for accumulation: environmental contestation and agrarian support to Mexico's oil palm expansion

    NARCIS (Netherlands)

    Castellanos Navarrete, A.; Jansen, K.

    2013-01-01

    Oil palm expansion has been related to rural dispossession, environmental degradation and rural resistance. This paper explores the politics and impact of farmer-based oil palm expansion in Chiapas, Mexico. In relation to the debate on the greening of the agrarian question, this paper engages with t

  16. Palm oil and the emission of carbon-based greenhouse gases

    NARCIS (Netherlands)

    Reijnders, L.; Huijbregts, M.A.J.

    2008-01-01

    The current use of South Asian palm oil as biofuel is far from climate neutral. Dependent on assumptions, losses of biogenic carbon associated with ecosystems, emission of CO2 due to the use of fossil fuels and the anaerobic conversion of palm oil mill effluent currently correspond in South Asia wit

  17. Development narratives, notions of forest crisis, and boom of oil palm plantations in Indonesia

    NARCIS (Netherlands)

    Susanti, Ari|info:eu-repo/dai/nl/343704676; Maryudi, Ahmad

    2016-01-01

    Indonesia experienced massive deforestation in the last decades where rapid oil palm expansion has been considered as one of the main drivers. This article shows that the process of deforestation and the rapid oil palm expansion cannot be viewed in isolation from broader development contexts. Variou

  18. Palm oil and the emission of carbon-based greenhouse gases

    NARCIS (Netherlands)

    Reijnders, L.; Huijbregts, M.A.J.

    2008-01-01

    The current use of South Asian palm oil as biofuel is far from climate neutral. Dependent on assumptions, losses of biogenic carbon associated with ecosystems, emission of CO2 due to the use of fossil fuels and the anaerobic conversion of palm oil mill effluent currently correspond in South Asia

  19. Characterization of oil palm MADS box genes in relation to the mantled flower abnormality

    NARCIS (Netherlands)

    Syed Alwee, S.; Linden, van der C.G.; Schoot, van der J.; Folter, de S.; Angenent, G.C.; Cheah, S.C.; Smulders, M.J.M.

    2006-01-01

    In vitro propagation of oil palm (Elaeis guineensis Jacq.) frequently induces a somaclonal variant called `mantled¿ abnormality, in which the stamens of both male and female flowers are transformed into carpels. This leads to a reduced yield or complete loss of the harvest of palm oil. The high

  20. 77 FR 4300 - Notice of Data Availability Concerning Renewable Fuels Produced From Palm Oil Under the RFS Program

    Science.gov (United States)

    2012-01-27

    ... Indonesia and Malaysia 5. Analysis of Palm Oil Mills B. Results of Lifecycle Analysis for Biodiesel From... palm oil for use in biofuels would be produced in Indonesia and Malaysia our modeling efforts focus on... response in the scenarios modeled is to increase palm oil production in Malaysia and Indonesia. In our...

  1. Aboveground carbon stocks in oil palm plantations and the threshold for carbon-neutral vegetation conversion on mineral soils

    NARCIS (Netherlands)

    Khasanah, N.; Noordwijk, van M.; Ningsih, H.

    2015-01-01

    The carbon (C) footprint of palm oil production is needed to judge emissions from potential biofuel use. Relevance includes wider sustainable palm oil debates. Within life cycle analysis, aboveground C debt is incurred if the vegetation replaced had a higher C stock than oil palm plantations. Our

  2. Understanding the expansion of energy crops beyond the global biofuel boom : evidence from oil palm expansion in Colombia

    NARCIS (Netherlands)

    Marin-Burgos, Victoria; Clancy, Joy S.

    2017-01-01

    Background: The global palm oil market experienced a remarkable boom since the year 2000. Since palm oil can be used for biodiesel production, the global expansion of oil palm cultivation has been associated with the global biofuel boom. Biofuel policies—especially those adopted in the European

  3. Aboveground carbon stocks in oil palm plantations and the threshold for carbon-neutral vegetation conversion on mineral soils

    NARCIS (Netherlands)

    Khasanah, N.; Noordwijk, van M.; Ningsih, H.

    2015-01-01

    The carbon (C) footprint of palm oil production is needed to judge emissions from potential biofuel use. Relevance includes wider sustainable palm oil debates. Within life cycle analysis, aboveground C debt is incurred if the vegetation replaced had a higher C stock than oil palm plantations. Our st

  4. Expression Comparison of Oil Biosynthesis Genes in Oil Palm Mesocarp Tissue Using Custom Array

    Directory of Open Access Journals (Sweden)

    Yick Ching Wong

    2014-11-01

    Full Text Available Gene expression changes that occur during mesocarp development are a major research focus in oil palm research due to the economic importance of this tissue and the relatively rapid increase in lipid content to very high levels at fruit ripeness. Here, we report the development of a transcriptome-based 105,000-probe oil palm mesocarp microarray. The expression of genes involved in fatty acid (FA and triacylglycerol (TAG assembly, along with the tricarboxylic acid cycle (TCA and glycolysis pathway at 16 Weeks After Anthesis (WAA exhibited significantly higher signals compared to those obtained from a cross-species hybridization to the Arabidopsis (p-value < 0.01, and rice (p-value < 0.01 arrays. The oil palm microarray data also showed comparable correlation of expression (r2 = 0.569, p < 0.01 throughout mesocarp development to transcriptome (RNA sequencing data, and improved correlation over quantitative real-time PCR (qPCR (r2 = 0.721, p < 0.01 of the same RNA samples. The results confirm the advantage of the custom microarray over commercially available arrays derived from model species. We demonstrate the utility of this custom microarray to gain a better understanding of gene expression patterns in the oil palm mesocarp that may lead to increasing future oil yield.

  5. In-situ data collection for oil palm tree height determination using synthetic aperture radar

    Science.gov (United States)

    Pohl, C.; Loong, C. K.

    2016-04-01

    The oil palm is recognized as the “golden crop,” producing the highest oil yield among oil seed crops. Malaysia, the world's second largest producer of palm oil, has 16 per cent of its territory planted with oil palms. To cope with the increasing global demand on edible oil, additional areas of oil palm are forecast to increase globally by 12 to 19 million hectares by 2050. Due to the limited land bank in Malaysia, new strategies have to be developed to avoid unauthorized clearing of primary forest for the use of oil palm cultivation. Microwave remote sensing could play a part by providing relevant, timely and accurate information for a plantation monitoring system. The use of synthetic aperture radar (SAR) has the advantage of daylight- and weather-independence, a criterion that is very relevant in constantly cloud-covered tropical regions, such as Malaysia. Using interferometric SAR, (InSAR) topographical and tree height profiles of oil palm plantations can be created; such information is useful for mapping oil palm age profiles of the plantations in the country. This paper reports on the use of SAR and InSAR in a multisensory context to provide up-to-date information at plantation level. Remote sensing and in-situ data collection for tree height determination are described. Further research to be carried out over the next two years is outlined.

  6. The possibility of palm oil mill effluent for biogas production

    Directory of Open Access Journals (Sweden)

    EDWI MAHAJOENO

    2008-01-01

    Full Text Available The world currently obtains its energy from the fossil fuels such as oil, natural gas and coal. However, the international crisis in the Middle East, rapid depletion of fossil fuel reserves as well as climate change have driven the world towards renewable energy sources which are abundant, untapped and environmentally friendly. Indonesia has abundant biomass resources generated from the agricultural industry particularly the large commodity, palm oil (Elaeis guiinensis Jacq.. The aims of the research were to (i characterize palm oil mill effluent which will be used as source of biogas production, (ii know the biotic and abiotic factors which effect POME substrate for biogas production by anaerobic digestion in bulk system. The results show that POME sludge generated from PT Pinago Utama mill is viscous, brown or grey and has an average total solid (TS content of, 26.5-45.4, BOD is 23.5-29.3, COD is 49.0-63.6 and SS is 17.1-35.9 g/L, respectively. This substrate is a potential source of environmental pollutants. The biotic factors were kind and concentration of the inoculums, i.e. seed sludge of anaerobic lagoon II and 20% (w/v respectively. Both physical and chemical factors such as pre-treated POME pH, pH neutralizer matter Ca (OH2, temperature ≥40oC, agitation effect to increase biogas production, but in both coagulant concentration, FeCl2 were not.

  7. SUSTAINABILITY OF SUSTAINABLE PALM OIL: A MARKET INTEGRATION ANALYSIS

    Directory of Open Access Journals (Sweden)

    Diana Chalil

    2016-07-01

    Full Text Available Crude Palm Oil (CPO is the biggest consumed vegetable oil in the world. The increase in CPO production raises concern on the environmental impact even outside the producing countries. As a response to this matter, the EU has made a requirement to only import certified CPO (CSPO. India and China, the two biggest importers in the world, are less restrictive to the environmental issues, and their demands are more influenced by CPO price levels. These countries are the main export markets for Indonesia and Malaysia, the two biggest CPO exporters in the world. This research using monthly price data from the Netherlands, Germany, Italy, EU28, India, China, Indonesia and Malaysia. Market integrations are tested with Cointegration Test, Vector Error Correction Model and Seemingly Unrelated Regression. The results show that these markets are integrated, but European countries are unlikely to lead the price movement. Therefore, the concern on sustainable certification from the European countries still slowly spreads to other main importers, resulting in low absorption of CSPO. Keywords: market integration; sustainable palm oil; seemingly unrelated regression; vector Error correction model

  8. How the palm oil industry is cooking the climate

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2007-11-15

    Every year, 1.8 billion tonnes (Gt) of climate changing greenhouse gas (GHG) emissions are released by the degradation and burning of Indonesia's peatlands, which is 4% of global GHG emissions from less than 0.1% of the land on earth. This report shows how, through growing demand for palm oil, the world's largest food, cosmetic and biofuel industries are driving the wholesale destruction of peatlands and rainforests. These companies include Unilever, Nestle and Procter and Gamble, who between them account for a significant volume of global palm oil use, mainly from Indonesia and Malaysia. Overlaying satellite imagery of forest fires with maps indicating the locations of the densest carbon stores in Indonesia, Greenpeace researchers have been able to pinpoint carbon 'hotspots'. Our research has taken us to the Indonesian province of Riau on the island of Sumatra, to document the current activities of those involved in the expansion of palm oil. These are the producers who trade with Unilever, Nestle and Procter and Gamble, as well as many of the other top names in the food, cosmetic and biofuel industries. The area of peatland in Riau is tiny: just 4 million hectares, about the size of Taiwan or Switzerland. Yet Riau's peatlands store 14.6Gt of carbon. If these peatlands were destroyed, the resulting GHG emissions would be equivalent to one year's total global emissions. Unless efforts are made to halt forest and peatland destruction, emissions from these peatlands may trigger a 'climate bomb'.

  9. Rigid polyurethane/oil palm fibre biocomposite foam

    Science.gov (United States)

    Alis, Adilah; Majid, Rohah A.; Nasir, Izzah Athirah Ahmad; Mustaffa, Nor Syatika; Hassan, Wan Hasamuddin Wan

    2017-07-01

    Rigid polyurethane (PU) biocomposite foam had been successfully prepared by reacting palm oil-derived polyol (PO-p) with polymeric 4, 4-diphenylmethane diisocynate (p-MDI). Two types of alkali-treated oil palm fibres namely, empty fruit bunch (EFB) and palm pressed fibre (PPF) were used as fillers to be incorporated into PU foam at 2.5 wt%, 5 wt% and 7.5 wt% fibre loadings. The effects of these fibres on surface morphology, compressive strength and thermal transition behaviours of biocomposite foams were investigated. Fourier transform infra-red (FTIR) analysis confirmed the formation of urethane linkages (-NHCOO) in all samples at 1530-1540 cm-1. Differential scanning calorimetry (DSC) analysis showed the average melting peak temperature (Tm) of biocomposite foams (132°C) were lower Tm than that of pure PU foam (161.67°C) and the increase amount of fibres did not give significant effect on the Tm of both biocomposite systems. Meanwhile, the microscopic images of PU-PPF foams exhibited smaller and uniform cell size morphologies compared with the PU-EFB foams that had coarse and irregular cell sizes, especially at 7.5wt% EFB. These findings were manifested with the gradually increase of compressive strength of PU-PPF at all PPF ratios while for PU-EFB system, the compressive strength increased up to 5 wt% before reduced at 7.5 wt% loading. It was thought due to the residual oil in PPF fibre had plasticized the PU matrix to a little extent, thus helping the dispersion of PPF fibre across the matrix.

  10. Gasification of Nickel-Preloaded Oil Palm Biomass with Air

    Directory of Open Access Journals (Sweden)

    Syed Shatir A. Syed-Hassan

    2016-10-01

    Full Text Available This study experimentally investigates the gasification of nickel-preloaded oil palm biomass as an alternative catalytic approach to produce clean syngas. To eliminate the use of catalyst support, nickel was added directly to the oil palm mesocarp fiber via ion-exchange using an aqueous solution of nickel nitrate. Nickel species was found to disperse very well on the biomass at a nano-scale dispersion. The presence of the finely dispersed nickels on biomass enhanced syngas production and reduced tar content in the producer gas during the air gasification of biomass. It is believed that nickel particles attached on the biomass and its char promote the catalytic cracking of tar on their surface and supply free radicals to the gas phase to enhance the radical-driven gas-phase reactions for the reforming of high molecular weight hydrocarbons. The unconsumed nickel-containing char shows great potential to be re-utilised as a catalyst to further enhance the destruction of tar components in the secondary tar reduction process. Copyright © 2016 BCREC GROUP. All rights reserved Received: 12nd September 2015; Revised: 10th January 2016; Accepted:16th January 2016 How to Cite: Syed-Hassan, S.S.A., Nor-Azemi, S. (2016. Gasification of Nickel-Preloaded Oil Palm Biomass with Air. Bulletin of Chemical Reaction Engineering & Catalysis, 11 (3: 262-272 (doi:10.9767/bcrec.11.3.566.262-272 Permalink/DOI: http://doi.org/10.9767/bcrec.11.3.566.262-272

  11. Electrical breakdown strength characteristics of palm kernel oil ester-based dielectric fluids

    OpenAIRE

    Abdelmalik, A. A.; Fothergill, J; Dodd, S.J.

    2011-01-01

    Natural ester fluids have been synthesized from crude palm kernel oil for consideration as an alternative to mineral oil based insulating fluid. Chemical modification of the oil enhanced the physico-chemical properties of the fluid. This paper presents the statistical analysis of the AC electrical breakdown strength of the synthesized esters in comparison with the crude palm kernel oil sample. The breakdown test was carried out in accordance with ASTM 1816 test method using a bespoke test cel...

  12. Closing oil palm yield gaps among Indonesian smallholders through industry schemes, pruning, weeding and improved seeds.

    Science.gov (United States)

    Soliman, T; Lim, F K S; Lee, J S H; Carrasco, L R

    2016-08-01

    Oil palm production has led to large losses of valuable habitats for tropical biodiversity. Sparing of land for nature could in theory be attained if oil palm yields increased. The efficiency of oil palm smallholders is below its potential capacity, but the factors determining efficiency are poorly understood. We employed a two-stage data envelopment analysis approach to assess the influence of agronomic, supply chain and management factors on oil palm production efficiency in 190 smallholders in six villages in Indonesia. The results show that, on average, yield increases of 65% were possible and that fertilizer and herbicide use was excessive and inefficient. Adopting industry-supported scheme management practices, use of high-quality seeds and higher pruning and weeding rates were found to improve efficiency. Smallholder oil palm production intensification in Indonesia has the capacity to increase production by 26%, an equivalent of 1.75 million hectares of land.

  13. A MODEL FOR THE PALM OIL MARKET IN NIGERIA: AN ECONOMETRICS APPROACH

    Directory of Open Access Journals (Sweden)

    Henry Egwuma

    2016-04-01

    Full Text Available The aim of this study is to formulate and estimate a model for the palm oil market in Nigeria with a view to identifying principal factors that shape the Nigerian palm oil industry. Four structural equation models comprising palm oil production, import demand, domestic demand and producer price have been estimated using the autoregressive distributed lag (ARDL cointegration approach over the 1970 to 2011 period. The results reveal that significant factors that influence the Nigerian palm oil industry include the own price, technological improvements, and income level. Government expenditure on agricultural development is also an important determinant, which underscores the need for government support in agriculture. Our model provides a useful framework for analyzing the effects of changes in major exogenous variables such as income or import tariff on the production, demand, and price of palm oil.

  14. Catalytic cracking of palm oil for the production of biofuels: optimization studies.

    Science.gov (United States)

    Tamunaidu, Pramila; Bhatia, Subhash

    2007-12-01

    Oil palm is widely grown in Malaysia. Palm oil has attracted the attention of researchers to develop an 'environmentally friendly' and high quality fuel, free of nitrogen and sulfur. In the present study, the catalytic cracking of palm oil to biofuel was studied over REY catalyst in a transport riser reactor at atmospheric pressure. The effect of reaction temperature (400-500 degrees C), catalyst/palm oil ratio (5-10) and residence time (10-30s) was studied over the yield of bio-gasoline and gas as fuel. Design of experiments was used to study the effect of operating variables over conversion of palm oil and yield of hydrocarbon fuel. The response surface methodology was used to determine the optimum value of the operating variables for maximum yield of bio-gasoline fraction in the liquid product obtained.

  15. Palm oil industry: A review of the literature on the modelling approaches and potential solution

    Science.gov (United States)

    Zabid, M. Faeid M.; Abidin, Norhaslinda Zainal

    2015-12-01

    Palm oil industry plays an important role as a backbone to the economy of a country, especially in many developing countries. Various issues related to the palm oil context have been studied rigorously by previous researchers using appropriate modeling approaches. Thus, the purpose of this paper is to present an overview of existing modeling approaches used by researchers in studying several issues in the palm oil industry. However, there are still limited numbers of researches that focus to determine the impact of strategy policies on palm oil studies. Furthermore, this paper introduces an improved system dynamics and genetic algorithm technique to facilitate the policy design process in palm oil industry. The proposed method is expected to become a framework for structured policy design process to assist the policy maker in evaluating and designing appropriate policies.

  16. The use of response surface analysis in obtaining maximum profit in oil palm industry

    Directory of Open Access Journals (Sweden)

    Ahmad Tarmizi Mohammed

    2006-03-01

    Full Text Available This study was conducted to show how to use Response Surface Analysis in obtaining the optimum level of fertilizer needs by oil palm. The ridge analysis was proposed to overcome the saddle point problem. Data from Malaysian Palm Oil Board database was analyzed. The fertilizers considered are N, P, K and Mg. The results from ridge analysis provided several alternatives of the fertilizer combination. Profit analysis was then applied to determine the best combination of fertilizers needed by the oil palm in order to generate maximum profit. It is found that N and K fertilizers were the important fertilizers required by the oil palm. It is also found that the N and K nutrient concentrations of the foliar nutrient composition were higher compared to other nutrients. Three different stations were considered and it was found that the fertilizersneeded by the oil palm and foliar nutrient composition were different at the different type of soil series.

  17. The Effect of the Operating Conditions on the Apparent Viscosity of Crude Palm Oil During Oil Clarification

    Directory of Open Access Journals (Sweden)

    Sulaiman Al-Zuhair, Mirghani I. Ahmed and Yousif A. Abakr

    2012-10-01

    Full Text Available This paper discusses the apparent viscosity of crude palm oil, using rotary viscometer, under different boundary conditions. It was experimentally shown that the apparent viscosity of palm oil drops with increasing of the shear rate and the temperature.  However, the effect of temperature on the viscosity tends to fade at temperatures beyond 80 oC.  A correlation between the apparent viscosity of crude palm oil and the operating conditions was developed. This correlation can be used in design of crude palm oil settlers and in determining the optimum operating conditions.Key Words:  Crude palm oil, apparent viscosity, shear rate, modelling, separation 

  18. Mechanical Properties of Oil Palm Empty Fruit Bunch Fiber

    Science.gov (United States)

    Gunawan, Fergyanto E.; Homma, Hiroomi; Brodjonegoro, Satryo S.; Hudin, Afzer Bin Baseri; Zainuddin, Aryanti Binti

    In tropical countries such as Indonesia and Malaysia, the empty fruit bunches are wastes of the oil palm industry. The wastes are abundantly available and has reached a level that severely threats the environment. Therefore, it is a great need to find useful applications of those waste materials; but firstly, the mechanical properties of the EFB fiber should be quantified. In this work, a small tensile test machine is manufactured, and the tensile test is performed on the EFB fibers. The results show that the strength of the EFB fiber is strongly affected by the fiber diameter; however, the fiber strength is relatively low in comparison to other natural fibers.

  19. Oil palm genome sequence reveals divergence of interfertile species in Old and New worlds.

    Science.gov (United States)

    Singh, Rajinder; Ong-Abdullah, Meilina; Low, Eng-Ti Leslie; Manaf, Mohamad Arif Abdul; Rosli, Rozana; Nookiah, Rajanaidu; Ooi, Leslie Cheng-Li; Ooi, Siew-Eng; Chan, Kuang-Lim; Halim, Mohd Amin; Azizi, Norazah; Nagappan, Jayanthi; Bacher, Blaire; Lakey, Nathan; Smith, Steven W; He, Dong; Hogan, Michael; Budiman, Muhammad A; Lee, Ernest K; DeSalle, Rob; Kudrna, David; Goicoechea, Jose Luis; Wing, Rod A; Wilson, Richard K; Fulton, Robert S; Ordway, Jared M; Martienssen, Robert A; Sambanthamurthi, Ravigadevi

    2013-08-15

    Oil palm is the most productive oil-bearing crop. Although it is planted on only 5% of the total world vegetable oil acreage, palm oil accounts for 33% of vegetable oil and 45% of edible oil worldwide, but increased cultivation competes with dwindling rainforest reserves. We report the 1.8-gigabase (Gb) genome sequence of the African oil palm Elaeis guineensis, the predominant source of worldwide oil production. A total of 1.535 Gb of assembled sequence and transcriptome data from 30 tissue types were used to predict at least 34,802 genes, including oil biosynthesis genes and homologues of WRINKLED1 (WRI1), and other transcriptional regulators, which are highly expressed in the kernel. We also report the draft sequence of the South American oil palm Elaeis oleifera, which has the same number of chromosomes (2n = 32) and produces fertile interspecific hybrids with E. guineensis but seems to have diverged in the New World. Segmental duplications of chromosome arms define the palaeotetraploid origin of palm trees. The oil palm sequence enables the discovery of genes for important traits as well as somaclonal epigenetic alterations that restrict the use of clones in commercial plantings, and should therefore help to achieve sustainability for biofuels and edible oils, reducing the rainforest footprint of this tropical plantation crop.

  20. Microcapsules Filled with a Palm Oil-Based Alkyd as Healing Agent for Epoxy Matrix

    Directory of Open Access Journals (Sweden)

    Nurshafiza Shahabudin

    2016-04-01

    Full Text Available One of the approaches to prolong the service lifespan of polymeric material is the development of self-healing ability by means of embedded microcapsules containing a healing agent. In this work, poly(melamine-urea-formaldehyde (PMUF microcapsules containing a palm oil-based alkyd were produced by polymerization of melamine resin, urea and formaldehyde that encapsulated droplets of the suspended alkyd particles. A series of spherical and free-flowing microcapsules were obtained. The chemical properties of core and shell materials were characterized by Attenuated total reflection-Fourier transform infrared spectroscopy (ATR-FTIR and proton nuclear magnetic resonance spectroscopy (1H-NMR. Differential scanning calorimetry (DSC analysis showed a glass transition around −15 °C due to the alkyd, and a melting temperature at around 200 °C due to the shell. Thermogravimetric analysis (TGA results showed that the core and shell thermally degraded within the temperature range of 200–600 °C. Field emission scanning electron microscope (FESEM examination of the ruptured microcapsule showed smooth inner and rough outer surfaces of the shell. Flexural strength and microhardness (Vickers of the cured epoxy compound were not affected with the incorporation of 1%–3% of the microcapsules. The viability of the healing reactions was demonstrated by blending small amounts of alkyd with epoxy and hardener at different ratios. The blends could readily cure to non-sticky hard solids at room temperature and the reactions could be verified by ATR-FTIR.

  1. Gene coexpression network analysis of oil biosynthesis in an interspecific backcross of oil palm.

    Science.gov (United States)

    Guerin, Chloé; Joët, Thierry; Serret, Julien; Lashermes, Philippe; Vaissayre, Virginie; Agbessi, Mawussé D T; Beulé, Thierry; Severac, Dany; Amblard, Philippe; Tregear, James; Durand-Gasselin, Tristan; Morcillo, Fabienne; Dussert, Stéphane

    2016-09-01

    Global demand for vegetable oils is increasing at a dramatic rate, while our understanding of the regulation of oil biosynthesis in plants remains limited. To gain insights into the mechanisms that govern oil synthesis and fatty acid (FA) composition in the oil palm fruit, we used a multilevel approach combining gene coexpression analysis, quantification of allele-specific expression and joint multivariate analysis of transcriptomic and lipid data, in an interspecific backcross population between the African oil palm, Elaeis guineensis, and the American oil palm, Elaeis oleifera, which display contrasting oil contents and FA compositions. The gene coexpression network produced revealed tight transcriptional coordination of fatty acid synthesis (FAS) in the plastid with sugar sensing, plastidial glycolysis, transient starch storage and carbon recapture pathways. It also revealed a concerted regulation, along with FAS, of both the transfer of nascent FA to the endoplasmic reticulum, where triacylglycerol assembly occurs, and of the production of glycerol-3-phosphate, which provides the backbone of triacylglycerols. Plastid biogenesis and auxin transport were the two other biological processes most tightly connected to FAS in the network. In addition to WRINKLED1, a transcription factor (TF) known to activate FAS genes, two novel TFs, termed NF-YB-1 and ZFP-1, were found at the core of the FAS module. The saturated FA content of palm oil appeared to vary above all in relation to the level of transcripts of the gene coding for β-ketoacyl-acyl carrier protein synthase II. Our findings should facilitate the development of breeding and engineering strategies in this and other oil crops.

  2. Characterizing commercial oil palm expansion in Latin America: land use change and trade

    Science.gov (United States)

    Furumo, Paul Richard; Aide, T. Mitchell

    2017-02-01

    Commodity crop expansion has increased with the globalization of production systems and consumer demand, linking distant socio-ecological systems. Oil palm plantations are expanding in the tropics to satisfy growing oilseed and biofuel markets, and much of this expansion has caused extensive deforestation, especially in Asia. In Latin America, palm oil output has doubled since 2001, and the majority of expansion seems to be occurring on non-forested lands. We used MODIS satellite imagery (250 m resolution) to map current oil palm plantations in Latin America and determined prior land use and land cover (LULC) using high-resolution images in Google Earth. In addition, we compiled trade data to determine where Latin American palm oil flows, in order to better understand the underlying drivers of expansion in the region. Based on a sample of 342 032 ha of oil palm plantations across Latin America, we found that 79% replaced previously intervened lands (e.g. pastures, croplands, bananas), primarily cattle pastures (56%). The remaining 21% came from areas that were classified as woody vegetation (e.g. forests), most notably in the Amazon and the Petén region in northern Guatemala. Latin America is a net exporter of palm oil but the majority of palm oil exports (70%) stayed within the region, with Mexico importing about half. Growth of the oil palm sector may be driven by global factors, but environmental and economic outcomes vary between regions (i.e. Asia and Latin America), within regions (i.e. Colombia and Peru), and within single countries (i.e. Guatemala), suggesting that local conditions are influential. The present trend of oil palm expanding onto previously cleared lands, guided by roundtable certifications programs, provides an opportunity for more sustainable development of the oil palm sector in Latin America.

  3. Proteomic profiling of mature leaves from oil palm (Elaeis guineensis Jacq.).

    Science.gov (United States)

    Tan, Hooi Sin; Jacoby, Richard P; Ong-Abdullah, Meilina; Taylor, Nicolas L; Liddell, Susan; Chee, Wong Wei; Chin, Chiew Foan

    2017-04-01

    Oil palm is one of the most productive oil bearing crops grown in Southeast Asia. Due to the dwindling availability of agricultural land and increasing demand for high yielding oil palm seedlings, clonal propagation is vital to the oil palm industry. Most commonly, leaf explants are used for in vitro micropropagation of oil palm and to optimize this process it is important to unravel the physiological and molecular mechanisms underlying somatic embryo production from leaves. In this study, a proteomic approach was used to determine protein abundance of mature oil palm leaves. To do this, leaf proteins were extracted using TCA/acetone precipitation protocol and separated by 2DE. A total of 191 protein spots were observed on the 2D gels and 67 of the most abundant protein spots that were consistently observed were selected for further analysis with 35 successfully identified using MALDI TOF/TOF MS. The majority of proteins were classified as being involved in photosynthesis, metabolism, cellular biogenesis, stress response, and transport. This study provides the first proteomic assessment of oil palm leaves in this important oil crop and demonstrates the successful identification of selected proteins spots using the Malaysian Palm Oil Board (MPOB) Elaeis guineensis EST and NCBI-protein databases. The MS data have been deposited in the ProteomeXchange Consortium database with the data set identifier PXD001307. © 2017 WILEY-VCH Verlag GmbH & Co. KGaA, Weinheim.

  4. Thermoliquefaction of palm oil fiber (Elaeis sp.) using supercritical ethanol.

    Science.gov (United States)

    Oliveira, Aline L P C; Almeida, Priscila S; Campos, Maria C V; Franceschi, Elton; Dariva, Cláudio; Borges, Gustavo R

    2017-04-01

    Thermoliquefaction of palm oil fiber was investigated using supercritical ethanol as solvent. A semi-continuous laboratory scale unit was developed to investigate the effects of temperature (300-500°C), heating rate (10-30°C.min(-1)) and cracking time (10-30min) on the conversion of biomass in bio-oil. The main advantage of the proposed process is that a pure solvent is pumping through the reactor that contains the biomass, dispensing the use of biomass slurries. The yield of bio-oil ranged from 56% to 84%, depending on the experimental conditions. It was observed that an increase in working temperature led to an increase in the bio-oil production. Cracking time and heating rate variation had not shown a considerable effect on the conversion of biomass. The chemical profiles of bio-oil determined by GC/MS, indicate that at low temperature mainly sugar derivatives are produced, while at higher temperatures alcohols and phenolic are the majority compounds of the bio-oil. Copyright © 2017 Elsevier Ltd. All rights reserved.

  5. Chemical interesterification of blends of palm stearin, coconut oil, and canola oil: physicochemical properties.

    Science.gov (United States)

    Soares, Fabiana Andreia Schäfer De Martini; da Silva, Roberta Claro; Hazzan, Márcia; Capacla, Isabele Renata; Viccola, Elise Raduan; Maruyama, Jessica Mayumi; Gioielli, Luiz Antonio

    2012-02-15

    trans-Free interesterified fat was produced for possible usage as a margarine. Palm stearin, coconut oil, and canola oil were used as substrates for chemical interesterification. The main aim of the present study was to evaluate the physicochemical properties of blends of palm stearin, coconut oil, and canola oil submitted to chemical interesterification using sodium methoxide as the catalyst. The original and interesterified blends were examined for fatty acid composition, softening and melting points, solid fat content, and consistency. Chemical interesterification reduced softening and melting points, consistency, and solid fat content. The interesterified fats showed desirable physicochemical properties for possible use as a margarine. Therefore, our result suggested that the interesterified fat without trans-fatty acids could be used as an alternative to partially hydrogenated fat.

  6. Coconut oil and palm oil's role in nutrition, health and national development: A review.

    Science.gov (United States)

    Boateng, Laurene; Ansong, Richard; Owusu, William B; Steiner-Asiedu, Matilda

    2016-09-01

    Coconut and palm oils which were the major sources of dietary fats for centuries in most of West Africa have been branded as unhealthy highly saturated fats. Their consumption has been peddled to supposedly raise the level of blood cholesterol, thereby increasing the risk of coronary heart disease. This adverse view has led to a reduction in their consumption in West Africa and they have been substituted for imported vegetable oils. Recent information however, indicates some beneficial effects of these oils particularly their roles in nutrition, health and national development. There is the need for a better understanding of their effects on health, nutritional status and national development. This paper therefore attempts to review the roles which coconut and palm oils play in these respects in developing countries, as a means of advocating for a return to their use in local diets.

  7. Experimental Investigation on Usage of Palm Oil as a Lubricant to Substitute Mineral Oil in CI Engines

    Directory of Open Access Journals (Sweden)

    K. S. V. Krishna Reddy

    2014-01-01

    Full Text Available Due to growing environmental concerns, vegetable oils are finding their way into lubricants for industrial and transportation applications. The substitution of mineral oil with vegetable oil as a base stock for an environment friendly lubricant in a CI engine is explored in this study without adding any additives. The experiments have been conducted with a mixture of palm oil and mineral oil, at different compositions. Blends of palm oil and mineral oil in different compositions, 0, 25, and 50 (by vol % were added to base SAE20W40 mineral oil to obtain different lubricant blends. The parameters evaluated include brake thermal efficiency, brake specific fuel consumption, volumetric efficiency, and mechanical efficiency and exhaust emissions. The engine performance and emission tests were carried out on a single cylinder, water cooled, 4-stroke CI engine. Compared to mineral oil, the palm oil-based lubricant revealed appreciable expedience on engine and emission performance.

  8. Performance Evaluation of Palm Oil-Based Biodiesel Combustion in an Oil Burner

    Directory of Open Access Journals (Sweden)

    Abdolsaeid Ganjehkaviri

    2016-02-01

    Full Text Available This paper presents an experimental investigation of the combustion characteristics of palm methyl ester (PME, also known as palm oil-based biodiesel, in an oil burner system. The performance of conventional diesel fuel (CDF and various percentages of diesel blended with palm oil-based biodiesel is also studied to evaluate their performance. The performance of the various fuels is evaluated based on the temperature profile of the combustor’s wall and emissions, such as nitrogen oxides (NOx and carbon monoxide (CO. The combustion experiments were conducted using three different oil burner nozzles (1.25, 1.50 and 1.75 USgal/h under lean (equivalence ratio (Φ = 0.8, stoichiometric (Φ = 1 and rich fuel (Φ = 1.2 ratio conditions. The results show that the rate of emission formation decreases as the volume percent of palm biodiesel in a blend increases. PME combustion tests present a lower temperature inside the chamber compared to CDF combustion. High rates of NOx formation occur under lean mixture conditions with the presence of high nitrogen and sufficient temperature, whereas high CO occurs for rich mixtures with low oxygen presence.

  9. Interactions in interesterified palm and palm kernel oils mixtures. I-Solid fat content and consistency

    Directory of Open Access Journals (Sweden)

    Simões, Ilka S.

    2001-12-01

    Full Text Available Palm oil (PO and palm kernel oil (PKO compositions (100/0, 80/20, 60/40, 50/50, 40/60, 20/80 and 0/100 were interesterified in laboratory scale under predetermined conditions (0.4% sodium metoxide, 20 minutes, 100oC. The fourteen samples, before and after interesterification, were characterized by solid fat content (SFC and consistency. Results showed a presence of eutectic system at PO and PKO compositions, mainly at 80/20, 60/40 and 50/50 fractions, proved through isosolids and isoconsistency diagrams. The incompatibility among the oils was decreased after reaction and improved the composition plasticity, demonstrated by the increment of solids value and yield value at room temperature.Se interesterificaron, en el laboratorio, mezclas de aceite de palma (PO y aceite de palmiste (PKO: 100/0, 80/20, 60/40, 50/50, 40/60, 20/80 y 0/100 en condiciones predefinidas (0.4% metóxido de sodio, 20 minutos, 100oC. Las catorce muestras fueron caracterizadas antes y después de la interesterificación por su contenido de grasa sólida (SFC y su consistencia. Los resultados mostraron la presencia de un sistema eutéctico en las mezclas de PO y PKO, principalmente en las proporciones 80/20, 60/40 y 50/50, demostrado por los diagramas de isosólidos y de isoconsistencia. La incompatibilidad entre los aceites disminuyó después de la interesterificación y la plasticidad de las mezclas mejoró, hecho demostrado por el incremento del contenido de sólidos y del límite de fluidez a temperatura ambiente.

  10. Analisis Faktor-Faktor yang Mempengaruhi Ekspor Crude Palm Oil (CPO) Indonesia ke Uni Eropa

    OpenAIRE

    Pinem, Nurul Fajriah

    2015-01-01

    Since 2004, Crude Palm Oil (CPO) is the largest contributor to the production of vegetable oil. Indonesia supplies 47 % of the world's palm oil, and Malaysia dominate 85% of palm oil market in the world. Most of them exported to European Union, India, China, and Singapore. World market price of CPO is still under controlled by European market particulary. Rotterdam as the standar. The purpose of this study was to analyze the factors influenced the Indonesian CPO exports to the EU. The data of...

  11. Impacts of current and projected oil palm plantation expansion on air quality over Southeast Asia

    Science.gov (United States)

    Silva, Sam J.; Heald, Colette L.; Geddes, Jeffrey A.; Austin, Kemen G.; Kasibhatla, Prasad S.; Marlier, Miriam E.

    2016-08-01

    Over recent decades oil palm plantations have rapidly expanded across Southeast Asia (SEA). According to the United Nations, oil palm production in SEA increased by a factor of 3 from 1995 to 2010. We investigate the impacts of current (2010) and near-term future (2020) projected oil palm expansion in SEA on surface-atmosphere exchange and the resulting air quality in the region. For this purpose, we use satellite data, high-resolution land maps, and the chemical transport model GEOS-Chem. Relative to a no oil palm plantation scenario (˜ 1990), overall simulated isoprene emissions in the region increased by 13 % due to oil palm plantations in 2010 and a further 11 % in the near-term future. In addition, the expansion of palm plantations leads to local increases in ozone deposition velocities of up to 20 %. The net result of these changes is that oil palm expansion in SEA increases surface O3 by up to 3.5 ppbv over dense urban regions, and in the near-term future could rise more than 4.5 ppbv above baseline levels. Biogenic secondary organic aerosol loadings also increase by up to 1 µg m-3 due to oil palm expansion, and could increase by a further 2.5 µg m-3 in the near-term future. Our analysis indicates that while the impact of recent oil palm expansion on air quality in the region has been significant, the retrieval error and sensitivity of the current constellation of satellite measurements limit our ability to observe these impacts from space. Oil palm expansion is likely to continue to degrade air quality in the region in the coming decade and hinder efforts to achieve air quality regulations in major urban areas such as Kuala Lumpur and Singapore.

  12. Applications of Supercritical Fluid Extraction (SFE) of Palm Oil and Oil from Natural Sources

    OpenAIRE

    Mohd Omar Ab Kadir; Sahena Ferdosh; Mohd Yazid Abdul Manap; Nik Norulaini Nik Ab Rahman; Mohammed Jahurul Haque Akanda; Mohammed Zaidul Islam Sarker

    2012-01-01

    Supercritical fluid extraction (SFE), which has received much interest in its use and further development for industrial applications, is a method that offers some advantages over conventional methods, especially for the palm oil industry. SC-CO2 refers to supercritical fluid extraction (SFE) that uses carbon dioxide (CO2) as a solvent which is a nontoxic, inexpensive, nonflammable, and nonpolluting supercritical fluid solvent for the extraction of natural products. Almost 100% oil can be ext...

  13. Life cycle inventory for the production of germinated oil palm seeds at a selected seed production unit in Malaysia

    Science.gov (United States)

    Khairuddin, Nik Sasha Khatrina; Ismail, B. S.; Muhamad, Halimah; May, Choo Yuen

    2013-11-01

    The increasing global demand for edible oil has encouraged Malaysia to increase the areas under oil palm cultivation. The total demand for germinated oil palm seeds in the years 2009, 2010, 2011 and 2012 were 86.4, 76.5, 72.6 and 75.2 million, respectively. Production of germinated oil palm seeds is the first link in the palm oil supply chain. Therefore, good management practices at seed production stage is required to ensure only high quality germinated oil palm seeds are produced before sale to customers. Life cycle assessment (LCA) has been used as a tool to assess environmental impact of the processes throughout a product's lifespan and this approach is an important tool for assessing green house gas (GHG) emission. For this study, a gate-to-gate life cycle inventory (LCI) of a single germinated oil palm seed production unit was carried out. The functional unit used for this LCI was one germinated oil palm seed. To determine the environmental impact for the production of germinated oil palm seeds, information on the inputs were obtained. The inputs for the production of germinated oil palm seeds involved materials such as polyethylene bags, electricity, water, chemicals and fungicides. For this study, the system boundary involved seed germination process and management of germinated oil palm seeds. It was found that the amount of input such as materials and energy used in the production of germinated oil palm seeds was very minimal.

  14. Oil Palm Boom and Land-Use Dynamics in Indonesia: The Role of Policies and Socioeconomic Factors

    OpenAIRE

    Gatto, Marcel; Wollni, Meike; Qaim, Matin

    2014-01-01

    We investigate land-use dynamics in Jambi, Sumatra, one of the hotspots of Indonesia' recent oil palm boom. Data from a structured village survey are used to analyze the role of socioeconomic and policy factors. Oil palm is partly grown on large plantations, but smallholders are also involved significantly. We find that, in spite of significant oil palm expansion, rubber remains the dominant crop. Most of the oil palm growth takes place on previous fallow and rubber land. Oil palm has not bee...

  15. A Gate-to-gate Case Study of the Life Cycle Assessment of an Oil Palm Seedling

    OpenAIRE

    Muhamad, Halimah; Sahid, Ismail Bin; Surif, Salmijah; Ai, Tan Yew; May, Choo Yuen

    2012-01-01

    The palm oil industry has played an important role in the economic development of Malaysia and has enhanced the economic welfare of its people. To determine the environmental impact of the oil palm seedling at the nursery stage, information on inputs and outputs need to be assessed. The oil palm nursery is the first link in the palm oil supply chain. A gate-to-gate study was carried out whereby the system boundary was set to only include the process of the oil palm seedling. The starting poin...

  16. Production of methyl ester from oil in the wastewater pond of a palm oil factory

    Directory of Open Access Journals (Sweden)

    Tongurai, C.

    2007-11-01

    Full Text Available This research studied the suitable technique for the production of methyl ester from waste palm oil in the water pond of a palm oil mill. The composition of the waste palm oil was 73.82% fatty acid, 5.07% triglyceride, 3.39% diglyceride and 17.76% unknown compounds. The unknown compounds were separated via simple distillation carried out at a temperature range of 300-350oC.First, the experiments were carried out in screw capped bottles using filtrated as-received waste oil as the reactant. The esterification and transesterification process were conducted using sulfuric acid catalyst in a methanol solution. The key parameters studied were mole ratio of waste oil to methanol (1:1 to 1:72, amount of catalyst from 0.1-20 v/w% of the reactant, temperature range of 60-98oC and reaction time range of 15-180 minutes. Thin Layer Chromatography (TLC analysis showed 85-90% purity of methyl ester with 4-5% of mono-, di-, and triglycerides and fatty acids and about 5-10% of the unknown compounds for the best condition. The resulting yield of biodiesel was 84-88%. Eradication of contaminants by distillation gave about a 75% distillate yield. Distilled waste palm oil was esterified and transesterified using the previous optimum condition of as-received waste oil, but the reaction time and temperature were varied. The optimal result was obtained by using distilled waste palm oil to methanol molar ratio of 1:8, sulfuric acid of 1 v/w% of reactant, reaction temperature of 70oC and reaction time of 1 hour. TLC analysis indicated a biodiesel composition of methyl ester, free fatty acid, diglyceride and monoglyceride of 96.39%, 3.20%, 0.24% and 0.17%, respectively. The yield of biodiesel was 96-98% having physical fuel properties according to Thailand standard for methyl esterFinally, the distilled waste palm oil was esterified using a 3 liters continuous stirred-tank reactor (CSTR. Using the suitable condition for the batch process and an hour retention time, the

  17. Bio-char from treated and untreated oil palm fronds

    Science.gov (United States)

    Sulaiman, Fauziah; Abdullah, Nurhayati; Rahman, Aizuddin Abdul

    2013-05-01

    The palm oil industry generates almost 94% of biomass in Malaysia, while other agricultural and forestry by-products contribute the remaining of 6%. Oil palm fronds (OPF) are estimated to be the highest available biomass amounting to 44.84 million tonnes in Malaysia. However, studies on OPF for thermochemical conversion technology which has good potential for energy conversion are still lacking. In this work, pyrolysis of OPF is conducted by using a fixed bed reactor. Samples were carbonized at slow pyrolysis temperature of around 300 to 500°C with heating rate of 10°C min-1. In addition, samples were treated for 20 min with distilled water at ambient temperature to reduce the ash content. Effectiveness of pre-treatment can be determined by observing the percentage of ash content reduction of each sample after undergoing washing pre-treatment. At 300°C, the char yields of the untreated OPF were slightly higher at 50.95% compared to the treated sample at 49.77%. Approximately all bio-char from the treated samples have better high heating value (HHV) of around 18-20 MJ kg-1 compared to the untreated samples. Besides that, all treated OPF char is more carbon rich and considered to be environmental friendly due to its low nitrogen content compared to the untreated OPF char. In this work, microscopic analysis of OPF bio-char were also studied by observing and evaluating their structure surface and morphology.

  18. Optimization of squalene produced from crude palm oil waste

    Science.gov (United States)

    Wandira, Irda; Legowo, Evita H.; Widiputri, Diah I.

    2017-01-01

    Squalene is a hydrocarbon originally and still mostly extracted from shark liver oil. Due to environmental issues over shark hunting, there have been efforts to extract squalene from alternative sources, such as Palm Fatty Acid Distillate (PFAD), one of crude palm oil (CPO) wastes. Previous researches have shown that squalene can be extracted from PFAD using saponification process followed with liquid-liquid extraction process although the method had yet to be optimized in order to optimize the amount of squalene extracted from PFAD. The optimization was done by optimizing both processes of squalene extraction method: saponification and liquid-liquid extraction. The factors utilized in the saponification process optimization were KOH concentration and saponification duration while during the liquid-liquid extraction (LLE) process optimization, the factors used were the volumes of distilled water and dichloromethane. The optimum percentage of squalene content in the extract (24.08%) was achieved by saponifying the PFAD with 50%w/v KOH for 60 minutes and subjecting the saponified PFAD to LLE, utilizing 100 ml of distilled water along with 3 times addition of fresh dichloromethane, 75 ml each; those factors would be utilized in the optimum squalene extraction method.

  19. CO2 and CH4 fluxes from oil palm plantations in Sumatra, Indonesia: effects of palm age and environmental conditions

    Science.gov (United States)

    Meijide, A.; Hassler, E.; Corre, M. D.; June, T.; Sabajo, C.; Veldkamp, E.; Knohl, A.

    2015-12-01

    Global increasing demand of palm oil is leading to the expansion of oil palm plantations, particularly in SE Asia, which in Sumatran lowlands has resulted in a 21% forest area loss. Large photosynthesis rates are expected for oil palms, due to their high growth and yield production. However, there is very limited information on their effect on carbon dioxide (CO2) fluxes and their sink or source strength at ecosystem scale. For methane (CH4) fluxes, research has mainly focused in oil palm plantations located on peatlands, but no information is available at ecosystem level from plantations on mineral soils. With the aim of studying CO2 fluxes during the non-productive and productive phases of oil palm cultivation, an eddy covariance (EC) tower was installed in a 2 year old oil palm plantation, where it was measuring for 8 months, and was subsequently moved to a 12 year old plantation, both in the province of Jambi, Sumatra. The EC system consisted of a Licor 7500A and an ultrasonic Metek anemometer, operating at 10 Hz, installed on a 7m and 22m tower respectively. In the 12 year old plantation, the tower was also equipped with a Los Gatos FGGA-24EP, to assess CH4 fluxes. Chamber measurements were also carried out to obtain information on respiration and CH4 fluxes from the soil. Radiation was the major driver controlling net carbon uptake, while soil moisture did not play a significant role. Average net ecosystem exchange in the hours of the day with higher radiation for the whole measurement period was 10 μmol m-2 s-1 for the 2 year old plantation and -22 μmol m-2 s-1 in the 12 year old. The analysis of the cumulative fluxes show that the non-productive plantation was a carbon source of around 636 g CO2 m-2 during the 8 months of measurements, while in the productive period, it acted as a strong carbon sink (-794 g CO2 m-2 yr-1). Methane uptake was observed in the soil in both plantations and also for the whole ecosystem in the 12 year old one, but its

  20. Post harvest ripening of oil palm fruit is accelerated by application of exogenous ethylene

    Directory of Open Access Journals (Sweden)

    Narumol Nualwijit

    2014-06-01

    Full Text Available Experiments were conducted with fresh fully mature fruit bunches of Tenera variety oil-palm. Palm fruit bunches were exposed to 0, 250, 500 or 1000 mlL-1 ethylene for 24 hours. Each fruit bunch was evaluated in three separate sections: the bottom, the middle, and the top. The exogenous ethylene treatments significantly hastened palm fruit ripening, quantified by an increase in the fruit peel coloring that turns from black to reddish orange. Ethylene treatments also significantly eased detaching the fruit, by reducing the tension force required. Total oil contents of fruit increased with 1000 mlL-1 ethylene treatment. Free fatty acids (FFA in untreated palm fruit, especially in the bottom section, were at their highest levels 2 days after harvest, and the FFA levels were lowered by ethylene treatments. In summary, exogenous ethylene fumigation accelerated the ripening of oil palm fruit, increased oil yield, and decreased the FFA levels.

  1. An overview of the Oil Palm Empty Fruit Bunch (OPEFB potential as reinforcing fibre in polymer composite for energy absorption applications

    Directory of Open Access Journals (Sweden)

    Faizi M.K.

    2017-01-01

    Full Text Available The oil palm empty fruit bunch (OPEFB natural fibres were comprehensively reviewed to assess their potential as reinforcing materials in polymer composites for energy absorption during low-velocity impact. The typical oil palm wastes include trunks, fronds, kernel shells, and empty fruit bunches. This has a tendency to burden the industry players with disposal difficulties and escalates the operating cost. Thus, there are several initiatives have been employed to convert these wastes into value added products. The objective of this study is to review the potential of oil palm empty fruit bunch (OPEFB as natural fibre polymer composite reinforcement to absorb the energy during low-velocity impact as another option for value added products. Initially, this paper reviewed the local oil palm waste issues. Previous research works on OPEFB polymer composite, and their mechanical characterization is appraised. Their potential for energy absorption in low-velocity impact application was also elaborated. The review suggests high potential applications of OPEFB as reinforcing materials in composite structures. Furthermore, it is wisely to utilize the oil palm biomass waste into a beneficial composite, hence, promotes the green environment.

  2. Prospective study for the production of oleochemicals derivates from palm and palm kernel oil in Colombia

    Directory of Open Access Journals (Sweden)

    Diana Ibeth Jaimes Moreno

    2010-03-01

    Full Text Available There are many ways get close to the future, being the prospective the one that concives the future, not like an unique reality but like a multiple one, obtained as a result of the identification of the human being future actions. For all this, the human being takes the knowledge, the yearnings and the fears that he sees for the actions he will undertake. Keeping in mind the characteristic of the palm cultivation (pereninal, of late growth, with a 25 years productive horizon, and the future of the sector captured in "Visión y estrategias de la palmicultura colombiana 2000 - 2020" together with the economic tendencies of the world, the methodology of planning denominated prospective, becomes an appropriate tool to establish the future of the oleochemical sector derived from the palm and palmist oils, which is right now very incipient in our country. Using the prospective, this article outlines the dynamics that will have the sector, starting from the definition of the keys that define the current and future behavior of the system, the position and the power that each one of the involved actors will have, and the determination of the scenarios (future representations will more probability to occur, as well as the definition of the scenario wanted and the strategies that will allow to reach it.

  3. Palm oil and cardiovascular disease: a randomized trial of the effects of hybrid palm oil supplementation on human plasma lipid patterns.

    Science.gov (United States)

    Lucci, P; Borrero, M; Ruiz, A; Pacetti, D; Frega, N G; Diez, O; Ojeda, M; Gagliardi, R; Parra, L; Angel, M

    2016-01-01

    This study examines, for the first time, the effect of hybrid Elaeis oleifera × E. guineensis palm oil supplementation on human plasma lipids related to CVD risk factors. One hundred sixty eligible participants were randomized and assigned to one of the two treatments: 25 mL hybrid palm oil (HPO group) or 25 mL extra virgin olive oil (EVOO group) daily for 3 months. Fasting venous samples were obtained at baseline and after 1, 2 and 3 months for measurement of plasma lipids (TC, LDL-C, HDL-C and TAGs). Changes in body mass index and waist circumference were also assessed. Although there was an overall reduction in TC (7.4%, p palm oil can be seen as a "tropical equivalent of olive oil".

  4. DNA Profiles of MTG (Moderat Tahan Gano) Oil Palm Variety Based on SSR Marker

    Science.gov (United States)

    Putri, L. A. P.; Setiado, H.; Hardianti, R.

    2017-03-01

    The oil palm, an economically important tree in Indonesia, has been one of the world’s major sources of edible oil and a significant precursor of biodiesel fuel. The objectives of this study were to know DNA profile of commercial MTG (Moderat Tahan Gano) oil palm variety collections. A total of 10 trees MTG oil palm variety were used for analysis. In this experiment, the DNA profile diversity was assessed using mEgCIR0174 and SSR-1 loci of oil palm’s specific SSR markers. The results of the experiment indicated out of 3 alleles of pcr product of mEgCIR0174 (198, 203 and 208 bp) and SSR-1 (201, 217 and 232 bp). These preliminary results demonstrated SSR marker can be used to evaluate genetic relatedness among trees of MTG (Moderat Tahan Gano) oil palm variety derived from different crossing or difference to desease resistance trait or misslabeled.

  5. Reconciling oil palm expansion and climate change mitigation in Kalimantan, Indonesia.

    Science.gov (United States)

    Austin, Kemen G; Kasibhatla, Prasad S; Urban, Dean L; Stolle, Fred; Vincent, Jeffrey

    2015-01-01

    Our society faces the pressing challenge of increasing agricultural production while minimizing negative consequences on ecosystems and the global climate. Indonesia, which has pledged to reduce greenhouse gas (GHG) emissions from deforestation while doubling production of several major agricultural commodities, exemplifies this challenge. Here we focus on palm oil, the world's most abundant vegetable oil and a commodity that has contributed significantly to Indonesia's economy. Most oil palm expansion in the country has occurred at the expense of forests, resulting in significant GHG emissions. We examine the extent to which land management policies can resolve the apparently conflicting goals of oil palm expansion and GHG mitigation in Kalimantan, a major oil palm growing region of Indonesia. Using a logistic regression model to predict the locations of new oil palm between 2010 and 2020 we evaluate the impacts of six alternative policy scenarios on future emissions. We estimate net emissions of 128.4-211.4 MtCO2 yr(-1) under business as usual expansion of oil palm plantations. The impact of diverting new plantations to low carbon stock land depends on the design of the policy. We estimate that emissions can be reduced by 9-10% by extending the current moratorium on new concessions in primary forests and peat lands, 35% by limiting expansion on all peat and forestlands, 46% by limiting expansion to areas with moderate carbon stocks, and 55-60% by limiting expansion to areas with low carbon stocks. Our results suggest that these policies would reduce oil palm profits only moderately but would vary greatly in terms of cost-effectiveness of emissions reductions. We conclude that a carefully designed and implemented oil palm expansion plan can contribute significantly towards Indonesia's national emissions mitigation goal, while allowing oil palm area to double.

  6. Reconciling oil palm expansion and climate change mitigation in Kalimantan, Indonesia.

    Directory of Open Access Journals (Sweden)

    Kemen G Austin

    Full Text Available Our society faces the pressing challenge of increasing agricultural production while minimizing negative consequences on ecosystems and the global climate. Indonesia, which has pledged to reduce greenhouse gas (GHG emissions from deforestation while doubling production of several major agricultural commodities, exemplifies this challenge. Here we focus on palm oil, the world's most abundant vegetable oil and a commodity that has contributed significantly to Indonesia's economy. Most oil palm expansion in the country has occurred at the expense of forests, resulting in significant GHG emissions. We examine the extent to which land management policies can resolve the apparently conflicting goals of oil palm expansion and GHG mitigation in Kalimantan, a major oil palm growing region of Indonesia. Using a logistic regression model to predict the locations of new oil palm between 2010 and 2020 we evaluate the impacts of six alternative policy scenarios on future emissions. We estimate net emissions of 128.4-211.4 MtCO2 yr(-1 under business as usual expansion of oil palm plantations. The impact of diverting new plantations to low carbon stock land depends on the design of the policy. We estimate that emissions can be reduced by 9-10% by extending the current moratorium on new concessions in primary forests and peat lands, 35% by limiting expansion on all peat and forestlands, 46% by limiting expansion to areas with moderate carbon stocks, and 55-60% by limiting expansion to areas with low carbon stocks. Our results suggest that these policies would reduce oil palm profits only moderately but would vary greatly in terms of cost-effectiveness of emissions reductions. We conclude that a carefully designed and implemented oil palm expansion plan can contribute significantly towards Indonesia's national emissions mitigation goal, while allowing oil palm area to double.

  7. Thermally Activated Palm Kernel Based Carbon as a Support for Edible Oil Hydrogenation Catalyst

    Directory of Open Access Journals (Sweden)

    Abdulmajid Alshaibani

    2013-01-01

    Full Text Available Activated carbon has distinctive properties as a support for hydrogenation catalysts. Thermally activated carbon has been prepared from palm kernel shell at 1073 K and placed under nitrogen flow for 2 h. It was impregnated by palladium using toluene solution of Pd (acac2. The Pd/C was reduced using a water solution of potassium borohydride (KBH4. The Pd-B/C was characterized by the Brunauer-Emmett-Teller surface area analysis (BET, scanning electron microscopy (SEM, transmission electron microscopy (TEM and inductively-coupled plasma mass spectrometry (ICP-MS. Pd-B/C was applied for sunflower oil hydrogenation at a temperature of 373 K, hydrogen pressure of 413.5 kPa and agitation of 1400 rpm for 1 h. Pd-B/C noticeably exhibited a higher overall catalyst activity in comparison to some recently published palladium catalysts.

  8. A Comparison of Dielectric Properties of Palm Oil with Mineral and Synthetic Types Insulating Liquid under Temperature Variation

    OpenAIRE

    Abdul Rajab; Aminuddin Sulaeman; Sudaryatno Sudirham; Suwarno

    2011-01-01

    Mineral oil is known to have a low biodegradability level and high susceptibility to the fire. These conditions motivate many researchers to look for alternative sources for insulating oil. One of the alternative liquid is palm oil. To verify the suitability of using palm oil as an insulating liquid, it is important to make dielectric properties comparison with the commonly used insulating liquid. This paper presents comparison of temperature effect on dielectric properties of palm oil with m...

  9. Proteomic analysis of the oil palm fruit mesocarp reveals elevated oxidative phosphorylation activity is critical for increased storage oil production.

    Science.gov (United States)

    Loei, Hendrick; Lim, Justin; Tan, Melvin; Lim, Teck Kwang; Lin, Qing Song; Chew, Fook Tim; Kulaveerasingam, Harikrishna; Chung, Maxey C M

    2013-11-01

    Palm oil is a highly versatile commodity with wide applications in the food, cosmetics, and biofuel industries. Storage oil in the oil palm mesocarp can make up a remarkable 80% of its dry mass, making it the oil crop with the richest oil content in the world. As such, there has been an ongoing interest in understanding the mechanism of oil production in oil palm fruits. To identify the proteome changes during oil palm fruit maturation and factors affecting oil yield in oil palm fruits, we examined the proteomic profiles of oil palm mesocarps at four developing stages--12, 16, 18, and 22 weeks after pollination--by 8-plex iTRAQ labeling coupled to 2D-LC and MALDI-TOF/TOF MS. It was found that proteins from several important metabolic processes, including starch and sucrose metabolism, glycolysis, pentose phosphate shunt, fatty acid biosynthesis, and oxidative phosphorylation, were differentially expressed in a concerted manner. These increases led to an increase in carbon flux and a diversion of resources such as ATP and NADH that are required for lipid biosynthesis. The temporal proteome profiles between the high-oil-yielding (HY) and low-oil-yielding (LY) fruits also showed significant differences in the levels of proteins involved in the regulation of the TCA cycle and oxidative phosphorylation. In particular, the expression level of the β subunit of the ATP synthase complex (complex IV of the electron transport chain) was found to be increased during fruit maturation in HY but decreased in the LY during the fruit maturation. These results suggested that increased energy supply is necessary for augmented oil yield in the HY oil palm trees.

  10. Development narratives, notions of forest crisis, and boom of oil palm plantations in Indonesia

    OpenAIRE

    Susanti, Ari; Maryudi, Ahmad

    2016-01-01

    Indonesia experienced massive deforestation in the last decades where rapid oil palm expansion has been considered as one of the main drivers. This article shows that the process of deforestation and the rapid oil palm expansion cannot be viewed in isolation from broader development contexts. Various actors at local, national, and global levels have used development narratives and poverty alleviation through various policies and institutional setting to create spaces and opportunities for oil...

  11. Rubber vs. oil palm: an analysis of factors influencing smallholders' crop choice in Jambi, Indonesia

    OpenAIRE

    Schwarze, Stefan; Euler, Michael; Gatto, Marcel; Hein, J.; Hettig, Elisabeth; Holtkamp, Anna Mareike; Izhar, Lutfi; Kunz, Y.; Lay, J.; Merten, J.; Moser, S.; Mußhoff, O.; Otten, Fenna; Qaim, M.; Soetarto, Endriatmo

    2015-01-01

    The rapid expansion of the oil palm area in many tropical countries has raised concerns about its negative impact on local communities, food security, and on the environment. While the expansion of oil palm in early stages was mainly driven by large private and public companies, it is expected that smallholders will outnumber large estates in the near future. For policy formulation it is hence important to better understand who these smallholders are and why they have started to cultivate oil...

  12. Reconciling Oil Palm Expansion and Climate Change Mitigation in Kalimantan, Indonesia

    OpenAIRE

    Kemen G Austin; Kasibhatla, Prasad S.; Dean L. Urban; Fred Stolle; Jeffrey Vincent

    2015-01-01

    Our society faces the pressing challenge of increasing agricultural production while minimizing negative consequences on ecosystems and the global climate. Indonesia, which has pledged to reduce greenhouse gas (GHG) emissions from deforestation while doubling production of several major agricultural commodities, exemplifies this challenge. Here we focus on palm oil, the world's most abundant vegetable oil and a commodity that has contributed significantly to Indonesia's economy. Most oil palm...

  13. Characterization of structural stability of palm oil esters-based nanocosmeceuticals loaded with tocotrienol

    OpenAIRE

    Ng, Sook Han; Woi, Pei Meng; Basri, Mahiran; Ismail, Zahariah

    2013-01-01

    Background Palm oil esters (POEs) are esters derived from palm oil and oleyl alcohol have great potential in the cosmetic and pharmaceutical industries due to the excellent wetting behavior of the esters without the oily feel. The role of oil-in-water nanoemulsions loaded with tocotrienol sedimentation behavior was studied. LUMiFuge® 116 particle separation analyzer was used to investigate the sedimentation behavior of POEs/tocotrienol/xanthan gum nanoemulsion system during centrifugation. An...

  14. Hard Fats As Additives In Palm Oil And Its Relationships To Crystallization Process And Polymorphism

    OpenAIRE

    Oliveira, MR; Glazieli Marangoni; Ribeiro; Ana Paula Badan; dos Santos; Adenilson Oliveira; Cardoso; Lisandro Pavie; Kieckbusch; Theo Guenter

    2016-01-01

    The application of palm oil in fat-based product can be inappropriate due to its low crystallization rates and formation of crystalline clusters in post-processing stages. The adjustment of these properties can be achieved with the addition of hard fats, which are low-cost industrial products resulting from the process of total catalytic hydrogenation of liquid oils. During the crystallization of palm oil, these components can act as preferential nuclei in a crystalline ordering process, and ...

  15. In vitro embryo rescue of interspecific hybrids of oil palm (Elaeis oleifera x Elaeis guineensis)

    OpenAIRE

    Alves, Sergio Augusto Oliveira; de Lemos, Oriel Filgueira; Filho,Benedito Gomes dos Santos; da Silva, André Luís Lopes

    2011-01-01

    The oil palm (Elaeis guineennsis Jacq.) is the plant with major oil yield in tropical areas over the world. Pará state is the major producer of Brazil. However, the production of resistant hybrids (Elaeis oleifera x Elaeis guinennsis) to several diseases is necessary, in spite of less productive, is a viable alternative for areas where occur more aggressive diseases. The aim of this research was to rescue in vitro embryos of four varieties of interspecific hybrids of oil palm (Elaeis oleifera...

  16. The impact of tropical forest logging and oil palm agriculture on the soil microbiome.

    Science.gov (United States)

    Tripathi, Binu M; Edwards, David P; Mendes, Lucas William; Kim, Mincheol; Dong, Ke; Kim, Hyoki; Adams, Jonathan M

    2016-05-01

    Selective logging and forest conversion to oil palm agriculture are rapidly altering tropical forests. However, functional responses of the soil microbiome to these land-use changes are poorly understood. Using 16S rRNA gene and shotgun metagenomic sequencing, we compared composition and functional attributes of soil biota between unlogged, once-logged and twice-logged rainforest, and areas converted to oil palm plantations in Sabah, Borneo. Although there was no significant effect of logging history, we found a significant difference between the taxonomic and functional composition of both primary and logged forests and oil palm. Oil palm had greater abundances of genes associated with DNA, RNA, protein metabolism and other core metabolic functions, but conversely, lower abundance of genes associated with secondary metabolism and cell-cell interactions, indicating less importance of antagonism or mutualism in the more oligotrophic oil palm environment. Overall, these results show a striking difference in taxonomic composition and functional gene diversity of soil microorganisms between oil palm and forest, but no significant difference between primary forest and forest areas with differing logging history. This reinforces the view that logged forest retains most features and functions of the original soil community. However, networks based on strong correlations between taxonomy and functions showed that network complexity is unexpectedly increased due to both logging and oil palm agriculture, which suggests a pervasive effect of both land-use changes on the interaction of soil microbes.

  17. Pollution Control: How Feasible is Zero Discharge Concepts in Malaysia Palm Oil Mills

    Directory of Open Access Journals (Sweden)

    Yahaya S. Madaki

    2013-10-01

    Full Text Available Many palm oil mills in Malaysia still discharged either partially treated or raw palm oil mill effluent (POME into nearby rivers. Either partially treated or untreated POME depletes a water body of its oxygen and suffocates aquatic life. Vast amounts of biogas are also generated during anaerobic digestion of POME. This paper presented the key findings from the survey mailed to 86 palm oil mills located in Sarawak and Sabah. The survey results provide an overview of the position of the palm oil mills operators on current advance POME treatment technology (PTT in relation to achieving zero discharge concepts. The survey attempted to identify the key issues about the PTT in respect to feasibility of zero discharge concepts in palm oil mills. The results shows that, although palm oil mills generate a lot of different types of wastes during processing of Fresh Fruit Bunches, according to the operators and available literature, POME is the most difficult waste to manage. The results also shows that, palm oil mills cannot meet up with the new discharge limits of 20ppm of BOD and zero emission using only conventional open or closed pounding system

  18. Biotechnology of oil palm: strategies towards manipulation of lipid content and composition.

    Science.gov (United States)

    Parveez, Ghulam Kadir Ahmad; Rasid, Omar Abdul; Masani, Mat Yunus Abdul; Sambanthamurthi, Ravigadevi

    2015-04-01

    Oil palm is a major economic crop for Malaysia. The major challenges faced by the industry are labor shortage, availability of arable land and unstable commodity price. This has caused the industry to diversify its applications into higher value products besides increasing its yield. While conventional breeding has its limitations, biotechnology was identified as one of the tools for overcoming the above challenges. Research on biotechnology of oil palm began more than two decades ago leveraging a multidisciplinary approach involving biochemical studies, gene and promoter isolation, transformation vector construction and finally genetic transformation to produce the targeted products. The main target of oil palm biotechnology research is to increase oleic acid in the mesocarp. Other targets are stearic acid, palmitoleic acid, ricinoleic acid, lycopene (carotenoid) and biodegradable plastics. Significant achievements were reported for the biochemical studies, isolation of useful oil palm genes and characterization of important promoters. A large number of transformation constructs for various targeted products were successfully produced using the isolated oil palm genes and promoters. Finally transformation of these constructs into oil palm embryogenic calli was carried out while the regeneration of transgenic oil palm harboring the useful genes is in progress.

  19. Identifying the Entrepreneurship Characteristics of the Oil Palm Community Plantation Farmers in the Riau Area

    Directory of Open Access Journals (Sweden)

    Brilliant Asmit

    2015-12-01

    Full Text Available Oil palm is an essential and strategic commodity in the Riau area because of its considerable role in supporting the peoples’ economy, especially for plantation farmers. Oil palm plantation activities have brought economic impacts to society there, both for the people who are directly involved with the plantations and for their surrounding communities. This regional advantage is a facility for farmers to be able to develop their farms as plantations. The aims of this research are to identify the entrepreneurship characteristics of the oil palm farmers, and also to identify the entrepreneurship characteristics that differentiate the farmers, as seen from their business’ achievements. The research used a grounded theory approach to identify the characteristics of oil palm farmers systematically. The sampling method used for the research was theoretical sampling, which is data gathering driven by the concepts derived from the theory of previous entrepreneurship characteristics studies. The research object is the oil palm farmers in Riau, Indonesia. The results of the analysis identified the entrepreneurship characteristics of the oil palm farmers, they are growth oriented, risk-taking, innovative, with a sense of personal control, self confident, and cooperative. But, among the characteristics, only the characteristic of their cooperation did not differentiate the oil palm farmers in the achievement of their business activities.

  20. Relationship between Sampling Distance and Carbon Dioxide Emission under Oil Palm Plantation

    Directory of Open Access Journals (Sweden)

    Ai Dariah

    2013-05-01

    Full Text Available A carbon dioxide emission on peatland under oil palm plantation was highly varied due to many factors involved. The objectives of the research were to evaluate the effect of sampling distance from center of oil palm tree on Carbon dioxide flux, and to study the factors that cause variability of carbon dioxide flux on peatland under oil palm plantation. The study was conducted on peatland at Arang-Arang Village, Kumpek Ulu Sub-District, Muaro Jambi District, Jambi Province, on six-years old oil palm plantation. The study was conducted in the form of observational exploratory. Emission measurements were performed on 5 selected oil palm trees at points within 100, 150, 200, 250, 300, 350, and 400 cm from the center of trunk. Carbon dioxide flux was measured using (IRGA, Li-COR 820. The results showed that there was significant correlation between the distance of sampling from center of oil palm tree and Carbon dioxide flux. The farther distance from the tree, the more decreased of Carbon dioxide flux . Before applying fertilizer, variability of soil fertility was not significantly correlated with the flux of Carbon dioxide, so the difference of Carbon dioxide flux based on distance sampling can be caused by root distribution factor. After fertilizer application, variability of Carbon dioxide flux under the oil palm tree were not only affected by differences in root distribution but also greatly influenced by fertilization.

  1. De novo transcriptome analyses of host-fungal interactions in oil palm (Elaeis guineensis Jacq.).

    Science.gov (United States)

    Ho, Chai-Ling; Tan, Yung-Chie; Yeoh, Keat-Ai; Ghazali, Ahmad-Kamal; Yee, Wai-Yan; Hoh, Chee-Choong

    2016-01-19

    Basal stem rot (BSR) is a fungal disease in oil palm (Elaeis guineensis Jacq.) which is caused by hemibiotrophic white rot fungi belonging to the Ganoderma genus. Molecular responses of oil palm to these pathogens are not well known although this information is crucial to strategize effective measures to eradicate BSR. In order to elucidate the molecular interactions between oil palm and G. boninense and its biocontrol fungus Trichoderma harzianum, we compared the root transcriptomes of untreated oil palm seedlings with those inoculated with G. boninense and T. harzianum, respectively. Differential gene expression analyses revealed that jasmonate (JA) and salicylate (SA) may act in an antagonistic manner in affecting the hormone biosynthesis, signaling, and downstream defense responses in G. boninense-treated oil palm roots. In addition, G. boninense may compete with the host to control disease symptom through the transcriptional regulation of ethylene (ET) biosynthesis, reactive oxygen species (ROS) production and scavenging. The strengthening of host cell walls and production of pathogenesis-related proteins as well as antifungal secondary metabolites in host plants, are among the important defense mechanisms deployed by oil palm against G. boninense. Meanwhile, endophytic T. harzianum was shown to improve the of nutrition status and nutrient transportation in host plants. The findings of this analysis have enhanced our understanding on the molecular interactions of G. boninense and oil palm, and also the biocontrol mechanisms involving T. harzianum, thus contributing to future formulations of better strategies for prevention and treatment of BSR.

  2. Financial assessment of oil palm cultivation on peatland in Selangor, Malaysia

    Directory of Open Access Journals (Sweden)

    M.N. Noormahayu

    2009-02-01

    Full Text Available Oil palm plantations on peat soils are generally believed to have greater environmental impacts than those on other soil types. Nonetheless, Malaysia operates substantial incentives to maximise palm oil production, which in practice encourage the establishment of plantations on peatland. This paper explores the social and economic basis of oil palm cultivation on one peatland estate at Sungai Panjang in the state of Selangor, peninsular Malaysia. Data were obtained by conducting a questionnaire survey of 200 farmers who cultivate oil palm on peat soil. Some of the data were cross-tabulated against farmers’ ages in order to identify any age-related trends in education level, the area of land farmed, annual income and knowledge about oil palm cultivation. The Cobb-Douglas production function was used to model the financial output from oil palm in terms of the costs of chemical inputs and labour. The results indicated that cultivation of this crop gives decreasing returns to scale on peatland in Sungai Panjang, and that chemical inputs are more important than labour cost in determining the level of financial output. Finally, the financial viability of oil palm cultivation for farmers was assessed by calculating three financial indicators (NPV, BCR and IRR. This can be a profitable investment so long as growth conditions, costs, selling price and interest rate do not fluctuate substantially. Greater annual returns can be achieved over 20–25 years than over shorter periods, especially of less than 10 years.

  3. Breaking the link between environmental degradation and oil palm expansion: a method for enabling sustainable oil palm expansion.

    Directory of Open Access Journals (Sweden)

    Hans Harmen Smit

    Full Text Available Land degradation is a global concern. In tropical areas it primarily concerns the conversion of forest into non-forest lands and the associated losses of environmental services. Defining such degradation is not straightforward hampering effective reduction in degradation and use of already degraded lands for more productive purposes. To facilitate the processes of avoided degradation and land rehabilitation, we have developed a methodology in which we have used international environmental and social sustainability standards to determine the suitability of lands for sustainable agricultural expansion. The method was developed and tested in one of the frontiers of agricultural expansion, West Kalimantan province in Indonesia. The focus was on oil palm expansion, which is considered as a major driver for deforestation in tropical regions globally. The results suggest that substantial changes in current land-use planning are necessary for most new plantations to comply with international sustainability standards. Through visualizing options for sustainable expansion with our methodology, we demonstrate that the link between oil palm expansion and degradation can be broken. Application of the methodology with criteria and thresholds similar to ours could help the Indonesian government and the industry to achieve its pro-growth, pro-job, pro-poor and pro-environment development goals. For sustainable agricultural production, context specific guidance has to be developed in areas suitable for expansion. Our methodology can serve as a template for designing such commodity and country specific tools and deliver such guidance.

  4. Breaking the link between environmental degradation and oil palm expansion: a method for enabling sustainable oil palm expansion.

    Science.gov (United States)

    Harmen Smit, Hans; Meijaard, Erik; van der Laan, Carina; Mantel, Stephan; Budiman, Arif; Verweij, Pita

    2013-01-01

    Land degradation is a global concern. In tropical areas it primarily concerns the conversion of forest into non-forest lands and the associated losses of environmental services. Defining such degradation is not straightforward hampering effective reduction in degradation and use of already degraded lands for more productive purposes. To facilitate the processes of avoided degradation and land rehabilitation, we have developed a methodology in which we have used international environmental and social sustainability standards to determine the suitability of lands for sustainable agricultural expansion. The method was developed and tested in one of the frontiers of agricultural expansion, West Kalimantan province in Indonesia. The focus was on oil palm expansion, which is considered as a major driver for deforestation in tropical regions globally. The results suggest that substantial changes in current land-use planning are necessary for most new plantations to comply with international sustainability standards. Through visualizing options for sustainable expansion with our methodology, we demonstrate that the link between oil palm expansion and degradation can be broken. Application of the methodology with criteria and thresholds similar to ours could help the Indonesian government and the industry to achieve its pro-growth, pro-job, pro-poor and pro-environment development goals. For sustainable agricultural production, context specific guidance has to be developed in areas suitable for expansion. Our methodology can serve as a template for designing such commodity and country specific tools and deliver such guidance.

  5. Production and Characterisation of Microfine Sized Palm Oil Fuel Ash (POFA Originated from Bau, Lundu Palm Oil Mill

    Directory of Open Access Journals (Sweden)

    Ahmadi R.

    2017-01-01

    Full Text Available This paper investigates an effective and economical way for laboratory scale production of micro fine sized palm oil fuel ash (POFA using an electric powder grinder. The raw POFA obtained from the palm oil mill is initially grinded by using Los Angeles abrasion machine, and then sieved using 150 μm sieve before it is burned in a furnace at 500°C. The burned POFA is then grinded using electric powder grinder to obtain the targeted micro fine sized. The physical, morphological and chemical properties of the micro fine sized POFA produced are analysed in the form of cement paste using Particle Size Analyzer (PSA, nitrogen sorption by using BET method, Fourier Transform Infrared Spectroscopy (FT-IR and Scanning Electron Microscopy (SEM with Energy Dispersive Spectroscopy (EDS. The results show that 96% micro fine sized POFA is produced when using the optimum grinding process. The microstructural analyses of cement paste with 20% micro fine sized POFA replacement give the optimum results that contribute to higher compressive strength. The overall results of this research show that the optimum grinding process by using electric powder grinder is relevant and can be used as pioneering work in the concrete production industry.

  6. Thermophilic anaerobic co-digestion of oil palm empty fruit bunches with palm oil mill effluent for efficient biogas production

    DEFF Research Database (Denmark)

    O-Thong, Sompong; Boe, Kanokwan; Angelidaki, Irini

    2012-01-01

    The effect of pretreatment methods for improved biodegradability and biogas production of oil palm empty fruit bunches (EFB) and its co-digestion with palm oil mill effluent (POME) was investigated. The maximum methane potential of POME was 502mL CH4/gVS-added corresponding to 33.2m3 CH4/ton POME...... and 98% biodegradability. Meanwhile, the maximum methane potential of EFB was 202mL CH4/gVS-added corresponding to 79.1m3 CH4/ton EFB with 38% biodegradability. Co-digestion of EFB with POME enhanced microbial biodegradability and resulted in 25–32% higher methane production at mixing ratios of 0.4:1, 0.......8:1 and 2.3:1 on VS basis than digesting EFB alone. The methane yield was 276–340mL CH4/gVS-added for co-digestion of EFB with POME at mixing ratios of 0.4:1–2.3:1, while minor improvement was observed at mixing ratios of 6.8:1 and 11:1 (175–197mL CH4/gVS-added). The best improved was achieved from co...

  7. Energy fluxes in oil palm plantations as affected by water storage in the trunk

    Science.gov (United States)

    Meijide, Ana; Röll, Alexander; Fan, Yuanchao; Herbst, Mathias; Niu, Furong; Tiedemann, Frank; June, Tania; Rauf, Abdul; Hölscher, Dirk; Knohl, Alexander

    2017-04-01

    Oil palm is increasingly expanding, particularly in Indonesia, but information on water and energy fluxes in oil palm plantations is still very limited and on how those are affected by environmental conditions or oil palm age. Using the eddy covariance technique, we studied turbulent fluxes of sensible (H) and latent (LE) heat and gross primary production (GPP) for 8 months each in a young oil palm plantation (1-year old) and subsequently in a mature plantation (12-year old) in Jambi Province, Sumatra, Indonesia. We measured transpiration (T) simultaneously using a sap flux technique. The energy budget was dominated by LE in both plantations, particularly in the mature one, where it represented up to 70% of the available energy. In the young oil palm plantation, evapotranspiration (ET) was significantly reduced and H fluxes were higher. This affected the Bowen ratio, defined as the ratio of H and LE, which was higher in the 1-year old plantation (0.67±0.33), where it remained constant during the day, than in the mature plantation (0.14±0.09), where it varied considerably over the day, suggesting that water accumulated inside the canopy. Using the Community Land Model (CLM), a process based land surface model that has been adapted to oil palm functional traits (i.e. CLM-Palm), we investigated the contribution of different water sources to the measured fluxes. CLM-Palm differentiates leaf and stem surfaces in modelling water interception and is therefore able to diagnose the fraction of dry leaves that contribute to T and the wet fraction of all vegetation surfaces (leaf and stem) that contributes to evaporation. Results from our simulations strengthen our hypothesis of significant contribution of canopy evaporation to ET. As observed in the field, water accumulates inside the canopy in the mature plantation in oil palm trunk surfaces including epiphytes, creating water reservoirs in the trunk, which potentially contribute to ET when they evaporate. The decoupling

  8. Oil palm and the emission of greenhouse gasses- from field measurements in Indonesia

    Science.gov (United States)

    Rahman, Niharika; Bruun, Thilde Bech; Giller, Ken E.; Magid, Jakob; van de Ven, Gerrie; de Neergaard, Andreas

    2017-04-01

    Palm oil from the oil palm (Elaeis guianensis) has in recent years become the world's most important vegetable oil. The increasing demand for palm oil has led to expansion of oil palm plantations, which has caused environmental controversies associated with carbon losses and the use of large amounts of mineral fertilizers. Efforts to increase sustainability of oil palm cultivation, include recycling of oil-mill residues and pruning's, but with this comes increased potential for methane emission from the plantations. Until now no field-based data on greenhouse gas emissions from oil palm plantations have been reported. Here for the first time we present data from a long term (360 days) field trial in Bah Lias Research Station, North Sumatra, Indonesia on greenhouse gas emissions from an oil palm plantation with various treatments of recycled oil palm waste products, fertilizers and simulated rainfall. The first experiment was conducted over a full year (dry + wet season) with mineral fertilizer treatments including urea and ammonium sulphate, and organic fertilizer treatments constituting: empty fruit bunches (EFB), enriched mulch (EFB + palm oil mill effluent (POME) ) and pruned oil palm fronds (OPF). Treatment doses represent the current management in Indonesian plantations and the higher doses that are expected in the imminent future. For the organic treatments several methods of application (applied in inter-rows, piles, patches or bands) were evaluated. The second experiment investigated effects of soil water saturation on GHG emissions through adding 25 mm simulated rainfall per day for 21 days. Each palm tree received 1 kg of N fertilizer as urea or ammonium sulphate and enriched mulch. The gas fluxes in the fields was measured by a large static-chamber (1.8 m x 1.2 m) method and CH4 and N2O concentrations were determined using gas chromatographs. We found that emissions were significantly affected by the type and dose of mineral fertilizers. Application of

  9. Water scarcity and oil palm expansion: social views and environmental processes

    Directory of Open Access Journals (Sweden)

    Jennifer Merten

    2016-06-01

    Full Text Available Conversions of natural ecosystems, e.g., from rain forests to managed plantations, result in significant changes in the hydrological cycle including periodic water scarcity. In Indonesia, large areas of forest were lost and extensive oil palm plantations were established over the last decades. We conducted a combined social and environmental study in a region of recent land-use change, the Jambi Province on Sumatra. The objective was to derive complementary lines of arguments to provide balanced insights into environmental perceptions and eco-hydrological processes accompanying land-use change. Interviews with villagers highlighted concerns regarding decreasing water levels in wells during dry periods and increasing fluctuations in stream flow between rainy and dry periods. Periodic water scarcity was found to severely impact livelihoods, which increased social polarization. Sap flux measurements on forest trees and oil palms indicate that oil palm plantations use as much water as forests for transpiration. Eddy covariance analyses of evapotranspiration over oil palm point to substantial additional sources of evaporation in oil palm plantations such as the soil and epiphytes. Stream base flow from a catchment dominated by oil palms was lower than from a catchment dominated by rubber plantations; both showed high peaks after rainfall. An estimate of erosion indicated approximately 30 cm of topsoil loss after forest conversion to both oil palm and rubber plantations. Analyses of climatic variables over the last 20 years and of a standardized precipitation evapotranspiration index for the last century suggested that droughts are recurrent in the area, but have not increased in frequency or intensity. Consequently, we assume that conversions of rain forest ecosystems to oil palm plantations lead to a redistribution of precipitated water by runoff, which leads to the reported periodic water scarcity. Our combined social and environmental approach

  10. Mitigating the impact of oil-palm monoculture on freshwater fishes in Southeast Asia.

    Science.gov (United States)

    Giam, Xingli; Hadiaty, Renny K; Tan, Heok Hui; Parenti, Lynne R; Wowor, Daisy; Sauri, Sopian; Chong, Kwek Yan; Yeo, Darren C J; Wilcove, David S

    2015-10-01

    Anthropogenic land-cover change is driving biodiversity loss worldwide. At the epicenter of this crisis lies Southeast Asia, where biodiversity-rich forests are being converted to oil-palm monocultures. As demand for palm oil increases, there is an urgent need to find strategies that maintain biodiversity in plantations. Previous studies found that retaining forest patches within plantations benefited some terrestrial taxa but not others. However, no study has focused on aquatic taxa such as fishes, despite their importance to human well-being. We assessed the efficacy of forested riparian reserves in conserving freshwater fish biodiversity in oil-palm monoculture by sampling stream fish communities in an oil-palm plantation in Central Kalimantan, Indonesia. Forested riparian reserves maintained preconversion local fish species richness and functional diversity. In contrast, local and total species richness, biomass, and functional diversity declined markedly in streams without riparian reserves. Mechanistically, riparian reserves appeared to increase local species richness by increasing leaf litter cover and maintaining coarse substrate. The loss of fishes specializing in leaf litter and coarse substrate decreased functional diversity and altered community composition in oil-palm plantation streams that lacked riparian reserves. Thus, a land-sharing strategy that incorporates the retention of forested riparian reserves may maintain the ecological integrity of fish communities in oil-palm plantations. We urge policy makers and growers to make retention of riparian reserves in oil-palm plantations standard practice, and we encourage palm-oil purchasers to source only palm oil from plantations that employ this practice. © 2015 Society for Conservation Biology.

  11. Sustainable management in crop monocultures: the impact of retaining forest on oil palm yield.

    Science.gov (United States)

    Edwards, Felicity A; Edwards, David P; Sloan, Sean; Hamer, Keith C

    2014-01-01

    Tropical agriculture is expanding rapidly at the expense of forest, driving a global extinction crisis. How to create agricultural landscapes that minimise the clearance of forest and maximise sustainability is thus a key issue. One possibility is protecting natural forest within or adjacent to crop monocultures to harness important ecosystem services provided by biodiversity spill-over that may facilitate production. Yet this contrasts with the conflicting potential that the retention of forest exports dis-services, such as agricultural pests. We focus on oil palm and obtained yields from 499 plantation parcels spanning a total of ≈23,000 ha of oil palm plantation in Sabah, Malaysian Borneo. We investigate the relationship between the extent and proximity of both contiguous and fragmented dipterocarp forest cover and oil palm yield, controlling for variation in oil palm age and for environmental heterogeneity by incorporating proximity to non-native forestry plantations, other oil palm plantations, and large rivers, elevation and soil type in our models. The extent of forest cover and proximity to dipterocarp forest were not significant predictors of oil palm yield. Similarly, proximity to large rivers and other oil palm plantations, as well as soil type had no significant effect. Instead, lower elevation and closer proximity to forestry plantations had significant positive impacts on oil palm yield. These findings suggest that if dipterocarp forests are exporting ecosystem service benefits or ecosystem dis-services, that the net effect on yield is neutral. There is thus no evidence to support arguments that forest should be retained within or adjacent to oil palm monocultures for the provision of ecosystem services that benefit yield. We urge for more nuanced assessments of the impacts of forest and biodiversity on yields in crop monocultures to better understand their role in sustainable agriculture.

  12. Evaluation of the Lubricating Properties of Palm Kernel Oil

    Directory of Open Access Journals (Sweden)

    John J MUSA

    2009-07-01

    Full Text Available The search for renewable energy resources continues to attract attention in recent times as fossil fuels such as petroleum, coal and natural gas, which are been used to meet the energy needs of man are associated with negative environmental impacts such as global warming. Biodiesel offered reduced exhaust emissions, improved biodegradability, reduced toxicity and higher carotene rating which can improve performance and clean up emissions. Standard methods were used to determine the physical and chemical properties of the oil, which includes the Density, Viscosity, flash/fire point, carbon residue, volatility and Specific Gravity were determined by chemical experimental analysis. The flash/fire points of the Heavy duty oil (SAE 40 and Light duty oil (SAE 30 is 260/300(°C and 243/290(°C respectively while the pour points of the samples are 22°C for palm kernel oil while 9°C and 21°C for SAE 40and SAE 30 respectively.

  13. Palm oil as a fuel for agricultural diesel engines: Comparative testing against diesel oil

    Directory of Open Access Journals (Sweden)

    Teerawat Apichato

    2003-05-01

    Full Text Available Due to unstable oil price situation in the world market, many countries have been looking for alternative energy sources to substitute for petroleum. Vegetable oil is one of the alternatives which can be used as fuel in automotive engines either in the form of straight vegetable oil, or in the form of ethyl or methyl ester. This paper presents a comparative performance testing of diesel engine using diesel oil and refined palm oil over 2,000 hours of continuous running time. Short-term performance testing was conducted for each fuel on the dynamometer engine test bed. Specific fuel consumption, exhaust temperature and black smoke density were determined and measured. Long-term performance testing (or endurance test was also done by running the engines coupled with a generator in order to supply load (electricity to a lightbulb board. For each 500 hours of engine run time, the engines were dissembled for engine wear inspection. It was found that the fuel pump and fuel valve weight losses from both engines showed insignificant differences either at the first 500 hours of running time or at the second 500 hours of running time but the inlet valve from the engine fueled by diesel oil had a higher weight loss than the engine fueled by refined palm oil at the first 500 hours and at the second 500 hours of running time. The compression rings from the engine fueled by refined palm oil showed a significant weight loss compared to the engine fueled by diesel oil both after 500 hours and after 1000 hours of running time.

  14. Market analysis of palm oil%棕榈油市场分析

    Institute of Scientific and Technical Information of China (English)

    沙克

    2009-01-01

    分析了2008年度的棕榈油市场发展状况,对2009年度的棕榈油市场进行了展望和预测.同时,对全球棕榈油库存及库存使用比以及在全球贸易中所占比例进行了分析.%Palm oil market in 2008 was introduced, and the prospect on the market of palm oil in 2009 was also made in this paper. At the same time, global palm oil inventory situation and it global trade stares were also analyzed.

  15. Strategic environmental assessment for sustainable expansion of palm oil biofuels in Brazilian north region

    Energy Technology Data Exchange (ETDEWEB)

    Carvalho, Carolina

    2010-09-15

    Biofuels development in Brazil is a key factor for the environment and sustainable development of the country. Brazil has great potential of available areas and has favourable climate and geography for biofuel production, such as palm oil, soy, sugar cane, etc. This research aims to evaluate palm oil production and expansion in Para state, in the north of Brazil and also Amazonian territory. Degraded land will be evaluated through remote sensing, because palm oil crops should be placed in these lands, and secondly, expansion scenarios would be created. This PhD research will be a decision support tool for public policies.

  16. Oil palm research in context: identifying the need for biodiversity assessment.

    Directory of Open Access Journals (Sweden)

    Edgar C Turner

    Full Text Available Oil palm cultivation is frequently cited as a major threat to tropical biodiversity as it is centered on some of the world's most biodiverse regions. In this report, Web of Science was used to find papers on oil palm published since 1970, which were assigned to different subject categories to visualize their research focus. Recent years have seen a broadening in the scope of research, with a slight growth in publications on the environment and a dramatic increase in those on biofuel. Despite this, less than 1% of publications are related to biodiversity and species conservation. In the context of global vegetable oil markets, palm oil and soyabean account for over 60% of production but are the subject of less than 10% of research. Much more work must be done to establish the impacts of habitat conversion to oil palm plantation on biodiversity. Results from such studies are crucial for informing conservation strategies and ensuring sustainable management of plantations.

  17. Oil palm research in context: identifying the need for biodiversity assessment.

    Science.gov (United States)

    Turner, Edgar C; Snaddon, Jake L; Fayle, Tom M; Foster, William A

    2008-02-13

    Oil palm cultivation is frequently cited as a major threat to tropical biodiversity as it is centered on some of the world's most biodiverse regions. In this report, Web of Science was used to find papers on oil palm published since 1970, which were assigned to different subject categories to visualize their research focus. Recent years have seen a broadening in the scope of research, with a slight growth in publications on the environment and a dramatic increase in those on biofuel. Despite this, less than 1% of publications are related to biodiversity and species conservation. In the context of global vegetable oil markets, palm oil and soyabean account for over 60% of production but are the subject of less than 10% of research. Much more work must be done to establish the impacts of habitat conversion to oil palm plantation on biodiversity. Results from such studies are crucial for informing conservation strategies and ensuring sustainable management of plantations.

  18. Biological and Nutritional Properties of Palm Oil and Palmitic Acid: Effects on Health.

    Science.gov (United States)

    Mancini, Annamaria; Imperlini, Esther; Nigro, Ersilia; Montagnese, Concetta; Daniele, Aurora; Orrù, Stefania; Buono, Pasqualina

    2015-09-18

    A growing body of evidence highlights the close association between nutrition and human health. Fat is an essential macronutrient, and vegetable oils, such as palm oil, are widely used in the food industry and highly represented in the human diet. Palmitic acid, a saturated fatty acid, is the principal constituent of refined palm oil. In the last few decades, controversial studies have reported potential unhealthy effects of palm oil due to the high palmitic acid content. In this review we provide a concise and comprehensive update on the functional role of palm oil and palmitic acid in the development of obesity, type 2 diabetes mellitus, cardiovascular diseases and cancer. The atherogenic potential of palmitic acid and its stereospecific position in triacylglycerols are also discussed.

  19. Two-component mixture model: Application to palm oil and exchange rate

    Science.gov (United States)

    Phoong, Seuk-Yen; Ismail, Mohd Tahir; Hamzah, Firdaus Mohamad

    2014-12-01

    Palm oil is a seed crop which is widely adopt for food and non-food products such as cookie, vegetable oil, cosmetics, household products and others. Palm oil is majority growth in Malaysia and Indonesia. However, the demand for palm oil is getting growth and rapidly running out over the years. This phenomenal cause illegal logging of trees and destroy the natural habitat. Hence, the present paper investigates the relationship between exchange rate and palm oil price in Malaysia by using Maximum Likelihood Estimation via Newton-Raphson algorithm to fit a two components mixture model. Besides, this paper proposes a mixture of normal distribution to accommodate with asymmetry characteristics and platykurtic time series data.

  20. Biological and Nutritional Properties of Palm Oil and Palmitic Acid: Effects on Health

    Directory of Open Access Journals (Sweden)

    Annamaria Mancini

    2015-09-01

    Full Text Available A growing body of evidence highlights the close association between nutrition and human health. Fat is an essential macronutrient, and vegetable oils, such as palm oil, are widely used in the food industry and highly represented in the human diet. Palmitic acid, a saturated fatty acid, is the principal constituent of refined palm oil. In the last few decades, controversial studies have reported potential unhealthy effects of palm oil due to the high palmitic acid content. In this review we provide a concise and comprehensive update on the functional role of palm oil and palmitic acid in the development of obesity, type 2 diabetes mellitus, cardiovascular diseases and cancer. The atherogenic potential of palmitic acid and its stereospecific position in triacylglycerols are also discussed.

  1. Using of mucilage palm oil in the toilet soap production.

    Directory of Open Access Journals (Sweden)

    Girgis, Adel Y.

    1999-06-01

    Full Text Available Mucilage palm oil (M.P.O. was obtained from physical refining step for crude palm oil. The components of M.P.O. were high content of free fatty acids (82.2% with simple amount of neutral oil (11.9%, while the residual content (unsaponifiable matter and impurities was 2.1% and in addition to 3.8% water. The results indicated that the colours of M.P.O., tallow and palm kemel oil improved after bleaching. Eight soap samples (n.os 1-8 were prepared from bleached fatty blends of mucilage palm oil, tallow and palm kernel oil at different ratios. The results showed that the moisture contents of soap samples n.os 2,7 and 8 were high compared with the standard soap (sample n.os 1, subsequently their total fatty matters became lower than that found in the control soap (sample n.os 1. The findings marked that the unsaponifiable matter of soaps nos 2,7 and 8 were higher compared with the other soaps. No high differences were observed in the free alkali of all soaps (range from 0.06 to 0.09%. On the other hand, high differences were found in the free oil of all soap samples (n.os2-8 compared with the standard soap (sample nos 1, except soap samples n.os2,7 and 8, which record very high. The best soap samples in the colour were in the following increasing order: n.os1 > 3 > 4 > 5 > 6 > 7 > 8 > 2, respectively. The results showed that the better soap samples in the physical properties were in the following increasing order: soap nos 3> soap nos 4> soap n.os 5> soap n.os 6 compared with the standard soap (sample nos 1, where from firm structure with high foam, while the other soap samples (n.os 2,7 and 8 were poor quality (i.e., low lathering properties with deep colours. Therefore, it could be concluded that mucilage palm oil can be used as a new fatty material for toilet soap manufacturing at

  2. Fungal degradation of oil palm cellulosic wastes after radiation pasteurisation

    Energy Technology Data Exchange (ETDEWEB)

    Ito, Hitoshi; Kume, Tamikazu; Ishigaki, Isao (Japan Atomic Energy Research Inst., Takasaki, Gunma (Japan). Takasaki Radiation Chemistry Research Establishment); Mat Rasol Awang; Fajah Bt Ali

    1990-10-01

    The fungal degradation ability was appreciated for upgrading of oil palm cellulosic wastes. In this work, Empty Fruit Bunch (EFB) and Palm press Fiber (PPF) were fermented in an attempt to upgrade to animal feed. However, the heavy contamination of microorganisms in EFB and PPF was observed, and they consist of largely spore forming bacteria and toxigenic moulds of Aspergillus flavus, A. versicolor, A. fumigatus and etc. Therefore, pasteurisation was necessary to be carried out before fermentation, and gamma-irradiation of ca. 10 kGy was employed. Solid-state culture media from EFB and PPF for cultivation of cellulolytic fungi were prepared by addition of some inorganic salts as nitrogen source. The degradation of crude fibre by Coprinus cinereus, Pleurotus species, Aspergillus niger, Trichoderma koningi, and T. viride was obtained in the range between 18 to 76 % after 18 to 20 days cultivation on non-alkali treated cellulosic wastes. C. cinereus could degradate crude fiber more than 50 %, and which resulted in reduction of crude fibre content to 20{approx}28 % and giving to 10-13 % crude protein content. Release of reducing sugars was obtained as 40 to 145 mg glucose/g after saccharification of precultivated alkali-treated EFB by C. cinereus, A. niger, T. knoningi and T. viride. (author).

  3. Different palm oil production systems for energy purposes and their greenhouse gas implications

    NARCIS (Netherlands)

    Wicke, B.; Dornburg, V.; Junginger, H.M.; Faaij, A.P.C.

    2008-01-01

    This study analyses the greenhouse gas (GHG) emissions of crude palm oil (CPO) and palm fatty acid distillate (PFAD) production in northern Borneo (Malaysia), their transport to the Netherlands and their co-firing with natural gas for electricity production. In the case of CPO, conversion to biodies

  4. proximate and ultimate analysis of fuel pellets from oil palm residues

    African Journals Online (AJOL)

    HOD

    The increase in the demand of renewable energy such as biomass is significantly growing worldwide [1] [2]. Biomass is used in various forms and as fuel for energy utilisation. Generally ... Pellets were produced from oil palm residues i.e. Palm.

  5. Different palm oil production systems for energy purposes and their greenhouse gas implications

    NARCIS (Netherlands)

    Wicke, B.|info:eu-repo/dai/nl/306645955; Dornburg, V.|info:eu-repo/dai/nl/189955007; Junginger, H.M.|info:eu-repo/dai/nl/202130703; Faaij, A.P.C.|info:eu-repo/dai/nl/10685903X

    2008-01-01

    This study analyses the greenhouse gas (GHG) emissions of crude palm oil (CPO) and palm fatty acid distillate (PFAD) production in northern Borneo (Malaysia), their transport to the Netherlands and their co-firing with natural gas for electricity production. In the case of CPO, conversion to

  6. The semi-wild oil palm and its industry in Africa

    NARCIS (Netherlands)

    Zeven, A.C.

    1967-01-01

    The oil palm (Elaeis quineensis Jacq.) is of great importance to the people of West Tropical and Equatorial Africa. This palm is there a major food crop under semi-wild conditions and since the end of the 18th century a principal commercial crop. In the first chapters the centres of

  7. Biochar potential evaluation of palm oil wastes through slow pyrolysis: Thermochemical characterization and pyrolytic kinetic studies.

    Science.gov (United States)

    Lee, Xin Jiat; Lee, Lai Yee; Gan, Suyin; Thangalazhy-Gopakumar, Suchithra; Ng, Hoon Kiat

    2017-03-22

    This research investigated the potential of palm kernel shell (PKS), empty fruit bunch (EFB) and palm oil sludge (POS), abundantly available agricultural wastes, as feedstock for biochar production by slow pyrolysis (50mLmin(-1) N2 at 500°C). Various characterization tests were performed to establish the thermochemical properties of the feedstocks and obtained biochars. PKS and EFB had higher lignin, volatiles, carbon and HHV, and lower ash than POS. The thermochemical conversion had enhanced the biofuel quality of PKS-char and EFB-char exhibiting increased HHV (26.18-27.50MJkg(-1)) and fixed carbon (53.78-59.92%), and decreased moisture (1.03-2.26%). The kinetics of pyrolysis were evaluated by thermogravimetry at different heating rates (10-40°C). The activation energies determined by Kissinger-Akahira-Sunose and Flynn-Wall-Ozawa models were similar, and comparable with literature data. The findings implied that PKS and EFB are very promising sources for biochars synthesis, and the obtained chars possessed significant biofuel potential.

  8. LIPASE-CATALYZED TRANSESTERIFICATION OF PALM KERNEL OIL WITH DIALKYLCARBONATES

    Directory of Open Access Journals (Sweden)

    Tjahjono Herawan

    2014-01-01

    Full Text Available Lipase-catalyzed transesterifications-especially in a solvent-free medium-are important for industrial applications because such systems would have an enormous advantage by avoiding the problem of separation, toxicity and flammability of organic solvents. However, the organic solvent-free alcoholysis, especially methanolysis, does not give high conversions. The same problem also occurs when ethyl or methyl acetate are used as acyl acceptors. The main problems of lipase-catalyzed organic solvent-free alcoholysis are first, the solubility of the plant oil in the substrate or solvent and second, the fact that transesterification is an equilibrium reaction. Dialkyl carbonates, versatile compounds due to their chemical reactivity and physical properties, may provide an alternative to solve both problems. Using dialkyl carbonates transesterification is not an equilibrium reaction, because the intermediate compound immediately decomposes to carbon dioxide and an alcohol. Moreover, dialkyl carbonates (especially dimethyl carbonate are cheap and widely available. For single step lipase-catalyzed transesterification of palm kernel oil, diakyl carbonates (in this case dimethyl and diethyl carbonate gave better yields compared to those of short chain alcohols. The rate of ester formation with dialkyl carbonates as substrate was about 6-7 times higher than that obtained with short chain alcohols. The formation of esters was gradually increased by a higher enzyme amount from 5-20% (w/w of oil for 8 h reaction time. However from the economic point of view, an enzyme amount of 10% on the weight base of oil was proposed for further reaction. Generally, the highest ester formation was observed when a temperature of 60°C was used. However, in the case of dimethyl carbonate little difference was observed at reaction temperatures of 60 and 70oC and the reactions proceeded nearly identically. The esters formation increased drastically up to more than 70% when water

  9. Early impact of oil palm planting density on vegetative and oil yield variables in West Africa

    Directory of Open Access Journals (Sweden)

    Bonneau Xavier

    2014-07-01

    Full Text Available A range of various different planting distances (from 7.5 to 9.5 m between oil palms were tested using an equilateral triangle design in a plantation density experiment which was settled in an oil palm commercial plantation in Nigeria. Climatic conditions were quite stable, with two seasons and around 2000 mm of annual rainfall. The soil was of desaturated ferralitic type, sandy on the surface, deep and without coarse elements. The early impact of plantation density was analysed at eight years after planting. Some early signs of depressive effect on yields were found for high planting densities (180 and 205 p/ha. Such a negative impact was not severe enough to counteract the effects of a higher number of palms per hectare. As a consequence, a gradient could be observed as yields (in tons of bunches per hectare increased with density. We can anticipate that the competition effect between palms will increase over time with high densities, so that the counteracting point ought to be reached in a few years. A thinning treatment has been included in the protocol. Thinning was carried out at the end of the eight-year period.

  10. Adsorption of residual oil from palm oil mill effluent using rubber powder

    Directory of Open Access Journals (Sweden)

    A.L. Ahmad

    2005-09-01

    Full Text Available A synthetic rubber powder was used to adsorb the residual oil in palm oil mill effluent (POME. POME is the wastewater produced by the palm oil industry. It is a colloidal suspension which is 95-96% water, 0.6-0.7% oil and 4-5% total solids including 2-4% suspended solids originating in the mixing of sterilizer condensate, separator sludge and hydrocyclone wastewater. POME contains 4,000 mg dm-3 of oil and grease, which is relatively high compared to the limit of only 50 mg dm-3 set by the Malaysian Department of Environment. A bench-scale study of the adsorption of residual oil in POME using synthetic rubber powder was conducted using a jar test apparatus. The adsorption process was studied by varying parameters affecting the process. The parameters were adsorbent dosage, mixing speed, mixing time and pH. The optimum values of the parameters were obtained. It was found that almost 88% removal of residual oil was obtained with an adsorbent dosage of 30 mg dm-3 and mixing speed of 150 rpm for 3 hr at a pH 7. Adsorption equilibrium was also studied, and it was found that the adsorption process on the synthetic rubber powder fit the Freundlich isotherm model.

  11. The palm oil supply chain, deforestation and peat clearing

    Science.gov (United States)

    Boucher, D. H.

    2013-12-01

    The palm oil industry has expanded rapidly in the last two decades, particularly in Indonesia. A considerable amount of this expansion has been at the expense of forests and peatlands, resulting in considerable greenhouse gas emissions. Now the industry is faced with two new challenges. There is a possible oversupply on the global market due to recent expansion and the time lag between clearing and new production coming on line, which may depress prices considerably. Furthermore, there is increasing pressure to reduce the industry's impact on climate and biodiversity, exemplified by the commitment by the businesses of the Consumer Goods Forum to eliminate deforestation from their supply chains by 2020. This presentation will examine the interaction between these two challenges and its implications for the industry, in both southeast Asia and new regions of expansion, and how this interaction could transform the industry's mode of expansion in the coming decade.

  12. Hydrothermal pretreatment of palm oil empty fruit bunch

    Science.gov (United States)

    Simanungkalit, Sabar Pangihutan; Mansur, Dieni; Nurhakim, Boby; Agustin, Astrid; Rinaldi, Nino; Muryanto, Fitriady, Muhammad Ariffudin

    2017-01-01

    Hydrothermal pretreatment methods in 2nd generation bioethanol production more profitable to be developed, since the conventional pretreatment, by using acids or alkalis, is associated with the serious economic and environmental constraints. The current studies investigate hydrothermal pretreatment of palm oil empty fruit bunch (EFB) in a batch tube reactor system with temperature and time range from 160 to 240 C and 15 to 30 min, respectively. The EFB were grinded and separated into 3 different particles sizes i.e. 10 mesh, 18 mesh and 40 mesh, prior to hydrothermal pretreatment. Solid yield and pH of the treated EFB slurries changed over treatment severities. The chemical composition of EFB was greatly affected by the hydrothermal pretreatment especially hemicellulose which decreased at higher severity factor as determined by HPLC. Both partial removal of hemicellulose and migration of lignin during hydrothermal pretreatment caused negatively affect for enzymatic hydrolysis. This studies provided important factors for maximizing hydrothermal pretreatment of EFB.

  13. Wavelet neural networks applied to pulping of oil palm fronds.

    Science.gov (United States)

    Zainuddin, Zarita; Wan Daud, Wan Rosli; Pauline, Ong; Shafie, Amran

    2011-12-01

    In the organosolv pulping of the oil palm fronds, the influence of the operational variables of the pulping reactor (viz. cooking temperature and time, ethanol and NaOH concentration) on the properties of the resulting pulp (yield and kappa number) and paper sheets (tensile index and tear index) was investigated using a wavelet neural network model. The experimental results with error less than 0.0965 (in terms of MSE) were produced, and were then compared with those obtained from the response surface methodology. Performance assessment indicated that the neural network model possessed superior predictive ability than the polynomial model, since a very close agreement between the experimental and the predicted values was obtained. Copyright © 2011 Elsevier Ltd. All rights reserved.

  14. Major components in oils obtained from Amazonian palm fruits

    Directory of Open Access Journals (Sweden)

    Santos, M. F. G.

    2013-06-01

    Full Text Available Native palm trees belong to the Arecaceae family and are among the most useful plant resources in the Amazons. Despite its great diversity and various uses, few species have been study in detail, which makes it necessary to perform more comprehensive studies on the quality and composition of species not yet explored. This study deals with the characterization of the major compounds in the oils obtained from the mesocarp of fruits of the main palm species from the State of Amapá, Brasil, i.e. bacaba (Oenocarpus bacaba, buriti (Mauritia flexuosa, inajá (Maximiliana maripa, pupunha (Bactris gasipaes and tucumã (Astrocaryum vulgare. Physicochemical characteristics, fatty acids and triacylglycerol (TAG contents were analyzed by HPLC and GC. The proximate composition of the fruits was also analyzed. The results relating to acidity, peroxide value and polar compounds indicate good quality of the oils obtained. Oleic acid ranging from 39.2 to 71.6% and palmitic acid ranging from 20.8 to 39.6% were the two major fatty acids in all the samples. The oils from inajá were characterized by the presence of significant amounts of lauric (4.6% and miristic (10.7% acids while in bacaba, buriti, pupunha and tucumã, as in most edible vegetable oils, only the fatty acids of 16 and 18 carbon atoms were present. Accordingly, the major TAG species in all the samples were POP, POO and OOO. The mesocarp of the palm fruit had a high content in lipids ranging from 17.0% for pupunha to 38.3% for bacaba, expressed as dry basis.Las palmeras nativas de la familia Arecaceae constituyen recursos alimentarios de gran importancia en la región amazónica. A pesar de su diversidad y utilidad, muchas especies son poco conocidas por lo que son de interés los estudios dirigidos a conocer la calidad y composición de las especies menos exploradas para evaluar su potencial económico. El objetivo de este estudio fue la caracterización de los aceites obtenidos del mesocarpio

  15. Utilisation of Oil Palm Ash in Foamed Concrete

    Directory of Open Access Journals (Sweden)

    Awang H.

    2014-01-01

    Full Text Available This study is a part of an on-going research examining the properties of foam concrete when replacing the cement with semi-processed Oil Palm Ash (OPA. Replacements range from 25% to 65% were used for a mix having the mix ratio of (1:2:0.45 and having the target density of 1300kg/m3. All mixes were tested for their strength using the compressive, splitting tensile and flexural strengths up to the age of 28 days. Results show that a 25% replacement level exhibited higher compressive and splitting tensile strength than that of the control mix at the age of 28 days. However, the same replacement level exhibited a close strength to that of the control mix when tested for the flexural strength at the same age.

  16. Crystallisation and Melting Behavior of Methyl Esters of Palm Oil

    Directory of Open Access Journals (Sweden)

    Cheng S. Foon

    2006-01-01

    Full Text Available The methyl esters of palm oil, which consists of saturated and unsaturated esters (0.6 to 95.9% unsaturation of the C12 to C18 fatty acids, solidify at the two temperature ranges, -52 to -45°C and -24 to 21°C, when the esters are cooled. When the esters are heated, they melt at two distinct temperatures, -25 and -33°C and a broad peak at -9 to 28°C. The heating thermograms also showed an exothermic crystallisation peak in between two endothermic melting peaks, indicating the occurrence of re-crystallisation of low melting methyl esters into higher melting point crystal and then melt again at higher temperature.

  17. Characterization of cellulose extracted from oil palm empty fruit bunch

    Science.gov (United States)

    Sisak, Muhammad Asri Abdul; Daik, Rusli; Ramli, Suria

    2015-09-01

    Recently, cellulose has been studied by many researchers due to its promising properties such as biodegradability, biocompatibility, hydrophilicity and robustness. Due to that it is applied in many fields such as paper, film, drug delivery, membranes, etc. Cellulose can be extracted from various plants while oil palm empty fruit bunch (OPEFB) is the one of its sources. In this study, cellulose was extracted by chemical treatments which involved the use of formic acid and hydrogen peroxide to remove hemicellulose and lignin components. Maximum yield was 43.22%. Based on the FT-IR spectra, the peak of wax (1735 cm-1), hemicellulose (1375 cm-1) and lignin (1248 cm-1 and 1037 cm-1) were not observed in extracted cellulose. TGA analysis showed that the extracted cellulose starts to thermally degrade at 340 °C. The SEM analysis suggested that the cellulose extracted from OPEFB was not much different from commercial cellulose.

  18. Physicochemical characterization of oil palm mesocarp fibre treated with glycerol

    Science.gov (United States)

    Nor Hamizah M., A.; Roila, A.; Rahimi M., Y.

    2015-09-01

    Lignocellulose has been identified as another source for conversion into value added products. In the present work, physicochemical features from the oil palm mesocarp fibre treated by using pure glycerol with 2% (w/w) NaOH catalyst and crude glycerol have been studied. Treatment was conducted at temperatures 150 °C for 60 min. Fibre treated by crude glycerol resulted in high percentages of holocellulose and lower content of insoluble lignin. These results suggest that crude glycerol can be used as an alternative solvent for pretreatment process. The characterization treated fibre by means of FTIR and TGA has shown significant differences compared to untreated fibre. It was revealed that treated fibre successful eliminated hemicellulose and reduce of lignin content.

  19. The political ecology of land management in the oil palm based cropping system on the Adja Plateau in Benin. NJAS - Wageningen

    NARCIS (Netherlands)

    Yemadje, H.R.M.; Crane, T.A.; Vissoh, V.P.; Mongbo, R.L.; Richards, P.; Kossou, D.K.; Kuyper, T.W.

    2012-01-01

    The Adja plateau (Benin) is densely populated by tenant and landowner farmers engaged in oil palm based cropping. Landowners use oil palm sap for the production of sodabi (a local spirit), and an oil palm fallow (if no crops are grown beneath the palms) to restore soil fertility. In this area,

  20. Use of waste ash from palm oil industry in concrete.

    Science.gov (United States)

    Tangchirapat, Weerachart; Saeting, Tirasit; Jaturapitakkul, Chai; Kiattikomol, Kraiwood; Siripanichgorn, Anek

    2007-01-01

    Palm oil fuel ash (POFA), a by-product from the palm oil industry, is disposed of as waste in landfills. In this study, POFA was utilized as a pozzolan in concrete. The original size POFA (termed OP) was ground until the median particle sizes were 15.9 microm (termed MP) and 7.4 microm (termed SP). Portland cement Type I was replaced by OP, MP, and SP of 10%, 20%, 30%, and 40% by weight of binder. The properties of concrete, such as setting time, compressive strength, and expansion due to magnesium sulfate attack were investigated. The results revealed that the use of POFA in concretes caused delay in both initial and final setting times, depending on the fineness and degree of replacement of POFA. The compressive strength of concrete containing OP was much lower than that of Portland cement Type I concrete. Thus, OP is not suitable to be used as a pozzolanic material in concrete. However, the replacement of Portland cement Type I by 10% of MP and 20% of SP gave the compressive strengths of concrete at 90 days higher than that of concrete made from Portland cement Type I. After being immersed in 5% of magnesium sulfate solution for 364 days, the concrete bar mixed with 30% of SP had the same expansion level as that of the concrete bar made from Portland cement Type V. The above results suggest that ground POFA is an excellent pozzolanic material and can be used as a cement replacement in concrete. It is recommended that the optimum replacement levels of Portland cement Type I by MP and SP are 20% and 30%, respectively.

  1. Physicochemical characterizations of nano-palm oil fuel ash

    Energy Technology Data Exchange (ETDEWEB)

    Rajak, Mohd Azrul Abdul, E-mail: azrulrajak88@gmail.com [Department of Chemistry, Faculty of Science, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru (Malaysia); Preparatory Centre of Science and Technology, Universiti Malaysia Sabah, Jalan UMS, 88400, Kota Kinabalu, Sabah (Malaysia); Majid, Zaiton Abdul, E-mail: zaiton@kimia.fs.utm.my [Department of Chemistry, Faculty of Science, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru (Malaysia); Ismail, Mohammad [Department of Structure and Material, Faculty of Civil Engineering, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru (Malaysia)

    2015-07-22

    Palm Oil Fuel Ash (POFA) is known as a good supplementary cementing material due to its siliceous-rich content. The application of nanotechnology in the pozzolanic materials could invent new functions in the efficiency of physical and chemical properties of materials. Thus, the present study aims to generate nano-sized POFA and characterize the physicochemical properties of nano-palm oil fuel ash (nPOFA). The nPOFA was prepared by mechanically grinding micro POFA using a high intensity ball milling for 6 hours. The physicochemical properties of nPOFA were characterized via X-Ray Fluoresence (XRF), Scanning Emission microscopy- Energy Dispersive X-Ray (SEM-EDX), Transmission Electron Microscope (TEM) and X-Ray Diffraction (XRD). The particle size of nPOFA acquired from TEM analysis was in the range of 20 nm to 90 nm, while the average crystallite size calculated from XRD diffractogram was 61.5 nm. The resulting nPOFA has a BET surface area of 145.35 m{sup 2}/g, which is more than 85% increment in surface area compared to micro-sized POFA. The morphology and elemental studies showed the presence of spherical as well as irregularly shaped and fine nPOFA particles contains with high silicon content. The presence of α-quartz as the major phase of the nPOFA was identified through XRD analysis. The study concludes that nPOFA has the potential as a supplementary cementing material due to the high silica content, high surface area and the unique behaviors of nano-structured particles.

  2. Preparation And Characterization Of Modified Calcium Oxide From Natural Sources And Their Application In The Transesterification Of Palm Oil

    Directory of Open Access Journals (Sweden)

    Aqliliriana

    2015-08-01

    Full Text Available Abstract Calcium oxide catalysts were prepared from natural calcium sources such as limestone and mud creeper shell and the catalytic activities were evaluated in the transesterification of palm oil. The raw material which mainly composed of calcium carbonate can be easily converted to calcium oxide CaO after calcination above 1000 K for few hours. Abundant cheap sources benign high conversion and nontoxic become main advantages of these catalysts. The catalysts were characterized by XRF TGA XRD CO2-TPD SEM and BET methods. Thermal decomposition of CaCO3 will produced CaO which later will be converted into calcium hydroxide CaOH2 via simple hydration technique. Under optimum reaction condition methanol to oil ratio 151 catalyst loading 3 wt. reaction temperature 338 K for 5 hours the highest conversion of palm oil to methyl ester recorded were 98 and 94 when using modified limestone and mud creeper shell respectively. The results observed an increment up to 80 by using modified catalysts with characterization results showed high in basicity and surface area. Hence promising materials via simple and cheap method can be achieved.

  3. Marketing Risk Management of Palm Oil Based Biodiesel Agroindustry

    Directory of Open Access Journals (Sweden)

    I Gusti Bagus Udayana

    2014-03-01

    Full Text Available Biodiesel is fuel generates from vegetable oils that have properties similar to diesel oil. The advantages of biodiesel compared to diesel is an environmentally friendly fuel because it produces much lower emissions (sulfur free, low smoke number in accordance with global issues, higher cetane number (> 57 so that the combustion efficiency is better than diesel, lubrication properties of the piston engine; biodegradable, a renewable energy because it is made from natural materials, and improve the independence of fuel supply because it can be produced locally. The purpose of this research is to design the risk management decision support system for agro-industry development biodiesel of oil palm-based. Determination of objectives and risk management strategies using the used to obtain an alternative value in the aspect of marketing. This research resulted in a decision support system that is useful to help decision makers in addressing the risk of agro-bio-diesel. Risk management model is designed in a decision support system  (DSS, can be used by industrial users and investors in the field of biodiesel. DSS software development using Microsoft Visual Basic Version 6.0 consists of three main components namely database management system, knowledge base management system and model base management system. Model base management system consists of risk marketing analysis.

  4. Effect of fertilizer application on yield of oil palm

    Directory of Open Access Journals (Sweden)

    Eksomtramage, T.

    2001-11-01

    Full Text Available The effects of fertilizer application rates on leaf nutrient contents and yield of oil palm were investigated at the Agricultural and Technological College Plantation in Trang province during May 1998 - June 2001. A five-year-old oil palm plantation, planted on the Na Tham soil series (Fine loamy, mixed, isohyperthermic Oxic Plinthudults with spacing 9x9x9 m, was selected for study. A randomized complete block designwith three replications with 20 palms/replication was used. The treatments included six different rates of fertilizer application. The rates of fertilizer were as follows: T1 (farmer practice, T2 (40% of application rate in T4, T3 (70% of application rate in T4, T4 (urea 2,750 g/plant; triple super phosphate 1,500 g/plant; potassium chloride 4,000 g/plant; kieserite 1,000 g/plant; borate 80 g/plant, T5 (130% of application rate in T4 and T6 (170% of application rate in T4. The high leaf nutrient contents of N, P and K at the range of 2.6-2.8%, 0.16-0.18% and 1.13-1.18%, respectively, were found in the high nutrient application rate treatments (T5, T6. However, the amounts of leaf Ca and Mg in T5 and T6 decreased from 0.75-0.80% and 0.33- 0.37% at the beginning of experiment to 0.65-0.70% and 0.22-0.24%, respectively, at the end of the experiment. Small increases of leaf sulphur and boron up to about 0.20-0.22% and 16-19 mg/kg were also found in the high rate of fertilizer treatments. Accumulated fresh fruit bunch yield (FFB increased according to increasing rate of fertilizer application. Accumulated FFB yield of 268.4 kg/plant in the low fertilizer rate (T1 (farmer practice and 278.8 kg/plant in T2 were found compared with the highest yield of 370.2 kg/plant in the highest fertilizer application treatment (T6 for the 3 years experiment. Regarding the economic return, the medium rate of fertilizer application (T3 which achieved an accumulated FFB yield of 338.0 kg/ plant gave the highest profit with the VCR (Value: Cost ratio of 2.53.

  5. KINETICS OF PALM OIL TRANSESTERIFICATION IN METHANOL WITH POTASSIUM HYDROXIDE AS A CATALYST

    Directory of Open Access Journals (Sweden)

    Yoeswono Yoeswono

    2010-06-01

    Full Text Available A study on palm oil transesterification to evaluate the effect of some parameters in the reaction on the reaction kinetics has been carried out. Transesterification was started by preparing potassium methoxide from potassium hydroxide and methanol and then mixed it with the palm oil. An aliquot was taken at certain time interval during transesterification and poured into test tube filled with distilled water to stop the reaction immediately. The oil phase that separated from the glycerol phase by centrifugation was analyzed by 1H-NMR spectrometer to determine the percentage of methyl ester conversion. Temperature and catalyst concentration were varied in order to determine the reaction rate constants, activation energies, pre-exponential factors, and effective collisions. The results showed that palm oil transesterification in methanol with 0.5 and 1 % w/w KOH/palm oil catalyst concentration appeared to follow pseudo-first order reaction. The rate constants increase with temperature. After 13 min of reaction, More methyl esters were formed using KOH 1 % than using 0.5 % w/w KOH/palm oil catalyst concentration. The activation energy (Ea and pre-exponential factor (A for reaction using 1 % w/w KOH was lower than those using 0.5 % w/w KOH.   Keywords: palm oil, transesterification, catalyst, first order kinetics, activation energy, pre-exponential factor

  6. Intelligent Color Vision System for Ripeness Classification of Oil Palm Fresh Fruit Bunch

    Directory of Open Access Journals (Sweden)

    Haidi Ibrahim

    2012-10-01

    Full Text Available Ripeness classification of oil palm fresh fruit bunches (FFBs during harvesting is important to ensure that they are harvested during optimum stage for maximum oil production. This paper presents the application of color vision for automated ripeness classification of oil palm FFB. Images of oil palm FFBs of type DxP Yangambi were collected and analyzed using digital image processing techniques. Then the color features were extracted from those images and used as the inputs for Artificial Neural Network (ANN learning. The performance of the ANN for ripeness classification of oil palm FFB was investigated using two methods: training ANN with full features and training ANN with reduced features based on the Principal Component Analysis (PCA data reduction technique. Results showed that compared with using full features in ANN, using the ANN trained with reduced features can improve the classification accuracy by 1.66% and is more effective in developing an automated ripeness classifier for oil palm FFB. The developed ripeness classifier can act as a sensor in determining the correct oil palm FFB ripeness category.

  7. Mapping palm oil expansion using SAR to study the impact on the CO2 cycle

    Science.gov (United States)

    Pohl, Christine

    2014-06-01

    With Malaysia being the second largest palm oil producer in the world and the fact that palm oil ranks first in vegetable oil production on the world market the palm oil industry became an important factor in the country. Along with the expansion of palm oil across the nation causing deforestation of natural rain forest and conversion of peat land into plantation land there are several factors causing a tremendous increase in carbon dioxide (CO2) emissions. Main causes of CO2 emission apart from deforestation and peat-land conversion are the fires to create plantation land plus the fires burning waste products of the plantations itself. This paper describes a project that aims at the development of a remote sensing monitoring system to allow a continuous observation of oil palm plantation activities and expansion in order to be able to quantify CO2 emissions. The research concentrates on developing a spaceborne synthetic aperture radar information extraction system for palm oil plantations in the Tropics. This will lead to objective figures that can be used internationally to create a policy implementation plan to sustainably reduce CO2 emission in the future.

  8. Screening of thermotolerant microorganisms and application for oil separation from palm oil mill wastewater

    Directory of Open Access Journals (Sweden)

    Aran H-Kittikun

    2007-05-01

    Full Text Available The characteristics of palm oil mill wastewater (POMW were brown color, pH 3.8-4.3, temperature 48-55oC, total solids 68.2-82.1 g/l, suspended solids 26.2-65.6 g/l, oil and grease 19.1-25.1 g/l, COD 49.9-160.7g/l and BOD 32.5-75.3 g/l. After centrifugation (3,184 xg of 50 ml POMW for 10 min, the POMW was separated into 3 layers: top (oil, middle (supernatant and bottom layer (sediment. The sediment containeddry weight 1.19 g and oil and grease 1.07 g. In order to release oil and grease trapped in palm fiber debris in the POMW, cellulase- and/or xylanase-enzyme-producing and thermotolerant microorganisms wereisolated. The isolates SO1 and SO2 were isolated from soil near the first anaerobic pond of the palm oil mill. They were aerobic, Gram positive, rod shaped, thermotolerant microorganisms and produced cellulase 12.11 U/ml (3 days and 7.2 U/ml (4 days, and xylanase 50.98 U/ml (4 days and 20.42 U/ml (4 days, respectivelyin synthetic medium containing carboxymethycellulose as a carbon source. When these 2 isolates were added into the steriled POMW under shaking condition for 7 days, after centrifugation at 3,184 xg the isolate SO1gave the better % reduction of dry weight (64.66 % and of oil and grease in the bottom layer (85.32 % of the POMW.

  9. Malaysian palm oil. Surviving the food versus fuel dispute for a sustainable future

    Energy Technology Data Exchange (ETDEWEB)

    Lam, Man Kee; Tan, Kok Tat; Lee, Keat Teong; Mohamed, Abdul Rahman [School of Chemical Engineering, Engineering Campus, Universiti Sains Malaysia, 14300 Nibong Tebal, Seberang Perai Selatan, Pulau Pinang (Malaysia)

    2009-08-15

    For the past few decades, palm oil has gone through a revolution that few would have predicted. From a humble source of edible oil that was heavily criticized as being un-healthy and un-fit for human consumption, it has proven itself based on scientific findings that it is indeed one of the most nutritious edible oils in the world. Besides, palm oil, the cheapest vegetable oil in the market has diversified as one of the main feedstock for oleo-chemical industries. Recently, with the price of crude petroleum hitting records height every other day, palm oil has become one of the few feasible sources for biodiesel, a renewable substitute for petroleum-derived diesel. Nevertheless, the conversion of palm oil into biodiesel has again received criticism from various NGOs worldwide, mainly on extinction of orang utans, deforestation and particularly the food versus fuel dispute. It was claimed that the conversion of food crops to fuel would significantly increase the number of undernourished people in the world. Malaysia, being the world second largest producer of palm oil, is not spared from this criticism. On the contrary, in the present study it was found that palm oil is indeed the most economical and sustainable source of food and biofuel in the world market. Besides, it was shown that it has the capacity to fulfill both demands simultaneously rather than engaging in priority debate. Nevertheless, fuel is now a necessity rather than a luxury for economy and development purposes. A few strategies will then be presented on how palm oil can survive in this feud and emerged as the main supply of affordable and healthy source of edible oil while concurrently satisfying the market demand for biodiesel throughout the world. (author)

  10. The Expression of Adipogenic Genes in Adipose Tissues of Feedlot Steers Fed Supplementary Palm Oil or Soybean Oil.

    Science.gov (United States)

    Choi, Seong Ho; Park, Sung Kwon; Choi, Chang Weon; Li, Xiang Zi; Kim, Kyoung Hoon; Kim, Won Young; Jeong, Joon; Johnson, Bradley J; Zan, Linsen; Smith, Stephen B

    2016-03-01

    We hypothesized that supplementing finishing diets with palm oil would promote adipogenic gene expression and stearoyl-CoA desaturase (SCD) gene expression in subcutaneous (s.c.) and intramuscular (i.m.) adipose tissues of feedlot steers. Eighteen Angus and Angus crossbred steers were assigned to three groups of 6 steers and fed a basal diet (control), with 3% palm oil, or with 3% soybean oil, for 70 d, top-dressed daily. Tailhead s.c. adipose tissue was obtained by biopsy at 14 d before the initiation of dietary treatments and at 35 d of dietary treatments. At slaughter, after 70 d of dietary treatment, tailhead s.c. adipose tissue and i.m. adipose tissue were obtained from the longissimus thoracis muscle. Palm oil increased plasma palmitic acid and soybean oil increased plasma linoleic acid and α-linolenic acid relative to the initial sampling time. Expression of AMP-activated protein kinase alpha (AMPKα) and peroxisome proliferator-activated receptor gamma (PPARγ) increased between the initial and intermediate biopsies and declined thereafter (padipose tissue than in s.c. adipose tissue (padipose tissue of palm oil-fed steers than in control steers (p = 0.04) and CCAAT enhancer binding protein-beta (CEBPβ) gene expression was less in s.c. and i.m. adipose tissues of palm oil-fed steers than in soybean oil-fed steers (padipose tissue (p = 0.05); SCD gene expression in palm oil-fed steers was intermediate between control and soybean oil-fed steers. Contrary to our original hypothesis, palm oil did not promote adipogenic gene expression in s.c. and i.m. adipose tissue.

  11. Determination of Indonesian palm-oil-based bioenergy sustainability indicators using fuzzy inference system

    Science.gov (United States)

    Arkeman, Y.; Rizkyanti, R. A.; Hambali, E.

    2017-05-01

    Development of Indonesian palm-oil-based bioenergy faces an international challenge regarding to sustainability issue, indicated by the establishment of standards on sustainable bioenergy. Currently, Indonesia has sustainability standards limited to palm-oil cultivation, while other standards are lacking appropriateness for Indonesian palm-oil-based bioenergy sustainability regarding to real condition in Indonesia. Thus, Indonesia requires sustainability indicators for Indonesian palm-oil-based bioenergy to gain recognition and easiness in marketing it. Determination of sustainability indicators was accomplished through three stages, which were preliminary analysis, indicator assessment (using fuzzy inference system), and system validation. Global Bioenergy partnership (GBEP) was used as the standard for the assessment because of its general for use, internationally accepted, and it contained balanced proportion between environment, economic, and social aspects. Result showed that the number of sustainability indicators using FIS method are 21 indicators. The system developed has an accuracy of 85%.

  12. Oil palm expansion in Riau province, Indonesia: Serving people, planet, profit?

    NARCIS (Netherlands)

    Susanti, A.; Burgers, P.P.M.|info:eu-repo/dai/nl/311475531

    2011-01-01

    This paper analyses the relation between the increase of global demand for biofuels and rapid oil palm expansion in Riau, Indonesia and in particular how these lead to more intensified forest conversion and put food and water security at risk.

  13. Technical and Economic Efficiency of Palm Oil Marketing in the Niger Delta Region of Southern Nigeria

    Directory of Open Access Journals (Sweden)

    Nkasiobi Silas Oguzor

    2013-09-01

    Full Text Available This study examined the structural performance and productive efficiency of palm oil marketing in some selected States in Southern Nigeria. Eighty districts were selected in the Niger Delta Area and data were collected from 1000 palm oil sellers randomly selected in these towns. The tools of analysis were marketing margin, Lorenz curve and Gini coefficient to measure the structural performance while the productive efficiency was measured with the use of the production function analysis using the OLS multiple regression analysis to estimate the parameters of the production function equations. All these phenomena portend a high poor structural performance in the system. The productive efficiency measurement showed that palm oil marketing was in stage one of the production surface in the area and this implies inefficient allocation and utilization of resources. Therefore palm oil marketing in the study is though profitable was grossly inefficient from the view point of market structure and productive efficiency analysis.

  14. Isolation of a kernel oleoyl-ACP thioesterase gene from the oil palm ...

    African Journals Online (AJOL)

    Administrator

    Department of Genetics, Faculty of Life Sciences, Universiti Kebangsaan Malaysia, 43600 Bangi, ... the oil palm Elaeis guineensis which encodes a thioesterase enzyme. .... (ACP) thioesterase and the evolutionary origin of plant Acyl-ACP.

  15. Supercritical carbon dioxide (SC-CO2 as a clean technology for palm kernel oil extraction

    Directory of Open Access Journals (Sweden)

    Norhuda I

    2009-04-01

    Kyoto Protocol. Keywords: By-product, Solvent extraction, Kyoto protocol, Supercritical Carbon Dioxide, Palm Kernel Oil Received: 13 July 2008 / Received in revised form: 17 February 2009, Accepted: 28 February 2009, Published online: 12 March 2009

  16. The effects of oil palm leaf meal-based diets on the growth ...

    African Journals Online (AJOL)

    ... diets on the growth performance and haematological indices of red Sokoto goats. ... Journal of Agriculture, Forestry and the Social Sciences ... indices of Red Sokoto goats placed on oil palm leaf meal (OPLM)-wheat offal based diet.

  17. Topological and thermal properties of polypropylene composites based on oil palm biomass

    Energy Technology Data Exchange (ETDEWEB)

    Bhat, A. H., E-mail: aamir.bhat@petronas.com.my, E-mail: anie-yal88@yahoo.com; Dasan, Y. K., E-mail: aamir.bhat@petronas.com.my, E-mail: anie-yal88@yahoo.com [Department of Fundamental and Applied Sciences, Universiti Teknologi Petronas, 31750 Perak (Malaysia)

    2014-10-24

    Roughness on pristine and polymer composite surfaces is of enormous practical importance for polymer applications. This study deals with the use of varying quantity of oil palm ash as a nanofiller in a polypropylene based matrix. The oil palm ash sample was preprocessed to break the particles into small diameter by using ultra sonication before using microfluidizer for further deduction in size and homogenization. The oil palm ash was made to undergo many passes through the microfluidizer for fine distribution of particles. Polypropylene based composites containing different loading percentage oil palm ash was granulated by twin screw extruder and then injection molded. The surface morphology of the OPA passed through microfluidizer was analyzed by Tapping Mode - Atomic Force Microscopy (TMAFM). Thermal analysis results showed an increase in the activation energy values. The thermal stability of the composite samples showed improvement as compared to the virgin polymer as corroborated by the on-set degradation temperatures and the temperatures at which 50% degradation occurred.

  18. influence of mould pressure and substitution of quartz by palm oil ...

    African Journals Online (AJOL)

    in quantities greater than 10% by mass of binder (Tay, 1990). In order ... superplasticizer (SP) needs to be increased to maintain the ... derived from the solid-state decomposition of the clay .... Engineered Cementitious Composite with Palm Oil.

  19. Effects of de-oiled palm kernel cake based fertilizers on sole maize ...

    African Journals Online (AJOL)

    AJL

    2012-03-08

    Mar 8, 2012 ... formulations on the yield of sole maize and cassava crops. Two de-oiled palm ... cake, urea, muriate of potash and single super phosphate. Two separate ..... establishment of nitrogen fixing bacteria in the rhizosphere. Microb.

  20. NEW APPROACH TO OIL PALM WOOD UTILIZATION FOR WOODWORKING PRODUCTION Part 1: Basic Properties

    Directory of Open Access Journals (Sweden)

    Jamal Balfas

    2006-03-01

    Full Text Available An explosive development in oil palm plantations in the country has produced a consequence in the generation of  plantation wastes. The  disposal of these wastes  has created  an  enormous environmental problem that some practical solution to their economic utilization has to  be sought.  A series of experiments have been accomplished to observe the possibility of converting the oil palm stem into valuable woodworking products. The  first stage of  this effort was determining basic characteristics of oil palm wood.  Results in general showed that the wood has a great characteristic variation across and along the stem, which may develop problems in its utilization. Characteristics of this wood also vary according to species variety.  Quality degradations of oil palm wood were mostly happened during drying process; hence, modifications to upgrade quality should be undertaken before or within the drying process.

  1. Isolation of palm oil-utilising, polyhydroxyalkanoate (PHA)-producing bacteria by an enrichment technique.

    Science.gov (United States)

    Alias, Zazali; Tan, Irene K P

    2005-07-01

    In early attempts to isolate palm oil-utilising bacteria from palm oil mill effluent (POME), diluted liquid samples of POME were spread on agar containing POME as primary nutrient. 45 purified colonies were screened for intracellular lipids by staining with Sudan Black B. Of these, 10 isolates were positively stained. The latter were grown in a nitrogen-limiting medium with palm olein (a triglyceride) or saponified palm olein (salts of fatty acids) as carbon source. None of the isolates grew in the palm olein medium but all grew well in the saponified palm olein medium. Of the latter however, only one isolate was positively stained with Nile Blue A, indicating the presence of PHA. This method did not successfully generate bacterial isolates which could metabolise palm olein to produce PHA. An enrichment technique was therefore developed whereby a selective medium was designed. The latter comprised minerals and palm olein (1% w/v) as sole carbon source to which POME (2.5% v/v) was added as the source of bacteria. The culture was incubated with shaking at 30 degrees C for 4 weeks. Out of seven isolates obtained from the selective medium, two isolates, FLP1 and FLP2, could utilise palm olein for growth and production of the homopolyester, poly(3-hydroxybutyrate). FLP1 is gram-negative and is identified (BIOLOG) to have 80% similarity to Burkholderia cepacia. When grown with propionate or valerate, FLP1 produced a copolyester, poly(3-hydroxybutyrate-co-3-hydroxyvalerate).

  2. The making of quality : a technography of small-scale women's groups and a medium-scale firm processing oil palm in Ghana

    OpenAIRE

    Adjei, B.E.

    2014-01-01

    Summary Palm oil is an important product in local diets and domestic markets in the South. The current attention for market quality standards and certification schemes in the palm oil sector has the risk to marginalise the role of palm oil in local food security and to direct public and private investments exclusively to industrial and export-oriented production systems. The rise of a variety of standards in the oil palm sector in recent times particularly the Roundtable for Sustainable Palm ...

  3. Renoprotective effect of virgin coconut oil in heated palm oil diet-induced hypertensive rats.

    Science.gov (United States)

    Kamisah, Yusof; Ang, Shu-Min; Othman, Faizah; Nurul-Iman, Badlishah Sham; Qodriyah, Hj Mohd Saad

    2016-10-01

    Virgin coconut oil, rich in antioxidants, was shown to attenuate hypertension. This study aimed to investigate the effects of virgin coconut oil on blood pressure and related parameters in kidneys in rats fed with 5-times-heated palm oil (5HPO). Thirty-two male Sprague-Dawley rats were divided into 4 groups. Two groups were fed 5HPO (15%) diet and the second group was also given virgin coconut oil (1.42 mL/kg, oral) daily for 16 weeks. The other 2 groups were given basal diet without (control) and with virgin coconut oil. Systolic blood pressure was measured pre- and post-treatment. After 16 weeks, the rats were sacrificed and kidneys were harvested. Dietary 5HPO increased blood pressure, renal thiobarbituric acid reactive substance (TBARS), and nitric oxide contents, but decreased heme oxygenase activity. Virgin coconut oil prevented increase in 5HPO-induced blood pressure and renal nitric oxide content as well as the decrease in renal heme oxygenase activity. The virgin coconut oil also reduced the elevation of renal TBARS induced by the heated oil. However, neither dietary 5HPO nor virgin coconut oil affected renal histomorphometry. In conclusion, virgin coconut oil has a potential to reduce the development of hypertension and renal injury induced by dietary heated oil, possibly via its antioxidant protective effects on the kidneys.

  4. Responses of tropical fruit bats to monoculture and polyculture farming in oil palm smallholdings

    Science.gov (United States)

    Syafiq, Muhamad; Nur Atiqah, Abd Rahman; Ghazali, Amal; Asmah, Siti; Yahya, Muhammad S.; Aziz, Najjib; Puan, Chong Leong; Azhar, Badrul

    2016-07-01

    The oil palm industry is one of the main economic drivers in Southeast Asia. The industry has caused tropical deforestation on a massive scale in producing countries, and this forest conversion to oil palm agriculture has decimated the habitat of numerous native species. Monoculture and polyculture practices are two distinctive oil palm production systems. We hypothesize that polyculture farming hosts a greater diversity of species than monoculture farming. Habitat complexity in smallholdings is influenced by multiple farming practices (i.e. polyculture and monoculture). However, little is known about the effects of such farming practices in smallholdings on mammalian biodiversity, and particularly frugivorous bats. Our study aimed to find the best farming practice to reconcile oil palm production with biodiversity conservation. Mist-nets were used to trap frugivorous bats at 120 smallholdings in Peninsular Malaysia. We compared species richness and the abundance of frugivorous bats between monoculture and polyculture smallholdings. We investigated their relationships with vegetation structure characteristics. Our results revealed that species richness and abundance of frugivorous bats were significantly greater in polyculture smallholdings than monoculture smallholdings. We also found that 28.21% of the variation in species richness was explained by in situ habitat characteristics, including the number of dead standing oil palms and immature oil palms, non-grass cover, height of non-grass cover, and farming practices. The in situ habitat quality was closely associated with oil palm farming management. Commercial growers should implement polyculture rather than monoculture farming because polyculture farming has positive effects on the abundance and species richness of bats in oil palm production landscapes.

  5. I want to change my fate now : the role of oil palm in Indonesia's rural development

    OpenAIRE

    Rist, L.; Levang, Patrice

    2010-01-01

    The rapid expansion of biofuel cultivation in the tropics, particularly of oil palm, has led to growing concern over impacts on natural habitats, biodiversity and the global climate. Alarm has also been raised over the implications for national and global food security, but the broader social and livelihood implications of biofuel cultivation remain uncertain. In Indonesia human rights organisations have criticised the oil palm industry for negative livelihood outcomes and human rights abuses...

  6. Sustainability of palm oil production and opportunities for Finnish technology and know-how transfer

    Energy Technology Data Exchange (ETDEWEB)

    Panapanaan, V.; Helin, T.; Kujanpaeae, M.; Soukka, R.; Heinimoe, R.; Linnanen, L.

    2009-07-01

    The global demand for palm oil is growing, thus prompting an increase in the global production particularly in Malaysia and Indonesia. Such increasing demand for palm oil is due to palm oil's relatively cheap price and versatile advantage both in edible and non-edible applications. Along with the increasing demand for palm oil, particularly for the production of biofuel, is a heated debate on its sustainability. Ecological degradation, climate change and social issues are among the main sustainability issues pressing the whole palm oil industry today. Clean Development Mechanism (CDM) projects fulfilling the imperatives of the Kyoto Protocol are starting to gain momentum in Malaysia as reflected by the increasing registration of CDM projects in the palm oil mills. Most CDM projects in palm oil mills are on waste-to-energy, cocomposting, and methane recovery with the latter being the most common. The study on greenhouse gases (GHG) in the milling process points that biogas collection and energy utilisation has the greatest positive effect on GHG balance. On the other hand, empty fruit bunches (EFB) end-use as energy and high energy efficiency of the mill have the least effect on GHG balance of the mill. The range of direct GHG emissions from the palm oil mill is from 2.5 to 27 gCO{sub 2}e/MJ{sub CPO}, while the range of GHG emissions with all indirect and avoided emissions included is from -9 to 29 gCO{sub 2}e/MJ{sub CPO}. Comparing this GHG balance result with that of the EU RES-Directive suggests a further check on the values and emissions consideration of the latter. (orig.)

  7. Feasibility Studies of Palm Oil Mill Waste Aggregates for the Construction Industry

    OpenAIRE

    Jegathish Kanadasan; Auni Filzah Ahmad Fauzi; Hashim Abdul Razak; Paramananthan Selliah; Vijaya Subramaniam; Sumiani Yusoff

    2015-01-01

    The agricultural industry in Malaysia has grown rapidly over the years. Palm oil clinker (POC) is a byproduct obtained from the palm oil industry. Its lightweight properties allows for its utilization as an aggregate, while in powder form as a filler material in concrete. POC specimens obtained throughout each state in Malaysia were investigated to evaluate the physical, chemical, and microstructure characteristics. Variations between each state were determined and their possible contributory...

  8. An Evaluation of Holistic Sustainability Assessment Framework for Palm Oil Production in Malaysia

    Directory of Open Access Journals (Sweden)

    Chye Ing Lim

    2015-12-01

    Full Text Available Palm oil based biodiesel offers an alternative energy source that can reduce current dependence on conventional fossil fuels and may reduce greenhouse gas (GHG emissions depending on the type of feedstock and processes used. In the Malaysian context, the palm oil industry not only provides high-yield, renewable feedstock to the world, it brings socio-economic development to the Malaysian rural community and contributes to the national income. However, the sustainability of palm oil remains controversial, due to deforestation, pollution and social conflicts associated with its production. Sustainability assessment is vital for the palm oil industry to identify weaknesses, improve its sustainability performance and improve consumer confidence. This paper proposes a holistic sustainability assessment framework for palm oil production with the aim to address the weaknesses of existing palm oil sustainability assessment methods. It identifies environmental, social and economic Headline Performance Indicators, Key Performance Indicators and their Performance Measures in crude palm oil production in a structured framework. Each quantitative/semi-quantitative performance measure is translated into Likert Scale of 1–5, where 3 is the threshold value, 5 is the ideal condition, and 1 is the worst case scenario. Calculation methods were established for the framework to provide quantitative assessment results. The framework was tested using a hypothetical example with data from existing studies. The results suggest that crude palm oil production in Malaysia is below the sustainability threshold. Evaluations of this sustainability assessment framework also demonstrate that it is a comprehensive assessment method for assessing sustainability of feedstock for biofuel production.

  9. Trading Fat for Forests: On Palm Oil, Tropical Forest Conservation, and Rational Consumption

    OpenAIRE

    Cindy Isenhour

    2014-01-01

    The longstanding butter vs margarine debate has recently become more complex as the links between margarine, industrial palm oil plantations, and tropical deforestation are made increasingly clear. Yet despite calls for consumers to get informed and take responsibility for tropical deforestation by boycotting margarine or purchasing buttery spreads made with sustainably-sourced palm oil, research in multiple contexts demonstrates that even the most aware, engaged, and rational consumers run i...

  10. Bacterial Community Structure and Biochemical Changes Associated With Composting of Lignocellulosic Oil Palm Empty Fruit Bunch

    OpenAIRE

    Mohd Huzairi Mohd Zainudin; Mohd Ali Hassan,; Umi Kalsom Md Shah; Norhani Abdullah; Mitsunori Tokura; Hisashi Yasueda; Yoshihito Shirai; Kenji Sakai; Azhari Samsu Baharuddin

    2013-01-01

    Bacterial community structure and biochemical changes during the composting of lignocellulosic oil palm empty bunch (EFB) and palm oil mill effluent (POME) anaerobic sludge were studied by examining the succession of the bacterial community and its association with changes in lignocellulosic components by denaturing gradient gel electrophoresis (DGGE) and the 16S rRNA gene clone library. During composting, a major reduction in cellulose after 10 days from 50% to 19% and the carbon content fro...

  11. Synergies for Improving Oil Palm Production and Forest Conservation in Floodplain Landscapes

    OpenAIRE

    Nicola K Abram; Xofis, Panteleimon; Tzanopoulos, Joseph; Douglas C. MacMillan; Ancrenaz, Marc; Chung, Robin; Peter, Lucy; Ong, Robert; Lackman, Isabelle; Goossens, Benoit; Ambu, Laurentius; Andrew T Knight

    2014-01-01

    Lowland tropical forests are increasingly threatened with conversion to oil palm as global demand and high profit drives crop expansion throughout the world’s tropical regions. Yet, landscapes are not homogeneous and regional constraints dictate land suitability for this crop. We conducted a regional study to investigate spatial and economic components of forest conversion to oil palm within a tropical floodplain in the Lower Kinabatangan, Sabah, Malaysian Borneo. The Kinabatangan ecosystem h...

  12. Synergies for Improving Oil Palm Production and Forest Conservation in Floodplain Landscapes

    OpenAIRE

    Abram, NK; Xofis, P.; Tzanopoulos, J; MacMillan, DC; Ancrenaz, M; Chung, R.; Peter, L; Ong, R.; Lackman, I; Goossens, B.; L. Ambu; Knight, AT

    2014-01-01

    Lowland tropical forests are increasingly threatened with conversion to oil palm as global demand and high profit drives crop expansion throughout the world?s tropical regions. Yet, landscapes are not homogeneous and regional constraints dictate land suitability for this crop. We conducted a regional study to investigate spatial and economic components of forest conversion to oil palm within a tropical floodplain in the Lower Kinabatangan, Sabah, Malaysian Borneo. The Kinabatangan ecosystem h...

  13. The relationship between immigration and labour market performance in Sabah’s oil palm plantation sector

    OpenAIRE

    Kasim Mansur

    2016-01-01

    The main objective of this paper is to analyze the relationship between immigration and labor market performance in Sabah region's oil palm plantation industry. The labour market performance refers to the wages and employment of local workers in the oil palm plantation sector. The relationship of these variables can be in short run or/ and in the long run. This study uses Vector Error Correction Model (VECM) to examine the relationship between the immigration and labour market performance. In...

  14. Environmental and Social Impacts of Oil Palm Plantations and their Implications for Biofuel Production in Indonesia

    OpenAIRE

    Krystof Obidzinski; Rubeta Andriani; Heru Komarudin; Agus Andrianto

    2012-01-01

    This paper reviews the development of oil palm with linkages to biofuel in Indonesia and analyzes the associated environmental and socioeconomic impacts. We selected three plantation study sites in West Papua (Manokwari), West Kalimantan (Kubu Raya), and Papua (Boven Digoel) to assess the impacts. Research findings indicate that the development of oil palm in all three sites has caused deforestation, resulting in significant secondary external impacts such as water pollution, soil erosion, an...

  15. To study the performance of Palm Kernel Oil in the use of non dairy whip topping

    Directory of Open Access Journals (Sweden)

    Yogesh R Patel ,

    2015-07-01

    Full Text Available Palm Kernel Oil is most suitable for Non dairy whip topping.The results show that The cream which is produced from PKO is smooth,Glossy and Shine,which has more shelf life than dairy whip topping.This study also shows that, the foam which is produced is more stable in whipping cream.this study also point out advantags of palm kernel oil based whipping cream,particularly when stability of cream is more important.

  16. Revisiting the palm oil boom in Southeast Asia: The role of fuel versus food demand drivers

    OpenAIRE

    Sanders, Daniel J.; Balagtas, Joseph V; Gruere, Guillaume P.

    2012-01-01

    In the last 30 years, palm oil production has known a ninefold increase, with almost all production growth concentrated in Malaysia and Indonesia. Several public reports have associated the palm oil boom with extensive deforestation, often pointing to the increase in biofuel demand in developed nations as a main driver of this phenomenon. Other demand drivers, especially as related to the food sector, have not been studied as much. In particular, regulations on genetically modified (GM) food ...

  17. Feasibility of producing insulation boards from oil palm fronds and empty Fruit bunches

    Directory of Open Access Journals (Sweden)

    Tanasri Sihabut

    2010-03-01

    Full Text Available This research focused on the feasibility of producing insulation boards made from oil palm fronds and empty fruit bunches via the wet forming process. Results confirmed no difference in the visual appearance between both board types. Both displayed low thermal conductivity, offering evidence of being good insulators. Boards made from empty fruit bunch weighed less than boards made from oil palm fronds. Other properties such as fire retardant, water absorption and strength still need to be investigated.