Manure sampling procedures and nutrient estimation by the hydrometer method for gestation pigs.

Science.gov (United States)

Zhu, Jun; Ndegwa, Pius M; Zhang, Zhijian

2004-05-01

Three manure agitation procedures were examined in this study (vertical mixing, horizontal mixing, and no mixing) to determine the efficacy of producing a representative manure sample. The total solids content for manure from gestation pigs was found to be well correlated with the total nitrogen (TN) and total phosphorus (TP) concentrations in the manure, with highly significant correlation coefficients of 0.988 and 0.994, respectively. Linear correlations were observed between the TN and TP contents and the manure specific gravity (correlation coefficients: 0.991 and 0.987, respectively). Therefore, it may be inferred that the nutrients in pig manure can be estimated with reasonable accuracy by measuring the liquid manure specific gravity. A rapid testing method for manure nutrient contents (TN and TP) using a soil hydrometer was also evaluated. The results showed that the estimating error increased from +/-10% to +/-30% with the decrease in TN (from 1000 to 100 ppm) and TP (from 700 to 50 ppm) concentrations in the manure. Data also showed that the hydrometer readings had to be taken within 10 s after mixing to avoid reading drift in specific gravity due to the settling of manure solids.

Innovative process scheme for removal of organic matter, phosphorus and nitrogen from pig manure

DEFF Research Database (Denmark)

Karakashev, Dimitar Borisov; Schmidt, Jens Ejbye; Angelidaki, Irini

2008-01-01

blanket (UASB) reactor, partial oxidation), nitrogen (oxygen-limited autotrophic nitrification-denitrification, OLAND) and phosphorus (phosphorus removal by precipitation as struvite, PRS) from pig manure were tested. Results obtained showed that microfiltration was unsuitable for pig manure treatment....... PRS treated effluent was negatively affecting the further processing of the pig manure in UASB, and was therefore not included in the final process flow scheme. In a final scheme (PIGMAN concept) combination of the following successive process steps was used: thermophilic anaerobic digestion...... with sequential separation by decanter centrifuge, post-digestion in UASB reactor, partial oxidation and finally OLAND process. This combination resulted in reduction of the total organic, nitrogen and phosphorus contents by 96%, 88%, and 81%, respectively....

Spring barley yield and nitrogen recovery after application of peat manure and pig slurry

Directory of Open Access Journals (Sweden)

P. K. MATTILA

2008-12-01

Full Text Available The effectiveness of peat manure, manufactured of pig slurry and moderately humified Sphagnum peat (slurry:peat ca. 1:1.5 v/v, as nitrogen (N source for spring barley was investigated in a four.year field experiment on a clay loam soil in south-western Finland. Pig slurry, NPK fertilizer and plain peat were used as references. Manures were incorporated before sowing or surface-applied after sowing in spring at an ammoniacal N rate of.54.106 kg.ha-1 with or without supplementary NPK fertilizer (40.kg N.ha-1. Soil moisture conditions were varied by different irrigation treatments. Peat manure produced 5.15% higher grain yields than pig slurry, with the largest difference after surface application. Incorporation was more important for slurry than for peat manure in increasing N uptake and yield. Soil moisture deficit in spring and early summer limited the availability of manure N. Part of the manure N that was not available in the early growing period was apparently taken up by the crop later. Consequently, N concentration tended to be higher with lower yields, and differences in the recovery of manure N were smaller than the differences in grain yield. Supplementation of manures with inorganic fertilizer N increased yield by 37%, on average, and improved the N recovery.;

Characterization the potential of biochar from cow and pig manure for geoecology application

Science.gov (United States)

Gunamantha, I. M.; Widana, G. A. B.

2018-03-01

Biochar is a solid product generated from the carbonization of biomass with various potential benefits. The utilisation of biochar should be adapted to its characteristic which is mainly influenced by its feedstock. In this study, cow and pig manure biochar generated by a conventional process, were characterized by its physical and chemical analysis and its potential to be used as soil amendment. For this purpose, several main parameters were analyzed: organic carbon, Nutrient (total-N, available P and K) status, Cation Exchange Capacity (CEC), proximate data analysis (moisture content, ash, volatile matter and fixed carbon) and its ash composition. The comparison between biochar and feedstock will be based on these parameters. The results of this study show that the organic carbon, available P, ash, and fixed carbon content of pig-manure biochar is higher than cow manure-derived biochar; while total-N, available K, CEC and volatile matter is lower. On its ash composition, the pig manure-derived biochar is dominated by SiO2, Al2O3, Fe2O3, P2O5, and CaO while the cow manure-derived biochar is dominated by SiO2, CaO, Al2O3, K2O, and P2O5. However, both biochar show potential for improving soil quality and reducing carbon emission from animal manure.

Dynamic chemical characteristics of soil solution after pig manure application: a column study.

Science.gov (United States)

Hao, Xiuzhen; Zhou, Dongmei; Sun, Lei; Li, Lianzhen; Zhang, Hailin

2008-06-01

When manures from intensive livestock operations are applied to agricultural or vegetable fields at a high rate, large amounts of salts and metals will be introduced into soils. Using a column leaching experiment, this study assessed the leaching potential of the downward movement of Cu and Zn as well as some salt ions after an intensive farm pig manure at rates of 0%, 5% and 10% (w/w) were applied to the top 20 cm of two different textured soils (G soil -sandy loam soil; H soil-silty clay loam soil), and investigated the growth of amaranth and Cu and Zn transfer from soil to amaranth (Amaranthus tricolor). Soil solutions were obtained at 20, 40 and 60 cm depth of the packed column and analyzed for pH, electrical conductivity (EC), dissolved organic matter (DOC) and Cu and Zn concentrations. The results indicated that application of pig manure containing Cu and Zn to sandy loam soil might cause higher leaching and uptake risk than silty clay loam soil, especially at high application rates. And manure amendment at 5% and 10% significantly decreased the biomass of amaranth, in which the salt impact rather than Cu and Zn toxicity from manures played more important role in amaranth growth. Thus the farmer should avoid application the high rate of pig manure containing metal and salt to soil at a time, especially in sandy soil.

Nutrients and heavy metal distribution in thermally treated pig manure

DEFF Research Database (Denmark)

Kuligowski, Ksawery; Poulsen, Tjalfe G.; Stoholm, Peder

2008-01-01

Ash from pig manure treated by combustion and thermal gasification was characterized and compared in terms of nutrient, i.e., potassium (K), phosphorus (P) and heavy metal, i.e., cadmium (Cd), chromium (Cr), copper (Cu), nickel (Ni) and zinc (Zn) contents. Total nutrient and metal concentrations...... that ash from gasified manure contained more water-extractable K in comparison with combusted manure whereas the opposite was the case with respect to P. Heavy metals Ni, Cr and Cd were present in higher concentrations in the fine particle size fractions (

Effect of pig manure on nutrient composition, growth and yield of Okra

African Journals Online (AJOL)

Five rates of manure, 0,2.5,5.0,7.5, and 10.0t/ha and NPK (15-15-15) fertilizer } at 200kg/ha were compared as to their effects on leaf nutrient composition, growth and pod yield of okra. Pig manure increased okra leaf nutrient N,P,K Ca and Mg contents, and the nutrients increased with application of manure. NPK fertilizer ...

Enhanced biogas production from anaerobic co-digestion of pig slurry and horse manure with mechanical pre-treatment.

Science.gov (United States)

Lopes, Madalena; Baptista, Patrícia; Duarte, Elizabeth; Moreira, António L N

2018-01-02

Enhanced biogas production from anaerobic co-digestion of pig slurry and horse manure with mechanical pre-treatment. In this study, co-digestion of horse manure and pig slurry was investigated in a continuously stirred tank reactor, with a mechanical pre-treatment. Experiments were conducted at 37°C, with hydraulic retention times of 23 days and increasing shares of horse manure, corresponding to different horse manure to pig slurry ratios (HM:PS) equal to 0:100, 10:90, 13:87 and 20:80, in terms of percentage of inlet volatile solids (%VS inlet). The results show that the best synergetic effect between the microbial consortia of pig slurry and the high Carbon to Nitrogen ratio (C/N) of horse manure is obtained for the mixture of 20:80%VS inlet, yielding the highest specific methane production (SMP = 142.6 L kg TCOD -1 ) and the highest soluble chemical oxygen demand (SCOD) reduction (68.5%), due to the high volatile dissolved solids content and soluble chemical oxygen demand to total chemical oxygen demand ratio (SCOD/TCOD). Thus, co-digestion of horse manure and pig slurry is shown to be a promising approach for biogas production and as a waste treatment solution. Furthermore, the analysis provides a methodology for the pre-treatment of these substrates and to investigate into the best combination for improved biogas production.

Sustainable Treatment and Reuse of Diluted Pig Manure Streams in Russia: From Laboratory Trials to Full-Scale Implementation

NARCIS (Netherlands)

Kalyuzhnyi, S.; Sklyar, V.; Epov, A.; Arkhipchenko, I.; Barboulina, I.; Orlova, O.; Kovalev, A.; Nozhevnikova, A.; Klapwijk, A.

2003-01-01

This article summarizes the results obtained during the laboratory and pilot development of integrated biologic and physicochemical treatment and reuse of diluted pig manure streams. The application of a straw filter was an effective means to separate the solid and liquid fractions of raw wastewater

Impacts of delayed addition of N-rich and acidic substrates on nitrogen loss and compost quality during pig manure composting.

Science.gov (United States)

Jiang, Jishao; Kang, Kang; Chen, Dan; Liu, Ningning

2018-02-01

Delayed addition of Nitrogen (N)-rich and acidic substrates was investigated to evaluate its effects on N loss and compost quality during the composting process. Three different delayed adding methods of N-rich (pig manure) and acidic substrates (phosphate fertilizer and rotten apples) were tested during the pig manure and wheat straw is composting. The results showed that delayed addition of pig manure and acidic materials led two temperature peaks, and the durations of two separate thermophilic phase were closely related to the amount of pig manure. Delayed addition reduced total N loss by up to 14% when using superphosphate as acidic substrates, and by up to 12% when using rotten apples as acidic substrates, which is mainly due to the decreased NH 3 emissions. At the end of composting, delayed the addition of pig manure caused a significant increase in the HS (humus substance) content, and the highest HS content was observed when 70% of the pig manure was applied at day 0 and the remaining 30% was applied on day 27. In the final compost, the GI in all treatments almost reached the maturity requirement by exceeding 80%. The results suggest that delayed addition of animal manure and acidic substrates could prevent the N loss during composting and improve the compost quality. Copyright © 2017 Elsevier Ltd. All rights reserved.

Diversity of the Tetracycline Mobilome within a Chinese Pig Manure Sample.

Science.gov (United States)

Leclercq, Sébastien Olivier; Wang, Chao; Zhu, Yaxin; Wu, Hai; Du, Xiaochen; Liu, Zhipei; Feng, Jie

2016-11-01

Tetracycline antibiotics are widely used in livestock, and tetracycline resistance genes (TRG) are frequently reported in the manure of farmed animals. However, the diversity of TRG-carrying transposons in manure has still been rarely investigated. Using a culture-free functional metagenomic procedure, combined with large-insert library construction and sequencing, bioinformatic analyses, and functional experiments, we identified 17 distinct TRGs in a single pig manure sample, including two new tet genes: tet(59), encoding a tetracycline efflux pump, and tet(W/N/W), encoding mosaic ribosomal protection. Our study also revealed six new TRG-carrying putative nonconjugative transposons: Tn5706-like transposon Tn6298, IS200/605-related transposon Tn6303, Tn3 family transposon Tn6299, and three ISCR2-related transposons, Tn62300, Tn62301, and Tn62302 IMPORTANCE: Fertilization of agricultural fields with animal manure is believed to play a major role in antibiotic resistance dissemination in the environment. There is growing concern for the possible spread of antibiotic resistance from the environment to humans since genetic resistance determinants may be located in transposons and other mobile genetic elements potentially transferable to pathogens. Among the various antibiotic resistance genes found in manure, tetracycline resistance genes (TRGs) are some of the most common. The present study provides a detailed snapshot of the tetracycline mobilome in a single pig manure sample, revealing an unappreciated diversity of TRGs and potential TRG mobility vectors. Our precise identification of the TRG-carrying units will enable us to investigate in more details their mobility effectiveness. Copyright © 2016, American Society for Microbiology. All Rights Reserved.

Passively Aerated Composting of Straw-Rich Organic Pig Manure

NARCIS (Netherlands)

Veeken, A.H.M.; Wilde, de V.; Szanto, G.; Hamelers, H.V.M.

2002-01-01

In this study pig manure from organic farming systems is composted with passive aeration. Effectiveness of the composting process strongly depended on the density of the compost. Best results were observed at a density of 700 kg/m3, where both aerobic degradation and drying were adequate and

Pig Manure Contamination Marker Selection Based on the Influence of Biological Treatment on the Dominant Fecal Microbial Groups▿

Science.gov (United States)

Marti, Romain; Dabert, Patrick; Pourcher, Anne-Marie

2009-01-01

The objective of this study was to identify a microbial marker for pig manure contamination. We quantified the persistence of four dominant bacterial groups from the pig intestinal tract throughout manure handling at 10 livestock operations (including aerobic digestion) by using molecular typing. The partial 16S rRNA genes of Bacteroides-Prevotella, Eubacterium-Clostridiaceae, Bacillus-Streptococcus-Lactobacillus (BSL), and Bifidobacterium group isolates were amplified and analyzed by capillary electrophoresis single-strand conformation polymorphism. The most dominant bacterial populations were identified by cloning and sequencing their 16S rRNA genes. The results showed that Bifidobacterium spp. and, to a lesser extent, members of the BSL group, were less affected by the aerobic treatment than either Eubacterium-Clostridiaceae or Bacteroides-Prevotella. Two Bifidobacterium species found in raw manure were still present in manure during land application, suggesting that they can survive outside the pig intestinal tract and also survive aerobic treatment. The 16S-23S rRNA internal transcribed spacer of one species, Bifidobacterium thermacidophilum subsp. porcinum, was sequenced, and a specific pair of primers was designed for its detection in the environment. With this nested PCR assay, this potential marker was not detected in samples from 30 bovine, 30 poultry, and 28 human fecal samples or in 15 urban wastewater effluents. As it was detected in runoff waters after spreading of pig manure, we propose this marker as a suitable microbial indicator of pig manure contamination. PMID:19525269

Pig manure contamination marker selection based on the influence of biological treatment on the dominant fecal microbial groups.

Science.gov (United States)

Marti, Romain; Dabert, Patrick; Pourcher, Anne-Marie

2009-08-01

The objective of this study was to identify a microbial marker for pig manure contamination. We quantified the persistence of four dominant bacterial groups from the pig intestinal tract throughout manure handling at 10 livestock operations (including aerobic digestion) by using molecular typing. The partial 16S rRNA genes of Bacteroides-Prevotella, Eubacterium-Clostridiaceae, Bacillus-Streptococcus-Lactobacillus (BSL), and Bifidobacterium group isolates were amplified and analyzed by capillary electrophoresis single-strand conformation polymorphism. The most dominant bacterial populations were identified by cloning and sequencing their 16S rRNA genes. The results showed that Bifidobacterium spp. and, to a lesser extent, members of the BSL group, were less affected by the aerobic treatment than either Eubacterium-Clostridiaceae or Bacteroides-Prevotella. Two Bifidobacterium species found in raw manure were still present in manure during land application, suggesting that they can survive outside the pig intestinal tract and also survive aerobic treatment. The 16S-23S rRNA internal transcribed spacer of one species, Bifidobacterium thermacidophilum subsp. porcinum, was sequenced, and a specific pair of primers was designed for its detection in the environment. With this nested PCR assay, this potential marker was not detected in samples from 30 bovine, 30 poultry, and 28 human fecal samples or in 15 urban wastewater effluents. As it was detected in runoff waters after spreading of pig manure, we propose this marker as a suitable microbial indicator of pig manure contamination.

Life cycle assessment of manure management and nutrient recycling from a Chinese pig farm.

Science.gov (United States)

Luo, Yiming; Stichnothe, Heinz; Schuchardt, Frank; Li, Guoxue; Huaitalla, Roxana Mendoza; Xu, Wen

2014-01-01

Driven by the growing numbers of intensified pig farms around cities in China, there are problems of nutrient surplus and shortage of arable land for utilising the manure. Hence, sustainable livestock systems with effective manure management are needed. The objective of this study is to compare the existing manure treatment of a typical pig farm in Beijing area (separate collection of faeces; 'Gan qing fen' system) with an alternative system and to identify the nutrients flow of the whole farm in order to quantify environmental burdens and to estimate the arable land required for sustainable nutrients recycling. Life cycle assessment is used for this purpose. Acidification potential (AP), eutrophication potential (EP) and global warming potential (GWP) are analysed in detail; the functional unit is the annual production of the pig farm. The results show that the cropland area demand for sustainable land application of the effluent can be reduced from 238 to 139 ha with the alternative system. It is possible to transfer 29% of total nitrogen, 87% of phosphorus, 34% of potassium and 75% of magnesium to the compost, and to reduce the total AP, EP and GWP of manure management on the farm by 64.1%, 96.7% and 22%, respectively, compared with the current system. Besides an effective manure management system, a full inventory of the regional nutrients flow is needed for sustainable development of livestock systems around big cities in China.

Anaerobic digestion characteristics of pig manures depending on various growth stages and initial substrate concentrations in a scaled pig farm in Southern China.

Science.gov (United States)

Zhang, Wanqin; Lang, Qianqian; Wu, Shubiao; Li, Wei; Bah, Hamidou; Dong, Renjie

2014-03-01

The characteristics of anaerobic digestion of pig manure from different growth stages were investigated. According to growth stage, batch experiments were performed using gestating sow manure (GSM), swine nursery with post-weaned piglet manure (SNM), growing fattening manure (GFM) and mixed manure (MM) as substrates at four substrate concentrations (40, 50, 65 and 80gVS/L) under mesophilic conditions. The maximum methane yields of MM, SNM, GSM and GFM were 354.7, 328.7, 282.4 and 263.5mLCH4/gVSadded, respectively. Volatile fatty acids/total inorganic carbon (VFA/TIC) ratio increased from 0.10 to 0.89 when loading increased from 40 to 80gVS/L for GFM. The modified Gompertz model shows a better fit to the experimental results than the first order model with a lower difference between measured and predicted methane yields. The kinetic parameters indicated that the methane production curve on the basis of differences in biodegradability of the pig manure at different growth stages. Copyright © 2014 Elsevier Ltd. All rights reserved.

Effect of pig manure on the chemical composition and microbial diversity during co-composting with spent mushroom substrate and rice husks.

Science.gov (United States)

Meng, Xingyao; Liu, Bin; Xi, Chen; Luo, Xiaosha; Yuan, Xufeng; Wang, Xiaofen; Zhu, Wanbin; Wang, Hongliang; Cui, Zongjun

2018-03-01

In this study, the impact of pig manure on the maturity of compost consisting of spent mushroom substrate and rice husks was accessed. The results showed that the addition of pig manure (SMS-PM) reached 50°C 5days earlier and lasted 15days longer than without pig manure (SMS). Furthermore, the addition of pig manure improved nutrition and germination index. High-throughput 16S rRNA pyrosequencing was used to evaluate the bacterial and fungal composition during the composting process of SMS-PM compared to SMS alone. The SMS treatment showed a relatively higher abundance of carbon-degrading microbes (Bacillaceae and Thermomyces) and plant pathogenic fungi (Sordariomycetes_unclassified) at the end of the compost. In contrast, the SMS-PM showed an increased bacterial diversity with anti-pathogen (Pseudomonas). The results indicated that the addition of pig manure improved the decomposition of refractory carbon from the spent mushroom substrate and promoted the maturity and nutritional content of the compost product. Copyright © 2017. Published by Elsevier Ltd.

Perspectives for manure digestion in Dutch dairy cow and pig farms

International Nuclear Information System (INIS)

Van Dooren, H.J.C.; Van Lent, A.J.H.

2001-01-01

At the Research Institute for Animal Husbandry (PV) a desk study has been conducted on the feasibility of anaerobic manure digestion for individual Dutch dairy and pig farms, based on data from the literature, from internet and from contacting experts in the Netherlands and abroad. PV carried out a preliminary study back in 1997, during which a model was developed for calculating the economic impact of manure digestion for various farm scenarios. In the latest study new information was incorporated into the model. The improved model can do calculations for pig farms and can calculate environmental impacts. The calculations assume the total energy from biogas produced by the digestion is used to generate electricity. The investment in the unit must be recouped from the savings made on purchasing electricity and natural gas, and by supplying electricity to the grid [nl

Pilot project of biogas production from pig manure and urine mixture at ambient temperature in Ventanilla (Lima, Peru)

International Nuclear Information System (INIS)

Ferrer, I.; Gamiz, M.; Almeida, M.; Ruiz, A.

2009-01-01

Parque Porcino de Ventanilla has an extension of 840 ha with 2200 farmers dedicated to pig production. There is a lack of services in the area (i.e., water supply, electricity, or waste collection). Anaerobic treatment of pig manure would replace current dumping and incineration, reducing environmental pollution and hazards to public health, as well as providing an organic fertilizer and biogas. The objective of the present work was to study the viability of ambient temperature anaerobic digestion of pig manure diluted in urine, by means of on-site pilot scale reactors. The final goal was to establish design parameters for anaerobic digesters to be implemented; since it was part of a project to improve life conditions for the farmers through the incorporation of better management techniques. Experiments were carried out in a low-cost pilot plant, which consists of three anaerobic digesters (225 L total volume), without heating or agitation, placed in a greenhouse. The start-up of the digestion process was performed with a mixture of temperature adapted pig manure-sludge and fresh rumen, and showed a good performance regardless of the dilution of pig manure with water or urine, which is a key parameter due to the scarcity of water in the area under study

Pilot project of biogas production from pig manure and urine mixture at ambient temperature in Ventanilla (Lima, Peru).

Science.gov (United States)

Ferrer, I; Gamiz, M; Almeida, M; Ruiz, A

2009-01-01

Parque Porcino de Ventanilla has an extension of 840ha with 2200 farmers dedicated to pig production. There is a lack of services in the area (i.e., water supply, electricity, or waste collection). Anaerobic treatment of pig manure would replace current dumping and incineration, reducing environmental pollution and hazards to public health, as well as providing an organic fertilizer and biogas. The objective of the present work was to study the viability of ambient temperature anaerobic digestion of pig manure diluted in urine, by means of on-site pilot scale reactors. The final goal was to establish design parameters for anaerobic digesters to be implemented; since it was part of a project to improve life conditions for the farmers through the incorporation of better management techniques. Experiments were carried out in a low-cost pilot plant, which consists of three anaerobic digesters (225L total volume), without heating or agitation, placed in a greenhouse. The start-up of the digestion process was performed with a mixture of temperature adapted pig manure-sludge and fresh rumen, and showed a good performance regardless of the dilution of pig manure with water or urine, which is a key parameter due to the scarcity of water in the area under study.

Evaluation of degradation of antibiotic tetracycline in pig manure by electron beam irradiation.

Science.gov (United States)

Cho, Jae-Young

2010-04-01

This study was carried out to evaluate the degradation efficiency and intermediate products of the tetracycline from artificially contaminated pig manure using of electron beam irradiation as a function of the absorbed dose. The degradation efficiency of tetracycline was 42.77% at 1 kGy, 64.20% at 3 kGy, 77.83% at 5 kGy, and 90.50% at 10 kGy. The initial concentration of tetracycline (300 mg kg(-1)) in pig manure decreased significantly to 24.2 +/- 5.3 mg kg(-1) after electron beam irradiation at 10 kGy. The radiolytic degradation products of tetracycline were 1,4-benzenedicarboxylic acid, hexadecanoic acid, 9-octadecenamide, 11-octadecenamide, and octadecanoic acid.

Effect of composting on the thermal decomposition behavior and kinetic parameters of pig manure-derived solid waste.

Science.gov (United States)

Dhyani, Vaibhav; Kumar Awasthi, Mukesh; Wang, Quan; Kumar, Jitendra; Ren, Xiuna; Zhao, Junchao; Chen, Hongyu; Wang, Meijing; Bhaskar, Thallada; Zhang, Zengqiang

2018-03-01

In this work, the influence of composting on the thermal decomposition behavior and decomposition kinetics of pig manure-derived solid wastes was analyzed using thermogravimetry. Wheat straw, biochar, zeolite, and wood vinegar were added to pig manure during composting. The composting was done in the 130 L PVC reactors with 100 L effective volume for 50 days. The activation energy of pyrolysis of samples before and after composting was calculated using Friedman's method, while the pre-exponential factor was calculated using Kissinger's equation. It was observed that composting decreased the volatile content of all the samples. The additives when added together in pig manure lead to a reduction in the activation energy of decomposition, advocating the presence of simpler compounds in the compost material in comparison with the complex feedstock. Copyright © 2017 Elsevier Ltd. All rights reserved.

Improved biogas production from rice straw by co-digestion with kitchen waste and pig manure

Energy Technology Data Exchange (ETDEWEB)

Ye, Jingqing [Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640 (China); School of Environmental Sciences and Engineering, Sun Yat-sen University, Guangzhou 510275 (China); Li, Dong; Sun, Yongming [Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640 (China); Wang, Guohui [School of Environmental Sciences and Engineering, Sun Yat-sen University, Guangzhou 510275 (China); Yuan, Zhenhong, E-mail: yuanzh@ms.giec.ac.cn [Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640 (China); Zhen, Feng; Wang, Yao [Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640 (China)

2013-12-15

Highlights: • Biogas production was enhanced by co-digestion of rice straw with other materials. • The optimal ratio of kitchen waste, pig manure and rice straw is 0.4:1.6:1. • The maximum biogas yield of 674.4 L/kg VS was obtained. • VFA inhibition occurred when kitchen waste content was more than 26%. • The dominant VFA were propionate and acetate in successful reactors. - Abstract: In order to investigate the effect of feedstock ratios in biogas production, anaerobic co-digestions of rice straw with kitchen waste and pig manure were carried out. A series of single-stage batch mesophilic (37 ± 1 °C) anaerobic digestions were performed at a substrate concentration of 54 g/L based on volatile solids (VS). The results showed that the optimal ratio of kitchen waste, pig manure, and rice straw was 0.4:1.6:1, for which the C/N ratio was 21.7. The methane content was 45.9–70.0% and rate of VS reduction was 55.8%. The biogas yield of 674.4 L/kg VS was higher than that of the digestion of rice straw or pig manure alone by 71.67% and 10.41%, respectively. Inhibition of biogas production by volatile fatty acids (VFA) occurred when the addition of kitchen waste was greater than 26%. The VFA analysis showed that, in the reactors that successfully produced biogas, the dominant intermediate metabolites were propionate and acetate, while they were lactic acid, acetate, and propionate in the others.

Improved biogas production from rice straw by co-digestion with kitchen waste and pig manure

International Nuclear Information System (INIS)

Ye, Jingqing; Li, Dong; Sun, Yongming; Wang, Guohui; Yuan, Zhenhong; Zhen, Feng; Wang, Yao

2013-01-01

Highlights: • Biogas production was enhanced by co-digestion of rice straw with other materials. • The optimal ratio of kitchen waste, pig manure and rice straw is 0.4:1.6:1. • The maximum biogas yield of 674.4 L/kg VS was obtained. • VFA inhibition occurred when kitchen waste content was more than 26%. • The dominant VFA were propionate and acetate in successful reactors. - Abstract: In order to investigate the effect of feedstock ratios in biogas production, anaerobic co-digestions of rice straw with kitchen waste and pig manure were carried out. A series of single-stage batch mesophilic (37 ± 1 °C) anaerobic digestions were performed at a substrate concentration of 54 g/L based on volatile solids (VS). The results showed that the optimal ratio of kitchen waste, pig manure, and rice straw was 0.4:1.6:1, for which the C/N ratio was 21.7. The methane content was 45.9–70.0% and rate of VS reduction was 55.8%. The biogas yield of 674.4 L/kg VS was higher than that of the digestion of rice straw or pig manure alone by 71.67% and 10.41%, respectively. Inhibition of biogas production by volatile fatty acids (VFA) occurred when the addition of kitchen waste was greater than 26%. The VFA analysis showed that, in the reactors that successfully produced biogas, the dominant intermediate metabolites were propionate and acetate, while they were lactic acid, acetate, and propionate in the others

Influence of pig manure biochar mineral content on Cr(III) sorption capacity

DEFF Research Database (Denmark)

Wnetrzak, Renata; Leahy, J.J.; Chojnacka, Katarzyna W.

2014-01-01

BACKGROUND: The adsorption of Cr(III) ions on various pig manure biochar (BC) samples was investigated to determine the effect of operating conditions (initial pH, sorbate and sorbent concentrations) on sorptive capacity. The BC samples with higher sorption capacity showed high surface area...

Hygienic aspects of livestock manure management and biogas systems operated by small-scale pig farmers in Vietnam

DEFF Research Database (Denmark)

Luu, Huong Quynh; Madsen, Henry; Anh, Le Xuan

2014-01-01

Biogas digesters are widely promoted and increasingly used to treat and generate gas from pig slurry worldwide. The objective of this study was to describe manure management practices with focus on biogas digestion among small scale pig farmers in Hue (50 farmers) and Hanoi (96 farmers) and to as......Biogas digesters are widely promoted and increasingly used to treat and generate gas from pig slurry worldwide. The objective of this study was to describe manure management practices with focus on biogas digestion among small scale pig farmers in Hue (50 farmers) and Hanoi (96 farmers......) and to assess fecal contamination levels in biogas effluent. Results showed that 84% of the farmers in Hanoi and 42% in Hue used both pig slurry and human excreta for biogas production. Biogas digestion only reduced E. coli concentrations by 1 to 2 log units to 3.70±0.84 Escherichia coli (log) cfu/ml on average...

Housefly maggot-treated composting as sustainable option for pig manure management.

Science.gov (United States)

Zhu, Feng-Xiang; Yao, Yan-Lai; Wang, Su-Juan; Du, Rong-Guang; Wang, Wei-Ping; Chen, Xiao-Yang; Hong, Chun-Lai; Qi, Bing; Xue, Zhi-Yong; Yang, Hong-Quan

2015-01-01

In traditional composting, large amounts of bulking agents must be added to reduce the moisture of pig manure, which increases the cost of composting and dilutes the N, P and K content in organic fertilizers. In this study, maggot treatment was used in composting instead of bulking agents. In experiment of selecting an optimal inoculum level for composting, the treatment of 0.5% maggot inoculum resulted in the maximum yield of late instar maggots, 11.6% (maggots weight/manure weight). The manure residue became noticeably granular by day 6 and its moisture content was below 60%, which was suitable for further composting without bulking agents. Moreover, in composting experiment with a natural compost without maggot inoculum and maggot-treated compost at 0.5% inoculum level, there were no significant differences in nutrient content between the two organic fertilizers from the two treatments (paired Student's t15=1.0032, P=0.3317). Therefore, maggot culturing did not affect the characteristics of the organic fertilizer. The content of TNPK (total nitrogen+total phosphorus+total potassium) in organic fertilizer from maggot treatment was 10.72% (dry weight), which was far more than that of organic fertilizer made by conventional composting with bulking agents (about 8.0%). Dried maggots as feed meet the national standard (GB/T19164-2003) for commercial fish meal in China, which contained 55.32 ± 1.09% protein; 1.34 ± 0.02% methionine; 4.15 ± 0.10% lysine. This study highlights housefly maggot-treated composting can be considered sustainable alternatives for pig manure management to achieve high-quality organic fertilizer and maggots as feed without bulking agents. Copyright © 2014 Elsevier Ltd. All rights reserved.

Anaerobic co-digestion of cyanide containing cassava pulp with pig manure.

Science.gov (United States)

Glanpracha, Naraporn; Annachhatre, Ajit P

2016-08-01

Anaerobic co-digestion of cyanide-containing cassava pulp with pig manure was evaluated using laboratory scale mesophilic digester. The digester was operated in a semi-continuous mode with the mixed feedstock having C/N ratio of 35:1. Digester startup was accomplished in 60days with loading of 0.5-1kgVS/m(3)d. Subsequently, the loading to digester was increased step-wise from 2 to 9kgVS/m(3)d. Digester performance was stable at loading between 2 and 6kgVS/m(3)d with an average volatile solid removal and methane yield of 82% and 0.38m(3)/kgVSadded, respectively. However, beyond loading of 7kgVS/m(3)d, solubilization of particulate matter did not take place efficiently. Cyanide present in cassava pulp was successfully degraded indicating that anaerobic sludge in the digester was well acclimatized to cyanide. The results show that cassava pulp can be successfully digested anaerobically with pig manure as co-substrate without any inhibitory effect of cyanide present in the cassava pulp. Copyright © 2016 Elsevier Ltd. All rights reserved.

Fouling mitigation in membrane distillation processes during ammonia stripping from pig manure

DEFF Research Database (Denmark)

Zarebska, Agata; Amor, Angel Cid; Ciurkot, Klaudia

2015-01-01

Over time fouling leads to membrane wetting. This is the biggest obstacle to widespread use of membrane distillation (MD) for ammonia removal from animal slurry. Feed pretreatment and cleaning strategies of membrane surfaces are the most common methods to prevent or diminish fouling phenomena....... This study investigates preliminary fouling of polypropylene (PP) and polytetrafluoroethylene (PTFE) membranes. A model manure solution was used as feed. In addition cleaning efficiencies with deionized water, NaOH/citric acid, and Novadan agents were studied. Further microfiltration and ultrafiltration were...... examined as manure pretreatment to diminish fouling. To this end polyvinylidene fluoride membranes (PVDF 0.2 µm and 150 kDa respectively) were used. Organic fouling was shown to be dominant. For the model manure solution the fouling comprised lipids, carbohydrates and proteins. For pig slurry the fouling...

Effect of turning frequency on co-composting pig manure and fungus residue.

Science.gov (United States)

Jiang-Ming, Zhou

2017-03-01

Composting of agricultural wastes not only can reduce environmental pollution caused by improper disposal, but also can recycle agricultural wastes and transform them into highly valuable products, such as fertilizers or soil conditioners, for agricultural applications. However, the composting process and final product are easily affected by the limited oxygen supply that results from insufficient aeration, especially in the center of a large-scale windrow. Hence, a pilot-scale experiment was conducted to investigate the effects of the turning frequency on the composting efficiency and compost quality of used pig manure and fungus residue. Physical and chemical characteristics were measured over the course of 63 days of composting. The data indicate that higher temperatures and more rapid moisture removal generally result from a turning treatment of once every 2-4 days than in fewer, or no, turning treatments. The total nitrogen, total phosphorus, and total potassium contents increased in all windrows as the organic matter content decreased, but both the increases and decrease were greater in windrows that were turned more frequently. The reduction of the organic matter mass by 53.7-66.0% for a turning of once every 2-8 days is significantly higher than that for the static windrow (39.1%). Although there is an increase in nitrogen mass loss with an increased turning frequency, lower nitrogen mass losses (12.7-25.7%) in all treatments were noted compared with previous studies. A final compost product with less moisture, less weight, higher nutrient content (N, P, and K), and greater stability was obtained in windrows with turning frequencies of once every 2-4 days, which is recommended when composting pig manure and fungus residue. Composting of agricultural wastes not only can reduce environmental pollution caused by improper disposal, but recycling of agricultural wastes transforms them into highly valuable products, such as fertilizers or soil conditioners, for

Methane content and potential of biogas' production by manure of pigs fed with corn or sorghum-based diets in different phases

Energy Technology Data Exchange (ETDEWEB)

Miranda, Adelia Pereira; Lucas Junior, Jorge de; Thomaz, Maria Cristina; Fukayama, Ellen Hatsumi [Universidade Estadual Paulista (UNESP), Jaboticabal, SP (Brazil)

2008-07-01

The aim of this trial was to value the methane content and potential of biogas' production by manure of pigs fed with corn or sorghum-based diets (energy's source) in different phases. The manures were daily collected, diluted in water and homogeneous. Were used 267 mL of influent with 6% total solids concentration for supply of continuous-flow laboratory anaerobic digesters, with 30 days of detention time (DT) and temperature of 35 deg C. The experiment was completely randomized design with 2 treatments (corn or sorghum) and 3 phases of growth (initial x growing x finishing) in 10 replications (anaerobic digesters). The methane contents by manure of pigs fed with corn were greater (p<0.01) than pigs fed with sorghum (65.19 and 67.32%) on the phases of growing and finishing, respectively. The most potential of biogas' production (0.181, 0.138 and 0.162 m{sup 3}/kg of manure) was with manure of pigs fed with corn on the phases of initial, growing and finishing, respectively (p<0.01). Considering all the phases, the most potential of biogas' production (p<0.01) was observed in the initial phase, in both treatments. (author)

Increased Abundance and Transferability of Resistance Genes after Field Application of Manure from Sulfadiazine-Treated Pigs

Science.gov (United States)

Jechalke, Sven; Kopmann, Christoph; Rosendahl, Ingrid; Groeneweg, Joost; Weichelt, Viola; Krögerrecklenfort, Ellen; Brandes, Nikola; Nordwig, Mathias; Ding, Guo-Chun; Siemens, Jan; Heuer, Holger

2013-01-01

Spreading manure containing antibiotics in agriculture is assumed to stimulate the dissemination of antibiotic resistance in soil bacterial populations. Plant roots influencing the soil environment and its microflora by exudation of growth substrates might considerably increase this effect. In this study, the effects of manure from pigs treated with sulfadiazine (SDZ), here called SDZ manure, on the abundance and transferability of sulfonamide resistance genes sul1 and sul2 in the rhizosphere of maize and grass were compared to the effects in bulk soil in a field experiment. In plots that repeatedly received SDZ manure, a significantly higher abundance of both sul genes was detected compared to that in plots where manure from untreated pigs was applied. Significantly lower abundances of sul genes relative to bacterial ribosomal genes were encountered in the rhizosphere than in bulk soil. However, in contrast to results for bulk soil, the sul gene abundance in the SDZ manure-treated rhizosphere constantly deviated from control treatments over a period of 6 weeks after manuring, suggesting ongoing antibiotic selection over this period. Transferability of sulfonamide resistance was analyzed by capturing resistance plasmids from soil communities into Escherichia coli. Increased rates of plasmid capture were observed in samples from SDZ manure-treated bulk soil and the rhizosphere of maize and grass. More than 97% of the captured plasmids belonged to the LowGC type (having low G+C content), giving further evidence for their important contribution to the environmental spread of antibiotic resistance. In conclusion, differences between bulk soil and rhizosphere need to be considered when assessing the risks associated with the spreading of antibiotic resistance. PMID:23315733

Passively Aerated Composting of Straw-Rich Pig Manure : Effect of Compost Bed Porosity

NARCIS (Netherlands)

Veeken, A.H.M.; Wilde, de V.; Hamelers, H.V.M.

2002-01-01

Straw-rich manure from organic pig farming systems can be composted in passively aerated systems as the high application of straw results in a compost bed with good structure and porosity. The passively aerated composting process was simulated in one-dimensional reactors of 2 m3 for straw-rich

Comparison of bacterial community structure and dynamics during the thermophilic composting of different types of solid wastes: anaerobic digestion residue, pig manure and chicken manure

OpenAIRE

Song, Caihong; Li, Mingxiao; Jia, Xuan; Wei, Zimin; Zhao, Yue; Xi, Beidou; Zhu, Chaowei; Liu, Dongming

2015-01-01

This study investigated the impact of composting substrate types on the bacterial community structure and dynamics during composting processes. To this end, pig manure (PM), chicken manure (CM), a mixture of PM and CM (PM + CM), and a mixture of PM, CM and anaerobic digestion residue (ADR) (PM + CM + ADR) were selected for thermophilic composting. The bacterial community structure and dynamics during the composting process were detected and analysed by polymerase chain reaction–denaturing gra...

Efficient Air Desulfurization Catalysts Derived from Pig Manure Liquefaction Char

Directory of Open Access Journals (Sweden)

Rajiv Wallace

2017-11-01

Full Text Available Biochar from the liquefaction of pig manure was used as a precursor of H2S desulfurization adsorbents. In its inorganic matter, it contains marked quantities of calcium, magnesium and iron, which are known as hydrogen sulfide oxidation catalysts. The char was used either as-received or mixed with 10% nanographite. The latter was added to increase both the content of the carbon phase and conductivity. ZnCl2 in two different ratios of char to an activation agent (1:1 and 1:2 was used to create the porosity in the carbon phase. The content of the later was between 18–45%. The activated samples adsorbed 144 mg/g H2S. Sulfur was the predominant product of reactive adsorption. Its deposition in the pore system and blockage of the most active pores ceased the materials’ activity. The presence of the catalytic phase was necessary but not sufficient to guarantee good performance. The developed porosity, which can store oxidation products in the resulting composite, is essential for the good performance of the desulfurization process. The surface of the composite with nanographite showed the highest catalytic activity, similar to that of the commercial Midas® carbon catalyst. The results obtained indicate that a high quality reactive adsorbent/catalyst for H2S removal can be obtained from pig manure liquefaction wastes.

Studies on the bactericidal effect of ionizing radiation on pig manure

Energy Technology Data Exchange (ETDEWEB)

Kleiner, U; Trenner, P [Ministerium fuer Land-, Forst- und Nahrungsgueterwirtschaft der DDR, Eberswalde. Inst. fuer Angewandte Tierhygiene

1983-03-01

Pig manure was treated with electrons and gamma rays at radiation doses of 4, 8, 15 and 30 kGy, resp. The mesophile bacteria were significantly reduced by all electron doses, but with repropagation at the 7. post-irradiation day. Gamma radiation at 4 and 8 kGy resulted also in not lasting reduction of mesophile bacteria. 15 kGy caused a significant and persistent elimination of the germs. 15 kGy electron irradiation and 8 kGy gamma irradiation killed the proteolytic bacteria. Euterococci and lactose-splitting bacteria were killed at 4 kGy irradiation of both kinds. Lasting elimination of manure specific germs was reached with 15 kGy ..gamma..-rays and more than 30 kGy electrons, resp. All the treatments are expensive and cannot be recommended.

Heavy metals in liquid pig manure in light of bacterial antimicrobial resistance

Energy Technology Data Exchange (ETDEWEB)

Hoelzel, Christina S., E-mail: Christina.Hoelzel@wzw.tum.de [Chair of Animal Hygiene, Technische Universitaet Muenchen, Weihenstephaner Berg 3, 85354 Freising (Germany); Mueller, Christa [Institute for Agroecology, Organic Farming and Soil Protection, Bavarian State Research Center for Agriculture (LfL), Lange Point 12, 85354 Freising (Germany); Harms, Katrin S. [Chair of Animal Hygiene, Technische Universitaet Muenchen, Weihenstephaner Berg 3, 85354 Freising (Germany); Mikolajewski, Sabine [Department for Quality Assurance and Analytics, Bavarian State Research Center for Agriculture (LfL), Lange Point 4, 85354 Freising (Germany); Schaefer, Stefanie; Schwaiger, Karin; Bauer, Johann [Chair of Animal Hygiene, Technische Universitaet Muenchen, Weihenstephaner Berg 3, 85354 Freising (Germany)

2012-02-15

Heavy metals are regularly found in liquid pig manure, and might interact with bacterial antimicrobial resistance. Concentrations of heavy metals were determined by atomic spectroscopic methods in 305 pig manure samples and were connected to the phenotypic resistance of Escherichia coli (n=613) against 29 antimicrobial drugs. Concentrations of heavy metals (/kg dry matter) were 0.08-5.30 mg cadmium, 1.1-32.0 mg chrome, 22.4-3387.6 mg copper, <2.0-26.7 mg lead, <0.01-0.11 mg mercury, 3.1-97.3 mg nickel and 93.0-8239.0 mg zinc. Associated with the detection of copper and zinc, resistance rates against {beta}-lactams were significantly elevated. By contrast, the presence of mercury was significantly associated with low antimicrobial resistance rates of Escherichia coli against {beta}-lactams, aminoglycosides and other antibiotics. Effects of subinhibitory concentrations of mercury on bacterial resistance against penicillins, cephalosporins, aminoglycosides and doxycycline were also demonstrated in a laboratory trial. Antimicrobial resistance in the porcine microflora might be increased by copper and zinc. By contrast, the occurrence of mercury in the environment might, due to co-toxicity, act counter-selective against antimicrobial resistant strains.

Dynamics of copper and tetracyclines during composting of water hyacinth biomass amended with peat or pig manure.

Science.gov (United States)

Lu, Xin; Liu, Lizhu; Fan, Ruqin; Luo, Jia; Yan, Shaohua; Rengel, Zed; Zhang, Zhenhua

2017-10-01

Composting is one of the post-treatment methods for phytoremediation plants. Due to a high potential of water hyacinth to accumulate pollutants, the physicochemical parameters, microbial activity as well as fates of copper (Cu) and tetracyclines (TCs) were investigated for the different amended water hyacinth biomass harvested from intensive livestock and poultry wastewater, including unamended water hyacinth (W), water hyacinth amended with peat (WP), and water hyacinth amended with pig manure (WPM) during the composting process. Pig manure application accelerated the composting process as evidenced by an increase of temperature, electrical conductivity (EC), NH 4 -N, as well as functional diversity of microbial communities compared to W and WP treatments. Composting process was slowed down by high Cu, but not by TCs. The addition of peat significantly increased the residual fraction of Cu, while pig manure addition increased available Cu concentration in the final compost. Cu could be effectively transformed into low available (oxidizable) and residual fractions after fermentation. In contrast, less than 0.5% of initial concentrations of TCs were determined at the end of 60-day composting for all treatments in the final composts. The dissipation of TCs was accelerated by the high Cu concentration during composting. Therefore, composting is an effective method for the post-treatment and resource utilization of phytoremediation plants containing Cu and/or TCs.

Evaluation of aerobic co-composting of penicillin fermentation fungi residue with pig manure on penicillin degradation, microbial population dynamics and composting maturity.

Science.gov (United States)

Zhang, Zhenhua; Zhao, Juan; Yu, Cigang; Dong, Shanshan; Zhang, Dini; Yu, Ran; Wang, Changyong; Liu, Yan

2015-12-01

Improper treatment of penicillin fermentation fungi residue (PFFR), one of the by-products of penicillin production process, may result in environmental pollution due to the high concentration of penicillin. Aerobic co-composting of PFFR with pig manure was determined to degrade penicillin in PFFR. Results showed that co-composting of PFFR with pig manure can significantly reduce the concentration of penicillin in PFFR, make the PFFR-compost safer as organic fertilizer for soil application. More than 99% of penicillin in PFFR were removed after 7-day composting. PFFR did not affect the composting process and even promote the activity of the microorganisms in the compost. Quantitative PCR (qPCR) indicated that the bacteria and actinomycetes number in the AC samples were 40-80% higher than that in the pig-manure compost (CK) samples in the same composting phases. This research indicated that the aerobic co-composting was a feasible PFFR treatment method. Copyright © 2015 Elsevier Ltd. All rights reserved.

Heavy metals in liquid pig manure in light of bacterial antimicrobial resistance

International Nuclear Information System (INIS)

Hölzel, Christina S.; Müller, Christa; Harms, Katrin S.; Mikolajewski, Sabine; Schäfer, Stefanie; Schwaiger, Karin; Bauer, Johann

2012-01-01

Heavy metals are regularly found in liquid pig manure, and might interact with bacterial antimicrobial resistance. Concentrations of heavy metals were determined by atomic spectroscopic methods in 305 pig manure samples and were connected to the phenotypic resistance of Escherichia coli (n=613) against 29 antimicrobial drugs. Concentrations of heavy metals (/kg dry matter) were 0.08–5.30 mg cadmium, 1.1–32.0 mg chrome, 22.4–3387.6 mg copper, <2.0–26.7 mg lead, <0.01–0.11 mg mercury, 3.1–97.3 mg nickel and 93.0–8239.0 mg zinc. Associated with the detection of copper and zinc, resistance rates against β-lactams were significantly elevated. By contrast, the presence of mercury was significantly associated with low antimicrobial resistance rates of Escherichia coli against β-lactams, aminoglycosides and other antibiotics. Effects of subinhibitory concentrations of mercury on bacterial resistance against penicillins, cephalosporins, aminoglycosides and doxycycline were also demonstrated in a laboratory trial. Antimicrobial resistance in the porcine microflora might be increased by copper and zinc. By contrast, the occurrence of mercury in the environment might, due to co-toxicity, act counter-selective against antimicrobial resistant strains.

A Determination and Comparison of Urease Activity in Feces and Fresh Manure from Pig and Cattle in Relation to Ammonia Production and pH Changes

Science.gov (United States)

Dai, Xiaorong; Karring, Henrik

2014-01-01

Ammonia emission from animal production is a major environmental problem and has impacts on the animal health and working environment inside production houses. Ammonia is formed in manure by the enzymatic degradation of urinary urea and catalyzed by urease that is present in feces. We have determined and compared the urease activity in feces and manure (a urine and feces mixture) from pigs and cattle at 25°C by using Michaelis-Menten kinetics. To obtain accurate estimates of kinetic parameters Vmax and K'm, we used a 5 min reaction time to determine the initial reaction velocities based on total ammoniacal nitrogen (TAN) concentrations. The resulting Vmax value (mmol urea hydrolyzed per kg wet feces per min) was 2.06±0.08 mmol urea/kg/min and 0.80±0.04 mmol urea/kg/min for pig feces and cattle feces, respectively. The K'm values were 32.59±5.65 mmol urea/l and 15.43±2.94 mmol urea/l for pig feces and cattle feces, respectively. Thus, our results reveal that both the Vmax and K'm values of the urease activity for pig feces are more than 2-fold higher than those for cattle feces. The difference in urea hydrolysis rates between animal species is even more significant in fresh manure. The initial velocities of TAN formation are 1.53 mM/min and 0.33 mM/min for pig and cattle manure, respectively. Furthermore, our investigation shows that the maximum urease activity for pig feces occurs at approximately pH 7, and in cattle feces it is closer to pH 8, indicating that the predominant fecal ureolytic bacteria species differ between animal species. We believe that our study contributes to a better understanding of the urea hydrolysis process in manure and provides a basis for more accurate and animal-specific prediction models for urea hydrolysis rates and ammonia concentration in manures and thus can be used to predict ammonia volatilization rates from animal production. PMID:25397404

Overview of manure treatment in France.

Science.gov (United States)

Loyon, L

2017-03-01

Manure treatment becomes a focal issue in relation to current EU and national policies on environmental, climate and renewable energy matters. The objective of this desk study was to collect all available data on the treatment of manure from cattle, pig and poultry farms for an overview of manure treatment in France. Specific surveys in 2008 showed that 12% of pig farms, 11% of poultry farms and 7.5% of cattle farms was concerned by manure treatment. Taken together, the treatment of pig, poultry and cattle manure accounted for 13.6milliontons corresponding to 11.3% of the total annual tonnage (120milliontons). The main processes, mostly applied on the farm, were composting (8.5milliontons), aerobic treatment (2.9milliontons of pig slurry) and anaerobic digestion (1milliontons). Other manure treatments, including physical-chemical treatment, were less frequent (0.4million of m 3 ). Treated manure was mainly used to fertilize the soil and crops on the farm concerned. Manure treatment can thus be considered to be underused in France. However, anaerobic digestion is expected to expand to reach the European target of 20% of energy from renewable sources. Nevertheless, this expansion will depend on overcoming the constraint requiring registration or normalization of the use of the digestate as fertilizer. Thus, to avoid penalizing farmers, the further development or creation of collective processing platforms is recommended, combined with an N recovery process that will enable the production of organic amendments and fertilizers in an easy marketable form. Copyright © 2016 Elsevier Ltd. All rights reserved.

Characterization of manure from conventional and phytase transgenic pigs by advanced solid-state NMR spectroscopy

Science.gov (United States)

Non-point phosphorus (P) pollution from animal manure is becoming a serious global problem. The current solution for the swine industry is including the enzyme phytase as a component of the cereal grain diet. A very real possibility in the future is the production of transgenic pigs that express phy...

Degradation of ampicillin in pig manure slurry and an aqueous ampicillin solution using electron beam irradiation

Science.gov (United States)

Chung, Byung Yeoup; Kim, Jae-Sung; Lee, Min Hee; Lee, Kang Soo; Hwang, Seon Ah; Cho, Jae Young

2009-07-01

This study was carried out to evaluate the efficiency of degradation of antibiotic ampicillin in pig manure slurry and an aqueous ampicillin solution with the use of electron beam irradiation as a function of the absorbed dose. The degradation efficiency of ampicillin was close to 95% at an absorbed dose of 10 kGy. The degradation of ampicillin followed a "first-order" reaction rate with respect to absorbed dose. The results demonstrate that the electron beam irradiation technology is an effective means to remove antibiotics in manure and bodies of water.

Degradation of ampicillin in pig manure slurry and an aqueous ampicillin solution using electron beam irradiation

International Nuclear Information System (INIS)

Chung, Byung Yeoup; Kim, Jae-Sung; Lee, Min Hee; Lee, Kang Soo; Hwang, Seon Ah; Cho, Jae Young

2009-01-01

This study was carried out to evaluate the efficiency of degradation of antibiotic ampicillin in pig manure slurry and an aqueous ampicillin solution with the use of electron beam irradiation as a function of the absorbed dose. The degradation efficiency of ampicillin was close to 95% at an absorbed dose of 10 kGy. The degradation of ampicillin followed a 'first-order' reaction rate with respect to absorbed dose. The results demonstrate that the electron beam irradiation technology is an effective means to remove antibiotics in manure and bodies of water.

Rapid production of maggots as feed supplement and organic fertilizer by the two-stage composting of pig manure.

Science.gov (United States)

Zhu, Feng-Xiang; Wang, Wei-Ping; Hong, Chun-Lai; Feng, Ming-Guang; Xue, Zhi-Yong; Chen, Xiao-Yang; Yao, Yan-Lai; Yu, Man

2012-07-01

A two-stage composting experiment was performed to utilize pig manure for producing maggots as feed supplement and organic fertilizer. Seven-day composting of 1.8 ton fresh manure inoculated with 9 kg mixture of housefly neonates and wheat bran produced 193 kg aging maggots, followed by 12 week composting to maturity. Reaching the thermophilic phase and final maturity faster was characteristic of the maggot-treated compost compared with the same-size natural compost. Upon the transit of the maggot-treated compost to the second stage, the composting temperature maintained around 55 °C for 9 days and the moisture decreased to ~40%. Moreover, higher pH, faster detoxification and different activity patterns for some microbial enzymes were observed. There was a strong material loss (35% water-soluble carbon and 16% total nitrogen) caused by the maggot culture in the first stage. Our results highlight a higher economic value of pig manure achieved through the two-stage composting without bulking agents. Copyright © 2012 Elsevier Ltd. All rights reserved.

Bacterial antibiotic resistance levels in Danish farmland as a result of treatment with pig manure slurry

DEFF Research Database (Denmark)

Sengeløv, Gitte; Agersø, Yvonne; Halling-Sørensen, B.

2003-01-01

Resistance to tetracycline, macrolides and streptomycin was measured for a period of 8 months in soil bacteria obtained from farmland treated with pig manure slurry. This was done by spread plating bacteria on selective media (Luria Bertani (LB) medium supplemented with antibiotics). To account...

Effects of Pig Manure Organic Fertilizer Application on Available Nutrient Content and Soil Aggregate Distribution in Fluvo-aquic Soil

Directory of Open Access Journals (Sweden)

SHI Wen-xuan

2017-08-01

Full Text Available This paper focuses on environmental risk caused by livestock manure disorderly discharged from integrated livestock and poultry industry. 2-year pot experiment was carried out to study the effects of pig manure organic fertilizer on fluvo-aquic soil organic carbon, available nutrient content and soil aggregate distribution, which designed in 5 levels of organic fertilizer application(0, 6.7, 13.3, 26.7, 40.0 g·kg-1 soil. The results showed that the organic carbon, alkali-hydrolyzable nitrogen, available P and available K contents in soil were enhanced with organic fertilizer application increasing, and the indicators of soil were increased significantly in second year, such as organic carbon content was 2.7%~54.0% higher than that of the first year, alkali-hydrolyzable nitrogen content was higher 6.7%~34.6%, available P content was higher 36.8%~159.5% and available K content was higher 20.3%~35.7%. There was a significant linear relationship between soil organic carbon content and external organic carbon input. Organic fertilizer application could significantly improve lettuce yield, and it had a significant effect. The soil micro-aggregate contents for 0.053~0.25 mm and 0.5 mm soil macro-aggregates were increased with organic fertilizer application increasing. Organic fertilizer application could promote soil macro-aggregates formation, when the pig manure organic fertilizer applied 40.0 g·kg-1 soil, the contents of >0.25 mm soil aggregates reached maximum, and also the mean weight diameter(MWD and geometric average diameter(GWD of soil aggregates were higher than that of other treatments, the soil agglomeration became more stronger and the soil structure became more stable.

Effects of co-digestion of cucumber residues to corn stover and pig manure ratio on methane production in solid state anaerobic digestion.

Science.gov (United States)

Wang, Yaya; Li, Guoxue; Chi, Menghao; Sun, Yanbo; Zhang, Jiaxing; Jiang, Shixu; Cui, Zongjun

2018-02-01

This study investigated the performance of co-digesting cucumber residues, corn stover, and pig manure at different ratios. Microbial community structure was analyzed to elucidate functional microorganism contributing to methane production during co-digestion. Results show that mixing cucumber residues with pig manure and corn stover could significantly improved methane yields 1.27-3.46 times higher than mono-feedstock. The methane yields decreased with the cucumber residues increasing when the pig manure ratio was fixed at 4 and 3, and was opposite at ratio 5. The optimal mixture ratio was T2 with the highest methane yield (305.4 mL/g VS) and co-digestion performance index (1.97). The main microbiological community in T2 was bacteria of Firmicutes (44.6%), Bacteroidetes (32.5%), Synergistetes (3.8%) and archaea of Methanosaeta (37.1%), Methanospirillum (18.2%). The mixture ratios changed the microbial community structures. The adding proportion of cucumber residues changed the community composition of the archaea, especially the proportion of Methanosaeta. Copyright © 2017 Elsevier Ltd. All rights reserved.

Production of methane by co-digestion of cassava pulp with various concentrations of pig manure

DEFF Research Database (Denmark)

Panichnumsin, Pan; Nopharatana, Annop; Ahring, Birgitte Kiær

2010-01-01

digestion process, the potential of co-digestion of cassava pulp (CP) with pig manure (PM) was further examined. The effect of the co-substrate mixture ratio was carried out in a semi-continuously fed stirred tank reactor (CSTR) operated under mesophilic condition (37 C) and at a constant OLR of 3.5 kg VS m...

Psychrophilic anaerobic digestion of guinea pig manure in low-cost tubular digesters at high altitude.

Science.gov (United States)

Garfí, Marianna; Ferrer-Martí, Laia; Villegas, Vidal; Ferrer, Ivet

2011-05-01

Guinea pig is one of the most common livestock in rural communities of the Andes. The aim of this research was to study the anaerobic digestion of guinea pig manure in low-cost unheated tubular digesters at high altitude. To this end, the performance of two pilot digesters was monitored during 7 months; and two greenhouse designs were compared. In the dome roof digester the temperature and biogas production were significantly higher than in the shed roof digester. However, the biogas production rate was low (0.04 m(biogas)(3)m(digester)(-3) d(-1)), which is attributed to the low organic loading rate (0.6 kg(VS)m(digester)(-3)d(-1)) and temperature (23°C) of the system, among other factors. In a preliminary fertilization study, the potato yield per hectare was increased by 100% using the effluent as biofertilizer. Improving manure management techniques, increasing the organic loading rate and co digesting other substrates may be considered to enhance the process. Copyright © 2011 Elsevier Ltd. All rights reserved.

[Effects of combined applications of pig manure and chemical fertilizers on CH4 and N2O emissions and their global warming potentials in paddy fields with double-rice cropping].

Science.gov (United States)

Wang, Cong; Shen, Jian-Lin; Zheng, Liang; Liu, Jie-Yun; Qin, Hong-Ling; Li, Yong; Wu, Jin-Shui

2014-08-01

A field experiment was carried out to study the effects of combined applications of pig manure and chemical fertilizers on CH4 and N2O emissions, which were measured using the static chamber/gas chromatography method, and their global warming potentials in typical paddy fields with double-rice cropping in Hunan province. The results showed that the combined applications of pig manure and chemical fertilizers did not change the seasonal patterns of CH4 and N2O emissions from paddy soils, but significantly changed the magnitudes of CH4 and N2O fluxes in rice growing seasons as compared with sole application of chemical fertilizers. During the two rice growing seasons, the cumulative CH4 emissions for the pig manure and chemical nitrogen (N) fertilizer each contributing to 50% of the total applied N (1/2N + PM) treatment were higher than those for the treatments of no N fertilizer (ON), half amount of chemical N fertilizer (1/2N) and 100% chemical N fertilizer (N) by 54.83%, 33.85% and 43.30%, respectively (P global warming potential (GWP) in both rice growing seasons, which contributed more than 99% to the integrated GWP of CH4 and N2O emissions for all the four treatments. Both GWP and yield-scaled GWP for the treatment of 1/2N + PM were significantly higher than the other three treatments. The yield-scaled GWP for the treatment of 1/2N + PM was higher than those for the N, 1/2N and ON treatments by 58.21%, 26.82% and 20. 63%, respectively. Therefore, combined applications of pig manure and chemical fertilizers in paddy fields would increase the GWP of CH4 and N2O emissions during rice growing seasons and this effect should be considered in regional greenhouse gases emissions inventory.

Why Danish pig farms have far more land and pigs than Dutch farms?

DEFF Research Database (Denmark)

Willems, Jaap; van Grinsven, H.J.M.; Jacobsen, Brian H

2016-01-01

The Netherlands and Denmark are the two biggest pig meat exporters in Europe, both with a strong focus on the German market. The structure of pig farms is very different: an average Danish pig farm has 3500 pigs, 170 ha of agricultural land on which a major part of the feed cereals are grown...... holdings using external sources of feed supply, and Danish farmers on efficient production of feed cereals on large holdings. Due to a gradual lowering of manure and fertiliser application standards, Dutch farmers increasingly have to process manure and export manure, further increasing the total costs...... pig farmers are less sensitive to nutrient policies and feed prices than those in the Netherlands, but the high debt rate makes the sector vulnerable to low pig prices....

Prevalence of Sulfonamide Resistance Genes in Bacterial Isolates from Manured Agricultural Soils and Pig Slurry in the United Kingdom▿

OpenAIRE

Byrne-Bailey, K. G.; Gaze, W. H.; Kay, P.; Boxall, A. B. A.; Hawkey, P. M.; Wellington, E. M. H.

2008-01-01

The prevalences of three sulfonamide resistance genes, sul1, sul2, and sul3 and sulfachloropyridazine (SCP) resistance were determined in bacteria isolated from manured agricultural clay soils and slurry samples in the United Kingdom over a 2-year period. Slurry from tylosin-fed pigs amended with SCP and oxytetracycline was used for manuring. Isolates positive for sul genes were further screened for the presence of class 1 and 2 integrons. Phenotypic resistance to SCP was significantly higher...

Responses of the biogas process to pulses of oleate in reactors treating mixtures of cattle and pig manure

DEFF Research Database (Denmark)

Nielsen, Henrik Bjørn; Ahring, Birgitte Kiær

2006-01-01

The effect of oleate on the anaerobic digestion process was investigated. Two thermophilic continuously stirred tank reactors (CSTR) were fed with mixtures of cattle and pig manure with different total solid (TS) and volatile solid (VS) content. The reactors were subjected to increasing pulses...

Reference life cycle assessment scenarios for manure management in the Baltic Sea Regions - An assessment covering six animal production, five BSR countries, and four manure types

DEFF Research Database (Denmark)

Hamelin, Lorie; Baky, A; Cano-Bernal, J

the manure is applied, specific legislations governing the manure management practices, etc.). Further, it presents a reference manure composition for each of these reference systems, including key parameters such as dry matter, nitrogen (inorganic and total), phosphorus, carbon and volatile solids content......One major pre-condition for assessing a manure management technique in a whole system or LCA-approach is to define a reference system against which this technique can be assessed. This report thus presents and details the establishment of such reference systems, comprising eight different manure...... types (fattening pig slurry, dairy cow slurry, hens manure, bulls deep litter, fattening pig solid manure, dairy cow solid manure, horse manure & broilers manure) and five Baltic Sea Regions (Denmark, Sweden, Finland, Estonia, Poland), for a total of 15 reference systems. It presents, for each...

Effect of aeration rate, moisture content and composting period on availability of copper and lead during pig manure composting.

Science.gov (United States)

Shen, Yujun; Zhao, Lixin; Meng, Haibo; Hou, Yueqing; Zhou, Haibin; Wang, Fei; Cheng, Hongsheng; Liu, Hongbin

2016-06-01

Pollution by heavy metals, such as copper and lead, has become a limiting factor for the land application of faecal manures, such as pig manure. This study was conducted to investigate the influence of composting process parameters, including aeration rate, moisture content and composting period, on the distribution of heavy metal species during composting, and to select an optimal parameter for copper and lead inactivation. Results showed that the distribution ratios of exchangeable fractions of copper and lead had a bigger decrease under conditions of aeration rate, 0.1 m(3) min(-1) m(-3), an initial moisture content of 65% and composting period of 50 days. Suboptimal composting process conditions could lead to increased availability of heavy metals. Statistical analysis indicated that the aeration rate was the main factor affecting copper and lead inactivation, while the effects of moisture content and composting period were not significant. The rates of reduction of copper-exchangeable fractions and lead-exchangeable fractions were positively correlated with increased pH. The optimal parameters for reducing heavy metal bioavailability during pig manure composting were aeration rate, 0.1 m(3) min(-1) m(-3), initial moisture content, 65%, and composting period, 20 days. © The Author(s) 2016.

Effect of Freezing and Thawing on Activity of Cu and Zn in Black Soil of Northeast China Under Simulated Fertilization Using Pig Manure

Directory of Open Access Journals (Sweden)

XU Cong-long

2015-06-01

Full Text Available With the development of large-scale farms and the addition of Cu and Zn in feed additives, high Cu and Zn contents in feces of livestock and poultry occurred, and may cause soil pollution of the heavy metal especially Cu and Zn by livestock and poultry manure fertilization. Both fertilization of livestock and poultry manure and freeze-thaw action can alter the activity of heavy metals in soil, and furthermore change the environmental effect of heavy metals in soil. This paper aimed at the influence of freezing and thawing on the activities of Cu and Zn (exchangeable and carbonate in black soil of Northeast China under pig manure fertilization according to the northeast climate characteristics through laboratory simulation. The results showed that the contents of exchangeable Cu and Zn significantly increased and that of carbonate Cu and Zn slightly decreased under pig manure fertilization initial stage comparing with the control without fertilizer. The contents of exchangeable Cu and Zn slightly increased and that of carbonate Cu and Zn decreased for the higher fertilization comparing with lower fertilization. The contents of exchangeable Cu and Zn decreased and that of carbonate Cu and Zn significantly increased with the extension of fertilization time (one month compared with the early fertilization (one week. Moreover, the contents of exchangeable Cu and Zn under higher fertilization were all higher than that under lower fertilization, on the contrary, the contents of carbonate Cu and Zn under higher fertilization all were lower than that under lower fertilization. The contents of exchangeable and carbonate Cu and Zn all increased obviously with the freezing and thawing temperature decreased, and the contents of Cu and Zn for higher fertilization were higher than that for lower fertilization. In conclusion, the activities of Cu and Zn in black soil were disturbed by both pig manure with different fertilization amounts and fertilization

Effect of microscale ZVI/magnetite on methane production and bioavailability of heavy metals during anaerobic digestion of diluted pig manure.

Science.gov (United States)

Liang, Yue-Gan; Li, Xiu-Juan; Zhang, Jin; Zhang, Li-Gan; Cheng, Beijiu

2017-05-01

Low methane production and high levels of heavy metal in pig slurries limit the feasibility of anaerobic digestion of pig manure. In this study, changes in the methane production and bioavailability of heavy metals in the anaerobic digestion of diluted pig manure were evaluated using single and combined action of microscale zero-valence iron (ZVI) and magnetite. After 30 days of anaerobic digestion, the methane yield ranged from 246.9 to 334.5 mL/g VS added, which increased by 20-26% in the group added with microscale ZVI and/or magnetite relative to that in the control group. Results of the first-order kinetic model revealed that addition of microscale ZVI and/or magnetite increased the biogas production potential, rather than the biogas production rate constant. These treatments also changed the distribution of chemical fractions for heavy metal. The addition of ZVI decreased the bioavailability of Cu and Zn in the solid digested residues. Moreover, a better performance was observed in the combined action of microscale ZVI and magnetite, and the ZVI anaerobic corrosion end-product, magnetite, might help enhance methane production through direct interspecies electron transfer in ZVI-anaerobic digestion process.

Emissions of ammonia, nitrous oxide and methane during the management of solid manures

DEFF Research Database (Denmark)

Webb, J; Sommer, Sven Gjedde; Kupper, Thomas

2012-01-01

manure tends to be small. Average unabated NH3 emissions following application of manure were 0.79, 0.63 and 0.40 of total ammoniacal-N (TAN) from cattle, pig and poultry manure respectively. The smaller emission from poultry manure is expected as hydrolysis of uric acid to urea may take many months...... application were 20%, 56% and 50% for cattle, pigs and poultry, respectively. Incorporation by disc or harrow reduced NH3 emissions less than incorporation by plough. Emissions of N2O following the application of cattle manure were 0.12 of TAN without incorporation after application and 0.073 TAN...... with incorporation after application. Conversely, emissions following application of pig and poultry manures were 0.003 and 0.001 TAN respectively without and 0.035 and 0.089 TAN respectively with incorporation after application...

Improving anaerobic digestion of pig manure by adding in the same reactor a stabilizing agent formulated with low-grade magnesium oxide

International Nuclear Information System (INIS)

Romero-Güiza, M.S.; Astals, S.; Chimenos, J.M.; Martínez, M.; Mata-Alvarez, J.

2014-01-01

Struvite precipitation and pig manure anaerobic digestion were coupled in the same reactor in order to mitigate the inhibitory effect of free ammonia and avoid precipitator costs. The stabilizing agent used to facilitate struvite precipitation was formulated with low-grade magnesium oxide by-product; an approach that would notably reduce struvite processing costs. The interaction between pig manure and stabilizing agent was analyzed in batch experiments, on a wide range of stabilizing agent additions from 5 to 100 kg m −3 . The monitoring of the pH and ammonia removal during 24 h showed the high capacity of the stabilizing agent to remove ammonia; removal efficiencies above 80% were obtained from 40 kg m −3 . However, a long-term anaerobic digester operation was required to assess the feasibility of the process and to ensure that the stabilizing agent does not introduce any harmful compound for the anaerobic biomass. In this vein, the addition of 5 and 30 kg m −3 of the stabilizing agent in a pig manure continuous digester resulted in a 25% (0.17 m 3  kg −1 ) and a 40% (0.19 m 3  kg −1 ) increase in methane production per mass of volatile solid, respectively, when compared with the reference digester (0.13 m 3  kg −1 ). Moreover, the stability of the process during four hydraulic retention times guarantees that the stabilizing agent did not exert a negative effect on the consortium of microorganisms. Finally, scanning electron microscopy and X-ray diffraction analysis confirmed the presence of struvite as well as two precipitation mechanisms, struvite precipitation on the stabilizing agent surface and in the bulk solution. - Highlights: • Anaerobic digestion and struvite precipitation were satisfactorily coupled. • The stabilizing agent showed high ammonia removals efficiencies. • The stabilizing agent improved the methane production of a pig manure digester. • The stabilizing agent does not introduce harmful compound for the

Environmental monitoring study of selected veterinary antibiotics in animal manure and soils in Austria

International Nuclear Information System (INIS)

Martinez-Carballo, Elena; Gonzalez-Barreiro, Carmen; Scharf, Sigrid; Gans, Oliver

2007-01-01

LC-MS/MS was used for determination of selected tetracyclines, sulfonamides, trimethoprim, and fluoroquinolones in manure samples of pig, chicken and turkey, as well as arable soils fertilized with manure. Recoveries from spiked samples ranged from 61 to 105%. Method quantification limits were set to 100 μg/kg for all substances. Analysis of 30 pig manure, 20 chicken and turkey dung, and 30 lyophilized soil samples taken in Austria revealed that in pig manure up to 46 mg/kg chlortetracycline, 29 mg/kg oxytetracycline and 23 mg/kg tetracycline could be detected. As representatives of the group of sulfonamides, sulfadimidine in pig manure and sulfadiazine in chicken and turkey dung were detected in significant amounts (maximum concentration, 20 and 91 mg/kg, respectively). Enrofloxacin was particularly observed in chicken and turkey samples. Positive detection of chlortetracycline, enrofloxacin, and ciprofloxacin, in soil samples should be outlined as most important results of this study. - Specific exposure data of selected veterinarian antibiotics in manure and samples of agriculturally used soils are reported for the first time in Austria

Environmental monitoring study of selected veterinary antibiotics in animal manure and soils in Austria

Energy Technology Data Exchange (ETDEWEB)

Martinez-Carballo, Elena [Department of Hazardous Substances and Metabolites, Umweltbundesamt GmbH - Austrian Federal Environment Agency, Spittelauer Laende 5, A-1090 Vienna (Austria); Gonzalez-Barreiro, Carmen [Department of Hazardous Substances and Metabolites, Umweltbundesamt GmbH - Austrian Federal Environment Agency, Spittelauer Laende 5, A-1090 Vienna (Austria); Scharf, Sigrid [Department of Hazardous Substances and Metabolites, Umweltbundesamt GmbH - Austrian Federal Environment Agency, Spittelauer Laende 5, A-1090 Vienna (Austria); Gans, Oliver [Department of Hazardous Substances and Metabolites, Umweltbundesamt GmbH - Austrian Federal Environment Agency, Spittelauer Laende 5, A-1090 Vienna (Austria)

2007-07-15

LC-MS/MS was used for determination of selected tetracyclines, sulfonamides, trimethoprim, and fluoroquinolones in manure samples of pig, chicken and turkey, as well as arable soils fertilized with manure. Recoveries from spiked samples ranged from 61 to 105%. Method quantification limits were set to 100 {mu}g/kg for all substances. Analysis of 30 pig manure, 20 chicken and turkey dung, and 30 lyophilized soil samples taken in Austria revealed that in pig manure up to 46 mg/kg chlortetracycline, 29 mg/kg oxytetracycline and 23 mg/kg tetracycline could be detected. As representatives of the group of sulfonamides, sulfadimidine in pig manure and sulfadiazine in chicken and turkey dung were detected in significant amounts (maximum concentration, 20 and 91 mg/kg, respectively). Enrofloxacin was particularly observed in chicken and turkey samples. Positive detection of chlortetracycline, enrofloxacin, and ciprofloxacin, in soil samples should be outlined as most important results of this study. - Specific exposure data of selected veterinarian antibiotics in manure and samples of agriculturally used soils are reported for the first time in Austria.

Marble waste and pig manure amendments decrease metal availability, increase soil quality and facilitate vegetation development in bare mine soils

Science.gov (United States)

Zornoza, Raúl; Faz, Ángel; Martínez-Martínez, Silvia; Acosta, José A.; Gómez, M. Dolores; Ángeles Muñoz, M.

2013-04-01

In order to bring out a functional and sustainable land use in a highly contaminated mine tailing, firstly environmental risks have to be reduced or eliminated by suitable reclamation activities. Tailing ponds pose environmental hazards, such as acidity and toxic metals reaching to waters through wind and water erosions and leaching. As a consequence, soils have no vegetation and low soil organic matter and nutrients. Various physicochemical and biochemical properties, together with exchangeable metals were measured before, 6 months and 12 months after the application of marble waste and pigs manure as reclamation strategy in a tailing pond from SE Spain to reduce hazards for environment and human health. Three months after the last addition of amendments, eight different native shrub species where planted for phytostabilization. Results showed the pH increased up to neutrality. Aggregates stability, organic carbon, total nitrogen, cation exchange capacity, bioavailable phosphorus and potassium, microbial biomass and microbial activity increased with the application of the amendments, while exchangeable metals drastically decreased (~90%). After one year of plantation, only 20% planted species died, with a high growth of survivals reaching flowering and fructification. This study confirms the high effectiveness of initial applications of marble wastes together with pig manure and plantation of shrub species to initialize the recovery of the ecosystem in bare mine soils under Mediterranean semiarid conditions. Key Words: pig manure, marble waste, heavy metals, mine soil. Acknowledgements This work has been funded by the European Union LIFE+ project MIPOLARE (LIFE09 ENV/ES/000439). J.A. Acosta acknowledges a "Saavedra Fajardo" contract from Comunidad Autónoma de Murcia (Spain)

Operational experinece with large scale biogas production at the promest manure processing plant in Helmond, the Netherlands

International Nuclear Information System (INIS)

Schomaker, A.H.H.M.

1992-01-01

In The Netherlands a surplus of 15 million tons of liquid pig manure is produced yearly on intensive pig breeding farms. The dutch government has set a three-way policy to reduce this excess of manure: 1. conversion of animal fodder into a product with less and better ingestible nutrients; 2. distribution of the surplus to regions with a shortage of animal manure; 3. processing of the remainder of the surplus in large scale processing plants. The first large scale plant for the processing of liquid pig manure was put in operation in 1988 as a demonstration plant at Promest in Helmond. The design capacity of this plant is 100,000 tons of pig manure per year. The plant was initiated by the Manure Steering Committee of the province Noord-Brabant in order to prove at short notice whether large scale manure processing might contribute to the solution of the problem of the manure surplus in The Netherlands. This steering committee is a corporation of the national and provincial government and the agricultural industrial life. (au)

Effect of fertilising with pig slurry and chicken manure on GHG emissions from Mediterranean paddies

Energy Technology Data Exchange (ETDEWEB)

Maris, S.C., E-mail: stefania@macs.udl.cat [Environment and Soil Science Department, University of Lleida, Av. Alcalde Rovira Roure 191, E-25198 Lleida (Spain); Teira-Esmatges, M.R.; Bosch-Serra, A.D. [Environment and Soil Science Department, University of Lleida, Av. Alcalde Rovira Roure 191, E-25198 Lleida (Spain); Moreno-García, B. [Soils and Irrigation Department, Agrifood Research and Technology Centre of Aragon (CITA), Av. Montañana 930, E-50059 Zaragoza (Spain); Català, M.M. [Ebre Field Station, Institute of Agrifood Research and Technology (IRTA), Ctra. de Balada, km 1, E-43870 Amposta (Spain)

2016-11-01

Soil fertilisation affects greenhouse gas emissions. The objective of this study was to compare the effect of different fertilisation strategies on N{sub 2}O, CH{sub 4} emissions and on ecosystem respiration (CO{sub 2} emissions), during different periods of rice cultivation (rice crop, postharvest period, and seedling) under Mediterranean climate. Emissions were quantified weekly by the photoacoustic technique at two sites. At Site 1 (2011 and 2012), background treatments were 2 doses of chicken manure (CM): 90 and 170 kg NH{sub 4}{sup +}-N ha{sup −} {sup 1} (CM-90, CM-170), urea (U, 150 kg N ha{sup −} {sup 1}) and no-N (control). Fifty kilogram N ha{sup −} {sup 1} ammonium sulphate (AS) were topdress applied to all of them. At Site 2 (2012), background treatments were 2 doses of pig slurry (PS): 91 and 152 kg NH{sub 4}{sup +}-N ha{sup −} {sup 1} (PS-91, PS-152) and ammonium sulphate (AS) at 120 kg NH{sub 4}{sup +}-N ha{sup −} {sup 1} and no-N (control). Sixty kilogram NH{sub 4}{sup +}-N ha{sup −} {sup 1} as AS were topdress applied to AS and PS-91. During seedling, global warming potential (GWP) was ~ 3.5–17% of that of the whole rice crop for the CM treatments. The postharvest period was a net sink for CH{sub 4}, and CO{sub 2} emissions only increased for the CM-170 treatment (up to 2 Mg CO{sub 2} ha{sup −} {sup 1}). The GWP of the entire rice crop reached 17 Mg CO{sub 2}-eq ha{sup −} {sup 1} for U, and was 14 for CM-170, and 37 for CM-90. The application of PS at agronomic doses (~ 170 kg N ha{sup −} {sup 1}) allowed high yields (~ 7.4 Mg ha{sup −} {sup 1}), the control of GWP (~ 6.5 Mg CO{sub 2}-eq ha{sup −} {sup 1}), and a 13% reduction in greenhouse gas intensity (GHGI) to 0.89 kg CO{sub 2}-eq kg{sup −} {sup 1} when compared to AS (1.02 kg CO{sub 2}-eq kg{sup −} {sup 1}). - Highlights: • Pig slurry (~ 170 kg N ha{sup −} {sup 1}; low C/N) allows high rice yields without increasing GWP. • Chicken manure (~ 170 kg N ha{sup �

Low-temperature anaerobic digestion of swine manure in a plug-flow reactor.

Science.gov (United States)

Massé, Daniel I; Gilbert, Yan; Saady, N M C; Liu, Charle

2013-01-01

A low-temperature (25 degrees C) anaerobic eight-compartment (PF01 to PF08) cascade reactor simulating a plug-flow reactor (PFR) treating pig manure was monitored for a year. The bioreactor was fed at an average loading rate of 2.4 +/- 0.2 g of total chemical oxygen demand (TCOD) per litre of reactor per day for a theoretical hydraulic retention time (HRT) of 67 +/- 7 d. An average of 79% of TCOD was removed from pig manure (converted into biogas and in sediments), whereas specific methane yields ranging from 397 to 482 NL CH4 kg(-1) VS (148.6 to 171.4 NL CH4 kg(-1) TCOD) were obtained. After 150 d, fluctuating performances of the process were observed, associated with solids accumulation in the upstream compartments, preventing the complete anaerobic digestion of swine manure in the compartments PF01 to PF04. Low-temperature anaerobic PFR represents an interesting alternative for the treatment of pig manure and recovery of green energy. Further investigations regarding a modified design, with better accumulating solids management, are needed to optimize the performance of this low-temperature PFR treating pig manure.

Comparing environmental consequences of anaerobic mono- and co-digestion of pig manure to produce bio-energy – A life cycle perspective

NARCIS (Netherlands)

Vries, de J.W.; Vinken, T.M.W.J.; Hamelin, L.; Boer, de I.J.M.

2012-01-01

The aim of this work was to assess the environmental consequences of anaerobic mono- and co-digestion of pig manure to produce bio-energy, from a life cycle perspective. This included assessing environmental impacts and land use change emissions (LUC) required to replace used co-substrates for

Impact of narasin on manure composition, microbial ecology, and gas emissions from finishing pigs fed either a corn-soybean meal or a corn-soybean meal-dried distillers grains with solubles diets.

Science.gov (United States)

Kerr, Brian J; Trabue, Steven L; van Weelden, Mark B; Andersen, Daniel S; Pepple, Laura M

2018-04-14

An experiment was conducted to determine the effect of feeding finishing pigs a corn-soybean (CSBM) diet or a CSBM diet supplemented with 30% dried distillers grains with solubles (DDGS), in combination with or without a growth-promoting ionophore (0 or 30 mg narasin/kg of diet), has on manure composition, microbial ecology, and gas emissions. Two separate groups of 24 gilts (initial BW = 145.1 kg, SD = 7.8 kg) were allotted to individual metabolism crates that allowed for total but separate collection of feces and urine during the 48-d collection period. After each of the twice-daily feedings, feces and urine from each crate was collected and added to its assigned enclosed manure storage tank. Each tank contained an individual fan system that pulled a constant stream of air over the manure surface for 2 wk prior to air (day 52) and manure sampling (day 53). After manure sampling, the manure in the tanks was dumped and the tanks cleaned for the second group of pigs. Except for total manure Ca and P output as a percent of intake and for manure methane product rate and biochemical methane potential (P ≤ 0.08), there were no interactions between diet composition and narasin supplementation. Narasin supplementation resulted in increased manure C (P = 0.05), increased manure DM, C, S, Ca, and phosphorus as a percent of animal intake (P ≤ 0.07), and increased manure volatile solids and foaming capacity (P ≤ 0.09). No effect of narasin supplementation was noted on manure VFA concentrations or any of the gas emission parameters measured (P ≥ 0.29). In contrast, feeding finishing pigs a diet containing DDGS dramatically affected manure composition as indicated by increased concentration of DM, C, ammonia, N, and total and volatile solids (P = 0.01), increased manure DM, N, and C as a percent of animal intake (P = 0.01), increased manure total VFA and phenols (P ≤ 0.05), decreased gas emissions of ammonia and volatile sulfur compounds (VSC; P = 0.01), increased

Effects of woody peat and superphosphate on compost maturity and gaseous emissions during pig manure composting.

Science.gov (United States)

Zhang, Difang; Luo, Wenhai; Yuan, Jing; Li, Guoxue; Luo, Yuan

2017-10-01

This study investigated the effect of calcium superphosphate on compost maturity and gaseous emissions during pig manure composting with woody peat as the bulking agent. Two treatments were conducted with or without the addition of calcium superphosphate (10% dry weight of the composting mass), which were denoted as the control and superphosphate-amended treatment, respectively. Results show that the composting temperature of both treatments was higher than 50°C for more than 5days, which is typically required for pathogen destruction during manure composting. Compared to the control treatment, the superphosphate-amended treatment increased the emission of nitrogen oxide, but reduced the emission of methane, ammonia and hydrogen sulfide by approximately 35.5%, 37.9% and 65.5%, respectively. As a result, the total greenhouse gas (GHG) emission during manure composting was reduced by nearly 34.7% with the addition of calcium superphosphate. The addition of calcium superphosphate increased the content of humic acid (indicated by E 4 /E 6 ratio). Nevertheless, the superphosphate-amended treatment postponed the biological degradation of organic matter and produced the mature compost with a higher electrical conductivity in comparison with the control treatment. Copyright © 2017. Published by Elsevier Ltd.

Optimisation and inhibition of anaerobic digestion of livestock manure

Energy Technology Data Exchange (ETDEWEB)

Sutaryo, S.

2012-11-15

The optimisation process during this PhD study focused on mixed enzyme (ME) addition, thermal pre-treatment and co-digestion of raw manure with solid fractions of acidified manure, while for inhibition processes, ammonia and sulphide inhibition were studied. ME addition increased methane yield of both dairy cow manure (DCM) and solid fractions of DCM (by 4.44% and 4.15% respectively, compared to the control) when ME was added to manure and incubated prior to anaerobic digestion (AD). However, no positive effect was found when ME was added to manure and fed immediately to either mesophilic (35 deg. C) or thermophilic (50 deg. C) digesters. Low-temperature pre-treatment (65 deg. C to 80 deg. C for 20 h) followed by batch assays increased the methane yield of pig manure in the range from 9.5% to 26.4% at 11 d incubation. These treatments also increased the methane yield of solid-fractions pig manure in the range from 6.1% to 25.3% at 11 d of the digestion test. However, at 90 d the increase in methane yield of pig manure was only significant at the 65 deg. C treatment, thus low-temperature thermal pre-treatment increased the rate of gas production, but did not increase the ultimate yield (B{sub o}). High-temperature pre-treatment (100 deg. C to 225 deg. C for 15 min.) increased the methane yield of DCM by 13% and 21% for treatments at 175 deg. C and 200 deg. C, respectively, at 27 d of batch assays. For pig manure, methane yield was increased by 29% following 200 deg. C treatment and 27 d of a batch digestion test. No positive effect was found of high-temperature pre-treatment on the methane yield of chicken manure. At the end of the experiment (90 d), high-temperature thermal pre-treatment was significantly increasing the B{sub 0} of pig manure and DCM. Acidification of animal manure using sulphuric acid is a well-known technology to reduce ammonia emission of animal manure. AD of acidified manure showed sulphide inhibition and consequently methane production was 45

Recycling phosphorus by fast pyrolysis of pig manure: concentration and extraction of phosphorus combined with formation of value-added pyrolysis products

NARCIS (Netherlands)

Azuara, M.; Kersten, Sascha R.A.; Kootstra, A.M.J.

2013-01-01

In order to recycle phosphorus from the livestock chain back to the land, fast pyrolysis of concentrated pig manure at different temperatures (400 °C, 500 °C, 600 °C), was undertaken to concentrate the phosphorus in the char fraction for recovery. Results show that 92%–97% of the phosphorus present

Microbial community dynamics and biogas production from manure fractions in sludge bed anaerobic digestion.

Science.gov (United States)

Nordgård, A S R; Bergland, W H; Bakke, R; Vadstein, O; Østgaard, K; Bakke, I

2015-12-01

To elucidate how granular sludge inoculum and particle-rich organic loading affect the structure of the microbial communities and process performance in upflow anaerobic sludge bed (UASB) reactors. We investigated four reactors run on dairy manure filtrate and four on pig manure supernatant for three months achieving similar methane yields. The reactors fed with less particle rich pig manure stabilized faster and had highest capacity. Microbial community dynamics analysed by a PCR/denaturing gradient gel electrophoresis approach showed that influent was a major determinant for the composition of the reactor communities. Comparisons of pre- and non-adapted inoculum in the reactors run on pig manure supernatant showed that the community structure of the nonadapted inoculum adapted in approximately two months. Microbiota variance partitioning analysis revealed that running time, organic loading rate and inoculum together explained 26 and 31% of the variance in bacterial and archaeal communities respectively. The microbial communities of UASBs adapted to the reactor conditions in treatment of particle rich manure fractions, obtaining high capacity, especially on pig manure supernatant. These findings provide relevant insight into the microbial community dynamics in startup and operation of sludge bed reactors for methane production from slurry fractions, a major potential source of biogas. © 2015 The Society for Applied Microbiology.

Soil bacterial consortia and previous exposure enhance the biodegradation of sulfonamides from pig manure.

Science.gov (United States)

Islas-Espinoza, Marina; Reid, Brian J; Wexler, Margaret; Bond, Philip L

2012-07-01

Persistence or degradation of synthetic antibiotics in soil is crucial in assessing their environmental risks. Microbial catabolic activity in a sandy loamy soil with pig manure using 12C- and 14C-labelled sulfamethazine (SMZ) respirometry showed that SMZ was not readily degradable. But after 100 days, degradation in sulfadiazine-exposed manure was 9.2%, far greater than soil and organic manure (0.5% and 0.11%, respectively, p library from the treatment with highest degradation showed that most bacteria belonged to α, β and γ classes of Proteobacteria, Firmicutes, Bacteroidetes and Acidobacteria. Proteobacteria (α, β and γ), Firmicutes and Bacteroidetes which were the most abundant classes on day 1 also decreased most following prolonged exposure. From the matrix showing the highest degradation rate, 17 SMZ-resistant isolates biodegraded low levels of 14C-labelled SMZ when each species was incubated separately (0.2-1.5%) but biodegradation was enhanced when the four isolates with the highest biodegradation were incubated in a consortium (Bacillus licheniformis, Pseudomonas putida, Alcaligenes sp. and Aquamicrobium defluvium as per 16S rRNA gene sequencing), removing up to 7.8% of SMZ after 20 days. One of these species (B. licheniformis) was a known livestock and occasional human pathogen. Despite an environmental role of these species in sulfonamide bioremediation, the possibility of horizontal transfer of pathogenicity and resistance genes should caution against an indiscriminate use of these species as sulfonamide degraders.

THE IMPACT OF FRESH SAWDUST AND DRY PIG MANURE PRODUCED ON SAWDUST BEDDING APPLICATION ON THE NUTRIENTS MOBILITY IN SOIL AND SUGAR BEET YIELD

Directory of Open Access Journals (Sweden)

Peter Kováčik

2013-07-01

Full Text Available The objective of the pot trial carried out at the area of the Slovak University of Agriculture in Nitra was to determine the impact of dry pig manure produced on the sawdust bedding and sawdust litter on the level of nutrients’ mobility in the soil and sugar beet yield. The achieved results showed that one month after the sawdust and manure application to the soil, the contents of mobile nutrients (Nan, P, K, Ca, Mg in soil were lower than in the control unfertilized treatment. The sawdust litter immobilized nutrients more considerably than manure. Four months after the manure application into soil, its immobilization effect was not evident. On the contrary, the manure increased the mobile nutrients content in soil. In the second year of experiment the immobilization effect of sawdust litter was proved even four months after its application into soil. The application of manure increased considerably the beet root yield. The maximum root yield was determined in the treatment where the highest dose of manure was applied. The minimum root yield was detected in the treatment where the highest dose of sawdust litter was applied.

Matrix parameters and storage conditions of manure

Energy Technology Data Exchange (ETDEWEB)

Weinfurtner, Karlheinz [Fraunhofer Institute for Molecular Biology and Applied Ecology (IME), Schmallenberg (Germany)

2011-01-15

The literature study presents an overview of storage conditions for manure and information about important matrix parameters of manure such as dry matter content, pH value, total organic carbon, total nitrogen and ammonium nitrogen. The presented results show that for matrix parameters a dissimilarity of cattle and pig manure can be observed but no difference within the species for different production types occurred with exception of calves. A scenario for western and central European countries is derived. (orig.)

Influence of bulking agents on CH4, N2O, and NH3 emissions during rapid composting of pig manure from the Chinese Ganqinfen system*

Science.gov (United States)

Sun, Xiang-ping; Lu, Peng; Jiang, Tao; Schuchardt, Frank; Li, Guo-xue

2014-01-01

Mismanagement of the composting process can result in emissions of CH4, N2O, and NH3, which have caused severe environmental problems. This study was aimed at determining whether CH4, N2O, and NH3 emissions from composting are affected by bulking agents during rapid composting of pig manure from the Chinese Ganqinfen system. Three bulking agents, corn stalks, spent mushroom compost, and sawdust, were used in composting with pig manure in 60 L reactors with forced aeration for more than a month. Gas emissions were measured continuously, and detailed gas emission patterns were obtained. Concentrations of NH3 and N2O from the composting pig manure mixed with corn stalks or sawdust were higher than those from the spent mushroom compost treatment, especially the sawdust treatment, which had the highest total nitrogen loss among the three runs. Most of the nitrogen was lost in the form of NH3, which accounts for 11.16% to 35.69% of the initial nitrogen. One-way analysis of variance for NH3 emission showed no significant differences between the corn stalk and sawdust treatments, but a significant difference was noted between the spent mushroom compost and sawdust treatments. The introduction of sawdust reduced CH4 emission more than the corn stalks and spent mushroom compost. However, there were no significant differences among the three runs for total carbon loss. All treatments were matured after 30 d. PMID:24711356

Impact of food industrial waste on anaerobic co-digestion of sewage sludge and pig manure.

Science.gov (United States)

Murto, M; Björnsson, L; Mattiasson, B

2004-02-01

The performance of an anaerobic digestion process is much dependent on the type and the composition of the material to be digested. The effects on the degradation process of co-digesting different types of waste were examined in two laboratory-scale studies. In the first investigation, sewage sludge was co-digested with industrial waste from potato processing. The co-digestion resulted in a low buffered system and when the fraction of starch-rich waste was increased, the result was a more sensitive process, with process overload occurring at a lower organic loading rate (OLR). In the second investigation, pig manure, slaughterhouse waste, vegetable waste and various kinds of industrial waste were digested. This resulted in a highly buffered system as the manure contributed to high amounts of ammonia. However, it is important to note that ammonia might be toxic to the micro-organisms. Although the conversion of volatile fatty acids was incomplete the processes worked well with high gas yields, 0.8-1.0 m3 kg(-1) VS.

Hygienic aspects of livestock manure management and biogas systems operated by small-scale pig farmers in Vietnam.

Science.gov (United States)

Huong, Luu Quynh; Madsen, Henry; Anh, Le Xuan; Ngoc, Pham Thi; Dalsgaard, Anders

2014-02-01

Biogas digesters are widely promoted and increasingly used to treat and generate gas from pig slurry worldwide. The objective of this study was to describe manure management practices with focus on biogas digestion among small scale pig farmers in Hue (50 farmers) and Hanoi (96 farmers) and to assess fecal contamination levels in biogas effluent. Results showed that 84% of the farmers in Hanoi and 42% in Hue used both pig slurry and human excreta for biogas production. Biogas digestion only reduced E. coli concentrations by 1 to 2 log units to 3.70 ± 0.84 Escherichia coli (log10) cfu/ml on average in effluent as compared with raw slurry. Biogas effluent was commonly used to fertilize vegetables or discharged directly into the garden or aquatic recipients. Reduced problems with bad smells and flies were reported as main reasons for establishing a biogas digester. Further studies are needed to assess human and animal health hazards associated with the discharge and use of biogas effluent from small-scale biogas systems. © 2013.

Impact of narasin on manure composition and microbial ecology, and gas emissions from finishing pigs fed either a corn-soybean meal or a corn-soybean meal-dried distillers grains with solubles diets

Science.gov (United States)

An experiment was conducted to determine the effect of feeding finishing pigs either a corn-soybean (CSBM) diet or a CSBM diet supplemented with 30.34% distillers dried grains with solubles (DDGS), in combination with either 0 or 30 mg narasin/kg of diet, on subsequent manure composition, manure mic...

The behavior of antibiotic resistance genes and arsenic influenced by biochar during different manure composting.

Science.gov (United States)

Cui, Erping; Wu, Ying; Jiao, Yanan; Zuo, Yiru; Rensing, Christopher; Chen, Hong

2017-06-01

The effect of two different biochar types, rice straw biochar (RSB) and mushroom biochar (MB), on chicken manure composting was previously examined by monitoring the fate of antibiotic resistance genes (ARGs) and arsenic. The behavior of ARGs and arsenic in other kinds of manure composting with the same biochar types had not been examined. In this study, we added either RSB or MB to pig and duck manure composts to study the behavior of ARGs (tet genes, sul genes, and chloramphenicol resistance genes) and arsenic under the same experimental condition. The results showed that the average removal values of selected ARGs were respectively 2.56 and 2.09 log units in duck and pig manure compost without the addition of biochar. The effect of biochar addition on the average removal value of ARGs depended on the type of biochar and manure. For instance, in pig manure compost, MB addition increased the average removal value of ARGs, while RSB addition decreased. And both biochar additions had a negative influence on the average removal value of ARGs in duck manure compost. Analytical results also demonstrated that MB addition reduced total arsenic and the percentage of bioavailable arsenic more than RSB.

Phenotypic and genotypic bacterial antimicrobial resistance in liquid pig manure is variously associated with contents of tetracyclines and sulfonamides.

Science.gov (United States)

Hölzel, C S; Harms, K S; Küchenhoff, H; Kunz, A; Müller, C; Meyer, K; Schwaiger, K; Bauer, J

2010-05-01

Antibiotic residues as well as antibiotic-resistant bacteria in environmental samples might pose a risk to human health. This study aimed to investigate the association between antibiotic residues and bacterial antimicrobial resistance in liquid pig manure used as fertilizer. Concentrations of tetracyclines (TETs) and sulfonamides (SULs) were determined by liquid chromatography-mass spectrometry in 305 pig manure samples; antibiotic contents were correlated to the phenotypic resistance of Escherichia coli (n = 613) and enterococci (n = 564) towards up to 24 antibiotics. In 121 samples, the concentration of the TET resistance genes tet(M), tet(O) and tet(B) was quantified by real-time-PCR. TETs were found in 54% of the samples. The median sum concentration of all investigated TETs in the positive samples was 0.73 mg kg(-1). SULs were found with a similar frequency (51%) and a median sum concentration of 0.15 mg kg(-1) in the positive samples. Associated with the detection of TETs and/or SULs, resistance rates were significantly elevated for several substances - some of them not used in farm animals, e.g. chloramphenicol and synercid. In addition, multiresistant isolates were found more often in samples containing antibiotics. Analysis of the resistance genes tet(M) and tet(O) already showed a significant increase in their concentrations - but not in tet(B) - in the lowest range of total TET concentration. Mean tet(M) concentrations increased by the factor of 4.5 in the TET concentration range of 0.1-1 mg kg(-1), compared to negative manure samples. Antibiotic contamination of manure seems to be associated with a variety of changes in bacterial resistance, calling for a prudent use of antibiotics in farm animals. This study provides an interdisciplinary approach to assess antimicrobial resistance by combining the microbiological analysis of bacterial resistance with high quality chemical analysis of antibiotic residues in a representative number of environmental

Influence of farmyard manure on some morphological and biochemical parameters of cowpea (Vigna unguiculata) seedling grown in cadmium-treated soil.

Science.gov (United States)

Asagba, Samuel Ogheneovo; Ezedom, Theresa; Kadiri, Helen

2017-10-01

The present study aims to assess the effects of the two kinds of farmyard manure (poultry and pig manures) as amendments for soil on cadmium (Cd) toxicity in plants using cowpea seedlings as plant model. Cd toxicity was evaluated by assessing the effect of the metal on the growth rate and antioxidant status as well as the ability of the plant to metabolise xenobiotic. There was a significantly (p cowpea seedlings grown in all the treated soils relative to control. Addition of poultry manure to the soil significantly (p cowpea seedlings grown in Cd-treated soil augmented with poultry manure but not in cowpea seedlings in cadmium-treated soil with pig manure amendments. Similarly, augmentation of Cd-treated soil with pig manure did not alter the Cd-induced effect on the levels of superoxide dismutase (SOD) and lipid peroxidation (LPO) in leaf, stem and roots, as SOD remained significantly (p cowpea seedlings grown in Cd-treated soils amended with poultry manure were restored to a level not significantly (p > 0.05) different from control. Like in the case of SOD, the Cd-induced inhibition of the activity of xenobiotic metabolising enzymes, aldehyde oxidase and sulphite oxidase remained significantly (p  0.05) different from control. In conclusion, the findings of the study revealed that supplementation of Cd-treated soils with pig and poultry manures reversed effects of Cd on cowpea seedlings. However, poultry manure was more effective than pig manure in ameliorating the effects of Cd.

Comparing environmental consequences of anaerobic mono- and co-digestion of pig manure to produce bio-energy – A life cycle perspective

DEFF Research Database (Denmark)

De Vries, J.W.; Vinken, T.M.W.J; Hamelin, Lorie

2012-01-01

The aim of this work was to assess the environmental consequences of anaerobic mono- and co-digestion of pig manure to produce bio-energy, from a life cycle perspective. This included assessing environmental impacts and land use change emissions (LUC) required to replace used co-substrates for an...... (up to 568%), but at expense of increasing climate change (through LUC), marine eutrophication, and land use. Codigestion with wastes or residues like roadside grass gave the best environmental performance.......-substrates for anaerobic digestion. Environmental impact categories considered were climate change, terrestrial acidification, marine and freshwater eutrophication, particulate matter formation, land use, and fossil fuel depletion. Six scenarios were evaluated: mono-digestion of manure, co-digestion with: maize silage...

Technical protocol for laboratory tests of transformation of veterinary medicinal products and biocides in liquid manures. Version 1.0

Energy Technology Data Exchange (ETDEWEB)

Kreuzig, Robert [Technische Univ. Braunschweig (Germany). Inst. fuer Oekologische Chemie und Abfallanalytik

2010-07-15

The technical protocol under consideration describes a laboratory test method to evaluate the transformation of chemicals in liquid bovine and pig manures under anaerobic conditions and primarily is designed for veterinary medicinal products and biocides. The environmentally relevant entry routes into liquid manures occur via urine and feces of cattle and pigs in stable housings after excretion of veterinary medicinal products as parent compounds or metabolites and after the application of biocides in animal housings. Further entry routes such as solid dung application and direct dung pat deposition by production animals on pasture are not considered by this technical protocol. Thus, this technical protocol focused on the sampling of excrements from cattles and pigs kept in stables and fed under standard nutrition conditions. This approach additionally ensures that excrement samples are operationally free of any contamination by veterinary medicinal products and biocides. After the matrix characterization, reference-manure samples are prepared from the excrement samples by adding tap water to adjust defined dry substance contents typical for bovine or pig manures. This technical protocol comprehends a tiered experimental design in two parts: (a) Sampling of excrements and preparation of reference bovine and pig manures; (b) Testing of anaerobic transformation of chemicals in reference manures.

An investigation into the removal of Salmonella and enteric indicator bacteria from the separated liquid fraction of raw or anaerobically digested pig manure using novel on-farm woodchip biofilters.

Science.gov (United States)

McCarthy, G; Lawlor, P G; Carney, K N; Zhan, X; Gutierrez, M; Gardiner, G E

2015-05-01

The objective was to investigate the removal of Salmonella and enteric indicator bacteria from the liquid fraction of raw and anaerobically digested (AD) pig manure in woodchip biofilters over a 14 week (98 day) period. Antibiotic susceptible Salmonella Infantis was detected in one influent material (liquid fraction of raw manure) on two occasions but was not found in the effluent at any time point. Furthermore, mean coliform reductions of 56% were observed in the biofilters treating the liquid fraction of raw manure. However, a mean increase of 228% was found in those treating the liquid from AD manure, despite the fact that the microbial challenge to these biofilters was lower. In addition, relatively high coliform counts were still present in the effluent from both biofilter treatments, especially in the systems treating the liquid fraction of AD manure. However, findings for Escherichia coli and Enterococcus were more promising, with reductions observed for both treatments (10 and 18.5% for E. coli and 71 and 87% for Enterococcus). Moreover, E. coli and Enterococcus were at, or just above, the limit of detection in the final effluents. Overall, although, there are no microbial limits for discharge or washwaters, the woodchip filter effluent would appear safe for discharge to waterways or use on-farm as regards Salmonella, E. coli and Enterococcus but not coliform. In conclusion, woodchip biofilters offer potential as a low-cost sustainable novel treatment option for the removal of pathogens from the liquid fraction of pig manure. Copyright © 2014 Elsevier B.V. All rights reserved.

Integrated manure management to reduce environmental impact: II. Environmental impact assessment of strategies

NARCIS (Netherlands)

Vries, de J.W.; Groenestein, C.M.; Schroder, J.J.; Hoogmoed, W.B.; Sukkel, W.; Groot Koerkamp, P.W.G.; Boer, de I.J.M.

2015-01-01

Manure management contributes to adverse environmental impacts through losses of nitrogen (N), phosphorus, and carbon (C). In this study, we aimed to assess the potential of newly designed strategies for integrated manure management (IS) to reduce environmental impact. An important aspect of the

Effects of oxytetracycline on archaeal community, and tetracycline resistance genes in anaerobic co-digestion of pig manure and wheat straw.

Science.gov (United States)

Wang, Xiaojuan; Pan, Hongjia; Gu, Jie; Qian, Xun; Gao, Hua; Qin, Qingjun

2016-12-01

In this study, the effects of different concentrations of oxytetracycline (OTC) on biogas production, archaeal community structure, and the levels of tetracycline resistance genes (TRGs) were investigated in the anaerobic co-digestion products of pig manure and wheat straw. PCR denaturing gradient gel electrophoresis analysis and real-time quantitative polymerase chain reaction (RT-qPCR) (PCR) were used to detect the archaeal community structure and the levels of four TRGs: tet(M), tet(Q), tet(W), and tet(C). The results showed that anaerobic co-digestion with OTC at concentrations of 60, 100, and 140 mg/kg (dry weight of pig manure) reduced the cumulative biogas production levels by 9.9%, 10.4%, and 14.1%, respectively, compared with that produced by the control, which lacked the antibiotic. The addition of OTC substantially modified the structure of the archaeal community. Two orders were identified by phylogenetic analysis, that is, Pseudomonadales and Methanomicrobiales, and the methanogen present during anaerobic co-digestion with OTC may have been resistant to OTC. The abundances of tet(Q) and tet(W) genes increased as the OTC concentration increased, whereas the abundances of tet(M) and tet(C) genes decreased as the OTC concentration increased.

Survival and leaching of Tetracycline resistant bacteria and fecal indicators from manure in field scale experiments

DEFF Research Database (Denmark)

Bech, Tina; Amin, Mostofa; Lægdsmand, Mette

The spreading of manure on agricultural land is an economic and practical solution for improving soil quality; however, animal manure frequently contains zoonotic pathogenic bacteria, such as certain Eschericia coli, Salmonella spp. and Campylobacter spp. The present experiment was conducted...... as a large multidisciplinary project. Pig manure with a natural content of Tetracycline resistant bacteria and fecal indicator organisms was followed in soil columns and a field scale experiment. In the field experiment pig manure was injected into agricultural soil. The distribution and survival of natural...... occurring indicator bacteria around a manure slurry slit in the soil was followed. During a period of two months, sections of soils with different distance to the manure string were assayed to obtain information on survival and spread of bacteriophage, faecal indicators (Enterococci, Bacterioides, E. coli...

Insight into the effects of biochar on manure composting: evidence supporting the relationship between N2O emission and denitrifying community.

Science.gov (United States)

Wang, Cheng; Lu, Haohao; Dong, Da; Deng, Hui; Strong, P J; Wang, Hailong; Wu, Weixiang

2013-07-02

Although nitrous oxide (N2O) emissions from composting contribute to the accelerated greenhouse effect, it is difficult to implement practical methods to mitigate these emissions. In this study, the effects of biochar amendment during pig manure composting were investigated to evaluate the inter-relationships between N2O emission and the abundance of denitrifying bacteria. Analytical results from two pilot composting treatments with (PWSB, pig manure + wood chips + sawdust + biochar) or without (PWS, pig manure + wood chips + sawdust) biochar (3% w/w) demonstrated that biochar amendment not only lowered NO2(-)-N concentrations but also lowered the total N2O emissions from pig manure composting, especially during the later stages. Quantification of functional genes involved in denitrification and Spearman rank correlations matrix revealed that the N2O emission rates correlated with the abundance of nosZ, nirK, and nirS genes. Biochar-amended pig manure had a higher pH and a lower moisture content. Biochar amendment altered the abundance of denitrifying bacteria significantly; less N2O-producing and more N2O-consuming bacteria were present in the PWSB, and this significantly lowered N2O emissions in the maturation phase. Together, the results demonstrate that biochar amendment could be a novel greenhouse gas mitigation strategy during pig manure composting.

Life Cycle Inventory & Assessment Report: Separation of Digested Fattening Pig Slurry for Optimal P Concentration, Denmark

DEFF Research Database (Denmark)

Wesnæs, Marianne; Hamelin, Lorie; Wenzel, Henrik

management chain” for a combination of techniques: Source-segregation of manure from fattening pigs, using the solid part from the source-segregation for biogas production, utilising the biogas for heat and electricity production, separating the digested pig manure after the biogas plant in order to optimize......The purpose of this Life Cycle Assessment report is to investigate the potential for separating the digested pig manure after the biogas plant in order to optimise the utilisation of the phosphorous content of the manure. By separating, the phosphorous rich solid fraction can be brought to fields...

Prevalence of sulfonamide resistance genes in bacterial isolates from manured agricultural soils and pig slurry in the United Kingdom.

Science.gov (United States)

Byrne-Bailey, K G; Gaze, W H; Kay, P; Boxall, A B A; Hawkey, P M; Wellington, E M H

2009-02-01

The prevalences of three sulfonamide resistance genes, sul1, sul2, and sul3 and sulfachloropyridazine (SCP) resistance were determined in bacteria isolated from manured agricultural clay soils and slurry samples in the United Kingdom over a 2-year period. Slurry from tylosin-fed pigs amended with SCP and oxytetracycline was used for manuring. Isolates positive for sul genes were further screened for the presence of class 1 and 2 integrons. Phenotypic resistance to SCP was significantly higher in isolates from pig slurry and postapplication soil than in those from preapplication soil. Of 531 isolates, 23% carried sul1, 18% sul2, and 9% sul3 only. Two percent of isolates contained all three sul genes. Class 1 and class 2 integrons were identified in 5% and 11.7%, respectively, of sul-positive isolates. In previous reports, sul1 was linked to class 1 integrons, but in this study only 8% of sul1-positive isolates carried the intI1 gene. Sulfonamide-resistant pathogens, including Shigella flexneri, Aerococcus spp., and Acinetobacter baumannii, were identified in slurry-amended soil and soil leachate, suggesting a potential environmental reservoir. Sulfonamide resistance in Psychrobacter, Enterococcus, and Bacillus spp. is reported for the first time, and this study also provides the first description of the genotypes sul1, sul2, and sul3 outside the Enterobacteriaceae and in the soil environment.

Prevalence of Sulfonamide Resistance Genes in Bacterial Isolates from Manured Agricultural Soils and Pig Slurry in the United Kingdom▿

Science.gov (United States)

Byrne-Bailey, K. G.; Gaze, W. H.; Kay, P.; Boxall, A. B. A.; Hawkey, P. M.; Wellington, E. M. H.

2009-01-01

The prevalences of three sulfonamide resistance genes, sul1, sul2, and sul3 and sulfachloropyridazine (SCP) resistance were determined in bacteria isolated from manured agricultural clay soils and slurry samples in the United Kingdom over a 2-year period. Slurry from tylosin-fed pigs amended with SCP and oxytetracycline was used for manuring. Isolates positive for sul genes were further screened for the presence of class 1 and 2 integrons. Phenotypic resistance to SCP was significantly higher in isolates from pig slurry and postapplication soil than in those from preapplication soil. Of 531 isolates, 23% carried sul1, 18% sul2, and 9% sul3 only. Two percent of isolates contained all three sul genes. Class 1 and class 2 integrons were identified in 5% and 11.7%, respectively, of sul-positive isolates. In previous reports, sul1 was linked to class 1 integrons, but in this study only 8% of sul1-positive isolates carried the intI1 gene. Sulfonamide-resistant pathogens, including Shigella flexneri, Aerococcus spp., and Acinetobacter baumannii, were identified in slurry-amended soil and soil leachate, suggesting a potential environmental reservoir. Sulfonamide resistance in Psychrobacter, Enterococcus, and Bacillus spp. is reported for the first time, and this study also provides the first description of the genotypes sul1, sul2, and sul3 outside the Enterobacteriaceae and in the soil environment. PMID:19064898

Organic manure of the corn (Zea mays L.) in alluvial soils of intermediate climate

International Nuclear Information System (INIS)

Tamayo V, Alvaro; Munoz A, Rodrigo; Diaz A; Carlos

1997-01-01

With the purpose to evaluate the effect on the yield of com ICA V.303 variety, using four sources of organic matter (hen manure, pig manure, cow manure, earthworm manure) in two doses (500 and 1.000 kg/ha), compared with a chemical treatment (300 kg/ha of 10-30-10 plus 150 kg of urea), and a control, an experiment was carried out at Tulio Ospina Research Center, located at Bello (Antioquia), with 1.320 m.s.n.m. The experiment was established using an alluvial soil (tropofluvent), frank, with low content of organic matter (3.1%), and potassium (0.11 meq/l00 g), and medium content of phosphorus (2 ppm). The results, after four consecutive harvests on the same plots, showed highly significative differences among treatments, compared with the control. The highest yield (4.709 kg/ha) was obtained with the chemical treatment (300 kg/ha of 10-30-10 plus 150 kg of urea). The addition of 500 and 1.000 kg/ha of hen manure and pig manure showed an average yield of corn of 4.315,4.539 .4.246, and 4.487 kg/ha respectively. the control only produced 2.620 kg/ha. The great profitability was obtained with 500 kg/ ha of cow manure, 1.000 kg/ha of pig manure and the chemical treatment (300 kg/ha 10-30-10 and 150 kg/ha of urea y 1.000 kg/ha hen manure). There were not significative differences between the chemical fertilization and the organic fertilization; these results show that organic matter is an alternative for fertilization with respect to the development of a sustained and biological agriculture

Concentrations of Trace Elements in Organic Fertilizers and Animal Manures and Feeds and Cadmium Contamination in Herbal Tea (Gynostemma pentaphyllum Makino).

Science.gov (United States)

Nookabkaew, Sumontha; Rangkadilok, Nuchanart; Prachoom, Norratouch; Satayavivad, Jutamaad

2016-04-27

Thailand is predominantly an agriculture-based country. Organic farming is enlisted as an important national agenda to promote food safety and international export. The present study aimed to determine the concentrations of trace elements in commercial organic fertilizers (fermented and nonfermented) composed of pig and cattle manures available in Thailand. Pig and cattle manures as well as animal feeds were also collected from either animal farms or markets. The results were compared to the literature data from other countries. Fermented fertilizer composed of pig manure contained higher concentrations of nitrogen (N) and phosphorus (P) than fertilizer composed of cattle manure. High concentrations of copper (Cu) and zinc (Zn) were also found in fertilizers and manures. Some organic fertilizers had high concentrations of arsenic (As), cadmium (Cd), and lead (Pb). The range of As concentration in these fertilizers was 0.50-24.4 mg/kg, whereas the ranges of Cd and Pb were 0.10-11.4 and 1.13-126 mg/kg, respectively. Moreover, pig manure contained As and Cd (15.7 and 4.59 mg/kg, respectively), higher than their levels in cattle manure (1.95 and 0.16 mg/kg, respectively). The use of pig manure as soil supplement also resulted in high Cd contamination in herbal tea (Gynostemma pentaphyllum Makino; GP). The Cd concentration in GP plants positively correlated with the Cd concentration in the soil. Therefore, the application of some organic fertilizers or animal manures to agricultural soil could increase some potentially toxic elements in soil, which may be absorbed by plants and, thus, increase the risk of contamination in agricultural products.

A dynamic growth model for prediction of nutrient partitioning and manure production in growing–finishing pigs: Model development and evaluation

DEFF Research Database (Denmark)

Danfær, Allan Christian; Jørgensen, Henry; Kebreab, E

2015-01-01

trials using growing–finishing pig diets that had a wide range of nutrient chemical composition. Nutrient and water excretion were quantified using the principle of mass conservation. The average daily observed and predicted manure production was 3.79 and 3.99 kg/d, respectively, with a RMSPE of 0.49 kg......Nutrient loading and air emissions from swine operations raise environmental concerns. The objective of the study was to describe and evaluate a mathematical model (Davis Swine Model) of nutrient partitioning and predict manure excretion and composition on a daily basis. State variables...... the body constituent pools. It was assumed that fluxes of metabolites follow saturation kinetics, depending on metabolite concentrations. The main inputs to the model were diet nutrient composition, feed intake, water-to-feed ratio, and initial BW. First, the model was challenged with nutrient partitioning...

Dutch notes on BAT (Best Available Techniques) for pig- and poultry intensive lifestock farms (draft)

Energy Technology Data Exchange (ETDEWEB)

Hendriks, H.J.M.; Van de Weerdhof, A.M. [Ministry of Agriculture, Nature Management and Fisheries, National Reference Centre Agriculture, Ede (Netherlands)

1999-08-01

This document describes available environmental control techniques for the pig- and poultry intensive lifestock farms. The purpose of this document is to support the identification of BAT for the European pig- and poultry housing, following the requirements of article 16 of the Council Directive 96/61, concerning Integrated Pollution Prevention and Control (IPPC Directive), which has been adopted on 24 September 1996. In this document, an attempt is made to include all relevant environmental aspects of the presented techniques. In this way, the integral weighing of available techniques is facilitated. Economical aspects of presented techniques are given as well. This document comprises the following elements: Process description; Emissions, economics and energy demand; and Candidate Best Available Techniques The rules concerning covered manure storage and low emission housing are based on the Environmental Management Act. This act sees to the activities in the 'appliance', which is in fact the farmyard and the animal-housing. The permit based on the Environmental Management Act regulates the nuisance and the environmental effects in relation to the housing. Manure application does not take place in the appliance but the application techniques are also added in this document as extra information. Those measures which are based on the Manure Act and the Manure Relocation Act are not taken into account. The Netherlands will deliver separate information on these subjects.

Tillage and manure effect on soil microbial biomass and respiration ...

African Journals Online (AJOL)

The objective of this study was to determine the influence of both tillage and liquid pig manure application on soil microbial biomass, enzyme activities and microbial respiration in a meadow soil. The results obtained did not show any significant effect of tillage and manure on microbial biomass carbon (C) and nitrogen (N) ...

Effect of animal manures on soil properties, growth, nutrients status ...

African Journals Online (AJOL)

A comparative field study was carried out at two sites in Akure, Southwest Nigeria to determine effect of different animal manures on soil physical and chemical properties and performance of tomato (Lycopersicm esculentus Mill). Analysis of cattle (CM), goat (GM), pig (PG) and poultry (PM) manures showed that N, K, Ca ...

Integrated manure utilization system life-cycle value assessment

Energy Technology Data Exchange (ETDEWEB)

Row, J.; Neabel, D. [Pembina Inst. for Appropriate Development, Drayton Valley, AB (Canada)

2005-10-15

A life-cycle assessment of the Alberta Research Council (ARC) and Highmark Renewables' development of an integrated manure utilization system (IMUS) were presented. The assessment focused on an evaluation of factors of primary importance to government, investors and the livestock industry. IMUS technology uses manure as a resource to produce electricity, heat, bio-based fertilizer and reusable water. Results of the assessment indicated that IMUS plants have the potential to be financially viable if a power purchase of $90 MWh on average can be purchased from a 30,000 head livestock operation. A capital cost of under $11 million is necessary, and an established biofertilizer price of $50 per tonne should be established. An IMUS plant was estimated to reduce life-cycle greenhouse gas emissions by 70 to 80 per cent when compared to land spreading. Reductions are accomplished through displacing electricity from the provincial grid and reducing nitrous oxide (N{sub 2}O) emissions from spreading of manure The IMUS plants lessen environment impacts by reducing the extraction and consumption of non-renewable resources, and by displacing an estimated 11,700 GJ of coal and natural gas per 1000 head of cattle per year. In addition, various pathogens within manure are eliminated. The plants have the potential to eliminate the environmental hazards associated with the disposal of deadstock. The systems reduce manure odour, lessen truck traffic and are expected to contribute to rural economic diversification. Barriers to further implementation of IMUS were discussed, as well as emerging opportunities for IMUS developers. It was concluded that the initial assessments of the IMUS were positive. Further investigation is needed to determine actual life-cycle performance of the operations. 18 refs., 3 tabs., 3 figs.

Impact of manure-related DOM on sulfonamide transport in arable soils

Science.gov (United States)

Zhou, Dan; Thiele-Bruhn, Sören; Arenz-Leufen, Martina Gesine; Jacques, Diederik; Lichtner, Peter; Engelhardt, Irina

2016-09-01

Field application of livestock manure introduces colloids and veterinary antibiotics, e.g. sulfonamides (SAs), into farmland. The presence of manure colloids may potentially intensify the SAs-pollution to soils and groundwater by colloid-facilitated transport. Transport of three SAs, sulfadiazine (SDZ), sulfamethoxypyridazine (SMPD), and sulfamoxole (SMOX), was investigated in saturated soil columns with and without manure colloids from sows and farrows, weaners, and fattening pigs. Experimental results showed that colloid-facilitated transport of SMOX was significant in the presence of manure colloids from fattening pigs with low C/N ratio, high SUVA280 nm and protein C, while manure colloids from sows and farrows and weaners had little effect on SMOX transport. In contrast, only retardation was observed for SDZ and SMPD when manure colloids were present. Breakthrough curves (BTCs) of colloids and SAs were replicated well by a newly developed numerical model that considers colloid-filtration theory, competitive kinetic sorption, and co-transport processes. Model results demonstrate that mobile colloids act as carriers for SMOX, while immobile colloids block SMOX from sorbing onto the soil. The low affinity of SMOX to sorb on immobile colloids prevents aggregation and also promotes SMOX's colloid-facilitated transport. Conversely, the high affinity of SDZ and SMPD to sorb on all types of immobile colloids retarded their transport. Thus, manure properties play a fundamental role in increasing the leaching risk of hydrophobic sulfonamides.

Stochastic modelling of the economic viability of on-farm co-digestion of pig manure and food waste in Ireland

International Nuclear Information System (INIS)

Dennehy, C.; Lawlor, P.G.; Gardiner, G.E.; Jiang, Y.; Shalloo, L.; Zhan, X.

2017-01-01

Highlights: •Assessed economic viability of on-farm manure mono- and co-digestion. •Assessed three farm sizes: 521 sows; 2607 sows; and 5214 sows. •Mono-digestion of manure alone not economically viable. •Co-digestion viable on small farms as food waste likely to be sourced. •Viability on larger farms dependent on securing sufficient food waste. -- Abstract: The majority of studies analysing the economic potential of biogas systems utilise deterministic models to assess the viability of a system using fixed inputs. However, changes in market conditions can significantly affect the viability of biogas plants, and need to be accounted for. This study assessed the economic potential of undertaking on-farm anaerobic co-digestion of food waste (FW) and pig manure (PM) using both deterministic and stochastic modelling approaches. The financial viability of three co-digestion plants sized to treat PM generated from 521, 2607 and 5214 sow integrated units was assessed. Under current market conditions the largest co-digestion scenario modelled was found to be unviable. Stochastic modelling of four key input variables (FW availability, renewable electricity tariff, gate fees and digestate disposal costs) was undertaken to assess the sensitivity of project viability to changes in market conditions. Due to the high likelihood of accessing sufficient FW, the smallest co-digestion scenario was found to be the least sensitive to any future changes in market conditions. Due to its potential to treat greater amounts of FW than the smallest scenario, a co-digestion plant designed for a 2607 sow farm had the highest revenue generating potential under optimal market conditions; however, it was more sensitive to changes in FW availability than the smaller scenario. This study illustrates the need for farm-based biogas plant projects to secure long-term, stable supplies of co-substrates and to size plants’ capacity based on the availability of the co-substrates which drive

Excessive application of pig manure increases the risk of P loss in calcic cinnamon soil in China.

Science.gov (United States)

Yang, Yanju; Zhang, Haipeng; Qian, Xiaoqing; Duan, Jiannan; Wang, Gailan

2017-12-31

Soil phosphorus (P) is a critical factor affecting crop yields and water environmental quality. To investigate the degree of loss risk and forms of soil P in calcic cinnamon soil, the P fraction activities in soils were analysed using chemical methods, combined with an in situ field experiment. Seven treatments were set in this study, including control (unfertilized), no P fertilizer (No-P), mineral P fertilizer (Min-P), low (L-Man) and high (H-Man) quantities of pig manure, Min-P+L-Man, and Min-P+H-Man. The results showed that manure fertilizer could not only significantly increase maize yield but could also enhance the accumulation of soil P in organic and inorganic forms. After 23years of repeated fertilization, the soil Olsen-P contents respectively showed 64.7-, 43.7- and 31.9-fold increases in the Min-P+H-Man, Min-P+L-Man and H-Man treatments, while the soil Olsen-P in Min-P treatment only increased 23.7-fold. The soil Olsen-P thresholds ranged from 22.59 to 32.48mgkg -1 in calcic cinnamon soil to maintain a higher maize yield as well as a lower risk of P loss. Therefore, long-term excessive manure application could obviously raise the content of soil Olsen-P and increase the risk of P loss in calcic cinnamon soil. Copyright © 2017 Elsevier B.V. All rights reserved.

Comparison of bacterial community structure and dynamics during the thermophilic composting of different types of solid wastes: anaerobic digestion residue, pig manure and chicken manure

Science.gov (United States)

Song, Caihong; Li, Mingxiao; Jia, Xuan; Wei, Zimin; Zhao, Yue; Xi, Beidou; Zhu, Chaowei; Liu, Dongming

2014-01-01

This study investigated the impact of composting substrate types on the bacterial community structure and dynamics during composting processes. To this end, pig manure (PM), chicken manure (CM), a mixture of PM and CM (PM + CM), and a mixture of PM, CM and anaerobic digestion residue (ADR) (PM + CM + ADR) were selected for thermophilic composting. The bacterial community structure and dynamics during the composting process were detected and analysed by polymerase chain reaction–denaturing gradient gel electrophoresis (DGGE) coupled with a statistic analysis. The physical-chemical analyses indicated that compared to single-material composting (PM, CM), co-composting (PM + CM, PM + CM + ADR) could promote the degradation of organic matter and strengthen the ability of conserving nitrogen. A DGGE profile and statistical analysis demonstrated that co-composting, especially PM + CM + ADR, could improve the bacterial community structure and functional diversity, even in the thermophilic stage. Therefore, co-composting could weaken the screening effect of high temperature on bacterial communities. Dominant sequencing analyses indicated a dramatic shift in the dominant bacterial communities from single-material composting to co-composting. Notably, compared with PM, PM + CM increased the quantity of xylan-degrading bacteria and reduced the quantity of human pathogens. PMID:24963997

Comparison of oxytetracycline degradation behavior in pig manure with different antibiotic addition methods.

Science.gov (United States)

Wang, Yan; Chen, Guixiu; Liang, Juanboo; Zou, Yongde; Wen, Xin; Liao, Xindi; Wu, Yinbao

2015-12-01

Using manure collected from swine fed with diet containing antibiotics and antibiotic-free swine manure spiked with antibiotics are the two common methods of studying the degradation behavior of veterinary antibiotic in manure in the environment. However, few studies had been conducted to co-compare these two different antibiotic addition methods. This study used oxytetracycline (OTC) as a model antibiotic to study antibiotic degradation behavior in manure under the above two OTC addition methods. In addition, the role of microorganisms present in the manure on degradation behavior was also examined. The results showed that degradation half-life of OTC in manure from swine fed OTC (9.04 days) was significantly shorter than that of the manure directly treated with OTC (9.65 days). Concentration of 4-epi-OTC in manure from swine fed OTC peaked earlier than that in manure spiked with OTC, and the degradation rates of 4-epi-OTC and α-apo-OTC in the manure from swine fed OTC were faster, but the peak concentrations were lower, than those in manure spiked with OTC. Bacterial diversity and relative abundance of Bacillus cereus data demonstrated that sterilization of the manure before experiment significantly decreased OTC degradation rate in both of the addition methods. Results of the present study demonstrated that the presence of the metabolites (especially 4-epi-OTC) and microorganisms had significant influence on OTC degradation.

Fate of viable but non-culturable Listeria monocytogenes in pig manure microcosms

Directory of Open Access Journals (Sweden)

Jeremy eDesneux

2016-03-01

Full Text Available The fate of two strains of L. monocytogenes and their ability to become viable but non-culturable (VBNC was investigated in microcosms containing piggery effluents (two raw manures and two biologically treated manures stored for two months at 8°C and 20°C. Levels of L. monocytogenes were estimated using the culture method, qPCR, and propidium monoazide treatment combined with qPCR (qPCRPMA. The chemical composition and the microbial community structure of the manures were also analysed. The strains showed similar decline rates and persisted up to 63 days. At day zero, the percentage of VBNC cells among viable cells was higher in raw manures (81.5-94.8% than in treated manures (67.8-79.2%. The changes in their proportion over time depended on the temperature and on the type of effluent: the biggest increase was observed in treated manures at 20°C and the smallest increase in raw manures at 8°C. The chemical parameters had no influence on the behaviour of the strains, but decrease of the persistence of viable cells was associated with an increase in the microbial richness of the manures. This study demonstrated that storing manure altered the culturability of L. monocytogenes, which rapidly entered the VBNC state, and underlines the importance of including VBNC cells when estimating the persistence of the pathogens in farm effluents.

Technical Protocol. Transformation of biocides in liquid manures

Energy Technology Data Exchange (ETDEWEB)

Kreuzig, Robert; Schlag, Patrick; Teigeler, Jennifer; Hartmann, Constanze; Cvetkovi, Benjamin [Technische Univ. Braunschweig (Germany). Inst. fuer Oekologische Chemie und Abfallanalytik

2010-07-15

The Reference Manure Concept, already developed for laboratory tests on fate and behavior of veterinary medicinal products in liquid manures and manured soils, was successfully applied for biocides used for disinfection purposes and control of insects in animal houses. Since the representative and reproducible sampling of manures from high-volume tanks has been considered impossible, excrement samples of cattle and pigs individually kept at an experimental animal house were taken. These samples were thoroughly matrix characterized. Then, tap water was added to prepare reference manures of definite dry substance contents. Subsequently, the long-term transformation of the biocides imazalil and cyanamide applied as {sup 14}C-labeled radiotracers was investigated in these manure samples. On the basis of the transformation tests, test manures with 7-day aged biocide residues were prepared and applied in laboratory tests on transformation and sorption in manured soil. By means of this experimental approach, the impacts of aging processes during manure storage and of the manure matrix on the fate of biocides in soils can be assessed already under laboratory conditions. These laboratory tests have been directed as closely as possible to agricultural practice as well as to analytical practicability and quality assurance. Finally, the methodological aspects have been compiled in a Technical Protocol (Draft version). (orig.)

Impacts of supplementing chemical fertilizers with organic fertilizers manufactured using pig manure as a substrate on the spread of tetracycline resistance genes in soil.

Science.gov (United States)

Kang, Yijun; Hao, Yangyang; Shen, Min; Zhao, Qingxin; Li, Qing; Hu, Jian

2016-08-01

Using pig manure (PM) compost as a partial substitute for the conventional chemical fertilizers (CFs) is considered an effective approach in sustainable agricultural systems. This study aimed to analyze the impacts of supplementing CF with organic fertilizers (OFs) manufactured using pig manure as a substrate on the spread of tetracycline resistance genes (TRGs) as well as the community structures and diversities of tetracycline-resistant bacteria (TRB) in bulk and cucumber rhizosphere soils. In this study, three organic fertilizers manufactured using the PM as a substrate, namely fresh PM, common OF, and bio-organic fertilizer (BF), were supplemented with a CF. Composted manures combined with a CF did not significantly increase TRB compared with the CF alone, but PM treatment resulted in the long-term survival of TRB in soil. The use of CF+PM also increased the risk of spreading TRGs in soil. As beneficial microorganisms in BF may function as reservoirs for the spread of antibiotic resistance genes, care should be taken when adding them to the OF matrix. The PM treatment significantly altered the community structures and increased the species diversity of TRB, especially in the rhizosphere soil. BF treatment caused insignificant changes in the community structure of TRB compared with CF treatment, yet it reduced the species diversities of TRB in soil. Thus, the partial use of fresh PM as a substitute for CF could increase the risk of spread of TRGs. Apart from plant growth promotion, BF was a promising fertilizer owing to its potential ability to control TRGs. Copyright © 2016 Elsevier Inc. All rights reserved.

Mesophilic and psychrophilic digestion of liquid manure

NARCIS (Netherlands)

Zeeman, G.

1991-01-01

IN GENERAL

In this thesis the possibilities for digestion of cow and pig manure are described for a completely stirred tank reactor system (CSTR) and an accumulation system (AC-system).
For this purpose were researched:
1. Anaerobic digestion

Effects of mix ratio, moisture content and aeration rate on sulfur odor emissions during pig manure composting.

Science.gov (United States)

Zang, Bing; Li, Shuyan; Michel, Frederick; Li, Guoxue; Luo, Yuan; Zhang, Difang; Li, Yangyang

2016-10-01

Sulfur compounds in swine manure can cause odor emissions during composting if conditions are not conducive to their rapid oxidation and degradation. In this study, the effects of controllable composting process variables on sulfur odor emissions were investigated. These included pig manure to corn stalk mix ratio (0.7:1, 1.5:1 and 2.2:1dw basis), initial moisture content (60%, 65%, 70% and 75%) and aeration rate (1.0, 2.0, 3.0 and 4.0m(3)m(-3)h(-1)). The compounds measured were carbonyl sulfide, carbon disulfide, hydrogen sulfide, methyl mercaptan, ethyl mercaptan, diethyl sulfide, dimethyl sulfide (Me2S) and dimethyl disulfide (Me2SS). The results showed that total sulfur losses ranged from 3.9% to 18.3% after 26days of composting. Me2S and Me2SS were the primary (>59.61%) sulfur compounds released during this period. After turning, emission rates of both Me2S and Me2SS increased. Emissions of the other six sulfur compounds were low and inconsistent during composting. Within the compost, feedstock mix ratio significantly influenced the concentration of Me2SS, while aeration rate significantly affected Me2S concentration (pMoisture content did not have a significant effect on the concentrations of either of these two compounds. Concentrations of sulfur odor compounds were the lowest at the highest aeration rate. Therefore, high aeration rates during the thermophilic phase, especially after turning, are recommended to minimize sulfur odors produced during swine manure composting. Copyright © 2016 Elsevier Ltd. All rights reserved.

Performance of phosphogypsum and calcium magnesium phosphate fertilizer for nitrogen conservation in pig manure composting.

Science.gov (United States)

Li, Yun; Luo, Wenhai; Li, Guoxue; Wang, Kun; Gong, Xiaoyan

2018-02-01

This study investigated the performance of phosphogypsum and calcium magnesium phosphate fertilizer for nitrogen conservation during pig manure composting with cornstalk as the bulking agent. Results show that phosphogypsum increased nitrous oxide (N 2 O) emission, but significantly reduced ammonia (NH 3 ) emission and thus enhanced the mineral and total nitrogen (TN) contents in compost. Although N 2 O emission could be reduced by adding calcium magnesium phosphate fertilizer, NH 3 emission was considerably increased, resulting in an increase in TN loss during composting. By blending these two additives, both NH 3 and N 2 O emissions could be mitigated, achieving effective nitrogen conservation in composting. More importantly, with the addition of 20% TN of the mixed composting materials, these two additives could synergistically improve the compost maturity and quality. Copyright © 2017 Elsevier Ltd. All rights reserved.

Microbiological and chemical attributes of a Hapludalf soil with swine manure fertilization

Directory of Open Access Journals (Sweden)

Rafael da Rosa Couto

2013-07-01

Full Text Available The objective of this work was to evaluate the microbiological and chemical attributes of a soil with a seven‑year history of urea and swine manure application. In the period from October 2008 to October 2009, soil samples were collected in the 0-10 cm layer and were subjected to the treatments: control, without application of urea or manure; and with the application of urea, pig slurry, and deep pig litter in two doses, in order to supply one or two times the recommended N doses for the maize (Zea mays/black oat (Avena strigosa crop succession. The carbon of the microbial biomass (MB‑C and the basal respiration (C‑CO2 were analyzed, and the metabolic (qCO2 and microbial quotient (qmic were calculated with the obtained data. Organic matter, pH in water, available P and K, and exchangeable Ca and Mg were also determined. The application of twice the dose of deep pig litter increases the MB‑C and C‑CO2 values. The qmic and qCO2 are little affected by the application of swine manure. The application of twice the dose of deep pig litter increases the values of pH in water and the contents of available P and of exchangeable Ca and Mg in the soil.

Economic feasibility and evaluation of a novel manure collection and anaerobic digestion system at a commercial swine finisher enterprise

International Nuclear Information System (INIS)

Meinen, Robert J.; Kephart, Kenneth B.; Graves, Robert E.

2014-01-01

A case study conducted at a commercial swine-finishing farm demonstrated that a novel manure management system increased economic feasibility of an anaerobic digester by eliminating the need for post-digestion manure storage construction at the farm. Uniquely designed underfloor manure storage pits collected manure for delivery to the digester, and then stored post-digested manure (digestate) in underfloor storage within the same swine houses. It was unknown if the introduction of biologically active digestate into these pits would produce pig living space air quality that was adverse to pig health, growth or survival, or if explosive methane levels would be generated within the buildings. Monitoring of air quality indicators both before and after digestate introduction to underfloor manure storage pits resulted in no observations of hydrogen sulfide (H 2 S) or methane (CH 4 ) concentrations above critical safety levels in swine housing. Hourly mean ammonia (NH 3 ) concentrations at pig level (0.15 m above the floor) before digestate was present in the buildings were higher (P < 0.05) compared to when digestate was present (24 ± 2.8 ppm vs. 17 ± 1.0 ppm). Air quality measures did not indicate that digestate introduction into underfloor manure pits caused degradations of air quality at pig level. No obvious etiologic effects on swine were observed. Evaluation of the electric cogeneration system showed that cost-savings of electricity produced from biogas combustion was approximately equal to the producer's debt service for capital investment. External funding and low interest financing were necessary for electric cost-savings to offset finance payments. - Highlights: • Swine dunging behavior used to collect 75% of manure for anaerobic digestion. • Digestate returned to housing without adverse etiologic or air quality effects. • System design offered some economic advantages. • Outside funding necessary for electric cost savings to offset

The effect of manure management regulations on competitiveness

DEFF Research Database (Denmark)

Andersen, Mikael Skou

2003-01-01

Significant differences in the competitiveness of pig production along with growing international competition in the pigmeat market have raised concerns about the cost impact of environmental regulations on producers, particularly those regarding the management of manure. There appears to be a U...

Accumulation of sulfonamide resistance genes in arable soils due to repeated application of manure containing sulfadiazine.

Science.gov (United States)

Heuer, Holger; Solehati, Qodiah; Zimmerling, Ute; Kleineidam, Kristina; Schloter, Michael; Müller, Tanja; Focks, Andreas; Thiele-Bruhn, Sören; Smalla, Kornelia

2011-04-01

Two soils were amended three times with pig manure. The abundance of sulfonamide resistance genes was determined by quantitative PCR 2 months after each application. In both soils treated with sulfadiazine-containing manure, the numbers of copies of sul1 and sul2 significantly increased compared to numbers after treatments with antibiotic-free manure or a control and accumulated with repeated applications.

Characteristics and Availability of Different Forms of Phosphorus in Animal Manures

Directory of Open Access Journals (Sweden)

YAN Zheng-juan

2015-02-01

Full Text Available The rapid development of intensive livestock industry has greatly increased the discharge of animal manure. Reasonable utilization of large amounts of phosphorus(Pin animal manure can not only save the fertilizer resource, but also avoid water pollution from manure due to direct discharge or excess application in farmland. In this study, P contents and fractionation in 76 animal manures were analyzed using Hedley P fractionation method based on the survey for 52 livestock farms, and P mobility and environmental risks in different manures were evaluated as the reference for manure P management. The results showed that there were significant differences in total P content of animal manures. The mean P contents were 22.5, 13.7, 12.9, 9.6 g P·kg-1 and 7.5 g P·kg-1, in which the proportion of organic P in total P were 33.1%, 41.5%, 66.4%, 28.1%and 36.8%in pig, chicken, duck, cattle and sheep manures, respectively. The contents of total and organic P in non-ruminant animal manure(pig, chicken and duck manureswere 1.7~3.0 times and 2.1~3.0 times greater than that in ruminant manure (cattle and sheep manuresand the proportion of organic P in total P in poultry manure was higher than that in other manures. P mineraliza-tion was easier in non-ruminant animal manure with lower C/P ratio(19~29, compared with that in ruminant manure with C/P ratio of 38~45. Manure P was sequentially extracted by deionized water(H2O-P, NaHCO3(NaHCO3-P, NaOH(NaOH-Pand HCl(HCl-P. The pro-portion of H2O-P, NaHCO3-P, NaOH-P, HCl-P and residual-P in total P in ruminant animal manure were 27.8%, 32.8%, 18.1%, 15.2%and 6.1%, respectively, while that were 24.6%, 19.4%, 12.7%, 34.4% and 8.9% in non-ruminant animal manure. The significant differences were in NaHCO3-P and HCl-P between ruminant and non-ruminant animal manures. Ruminant manure had greater proportion of liable P (H2O-P and NaHCO3-Pin total P(>60%, but the characteristics of higher mineralization rate might result in

The sensitivity of the most common microorganisms of pig liquid manure to the effect of 60Co irradiation

International Nuclear Information System (INIS)

Szemeredy, Gy.; Simon, J.

1979-01-01

In model experiments the most common representatives of pathogens and facultative pathogens of pig liquid manure contaminating bacterial flora were examined for their sensitivity to different doses of 60 Co, using liquid medium supplemented with 1% glucose, as well as Korthof-medium and different kinds of selective media. Erysipelothrix rhusiopathiea, Brucella suis, Mycoplasma hyorhinis and Pasteurella haemolytica proved to be the most senstive ones to irradiation, as they did not survive 100 krad dose. The highest resistances were observed in the cases of the following microorganisms: the spore containing Bacillus anthracis, killed by 700 krad irradiation dose, the saprophytic and pathogenic Mycobacteria and the spore containing Clostridium perfringens, killed by 1000-1500 krad irradiation. (author)

Coupling Cover Crops with Alternative Swine Manure Application Strategies: Manure-15N Tracer Studies

Science.gov (United States)

Integration of rye cover crops with alternative liquid swine (Sus scrofa L.) manure application strategies may enhance retention of manure N in corn (Zea mays L.) - soybean [Glycine max (L.) Merr] cropping systems. The objective of this study was to quantify uptake of manure derived-N by a rye (Seca...

Joint stabilization of sewage sludge and separated manure fluid. Treatment and utilization of manure. Final report; Gemeinsame Stabilisierung von Klaerschlamm und separierter Guellefluessigkeit. Guellebehandlung und -verwertung. Schlussbericht

Energy Technology Data Exchange (ETDEWEB)

Geiger, W.F.; Kolisch, G.

1994-12-01

As an alternative to separate manure processing, anaerobic stabilization of surplus manure and sewage sludge in combination is possible at municipal sewage treatment plants. Subsequently to the removal of solids, pig manure is fed into existing digesters. The process concept comprises the following partial steps: preliminary treatment of crude manure, anarobic stabilization of the separated manure fluid, biological nitrogen elimination from the digested mixture of sewage sludge and manure, and dewatering of the mixed sludge in the dewatering systems of the sewage treatment plant. (orig./SR) [Deutsch] Eine Alternative zu den Verfahren einer separaten Guelleaufbereitung stellt die gemeinsame anaerobe Stabilisierung von Ueberschussguelle und Klaerschlamm auf kommunalen Klaeranlagen dar, die eine Einspeisung feststoffseparierter Schweineguelle in bereits vorhandene Faulbehaelter vorsieht. Das Verfahrenskonzept besteht aus den Teilschritten Vorseparierung der Rohguelle, anaerobe Stabiliserung der separierten Guellefluessigkeit, biologische Stickstoffelimination aus dem ausgefaulten Klaerschlamm-Guelle-Gemisch sowie Entwaesserung der Mischschlaemme auf den Entwaesserungsaggregaten der Klaeranlage. (orig./SR)

Changes in physical properties and organic carbon of a Kandiudox fertilized with manure

Directory of Open Access Journals (Sweden)

Andréia Patricia Andrade

2016-05-01

Full Text Available ABSTRACT: Successive applications of pig slurry and poultry manure can improve the soil structure, according to the land use conditions and amounts applied. This study evaluated the effect of manure fertilization on the physical properties and organic carbon of a Rhodic Kandiudox. Treatments included land use and management and time of pig slurry and poultry litter application, namely: native forest (NF; yerba mate after 20 years of animal waste application (YM20; pasture after 15 years of application (P15; grassland after 20 years of manuring (PP20; grassland after 3 years of manuring (P3; pasture without application (P0, maize after 20 years of application (M20; and maize after 7 years of application (M7. Soil samples were collected in the 0-5, 5-10 and 10-20cm layers, in which density, porosity, aggregate stability, flocculation, penetration resistance, available water, and total clay content, total and particulate organic carbon, and C:N ratio were analyzed. The total organic carbon is sensitive to management and was not related to waste application, except in the 10-20cm layer of ryegrass pasture after three years of manuring. Reponses to waste application and land use and management systems were observed in the variables soil density and penetration resistance.

Accumulation of Sulfonamide Resistance Genes in Arable Soils Due to Repeated Application of Manure Containing Sulfadiazine ▿

OpenAIRE

Heuer, Holger; Solehati, Qodiah; Zimmerling, Ute; Kleineidam, Kristina; Schloter, Michael; Müller, Tanja; Focks, Andreas; Thiele-Bruhn, Sören; Smalla, Kornelia

2011-01-01

Two soils were amended three times with pig manure. The abundance of sulfonamide resistance genes was determined by quantitative PCR 2 months after each application. In both soils treated with sulfadiazine-containing manure, the numbers of copies of sul1 and sul2 significantly increased compared to numbers after treatments with antibiotic-free manure or a control and accumulated with repeated applications.

The effect of anaerobic digestion and storage on indicator microorganisms in swine and dairy manure.

Science.gov (United States)

Costa, Annamaria; Gusmara, Claudia; Gardoni, Davide; Zaninelli, Mauro; Tambone, Fulvia; Sala, Vittorio; Guarino, Marcella

2017-11-01

The aim of this experimental study was to evaluate the influence of anaerobic digestion and storage on indicator microorganisms in swine and dairy excreta. Samples were collected every 90 days for 15 months at eight farms, four pig, and four dairy farms, four of them having a biogas plant. Moreover, to evaluate storage effects on samples, 20 l of manure and slurry taken at each farm (digested manure only in farms with a biogas plant) were stored in a controlled climatic chamber at 18 °C, for 6 months. The bacterial load and the chemical-physical characteristics of excreta were evaluated at each sampling time, stored slurry, and manure were sampled and analyzed every 2 months. A high variability of the concentration of bacteria in the different excreta types was observed during the experiment, mainly depending on the type and time of treatment. No sample revealed either the presence of Escherichia coli O157:H7 or of Salmonella, usually linked to the temporary rearing of infected animals in facilities. Anaerobic digestion and storage affected in a significant way the reduction of indicator bacteria like lactobacilli, coliforms, and streptococci. Anaerobic digestion lowered coliforms in pig slurry (- 2.80 log, P manure (- 2.44 log, P < 0.001) and in pig slurry (- 1.43 log, P < 0.05), and lactobacilli in pig slurry (- 3.03 log, P < 0.05). Storage lowered coliforms and the other indicators counts, in particular in fresh wastes, while clostridia did not show a reduction in concentration.

Mass and Energy Balances of Dry Thermophilic Anaerobic Digestion Treating Swine Manure Mixed with Rice Straw

OpenAIRE

Zhou, Sheng; Zhang, Jining; Zou, Guoyan; Riya, Shohei; Hosomi, Masaaki

2015-01-01

To evaluate the feasibility of swine manure treatment by a proposed Dry Thermophilic Anaerobic Digestion (DT-AD) system, we evaluated the methane yield of swine manure treated using a DT-AD method with rice straw under different C/N ratios and solid retention time (SRT) and calculated the mass and energy balances when the DT-AD system is used for swine manure treatment from a model farm with 1000 pigs and the digested residue is used for forage rice production. A traditional swine manure trea...

Comparison of biochar, zeolite and their mixture amendment for aiding organic matter transformation and nitrogen conservation during pig manure composting.

Science.gov (United States)

Wang, Quan; Awasthi, Mukesh Kumar; Ren, Xiuna; Zhao, Junchao; Li, Ronghua; Wang, Zhen; Chen, Hongyu; Wang, Meijing; Zhang, Zengqiang

2017-12-01

The aim of this work was to compare the impact of biochar, zeolite and their mixture on nitrogen conservation and organic matter transformation during pig manure (PM) composting. Four treatments were set-up from PM mixed with wheat straw and then applied 10% biochar (B), 10% zeolite (Z) and 10% biochar+10% zeolite (B+Z) into composting mixtures (dry weight basis), while treatment without additives applied used as control. Results indicated that adding B, Z and B+Z could obviously (pcompost quality indicated that the combined use of biochar and zeolite could be more useful for PM composting. Copyright © 2017 Elsevier Ltd. All rights reserved.

Anammox for ammonia removal from pig manure effluents: Effect of organic matter content on process performance

DEFF Research Database (Denmark)

Salces, Beatriz Molinuevo; García, M. C.; Karakashev, Dimitar Borisov

2009-01-01

oxidation) diluted with synthetic wastewater. High ammonium removal was achieved, up to 92.1 +/- 4.9% for diluted UASB-post-digested effluent (95 mg COD L-1) and up to 98.5 +/- 0.8% for diluted partially oxidized effluent (121 mg COD L-1). Mass balance clearly showed that an increase in organic loading......The anammox process, under different organic loading rates (COD), was evaluated using a semi-continous UASB reactor at 37 degrees C. Three different substrates were used: initially, synthetic wastewater, and later, two different pig manure effluents (after UASB-post-digestion and after partial...... improved ammonium removal at high organic matter concentration. Up to threshold organic load concentration of 142 mg COD L-1 of UASB-post-digested effluent and 242 mg COD L-1 of partially oxidized effluent, no effect of organic loading on ammonia removal was registered (ammonium removal was above 80...

Salmonella Weltevreden in integrated and non-integrated tilapia aquaculture systems in Guangdong, China.

Science.gov (United States)

Li, Kang; Petersen, Gitte; Barco, Lisa; Hvidtfeldt, Kristian; Liu, Liping; Dalsgaard, Anders

2017-08-01

Integrated tilapia-pig farming, which uses manure from pigs as fertilizers in fish pond, is a traditional and common production system practised by small-scale farmers in South-east Asia. Although such systems may be environmentally sustainable, they also pose potential food safety hazards including transmission of faecal zoonotic pathogens and accumulation of antimicrobial and other chemical residues. This study aimed to determine differences in occurrence and characteristics of Salmonella spp. isolated from tilapia-pig and non-integrated aquaculture systems in Guangdong province, China. A total of 77 samples (9 pig feed, 19 fish feed, 9 pig faeces, 20 fish mucus and 20 fish intestine) from 10 tilapia-pig ponds and 10 non-integrated ponds were analysed. Salmonella spp. was found in fish mucus (20.0%), fish intestine (40.0%) and pig faeces (11.1%) from integrated ponds, and from fish mucus (40.0%) and fish intestine (40.0%) from non-integrated ponds. S. Weltevreden (76.5%) was by far the most common serovar showing limited antimicrobial resistance. One pig faeces sample contained S. Typhimurium whereas feed samples were found free of Salmonella spp.. DNA fingerprinting by the PFGE method showed a clonal relationship of S. Weltevreden which was supported by similar antimicrobial resistance patterns (sulfamethoxazole and trimethoprim resistance) as well as most isolates harbouring a 147-kb sized plasmid. The common finding of S. Weltevreden in both tilapia production systems indicates that this serovar may have a different ecology and increased survival in aquaculture environments in comparison with other Salmonella serovars. Further in vivo studies of the ecology of S. Weltevreden in aquaculture environments are needed. Copyright © 2017. Published by Elsevier Ltd.

Pig-duck-fish-azolla integration in La Union, Philippines

OpenAIRE

Gavina, L.D.

1994-01-01

Three studies on pig-duck-fish-azolla integration were conducted simultaneously in La Union, Philippines. Growth performance of pigs and ducks as affected by different levels of azolla meal in their feed, and that of tilapia (Oreochromis niloticus) under varying stocking rates are presented and discussed.

Spent mushroom substrate biochar as a potential amendment in pig manure and rice straw composting processes.

Science.gov (United States)

Chang, Ken-Lin; Chen, Xi-Mei; Sun, Jian; Liu, Jing-Yong; Sun, Shui-Yu; Yang, Zuo-Yi; Wang, Yin

2017-07-01

Spent mushroom substrate (SMS) is a bulky waste byproduct of commercial mushroom production, which can cause serious environmental problems and, therefore, poses a significant barrier to future expansion of the mushroom industry. In the present study, we explored the use of SMS as a biochar to improve the quality of bio-fertilizer. Specifically, we performed a series of experiments using composting reactors to investigate the effects of SMS biochar on the physio-chemical properties of bio-fertilizer. Biochar was derived from dry SMS pyrolysed at 500°C and mixed with pig manure and rice straw. Results from this study demonstrate that the addition of biochar significantly reduced electrical conductivity and loss of organic matter in compost material. Nutrient analysis revealed that the SMS-derived biochar is rich in fertilizer nutrients such as P, K, Na, and N. All of these findings suggest that SMS biochar could be an excellent medium for compost.

Alterations in soil microbial activity and N-transformation processes due to sulfadiazine loads in pig-manure

International Nuclear Information System (INIS)

Kotzerke, Anja; Sharma, Shilpi; Schauss, Kristina; Heuer, Holger; Thiele-Bruhn, Soeren; Smalla, Kornelia; Wilke, Berndt-Michael; Schloter, Michael

2008-01-01

Most veterinary drugs enter the environment via manure application. However, it is unclear how these substances interact with soil biota. Therefore, it was the aim of the present study to investigate the effects of manure containing different concentrations of the antibiotic sulfadiazine (SDZ) on the soil microbial communities. It was shown that manure alone has a stimulating effect on microbial activity. Only potential nitrification was negatively influenced by manure application. The addition of SDZ to the manure reduced microbial activity. Depending on the SDZ concentration, levels of activity were in the range of the control soil without manure application. Also, selected processes in nitrogen turnover were negatively influenced by the addition of SDZ to the manure, with nitrification being the only exception. The effects were visible for up to 4 days after application of the manure with or without SDZ and were correlated with the bioavailability of the antibiotic. - This study gives first insights into the effects of manure containing the antibiotic sulfadiazine on microbial activity and nitrogen transformation potentials in soil

Effect of Dietary Protein Levels on Composition of Odorous Compounds and Bacterial Ecology in Pig Manure

Directory of Open Access Journals (Sweden)

Sungback Cho

2015-09-01

Full Text Available This study was performed to investigate the effect of different levels of dietary crude protein (CP on composition of odorous compounds and bacterial communities in pig manure. A total of 48 male pigs (average initial body weight 45 kg fed diets containing three levels of dietary CP (20%, 17.5%, and 15% and their slurry samples were collected from the pits under the floor every week for one month. Changes in composition of odorous compounds and bacterial communities were analyzed by gas chromatography and 454 FLX titanium pyrosequencing systems, respectively. Levels of phenols, indoles, short chain fatty acid and branched chain fatty acid were lowest (p<0.05 in CP 15% group among three CP levels. Relative abundance of Bacteroidetes phylum and bacterial genera including Leuconostoc, Bacillus, Atopostipes, Peptonphilus, Ruminococcaceae_uc, Bacteroides, and Pseudomonas was lower (p<0.05 in CP 15% than in CP 20% group. There was a positive correlation (p<0.05 between odorous compounds and bacterial genera: phenol, indole, iso-butyric acid, and iso-valeric acid with Atopostipes, p-cresol and skatole with Bacteroides, acetic acid and butyric acid with AM982595_g of Porphyromonadaceae family, and propionic acid with Tissierella. Taken together, administration of 15% CP showed less production of odorous compounds than 20% CP group and this result might be associated with the changes in bacterial communities especially whose roles in protein metabolism.

Haalbaarheidsstudie terugwinning van mestnutriënten : Fase 1: Processchema en nutriëntenstromen = Feasibility study on nutrient recovery from animal manure : Phase 1: Process scheme and nutrient flows

NARCIS (Netherlands)

Starmans, D.A.J.; Melse, R.W.; Sanders, J.P.M.

2011-01-01

A process scheme for a new manure treatment system for pig and cattle manure was formulated which aims to produce manure nutrient flows with added value. The basic process behind the treatment system is fermentation of manure, which is preceded by both stripping ammonia and chemical digestion of the

Effects of genetically modified cotton stalks on antibiotic resistance genes, intI1, and intI2 during pig manure composting.

Science.gov (United States)

Duan, Manli; Gu, Jie; Wang, Xiaojuan; Li, Yang; Zhang, Sheqi; Yin, Yanan; Zhang, Ranran

2018-01-01

Genetically modified (GM) cotton production generates a large yield of stalks and their disposal is difficult. In order to study the feasibility of using GM cotton stalks for composting and the changes that occur in antibiotic resistance genes (ARGs) during composting, we supplemented pig manure with GM or non-GM cotton stalks during composting and we compared their effects on the absolute abundances (AA) of intI1, intI2, and ARGs under the two treatments. The compost was mature after processing based on the germination index and C/N ratio. After composting, the AAs of ARGs, intI1, and intI2 were reduced by 41.7% and 45.0% in the non-GM and GM treatments, respectively. The ARG profiles were affected significantly by temperature and ammonia nitrogen. In addition, excluding tetC, GM cotton stalks had no significant effects on ARGs, intI1, and intI2 compared with the non-GM treatment (p composting with livestock manure, and the AAs of ARGs can be reduced. Furthermore, the results of this study provide a theoretical basis for the harmless utilization of GM cotton stalks. Copyright © 2017 Elsevier Inc. All rights reserved.

of integrated application of farmyard manure, plant growth promoting rhizobacteria and chemical fertilizers on production of canola (Brassica napus L. in saline soil of Qum

Directory of Open Access Journals (Sweden)

H. Sabahi

2016-04-01

Full Text Available Canola (Brassica napus L. is one of the most important oil seed crops. In order to evaluate the effects of integrated fertilization (chemical, manure and biofertilizers on canola (B. napus variety Hyola 401 yield and uptake of mineral nutrients in saline soil and water, a field experiment was conducted in randomized complete blocks (RCBD arrangement with eight treatments in three replications in Qum Province, Iran. Treatments were: (1 Control, P%100 (Phosphorus %100, (2 P%75B1 (Phosphorus %75+ Barvar biofertilizer, (3 P%75B2 (Phosphorus %75+ Nitroxin biofertilizer, (4 P%75M (Phosphorus %75+ farmyard manure, (5 P%75B1M (Phosphorus %75+ Barvar + Farmyard manure, (6 P%75B2M (Phosphorus %75+ Nitroxin+ Farmyard manure, (7 P%100B1 (Phosphorus %100 + Barvar and (8 P%125B2 (Phosphorus %125+ Nitroxin. The results showed that the highest yield was obtained from P%75B1M. Difference between integrated fertilization of farmyard manure and other treatments was significant. Farmyard manure increased canola yield which was attributed to increase in availability of mineral nutrients, decreasing effects of salinity and toxic ions. Integrated application of 5 t. ha-1 of farmyard manure and %75 recommended chemical P increased yield and decreased fertilizer consumption. The results revealed that integrated applications of farmyard manure and chemical fertilizer and after that integrated use of bio- and chemical fertilizer are the best strategies to increase nutrient availability and improving canola yield in saline soil.

Fossil energy and GHG saving potentials of pig farming in the EU

DEFF Research Database (Denmark)

Nguyen, T Lan T; Mogensen, Lisbeth; Hermansen, John Erik

2010-01-01

) savings can be feasibly achieved. As shown in the results of the analysis, pig farming in the EU has a high potential to reduce fossil energy use and GHG emissions by taking improvement measures in three aspects: (i) feed use; (ii) manure management; and (iii) manure utilization. In particular......In Europe, the highly developed livestock industry places a high burden on resource use and environmental quality. This paper examines pig meat production in North-West Europe as a base case and runs different scenarios to investigate how improvements in terms of energy and greenhouse gas (GHG...

Global asessment of manure management policies and practices

NARCIS (Netherlands)

Teenstra, E.D.; Vellinga, Th.V.; Aktasaeng, N.; Amatayaku, W.; Ndambi, A.; Pelster, D.; Germer, L.; Jenet, A.; Opio, C.; Andeweg, K.

2014-01-01

The Livestock and Manure Management Component (LMMC) of the CCAC Agriculture Initiative supports integrated manure management practices by increasing knowledge and awareness, removing barriers to action and enhancing practice change. This Global Assessment report provides an overview of manure

Estimation of Pig contaminations in catchment by real-time PCR using two pig-specific bacteroidales 16S rRNA genetic markers

International Nuclear Information System (INIS)

Mieszkin, S.; Furet, J. P.; Corthier, G.; Gournelon, M.

2009-01-01

The microbiological quality of coastal and river waters can be deteriorated by fecal contamination from human or animal activities. In Brittany, France, pig farming is one of the most important animal activities and can cause fecal contamination of surface water due to spreading of pig manure to agricultural soils and in a lesser extent with the use of lagoon surface water for irrigation. (Author)

Effects of short-term nitrogen supply from livestock manures and cover crops on silage maize production and nitrate leaching

NARCIS (Netherlands)

Schroder, J.J.; Visser, de W.; Assinck, F.B.T.; Velthof, G.L.

2013-01-01

Resource use efficiency requires a correct appreciation of the nitrogen (N) fertilizer replacement value (NFRV, percentage of total N applied) of manures. We assessed the NFRVs of the liquid fraction originating from separated pig slurry (MC), untreated pig slurry (PS), untreated cattle slurry (CS),

Application of swine manure on agricultural fields contributes to extended-spectrum β-lactamase-producing Escherichia coli spread in Tai’an, China

Directory of Open Access Journals (Sweden)

Lili eGao

2015-04-01

Full Text Available The prevalence of extended-spectrum beta-lactamase (ESBL-producing Escherichia coli (E. coli is increasing rapidly in both hospital environments and animal farms. A lot of animal manure has been directly applied into arable fields in the developing countries. But the impact of ESBL-positive bacteria from animal manure on the agricultural fields is sparse, especially in the rural regions of Tai’an, China. Here, we collected 29, 3, and 10 ESBL-producing E. coli from pig manure, compost, and soil samples, respectively. To track ESBL-harboring E. coli from agricultural soil, these isolates of different sources were analyzed with regard to antibiotic resistance profiles, ESBL genes, plasmid replicons, and enterobacterial repetitive intergenic consensus (ERIC-polymerase chain reaction (PCR typing. The results showed that all the isolates exhibited multi-drug resistance. CTX-M gene was the predominant ESBL gene in the isolates from pig farm samples (30/32, 93.8% and soil samples (7/10, 70.0%, but no SHV gene was detected. 25 isolates contained the IncF-type replicon of plasmid, including 18 strains (18/32, 56.3% from the pig farm and 7 (7/10, 70.0% from the soil samples. ERIC-PCR demonstrated that 3 isolates from the soil had above 90% genetic similarity with strains from pig farm samples. In conclusion, application of animal manure carrying drug-resistant bacteria on agricultural fields is a likely contributor to antibiotic resistance gene spread.

Perfil de ácidos graxos e composição centesimal de carpas (Cyprinus carpio alimentadas com ração e com dejetos suínos Fatty acid profile and proximate composition of carp (Cyprinus carpio feed artificial food and pig manure

Directory of Open Access Journals (Sweden)

Janice Izabel Druzian

2007-04-01

Full Text Available Este estudo investigou o efeito da alimentação com dejetos suínos na composição centesimal e no perfil de ácidos graxos do músculo de carpas. Amostras de carpas com 4-10 meses de idade, recolhidas em Santa Catarina, foram filetadas, trituradas e acondicionadas em atmosfera de nitrogênio (-18°C. Os valores (% de umidade, proteína e cinzas foram: 72,24; 14,85; e 2,16, respectivamente, para carpas alimentados com ração; e 83,33; 14,48; e 3,49 para carpas alimentadas com dejetos suínos. Os valores de sódio e potássio foram: 0,491% e 1,20% carpas/ração; e 2,28% e 0,367% carpas/dejetos suínos, respectivamente. Os teores de lipídios totais também apresentaram diferenças significativas: 9,88% carpas/ração e 1,69% carpas/dejetos suínos. O perfil de ácidos graxos mostrou tendências similares nos dois músculos. Portanto, verificou-se um efeito significativo da alteração da dieta sobre a composição do tecido muscular de carpas alimentadas com dejetos suínos, principalmente no conteúdo de minerais e de lipídios totais, embora a variação observada no conteúdo de lipídios totais não tenha se refletido na composição de ácidos graxos.This study investigated the proximate composition and fatty acid profile of the carp muscle fed with pig manure. Carp with 4-10 months of age were collected in Santa Catarina. Muscle samples were sliced and then triturated in a multiprocessor and stored under gaseous nitrogen atmosphere (-18°C. The moisture, protein, and ash contents (% were as follows: 72.24; 14.85; e 2.16, respectively, for carp feed artificial food; and 83.33; 14.48; e 3.49 for carp feed pig manure. The contents of sodium and potassium were: 0.491% and 1.20% carp/artificial food; 2.28% and 0.367% carp/pig manure. The total lipids contents also presented significant differences: 9.88% carp/artificial food, and 1.69% carp/pig manure. Fatty acid profile showed similar tends in both muscles. Therefore, a significant

Effects of pig slurry on the sorption of sulfonamide antibiotics in soil.

Science.gov (United States)

Thiele-Bruhn, S; Aust, M O

2004-07-01

Sorption of p-aminobenzoic acid (pABA) and five sulfonamide antibiotics to loess Chernozem topsoil amended with varied additions of pig slurry was investigated in batch trials. In unfertilized soil, partition coefficients (Kd) of sulfonamides ranged from 0.3 to 2.0. Strong sorption nonlinearity (1/n = 0.5 to 0.8) was best fitted by the Freundlich isotherm (R2 = 0.7 to 1.0) and was indicative for specific sorption mechanisms. Adsorption to pig slurry was much stronger, and nondesorbable portions were increased compared with soil. However, in a mixture of soil and slurry (50:1 w/w), sorption of the antibiotics was significantly decreased at a lower concentration range of pABA and the sulfonamides. This was attributed to competitive adsorption of dissolved organic matter (DOM) constituents from manure. An increase in pig slurry amendment resulted in increased total organic matter, DOM concentration, and ionic strength, but pH decreased. As a result, the nonadsorbed portions of pABA, sulfanilamide, and sulfadiazine (logD(ow) 0.1)--remained nearly constant in the presence of increased manure input. The pH changes caused by manure amendment strongly affected ionisation status of the latter compounds, thus resulting in increased adsorption, which compensated the mobilizing effect of DOM. It is suggested that the effect of manure be considered in test methods to determine the soil retention of pharmaceutical substances.

Emissies uit een vleesvarkensstal voorzien van een V-vormige mestband voor het gescheiden afvoeren van mest en urine = Emissions from a housing system for fattening pigs with a V-shaped manure belt for separated removal of faeces and urine

NARCIS (Netherlands)

Ellen, H.H.; Hol, J.M.G.; Mosquera, J.; Aarnink, A.J.A.

2013-01-01

This study reports the emissions of ammonia, odour, fine dust (PM10 and PM2.5), methane and nitrous oxide from an animal house for fattening pigs provided with V-shaped manure belts for separated removal of faeces and urine (the Kempfarm system).

Utilisation of cattle manure and inorganic fertiliser for food production in central Uganda

Directory of Open Access Journals (Sweden)

Innocent Muhereza

2014-12-01

Full Text Available Fertiliser use in small-holder peri-urban crop-livestock farms in Uganda was investigated by conducting a socio-economic survey of 40 farms in the central districts of Wakiso and Kampala where cattle manure is commonly applied to address the issue of declining crop yields. The major benefits obtained from cattle manure application were increased yields and low cost, while negative effects were poor hygienic conditions and bad odour. The challenges associated with the use of cattle manure included its weight and bulkiness, lack of labour, insufficient quantities, high transportation and application costs, lack of storage facilities to maintain quality attributes of manure and the incidence of chaffer grubs and worms; a nuisance during application which affected crop growth. The survey indicated that of the farmers using cattle manure, only 5% also supplemented with inorganic fertilisers. Other animal manures applied included poultry, pig, goat and rabbit where available. The nutrient content of cattle manure was generally low, as a result of livestock diet and storage. There was little education available to farmers as to optimum strategies and rates of fertiliser (including both inorganic and organic fertilisers to improve crop yield and this needed addressing to improve food security and economic development in Uganda. Keywords: cattle manure; fertiliser; urea

Fate of metal resistance genes in arable soil after manure application in a microcosm study.

Science.gov (United States)

Xiong, Wenguang; Zeng, Zhenling; Zhang, Yiming; Ding, Xueyao; Sun, Yongxue

2015-03-01

Manure application contributes to the spread and persistence of metal resistance genes (MRGs) in the environment. We investigated the fate of copper (Cu) and zinc (Zn) resistance genes (pcoA, pcoD and zntA) in arable soil after Cu/Zn-containing manure application. Manure with or without addition of metals (Cu/Zn) was added in a soil microcosm over 2 months. Soil samples were collected for analysis on day 0, 30 and 60. The abundances of all MRGs (pcoA, pcoD and zntA) in manure group were significantly higher than those in untreated soil and manure+metals groups. All MRGs dissipated 1.2-1.3 times faster in manure group (from -90 ± 8% to -93 ± 7%) than those in manure+metals group (from -68 ± 8% to -78 ± 5%). The results indicated that manure from healthy pigs contributed to the occurrence of metals (Cu/Zn) and MRGs (pcoA, pcoD and zntA) in arable soil. The significant effects of manure application on the accumulation of pcoA, pcoD and zntA lasted for 1-2 months. Cu/Zn can slow down the dissipation of pcoA, pcoD and zntA after manure application. This is the first report to investigate the fate of MRGs in soil after manure application. Copyright © 2014 Elsevier Inc. All rights reserved.

Odor and odorous compound emissions from manure of swine fed standard and dried distillers grains with soluble (DDGS) supplemented diets

Science.gov (United States)

This study was conducted to determine the impact diets containing dried distillers grains with soluble (DDGS) have on emissions of odor and odorous compounds from swine manure storage. Twenty-four pigs were fed either a corn-soybean meal (CSBM) diet or a CSBM diet containing 35% DDGS. Pigs were fed ...

the effects of 4 ratios of organic to inorganic manures on soil ...

African Journals Online (AJOL)

nkechi

2011-05-02

May 2, 2011 ... ON SOIL PHYSICOCHEMICAL PROPERTIES AND MAIZE YIELD. ... fertilizers with the uncombined ones were used for field ... ferallitic sandy loam classified as an ultisol. ... The pots were kept in the field moisture capacity ... the data fitted in the soil textural triangle to obtain ... Equivalent in t/ha pig manure.

Influence of Organic Manure on Organic Phosphorus Fraction in Soils

Institute of Scientific and Technical Information of China (English)

ZHANGYONG－SONG; NIWU－ZHONG; 等

1993-01-01

The transformation of organic P(Po) from organic manures in two types of soils (ultisol and entisol) and the influences of external addition of organic substance or inorganic P(Pi) on Po under the condition of the 60% maximum water capacity were investigated.The results obtained from Po fractionation experiments indicated that all the Po fractions except for the highly resistant Po fraction decreased during incubation.Application of pig feces and cow feces could largely increase each fraction of Po in the soils.Immediately after application of organic manure into the soils a large part of labile and moderately labile Po from organic manure was transferred into moderately resistant Po,which might be due to the fact that Ca-or Mg-inositol P was precipitated into Fe-inositol P.However,the availability of Po from organic manure in the soils would increase again after incubation because of the transformation of moderately labile and resistant Po fractions into labile Po fractions.Addition of cellulose or Pi into the soils showed a good effect on increasing all the Po fractions except for the highly resistant Po,and this effect was much more pronounced when cellulose was applied in combination with Pi.Therefore,in view of the effect of organic manure on improving P nutrition to plant,attention should be paid to both the Po and the organic substances from organic manure,It is suggested that application of Pi fertilizer combined with organic manure may be referred to as an effective means of protecting Pi from chemical fixation in soil.

Towards a sustainable and efficient use of manure in agriculture: The Dutch case

NARCIS (Netherlands)

F.J. Dietz (Frank); N.J.P. Hoogervorst (Nico)

1991-01-01

textabstractRapid increases in livestock production in the Netherlands have changed manure from a valuable input into a mere waste product. This is especially true for the southern and eastern parts of the country, where specialized pig and poultry farms have concentrated on sandy soils. As these

Integrating livestock manure with a corn-soybean bioenergy cropping system improves short-term carbon sequestration rates and net global warming potential

International Nuclear Information System (INIS)

Thelen, K.D.; Fronning, B.E.; Kravchenko, A.; Min, D.H.; Robertson, G.P.

2010-01-01

Carbon cycling and the global warming potential (GWP) of bioenergy cropping systems with complete biomass removal are of agronomic and environmental concern. Corn growers who plan to remove corn stover as a feedstock for the emerging cellulosic ethanol industry will benefit from carbon amendments such as manure and compost, to replace carbon removed with the corn stover. The objective of this research was to determine the effect of beef cattle feedlot manure and composted dairy manure on short-term carbon sequestration rates and net global warming potential (GWP) in a corn-soybean rotation with complete corn-stover removal. Field experiments consisting of a corn-soybean rotation with whole-plant corn harvest, were conducted near East Lansing, MI over a three-year period beginning in 2002. Compost and manure amendments raised soil carbon (C) at a level sufficient to overcome the C debt associated with manure production, manure collection and storage, land application, and post-application field emissions. The net GWP in carbon dioxide equivalents for the manure and compost amended cropping systems was -934 and -784 g m -2 y -1 , respectively, compared to 52 g m -2 y -1 for the non-manure amended synthetic fertilizer check. This work further substantiates the environmental benefits associated with renewable fuels and demonstrates that with proper management, the integration of livestock manures in biofuel cropping systems can enhance greenhouse gas (GHG) remediation.

Organic and chemical manure of the bean (Phaseolus vulgaris) in alluvial soils of intermediate climate

International Nuclear Information System (INIS)

Tamayo V, Alvaro; Munoz A, Rodrigo

1997-01-01

With the purpose to evaluate the effect on bean production ICA CITARA variety, four sources of organic matter (hen manure, pig manure, cow manure, and earthworm manure) in four doses 280,500 y 1.000 kg/ha with the same doses of chemical fertilization, were evaluated the experiment was carried out at Tulio Ospina Research Center, located at Bello (Antioquia) of medium climate with 1.320 m.s.n.m. This was established using an alluvial soil (Tropofluvent), frenk, with low contents of organic, matter (2,2%), phosphorus (10 ppm), and potassium (0,10 meq/l00 g). the results, after six consecutive harvests on the same plots, showed highly significative differences among treatments. The highest yield (1.836 kg/ha) was obtained when to the chemical fertilization (300 kg of 10-30-10) was added with 250 kg/ha of hen manure, followed by the application of 100 kg/ha, of cow manure (1.812 kg/ha). Chemical fertilization without organic matter produced 1.640 kg/ha of bean, which was very similar to the addition of 1.000 kg/ha of cow manure and earthworm manure with yields of 1.688 kg/ha and 1.635 kg/ha respectively

Comparative performance and microbial community of single-phase and two-phase anaerobic systems co-digesting cassava pulp and pig manure

DEFF Research Database (Denmark)

Panichnumsin, P.; Ahring, B.K.; Nopharatana, A.

2010-01-01

In this study, we illustrated the performance and microbial community of single- and two-phase systems anaerobically co-digesting cassava pulp and pig manure. The results showed that the volatile solid reduction and biogas productivity of two-phase CSTR were 66 ± 4% and 2000 ± 210 ml l-1 d-1, while...... those of singlephase CSTR were 59 ± 1% and 1670 ± 60 ml l-1 d-1, respectively. Codigestion in two-phase CSTR gave higher 12% solid degradation and 25% methane production than single-phase CSTR. Phylogenetic analysis of 16S rDNA clone library revealed that the Bacteroidetes were the most abundant group......, followed by the Clostridia in singlephase CSTR. In hydrolysis/acidification reactor of two-phase system, the bacteria within the phylum Firmicutes, especially Clostridium, Eubacteriaceae and Lactobacillus were the dominant phylogenetic groups. Among the Archaea, Methanosaeta sp. was the exclusive...

Radical change of Zn speciation in pig slurry amended soil: Key role of nano-sized sulfide particles.

Science.gov (United States)

Formentini, Thiago Augusto; Legros, Samuel; Fernandes, Cristovão Vicente Scapulatempo; Pinheiro, Adilson; Le Bars, Maureen; Levard, Clément; Mallmann, Fábio Joel Kochem; da Veiga, Milton; Doelsch, Emmanuel

2017-03-01

Spreading livestock manure as fertilizer on farmlands is a widespread practice. It represents the major source of heavy metal(loid)s (HM) input in agricultural soils. Since zinc (Zn) is present at high concentrations in manure, it poses special environmental concerns related to phytotoxicity, groundwater contamination, and introduction in the food chain. Therefore, investigations on the fate and behavior of manure-borne Zn, when it enters the soil environment, are necessary to predict the environmental effects. Nevertheless, long-term field studies assessing Zn speciation in the organic waste matrix, as well as within the soil after manure application, are lacking. This study was designed to fill this gap. Using SEM-EDS and XAS analysis, we reported the following new results: (i) ZnS made up 100% of the Zn speciation in the pig slurry (the highest proportion of ZnS ever observed in organic waste); and (ii) ZnS aggregates were about 1-μm diameter (the smallest particle size ever reported in pig slurry). Moreover, the pig slurry containing ZnS was spread on the soil over an 11-year period, totaling 22 applications, and the resulting Zn speciation within the amended soil was analyzed. Surprisingly, ZnS, i.e. the only species responsible for a nearly 2-fold increase in the Zn concentration within the amended soil, was not detected in this soil. Based on SEM-EDS and XAS observations, we put forward the hypothesis that Zn in the pig slurry consisted of nano-sized ZnS crystallites that further aggregated. The low stability of ZnS nanoparticles within oxic and complex environments such as the studied soil was the key explanation for the radical change in pig slurry-borne Zn speciation after long-term amendments. Copyright © 2016 Elsevier Ltd. All rights reserved.

Integrating livestock manure with a corn-soybean bioenergy cropping system improves short-term carbon sequestration rates and net global warming potential

Energy Technology Data Exchange (ETDEWEB)

Thelen, K.D.; Fronning, B.E.; Kravchenko, A.; Min, D.H.; Robertson, G.P. [Michigan State University, East Lansing, MI 48824 (United States)

2010-07-15

Carbon cycling and the global warming potential (GWP) of bioenergy cropping systems with complete biomass removal are of agronomic and environmental concern. Corn growers who plan to remove corn stover as a feedstock for the emerging cellulosic ethanol industry will benefit from carbon amendments such as manure and compost, to replace carbon removed with the corn stover. The objective of this research was to determine the effect of beef cattle feedlot manure and composted dairy manure on short-term carbon sequestration rates and net global warming potential (GWP) in a corn-soybean rotation with complete corn-stover removal. Field experiments consisting of a corn-soybean rotation with whole-plant corn harvest, were conducted near East Lansing, MI over a three-year period beginning in 2002. Compost and manure amendments raised soil carbon (C) at a level sufficient to overcome the C debt associated with manure production, manure collection and storage, land application, and post-application field emissions. The net GWP in carbon dioxide equivalents for the manure and compost amended cropping systems was -934 and -784 g m{sup -2} y{sup -1}, respectively, compared to 52 g m{sup -2} y{sup -1} for the non-manure amended synthetic fertilizer check. This work further substantiates the environmental benefits associated with renewable fuels and demonstrates that with proper management, the integration of livestock manures in biofuel cropping systems can enhance greenhouse gas (GHG) remediation. (author)

2004 Methane and Nitrous Oxide Emissions from Manure Management in South Africa

Directory of Open Access Journals (Sweden)

Mokhele Edmond Moeletsi

2015-03-01

Full Text Available Manure management in livestock makes a significant contribution towards greenhouse gas emissions in the Agriculture; Forestry and Other Land Use category in South Africa. Methane and nitrous oxide emissions are prevalent in contrasting manure management systems; promoting anaerobic and aerobic conditions respectively. In this paper; both Tier 1 and modified Tier 2 approaches of the IPCC guidelines are utilized to estimate the emissions from South African livestock manure management. Activity data (animal population, animal weights, manure management systems, etc. were sourced from various resources for estimation of both emissions factors and emissions of methane and nitrous oxide. The results show relatively high methane emissions factors from manure management for mature female dairy cattle (40.98 kg/year/animal, sows (25.23 kg/year/animal and boars (25.23 kg/year/animal. Hence, contributions for pig farming and dairy cattle are the highest at 54.50 Gg and 32.01 Gg respectively, with total emissions of 134.97 Gg (3104 Gg CO2 Equivalent. Total nitrous oxide emissions are estimated at 7.10 Gg (2272 Gg CO2 Equivalent and the three main contributors are commercial beef cattle; poultry and small-scale beef farming at 1.80 Gg; 1.72 Gg and 1.69 Gg respectively. Mitigation options from manure management must be taken with care due to divergent conducive requirements of methane and nitrous oxide emissions requirements.

Behaviour of 14C-sulfadiazine and 14C-difloxacin during manure storage

International Nuclear Information System (INIS)

Lamshoeft, Marc; Sukul, Premasis; Zuehlke, Sebastian; Spiteller, Michael

2010-01-01

The persistence of sulfadiazine, difloxacin, and their metabolites has been investigated in stored manure. The manure collected from sulfadiazine ( 14 C-SDZ) and difloxacin ( 14 C-DIF) treated pigs contained N-acetylsulfadiazine (Ac-SDZ), 4-hydroxy-SDZ (4-OH-SDZ), and sarafloxacin (SARA) as the main metabolites, respectively along with their parent compounds. Manures were stored separately at 10 o C and 20 o C at various moisture levels. About 96-99% of the radioactivity remained in extractable parent compounds and their metabolites after 150 d of storage. The formation of non-extractable residue and the rate of mineralization were both negligible in manure containing SDZ and DIF. During storage SDZ concentration increased as a result of the deacetylation of Ac-SDZ, whose concentration decreased proportionally. Hence the environmental effects may be underestimated if the parent compound alone is considered for environmental risk assessment. About 11% and 14% of 4-OH-SDZ were lost after 20 and 40 d of storage; thereafter its concentration increased relatively, highlighting hydroxylation of SDZ. DIF degraded very slowly (7% loss after 150 d) during the storage of manure; in contrast the concentration of SARA decreased rapidly (72-90% loss after 150 d). Dilution of manure and storage at higher temperatures for a reasonable period of time enhanced the rate of reactions of SDZ, DIF and their related metabolites.

Effect of integrated forage rotation and manure management on yield, nutrient balance and soil organic matter

Directory of Open Access Journals (Sweden)

Cesare Tomasoni

2011-03-01

Full Text Available This paper reports results from a field experiment established in 1995 and still on going. It is located in Lodi, in the irrigated lowlands of Lombardy, Northern Italy. The experiment compares two rotations: the annual double cropping system, Italian ryegrass + silage maize (R1; and the 6-year rotation, in which three years of double crop Italian ryegrass + silage maize are followed by three years of alfalfa harvested for hay (R6 Each rotation have received two types of dairy manure: i farmyard manure (FYM; ii semi-liquid manure (SLM. The intent was to apply to each unit land area the excreta produced by the number of adult dairy cows sustained, in terms of net energy, by the forage produced in each rotation, corresponding to about 6 adult cows ha-1 for R1 and 4 adult cows ha-1 for R6. Manure was applied with (N1 or without (N0 an extra supply of mineral N in the form of urea. The objectives of this study were: i to assess whether the recycling of two types of manure in two forage rotation systems can sustain crop yields in the medium and long term without additional N fertilization; ii to evaluate the nutrient balance of these integrated forage rotations and manure management systems; iii to compare the effects of farmyard manure and semi-liquid manure on soil organic matter. The application of FYM, compared to SLM, increased yield of silage maize by 19% and alfalfa by 23%, while Italian ryegrass was not influenced by the manure treatment. Yet, silage maize produced 6% more in rotation R6 compared to rotation R1. The mineral nitrogen fertilization increased yield of Italian ryegrass by 11% and of silage maize by 10%. Alfalfa, not directly fertilized with mineral nitrogen, was not influenced by the nitrogen applied to the other crops in rotation. The application of FYM, compared to SLM, increased soil organic matter (SOM by +37 % for the rotation R1, and by +20% for the rotation R6. Conversely, no significant difference on SOM was observed

Comparison of anaerobic digestion characteristics and kinetics of four livestock manures with different substrate concentrations.

Science.gov (United States)

Li, Kun; Liu, Ronghou; Sun, Chen

2015-12-01

Anaerobic digestions of pig manure (PM), dairy manure (DM), chicken manure (CM) and rabbit manure (RM) at initial volatile solid loading (VSL) of 8 g VS/L, 16 g VS/L, 32 g VS/L, 64 g VS/L were investigated under mesophilic conditions. The maximum methane yields of 410, 270, 377 and 323 mL CH4/g VSadded for PM, DM, CM and RM were all obtained at initial VSL of 8 g VS/L, respectively. The improvement of substrate concentration to 64 g VS/L not only decreased the methane yield and biodegradability both by 22.4%, 37.3%, 49.1% and 34.6% for PM, DM, CM and RM respectively, but also reduced the methane content in final biogas production. The Cone model (R(2): 0.9910-0.9974) showed a better fit to the experiment data and the calculated parameters indicated that anaerobic digestion of manures at higher loading has longer lag phase and lower hydrolysis rate. Copyright © 2015 Elsevier Ltd. All rights reserved.

Effects of chlortetracycline amended feed on anaerobic sequencing batch reactor performance of swine manure digestion.

Science.gov (United States)

Dreher, Teal M; Mott, Henry V; Lupo, Christopher D; Oswald, Aaron S; Clay, Sharon A; Stone, James J

2012-12-01

The effects of antimicrobial chlortetracycline (CTC) on the anaerobic digestion (AD) of swine manure slurry using anaerobic sequencing batch reactors (ASBRs) was investigated. Reactors were loaded with manure collected from pigs receiving CTC and no-antimicrobial amended diets at 2.5 g/L/d. The slurry was intermittently fed to four 9.5L lab-scale anaerobic sequencing batch reactors, two with no-antimicrobial manure, and two with CTC-amended manure, and four 28 day ASBR cycles were completed. The CTC concentration within the manure was 2 8 mg/L immediately after collection and 1.02 mg/L after dilution and 250 days of storage. CTC did not inhibit ASBR biogas production extent, however the volumetric composition of methane was significantly less (approximately 13% and 15% for cycles 1 and 2, respectively) than the no-antimicrobial through 56 d. CTC decreased soluble chemical oxygen demand and acetic acid utilization through 56 d, after which acclimation to CTC was apparent for the duration of the experiment. Copyright © 2012 Elsevier Ltd. All rights reserved.

Monitoring the Perturbation of Soil and Groundwater Microbial Communities Due to Pig Production Activities

KAUST Repository

Hong, Pei-Ying

2013-02-08

This study aimed to determine if biotic contaminants originating from pig production farms are disseminated into soil and groundwater microbial communities. A spatial and temporal sampling of soil and groundwater in proximity to pig production farms was conducted, and quantitative PCR (Q-PCR) was utilized to determine the abundances of tetracycline resistance genes (i.e., tetQ and tetZ) and integrase genes (i.e., intI1 and intI2). We observed that the abundances of tetZ, tetQ, intI1, and intI2 in the soils increased at least 6-fold after manure application, and their abundances remained elevated above the background for up to 16 months. Q-PCR further determined total abundances of up to 5.88 × 109 copies/ng DNA for tetZ, tetQ, intI1, and intI2 in some of the groundwater wells that were situated next to the manure lagoon and in the facility well used to supply water for one of the farms. We further utilized 16S rRNA-based pyrosequencing to assess the microbial communities, and our comparative analyses suggest that most of the soil samples collected before and after manure application did not change significantly, sharing a high Bray-Curtis similarity of 78.5%. In contrast, an increase in Bacteroidetes and sulfur-oxidizing bacterial populations was observed in the groundwaters collected from lagoon-associated groundwater wells. Genera associated with opportunistic human and animal pathogens, such as Acinetobacter, Arcobacter, Yersinia, and Coxiella, were detected in some of the manure-treated soils and affected groundwater wells. Feces-associated bacteria such as Streptococcus, Erysipelothrix, and Bacteroides were detected in the manure, soil, and groundwater ecosystems, suggesting a perturbation of the soil and groundwater environments by invader species from pig production activities.

[The stratification of moisture content and its dynamics in co-composting of sewage sludge and pig manure].

Science.gov (United States)

Luo, Wei; Chen, Tong-bin; Gao, Ding; Zheng, Yu-qi; Zheng, Guo-di

2004-03-01

The experiment of co-composting of sewage sludge and pig manure was studied. The moisture contents were 50.82%-60.87% at the stage of temperature rising and 38.7%-52.17% at the stage of thermophilic fermentation, and the stratification of moisture content were not obvious for both stages because the door, the internal wall and the depth of the composting bay had little effect on the stratification. At the stage of cooling, the moisture content was 24.54%-49.39%, and the stratification of moisture content was remarkable as the door, the internal wall and the depth of the composting bay had great influence on it. At the stage of maturity, the moisture content was 19.18%-49.34%, and the stratification of moisture weakened, for which the door and the internal wall were mainly responsible. At the different composting stage, the degree of difference of moisture content on the profiles of the pile was of the order: maturity stage > cooling stage > thermophilic stage = temperature rising stage, and the moisture content in the pile was as follows: the lower > the middle > the upper. The relation between moisture content and composting time meeted with two-order kinetics equation.

Technological Options to Ameliorate Waste Treatment of Intensive Pig Production in China：An Analysis Based on Bio-Economic Model

Institute of Scientific and Technical Information of China (English)

LU Wen-cong; MA Yong-xi; Holger Bergmann

2014-01-01

Ameliorating waste treatment by technological improvements affects the economic and the ecological-environment beneifts of intensive pig production. The objective of the research was to develop and test a method to determine the technical optimization to ameliorate waste treatment methods and gain insight into the relationship between technological options and the economic and ecological effects. We developed an integrated bio-economic model which incorporates the farming production and waste disposal systems to simulate the impact of technological improvements in pig manure treatment on economic and environmental benefits for the case of a pilot farm in Beijing, China. Based on different waste treatment technology options, three scenarios are applied for the simulation analysis of the model. The simulation results reveal that the economic-environmental beneifts of the livestock farm could be improved by reducing the cropland manure application and increasing the composting production with the current technologies. Nevertheless, the technical efifciency, the waste treatment capacity and the economic beneifts could be further improved by the introduction of new technologies. It implies that technological and economic support policies should be implemented comprehensively on waste disposal and resource utilization to promote sustainable development in intensive livestock production in China.

Microbial and chemical markers: runoff transfer in animal manure-amended soils.

Science.gov (United States)

Jaffrezic, Anne; Jardé, Emilie; Pourcher, Anne-Marie; Gourmelon, Michèle; Caprais, Marie-Paule; Heddadj, Djilali; Cottinet, Patrice; Bilal, Muhamad; Derrien, Morgane; Marti, Romain; Mieszkin, Sophie

2011-01-01

Fecal contamination of water resources is evaluated by the enumeration of the fecal coliforms and Enterococci. However, the enumeration of these indicators does not allow us to differentiate between the sources of fecal contamination. Therefore, it is important to use alternative indicators of fecal contamination to identify livestock contamination in surface waters. The concentration of fecal indicators (, enteroccoci, and F-specific bacteriophages), microbiological markers (Rum-2-bac, Pig-2-bac, and ), and chemical fingerprints (sterols and stanols and other chemical compounds analyzed by 3D-fluorescence excitation-matrix spectroscopy) were determined in runoff waters generated by an artificial rainfall simulator. Three replicate plot experiments were conducted with swine slurry and cattle manure at agronomic nitrogen application rates. Low amounts of bacterial indicators (1.9-4.7%) are released in runoff water from swine-slurry-amended soils, whereas greater amounts (1.1-28.3%) of these indicators are released in runoff water from cattle-manure-amended soils. Microbial and chemical markers from animal manure were transferred to runoff water, allowing discrimination between swine and cattle fecal contamination in the environment via runoff after manure spreading. Host-specific bacterial and chemical markers were quantified for the first time in runoff waters samples after the experimental spreading of swine slurry or cattle manure. American Society of Agronomy, Crop Science Society of America, and Soil Science Society of America.

Surface runoff and transport of sulfonamide antibiotics and tracers on manured grassland.

Science.gov (United States)

Burkhardt, Michael; Stamm, Christian; Waul, Christopher; Singer, Heinz; Müller, Stephan

2005-01-01

Despite their common use in animal production the environmental fate of the veterinary sulfonamide antibiotics after excretion is only poorly understood. We performed irrigation experiments to investigate the transport of these substances with surface runoff on grassland. Liquid manure from pigs treated with sulfadimidine was spiked with sulfadiazine, sulfathiazole, the herbicide atrazine (2-chloro-4-ethylamino-6-isopropylamino-1,3,5-triazine), and the conservative tracer bromide and spread onto eight plots. Four plots received the same amounts of the spiked substances in aqueous solution (controls). Apart from the application matrix we varied the time between application and irrigation. Manure increased the runoff volume up to six times compared with the controls. It seemed that manure enhanced the runoff by sealing the soil surface. On manured plots the relative antibiotic concentrations in runoff were higher than on the controls, reaching an average of 0.3% (sulfadiazine), 0.8% (sulfathiazole), and 1.4% (sulfadimidine) of the input concentrations after a 1-d contact time. The corresponding values on the controls were 0.16% for sulfadiazine and 0.08% for sulfathiazole. After 3 d, the maximum values on the manured plots were even higher, whereas they had fallen below the limit of quantification on the controls. As a consequence, the sulfonamide losses were 10 to 40 times larger on the manured plots. The relative mobility of the sulfonamides on the control plots followed the trend expected from their chromatographic separation but the opposite was found on the manured plots. Hence it is important to consider explicitly the physical and chemical effects of manure when assessing the environmental fate of sulfonamides.

Manure management in the (Sub-)Tropics : training manual for extension workers

NARCIS (Netherlands)

Teenstra, E.D.; Buisonjé, de F.E.; Ndambi, A.; Pelster, D.

2015-01-01

Having identified a general lack of knowledge about the value of livestock manure and integrated manure management at multiple levels in government and society, a concerted action led to the compilation of a training manual for extension workers on manure management in the (sub-)tropics. Covering

Energy use in pig production: an examination of current Iowa systems.

Science.gov (United States)

Lammers, P J; Kenealy, M D; Kliebenstein, J B; Harmon, J D; Helmers, M J; Honeyman, M S

2012-03-01

This paper compares energy use for different pig production systems in Iowa, a leader in US swine production. Pig production systems include not only the growth and performance of the pigs, but also the supporting infrastructure of pig production. This supporting infrastructure includes swine housing, facility management, feedstuff provision, swine diets, and manure management. Six different facility type × diet formulation × cropping sequence scenarios were modeled and compared. The baseline system examined produces 15,600 pigs annually using confinement facilities and a corn-soybean cropping sequence. Diet formulations for the baseline system were corn-soybean meal diets that included the synthetic AA l-lysine and exogenous phytase. The baseline system represents the majority of current US pork production in the Upper Midwest, where most US swine are produced. This system was found to require 744.6 MJ per 136-kg market pig. An alternative system that uses bedded hoop barns for grow-finish pigs and gestating sows would require 3% less (720.8 MJ) energy per 136-kg market pig. When swine production systems were assessed, diet type and feed ingredient processing were the major influences on energy use, accounting for 61 and 79% of total energy in conventional and hoop barn-based systems, respectively. Improving feed efficiency and better matching the diet formulation with the thermal environment and genetic potential are thus key aspects of reducing energy use by pig production, particularly in a hoop barn-based system. The most energy-intensive aspect of provisioning pig feed is the production of synthetic N for crop production; thus, effectively recycling manure nutrients to cropland is another important avenue for future research. Almost 25% of energy use by a conventional farrow-to-finish pig production system is attributable to operation of the swine buildings. Developing strategies to minimize energy use for heating and ventilation of swine buildings while

The ALFAM2 database on ammonia emission from field-applied manure: Description and illustrative analysis

DEFF Research Database (Denmark)

Hafner, Sasha D.; Pacholski, Andreas; Bittman, Shabtai

2018-01-01

. Data on five manure types (cattle, pig, mink, poultry, mixed, as well as sludge and “other”) applied to three types of crops (grass, small grains, maize, as well as stubble and bare soil) are included. Application methods represented in the database include broadcast, trailing hose, trailing shoe...

Effect of phosphate additive on the nitrogen transformation during pig manure composting.

Science.gov (United States)

Wu, Juan; He, Shengzhou; Liang, Ying; Li, Guoxue; Li, Song; Chen, Shili; Nadeem, Faisal; Hu, Jingwei

2017-07-01

Previous studies revealed that phosphate, as an additive to composting, could significantly reduce NH 3 emission and nitrogen loss through change of pH and nitrogen fixation to form ammonium phosphate. However, few studies have explored the influence of pH change and phosphate additive on NO x - -N, NH 4 + -N, NH 3 , and N 2 O, which are dominate forms of nitrogen in composting. In this study, the equimolar H 3 PO 4 , H 2 SO 4 , and K 2 HPO 4 were added into pig manure composting to evaluate the effect of H + and PO 4 3- on nitrogen transformation. As a result, we reached the conclusion that pH displays significant influence on adsorption from PO 4 3- to NH 4 + . The NH 4 + -N concentration in H 3 PO 4 treatment kept over 3 g kg -1 DM (dry matter) which is obviously higher than that in H 2 SO 4 treatment, and NH 4 + -N concentration in K 2 HPO 4 treatment (pH>8.5) is lower than 0.5 g kg -1 DM because adsorption capacity of PO 4 3- is greatly weakened and NH 4 + -N rapidly transformed to NH 3 -N influenced by high pH value. The N 2 O emission of composting is significantly correlated with incomplete denitrification of NO x - -N, and PO 4 3- addition could raise NO x - -N contents to restrict denitrification and further to promote N 2 O emission. The study reveals the influence mechanism of phosphate additive to nitrogen transformation during composting, presents theoretical basis for additive selection in nitrogen fixation, and lays foundation for study about nitrogen circulation mechanism during composting.

Composting of pig manure and forest green waste amended with industrial sludge.

Science.gov (United States)

Arias, O; Viña, S; Uzal, M; Soto, M

2017-05-15

The aim of this research was to study the composting of chestnut forest green waste (FGW) from short rotation chestnut stands amended with sludge resulting from the manufacture of Medium Density Fibreboard (MDFS) and pig manure (PM). Both FGW and MDFS presented low biodegradation potential but different characteristics in granulometry and bulk density that make its mixture of interest to achieve high composting temperatures. PM decreased the C/N ratio of the mixture and increased its moisture content (MC). Three mixtures of MDFS:FGW at volume ratios of 1:1.3 (M2), 1:2.4 (M3) and 0:1 (M4) were composted after increasing its MC to about 70% with PM. A control with food waste (OFW) and FGW (1:2.4 in volume) (M1) was run in parallel. Watering ratios reached 0.25 (M1), 1.08 (M2) 1.56 (M3) and 4.35 (M4) L PM/kg TS of added solids wastes. Treatments M2 and M3 reached a thermophilic phase shorter than M1, whilst M4 remained in the mesophilic range. After 48days of composting, temperature gradients in respect to ambient temperature were reduced, but the mineralization process continued for around 8months. Final reduction in total organic carbon reached 35-56%, depending mainly on the content in MDFS. MDFS addition to composting matrices largely reduced nitrogen losses, which range from 22% (M2) to 37% (M3) and 53% (M4). Final products had high nutrient content, low electrical conductivity and low heavy metal content which make it a valuable product for soil fertilization, right to amend in the chestnut forests and as a pillar of their sustainable management. Copyright © 2017 Elsevier B.V. All rights reserved.

Integrated anaerobic/aerobic biological treatment for intensive swine production.

Science.gov (United States)

Bortone, Giuseppe

2009-11-01

Manure processing could help farmers to effectively manage nitrogen (N) surplus load. Many pig farms have to treat wastewater. Piggery wastewater treatment is a complex challenge, due to the high COD and N concentrations and low C/N ratio. Anaerobic digestion (AD) could be a convenient pre-treatment, particularly from the energetic view point and farm income, but this causes further reduction of C/N ratio and makes denitrification difficult. N removal can only be obtained integrating anaerobic/aerobic treatment by taking into account the best use of electron donors. Experiences gained in Italy during development of integrated biological treatment approaches for swine manure, from bench to full scale, are reported in this paper. Solid/liquid separation as pre-treatment of raw manure is an efficient strategy to facilitate liquid fraction treatment without significantly lowering C/N ratio. In Italy, two full scale SBRs showed excellent efficiency and reliability. Current renewable energy policy and incentives makes economically attractive the application of AD to the separated solid fraction using high solid anaerobic digester (HSAD) technology. Economic evaluation showed that energy production can reduce costs up to 60%, making sustainable the overall treatment.

Manure derived biochar can successfully replace phosphate rock amendment in peatland restoration.

Science.gov (United States)

Pouliot, Rémy; Hugron, Sandrine; Rochefort, Line; Godbout, Stéphane; Palacios, Joahnn H; Groeneveld, Elisabeth; Jarry, Isabelle

2015-07-01

Phosphate rock fertilization is commonly used in peatland restoration to promote the growth of Polytrichum strictum, a nurse plant which aids the establishment of Sphagnum mosses. The present study tested whether 1) phosphorus fertilization facilitates the germination of P. strictum spores and 2) biochar derived from local pig manure can replace imported phosphate rock currently used in peatland restoration. Various doses of biochar were compared to phosphate rock to test its effect directly on P. strictum stem regeneration (in Petri dishes in a growth chamber) and in a simulation of peatland restoration with the moss layer transfer technique (in mesocoms in a greenhouse). Phosphorus fertilization promoted the germination of P. strictum spores as well as vegetative stem development. Biochar can effectively replace phosphate rock in peatland restoration giving a new waste management option for rural regions with phosphorus surpluses. As more available phosphorus was present in biochar, an addition of only 3-9 g m(-2) of pig manure biochar is recommended during the peatland restoration process, which is less than the standard dose of phosphate rock (15 g m(-2)). Copyright © 2015 Elsevier Ltd. All rights reserved.

Nitrous oxide emissions from manure handling - effects of storage conditions and climate

International Nuclear Information System (INIS)

Sommer, S.G.; Petersen, S.O.

2002-01-01

Stored animal manure and manure applied in the field contributes an estimated 20% to the total anthropogenic emissions of nitrous oxide (N 2 0) in Denmark. Manure composition, handling and climatic conditions may all influence the emission level during storage, but there are relatively few experimental data on emissions of N 2 0 from manure management, including animal houses, slurry stores and manure heaps. Among animal housing systems, very high emission rates have been found with pig deep lifter, and N 2 0 emissions are further stimulated by mechanical mixing. Slurry stores are anaerobic, but a recent study showed that N 2 0 can be produced in porous surface covers such as natural surface crusts, straw or leca pebbles, while no N 2 0 was emitted from uncovered slurry. The emission was significantly related to the water balance, i.e., the difference between evaporation and rain, during dry periods; during wet periods no N 2 0 was emitted. For solid manure, previous studies have typically found that less than 1 % of total N is emitted as N 2 0. Nitrous oxide may be produced throughout the manure heap, provided an environment with both aerobic and anaerobic pockets exists. Profiles from an experimental heap indicated that most of the N 2 0 emitted from solid manure was produced near the surface of the heap. Increasing density appears to stimulate N 2 0 emissions up to a point, where the air exchange is significantly impeded. The IPCC methodology calculates N 2 0 emissions from manure on the basis of total N content (that is, on the basis of volume) and climate region only. Possibly, estimates of N 2 0 emissions from slurry stores could be improved by considering surface area, ammonium content and water balance as input variables. Emissions from solid manure heaps should consider surface area and the potential for composting, as reflected in bulk density and moisture content. (au)

Fossil energy and GHG saving potentials of pig farming in the EU

International Nuclear Information System (INIS)

Nguyen, Thu Lan T.; Hermansen, John E.; Mogensen, Lisbeth

2010-01-01

In Europe, the highly developed livestock industry places a high burden on resource use and environmental quality. This paper examines pig meat production in North-West Europe as a base case and runs different scenarios to investigate how improvements in terms of energy and greenhouse gas (GHG) savings can be feasibly achieved. As shown in the results of the analysis, pig farming in the EU has a high potential to reduce fossil energy use and GHG emissions by taking improvement measures in three aspects: (i) feed use; (ii) manure management; and (iii) manure utilization. In particular, a combination of improvements in all mentioned aspects offers the highest savings potential of up to 61% fossil energy and 49% GHG emissions. In weighing these three aspects, manure utilization for energy production is found to be the most important factor in reducing fossil energy use and GHG emissions. However, when GHG implications of land use change and land opportunity cost associated with the production of feed crops (e.g. soy meal, cereals) are considered, reducing feed use becomes the main factor in improving GHG performance of EU pork.

Fossil energy and GHG saving potentials of pig farming in the EU

Energy Technology Data Exchange (ETDEWEB)

Nguyen, Thu Lan T.; Hermansen, John E.; Mogensen, Lisbeth [Department of Agroecology and Environment, Aarhus University, Tjele (Denmark)

2010-05-15

In Europe, the highly developed livestock industry places a high burden on resource use and environmental quality. This paper examines pig meat production in North-West Europe as a base case and runs different scenarios to investigate how improvements in terms of energy and greenhouse gas (GHG) savings can be feasibly achieved. As shown in the results of the analysis, pig farming in the EU has a high potential to reduce fossil energy use and GHG emissions by taking improvement measures in three aspects: (i) feed use; (2) manure management; and (3) manure utilization. In particular, a combination of improvements in all mentioned aspects offers the highest savings potential of up to 61% fossil energy and 49% GHG emissions. In weighing these three aspects, manure utilization for energy production is found to be the most important factor in reducing fossil energy use and GHG emissions. However, when GHG implications of land use change and land opportunity cost associated with the production of feed crops (e.g. soy meal, cereals) are considered, reducing feed use becomes the main factor in improving GHG performance of EU pork. (author)

Escherichia coli Probiotic Strain ED1a in Pigs Has a Limited Impact on the Gut Carriage of Extended-Spectrum-β-Lactamase-Producing E. coli

Science.gov (United States)

Mourand, G.; Paboeuf, F.; Fleury, M. A.; Jouy, E.; Bougeard, S.; Denamur, E.

2016-01-01

ABSTRACT Four trials were conducted to evaluate the impact of Escherichia coli probiotic strain ED1a administration to pigs on the gut carriage or survival in manure of extended-spectrum-β-lactamase-producing E. coli. Groups of pigs were orally inoculated with strain E. coli M63 carrying the blaCTX-M-1 gene (n = 84) or used as a control (n = 26). In the first two trials, 24 of 40 E. coli M63-inoculated pigs were given E. coli ED1a orally for 6 days starting 8 days after oral inoculation. In the third trial, 10 E. coli M63-inoculated pigs were given either E. coli ED1a or probiotic E. coli Nissle 1917 for 5 days. In the fourth trial, E. coli ED1a was given to a sow and its 12 piglets, and these 12 piglets plus 12 piglets that had not received E. coli ED1a were then inoculated with E. coli M63. Fecal shedding of cefotaxime-resistant Enterobacteriaceae (CTX-RE) was studied by culture, and blaCTX-M-1 genes were quantified by PCR. The persistence of CTX-RE in manure samples from inoculated pigs or manure samples inoculated in vitro with E. coli M63 with or without probiotics was studied. The results showed that E. coli M63 and ED1a were good gut colonizers. The reduction in the level of fecal excretion of CTX-RE in E. coli ED1a-treated pigs compared to that in nontreated pigs was usually less than 1 log10 CFU and was mainly observed during the probiotic administration period. The results obtained with E. coli Nissle 1917 did not differ significantly from those obtained with E. coli ED1a. CTX-RE survival did not differ significantly in manure samples with or without probiotic treatment. In conclusion, under our experimental conditions, E. coli ED1a and E. coli Nissle 1917 could not durably prevent CTX-RE colonization of the pig gut. PMID:27795372

Escherichia coli Probiotic Strain ED1a in Pigs Has a Limited Impact on the Gut Carriage of Extended-Spectrum-β-Lactamase-Producing E. coli.

Science.gov (United States)

Mourand, G; Paboeuf, F; Fleury, M A; Jouy, E; Bougeard, S; Denamur, E; Kempf, I

2017-01-01

Four trials were conducted to evaluate the impact of Escherichia coli probiotic strain ED1a administration to pigs on the gut carriage or survival in manure of extended-spectrum-β-lactamase-producing E. coli Groups of pigs were orally inoculated with strain E. coli M63 carrying the bla CTX-M-1 gene (n = 84) or used as a control (n = 26). In the first two trials, 24 of 40 E. coli M63-inoculated pigs were given E. coli ED1a orally for 6 days starting 8 days after oral inoculation. In the third trial, 10 E. coli M63-inoculated pigs were given either E. coli ED1a or probiotic E. coli Nissle 1917 for 5 days. In the fourth trial, E. coli ED1a was given to a sow and its 12 piglets, and these 12 piglets plus 12 piglets that had not received E. coli ED1a were then inoculated with E. coli M63. Fecal shedding of cefotaxime-resistant Enterobacteriaceae (CTX-RE) was studied by culture, and bla CTX-M-1 genes were quantified by PCR. The persistence of CTX-RE in manure samples from inoculated pigs or manure samples inoculated in vitro with E. coli M63 with or without probiotics was studied. The results showed that E. coli M63 and ED1a were good gut colonizers. The reduction in the level of fecal excretion of CTX-RE in E. coli ED1a-treated pigs compared to that in nontreated pigs was usually less than 1 log 10 CFU and was mainly observed during the probiotic administration period. The results obtained with E. coli Nissle 1917 did not differ significantly from those obtained with E. coli ED1a. CTX-RE survival did not differ significantly in manure samples with or without probiotic treatment. In conclusion, under our experimental conditions, E. coli ED1a and E. coli Nissle 1917 could not durably prevent CTX-RE colonization of the pig gut. Copyright © 2016 American Society for Microbiology.

Models to quantify excretion of dry matter, nitrogen, phosphorus and carbon in growing pigs fed regional diets

OpenAIRE

Jørgensen, Henry; Prapaspongsa, Trakarn; Vu, Van Thi Khanh; Poulsen, Hanne Damgaard

2013-01-01

Modern pig production contributes to many environmental problems that relate to manure, especially in areas with highly intensive production systems and in regions like Asia where the regulative control is not effective. Therefore, the objective of this study was to use three different pig diets varying in dietary protein, fibre and fat as representative for Danish (DK), Thai (TH) and Vietnamese (VN) pig production to develop and evaluate different approaches to predict/calculate excretion fr...

Mitigation of greenhouse gas emissions by adopting anaerobic digestion technology on dairy, sow and pig farms in Finland

Energy Technology Data Exchange (ETDEWEB)

Kaparaju, P.; Rintala, J. [Department of Biological and Environmental Science, University of Jyvaeskylae, P.O. Box 35, FIN-40014 Jyvaeskylae (Finland)

2011-01-15

The impact of anaerobic digestion (AD) technology on mitigating greenhouse gas (GHG) emissions from manure management on typical dairy, sow and pig farms in Finland was compared. Firstly, the total annual GHG emissions from the farms were calculated using IPCC guidelines for a similar slurry type manure management system. Secondly, laboratory-scale experiments were conducted to estimate methane (CH{sub 4}) potentials and process parameters for semi-continuous digestion of manures. Finally, the obtained experimental data were used to evaluate the potential renewable energy production and subsequently, the possible GHG emissions that could be avoided through adoption of AD technology on the studied farms. Results showed that enteric fermentation (CH{sub 4}) and manure management (CH{sub 4} and N{sub 2}O) accounted for 231.3, 32.3 and 18.3 Mg of CO{sub 2} eq. yr{sup -1} on dairy, sow and pig farms, respectively. With the existing farm data and experimental methane yields, an estimated renewable energy of 115.2, 36.3 and 79.5 MWh of heat yr{sup -1} and 62.8, 21.8 and 47.7 MWh of electricity yr{sup -1} could be generated in a CHP plant on these farms respectively. The total GHG emissions that could be offset on the studied dairy cow, sow and pig farms were 177, 87.7 and 125.6 Mg of CO{sub 2} eq. yr{sup -1}, respectively. The impact of AD technology on mitigating GHG emissions was mainly through replaced fossil fuel consumption followed by reduced emissions due to reduced fertilizer use and production, and from manure management. (author)

Multi-component analysis of tetracyclines, sulfonamides and tylosin in swine manure by liquid chromatography-tandem mass spectrometry.

Science.gov (United States)

Jacobsen, Anne Marie; Halling-Sørensen, Bent

2006-03-01

A multi-component method focussing on thorough sample preparation has been developed for simultaneous analysis of swine manure for three classes of antibiotic-tetracyclines, sulfonamides, and tylosin. Liquid manure was initially freeze-dried and homogenised by pulverization before extraction by pressurised liquid extraction. The extraction was performed at 75 degrees C and 2,500 psig in three steps using two cycles with 0.2 mol L(-1) citric acid buffer (pH 4.7) and one cycle with a mixture of 80% methanol with 0.2 mol L(-1) citric acid (pH 3). After liquid-liquid extraction with heptane to remove lipids, the pH of the manure was adjusted to 3 with formic acid and the sample was vacuum-filtered through 0.6 mum glass-fibre filters. Finally the samples were pre-concentrated by tandem SPE (SAX-HLB). Recoveries were determined for manure samples spiked at three concentrations (50-5,000 microg kg(-1) dry matter); quantification was achieved by matrix-matched calibration. Recoveries were >70% except for oxytetracycline (42-54%), sulfadiazine (59-73%), and tylosin (9-35%) and did not vary with concentration or from day-to-day. Limits of quantification (LOQ) for all compounds, determined as a signal-to-noise ratio of 10, were in the range 10-100 microg kg(-1) dry matter. The suitability of the method was assessed by analysis of swine manure samples from six different pig-production sites, e.g. finishing pigs, sows, or mixed production. Residues of antibiotics were detected in all samples. The largest amounts were found for tetracyclines (up to 30 mg kg(-1) dry matter for the sum of CTC and ECTC). Sulfonamides were detected at concentrations up to 2 mg kg(-1) dry matter (SDZ); tylosin was not detected in any samples.

Redistribution of contaminants from pig slurry after direct injection into soil

DEFF Research Database (Denmark)

Amin, Mostofa; Bech, T B; Forslund, A

2010-01-01

The redistribution of pig manure-borne contaminants after direct injection to soil was investigated in a field study. The spatial distribution of Escherichia coli, Salmonella Typhimurium Bacteriophage 28B and other slurry components in and around the injection slit was measured on day 0.15, 1, 6...

Dissolution of rock phosphate in animal manure soil amendment and lettuce growth

Directory of Open Access Journals (Sweden)

Kofi Agyarko

2016-04-01

Full Text Available A study was conducted in pots on the field to assess the effect of different quantities of poultry manure (PM, cattle manure (CM and pig manure (PG on the release of available phosphorus from Togo rock phosphate (RP and lettuce growth. There were eleven (11 treatments which were: Control (soil only; 2.5g RP; 2.5g CM; 2.5gRP + 2.5g CM; 2.5gRP + 5gCM; 2.5gPM; 2.5gRP + 2.5gPM; 2.5gRP + 5gPM; 2.5gPG; 2.5gRP + 2.5gPG; 2.5gRP + 5gPG, applied per kg soil, using the Completely Randomized Design (CRD with three replications. Available phosphorus and other parameters were assessed using standard methods. Results were statistically analyzed using the the GenStat (11th Edition statistical software package. The amount and type of animal manure in the amendment affected the amount of the available P released. The addition of 2.5g manure to 2.5g RP in a kg of soil significantly (P<0.05 increased available P by 4 to 7 times over the sole 2.5g RP/kg soil treatment. Doubling the amount of manure in the amendment (5g manure + 2.5g RP almost doubled the amount of P released, with the poultry manure combinations being more significant. The amount of available P in the soil positively related to the plant height (R2=63, leaf area (R2=0.55, dry weight (R2=0.73 and the percentage P in the leaf (R2=0.88 of lettuce. The PM at 2.5gRP + 5gPM recorded the highest significant (P<0.05 values. The study has provided further basis for manure selection and quantities to be used in enhancing the release of P from rock phosphate. However, investigations need to be continued using nuclear techniques.

Production of Bio-Energy from Pig Manure: A Focus on the Dynamics Change of Four Parameters under Sunlight-Dark Conditions.

Directory of Open Access Journals (Sweden)

Dongxue Yin

Full Text Available This study investigated the effect of sunlight-dark conditions on volatile fatty acids (VFAs, total ammonium nitrogen (TAN, total alkalinity (TA and pH during pig manure (PM digestion and then the subsequent influence on biogas yield of PM. PM1 and PM2 were performed in a transparent reactor and a non-transparent reactor, respectively. Two sets of experiments were conducted with a temperature of 35.0±2.0 °C and a total solid concentration of 8.0% to the digestion material. The dynamic change of the four parameters in response to sunlight-dark conditions resulted in variations of the physiological properties in the digester and affected the cumulative biogas production (CBP. PM1 obtained higher CBP (15020.0 mL with a more stable pH and a lower TAN concentration (1414.5 mg/L compared to PM2 (2675.0 mL and 1670.0 mg/L, respectively. The direct path coefficients and indirect path coefficients between the four parameters and CBP were also analyzed.

Production of Bio-Energy from Pig Manure: A Focus on the Dynamics Change of Four Parameters under Sunlight-Dark Conditions.

Science.gov (United States)

Yin, Dongxue; Liu, Wei; Zhai, Ningning; Feng, Yongzhong; Yang, Gaihe; Wang, Xiaojiao; Han, Xinhui

2015-01-01

This study investigated the effect of sunlight-dark conditions on volatile fatty acids (VFAs), total ammonium nitrogen (TAN), total alkalinity (TA) and pH during pig manure (PM) digestion and then the subsequent influence on biogas yield of PM. PM1 and PM2 were performed in a transparent reactor and a non-transparent reactor, respectively. Two sets of experiments were conducted with a temperature of 35.0±2.0 °C and a total solid concentration of 8.0% to the digestion material. The dynamic change of the four parameters in response to sunlight-dark conditions resulted in variations of the physiological properties in the digester and affected the cumulative biogas production (CBP). PM1 obtained higher CBP (15020.0 mL) with a more stable pH and a lower TAN concentration (1414.5 mg/L) compared to PM2 (2675.0 mL and 1670.0 mg/L, respectively). The direct path coefficients and indirect path coefficients between the four parameters and CBP were also analyzed.

Manure management practices on biogas and non-biogas pig farms in developing countries - using livestock farms in Vietnam as an example

DEFF Research Database (Denmark)

Cu, T. T. T.; Cuong, P. H.; Hang, L. T.

2012-01-01

This survey was carried out to study animal manure management on livestock farms with biogas technology (biogas farms) and without (non-biogas farms) in the areas surrounding the Vietnamese cities Hanoi and Hue. The objective of the study was to assess the contribution of biogas production...... to a better environment as well as to recognize the problems with livestock manure management on small-scale farms. On all the farms included in the study more than one manure management technology was used, i.e. composting, separation of manure, biogas production and discharge of liquid manure to recipients...... such as public sewers or ponds. On biogas farms, most of the manure collected was used for bio-digestion. The farmers used the fermented manure (digestate) as a source of nutrients for crops, but on more than 50% of the interviewed biogas farms digestate was discharged to the environment. On non-biogas farms...

Ammonia emission from excreta of growing-finishing pigs as affected by dietary composition

NARCIS (Netherlands)

Canh, T.T.

1998-01-01

Ammonia, volatilised from pig slurry decreases manure's fertiliser value. Furthermore, the deposition of ammonia emitted into the atmosphere may cause undesirable changes in aquatic and terrestrial ecosystems. At present, there is increasing interest in nutritional means to reduce ammonia

Estimation of methane emissions from slurry pits under pig and cattle confinements

DEFF Research Database (Denmark)

Petersen, Søren O.; Olsen, Anne B.; Elsgaard, Lars

2016-01-01

Quantifying in-house emissions of methane (CH4) from liquid manure (slurry) is difficult due to high background emissions from enteric processes, yet of great importance for correct estimation of CH4 emissions from manure management and effects of treatment Technologies such as anaerobic digestion...... less sensitive to uncertainties in VSd or slurry temperature. A model application indicated that losses of carbon in VS as CO2 may be much greater than losses as CH4. Implications of these results for the correct estimation of CH4 emissions from manure management, and for the mitigation potential...... and cattle slurry differed significantly at 0.030 and 0.011 kg CH4 kg-1 VS (volatile solids). Current estimates of CH4 emissions from pig and cattle manure management correspond to 0.032 and 0.015 kg CH4 kg-1, respectively, indicating that slurry pits under animal confinements are a significant source...

Optimization of the anaerobic co-digestion of pasteurized slaughterhouse waste, pig slurry and glycerine.

Science.gov (United States)

Rodríguez-Abalde, Ángela; Flotats, Xavier; Fernández, Belén

2017-03-01

The feasibility of co-digestion of blends of two different animal by-products (pig manure and pasteurized slaughterhouse waste) and recovered glycerine was studied in mesophilic conditions. Experiments were performed in a lab-scale CSTR along 490days, with a hydraulic retention time of 21-33days and with a step-wise increased organic loading rate, by adding and/or changing the wastes ratio, from 0.8 to 3.2kg COD m -3 d -1 . The best methane production rate (0.64Nm 3 CH4 m -3 d -1 ) represented an increment of 2.9-fold the initial one (0.22Nm 3 CH4 m -3 d -1 with pig manure solely). It was attained with a ternary mixture composed, in terms of inlet volatile solids, by 35% pig slurry, 47% pasteurized slaughterhouse waste and 18% glycerine. This blend was obtained through a stepwise C/N adjustment: this strategy led to a more balanced biodegradation due to unstressed bacterial populations through the performance, showed by the VFA-related indicators. Besides this, an improved methane yield (+153%) and an organic matter removal efficiency (+83%), regarding the digestion of solely pig slurry, were attained when the C/N ratio was adjusted to 10.3. Copyright © 2016 Elsevier Ltd. All rights reserved.

Modelling nitrogen and carbon interactions in composting of animal manure in naturally aerated piles.

Science.gov (United States)

Oudart, D; Robin, P; Paillat, J M; Paul, E

2015-12-01

Composting animal manure with natural aeration is a low-cost and low-energy process that can improve nitrogen recycling in millions of farms world-wide. Modelling can decrease the cost of choosing the best options for solid manure management in order to decrease the risk of loss of fertilizer value and ammonia emission. Semi-empirical models are suitable, considering the scarce data available in farm situations. Eleven static piles of pig or poultry manure were monitored to identify the main processes governing nitrogen transformations and losses. A new model was implemented to represent these processes in a pile considered as homogeneous. The model is based on four modules: biodegradation, nitrogen transformations and volatilization, thermal exchanges, and free air space evolution. When necessary, the parameters were calibrated with the data set. The results showed that microbial growth could reduce ammonia volatilization. Greatest nitrogen conservation is achieved when microbial growth was limited by nitrogen availability. Copyright © 2015 The Authors. Published by Elsevier Ltd.. All rights reserved.

Comparison of three distinct management strategies for pig slurry applied to three groups of farms

International Nuclear Information System (INIS)

Dauden, A.; Teresa, M.; Siegler, C.; Bescos, B.; Burton, C.

2009-01-01

Poor management of pig slurry can lead to the contamination of the soil, water and air, which is mostly of the result of sur-plus nutrients. Such environmental impact from pig farming are common in areas with intensive livestock farming. The projects primary objectives is to demonstrate at farm scale the application of the three main manure management technologies deployed within structured local schemes to minimize the environmental impact. (Author)

Mass loading of typical artificial sweeteners in a pig farm and their dissipation and uptake by plants in neighboring farmland.

Science.gov (United States)

Ma, Ling; Liu, Yarui; Xu, Jiayao; Sun, Hongwen; Chen, Hao; Yao, Yiming; Zhang, Peng; Shen, Fengju; Alder, Aldredo C

2017-12-15

Pig farm is an important potential source for artificial sweeteners (ASs) in the environment due to their wide use as additives in pig feed. The objective of this study was to evaluate the fate of typical ASs in pig farm and neighboring farmland. For this purpose, the levels of four typical artificial ASs, i.e. saccharin (SAC), cyclamate (CYC), acesulfame (ACE) and sucralose (SUC), in pig feed and manure from a pig farm and water samples from an on-farm wastewater treatment plant (WWTP) in Tianjin, China were measured and the mass loadings and removal efficiencies were assessed. Moreover, the levels of ASs in different layers of soil and vegetables in neighboring farmland that received manure fertilizers and wastewater from the farm were consecutively monitored for 60-80days. The SAC, CYC and ACE were widely determined in all kinds of the samples, while SUC was only found in few soil samples. The mass loadings of the ASs in pig feed were estimated up to 311kg/year for SAC, 59.1kg/year for CYC, and 17.1kg/year for ACE, respectively. The fractions of the total mass of ASs excreted via manure were estimated to be 36.0% for SAC, 59.4% for CYC, and 36.7% for ACE as compared to those in pig feed. High removal efficiencies (>90%) of ASs in the on-farm WWTP was achieved. In greenhouse soils, CYC, SAC, ACE, and SUC were degraded quickly, with half-lives of 4.3-5.9 d, 2.7-4.2 d, 8.4-12.3 d, and 7.3-10.8 d, respectively. Lower levels of ASs were found in deeper soil layer (20-30cm). The ASs were considerably absorbed by plants when the ASs' concentrations were high in soil. This study presents the first comprehensive overview of ASs fate from a pig farm to the neighboring agricultural ecosystem. Copyright © 2017. Published by Elsevier B.V.

Microbial ecology, bacterial pathogens, and antibiotic resistant genes in swine manure as influenced by three swine management systems

Science.gov (United States)

The environmental influence of farm management in concentrated animal feeding operations (CAFO) can yield vastly different microbial constituents in both the pig and the manure lagoons used to treat the fecal waste of the operation. While some of these changes may not be negative, it is possible th...

A simple method to identify areas of environmental risk due to manure application.

Science.gov (United States)

Flores, Héctor; Arumí, José Luis; Rivera, Diego; Lagos, L Octavio

2012-06-01

The management of swine manure is becoming an important environmental issue in Chile. One option for the final disposal of manure is to use it as a biofertilizer, but this practice could impact the surrounding environment. To assess the potential environmental impacts of the use of swine manure as a biofertilizer, we propose a method to identify zones of environmental risk through indices. The method considers two processes: nutrient runoff and solute leaching, and uses available information about soils, crops and management practices (irrigation, fertilization, and rotation). We applied the method to qualitatively assess the environmental risk associated with the use of swine manure as a biofertilizer in an 8,000-pig farm located in Central Chile. Results showed that the farm has a moderate environmental risk, but some specific locations have high environmental risks, especially those associated with impacts on areas surrounding water resources. This information could assist the definition of better farm-level management practices, as well as the preservation of riparian vegetation acting as buffer strips. The main advantage of our approach is that it combines qualitative and quantitative information, including particular situations or field features based on expert knowledge. The method is flexible, simple, and can be easily extended or adapted to other processes.

Impact of fiber source and feed particle size on swine manure properties related to spontaneous foam formation during anaerobic decomposition.

Science.gov (United States)

Van Weelden, M B; Andersen, D S; Kerr, B J; Trabue, S L; Pepple, L M

2016-02-01

Foam accumulation in deep-pit manure storage facilities is of concern for swine producers because of the logistical and safety-related problems it creates. A feeding trial was performed to evaluate the impact of feed grind size, fiber source, and manure inoculation on foaming characteristics. Animals were fed: (1) C-SBM (corn-soybean meal): (2) C-DDGS (corn-dried distiller grains with solubles); and (3) C-Soybean Hull (corn-soybean meal with soybean hulls) with each diet ground to either fine (374 μm) or coarse (631 μm) particle size. Two sets of 24 pigs were fed and their manure collected. Factors that decreased feed digestibility (larger grind size and increased fiber content) resulted in increased solids loading to the manure, greater foaming characteristics, more particles in the critical particle size range (2-25 μm), and a greater biological activity/potential. Copyright © 2015 Elsevier Ltd. All rights reserved.

NH3 dynamics in composting : assessment of the integration of composting in manure management chains

NARCIS (Netherlands)

Szanto, G.L.

2009-01-01

The Dutch animal production sector copes with a manure problem. Their high nitrogen content makes manures popular fertilizers, but most of this nitrogen is emitted before it could be used by plants. Ammonia is the main emission form during the manure management chain of storage, transportation and

Process performance and comparative metagenomic analysis during co-digestion of manure and lignocellulosic biomass for biogas production

International Nuclear Information System (INIS)

Tsapekos, P.; Kougias, P.G.; Treu, L.; Campanaro, S.; Angelidaki, I.

2017-01-01

Highlights: • Pig manure and ensiled meadow grass were examined in co-digestion process. • Mechanical pretreatment increased the methane yield by 6.4%. • Coprothermobacter proteolyticus was firmly bounded to the digested grass. • Clostridium thermocellum was enriched in the firmly attached grass samples. • The abundance of methanogens was higher in the liquid fraction of digestate. - Abstract: Mechanical pretreatment is considered to be a fast and easily applicable method to prepare the biomass for anaerobic digestion. In the present study, the effect of mechanical pretreatment on lignocellulosic silages biodegradability was elucidated in batch reactors. Moreover, co-digestion of the silages with pig manure in continuously fed biogas reactors was examined. Metagenomic analysis for determining the microbial communities in the pig manure digestion system was performed by analysing unassembled shotgun genomic sequences. A comparative analysis allowed to identify the microbial species firmly attached to the digested grass particles and to distinguish them from the planktonic microbes floating in the liquid medium. It was shown that the methane yield of ensiled grass was significantly increased by 12.3% due to mechanical pretreatment in batch experiments. Similarly, the increment of the methane yield in the co-digestion system reached 6.4%. Regarding the metagenomic study, species similar to Coprothermobacter proteolyticus and to Clostridium thermocellum, known for high proteolytic and cellulolytic activity respectively, were found firmly attached to the solid fraction of digested feedstock. Results from liquid samples revealed clear differences in microbial community composition, mainly dominated by Proteobacteria. The archaeal community was found in higher relative abundance in the liquid fraction of co-digestion experiment compared to the solid fraction. Finally, an unclassified Alkaliphilus sp. was found in high relative abundance in all samples.

Methane productivity of manure, straw and solid fractions of manure

DEFF Research Database (Denmark)

Møller, H.B.; Sommer, S.G.; Ahring, Birgitte Kiær

2004-01-01

are in the same range (282-301 m(3) CH4 LU-1). Pre-treatment of manure by separation is a way of making fractions of the manure that have a higher gas potential per volume. Theoretical methane potential and biodegradability of three types of fractions deriving from manure separation were tested. The volumetric...... methane yield of straw was found to be higher than the yield from total manure and the solid fractions of manure, due to the higher VS content, and hence the use of straw as bedding material will increase the volumetric as well as the livestock-based methane productivity....

Residues of veterinary antibiotics in manures from feedlot livestock in eight provinces of China.

Science.gov (United States)

Zhao, Ling; Dong, Yuan Hua; Wang, Hui

2010-02-01

The residue levels of selected fluoroquinolones, sulfonamides and tetracyclines in 143 animal dung samples collected in 2007 from large-scale livestock and poultry feedlots in 8 provinces were determined by using ultrasonic extraction and liquid chromatography. Recoveries from spiked pig dung samples (spike level=1mg/kg) ranged from 73.9 to 102.0% for fluoroquinolones, from 81.6 to 92.3% for sulfonamides, and from 57.2 to 72.6% for tetracyclines. Relative standard deviations of the recoveries were less than 10% within the same day. Method quantification limits were measured from 0.031 to 0.150 mg/kg for fluoroquinolones, from 0.023 to 0.082 mg/kg for sulfonamides, and 0.091 to 0.182 mg/kg for tetracyclines in spiked pig manure samples. Analysis of 61 pig, 54 chicken and 28 cow dung samples collected in China revealed that in pig and cow dung, up to 33.98 and 29.59 mg/kg ciprofloxacin, 33.26 and 46.70 mg/kg enrofloxacin, 59.06 and 59.59 mg/kg oxytetracycline, and 21.06 and 27.59 mg/kg chlortetracycline could be detected, respectively. A maximum concentration of 99.43 mg/kg fleroxacin, 225.45 mg/kg norfloxacin, 45.59 mg/kg ciprofloxacin and 1420.76 mg/kg enrofloxacin could be detected in chicken dung. No appreciable sulfonamide antibiotic concentrations (less than 10mg/kg) were found in any animal dung, and only sulfadimidine was observed, at a maximum concentration of 6.04 mg/kg, in chicken dung. Both enrofloxacin and chlortetracycline were detected with a very high occurrence in three animal manure samples. The residue levels for most antibiotics showed significant statistical differences among the sampling districts and the animal species. Copyright 2009 Elsevier B.V. All rights reserved.

Odour and ammonia removal from pig house exhaust air using a biotrickling filter

NARCIS (Netherlands)

Melse, R.W.; Mol, G.

2004-01-01

Odour from agricultural activities, such as the spreading of manure and the housing of animals, is increasingly being considered a nuisance in densely populated countries like the Netherlands. The objective of this research was to study the odour removal from pig house exhaust air by a biotrickling

Nitrogen consumption, utilisation and losses in pig production in France, The Netherlands, and Denmark

NARCIS (Netherlands)

Dourmad, J.Y.; SOve, B.; Latimer, P.; Boisen, S.; Fernández, J.; Peet-Schwering, van der C.; Jongbloed, A.W.

1999-01-01

In highly intensive pig production areas, manure disposal is a major problem especially for nitrogen, because of water pollution by nitrates and air pollution by gaseous ammonia emissions. The situations in three European countries (Denmark, The Netherlands and France) were compared, on average, it

Effects of air exchange, temperature and slurry management on odorant emissions from pig production units and slurry tanks studied by proton-transfer-reaction mass spectrometry (PTR-MS)

Energy Technology Data Exchange (ETDEWEB)

Feilberg, A.; Adamsen, A.P.S.; Liu, D.; Hansen, M.J.; Bildsoe, P. [Aarhus Univ., Tjele (Denmark). Dept. of Biosystems Engineering

2010-07-01

The factors affecting the variability of odorant emissions from intensive pig production facilities were examined using proton-transfer-reaction mass spectrometry (PTR-MS) to monitor emissions of odorants. Quantitative and time-resolved results for protonated ions representing hydrogen sulphide (H{sub 2}S), volatile organic sulphur compounds, organic amines, volatile carboxylic acids, carbonyls, phenols and indoles can be obtained. This study presented the results from PTRMS measurements of odorant emissions from finisher pig houses and finisher manure storage tanks. The measurements were performed at an experimental full-scale pig section with mechanical ventilation and at an experimental manure storage facility with controlled air exchange. Field measurements were taken during variable air exchange rates and temperatures, during finisher growth, and during emptying of the slurry pit. The results revealed a pronounced diurnal variation in emissions of odorants from the pig section with peaks in daytime coinciding with the highest ventilation rates and highest room temperatures. The highest emission rates were observed for H{sub 2}S and carboxylic acids. Based on odour threshold values, methanethiol and 4-methylphenol were estimated to contribute considerably to the odour nuisance. Discharging of the slurry pit led to reduced H{sub 2}S emissions, but peaks of H{sub 2}S were observed during manure handling.

Profile and Role of Woman Involvement in Dry System Pig Farming

Directory of Open Access Journals (Sweden)

Hartoko Hartoko

2004-01-01

Full Text Available This research was purposed to study the profile and role of woman involvement in dry system pig farming (pig housing with mattress from grass, pig manure, vegetable waste and kitchen waste.  The research was carried out from August to November 2003.  Pig housing areas were located on eight villages of Kertek District in Wonosobo Regency (Central Java.  The method applied was survey with intensive observation.  Sample were randomly selected, involved 180 respondents (15 percent of total pig farmers, while the locations of the sample were selected based on purposive sampling method.  The result showed that respondents were in productive age, with low formal education level. Most of all are Moslems (98% and they have small family size.  The level of woman involvement in pig farming was high, approximately 85 percent.  They have other income source and they involve in pig farming to help their husbands in generating income.  Experience in the dry system pig farming was quite long (more than 10 years and skill come from imitating their neighbours otherwise of autodidact. (Animal Production 6(1: 23-29 (2004   Key Words: Pig, Dry System, Woman Profile and Role

Sulfonamide-resistant bacteria and their resistance genes in soils fertilized with manures from Jiangsu Province, Southeastern China.

Science.gov (United States)

Wang, Na; Yang, Xiaohong; Jiao, Shaojun; Zhang, Jun; Ye, Boping; Gao, Shixiang

2014-01-01

Antibiotic-resistant bacteria and genes are recognized as new environmental pollutants that warrant special concern. There were few reports on veterinary antibiotic-resistant bacteria and genes in China. This work systematically analyzed the prevalence and distribution of sulfonamide resistance genes in soils from the environments around poultry and livestock farms in Jiangsu Province, Southeastern China. The results showed that the animal manure application made the spread and abundance of antibiotic resistance genes (ARGs) increasingly in the soil. The frequency of sulfonamide resistance genes was sul1 > sul2 > sul3 in pig-manured soil DNA and sul2 > sul1 > sul3 in chicken-manured soil DNA. Further analysis suggested that the frequency distribution of the sul genes in the genomic DNA and plasmids of the SR isolates from manured soil was sul2 > sul1 > sul3 overall (psulfonamide resistance genes. The present study also indicated that Bacillus, Pseudomonas and Shigella were the most prevalent sul-positive genera in the soil, suggesting a potential human health risk. The above results could be important in the evaluation of antibiotic-resistant bacteria and genes from manure as sources of agricultural soil pollution; the results also demonstrate the necessity and urgency of the regulation and supervision of veterinary antibiotics in China.

Effect of spent mushroom substrate as a bulking agent on gaseous emissions and compost quality during pig manure composting.

Science.gov (United States)

Li, Shuyan; Li, Danyang; Li, Jijin; Li, Yangyang; Li, Guoxue; Zang, Bing; Li, Yun

2018-05-01

The aim of this study was to investigate the gaseous emissions (CH 4 , N 2 O, and NH 3 ) and compost quality during the pig manure composting by adding spent mushroom substrate (SMS) as a bulking agent. The control treatment was also studied using corn stalk (CS) as a bulking agent. The experiment was conducted in a pilot scale composting reactor under aerobic condition with the initial C/N ratio of 20. Results showed that bulking agents significantly affected gaseous emissions and compost quality. Using SMS as a bulking agent improved composting efficiency by shortening the time for maturity. SMS increased germination index and humic acid of the final compost (by 13.44 and 41.94%, respectively) compared with CS. Furthermore, composting with SMS as a bulking agent could reduce nitrogen loss, NH 3 , and N 2 O emissions (by 13.57, 35.56, and 46.48%, respectively) compared with the control. SMS slightly increased CH 4 emission about 1.1 times of the CS. However, a 33.95% decrease in the global warming potential of CH 4 and N 2 O was obtained by adding SMS treatment. These results indicate that SMS is a favorable bulking agent for reducing gaseous emissions and increasing compost quality.

Greenhouse Gas and Ammonia Emissions from Different Stages of Liquid Manure Management Chains: Abatement Options and Emission Interactions.

Science.gov (United States)

Mohankumar Sajeev, Erangu Purath; Winiwarter, Wilfried; Amon, Barbara

2018-01-01

Farm livestock manure is an important source of ammonia and greenhouse gases. Concerns over the environmental impact of emissions from manure management have resulted in research efforts focusing on emission abatement. However, questions regarding the successful abatement of manure-related emissions remain. This study uses a meta-analytical approach comprising 89 peer-reviewed studies to quantify emission reduction potentials of abatement options for liquid manure management chains from cattle and pigs. Analyses of emission reductions highlight the importance of accounting for interactions between emissions. Only three out of the eight abatement options considered (frequent removal of manure, anaerobic digesters, and manure acidification) reduced ammonia (3-60%), nitrous oxide (21-55%), and methane (29-74%) emissions simultaneously, whereas in all other cases, tradeoffs were identified. The results demonstrate that a shift from single-stage emission abatement options towards a whole-chain perspective is vital in reducing overall emissions along the manure management chain. The study also identifies some key elements like proper clustering, reporting of influencing factors, and explicitly describing assumptions associated with abatement options that can reduce variability in emission reduction estimates. Prioritization of abatement options according to their functioning can help to determine low-risk emission reduction options, specifically options that alter manure characteristics (e.g., reduced protein diets, anaerobic digestion, or slurry acidification). These insights supported by comprehensive emission measurement studies can help improve the effectiveness of emission abatement and harmonize strategies aimed at reducing air pollution and climate change simultaneously. Copyright © by the American Society of Agronomy, Crop Science Society of America, and Soil Science Society of America, Inc.

Production of methane by co-digestion of cassava pulp with various concentrations of pig manure

Energy Technology Data Exchange (ETDEWEB)

Panichnumsin, Pornpan [The Joint Graduate School of Energy and Environment, King Mongkut' s University of Technology Thonburi, Thungkru, Bangkok 10140 (Thailand); Excellent Center of Waste Utilization and Management, National Center for Genetic Engineering and Biotechnology, Bangkhuntien, Bangkok 10150 (Thailand); Nopharatana, Annop [Pilot Plant Development and Training Institute, King Mongkut' s University of Technology Thonburi, Bangkhuntien, Bangkok 10150 (Thailand); Ahring, Birgitte [AAU, Copenhagen Institute of Technology, Lautrupvang 15, 2750 Ballerup (Denmark); Chaiprasert, Pawinee [School of Bioresources and Technology, King Mongkut' s University of Technology Thonburi, Bangkhuntien, Bangkok 10150 (Thailand)

2010-08-15

Cassava pulp is a major by-product produced in a cassava starch factory, containing 50-60% of starch (dry basis). Therefore, in this study we are considering its potential as a raw material substrate for the production of methane. To ensure sufficient amounts of nutrients for the anaerobic digestion process, the potential of co-digestion of cassava pulp (CP) with pig manure (PM) was further examined. The effect of the co-substrate mixture ratio was carried out in a semi-continuously fed stirred tank reactor (CSTR) operated under mesophilic condition (37 C) and at a constant OLR of 3.5 kg VS m{sup -3} d{sup -1} and a HRT of 15 days. The results showed that co-digestion resulted in higher methane production and reduction of volatile solids (VS) but lower buffering capacity. Compared to the digestion of PM alone, the specific methane yield increased 41% higher when co-digested with CP in concentrations up to 60% of the incoming VS. This was probably due to an increase in available easily degradable carbohydrates as the CP ratio in feedstock increased. The highest methane yield and VS removal of 306 mL g{sup -1} VS{sub added} and 61%, respectively, were achieved with good process stability (VFA:Alkalinity ratio < 0.1) when CP accounted for 60% of the feedstock VS. A further increase of CP of the feedstock led to a decrease in methane yield and solid reductions. This appeared to be caused by an extremely high C:N ratio of the feedstock resulting in a deficiency of ammonium nitrogen for microbial growth and buffering capacity. (author)

Production of methane by co-digestion of cassava pulp with various concentrations of pig manure

International Nuclear Information System (INIS)

Panichnumsin, Pornpan; Nopharatana, Annop; Ahring, Birgitte; Chaiprasert, Pawinee

2010-01-01

Cassava pulp is a major by-product produced in a cassava starch factory, containing 50-60% of starch (dry basis). Therefore, in this study we are considering its potential as a raw material substrate for the production of methane. To ensure sufficient amounts of nutrients for the anaerobic digestion process, the potential of co-digestion of cassava pulp (CP) with pig manure (PM) was further examined. The effect of the co-substrate mixture ratio was carried out in a semi-continuously fed stirred tank reactor (CSTR) operated under mesophilic condition (37 o C) and at a constant OLR of 3.5 kg VS m -3 d -1 and a HRT of 15 days. The results showed that co-digestion resulted in higher methane production and reduction of volatile solids (VS) but lower buffering capacity. Compared to the digestion of PM alone, the specific methane yield increased 41% higher when co-digested with CP in concentrations up to 60% of the incoming VS. This was probably due to an increase in available easily degradable carbohydrates as the CP ratio in feedstock increased. The highest methane yield and VS removal of 306 mL g -1 VS added and 61%, respectively, were achieved with good process stability (VFA:Alkalinity ratio < 0.1) when CP accounted for 60% of the feedstock VS. A further increase of CP of the feedstock led to a decrease in methane yield and solid reductions. This appeared to be caused by an extremely high C:N ratio of the feedstock resulting in a deficiency of ammonium nitrogen for microbial growth and buffering capacity.

Enhanced methane production from pig slurry with pulsed electric field pre-treatment.

Science.gov (United States)

Safavi, Seyedeh Masoumeh; Unnthorsson, Runar

2018-02-01

Intensive amount of manure produced in pig breeding sectors represents negative impact on the environment and requires optimal management. Anaerobic digestion as a well-known manure management process was optimized in this experimental study by pulsed electric field (PEF) pre-treatment. The effect of PEF on methane production was investigated at three different intensities (15, 30 and 50 kWh/m 3 ). The results indicate that the methane production and chemical oxygen demand (COD) removal was improved by continuous escalation of applied intensity, up to 50 kWh/m 3 . In comparison with untreated slurry, methane production and COD removal were increased up to 58% and 44%, respectively.

Feeding on microbiomes: effects of detritivory on the taxonomic and phylogenetic bacterial composition of animal manures.

Science.gov (United States)

Aira, Manuel; Bybee, Seth; Pérez-Losada, Marcos; Domínguez, Jorge

2015-11-01

Earthworms play a key role in nutrient cycling by interacting with microorganisms thus accelerating organic matter turnover in soil systems. As detritivores, some earthworm types ingest and digest a mixture of dead organic matter and microorganisms, like animal manures (i.e. animal gut microbiomes). Here we described the earthworm cast microbiome and the role ingested bacteria play on its composition. We fed Eisenia andrei with cow, horse and pig manures and determined the taxonomic and phylogenetic composition of the these manures before and after passage through the earthworm gut. Earthworm cast microbiomes showed a smaller diversity than the manure they fed on. Manures strongly differed in their taxonomic and phylogenetic composition, but these differences were markedly reduced once transformed into earthworm cast microbiomes after passage through the earthworm gut. The core earthworm cast microbiome comprised 30 OTUs (2.6% of OTUs from cast samples), of which 10 are possibly native to the earthworm gut. Most of the core cast microbiome OTUs belonged to phyla Actinobacteria and Proteobacteria, as opposed to already described animal core gut microbiomes, which are composed mainly of Firmicutes and Bacteroidetes. Our results suggest that earthworms build up their cast microbiome by selecting from the pool of ingested bacteria. © FEMS 2015. All rights reserved. For permissions, please e-mail: journals.permissions@oup.com.

Kinetics of Methane Production from Swine Manure and Buffalo Manure.

Science.gov (United States)

Sun, Chen; Cao, Weixing; Liu, Ronghou

2015-10-01

The degradation kinetics of swine and buffalo manure for methane production was investigated. Six kinetic models were employed to describe the corresponding experimental data. These models were evaluated by two statistical measurements, which were root mean square prediction error (RMSPE) and Akaike's information criterion (AIC). The results showed that the logistic and Fitzhugh models could predict the experimental data very well for the digestion of swine and buffalo manure, respectively. The predicted methane yield potential for swine and buffalo manure was 487.9 and 340.4 mL CH4/g volatile solid (VS), respectively, which was close to experimental values, when the digestion temperature was 36 ± 1 °C in the biochemical methane potential assays. Besides, the rate constant revealed that swine manure had a much faster methane production rate than buffalo manure.

Analysis of integrated animal-fish production system under subtropical hill agro ecosystem in India: growth performance of animals, total biomass production and monetary benefit.

Science.gov (United States)

Kumaresan, A; Pathak, K A; Bujarbaruah, K M; Vinod, K

2009-03-01

The present study assessed the benefits of integration of animals with fish production in optimizing the bio mass production from unit land in subtropical hill agro ecosystem. Hampshire pigs and Khaki Campbell ducks were integrated with composite fish culture. The pig and duck excreta were directly allowed into the pond and no supplementary feed was given to fish during the period of study. The average levels of N, P and K in dried pig and duck manure were 0.9, 0.7 and 0.6 per cent and 1.3, 0.6 and 0.5 per cent, respectively. The average body weight of pig and duck at 11 months age was 90 and 1.74 kg with an average daily weight gain of 333.33 and 6.44 g, respectively. The fish production in pig-fish and duck-fish systems were 2209 and 2964 kg/ha, respectively while the fish productivity in control pond was only 820 kg/ha. The total biomass (animal and fish) production was higher (pfeeding system compared to the traditional system, however the input/output ratio was 1:1.2 and 1:1.55 for commercial and traditional systems, respectively. It was inferred that the total biomass production per unit land was high (pfish were integrated together.

Nitrogen, phosphorus and carbon excretion and losses in growing pigs fed Danish or Asian diets

DEFF Research Database (Denmark)

Prapaspongsa, Trakarn; Vu, Van Thi Khanh; Poulsen, Hanne Damgaard

2008-01-01

The objectives of this study were to determine inputs and outputs of nitrogen (N), phosphorus (P) and carbon (C) and to estimate the nutrient losses during housing and storage in order to address these important parts of the whole manure management systems in pigs fed different diets....

Changes in pig production in China and their effects on nitrogen and phosphorus use and losses.

Science.gov (United States)

Bai, Z H; Ma, L; Qin, W; Chen, Q; Oenema, O; Zhang, F S

2014-11-04

China's pig production has increased manifold in the past 50 years, and this has greatly affected the nitrogen and phosphorus use and losses in the pig production sector. However, the magnitude of these changes are not well-known. Here, we provide an in-depth account of the changes in pig production--N and P use and total N and P losses in the whole pig production chain during the period 1960-2010--through simulation modeling and using data from national statistics and farm surveys. For the period of 2010-2030, we explored possible effects of technological and managerial measures aimed at improving the performances of pig production via scenario analysis. We used and further developed the NUtrient flows in Food chains, Environment and Resources use (NUFER) model to calculate the feed requirement and consumption, and N and P losses in different pig production systems for all the years. Between 1960 and 2010, pig production has largely shifted from the so-called backyard system to landless systems. The N use efficiencies at fattener level increased from 18 to 28%, due to the increased animal productivity. However, the N use efficiencies at the whole-system level decreased from 46 to 11% during this period, mainly due to the increase of landless pig farms, which rely on imported feed and have no land-base for manure disposal. The total N and P losses were 5289 and 829 Gg in 2010, which is 30 and 95 times higher than in 1960. In the business as usual scenario, the total N and P losses were projected to increase by 25 and 55% between 2010 and 2030, respectively. Analyses of other scenarios indicate that packages of technological and managerial measures can decrease total N and P losses by 64 and 95%, respectively. Such improvements require major transition in the pig production sector, notably, in manure management, herd management, and feeding practices.

Mass and Energy Balances of Dry Thermophilic Anaerobic Digestion Treating Swine Manure Mixed with Rice Straw.

Science.gov (United States)

Zhou, Sheng; Zhang, Jining; Zou, Guoyan; Riya, Shohei; Hosomi, Masaaki

2015-01-01

To evaluate the feasibility of swine manure treatment by a proposed Dry Thermophilic Anaerobic Digestion (DT-AD) system, we evaluated the methane yield of swine manure treated using a DT-AD method with rice straw under different C/N ratios and solid retention time (SRT) and calculated the mass and energy balances when the DT-AD system is used for swine manure treatment from a model farm with 1000 pigs and the digested residue is used for forage rice production. A traditional swine manure treatment Oxidation Ditch system was used as the study control. The results suggest that methane yield using the proposed DT-AD system increased with a higher C/N ratio and shorter SRT. Correspondently, for the DT-AD system running with SRT of 80 days, the net energy yields for all treatments were negative, due to low biogas production and high heat loss of digestion tank. However, the biogas yield increased when the SRT was shortened to 40 days, and the generated energy was greater than consumed energy when C/N ratio was 20 : 1 and 30 : 1. The results suggest that with the correct optimization of C/N ratio and SRT, the proposed DT-AD system, followed by using digestate for forage rice production, can attain energy self-sufficiency.

Models to quantify excretion of dry matter, nitrogen, phosphorus and carbon in growing pigs fed regional diets

DEFF Research Database (Denmark)

Jørgensen, Henry; Poulsen, Hanne Damgaard; Prapaspongsa, Trakarn

2013-01-01

used in a digestibility and balance experiment. Excretion of dry matter (DM), nitrogen (N), phosphorus (P) and carbon (C) of the experimental diets were determined. Due to the highest dietary fibre content, VN had the lowest digestibility of N, P and C (73, 49, and 73%, respectively) compared......Modern pig production contributes to many environmental problems that relate to manure, especially in areas with highly intensive production systems and in regions like Asia where the regulative control is not effective. Therefore, the objective of this study was to use three different pig diets...... varying in dietary protein, fibre and fat as representative for Danish (DK), Thai (TH) and Vietnamese (VN) pig production to develop and evaluate different approaches to predict/calculate excretion from growing pigs in comparison with the experimentally determined values. Nine female growing pigs were...

Methanic fermentation of manure

Energy Technology Data Exchange (ETDEWEB)

Donadeo, M

1954-06-01

A comparison between the chemical composition of manure ripened in conventional ditches and that of manure anaerobically fermented in tanks led to the conclusion that the latter was not satisfactory; the resulting manure was less valuable.

Biogas Production from Chicken Manure

Directory of Open Access Journals (Sweden)

Kenan Dalkılıç

2013-11-01

Full Text Available Traditionally, animal manures are burned for heating in Turkey. It is also used as soil conditioner which has adverse environmental effects. Although, the use of renewable energy sources in Turkey is very limited, the application studies on biogas production from animal manure are increasing. 25-30% of total animal manures produced in Turkey are composed of chicken manure. The works on biogas production from chicken manure are very limited in Turkey. In this paper, biogas production studies from chicken manure in Turkey and in the World are reviewed.

Microbial pollution in wildlife: Linking agricultural manuring and bacterial antibiotic resistance in red-billed choughs.

Science.gov (United States)

Blanco, Guillermo; Lemus, Jesús A; Grande, Javier

2009-05-01

The spread of pathogens in the environment due to human activities (pathogen pollution) may be involved in the emergence of many diseases in humans, livestock and wildlife. When manure from medicated livestock and urban effluents is spread onto agricultural land, both residues of antibiotics and bacteria carrying antibiotic resistance may be introduced into the environment. The transmission of bacterial resistance from livestock and humans to wildlife remains poorly understood even while wild animals may act as reservoirs of resistance that may be amplified and spread in the environment. We determined bacterial resistance to antibiotics in wildlife using the red-billed chough Pyrrhocorax pyrrhocorax as a potential bioindicator of soil health, and evaluated the role of agricultural manuring with waste of different origins in the acquisition and characteristics of such resistance. Agricultural manure was found to harbor high levels of bacterial resistance to multiple antibiotics. Choughs from areas where manure landspreading is a common agricultural practice harbor a high bacterial resistance to multiple antibiotics, resembling the resistance profile found in the waste (pig slurry and sewage sludge) used in each area. The transfer of bacterial resistance to wildlife should be considered as an important risk for environmental health when agricultural manuring involves fecal material containing multiresistant enteric bacteria including pathogens from livestock operations and urban areas. The assessment of bacterial resistance in wild animals may be valuable for the monitoring of environmental health and for the management of emergent infectious diseases influenced by the impact of different human activities in the environment.

The Agrocentre. A sustainable pig cluster; Het Agrocentrum. Een duurzaam varkenscluster

Energy Technology Data Exchange (ETDEWEB)

De Wilt, J.G. [InnovatieNetwerk, Utrecht (Netherlands); Noorduyn, L. [De Schrijfster, Bennekom (Netherlands)

2011-02-15

To what extent does the continuous process of upscaling in pig farming present opportunities to take sustainability to a new level? To answer this question, several pig farmers, assisted by InnovationNetwork, have devised a concept for a sustainable pig cluster which they have dubbed Agrocentre. Various studies have shown that the Agrocentre can grow into an animal- and environment-friendly form of pig farming that blends in well with the countryside whilst also being economically viable. An Agrocentre is a type of Agropark where pig farming is clustered with an agro-power station and an abattoir. Another characteristic is that direct connections with other sectors make it possible to largely close energy, CO2, mineral and water cycles. The Agrocentre accommodates all categories of pigs, ranging from sows and piglets to meat pigs. A scale of about 80,000 to 100,000 pigs is necessary to make the abattoir economically viable. The on-site abattoir prevents the stressful transportation of live animals. The meat is processed elsewhere. The power station runs on the manure from the farm's own pigs and supplies all energy required for the pig farm, while any residual heat and electricity is supplied to nearby greenhouse growers or fish farms. The pig feed is mainly sourced from surrounding arable farms which, in turn, procure the manure product from the agro-power station [Dutch] In hoeverre biedt de voortgaande schaalvergroting in de varkenshouderij kansen voor een duurzaamheidssprong? Met deze vraagstelling hebben enkele varkenshouders met ondersteuning vanuit InnovatieNetwerk een ontwerp gemaakt voor een duurzaam varkenscluster, dat ze 'Agrocentrum' hebben genoemd. Uit verschillende studies is gebleken dat het Agrocentrum kan uitgroeien tot een welzijns- en milieuvriendelijke vorm van varkenshouderij die goed in het landschap past en die ook economisch kansen biedt. Een Agrocentrum is een specifieke vorm van een Agropark waar varkenshouderij is

CONVERSION OF ORGANIC MANURE INTO BIOGAS

Directory of Open Access Journals (Sweden)

Dario Brdarić

2009-12-01

Full Text Available Production of biogas with anaerobic degradation from organic waste is one of the pledge alternative energetic solutions, especially from organic manure made from animal farming and other residuals of agricultural production. According to 2005 livestock manufacture data daily quantity of animal excrements in Croatia, based on LSU number, is 784 015.26 m3. The aim of this paper is to determine the possibility of production of biogas from the most common types of domestic animals in Croatia. Anaerobic fermentation period of 40 days in mesophilic conditions produced from 1 kg of beef, 31 litres of biogas slurry and from pig slurry 14.83 litres of biogas. From our study it follows that the Republic of Croatia (based on the number of UG could produce 426,995,250.00 Nm3 biogas annually. Exploitation of biogas can decrease import of the referred energents, especially electric energy.

Optimising Anaerobic Digestion of Manure Resources at a Regional Level

Directory of Open Access Journals (Sweden)

Kari-Anne Lyng

2018-01-01

Full Text Available An optimisation model was developed to give decision support on methods of managing manure resources within a region to reduce greenhouse gases and at the same time obtain economic profitability for the farmer. The model was tested by performing a case study on 50 farms in one region in Norway. Based on input data on the number of cattle and pigs on each farm, and the transport distance between each farm and the nearest centralised biogas plant, the model calculates the economic profit of the farmer and the greenhouse gas emissions for three manure management alternatives: (1 no biogas production; (2 farm scale biogas production; and (3 centralised biogas production. The model could minimise the greenhouse gas emissions, maximise the profit for the farmers or a combination of the two. Results from the case study showed that both options for anaerobic digestion (farm scale and centralised biogas production are beneficial in terms of the reduction of greenhouse gases and can be profitable for the farmers. The case study has validated the functionality and usefulness of the model. Some improvements are suggested for further development and use.

Development of pig welfare assessment protocol integrating animal-, environment-, and management-based measures.

Science.gov (United States)

Renggaman, Anriansyah; Choi, Hong L; Sudiarto, Sartika Ia; Alasaarela, Laura; Nam, Ok S

2015-01-01

Due to increased interest in animal welfare, there is now a need for a comprehensive assessment protocol to be used in intensive pig farming systems. There are two current welfare assessment protocols for pigs: Welfare Quality® Assessment Protocols (applicable in the Europe Union), that mostly focuses on animal-based measures, and the Swine Welfare Assurance Program (applicable in the United States), that mostly focuses on management- and environment-based measures. In certain cases, however, animal-based measures might not be adequate for properly assessing pig welfare status. Similarly, welfare assessment that relies only on environment- and management-based measures might not represent the actual welfare status of pigs. Therefore, the objective of this paper was to develop a new welfare protocol by integrating animal-, environment-, and management-based measures. The background for selection of certain welfare criteria and modification of the scoring systems from existing welfare assessment protocols are described. The developed pig welfare assessment protocol consists of 17 criteria that are related to four main principles of welfare (good feeding, good housing, good health, and appropriate behavior). Good feeding, good housing, and good health were assessed using a 3-point scale: 0 (good welfare), 1 (moderate welfare), and 2 (poor welfare). In certain cases, only a 2-point scale was used: 0 (certain condition is present) or 2 (certain condition is absent). Appropriate behavior was assessed by scan sampling of positive and negative social behaviors based on qualitative behavior assessment and human-animal relationship tests. Modification of the body condition score into a 3-point scale revealed pigs with a moderate body condition (score 1). Moreover, additional criteria such as feed quality confirmed that farms had moderate (score 1) or poor feed quality (score 2), especially those farms located in a high relative humidity region. The developed protocol can be

Integrated resource-driven pig production systems in a mountainous area of Northeast India: production practices and pig performance.

Science.gov (United States)

Kumaresan, A; Bujarbaruah, K M; Pathak, K A; Das, Anubrata; Bardoloi, R K

2009-10-01

Data on pig production system was derived through structured household interviews from a total number of 320 rural households and performance of pigs was assessed. Results revealed that the pig production system represented mixed farming based mainly on the common property resources. Majority of the pigs were reared in intensive system and fed with home made cooked feed (kitchen waste and locally available plants). The body weight of crossbred, Burmese and local pigs were 67, 65.4 and 45.6 kg, respectively at 12 months of age with average daily body weight of 184, 179 and 125 g, respectively. The overall mortality among the pigs was 17.96%. The major causes of mortality in pigs were Swine fever, Swine erysipelas, digestive disorders, nephritis and respiratory disorders. The body weight gain in pigs subjected to deworming and mineral mixture supplementation (218 g/day) was significantly (p pigs, while the corresponding ratio for local pigs was 1:1.2. It is inferred that the smallholder resource driven pig production system is economically viable and sustainable at household level and there is enough scope to improve the smallholder resource driven pig production system.

Assessing anaerobic co-digestion of pig manure with agroindustrial wastes: the link between environmental impacts and operational parameters.

Science.gov (United States)

Rodriguez-Verde, Ivan; Regueiro, Leticia; Carballa, Marta; Hospido, Almudena; Lema, Juan M

2014-11-01

Anaerobic co-digestion (AcoD) is established as a techno-economic profitable process by incrementing biogas yield (increased cost-efficiency) and improving the nutrient balance (better quality digestate) in comparison to mono-digestion of livestock wastes. However, few data are available on the environmental consequences of AcoD and most of them are mainly related to the use of energy crops as co-substrates. This work analysed the environmental impact of the AcoD of pig manure (PM) with several agroindustrial wastes (molasses, fish, biodiesel and vinasses residues) using life cycle assessment (LCA) methodology. For comparative purposes, mono digestion of PM has also been evaluated. Four out of six selected categories (acidification, eutrophication, global warming and photochemical oxidation potentials) showed environmental impacts in all the scenarios assessed, whereas the other two (abiotic depletion and ozone layer depletion potentials) showed environmental credits, remarking the benefit of replacing fossil fuels by biogas. This was also confirmed by the sensitivity analysis applied to the PM quality (i.e. organic matter content) and the avoided energy source demonstrating the importance of the energy recovery step. The influence of the type of co-substrate could not be discerned; however, a link between the environmental performance and the hydraulic retention time, the organic loading rate and the nutrient content in the digestate could be established. Therefore, LCA results were successfully correlated to process variables involved in AcoD, going a step further in the combination of techno-economic and environmental feasibilities. Copyright © 2014 Elsevier B.V. All rights reserved.

Commercial Manure Applicators

Data.gov (United States)

Iowa State University GIS Support and Research Facility — This layer represents the office location for Commercial Manure Services (CMS). They transport, handle, store or apply manure for a fee. The company must be licensed...

Antibiotic losses from unprotected manure stockpiles.

Science.gov (United States)

Dolliver, Holly A S; Gupta, Satish C

2008-01-01

Manure management is a major concern in livestock production systems. Although historically the primary concerns have been nutrients and pathogens, manure is also a source of emerging contaminants, such as antibiotics, to the environment. There is a growing concern that antibiotics in manure are reaching surface and ground waters and contributing to the development and spread of antibiotic resistance in the environment. One such pathway is through leaching and runoff from manure stockpiles. In this study, we quantified chlortetracycline, monensin, and tylosin losses in runoff from beef manure stockpiles during two separate but consecutive experiments representing different weather conditions (i.e., temperature and precipitation amount and form). Concentrations of chlortetracycline, monensin, and tylosin in runoff were positively correlated with initial concentrations of antibiotics in manure. The highest concentrations of chlortetracycline, monensin, and tylosin in runoff were 210, 3175, and 2544 microg L(-1), respectively. Relative antibiotic losses were primarily a function of water losses. In the experiment that had higher runoff water losses, antibiotic losses ranged from 1.2 to 1.8% of total extractable antibiotics in manure. In the experiment with lower runoff water losses, antibiotic losses varied from 0.2 to 0.6% of the total extractable antibiotics in manure. Manure analysis over time suggests that in situ degradation is an important mechanism for antibiotic losses. Degradation losses during manure stockpiling may exceed cumulative losses from runoff events. Storing manure in protected (i.e., covered) facilities could reduce the risk of aquatic contamination associated with manure stockpiling and other outdoor manure management practices.

Project proposal: integrated farming scheme incorporating management of water hyacinth - Water hyacinth as a pig feed

International Nuclear Information System (INIS)

Singh, D.N.

1981-01-01

One of the objectives of pig research undertaken by the Research Section of the Ministry of Agriculture and Fisheries (Fiji), is to evaluate local feed sources in an attempt to reduce importation of pig feeds. Protein is the major limiting nutrient in most local feed sources. Fish and meat meals are incorporated in pig feeds by many farmers but the cost of these are very high. Chemical analysis of water hyacinth taken from Rewa River showed that leaves contain 22% crude protein and stems 8%. This was determined on a dry weight basis. Therefore, water hyacinth could be a good source of protein for pigs. Utilization of water hyacinth was considered in the First Review; meeting on Management of Water Hyacinth conducted by Commonwealth Regional (Asia/Pacific) Rural Technology Programme. Water hyacinth as an animal feed was discussed in that review. It points out that the following has to be taken into account in considering the use of water hyacinth as an animal feed. The objective of the study is to investigate the use of water hyacinth as a feed for pigs in an integrated farming system involving a piggery, biogas digester and a pond and: compare pig preference for water hyacinth when fed fresh or dry compare the performance of pigs when fed water hyacinth only and in combination with a normal diet and cost/benefit analysis

Autoclave treatment of pig manure does not reduce the risk of transmission and transfer of tetracycline resistance genes in soil: successive determinations with soil column experiments.

Science.gov (United States)

Kang, Yijun; Gu, Xian; Hao, Yangyang; Hu, Jian

2016-03-01

The increasing use of antibiotics, especially tetracycline, in livestock feed adversely affects animal health and ecological integrity. Therefore, approaches to decrease this risk are urgently needed. High temperatures facilitate antibiotic degradation; whether this reduces transmission risk and transfer of tetracycline-resistant bacteria (TRBs) and tetracycline resistance genes (TRGs) in soil remains unknown. Successive experiments with soil columns evaluated the effects of autoclaving pig manure (APM) on soil TRB populations and TRGs over time at different soil depths. The data showed sharp increases in TRB populations and TRGs in each subsoil layer of PM (non-APM) and APM treatments within 30 days, indicating that TRBs and TRGs transferred rapidly. The level of TRBs in the upper soil layers was approximately 15-fold higher than in subsoils. TRBs were not dependent on PM and APM levels, especially in the late phase. Nevertheless, higher levels of APM led to rapid expansion of TRBs as compared to PM. Moreover, temporal changes in TRB frequencies in total culturable bacteria (TCBs) were similar to TRBs, indicating that the impact of PM or APM on TRBs was more obvious than for TCBs. TRBs were hypothesized to depend on the numbers of TRGs and indigenous recipient bacteria. In the plough layer, five TRGs (tetB, tetG, tetM, tetW, and tetB/P) existed in each treatment within 150 days. Selective pressure of TC may not be a necessary condition for the transfer and persistence of TRGs in soil. High temperatures might reduce TRBs in PM, which had minimal impact on the transmission and transfer of TRGs in soil. Identifying alternatives to decrease TRG transmission remains a major challenge.

Sulfonamide-resistant bacteria and their resistance genes in soils fertilized with manures from Jiangsu Province, Southeastern China.

Directory of Open Access Journals (Sweden)

Na Wang

Full Text Available Antibiotic-resistant bacteria and genes are recognized as new environmental pollutants that warrant special concern. There were few reports on veterinary antibiotic-resistant bacteria and genes in China. This work systematically analyzed the prevalence and distribution of sulfonamide resistance genes in soils from the environments around poultry and livestock farms in Jiangsu Province, Southeastern China. The results showed that the animal manure application made the spread and abundance of antibiotic resistance genes (ARGs increasingly in the soil. The frequency of sulfonamide resistance genes was sul1 > sul2 > sul3 in pig-manured soil DNA and sul2 > sul1 > sul3 in chicken-manured soil DNA. Further analysis suggested that the frequency distribution of the sul genes in the genomic DNA and plasmids of the SR isolates from manured soil was sul2 > sul1 > sul3 overall (p<0.05. The combination of sul1 and sul2 was the most frequent, and the co-existence of sul1 and sul3 was not found either in the genomic DNA or plasmids. The sample type, animal type and sampling time can influence the prevalence and distribution pattern of sulfonamide resistance genes. The present study also indicated that Bacillus, Pseudomonas and Shigella were the most prevalent sul-positive genera in the soil, suggesting a potential human health risk. The above results could be important in the evaluation of antibiotic-resistant bacteria and genes from manure as sources of agricultural soil pollution; the results also demonstrate the necessity and urgency of the regulation and supervision of veterinary antibiotics in China.

Composting poultry manure by fly larvae (Musca domestica) eliminates Campylobacter jejuni from the manure

DEFF Research Database (Denmark)

Nordentoft, Steen; Hald, Birthe

2013-01-01

study To monitor fly larvae composting of poultry manure artificially contaminated with C. jejuni, and to investigate a possible transmission route of C. jejuni from the manure through the fly larvae to the adult fly. Conclusions The addition of fly larvae both accelerated the degradation of manure...

Effects of manure storage additivies on manure composition and greenhouse gas and ammonia emissions

Science.gov (United States)

Abstract: Storage of dairy manure slurry allows for flexibility in the timing of land application of manure to reduce environmental impacts related to water quality. Yet, manure storage can increase greenhouse gas (GHG) and ammonia emissions and cause operational issues due to the buildup of slurry ...

Anaerobic digestion of manure and mixture of manure with lipids: biogas reactor performance and microbial community analysis

DEFF Research Database (Denmark)

Mladenovska, Zuzana; Dabrowski, Slawomir; Ahring, Birgitte Kiær

2003-01-01

Anaerobic digestion of cattle manure and a mixture of cattle manure with glycerol trioleate (GTO) was studied in lab-scale, continuously stirred tank reactors (CSTR) operated at 37degreesC. The reactor. codigesting manure and lipids exhibited a significantly higher specific methane yield and a hi......Anaerobic digestion of cattle manure and a mixture of cattle manure with glycerol trioleate (GTO) was studied in lab-scale, continuously stirred tank reactors (CSTR) operated at 37degreesC. The reactor. codigesting manure and lipids exhibited a significantly higher specific methane yield...

Assessment of the Contribution of Poultry and Pig Production to Greenhouse Gas Emissions in South Korea Over the Last 10 Years (2005 through 2014)

Science.gov (United States)

Boontiam, Waewaree; Shin, Yongjin; Choi, Hong Lim; Kumari, Priyanka

2016-01-01

The goal of this study was to estimate the emissions of greenhouse gases (GHG), namely methane (CH4), nitrous oxide (N2O), and carbon dioxide (CO2) from poultry and pig production in South Korea over the last 10 years (2005 through 2014). The calculations of GHG emissions were based on Intergovernmental Panel on Climate Change (IPCC) guidelines. Over the study period, the CH4 emission from manure management decreased in layer chickens, nursery to finishing pigs and gestating to lactating sows, but there was a gradual increase in CH4 emission from broiler chickens and male breeding pigs. Both sows and nursery to finishing pigs were associated with greater emissions from enteric fermentation than the boars, especially in 2009. Layer chickens produced lower direct and indirect N2O emissions from 2009 to 2014, whereas the average direct and indirect N2O emissions from manure management for broiler chickens were 12.48 and 4.93 Gg CO2-eq/yr, respectively. Annual direct and indirect N2O emissions for broiler chickens tended to decrease in 2014. Average CO2 emission from direct on-farm energy uses for broiler and layer chickens were 46.62 and 136.56 Gg CO2-eq/yr, respectively. For pig sectors, the N2O emission from direct and indirect sources gradually increased, but they decreased for breeding pigs. Carbon dioxide emission from direct on-farm energy uses reached a maximum of 53.93 Gg CO2-eq/yr in 2009, but this total gradually declined in 2010 and 2011. For boars, the greatest CO2 emission occurred in 2012 and was 9.44 Gg CO2-eq/yr. Indirect N2O emission was the largest component of GHG emissions in broilers. In layer chickens, the largest contributing factor to GHG emissions was CO2 from direct on-farm energy uses. For pig production, the largest component of GHG emissions was CH4 from manure management, followed by CO2 emission from direct on-farm energy use and CH4 enteric fermentation emission, which accounted for 8.47, 2.85, and 2.82 Gg-CO2/yr, respectively. The

Assessment of the Contribution of Poultry and Pig Production to Greenhouse Gas Emissions in South Korea Over the Last 10 Years (2005 through 2014

Directory of Open Access Journals (Sweden)

Waewaree Boontiam

2016-12-01

Full Text Available The goal of this study was to estimate the emissions of greenhouse gases (GHG, namely methane (CH4, nitrous oxide (N2O, and carbon dioxide (CO2 from poultry and pig production in South Korea over the last 10 years (2005 through 2014. The calculations of GHG emissions were based on Intergovernmental Panel on Climate Change (IPCC guidelines. Over the study period, the CH4 emission from manure management decreased in layer chickens, nursery to finishing pigs and gestating to lactating sows, but there was a gradual increase in CH4 emission from broiler chickens and male breeding pigs. Both sows and nursery to finishing pigs were associated with greater emissions from enteric fermentation than the boars, especially in 2009. Layer chickens produced lower direct and indirect N2O emissions from 2009 to 2014, whereas the average direct and indirect N2O emissions from manure management for broiler chickens were 12.48 and 4.93 Gg CO2-eq/yr, respectively. Annual direct and indirect N2O emissions for broiler chickens tended to decrease in 2014. Average CO2 emission from direct on-farm energy uses for broiler and layer chickens were 46.62 and 136.56 Gg CO2-eq/yr, respectively. For pig sectors, the N2O emission from direct and indirect sources gradually increased, but they decreased for breeding pigs. Carbon dioxide emission from direct on-farm energy uses reached a maximum of 53.93 Gg CO2-eq/yr in 2009, but this total gradually declined in 2010 and 2011. For boars, the greatest CO2 emission occurred in 2012 and was 9.44 Gg CO2-eq/yr. Indirect N2O emission was the largest component of GHG emissions in broilers. In layer chickens, the largest contributing factor to GHG emissions was CO2 from direct on-farm energy uses. For pig production, the largest component of GHG emissions was CH4 from manure management, followed by CO2 emission from direct on-farm energy use and CH4 enteric fermentation emission, which accounted for 8.47, 2.85, and 2.82 Gg-CO2/yr

An Electronic Worker Service System of the Pig House Based on ATmega16

Science.gov (United States)

Li, Liu-An; Jin, Tian-Ming; Yu, Ya-Ping; Zhang, Guo-Qiang; Hong, Tao

Pork is very important for people in daily life. Quality of livestock environment is closely related to the growth of animals. To improve environmental quality, the paper designed an electronic worker service system of the pig house based on ATmega16, which consisted of 6 detection modules, wireless data collecting, GSM, time circuit, display, anti-th alarm and music player, etc. A small LAN was constructed by wireless transceiver module to test and collect data of temperature, humidity and harmful gas concentration in the pig house. If one detection point exists that harmful pollutant gases concentration exceeds the standard value, GSM module took a message for livestock farmers, so that farmers can promptly arrive at the pig house to ventilate or deal with manure in the pig house, which can effectively prevent from bad things. Time of pyroelectric detector deployment can be freely set, and intrusion information was timely sent to the users. The anti-th alarm function was achieved by the auxiliary light. The music playing module is open by timer module in order to soothing pigs' life state. All are suitable for small farms and can save human resources.

Leaching of Copper and Zinc in a Garden Soil Receiving Poultry and Livestock Manures from Intensive Farming

Institute of Scientific and Technical Information of China (English)

无

2008-01-01

The leaching characteristics of a garden soil may be greatly affected by application of poultry and livestock manures from intensive farming.Packed soil columns of a garden soil(CK)and the soils after respectively receiving 2% pig manure (PM),chicken manure(CM),and commercial organic manure(OM)were leached with 0.05 mol L-1 Ca(NO3)2 and 0.01 mol L-1 EDTA solutions.The leachate EC(electric conductivity)values gradually increased at the beginning and then reached a stable value when the soil columns were leached with 0.05 mol L-1 Ca(NO3)2 solution.The leachate EC values showed a peak-shape when leached with 0.01 mol L-1 EDTA solution.In all the soil columns,the pH values of the leachates decreased with increase of displacement volumes when the Ca(NO3)2 solution was used.The total amounts of Cu and Zn eluted from the four soil columns were significantly correlated with the extracted soil Cu and Zn concentrations by 1.0 mol L-1 NH4NO3,but were not correlated with the leachate dissolved organic carbon(DOC)contents.The Zn concentration in the leachate of the PM-treated soil column with 0.05 mol L-1 Ca(NO3)2 solution was above the Quality Standard III for Ground Water of China(GB/T 14848-93,Zn ＜ 1.0 mg L-1).When compared with 0.05 mol L-1 Ca(NO3)2,the EDTA solution significantly accelerated Cu and Zn elutions in the manure-treated columns.This suggested that applying poultry and livestock manures from intensive farming to farmland might pose a threat to the groundwater quality.

Environmental chemistry of animal manure

Science.gov (United States)

Animal manure is traditionally regarded as a valuable resource of plant nutrients. However, there is an increasing environmental concern associated with animal manure utilization due to high and locally concentrated volumes of manure produced in modern intensified animal production. Although conside...

Economies of scale in the production of swine manure Economias de escala na produção de dejetos de suínos

Directory of Open Access Journals (Sweden)

W.C. Losinger

2000-06-01

Full Text Available Manure production on grower/finisher swine operations in the United States was examined using data from 184 grower/finisher swine operations that participated in the United States National Animal Health Monitoring System's 1995 National Swine Study. Two methods were used: one, assuming that pigs produced 8.4% of their body weight in manure each day; another using the difference between feed fed and weight gained as a proxy variable to study manure production. Using this latter approach, a production function was developed. The function exhibited diminishing returns to scale when food waste was not fed to pigs, but constant returns to scale when food waste was included in their diets. The difference between feed fed and weight gained was lower on operations that restricted entry to employees only.A produção de dejetos em granjas de crescimento e terminação de suínos nos Estados Unidos foi avaliada utilizando dados de 184 granjas participantes de um estudo nacional de 1995 do "United States National Animal Health Monitoring System". Dois métodos foram usados: um considerando que suínos produzem 8,4% do seu peso corporal de dejetos por dia e o outro usando a diferença entre o alimento ingerido e o ganho de peso como um indicador para o estudo da produção de esterco. Através desse último procedimento, desenvolveu-se uma função de produção.

Survey of current Swiss pig feeding practices and potential for ammonia emission reduction

OpenAIRE

Spring, P.; Bracher, A.

2017-01-01

Controlling potentially harmful and polluting emissions from farms is important in the developed world, where legislation exists in many countries limiting emissions such as ammonia and controlling how manure is disposed of from intensive farming operations. In Switzerland, there are legal agreements concerning controls of ammonia emissions, most especially from farms. Ammonia production from pig farms can be controlled by dietary intervention, such as reducing protein levels, which in turn r...

Cattle Manure Enhances Methanogens Diversity and Methane Emissions Compared to Swine Manure under Rice Paddy

NARCIS (Netherlands)

Kim, Sang Yoon; Pramanik, Prabhat; Bodelier, Paul L. E.; Kim, Pil Joo

2014-01-01

Livestock manures are broadly used in agriculture to improve soil quality. However, manure application can increase the availability of organic carbon, thereby facilitating methane (CH4) production. Cattle and swine manures are expected to have different CH4 emission characteristics in rice paddy

Adsorption and catalytic hydrolysis of carbaryl and atrazine on pig manure-derived biochars: Impact of structural properties of biochars

International Nuclear Information System (INIS)

Zhang, Peng; Sun, Hongwen; Yu, Li; Sun, Tieheng

2013-01-01

Highlights: ► High ash content biochar can increase solution pH and released metal ions. ► Ash in biochar can combine pesticide through specific interactions. ► Composition and structure of biochar is favor for the hydrolysis of pesticides. -- Abstract: Biochars were produced from pig manure to elucidate the influence of biochars with high ash contents on the fate of pesticides. Adsorption and catalytic hydrolysis of carbaryl and atrazine on original biochars and deashed biochars were investigated. The two pesticides were substantially adsorbed by the biochars, with organic carbon normalized sorption coefficient (K oc ) values of 10 2.65 –10 3.66 L/kg for carbaryl and 10 1.90 –10 3.57 L/kg for atrazine at C e of 0.5 mg/L. Hydrophobic effect alone could not explain the sorption, and several other processes including pore-filling and π–π electron donor–acceptor interactions were involved in pesticide adsorption. Adsorption increased greatly on the deashed biochar, indicating that some organic sorption sites in the original biochars were blocked or difficult to access due to their interactions with inorganic moiety. The pesticides were found to hydrolyze faster in the presence of biochars, and in the presence of biochar pyrolyzed at 700 °C, carbaryl and atrazine were decomposed by 71.8% and 27.9% in 12 h, respectively. The elevated solution pH was the main reason for the enhanced hydrolysis; however both the mineral surface and dissolved metal ions released from the biochars were confirmed to catalyze the hydrolysis

Adsorption and catalytic hydrolysis of carbaryl and atrazine on pig manure-derived biochars: Impact of structural properties of biochars

Energy Technology Data Exchange (ETDEWEB)

Zhang, Peng, E-mail: phevos1983@yahoo.com.cn [MOE Key Laboratory of Pollution Processes and Environmental Criteria, College of Environmental Science and Engineering, Nankai University, Tianjin 300071 (China); Sun, Hongwen, E-mail: sunhongwen@nankai.edu.cn [MOE Key Laboratory of Pollution Processes and Environmental Criteria, College of Environmental Science and Engineering, Nankai University, Tianjin 300071 (China); Yu, Li [MOE Key Laboratory of Pollution Processes and Environmental Criteria, College of Environmental Science and Engineering, Nankai University, Tianjin 300071 (China); Sun, Tieheng [Institute of Applied Ecology, Chinese Academy of Sciences, Shenyang 110016 (China)

2013-01-15

Highlights: ► High ash content biochar can increase solution pH and released metal ions. ► Ash in biochar can combine pesticide through specific interactions. ► Composition and structure of biochar is favor for the hydrolysis of pesticides. -- Abstract: Biochars were produced from pig manure to elucidate the influence of biochars with high ash contents on the fate of pesticides. Adsorption and catalytic hydrolysis of carbaryl and atrazine on original biochars and deashed biochars were investigated. The two pesticides were substantially adsorbed by the biochars, with organic carbon normalized sorption coefficient (K{sub oc}) values of 10{sup 2.65}–10{sup 3.66} L/kg for carbaryl and 10{sup 1.90}–10{sup 3.57} L/kg for atrazine at C{sub e} of 0.5 mg/L. Hydrophobic effect alone could not explain the sorption, and several other processes including pore-filling and π–π electron donor–acceptor interactions were involved in pesticide adsorption. Adsorption increased greatly on the deashed biochar, indicating that some organic sorption sites in the original biochars were blocked or difficult to access due to their interactions with inorganic moiety. The pesticides were found to hydrolyze faster in the presence of biochars, and in the presence of biochar pyrolyzed at 700 °C, carbaryl and atrazine were decomposed by 71.8% and 27.9% in 12 h, respectively. The elevated solution pH was the main reason for the enhanced hydrolysis; however both the mineral surface and dissolved metal ions released from the biochars were confirmed to catalyze the hydrolysis.

Performance evaluation of a completely stirred anaerobic reactor treating pig manure at a low range of mesophilic conditions

International Nuclear Information System (INIS)

Guo, Jianbin; Dong, Renjie; Clemens, Joachim; Wang, Wei

2013-01-01

Highlights: • The biogas process can run stably at 20 °C at extremely low OLR after long-term acclimation of bacteria. • A biogas plant running at 28 °C seems as efficient as that operated at 38 °C at low OLR of 1.3 g ODM L −1 d −1 . • Lower temperature operation is inadvisable for the commercial biogas plant running at rather high OLR. • The estimated sludge yield at 28 °C is higher than that at 38 °C. - Abstract: Many Chinese biogas plants run in the lower range of mesophilic conditions. This study evaluated the performance of a completely stirred anaerobic reactor treating pig manure at different temperatures (20, 28 and 38 °C). The start-up phase of the reactor at 20 °C was very long and extremely poor performance was observed with increasing organic loading rate (OLR). At an OLR of 4.3 g ODM L −1 d −1 , methane production at 28 °C was comparable (3% less) with that at 38 °C, but the risk of acidification was high at 28 °C. At low OLR (1.3 g ODM L −1 d −1 ), the biogas process appeared stable at 28 °C and gave same methane yields as compared to the reactor operating at 38 °C. The estimated sludge yield at 28 °C was 0.065 g VSS g −1 COD removed, which was higher than that at 38 °C (0.016 g VSS g −1 COD removed )

Mineralização do carbono da palha de aveia e dejetos de suínos aplicados na superfície ou incorporados ao solo Carbon mineralization of straw and pig manure with and without incorporation in soil

Directory of Open Access Journals (Sweden)

Sandro José Giacomini

2008-12-01

Full Text Available A mineralização do C de dejetos de suínos e de palhas de cereais é um processo ainda relativamente pouco estudado no Brasil. O objetivo deste trabalho foi avaliar a mineralização do C da palha de aveia, dos dejetos líquidos de suínos e da cama sobreposta de suínos, aplicados na superfície ou incorporados em um Argissolo Vermelho distrófico arênico, em condições de laboratório. Utilizou-se o delineamento inteiramente casualizado, com quatro repetições dos seguintes tratamentos: solo; solo + palha incorporada; solo + palha em superfície; solo + cama sobreposta incorporada; solo + cama sobreposta em superfície; solo + dejetos líquidos incorporados; solo + dejetos líquidos em superfície; solo + palha + dejetos líquidos incorporados; e solo + palha + dejetos líquidos em superfície. Durante 80 dias de incubação, a emissão de CO2 foi medida continuamente. Ao final desse período, observou-se que foram mineralizados 59 % do C dos dejetos líquidos e apenas 23 % do C da cama sobreposta. A incorporação dos materiais orgânicos ao solo não resultou em maior mineralização do C, quando comparado à permanência desses na superfície do solo. O N amoniacal, aplicado com os dejetos líquidos de suínos, não aumentou a mineralização do C da palha de aveia.The C mineralization of pig manure and cereal straw is still relatively little studied in Brazil. The aim of this work was to evaluate C mineralization of oat straw, pig slurry and pig deep-litter, applied on the surface or incorporated in a Hapludalf soil, in laboratory conditions. The experiment was a completely randomized design with four replications of the following treatments: soil; soil + incorporated straw; soil + surface straw; soil + incorporated pig deep-litter; soil + surface pig deep-litter; soil + incorporated pig slurry; soil + surface pig slurry; soil + incorporated straw + pig slurry; and soil + surface straw + pig slurry. During the 80 days of incubation

Germline transgenic pigs by Sleeping Beauty transposition in porcine zygotes and targeted integration in the pig genome.

Directory of Open Access Journals (Sweden)

Wiebke Garrels

Full Text Available Genetic engineering can expand the utility of pigs for modeling human diseases, and for developing advanced therapeutic approaches. However, the inefficient production of transgenic pigs represents a technological bottleneck. Here, we assessed the hyperactive Sleeping Beauty (SB100X transposon system for enzyme-catalyzed transgene integration into the embryonic porcine genome. The components of the transposon vector system were microinjected as circular plasmids into the cytoplasm of porcine zygotes, resulting in high frequencies of transgenic fetuses and piglets. The transgenic animals showed normal development and persistent reporter gene expression for >12 months. Molecular hallmarks of transposition were confirmed by analysis of 25 genomic insertion sites. We demonstrate germ-line transmission, segregation of individual transposons, and continued, copy number-dependent transgene expression in F1-offspring. In addition, we demonstrate target-selected gene insertion into transposon-tagged genomic loci by Cre-loxP-based cassette exchange in somatic cells followed by nuclear transfer. Transposase-catalyzed transgenesis in a large mammalian species expands the arsenal of transgenic technologies for use in domestic animals and will facilitate the development of large animal models for human diseases.

Integrated biological treatment of fowl manure for nitrogen recovery and reuse.

Science.gov (United States)

Posmanik, Roy; Nejidat, Ali; Bar-Sinay, Boaz; Gross, Amit

2013-03-15

Biowaste such as animal manure poses an environmental threat, due to among others, uncontrolled emissions of ammonia and additional hazardous gases to the atmosphere. This study presents a quantitative analysis of an alternative biowaste management approach aimed at nitrogen recovery and reduction of contamination risks. The suggested technology combines anaerobic digestion of nitrogen-rich biowaste with biofiltration of the resulting gaseous ammonia. A compost-based biofilter is used to capture the ammonia and convert it to nitrate by nitrifying microorganisms. Nitrogen mass balance was applied to quantify the system's capacity under various fowl manure-loading regimes and ammonia loading rates. The produced nitrate was recovered and its use as liquid fertilizer was evaluated with cucumber plant as a model crop. In addition, emissions of other hazardous gases (N(2)O, CH(4) and H(2)S) were monitored before and after biofiltration to evaluate the efficiency of the system for treating these gases. It was found that nitrate-rich liquid fertilizer can be continuously produced using the suggested approach, with an over 67 percentage of nitrogen recovery, under an ammonia loading rate of up to 40 g NH(3) per cubic meter biofilter per hour. Complete elimination of NH(3), H(2)S, CH(4) and N(2)O was achieved, demonstrating the potential of the suggested technology for mitigating emission of these gases from fowl manure. Moreover, the quality of the recovered fertilizer was demonstrated by higher yield performance of cucumber plant compared with control plants treated with a commonly applied organic liquid fertilizer. Copyright © 2013 Elsevier Ltd. All rights reserved.

The Optimization of Cyclic Links of Live Pig-Industry Chain Based on Circular Economics

Directory of Open Access Journals (Sweden)

Xing Liu

2015-12-01

Full Text Available To reduce waste and wastewater pollution and to improve the utilization rate of resources in the pig-industry chain, a circular economy of the chain can be developed. The key to constructing the circular economic system of the pig-industry chain is to determine the path of the cyclic materials and to design reasonable waste- and wastewater-treatment capacities. This paper focuses on the treatment and recycling of wastewater in the pig-industry chain and the treatment and recycling of waste into manure and feed. After giving the two circular paths, the paper proposes a multi-objective uncertainty-optimization model for the cyclic links of the pig-industry chain with the highest resource-reuse efficiency and the lowest construction cost based on the uncertainty of market demand. Using a combination of the neural network and genetic algorithm method for designing the solution process for the model, the paper finally introduces the determination methods of relevant parameters and verifies the feasibility and effectiveness of the model through a case study.

Capture and treatment of goat manure

Directory of Open Access Journals (Sweden)

João Elzeário Castelo Branco Iapichini

2012-12-01

this new manure system we observed great decrease in the occurrence of typical confined kids diseases, like diarrhea, pneumonia and omphalophlebitis, and lower overall mortality rate until slaughter when compared with goats reared in pens with dirt and litter. The investment for installation of the system was assessed $ 722.50 (U.S. $ 48.16/m². Considering the potential use of the stall, placing 10 adult animals (1.5 m²/head, with average production of the adult animal of 600 kg of manure/year, can be obtained easily, 6000 kg of manure, with average price of $ 0.13/kg., which could revert to $ 780.00/production cycle, this feature would pay the investment in about two years. In order to improve the investment cost it can be used in the construction of treated pine wooden pallets, in view of durability, ease of working wood and the lowest price. In order to facilitate a return on investment, can be treated pine used in the construction of wooden pallets, in view of its durability, workability and lower price, which can replace other more expensive types of wood, with the same efficiency and advantage of being lighter, which facilitates the management and operational cleaning of pallets. Furthermore, the capture system can be strong allies on the aggregation of producers of small ruminants, increasing the production of humus, energy source for anaerobic digesters, manure crops and organic manure use in integrated agriculture systems, pastures and forest. The validated system made possible the manpower needed to maintain the stall tested, improving the management and performance of goats, other income generating activities for productive and sustainable.

Farm-scale testing of soybean peroxidase and calcium peroxide for surficial swine manure treatment and mitigation of odorous VOCs, ammonia and hydrogen sulfide emissions

Science.gov (United States)

Maurer, Devin L.; Koziel, Jacek A.; Bruning, Kelsey; Parker, David B.

2017-10-01

The swine industry, regulatory agencies, and the public are interested in farm-tested methods for controlling gaseous emissions from swine barns. In earlier lab- and pilot-scale studies, a renewable catalyst consisting of soybean peroxidase (SBP) mixed with calcium peroxide (CaO2) was found to be effective in mitigating gaseous emissions from swine manure. Thus, a farm-scale experiment was conducted at the university's 178-pig, shallow-pit, mechanically-ventilated swine barn to evaluate SBP/CaO2 as a surficial manure pit additive under field conditions. The SBP was applied once at the beginning of the 42-day experiment at an application rate of 2.28 kg m-2 with 4.2% CaO2 added by weight. Gas samples were collected from the primary barn exhaust fans. As compared to the control, significant reductions in gaseous emissions were observed for ammonia (NH3, 21.7%), hydrogen sulfide (H2S, 79.7%), n-butyric acid (37.2%), valeric acid (47.7%), isovaleric acid (39.3%), indole (31.2%), and skatole (43.5%). Emissions of dimethyl disulfide/methanethiol (DMDS/MT) increased by 30.6%. Emissions of p-cresol were reduced by 14.4% but were not statistically significant. There were no significant changes to the greenhouse gas (GHG) emissions of methane (CH4), carbon dioxide (CO2) and nitrous oxide (N2O). The total (material + labor) treatment cost was 2.62 per marketed pig, equivalent to 1.5% of the pig market price. The cost of CaO2 catalyst was ∼60% of materials cost. The cost of soybean hulls (SBP source) was 0.60 per marketed pig, i.e., only 40% of materials cost.

Psychrophilic anaerobic co-digestion of highland barley straw with two animal manures at high altitude for enhancing biogas production

International Nuclear Information System (INIS)

Wei, Suzhen; Zhang, Hongfeng; Cai, Xiaobu; Xu, Jin; Fang, Jiangping; Liu, Heman

2014-01-01

Highlights: • High I/S ratio (>2/1) was favorable to both sole digestion and co-digestion. • Biogas production from BS was feasible at low temperature and low air pressure condition. • Long SRT (>80 days) is needed for biogas production at low temperature and low air pressure condition. • BS to manure ratio of 1/1 could increase biogas production. • IVS removal efficiency was correlated with biogas production. - Abstract: Biogas production from the co-digestion of highland barley straw (BS) with Tibet pig manure (TPM) and cow manure (CM) was investigated at Tibet plateau under low temperature (15 °C) condition. The effect of inoculum to substrate (I/S) ratio and BS to manure ratio on the biogas production was studied using a series of batch digesters performed at substrate concentration of 20%, based on total solid (TS). The results showed that biogas production from BS was feasible at low temperature and low air pressure condition. High I/S ratio (>2/1) and BS to manure ratio of 1/1 could increase the biogas production. Long solid retention time (SRT) (>80 days) was needed for biogas production at low temperature and low air pressure condition. The highest cumulative biogas production obtained from the co-digestion of BS with TPM and CM was 233.4 ml/gVS and 192.0 ml/gVS, respectively. Removal efficiencies of substrate showed that biogas production was correlated with the removal efficiency of water-insoluble volatile solids (IVS) but not with the change rate of soluble chemical oxygen demand (SCOD)

Validation and Recommendation of Methods to Measure Biogas Production Potential of Animal Manure

Directory of Open Access Journals (Sweden)

C. H. Pham

2013-06-01

Full Text Available In developing countries, biogas energy production is seen as a technology that can provide clean energy in poor regions and reduce pollution caused by animal manure. Laboratories in these countries have little access to advanced gas measuring equipment, which may limit research aimed at improving local adapted biogas production. They may also be unable to produce valid estimates of an international standard that can be used for articles published in international peer-reviewed science journals. This study tested and validated methods for measuring total biogas and methane (CH4 production using batch fermentation and for characterizing the biomass. The biochemical methane potential (BMP (CH4 NL kg−1 VS of pig manure, cow manure and cellulose determined with the Moller and VDI methods was not significantly different in this test (p>0.05. The biodegradability using a ratio of BMP and theoretical BMP (TBMP was slightly higher using the Hansen method, but differences were not significant. Degradation rate assessed by methane formation rate showed wide variation within the batch method tested. The first-order kinetics constant k for the cumulative methane production curve was highest when two animal manures were fermented using the VDI 4630 method, indicating that this method was able to reach steady conditions in a shorter time, reducing fermentation duration. In precision tests, the repeatability of the relative standard deviation (RSDr for all batch methods was very low (4.8 to 8.1%, while the reproducibility of the relative standard deviation (RSDR varied widely, from 7.3 to 19.8%. In determination of biomethane concentration, the values obtained using the liquid replacement method (LRM were comparable to those obtained using gas chromatography (GC. This indicates that the LRM method could be used to determine biomethane concentration in biogas in laboratories with limited access to GC.

Substitution of pig feed preparation using firewood with biogas in Samosir Island: transforming an environmental catastrophe into environmental, social, economic benefits

Science.gov (United States)

Ginting, N.

2018-02-01

In Samosir Island, Indonesia pigs care was not environmentally friendly as people were used firewood in pig feed preparation. A series of research has been conducted from March until September 2017 which was preceded by survey. It was found that people cut tree for firewood. As Samosir Island was under Toba Go Green Project which was a tree planting project so feed pig preparation was in contrast to the project. More over, Indonesia has been committed to reduce its green house gases (GHG) by 26% in 2020, any mitigation on GHG was strongly recommended. One way of mitigation in Samosir was by installing biogas for pig feed preparation. 5 biodigesters 500 liters capacity each were installed in Parbaba Village, Samosir Island and biodigester input were pig manure, water hyacinth. Research design was Randomized Completely Design. Parameters were gas production, pH, temperature and C/N ratio. Biogas than used to cook feed pig. It was known that to cook for 5 finisher pigs, 3 kg firewood could be substituted by 250 liters of biogas.

Harmless Treatment on Scale Pig Farm Fecaluria%规模化猪场粪尿的无害化处理

Institute of Scientific and Technical Information of China (English)

淡江华; 冯燕平; 段栋梁; 王树华; 穆秀梅; 程晓亮; 师亮

2017-01-01

The amount of pig breeding in China ranked first in the world.The pig industry is the pillar industry of animal husbandry in China,it is one of the main industries indispensable agricultural economic development in China.But in recent years,with global warming,environmental problems caused by the pig industry is paid more and more attention,and the pig related environmental protection law,world countries frequently publish,pig people face a hitherto unknown difficulties,if don't deal with the sewage problem,many pigs can not meet the environmental standards are forced to close.Facing the new situation,it is necessary to strengthen the research and application of pig farm waste harmless treatment technology,so as to realize the sustainable development of pig industry in our country.This paper mainly summarized from the pig industry in our country environmental protection situation,pig manure pollution,large-scale pig manure cleaning process and harmless treatment methods,and puts forward the corresponding suggestions.%养猪业是我国畜牧业的支柱产业,在我国农业经济发展中占据重要板块.随着社会的发展和进步,环境问题已经成为人们关注的热点,而猪场废弃物是环境污染的重要来源.随着一系列环保法律法规的陆续颁布,生猪产业面临较大的环保压力,很多达不到环保标准的猪场被迫关闭.面对新的形势,必须加强猪场废弃物无害化处理技术的研究和推广应用,才能实现我国生猪产业的可持续发展.主要从我国养猪业环保问题现状、猪粪尿对环境的污染、规模化猪场粪尿清理工艺和无害化处理方式等方面进行综述,并提出相应的建议.

Leaching of viruses and other microorganisms naturally occurring in pig slurry to tile drains on a well-structured loamy field in Denmark

DEFF Research Database (Denmark)

Krog, Jesper Schak; Forslund, Anita; Larsen, Lars Erik

2017-01-01

The amount of animal manure used in modern agriculture is increasing due to the increase in global animal production. Pig slurry is known to contain zoonotic bacteria such as E. coli, Salmonella spp. and Campylobacter spp., and viruses such as hepatitis E virus and group A rotavirus. Coliform...

Potential substitution of mineral P fertilizer by manure: EPIC development and implementation

Science.gov (United States)

Azevedo, Ligia B.; Vadas, Peter A.; Balkovič, Juraj; Skalský, Rastislav; Folberth, Christian; van der Velde, Marijn; Obersteiner, Michael

2016-04-01

Sources of mineral phosphorus (P) fertilizers are non-renewable. Although the longevity of P mines and the risk of future P depletion are highly debated P scarcity may be detrimental to agriculture in various ways. Some of these impacts include increasing food insecurity and nitrogen (N) and P imbalances, serious fluctuations in the global fertilizer and crop market prices, and contribution in geopolitical conflicts. P-rich waste produced from livestock production activities (i.e. manure) are an alternative to mineral P fertilizer. The substitution of mineral fertilizer with manure (1) delays the depletion of phosphate rock stocks, (2) reduces the vulnerability of P fertilizer importing countries to sudden changes in the fertilizer market, (3) reduces the chances of geopolitical conflicts arising from P exploitation pressures, (4) avoids the need for environmental protection policies in livestock systems, (5) is an opportunity for the boosting of crop yields in low nutrient input agricultural systems, and (6) contributes to the inflow of not only P but also other essential nutrients to agricultural soils. The Environmental Policy Integrated Climate model (EPIC) is a widely used process-based, crop model integrating various environmental flows relevant to crop production as well as environmental quality assessments. We simulate crop yields using a powerful computer cluster infra-structure (known as EPIC-IIASA) in combination with spatially-explicit EPIC input data on climate, management, soils, and landscape. EPIC-IIASA contains over 131,000 simulation units and it has 5 arc-min resolution. In this work, we implement two process-based models of manure biogeochemistry into EPIC-IIASA, i.e. SurPhos (for P) and Manure DNDC (for N and carbon) and a fate model model describing nutrient outflows from fertilizer via runoff. For EGU, we will use EPIC-IIASA to quantify the potential of mineral P fertilizer substitution with manure. Specifically, we will estimate the relative

Economic benefits comparison of two pig breeding cycle modes -- Taking Liaoning Province as an example

Science.gov (United States)

Xue, Yunan; Wang, Hui; Ma, Yu

2018-01-01

Pig breeding pollution has become one of the important sources of environmental pollution, and the circular economy has provided an effective way to alleviate the pollution of pig breeding. In this paper, the “Three-in-one” and “Four-in-one” mode of circular economy with methane as link were constructed, and taking Liaoning Province as the research area, the economic benefits of different pig breeding modes were compared and analyzed. The results show that: (1) The modes of circular economy use the pig manure waste as raw materials through the digesters, solar greenhouse to generate new resources, compared with the traditional farming methods, created considerable economic benefits and also alleviated the pressure of pollution, is an effective way to control the pollution of pig breeding. (2) The economic benefit of the “Four-in-one” mode in Liaoning was much higher than the “Three-in-one” mode. The economic benefits of biogas digesters were higher than the “Three-in-one” mode of 125 million yuan, while the solar greenhouse would introduce the planting industry into the recycling chain, with a net profit of about 38.64*108 yuan.

Heat stress and reduced plane of nutrition decreases intestinal integrity and function in pigs.

Science.gov (United States)

Pearce, S C; Mani, V; Weber, T E; Rhoads, R P; Patience, J F; Baumgard, L H; Gabler, N K

2013-11-01

Heat stress can compromise intestinal integrity and induce leaky gut in a variety of species. Therefore, the objectives of this study were to determine if heat stress (HS) directly or indirectly (via reduced feed intake) increases intestinal permeability in growing pigs. We hypothesized that an increased heat-load causes physiological alterations to the intestinal epithelium, resulting in compromised barrier integrity and altered intestinal function that contributes to the overall severity of HS-related illness. Crossbred gilts (n=48, 43±4 kg BW) were housed in constant climate controlled rooms in individual pens and exposed to 1) thermal neutral (TN) conditions (20°C, 35-50% humidity) with ad libitum intake, 2) HS conditions (35°C, 20-35% humidity) with ad libitum feed intake, or 3) pair-fed in TN conditions (PFTN) to eliminate confounding effects of dissimilar feed intake. Pigs were sacrificed at 1, 3, or 7 d of environmental exposure and jejunum samples were mounted into modified Ussing chambers for assessment of transepithelial electrical resistance (TER) and intestinal fluorescein isothiocyanate (FITC)-labeled lipopolysaccharide (LPS) permeability (expressed as apparent permeability coefficient, APP). Further, gene and protein markers of intestinal integrity and stress were assessed. Irrespective of d of HS exposure, plasma endotoxin levels increased 45% (Pwarm summer months.

Combining biochar, zeolite and wood vinegar for composting of pig manure: The effect on greenhouse gas emission and nitrogen conservation.

Science.gov (United States)

Wang, Quan; Awasthi, Mukesh Kumar; Ren, Xiuna; Zhao, Junchao; Li, Ronghua; Wang, Zhen; Wang, Meijing; Chen, Hongyu; Zhang, Zengqiang

2018-04-01

The effect of enhancing wood vinegar (WV) with a mixture of biochar (B) and zeolite (Z) to compost pig manure (PM) in a 130 L reactor was evaluated to determine the levels of greenhouse gas (GHG) and ammonia emissions. Six treatments were prepared in a 2:1 ratio of PM mixed with wheat straw (WS; dry weight basis): PM + WS (control), PM + WS + 10%B, PM + WS + 10%B + 10%Z, and PM + WS with 0.5%, 1.0% and 2.0%WV combined with 10%B + 10%Z. These were composted for 50 days, and the results indicated that the combined use of B, Z, and WV could shorten the thermophilic phase and improve the maturity of compost compared to the control treatment. In addition, WV mixed with B and Z could reduce ammonia loss by 64.45-74.32% and decrease CO 2 , CH 4 , and N 2 O emissions by 33.90-46.98%, 50.39-61.15%, and 79.51-81.10%, respectively. Furthermore, compared to treatments in which B and B + Z were added, adding WV was more efficient to reduce the nitrogen and carbon loss, and the 10%B + 10%Z + 2%WV treatment presented the lowest loss of carbon (9.16%) and nitrogen (0.75%). Based on the maturity indexes used, nitrogen conservation, and efficiency of GHG emissions reduction, the treatment 10%B + 10%Z + 2%WV is suggested for efficient PM composting. Copyright © 2018 Elsevier Ltd. All rights reserved.

Decline in extractable antibiotics in manure-based composts during composting.

Science.gov (United States)

Kim, K-R; Owens, G; Ok, Y S; Park, W-K; Lee, D B; Kwon, S-I

2012-01-01

A wide variety of antibiotics have been detected in natural water samples and this is of potential concern because of the adverse environmental effects of such antibiotic residues. One of the main sources of antibiotics effluence to the surrounding environment is livestock manures which often contain elevated concentrations of veterinary antibiotics (VAs) which survive digestion in the animal stomach following application in animal husbandry practices. In Korea, livestock manures are normally used for compost production indicating that there is potential for antibiotic release to the environment through compost application to agricultural lands. Therefore, reduction of the amount of VAs in composts is crucial. The purpose of this study was to understand the influence of the composting process and the components of the compost on the levels of three common classes of antibiotics (tetracyclines, sulfonamides, and macrolides). Composted materials at different stages of composting were collected from compost manufacturing plants and the variation in antibiotic concentrations was determined. Three different antibiotics, chlortetracycline (CTC), sulfamethazine (SMZ), and tylosin (TYL) at three different concentrations (2, 10, and 20mgkg(-1)) were also applied to a mixture of pig manure and sawdust and the mixtures incubated using a laboratory scale composting apparatus to monitor the changes in antibiotic concentrations during composting together with the physicochemical properties of the composts. During composting, in both field and lab-scale investigations, the concentrations of all three different antibiotics declined below the relevant Korean guideline values (0.8mgkg(-1) for tetracyclines, 0.2mgkg(-1) for sulfonamides and 1.0mgkg(-1) for macrolides). The decline of tetracycline and sulfonamide concentrations was highly dependent on the presence of sawdust while there was no influence of sawdust on TYL decline. Copyright © 2011 Elsevier Ltd. All rights reserved.

Effect of temperature on continuous dry fermentation of swine manure.

Science.gov (United States)

Deng, Liangwei; Chen, Chuang; Zheng, Dan; Yang, Hongnan; Liu, Yi; Chen, Ziai

2016-07-15

Laboratory-scale experiments were performed on the dry digestion of solid swine manure in a semi-continuous mode using 4.5 L down plug-flow anaerobic reactors with an organic loading rate of 3.46 kg volatile solids (VS) m(-3) d(-1) to evaluate the effects of temperature (15, 25 and 35 °C). At 15 °C, biogas production was the poorest due to organic overload and acidification, with a methane yield of 0.036 L CH4 g(-1) VS added and a volumetric methane production rate of 0.125 L CH4 L(-1) d(-1). The methane yield and volumetric methane production rate at 25 °C (0.226 L CH4 g(-1) VS added and 0.783 L CH4 L(-1) d(-1), respectively) were 6.24 times higher than those at 15 °C. However, the methane yield (0.237 L CH4 g(-1) VS added) and the volumetric methane production rate (0.821 L CH4 L(-1) d(-1)) at 35 °C were only 4.86% higher than those at 25 °C, which indicated similar results were obtained at 25 °C and 35 °C. The lower biogas production at 35 °C in dry digestion compared with that in wet digestion could be attributed to ammonia inhibition. For a single pig farm, digestion of solid manure is accomplished in small-scale domestic or small-farm bioreactors, for which operating temperatures of 35 °C are sometimes difficult to achieve. Considering biogas production, ammonia inhibition and net energy recovery, an optimum temperature for dry digestion of solid swine manure is 25 °C. Copyright © 2016 Elsevier Ltd. All rights reserved.

Substitute fluid examinations for liquid manure

Directory of Open Access Journals (Sweden)

Schrader Kevin

2017-01-01

Full Text Available For the farming industry it is essential to use liquid manure as natural fertilizer. Through new agricultural regulation 2015 in Germany the industry must develop new liquid manure spreader systems because the ammonia and methane emission are limited. In a research project the University of Applied Sciences Zwickau and some other industry partners will develop such a new innovative liquid manure spreader. The new liquid manure spreader should use pulsating air to distribute the liquid manure exactly. The pulsating air, which flows through the pipelines, should be analysed at a test station. For examinations at this test station it is important to find another substitute fluid because liquid manure smells strong, is not transparent and is also not homogeneous enough for scientific investigations. Furthermore it is important to ensure that the substitute fluid is, like liquid manure, a non-Newtonian fluid. The substitute fluid must be a shear-thinning substance - this means the viscosity decrease at higher shear rate. Many different samples like soap-water-farragoes, jelly-water-farragoes, agar-water-farragoes, soap-ethanol-farragoes and more are, for the project, examined in regard of their physical properties to find the best substitute fluid. The samples are examined at the rotational viscometer for viscosity at various shear rates and then compared with the viscosity values of liquid manure.

Substitute fluid examinations for liquid manure

Science.gov (United States)

Schrader, Kevin; Riedel, Marco; Eichert, Helmut

For the farming industry it is essential to use liquid manure as natural fertilizer. Through new agricultural regulation 2015 in Germany the industry must develop new liquid manure spreader systems because the ammonia and methane emission are limited. In a research project the University of Applied Sciences Zwickau and some other industry partners will develop such a new innovative liquid manure spreader. The new liquid manure spreader should use pulsating air to distribute the liquid manure exactly. The pulsating air, which flows through the pipelines, should be analysed at a test station. For examinations at this test station it is important to find another substitute fluid because liquid manure smells strong, is not transparent and is also not homogeneous enough for scientific investigations. Furthermore it is important to ensure that the substitute fluid is, like liquid manure, a non-Newtonian fluid. The substitute fluid must be a shear-thinning substance - this means the viscosity decrease at higher shear rate. Many different samples like soap-water-farragoes, jelly-water-farragoes, agar-water-farragoes, soap-ethanol-farragoes and more are, for the project, examined in regard of their physical properties to find the best substitute fluid. The samples are examined at the rotational viscometer for viscosity at various shear rates and then compared with the viscosity values of liquid manure.

Retinal progenitor cell xenografts to the pig retina

DEFF Research Database (Denmark)

Warfvinge, Karin; Kiilgaard, Jens Folke; Lavik, Erin B

2005-01-01

To investigate the survival, integration, and differentiation of mouse retinal progenitor cells after transplantation to the subretinal space of adult pigs.......To investigate the survival, integration, and differentiation of mouse retinal progenitor cells after transplantation to the subretinal space of adult pigs....

Economics of poultry manure utilization in land quality improvement ...

African Journals Online (AJOL)

The rapid growth of Nigerian's poultry has made it more advantageous in terms of providing the essential raw material for soil fertility enhancement than other livestock. This paper evaluates the benefits of poultry manure use among integrated poultry-maize farmers in Ekiti and Osun States of Nigeria for improved land ...

Cattle manure fertilization increases fig yield

OpenAIRE

Leonel,Sarita; Tecchio,Marco Antonio

2009-01-01

Fertilization using organic compounds is complementary to chemical fertilization, being essential to integrated fruit production. Reports on fig tree (Ficus carica L.) organic fertilization and mineral nutrition are worldwide scarce, especially in Brazil. This experiment aimed to evaluate the effects of cattle manure fertilization on the yield and productivity of the fig tree 'Roxo de Valinhos' in Botucatu, São Paulo State, Brazil, during the 2002/03, 2003/04, 2004/05 and 2005/06 crop cycles....

Turnover of manure _¹⁵N-labelled ammonium during composting and soil application as affected by lime and superphosphate addition

DEFF Research Database (Denmark)

Tran, Tien Minh; Luxhøi, Jesper; Jensen, Lars Stoumann

2012-01-01

). The NH4-N pool in the pig manure was initially labeled with 15N to determine the fate of manure NH4-N during composting. The composts were subsequently applied to soil to investigate the effects on soil mineral N and to trace the 15N during 60 d of incubation at 25°C. Of the initial manure 15NH4-N......, approximately 30, 90, and 20% was lost by NH3 volatilization during composting in the Straw, Lime, and SSP treatments, respectively. Concurrently, 62, 16, and 41% of initial 15NH4-N was immobilized in the respective treatments. When the composts were applied to soil, the mineral N in soil with SSP compost...... or effectively in balance. In soil with Lime compost, net N immobilization was strong in the fi rst 10 d, but then net N mineralization dominated the remaining period of soil incubation. Overall, adding lime before composting reduced the NH4-N content in the compost and the amount available in soil, while adding...

Pig manure vermicompost (PMVC) can improve phytoremediation of Cd and PAHs co-contaminated soil by Sedum alfredii

Energy Technology Data Exchange (ETDEWEB)

Wang, Kai; Zhang, Jie; Huang, Huagang; Li, Tingqiang; Yang, Xiaoe [Zhejiang Univ., Hangzhou (China). MOE Key Laboratory of Environment Remediation and Ecosystem Health; Zhu, Zhiqiang [Zhejiang Univ., Hangzhou (China). MOE Key Laboratory of Environment Remediation and Ecosystem Health; Hainan Univ., Haikou (China). College of Agriculture; He, Zehnli [Florida Univ., Fort Pierce (United States). Indian River Research and Education Center; Alva, Ashok [U.S. Department of Agriculture, Prosser, WA (United States). Agricultural Research Service

2012-08-15

Purpose: A major challenge to phytoremediation of co-contaminated soils is developing strategies for efficient and simultaneous removal of multiple pollutants. A pot experiment was conducted to investigate the potential for enhanced phytoextraction of cadmium (Cd) by Sedum alfredii and dissipation of polycyclic aromatic hydrocarbons (PAHs) in co-contaminated soil by application of pig manure vermicompost (PMVC). Materials and methods: Soil contaminated by Cd (5.53 mg kg{sup -1} DW) was spiked with phenanthrene, anthracene, and pyrene together (250 mg kg{sup -1} DW for each PAH). A pot experiment was conducted in a greenhouse with four treatments: (1) soil without plants and PMVC (Control), (2) soil planted with S. alfredii (Plant), (3) soil amended with PMVC at 5 % (w/w) (PMVC), and (4) treatment 2 + 3 (Plant + PMVC). After 90 days, shoot and root biomass of plants, Cd concentrations in plant and soil, and PAH concentrations in soil were determined. Abundance of PAH degraders in soil, soil bacterial community structure and diversity, and soil enzyme activities and microbial biomass carbon were measured. Results and discussion: Application of PMVC to co-contaminated soil increased the shoot and root dry biomass of S. alfredii by 2.27- and 3.93-fold, respectively, and simultaneously increased Cd phytoextraction without inhibiting soil microbial population and enzyme activities. The highest dissipation rate of PAHs was observed in Plant + PMVC treatment. However, neither S. alfredii nor PMVC enhanced PAH dissipation when applied separately. Abundance of PAH degraders in soil was not significantly related to PAH dissipation rate. Plant + PMVC treatment significantly influenced the bacterial community structure. Enhanced PAH dissipation in the Plant + PMVC treatment could be due to the improvement of plant root growth, which may result in increased root exudates, and subsequently change bacterial community structure to be favorable for PAH dissipation. Conclusions: This

Catalytic reforming of nitrogen-containing volatiles evolved through pyrolysis of composted pig manure.

Science.gov (United States)

Meesuk, Sirimirin; Sato, Kazuyoshi; Cao, Jing-Pei; Hoshino, Akihiro; Utsumi, Kazuhiko; Takarada, Takayuki

2013-12-01

The pyrolysis of pig compost was performed in a two-stage fixed-bed reactor to determine the effects of decomposition temperatures and catalysts (i.e., transition-metal and non-transition-metal catalysts) on carbon and nitrogen conversions. The secondary decomposition was investigated at different temperatures from room temperature up to 750°C. Then the effects of various catalysts were investigated at 650°C. Approximately 60% of the carbon and 80% of the nitrogen in the pig compost were converted into volatiles during pyrolysis. Conversion of carbon and nitrogen species in tar into gas, and the evolution undesirable NH3 and HCN without catalyst increased with increasing decomposition temperature. Transition-metal catalysts showed excellent activity for conversion of condensable volatiles into gas and NH3 and HCN into N2. Although non-transition-metal catalysts had moderate activity for the conversion of volatiles into gas and negligible activity for the conversion of NH3 into N2, dolomite can provide liquid fuel with negligible amount of nitrogen species. Copyright © 2013 Elsevier Ltd. All rights reserved.

Biogas Production from Vietnamese Animal Manure, Plant Residues and Organic Waste: Influence of Biomass Composition on Methane Yield

Directory of Open Access Journals (Sweden)

T. T. T. Cu

2015-02-01

Full Text Available Anaerobic digestion is an efficient and renewable energy technology that can produce biogas from a variety of biomasses such as animal manure, food waste and plant residues. In developing countries this technology is widely used for the production of biogas using local biomasses, but there is little information about the value of these biomasses for energy production. This study was therefore carried out with the objective of estimating the biogas production potential of typical Vietnamese biomasses such as animal manure, slaughterhouse waste and plant residues, and developing a model that relates methane (CH4 production to the chemical characteristics of the biomass. The biochemical methane potential (BMP and biomass characteristics were measured. Results showed that piglet manure produced the highest CH4 yield of 443 normal litter (NL CH4 kg−1 volatile solids (VS compared to 222 from cows, 177 from sows, 172 from rabbits, 169 from goats and 153 from buffaloes. Methane production from duckweed (Spirodela polyrrhiza was higher than from lawn grass and water spinach at 340, 220, and 110.6 NL CH4 kg−1 VS, respectively. The BMP experiment also demonstrated that the CH4 production was inhibited with chicken manure, slaughterhouse waste, cassava residue and shoe-making waste. Statistical analysis showed that lipid and lignin are the most significant predictors of BMP. The model was developed from knowledge that the BMP was related to biomass content of lipid, lignin and protein from manure and plant residues as a percentage of VS with coefficient of determination (R-square at 0.95. This model was applied to calculate the CH4 yield for a household with 17 fattening pigs in the highlands and lowlands of northern Vietnam.

Biogas production from vietnamese animal manure, plant residues and organic waste: influence of biomass composition on methane yield.

Science.gov (United States)

Cu, T T T; Nguyen, T X; Triolo, J M; Pedersen, L; Le, V D; Le, P D; Sommer, S G

2015-02-01

Anaerobic digestion is an efficient and renewable energy technology that can produce biogas from a variety of biomasses such as animal manure, food waste and plant residues. In developing countries this technology is widely used for the production of biogas using local biomasses, but there is little information about the value of these biomasses for energy production. This study was therefore carried out with the objective of estimating the biogas production potential of typical Vietnamese biomasses such as animal manure, slaughterhouse waste and plant residues, and developing a model that relates methane (CH4) production to the chemical characteristics of the biomass. The biochemical methane potential (BMP) and biomass characteristics were measured. Results showed that piglet manure produced the highest CH4 yield of 443 normal litter (NL) CH4 kg(-1) volatile solids (VS) compared to 222 from cows, 177 from sows, 172 from rabbits, 169 from goats and 153 from buffaloes. Methane production from duckweed (Spirodela polyrrhiza) was higher than from lawn grass and water spinach at 340, 220, and 110.6 NL CH4 kg(-1) VS, respectively. The BMP experiment also demonstrated that the CH4 production was inhibited with chicken manure, slaughterhouse waste, cassava residue and shoe-making waste. Statistical analysis showed that lipid and lignin are the most significant predictors of BMP. The model was developed from knowledge that the BMP was related to biomass content of lipid, lignin and protein from manure and plant residues as a percentage of VS with coefficient of determination (R-square) at 0.95. This model was applied to calculate the CH4 yield for a household with 17 fattening pigs in the highlands and lowlands of northern Vietnam.

Centralized manure digestion. Selection of locations and estimation of costs of large-scale manure storage application

International Nuclear Information System (INIS)

1995-03-01

A study to assess the possibilities and the consequences of the use of existing Dutch large scale manure silos at centralised anaerobic digestion plants (CAD-plants) for manure and energy-rich organic wastes is carried out. Reconstruction of these large scale manure silos into digesters for a CAD-plant is not self-evident due to the high height/diameter ratio of these silos and the extra investments that have to be made for additional facilities for roofing, insulation, mixing and heating. From the results of an inventory and selection of large scale manure silos with a storage capacity above 1,500 m 3 it appeared that there are 21 locations in The Netherlands that can be qualified for realisation of a CAD plant with a processing capacity of 100 m 3 biomass (80% manure, 20% additives) per day. These locations are found in particular at the 'shortage-areas' for manure fertilisation in the Dutch provinces Groningen and Drenthe. Three of these 21 locations with large scale silos are considered to be the most suitable for realisation of a large scale CAD-plant. The selection is based on an optimal scale for a CAD-plant of 300 m 3 material (80% manure, 20% additives) to be processed per day and the most suitable consuming markets for the biogas produced at the CAD-plant. The three locations are at Middelharnis, Veendam, and Klazinaveen. Applying the conditions as used in this study and accounting for all costs for transport of manure, additives and end-product including the costs for the storage facilities, a break-even operation might be realised at a minimum income for the additives of approximately 50 Dutch guilders per m 3 (including TAV). This income price is considerably lower than the prevailing costs for tipping or processing of organic wastes in The Netherlands. This study revealed that a break-even exploitation of a large scale CAD-plant for the processing of manure with energy-rich additives is possible. (Abstract Truncated)

Continuous anaerobic digestion of swine manure: ADM1-based modelling and effect of addition of swine manure fibers pretreated with aqueous ammonia soaking

OpenAIRE

Jurado, E.; Antonopoulou, G.; Lyberatos, G.; Gavala, Hariklia N.; Skiadas, Ioannis V.

2016-01-01

Anaerobic digestion of manure fibers presents challenges due to their low biodegradability. Aqueous ammonia soaking (AAS) has been tested as a simple method to disrupt the lignocellulose and increase the methane yield of manure fibers. In the present study, mesophilic anaerobic digestion of AAS pretreated manure fibers was performed in CSTR-type digesters, fed with swine manure and/or a mixtureof swine manure and AAS pretreated manure fibers (at a total solids based ratio of 0.52 manure per0....

Sustainable livestock production: Low emission farm – The innovative combination of nutrient, emission and waste management with special emphasis on Chinese pig production

Directory of Open Access Journals (Sweden)

Thomas Kaufmann

2015-09-01

Full Text Available Global livestock production is going to be more and more sophisticated in order to improve efficiency needed to supply the rising demand for animal protein of a growing, more urban and affluent population. To cope with the rising public importance of sustainability is a big challenge for all animal farmers and more industrialized operations especially. Confined animal farming operations (CAFO are seen very critical by many consumers with regard to their sustainability performance, however, the need to improve the sustainability performance especially in the ecological and social dimension exists at both ends of the intensity, i.e., also for the small holder and family owned animal farming models. As in livestock operations, feed and manure contribute the majority to the three most critical environmental impact categories global warming potential (GWP, acidification (AP and eutrophication potential (EP any effort for improvement should start there. Intelligent combination of nutrient-, emission- and waste management in an integrated low emission farm (LEF concept not only significantly reduces the environmental footprint in the ecological dimension of sustainability, but by producing renewable energy (heat, electricity, biomethane with animal manure as major feedstock in an anaerobic digester also the economic dimension can be improved. Model calculations using new software show the ecological improvement potential of low protein diets using more supplemented amino acids for the Chinese pig production. The ecological impact of producing biogas or upgraded biomethane, of further treatment of the digestate and producing defined fertilizers is discussed. Finally, the LEF concept allows the integration of an insect protein plant module which offers additional ecological and economical sustainability improvement potential in the future. Active stakeholder communication about implementation steps of LEF examples improves also the social aspect of

Continuous anaerobic digestion of swine manure: ADM1-based modelling and effect of addition of swine manure fibers pretreated with aqueous ammonia soaking

DEFF Research Database (Denmark)

Jurado, E.; Antonopoulou, G.; Lyberatos, G.

2016-01-01

pretreated manure fibers was performed in CSTR-type digesters, fed with swine manure and/or a mixtureof swine manure and AAS pretreated manure fibers (at a total solids based ratio of 0.52 manure per0.48 fibers). Two different simulations were performed. In the first place, the Anaerobic Digestion Model 1......Anaerobic digestion of manure fibers presents challenges due to their low biodegradability. Aqueous ammonia soaking (AAS) has been tested as a simple method to disrupt the lignocellulose and increase the methane yield of manure fibers. In the present study, mesophilic anaerobic digestion of AAS...... (ADM1) was fitted to a manure-fed, CSTR-type digester and validated by simulating the performance of a second reactor digesting manure. It was shown that disintegration and hydrolysis of the solid matter of manure was such a slow process that the organic particulate matter did not significantly...

Biogas production from steer manures in Vietnam

DEFF Research Database (Denmark)

Pham, Cuong H.; Saggar, Surinder; Vu, Cuong C.

2017-01-01

manures collected from two different experiments of steers fed diets containing feed supplements. BMP was 110.1 (NLkg-1 VS) for manure from steers receiving a control diet, significantly lower 79.0 (NL kg-1 VS) for manure from steers fed a diet containing 0.3% tannin (%DM), but then showed an increasing...... trend to 90.9 and 91.2 (NL kg-1 VS) for manures from steers receiving 0.4 and 0.5% tannin (%DM) supplements, respectively. Similarly, the CH4 production (NL kg-1 VS) of manure from steers was 174 for control, 142 for control supplemented concentrate (C), 143 for control added rice straw treated...

Manure application and ammonia volatilization

NARCIS (Netherlands)

Huijsmans, J.F.M.

2003-01-01

Keywords: manure application, ammonia volatilization, environmental conditions, application technique, incorporation technique, draught force, work organization, costs Livestock manure applied on farmland is an important source of ammonia (NH3) volatilization, and NH3 is a major atmospheric

Inspiration from Ecocycle Clean Production Mode of Pig Farm to Sustainable Development of Stockbreeding-A Case Study in Guoxing Pig Farm of Dongtai City%猪场生态循环清洁生产模式对畜牧业可持续发展的启示--以东台市国兴猪场为例

Institute of Scientific and Technical Information of China (English)

王长青

2014-01-01

以东台市国兴猪场为例，详细介绍了该猪场采取的“猪-沼-粮-猪”、“猪-沼-渔”和“猪-沼-加-猪”等以沼气为中心环节，突出解决猪粪尿生物物质多层次利用的生态循环清洁生产模式及其效益，在此基础上，提出了畜牧业应从种养结合，提高综合利用效益；延伸产业链，实行生物质多级多重循环；加大政策引导和扶持，促进畜牧业转型升级等方面解决畜禽养殖粪尿污染问题，以实现畜牧业的可持续发展。%Taking Guoxing Pig Farm of Dongtai City as the example, the ecocycle clean production mode used in the pig farm, which taking methane as the central point such as“pig-methane-grain-pig”,“pig-methane-ifshery”and“pig-methane-processing-pig”, and giving emphasis on multi-layer utilization of biological substances in pig manure, had been introduced detailedly, and its benefit was analyzed. Then, it proposed some suggestions in order to solve the problem of manure pollution in stockbreeding and realize the target of sustainable development of stockbreeding, such as enhancing comprehensive utilization benefit of stockbreeding via combining planting and farming; extending industry chain and applying multi-level and multi-layer cycle of biological substances; strengthening policy guidance and supporting to promoting transformation and upgrading of stockbreeding.

Evaluation of the air quality in pig housing facilities equipped with a liquid-solid separation system

International Nuclear Information System (INIS)

Lavoie, J.; Beaudet, Y.; Letourneau, C.; Godbout, S.; Lemay, S.; Belzile, M.; Lachance, I.; Pouliot, F.

2006-01-01

A new regulation regarding agricultural operations in Quebec was passed in June 2002. It stated the new standards for managing phosphorous generated from animal livestock. The regulation is intended to protect the environment, more specifically, water, soil and air quality. This new regulation stipulates that agricultural producers acquire a balanced phosphorous assessment by 2010. In order to achieve this, a system is needed to separate solid and liquid pig manure on a daily basis. Producers must also comply with environmental requirements on odour elimination and atmospheric control. The proposed solid-liquid separation system would improve the indoor and outdoor air quality at pig housing facilities by reducing toxic gas and bioaerosol formation. In addition, it would contribute to stream purification. The solid-liquid separation technique was successfully tested in a pilot project at a mini pig housing facility. It was concluded that type of separation equipment system could readily used for other types of animal farming, such as cattle raising. 41 refs., 13 tabs., 12 figs

Nitrification of leachates from manure composting under field conditions and their use in horticulture.

Science.gov (United States)

Cáceres, Rafaela; Magrí, Albert; Marfà, Oriol

2015-10-01

This work aimed to demonstrate the feasibility of nitrification applied to the treatment of leachates formed during composting of cattle and pig manure in order to promote their further use as liquid fertilizer in horticulture. Nitrification trials were successfully conducted in summer and winter seasons under Mediterranean climate conditions. Subsequently, effect of using the nitrified effluents as nutritive solution in the fertigation of lettuce (Lactuca sativa L.) was assessed in terms of productivity and nutrient uptake. Similar productivities were obtained when using the nitrified effluents and a standard nutritive solution. However, results also evidenced high nutrient uptake, which indicates that dosage should be adjusted to culture requirements. Copyright © 2015 Elsevier Ltd. All rights reserved.

Chemical characterization of manure in relation to manure quality as a contribution to a reduced nitrogen emission to the environment

NARCIS (Netherlands)

Stelt, van der B.

2007-01-01

Keywords:manure composition, ammonia volatilization, free ions, Donnan Membrane Technique, manure additives, dietary changes, nitrogen dynamics,grasslandsoils.More insight in manure composition, ammonia (NH ₃ )

Continuous anaerobic digestion of swine manure: ADM1-based modelling and effect of addition of swine manure fibers pretreated with aqueous ammonia soaking

International Nuclear Information System (INIS)

Jurado, E.; Antonopoulou, G.; Lyberatos, G.; Gavala, H.N.; Skiadas, I.V.

2016-01-01

Highlights: • Aqueous ammonia soaking (AAS) effect on methane yield: verification in continuously fed digesters. • AAS resulted in 98% increase of the methane yield of swine manure fibers in continuously fed digesters. • ADM1 was successfully adapted to simulating anaerobic digestion of swine manure. • Modification of hydrolysis kinetics was necessary for an adequate simulation of the digestion of AAS-treated fibers. - Abstract: Anaerobic digestion of manure fibers presents challenges due to their low biodegradability. Aqueous ammonia soaking (AAS) has been tested as a simple method to disrupt the lignocellulose and increase the methane yield of manure fibers. In the present study, mesophilic anaerobic digestion of AAS pretreated manure fibers was performed in CSTR-type digesters, fed with swine manure and/or a mixture of swine manure and AAS pretreated manure fibers (at a total solids based ratio of 0.52 manure per 0.48 fibers). Two different simulations were performed. In the first place, the Anaerobic Digestion Model 1 (ADM1) was fitted to a manure-fed, CSTR-type digester and validated by simulating the performance of a second reactor digesting manure. It was shown that disintegration and hydrolysis of the solid matter of manure was such a slow process that the organic particulate matter did not significantly contribute to the methane production. In the second place, ADM1 was used to describe biogas production from the codigestion of manure and AAS pretreated manure fibers. The model predictions regarding biogas production and methane content were in good agreement with the experimental data. It was shown that, AAS treatment significantly increased the disintegration and hydrolysis rate of the carbohydrate compounds of the fibers. The effect of the addition of AAS treated fibers on the kinetics of the conversion of other key compounds such as volatile fatty acids was negligible.

Integrating economic parameters into genetic selection for Large White pigs.

Science.gov (United States)

Dube, Bekezela; Mulugeta, Sendros D; Dzama, Kennedy

2013-08-01

The objective of the study was to integrate economic parameters into genetic selection for sow productivity, growth performance and carcass characteristics in South African Large White pigs. Simulation models for sow productivity and terminal production systems were performed based on a hypothetical 100-sow herd, to derive economic values for the economically relevant traits. The traits included in the study were number born alive (NBA), 21-day litter size (D21LS), 21-day litter weight (D21LWT), average daily gain (ADG), feed conversion ratio (FCR), age at slaughter (AGES), dressing percentage (DRESS), lean content (LEAN) and backfat thickness (BFAT). Growth of a pig was described by the Gompertz growth function, while feed intake was derived from the nutrient requirements of pigs at the respective ages. Partial budgeting and partial differentiation of the profit function were used to derive economic values, which were defined as the change in profit per unit genetic change in a given trait. The respective economic values (ZAR) were: 61.26, 38.02, 210.15, 33.34, -21.81, -68.18, 5.78, 4.69 and -1.48. These economic values indicated the direction and emphases of selection, and were sensitive to changes in feed prices and marketing prices for carcasses and maiden gilts. Economic values for NBA, D21LS, DRESS and LEAN decreased with increasing feed prices, suggesting a point where genetic improvement would be a loss, if feed prices continued to increase. The economic values for DRESS and LEAN increased as the marketing prices for carcasses increased, while the economic value for BFAT was not sensitive to changes in all prices. Reductions in economic values can be counterbalanced by simultaneous increases in marketing prices of carcasses and maiden gilts. Economic values facilitate genetic improvement by translating it to proportionate profitability. Breeders should, however, continually recalculate economic values to place the most appropriate emphases on the respective

Winter cereal yields as affected by animal manure and green manure in organic arable farming

DEFF Research Database (Denmark)

Olesen, Jørgen E; Askegaard, Margrethe; Rasmussen, Ilse Ankjær

2009-01-01

The effect of nitrogen (N) supply through animal and green manures on grain yield of winter wheat and winter rye was investigated from 1997 to 2004 in an organic farming crop rotation experiment in Denmark on three different soil types varying from coarse sand to sandy loam. Two experimental....... Adjusting for these model-estimated side-effects resulted in wheat grain yields gains from manure application of 0.7-1.1 Mg DM ha-1. The apparent recovery efficiency of N in grains (N use efficiency, NUE) from NH4-N in applied manure varied from 23% to 44%. The NUE in the winter cereals of N accumulated......-estimated benefit of increasing N input in grass-clover from 100 to 500 kg N ha-1 varied from 0.8 to 2.0 Mg DM ha-1 between locations. This is a considerably smaller yield increase than obtained for manure application, and it suggests that the productivity in this system may be improved by removing the cuttings...

BASIC ENGINEERING FOR GENERATION PROCESS OF BIOGAS FROM PIG MANURE

Directory of Open Access Journals (Sweden)

Julio Cesar Ramírez

2010-05-01

Full Text Available The study of this project examines the effectiveness of three treatments biodigestors by means of calculation and analysis of parameters such as chemical oxygen demand, suspended solids, fixed solids, volatile solids, pH, temperature and biogas production, taking into account that work with organic waste from pig (porquinaza, from where it determines what should be used in a farm in Tocancipá, Cundinamarca. Based on experimentation continues to perform the basic engineering for this type of system, which determined the size of the biodigestor, with the daily production of gas according to the characteristics of both the food and the farm is 4.023 m3, with a heat capacity of 14084.64 Kcal / day, which allows for comparisons of technical and economic, with the current situation of the farm. Finally concluding with the project is viable in both financial factors as energy requirements, and depend solely on the availability of resources of the owners of the property, for investment of $ 1'716 .300.

Applied and environmental chemistry of animal manure: A review

Science.gov (United States)

Animal manure consists of predominantly urine and feces, but also may contain bedding materials, dropped feed, scurf and other farming wastes. The estimated amount of manure produced in 12 major livestock producing countries is 9 x109 Mg of manure annually. Manures are rich in plant nutrients. Howev...

Selection and Location of Poultry and Livestock Manure Storage

OpenAIRE

Ogejo, Jactone Arogo

2009-01-01

Manure storage is part of the manure management system of a facility or property where animals and/or poultry are raised. Manure should be considered a resource not a waste to be discarded. Manure contains valuable organic matter and nutrients that can be used as a fertilizer and/or to produce energy. If not managed properly, manure will accumulate very quickly and pose the potential for polluting the environment from odors and contamination of surface water and ground water.

Antibiotics in dust originating from a pig-fattening farm: a new source of health hazard for farmers?

OpenAIRE

Hamscher, Gerd; Pawelzick, Heike Theresia; Sczesny, Silke; Nau, Heinz; Hartung, Jörg

2003-01-01

Pig-house dust originates from feed, bedding, feces, and the animals themselves. If the animals receive drugs such as antibiotics, residues of these substances may occur in manure, in the air, or on surfaces of the respective animal house. In a retrospective study, we investigated dust samples collected during two decades from the same piggery for the occurrence of various antibiotics. In 90% of these samples, we detected up to five different antibiotics, including tylosin, various tetracycli...

Co-digestion of cattle manure with food waste and sludge to increase biogas production

International Nuclear Information System (INIS)

Marañón, E.; Castrillón, L.; Quiroga, G.; Fernández-Nava, Y.; Gómez, L.; García, M.M.

2012-01-01

Highlights: ► Small increase in methane production was observed applying sonication pretreatment. ► Biogas productions between 720 and 1100 mL/Lreactor day were achieved. ► Volatile solids removal efficiencies ranged between 53% and 60%. ► Lower methane yields were obtained when operating under thermophilic conditions. ► Optimum OLR in lab-scale CSTR was 1.2–1.3 g VS/L day (HRT: 20 days). - Abstract: Anaerobic co-digestion strategies are needed to enhance biogas production, especially when treating certain residues such as cattle/pig manure. This paper presents a study of co-digestion of cattle manure with food waste and sewage sludge. With the aim of maximising biogas yields, a series of experiments were carried out under mesophilic and thermophilic conditions using continuously stirred-tank reactors, operating at different hydraulic residence times. Pretreatment with ultrasound was also applied to compare the results with those obtained with non-pretreated waste. Specific methane production decreases when increasing the OLR and decreasing HRT. The maximum value obtained was 603 LCH 4 /kg VS feed for the co-digestion of a mixture of 70% manure, 20% food waste and 10% sewage sludge (total solid concentration around 4%) at 36 °C, for an OLR of 1.2 g VS/L day. Increasing the OLR to 1.5 g VS/L day led to a decrease of around 20–28% in SMP. Lower methane yields were obtained when operating at 55 °C. The increase in methane production when applying ultrasound to the feed mixtures does not compensate for the energy spent in this pretreatment.

Performance Of Growing Pigs And Finisher Broilers Housed Together

African Journals Online (AJOL)

Growth performance and cost of feeding young growing pigs and finisher broilers under integrated broiler/pig production system were investigated. Four young growing pigs (the control) were housed in pen A and fed 4% of their body weight as commercial growers feed. Another 4 were housed in pen B with broilers in ...

Characterization of leached phosphorus from soil, manure, and manure-amended soil by physical and chemical fractionation and diffusive gradients in thin films (DGT)

DEFF Research Database (Denmark)

Glæsner, Nadia Andersen; Donner, Erica; Magid, Jakob

2012-01-01

We are challenged to date to fully understand mechanisms controlling phosphorus (P) mobilization in soil. In this study we evaluated physical properties, chemical reactivity, and potential bioavailability of P mobilized in soil during a leaching event and examined how the amounts and properties...... with manure. Manure particles themselves were also largely retained by the soil. Combined physical (centrifugation) and chemical (molybdate reactiveness) fractionation of leached P showed that leachates in the manure treated soils were dominated by dissolved unreactive P (DUP), mainly originating from manure...... of leached P were influenced by surface application of cattle manure. Leaching experiments on manure itself, and on intact soil columns (14.1 cm inner dia., 25 cm height) before and after manure application, were carried out at an irrigation rate of 1 mm h−1 for 48 h. High concentrations of dissolved...

Optimization of the anaerobic co-digestion of pasteurized slaughterhouse waste, pig slurry and glycerine

OpenAIRE

Rodríguez-Abalde, Ángela; Flotats Ripoll, Xavier; Fernández García, Belén

2016-01-01

The feasibility of co-digestion of blends of two different animal by-products (pig manure and pasteurized slaughterhouse waste) and recovered glycerine was studied in mesophilic conditions. Experiments were performed in a lab-scale CSTR along 490 days, with a hydraulic retention time of 21–33 days and with a step-wise increased organic loading rate, by adding and/or changing the wastes ratio, from 0.8 to 3.2 kgCOD m-3 d-1. The best methane production rate (0.64 Nm3CH4 m-3 d-1) represented an ...

Recovery of amino acids and phosphorus from manure

Science.gov (United States)

Background & Objectives: The recovery of phosphorus and proteins from manure could be advantageous to both offset costs and to improve and lessen the environmental impacts of manure. Phosphorous in manure can contaminate rivers, lakes, and bays through runoff, if applied onto a cropland excessively....

[Effect of different organic fertilizers on bioavailability of soil Cd and Zn].

Science.gov (United States)

Xie, Yun-he; Ji, Xiong-hui; Wu, Jia-mei; Huang, Juan; Guan, Di; Zhu, Jian

2015-03-01

The active effect of soil Cd and Zn and their interaction was studied in typical paddy field in south China by monitoring the contents of Cd and Zn in soil and rice in rice fields applied with pig manure, chicken manure or rice straw for 4 years continuously. The results showed that applying pig manure, chicken manure or rice straw had no significant impact on the soil total Cd content, soil available Cd content and soil Cd activity, but tended to increase the soil total Cd content and increased the soil total Zn content, soil available Zn content and Zn activity significantly. Applications of pig manure, chicken manure and rice straw all reduced the Cd content of brown rice, in order of pig manure > chicken manure > rice straw. The Cd contents of brown rice, stem and leaf in the treatment applied with pig manure were lower than in the control by 37.5%, 44.0% and 36.4%, respectively; the Cd contents of brown rice, stem and leaf in the treatment applied with chicken manure were lower than in the control by 22.5%, 33.8%, and 22.7%, respectively; the Cd content of brown rice in the treatment applied with rice straw was lower than in the control by 7.5% but its contents in stem and leaf increased by 8.2% and 22.7% , respectively. The reduction in the brown rice Cd content was mainly due to the reduction of Cd enrichment from soil to brown rice after application of pig or chicken manure, but mainly due to the reduction of Cd transportation from stem to brown rice after straw application. Applications of pig manure, chicken manure and rice straw increased Zn contents in rice stem by 53.4%, 53.4% and 13.9%, respectively, but all had no significant effect on brown rice and leaf' s Zn contents. Zn and Cd had the significant antagonistic effects in the soil and rice stem. The increase of Zn content in soil and rice stem inhibited the adsorption and accumulation of Cd in the brown rice, stem and leaf significantly, and with the increase of the proportion of Zn/Cd, the

Influence of basal application of organic wastes on absorption and translocation of 15N-tagged nitrogen fertilizer in tea plants

International Nuclear Information System (INIS)

Watanabe, Ikuo; Ikegaya, Kenjiro; Hiramine, Shigeo

1979-01-01

Influence of the basal application of rape seed oil cake and shavings pig manure compost on the absorption, translocation and utilization of top-dressed 15 N-tagged ammonium sulfate in tea plants were studied. Nitrogen uptake and dry weights of new shoots increased in rape seed oil cake and shavings pig manure compost treatments as compared with ammonium sulfate treatments. The high rate of nitrogen absorption per the weight of rootlets in rape seed oil cake treatments suggested that the enhanced root activity might contribute to the increase. And the increase in shavings pig manure compost treatments could be due to the increase of the quantity of rootlets. The absorbed tagged nitrogen was 34% of total absorbed nitrogen in rape seed oil cake treatments, and 67% in shavings pig manure treatments. The results suggested that available nitrogen contents in soil originated from the basal nitrogen might be low in shavings pig manure compost treatments in comparison with rape seed oil cake treatments. Total nitrogen and nitrogen contents of amino acid fraction of ''a bud and two leaves'' of new shoots were relatively high in shavings pig manure compost treatments. With the growth of new shoots, nitrogen contents of protein fraction decreased in old leaves, branches and trunks in ammonium sulfate and rape seed oil cake treatments. This fact suggested that the storage protein might be present in these organs. (author)

Immobilization of tetracyclines in manure and manure-amended soils using aluminum-based drinking water treatment residuals.

Science.gov (United States)

Punamiya, Pravin; Sarkar, Dibyendu; Rakshit, Sudipta; Elzinga, Evert J; Datta, Rupali

2016-02-01

Veterinary antibiotics (VAs) are emerging contaminants of concern in the environment, mainly due to the potential for development of antibiotic-resistant bacteria and effect on microbiota that could interfere with crucial ecosystem functions such as nutrient cycling and decomposition. High levels of VAs such as tetracyclines (TCs) have been reported in agricultural soils amended with manure, which also has the potential to cause surface and groundwater contamination. Several recent studies have focused on developing methods to immobilize VAs such as composting with straw, hardwood chips, commercial biochar, aeration, mixing, heat treatment, etc. The major shortcomings of these methods include high cost and limited effectiveness. In the current study, we assessed the effectiveness of aluminum-based drinking water treatment residuals (Al-WTR) as a "green" sorbent to immobilize TCs in manure and manure-applied soils with varying physicochemical properties by laboratory incubation study. Results show that Al-WTR is very effective in immobilizing tetracycline (TTC) and oxytetracycline (OTC). The presence of phosphate resulted in significant (p < 0.01) decrease in TTC/OTC sorption by Al-WTR, but the presence of sulfate did not. attenuated total reflection (ATR)-FTIR spectroscopy indicate that TTC and OTC likely forming surface complexes via inner-sphere-type bonds in soils, manure, and manure-applied soils amended with Al-WTR.

Greenhouse gas emissions from liquid dairy manure: Prediction and mitigation

DEFF Research Database (Denmark)

Petersen, Søren O.

2017-01-01

The handling and use of manure on livestock farms contributes to emissions of the greenhouse gases (GHG) CH4 and N2O, especially with liquid manure management. Dairy farms are diverse with respect to manure management, with practices ranging from daily spreading to long-term storage for more......, and use of treatment technologies. Also, effects of treatment and handling on the properties of field-applied manure must be taken into account. Storage conditions and manure composition importantly define carbon and nitrogen transformations, and the resulting emissions of CH4 and N2O, as well as CO2...... application, manure and soil together define the equilibrium distribution of labile carbon and nitrogen between bulk soil and manure hotspots. This introduces heterogeneity with respect to potential for N2O emissions, which is not represented in existing prediction models. Manure treatment and management...

Influence of feeding thermally peroxidized soybean oil on growth performance, digestibility, and gut integrity in finishing pigs.

Science.gov (United States)

Overholt, Martin F; Dilger, Anna C; Boler, Dustin D; Kerr, Brian J

2018-05-26

Consumption of peroxidized lipids has been shown to reduce pig performance and energy and lipid digestibility. Objectives of the current study were to evaluate the effect of feeding soybean oil (SO) with different levels of peroxidation on growth performance, lipid, N, and GE digestibility, plasma Trp, and gut integrity in finishing pigs. Fifty-six barrows (46.7 ± 5.1 kg initial BW) were randomly assigned to one of four diets in each of two dietary phases, containing either 10% fresh SO (22.5 °C) or thermally processed SO (45 °C for 288 h, 90 °C for 72 h, or 180 °C for 6 h), each infused with of 15 L/min of air. Peroxide values were 2.0, 17.4, 123.6, and 19.4 mEq/kg; 2,4-decadienal values were 2.07, 1.90, 912.15, and 915.49 mg/kg; and 4-hydroxynonenal concentrations were 0.66, 1.49, 170.48, and 82.80 mg/kg, for the 22.5, 45, 90, and 180 °C processed SO, respectively. Pigs were individually housed and fed ad libitum for 81 d to measure growth performance, including a metabolism period to collect urine and feces for determination of GE, lipid, N digestibility, and N retention. Following the last day of fecal and urine collection when pigs were in the metabolism crates, lactulose and mannitol were fed and subsequently measured in the urine to evaluate gut permeability, while markers of oxidative stress were evaluated in plasma, urine, and liver. There were no differences observed in ADFI (P = 0.91), but average daily gain (ADG) and gain:feed G:F were decreased in pigs fed 90 °C SO diet (P ≤ 0.07) compared to pigs fed the other SO diets. Pigs fed the 90 and 180 °C SO had the lowest (P = 0.05) DE as a % of GE compared to pigs fed the 22.5 °C SO, with pigs fed the 45 °C SO being intermediate. Lipid digestibility was similarly affected (P = 0.01) as energy digestibility, but ME as a % of DE was not affected by dietary treatment (P = 0.16). There were no effects of lipid peroxidation on N digested, N retained, or the urinary lactulose:mannitol ratio (P ≥ 0

Toxicity Evaluation of Pig Slurry Using Luminescent Bacteria and Zebrafish

Directory of Open Access Journals (Sweden)

Wenyan Chen

2014-07-01

Full Text Available Biogas slurry has become a serious pollution problem and anaerobic digestion is widely applied to pig manure treatment for environmental protection and energy recovery. To evaluate environmental risk of the emission of biogas slurry, luminescent bacteria (Vibrio fischeri, larvae and embryos of zebrafish (Danio rerio were used to detect the acute and development toxicity of digested and post-treated slurry. Then the ability of treatment process was evaluated. The results showed that digested slurry displayed strong toxicity to both zebrafish and luminescent bacteria, while the EC50 for luminescent bacteria and the LC50 for larvae were only 6.81% (v/v and 1.95% (v/v respectively, and embryonic development was inhibited at just 1% (v/v. Slurry still maintained a high level of toxicity although it had been treated by membrane bioreactor (MBR, while the LC50 of larvae was 75.23% (v/v and there was a little effect on the development of embryos and V. fischeri; the results also revealed that the zebrafish larvae are more sensitive than embryos and luminescent bacteria to pig slurry. Finally, we also found the toxicity removal rate was higher than 90% after the treatment of MBR according to toxicity tests. In conclusion, further treatment should be used in pig slurry disposal or reused of final effluent.

Field experiment with liquid manure and enhanced biochar

Science.gov (United States)

Dunst, Gerald

2017-04-01

Field experiments with low amounts of various liquid manure enhanced biochars. In 2016 a new machine was developed to inject liquid biochar based fertilizer directly into the crop root zone. A large-scale field experiment with corn and oil seed pumpkin was set-up on 42 hectares on 15 different fields in the south East of Austria. Three treatments were compared: (1) surface spreading of liquid manure as control (common practice), (2) 20 cm deep root zone injection with same amount of liquid manure, and (3) 20 cm deep root zone injection with same amount of liquid manure mixed with 1 to 2 tons of various nutrient enhanced biochars. The biochar were quenched with the liquid phase from a separated digestate from a biogas plant (feedstock: cow manure). From May to October nitrate and ammonium content was analyzed monthly from 0-30cm and 30-60cm soil horizons. At the end of the growing season the yield was determined. The root zone injection of the liquid manure reduced the nitrate content during the first two months at 13-16% compared to the control. When the liquid manure was blended with biochar, Nitrate soil content was lowest (reduction 40-47%). On average the root zone injection of manure-biochar increased the yield by 7% compared to the surface applied control and 3% compared to the root zone injected manure without biochar. The results shows, that biochar is able to reduce the Nitrate load in soils and increase the yield of corn at the same time. The nutrient efficiency of organic liquid fertilizers can be increased.

Treatment and trade or organic manures in the future

International Nuclear Information System (INIS)

Verkuyten, J.C.A.M.

1997-01-01

The manure market is dominated by both low prices and low quality. This current market does not favour the sustainable use of manures, nor does it favour innovation. First step in improving both manure quality and manure utilisation is optimizing the manure supply chain. A powerful instrument for this optimizing forms ''certification of the links within the chain''. The successful marketing of the derivates requires technological and organisational innovation. A powerful instrument in successful marketing is ''certification''. Through certification of the supply chain, as well as certification of the products, upgrading of the products is possible, leading to economical viable investments in waste treatment. Product certification leads furthermore to the possibility of positioning the products. A positive positioning of the products, differentiating it from ''waste'', is essential for the desired investments by market parties. In this paper new ideas and developments on the Dutch manure market are presented. A new technology (v. Aspert plant), including the marketing concept as the derivates produced are presented. A profile on a manure brokerage organisation (MBO) and, on last year founded, European Manure association (EMA) are added. (au)

Treatment and trade or organic manures in the future

Energy Technology Data Exchange (ETDEWEB)

Verkuyten, J C.A.M. [European Manure Association, EMA, Deventer (Netherlands)

1997-08-01

The manure market is dominated by both low prices and low quality. This current market does not favour the sustainable use of manures, nor does it favour innovation. First step in improving both manure quality and manure utilisation is optimizing the manure supply chain. A powerful instrument for this optimizing forms `certification of the links within the chain`. The successful marketing of the derivates requires technological and organisational innovation. A powerful instrument in successful marketing is `certification`. Through certification of the supply chain, as well as certification of the products, upgrading of the products is possible, leading to economical viable investments in waste treatment. Product certification leads furthermore to the possibility of positioning the products. A positive positioning of the products, differentiating it from `waste`, is essential for the desired investments by market parties. In this paper new ideas and developments on the Dutch manure market are presented. A new technology (v. Aspert plant), including the marketing concept as the derivates produced are presented. A profile on a manure brokerage organisation (MBO) and, on last year founded, European Manure association (EMA) are added. (au)

9 CFR 93.312 - Manure from quarantined horses.

Science.gov (United States)

2010-01-01

... 9 Animals and Animal Products 1 2010-01-01 2010-01-01 false Manure from quarantined horses. 93.312... FOR MEANS OF CONVEYANCE AND SHIPPING CONTAINERS Horses § 93.312 Manure from quarantined horses. No manure shall be removed from the quarantine premises until the release of the horses producing same. ...

A process-based model for cattle manure compost windrows: Model performance and application

Science.gov (United States)

A model was developed and incorporated in the Integrated Farm System Model (IFSM, v.4.3) that simulates important processes occurring during windrow composting of manure. The model, documented in an accompanying paper, predicts changes in windrow properties and conditions and the resulting emissions...

Costs of emission-reducing manure application

NARCIS (Netherlands)

Huijsmans, J.F.M.; Verwijs, B.; Rodhe, L.; Smith, K.

2004-01-01

Favourable economics of handling and application of manure are of fundamental importance to encourage the implementation of emission-reducing application techniques. The economics of manure application depend on the costs of the equipment and the time to carry out the field operation. In this study

Livestock production and manure management on animal farms in Vietnam

DEFF Research Database (Denmark)

Sommer, S.G.; Bui, H.H.; Dalsgaard, Anders

2008-01-01

  The Vietnamese and Asian livestock production is increasing these years. In consequence large amounts of manure are produced, which may be a hazard to the environment because the traditional technology and the management practise of manure is not adapted to specialised livestock production.......  Further, there is little knowledge about the plant nutrient value of animal manure, and about technologies for environmentally-friendly manure management. This lack of knowledge enhances the risk of polluting the environment by inappropriate use of livestock manure and is also a potential risk...... for transferring pathogens between livestock and from livestock to humans (zoonoses). The objective of this article is to describe manure management at livestock farms in Vietnam. The focus is on presenting the most typical farming concepts, manure management on these farms, environmental and hygienic risks...

Agriculture, trade and environment linkages in the pig sector: A comparative study of manure regulations and their significance for the competitiveness of the pig sector

DEFF Research Database (Denmark)

Andersen, Mikael Skou

2002-01-01

In this paper we investigate the possible effects of differences in pollution control on the competitiveness of intensive livestock producers of pork, and hence to what extent environmental regulations might distort free trade in this market. We understand environmental regulations somewhat...... narrowly as the regulations that concern the storage, disposal and application of manure because the nutrient overload is commonly seen as the key environmental issue of the livestock industry. Despite this focus the perspective locks into a multitude of issues related with land use, production equipment...

An Investigation into the Physico-chemical Factors Affecting the Abundance and Diversity of Aquatic Insects in Organically Manured Aquadams and Their Utilization by Oreochromis mossambicus (Perciformes: Cichlidae).

Science.gov (United States)

Rapatsa, M M; Moyo, N A G

2015-08-01

The interaction between the fish Oreochromis mossambicus (Percifomes: Cichlidae) and aquatic insects after application of chicken, cow, and pig manure was studied in 7,000-liter plastic aquadams. Principal component analysis showed that most of the variation in water quality after application of manure was accounted for by potassium, nitrogen, dissolved oxygen, phosphate, and alkalinity. Canonical correspondence analysis showed that Gyrinidae, Elminidae, Hydrophilidae, Hydraenidae, and Athericidae were associated with high nutrient levels (nitrogen, phosphorus, and potassium) characteristic of the chicken manure. However, the most abundant aquatic insects Gerridae, Notonectidae, and Culicidae were close to the centre of the ordination and not defined by any nutrient gradient. The Shannon-Wiener diversity was highest in the aquadams treated with chicken manure. The most frequently occurring aquatic insects in the diet of O. mossambicus were culicid mosquitoes in all the treatments. However, in the laboratory, Chironomidae were the most preferred because they lacked refuge. Notonectidae and Gerridae were not recorded in the diet of O. mossambicus despite their abundance. This may be because of their anti-predation strategies. Laboratory experiments showed that Notonectidae, Gyrinidae, and Gerridae fed on Chironomidae and Culicidae. This implies that aquatic predatory insects competed for food with O. mossambicus. © The Authors 2015. Published by Oxford University Press on behalf of Entomological Society of America. All rights reserved. For Permissions, please email: journals.permissions@oup.com.

Evaluation of organic amendment on the effect of cadmium bioavailability in contaminated soils using the DGT technique and traditional methods.

Science.gov (United States)

Yao, Yu; Sun, Qin; Wang, Chao; Wang, Pei-Fang; Ding, Shi-Ming

2017-03-01

Organic amendments have been widely proposed as a remediation technology for metal-contaminated soils, but there exist controversial results on their effectiveness. In this study, the effect of pig manure addition on cadmium (Cd) bioavailability in Cd-contaminated soils was systematically evaluated by one dynamic, in situ technique of diffusive gradients in thin films (DGT) and four traditional methods based on the equilibrium theory (soil solution concentration and the three commonly used extractants, i.e., acetic acid (HAc), ethylenediamine tetraacetic acid (EDTA), and calcium chloride (CaCl 2 ). Wheat and maize were selected for measurement of plant Cd uptake. The results showed that pig manure addition could promote the growth of two plants, accompanied by increasing biomasses of shoots and roots with increasing doses of pig manure addition. Correspondingly, increasing additions of pig manure reduced plant Cd uptake and accumulation, as indicated by the decreases of Cd concentrations in shoots and roots. The bioavailable concentrations of Cd in Cd-contaminated soils reflected by the DGT technique obviously decreased with increasing doses of pig manure addition, following the same changing trend as plant Cd uptake. Changes in soil solution Cd concentration and extractable Cd by HAc, EDTA, and CaCl 2 in soils were similar to DGT measurement. Meanwhile, the capability of Cd resupply from solid phase to soil solution decreased with increasing additions of pig manure, as reflected by the decreases in the ratio (R) value of C DGT to C sol . Positive correlations were observed between various bioavailable indicators of Cd in soils and Cd concentrations in the tissues of the two plants. These findings provide stronger evidence that pig manure amendment is effective in reducing Cd mobility and bioavailability in soils and it is an ideal organic material for remediation of Cd-contaminated soils.

Guidelines for sustainable manure management in Asian livestock production systems. A publication prepared under the framework of the RCA project on Integrated Approach for Improving Livestock Production Using Indigenous Resources and Conserving the Environment

International Nuclear Information System (INIS)

2008-05-01

The International Atomic Energy Agency (IAEA) and the Regional Cooperative Agreement for Asia and the Pacific Region (RCA), with the technical support of the Joint FAO/IAEA Programme of Nuclear Techniques in Food and Agriculture, implemented a Technical Cooperation (TC) project entitled 'Integrated approach for improving livestock production using indigenous resources and conserving the environment' (RAS/5/044). Technical Cooperation projects are technology transfer initiatives, designed to address specific priorities identified by Member States. The specific objectives of this project were: (a) to improve animal productivity and decrease discharges of selected greenhouse gases, (methane and carbon dioxide) and selected nutrients (nitrogen and phosphorus) into the environment; and (b) to identify and adopt better breeding strategies to improve animal productivity through the use of better selection criteria for offspring from cross-breeding programmes, optimum utilization of appropriate indigenous cows, benchmarking for growth and reproduction, and improving procedures for management, nutrition and healthcare programmes in dairy farms. The first meeting to plan project activities was hosted by the Institute of Agricultural Environment and Sustainable Development of the Chinese Academy of Agricultural Sciences (CAAS), Beijing, and was held from 4 to 8 April 2005. It was attended by 23 nominated project counterparts from 12 RCA Member States and was supported by three IAEA experts. One of the conclusions from this meeting was that there was considerable scope and need for improving current manure management practices in the region to enhance the productive recycling of ingested nutrients in animal production systems, which in addition to increasing livestock and crop productivity will decrease environment pollution. It was agreed that there was a need to focus on improving the nutritional and manure management in integrated livestock systems, and that it was

Brazilian beef cattle feedlot manure management: a country survey.

Science.gov (United States)

Costa, C; Goulart, R S; Albertini, T Z; Feigl, B J; Cerri, C E P; Vasconcelos, J T; Bernoux, M; Lanna, D P D; Cerri, C C

2013-04-01

No information regarding the management of manure from beef cattle feedlots is available for Brazil. To fill this knowledge gap, a survey of 73 feedlots was conducted in 7 Brazilian states. In this survey, questions were asked regarding animal characteristics, their diets, and manure handling management from generation to disposal. These feedlots finished 831,450 animals in 2010. The predominant breed fed was Nellore, with average feeding periods of 60 to 135 d. Corn was the primary source of grain used in the feedlot diets (76% of surveyed animals) with concentrate inclusion levels ranging from 81 to 90% (38% of surveyed animals). The most representative manure management practice was the removal of manure from pens only at the end of the feeding period. Subsequently, the manure was stored in mounds before being applied to crop and pasture lands. Runoff, mainly from rainwater, was collected in retention ponds and used for agriculture. However, the quantity of runoff was not known. Manure was composted for only 20% of the animals in the survey and was treated in anaerobic digesters for only 1% of the animals. Manure from 59% of the cattle surveyed was used as fertilizer, providing a cost savings over the use of synthetic fertilizers. Overall, chemical analysis of the manure before application to fields was conducted for the manure of 56% of the surveyed animals, but the exact quantity applied (per hectare) was unknown for 48%. Feedlots representing 48% of the surveyed animals noted similar or greater crop and pasture yields when using manure, rather than synthetic fertilizers. In addition, 32% mentioned an increase in soil organic matter. Feedlots representing 88% of the surveyed cattle indicated that information concerning management practices that improve manure use efficiency is lacking. Feedlots representing 93% of the animals in the survey reported having basic information regarding the generation of energy and fertilizer with anaerobic digesters. However

Co-digestion of cattle manure with food waste and sludge to increase biogas production

Energy Technology Data Exchange (ETDEWEB)

Maranon, E., E-mail: emara@uniovi.es [Department of Chemical Engineering and Environmental Technology, University Institute of Technology of Asturias, Campus of Gijon, University of Oviedo, 33203 Gijon (Spain); Castrillon, L.; Quiroga, G.; Fernandez-Nava, Y. [Department of Chemical Engineering and Environmental Technology, University Institute of Technology of Asturias, Campus of Gijon, University of Oviedo, 33203 Gijon (Spain); Gomez, L.; Garcia, M.M. [Zero Emissions Technology, 41018 Seville (Spain)

2012-10-15

Highlights: Black-Right-Pointing-Pointer Small increase in methane production was observed applying sonication pretreatment. Black-Right-Pointing-Pointer Biogas productions between 720 and 1100 mL/Lreactor day were achieved. Black-Right-Pointing-Pointer Volatile solids removal efficiencies ranged between 53% and 60%. Black-Right-Pointing-Pointer Lower methane yields were obtained when operating under thermophilic conditions. Black-Right-Pointing-Pointer Optimum OLR in lab-scale CSTR was 1.2-1.3 g VS/L day (HRT: 20 days). - Abstract: Anaerobic co-digestion strategies are needed to enhance biogas production, especially when treating certain residues such as cattle/pig manure. This paper presents a study of co-digestion of cattle manure with food waste and sewage sludge. With the aim of maximising biogas yields, a series of experiments were carried out under mesophilic and thermophilic conditions using continuously stirred-tank reactors, operating at different hydraulic residence times. Pretreatment with ultrasound was also applied to compare the results with those obtained with non-pretreated waste. Specific methane production decreases when increasing the OLR and decreasing HRT. The maximum value obtained was 603 LCH{sub 4}/kg VS{sub feed} for the co-digestion of a mixture of 70% manure, 20% food waste and 10% sewage sludge (total solid concentration around 4%) at 36 Degree-Sign C, for an OLR of 1.2 g VS/L day. Increasing the OLR to 1.5 g VS/L day led to a decrease of around 20-28% in SMP. Lower methane yields were obtained when operating at 55 Degree-Sign C. The increase in methane production when applying ultrasound to the feed mixtures does not compensate for the energy spent in this pretreatment.

Towards improving the manure management chain

NARCIS (Netherlands)

Hou, Yong

2016-01-01

Animal manures are major sources of nutrients and organic matter, to be used to fertilize crops and improve soil quality. However, when not properly managed, these manures release considerable amounts of ammonia (NH3), nitrous oxide (N2O) and methane (CH4) into the air, and nitrogen (N) and

Tracing heavy metals in 'swine manure - maggot - chicken' production chain.

Science.gov (United States)

Wang, Wanqiang; Zhang, Wenjuan; Wang, Xiaoping; Lei, Chaoliang; Tang, Rui; Zhang, Feng; Yang, Qizhi; Zhu, Fen

2017-08-21

With the development of large-scale livestock farming, manure pollution has drawn much attention. Conversion by insects is a rapid and cost-effective new method for manure management. Swine manure conversion with maggots (Musca domestica larvae) has developed, and the harvested maggots are often used as animal feed. However, the flow of heavy metals from manure to downstream processes cannot be ignored, and therefore, heavy metal content was measured in untreated raw manure, maggot-treated manure, harvested maggots and maggot-eating chickens (chest muscle and liver) to evaluate potential heavy metal risks. The levels of zinc, copper, chromium, selenium, cadmium and lead had significant differences between untreated raw manure and maggot-treated manure. The concentrations of all detected heavy metals, except for cadmium and selenium, in maggots met the limits established by the feed or feed additive standards of many countries. The bioaccumulation factor (BAF) of heavy metals decreased with the increase of the maggot instar, indicating that heavy metals were discharged from the bodies of maggots with the growth of maggots. Also, the contents of overall heavy metals in chickens fed harvested maggots met the standards for food. In conclusion, regarding heavy metals, it is eco-safe to use maggots in manure management.

Integrating market chain assessments with zoonoses risk analysis in two cross-border pig value chains in Lao PDR.

Science.gov (United States)

Okello, Anna L; Tiemann, Tassilo T; Inthavong, Phouth; Khamlome, Boualam; Phengvilaysouk, Ammaly; Keonouchanh, Soukanh; Keokhamphet, Chattouphone; Somoulay, Virasack; Blaszak, Kate; Blacksell, Stuart D; Okello, Walter O; Allen, John

2017-11-01

Lao PDR's recent accession to the World Trade Organization necessitates a greater understanding of the patterns and risk of livestock production in order to better align national policy with the Agreement on the Application of Sanitary and Phytosanitary Measures. This eco-health study was conducted to improve understanding of the interrelations between market chains and zoonotic infection risks at two strategic cross border points between Lao PDR, Thailand and Viet Nam. Information gained from smallholder farmer/trader interviews was integrated with serological surveys for pig-associated zoonoses-including hepatitis E virus (HEV), Taenia solium (T. solium) and trichinella-to identify potential linkages between disease risk and pig production and slaughter in low input systems common across the country. Trichinella and HEV exposure was high in both humans and pigs in both study areas, significantly associated with pig slaughter and the subsequent consumption and handling of raw pork products. T. solium demonstrated a strong geographical and ethnic association with the northern study area bordering Vietnam. With the right knowledge and accessible, affordable inputs, the majority of smallholder farmers indicated a willingness to invest more in pig production, which could simultaneously improve livelihoods and decrease exposure to HEV, Trichinella, and T. solium through increased access to formal markets and an improved slaughter processes. The linkages identified when assessing disease risk in the context of potential economic and cultural drivers of transmission highlight the importance of a systems-based approach for the detection and control of zoonotic disease, and contributes to an improved understanding of the Lao PDR livestock sector.

Heterogeneity of O2 dynamics in soil amended with animal manure and implications for greenhouse gas emissions

DEFF Research Database (Denmark)

Zhu, Kun; Bruun, Sander; Larsen, Morten Kobæk

2015-01-01

in soils in which the same amount of solid fraction of pig manure had been distributed in three different ways (mixed, layered, single patch) and which were maintained at awater potential of 5 kPa (corresponding to 91% of water-filled pore space). In parallel, the greenhouse gas emissions (N2O, CO2 and CH4...... the cumulative N2O emissions and reduced the cumulative CO2 fluxes. The faster the anoxia developed, the less the nitrification process appeared to contribute to N2O emissions. No treatment effects on CH4 emissions were observed. Combined high resolution imaging of O2 dynamics and measurements of N2O emission...

Characterization of Insertional Variation of Porcine Endogenous Retroviruses in Six Different Pig Breeds

Directory of Open Access Journals (Sweden)

W. Y. Jung

2012-10-01

Full Text Available Pigs may need to be exploited as xenotransplantation donors due to the shortage of human organs, tissues and cells. Porcine endogenous retroviruses (PERVs are a significant obstacle to xenotransplantation because they can infect human cells in vitro and have the potential for transmission of unexpected pathogens to humans. In this research, 101 pigs, including four commercial breeds (23 Berkshire, 13 Duroc, 22 Landrace and 14 Yorkshire pigs, one native breed (19 Korean native pigs and one miniature breed (10 NIH miniature pigs were used to investigate insertional variations for 11 PERV loci (three PERV-A, six PERV-B and two PERV-C. Over 60% of the pigs harbored one PERV-A (907F8 integration and five PERV-B (B3-3G, B3-7G, 742H1, 1155D9 and 465D1 integrations. However, two PERV-A loci (A1-6C and 1347C1 and one PERV-B locus (B3-7F were absent in Duroc pigs. Moreover, two PERV-C loci (C2-6C and C4-2G only existed in Korean native pigs and NIH miniature pigs. The results suggest that PERV insertional variations differ among pig breeds as well as among individuals within a breed. Also, the results presented here can be used for the selection of animals that do not have specific PERV integration for xenotransplantation research.

Manure management for greenhouse gas mitigation

DEFF Research Database (Denmark)

Petersen, Søren O; Blanchard, M.; Chadwick, D.

2013-01-01

Ongoing intensification and specialisation of livestock production lead to increasing volumes of manure to be managed, which are a source of the greenhouse gases (GHGs) methane (CH4) and nitrous oxide (N2O). Net emissions of CH4 and N2O result from a multitude of microbial activities in the manure...

Evaluation of Poultry Manure Application Rates on the Nutrient ...

African Journals Online (AJOL)

The total carotenoid content was not significantly affected by poultry manure application. The phosphorus, calcium and magnesium contents were significantly affected by poultry manure application. Water and oil absorption capacity increased with increase in the level of poultry manure while the bulk density was not ...

Environmental and economic comparisons of manure application methods in farming systems.

Science.gov (United States)

Rotz, C A; Kleinman, P J A; Dell, C J; Veith, T L; Beegle, D B

2011-01-01

Alternative methods for applying livestock manure to no-till soils involve environmental and economic trade-offs. A process-level farm simulation model (Integrated Farm System Model) was used to evaluate methods for applying liquid dairy (Bos taurus L.) and swine (Sus scrofa L.) manure, including no application, broadcast spreading with and without incorporation by tillage, band application with soil aeration, and shallow disk injection. The model predicted ammonia emissions, nitrate leaching, and phosphorus (P) runoff losses similar to those measured over 4 yr of field trials. Each application method was simulated over 25 yr of weather on three Pennsylvania farms. On a swine and cow-calf beef operation under grass production, shallow disk injection increased profit by $340 yr(-1) while reducing ammonia nitrogen and soluble P losses by 48 and 70%, respectively. On a corn (Zea mays L.)-and-grass-based grazing dairy farm, shallow disk injection reduced ammonia loss by 21% and soluble P loss by 76% with little impact on farm profit. Incorporation by tillage and band application with aeration provided less environmental benefit with a net decrease in farm profit. On a large corn-and-alfalfa (Medicago sativa L.)-based dairy farm where manure nutrients were available in excess of crop needs, incorporation methods were not economically beneficial, but they provided environmental benefits with relatively low annual net costs ($13 to $18 cow). In all farming systems, shallow disk injection provided the greatest environmental benefit at the least cost or greatest profit for the producer. With these results, producers are better informed when selecting manure application equipment.

Elimination of macrolides, tiamulin, and salinomycin during manure storage.

Science.gov (United States)

Schlüsener, M P; von Arb, M A; Bester, K

2006-07-01

The extensive use of veterinary drugs in livestock farming increases the risk that these compounds end up in the environment when manure is used as fertilizer. This study focuses on the fate of antibiotics in liquid manure tanks before the liquid manure is spread on fields. A 180-day degradation experiment of four commonly used antibiotics erythromycin, roxithromycin, salinomycin, and tiamulin in liquid manure was performed. The resulting half-lives during manure storage were calculated as follows: 41 days for erythromycin, 130 days for roxithromycin, and 6 days for salinomycin. A first-order degradation rate was calculated for these three antibiotics. The concentration of tiamulin remained unchanged during the entire experiment. No degradation of tiamulin was detected even after 180 days.

Methane Recovery from Animal Manures The Current Opportunities Casebook

Energy Technology Data Exchange (ETDEWEB)

Lusk, P.

1998-09-22

Growth and concentration of the livestock industry create opportunities for the proper disposal of the large quantities of manures generated at dairy, swine, and poultry farms. Pollutants from unmanaged livestock wastes can degrade the environment, and methane emitted from decomposing manure may contribute to global climate change. One management system not only helps prevent pollution but can also convert a manure problem into a new profit center. Economic evaluations and case studies of operating systems indicate that the anaerobic digestion of livestock manures is a commercially viable conversion technology with considerable potential for providing profitable coproducts, including a cost-effective renewable fuel for livestock production operations. This casebook examines some of the current opportunities for recovering methane from anaerobic digestion animal manures.

Radiation disinfection of manure for animal feed supplement

International Nuclear Information System (INIS)

Harsojo; Andini, S.; Nazly, H.; Suwirma, S.; Danius, J.

1989-01-01

Radiation disinfection of manure for animal feed supplement. Radiation treatment for disinfection of manure have been investigated on manure collected during the dry and rainy seasons. Total bacterial counts of non-irradiated dewatered manure with water content of around 13.44% were found to be 1.0x10 6 up to 1.4x10 8 per g during the dry season, and 2.0x10 5 up to 1.7x10 7 per g during the rainy season, while coliforms, enterobecteriacease, staphylococcus, streptococcus, and pseudomonas were found to be 1.0x10 6 up to 1.4x10 8 per g, 1.0x10 4 up to 1.2x10 6 per g, 4.0x10 5 up to 2.2x10 7 per g, 1.8x10 3 per g, and 1.0x10 2 up to 5.4x10 3 per g, respectively. About 30% of the total coliforms were found to be escherichia coli. Irradiation dose of 4 kGy eliminated salmonella from all samples observed. No. Shigella Vibrio, and parasites were detected in the samples. Total nitrogen of the dewatered manure ranged between 1.87 and 2.33%, phosphorus between 1.25 and 4.38%, and potassium between 0.66 and 2.18%. Heavy metal elements were found only in very small amounts, hence the dewatered manure could be applied as animal feed or soil conditioner. A combination of irradiation at 4 kGy and storage for 3 months was synergistically effective to eliminate coliform, E. coli, and salmonella in the dewatered manure. From nutritional point of view, the manure is still acceptable for animal feed supplement. (author). 13 refs

Livestock farmer perceptions of successful collaborative arrangements for manure exchange

DEFF Research Database (Denmark)

Asai, Masayasu; Langer, Vibeke; Frederiksen, Pia

2014-01-01

to underground water, self-governing manure exchanges have been widely organised among farms in local communities. This allows large livestock farms to achieve the required balance between manure production and the agricultural production area although the importer rarely pays the full nutrient value...... for the manure received. Despite the potential for improved efficiency of manure use, few studies have examined livestock farmers’ perceptions of coordinated arrangements with recipient farms and factors in successful arrangements. A total of 644 manure exporters were asked about factors they consider important...... in identifying and selecting a new partner for manure export, including factors regarding the potential partner and the function of the partnership. They evaluated a total of 18 statements relating to possible perceptions. The results revealed that exporters appreciated especially four qualities: (1) timely...

Mercury in Animal Manures and Impacts on Environmental Health

Science.gov (United States)

Animal manure is widely used as a cheap source of fertilizer all over the world, and is also used as animal feed. In industrialized countries, tons of animal manures per hectare each year are applied to agricultural lands as an easy means of disposal. Analysis of these manures shows low Hg concentra...

Green manure and inorganic fertiliser as management strategies for ...

African Journals Online (AJOL)

To alleviate the problem of Striga and soil fertility, green-manure applications could be an alternative strategy. Ths study was conducted to (a) evaluate the potential of green manure against Striga, and (b) determine the potential of inducing Striga suicidal germination by selected green manures. For the first part of the study, ...

PENGARUH JENIS DAN DOSIS PUPUK KANDANG TERHADAP PERTUMBUHAN DAN PRODUKSI JAGUNG MANIS (Zea mays saccharata Sturt

Directory of Open Access Journals (Sweden)

A.A.A.S. Trisnadewi

2011-08-01

Full Text Available The experiment that aimed to study the types and various levels of manure for improving growth and production of sweet corn was conducted for 9 weeks. Completely randomized design (CRD arranged with nested model was used in this experiment. The main plot consisted of three kind of manures, there were broiler manure (A, horse manure (K, and pig manure (B. As sub plot were levels of manure: without manure D0 (0 ton/ha, D1 (10 ton/ha = 87.51 g/pot, D2 (20 ton/ha = 175 g/pot, D3 (30 ton/ha = 262.5 g/pot, with three replication in each combination treatment. Variables measured in this experiment were plant high, stem diameter, fresh and dry weight of leaf, stem and maize-ear of corn, total dry weight of forage production (stem + leaf and dry weight ratio of stem and leaf of sweet corn. The result of the experiment showed that the effect of broiler, horse, and pig manure on all variables which measured in the experiment were not significantly different (P>0,05. The highest growth and production of sweet corn were obtained at 20 ton/ha level for all kind of manures that used in this experiment with total dry weight of forage production 48.88; 51.11; and 48.30 g/pot and dry weight of maize-ear production 23.80; 23.30 and 22.00 g/pot for broiler, horse and pig manure respectively. Based on results of the experiment it can be concluded that no different effect on type of manure (broiler, horse and pig to the growth and production of sweet corn and the using manure at 20 ton/ha level give the highest growth and production of sweet corn.

[Interaction Between Sulfonamide Antibiotics Fates and Chicken Manure Composting].

Science.gov (United States)

Lin, Hui; Wang, Jian-mei; Sun, Wan-chun; Fu, Jian-rong; Chen, Hong-jin; Ma, Jun-wei

2016-05-15

Based on aerobic manure composting with or without the addition of a mixture of sulfadimethoxine SM2 and sulfamonomethoxine SMM (1:1, m/m), changes in the physic-chemical properties of manure compost, the microbial community physiological profiles, the antibiotics concentration and the abundances of five antibiotic resistance genes (ARGs) during the composting were tracked. The results indicated that the introduction of sulfonamide antibiotics led to inhibition on the basal respiration of manure compost during the early composting period, delayed the formation of thermophilic temperature and reduced the conversion of nutrients such as organic matter, ammonia nitrogen and nitrate nitrogen. Meanwhile, the introduction of sulfonamide antibiotics dramatically affected the physiological profile of microbial community in manure in the middle stage of composting. HPLC-MS/MS results showed that both SMM and SM2 in manure were completely degraded within 14 days, while the degradation rate of SMM was faster than that of SM2. For both composting treatments with or without addition of exogenous antibiotics, the relative abundance of sull and sul2 showed an initial decline in the first 14 or 21 days and a slight increase thereafter. The addition of exogenous antibiotics showed insignificant enhancement on increasing the relative abundance of sul1 and IntI1 in manure, but resulted in an apparent increase in sul2 relative abundance. Although the fates of tetQ and tetW during composting were different from that of sulfonamide ARGs, the introduction of sulfonamide antibiotics into manure increased the relative abundance of tetracycline ARGs. Redundancy analysis indicated that composting temperature correlated negatively with sul1, sul2 and IntI1 relative abundance in manure but had no obvious relationship with tetQ and tetW relative abundance. All the ARGs detected in this work correlated negatively with C/N ratio and the nitrate nitrogen concentration of manure compost but

Decision-support for Digester-Algae IntegRation for Improved Environmental and Economic Sustainability (DAIRIEES)

Energy Technology Data Exchange (ETDEWEB)

Guillen, Donna Post [Idaho National Lab. (INL), Idaho Falls, ID (United States)

2017-06-01

Manure management is a major concern for dairy farms, as manure emits significant quantities of greenhouse gases and contains concentrated nutrients, especially nitrogen and phosphorus. Current manure management practices consist of spreading minimally processed manure on agricultural fields, which releases greenhouse gases directly to the atmosphere and often leads to nutrient overloading on fields and runoff to surface and groundwater. A novel manure treatment system has been proposed that mitigates many of the current environmental concerns and creates value added products from the manure including bioplastics, electricity, fertilizer, and animal bedding. DAIRIEES, an Excel based model, allows users to enter characteristics about a dairy farm’s manure, manure management plan, and regional market. Based on these inputs, the five main processes of the integrated system—fermenter, anaerobic digester, bioplastics reactor, algae cultivation, and hydrothermal liquefaction or fast pyrolysis system—are analyzed in detail using data from laboratory scale experiments supplemented by information on full-scale processes from the literature. The model can be used to estimate performance of the integrated manure treatment system, including: 1) carbon and nutrient sequestration, 2) quantities and market value of end products, and 3) the system’s overall economic viability. The DAIRIEES model outlines the major economic considerations for construction and operation of a full scale integrated treatment system. This information can be used to inform a more detailed pro forma analysis of the deployed system.

Decision-support for Digester-Algae IntegRation for Improved Environmental and Economic Sustainability (DAIRIEES)

International Nuclear Information System (INIS)

Guillen, Donna Post

2017-01-01

Manure management is a major concern for dairy farms, as manure emits significant quantities of greenhouse gases and contains concentrated nutrients, especially nitrogen and phosphorus. Current manure management practices consist of spreading minimally processed manure on agricultural fields, which releases greenhouse gases directly to the atmosphere and often leads to nutrient overloading on fields and runoff to surface and groundwater. A novel manure treatment system has been proposed that mitigates many of the current environmental concerns and creates value added products from the manure including bioplastics, electricity, fertilizer, and animal bedding. DAIRIEES, an Excel based model, allows users to enter characteristics about a dairy farm’s manure, manure management plan, and regional market. Based on these inputs, the five main processes of the integrated system—fermenter, anaerobic digester, bioplastics reactor, algae cultivation, and hydrothermal liquefaction or fast pyrolysis system—are analyzed in detail using data from laboratory scale experiments supplemented by information on full-scale processes from the literature. The model can be used to estimate performance of the integrated manure treatment system, including: 1) carbon and nutrient sequestration, 2) quantities and market value of end products, and 3) the system’s overall economic viability. The DAIRIEES model outlines the major economic considerations for construction and operation of a full scale integrated treatment system. This information can be used to inform a more detailed pro forma analysis of the deployed system.

COMPARATIVE EFFECTIVENESS OF ANIMAL MANURES ON SOIL ...

African Journals Online (AJOL)

Administrator

tons/ha and 13.4 tons/ha of poultry, goat and dairy cow manure will suffice the requirement of. 40 kg N/ha and 20 ..... supplementation with inorganic P sources. Rate. Manure ... organic and available forms of phosphorus in soils. Soil Science.

Fate and transport of antimicrobials and antimicrobial resistance genes in soil and runoff following land application of swine manure slurry.

Science.gov (United States)

Joy, Stacey R; Bartelt-Hunt, Shannon L; Snow, Daniel D; Gilley, John E; Woodbury, Bryan L; Parker, David B; Marx, David B; Li, Xu

2013-01-01

Due to the use of antimicrobials in livestock production, residual antimicrobials and antimicrobial resistance genes (ARGs) could enter the environment following the land application of animal wastes and could further contaminate surface and groundwater. The objective of this study was to determine the effect of various manure land application methods on the fate and transport of antimicrobials and ARGs in soil and runoff following land application of swine manure slurry. Swine manure slurries were obtained from facilities housing pigs that were fed chlortetracyline, tylosin or bacitracin and were land applied via broadcast, incorporation, and injection methods. Three rainfall simulation tests were then performed on amended and control plots. Results show that land application methods had no statistically significant effect on the aqueous concentrations of antimicrobials in runoff. However, among the three application methods tested broadcast resulted in the highest total mass loading of antimicrobials in runoff from the three rainfall simulation tests. The aqueous concentrations of chlortetracyline and tylosin in runoff decreased in consecutive rainfall events, although the trend was only statistically significant for tylosin. For ARGs, broadcast resulted in significantly higher erm genes in runoff than did incorporation and injection methods. In soil, the effects of land application methods on the fate of antimicrobials in top soil were compound specific. No clear trend was observed in the ARG levels in soil, likely because different host cells may respond differently to the soil environments created by various land application methods.

Dark fermentation, anaerobic digestion and microbial fuel cells: An integrated system to valorize swine manure and rice bran.

Science.gov (United States)

Schievano, Andrea; Sciarria, Tommy Pepè; Gao, Yong Chang; Scaglia, Barbara; Salati, Silvia; Zanardo, Marina; Quiao, Wei; Dong, Renjie; Adani, Fabrizio

2016-10-01

This work describes how dark fermentation (DF), anaerobic digestion (AD) and microbial fuel cells (MFC) and solid-liquid separation can be integrated to co-produce valuable biochemicals (hydrogen and methane), bioelectricity and biofertilizers. Two integrated systems (System 1: AD+MFC, and System 2: DF+AD+MFC) are described and compared to a traditional one-stage AD system in converting a mixture (COD=124±8.1gO2kg(-1)Fresh Matter) of swine manure and rice bran. System 1 gave a biomethane yield of 182 LCH4kg(-1)COD-added, while System 2 gave L yields of bio-hydrogen and bio-methane of 27.3±7.2LH2kg(-1)COD-added and 154±14LCH4kg(-1)COD-added, respectively. A solid-liquid separation (SLS) step was applied to the digested slurry, giving solid and liquid fractions. The liquid fraction was treated via the MFC-steps, showing power densities of 12-13Wm(-3) (500Ω) and average bioelectricity yields of 39.8Whkg(-1)COD to 54.2Whkg(-1)COD. Copyright © 2016 Elsevier Ltd. All rights reserved.

Integrating market chain assessments with zoonoses risk analysis in two cross-border pig value chains in Lao PDR

Directory of Open Access Journals (Sweden)

Anna L Okello

2017-11-01

Full Text Available Objective Lao PDR’s recent accession to the World Trade Organization necessitates a greater understanding of the patterns and risk of livestock production in order to better align national policy with the Agreement on the Application of Sanitary and Phytosanitary Measures. This eco-health study was conducted to improve understanding of the interrelations between market chains and zoonotic infection risks at two strategic cross border points between Lao PDR, Thailand and Viet Nam. Methods Information gained from smallholder farmer/trader interviews was integrated with serological surveys for pig-associated zoonoses—including hepatitis E virus (HEV, Taenia solium (T. solium and trichinella—to identify potential linkages between disease risk and pig production and slaughter in low input systems common across the country. Results Trichinella and HEV exposure was high in both humans and pigs in both study areas, significantly associated with pig slaughter and the subsequent consumption and handling of raw pork products. T. solium demonstrated a strong geographical and ethnic association with the northern study area bordering Vietnam. With the right knowledge and accessible, affordable inputs, the majority of smallholder farmers indicated a willingness to invest more in pig production, which could simultaneously improve livelihoods and decrease exposure to HEV, Trichinella, and T. solium through increased access to formal markets and an improved slaughter processes. Conclusion The linkages identified when assessing disease risk in the context of potential economic and cultural drivers of transmission highlight the importance of a systems-based approach for the detection and control of zoonotic disease, and contributes to an improved understanding of the Lao PDR livestock sector.

Integrating market chain assessments with zoonoses risk analysis in two cross-border pig value chains in Lao PDR

Science.gov (United States)

Okello, Anna L; Tiemann, Tassilo T; Inthavong, Phouth; Khamlome, Boualam; Phengvilaysouk, Ammaly; Keonouchanh, Soukanh; Keokhamphet, Chattouphone; Somoulay, Virasack; Blaszak, Kate; Blacksell, Stuart D; Okello, Walter O; Allen, John

2017-01-01

Objective Lao PDR’s recent accession to the World Trade Organization necessitates a greater understanding of the patterns and risk of livestock production in order to better align national policy with the Agreement on the Application of Sanitary and Phytosanitary Measures. This eco-health study was conducted to improve understanding of the interrelations between market chains and zoonotic infection risks at two strategic cross border points between Lao PDR, Thailand and Viet Nam. Methods Information gained from smallholder farmer/trader interviews was integrated with serological surveys for pig-associated zoonoses—including hepatitis E virus (HEV), Taenia solium (T. solium) and trichinella—to identify potential linkages between disease risk and pig production and slaughter in low input systems common across the country. Results Trichinella and HEV exposure was high in both humans and pigs in both study areas, significantly associated with pig slaughter and the subsequent consumption and handling of raw pork products. T. solium demonstrated a strong geographical and ethnic association with the northern study area bordering Vietnam. With the right knowledge and accessible, affordable inputs, the majority of smallholder farmers indicated a willingness to invest more in pig production, which could simultaneously improve livelihoods and decrease exposure to HEV, Trichinella, and T. solium through increased access to formal markets and an improved slaughter processes. Conclusion The linkages identified when assessing disease risk in the context of potential economic and cultural drivers of transmission highlight the importance of a systems-based approach for the detection and control of zoonotic disease, and contributes to an improved understanding of the Lao PDR livestock sector. PMID:28423884

Biogas production from llama and cow manure at high altitude

International Nuclear Information System (INIS)

Alvarez, Rene; Villca, Saul; Liden, Gunnar

2006-01-01

Methane production from llama and cow manures from the Bolivian high plateau (The 'Altiplano') was studied using a parallel reactor set-up consisting of 10 lab-scale biogasifiers. The effects of pressure (495 and 760mmHg), temperature (11 and 35 deg. C), hydraulic retention time (20 and 50 days), and manure content in the slurry (10%, 20% and 50%) were evaluated with respect to productivity and methane yields based on two 2 4-1 fractional factorial designs with 8 treatments for each kind of manure. The reactors were operated semi-continuously with daily manure feeding for periods between 50 and 100 days. Temperature was the main factor effect found, and the hydraulic retention time and the manure content in feed were also found significant whereas the effect of pressure was not significant in the range studied. The methane yield obtained with cow manure at 11 - bar C was between 6.4 and 33.6lCH 4 kg -1 VS (volatile solids added) whereas at 35 deg. C the methane yield was between 49.6 and 131.3lCH 4 kg -1 VS. The methane yield from llama manure was somewhat lower than for cow manure (between 3.3 and 19.3lCH 4 kg -1 VS at 11 deg. C and between 35.6 and 84.1lCH 4 kg -1 VS at 35 deg. C, respectively). However, overall llama manure was found to be the best raw material of the two for biogas production, due to its high content of volatile solid-higher than has been previously reported for most manures-and also its high nitrogen and phosphorous content

典型粪污处理模式下规模养猪场农牧结合规模配置研究*Ⅱ粪污直接厌氧发酵处理模式%Pig farm-cropland configuration under typical waste treatment mode- A case study of direct anaerobic fermentation of manure

Institute of Scientific and Technical Information of China (English)

盛婧; 孙国峰; 郑建初

2015-01-01

粪污直接厌氧发酵模式是当前我国畜禽粪污处理的另一种主要模式。研究粪污直接厌氧发酵模式下规模养猪场农牧结合适宜规模配置对于减少畜禽粪便污染、促进畜牧业可持续发展具有重要意义。本研究以存栏万头猪场为例,采用分步逐级计算的方法估算典型粪便处理模式——粪污直接厌氧发酵模式下,规模养猪场废弃物完全消纳的不同种植模式农田匹配面积,并研究了基于作物养分需求的不同种植模式农田畜禽粪便承载量,以期为畜牧业废弃物减排、农牧结合生态模式建立提供理论依据。结果表明：粪污直接厌氧发酵处理模式,以沼渣和沼液全部在农田安全消纳为目标,万头猪场需要配置的最少农田面积分别为粮油作物地272.5~285.4 hm2,或茄果类蔬菜地149.4~188.2 hm2,或果树苗木地599.4~1248.8 hm2；该模式下粮油作物地、茄果类蔬菜地、果树苗木地每公顷分别可承载35~37头、53~67头、8~17头存栏猪排放粪便的发酵沼渣和沼液。规模养猪场应根据猪养殖数量及其周边农田面积,选择适宜的粪污处理模式及种植作物类型,因地制宜,合理调控。为了确保作物养分需求,所有作物种植模式沼液施用后还需要补充一定量的化肥。本文中9种模式均需补充钾肥,其中,辣椒黄瓜模式钾肥补充量最高,占其需求量的48.0%；黄瓜蕃茄模式其次,占其需求量的34.4%；粮油作物、梨和茶叶还需同时补充氮肥,补充量为51.2~193.7 kg·hm2；茄果类蔬菜、葡萄和桃则需要补充13.8~108.8 kg·hm2的磷肥。%Earlier study has focused mainly on the mode of manure treatment of liquid anaerobic fermentation after separation of solid and liquid. Direct anaerobic fermentation of manure is another main mode of current treatment of pig manure in China. Studies on configurations of pig farms and croplands under waste disposal mode of direct

Survival of Salmonella spp. and fecal indicator bacteria in Vietnamese biogas digesters receiving pig slurry.

Science.gov (United States)

Huong, Luu Quynh; Forslund, Anita; Madsen, Henry; Dalsgaard, Anders

2014-09-01

Small-scale biogas digesters are widely promoted worldwide as a sustainable technology to manage livestock manure. In Vietnam, pig slurry is commonly applied to biogas digesters for production of gas for electricity and cooking with the effluent being used to fertilize field crops, vegetables and fish ponds. Slurry may contain a variety of zoonotic pathogens, e.g. Salmonella spp., which are able to cause disease in humans either through direct contact with slurry or by fecal contamination of water and foods. The objective of this study was to evaluate the survival of Salmonella spp. and the fecal indicator bacteria, enterococci, E. coli, and spores of Clostridium perfringens in biogas digesters operated by small-scale Vietnamese pig farmers. The serovar and antimicrobial susceptibility of the Salmonella spp. isolated were also established. The study was conducted in 12 farms (6 farms with and 6 farms without toilet connected) located in Hanam province, Vietnam. Sampling of pig slurry and biogas effluent was done during two seasons. Results showed that the concentration of enterococci, E. coli, and Clostridium perfringens spores was overall reduced by only 1-2 log10-units in the biogas digesters when comparing raw slurry and biogas effluent. Salmonella spp. was found in both raw slurry and biogas effluent. A total of 19 Salmonella serovars were identified, with the main serovars being Salmonella Typhimurium (55/138), Salmonella enterica serovar 4,[5],12:i:- (19/138), Salmonella Weltevreden (9/138) and Salmonella Rissen (9/138). The Salmonella serovars showed similar antimicrobial resistance patterns to those previously reported from Vietnam. When promoting biogas, farmers should be made aware that effluent should only be used as fertilizer for crops not consumed raw and that indiscriminate discharge of effluent are likely to contaminate water recipients, e.g. drinking water sources, with pathogens. Relevant authorities should promote safe animal manure management

[Regional differences and development tendency of livestock manure pollution in China].

Science.gov (United States)

Qiu, Huan-Guang; Liao, Shao-Pan; Jing, Yue; Luan, Jiang

2013-07-01

The rapid development of livestock production in China has brought livestock manure pollution as a serious environment problem, even threatens China's agriculture sustainable development. On the basis of public statistical data and field research data, this paper analyzed the magnitude of livestock manure excretion and pollution of China and different provinces in 2010, and predicted development tendencies of livestock manure excretion and pollution in 2020 through the Decision Support System for China's Agricultural Sustainable Development (CHINAGRO). The result shows that total livestock manure excretion of China in 2010 is 1 900 million tons, and livestock manure pollution is 227 million tons, while per hectare arable land of livestock manure pollution is 1.86 tons. Provinces in the southeast China, such as Guangdong and Fujian, are areas with high pressure of livestock manure pollution. Model simulation shows that China's total amount of livestock manure pollution will increase to 298 million tons in 2020 without government intervention. The pressure of livestock manure pollution will become higher in most regions of China, especially in east and south regions. The situation in central and western region is better than that in east regions although the pollution pressure will also increase in those areas. Policy intervention such as taxes and subsidies should be adopted to reduce the discharge of livestock manure pollution, and encourage livestock production transfer from eastern areas to the central and western regions.

Grass as a C booster for manure-biogas in Estonia

DEFF Research Database (Denmark)

Pehme, Sirli; Hamelin, Lorie; Veromann, Eve

2014-01-01

The aim of this study was to assess the environmental consequences of using grass (from both unused and cultivated boreal grasslands) as a co-substrate to dairy cow manure for biogas production. Environmental impact categories assessed were global warming, acidification and nutrient enrichment...... (distinguishing between N and P). Scenarios studied were: traditional management of dairy cow manure, monodigestion of manure, manure co-digestion with reed canary grass and manure co-digestion with residual grass from semi-natural grasslands. The latter scenario showed the best environmental performance...... for the global warming category, for other categories it did not show clear benefits. Using reed canary grass specially produced for biogas purpose resulted in a climate change impact just as big as the reference manure management, mainly as a result of indirect land use changes. Increased impacts also occurred...

Production Practices and Statistics of the Pig Industry in Zuru Local ...

African Journals Online (AJOL)

Pig is one of the earliest domesticated animals and plays an integral part in a number of peasant economies in the tropics. The people of Zuru Local Government Area of Kebbi State, Nigeria keep Pig as a source of animal protein and also to generate income. Seven communities of Zuru Local Government rear pig.

Factors influencing adoption of manure separation technology in the Netherlands

NARCIS (Netherlands)

Gebrezgabher, Solomie; Meuwissen, M.P.M.; Kruseman, G.; Lakner, D.; Oude Lansink, A.G.J.M.

2015-01-01

Manure separation technologies are essential for sustainable livestock operations in areas with high livestock density as these technologies result in better utilization of manure and reduced environmental impact. Technologies for manure separation have been well researched and are ready for use.

农村规模化养猪场粪污危害与处理措施%Manure Hazards and Treatment Measures in Rural Large-Scale Hoggery

Institute of Scientific and Technical Information of China (English)

王小芬; 彭有义

2014-01-01

With the scale development of rural pig breeding industry, there are more and more waste farm emissions, in which the manure emissions severely contaminate the surrounding air, soil and water, whose harm is becoming more and more serious. So we must carry on the harmless treatment. The rural large-scale pig farms should give full play to their own advantages, prefer dry dung cleaning process, implement rain and sewage separation, use suitable manure treatment facilities, scientifically treat piggery wastewater, to make it harmless, resource development, so as to reduce the pollution of the environment, protect human and animal health, to achieve healthy, sustainable development of the pig industry.%随着农村牲猪养殖业的规模化发展，猪场排放的废弃物越来越多，其中排放的粪污严重污染着周边大气、土壤和水体，其危害日趋严重，必须对其进行无害化处理。农村规模化养猪场应充分发挥自身优势，优先选用干清粪工艺，实施雨污分离，采用适宜的粪污处理设施，科学处理猪场粪污，使之向无害化、资源化方向发展，从而减少环境污染，保障人畜健康，实现养猪业可持续性健康发展。

Assessment of nitrogen content in buffalo manure and land application costs

Directory of Open Access Journals (Sweden)

Salvatore Faugno

2012-09-01

Full Text Available Buffalo (Bubalus bubalis livestock for mozzarella cheese production plays a fundamental role in the economy of southern Italy. European and Italian regulations consider nitrogen content in buffalo manure to be the same as that of cattle manure. This study aimed to assess whether this assumption is true. The first aim of the study was to assess nitrogen content in buffalo manure. Samples were taken from 35 farms to analyse nitrogen and phosphorous concentration in the manure. Analysis confirmed a lower nitrogen concentration (2% in buffalo manure. A secondary aim of the study was to evaluate whether manure application techniques that are apparently less suitable, e.g. splash plate spreader, could be feasible. The cost of different methods of land application of manure and their characteristics were evaluated on the basis of one operational cycle. Considering losses for volatilisation, and taking into account cost assessment, the immediate incorporation of buffalo manure (nitrogen content 2% is a suitable method of ammonia volatilisation. However, it is expensive and involves high fuel consumption in relation to the environmental benefit.

Spatiotemporal dynamics of phosphorus release, oxygen consumption and greenhouse gas emissions after localised soil amendment with organic fertilisers

DEFF Research Database (Denmark)

Christel, Wibke; Zhu, Kun; Hoefer, Christoph

2016-01-01

processes and fixation in the residue sphere, giving rise to distinct differences in nutrient availability, soil oxygen content and greenhouse gas (GHG) production. In this study we investigated the spatiotemporal dynamics of the reaction of manure solids and manure solids char with soil, focusing...... on their phosphorus (P) availability, as current emphasis on improving societal P efficiency through recycling waste or bio-based fertilisers necessitates a sound understanding of their behaviour. Soil layers amended at a constant P application rate with either pig manure solids or char made from pig manure solids...

Overview of the advances in environmental chemistry of animal manure

Science.gov (United States)

There is an increasing environmental concern over animal manure due to the volumes produced in modern intensified animal production. However, animal manure is traditionally regarded as a valuable resource of plant nutrients. Although research on environmental impacts of animal manure and associated...

Okra yield fertilized with bovine manure and biofertilizer

Directory of Open Access Journals (Sweden)

Ademar Pereira de Oliveira

2013-12-01

Full Text Available The use of bovine manure becomes an useful and economic practice for the small and medium producers of vegetables, and the okra plant normally demands high doses of organic fertilizers. This study was carried out, from January to July 2011, at the Federal University of Paraíba, in Areia city - PB, aiming to evaluate the effect of bovine manure and biofertilizer on the productive behavior of the okra plant. The experimental design used was randomized blocks, with four repetitions in factorial scheme 6 x 2, with the doses factors of bovine manure (0, 10, 20, 30, 40 and 50 t ha-1 with and without biofertilizer. The average mass of commercial fruit of okra, with and without biofertilizer was 18 and 16.5 g, respectively, in the doses of 27.5 and 60 t ha-1 of manure. The number of fruit plant-1 without biofertilizer was 30 fruits plant-1 of okra in the dose of 60 t ha-1 and with biofertilizer, the number of fruits plant-1 was 33 fruits in the dose of 28 t ha-1 of bovine manure. The productivity of commercial fruits of okra without biofertilizer was 20.4 t ha-1 and 22 t ha-1 with biofertilizer, respectively, in the doses of 60 and 31 t ha-1 of bovine manure.

Potential for reduction of odorous compounds in swine manure through diet modification.

Science.gov (United States)

Sutton, A L; Kephart, K B; Verstegen, M W; Canh, T T; Hobbs, P J

1999-02-01

Recent public concern about air pollution from pork production units has prompted more research to develop methods to reduce and control odors. Masking agents, enzymes and bacterial preparations, feed additives, chemicals, oxidation processes, air scrubbers, biofilters, and new ventilation systems have been studied. Research relating the effects of the swine diet on manure odors has been scarce. Introducing feed additives to bind ammonia, change digesta pH, affect specific enzyme activity, and mask odors has been either costly or not consistently successful. Recent research emphasis has focused on manipulating the diet 1) to increase the nutrient utilization of the diet to reduce excretion products, 2) to enhance microbial metabolism in the lower digestive tract to reduce excretion of odor-causing compounds, and 3) to change the physical characteristics of urine and feces to reduce odor emissions. Primary odor-causing compounds evolve from excess degradable proteins and lack of specific fermentable carbohydrates during microbial fermentation. Reductions in ammonia emissions by 28 to 79% through diet modifications have been reported. Limited research on reduction of other odorous volatile organic compounds through diet modifications is promising. Use of synthetic amino acids with reduced intact protein levels in diets significantly reduces nitrogen excretions and odor production. Addition of nonstarch polysaccharides and specific oligosaccharides further alters the pathway of nitrogen excretion and reduces odor emission. Continued nutritional and microbial research to incorporate protein degradation products, especially sulfur-containing organics, with fermentable carbohydrates in the lower gastrointestinal tract of pigs will further control odors from manure.

Bridging Gaps in the Agricultural Phosphorus Cycle from an Animal Husbandry Perspective—The Case of Pigs and Poultry

Directory of Open Access Journals (Sweden)

Michael Oster

2018-06-01

Full Text Available Since phosphorus (P is an essential element for life, its usage and application across agricultural production systems requires great attention. Monogastric species such as pigs and poultry can significantly contribute to global food security but these animals remain highly dependent on the supply of mineral inorganic P in their feeds. Pig and poultry, which represent 70% of the global meat production, are also major P excretors and thus represent important sources of environmental P inputs. Balancing the P cycle within farming systems is crucial to achieve P sustainable and resilient livestock production. Therefore, the interconnection of animal feed, livestock farming, manure, and soil/aquatic ecosystems requires multidisciplinary approaches to improve P management. With regard to a sustainable agricultural P cycle, this study addresses aspects of feeding strategies and animal physiology (e.g., phase feeding, P conditioning, liquid feeding, phytase supplementation, genetics, soil agroecosystems (e.g., P cycling, P losses, P gains, reuse and recycling (e.g., manure, slaughter waste, measures of farmers’ economic performance (e.g., bio-economic models, and P governance/policy instruments (e.g., P quota, P tax. To reconcile the economic and ecological sustainability of animal husbandry, the strategic objective of future research will be to provide solutions for a sufficient supply of high-quality animal products from resource-efficient and economically competitive agro-systems which are valued by society and preserve soil and aquatic ecosystems.

Environmental assessment of untreated manure use, manure digestion and codigestion with silage maize : Deliverable for the 'EU-AGRO-BIOGAS' project

NARCIS (Netherlands)

Vries, de J.W.; Corre, W.J.; Dooren, van H.J.C.

2010-01-01

This report describes the environmental impact of untreated manure use, manure digestion, and co-digestion with silage maize for energy production. The life cycle assessment methodology was used. Environmental indicators included were, global warming potential, energy use, eutrophication,

Optimization of Aqueous Ammonia Soaking of manure fibers by Response Surface Methodology for unlocking the methane potential of swine manure

DEFF Research Database (Denmark)

Lymperatou, Anna; Gavala, Hariklia N.; Skiadas, Ioannis

2017-01-01

Swine manure mono-digestion often results to economically non-feasible processes, due to the high dilution and ammonia concentration together with the low degradation rates it presents. The effects of different parameters of Aqueous Ammonia Soaking (AAS) as a pretreatment for improving...... to be optimal (7% w/w NH3, 96 hours, and 0.16 kg/l) in combination to a significant increase of the short term CH4 yield (244% in 17 days), make this pretreatment a promising solution for improving swine manure mono-digestion. Furthermore, compositional analysis of the manure fibers revealed significant...... the digestion of manure fibers when coupled to an ammonia removal step were investigated in this study. Response Surface Methodology was followed and the influence and interactions of the following AAS parameters were studied: NH3 concentration, duration and solid-to-liquid ratio. The mild conditions found...

Centrifuge separation effect on bacterial indicator reduction in dairy manure.

Science.gov (United States)

Liu, Zong; Carroll, Zachary S; Long, Sharon C; Roa-Espinosa, Aicardo; Runge, Troy

2017-04-15

Centrifugation is a commonly applied separation method for manure processing on large farms to separate solids and nutrients. Pathogen reduction is also an important consideration for managing manure. Appropriate treatment reduces risks from pathogen exposure when manure is used as soil amendments or the processed liquid stream is recycled to flush the barn. This study investigated the effects of centrifugation and polymer addition on bacterial indicator removal from the liquid fraction of manure slurries. Farm samples were taken from a manure centrifuge processing system. There were negligible changes of quantified pathogen indicator concentrations in the low-solids centrate compared to the influent slurry. To study if possible improvements could be made to the system, lab scale experiments were performed investigating a range of g-forces and flocculating polymer addition. The results demonstrated that polymer addition had a negligible effect on the indicator bacteria levels when centrifuged at high g forces. However, the higher g force centrifugation was capable of reducing bacterial indicator levels up to two-log 10 in the liquid stream of the manure, although at speeds higher than typical centrifuge operations currently used for manure processing applications. This study suggests manure centrifuge equipment could be redesigned to provide pathogen reduction to meet emerging issues, such as zoonotic pathogen control. Copyright © 2017 The Authors. Published by Elsevier Ltd.. All rights reserved.

Evaluation of biochars from different stock materials as carriers of bacterial strain for remediation of heavy metal-contaminated soil.

Science.gov (United States)

Wang, Ting; Sun, Hongwen; Ren, Xinhao; Li, Bing; Mao, Hongjun

2017-09-21

Two kinds of biochars, one derived from corn straw and one from pig manure, were studied as carriers of a mutant genotype from Bacillus subtilis (B38) for heavy metal contaminated soil remediation. After amendment with biochar, the heavy metal bioavailability decreased. Moreover, the heavy metal immobilization ability of the biochar was enhanced by combining it with B38. The simultaneous application of B38 and pig manure-derived biochar exhibited a superior effect on the promotion of plant growth and the immobilization of heavy metals in soil. The plant biomass increased by 37.9% and heavy metal concentrations in the edible part of lettuce decreased by 69.9-96.1%. The polymerase chain reaction-denaturing gradient gel electrophoresis (PCR-DGGE) profiles revealed that pig manure-derived biochar could enhance the proliferation of both exotic B38 and native microbes. These results suggest that B38 carried by pig manure-derived biochar may be a promising candidate for the remediation of soils contaminated by multiple heavy metals.

Horse manure as feedstock for anaerobic digestion.

Science.gov (United States)

Hadin, Sa; Eriksson, Ola

2016-10-01

Horse keeping is of great economic, social and environmental benefit for society, but causes environmental impacts throughout the whole chain from feed production to manure treatment. According to national statistics, the number of horses in Sweden is continually increasing and is currently approximately 360,000. This in turn leads to increasing amounts of horse manure that have to be managed and treated. Current practices could cause local and global environmental impacts due to poor performance or lack of proper management. Horse manure with its content of nutrients and organic material can however contribute to fertilisation of arable land and recovery of renewable energy following anaerobic digestion. At present anaerobic digestion of horse manure is not a common treatment. In this paper the potential for producing biogas and biofertiliser from horse manure is analysed based on a thorough literature review in combination with mathematical modelling and simulations. Anaerobic digestion was chosen as it has a high degree of resource conservation, both in terms of energy (biogas) and nutrients (digestate). Important factors regarding manure characteristics and operating factors in the biogas plant are identified. Two crucial factors are the type and amount of bedding material used, which has strong implications for feedstock characteristics, and the type of digestion method applied (dry or wet process). Straw and waste paper are identified as the best materials in an energy point of view. While the specific methane yield decreases with a high amount of bedding, the bedding material still makes a positive contribution to the energy balance. Thermophilic digestion increases the methane generation rate and yield, compared with mesophilic digestion, but the total effect is negligible. Copyright © 2016. Published by Elsevier Ltd.

Influence of Integrated Use of Inorganic fertiliser and Organic manures on Bacterial Wilt Incidence (WI) and Tuber Yield in Potato Production Systems in Southern Slopes of Mt. Kenya

International Nuclear Information System (INIS)

Mriithi, L.M.

2002-01-01

Bacterial wilt (BW) caused by Ralstonia solanacearum is one of the most damaging of potato (Solanum tuberosum L.) in Kenya and worldwide. In Kenya Potato tuber yield losses due to BW infection are estimated at 50-100%. Low soil fertility is also one of the most important constraints limiting potato production in central Kenya highlands. Farmers tackle this problem through use of inorganic fertilisers and organic manures, both of which amend the soil environment to influence bacterial wilt development. Undecomposed organic manures can also introduce the pathogen into a clean field. Between short rains 1999 and 2000, 10 on-farm researcher/farmer-designed and farmer-managed trials were done at Kianjuki catchment in Embu District. The objective was to use farmers' participatory research approach and select the most suitable organic and inorganic fertiliser combination(s) with lowest BWI and acceptable usable tuber yields. And also demonstrate use of some components of integrated disease management methods in reduction of disease incidence and spread. Seven treatments were proposed, presented to the farmers for discussion and the most relevant four were selected for evaluation . A newly released potato variety 'Asante' was planted during the short-rains 1999 and long rains 2000. BWI didn't;t result in significant differences between treatments but the tuber yields were significantly different in short-rains 1999 and 2000. During short-rains 2000, both BWI and tuber yields and unusable tubers differed significantly between treatments. The results confirmed that use of well-decomposed manures or manures from pathogen-free areas can be used in combination with inorganic fertilisers to improve soil fertility and potato tuber yields in smallholder farm without influencing BWI. Use of certified seed tubers in pathogen free fields and following recommendation field sanitation measures, resulted in apparently bacterial wilt free crop

Nitrous Oxide Emissions after Application of Manure-Derived Fertiliseres

DEFF Research Database (Denmark)

Zhu, Kun

of N2O emission between different manure-derived fertilisers were observed. The application of fresh or composted manure solids had much higher N2O emissions than that of charred manure solids which contained low available C and N contents. The immature compost with a high content of dissolved organic...... different levels of C availability. The turnover and availability of N was modified by addition of nitrification inhibitor dicyandiamide (DCD) or mineral N. Soil O2 dynamics was monitored with high spatiotemporal resolution to elucidate the related mechanism regulating N2O emissions. Significant differences...... warming. This PhD project therefore investigated N2O emissions from soil after application of manure-derived fertilisers with varying spatial distribution, and evaluated the influences of available C, N and O2 on N2O emissions. Fresh, composted and charred manure solids were applied in soil to provide...

Biodiesel synthesis using chicken manure biochar and waste cooking oil.

Science.gov (United States)

Jung, Jong-Min; Lee, Sang-Ryong; Lee, Jechan; Lee, Taewoo; Tsang, Daniel C W; Kwon, Eilhann E

2017-11-01

This study laid an emphasis on the possible employment of biochar generated from pyrolysis of chicken manure to establish a green platform for producing biodiesel. To this end, the pseudo-catalytic transesterification reaction using chicken manure biochar and waste cooking oil was investigated. Compared with a commercial porous material (SiO 2 ), chicken manure biochar generated from 350°C showed better performance, resulting in 95.6% of the FAME yield at 350°C. The Ca species in chicken manure biochar imparted strong catalytic capability by providing the basicity for transesterification. The identified catalytic effect also led to the thermal cracking of unsaturated FAMEs, which decreased the overall FAME yield. For example, 40-60% of converted FAMEs were thermally degraded. To avoid undesirable thermal cracking arising from the high content of the Ca species in chicken manure biochar, the fabrication of chicken manure biochar at temperatures ≥350°C was highly recommended. Copyright © 2017 Elsevier Ltd. All rights reserved.

养猪业清洁生产途径与循环经济发展模式探讨%Pig industry clean production and recycling and the mode of economic development approach

Institute of Scientific and Technical Information of China (English)

严良政; 朱金城; 林成先; 矫学成

2011-01-01

In recent years, China＇s pig industry has developed rapidly, faster economic growth in rural areas, farmers＂ incomes and living standards improved significantly. Meanwhile, the pig pig manure produced increasingly serious pollution has seriously affected production and living of local residents and health.To remove the rural pig farm pig manure smell of sewage and pollution, improve environmental quality in rural areas, promote agricultural economic development, Authors conscientiously sum up long been engaged in clean production and recycling economic development research experience, made a clean way of producing the pig industry and the recycling economy development model, aimed at prevention and control at source pollution, clean production and vigorously promote the pig farming industry and rural economy can be recycled sustainable development,and concern for clean production and recycling of China＇s pig counterparts reference of economic development.%近年来，我国养猪业发展迅速，农村经济增长较快，农民收入和生活水平明显提高。同时，养猪业产生的猪粪便污染日趋严重，已严重影响当地居民生产生活和身体健康。为了彻底消除农村养猪场猪粪便污水和臭味污染，改善农村环境质量，促进农业经济发展，总结了长期从事清洁生产和循环经济发展研究的实践经验，提出了养猪业清洁生产途径和循环经济发展模式，意在从源头预防控制污染，大力推进养猪业清洁生产与农村经济可循环持续发展，并供关心我国养猪清洁生产与循环经济发展的同行借鉴参考。

Characterization of fouling of membrane contactors

DEFF Research Database (Denmark)

Ciurkot, Kaludia; Zarebska, Agata; Christensen, Knud Villy

2013-01-01

of ammonia and membrane fouling tendency. The surface morphology of both clean and fouled membranes by model manure solution and undigested pig manure has been studied by: Optical and Atomic Force Microscopy and contact angle measurements. Based on the experimental results, it is concluded that real manure...... achieved higher ammonia removal than the synthetic model manure solution. This might be due to the larger particle size of the milled straw in the model solution compared to the size of suspended solids present in real manure. From the fouling autopsy, it was found that PTFE membranes are more prone...... to fouling than PP membranes. In both membranes the hydrophobicity decreased after running the process for 30 h, especially when undigested pig manure was used....

Partitioning washoff of manure-borne fecal indicators (Escherichia coli and stanols) into splash and hydraulic components: field rainfall simulations in a tropical agro-ecosystem.

Science.gov (United States)

Ribolzi, Olivier; Rochelle-Newall, Emma J.; Janeau, Jean-Louis; Viguier, Marion; Jardé, Emilie; Latsachack, Keooudone; Henri-Des-Tureaux, Thierry; Thammahacksac, Chanthamousone; Mugler, Claude; Valentin, Christian; Sengtaheuanghoung, Oloth

2017-04-01

Overland flow from manured fields and pastures is known to be an important mechanism by which organisms of faecal origin are transferred to streams in rural watersheds. In the tropical montane areas of South-East Asia, recent changes in land use have induced increased runoff, soil erosion, in-stream suspended sediment loads resulting in increased microbial pathogen dissemination and contamination of stream waters. The majority of enteric and environmental bacteria in aquatic systems are associated with particles such as sediments which can strongly influence their survival and transport characteristics. Escherichia coli (E. coli) has emerged as one of the most appropriate microbial indicators of faecal contamination of natural waters, with the presence of E. coli indicating that faecal contamination is present. In association with E. coli, faecal stanols can also be used as microbial source tracking tool for the identification of the origin of the faecal contamination (e.g. livestock, human, etc). Field rain simulations were used to examine how E.coli and stanols are exported from the surface of upland, agricultural soils during overland flow events. The objectives were to characterize the loss dynamics of these indicators from agricultural soils contaminated with livestock waste, and to partition total detachment into the splash and hydraulic components. Nine 1m2 microplots were divided in triplicated treatment groups: (a) controls with no amendments, (b) amended with pig manure or (c) poultry manure. Each plot was divided into two 0.5m2 rectangular subplots. For each simulation, one subplot was designated as a rain splash treatment; the other was covered with 2-mm grid size wire screen 10 cm above the soil surface to break the raindrops into fine droplets, thus drastically reducing their kinetic energy. E. coli concentrations in overland flow were estimated for both the attached and free living fractions and stanols were measured on the particulate matter washed

Potential use of gas sensors in beef manure nutrient content ...

African Journals Online (AJOL)

The purpose of this study was to develop a gas sensor array to estimate the manure nutrient contents. Three metal-oxide gas sensors including methane, ammonia and hydrogen sulfide were used. Forty manure samples were collected from four beef operations in Southwest North Dakota. Manure samples were sent to be ...

ANIMAL MANURE – REDUCED QUALITY BY ANAEROBIC DIGESTION?

DEFF Research Database (Denmark)

Løes, Anne-Kristin; Johansen, Anders; Pommeresche, Reidun

2014-01-01

Anaerobic digestion may reduce emissions of greenhouse gases, but we know little about its impact on soil fertility. Reduced concentrations of easily degradable C in the manure may imply less food for the soil fauna and microflora. A field experiment to study its effect on crop yields and soil...... caused the death of both surface-dwelling and soil-living earthworms shortly after application, but the long-term effect of manure application seemed more positive, especially at low application levels. So far, we have observed only small differences in the effects of digested and undigested manure...

Evaluation of quick tests for phosphorus determination in dairy manures

International Nuclear Information System (INIS)

Lugo-Ospina, A.; Dao, Thanh H.; Van Kessel, J.A.; Reeves, J.B.

2005-01-01

Nutrients in animal manure are valuable inputs in agronomic crop production. Rapid and timely information about manure nutrient content are needed to minimize the risks of phosphorus (P) over-application and losses of dissolved P (DP) in runoff from fields treated with manure. We evaluated the suitability of a commercial hand-held reflectometer, a hydrometer, and an electrical conductivity (EC) meter for determining DP and total P (TP) in dairy manures. Bulk samples (n = 107) collected from farms across CT, MD, NY, PA, and VA were highly variable in total solids (TS) concentration, ranging from 11 to 213 g L -1 , in suspensions' pH (6.3-9.2), and EC (6.2-53.3 dS m -1 ). Manure DP concentrations measured using the RQFlex reflectometer (RQFlex-DP s ) were related to molybdate-reactive P (MRP s ) concentrations as follows: RQFlex-DP s = 0.471 x MRP s + 1102 (r 2 = 0.29). Inclusion of pH and squared-pH terms improved the prediction of manure DP from RQFlex results (r 2 = 0.66). Excluding five outlier samples that had pH ≤ 6.9 the coefficient of determination (r 2 ) for the MRP s and RQFlex-DP s relationship was 0.83 for 95% of the samples. Manure TS were related to hydrometer specific gravity readings (r 2 = 0.53) that were in turn related to TP (r 2 = 0.34), but not to either RQFlex-DP or MRP. Relationships between suspensions' EC and DP or TP were non-significant. Therefore, the RQFlex method is the only viable option for on-site quick estimates of DP that can be made more robust when complemented with TS and pH measurements. The DP quick test can provide near real-time information on soluble manure nutrient content across a wide range of handling and storage conditions on dairy farms and quick estimates of potential soluble P losses in runoff following land applications of manure. - The dissolved phosphorous quick test can provide real-time information on soluble manure nutrient control

Inoculum and zeolite synergistic effect on anaerobic digestion of poultry manure.

Science.gov (United States)

Fotidis, Ioannis A; Kougias, Panagiotis G; Zaganas, Ioannis D; Kotsopoulos, Thomas A; Martzopoulos, Gerasimos G

2014-01-01

Poultry manure is an ammonia-rich substrate due to its high content of proteins and amino acids. Ammonia is the major inhibitor of anaerobic digestion (AD) process, affecting biogas production and causing great economic losses to the biogas plants. In this study, the effect of different natural zeolite dosages on the mesophilic AD of poultry manure inoculated with a non-acclimatized to ammonia inoculum (dairy manure) was investigated. Additionally, a comparative analysis was performed between the data extracted from this study and the results of a previous study, which has been conducted under the same experimental conditions but with the use of ammonia acclimatized inoculum (swine manure). At 5 and 10 g zeolite L(-1), the methane yield of poultry manure was 43.4% and 80.3% higher compared with the experimental set without zeolite addition. However, the ammonia non-acclimatized inoculum was not efficient in digesting poultry manure even in the presence of 10 g zeolite L(-1), due to low methane production (only 39%) compared with the maximum theoretical yield. Finally, ammonia acclimatized inoculum and zeolite have demonstrated a possible 'synergistic effect', which led to a more efficient AD of poultry manure. The results of this study could potentially been used by the biogas plant operators to efficiently digest poultry manure.

Thermochemical conversion of biomass storage covers to reduce ammonia emissions from dairy manure Thermochemical conversion of biomass storage covers to reduce ammonia emissions from dairy manure

Science.gov (United States)

Manure storages, and in particular those storing digested manure, are a source of ammonia (NH3) emissions. Permeable manure storage covers can reduce NH3 emissions, however performance can decline as they degrade. Thermochemical conversion of biomass through pyrolysis and steam treatment could incre...

Impacts of manure application on SWAT model outputs in the Xiangxi River watershed

Science.gov (United States)

Liu, Ruimin; Wang, Qingrui; Xu, Fei; Men, Cong; Guo, Lijia

2017-12-01

SWAT (Soil and Water Assessment Tool) model has been widely used to simulate agricultural non-point source (ANPS) pollution; however, the impacts of livestock manure application on SWAT model outputs have not been well studied. The objective of this study was to investigate the environmental effects of livestock manure application based on the SWAT model in the Xiangxi River watershed, which is one of the largest tributaries of the Three Gorges Reservoir in China. Three newly-built manure databases (NB) were created and applied to different subbasins based on the actual livestock manure discharging amount. The calibration and validation values of SWAT model outputs obtained from the NB manure application and the original mixed (OM) manure were compared. The study results are as follows: (1) The livestock industry of Xingshan County developed quickly between 2005 and 2015. The downstream of the Xiangxi River (Huangliang, Shuiyuesi and Xiakou) had the largest livestock amount, and largely accounted for manure, total nitrogen (TN) and total phosphorus (TP) production (>50%). (2) The NB manure application resulted in less phosphorus pollution (1686.35 kg for ORGP and 31.70 kg for MINP) than the OM manure application. Compared with the upstream, the downstream was influenced more by the manure application. (3) The SWAT results obtained from the NB manure had a better calibration and validation values than those from the OM manure. For ORGP, R2 and NSE values were 0.77 and 0.65 for the NB manure calibration; and the same values for the OM manure were 0.72 and 0.61, respectively. For MINP, R2 values were 0.65 and 0.62 for the NB manure and the OM manure, and the NSE values were 0.60 and 0.58, respectively. The results indicated that the built-in fertilizer database in SWAT has its limitation because it is set up for the simulation in the USA. Thus, when livestock manure is considered in a SWAT simulation, a newly built fertilizer database needs to be set up to represent

Effect of farmyard manure after methane fermentation in the light of field experiments

Energy Technology Data Exchange (ETDEWEB)

Kuzelewski, L; Pentkowski, A

1961-01-01

Yard manure after CH/sub 4/ fermentation was compared with manure kept in a manure pit with respect to composition and the effect on the crop, in both pot and field experiments. CH/sub 4/ fermentation reduced N losses of fresh manure and made for more easily assimilable N compounds. However, the first year and after-effects on crops of both types of manure were the same. No differences were noted for fermented manure due to ploughing over as compared to mere spreading on the soil.

Effect of manure vs. fertilizer inputs on productivity of forage crop models.

Science.gov (United States)

Annicchiarico, Giovanni; Caternolo, Giovanni; Rossi, Emanuela; Martiniello, Pasquale

2011-06-01

Manure produced by livestock activity is a dangerous product capable of causing serious environmental pollution. Agronomic management practices on the use of manure may transform the target from a waste to a resource product. Experiments performed on comparison of manure with standard chemical fertilizers (CF) were studied under a double cropping per year regime (alfalfa, model I; Italian ryegrass-corn, model II; barley-seed sorghum, model III; and horse-bean-silage sorghum, model IV). The total amount of manure applied in the annual forage crops of the model II, III and IV was 158, 140 and 80 m3 ha(-1), respectively. The manure applied to soil by broadcast and injection procedure provides an amount of nitrogen equal to that supplied by CF. The effect of manure applications on animal feeding production and biochemical soil characteristics was related to the models. The weather condition and manures and CF showed small interaction among treatments. The number of MFU ha(-1) of biomass crop gross product produced in autumn and spring sowing models under manure applications was 11,769, 20,525, 11,342, 21,397 in models I through IV, respectively. The reduction of MFU ha(-1) under CF ranges from 10.7% to 13.2% those of the manure models. The effect of manure on organic carbon and total nitrogen of topsoil, compared to model I, stressed the parameters as CF whose amount was higher in models II and III than model IV. In term of percentage the organic carbon and total nitrogen of model I and treatment with manure was reduced by about 18.5 and 21.9% in model II and model III and 8.8 and 6.3% in model IV, respectively. Manure management may substitute CF without reducing gross production and sustainability of cropping systems, thus allowing the opportunity to recycle the waste product for animal forage feeding.

SWINE MANURE SOLIDS SEPARATION AND THERMOCHEMICAL CONVERSION TO HEAVY OIL

Directory of Open Access Journals (Sweden)

Shuangning Xiu

2009-05-01

Full Text Available Separation of solids from liquid swine manure and subsequent thermo-chemical conversion (TCC of the solids fraction into oil is one way of reducing the waste strength and odor emission. Such processing also provides a potential means of producing renewable energy from animal wastes. Gravity settling and mechanical separation techniques, by means of a centrifuge and belt press, were used to remove the solids from liquid swine manure. The solid fractions from the above separation processes were used as the feedstock for the TCC process for oil production. Experiments were conducted in a batch reactor with a steady temperature 305 oC, and the corresponding pressure was 10.34 Mpa. Gravity settling was demonstrated to be capable of increasing the total solids content of manure from 1% to 9%. Both of the mechanical separation systems were able to produce solids with dry matter around 18% for manure, with 1% to 2% initial total solids. A significant amount of volatile solid (75.7% was also obtained from the liquid fraction using the belt press process. The oil yields of shallow pit manure solids and deep pit manure solids with belt press separation were 28.72% and 29.8% of the total volatile solids, respectively. There was no visible oil product obtained from the deep pit manure solids with centrifuge separation. It is believed that it is the volatile solid content and the other components in the manure chemical composition which mainly deter-mine the oil production.

Structure, dynamics and movement patterns of the Australian pig industry.

Science.gov (United States)

East, I J; Davis, J; Sergeant, E S G; Garner, M G

2014-03-01

To assess management practices and movement patterns that could influence the establishment and spread of exotic animal diseases (EAD) in pigs in Australia. A literature review of published information and a telephone survey of 370 pig producers owning >10 pigs who were registered with the PigPass national vendor declaration scheme. The movement and marketing patterns of Australian pig producers interviewed were divided into two groups based predominantly on the size of the herd. Major pig producers maintain closed herds, use artificial insemination and market direct to abattoirs. Smaller producers continue to purchase from saleyards and market to other farms, abattoirs and through saleyards in an apparently opportunistic fashion. The role of saleyards in the Australian pig industry continues to decline, with 92% of all pigs marketed directly from farm to abattoir. This survey described movement patterns that will assist in modelling the potential spread of EAD in the Australian pig industry. Continued movement towards vertical integration and closed herds in the Australian pig industry effectively divides the industry into a number of compartments that mitigate against the widespread dissemination of disease to farms adopting these practices. © 2014 Australian Veterinary Association.

The economics of energy from animal manure for greenhouse gas mitigation

Science.gov (United States)

Ghafoori, Emad

2007-12-01

Anaerobic digestion (AD) has significant economies of scale, i.e. per unit processing costs decrease with increasing size. The economics of AD to produce biogas and in turn electric power in farm or feedlot based units as well as centralized plants is evaluated for two settings in Alberta: a mixed farming area, Red Deer County, and an area of concentrated beef cattle feedlots, Lethbridge County. A centralized plant drawing manure from 61 sources in the mixed farming area could produce power at a cost of 218 MWh-1 (2005 US). A centralized plant drawing manure from 560,000 beef cattle in Lethbridge County, can produce power at a cost of 138 MWh-1. Digestate processing, if commercially available, shifts the balance in favor of centralized processing. At larger scales, pipelines could be used to deliver manure to a centralized plant and return the processed digestate back to the manure source for spreading. Pipeline transport of beef cattle manure is more economic than truck transport for the manure produced by more than 90,000 animals. Pipeline transport of digestate is more economic when manure from more than 21,000 beef cattle is available and two-way pipelining of manure plus digestate is more economic when manure from more than 29,000 beef cattle is available. The value of carbon credits necessary to make AD profitable in a mixed farming region is also calculated based on a detailed analysis of manure and digestate transport and processing costs at an AD plant. Carbon emission reductions from power generation are calculated for displacement of power from coal and natural gas. The required carbon credit to cover the cost of AD processing of manure is greater than 150 per tonne of CO2. These results show that AD treatment of manure from mixed farming areas is not economic given current values of carbon credits. Power from biogas has a high cost relative to current power prices and to the cost of power from other large scale renewable sources. Power from biogas would

The economics of energy from animal manure for greenhouse gas mitigation

International Nuclear Information System (INIS)

Ghafoori, E.

2008-01-01

This study examined the economic feasibility of using anaerobic digestion to produce biogas for the purpose of generating electricity. Centralized plants in 2 settings in Alberta were evaluated, notably a mixed farming area in Red Deer County and an area of concentrated beef cattle feedlots in Lethbridge County. The cost of producing power at a centralized plant drawing manure from 61 sources in the mixed farming area was shown to be nearly double the cost of producing power at a centralized plant drawing manure from 560,000 beef cattle in Lethbridge County. Digestate processing shifts the balance in favour of centralized processing. At larger scales, pipelines could be used to transport manure to a centralized plant and return the processed digestate back to the manure source for spreading. Pipeline transport is more economic than truck transport in cases where manure is produced by more than 90,000 animals. Pipeline transport of digestate is more economic when manure from more than 21,000 beef cattle is available and two-way pipelining of manure plus digestate is more economic when manure from more than 29,000 beef cattle is available. The value of carbon credits needed to make AD profitable in a mixed farming region was calculated based on an analysis of manure and digestate transport and processing costs. Carbon emission reductions from power generation were calculated for displacement of power from coal and natural gas. The carbon credit needed to cover the cost of AD processing of manure is greater than $150 per tonne of carbon dioxide, indicating that AD treatment of manure from mixed farming areas is not economic given current values of carbon credits. It was concluded that power generated from biogas has a high cost compared to current power prices and the cost of power from other large scale renewable sources. As such, factors other than energy value, such as phosphate, pathogen or odour control would have to be considered in order to justify power

Low-disturbance manure application methods in a corn silage-rye cover crop system

Science.gov (United States)

Incorporation of manure by tillage can conserve manure N by reducing ammonia volatilization losses, but tillage also incorporates crop residue, which increases erosion potential. This study compared several low-disturbance manure application methods, designed to incorporate manure while still mainta...

Anaerobic digestion of manure - consequences for plant production

DEFF Research Database (Denmark)

Løes, Anne-Kristin; Pommeresche, Reidun; Johansen, Anders

2013-01-01

Organic farming systems are today dependent upon fossil energy. Another challenge are soil nutrient concentrations, which may be depleted with time even in animal husbandry systems (Løes & Øgaard 2001). Anaerobic digestion (AD) of animal manure may produce biogas to replace fossil fuels, and reduce...... methane (CH4) emissions during manure storage. Co-digestion of substrates rich in energy increases the economic viability of the biogas plant, and off-farm substrates such as fish silage or household waste may add nutrients to the farming system. AD may also ease manure handling, while reducing the amount...

Transformations of manure during the course of an experiment on the production of gas from manure

Energy Technology Data Exchange (ETDEWEB)

Coppenet, M; Ducet, G

1948-01-01

A concrete vat was filled with a mixture of horse and cow manure and liquid manure and fermented for 106 days at 28--30/sup 0/C. A daily average of 524 liters gas/tonne was produced, the gas consisting of equal parts CO/sub 2/ and CH/sub 4/, with H/sub 2/ varying from almost none to 25%. It was determined that the gas was produced by the destruction of cellulose and pentosans with little contribution from the lignins and humic acids.

An Overview of the Control of Bacterial Pathogens in Cattle Manure

Directory of Open Access Journals (Sweden)

Christy E. Manyi-Loh

2016-08-01

Full Text Available Cattle manure harbors microbial constituents that make it a potential source of pollution in the environment and infections in humans. Knowledge of, and microbial assessment of, manure is crucial in a bid to prevent public health and environmental hazards through the development of better management practices and policies that should govern manure handling. Physical, chemical and biological methods to reduce pathogen population in manure do exist, but are faced with challenges such as cost, odor pollution, green house gas emission, etc. Consequently, anaerobic digestion of animal manure is currently one of the most widely used treatment method that can help to salvage the above-mentioned adverse effects and in addition, produces biogas that can serve as an alternative/complementary source of energy. However, this method has to be monitored closely as it could be fraught with challenges during operation, caused by the inherent characteristics of the manure. In addition, to further reduce bacterial pathogens to a significant level, anaerobic digestion can be combined with other methods such as thermal, aerobic and physical methods. In this paper, we review the bacterial composition of cattle manure as well as methods engaged in the control of pathogenic microbes present in manure and recommendations that need to be respected and implemented in order to prevent microbial contamination of the environment, animals and humans.

Vacuum pyrolysis of swine manure : biochar production and characteristics

Energy Technology Data Exchange (ETDEWEB)

Verma, M. [Inst. de recherche et de developpement en agroenvironnement Inc., Quebec City, PQ (Canada); Centre de recherche industrielle du Quebec, Quebec City, PQ (Canada); Godbout, S.; Larouche, J.P.; Lemay, S.P.; Pelletier, F. [Inst. de recherche et de developpement en agroenvironnement Inc., Quebec City, PQ (Canada); Solomatnikova, O. [Centre de recherche industrielle du Quebec, Quebec City, PQ (Canada); Brar, S.K. [Inst. national de la recherche scientifique, eau, terre et environnement, Quebec City, PQ (Canada)

2010-07-01

Quebec accounts for nearly 25 per cent of swine production in Canada. The issue of swine manure is addressed through land spreading and conversion into fertilizer. However, current regulations restrict the use of swine manure as fertilizer on most farmlands due to the problem of surplus phosphorus and nitrogen. Although many technologies exist to separate phosphorus and nitrogen from the organic-rich dry matter in swine manure, about 40 per cent of the treated waste matter must still be disposed in an environmentally sound manner. This study investigated the technical feasibility of pretreating the swine manure solids into biofuels on a farm-scale basis using vacuum pyrolysis process. A custom built stainless steel pressure vessel was used to carry out pyrolysis reaction of swine manure biomass at a temperature range between 200 to 600 degrees C under vacuum. The pyrolytic vapour was condensed in 2 glass condensers in series. The biochar was collected directly from the pyrolysis vessel following completion of the pyrolysis batch. The non condensable vapour and gases were considered as losses. Biochar, bio-oil, an aqueous phase and a gas mixture were the 4 products of the pyrolysis process. A thermogravimetric analysis of the swine manure samples was conducted before the pyrolysis tests. The study showed that 238 degrees C is the optimal pyrolysis temperature for biochar production.

Cama sobreposta e dejetos líquidos de suínos como fonte de nitrogênio ao milho Deep-Litter and pig slurry as nitrogen sources for corn

Directory of Open Access Journals (Sweden)

Sandro José Giacomini

2008-02-01

cama sobreposta e dos dejetos líquidos foi de 10,9 e 22,1 %, respectivamente. Os resultados deste trabalho mostram que, embora a aplicação da cama sobreposta tenha aumentado o fornecimento de N e a produtividade de grãos de milho em relação ao tratamento sem adubação, o seu efeito imediato como fonte de N ao milho é menor que o encontrado quando é feita a aplicação de dejetos líquidos de suínos ou uréia.Most of the pig manure generated in the swine production in southern Brazil is handled and stored as liquid manure, but there is a growing interest in adopting the deep-litter production system and using the resulting organic material as fertilizer. A field experiment was carried out on a typic Hapludalf in an experimental area of the Universidade Federal de Santa Maria, Santa Maria, state of Rio Grande do Sul, from October 2002 to March 2003, to evaluate the soil N dynamics and nitrogen fertilization potential of deep-litter and pig slurry for corn production. The treatments consisted of the application or non-application of pig slurry and deep-litter manure on oat straw, with and without incorporation into the soil. One additional treatment was evaluated, in which mineral fertilizer (NPK was applied without incorporation. The doses of deep-litter (13,2 Mg ha-1 and pig slurry (63,6 m³ ha-1 was equivalent to the application of 140 kg ha-1 N. In the soil, mineral N (N-NH4+ and N-NO2- + N-NO3- was evaluated in six dates for the layers 0-10, 10-30, 30-60, and 60-90 cm. Corn grain yield and dry matter (DM production and total N uptake were evaluated. The soil mineral N availability in the treatments with pig slurry application was higher than in the deep-litter treatments, indicating a low mineralization rate of organic N in deep-litter. Deep-litter manure and pig slurry promoted higher corn N uptake and DM production and corn grain yield as compared to the treatment without application of organic residues. The corn grain yield increments were 54 and 253

Anaerobic digestion of swine manure: Inhibition by ammonia

DEFF Research Database (Denmark)

Hansen, Kaare Hvid; Angelidaki, Irini; Ahring, Birgitte Kiær

1998-01-01

A stable anaerobic degradation of swine manure with ammonia concentration of 6 g-N/litre was obtained in continuously stirred tank reactors with a hydraulic retention time of 15 days, at Four different temperatures. Methane yields of 188, 141, 67 and 22 ml-CH4/g-VS were obtained at 37, 45, 55...... and 60 degrees C, respectively. The yields were significantly lower than the potential biogas yield of the swine manure used (300 ml-CH4/g-VS). A free ammonia concentration of 1.1 g-N/litre or more was found to cause inhibition in batch cultures at pH 8.0 (reactor pH), and higher free ammonia...... concentrations resulted in a decreased apparent specific growth rate. Batch experiments with various mixtures of swine and cattle manure showed that the biogas process was inhibited when the swine-to-cattle manure ratio was higher than 25:75, corresponding to a free ammonia concentration of approximately 1.1 g...

Evaluation of quick tests for phosphorus determination in dairy manures

Energy Technology Data Exchange (ETDEWEB)

Lugo-Ospina, A. [Animal Manure and By-Products Laboratory, BARC East, Beltsville, MD 20705 (United States); Dao, Thanh H. [Animal Manure and By-Products Laboratory, BARC East, Beltsville, MD 20705 (United States); Van Kessel, J.A. [Animal Waste Pathogens Laboratory, BARC East, Beltsville, MD 20705 (United States); Reeves, J.B. [Animal Manure and By-Products Laboratory, BARC East, Beltsville, MD 20705 (United States)]. E-mail: jreeves@anri.barc.usda.gov

2005-05-01

Nutrients in animal manure are valuable inputs in agronomic crop production. Rapid and timely information about manure nutrient content are needed to minimize the risks of phosphorus (P) over-application and losses of dissolved P (DP) in runoff from fields treated with manure. We evaluated the suitability of a commercial hand-held reflectometer, a hydrometer, and an electrical conductivity (EC) meter for determining DP and total P (TP) in dairy manures. Bulk samples (n = 107) collected from farms across CT, MD, NY, PA, and VA were highly variable in total solids (TS) concentration, ranging from 11 to 213 g L{sup -1}, in suspensions' pH (6.3-9.2), and EC (6.2-53.3 dS m{sup -1}). Manure DP concentrations measured using the RQFlex reflectometer (RQFlex-DP{sub s}) were related to molybdate-reactive P (MRP{sub s}) concentrations as follows: RQFlex-DP{sub s} = 0.471 x MRP{sub s} + 1102 (r{sup 2} = 0.29). Inclusion of pH and squared-pH terms improved the prediction of manure DP from RQFlex results (r{sup 2} = 0.66). Excluding five outlier samples that had pH {<=} 6.9 the coefficient of determination (r{sup 2}) for the MRP{sub s} and RQFlex-DP{sub s} relationship was 0.83 for 95% of the samples. Manure TS were related to hydrometer specific gravity readings (r{sup 2} = 0.53) that were in turn related to TP (r{sup 2} = 0.34), but not to either RQFlex-DP or MRP. Relationships between suspensions' EC and DP or TP were non-significant. Therefore, the RQFlex method is the only viable option for on-site quick estimates of DP that can be made more robust when complemented with TS and pH measurements. The DP quick test can provide near real-time information on soluble manure nutrient content across a wide range of handling and storage conditions on dairy farms and quick estimates of potential soluble P losses in runoff following land applications of manure. - The dissolved phosphorous quick test can provide real-time information on soluble manure nutrient control.

Method for extraction of proteins and phosphate minerals from swine manure

Science.gov (United States)

The recovery of phosphorus and proteins from manure could be advantageous to both offset costs and to improve and lessen the environmental impacts of manure storage and treatment. Phosphorous in manure can contaminate rivers, lakes, and bays through runoff, if applied onto a cropland excessively. Th...

Effects of cattle and poultry manures on organic matter content and ...

African Journals Online (AJOL)

The organic fertilizer showed significant effect on earthworms populations Hyperiodrilus africanus (Oligochaeta, Eudrilidae) in the soil, with 128 and 85% respectively about the poultry and cattle manures compared to the control (p < 0.01). Key words: Cattle manure, poultry manure, cassava, organic matter, cation exchange ...

Liming Poultry Manures to Kill Pathogens and Decrease Soluble Phosphorus

International Nuclear Information System (INIS)

Maguire, R.; Hesterberg, D.; Gernat, A.; Anderson, K.; Wineland, M.; Grimes, J.

2006-01-01

Received for publication September 9, 2005. Stabilizing phosphorus (P) in poultry waste to reduce P losses from manured soils is important to protect surface waters, while pathogens in manures are an emerging issue. This study was conducted to evaluate CaO and Ca(OH) 2 for killing manure bacterial populations (pathogens) and stabilizing P in poultry wastes and to investigate the influence on soils following amendment with the treated wastes. Layer manure and broiler litter varying in moisture content were treated with CaO and Ca(OH) 2 at rates of 2.5, 5, 10, and 15% by weight. All treated wastes were analyzed for microbial plate counts, pH, and water-soluble phosphorus (WSP), while a few selected layer manures were analyzed by phosphorus X-ray absorption near edge structure (XANES). A loamy sand and a silt loam were amended with broiler litter and layer manure treated with CaO at rates of 0, 2.5, 5, 10, and 15% and soil WSP and pH were measured at times 1, 8, and 29 d. Liming reduced bacterial populations, with greater rates of lime leading to greater reductions; for example 10% CaO applied to 20% solids broiler litter reduced the plate counts from 793 000 to 6500 mL -1 . Liming also reduced the WSP in the manures by over 90% in all cases where at least 10% CaO was added. Liming the manures also reduced WSP in soils immediately following application and raised soil pH. The liming process used successfully reduced plate counts and concerns about P losses in runoff following land application of these limed products due to decreased WSP

Tissue integration of polyacrylamide hydrogel: an experimental study of periurethral, perivesical, and mammary gland tissue in the pig

DEFF Research Database (Denmark)

Christensen, Lise H; Nielsen, John B; Mouritsen, Lone

2008-01-01

BACKGROUND Polyacrylamide hydrogel (PAAG) is a nondegradable water-based polymer with high viscoelasticity. The gel is used as a tissue filler, the only risk being prolonged infection with anaerobic, contaminating microorganisms if not treated early with broad-spectrum antibiotics. OBJECTIVE...... With silicone gel as reference, PAAG tissue integration and migration was studied in a longitudinal study of the pig. MATERIALS AND METHODS Forty-one pigs were used. PAAG and silicone gel were injected into mammary tissue, and PAAG was injected into urethral or bladder wall or the anal canal. Tissues...... and regional lymph nodes were examined at 1, 1 1/2, 3, 3 1/2, 6, 12, and 14 months, and other lymph nodes and organs were examined at 1, 6, 12, and 14 months. RESULTS PAAG was invaded by macrophages and giant cells that were gradually replaced by a network of fibrous tissue. Silicone gel was seen inside...

Energy conversion of animal manures: Feasibility analysis for thirteen western states

Energy Technology Data Exchange (ETDEWEB)

Whittier, J.; Haase, S.; Milward, R.; Churchill, G.; Searles, M.B. [NEOS Corp., Lakewood, CO (United States); Moser, M. [Resource Conservation Management, Inc., Berkeley, CA (United States); Swanson, D.; Morgan, G. [Western Regional Biomass Energy Program, Golden, CO (United States)

1993-12-31

The growth and concentration of the livestock industry has led to environmental disposal problems for large quantities of manure at feedlots, dairies, poultry production plants, animal holding areas and pasturelands. Consequently, waste management systems that facilitate energy recovery are becoming increasingly attractive since they address pollution problems and allow for energy generation from manure resources. This paper presents a manure resource assessment for the 13 US Department of Energy, Western Regional Biomass Energy Program states, describes and evaluates available energy conversion technologies, identifies environmental and regulatory factors associated with manure collection, storage and disposal, and identifies common disposal practices specific to animal types and areas within the WRBEP region. The paper also presents a pro forma economic analysis for selected manure-to-energy conversion technologies. The annual energy potential of various manures within the WRBEP region is equivalent to approximately 111 {times} 10{sup 13} Btu. Anaerobic digestion systems, both lagoon and plug flow, offer positive economic returns in a broad range of utility service territories.

Life Cycle Assessment of Horse Manure Treatment

Directory of Open Access Journals (Sweden)

Ola Eriksson

2016-11-01

Full Text Available Horse manure consists of feces, urine, and varying amounts of various bedding materials. The management of horse manure causes environmental problems when emissions occur during the decomposition of organic material, in addition to nutrients not being recycled. The interest in horse manure undergoing anaerobic digestion and thereby producing biogas has increased with an increasing interest in biogas as a renewable fuel. This study aims to highlight the environmental impact of different treatment options for horse manure from a system perspective. The treatment methods investigated are: (1 unmanaged composting; (2 managed composting; (3 large-scale incineration in a waste-fired combined heat and power (CHP plant; (4 drying and small-scale combustion; and (5 liquid anaerobic digestion with thermal pre-treatment. Following significant data uncertainty in the survey, the results are only indicative. No clear conclusions can be drawn regarding any preference in treatment methods, with the exception of their climate impact, for which anaerobic digestion is preferred. The overall conclusion is that more research is needed to ensure the quality of future surveys, thus an overall research effort from horse management to waste management.

Increased Foraging in Outdoor Organic Pig Production—Modeling Environmental Consequences

Directory of Open Access Journals (Sweden)

Malene Jakobsen

2015-11-01

Full Text Available Consumers’ motivations for buying organic products include a wish of acquiring healthy, environmentally friendly products from production systems that also ensure a high level of animal welfare. However, the current Danish organic pig production faces important challenges regarding environmental impact of the system. High ammonia emissions arise from outdoor concrete areas with growing pigs and sows on pasture possess an increased risk of nitrogen (N leaching. Direct foraging in the range area is suggested as a way to improve the nutrient efficiency at farm level and to support a more natural behavior of the pig. Thus, by modeling, we investigated the environmental consequences of two alternative scenarios with growing pigs foraging in the range area and different levels of crops available for foraging—grass–clover or a combination of Jerusalem artichokes and lucerne. It was possible to have growing pigs on free-range without increasing N leaching compared to the current practice. The alternative system with Jerusalem artichokes and lucerne (high integration of forage showed the lowest carbon foot print with 3.12 CO2 eq kg−1 live weight pig compared to the current Danish pasture based system with 3.69 kg CO2 eq kg−1 live weight pig. Due to positive impact on soil carbon sequestration, the second alternative system based on grass-clover (low integration of forage showed a similar carbon foot print compared to current practice with 3.68 kg CO2 eq kg−1 live weight pig. It is concluded that in practice there is room for development of organic farming systems where direct foraging plays a central role.

Effect of Manure vs. Fertilizer Inputs on Productivity of Forage Crop Models

Directory of Open Access Journals (Sweden)

Pasquale Martiniello

2011-06-01

Full Text Available Manure produced by livestock activity is a dangerous product capable of causing serious environmental pollution. Agronomic management practices on the use of manure may transform the target from a waste to a resource product. Experiments performed on comparison of manure with standard chemical fertilizers (CF were studied under a double cropping per year regime (alfalfa, model I; Italian ryegrass-corn, model II; barley-seed sorghum, model III; and horse-bean-silage sorghum, model IV. The total amount of manure applied in the annual forage crops of the model II, III and IV was 158, 140 and 80 m3 ha−1, respectively. The manure applied to soil by broadcast and injection procedure provides an amount of nitrogen equal to that supplied by CF. The effect of manure applications on animal feeding production and biochemical soil characteristics was related to the models. The weather condition and manures and CF showed small interaction among treatments. The number of MFU ha−1 of biomass crop gross product produced in autumn and spring sowing models under manure applications was 11,769, 20,525, 11,342, 21,397 in models I through IV, respectively. The reduction of MFU ha−1 under CF ranges from 10.7% to 13.2% those of the manure models. The effect of manure on organic carbon and total nitrogen of topsoil, compared to model I, stressed the parameters as CF whose amount was higher in models II and III than model IV. In term of percentage the organic carbon and total nitrogen of model I and treatment with manure was reduced by about 18.5 and 21.9% in model II and model III and 8.8 and 6.3% in model IV, respectively. Manure management may substitute CF without reducing gross production and sustainability of cropping systems, thus allowing the opportunity to recycle the waste product for animal forage feeding.

Impact of Anaerobic Digestion of Liquid Dairy Manure on Ammonia Volatilization Process

Science.gov (United States)

Koirala, K.

2013-12-01

The goal of this study was to determine the effect of anaerobic digestion (AD) on the mechanism of ammonia volatilization from liquid dairy manure, in storage or treatment lagoon, prior to land application. Physical-chemical properties of liquid dairy manure, which may affect ammonia volatilization process, were determined before and after AD. The properties of interest included: particle size distribution (PSD), total solids (TS), volatile solids (VS), viscosity, pH, total ammoniacal nitrogen (TAN), and ionic strength (IS). The overall mass transfer coefficient of ammonia (KoL) and the NH3 fraction of TAN (β) for the undigested (UD) and AD manures were then experimentally determined in a laboratory convective emission chamber (CEC) at a constant wind speed of 1.5 m s-1 and fixed air temperature of 25 °C at liquid manure temperatures of 15, 25, and 35 °C. The PSD indicated non-normal left skewed distribution for both AD and UD manures particles, suggestive of heavier concentrations of particles towards the lower particle size range. The volume median diameters (VMD) for solids from UD and AD were not significantly different (p= 0.65), but the geometric standard deviations (GSD) were significantly different (p = 0.001), indicating slightly larger particles but more widely distributed solids in UD than AD manure. Results also indicated significantly higher pH, TAN, ionic strength (IS) and viscosity in AD manure. The KoL and β for AD manure determined under identical conditions (air temperature, liquid temperature, and airflow) were significantly higher (p > 0.05) than for UD manure. Overall, these findings suggest that AD of dairy manure significantly increased initial ammonia volatilization potential from liquid dairy manure; with the largest increase (~62%) emanating from increased ammonium dissociation. The initial flux of ammonia, during the experiment period, was ~84% more from AD than in UD dairy manure. Keywords. Process based models, mass transfer

Technologies and logistics for handling, transport and distribution of animal manures

Science.gov (United States)

Organizing and managing the whole manure handling chain from the animal house through transport to the point of use (e.g. in the field) is a challenging task requiring consideration of manure type and operating conditions. Solid and liquid manure must be handled differently, using very different tec...

Optimization of Aqueous Ammonia Soaking of manure fibers by Response Surface Methodology for unlocking the methane potential of swine manure.

Science.gov (United States)

Lymperatou, Anna; Gavala, Hariklia N; Skiadas, Ioannis V

2017-11-01

Swine manure mono-digestion often results to economically non-feasible processes, due to the high dilution and ammonia concentration together with the low degradation rates it presents. The effects of different parameters of Aqueous Ammonia Soaking (AAS) as a pretreatment for improving the digestion of manure fibers when coupled to an ammonia removal step were investigated in this study. Response Surface Methodology was followed and the influence and interactions of the following AAS parameters were studied: NH 3 concentration, duration and solid-to-liquid ratio. The mild conditions found to be optimal (7%w/w NH 3 , 96h, and 0.16kg/L) in combination to a significant increase of the short term CH 4 yield (244% in 17days), make this pretreatment a promising solution for improving swine manure mono-digestion. Furthermore, compositional analysis of the manure fibers revealed significant solubilization of hemicellulose, while no lignin removal or loss of cellulose occurred under optimal conditions. Copyright © 2017 The Authors. Published by Elsevier Ltd.. All rights reserved.

Bioconversion of organic wastes for fuel and manure

International Nuclear Information System (INIS)

Jain, M.C.

1993-01-01

Major source of fuel in rural areas is still fire wood, cowdung and crop residues. Cowdung and crop residues can be effectively used as manure too. Bioconversion of organic wastes for fuel and manure can solve the twin problems. The paper deals with various kinds of organic wastes used as fuel, manure and for both, other organic wastes as alternate and supplemental feedstocks, impact of their bioconversion on rural energy and environment, dry fermentation technology, manurial value of the biogas slurry, etc. Important constraints in popularizing the biogas programme have been mentioned and their remedial measures have also been suggested. (author). 32 refs., 4 tabs., 3 figs

Quality of shallow groundwater and manure effluents in a livestock farm

Directory of Open Access Journals (Sweden)

Smoroń Sylwester

2016-06-01

Full Text Available The aim of the study was to assess the quality of shallow groundwater on the site pens and runoff from livestock manure heaps, in three selected farms involved in animal production and vegetable crops in the area of Plateau Proszowice. The analysis mainly included water from farm wells and effluents from manure. Additionally, water from drainage ditch running nearby farms was collected, before inflow of effluent (i.e. ditch water without manure effluent and below inflow of effluent from heap of manure (i.e. ditch water containing manure effluent. Samples of the research material were collected from April 2012 to March 2014 at monthly intervals and analysed for the content of NO3-N, NH4-N, PO4-P, K, Na and Cl. Based on the obtained results it was found that water from the farm wells near the livestock buildings and from manure storage sites, was heavily polluted by the majority of these contaminants. The highest concentration of these pollutants, except for the NO3-N, was found in manure effluent – it exceeded a few dozen to a few hundred to any standards for water quality. There was also a significant deterioration in the quality of drainage ditch water because of the penetration of contaminants into ditch water from heaps of improperly stored manure. The water of the farm wells was characterized by excessive concentrations of NO3-N which disqualified it for drinking purposes.

An Assessment Tool applied to Manure Management Systems using Innovative Technologies

DEFF Research Database (Denmark)

Sørensen, Claus Aage Grøn; Jacobsen, B.H.; Sommer, Sven Gjedde

2003-01-01

of operational and cost-effective animal manure handling technologies. An assessment tool covering the whole chain of the manure handling system from the animal houses to the field has been developed. The tool enables a system-oriented evaluation of labour demand, machinery capacity and costs related......In Denmark, stringent new regulations, placing strict time limits on manure application and setting thresholds for nitrogen utilisation, have been imposed in order to increase the efficiency of uptake of plant nutrients from manure. An important factor in meeting these requirements is the use...

Methane Recovery from Animal Manures The Current Opportunities Casebook

Energy Technology Data Exchange (ETDEWEB)

Lusk, P.

1998-09-01

Growth and concentration of the livestock industry create opportunities for the proper disposal of the large quantities of manures generated at dairy, swine, and poultry farms. Pollutants from unmanaged livestock wastes can degrade the environment, and methane emitted from decomposing manure may contribute to global climate change. One management system not only provides pollution prevention but also can convert a manure problem into a new profit center. Economic evaluations and case studies of operating systems indicate that the anaerobic digestion (AD) of livestock manures is a commercially available bioconversion technology with considerable potential for providing profitable coproducts, including a cost-effective renewable fuel for livestock production operations. This Casebook examines some of the current opportunities for the recovery of methane from the AD animal manures. U.S. livestock operations currently employ four types of anaerobic digester technology: slurry, plug-flow, complete-mix, and covered lagoon. An introduction to the engineering economies of these technologies is provided, and possible end-use applications for the methane gas generated by the digestion process are discussed. The economic evaluations are based on engineering studies of digesters that generate electricity from the recovered methane. Case studies of operating digesters, with project and maintenance histories and the operators ''lessons learned,'' are included as reality checks. Factors necessary for successful projects, as well as a list of reasons explaining why some AD projects fail, are provided. The role of farm management is key; not only must digesters be well engineered and built with high-quality components, they must also be sited at farms willing to incorporate the uncertainties of a new technology. More than two decades of research has provided much information about how manure can be converted to an energy source; however, the American farmer has

Ultimate methane yield from beef cattle manure: effect of temperature, ration constituents, antibiotics and manure age

Energy Technology Data Exchange (ETDEWEB)

Hashimoto, A G; Varel, V H; Chen, Y R

1981-10-01

The effects of temperature, ration constituents, antibiotics and manure age on the ultimate methane yield (Bo, litre CH4/g volatile solids fed (VSf)) were investigated using 4-litre batch fermenters. The average Bo for fermenters maintained at 30-60 degrees Celcius (at 5 degrees Celcius intervals) was 0.328 litre CH4/g VSf. The Bo at 65 degrees Celcius averaged 0.118 litre CH4g VSf, but this low yield was attributed to unstable fermentation rather than decreased substrate availability at that temperature. These results agreed well with Bo values estimated from daily-fed fermenters. Chlortetracycline and monensin did not affect Bo; however, monensin did delay the start of active fermentation in batch fermenters. The average Bo of manure from cattle fed 91.5, 40 and 7% corn silage were 0.173, 0.232 and 0.290 litre CH4/g VSf, respectively. The average Bo for 6-8 week old manure from a dirt feedlot was 0.210 litre CH4/g VSf. (Refs. 14).

USE MANURE AND ORGANIC WASTE AS PLANTING MEDIA OF SEED POTATOES PRODUCTION

Directory of Open Access Journals (Sweden)

Meksy Dianawati

2014-02-01

Full Text Available Manure and organic waste could be used as organic media at potato seed production of G1. The goal of this research was to increase production of potato seed G1 by several kinds of manure and organic waste. This research was conducted at plastic house in Lembang, West Java, from June to September 2014. This research used randomized completed block design with two treatment factors and six replications. The first factor was kinds of manure i.e chicken manure and sheep manure. The second factor was kinds of organic waste. Data was analysed by F test and followed by Duncan and correlation test at 95 percent confidence level. The results showed that media of husk waste with chicken and sheep manure has higher tuber weight and number of big-size tuber per plant than one of cocopeat significantly. Media of sheep manure with husk and bamboo waste has highest tuber weight per plant significantly. Number of total tuber was effected by number of smallsized tuber by 84 percent.

Methane recovery from animal manures: A current opportunities casebook

Energy Technology Data Exchange (ETDEWEB)

Lusk, P. [Resource Development Associates, Marietta, GA (United States)

1994-12-01

One manure management system provides not only pollution prevention but also converts a manure management problem into a new profit center. Economic evaluations and case studies of operating systems indicate that the anaerobic digestion of livestock manures is a commercially-available bioconversion technology with considerable potential for providing profitable co-products including a cost-effective renewable fuel for livestock production operations. This Casebook examines some of the current opportunities for the recovery of methane from the anaerobic digestion of animal manures. The economic evaluations are based on engineering studies of digesters that generate electricity from the recovered methane. Regression models, which can be used to estimate digester cost and internal rate of return, are developed from the evaluations. Finally, anaerobic digestion has considerable potential beyond agribusiness. Examples of digesters currently employed by other industries are provided.

Cost-effective production of biogas from manure – retrogas project

DEFF Research Database (Denmark)

Jurado, Esperanza; Gavala, Hariklia N.; Rohold, Lars

2010-01-01

, this is the main reason for the poor economic performance of biogas plants in Denmark. The idea of increasing the methane productivity of the manure has triggered the development of new separation technologies for being applied before the anaerobic digestion of the swine manure. Thus, the solid and liquid...... at the development of new separation and liquefaction technology in order to make the anaerobic digestion of swine manure cost efficient and viable.......Transport of large quantities of low concentrated swine manure (total solids around 5-7%) to biogas plants represents a significant proportion of the operating costs for co-digestion plants. Together with the increment of the prices of the industrial effluents that are used for codigestion...

Leaching of viruses and other microorganisms naturally occurring in pig slurry to tile drains on a well-structured loamy field in Denmark

DEFF Research Database (Denmark)

Krog, Jesper Schak; Forslund, Anita; Larsen, Lars Erik

2017-01-01

The amount of animal manure used in modern agriculture is increasing due to the increase in global animal production. Pig slurry is known to contain zoonotic bacteria such as E. coli, Salmonella spp. and Campylobacter spp., and viruses such as hepatitis E virus and group A rotavirus. Coliform...... sets out to investigate the leaching potential of six different microorganisms: E. coli and Enterococcus spp. (detected by colony assay), somatic coliphages (using plaque assays), and hepatitis E virus, porcine circovirus type 2, and group A rotavirus (by real-time polymerase chain reaction). All six...... microorganisms leached through the soil entering the tile drains situated at 1-m depth the first day following pig slurry application. The leaching pattern of group A rotavirus differed substantially from the pattern for somatic coliphages, which are otherwise used as indicators for virus contamination...

Effect of ISPAD Anaerobic Digestion on Ammonia Volatilization from Soil Applied Swine Manure

Directory of Open Access Journals (Sweden)

Susan King

2012-01-01

Full Text Available Swine manure subjected to in-storage psychrophilic anaerobic digestion (ISPAD undergoes proteins degradation but limited NH3 volatilization, producing an effluent rich in plant-available nitrogen. Accordingly, ISPAD effluent can offer a higher fertilizer value during land application, as compared to manure of similar age stored in an open tank. However, this additional nitrogen can also be lost by volatilization during land application. The objective of this study was therefore to measure NH3 volatilization from both ISPAD and open tank swine manures when applied to 5 different soils, namely, washed sand, a Ste Rosalie clay, an Upland sandy loam, a St Bernard loam, and an Ormstown loam. This research was conducted using laboratory wind tunnels simulating land application. The five experimental soils offered similar pH values but different water holding capacity, cation exchange capacity, cation saturation, and organic matter. After 47 h of wind tunnel monitoring, the % of total available nitrogen (TAN or NH4 + and NH3 volatilized varied with both manure and soil type. For all soil types, the ISPAD manure consistently lost less NH3 as compared to the open tank manure, averaging 53% less. Lower volatile solids content improving manure infiltration into the soil and a more complex ionic solution explain the effect of the ISPAD manure advantages. This was reinforced by the St Bernard sandy loam losing the same nitrogen mass for both manures, because of its higher pH and buffer pH coupled with an intermediate CEC resulting in more soil solution NH3. Within each manure type, % TAN volatilized was highest for washed sand and lowest for the clay soil. As a result, ISPAD manure can offer up to 21% more plant-available nitrogen fertilizer especially when the manure is not incorporated into the soil following its application.

Fertilizing properties of farm manure submitted to methane fermentation, according to pot tests

Energy Technology Data Exchange (ETDEWEB)

Kuzelewski, L; Pentkowski, A

1962-01-01

In order to compare the fertilizing properties of the ordinary farm manure stored and fermented in dung hills with those of the manure submitted to CH/sub 4/ fermentation, pot tests with oats and potatoes were carried out. Investigation showed that: N losses taking place during CH/sub 4/ fermentation are much smaller than those from manure fermented in dung-hills. Because of different fermentation processes, the losses of solid matter in the CH/sub 4/ fermentation were greater than in manure fermented and stored in dung-hills. Although the manure submitted to CH/sub 4/ fermentation contained more N, its effect on crops was almost identical with the effect of ordinary manure. Experiments have shown that it is not necessary to cover with soil the manure submitted to the CH/sub 4/ fermentation after spreading it. Whether it was covered with soil or not, there was no difference in crop yield. Manure fermenting in O-free atmosphere may contain products harmful to plants, but they oxidize quickly on exposure to the atmosphere. 53 references.

Farm effluent plant produces gas for domestic heat and power

Energy Technology Data Exchange (ETDEWEB)

1963-01-01

A plant for treating farm waste waters, developed by Wright Rain Ltd. and based on a prototype plant invented by J. Fry which has been in continuous use for 5 years on a pig farm at Rietvlei, Johannesburg, is described. Manure is pumped into one end of the digestion tank about one-third of the way up the tank, and anaerobic decomposition occurs at a controlled temperature (optimum 35/sup 0/C); the gas rises to the top and is collected in gas holders to be utilized for domestic heat and power, while an outlet near the bottom of the tank allows decomposed matter to be drawn off for spreading. Results with pig manure suggest that a digestion tank should be planned for a 60-day cycle. Cow and pig manure can be digested without difficulty, but it would be necessary to add water to chicken manure for successful digestion.

Precision control of biogas plants. Final report

Energy Technology Data Exchange (ETDEWEB)

Moeller, H.B.; Nielsen, Anders M.; Ward, A.J.

2009-10-15

The objective of the project has been to improve design and process stability in biogas plants. The results can be divided within the following main categories: 1) Pre-treatment, serial coupling of digesters and post digestion 2) Process inhibition 3) Process control Ad 1) This work has shown that extreme thermophilic pre-treatment of cattle manure and pig manure mixed with silage has a considerable effect on methane yield in a subsequent methanogenic reactor. Ad 2) The effect of ammonia inhibition was studied in a series of continuously stirred tank reactors co-digesting pig manure (40%) with the addition of solid fractions (60%) and increasing concentrations of ammonia caused by addition of NH{sub 4}Cl pulses. Ad 3) Near infrared spectroscopy (NIRS) was used to predict liquid phase volatile fatty acid (VFA) concentrations in three experiments treating three different materials: pig slurry with maize silage, chicken manure and cattle slurry.

Pharmacokinetic/pharmacodynamic integration and modelling of florfenicol for the pig pneumonia pathogens Actinobacillus pleuropneumoniae and Pasteurella multocida.

Directory of Open Access Journals (Sweden)

Lucy Dorey

Full Text Available Pharmacokinetic-pharmacodynamic (PK/PD integration and modelling were used to predict dosage schedules for florfenicol for two pig pneumonia pathogens, Actinobacillus pleuropneumoniae and Pasteurella multocida. Pharmacokinetic data were pooled for two bioequivalent products, pioneer and generic formulations, administered intramuscularly to pigs at a dose rate of 15 mg/kg. Antibacterial potency was determined in vitro as minimum inhibitory concentration (MIC and Mutant Prevention Concentration in broth and pig serum, for six isolates of each organism. For both organisms and for both serum and broth MICs, average concentration:MIC ratios over 48 h were similar and exceeded 2.5:1 and times greater than MIC exceeded 35 h. From in vitro time-kill curves, PK/PD modelling established serum breakpoint values for the index AUC24h/MIC for three levels of inhibition of growth, bacteriostasis and 3 and 4log10 reductions in bacterial count; means were 25.7, 40.2 and 47.0 h, respectively, for P. multocida and 24.6, 43.8 and 58.6 h for A. pleuropneumoniae. Using these PK and PD data, together with literature MIC distributions, doses for each pathogen were predicted for: (1 bacteriostatic and bactericidal levels of kill; (2 for 50 and 90% target attainment rates (TAR; and (3 for single dosing and daily dosing at steady state. Monte Carlo simulations for 90% TAR predicted single doses to achieve bacteriostatic and bactericidal actions over 48 h of 14.4 and 22.2 mg/kg (P. multocida and 44.7 and 86.6 mg/kg (A. pleuropneumoniae. For daily doses at steady state, and 90% TAR bacteriostatic and bactericidal actions, dosages of 6.2 and 9.6 mg/kg (P. multocida and 18.2 and 35.2 mg/kg (A. pleuropneumoniae were required. PK/PD integration and modelling approaches to dose determination indicate the possibility of tailoring dose to a range of end-points.

Effects of Combined Application of Manure and Nitrogen in a Semi-Arid Environment

International Nuclear Information System (INIS)

1999-01-01

A study was conducted under field conditions at Masii to examine maize response to a combined application of cattle manure and nitrogen (N) in a sandy soil. The treatments consisted of 0, 10 and 20 tons of manure per hectare (t ha -1 ) applied in a brand along the maize rows. the manure was combined with 0, 30, 60 and 120 kg N ha -1 all applied at planting in the first year, and o, 40, 90 and 150 kg N ha -1 split into two applications in the second year. Maize plants grown without either manure or nitrogen were stunted and yellow. Grain yields were low ranging from 175 to 246 kg ha -1 , in the two years of study when no manure or fertilizer was applied. Application of 10 t ha -1 of manure alone increased the grain yield to a maximum of 1529 kg ha -1 . Grain yield increased significantly with combined application of manure and nitrogen to 3145 kg ha -1 , when a combination of 20 t ha - 1 of manure and 120 kg N ha -1 was applied in the year. Even the a yield plateau could not be attained. The study indicated that low soil fertility is a major limitation to maize growth and production in the study area. Maize production can be improved by application of manure or nitrogen, however, higher yields could be achieved when manure and nitrogen are applied in combination

Consommation de quelques graminées tropicales par le cobaye [Cavia porcellus : performances et détermination des surfaces nécessaires à l'entretien d'un cheptel

Directory of Open Access Journals (Sweden)

Kouonmenioc, J.

2000-01-01

Full Text Available Consumption of some Tropical Grass Forages by Guinea-Pigs (Cavia porcellus ; Performances and Determination of Required Areas to Maintain a Flock. In order to develop the mini-livestock sector in the agricultural production systems, investigations have been carried out on five tropical grass forages in the Cameroon forest humid zone in order to show the impact of organic manure on the total biomass production for guinea-pigs feeding. Adequate forages area required to maintain a family size guinea-pigs flock was determined. These various forage species compared in terms of growth showed positive response to guinea pigs manure. Panicum maximum with a 8 weeks regrowth which yielded 5146.7 kg DM/ha (on increase of 1500.8 kg seemed to be the best forage in terms of production. Positive response of these grasses to organic manure from guinea-pigs farming may direct the farmer not to use the manure not only for food and cash cropping, but also to sustain forage production. For a 8 weeks cutting frequency the adequate forage area to maintain a family flock size of 20 animals ranges from 90.8 m2 x2 for Brachiaria ruziziensis to 152.9 m2 x 2 for Trypsacum laxum.

Relevant Measures to Prevent the Spread of African Swine Fever in the European Union Domestic Pig Sector.

Science.gov (United States)

Jurado, Cristina; Martínez-Avilés, Marta; De La Torre, Ana; Štukelj, Marina; de Carvalho Ferreira, Helena Cardoso; Cerioli, Monica; Sánchez-Vizcaíno, José Manuel; Bellini, Silvia

2018-01-01

During the past decade, African swine fever (ASF) has spread from the Caucasus region to eastern European Union countries affecting domestic pig and wild boar populations. In order to avert ASF spread, mitigation measures targeting both populations have been established. However, despite these efforts, ASF has been reported in thirteen different countries (Georgia, Azerbaijan, Armenia, the Russian Federation, Ukraine, Belarus, Estonia, Latvia, Lithuania, Poland, Moldova, Czech Republic, and Romania). In the absence of an effective vaccine or treatment to ASF, introduction and spread of ASF onto domestic pig farms can only be prevented by strict compliance to control measures. This study systematically reviewed available measures to prevent the spread of ASF in the EU domestic pig sector distinguishing between commercial, non-commercial, and outdoor farms. The search was performed in PubMed and using a common browser. A total of 52 documents were selected for the final review process, which included scientific articles, reports, EU documents and official recommendations, among others. From this literature review, 37 measures were identified as preventive measures for the introduction and spread of ASF. Subsequently, these measures were assessed by ASF experts for their relevance in the mitigation of ASF spread on the three mentioned types of farms. All experts agreed that some of the important preventive measures for all three types of farms were: the identification of animals and farm records; strict enforcement of the ban on swill feeding; and containment of pigs, so as to not allow direct or indirect pig-pig and/or pig-wild boar contacts. Other important preventive measures for all farms were education of farmers, workers, and operators; no contact between farmers and farm staff and external pigs; appropriate removal of carcasses, slaughter residues, and food waste; proper disposal of manure and dead animals, and abstaining from hunting activities during the

Nutrient Runoff Losses from Liquid Dairy Manure Applied with Low-Disturbance Methods.

Science.gov (United States)

Jokela, William; Sherman, Jessica; Cavadini, Jason

2016-09-01

Manure applied to cropland is a source of phosphorus (P) and nitrogen (N) in surface runoff and can contribute to impairment of surface waters. Tillage immediately after application incorporates manure into the soil, which may reduce nutrient loss in runoff as well as N loss via NH volatilization. However, tillage also incorporates crop residue, which reduces surface cover and may increase erosion potential. We applied liquid dairy manure in a silage corn ( L.)-cereal rye ( L.) cover crop system in late October using methods designed to incorporate manure with minimal soil and residue disturbance. These include strip-till injection and tine aerator-band manure application, which were compared with standard broadcast application, either incorporated with a disk or left on the surface. Runoff was generated with a portable rainfall simulator (42 mm h for 30 min) three separate times: (i) 2 to 5 d after the October manure application, (ii) in early spring, and (iii) after tillage and planting. In the postmanure application runoff, the highest losses of total P and dissolved reactive P were from surface-applied manure. Dissolved P loss was reduced 98% by strip-till injection; this result was not statistically different from the no-manure control. Reductions from the aerator band method and disk incorporation were 53 and 80%, respectively. Total P losses followed a similar pattern, with 87% reduction from injected manure. Runoff losses of N had generally similar patterns to those of P. Losses of P and N were, in most cases, lower in the spring rain simulations with fewer significant treatment effects. Overall, results show that low-disturbance manure application methods can significantly reduce nutrient runoff losses compared with surface application while maintaining residue cover better than incorporation by tillage. Copyright © by the American Society of Agronomy, Crop Science Society of America, and Soil Science Society of America, Inc.

Selection of Green Manure Species for Efficient Absorbtion of Poorly-Available Forms of Soil Phosphorus

Energy Technology Data Exchange (ETDEWEB)

Franzini, V. I.; Mendes, F. L. [Brazilian Agricultural Research Corporation, EMBRAPA-Amazonia Oriental, Belem, PA, (Brazil); Muraoka, T.; Da Silva, E. C. [Center for Nuclear Energy in Agriculture, University of Sao Paulo, Piracicaba, SP (Brazil); Adu-Gyamfi, J. J. [Soil and Water Management and Crop Nutrition Laboratory, International Atomic Energy Agency, Vienna (Austria)

2013-11-15

Green manuring is an agronomic practice in which plants or their residues are added to the soil, improving of the soil physical, chemical and biological attributes, and increasing organic matter and fertility levels through nutrient cycling. It is estimated that green manures can increase P bioavailability. The integration of plant species in crop rotations to immobilize P is one of the most promising agronomic measures to improve the availability of P for the main crop. This study aimed to assess 21 species of green manure and a standard plant species (Lupinus albus) on their ability to absorb the available forms of P by the {sup 32}P isotopic dilution technique. It also aimed to determine if the isotopically exchangeable P, the L-values, differed when calculated with or without taking seed N into account. The results were statistically correlated and analyzed by hierarchical clustering (HCA) in order to group similar plant species. Jack bean was the most efficient species in P utilization while the Stylosanthes spp. were the most efficient in P uptake. The seed-derived P affected the P uptake efficiency evaluated by L-value technique. (author)

effect of farmyard manure on senescence, nitrogen and protein

African Journals Online (AJOL)

DR. AMINU

treatment (manurex2) at the ratio of 5:1 soil to manure and the control (no manure added). Plastic pots of ... seasons, senescence started earlier rainy season than in dry season. On the other hand ... These changes, visible to the naked eye are.