WorldWideScience

Sample records for biogas plant slurry

  1. Comparison and analysis of organic components of biogas slurry from eichhornia crassipes solms and corn straw biogas slurry

    Science.gov (United States)

    Li, Q.; Li, Y. B.; Liu, Z. H.; Min, J.; Cui, Y.; Gao, X. H.

    2017-11-01

    Biogas slurry is one of anaerobic fermentations, and biomass fermentation biogas slurries with different compositions are different. This paper mainly presents through the anaerobic fermentation of Eichhornia crassipes solms biogas slurry and biogas slurry of corn straw, the organic components of two kinds of biogas slurry after extraction were compared by TLC, HPLC and spectrophotometric determination of nucleic acid and protein of two kinds of biogas slurry organic components, and analyzes the result of comparison.

  2. Environmental Consequences of Future Biogas Technologies based on Separated Slurry

    DEFF Research Database (Denmark)

    Hamelin, Lorie; Wesnæs, Marianne; Wenzel, Henrik

    2011-01-01

    This consequential life cycle assessment study highlights the key environmental aspects of producing biogas from separated pig and cow slurry, a relatively new but probable scenario for future biogas production, as it avoids the reliance on constrained carbon cosubstrates. Three scenarios involving...... the whole slurry life cycle, including the flows bypassing the biogas plant. This study includes soil carbon balances and a method for quantifying the changes in yield resulting from increased nitrogen availability as well as for quantifying mineral fertilizers displacement. Soil carbon balances showed...

  3. Integrated use of plant growth promoting rhizobacteria, biogas slurry and chemical nitrogen for sustainable production of maize under salt-affected conditions

    International Nuclear Information System (INIS)

    Ahmad, M.; Jamil, M.; Akhtar, F.U.Z.

    2014-01-01

    Salinity is one of the most critical constraints hampering agricultural production throughout the world, including Pakistan. Some plant growth promoting rhizobacteria (PGPR) have the ability to reduce the deleterious effect of salinity on plants due to the presence of ACC-deaminase enzyme along with some other mechanisms. The integrated use of organic, chemical and biofertilizers can reduce dependence on expensive chemical inputs. To sustain high crop yields without deterioration of soil fertility, it is important to work out optimal combination of chemical and biofertilizers, and manures in the cropping system. A pot trial was conducted to study the effect of integrated use of PGPR, chemical nitrogen, and biogas slurry for sustainable production of maize under salt-stressed conditions and for good soil health. Results showed that sole application of PGPR, chemical nitrogen and biogas slurry enhanced maize growth but their combined application was more effective. Maximum improvement in maize growth, yield, ionic concentration in leaves and nutrient concentration in grains was observed in the treatment where PGPR and biogas slurry was used in the presence of 100% recommended nitrogen as chemical fertilizer. It also improved the soil pH, ECe, and available N, P and K contents. It is concluded that integrated use of PGPR, biogas slurry and chemical nitrogen not only enhanced maize growth, yield and quality but also improved soil health. So, it may be evaluated under field conditions to get sustained yield of maize from salt-affected soils. (author)

  4. Life cycle assessment of biogas from separated slurry

    Energy Technology Data Exchange (ETDEWEB)

    Hamelin, L.; Wesnaes, M.; Wenzel, H. (Univ. of Southern Denmark, Odense (Denmark)); Molt Petersen, B. (Aarhus Univ.. Faculty of Agricultural Sciences, Aarhus (Denmark))

    2010-07-01

    The environmental aspects of biogas production based on pre-treated slurry from fattening pigs and dairy cows have been investigated in a life cycle perspective. The pre-treatment consists of concentrating the slurry using a separation technology. Significant environmental benefits, compared to the status quo slurry management, can be obtained for both pig and cow slurry, especially regarding reductions of the contributions to global warming, but the results depend to a large extent on the efficiency of the separation technology. Adding separation after the biogas plant can contribute to a more efficient management of the phosphorus, and this has also been investigated. Based on the results of the study it can be concluded that: 1) The environmental benefits of biogas from separated slurry are very dependent upon the separation efficiency (for carbon, nitrogen and phosphorous). This particularly applies for carbon, as the separation efficiency defines the extent to which the degradable carbon contained in the slurry is transferred to the biogas plant. Efficient separation can be obtained by using polymer, but also by using a suitable separation technology. It could be mentioned that the decanter centrifuge used has a rather high efficiency of transferring volatile solids (VS) to the fibre fraction also without the use of polymer. 2) Biogas production from separated slurry can lead to significant reductions in the contributions to global warming, provided that the 'best available technologies' described in the report are used. That includes, among others: - a covered and short time storage of the fibre fraction before entering the biogas plant, - a 2-step biogas production where the post-digestion tank is covered with air-tight cover, - a covered storage of the degassed fibre fraction The benefits are also highly dependent upon the source of energy substituted by the biogas. 3) Based on evidences from reviewed studies, the cationic polyacrylamide polymer

  5. Biogas slurry pricing method based on nutrient content

    Science.gov (United States)

    Zhang, Chang-ai; Guo, Honghai; Yang, Zhengtao; Xin, Shurong

    2017-11-01

    In order to promote biogas-slurry commercialization, A method was put forward to valuate biogas slurry based on its nutrient contents. Firstly, element contents of biogas slurry was measured; Secondly, each element was valuated based on its market price, and then traffic cost, using cost and market effect were taken into account, the pricing method of biogas slurry were obtained lastly. This method could be useful in practical production. Taking cattle manure raw meterial biogas slurry and con stalk raw material biogas slurry for example, their price were 38.50 yuan RMB per ton and 28.80 yuan RMB per ton. This paper will be useful for recognizing the value of biogas projects, ensuring biogas project running, and instructing the cyclic utilization of biomass resources in China.

  6. Vermiconversion of wastewater sludge from textile mill mixed with anaerobically digested biogas plant slurry employing Eisenia foetida.

    Science.gov (United States)

    Garg, V K; Kaushik, Priya; Dilbaghi, Neeraj

    2006-11-01

    Vermicomposting is commonly used for the management of organic wastes. We have investigated the potential of an epigeic earthworm, Eisenia foetida, to transform solid textile mill sludge (STMS) spiked with anaerobically digested biogas plant slurry (BPS) into vermicompost to evaluate the feasibility of vermicomposting in industries for waste management. The growth and reproduction of E. foetida was monitored in a range of different feed mixtures for 15 weeks in laboratory under controlled experimental conditions. E. foetida did not survive in fresh STMS. But worms grew and reproduced in STMS spiked with BPS feed mixtures. A greater percentage of STMS in feed mixture affected biomass gain and cocoon production by earthworms. The maximum growth was recorded in 100% BPS. The net weight gain by E. foetida in 100% BPS was two-four-fold higher than STMS-containing feed mixtures. After 15 weeks, maximum cocoons (78) were counted in 100% BPS and minimum (26) in 60% BPS+40% STMS feed. Vermicomposting resulted in pH shift toward acidic, significant reduction in C:N ratio, and increase in nitrogen, phosphorus, and potassium contents. Microbial activity measured as dehydrogenase activity increased with time up to day 75 but decreased on day 90, indicating the exhaustion of feed and decrease in microbial activity. These experiments demonstrate that vermicomposting can be an alternate technology for the recycling and environmentally safe disposal/management of textile mill sludge using an epigeic earthworm, E. foetida, if mixed with anaerobically digested BPS in appropriate ratios.

  7. Concentrated biogas slurry enhanced soil fertility and tomato quality

    Energy Technology Data Exchange (ETDEWEB)

    Fang-Bo Yu; Xi-Ping Luo; Fang-Bo Yu; Xi-Ping Luo; Cheng-Fang Song; Miao-Xian Zhang; Sheng-Dao Shan (Dept. of Environmental Sciences, Inst. of Environmental Technology, Zhejiang Forestry University, Linan (China))

    2010-05-15

    Biogas slurry is a cheap source of plant nutrients and can offer extra benefits to soil fertility and fruit quality. However, its current utilization mode and low content of active ingredients limit its further development. In this paper, a one-growing-season field study was conducted to assess the effects of concentrated biogas slurry on soil property, tomato fruit quality, and composition of microflora in both nonrhizosphere and rhizosphere soils. The results showed that application of concentrated slurry could bring significant changes to tomato cultivation, including increases in organic matter, available N, P, and K, total N and P, electrical conductivity, and fruit contents of amino acids, protein, soluble sugar, beta-carotene, tannins, and vitamin C, together with the R/S ratios and the culturable counts of bacteria, actinomycetes, and fungi in soils. It was concluded that the application is a practicable means in tomato production and will better service the area of sustainable agriculture

  8. Experimental investigation of an applicator of liquid slurry, from biogas production, for crop production.

    Science.gov (United States)

    Kurchania, A K; Panwar, N L

    2011-01-01

    A unit for the application of liquid digested slurry in the field was designed and developed. The developed slurry applicator had a capacity of 1500 L and was pulled by a 35 h.p. tractor. The liquid digested slurry of a biogas plant was pumped in to the tank with the help of a slurry pump. The necessary power transmission system, consisting of a pulley, power take off shaft (PTO) and cross joints, was provided to get power from the PTO of the tractor. In this paper an attempt has been made to evaluate the application of liquid slurry in the field in terms of plant growth parameters such as number of branches/plant, number of nodules/plant, plant height and yield attributes like pods/plant and grains/pod. The application of liquid slurry resulted in an increase in grain, straw and biological yields of 32%, 7% and 15%, respectively, compared with the application of farmyard manure.

  9. Microalgal cultivation with biogas slurry for biofuel production.

    Science.gov (United States)

    Zhu, Liandong; Yan, Cheng; Li, Zhaohua

    2016-11-01

    Microalgal growth requires a substantial amount of chemical fertilizers. An alternative to the utilization of fertilizer is to apply biogas slurry produced through anaerobic digestion to cultivate microalgae for the production of biofuels. Plenty of studies have suggested that anaerobic digestate containing high nutrient contents is a potentially feasible nutrient source to culture microalgae. However, current literature indicates a lack of review available regarding microalgal cultivation with biogas slurry for the production of biofuels. To help fill this gap, this review highlights the integration of digestate nutrient management with microalgal production. It first unveils the current status of microalgal production, providing basic background to the topic. Subsequently, microalgal cultivation technologies using biogas slurry are discussed in detail. A scale-up scheme for simultaneous biogas upgrade and digestate application through microalgal cultivation is then proposed. Afterwards, several uncertainties that might affect this practice are explored. Finally, concluding remarks are put forward. Copyright © 2016 Elsevier Ltd. All rights reserved.

  10. Choosing co-substrates to supplement biogas production from animal slurry - A life cycle assessment of the environmental consequences

    DEFF Research Database (Denmark)

    Croxatto Vega, Giovanna Catalina; Ten Hoeve, Marieke; Birkved, Morten

    2014-01-01

    Biogas production from animal slurry can provide substantial contributions to reach renewable energy targets, yet due to the low methane potential of slurry, biogas plants depend on the addition of co-substrates to make operations profitable. The environmental performance of three underexploited co...... is then produced from conventional fossil fuels. The scenarios can often provide benefits for one impact category while causing impacts in another....

  11. Studies on the Ecological Adaptability of Growing Rice with Floating Bed on the Dilute Biogas Slurry

    Science.gov (United States)

    Du, Qi; Cheng, Bowen; Liao, Zhiqi; Sun, Chengcheng

    2016-01-01

    This study aimed to explore the ecological adaptability and the possibility of growing rice with floating bed on the dilute biogas slurry. The results of the experiments show that the growth stage, rice plant height, and rice yield and quality were significantly affected by multiple dilutions; rice plants cultivated with 45 multiple dilutions had better ecological adaptability than others. In the 45 multiple dilutions' group, the yield of rice was 13.3 g/bucket (8 rice plants), milled rice rate was 63.1%, and the content of crude protein in the rice was 6.3%. The concentrations of heavy metals in the rice cultivated with 30 multiple dilutions' slurry, such as total lead, cadmium, mercury, chromium, and arsenic, were all below the national standard. The study shows that it is possible and safe to cultivate rice plants with no soil but diluted biogas slurry. In the experiments, the yield, milled rice rate, and crude protein of the rice cultivated with slurry were not as much as those of rice cultivated with regular way in soil. This study provides the basic theoretical support for the development of biogas projects and the potential achievement of organic farming in special agricultural facilities and circular economy. PMID:27882324

  12. Studies on the Ecological Adaptability of Growing Rice with Floating Bed on the Dilute Biogas Slurry.

    Science.gov (United States)

    Kang, Qun; Li, Rui; Du, Qi; Cheng, Bowen; Liao, Zhiqi; Sun, Chengcheng; Li, Zhaohua

    2016-01-01

    This study aimed to explore the ecological adaptability and the possibility of growing rice with floating bed on the dilute biogas slurry. The results of the experiments show that the growth stage, rice plant height, and rice yield and quality were significantly affected by multiple dilutions; rice plants cultivated with 45 multiple dilutions had better ecological adaptability than others. In the 45 multiple dilutions' group, the yield of rice was 13.3 g/bucket (8 rice plants), milled rice rate was 63.1%, and the content of crude protein in the rice was 6.3%. The concentrations of heavy metals in the rice cultivated with 30 multiple dilutions' slurry, such as total lead, cadmium, mercury, chromium, and arsenic, were all below the national standard. The study shows that it is possible and safe to cultivate rice plants with no soil but diluted biogas slurry. In the experiments, the yield, milled rice rate, and crude protein of the rice cultivated with slurry were not as much as those of rice cultivated with regular way in soil. This study provides the basic theoretical support for the development of biogas projects and the potential achievement of organic farming in special agricultural facilities and circular economy.

  13. Management of Biogas spent slurry for hastening the composting of agro residues

    Directory of Open Access Journals (Sweden)

    G. S. Geeta

    2015-04-01

    Full Text Available The demand for energy and the fertilizers are ever increasing. Organic farming has many advantages looking to the environment pollution, unproductive soil, less yields etc. By installation of a biogas plant serves both the purposes of meeting the fuel as well as obtaining manures. The organic manures need to be added in bulk to meet the nutrient demands of the crop as it is not in concentrated form like chemical fertilizers. Hence, biogas spent slurry is the best alternate for hastening the compost preparation of abundantly available crop residues as well as obtaining enriched compost as conventional method takes long time. Moreover, slurry is composed of major nutrients besides enzymes and a rich microflora. Based on the preliminary results, the present study was conducted at farmer’s field to know whether slurry could be used for degradation of agro residues. One ton of crop residues that included banana waste, sunflower and maize waste, leaf litter of horticultural crops were inoculated individually with 60 L of spent slurry along with consortia of degrading fungi and P-solubilising bacteria. After a retention period of 60 days, nutrients were analysed. The cultures along with slurry indicated 1.5 - 1.96% N with reduction in C:N ratio between 1.6 - 1.82. The micronutrients also increased. Thus, it was concluded that efficient use of spent slurry can be made besides utilising the crop residues and the product for organic cultivation.

  14. The optimal size for biogas plants

    Energy Technology Data Exchange (ETDEWEB)

    Walla, C.; Schneeberger, W. [Department of Economics and Social Sciences, Institute of Agricultural and Forestry Economics, University of Natural Resources and Applied Life Sciences Vienna, Gregor-Mendel-Strasse 33, 1180 Vienna (Austria)

    2008-06-15

    The costs of biogas and electricity production from maize silage in relation to plant size are investigated in this paper. A survey of manufacturers' engineering data was conducted to derive a reliable relationship between the capacity of a combined heat and power (CHP) unit and its electrical efficiency. Then a model was developed to derive cost curves for the unit costs of biogas and electricity production and for the transport costs for maize silage and biogas slurry. The least-cost plant capacity depends to a great extent on the local availability of silage maize, and ranges in the model calculations from 575 to 1150 kW{sub el}. Finally, the paper deals with the optimum operating plant size due to the investment support available and the graduated tariff for green electricity in Austria. (author)

  15. CONSIDERATIONS OVER A BIOGAS PLANT COMPONENTS

    Directory of Open Access Journals (Sweden)

    Mariana DUMITRU

    2014-04-01

    Full Text Available This paper starts from the conviction that one of the main environmental problems of today’s society is the continuously increasing production of organic wastes. In many countries, sustainable waste management have become major political priorities in order to reduce pollution and greenhouse gas emissions and to avoid, as much as possible, global climate changes. This problem becomes more and more present in our country too. Production of biogas through anaerobic digestion of animal manure and slurries as well as of a wide range of digestible organic wastes, converts these substrates into renewable energy and offers a natural fertiliser for agriculture. That is why we consider that biogas plants will be more and more used in the future. In this paper we show the different stages which must be operated in a biogas plant and the problems which can be met in each of them.

  16. Collective biogas plants

    International Nuclear Information System (INIS)

    1992-01-01

    Papers contributed to the European seminar on collective biogas plants held at Herning, Denmark on October 22-23 under the auspices of the Commission of the European Communities, Directorate-General for Energy (DG XVII) are presented. Within the framework of the THERMIE programme, a network of OPETs (Organizations for the Promotion of Energy Technologies) was set up in order to disseminate information on new energy technologies throughout the European communities. The potential for further implementation of centralized capacity for the conversion of animal manures and other organic wastes to bio-fuels, not only in central and eastern Europe but also in the developing countries, is discussed in addition to the relevant technologies. Actual biomass conversion plants are described and details are given on operational experience and plant management. Agricultural, economic and policy aspects are also dealt with. (AB)

  17. Integration of centralized biogas plant in cold-snowy region in Japan

    OpenAIRE

    Umetsu K.; Ying C.; Kikuchi S.; Iwasaki M.; Takeuchi Y.; Oi M.; Shiroishi K.; Uematsu T.; Yasui S.

    2011-01-01

    A centralized biogas plant was built in Shikaoi town, Hokkaido, Japan to treat manure from 1320 cattle heads. The biogas plant was designed to operate at a feeding amount of 85.8 t/day, a hydraulic retention time (HRT) of 37 days and at a digester temperature of 38 °C. In this study, the operational performance of biogas plant, utilization of digested slurry and economic balance were investigated. Since the working conditions of the plant became stable, the...

  18. Screening of microalgae for integral biogas slurry nutrient removal and biogas upgrading by different microalgae cultivation technology.

    Science.gov (United States)

    Wang, Xue; Bao, Keting; Cao, Weixing; Zhao, Yongjun; Hu, Chang Wei

    2017-07-14

    The microalgae-based technology has been developed to reduce biogas slurry nutrients and upgrade biogas simultaneously. In this work, five microalgal strains named Chlorella vulgaris, Scenedesmus obliquus, Selenastrum capricornutum, Nitzschia palea, and Anabaena spiroides under mono- and co-cultivation were used for biogas upgrading. Optimum biogas slurry nutrient reduction could be achieved by co-cultivating microalgae (Chlorella vulgaris, Scenedesmus obliquus, and Nitzschia palea) with fungi using the pelletization technology. In addition, the effects of different ratio of mixed LED light wavelengths applying mixed light-emitting diode during algae strains and fungi co-cultivation on CO 2 and biogas slurry nutrient removal efficiency were also investigated. The results showed that the COD (chemical oxygen demand), TN (total nitrogen), and TP (total phosphorus) removal efficiency were 85.82 ± 5.37%, 83.31 ± 4.72%, and 84.26 ± 5.58%, respectively at red: blue = 5:5 under the co-cultivation of S. obliquus and fungi. In terms of biogas upgrading, CH 4 contents were higher than 90% (v/v) for all strains, except the co-cultivation with S. obliquus and fungi at red: blue = 3:7. The results indicated that co-cultivation of microalgae with fungi under mixed light wavelengths treatments was most successful in nutrient removal from wastewater and biogas upgrading.

  19. Nitrogen and phosphorus removal coupled with carbohydrate production by five microalgae cultures cultivated in biogas slurry.

    Science.gov (United States)

    Tan, Fen; Wang, Zhi; Zhouyang, Siyu; Li, Heng; Xie, Youping; Wang, Yuanpeng; Zheng, Yanmei; Li, Qingbiao

    2016-12-01

    In this study, five microalgae strains were cultured for their ability to survive in biogas slurry, remove nitrogen resources and accumulate carbohydrates. It was proved that five microalgae strains adapted in biogas slurry well without ammonia inhibition. Among them, Chlorella vulgaris ESP-6 showed the best performance on carbohydrate accumulation, giving the highest carbohydrate content of 61.5% in biogas slurry and the highest ammonia removal efficiency and rate of 96.3% and 91.7mg/L/d respectively in biogas slurry with phosphorus and magnesium added. Additionally, the absence of phosphorus and magnesium that can be adverse for biomass accumulation resulted in earlier timing of carbohydrate accumulation and magnesium was firstly recognized and proved as the influence factor for carbohydrate accumulation. Microalgae that cultured in biogas slurry accumulated more carbohydrate in cell, making biogas slurry more suitable medium for the improvement of carbohydrate content, thus can be regarded as a new strategy to accumulate carbohydrate. Copyright © 2016 Elsevier Ltd. All rights reserved.

  20. Precision control of biogas plants. Final report

    Energy Technology Data Exchange (ETDEWEB)

    Moeller, H.B.; Nielsen, Anders M.; Ward, A.J.

    2009-10-15

    The objective of the project has been to improve design and process stability in biogas plants. The results can be divided within the following main categories: 1) Pre-treatment, serial coupling of digesters and post digestion 2) Process inhibition 3) Process control Ad 1) This work has shown that extreme thermophilic pre-treatment of cattle manure and pig manure mixed with silage has a considerable effect on methane yield in a subsequent methanogenic reactor. Ad 2) The effect of ammonia inhibition was studied in a series of continuously stirred tank reactors co-digesting pig manure (40%) with the addition of solid fractions (60%) and increasing concentrations of ammonia caused by addition of NH{sub 4}Cl pulses. Ad 3) Near infrared spectroscopy (NIRS) was used to predict liquid phase volatile fatty acid (VFA) concentrations in three experiments treating three different materials: pig slurry with maize silage, chicken manure and cattle slurry.

  1. Effect of slurry mixture variation on the quality of biogas produced ...

    African Journals Online (AJOL)

    This paper reports the effect of slurry mixture variations on the quality of biogas produced from chicken droppings. Chicken droppings were anaerobically digested to generate biogas as a sustainable alternative energy source for rural household energy requirements, in place of firewood. Samples of the chicken dropping ...

  2. Monitoring of biogas test plants

    DEFF Research Database (Denmark)

    Holm-Nielsen, Jens Bo; Esbensen, Kim H.

    2011-01-01

    Most studies reported in the literature have investigated near infrared spectroscopy (NIR) in laboratory-scale or minor pilot biogas plants only; practically no other studies have examined the potential for meso-scale/full-scale on-line process monitoring. The focus of this study is on a meso......-scale biogas test plant implementation of process analytical technologies (PAT) to develop multivariate calibration/prediction models for anaerobic digestion (AD) processes. A 150 L bioreactor was fitted with a recurrent loop at which NIR spectroscopy and attendant reference sampling were carried out. In all...... realistic bioreactor scales, it is necessary to obtain a fairly constant level of volatile fatty acid (VFA) concentration, which furthers a stable biogas production. Uncontrolled VFA contents have a significant negative impact on biogas production; VFA concentrations should not exceed 5–6000 mg/L lest...

  3. The contribution of Slovenian biogas plants to the reduction of agricultural sector green house emissions

    Directory of Open Access Journals (Sweden)

    Romana MARINŠEK LOGAR

    2015-12-01

    Full Text Available Agriculture is a source of emissions of the greenhouse gas methane into the environment. These emissions can be reduced by appropriate storage of animal slurry and manure, with proper fertilization and processing of organic agricultural waste into biogas, where methane is captured and used as an energy source. Biogas is a renewable source of energy that is produced by microbial anaerobic digestion in biogas plants. As a substrate in biogas plants using different types of organic biomass such as animal manure and slurry, crop residues, spoilt silage, waste from food processing industry and biodegradable industrial and municipal waste. Biogas can be used to produce heat and electricity or purified to biomethane as a fuel for vehicles. Digestate can be used as a high-quality fertilizer. Biogas as a renewable energy source represents a replacement for fossil fuels, thus reducing greenhouse gas emissions from fossil sources. The system of financial supports for electricity produced from biogas is applied in Slovenia. There were 24 operating biogas plants in Slovenia in year 2014. Slovenian biogas plants currently produce the majority of biogas from energy crops. As only the minority of biogas is produced from animal excrements we will primarily support the development of agricultural microbiogas plants that will use animal excrements and organic waste biomass from agri-food sector as substrates.

  4. Denitrification of aging biogas slurry from livestock farm by photosynthetic bacteria.

    Science.gov (United States)

    Yang, Anqi; Zhang, Guangming; Yang, Guang; Wang, Hangyao; Meng, Fan; Wang, Hongchen; Peng, Meng

    2017-05-01

    Huge amount of aging biogas slurry is in urgent need to be treated properly. However, due to high NH 3 -N concentration and low C/N ratio, this aging biogas slurry is refractory for traditional methods. Its denitrification has become a big challenge. In this paper, photosynthetic bacteria (PSB) were employed to handle this problem. The results showed denitrification of aging biogas slurry by PSB treatment was promising. The highest removal efficiency of NH 3 -N reached 99.75%, much higher than all other treatments. The removal of NH 3 -N followed pseudo zero order reaction under dark-aerobic condition. The better inoculation rate for NH 3 -N removal was 30%; and aerobic condition was more beneficial for NH 3 -N removal than anaerobic condition because of different metabolic pathways. Copyright © 2017 Elsevier Ltd. All rights reserved.

  5. Micronutrient component changes in the biogas slurry treated by a pilot solar-heated anaerobic reactor

    Science.gov (United States)

    Yang, Z. Y.; Xu, Y. B.; Li, P. F.; Wang, Y. J.; Sun, J.; Zhang, Y. P.

    2017-06-01

    A solar-heated anaerobic reactor system was applied to decompose livestock wastewater, in which cattle manure and chopped straw were mixed (CODCr 15,000∼25,000 mg·l-1), the commercial microorganisms were added to ambient acidification (about 32°C) and the acclimated sludge was inoculated. Then, the experiments were carried out on wastewater anaerobic degradation and biogas production at 40∼42°C, as fed every 10 days till stable running. The results showed that NH3-N and PO4 3- of the biogas slurry were 441 mg·l-1 and 65.0 mg·l-1 on the 35th day, respectively. The concentration of K was up to 350 mg·l-1 in the biogas slurry, rather higher than that of Mg and Fe, which indicated that the available K could contribute more in the agricultural irrigation. Total amino acids were up to 23.7 mg·l-1 after anaerobic digestion, in which Lys, Thr, Ala and Arg were prominent in the biogas slurry. These amino acids could be beneficial to seed soaking, feed adding and apply as foliar fertilizer. The major volatile organic compounds were detected in the biogas slurry, including toluene, m-cresol (up to 0.036% in the process of ambient acidification) and triethylsilane, which could be reduced to scarcely influence on agricultural application after anaerobic digestion.

  6. Simultaneously upgrading biogas and purifying biogas slurry using cocultivation of Chlorella vulgaris and three different fungi under various mixed light wavelength and photoperiods.

    Science.gov (United States)

    Cao, Weixing; Wang, Xue; Sun, Shiqing; Hu, Changwei; Zhao, Yongjun

    2017-10-01

    In order to purify biogas slurry and biogas simultaneously, three different fungi, Pleurotus geesteranus (P. geesteranus), Ganoderma lucidum (G. lucidum), and Pleurotus ostreatus (P. ostreatus) were pelletized with Chlorella vulgaris (C. vulgaris). The results showed that the optimal light wavelength ratio for red:blue was 5:5 for these three different fungi-assisted C. vulgaris, resulting in higher specific growth rate as well as nutrient and CO 2 removal efficiency compared with other ratios. G. lucidum/C. vulgaris was screened as the best fungi-mialgae for biogas slurry purification and biogas upgrading with light/dark ratio of 14h:10h, which was also confirmed by the economic efficiency analysis of the energy consumptions. These results will provide a theoretical foundation for large-scale biogas slurry purifying and biogas upgrading using microalgae. Copyright © 2017 Elsevier Ltd. All rights reserved.

  7. Survival of Salmonella spp. and fecal indicator bacteria in Vietnamese biogas digesters receiving pig slurry.

    Science.gov (United States)

    Huong, Luu Quynh; Forslund, Anita; Madsen, Henry; Dalsgaard, Anders

    2014-09-01

    Small-scale biogas digesters are widely promoted worldwide as a sustainable technology to manage livestock manure. In Vietnam, pig slurry is commonly applied to biogas digesters for production of gas for electricity and cooking with the effluent being used to fertilize field crops, vegetables and fish ponds. Slurry may contain a variety of zoonotic pathogens, e.g. Salmonella spp., which are able to cause disease in humans either through direct contact with slurry or by fecal contamination of water and foods. The objective of this study was to evaluate the survival of Salmonella spp. and the fecal indicator bacteria, enterococci, E. coli, and spores of Clostridium perfringens in biogas digesters operated by small-scale Vietnamese pig farmers. The serovar and antimicrobial susceptibility of the Salmonella spp. isolated were also established. The study was conducted in 12 farms (6 farms with and 6 farms without toilet connected) located in Hanam province, Vietnam. Sampling of pig slurry and biogas effluent was done during two seasons. Results showed that the concentration of enterococci, E. coli, and Clostridium perfringens spores was overall reduced by only 1-2 log10-units in the biogas digesters when comparing raw slurry and biogas effluent. Salmonella spp. was found in both raw slurry and biogas effluent. A total of 19 Salmonella serovars were identified, with the main serovars being Salmonella Typhimurium (55/138), Salmonella enterica serovar 4,[5],12:i:- (19/138), Salmonella Weltevreden (9/138) and Salmonella Rissen (9/138). The Salmonella serovars showed similar antimicrobial resistance patterns to those previously reported from Vietnam. When promoting biogas, farmers should be made aware that effluent should only be used as fertilizer for crops not consumed raw and that indiscriminate discharge of effluent are likely to contaminate water recipients, e.g. drinking water sources, with pathogens. Relevant authorities should promote safe animal manure management

  8. [Culture medium based on biogas slurry and breeding of oil Chlorella].

    Science.gov (United States)

    Zhao, Feng-Min; Mei, Shuai; Cao, You-Fu; Ding, Jin-Feng; Xu, Jia-Jie; Li, Shu-Jun

    2014-06-01

    The oil chlorella cultivation and biogas slurry treatment were combined. The biogas slurry provided water and nutrient for growing chlorella, at the same time, harmless treatment of biogas slurry was realized. This paper cultivated 4 species of oil chlorella in the mixed medium of biogas slurry and green algae medium (the volume ratios were 1 : 9, 1 : 3, 1 : 1 and 3 : 1, respectively), and compared their oil productivity to select the best oil chlorella species and the optimal culture medium. The results showed that, the combination of medium and chlorella species to reach the highest oil productivity was a volume ratio of 1 : 3 and the chlorella species BJ05, and the oil productivity of chlorella BJ05 was 9.20 mg x (L x d)(-1), higher than that in green algae medium [8.66 mg x (L x d)(-1)]. In mixed medium with a volume ratio of 1:3, the effect of adding different nutrients into the green algae medium on the oil productivity was examined, and the results showed that, sodium carbonate and citric acid had no negative effect on the oil productivity of chlorella BJ05. in the absence of sodium carbonate and citric acid, the oil productivity of chlorella BJ05 was 9.36 mg x (L x d)(-1), and the removal of COD (chemical oxygen demand), total nitrogen, total phosphorus and ammonia nitrogen rates were 59%, 75%, 61% and 100%, respectively. Deficiency in other nutrients had negative effect on the oil productivity. Therefore, the culture medium was further optimized to the mixed medium of biogas slurry and green algae medium with a volume ratio of 1 : 3 and without addition of sodium carbonate and citric acid.

  9. Recycling of cattle dung, biogas plant-effluent and water hyacinth in vermiculture

    Energy Technology Data Exchange (ETDEWEB)

    Balasubramanian, P.R.; Bai, R.K. [Madurai Kamaraj Univ. (India)

    1995-08-01

    The efficiency of recycling cattle dung, anaerobically digested cattle dung (biogas plant-effluent) and water hyacinth (Eichhornia crassipes) by culture of the earthworm Megascolex sp. was studied. The growth of the earthworms was increased by 156, 148 and 119% in soil supplemented with water hyacinth, cattle dung and biogas plant-effluent, respectively. The growth rate of the earthworms was increased significantly by raw cattle dung and water hyacinth over that by biodigested slurry. (author)

  10. Planning for Biogas Plant in Denmark

    DEFF Research Database (Denmark)

    Landt, Cristina C.; Gaarsmand, Regin; Palsberg, Aske

    2016-01-01

    This article is about establishing biogas in Denmark in the region of Zealand, the challenges that are related to this establishment and how to overcome this challenges. The article highlights three reasons for these challenges: 1) Regulation, 2) The municipal planning and 3) Involved various...... stakeholders. It investigates how these challenges affected the process and were overcome in the establishment of Solrod Biogas. In terms of ownership and biomass input, this biogas plant is unique compared to other Danish biogas plants. The biogas plant is based on organic by-products from local industries...... and seaweed. The plant solves an essential environmental issue for the municipality and citizens who were affected by the smell of rotten seaweed washed up in Koge Bay. The seaweed is used as input; this solves several problems at the same time. The method used to establish Solrod Biogas was an integrated...

  11. ORGANIC WASTE USED IN AGRICULTURAL BIOGAS PLANTS

    Directory of Open Access Journals (Sweden)

    Joanna Kazimierowicz

    2014-04-01

    Full Text Available Treatment of organic waste is an ecological and economical problem. Searching method for disposal of these wastes, interest is methane fermentation. The use of this process in agricultural biogas plants allows disposal of hazardous waste, obtaining valuable fertilizer, while the production of ecologically clean fuel – biogas. The article presents the characteristics of organic waste from various industries, which make them suitable for use as substrates in agricultural biogas plants.

  12. Hygiene and sanitation requirements in Danish biogas plants

    Energy Technology Data Exchange (ETDEWEB)

    Bendixen, H.J.

    1997-08-01

    According to Danish regulations, systematic pathogen reducing treatment is required, when industrial by-products and waste products, and urban waste, ie garbage from households and sewage sludge, are processed, before being used - without restrictions - as fertilizers on agricultural land. An adequate pathogen reducing effect (PRE) can be achieved in the digestion tanks and sanitation tanks of the biogas plants, provided they are operated correctly and respect the criteria of the official requirements. The FS-method is a microbiological indicator method based on faecal streptococci (enterococci) (FS). It may be used to check the sanitation effect achieved by the treatment in a tank. The effect is expressed numerically by the log{sub 10}-reduction of the numbers of FS measured in the biomass before and after treatment. The PRE was examined in 10 large-scale biogas plants during a period of 2-3 years. It was demonstrated that properly directed and well-functioning thermophilic digestion tanks ensure the removal of most pathogenic microorganisms from organic waste and slurry. The removal of pathogens by the treatment in mesophilic digestion tanks is incomplete. Systematic studies of the processes of inactivation of bacteria and virus in slurry and in animal tissues gave evidence that the PRE is enhanced in the microbiological environment of thermophilic digestion tanks. The sanitation criteria, ie combinations of temperature/time, for the processing of biomass in digestion tanks and sanitation tanks in biogas plants are specified. (au) 19 refs.

  13. Effects of Co and Ni nanoparticles on biogas and methane production from anaerobic digestion of slurry

    International Nuclear Information System (INIS)

    Abdelsalam, E.; Samer, M.; Attia, Y.A.; Abdel-Hadi, M.A.; Hassan, H.E.; Badr, Y.

    2017-01-01

    Highlights: • The addition of trace metals in form of nanoparticles reduced the lag phase. • Nanoparticles reduced time to achieve the highest biogas and methane production. • Biogas and methane production were proportional to nanoparticles concentration. • Nanoparticles biostimulate the methanogenic bacteria and increase their activity. - Abstract: Nanoparticles (NPs) were hypothesized to enhance the anaerobic process and to accelerate the slurry digestion, which increases the biogas and methane production. The effects of NPs on biogas and methane production were investigated using a specially designed batch anaerobic system. For this purpose, a series of 2 L biodigesters were manufactured and implemented to study the effects of Cobalt (Co) and Nickel (Ni) nanoparticles with different concentrations on biogas and methane production. The best results of NPs additives were determined based on the statistical analysis (Least Significant Difference using M-Stat) of biogas and methane production, which were 1 mg/L Co NPs and 2 mg/L Ni NPs (p < 0.05). These NPs additives delivered the highest biogas and methane yields in comparison with their other concentrations (0.5, 1, and 2 mg/L), their salts (CoCl 2 , and NiCl 2 ) and the control. Furthermore, the addition of 1 mg/L Co NPs and 2 mg/L Ni NPs significantly increased the biogas volume (p < 0.05) by 1.64 and 1.74 times the biogas volume produced by the control, respectively. Moreover, the aforementioned additives significantly increased the methane volume (p < 0.05) by 1.86 and 2.01 times the methane volume produced by the control, respectively. The highest specific biogas and methane production were attained with 2 mg/L Ni NPs (p < 0.05), and were 614.5 ml Biogas g −1 VS and 361.6 ml CH 4 g −1 VS, respectively compared with the control which yielded only 352.6 ml Biogas g −1 VS and 179.6 ml CH 4 g −1 VS.

  14. Biocapture of CO2 by Different Microalgal-Based Technologies for Biogas Upgrading and Simultaneous Biogas Slurry Purification under Various Light Intensities and Photoperiods

    Science.gov (United States)

    Guo, Pengfei; Zhang, Yuejin; Zhao, Yongjun

    2018-01-01

    Co-cultivation of microalgae and microbes for pollutant removal from sewage is considered as an effective wastewater treatment method. The aim of this study is to screen the optimal photoperiod, light intensity and microalgae co-cultivation method for simultaneously removing nutrients in biogas slurry and capturing CO2 in biogas. The microalgae–fungi pellets are deemed to be a viable option because of their high specific growth rate and nutrient and CO2 removal efficiency under the photoperiod of 14 h light:10 h dark. The order of both the biogas slurry purification and biogas upgrading is ranked the same, that is Chlorella vulgaris–Ganoderma lucidum > Chlorella vulgaris–activated sludge > Chlorella vulgaris under different light intensities. For all cultivation methods, the moderate light intensity of 450 μmol m−2 s−1 is regarded as the best choice. This research revealed that the control of photoperiod and light intensity can promote the biological treatment process of biogas slurry purification and biogas upgrading using microalgal-based technology. PMID:29543784

  15. Biocapture of CO2 by Different Microalgal-Based Technologies for Biogas Upgrading and Simultaneous Biogas Slurry Purification under Various Light Intensities and Photoperiods

    Directory of Open Access Journals (Sweden)

    Pengfei Guo

    2018-03-01

    Full Text Available Co-cultivation of microalgae and microbes for pollutant removal from sewage is considered as an effective wastewater treatment method. The aim of this study is to screen the optimal photoperiod, light intensity and microalgae co-cultivation method for simultaneously removing nutrients in biogas slurry and capturing CO2 in biogas. The microalgae–fungi pellets are deemed to be a viable option because of their high specific growth rate and nutrient and CO2 removal efficiency under the photoperiod of 14 h light:10 h dark. The order of both the biogas slurry purification and biogas upgrading is ranked the same, that is Chlorella vulgaris–Ganoderma lucidum > Chlorella vulgaris–activated sludge > Chlorella vulgaris under different light intensities. For all cultivation methods, the moderate light intensity of 450 μmol m−2 s−1 is regarded as the best choice. This research revealed that the control of photoperiod and light intensity can promote the biological treatment process of biogas slurry purification and biogas upgrading using microalgal-based technology.

  16. Solar assisted biogas plants: Pt. 4. Optimum area for blackening and double glazing over a fixed-dome biogas plant

    Energy Technology Data Exchange (ETDEWEB)

    Jayashankar, B.C.; Kishor, J.; Goyal, I.C.; Sawhney, R.L.; Sodha, M.S.

    The economic analysis of a fixed-dome biogas plant of rated capacity 8 m/sup 3/, above which a part of the ground is blackened and doubly glazed in the cold climate of Srinagar is presented. Blackening and glazing of the ground cannot alone maintain the slurry temperature at 35/sup 0/C, which is the optimum temperature in the mesophilic range for the anaerobic digestion of cattle dung, and so a part of the biogas must be burnt. The electrical simulation experiments have been performed to determine the loss or gain of heat from the underground biodigestor to the ambient atmosphere through the ground if a part of the ground above is blackened and double glazed. Economic analysis of the system shows that the optimum area to be blackened and glazed would have a radius 1.5 times that of the biodigestor.

  17. Survival of Salmonella spp. and fecal indicator bacteria in Vietnamese biogas digesters receiving pig slurry

    DEFF Research Database (Denmark)

    Luu, Huong Quynh; Forslund, Anita; Madsen, Henry

    2014-01-01

    . and the fecal indicator bacteria, enterococci, E. coli, and spores of Clostridium perfringens in biogas digesters operated by small-scale Vietnamese pig farmers. The serovar and antimicrobial susceptibility of the Salmonella spp. isolated were also established. The study was conducted in 12 farms (6 farms...... digesters when comparing raw slurry and biogas effluent. Salmonella spp. was found in both raw slurry and biogas effluent. A total of 19 Salmonella serovars were identified, with the main serovars being Salmonella Typhimurium (55/138), Salmonella enterica serovar 4,[5],12:i:- (19/138), Salmonella...... Weltevreden (9/138) and Salmonella Rissen (9/138). The Salmonella serovars showed similar antimicrobial resistance patterns to those previously reported from Vietnam. When promoting biogas, farmers should be made aware that effluent should only be used as fertilizer for crops not consumed raw...

  18. Future biogas plants. New plant outlines and economic potential; Fremtidens biogasfaellesanlaeg. Nye anlaegskoncepter og oekonomisk potentiale

    Energy Technology Data Exchange (ETDEWEB)

    Christensen, Johannes (ed.)

    2006-06-16

    The Working Paper is the first joint reporting from a project aiming at identifying new outlines for joint biogas plants with profitable operation mainly based on slurry. So far a pre-requisition for profitable operation has been supply of 20-25% organic waste as supplement to the slurry, partly because organic waste increases gas production, and partly to collect recipient fee. The new outlines, which are analysed, represent different combinations of technology for separation, pre-treatment and re-circulation, including separation at each separate farm and separation of degassed slurry. Simultaneously with an increased gas yield, a number of synergy effects are achieved, which can contribute to ensure an environmentally friendly distribution and use of the nutrients, especially in areas with large concentrations of animal husbandry. (BA)

  19. Optimized construction of biogas plants; Optimierte Bauweise fuer Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2012-09-19

    Within the conference of the International Trade Fair for Biogas Plant Technology at 21st February, 2012 in Berlin, the following lectures were held: (1) Optimized dimensions of containers for small systems of liquid manure (Manfred Thalmann); (2) Microferm mini biogas plants (Bart Brouwer); (3) Fermentation of stackable biomass in rural biogas plant - The DeNaBa system (Christian Deterding); (4) The Sauter Biogas System for the fermentation of liquid manure, solid dung, and other residual materials (Stefan Sauter); (5) Bio-electricity: Controllable power generation by means of biogas plants (Matthias Sonnleitner); (6) Reduction of the effort and increase of the yield using UDR fixed bed technology (Alfred van den Berg); (7) Prestressed concrete container for biogas plants: Area of application - quality - options (Harald Feldmann); (8) Corrosion protection of agricultural and communal biogas plants (Michael Normann); (9) Fundamentals of efficient and effective flow generation in biogas plants (Kay Rotalski); (10) Rotary piston screw pistons and eccentric screw pumps (Thorsten Gilles).

  20. Promotion of biogas plant application in the Mekong Delta of Vietnam

    Energy Technology Data Exchange (ETDEWEB)

    Nguyen, Vo Chau Ngan

    2012-06-11

    for locally available materials to be used as additional inputs to pig manure (PM) in biogas plants, water hyacinth (WH) and spent mushroom compost (SMC) were chosen due to their potentials and availability. The testing results showed that codigestion of PM with either WH or SMC maintained the quality and quantity of produced biogas very well. The batch experiments of the PM+WH co-digestion indicated that the more percentage of WH containing in the feeding rate, the more biogas will be produced. The produced biogas was not significantly different between the treatment of 100%PM+0%SMC, of 75%PM+25%SMC, of 50%PM+50%SMC, and of 25%PM+75%SMC. In both of the cases, the produced biogas was in good quality with methane content reaching up to 60%. More significantly, the semi-continuous treatment of 75%PM+25%WH and of 75%PM+25%SMC were in good operation during a 90 consecutive day period without a blockage of the substrate even though the substrate was not agitated. In addition to the high potentials of WH and SMC as the additional materials, the bioslurries from the co-digesters had a positive response to cultivation and aquaculture. In the tests on the growth of leaf mustard fertilized separately with the bio-slurries from the different kinds of co-digestion plants (the plant fed solely with PM, with PM+WH, and with PM+SMC) and inorganic fertilizer (IF), the weight of the plant was not significantly different in the treatment of IF, of PM, and of PM+WH. The weight of the mustard fed with the bio-slurry from the PM+SMC co-digester was bigger than the others. By application of the bio-slurries into the fishpond, the growing weight of the fish was not significantly different from the treatment of PM, of PM+WH, and of PM+SMC. In the study, a new HDPE digester was developed and worked considerably well in the treatment of pig manure at the farming household. The testing results showed that this HDPE digester can make a relatively efficient treatment and produce biogas with

  1. Enhanced biogas recovery by applying post-digestion in large-scale centralized biogas plants

    DEFF Research Database (Denmark)

    Angelidaki, Irini; Hejnfelt, Anette; Ellegaard, L.

    2006-01-01

    The main objective of this study was to investigate the degradation efficiency of centralized biogas plants and provide guidance for the design of more efficient digester and post-digestion systems. These centralized biogas plants in Denmark digest manure together with organic waste from the food...... industry to generate biogas, which is used for electricity and thermal energy. A total of 20 such plants are currently active in Denmark, most of which were included in the investigation. From the plants, samples were obtained from various steps of the process. Samples were analysed and the residual biogas...... potential determined by batch post-digestion at various temperature levels. Results were correlated with plant characteristics and production statistics in order to judge the efficiency of various digestion concepts. A simplified model based on a two-step biogas production process was developed...

  2. Enteric and manure-derived methane emissions and biogas yield of slurry from dairy cows fed grass silage or maize silage with and without supplementation of rapeseed

    DEFF Research Database (Denmark)

    Hellwing, Anne Louise Frydendahl; Weisbjerg, Martin Riis; Møller, Henrik Bjarne

    2014-01-01

    to parity and days in milk. Two diets were based on maize silage with (MS+) or without (MS−) supplementation of crushed rapeseed, and the third diet was based on late cut grass silage without supplementation of crushed rapeseed (GS−). Dry matter intake, milk yield and composition were measured. Enteric......The aim of this study was to investigate the effect of three different dietary strategies on milk production and composition, enteric CH4 emissions, slurry storage losses of CH4 and total emissions of CH4 with and without biogas production. Fifty-four cows were allocated to three diets according......±standard deviation) was 25.3±2.5, 26.8±3.3 and 29.0±4.2 L CH4/kg ECM if manure was stored at 10 °C, 15 °C or 20 °C, respectively. When the slurry was digested in a laboratory scale biogas plant, the lowest total CH4 emissions per kg ECM were observed for MS+ (20.5 L CH4/ECM) and the highest for GS− (24.3 L CH4/ECM...

  3. Comparative life cycle assessment of biogas plant configurations for a demand oriented biogas supply for flexible power generation.

    Science.gov (United States)

    Hahn, Henning; Hartmann, Kilian; Bühle, Lutz; Wachendorf, Michael

    2015-03-01

    The environmental performance of biogas plant configurations for a demand - oriented biogas supply for flexible power generation is comparatively assessed in this study. Those configurations indicate an increased energy demand to operate the operational enhancements compared to conventional biogas plants supplying biogas for baseload power generation. However, findings show that in contrast to an alternative supply of power generators with natural gas, biogas supplied on demand by adapted biogas plant configurations saves greenhouse gas emissions by 54-65 g CO(2-eq) MJ(-1) and primary energy by about 1.17 MJ MJ(-1). In this regard, configurations with flexible biogas production profit from reduced biogas storage requirements and achieve higher savings compared to configurations with continuous biogas production. Using thicker biogas storage sheeting material reduces the methane permeability of up to 6m(3) d(-1) which equals a reduction of 8% of the configuration's total methane emissions. Copyright © 2014 Elsevier Ltd. All rights reserved.

  4. Development, Operation, and Future Prospects for Implementing Biogas Plants

    DEFF Research Database (Denmark)

    Lybæk, Rikke

    2014-01-01

    This chapter elaborates the different concepts of biogas technology understood in the Danish context. It emphasizes how energy from production of biogas is distributed, either as biogas to regional combined heat and power plants (CHP) or as district heating (DH) to small-scale local networks...... technology are emphasized: its capacity as a renewable energy and GHG-avoiding technology, and as a waste processing and environmental technology. It is argued that biogas can provide a future platform for the use of household waste and other types of organic materials (gas boosters) to enhance gas yield...... of developing new gas boosters to support a further development of the biogas sector. The chapter ends with a discussion of new trends in biogas production, for example, how new organizational models can be designed as well as how the use of alternative boosters—like blue biomass—can be applied. Finally, biogas...

  5. Process control in biogas plants

    DEFF Research Database (Denmark)

    Holm-Nielsen, Jens Bo; Oleskowicz-Popiel, Piotr

    2013-01-01

    (PAT) have been identified as some of the most promising on-line facilities for monitoring and controlling heterogeneous bioconversion processes. The future trend is to keep procedures as simple as possible, but to have available on-line monitoring systems with early warning strategies for plant...

  6. Biogas plants: Design, construction and operation

    International Nuclear Information System (INIS)

    2001-01-01

    At the big readiness of waste coming from the agricultural activities are looked for the production of Energy and Payments, the biogas like product of the organic decomposition under anaerobic conditions, their composition and characteristic. The elements that conform the design as the digester, the storage, the load tanks and it discharges and the conduction is described and analyzed. They are given a series of elements to obtain the characteristics of the system possible to place as: planning, calculations, evaluation, execution and operation. Lastly the steps are indicated that should be continued in the construction of the plant including planning for the work

  7. Investigation of factors influencing biogas production in a large-scale thermophilic municipal biogas plant

    Energy Technology Data Exchange (ETDEWEB)

    Weiss, Agnes; Jerome, Valerie; Freitag, Ruth [Bayreuth Univ. (Germany). Chair for Process Biotechnology; Burghardt, Diana; Likke, Likke; Peiffer, Stefan [Bayreuth Univ. (Germany). Dept. of Hydrology; Hofstetter, Eugen M. [RVT Process Equipment GmbH, Steinwiesen (Germany); Gabler, Ralf [BKW Biokraftwerke Fuerstenwalde GmbH, Fuerstenwalde (Germany)

    2009-10-15

    A continuously operated, thermophilic, municipal biogas plant was observed over 26 months (sampling twice per month) in regard to a number of physicochemical parameters and the biogas production. Biogas yields were put in correlation to parameters such as the volatile fatty acid concentration, the pH and the ammonium concentration. When the residing microbiota was classified via analysis of the 16S rRNA genes, most bacterial sequences matched with unidentified or uncultured bacteria from similar habitats. Of the archaeal sequences, 78.4% were identified as belonging to the genus Methanoculleus, which has not previously been reported for biogas plants, but is known to efficiently use H{sub 2} and CO{sub 2} produced by the degradation of fatty acids by syntrophic microorganisms. In order to further investigate the influence of varied amounts of ammonia (2-8 g/L) and volatile fatty acids on biogas production and composition (methane/CO{sub 2}), laboratory scale satellite experiments were performed in parallel to the technical plant. Finally, ammonia stripping of the process water of the technical plant was accomplished, a measure through which the ammonia entering the biogas reactor via the mash could be nearly halved, which increased the energy output of the biogas plant by almost 20%. (orig.)

  8. Analysis of operational methane emissions from pressure relief valves from biogas storages of biogas plants.

    Science.gov (United States)

    Reinelt, Torsten; Liebetrau, Jan; Nelles, Michael

    2016-10-01

    The study presents the development of a method for the long term monitoring of methane emissions from pressure relief valves (PRV(1)) of biogas storages, which has been verified during test series at two PRVs of two agricultural biogas plants located in Germany. The determined methane emission factors are 0.12gCH4kWhel(-1) (0.06% CH4-loss, within 106days, 161 triggering events, winter season) from biogas plant A and 6.80/7.44gCH4kWhel(-1) (3.60/3.88% CH4-loss, within 66days, 452 triggering events, summer season) from biogas plant B. Besides the operational state of the biogas plant (e.g. malfunction of the combined heat and power unit), the mode of operation of the biogas flare, which can be manually or automatically operated as well as the atmospheric conditions (e.g. drop of the atmospheric pressure) can also affect the biogas emission from PRVs. Copyright © 2016 Elsevier Ltd. All rights reserved.

  9. Process performance of biogas plants integrating pre-separation of manure

    Energy Technology Data Exchange (ETDEWEB)

    Moeller, Henrik B.; Nielsen, Anders M.; Hastrup Andersen, G.; Nakakubo, R. [Danish Inst. of Agricultural Sciences, Dept. of Agricultural Engineering, Horsens (Denmark)

    2006-08-15

    In terms of yield per volume the biogas production from liquid manure (slurry) is low, often causing a poor economical performance for plants treating manures as the only substrate. Pre-treatment of liquid manure by separation for producing a concentrated solid fraction increases significantly the biogas potential per waste volume. However there is no experience with the process performance of plants substituting liquid manure with varying amounts of concentrated manure solids. In the present study, different concepts integrating solid-liquid pre- and post separation were studied. In lab scale CSTR digesters liquid manure was substituted with varying amounts of the solid fraction from manure separation, starting with 20% substitution and ending with 60%. By increasing the substitution, the organic loading and the NH{sub 3} level will increase considerably. The process stability was evaluated by monitoring the VFA and NH{sub 4}-N levels at regular intervals. (au)

  10. Influence of soil organic C content on the greenhouse gas emission potential after application of biogas residues or cattle slurry - Results from a pot experiment

    Science.gov (United States)

    Heintze, Gawan

    2017-04-01

    Influence of soil organic C content on the greenhouse gas emission potential after application of biogas residues or cattle slurry - Results from a pot experiment Gawan Heintze1,2, Tim Eickenscheidt1, Urs Schmidthalter2 and Matthias Drösler1 1University of Applied Sciences Weihenstephan-Triesdorf, Chair of Vegetation Ecology, Weihenstephaner Berg 4, 85354 Freising, Germany 2Technische Universität München, Chair of Plant Nutrition, Emil-Ramann-Str. 2, 85354 Freising, Germany The European Union Renewable Energy Directive, which sets a binding target of a final energy consumption of 20% from renewable sources by 2020, has markedly promoted the increase of biogas plants, particularly in Germany. As a consequence, a large amount of biogas residue remains as a by-product of the fermentative process. These residues are now widely used instead of mineral fertilizers or animal slurries to maintain soil fertility and productivity. However, to date, the effect of the application of biogas residue on greenhouse gas (GHG) emission, compared to that of other organic fertilizers, is contradictory in literature, not having been completely understood. It is often stated that GHG fluxes are closely related to the quality of the raw material, particularly the type of soil to which the digestates are applied. This study addresses the questions (a) to what extent are the applications of biogas digestate and cattle slurry different in terms of their GHG emission (CO2, CH4 and N2O) potential, and (b) how do different soil organic carbon contents (SOCs) influence the rate of GHG exchange. We hypothesize that, i) cattle slurry application enhances the CO2 and N2O fluxes compared to the biogas digestate due to the overall higher C and N input, and ii) that with increasing SOC and N content, higher emissions of CO2 and N2O can be expected. The study was conducted as a pot experiment. Biogas digestate and cattle slurry were applied to and incorporated into three different soil types with

  11. Performance optimization of the Växtkraft biogas production plant

    International Nuclear Information System (INIS)

    Thorin, Eva; Lindmark, Johan; Nordlander, Eva; Odlare, Monica; Dahlquist, Erik; Kastensson, Jan; Leksell, Niklas; Pettersson, Carl-Magnus

    2012-01-01

    Highlights: ► Pre-treatment of ley crop can increase the biogas plant performance. ► Membrane filtration can increase the capacity of the biogas plant. ► Mechanical pre-treatment of the ley crop shows the highest energy efficiency. ► Using a distributor to spread the residues as fertilizer show promising results. -- Abstract: All over the world there is a strong interest and also potential for biogas production from organic residues as well as from different crops. However, to be commercially competitive with other types of fuels, efficiency improvements of the biogas production process are needed. In this paper, results of improvements studies done on a full scale co-digestion plant are presented. In the plant organic wastes from households and restaurants are mixed and digested with crops from pasture land. The areas for improvement of the plant addressed in this paper are treatment of the feed material to enhance the digestion rate, limitation of the ballast of organics in the water stream recirculated in the process, and use of the biogas plant residues at farms. Results from previous studies on pre-treatment and membrane filtration of recirculated process water are combined for an estimation of the total improvement potential. Further, the possibility of using neural networks to predict biogas production using historical data from the full-scale biogas plant was investigated. Results from an investigation using the process residues as fertilizer are also presented. The results indicate a potential to increase the biogas yield from the process with up to over 30% with pre-treatment of the feed and including membrane filtration in the process. Neural networks have the potential to be used for prediction of biogas production. Further, it is shown that the residues from biogas production can be used as fertilizers but that the emission of N 2 O from the fertilized soil is dependent on the soil type and spreading technology.

  12. Microbiologic handbook for biogas plants; Mikrobiologisk handbok foer biogasanlaeggningar

    Energy Technology Data Exchange (ETDEWEB)

    Jarvis, Aasa; Schnuerer, Anna

    2009-05-15

    There is today great interest in the biogas process. The reason for interest is that this process offers an opportunity to stabilize and reduce various types of organic waste, while also generating clean renewable energy in the form of biogas. Purified biogas is a good alternative to gasoline and diesel as motor fuel and can also be used for heating and electricity production. Behind efficient biogas production lies a complex microbiological process. For biogas to be formed many different species of microorganisms have to be active. A disturbance of this teamwork leads to a reduction in biogas production or in the worst case that the process stops. In order to operate a biogas process in an efficient manner, it is necessary to have knowledge of the underlying microbiology and how microorganisms function. Today Swedish biogas plants have personnel with great technical knowledge, while the biological knowledge often is more limited. It has been difficult to find appropriate Swedish language literature in the field. This handbook aims to increase the microbiological expertise of staff at the biogas plants and thus to facilitate the stable operation and optimization of gas production

  13. Energy and Greenhouse gas balances of the utilisation of biogas for energy

    DEFF Research Database (Denmark)

    Nielsen, Per Sieverts; Karlsson, Kenneth Bernard; Holm-Nielsen, Jens Bo

    1998-01-01

    of the implementation programmes has been on development of technologies for joint biogas plants, where more than one farm supplies the animal slurry. The joint biogas plants are dependent on industrial organic wastes to obtain high biogas yields for making the biogas plant economical. The industrial organic waste will...... biogas for energy. Two different Danish joint biogas plants are evaluated with the aim of determining the role of transportation and co-fermentation on the energy and the balance of greenhouse gases from the biogas fuel cycle....

  14. Advenella alkanexedens sp. nov., an alkane-degrading bacterium isolated from biogas slurry samples.

    Science.gov (United States)

    Wang, Huimin; Zhou, Shan; Wang, Yanwei; Kong, Delong; Guo, Xiang; Zhu, Jie; Dong, Weiwei; Ruan, Zhiyong

    2016-02-01

    A novel aerobic bacterium, designated strain LAM0050 T , was isolated from a biogas slurry sample, which had been enriched with diesel oil for 30 days. Cells of strain LAM0050 T were gram-stain-negative, non-motile, non-spore-forming and coccoid-shaped. The optimal temperature and pH for growth were 30-35 °C and 8.5, respectively. The strain did not require NaCl for growth, but tolerated up to 5.3 % (w/v) NaCl. Phylogenetic analysis of 16S rRNA gene sequences revealed that strain LAM0050 T was a member of the genus Advenella , and was most closely related to Advenella faeciporci KCTC 23732 T , Advenella incenata CCUG 45225 T , Advenella kashmirensis DSM 17095 T and Advenella mimigardefordensis DSM 17166 T , with 98.1, 96.6, 96.6 and 96.3 % sequence similarity, respectively. The DNA-DNA hybridization relatedness between strain LAM0050 T and A. faeciporci KCTC 23732 T was 41.7 ± 2.4 %. The genomic DNA G+C content was 51.2 mol%, as determined by the T m method. The major fatty acids of strain LAM0050 T were C 16 : 0 , C 17 : 0 cyclo, summed feature 3 (C 16 : 1 ω7 c and/or C 16 : 1 ω6 c ) and summed feature 8 (C 18 : 1 ω7 c and/or C 18 : 1 ω6 c ). The predominant ubiquinone was Q-8. The main polar lipids were diphosphatidyglycerol, phosphatidylethanolamine, phosphatidylmethylethanolamine and four unidentified phospholipids. Based on the phenotypic and genotypic properties, strain LAM0050 T is suggested to represent a novel species of the genus Advenella , for which the name Advenella alkanexedens sp. nov., is proposed, the type strain is LAM0050 T ( = ACCC 06485 T  = JCM 30465 T ).

  15. Detailed monitoring of two biogas plants and mechanical solid-liquid separation of fermentation residues.

    Science.gov (United States)

    Bauer, Alexander; Mayr, Herwig; Hopfner-Sixt, Katharina; Amon, Thomas

    2009-06-01

    The Austrian "green electricity act" (Okostromgesetz) has led to an increase in biogas power plant size and consequently to an increased use of biomass. A biogas power plant with a generating capacity of 500 kW(el) consumes up to 38,000 kg of biomass per day. 260 ha of cropland is required to produce this mass. The high water content of biomass necessitates a high transport volume for energy crops and fermentation residues. The transport and application of fermentation residues to farmland is the last step in this logistic chain. The use of fermentation residues as fertilizer closes the nutrient cycle and is a central element in the efficient use of biomass for power production. Treatment of fermentation residues by separation into liquid and solid phases may be a solution to the transport problem. This paper presents detailed results from the monitoring of two biogas plants and from the analysis of the separation of fermentation residues. Furthermore, two different separator technologies for the separation of fermentation residues of biogas plants were analyzed. The examined biogas plants correspond to the current technological state of the art and have designs developed specifically for the utilization of energy crops. The hydraulic retention time ranged between 45.0 and 83.7 days. The specific methane yields were 0.40-0.43 m(3)N CH(4) per kg VS. The volume loads ranged between 3.69 and 4.00 kg VS/m(3). The degree of degradation was between 77.3% and 82.14%. The screw extractor separator was better suited for biogas slurry separation than the rotary screen separator. The screw extractor separator exhibited a high throughput and good separation efficiency. The efficiency of slurry separation depended on the dry matter content of the fermentation residue. The higher the dry matter content, the higher the proportion of solid phase after separation. In this project, we found that the fermentation residues could be divided into 79.2% fluid phase with a dry matter

  16. Utilization of wasted sardine oil as co-substrate with pig slurry for biogas production--a pilot experience of decentralized industrial organic waste management in a Portuguese pig farm.

    Science.gov (United States)

    Ferreira, L; Duarte, E; Figueiredo, D

    2012-07-01

    This work aimed to demonstrate in a pig farm and in real conditions, the possibilities to co-digest wasted sardine oil (WSO) and pig slurry (PS) at farm scale. A biogas mobile pilot plant, was set up in the farm and operated in real conditions during 4 months. Dynamic mesophilic (35-37 °C) continuous pilot trials were performed during four different periods of time. In each period a different organic loading rate (OLR) based on the chemical oxygen demand (COD) was operated sequentially, with pig slurry (PS) (OLR = 1.6 kg COD/m(3) d(-1)) and with mixtures of WSO:PS with a volumetric composition (% v/v) of 2:98 (OLR = 3.0 kg COD/m(3) d(-1)), 3:97 (OLR = 3.7 kg COD/m(3) d(-1)) and 5:95 (OLR = 5.2 kg COD/m(3) d(-1)). Biomass adapted very fast in metabolise the WSO and biogas productivity was raised substantially for different compositions of WSO:PS. Process stability indicators pH and Total volatile fatty acids/bicarbonate alkalinity (T-VFA/BA) ratio, suggests that the co-digestion process was robust. It was concluded that WSO could be easily co-digested in farm scale biogas plants. Copyright © 2012. Published by Elsevier Ltd.

  17. Energy crops for biogas plants. Thuringia; Energiepflanzen fuer Biogasanlagen. Thueringen

    Energy Technology Data Exchange (ETDEWEB)

    Biertuempfel, A.; Bischof, R.; Conrad, M. (and others)

    2012-06-15

    In the brochure under consideration the Agency for Renewable Resources (Guelzow-Pruezen, Federal Republic of Germany) reports on the support of the implementation of different plant cultures in structure of plantations and crop rotation systems of companies under consideration of the Federal State Thuringia. The main chapters of this brochure are: Crops for the production of biogas; implementation in plantations; ensilage and biogas yields; economy of the cultivation of energy plants.

  18. Energy crops for biogas plants. Saxony; Energiepflanzen fuer Biogasanlagen. Sachsen

    Energy Technology Data Exchange (ETDEWEB)

    Biertuempfel, A.; Buttlar, C. von; Conrad, M. [and others

    2012-08-15

    In the brochure under consideration the Agency for Renewable Resources (Guelzow-Pruezen, Federal Republic of Germany) reports on the support of the implementation of different plant cultures in structure of plantations and crop rotation systems of companies under consideration of the Federal State Saxony. The main chapters of this brochure are: Crops for the production of biogas; implementation in plantations; ensilage and biogas yields; economy of the cultivation of energy plants.

  19. PRODUCTION, ECONOMIC AND ENVIRONMENTAL EFFECTS OF AGRICULTURAL BIOGAS PLANT IN KOSTKOWICE

    Directory of Open Access Journals (Sweden)

    Karol Węglarzy

    2017-06-01

    Full Text Available This paper presents the economic and ecological effect of Kostkowice Agricultural biogas plant based on a four year study carried out on the prototype installation. Agricultural biogas plant is part of the nature of the research conducted for twenty years at the National Research Institute of Animal PIB Experimental Station. Prof. Mieczyslaw Czaja relates to various aspects of environmental protection. It describes the economic justification for the production of energy from waste biomass (manure, slurry, wastes from feeding table, by the characteristics of substrates and products. It was found that agricultural biogas plant in rural areas are an important link in energy security, mainly due to the very high availability. Ecological effect is presented as effect of the installation solutions for the reduction of pollution of water, soil and air. Reducing greenhouse gas emissions through the recycling of environmentally harmful by-products of animal production of electricity and thermal energy, which is a substitute for environmentally harmful fossil fuels. The advantage of substances digestate is odorless, which is important both in an effort to improve the work culture in agriculture and improving living conditions in rural communities and it is an indisputable argument for the use of biomass for energy purposes.

  20. Local acceptance of existing biogas plants in Switzerland

    International Nuclear Information System (INIS)

    Soland, Martin; Steimer, Nora; Walter, Götz

    2013-01-01

    After the Swiss government's decision to decommission its five nuclear power plants by 2035, energy production from wind, biomass, biogas and photovoltaic is expected to increase significantly. Due to its many aspects of a direct democracy, high levels of public acceptance are necessary if a substantial increase in new renewable energy power plants is to be achieved in Switzerland. A survey of 502 citizens living near 19 biogas plants was conducted as the basis for using structural equation modeling to measure the effects of perceived benefits, perceived costs, trust towards the plant operator, perceived smell, information received and participation options on citizens’ acceptance of “their” biogas plant. Results show that local acceptance towards existing biogas power plants is relatively high in Switzerland. Perceived benefits and costs as well as trust towards the plant operator are highly correlated and have a significant effect on local acceptance. While smell perception and information received had a significant effect on local acceptance as well, no such effect was found for participation options. Reasons for the non-impact of participation options on local acceptance are discussed, and pathways for future research are presented. - Highlights: • Acceptance of biogas plants by local residents in Switzerland is relatively high. • Local acceptance is highly affected by perceived outcomes and citizens’ trust. • Smell perception increases perceived costs and reduces perceived benefits and trust. • Information offers reduce perceived costs and increase trust and perceived benefits. • Participation offers do not have any effect on local acceptance

  1. Isolation of lactic acid-forming bacteria from biogas plants.

    Science.gov (United States)

    Bohn, Jelena; Yüksel-Dadak, Aytül; Dröge, Stefan; König, Helmut

    2017-02-20

    Direct molecular approaches provide hints that lactic acid bacteria play an important role in the degradation process of organic material to methanogenetic substrates in biogas plants. However, their diversity in biogas fermenter samples has not been analyzed in detail yet. For that reason, five different biogas fermenters, which were fed mainly with maize silage and manure from cattle or pigs, were examined for the occurrence of lactic acid-forming bacteria. A total of 197 lactic acid-forming bacterial strains were isolated, which we assigned to 21 species, belonging to the genera Bacillus, Clostridium, Lactobacillus, Pediococcus, Streptococcus and Pseudoramibacter-related. A qualitative multiplex system and a real-time quantitative PCR could be developed for most isolates, realized by the selection of specific primers. Their role in biogas plants was discussed on the basis of the quantitative results and on physiological data of the isolates. Copyright © 2016. Published by Elsevier B.V.

  2. Methane production and energy evaluation of a farm scaled biogas plant in cold climate area.

    Science.gov (United States)

    Fjørtoft, Kristian; Morken, John; Hanssen, Jon Fredrik; Briseid, Tormod

    2014-10-01

    The aim of this study was to investigate the specific methane production and the energy balance at a small farm scaled mesophilic biogas plant in a cold climate area. The main substrate was dairy cow slurry. Fish silage was used as co-substrate for two of the three test periods. Energy production, substrate volumes and thermal and electric energy consumption was monitored. Methane production depended mainly on type and amount of substrates, while energy consumption depended mainly on the ambient temperature. During summer the main thermal energy consumption was caused by heating of new substrates, while covering for thermal energy losses from digester and pipes required most thermal energy during winter. Fish silage gave a total energy production of 1623 k Wh/m(3), while the dairy cow slurry produced 79 k Wh/m(3) slurry. Total energy demand at the plant varied between 26.9% and 88.2% of the energy produced. Copyright © 2014 Elsevier Ltd. All rights reserved.

  3. Methodology for Analysing Energy Demand in Biogas Production Plants—A Comparative Study of Two Biogas Plants

    Directory of Open Access Journals (Sweden)

    Emma Lindkvist

    2017-11-01

    Full Text Available Biogas production through anaerobic digestion may play an important role in a circular economy because of the opportunity to produce a renewable fuel from organic waste. However, the production of biogas may require energy in the form of heat and electricity. Therefore, resource-effective biogas production must consider both biological and energy performance. For the individual biogas plant to improve its energy performance, a robust methodology to analyse and evaluate the energy demand on a detailed level is needed. Moreover, to compare the energy performance of different biogas plants, a methodology with a consistent terminology, system boundary and procedure is vital. The aim of this study was to develop a methodology for analysing the energy demand in biogas plants on a detailed level. In the methodology, the energy carriers are allocated to: (1 sub-processes (e.g., pretreatment, anaerobic digestion, gas cleaning, (2 unit processes (e.g., heating, mixing, pumping, lighting and (3 a combination of these. For a thorough energy analysis, a combination of allocations is recommended. The methodology was validated by applying it to two different biogas plants. The results show that the methodology is applicable to biogas plants with different configurations of their production system.

  4. Effects of digestate from anaerobically digested cattle slurry and plant materials on soil microbial community and emission of CO2 and N2O

    DEFF Research Database (Denmark)

    Johansen, Anders; Carter, Mette Sustmann; Jensen, Erik S.

    2013-01-01

    Anaerobic digestion of animal manure and crop residues may be employed to produce biogas as a climate-neutral source of energy and to recycle plant nutrients as fertilizers. However, especially organic farmers are concerned that fertilizing with the digestates may impact the soil microbiota...... of the other treatments during the 9 days. Regarding microbial community composition, grass-clover induced the largest changes in microbial diversity measures compared to the controls, where raw cattle slurry and the two anaerobically digested materials (cattle slurry/maize, cattle slurry/grass-clover) only...... induced minor and transient changes....

  5. Monitoring of biogas plants - experiences in laboratory and full scale

    Directory of Open Access Journals (Sweden)

    B. Habermann

    2015-04-01

    Full Text Available To control and regulate the biogas process there are online process parameters and offline process parameters, which basically don’t differ between pilot biogas plants and industrial biogas plants. Generally, temperature, pH-value, volume flow rate and sometimes redox potential are measured online. An online-measurement of the dissolved volatile fatty acids and an online-detection of dissolved hydrogen both directly in the liquid phase as well as near-infrared spectroscopy are under development. FOS/TAC-analysis is the most common offline-analysis of the biogas process and normally it is carried out by the plant operator directly at the biogas plant. For example dry matter, organic dry matter, nitrogen and fatty acids are other analyses, which are carried out but by a laboratory. Microbiological analyses of biogas plants are very expensive and time-consuming and are therefore in Germany very rare. Microbiological analyses are mainly for research purposes. For example the Fluorescence in situ Hybridiation (FISH is used for characterization of the populations. Electric-optical measurement should be established as a new method to investigate the vitality of the methane producing microorganisms. In a cooperation project, which is promoted by the German ministry for technology, between IASP and Chair of Bioprocess Engineering at TU Berlin, this method is proper investigated using a device from the firm EloSystems. The microorganisms are brought in an electrical field of different frequencies. In this field the microorganisms direct themselves differently according to their physiological state. At the end of this project an early detection of process disturbance will be possible with the help of this method. In this presentation the result of the first tests are presented.

  6. LED-Absorption-QEPAS Sensor for Biogas Plants

    Directory of Open Access Journals (Sweden)

    Michael Köhring

    2015-05-01

    Full Text Available A new sensor for methane and carbon dioxide concentration measurements in biogas plants is presented. LEDs in the mid infrared spectral region are implemented as low cost light source. The combination of quartz-enhanced photoacoustic spectroscopy with an absorption path leads to a sensor setup suitable for the harsh application environment. The sensor system contains an electronics unit and the two gas sensors; it was designed to work as standalone device and was tested in a biogas plant for several weeks. Gas concentration dependent measurements show a precision better than 1% in a range between 40% and 60% target gas concentration for both sensors. Concentration dependent measurements with different background gases show a considerable decrease in cross sensitivity against the major components of biogas in direct comparison to common absorption based sensors.

  7. Cooperative biogas plants. Economic results and analyses. Status report 1998

    International Nuclear Information System (INIS)

    Hjort-Gregersen, K.

    1998-11-01

    The years 1995 - 1998 have been characterised by stabilisation of operation and economy of the Danish co-operative biogas plants. Most of the plants have obtained increasingly better economic results although the increase has been less significant than during earlier periods. There are several reasons for the increase. Most of the plants have been able to increase the sales income because of larger amounts of biomass available resulting in an increased biogas production. Furthermore it has been possible to contain the income level for biomass receipt. Several plants have established gas collection in storage tanks, which has resulted in increased gas yield. The operational stability related to both technique and processes have improved. The operational costs have been stabilised and are under control at most of the plants. The improved economic results have resulted in most of the plants having a satisfactory operation and economy. However, it must be stressed that some of the oldest plants have not been able to settle the investment dept at normal conditions. Also some, even rather new plants, still are in a difficult economic situation. Most of the plants established in the 90'ies have had a good start both operationally and economically. Thus the economic risk of establishing a plant has been reduced compared to earlier years. Generally the prerequisites for establishing a biogas plant are favourable economic conditions and quality assurance of the project. (LN)

  8. biogas

    DEFF Research Database (Denmark)

    2015-01-01

    Functions for working with biogas data. Both low- and high-level functions are included for carrying out common tasks for analysis of biogas and related data. Molar mass and calculated oxygen demand (COD') can be determined from a chemical formula. Measured gas volume can be corrected for water...... vapor and to (possibly user-defined) standard temperature and pressure. Gas composition, cumulative production, or other variables can be interpolated to a specified time. Cumulative biogas and methane production (and rates) can be calculated using volumetric, manometric, or gravimetric methods for any...... be summarized in several different ways (e.g., omitting normalization) using the same function. Lastly, biogas and methane production can be predicted from substrate composition and additional, optional data....

  9. Total methane loss from biogas plants, determined by tracer dispersion measurements

    DEFF Research Database (Denmark)

    Fredenslund, Anders Michael; Scheutz, Charlotte

    2017-01-01

    Methane losses from biogas plants are problematic, since methane emitted into the atmosphere contributes to global warming, and any losses may thus reduce the environmental benefits of biogas production. A tracer gas dispersion method was used to measure total methane emissions from seven biogas ...... the detection and quantification of individual leaks at the plants require other methods....

  10. The Fuzzy WOD Model with application to biogas plant location

    DEFF Research Database (Denmark)

    Franco, Camilo; Bojesen, Mikkel; Hougaard, Jens Leth

    2014-01-01

    be expressed by degrees of intensity in which the alternatives satisfy the given criteria. Hence, such degrees can be gradually expressed either by unique values or by intervals, in order to fully represent the characteristics of each alternative. This paper examines the selection of biogas plant location...

  11. The success of biogas plants in Nepal: a note on gender

    NARCIS (Netherlands)

    Opdam, J.H.M.

    1997-01-01

    This article describes a successful programme to disseminate biogas plants in Nepal, and summarises the findings of various studies on the impact of the biogas technology on the quality of life of women.

  12. Biogas production generated through continuous digestion of natural and cultivated seaweeds with dairy slurry.

    Science.gov (United States)

    Tabassum, Muhammad Rizwan; Wall, David M; Murphy, Jerry D

    2016-11-01

    The technical feasibility of long term anaerobic mono-digestion of two brown seaweeds, and co-digestion of both seaweeds with dairy slurry was investigated whilst increasing the organic loading rate (OLR). One seaweed was natural (L. digitata); the second seaweed (S. Latissima) was cultivated. Higher proportions of L. digitata in co-digestion (66.6%) allowed the digester to operate more efficiently (OLR of 5kgVSm(-3)d(-1) achieving a specific methane yield (SMY) of 232LCH4kg(-1)VS) as compared to lower proportions (33.3%). Co-digestion of 66.6% cultivated S. latissima, with dairy slurry allowed a higher SMY of 252LCH4kg(-1)VS but at a lower OLR of 4kgVSm(-3)d(-1). Optimum conditions for mono-digestion of both seaweeds were effected at 4kgVSm(-3)d(-1). Chloride concentrations increased to high levels in the digestion of both seaweeds but were not detrimental to operation. Copyright © 2016 Elsevier Ltd. All rights reserved.

  13. Hanford Waste Vitrification Plant full-scale feed preparation testing with water and process simulant slurries

    International Nuclear Information System (INIS)

    Gaskill, J.R.; Larson, D.E.; Abrigo, G.P.

    1996-03-01

    The Hanford Waste Vitrification Plant was intended to convert selected, pretreated defense high-level waste and transuranic waste from the Hanford Site into a borosilicate glass. A full-scale testing program was conducted with nonradioactive waste simulants to develop information for process and equipment design of the feed-preparation system. The equipment systems tested included the Slurry Receipt and Adjustment Tank, Slurry Mix Evaporator, and Melter-Feed Tank. The areas of data generation included heat transfer (boiling, heating, and cooling), slurry mixing, slurry pumping and transport, slurry sampling, and process chemistry. 13 refs., 129 figs., 68 tabs

  14. Hanford Waste Vitrification Plant full-scale feed preparation testing with water and process simulant slurries

    Energy Technology Data Exchange (ETDEWEB)

    Gaskill, J.R.; Larson, D.E.; Abrigo, G.P. [and others

    1996-03-01

    The Hanford Waste Vitrification Plant was intended to convert selected, pretreated defense high-level waste and transuranic waste from the Hanford Site into a borosilicate glass. A full-scale testing program was conducted with nonradioactive waste simulants to develop information for process and equipment design of the feed-preparation system. The equipment systems tested included the Slurry Receipt and Adjustment Tank, Slurry Mix Evaporator, and Melter-Feed Tank. The areas of data generation included heat transfer (boiling, heating, and cooling), slurry mixing, slurry pumping and transport, slurry sampling, and process chemistry. 13 refs., 129 figs., 68 tabs.

  15. Economical and ecological benchmarking of biogas plant configurations for flexible power generation in future power supply systems

    International Nuclear Information System (INIS)

    Hahn, Henning

    2016-01-01

    With the share of intermittent renewable energies within the electricity system rising, balancing services from dispatchable power plants are of increasing importance. This study comparatively assesses the environmental and economic performance of biogas plant configurations, supplying biogas on demand for flexible power generation. A cost analysis of five configurations based on biogas storing and flexible biogas production concepts has been carried out. Results show that additional flexibility costs for a biogas supply of 8 hours per day range between 2 Euro to 11 Euro MWh -1 and for a 72 hour period without biogas demand from 9 Euro to 19 Euro MWh -1 . While biogas storage concepts were identified as favorable short-term supply configurations, flexible biogas production concepts profit from reduced storage requirements at plants with large biogas production capacities or for longer periods without biogas demand [1, 2]. Flexible biogas plant configurations indicate an increased energy demand to operate the operational enhancements compared to conventional biogas plants supplying biogas for baseload power generation. However, findings show that in contrast to an alternative supply of power generators with natural gas, biogas supplied on demand by adapted biogas plant configurations saves greenhouse gas emissions by 54 to 65 g CO 2-eq MJ -1 and primary energy by about 1.17 MJ MJ -1 . In this regard, configurations with flexible biogas production profit from reduced biogas storage requirements and achieve higher savings compared to configurations with continuous biogas production [1, 3].

  16. Enhancing identified circular economic benefits related to the deployment off Solrød biogas plant

    DEFF Research Database (Denmark)

    Lybæk, Rikke

    This paper investigates how experiences from the deployment of Solrød biogas plant in Denmark - a large scale centralized biogas plant - can assist future biogas technologies in achieving Circular Economic benefits. Departing from a theoretical understanding of Circular Economy provided by Ellen...... energy market. Finally, the paper suggests how to qualify the Circular Economic concept based on the finding from Solrød biogas plant. It is here concluded, that emphasis should be on cascading energy from the biogas production by means of Combined Heat and Power (CHP), district heating or process heat...

  17. Efficiency of biogas slurry and Burkholderia phytofirmans PsJN to improve growth, physiology, and antioxidant activity of Brassica napus L. in chromium-contaminated soil.

    Science.gov (United States)

    Nafees, Muhammad; Ali, Shafaqat; Naveed, Muhammad; Rizwan, Muhammad

    2018-03-01

    Contamination of soil is a major problem globally with colligated danger for ecosystem and human health. Chromium (Cr) is a toxic heavy metal and caused harmful effect on growth and development of plants. Phytostabilization reduced the mobility of heavy metals with addition of amendments which can significantly decrease metal solubility in soil. Phytostabilization can be achieved by application of biogas slurry (BGS) and endophytic bacteria as amendments in the contaminated soils. The present study revealed that the Burkholderia phytofirmans PsJN and BGS improved the growth, physiology, and antioxidant activity and reduced Cr uptake under a pot experiment spiked with Cr (20 mg kg -1 soil). The experiment was designed under completely randomized design, four treatments with three replications in normal and Cr-contaminated soil. The inoculation of endophytic bacteria improved the growth and physiology of Brassica. This study showed that the inoculation of endophytic bacteria stabilized the Cr levels in soil and minimized the uptake by the plant shoots and roots in BGS-amended soil. Similarly, activity of antioxidants such as catalase (CAT), reduced glutathione (GSH), glutathione peroxidase (GSH-Px), and glutathione s-transferase (GST) was decreased to normal with combined treatment of BGS and endophytic bacteria in Cr-stressed soil. Overall, the best results were analyzed by combined treatment of BGS and endophytic bacteria to improve growth, physiology, and antioxidant activity of Brassica and immobilize Cr in soil. Moreover, results emphasized the need to use BGS alone or in combination with endophytic bacteria to optimize crop performance, stabilize Cr concentration, and improve environmental efficiency.

  18. Establishment of a biogas grid and interaction between a biogas grid and a natural gas grid

    Energy Technology Data Exchange (ETDEWEB)

    Kvist, T.

    2011-01-15

    The project has aimed to clarify the advantages and disadvantages of a large biogas net in Ringkoebing Skjern municipality in Denmark, which wants to become self-sufficient in renewable energy by 2020. It is estimated that the biogas potential in the municipality is about. 60 mill. m3 methane gas a year. Half of the methane will be generated by digesting 80 % of the area's slurry, while the other half will be produced from energy crops. It will require an area equivalent to 5 % of the municipality's farmland. The idea is to establish decentralized 60-80 and 1-3 large centralized biogas plants, and that the produced biogas is distributed to natural gas-fired decentralized power plants. Based on this framework, a number of issues for the establishment of a biogas net have been investigated. These are: - the relation between biogas production and demand; - biogas compared to the overall energy system, - purification and measurement of biogas; - conversion of natural gas-fired power plants to biogas; - the value of biogas for cogeneration plants; - design of a biogas distribution net; - ownership and accountability; - potential business models. (LN)

  19. Effect of inoculum and sulfide type on simultaneous hydrogen sulfide removal from biogas and nitrogen removal from swine slurry and microbial mechanism.

    Science.gov (United States)

    Wang, Lan; Wei, Benping; Chen, Ziai; Deng, Liangwei; Song, Li; Wang, Shuang; Zheng, Dan; Liu, Yi; Pu, Xiaodong; Zhang, Yunhong

    2015-12-01

    Four reactors were initiated to study the effect of inoculum and sulfide type on the simultaneous hydrogen sulfide removal from biogas and nitrogen removal from swine slurry (Ssu-Nir) process. Anaerobic sludge, aerobic sludge, and water were used as inocula, and Na2S and biogas were used as a sulfide substrate, respectively. Additionally, 454 pyrosequencing of the 16S rRNA gene was used to explore the bacterial diversity. The results showed that sulfur-oxidizing bacteria (Thiobacillus, 42.2-84.4 %) were dominant in Ssu-Nir process and led to the excellent performance. Aerobic sludge was more suitable for inoculation of the Ssu-Nir process because it is better for rapidly enriching dominant sulfur-oxidizing bacteria (Thiobacillus, 54.4 %), denitrifying sulfur-oxidizing bacteria (40.0 %) and denitrifiers (23.9 %). Lower S(2-) removal efficiency (72.6 %) and NO3 (-) removal efficiency (biogas as a sulfide substrate than when Na2S was used. For the Ssu-Nir process with biogas as the sulfide substrate, limiting H2S absorption caused a high relative abundance of sulfur-oxidizing bacteria, Thiobacillus (84.8 %) and Thiobacillus sayanicus (39.6 %), which in turn led to low relative abundance of denitrifiers (1.6 %) and denitrifying sulfur-oxidizing bacteria (24.4 %), low NO3 (-) removal efficiency, and eventually poor performance.

  20. Design and operation of small biogas plants

    Energy Technology Data Exchange (ETDEWEB)

    Abdel-Dayem, A.M.; Hamad, M.A.

    1980-12-01

    This paper concentrates on the experience gained from the adaptation of the Chinese biogas technology to rural areas of Egypt. Three different prototype digesters have been constructed. The first is a 10 M/sup 3/ rectangular digester of the water pressure type, the second is a 6 M/sup 3/ circular and shallow digester with domed roof and dished bottom. The third prototype unit with a capacity of 7 M/sup 3/ has been recently constructed. It combines the features of both plug flow and the Indian movable cap types. Provisions for solar heating of feed water, composting of effluent and attachments to both latrine and animal shed were incorporated in the unit. The structural theory, design criteria, construction technique and cost estimation of the circular digester are described. Some operation and performance data of the circular digester are presented. This covers the effects of variation of ambient temperature on internal temperature, effects of temperature and pressure on the gas production rate and composition.

  1. The commercialization of biogas production

    International Nuclear Information System (INIS)

    Christensen, J.

    1992-01-01

    Currently there are ten large collective biogas plants and ten smaller farm plants operating in Denmark. During the last five years, biogas technology has undergone extensive technological development. The developmental process is supported by a public R and D programme and a follow-up programme for full-scale demonstration plants. Most plants still need considerable income increases before a final conclusion can be reached as to whether it is possible to achieve a profit from a corporate economic viewpoint. All plants have received investment grants. Gas production is in most cases reliable, especially due to the admixture of easily convertible organic waste as a supplement to the slurry supplies. Profitable collective biogas plants are within reach, even without investment grants. The total intake of biomass must be supplemented by 10 to 25 per cent easily convertible organic waste so that the minimum gas production reaches 30 to 35 m 3 per m 3 of biomass. Plants based solely on animal manure are not profitable. Energy from the biogas has to be sold at prices corresponding to consumer prices, which include Danish energy taxes. Collective biogas plants in Denmark appear to be approaching a commercial breakthrough. The concept of a collective biogas plant has been developed to address the energy-related, environmentally-related and agricultural problems. (AB)

  2. State-of-the-art of large scale biogas plants

    International Nuclear Information System (INIS)

    Prisum, J.M.; Noergaard, P.

    1992-01-01

    A survey of the technological state of large scale biogas plants in Europe treating manure is given. 83 plants are in operation at present. Of these, 16 are centralised digestion plants. Transport costs at centralised digestion plants amounts to between 25 and 40 percent of the total operational costs. Various transport equipment is used. Most large scale digesters are CSTRs, but serial, contact, 2-step, and plug-flow digesters are also found. Construction materials are mostly steel and concrete. Mesophilic digestion is most common (56%), thermophilic digestion is used in 17% of the plants, combined mesophilic and thermophilic digestion is used in 28% of the centralised plants. Mixing of digester content is performed with gas injection, propellers, and gas-liquid displacement. Heating is carried out using external or internal heat exchangers. Heat recovery is only used in Denmark. Gas purification equipment is commonplace, but not often needed. Several plants use separation of the digested manure, often as part of a post-treatment/-purification process or for the production of 'compost'. Screens, sieve belt separaters, centrifuges and filter presses are employed. The use of biogas varies considerably. In some cases, combined heat and power stations are supplying the grid and district heating systems. Other plants use only either the electricity or heat. (au)

  3. Biogas production from Eichhornia crassipes aquatic plant; Producao de biogas a partir da planta aquatica Eichhornia crassipes

    Energy Technology Data Exchange (ETDEWEB)

    Pereira, Roberto Guimaraes; Silva, Jose Goncalves da; Fernandes Filho, Jorge; Pereira, Maria Cristina Duarte Eiras [Universidade Federal Fluminense (UFF), Niteroi, RJ (Brazil). Dept. de Engenharia Mecanica. Programa de Pos-Graduacao em Engenharia Mecanica]. E-mail: temrobe@vm.uff.br; Melo, Ricardo Bichara de [Light Servicos de Eletricidade S.A., Rio de Janeiro, RJ (Brazil)]. E-mail: rbmelo@light.com.br

    2004-07-01

    Virtually all plants and waste plants and animals may in some way be used as an energy source. The anaerobic digestion of these materials is an option, resulting in the biogas. Besides the gas obtained in the process, is produced, inside the biodigester, an excellent fertilizer. The aquatic plant Eichhornia crassipes is found in large quantities in various water bodies, such as reservoirs, lakes and ponds, becoming mostly often a big problem and it is necessary its systematic removal of water. The bench biodigester used in the experiment of biodigestion of aquatic plants is composed of a reactor containing the biomass, where the biogas is produced, and a reservoir to monitor the production of biogas. The reactor is located within a receptacle containing water that can be heated by an electrical resistance, with the purpose of maintaining the temperature inside the reactor around 35 deg C. The results of analysis of gas of the reactor made in a gas chromatograph to CG MASTER of double ionization detector with a flame and thermal conductivity, show a percentage of 50% of methane in the biogas. The process of biodigestion of aquatic plant Eichhornia crassipes shows potential to obtain biogas, with considerable levels of methane in order to make its exploitation. Also, were analyzed the biomass in the biodigester for determination of humid, total organic matter, mineral and organic carbon residue.

  4. CONTEXT MATTERS: THE IMPORTANCE OF MARKET CHARACTERISTICS IN THE VOLATILITY OF FEEDSTOCK COSTS FOR BIOGAS PLANTS.

    Science.gov (United States)

    Mertens, A; Van Meensel, J; Mondelaers, K; Buysse, J

    2015-01-01

    Recently, biogas plant managers in Flanders face increased financial uncertainty. Between 2011 and 2012, 20% of the Flemish biogas plants went bankrupt. Difficulties in obtaining feedstock at stable and affordable prices is one reason why the biogas sector struggles. In literature, contracting is often proposed as a way to decrease the volatility of the feedstock costs. However, these studies generally do not consider the context in which the biogas plant manager needs to buy the feedstock. Yet, this context could be of specific importance when biogas plant managers are in competition with other users of the same biomass type. Silage maize is an example of such a feedstock, as it is both used by dairy farmers and biogas plant managers. Using a combination of qualitative research and agent-based modelling, we investigated the effect of specific characteristics of the silage maize market on the acquisition of local silage maize by biogas plant managers. This paper details the institutional arrangements of the silage maize market in Flanders and the results of a scenario analysis, simulating three different scenarios. As shown by the results, the time of entry into the market, as well as the different institutional arrangements used by the biogas plant managers as opposed to dairy farmers could explain the difficulties in obtaining a stable supply of local silage maize by biogas plants. Our findings can help to develop mitigation strategies addressing these difficulties.

  5. Biodigestion of the aquatics plants mixtures and biogas production; Biodigestao de misturas de plantas aquaticas e producao de biogas

    Energy Technology Data Exchange (ETDEWEB)

    Pereira, Roberto Guimaraes; Abreu, Fernando Luiz Barbuda de; Fernandes Filho, Jorge; Pereira, Maria Cristina Duarte Eiras [Universidade Federal Fluminense (UFF), Niteroi, RJ (Brazil). Dept. de Engenharia Mecanica. Programa de Pos-Graduacao em Engenharia Mecanica]. E-mail: temrobe@vm.uff.br; Melo, Ricardo Bichara de [Light Servicos de Eletricidade S.A., Rio de Janeiro, RJ (Brazil). Gerencia de Estudos e Gestao de Geracao]. E-mail: rbmelo@light.com.br

    2004-07-01

    Several systems of generating electricity using water storage reservoirs. One problem that occurs constantly in these reservoirs is the accumulation of aquatic plants, such as Eichhornia crassipes, Eichhornia azurea, Pistia stratiotes and Salvinia that may cause serious problems for the system. Periodically, the biomass must be removed and disposed of appropriate form, so that does not cause contamination of soil, groundwater or allowing the proliferation of vectors. One possible destination is the use of biomass in a process of biodigestion, resulting in biogas. The bench of biodigester used in the experiment of biodigestion of aquatic plants is composed of a reactor containing the biomass, where the biogas is produced and a reservoir for the monitoring the production of biogas. The reactor is located inside a container containing water that can be heated by an electrical resistance, with the aim of maintaining the temperature inside the reactor around 35 deg C. The results of analysis of gas of the reactor was obtained using a gas chromatograph to CG MASTER of double ionization detector with a flame and thermal conductivity. These results show a percentage of 50% of methane in the biogas. Also, were analyzed the biomass in the biodigester for determination of humidity, total organic matter, waste mineral and organic carbon. The process of biodigestion of the mixture of aquatic plants: Eichhornia crassipes, Eichhornia azurea and Pistia stratiotes and Salvinia shows potential for obtaining biogas, with considerable levels of methane, in order to facilitate its recovery.

  6. Comparative review of foam formation in biogas plants and ruminant bloat

    Energy Technology Data Exchange (ETDEWEB)

    Moeller, Lucie; Goersch, Kati; Zehnsdorf, Andreas; Mueller, Roland Arno [UFZ - Helmholtz Centre for Environmental Research, Leipzig (Germany). Environmental and Biotechnology Centre; Neuhaus, Juergen [Leipzig Univ. (Germany). Inst. of Bacteriology and Mycology

    2012-12-15

    This review gives an overview of the current knowledge concerning the problem of foam formation in the process of anaerobic digestion in biogas plants that utilize renewable resources or biogenic waste material for biogas production. Process upsets in biogas production induced by foam formation can have a negative impact on the efficiency of biogas plants. The foam can block gas pipes and cause severe damage to the bioreactor equipment, ranging from a failure of the feeders to a damage of the roof of the biogas plant. The most common foam removal methods - stirring in the foam, adding anti-foaming agents, diminishing substrate feeding, and altering the biogas reactor management - are not always successful. However, the reasons for the excessive foam formation during the biogas production process have not yet been elucidated in detail. In contrast, foam building in the rumen of ruminants as a cause for bloat has been studied thoroughly. In general, the interaction between proteins, polysaccharides (mucilage), and small plant particles is assumed to be the crucial factor. As the fermentation process in the rumen has many similarities with the biogas production process, the current research results on bloat in ruminants are summarized and compared with the process of foaming in biogas plants. (orig.)

  7. Promoting use of bio-gas in India

    International Nuclear Information System (INIS)

    Saha, S.L.

    1994-01-01

    Biogas is a single energy source with multiple benefits. Biogas is an environment friendly cheap fuel for rural areas. Fuel-gas from organic materials like cattle dung, night-soil, poultry droppings, sludge, waste water etc., without destroying their manurial value, accrues many social benefits particularly for women and children. Biogas plant improve rural sanitation, life style of rural folks and reduce pressure on forests. Biogas slurry offers a cheap, entirely organic and indigenous alternative fertilizer. Rural electrification at a reasonable cost is possible by using the available crop residues and other biomass waste. This waste can yield wealth by using it to produce energy for the industry and for homes. (author)

  8. Economic and ecological evaluation of biogas plant configurations for a demand oriented biogas supply for flexible power generation

    International Nuclear Information System (INIS)

    Hahn, Henning

    2015-01-01

    The transformation of the power supply towards renewable energy (RE) sources will depend on a large scale of fluctuating RE sources, primarily of wind energy and photovoltaics. However, the variable power generation of these renewable sources will lead to an increased need of flexible power producers in order to balance differences between energy generation and consumption. Among the different types of RE sources, biogas plants have the advantage that their input biomass and the produced biogas can be stored and electricity can consequently be generated on demand. Since electricity from biogas has not been used to balance fluctuations of intermittent RE in the past, new concepts are required. These concepts should be able to meet the requirements of highly renewable electricity systems and to supply biogas according to the varying demand for long-and short-term balance power generation. In this regard, this thesis focused on the identification of biogas plant concepts for flexible power generation, as well as on ranking them regarding their economic and life cycle performance.

  9. The biogas

    International Nuclear Information System (INIS)

    Rigaud, Ch.; Laffargue, C.; Zebboud, I.

    2007-01-01

    Mixed of methane and carbon dioxide the biogas can be produced by many sources for the heat or the electricity production and the fuel production. This document aims to better understand the biogas, its characteristics, its valorization, the plants concerned, the installations and the regulation. It provides also an example of a biogas power plant and the biogas use in the farms. (A.L.B.)

  10. Analysis on Reduction of Greenhouse Gas Emissions by the Introduction of a Bio-methane Production Plant Using Dairy Cow Slurry as the Main Ingredient, and Management Balance of the Plant

    Science.gov (United States)

    Ohkubo, Takashi; Hideshima, Yoshiaki; Shudo, Yukoh; Ohmiya, Kazuhiko

    A study was conducted on a system to refine biogas generated from a biogas plant, which uses cow slurry as its main ingredient, and use the bio-methane as a regional energy supply source. Based on the data obtained by the demonstrative operation of the biogas plant and bio-methane production experiments, a bio-methane production plant that can process waste from 1,000 dairy cows was assumed, and optimization of plant operation was attempted using the linear programming method with maximum environmental friendliness (reduction of greenhouse gas emissions) and economic efficiency (management balance of the plant) as the target functions. The results revealed that plant operation methods varied according to the target of optimization. Environmental friendliness and economic efficiency were in a trade-off relationship with each other, but in the case where the greatest importance was placed on economic efficiency, greenhouse gas emissions were equivalent to that in the case where the greatest importance was placed on environmental friendliness itself. However, the values of economic efficiency were negative in both cases, indicating that it is difficult to make the plant management economically feasible under the current circumstances. To make the plant management balance positive, it is necessary to take measures, such as reduction of plant construction costs and exemption from interest costs. In addition, as a future direction for such regional bio-methane use, a micro grid system with a dispersed power source using bio-methane as raw fuel was presented.

  11. Present status of micro and mini-hydel power plants and biogas plants in Pakistan

    International Nuclear Information System (INIS)

    Hussain, T.

    1997-01-01

    The Government of Pakistan has high priority to develop indigenous energy resources and announced a policy framework and package of incentives to private sector in hydro electric power generation. Hydro electric power in Pakistan has been estimated to be nearly 35,000 MW, whereas only 3330 MW have so far been exploited which constitutes only 15.11% share of the total commercial energy fuel consumption in 1994-95 and 42.7% of total electricity generation. The Government Agency in Pakistan i.e. WAPDA which produced 85.4% electricity generation had found it difficult to implement and run small hydro projects. There are 200 MHP plants were installed with a total capacity of 3,000 KW (3 MW), out of which 160 plants are working with 80% success rate. The selling price is Rs. 3.00 against cost of production is Rs. 0.11 per unit. Biogas is a clean and cheap fuel in the form of gas. The total dung available per day in the rural areas of Pakistan works out between 250-300 million Kg and 1804 million cubic m. of biogas can be produced having economic value of 6.711 billions. During 70's several biogas plants were installed but they have some problems. As regards biogas the production has remained stagnant for the last 5 years or more. There is need for clear governmental priorities and effective use of form biogas. (A.B.)

  12. Innovative test method for the estimation of the foaming tendency of substrates for biogas plants.

    Science.gov (United States)

    Moeller, Lucie; Eismann, Frank; Wißmann, Daniel; Nägele, Hans-Joachim; Zielonka, Simon; Müller, Roland A; Zehnsdorf, Andreas

    2015-07-01

    Excessive foaming in anaerobic digestion occurs at many biogas plants and can cause problems including plugged gas pipes. Unfortunately, the majority of biogas plant operators are unable to identify the causes of foaming in their biogas reactor. The occurrence of foaming is often related to the chemical composition of substrates fed to the reactor. The consistency of the digestate itself is also a crucial part of the foam formation process. Thus, no specific recommendations concerning substrates can be given in order to prevent foam formation in biogas plants. The safest way to avoid foaming is to test the foaming tendency of substrates on-site. A possible solution is offered by an innovative foaming test. With the help of this tool, biogas plant operators can evaluate the foaming disposition of new substrates prior to use in order to adjust the composition of substrate mixes. Copyright © 2015 Elsevier Ltd. All rights reserved.

  13. Anaerobic digestion foaming in full-scale biogas plants: A survey on causes and solutions

    DEFF Research Database (Denmark)

    Kougias, Panagiotis; Boe, Kanokwan; O-Thong, Sompong

    2014-01-01

    Anaerobic digestion foaming is a common operation problem in biogas plants with negative impacts on the biogas plants economy and environment. A survey of 16 Danish full-scale biogas plants on foaming problems revealed that most of them had experienced foaming in their processes up to three times...... of foaming in this case. Moreover, no difference in bacterial communities between the foaming and non-foaming reactors was observed, showing that filamentous bacteria were not the main reason for foaming in this case. © IWA Publishing 2014....... per year. Foaming incidents often lasted from one day to three weeks, causing 20-50% biogas production loss. One foaming case at Lemvig biogas plant has been investigated and the results indicated that the combination of feedstock composition and mixing pattern of the reactor was the main cause...

  14. A concise biogas plant construction suitable for Ghana and other tropical countries

    Energy Technology Data Exchange (ETDEWEB)

    Gbagbo, J.K.N.

    1997-04-01

    This report is intended to be used by people in the field of biogas for workshops, technicians, teachers to educate as well as to carry out hands on constructions in Ghana and other tropical countries. Chapter 1, discusses the biogas technology, what a biogas plant is, and how it functions. Chapter 2, describes the entire process. Chapter 3, discusses the necessary conditions for fermentation. Chapter 4, the measuring parameters for monitoring the system. Chapter 5, describes the various types of biogas plants suitable for tropical countries. Chapter 6, describes a planning guide for Ghana and other tropical countries. Chapter 7, discusses digester sizing and finally, Chapter 8, describes a concise biogas plant construction suitable for the rural areas of Ghana and other tropical countries. (au)

  15. Biogas everywhere

    International Nuclear Information System (INIS)

    Couturier, Ch.; Pegret-Rosa, A.S.; Leca, Ch.; Adlec, E.

    2009-01-01

    Since the publication in July 2006 of the new purchase tariff of electricity produced by biogas, the methanation channel is increasing. In the past ten years the number of biogas plants from domestic wastes, passed from 1 to 20. This document presents an economic analysis of the different sources of biogas, the performances and the injection of biogas in the public network of the gas utilities. (A.L.B.)

  16. The use of co-digested solid fraction as feedstock for biogas plants

    Directory of Open Access Journals (Sweden)

    Elio Dinuccio

    2014-02-01

    Full Text Available A comparative study was set up in order to assess the technical feasibility of the long-term reuse of the mechanically separated co-digested solid fraction as a feedstock for anaerobic digestion plants (ADP. The biogas yields of two feedstock mixtures (A and B were assessed in mesophilic conditions (40°C±2°C using 6 lab-scale continuous stirredtank reactors. Feedstock mixture A (control consisted of pig slurry (70%, farmyard manure (4%, sorghum silage (12% and maize silage (14%. Feedstock mixture B was the same as the control plus the solid fraction derived from the mechanical separation of the output raw codigestate collected from the reactors. All reactors were fed simultaneously, three times a week, over a period of nine month. According to the study results, the reuse of the co-digested solid fraction as feedstock for ADP could increase the methane yield by approximately 4%. However, ADP efficiency evaluation (e.g., daily yield of methane per m3 of digester suggests limiting this practice to a maximum time period of 120 days.

  17. The use of co-digested solid fraction as feedstock for biogas plants

    Directory of Open Access Journals (Sweden)

    E. Dinuccio

    2013-09-01

    Full Text Available A comparative study was set up in order to assess the technical feasibility of the long-term reuse of the mechanically separated co-digested solid fraction as a feedstock for anaerobic digestion plants (ADP. The biogas yields of two feedstock mixtures (A and B were assessed in mesophilic conditions (40 °C ± 2 °C using 8 lab-scale continuous stirred-tank reactors (CSRT. Feedstock mixture A (control consisted of pig slurry (70%, farmyard manure (4%, sorghum silage (12% and maize silage (14%. Feedstock mixture B was the same as the control plus the solid fraction derived from the mechanical separation of the output raw co-digestate collected on daily basis from the reactors. All reactors were fed simultaneously, three times a week, over a period of nine month. According to the study results, the reuse of the co-digested solid fraction as feedstock for ADP could increase the methane yield by approximately 4%. However, ADP efficiency evaluation (e.g., daily yield of methane per m3 of digester suggest to limit this practice to a maximum time period of 120 days.

  18. Improvement in water-slurry circulation at the Chumakovskaya coal preparation plant

    Energy Technology Data Exchange (ETDEWEB)

    Nabokov, A.K.; Fedotov, B.P.; Mitlash, V.V.

    1988-02-01

    The Chumakovskaya coal preparation plant (Donetskugleobogashchenie association) was put into operation in 1935. It processes 570 t/h of coal slurry with an ash content of 38.6% and produces grade T coal for coking and power generation. Coal preparation technology used is described. Shortcomings of the system cause 130 kg of high ash slurries to be recirculated per m/sup 3/ of hydrocyclone drain. Mathematical analysis of the present process and of two improved variants is presented. The analysis permits variants for clarification of the recirculated water to be developed and evaluated and the best one to be selected. The optimum variant permits the amount of thin recirculated slurry to be reduced to 48% and the amount of granular slurry to 13%. Implementation of this variant at the Chumakovskaya coal preparation plant will ensure annual savings of 20,000 rubles.

  19. Innovative test method for the estimation of the foaming tendency of substrates for biogas plants

    Energy Technology Data Exchange (ETDEWEB)

    Moeller, Lucie, E-mail: lucie.moeller@ufz.de [UFZ – Helmholtz Centre for Environmental Research, Centre for Environmental Biotechnology, Permoserstrasse 15, 04318 Leipzig (Germany); Eismann, Frank, E-mail: info@antoc.de [Eismann & Stöbe GbR, GeoPark, Geb. A12, Bautzner Strasse 67, 04347 Leipzig (Germany); Wißmann, Daniel, E-mail: d.s.wissmann@gmx.de [University of Hohenheim, State Institute of Agricultural Engineering and Bioenergy (LA740), Garbenstrasse 9, 70599 Stuttgart (Germany); Nägele, Hans-Joachim, E-mail: hajo.naegele@uni-hohenheim.de [University of Hohenheim, State Institute of Agricultural Engineering and Bioenergy (LA740), Garbenstrasse 9, 70599 Stuttgart (Germany); Zielonka, Simon, E-mail: simon.zielonka@uni-hohenheim.de [University of Hohenheim, State Institute of Agricultural Engineering and Bioenergy (LA740), Garbenstrasse 9, 70599 Stuttgart (Germany); Müller, Roland A., E-mail: roland.mueller@ufz.de [UFZ – Helmholtz Centre for Environmental Research, Centre for Environmental Biotechnology, Permoserstrasse 15, 04318 Leipzig (Germany); Zehnsdorf, Andreas, E-mail: andreas.zehnsdorf@ufz.de [UFZ – Helmholtz Centre for Environmental Research, Centre for Environmental Biotechnology, Permoserstrasse 15, 04318 Leipzig (Germany)

    2015-07-15

    Graphical abstract: Display Omitted - Highlights: • Foaming in biogas plants depends on the interactions between substrate and digestate. • Foaming tests enable the evaluation of substrate foaming tendency in biogas plants. • Leipzig foam tester enables foaming tests of substrates prior to use. - Abstract: Excessive foaming in anaerobic digestion occurs at many biogas plants and can cause problems including plugged gas pipes. Unfortunately, the majority of biogas plant operators are unable to identify the causes of foaming in their biogas reactor. The occurrence of foaming is often related to the chemical composition of substrates fed to the reactor. The consistency of the digestate itself is also a crucial part of the foam formation process. Thus, no specific recommendations concerning substrates can be given in order to prevent foam formation in biogas plants. The safest way to avoid foaming is to test the foaming tendency of substrates on-site. A possible solution is offered by an innovative foaming test. With the help of this tool, biogas plant operators can evaluate the foaming disposition of new substrates prior to use in order to adjust the composition of substrate mixes.

  20. Potential of Biogas Power Plant Produced by Anaerobic Digestion of Biodegradable Materials

    Directory of Open Access Journals (Sweden)

    Nur Shuhada Ghazali

    2013-09-01

    Full Text Available Biogas typically refers to a gas produced by the breakdown of organic matter in the absence of oxygen. It is a renewable energy source, like solar and wind energy. Furthermore, biogas can be produced from regionally available raw materials and recycled waste and is environmentally friendly and CO2 neutral. Biogas is produced by the anaerobic digestion or fermentation of biodegradable materials such as manure, sewage, municipal waste, green waste, plant material, and crops. Biogas comprises primarily methane (CH4 and carbon dioxide (CO2 and may have small amounts of hydrogen sulphide (H2S, moisture and siloxanes. The gases methane, hydrogen, and carbon monoxide (CO can be combusted or oxidized with oxygen. This energy release allows biogas to be used as a fuel. Biogas can be compressed, much like natural gas, and used to power motor vehicles. Biogas is a renewable fuel so it qualifies for renewable energy subsidies in some parts of the world. Biogas can also be cleaned and upgraded to natural gas standards when it becomes bio methane. This paper will discuss the potential of biogas in order to provide a clean, easily controlled source of renewable energy from organic waste materials for a small labour input, replacing firewood or fossil fuels which are becoming more expensive as supply falls behind demand.

  1. Coal waste slurries as a fuel for integrated gasification combined cycle plants

    Directory of Open Access Journals (Sweden)

    Lutynski Marcin A.

    2016-01-01

    Full Text Available The article summarizes recent development in integrated gasification combined cycle technology and lists existing and planned IGCC plants. A brief outlook on the IGCC gasification technology is given with focus on entrained-flow gasifiers where the low-quality coal waste slurry fuel can be used. Desired properties of coal and ash for entrained-flow gasifiers are listed. The coal waste slurries, which were deposited at impoundments in Upper Silesian Coal Basin, were considered as a direct feed for such gasifiers. The average ash content, moisture content and lower heating value were analysed and presented as an average values. Entrained-flow commercial gasifiers can be considered as suitable for the coal slurry feed, however the ash content of coal slurries deposited in impoundments is too high for the direct use as the feed for the gasifiers. The moisture content of slurries calculated on as received basis meets the requirements of entrained-flow slurry feed gasifiers. The content of fines is relatively high which allow to use the slurries in entrained-flow gasifiers.

  2. Biogas. Plants, raw materials, products. 7. rev. ed.; Biogas. Pflanzen, Rohstoffe, Produkte

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2011-08-15

    In order to save fossil fuels and to stopp the climate change, a gradual shift to renewable energies is necessary. The federal government has aimed to a modern, environmental friendly, sustainable and secure energy supply by means of the expansion of renewable energies. Bioenergy plays a central role in the future. Biogas for renewable energies will play a special role. Biogas can be used for simultaneous production of electricity and heat, as a fuel and as a substitute for natural gas.

  3. Hydrothermal catalytic gasification of fermentation residues from a biogas plant

    International Nuclear Information System (INIS)

    Zöhrer, Hemma; Vogel, Frédéric

    2013-01-01

    Biogas plants, increasing in number, produce a stream of fermentation residue with high organic content, providing an energy source which is by now mostly unused. We tested this biomass as a potential feedstock for catalytic gasification in supercritical water (T ≥ 374 °C, p ≥ 22 MPa) for methane production using a batch reactor system. The coke formation tendency during the heat-up phase was evaluated as well as the cleavage of biomass-bound sulfur with respect to its removal from the process as a salt. We found that sulfur is not sufficiently released from the biomass during heating up to a temperature of 410 °C. Addition of alkali salts improved the liquefaction of fermentation residues with a low content of minerals, probably by buffering the pH. We found a deactivation of the carbon-supported ruthenium catalyst at low catalyst-to-biomass loadings, which we attribute to sulfur poisoning and fouling in accordance with the composition of the fermentation residue. A temperature of 400 °C was found to maximize the methane yield. A residence time dependent biomass to catalyst ratio of 0.45 g g −1 h −1 was found to result in nearly full conversion with the Ru/C catalyst. A Ru/ZrO 2 catalyst, tested under similar conditions, was less active. -- Highlights: ► Fermentation residue of a biogas plant could be successfully liquefied with a low rate of coke formation. ► Liquefaction resulted in an incomplete removal of biomass-bound sulfur. ► Low catalyst loadings result in incomplete conversion, implicating catalyst deactivation. ► At 400 °C the observed conversion to methane was highest. ► A residence time dependent biomass to catalyst ratio of 0.45 g g −1 h −1 was determined to yield nearly complete conversion

  4. Sustainable energy management in industry of Republic of Serbia: Biogas power plants advantages

    Directory of Open Access Journals (Sweden)

    Golušin Mirjan

    2012-12-01

    Full Text Available This paper reviews the specifics of energy policy in Serbia on the example of designing a biogas power plant. The biogas power plant is designed in accordance with the existing energy policy that recognizes producers of energy from renewable sources as This paper reviews the previously performed analysis in the sphere of energy consumption, which served as the basis for creating a new corporate energy policy. The paper presents an analysis of biogas power plant output (electrical and thermal energy, potential prices on the market, that are consistent with the incentives of energy policy of Serbia. In addition, special emphasis is given to the revenues that a biogas power plant realizes by using mechanism of energy policy, which promotes gaining revenues by reducing pollution of the atmosphere. The authors also show the procedure, costs and expected effects for the qualification of this power plant project (CDM project categories.

  5. Process optimization of biogas production at Nemščak biogas plant by pre-treatment of the substrate and combining with waste sludge

    OpenAIRE

    Žitek, Filip

    2015-01-01

    The purpose of this thesis is to increase the amount of biogas produced by pre-treatment of the substrate and combining with waste sludge. For anaerobic digestion of different substrates, we used a pilot reactor to determine the biogas potential at Nemščak biogas plant. The pilot reactor was built in 2009 for the purpose of testing new substrates in the process of biogas production. The pilot reactor has a working volume of 2000 litres; there is a gas tank above it with the volume of 500 litr...

  6. Optimised biogas production from the co-digestion of sugar beet with pig slurry: Integrating energy, GHG and economic accounting

    DEFF Research Database (Denmark)

    Boldrin, Alessio; Baral, Khagendra Raj; Fitamo, Temesgen Mathewos

    2016-01-01

    Several countries have established a number of increased targets for energy production from renewable sources. Biogas production, which will play a key role in future energy systems largely based on renewable sources, is expected to grow significantly in the next few decades. To achieve these amb...

  7. Enhancing identified Circular Economic benefits related to the deployment of the Solrød biogas plant

    DEFF Research Database (Denmark)

    Lybæk, Rikke; Kjær, Tyge

    2017-01-01

    This paper investigates how experiences from the deployment of the Solrød biogas plant in Denmark - a large scale centralized biogas plant - can assist future biogas technologies in achieving circular economic benefits. Departing from a theoretical understanding of a circular economy provided...... adapted to the local energy market. Finally, the paper suggests how to qualify the circular economic concept based on the findings from the Solrød biogas plant. It is here concluded, that emphasis should be on cascading energy from biogas production by means of combined heat and power (CHP), district...

  8. Analysis of exergy parameters of biogas power plant

    OpenAIRE

    Denysova, A.; Ngo, Minh

    2014-01-01

    The techniques of an exergy analysis concerning various circuits of biogas units, which allows replacing traditional energy resources and improving environmental conditions, has been presented. The heat schemes of biogas units were proposed, and analysis of their effectiveness was made. The comparison of different cycle parameters of various biogas units (i.e. a combustion turbine unit, a combined cycle gas turbine unit with gas discharges into the boiler and a combined cycle gas turbine with...

  9. Costs of slurry separation technologies and alternative use of the solid fraction for biogas production or burning

    DEFF Research Database (Denmark)

    Jacobsen, Brian H.

    2011-01-01

    parameters are livestock density, transport distance and cost of separation. The conclusion is that unless land prices or prices on slurry agreements are very high, traditional handling of animal manure has the lowest costs. Decanter separation can be the cheapest if area is limited and co...

  10. Microfiltration and ultrafiltration as a post-treatment of biogas plant digestates for producing concentrated fertilizers

    DEFF Research Database (Denmark)

    Camilleri Rumbau, Maria Salud; Norddahl, Birgir; Wei, Jiang

    2015-01-01

    Biogas plant digestate liquid fractions can be concentrated by microfiltration and ultrafiltration. Two types of microfiltration membranes (polysulphone (PS) and surface-modified polyvinylidene fluoride (PVDF)) were used to process digestate liquid fractions, and to assess their applicability in ...

  11. EU Agro Biogas Project

    NARCIS (Netherlands)

    Amon, T.; Mayr, H.; Eder, M.; Hobbs, P.; Rao Ravella, S.; Roth, U.; Niebaum, A.; Doehler, H.; Weiland, P.; Abdoun, E.; Moser, A.; Lyson, M.; Heiermann, M.; Plöchl, M.; Budde, J.; Schattauer, A.; Suarez, T.; Möller, H.; Ward, A.; Hillen, F.; Sulima, P.; Oniszk-Polplawska, A.; Krampe, P.; Pastorek, Z.; Kara, J.; Mazancova, J.; Dooren, van H.J.C.; Wim, C.; Gioelli, F.; Balsari, P.

    2009-01-01

    EU-AGRO-BIOGAS is a European Biogas initiative to improve the yield of agricultural biogas plants in Europe, to optimise biogas technology and processes and to improve the efficiency in all parts of the production chain from feedstock to biogas utilisation. Leading European research institutions and

  12. Increase of anaerobic degradation of particulate organic matter in full-scale biogas plants by mechanical maceration

    DEFF Research Database (Denmark)

    Hartmann, Hinrich; Angelidaki, Irini; Ahring, Birgitte Kiær

    2000-01-01

    Different concepts of implementation of mechanical pretreatment for enhancing the biogas potential from fibers in manure feedstock were evaluated by sampling before and after macerators at different biogas plants and from a fiber separation unit. An increase of the biogas potential of up to 25% b...

  13. Energy crops for biogas plants. Lower Saxony; Energiepflanzen fuer Biogasanlagen. Niedersachsen

    Energy Technology Data Exchange (ETDEWEB)

    Aurbacher, J.; Benke, M.; Formowitz, B. (and others)

    2012-06-15

    In the brochure under consideration the Agency for Renewable Resources (Guelzow-Pruezen, Federal Republic of Germany) reports on the support of the implementation of different plant cultures in structure of plantations and crop rotation systems of companies under consideration of the Federal State Lower Saxony. The main chapters of this brochure are: Crops for the production of biogas; implementation in plantations; ensilage and biogas yields; economy of the cultivation of energy plants.

  14. Theoretical and experimental investigations of thermal conditions of household biogas plant

    Science.gov (United States)

    Zhelykh, Vasil; Furdas, Yura; Dzeryn, Oleksandra

    2016-06-01

    The construction of domestic continuous bioreactor is proposed. The modeling of thermal modes of household biogas plant using graph theory was done. The correction factor taking into account with the influence of variables on its value was determined. The system of balance equations for the desired thermal conditions in the bioreactor was presented. The graphical and analytical capabilities were represented that can be applied in the design of domestic biogas plants of organic waste recycling.

  15. Perspectives on Spatial Decision Support Concerning Location of Biogas Production

    DEFF Research Database (Denmark)

    Bojesen, Mikkel

    whilst safeguarding a transparent and informative decision making process. Through the PhD thesis spatial temporal issues regarding slurry biomass resource availability is analysed together with the aspects of spatial competition in order to achieve national biogas policy ambitions. We find that slurry......, understand the industrial economic aspects of such a role. Through the use of spatial multi-criteria evaluation models stakeholder preferences to decision criteria are included in a sustainable biogas facility location analysis. By the use of these models it is demonstrated how overall biogas production...... costs can be reduced by 3% while also environmental and social concerns are appreciated. Spatial decision support models offer great potential for enhancing transparency and qualifying the basis for decision making with regard to location of future biogas plant. The spatial decision support tools, which...

  16. Potentials of the separation of cow manure. Utilization of solid materials as an alternative fermentation substrate in biogas conversion plants; Potentiale der Rinderguelleseparation. Nutzung der Feststoffe als alternatives Gaersubstrat in Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Kroeger, Rhena; Hothan, Andreas; Theuvsen, Ludwig; Broll, Gabriele; Brauckmann, Hans-Joerg; Bronsema, Hauke [Goettingen Univ. (Germany). Dept. fuer Agraroekonomie und Rurale Entwicklung, Betriebswirtschaftslehre des Agribusiness

    2013-10-01

    The increasing regional concentration of dairy farming requires alternatives for the use of the accruing slurry to defuse the nutrient problem. One possibility is to separate the manure and use the solid fraction for an energetic use in biogas plants in nutrient undersupplied regions. First practical tests on dairy slurry separation have shown that separators are able to achieve a performance 1.3 to 16.6 tons of mass flow per hour. The nutrients are disproportionately deposited in the solid fraction. Furthermore, the solid fractions show a methane building potential that is double as high as the raw slurry methane yield. An energetic use of the solid fraction allows the reduction of other substrates. Thus, it is possible to decrease the land requirements and the costs for other substrates. (orig.)

  17. Production Analysis of Biogas Plant in the Czech Republic

    Directory of Open Access Journals (Sweden)

    Josef Slaboch

    2016-01-01

    Full Text Available The paper deals with an agriculture production analysis of biogas plant in the Czech Republic and evaluates the effect of input-factors and their relevance. Cobb-Douglas functions for crop, livestock and total agriculture production are used. Econometric models are used for structure and magnitude determination of land and labour factors at individual farms, which lead to an increase of production defined in scenarios. Estimations are based on cross-section data. Results indicate statistical significance and the economically highest effect of land and fixed assets on the total agriculture production. The results of first period model show, that there is preferably a need for an increase of fixed assets when enlarging the livestock production. There is an increase of the importance of wages in total and livestock production in 2011 compared to 2010. The crop production is dependent on land are in the most, but the model must be rejected because of parameters intensity and economic justification. Quantification of relationships among variables can be used for planning of the whole production or its components.

  18. Consequential environmental life cycle assessment of a farm-scale biogas plant.

    Science.gov (United States)

    Van Stappen, Florence; Mathot, Michaël; Decruyenaere, Virginie; Loriers, Astrid; Delcour, Alice; Planchon, Viviane; Goffart, Jean-Pierre; Stilmant, Didier

    2016-06-15

    Producing biogas via anaerobic digestion is a promising technology for meeting European and regional goals on energy production from renewable sources. It offers interesting opportunities for the agricultural sector, allowing waste and by-products to be converted into bioenergy and bio-based materials. A consequential life cycle assessment (cLCA) was conducted to examine the consequences of the installation of a farm-scale biogas plant, taking account of assumptions about processes displaced by biogas plant co-products (power, heat and digestate) and the uses of the biogas plant feedstock prior to plant installation. Inventory data were collected on an existing farm-scale biogas plant. The plant inputs are maize cultivated for energy, solid cattle manure and various by-products from surrounding agro-food industries. Based on hypotheses about displaced electricity production (oil or gas) and the initial uses of the plant feedstock (animal feed, compost or incineration), six scenarios were analyzed and compared. Digested feedstock previously used in animal feed was replaced with other feed ingredients in equivalent feed diets, designed to take account of various nutritional parameters for bovine feeding. The displaced production of mineral fertilizers and field emissions due to the use of digestate as organic fertilizer was balanced against the avoided use of manure and compost. For all of the envisaged scenarios, the installation of the biogas plant led to reduced impacts on water depletion and aquatic ecotoxicity (thanks mainly to the displaced mineral fertilizer production). However, with the additional animal feed ingredients required to replace digested feedstock in the bovine diets, extra agricultural land was needed in all scenarios. Field emissions from the digestate used as organic fertilizer also had a significant impact on acidification and eutrophication. The choice of displaced marginal technologies has a huge influence on the results, as have the

  19. Enhancing Nutritional Contents ofLentinus sajor-cajuUsing Residual Biogas Slurry Waste of Detoxified Mahua Cake Mixed with Wheat Straw.

    Science.gov (United States)

    Gupta, Aditi; Sharma, Satyawati; Kumar, Ashwani; Alam, Pravej; Ahmad, Parvaiz

    2016-01-01

    Residual biogas slurries (BGS) of detoxified mahua cake and cow dung were used as supplements to enhance the yield and nutritional quality of Lentinus sajor-caju on wheat straw (WS). Supplementation with 20% BGS gave a maximum yield of 1155 gkg -1 fruit bodies, furnishing an increase of 95.1% over WS control. Significant increase ( p ≤ 0.05) in protein content (29.6-38.9%), sugars (29.1-32.3%) and minerals (N, P, K, Fe, Zn) was observed in the fruit bodies. Principle component analysis (PCA) was performed to see the pattern of correlation within a set of observed variables and how these different variables varied in different treatments. PC1 and PC2 represented 90% of total variation in the observed variables. Moisture (%), lignin (%), celluloses (%), and C/N ratio were closely correlated in comparison to Fe, N, and saponins. PCA of amino acids revealed that, PC1 and PC2 represented 74% of total variation in the data set. HPLC confirmed the absence of any saponin residues (characteristic toxins of mahua cake) in fruit bodies and mushroom spent. FTIR studies showed significant degradation of celluloses (22.2-32.4%), hemicelluloses (14.1-23.1%) and lignin (27.4-39.23%) in the spent, along with an increase in nutrition content. The study provided a simple, cost effective approach to improve the yield and nutritional quality of L. sajor-caju by resourceful utilization of BGS.

  20. Enhancing Nutritional Contents of Lentinus sajor-caju Using Residual Biogas Slurry Waste of Detoxified Mahua Cake Mixed with Wheat Straw

    Science.gov (United States)

    Gupta, Aditi; Sharma, Satyawati; Kumar, Ashwani; Alam, Pravej; Ahmad, Parvaiz

    2016-01-01

    Residual biogas slurries (BGS) of detoxified mahua cake and cow dung were used as supplements to enhance the yield and nutritional quality of Lentinus sajor-caju on wheat straw (WS). Supplementation with 20% BGS gave a maximum yield of 1155 gkg-1 fruit bodies, furnishing an increase of 95.1% over WS control. Significant increase (p ≤ 0.05) in protein content (29.6-38.9%), sugars (29.1-32.3%) and minerals (N, P, K, Fe, Zn) was observed in the fruit bodies. Principle component analysis (PCA) was performed to see the pattern of correlation within a set of observed variables and how these different variables varied in different treatments. PC1 and PC2 represented 90% of total variation in the observed variables. Moisture (%), lignin (%), celluloses (%), and C/N ratio were closely correlated in comparison to Fe, N, and saponins. PCA of amino acids revealed that, PC1 and PC2 represented 74% of total variation in the data set. HPLC confirmed the absence of any saponin residues (characteristic toxins of mahua cake) in fruit bodies and mushroom spent. FTIR studies showed significant degradation of celluloses (22.2-32.4%), hemicelluloses (14.1-23.1%) and lignin (27.4-39.23%) in the spent, along with an increase in nutrition content. The study provided a simple, cost effective approach to improve the yield and nutritional quality of L. sajor-caju by resourceful utilization of BGS. PMID:27790187

  1. Enhancing nutritional contents of Lentinus sajor-caju using residual biogas slurry waste of detoxified mahua cake mixed with wheat straw

    Directory of Open Access Journals (Sweden)

    Aditi Gupta

    2016-10-01

    Full Text Available Residual biogas slurries (BGS of detoxified mahua cake (DMC and cow dung (CD were used as supplements to enhance the yield and nutritional quality of Lentinus sajor-caju on wheat straw (WS. Supplementation with 20% BGS gave a maximum yield of 1155 gkg-1 fruit bodies, furnishing an increase of 95.1% over WS control. Significant increase (p≤0.05 in protein content (29.6-38.9%, sugars (29.1-32.3% and minerals (N, P, K, Fe, Zn was observed in the fruit bodies. Principle component analysis (PCA was performed to see the pattern of correlation within a set of observed variables and how these different variables varied in different treatments. PC1 and PC2 represented 90% of total variation in the observed variables. Moisture (%, lignin (%, celluloses (% and C/N ratio were closely correlated in comparison to Fe, N and saponins. PCA of amino acids revealed that, PC1 and PC2 represented 74% of total variation in the data set. HPLC confirmed the absence of any saponin residues (characteristic toxins of mahua cake in fruit bodies and mushroom spent. FTIR studies showed significant degradation of celluloses (22.2-32.4%, hemicelluloses (14.1-23.1% and lignin (27.4-39.23% in the spent, along with an increase in nutrition content. The study provided a simple, cost effective approach to improve the yield and nutritional quality of Lentinus sajor-caju by resourceful utilization of BGS.

  2. Feasibility study for biogas integration into waste treatment plants in Ghana

    Directory of Open Access Journals (Sweden)

    M. Mohammed

    2017-09-01

    Full Text Available Biogas (anaerobic digestion technology is one of the most viable renewable energy technologies today. However, its economic efficiency depends on the investment costs, costs of operating the biogas plant and optimum methane production. Likewise the profit level also rests on its use directly for cooking or conversion into electricity. The present study assessed the economic potential for a 9000 m3 biogas plant, as an alternative to addressing energy and environmental challenges currently in Ghana. A cost-benefit analysis of the installation of biogas plant at University of Ghana (Legon Sewerage Treatment Plant yielded positive net present values (NPV at the prevailing discount rate of 23%. Further the results demonstrate that installation of the plant is capital intensive. Biogas used for cooking was by far the most viable option with a payback period (PBP of 5 years. Sensitivity analysis also revealed cost of capital, plant and machinery as the most effective factors impacting on NPV and internal rate of return (IRR.

  3. Economics of production of biogas from specifically-grown plant material. [New Zealand

    Energy Technology Data Exchange (ETDEWEB)

    Stewart, D.J.

    1977-10-15

    The production of biogas from plant materials is technologically very simple, and is the only process currently available (other than direct burning) for conversion of cellulose materials into energy or fuels that is feasible at a farm-scale, or even a home-scale, as well as a large industrial plant scale. For this reason the economics of biogas production can be considered at the farm-scale as well as the industrial scale. An accurate assessment of the economics at the farm-scale is possible, because commercially produced units are now available in New Zealand and in operation. However, although large-scale plants have been proposed and costed in the USA for the conversion of the cellulose component of garbage into biogas, operational data are not yet available, and the costing has not been applied to the use of specifically-grown plant material. Nevertheless, the large-scale plants envisaged use a large number of digesters each of 100,000 gallons capacity and can thus be regarded as a combination of farm-size units, although with some economics in digester size, number of pumps required, etc. For these reasons, this review of the economics of biogas production is based on the operation of commercial 20,000 gallon digesters available in NZ for farm-scale use. Factors governing the economics of farm-scale and industrial-scale production of biogas will be discussed in section 6.

  4. Costs of slurry separation technologies and alternative use of the solid fraction for biogas production or burning

    DEFF Research Database (Denmark)

    Jacobsen, Brian H.

    2011-01-01

    separation, in order to establish the overall costs. Key parameters are livestock density, transport distance, price of additional land and cost of separation. The conclusion is that unless land prices or prices on slurry agreements are very high, traditional handling of animal manure has the lowest costs......The purpose of this paper is to analyse different separation concepts in order to evaluate the overall costs based on a systems approach from stable to field. When livestock are produced in livestock intensive areas the distribution of manure without creating a surplus of nutrients is often...... for P-balance is stricter in Denmark than before, but developments in feeding, changes in regulation and the reduction of livestock numbers have made separation less favourable. This article compares dominant separation technologies in Denmark, such as decanter and flocculation, as well as source...

  5. Effect of operating conditions and reactor configuration on efficiency of full-scale biogas plants

    DEFF Research Database (Denmark)

    Angelidaki, Irini; Boe, Kanokwan; Ellegaard, L.

    2005-01-01

    A study on 18 full-scale centralized biogas plants was carried out in order to find significant operational factors influencing productivity and stability of the plants. It was found that the most plants were operating relatively stable with volatile fatty acids (VFA) concentration below 1.5 g....../l. VFA concentration increase was observed in occasions with dramatic overloading or other disturbances such as operational temperature changes. Ammonia was found to be a significant factor for stability. A correlation between increased residual biogas production and high ammonia was found. When ammonia...

  6. Swiss statistics on renewable energy - Biogas - Collection of biogas data from regional wastewater treatment plants; Schweizerische Statistik erneuerbarer Energien - Teilstatistik Biogas - Erfassung Biogasdaten aus kommunalen ARA

    Energy Technology Data Exchange (ETDEWEB)

    Buri, R.; Kobel, B.

    2000-07-01

    This final report for the Swiss Federal Office of Energy presents the results of a project that involved the collection of data on the production of biogas in wastewater treatment plants that each serve at least 200 inhabitants. The methods used to collect and verify the data are described. The assessment methods used to evaluate the findings are discussed, as is the extrapolation method used. The results are compared with the data previously used. Further, a data collection concept for use in subsequent years is described that involves the segregation of the wastewater treatment plants into three size categories. A comprehensive annex provides details on the data collection and the paperwork used, a list of the addresses of the wastewater facilities involved, an estimate of electrical power consumption and individual power production, the calculation of average efficiencies and tables of data.

  7. Presence and transcriptional activity of anaerobic fungi in agricultural biogas plants.

    Science.gov (United States)

    Dollhofer, Veronika; Callaghan, Tony M; Griffith, Gareth W; Lebuhn, Michael; Bauer, Johann

    2017-07-01

    Bioaugmentation with anaerobic fungi (AF) is promising for improved biogas generation from lignocelluloses-rich substrates. However, before implementing AF into biogas processes it is necessary to investigate their natural occurrence, community structure and transcriptional activity in agricultural biogas plants. Thus, AF were detected with three specific PCR based methods: (i) Copies of their 18S genes were found in 7 of 10 biogas plants. (ii) Transcripts of a GH5 endoglucanase gene were present at low level in two digesters, indicating transcriptional cellulolytic activity of AF. (iii) Phylogeny of the AF-community was inferred with the 28S gene. A new Piromyces species was isolated from a PCR-positive digester. Evidence for AF was only found in biogas plants operated with high proportions of animal feces. Thus, AF were most likely transferred into digesters with animal derived substrates. Additionally, high process temperatures in combination with long retention times seemed to impede AF survival and activity. Copyright © 2017 Elsevier Ltd. All rights reserved.

  8. Biogas production from poultry rendering plant anaerobic digesters: systems comparison

    Science.gov (United States)

    Animal wastes can serve as the feedstock for biogas production (mainly methane) that could be used as alternative energy source. The green energy derived from animal wastes is considered to be carbon neutral and offsetting those generated from fossil fuels. In this study, an evaluation of system p...

  9. ANALYSIS OF EXERGY PARAMETERS OF BIOGAS POWER PLANT

    Directory of Open Access Journals (Sweden)

    Denysova A.E.

    2014-08-01

    Full Text Available The techniques of an exergy analysis concerning various circuits of biogas units, which allows replacing traditional energy resources and improving environmental conditions, has been presented. The heat schemes of biogas units were proposed, and analysis of their effectiveness was made. The comparison of different cycle parameters of various biogas units (i.e. a combustion turbine unit, a combined cycle gas turbine unit with gas discharges into the boiler and a combined cycle gas turbine with a high-temperature vapor generator and a reheating stage was made, and the comparison of their exergy characteristics was carried out. The results of exergy analysis had demonstrated that the cycle of biogas CCGT (combined cycle gas turbine with a reheating stage and using a high-pressure steam generator is the most effective, that can be explained by the fact that the thermal energy proportions of combustion products, accounting for the steam cycle and the gas cycle are approximately equal, comparing to conventional combined cycle gas turbine units.

  10. Alternatives for handling of digestate from large biogas plants; Foeraedling av roetrest fraan storskaliga biogasanlaeggningar

    Energy Technology Data Exchange (ETDEWEB)

    Aarsrud, Peter (Kretsloppskontoret Goeteborg (Sweden)); Bisaillon, Mattias (Profu (Sweden)); Hellstroem, Hanna; Henriksson, Gunilla (SP, Boraas (Sweden)); Jakobsson, Emma; Jarlsvik, Tisse; Martinsson, Ulf (Goeteborg Energi (Sweden)); Jensen, Carl (Renova (Sweden)); Johansson, Lars-Gunnar (Biogas Vaest/LRF (Sweden)); Kanerot, Mija (Boraas Energi och Miljoe (Sweden)); Ling, Daniel (Laeckeby Water (Sweden))

    2010-07-01

    Biogas plants located in city environments are becoming increasingly common in Sweden. More and more municipalities are electing to collect food waste for treatment in a biogas plant. The environment target of treating 35 % all organic waste biologically try to obtain from municipalities. Certain demands are placed on biogas plants and their system environments if they are to be able to treat food waste successfully. Firstly, there needs to be a use for the nutrient-rich biofertilizer product, and secondly it must be possible to clean the reject water before it is released to the recipient. The goal of the project is to conduct a system analysis from the economic and environmental perspectives to investigate what is the best alternative for dealing with the digestate and reject water for two biogas plants located in city environments. The plants used as the point of departure for the study are a planned biogas plant in Gothenburg and an existing biogas plant in Boraas. The plant in Boraas is planned to be included in an energy combine with ethanol production. The target group for the project comprises biogas plants built in city environments with the purpose of treating food waste, but also other plants that treat organic waste in a digester, e.g., sludge from sewage treatment works. Table 1 below shows the results for each technology studied. [Table 1 Results from system analysis.] The results of the system analysis show that the best alternative for Gothenburg, both from an economical point of view and when considering the climate impact, is to transport and spread the un-dewatered digestate directly onto arable land. On the basis of acidification and eutrophication potentials, the best alternative is to treat the reject water with the DeAmmon process. From the economic perspective, the best alternative for Boraas is to continue with the treatment method used today at the plant, that is, SBR. From the perspective of climate impact, the best alternative is to

  11. Effects of Combined Application of Biogas Slurry and Chemical Fertilizer on Soil Aggregation and C/N Distribution in an Ultisol

    Science.gov (United States)

    Zheng, Xuebo; Fan, Jianbo; Xu, Lei; Zhou, Jing

    2017-01-01

    Unreasonable use of chemical fertilizer (CF) on agricultural soil leads to massive losses of soil organic carbon (SOC) and total nitrogen (TN) in tropical and subtropical areas, where soil conditions are unfavorable for aggregate formation. This study evaluated the effects of combined application of biogas slurry (BS) plus CF on soil aggregation and aggregate—associated C/N concentration and storage in an Ultisol. Six treatments included: no fertilizer (T1), CF only (T2), partial (15% (T3), 30% (T4) and 45% (T5)) substitution of TN with BS and BS only (T6). Soil mechanical—stable aggregates (MSAs) formation and stability as well as MSAs—associated C/N concentration and storage were observed in different aggregate sizes (>5, 5–2, 2–1, 1.0–0.5, 0.50–0.25 and 5 mm significantly increased with BS substitution (T5), while the proportions of MSAs 1.0–0.5 mm, MSAs 0.50–0.25 mm and MSAs soil aggregation stability as well as resulted in significantly higher SOC and TN concentrations and storage in MSAs >0.5 mm that constituted 72–82% of MSAs. Stepwise regression analysis showed that MSAs >5 mm, SOC in MSAs >5 mm and TN in MSAs >5 mm were the dominant variables affecting aggregate stability. Meanwhile SOC in MSAs soils. Therefore, certain rate of combined application of BS plus CF is an effective, eco—friendly way to improve soil quality in an Ultisol. PMID:28125647

  12. Detection of Clostridium botulinum in liquid manure and biogas plant wastes.

    Science.gov (United States)

    Neuhaus, Jürgen; Schrödl, Wieland; Shehata, Awad A; Krüger, Monika

    2015-09-01

    Biogas plants have been considered as a source for possible amplification and distribution of pathogenic bacteria capable of causing severe infections in humans and animals. Manure and biogas wastes could be sources for spore-forming bacteria such as Clostridium botulinum. In the present study, 24 liquid manure and 84 biogas waste samples from dairies where the majority of the cows suffered from chronic botulism were investigated for the presence of botulinum neurotoxins (BoNT) and C. botulinum spores. The prevalence of BoNT/A, B, C, D, and E in biogas wastes was 16.6, 8.3, 10.7, 7.1, and 10.8 %, respectively, while in manure, the prevalence was 0.0, 0.0, 0.0, 8.3, and 4.1 %, respectively. After enrichment of samples in reinforced cultural medium, they were tested for C. botulinum BoNT/A, B, C, D, and E using ELISA (indirect C. botulinum detection). The prevalence of C. botulinum type A, B, C, D, and E samples in biogas wastes was 20.2, 15.5, 19, 10.7, and 34.8 %, respectively, while the prevalence in liquid manure was 0.0, 0.0, 0.0, 8.3, and 12.5 %, respectively. In conclusion, the occurrence of BoNT and C. botulinum spores in biogas waste of diseased animals indicates an increased and underestimated hygienic risk. Application of digestates from biogas fermentations as fertilizers could lead to an accumulation of long lifespan spores in the environment and could be a possible health hazard.

  13. Biogas conference on direct selling and financing in France and in Germany

    International Nuclear Information System (INIS)

    Furois, Timothee; Vollmer, Carla; Schlienger, Marc; Delagrandanne, Julien; Schwill, Jochen; Trommler, Marcus; Barchmann, Tino; Dotzauer, Martin; Durot, Alexandre; Ricordeau, Damien; Schuenemann-Plag, Peter; Wehner, Gustav; Wagner, Robert; Mestrel, Marc

    2016-01-01

    The French-German office for Renewable energies (OFAEnR) organised a conference on the regulatory context, direct selling and financing of methanation plants in France and in Germany. In the framework of this French-German exchange of experience, about 60 participants debated the following topics: direct selling impact on biogas industry, key-steps of methanation development in Germany, experience feedback of direct electricity selling and optimization of the production, banks experience feedback in methanation financing. This document brings together the available presentations (slides) made during this event: 1 - French support schemes for biogas (Timothee Furois); 2 - Development of the framework for biogas plants within the Renewable energy Sources Act from 2000 until 2015 (Carla Vollmer); 3 - Direct selling: challenges and opportunities (Marc Schlienger); 4 - The rules of the aggregator and electricity market (Julien Delagrandanne); 5 - Feed in Premium (FiP) with Biogas Power Plants, experiences in Germany (Jochen Schwill); 6 - Flexibilisation of biogas production - Impulses from EEG -legislation (Marcus Trommler); 7 - Bank approach in the direct selling approach (Alexandre Durot); 8 - Biogas Financing - Correlation between Return and Project Financing (Damien Ricordeau); 9 - Comparative economic analysis of various types of biogas plant Profitability of small and medium biogas plants on the basis of slurry and maize silage in Germany (Peter Schuenemann-Plag); 10 - experience feedback on important financing leviers (Gustav Wehner); 11 - Analysis of the different ways of methanation facilities financing (Robert Wagner); 12- The development of biogas project without recourse to purchase prices in France and Germany (Marc Mestrel)

  14. Anaerobic biogasification of domestic wastes and direct solar energy use to produce biogas, biofertilizer and distilled water in a city - a pilot plant

    Energy Technology Data Exchange (ETDEWEB)

    kumar, R.A.; Pandya, N.H.; Patil, A.M.; Annamalai, M.; Iyer, M.V.; Nirmala, K.A.; Venkatesh, P.; Prasad, C.R.; Subramani, C.

    1982-01-01

    Domestic wastes are a source of gas of high calorific value as well as biofertilizer and distilled water. A pilot project undertaken by the Tata Electric Cos., Bombay on recycling sewage, garbage and garden wastes of a community by converting them into biogas, organic fertilizer and distilled water is described. Techniques used are anaerobic fermentation and Solar drying using Solar stills. A fish pond also can be fed the output slurry as feed material. In this pilot plant, 1 to 2 m/sup 3/ raw sewage and one to two tons of processed garden wastes and garbage would be input daily into the digester. The production is expected to be about 100 m/sup 3/ of gas per day, along with about 1500 litres of slurry from which organic fertilizer of 100 200 Kgs can be bagged and transported as well as distilled water of about 500 to 1000 litres Laboratory studies and studies on an approximate scale model of the plant are described. Scaling up to a pilot plant by about 2000 times would increase the efficiency of the rate of gas production as has been found by other workers. These tests and studies have shown that the project is technically and eonomically viable. Applications of the process on a mass scale would result in increasing replacement of fossil energy intensive processes with negentropic methods of economic and social activities.

  15. The effect of electron acceptors on biogas production from tannery sludge of a Mexican wastewater plant

    Science.gov (United States)

    Effluents from the leather processing plants generally are discharged into rivers or are used to irrigate farmland. The biogas production from the digestion of sludge produced could be used as alternative sources for energy and power generation. A study was carried out to examine the effects of vari...

  16. ANALYSIS OF ELECTROMAGNETIC FIELDS AND NOISE IN THE AREA OF AGRICUL-TURAL BIOGAS PLANT

    Directory of Open Access Journals (Sweden)

    Paweł A. Mazurek

    2016-12-01

    Full Text Available Electro-magnetic and acoustic fields were analysed at the bioenergy and biogas production plant of 0.999 MW operational power, localized in Piaski. Measured values were compared with valid national norms and did not exceed limiting values in zones of people’s permanent residence.

  17. Theoretical and experimental investigations of thermal conditions of household biogas plant

    Directory of Open Access Journals (Sweden)

    Zhelykh Vasil

    2016-06-01

    Full Text Available The construction of domestic continuous bioreactor is proposed. The modeling of thermal modes of household biogas plant using graph theory was done. The correction factor taking into account with the influence of variables on its value was determined. The system of balance equations for the desired thermal conditions in the bioreactor was presented.

  18. BEAP profiles as rapid test system for status analysis and early detection of process incidents in biogas plants.

    Science.gov (United States)

    Refai, Sarah; Berger, Stefanie; Wassmann, Kati; Hecht, Melanie; Dickhaus, Thomas; Deppenmeier, Uwe

    2017-03-01

    A method was developed to quantify the performance of microorganisms involved in different digestion levels in biogas plants. The test system was based on the addition of butyrate (BCON), ethanol (ECON), acetate (ACON) or propionate (PCON) to biogas sludge samples and the subsequent analysis of CH 4 formation in comparison to control samples. The combination of the four values was referred to as BEAP profile. Determination of BEAP profiles enabled rapid testing of a biogas plant's metabolic state within 24 h and an accurate mapping of all degradation levels in a lab-scale experimental setup. Furthermore, it was possible to distinguish between specific BEAP profiles for standard biogas plants and for biogas reactors with process incidents (beginning of NH 4 + -N inhibition, start of acidification, insufficient hydrolysis and potential mycotoxin effects). Finally, BEAP profiles also functioned as a warning system for the early prediction of critical NH 4 + -N concentrations leading to a drop of CH 4 formation.

  19. The opportunity of rising efficiency at biogas plants without BHKW; Moeglichkeit der Effizienzsteigerung bei Biogasanlagen ohne BHKW

    Energy Technology Data Exchange (ETDEWEB)

    Wemken, Klaus; Dietz, Juergen [Bundesanstalt fuer Landwirtschaft und Ernaehrung (BLE), Bonn (Germany)

    2013-10-01

    The following is a presentation of a sustainably environment-friendly and economically viable alternative to a standard biogas plant operated pursuant to the German Renewable Energies Act (EEG) 2012. It aims to archive maximum efficiency in both the production and the direct use of biogas within regional energy networks and makes funding pursuant to the EEG unnecessary. There are aspects of the alternative: - The biogas plant is operated without CHP and without district heating. - Users obtain biogas via the gas line without energetic losses. - Biogas production is possible according to seasonal needs. - CO{sub 2} in biogas is a valuable raw material. Adding hydrogen, from excess photovoltaic (PV) or wind energy, results in biomethane/synthetic natural gas. - In a PV or wind energy network, a biogas plant without CHP, excluding district heating, and with the CO{sub 2} contained in the biogas methanised, can contribute to - regional need-oriented, effective and affordable energy supplies, - reduced biomass cultivation area (up to 65% less), i.e. to a positive ''plant-tank-balance'', - the relief of energy transmission networks. (orig.)

  20. Economic analysis of operation parameters of the biogas plant in Rozhanovce

    Directory of Open Access Journals (Sweden)

    Erich Nováček

    2012-12-01

    Full Text Available The use of renewable sources in the production of electricity and heat is currently rather common practice than somethingunusual. Nevertheless, while projecting such a source of energy, it is necessary to take into account certain particularities, risks as wellas possibilities. With the production and usage of biogas it is the use of local energy and working sources, which has a positive impacton the development of the region. In this article, technical and economic operation parameters of the biogas plant in Rozhanovce areanalysed.

  1. Replacement of cowdung by fermentation of aquatic and terrestrial plants for use as fuel, fertilizer and biogas plant feed

    Energy Technology Data Exchange (ETDEWEB)

    Das, C.R.; Ghatnekar, S.D.

    1979-01-01

    With 85% of the entire Indian population living in villages and 98% of the household energy requirement of the rural population demanded for cooking, research was undertaken on the supply of biomass for those Indians who do not have cattle. This research was carried out on the fermentation of aquatic and terrestrial plants for use in biogas generation. The plants utilized for biogas generation are: water hyacinth, water lettuce, African payal, duck weed, water spinach, cattail ramban, ipil-ipil, morning glory, paragrass, purple nutsedge, and durva grass.

  2. Landfill biogas for heating greenhouses and providing carbon dioxide supplement for plant growth

    Energy Technology Data Exchange (ETDEWEB)

    Jaffrin, A. [INRA-Unite d' Amelioration des Plantes, Frejus, At Aygulf, 83 (France); Bentounes, N. [PICC Sarl, Rognac, 13 (France); Joan, A.M. [J and J Prod. Sarl, Entrecasteaux, 83 (France); Makhlouf, S. [Univ. Tizi Ouzou, Dept.of Mechanical Engineering, Tizi Ouzou (Algeria)

    2003-09-01

    Present municipal solid waste landfills generate biogas and leachate. Biogas is flared on site to destroy noxious contaminants and water is extracted from leachate to be drained away. However, biogas could alternatively be a cheap fuel for winter heating and could provide horticultural greenhouses with abundant carbon dioxide to boost plant growth all year long. The paper describes how this idea was tested in a full-scale experiment through a partnership between French Institut National de la Recherche Agronomique (INRA) and a pool of private industries. A commercial boiler was converted to biogas and combustion exhaust gases rich in carbon dioxide were purified to remove phytotoxic residues. A CO{sub 2} supplementation technique using these purified exhaust gases was tested. Two soilless rose crops were grown under two identical 300 m2 plastic greenhouses, one equipped with exhaust gas injection and the other one, kept under normal atmosphere, being the control. Crop yields and cut rose quality were compared during 24 months. It was found that the high crop productivity gains allowed by exhaust gas injection bring the major contribution to greenhouse economics, much more important than the reduction of heating costs brought by burning biogas. This underlines the potential for new efficient horticultural greenhouses locating near modern landfill sites in France and elsewhere in developed countries. (Author)

  3. Continuous in-house acidification affecting animal slurry composition

    DEFF Research Database (Denmark)

    Hjorth, Maibritt; Cocolo, Giorgia; Jonassen, Kristoffer

    2015-01-01

    The emerging slurry acidification technology affects gaseous emissions, fertiliser value, biogas production and solid-liquid separation; however, maximising the advantages is difficult, as the effect of acidification on the slurry characteristics resulting in those observations remains unclarifie...

  4. Measures to prevent foam formation in the anaerobic digestion of sugar beet in biogas plants

    Directory of Open Access Journals (Sweden)

    Lucie Moeller

    2017-01-01

    Full Text Available The occurrence of persistent foaming is observed in many anaerobic digesters that have sugar beet as their feedstock. The formation of foam entails a significant risk of damage to biogas plants, as gas pipes can become blocked. For this reason, foaming tests have been conducted to investigate which measures lead to reductions in foam development. It was found that generally available fertilizers such as urea, ammonium nitrate and calcium cyanamide have a foam-reducing effect. However, batch fermentation tests showed inhibition of biogas production at higher concentrations of these substances, which means that they should be used with care. Calcium cyanamide was found to be very unsuitable, as this substance inhibited biogas production even at low concentrations and caused the fermentation process to come to a complete stop at higher concentrations.

  5. Energetic efficiency analysis of the agricultural biogas plant in 250 kWe experimental installation

    International Nuclear Information System (INIS)

    Dach, Jacek; Boniecki, Piotr; Przybył, Jacek; Janczak, Damian; Lewicki, Andrzej; Czekała, Wojciech; Witaszek, Kamil; Rodríguez Carmona, Pablo César; Cieślik, Marta

    2014-01-01

    European direction of energy development has been already set few years ago. Proper waste management is not just a fashion trend of the wealthy European countries – it has become a legal requirement. Processing of the biowaste into the biogas is one of the most effective technologies providing to obtain a “green” energy and improvement of the environment. Construction of small and cheap agricultural biogas plants, like in case of Poznan University of Life Sciences (PULS) experimental station Przybroda, is one of the best directions of dissemination of this biowaste valorization technology. The aim of this paper was to investigate the biogas efficiency of the substrates available in PULS experimental farm Przybroda (cattle manure, maize silage). The results have shown that the most energetic valuable substrate is maize silage with cumulative biogas yield 218.4 m 3 /Mg FM (almost 3 times more than cattle manure). With yearly substrate availability on the Przybroda farm, total amount of biomethane produced is 521,440 m 3 from maize silage and 23,615 m 3 from cattle manure. It allows to obtain 2212.38 MWh/year of electric energy as well as 2428.22 MWh/year thermal energy production. The calculated electric energy power was 0.270 MW. - Highlights: • Research on biogas efficiency from different substrates has been made. • Estimation of energy produced from own substrates was done. • Power of biogas plant on experimental farm calculated as 0.270 MW e and 0.296 MW t

  6. The possibility of functioning micro-scale biogas plant in selected farm

    Directory of Open Access Journals (Sweden)

    Czekała Wojciech

    2017-12-01

    Full Text Available Renewable energy sources (RES become more and more popular. In Poland, biomass has the highest energy potential among all RES. Methane fermentation is one of possible ways to use it. The aim of the study was to perform energy and economic calculations for the biogas plant installation project in an existing farm situated in the Wielkopolska voivodeship. Because of the small area of the farm and the type of production, the calculations were carried out for micro-installation biogas plants. During the preparation of the project the production potential of the substrates was determined, allowing for further analyses. It was calculated that the electrical power of the designed biogas plant was 8.10 kW, with a total annual production of biogas at 29 471 m3. The obtained amount allows to generate in the cogeneration system 66 450 kWh of electricity and 71 190 kWh of heat energy. Some of the energy produced can be used on the farm and its surplus sold to the grid, which will allow for financial and environmental benefits.

  7. Energy crops for biogas plants. Bavaria; Energiepflanzen fuer Biogasanlagen. Bayern

    Energy Technology Data Exchange (ETDEWEB)

    Aigner, A.; Biertuempel, A.; Conrad, M. (and others)

    2012-08-15

    For agriculturists in Bavaria (Federal Republic of Germany), the brochure under consideration provides recommendations on alternative crop rotation systems. With the help of these alternative cultivation systems, crop rotation with high yields in combination with high diversity, diversification and sustainability can be realized. Subsequently to the presentation of energy crops for the production of biogas, recommendations for the design of crop rotation are given. Other chapters of this booklet deal with ensilage and gas yields as well as the economics of energy crop cultivation.

  8. Experimental biogas power plant at STU in bratislava

    International Nuclear Information System (INIS)

    Pipa, M.; Kment, A.; Janicek, F.

    2012-01-01

    Slovak University of Technology in Bratislava builds the technological research and development center financed by the Structural Funds of the European Union focused on use of different energy sources. In terms of renewable energy is discussed use of biomass energy available through biogas technology with a dry fermentation process. This is a pilot project of experimental physical model, which will be attempting to verify and optimize the pre-project phase parameters and technology already in commercial projects in scaled-down model. The paper deals with the design of this device. (Authors)

  9. Technical and economical analysis of concepts for using the heat of biogas plants in rural areas

    International Nuclear Information System (INIS)

    Kaths, Friederike Annette

    2012-08-01

    Since the implementation of the EEG in Germany the biogas production becomes an independent branch of industry in the agriculture. At this time more than 90 percent of the biogas plants work with co-generation plant for heat and power with a thermal engine efficiencies of more than 50 percent. Because of the location in the rural area heat costumers with a continuous demand of heat over the whole year are rare. This research had a closer look how to use the heat of biogas production efficiently and also generating profit. The aim of the study was to use heat over the whole year, a profitable heat concept without counting the KWK-bonus and an added value on the farm. During the study the following concepts were analyzed: asparagus production using soil heating, drying equipment for different products, the production of fish in aquaculture, the poultry production and the heated production of tomatoes. The results showed different concepts using heat of biogas plants as efficient for farmers. However with only one concept the aims - to use the heat over the whole year, generating a profitable heat concept without counting the KWK-bonus, add an value on the farm - mostly can not be achieved. The combination of different heat concepts is necessary. In this analysis the poultry production in combination with the dryer can be considered as the most efficient concept. Bearing in mind the benefit which can be generated with a heat concept as well as the higher income and the higher technical efficiency of biogas plants operators should implement an individual concept for their heat.

  10. Determination of mixing quality in biogas plant digesters using tracer tests and computational fluid dynamics

    Directory of Open Access Journals (Sweden)

    Luděk Kamarád

    2013-01-01

    Full Text Available The total electricity demand of investigated biogas plants (BGP makes up 7–8 % of the total electricity produced. Nearly 40 % of this energy is consumed just for mixing in digesters and the energy demand for mixing in some biogas plants can be even higher. Therefore, optimal mixing in anaerobic digesters is a basic condition for efficient plant operation and biogas production. The use of problematic substrates (e.g. grass silage or other fibrous substrates, installation of unsuitable mixing systems or inconvenient mixing intervals may lead to mixing problems. Knowledge about mixing in biogas digesters is still insufficient, so the objective of this study was to fill the information gaps in the literature by determining the minimal retention time of substrates fed into anaerobic digesters and to describe substrate distribution and washing out rates from investigated digesters. Two full-scale biogas plant digesters (2000 m3 and 1500 m3 using different mixing systems and substrates were investigated. To characterize the substrate distribution, lithium hydroxide monohydrate solutions were used for tracer tests at concentrations of 47.1 mg Li+ / kg TS and 46.6 mg Li+ / kg TS in digester. The tracer concentration in the digester effluents was measured during two hydraulic retention times and compared. Although the tracer was detected in the digester effluent at nearly the same time in both cases, the tracer tests showed very different distribution curves. The tracer concentration in effluent B grew much slower than in effluent A and no significant short circuiting streams were detected. Although the data calculated by computational fluid dynamics methods (CFD showed a very good agreement with the full scale results, full comparison was not possible.

  11. Future biogas plants. New systems and their economic potential; Fremtidens biogasfaellesanlaeg. Nye anlaegskoncepter og oekonomisk potentiale

    Energy Technology Data Exchange (ETDEWEB)

    Christensen, Johannes; Hjort-Gregersen, K.; Uellendahl, H.; Ahring, B.K.; Lau Baggesen, D.; Stockmarr, A.; Moeller, Henrik B.; Birkmose, T.

    2007-06-15

    The main objective of the project was the identification and analysis of new technical concepts for centralized biogas plants, which would make them less dependant on organic waste supplies, and thus be economically self sustained mainly on manure supplies. The analyses have been carried out as system analyses, where plant concepts have been evaluated in connection with agricultural areas. 8 scenarios where analyzed, of which 2 were reference scenarios. (au)

  12. Conceptual design of an integrated hydrothermal liquefaction and biogas plant for sustainable bioenergy production

    DEFF Research Database (Denmark)

    Hoffmann, Jessica; Rudra, Souman; Toor, Saqib

    2013-01-01

    Initial process studies carried out in Aspen Plus on an integrated thermochemical conversion process are presented herein. In the simulations, a hydrothermal liquefaction (HTL) plant is combined with a biogas plant (BP), such that the digestate from the BP is converted to a biocrude in the HTL...... grid or for CHP. An estimated 62–84% of the biomass energy can be recovered in the biofuels....

  13. The operating economy of communal biogas plants by mid-1992

    International Nuclear Information System (INIS)

    Hjort-Gregersen, K.

    1992-01-01

    The aim was to describe the status of the operational economy of Danish communal biogas systems one year after the Coordinating Committee for Communal Biogas Systems (Koordineringsudvalget for Biogasfaellesanlaeg) had published its main report. Initiatives aimed at the improvement of the systems' economy are also described. The economic analysis is based on actual current earnings. Tables also compare actual and expected earnings in the case of nine communal systems. It is concluded that methane production is generally high and stable as a result of adding organic wastes to the animal manures, yet maintenance and running costs are too high, and capital gains must be raised in order to achieve economical balance. It is recommended that prices and supply of organic wastes be regulated. The quality of used manures must be improved, also by reducing the moisture content. Process control must be initiated as a means of further increasing methane production. Transport systems should be analyzed in an attempt to reduce maintenance costs and the technology should be developed to obtain a stable operation. More personnel are required to ensure operational reliability. The overall administration should be stream-lined, and personnel training should be given higher priority - also implemented by means of manuals and servicing programmes. Personnel should be more familiar with aspects of the general related economy and cost control. (AB)

  14. Double stage dry-wet-fermentation - start-up of a pilot biogas plant

    International Nuclear Information System (INIS)

    Buschmann, Jeannette; Busch, Gunter; Burkhardt, Marko

    2009-01-01

    The Brandenburg University of Technology (BTU) has developed a double stage dry-wet fermentation process for fast and safe anaerobic degradation. Originally designed for treatment of organic wastes, this process allows using a wide variety of solid biodegradable materials. The dividing of hydrolysis and methanation in this process, allows an optimization of the different steps of biogas generation separately. The main advantages of the process are the optimum process control, an extremely stable process operation and a high gas productivity and quality. Compared to conventional processes, the retention times within the percolation stage (hydrolysis) are reduced considerably. In cooperation with the engineering and consulting company GICON, the technology was qualified further to an industrial scale. In 2007 a pilot plant, and, simultaneously, an industrial plant were built by GICON based on this double stage technology. Based on practical experience from the operation of laboratory fermentation plants, the commissioning of the pilot plant was planned, controlled and monitored by our institution. The start-up of a biogas plant of this type focuses mainly on the inoculation the of methane reactor. The growth of microbial populations and generation of a stable biocenosis within the methane reactor is essential and affects the duration of starting period as well as the methanation efficiency a long time afterwards. This paper concerns with start-up of a pilot biogas plant and discusses particular occurrences and effects during this period. (author)

  15. Agricultural biogas plants – A systematic analysis of strengths, weaknesses, opportunities and threats

    International Nuclear Information System (INIS)

    Brudermann, Thomas; Mitterhuber, Corinna; Posch, Alfred

    2015-01-01

    In this paper, we discuss the prospects of agricultural biogas plants. We conducted an integrated SWOT–AHP analysis for such plants in Austria in order to identify strengths, weaknesses, opportunities and threats (SWOT factors), and to weight the factors identified based on expert judgments, calculated according to the Analytic Hierarchy Process (AHP) method. The results show that financial aspects are dominant in three of the four SWOT categories. Technological aspects and issues regarding utilization seem to play a relatively minor role. Factors that are not directly under the control of plant operators are currently perceived as crucial for the success of agricultural biogas plants. We conclude that such plants will only succeed in contributing to sustainable energy supply goals when economic and political conditions are favorable over the long term. - Highlights: • Integrated SWOT–AHP analysis for agricultural biogas plants in Austria. • Quantification of weighting factors based on expert judgments. • Financial aspects dominate over technological and environmental aspects. • Sophisticated and flexible subsidy schemes are crucial for the further diffusion of the technology

  16. Air Emission Reduction Benefits of Biogas Electricity Generation at Municipal Wastewater Treatment Plants.

    Science.gov (United States)

    Gingerich, Daniel B; Mauter, Meagan S

    2018-02-06

    Conventional processes for municipal wastewater treatment facilities are energy and materially intensive. This work quantifies the air emission implications of energy consumption, chemical use, and direct pollutant release at municipal wastewater treatment facilities across the U.S. and assesses the potential to avoid these damages by generating electricity and heat from the combustion of biogas produced during anaerobic sludge digestion. We find that embedded and on-site air emissions from municipal wastewater treatment imposed human health, environmental, and climate (HEC) damages on the order of $1.63 billion USD in 2012, with 85% of these damages attributed to the estimated consumption of 19 500 GWh of electricity by treatment processes annually, or 0.53% of the US electricity demand. An additional 11.8 million tons of biogenic CO 2 are directly emitted by wastewater treatment and sludge digestion processes currently installed at plants. Retrofitting existing wastewater treatment facilities with anaerobic sludge digestion for biogas production and biogas-fueled heat and electricity generation has the potential to reduce HEC damages by up to 24.9% relative to baseline emissions. Retrofitting only large plants (>5 MGD), where biogas generation is more likely to be economically viable, would generate HEC benefits of $254 annually. These findings reinforce the importance of accounting for use-phase embedded air emissions and spatially resolved marginal damage estimates when designing sustainable infrastructure systems.

  17. Economical and ecological benchmarking of biogas plant configurations for flexible power generation in future power supply systems; Oekonomisches und oekologisches Benchmarking von Biogasanlagenkonfigurationen zur flexiblen Verstromung in zukuenftigen Stromversorgungssystemen

    Energy Technology Data Exchange (ETDEWEB)

    Hahn, Henning [Fraunhofer Institut fuer Windenergie und Energiesystemtechnik (IWES), Kassel (Germany). Bereich Energieverfahrenstechnik

    2016-08-01

    With the share of intermittent renewable energies within the electricity system rising, balancing services from dispatchable power plants are of increasing importance. This study comparatively assesses the environmental and economic performance of biogas plant configurations, supplying biogas on demand for flexible power generation. A cost analysis of five configurations based on biogas storing and flexible biogas production concepts has been carried out. Results show that additional flexibility costs for a biogas supply of 8 hours per day range between 2 Euro to 11 Euro MWh{sup -1} and for a 72 hour period without biogas demand from 9 Euro to 19 Euro MWh{sup -1}. While biogas storage concepts were identified as favorable short-term supply configurations, flexible biogas production concepts profit from reduced storage requirements at plants with large biogas production capacities or for longer periods without biogas demand [1, 2]. Flexible biogas plant configurations indicate an increased energy demand to operate the operational enhancements compared to conventional biogas plants supplying biogas for baseload power generation. However, findings show that in contrast to an alternative supply of power generators with natural gas, biogas supplied on demand by adapted biogas plant configurations saves greenhouse gas emissions by 54 to 65 g CO{sub 2-eq} MJ{sup -1} and primary energy by about 1.17 MJ MJ{sup -1}. In this regard, configurations with flexible biogas production profit from reduced biogas storage requirements and achieve higher savings compared to configurations with continuous biogas production [1, 3].

  18. Unit commitment and investment valuation of flexible biogas plants in German power markets

    Energy Technology Data Exchange (ETDEWEB)

    Hochloff, Patrick

    2017-07-01

    Biogas plants contribute a significant share of renewable energy sources (RES) to the electricity system. Most of them are designed to supply constant power generation. In the future biogas plants will most likely become more flexible, scheduling their power generation with respect to market prices. For this purpose power units need extended electrical capacity to convert the continuously produced gas as well as the gas held in storage. When constructing extended capacity at biogas plants, the flexibility premium is the main focus for about 8000 plants which were constructed before August 2014. Additional incomes as a result of selling at higher market prices have been considered, too. However, their relationship to the electrical capacity and storage size of biogas plants was unknown as was the impact on investment valuation. This work has shown how biogas plants with extended capacity can be analyzed when they are operated in power markets, in particular the power spot market and the control reserve markets. Models on the basis of unit commitment have been developed in order to obtain optimized schedules and financial parameters, such as gross income and net present value (NPV), when biogas plants with extended capacity capitalize on prices in each market. The models developed consider several use cases that describe possible ways of participating in German power markets, switching between static and variable gas supply, providing secondary and tertiary control reserve, and claiming the market and flexibility premium. Mixed integer linear programs (MILP) have been developed for the unit commitment of each use case. The model for the unit commitment of providing control reserve with biogas plants made significant progress compared to the state of the art and has been published in (Hochloff, Braun 2014). There are two ways to make use of this model. First of all, the model could be applied to plan daily schedules for the operation of gas plants located at a gas

  19. Unit commitment and investment valuation of flexible biogas plants in German power markets

    International Nuclear Information System (INIS)

    Hochloff, Patrick

    2017-01-01

    Biogas plants contribute a significant share of renewable energy sources (RES) to the electricity system. Most of them are designed to supply constant power generation. In the future biogas plants will most likely become more flexible, scheduling their power generation with respect to market prices. For this purpose power units need extended electrical capacity to convert the continuously produced gas as well as the gas held in storage. When constructing extended capacity at biogas plants, the flexibility premium is the main focus for about 8000 plants which were constructed before August 2014. Additional incomes as a result of selling at higher market prices have been considered, too. However, their relationship to the electrical capacity and storage size of biogas plants was unknown as was the impact on investment valuation. This work has shown how biogas plants with extended capacity can be analyzed when they are operated in power markets, in particular the power spot market and the control reserve markets. Models on the basis of unit commitment have been developed in order to obtain optimized schedules and financial parameters, such as gross income and net present value (NPV), when biogas plants with extended capacity capitalize on prices in each market. The models developed consider several use cases that describe possible ways of participating in German power markets, switching between static and variable gas supply, providing secondary and tertiary control reserve, and claiming the market and flexibility premium. Mixed integer linear programs (MILP) have been developed for the unit commitment of each use case. The model for the unit commitment of providing control reserve with biogas plants made significant progress compared to the state of the art and has been published in (Hochloff, Braun 2014). There are two ways to make use of this model. First of all, the model could be applied to plan daily schedules for the operation of gas plants located at a gas

  20. Power requirements of biogas upgrading by water scrubbing and biomethane compression: Comparative analysis of various plant configurations

    International Nuclear Information System (INIS)

    Budzianowski, Wojciech M.; Wylock, Christophe E.; Marciniak, Przemysław A.

    2017-01-01

    Highlights: • Insights into power requirements of biomethane production from biogas are provided. • Process model is constructed, validated and simulated. • High-pressure and low-pressure plant operation in different configurations is compared. - Abstract: Biogas upgrading by water scrubbing followed by biomethane compression is an environmentally benign process. It may be achieved using various plant configurations characterised by various power requirements with associated effects on biomethane sustainability. Therefore, the current study has been undertaken to systematically investigate the power requirements of a range of water scrubbing options. Two groups of water scrubbing are analysed: (1) high pressure water scrubbing (HPWS) and (2) near-atmospheric pressure water scrubbing (NAPWS). A water scrubbing plant model is constructed, experimentally validated and simulated for seven upgrading plant configurations. Simulation results show that the power requirement of biogas upgrading in HPWS plants is mainly associated with biogas compression. In contrast, in NAPWS plants the main power is required for water pumping. In both plants the compression of the biomethane from atmosphereic pressure to 20 MPa also contributes remarkably. It is observed that the lowest specific power requirement can be obtained for a NAPWS plant without water regeneration (0.24 kW h/Nm 3 raw biogas) but this plant requires cheap water supply, e.g. outlet water from a sewage treatment plant or river. The second is HPWS without flash (0.29 kW h/Nm 3 raw biogas). All other HPWS with flash and NAPWS with water regeneration plants have specific power requirements between 0.30 and 0.33 kW h/Nm 3 raw biogas. Biogas compression without upgrading requires about 0.29 kW h/Nm 3 raw biogas. The thermodynamic efficiency of biogas upgrading is between 2.2% and 9.8% depending on the plant configuration while biomethane compression efficiency is higher, about 55%. This result implies that the

  1. Different approaches to assess the environmental performance of a cow manure biogas plant

    Science.gov (United States)

    Torrellas, Marta; Burgos, Laura; Tey, Laura; Noguerol, Joan; Riau, Victor; Palatsi, Jordi; Antón, Assumpció; Flotats, Xavier; Bonmatí, August

    2018-03-01

    In intensive livestock production areas, farmers must apply manure management systems to comply with governmental regulations. Biogas plants, as a source of renewable energy, have the potential to reduce environmental impacts comparing with other manure management practices. Nevertheless, manure processing at biogas plants also incurs in non-desired gas emissions that should be considered. At present, available emission calculation methods cover partially emissions produced at a biogas plant, with the subsequent difficulty in the preparation of life cycle inventories. The objective of this study is to characterise gaseous emissions: ammonia (NH3-N), methane (CH4), nitrous oxide (N2Oindirect, and N2Odirect) and hydrogen sulphide (H2S) from the anaerobic co-digestion of cow manure by using different approaches for preparing gaseous emission inventories, and to compare the different methodologies used. The chosen scenario for the study is a biogas plant located next to a dairy farm in the North of Catalonia, Spain. Emissions were calculated by two methods: field measurements and estimation, following international guidelines. International Panel on Climate Change (IPCC) guidelines were adapted to estimate emissions for the specific situation according to Tier 1, Tier 2 and Tier 3 approaches. Total air emissions at the biogas plant were calculated from the emissions produced at the three main manure storage facilities on the plant: influent storage, liquid fraction storage, and the solid fraction storage of the digestate. Results showed that most of the emissions were produced in the liquid fraction storage. Comparing measured emissions with estimated emissions, NH3, CH4, N2Oindirect and H2S total emission results were in the same order of magnitude for both methodologies, while, N2Odirect total measured emissions were one order of magnitude higher than the estimates. A Monte Carlo analysis was carried out to examine the uncertainties of emissions determined from

  2. Codigestion of manure and industrial organic waste at centralized biogas plants: process imbalances and limitations

    DEFF Research Database (Denmark)

    Bangsø Nielsen, Henrik; Angelidaki, Irini

    2008-01-01

    The present study focuses on process imbalances in Danish centralized biogas plants treating manure in combination with industrial waste. Collection of process data from various full-scale plants along with a number of interviews showed that imbalances occur frequently. High concentrations...... of ammonia or long chain fatty acids is in most cases expected to be the cause of microbial inhibitions/imbalances while foaming in the prestorage tanks and digesters is the most important practical process problem at the plants. A correlation between increased residual biogas production (suboptimal process...... conditions) and high fractions of industrial waste in the feedstock was also observed. The process imbalances and suboptimal conditions are mainly allowed to occur due to 1) inadequate knowledge about the waste composition, 2) inadequate knowledge about the waste degradation characteristics, 3) inadequate...

  3. Comparative study of economics of different models of family size biogas plants for state of Punjab, India

    International Nuclear Information System (INIS)

    Singh, K. Jatinder; Sooch, Sarbjit Singh

    2004-01-01

    Biogas, the end product of anaerobic digestion of cattle dung, can successfully supplement the cooking fuels in the countryside areas of India, where the raw material needed for its production is plentifully available. Because of the lack of awareness regarding selection of a suitable model and size of biogas plant, the full potential of the biogas producing material is not harnessed, and the economic viability of biogas technology is rendered doubtful. To facilitate this decision making, the economics of family size biogas plants, i.e. with capacity from 1 to 6 m 3 , was studied, and three prevalent models, viz. KVIC, Janta and Deenbandu, were compared. Calculations for installation cost and annual operational cost were made for the state of Punjab, India, where the hydraulic retention time is 40 days, and current market prices were taken into account. Comparison of the economics revealed that the cost of installation and annual operational cost of each capacity were higher for the KVIC model, followed by the Janta and then the Deenbandhu model. Irrespective of the model, as the capacity of the biogas plant increases, the installation, as well as the annual operational cost increase proportionately. With increase in capacity, the payback period decreased exponentially with the exponential character being highest for the KVIC model, followed by the Janta and then the Deenbandhu model. However, on the basis of comparative economics, the Deenbandhu model was found to be the cheapest and most viable model of biogas plant

  4. Western waterweed (Elodea nuttallii) as a co-substrate for biogas plants; Schmalblaettrige Wasserpest (Elodea nuttallii) als Cosubstrat fuer Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Zehnsdorf, Andreas [Helmholtz-Zentrum fuer Umweltforschung - UFZ, Leipzig (Germany). Arbeitsgruppe Bioprozesstechnik; Korn, Ulrich; Pieper, Bernd [Dr. Pieper Technologie- und Produktentwicklung GmbH (Germany); Proeter, Juergen; Naumann, Dirk [Deutsches BiomasseForschungsZentrum gemeinnuetzige GmbH (Germany). Arbeitsgruppe Substratcharakterisierung und -management; Seirig, Michael [Helmholtz-Zentrum fuer Umweltforschung - UFZ, Leipzig (Germany). Umwelt- und Biotechnologisches Zentrum; Roenicke, Helmut [Helmholtz-Zentrum fuer Umweltforschung - UFZ, Leipzig (Germany). Arbeitsgruppe Planktonoekologie

    2011-07-01

    Western waterweed (Elodea nuttallii) grows vigorously in bodies of water in Germany and hinders in many places their recreational use. For this reason, this aquatic plant is now often harvested and subsequently disposed of as organic waste. As a possible alternative use, the harvested Elodea biomass can also be used as co-substrate in biogas plants. As the digestion of western waterweed alone in a laboratory biogas plant led to a reduction of the biogas yield of over 50 %, Elodea was used in combination with maize silage. A mix of 30 % Elodea and 70 % maize silage produced a biogas yield of 580 standard litres per kilogram of organic dry matter. In addition, the aquatic plant and maize were readily ensilable, which made it easy to store and ensured that it was ready to use over a longer period of time. (orig.)

  5. Comparative genotyping of Clostridium thermocellum strains isolated from biogas plants: genetic markers and characterization of cellulolytic potential.

    Science.gov (United States)

    Koeck, Daniela E; Zverlov, Vladimir V; Liebl, Wolfgang; Schwarz, Wolfgang H

    2014-07-01

    Clostridium thermocellum is among the most prevalent of known anaerobic cellulolytic bacteria. In this study, genetic and phenotypic variations among C. thermocellum strains isolated from different biogas plants were determined and different genotyping methods were evaluated on these isolates. At least two C. thermocellum strains were isolated independently from each of nine different biogas plants via enrichment on cellulose. Various DNA-based genotyping methods such as ribotyping, RAPD (Random Amplified Polymorphic DNA) and VNTR (Variable Number of Tandem Repeats) were applied to these isolates. One novel approach - the amplification of unknown target sequences between copies of a previously discovered Random Inserted Mobile Element (RIME) - was also tested. The genotyping method with the highest discriminatory power was found to be the amplification of the sequences between the insertion elements, where isolates from each biogas plant yielded a different band pattern. Cellulolytic potentials, optimal growth conditions and substrate spectra of all isolates were characterized to help identify phenotypic variations. Irrespective of the genotyping method used, the isolates from each individual biogas plant always exhibited identical patterns. This is suggestive of a single C. thermocellum strain exhibiting dominance in each biogas plant. The genotypic groups reflect the results of the physiological characterization of the isolates like substrate diversity and cellulase activity. Conversely, strains isolated across a range of biogas plants differed in their genotyping results and physiological properties. Both strains isolated from one biogas plant had the best specific cellulose-degrading properties and might therefore achieve superior substrate utilization yields in biogas fermenters. Copyright © 2014 Elsevier GmbH. All rights reserved.

  6. Construction and operation of biogas plants. Bau und Betrieb von Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Koenig, F. von

    1985-01-01

    Biogas utilisation in agriculture has increased considerably as a consequence of the energy crisis. So far, energy production was the most important aspect, and the high-quality natural fertilizer offered by the fermentation residues was commonly neglected. This fertilizer is an effective substitute for commercial fertilizers and thus contributes to the reduction of environmental pollution. The book discusses the chemical and biological mechanisms, the criteria of selection for plants and materials, optimum gas production techniques, uses of the product gas, and the advantages and properties of the biofertilizer produced. Planning procedures, design, construction, function and performance of several biogas production plants now in operation are described. Hints are given for do-it-yourself construction, as are cost-benefit calculations and decision aids for construction.

  7. Biological methanation of hydrogen within biogas plants: A model-based feasibility study

    International Nuclear Information System (INIS)

    Bensmann, A.; Hanke-Rauschenbach, R.; Heyer, R.; Kohrs, F.; Benndorf, D.; Reichl, U.; Sundmacher, K.

    2014-01-01

    Highlights: • Simulation study about direct methanation of hydrogen within biogas plants. • In stationary operation two limitations, namely biological and transfer limit. • Biological limit at 4m H2 3 /m CO2 3 due to stoichiometry. • Dynamic behaviour shows three qualitatively different step responses. • A simple control scheme to meet the output quality was developed. - Abstract: One option to utilize excess electric energy is its conversion to hydrogen and the subsequent methanation. An alternative to the classical chemical Sabatier process is the biological methanation (methanogenesis) within biogas plants. In conventional biogas plants methane and carbon dioxide is produced. The latter can be directly converted to methane by feeding hydrogen into the reactor, since hydrogenotrophic bacteria are present. In the present contribution, a comprehensive simulation study with respect to stationary operating conditions and disturbances is presented. It reveals two qualitative different limitations, namely a biological limit (appr. at 4m H2 3 /m CO2 3 corresponds to 4.2m H2,STP 3 /m liq 3 /d) as well as a transfer limit. A parameter region for a safe operation was defined. The temporary operation with stationary unfeasible conditions was analysed and thereby three qualitatively different disturbances can be distinguished. In one of these the operation for several days is possible. On the basis of these results, a controller was proposed and tested that meets the demands on the conversion of hydrogen and also prevents the washout of the microbial community due to hydrogen overload

  8. Evaluation of one year of operation of the biogas plant in Suchohrdly u Miroslavi

    Directory of Open Access Journals (Sweden)

    Adam Moravec

    2011-01-01

    Full Text Available The manner of designing biogas plants is eagerly described by each and every seller or supplier of the respective technology. Numerous feasibility studies comprising forecasts of future operation featuring different quality levels have been written. However, it is rarely possible to obtain information comparing the anticipated future numbers and real values. Nevertheless, an evaluation of past operation of BGP is of utmost importance for calibration of the calculation methods used for designing of future BGPs. Information obtained on the basis of an evaluation is also useful for the purpose of verification of correct functionality of the equipment as well as optimisation of its operation with the objective of achieving the planned (or even better values of profitability of each respective project. A comprehensive analysis of a biogas plant is a project sensitive to accuracy of inputs. Measurements of amounts and quality of the feed substrate throughout the whole year, which comprises numerous criteria, is highly demanding and complicated, and therefore the objective of this evaluation is to analyze the performance, production and consumption of the biogas plant in the course of a calendar year (Schulz et al., 2004. Power measuring tasks are performed using calibrated gauges (which are mostly used for invoicing purposes, thus ensuring accuracy and credibility of the input data.

  9. First tests of using an electronic nose to control biogas plant efficiency

    Directory of Open Access Journals (Sweden)

    Federica Borgonovo

    2013-09-01

    Full Text Available The demand for online monitoring and control of biogas process is increasing, since better monitoring and control system can improve process plants stability and economy. A number of parameters,such as gas production, pH, alkalinity, Volatile Fatty Acids (VFA and H2, in both the liquid and the gas phase have been suggested as process indicators. For different reasons these indicators do not offer enough information to build a consistent feedback control able to promptly forecast and solve plants working problems. The study proposes the use of unconventional complex sensors as a possible solution to engineer a reliable control system. Tests to analyze the biogas coming from a plant were performed using an electronic nose (Airsense PEN 2, AIRSENSE Analytics GmbH. In particular, a 108 olfactometric fingerprinting reference database obtained by different combination of VFA (acetic, propionic e butyric acids, pure or in solution with water was initially determined. As a second step, the e-nose was tested to verify a potential difference in the analysis of gases emitted by digested manure. Statistic multivariate analysis confirm that the e-nose can distinguish the manure and digester mixed liquor aromatic emission proving the possibility of using this technology as possible base for a biogas control system.

  10. Methane emissions from digestate at an agricultural biogas plant.

    Science.gov (United States)

    Baldé, Hambaliou; VanderZaag, Andrew C; Burtt, Stephen D; Wagner-Riddle, Claudia; Crolla, Anna; Desjardins, Raymond L; MacDonald, Douglas J

    2016-09-01

    Methane (CH4) emissions were measured over two years at an earthen storage containing digestate from a mesophilic biodigester in Ontario, Canada. The digester processed dairy manure and co-substrates from the food industry, and destroyed 62% of the influent volatile solids (VS). Annual average emissions were 19gCH4m(-3)d(-1) and 0.27gCH4kg(-1)VSd(-1). About 76% of annual emissions occurred from June to October. Annual cumulative emissions from digestate corresponded to 12% of the CH4 produced within the digester. A key contributor to CH4 emissions was the sludge layer in storage, which contained as much VS as the annual discharge from the digester. These findings suggest that digestate management provides an opportunity to further enhance the benefits of biogas (i.e. reducing CH4 emissions compared to undigested liquid manure, and producing renewable energy). Potential best practices for future study include complete storage emptying, solid-liquid separation, and storage covering. Crown Copyright © 2016. Published by Elsevier Ltd. All rights reserved.

  11. Replacement of mineral fertilizers with anaerobically digested pig slurry in paddy fields: assessment of plant growth and grain quality.

    Science.gov (United States)

    Zhang, Jin; Wang, Minyan; Cao, Yucheng; Liang, Peng; Wu, Shengchun; Leung, Anna Oi Wah; Christie, Peter

    2017-04-01

    Rice cultivation requires large quantities of irrigation water and mineral fertilizers. This provides an opportunity for the recycling of the plant nutrients in anaerobically digested pig slurry, large amounts of which are generated in Chinese pig farms. Hence, to promote the sustainable development of livestock and poultry breeding and rice production, a micro-plot field experiment was carried out to assess whether or not slurry can replace mineral fertilizers in rice paddy production in terms of plant tillering, grain quality, and yields. The results indicate that the total N content of the slurry can serve as an alternative source of N when compared to the control (450 kg ha -1 commercial compound fertilizer (N/P 2 O 5 /K 2 O = 15:15:15) as basal fertilizer, 300 kg ha -1 urea (N% = 46), and 150 kg ha -1 commercial compound fertilizer as top-dressed fertilizer). No negative effects on plant growth or grain yield were observed, although there may be a potential risk due to an increase in grain Cu concentration. The amylose content and gel consistency of the rice grains were enhanced significantly by the use of slurry as a basal fertilizer, but the grain protein and total amino acid contents decreased. The results suggest that anaerobically digested pig slurry can replace mineral fertilizers in rice production when applied as a basal dressing together with urea and commercial compound fertilizer as top-dressed fertilizers.

  12. The Biogas from bio-energy electrical power plant of Nuevo Leon; Central electrica de biogas de bioenergia de Nuevo Leon

    Energy Technology Data Exchange (ETDEWEB)

    Arvizu F, Jose L [Instituto de Investigaciones Electricas, Cuernavaca, Morelos (Mexico); Saldana M, Jaime L [Sistemas de Energia Internacional S.A. de C.V. (Mexico)

    2005-07-01

    The biogas from bio-energy electrical power plant of Nuevo Leon represents, in all the national territory, the first experience on the advantage of biogas emitted by the sanitary landfills for the generation of electrical energy. Therefore, one of the specific objectives of this paper is the one of diffusion and reproduction of the same one in other cities of Mexico and Latin America. The project is framed within the world-wide policies on the control of emissions for the reduction of the greenhouse effect gases (GEG) and its impact in the global climatic change. The gas emitted by the trash sanitary landfills, commonly known as biogas, is a gas mixture derived from the decomposition of the organic matter of the municipal trash by microorganisms in anaerobic conditions. Biogas generated in the sanitary landfills has a methane content of 55% and a 35% of carbon dioxide. The balance 10% is made up of water steam, hydrogen, nitrogen, oxygen, hydrogen sulfur and other gases in minimum amounts. [Spanish] La Central Electrica de Biogas de Bioenergia de Nuevo Leon representa, en todo el territorio nacional, la primera experiencia sobre el aprovechamiento del biogas emitido por los rellenos sanitarios para la generacion de energia electrica. Por esta razon, uno de los objetivos especificos de este trabajo es la de difusion y reproduccion del mismo en otras ciudades de Mexico y Latinoamerica. El proyecto esta enmarcado dentro de las politicas mundiales sobre el control de emisiones para la reduccion de los gases de efecto invernadero (GEI) y su impacto en el cambio climatico global. El gas emitido por la basura dispuesta en los rellenos sanitarios, comunmente conocido como biogas, es una mezcla de gases derivado de la descompensacion de la materia organica de la basura municipal por microorganismos en condiciones anaerobias. El biogas generado en los rellenos sanitarios tiene un contenido de metano del 55% y un 35% de bioxido de carbono. El 10% restante se compone de vapor

  13. Biogas production from coumarin-rich plants--inhibition by coumarin and recovery by adaptation of the bacterial community.

    Science.gov (United States)

    Popp, Denny; Schrader, Steffi; Kleinsteuber, Sabine; Harms, Hauke; Sträuber, Heike

    2015-09-01

    Plants like sweet clover (Melilotus spp.) are not suitable as fodder for cattle because of harmful effects of the plant secondary metabolite coumarin. As an alternative usage, the applicability of coumarin-rich plants as substrates for biogas production was investigated. When coumarin was added to continuous fermentation processes codigesting grass silage and cow manure, it caused a strong inhibition noticeable as decrease of biogas production by 19% and increase of metabolite concentrations to an organic acids/alkalinity ratio higher than 0.3(gorganic acids) gCaCO3 (-1). Microbial communities of methanogenic archaea were dominated by the genera Methanosarcina (77%) and Methanoculleus (11%). This community composition was not influenced by coumarin addition. The bacterial community analysis unraveled a divergence caused by coumarin addition correlating with the anaerobic degradation of coumarin and the recovery of the biogas process. As a consequence, biogas production resumed similar to the coumarin-free control with a biogas yield of 0.34 LN g(volatile solids) (-1) and at initial metabolite concentrations (∼ 0.2 g(organic acids) gCaCO3 (-1)). Coumarin acts as inhibitor and as substrate during anaerobic digestion. Hence, coumarin-rich plants might be suitable for biogas production, but should only be used after adaptation of the microbial community to coumarin. © FEMS 2015. All rights reserved. For permissions, please e-mail: journals.permissions@oup.com.

  14. THE IMPACT OF EXTRUSION ON THE BIOGAS AND BIOMETHANE YIELD OF PLANT SUBSTRATES

    Directory of Open Access Journals (Sweden)

    Krzysztof Pilarski

    2016-09-01

    Full Text Available The objective of the present work was to determine the effect of pretreatment by extrusion on the biogas and biomethane yield of lignocellulosic substrates such as maize silage and maize straw silage. The biogas yields of the substrates before and after treatment were compared. Moreover, energy efficiency of pretreatment by extrusion was analyzed in order to assess the applicability of the process in an agricultural biogas plant. Extrusion tests were carried out in a short single-screw extruder KZM-2 in which the length-to-diameter ratio of the screw was 6:1 and rotational speed was 200 rpm. The biogas yield tests of the plant substrates after extrusion were carried out in a laboratory scale, using 15 biofermenters operated in a periodic manner, at a constant temperature of 39°C (mesophilic digestion and controlled pH conditions. The gas-emission analysis was performed using a certified gas analyzer from Geotech GA5000. Pretreatment by extrusion was observed to improve the quantity of methane generated: in terms of fresh matter for maize silage subjected to extrusion, the methane yield was 16.48% higher than that of the non-extruded silage. On the other hand, maize straw silage after extrusion gave 35.30% more methane than did the same, non-extruded, material. Differences in yields relative to dry organic matter are also described in this paper. Taking into account the amount of energy that is spent on pretreatment and the generated amount of methane, the energy balance for the process gives an idea of the economics of the operation. For maize silage, energy efficiency was lower by 13.21% (-553.2 kWh/Mg, in contrast to maize straw silage, where the increase in energy was 33.49% (678.4 kWh/Mg. The obtained results indicate that more studies on the pretreatment and digestion of maize silage are required in order to improve the efficiency of its use for making biogas. To fully utilize its potential, it is necessary to know thoroughly the effect of

  15. Accounting of greenhouse gas emissions of a biogas plant. Results from the practice; Bilanzierung der Treibhausgasemissionen einer Biogasanlage. Ergebnisse aus der Praxis

    Energy Technology Data Exchange (ETDEWEB)

    Reckmann, Karoline [Union Agricole Holding AG, Pinneberg (Germany); Fritz, Thomas; Lasar, Ansgar

    2014-08-01

    The assessment of greenhouse gas emissions for biogas plants aims at providing valuable data in order to identify set screws for improvements. Most measurements potentially reducing CO{sub 2}-emissions also help improving the profitability of the biogas plant. The current study therefore aimed at quantifying the environmental impacts of biogas plants. To that end, greenhouse gas emissions were assessed using data of a company-owned 776 kW biogas plant located in Wahlstedt, Schleswig-Holstein, Germany. Fermentation substrates are maize, grass and cattle manure. Specific greenhouse gas emissions of 282 g CO{sub 2}-eq per kWh{sub el} have been calculated.

  16. Plant response to FBC waste-coal slurry solid mixtures. [Quarterly] technical report, September 1--November 30, 1993

    Energy Technology Data Exchange (ETDEWEB)

    Darmody, R.G.; Dunker, R.E. [Illinois Univ., Urbana, IL (United States); Dreher, G.B.; Roy, W.R.; Steel, J.D. [Illinois State Geological Survey, Urbana, IL (United States)

    1994-03-01

    The goal of this project is to test the feasibility of stabilizing coal slurry solids (CSS) wastes by directly seeding plants into the waste. This is not done conventionally because the waste can generate toxic amounts of sulfuric acid. Our approach is to neutralize the potential acidity by mixing fluidized bed combustion (FBC) waste into the slurry. If successful, this approach would both help dispose of FBC wastes while providing a more economical slurry stabilization technique. The project involves growing forage plants in CSS-FBC mixtures in the greenhouse. This is the first quarter of the project. We have designed the experiment, secured greenhouse space, purchased the seeds, collected and dried the FBC and CSS samples. The samples represent a typical range of properties. We retrieved two FBC and two CSS samples. One CSS sample appears to have a higher pyrite content than the other.

  17. Energy and substance conversion in biogas plants. Results of measurement investigations of agricultural biogas plants in the Rheinland; Energie- und Stoffumsetzung in Biogasanlagen. Ergebnisse messtechnischer Untersuchungen an landwirtschaftlichen Biogasanlagen im Rheinland

    Energy Technology Data Exchange (ETDEWEB)

    Besgen, S.

    2005-08-15

    The current data situation on biogas technology is not extensive and is mainly based on laboratory testing. This was the starting point for a pilot project and the dissertation at hand, where data was collected from four agricultural biogas plants during a period of two years. These four plants are equipped with extensive measurement technology and are run under mesophilic temperature conditions. They utilize manure, renewable primary products and organic waste products. The measurements carried out cover balancing, i.e. determining the gas-output, production and usage of energy, as well as process analysis. The latter investigates parameters which permit statements on stability of the fermentation process and on the substances of contents of the substrate. Input and output of the plants were quantified during the measurement periods. Input is defined as organic substance, output as the production of electricity and heat from burning biogas in block-type thermal power stations. Concerning the latter, the thermal and electrical efficiency factor was calculated, indicating also the respective fuel oil proportion. Furthermore, the process energy demand in form of electricity and heat for running the plants was analysed. It was possible to define the quality of the biogas produced as well as the quantity of individual substrates based on standard gas calculations. The measurement programme gained valuable data for the practical use of biogas plants. The results will be helpful for planning and designing these plants. (orig.)

  18. Compost and residues from biogas plant as potting substrates for salt-tolerant and salt-sensitive plants

    Energy Technology Data Exchange (ETDEWEB)

    Cam Van, Do Thi

    2013-08-01

    Compost and residues from biogas plant have been increasingly recognized as potting substrates in horticulture. To investigate the suitability of both materials to grow salt tolerant plants in 2010 a pot experiment was conducted in the greenhouse of INRES-Plant nutrition, University of Bonn. Ryegrass (Lolium perenne L.), rape (Brassica napus) and sunflower (Helianthus annuus) were chosen as experimental plants. To reduce the high salt content compost and residues from biogas plant were leached. To improve physical characteristics of raw materials, additives including Perlite, Styromull, Hygromull, Lecaton, Peat, Cocofiber were incorporated into compost or residues from biogas plant with the volumetric ratio of 4:1. Plant growth (DM) and nutrient uptake (N, P, K, Mg, Ca, Na and S) of the experimental plants grown in compost-based or residue-based substrates with and without additives and standard soil as a control were determined. Preliminary results reveal that origin compost and residues from biogas plant without leaching are suitable potting substrates for those plants. For compost leaching may not be recommended while for residues from biogas plant the effect of leaching was not distinct and needs further investigations. The incorporation of additives into the basic materials partially resulted in higher plant dry matter yield and nutrient uptake. However, differences between the additives on both parameters were mainly insignificant. Incorporation of Hygromull or Peat, especially into residues from biogas plant favored plant growth and enhanced total nutrient uptake. In 2011, pot experiments were continued with the salt-sensitive ornamental plants, Pelargonium (Pelargonium zonale Toro) and Salvia (Salvia splendens). Two separate experiments were carried out for the mixtures of compost and additives (SPS standard soil type 73 based on Peat, Hygromull or Cocofiber) with different volumetric ratios (4:1, 1:1, 1:4) and the mixtures of Peat incorporated with small

  19. Boosting biogas yield of anaerobic digesters by utilizing concentrated molasses from 2nd generation bioethanol plant

    Energy Technology Data Exchange (ETDEWEB)

    Sarker, Shiplu [Department of Renewable Energy, Faculty of Engineering and Science, University of Agder, Grimstad-4879 (Norway); Moeller, Henrik Bjarne [Department of Biosystems Engineering, Faculty of Science and Technology, Aarhus University, Research center Foulum, Blichers Alle, Post Box 50, Tjele-8830 (Denmark)

    2013-07-01

    Concentrated molasses (C5 molasses) from 2nd generation bioethanol plant has been investigated for enhancing productivity of manure based digesters. A batch study at mesophilic condition (35+- 1 deg C) showed the maximum methane yield from molasses as 286 LCH4/kgVS which was approximately 63% of the calculated theoretical yield. In addition to the batch study, co-digestion of molasses with cattle manure in a semi-continuously stirred reactor at thermophilic temperature (50+- 1 deg C) was also performed with a stepwise increase in molasses concentration. The results from this experiment revealed the maximum average biogas yield of 1.89 L/L/day when 23% VSmolasses was co-digested with cattle manure. However, digesters fed with more than 32% VSmolasses and with short adaptation period resulted in VFA accumulation and reduced methane productivity indicating that when using molasses as biogas booster this level should not be exceeded.

  20. Increased utilisation of existing biogas plants; Oekat utnyttjande av befintliga biogasanlaeggningar

    Energy Technology Data Exchange (ETDEWEB)

    Lantz, Mikael

    2007-09-15

    The purpose of this study is to analyse how existing biogas plants in Sweden could be utilised more efficiently, by increase the organic loading rate, and to calculate the cost efficiency of such measures. Biogas plants treating sewage sludge are currently operated with low organic loading rates and it is likely that there could be a considerable potential of increased utilisation of existing capacity. However, disposal costs of digested sewage sludge have a great impact on the economic result. Thus, the cost must be low, below 200 - 850 SEK/tonne DS, for co-digestion of sewage sludge and organic household waste to be economic competitive, compared to building of a new reactor. For co-digestion plants, using manure and organic waste as feedstock, it is not possible to say whether it is more economic to increase the utilisation of existing capacity or to increase the reactor volume. Therefore, more specific studies are required for individual plants and cases. Regarding the need for a more sophisticated monitoring and control of the biogas process, it can be established that the utilisation of sewage sludge digestion plants could be increased considerably without exceptionally high organic loading rates, thus probably without any additional monitoring and control. However, indicated prices for such applications are probably acceptable compared to establishing a new reactor. For co-digestion plants, the scope for investments is smaller and more dependent on the alternative cost for new reactors. Also, any process disturbances, which may appear even at low organic loading rates, could be very costly and result in costs in the same range as for monitoring and control equipment. Finally, the reader should observe that the analyses conducted here assume that funding and physical space for additional reactors is available at the existing site. If not, there could be situations where it is economic interesting to increase the organic loading rate although cost estimates

  1. Increase of anaerobic degradation of particulate organic matter in full-scale biogas plants by mechanical maceration

    DEFF Research Database (Denmark)

    Hartmann, Hinrich; Angelidaki, Irini; Ahring, Birgitte Kiær

    2000-01-01

    Different concepts of implementation of mechanical pretreatment for enhancing the biogas potential from fibers in manure feedstock were evaluated by sampling before and after macerators at different biogas plants and from a fiber separation unit. An increase of the biogas potential of up to 25......% by pretreatment of the whole feed in the macerator before the reactor was observed. implementation concepts with a treatment of the fibers alone after separation from the manure showed to be not efficient due to a low recovery of organic matter in the fibers by the separation unit. The low operational costs...... of a macerator make it attractive to use this pretreatment method for a more complete degradation of particulate organic matter. investigation of the size distribution of the fibers showed that a change in biogas potential was not correlated to a smaller size of the fibers. Results from the macerators indicate...

  2. Energy potential and alternative usages of biogas and sludge from UASB reactors: case study of the Laboreaux wastewater treatment plant.

    Science.gov (United States)

    Rosa, A P; Conesa, J A; Fullana, A; Melo, G C B; Borges, J M; Chernicharo, C A L

    2016-01-01

    This work assessed the energy potential and alternative usages of biogas and sludge generated in upflow anaerobic sludge blanket reactors at the Laboreaux sewage treatment plant (STP), Brazil. Two scenarios were considered: (i) priority use of biogas for the thermal drying of dehydrated sludge and the use of the excess biogas for electricity generation in an ICE (internal combustion engine); and (ii) priority use of biogas for electricity generation and the use of the heat of the engine exhaust gases for the thermal drying of the sludge. Scenario 1 showed that the electricity generated is able to supply 22.2% of the STP power demand, but the thermal drying process enables a greater reduction or even elimination of the final volume of sludge to be disposed. In Scenario 2, the electricity generated is able to supply 57.6% of the STP power demand; however, the heat in the exhaust gases is not enough to dry the total amount of dehydrated sludge.

  3. Comparative techno-economical study between membrane technology systems for obtaining concentrated fertilizers from biogas plant effluents

    DEFF Research Database (Denmark)

    Camilleri Rumbau, Maria Salud; Norddahl, Birgir; Kjærhus Nielsen, Anne

    2013-01-01

    Membrane technology is a promising candidate for producing mineral fertilizers from animal slurry. This paper presents a combination of membrane technologies for processing digested slurry, lists retentions of nitrogen (N), phosphorus (P) and potassium (K) and evaluates the economic and technolog...... and technological potential of the processes presented. To increase the content of plant nutrients in mineral concentrates substantially, improved RO (reverse osmosis) or additional technology is required....

  4. Case study of 85 m{sup 3} floating drum biogas plant under hilly conditions

    Energy Technology Data Exchange (ETDEWEB)

    Kalia, A.K.; Singh, S.P. [HPKV, Palampur (India). Dept. of Agricultural Engineering

    1999-05-01

    An 85 m{sup 3} floating drum biogas plant was installed at the dairy farm of HP Agricultural University, Palampur, in 1989 to meet the energy needs of cooking food in the veterinary hostel mess and for general dairy requirements. It cost nearly Rs. 0.21 million (US dollars 6293), including the cost of an 800 m gas pipe line, and is working satisfactorily without any major problems except breakage of the central guide of its gas holder. With the feed rate of 17 q cattle dung/day, 50 m{sup 3} and 30 m{sup 3} biogas was obtained in the summer and winter months, respectively, during 1989-1991. The reduction of feed rate to 9 q cattle dung/day in 1992 onwards resulted in lowering the gas production of 25 m{sup 3} and 18 m{sup 3} in the summer and winter months, respectively. This gas was just sufficient to meet 73% (9466 MJ/month) and 53% (7019 MJ/month) of the energy needs for cooking meals in the hostel alone in the summer and winter months, respectively, during the course of the study. Considering the biogas and manure obtained from the plant, the income-cost ratios during the period 1989-1991 and 1992-1997 were found to be 1.44 and 1.15, respectively, suggesting that, though the plant was under fed relatively to the requisite feed rate (21 q cattle dung/day), the installation of this plant was an economically viable proposition. (author)

  5. Analysis of MSW treatment plant with production of biogas, RDF and compost through simulative approach

    Energy Technology Data Exchange (ETDEWEB)

    Mosca, R.; Giribone, P.; Schenone, M. [Genoa Univ. (Italy). ITIM, Engineering Dept.; Macchiavello, A. [Genoa Univ. (Italy). ISTIC, Engineering Dept.

    1995-12-31

    This work concerns the feasibility study of a MSW (Municipal Solid Waste) treatment plant based on wet way technology. The choice towards such a plant engineering-solution is due to the utilization of the energetic component of waste, through a production of both biogas and RDF (Refuse Derived Fuel) with practically any impact on environment. That`s why this solution is preferred to the traditional incinerating technologies and pyrolysis, that cause environmental damage because of more or less noxious emissions. In order to analyse how a so called multipurpose platform works, a discrete and stochastic simulation modeL able to describe in detail the flow of plant materials, was built. Then a very accurate experimentation campaign was carried out in order to determine a technical evaluation and consequently an economic analysis to verify the convenience of such a plant in the area of western Liguria. (author)

  6. Environmental assessment and finding of no significant impact: Biorecycling Technologies, Inc., Noble Biogas and Fertilizer Plant, Fresno County, California

    International Nuclear Information System (INIS)

    1997-09-01

    The US Department of Energy (DOE) is considering a proposal from the California Energy Commission for partial funding up to $1,500,000 of the construction of the biorecycling Technologies, Inc., (BTI) Noble Biogas and Fertilizer Plant in Fresno County, California. BTI along with its contractors and business partners would develop the plant, which would use manure and green waste to produce biogas and a variety of organic fertilizer products. The California Energy Commission has requested funding from the DOE Commercialization Ventures program to assist in the construction of the plant, which would produce up to one megawatt of electricity by burning biogas in a cogeneration unit. The purpose of this environmental assessment (EA) is to provide DOE and the public with information on potential environmental impacts associated with funding development of the proposed project

  7. Environmental assessment and finding of no significant impact: Biorecycling Technologies, Inc., Noble Biogas and Fertilizer Plant, Fresno County, California

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    1997-09-01

    The US Department of Energy (DOE) is considering a proposal from the California Energy Commission for partial funding up to $1,500,000 of the construction of the biorecycling Technologies, Inc., (BTI) Noble Biogas and Fertilizer Plant in Fresno County, California. BTI along with its contractors and business partners would develop the plant, which would use manure and green waste to produce biogas and a variety of organic fertilizer products. The California Energy Commission has requested funding from the DOE Commercialization Ventures program to assist in the construction of the plant, which would produce up to one megawatt of electricity by burning biogas in a cogeneration unit. The purpose of this environmental assessment (EA) is to provide DOE and the public with information on potential environmental impacts associated with funding development of the proposed project.

  8. Monitoring and documentation of practice biogas plants; Monitoring und Dokumentation von Praxis-Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Ebertseder, Florian; Kissel, Rainer; Lehner, Andreas; Rivera Gracia, Eunice; Bachmaier, Hans; Effenberger, Mathias

    2012-09-15

    The aim of the project is to extend the data base for the evaluation of biogas plants in terms of functionality and reliability of the technical equipment, the stability and efficiency of the fermentation process as well as the energy utilization. For the presented studies six companies were selected as examples. [German] Ziel des Projektes ist die Erweiterung der Datengrundlage zur Bewertung von Biogasanlagen hinsichtlich der Funktionalitaet und Zuverlaessigkeit der technischen Einrichtungen, der Stabilitaet und Leistungsfaehigkeit des Gaerprozesses sowie der Energieverwertung. Fuer die in diesem Bericht vorgestellten Untersuchungen wurden sechs Betriebe beispielhaft ausgewaehlt.

  9. Hazardous organic compounds in biogas plant end products-Soil burden and risk to food safety

    Energy Technology Data Exchange (ETDEWEB)

    Suominen, K., E-mail: kimmo.suominen@evira.fi [Finnish Food Safety Authority Evira, Risk Assessment Research Unit, Mustialankatu 3, 00790 Helsinki (Finland); Verta, M. [Finnish Environmental Institute (SYKE), Mechelininkatu 34a, P.O. Box 140, 00251 Helsinki (Finland); Marttinen, S. [MTT Agrifood Research Finland, 31600 Jokioinen (Finland)

    2014-09-01

    The end products (digestate, solid fraction of the digestate, liquid fraction of the digestate) of ten biogas production lines in Finland were analyzed for ten hazardous organic compounds or compound groups: polychlorinated dibenzo-p-dioxins and furans (PCDD/Fs), polychlorinated biphenyls (PCB(7)), polyaromatic hydrocarbons (PAH(16)), bis-(2-ethylhexyl) phthalate (DEHP), perfluorinated alkyl compounds (PFCs), linear alkylbenzene sulfonates (LASs), nonylphenols and nonylphenol ethoxylates (NP + NPEOs), polybrominated diphenyl ethers (PBDEs), hexabromocyclododecane (HBCD) and tetrabromobisphenol A (TBBPA). Biogas plant feedstocks were divided into six groups: municipal sewage sludge, municipal biowaste, fat, food industry by-products, animal manure and others (consisting of milling by-products (husk) and raw former foodstuffs of animal origin from the retail trade). There was no clear connection between the origin of the feedstocks of a plant and the concentrations of hazardous organic compounds in the digestate. For PCDD/Fs and for DEHP, the median soil burden of the compound after a single addition of digestate was similar to the annual atmospheric deposition of the compound or compound group in Finland or other Nordic countries. For PFCs, the median soil burden was somewhat lower than the atmospheric deposition in Finland or Sweden. For NP + NPEOs, the soil burden was somewhat higher than the atmospheric deposition in Denmark. The median soil burden of PBDEs was 400 to 1000 times higher than the PBDE air deposition in Finland or in Sweden. With PBDEs, PFCs and HBCD, the impact of the use of end products should be a focus of further research. Highly persistent compounds, such as PBDE- and PFC-compounds may accumulate in agricultural soil after repeated use of organic fertilizers containing these compounds. For other compounds included in this study, agricultural use of biogas plant end products is unlikely to cause risk to food safety in Finland. - Highlights:

  10. Hazardous organic compounds in biogas plant end products-Soil burden and risk to food safety

    International Nuclear Information System (INIS)

    Suominen, K.; Verta, M.; Marttinen, S.

    2014-01-01

    The end products (digestate, solid fraction of the digestate, liquid fraction of the digestate) of ten biogas production lines in Finland were analyzed for ten hazardous organic compounds or compound groups: polychlorinated dibenzo-p-dioxins and furans (PCDD/Fs), polychlorinated biphenyls (PCB(7)), polyaromatic hydrocarbons (PAH(16)), bis-(2-ethylhexyl) phthalate (DEHP), perfluorinated alkyl compounds (PFCs), linear alkylbenzene sulfonates (LASs), nonylphenols and nonylphenol ethoxylates (NP + NPEOs), polybrominated diphenyl ethers (PBDEs), hexabromocyclododecane (HBCD) and tetrabromobisphenol A (TBBPA). Biogas plant feedstocks were divided into six groups: municipal sewage sludge, municipal biowaste, fat, food industry by-products, animal manure and others (consisting of milling by-products (husk) and raw former foodstuffs of animal origin from the retail trade). There was no clear connection between the origin of the feedstocks of a plant and the concentrations of hazardous organic compounds in the digestate. For PCDD/Fs and for DEHP, the median soil burden of the compound after a single addition of digestate was similar to the annual atmospheric deposition of the compound or compound group in Finland or other Nordic countries. For PFCs, the median soil burden was somewhat lower than the atmospheric deposition in Finland or Sweden. For NP + NPEOs, the soil burden was somewhat higher than the atmospheric deposition in Denmark. The median soil burden of PBDEs was 400 to 1000 times higher than the PBDE air deposition in Finland or in Sweden. With PBDEs, PFCs and HBCD, the impact of the use of end products should be a focus of further research. Highly persistent compounds, such as PBDE- and PFC-compounds may accumulate in agricultural soil after repeated use of organic fertilizers containing these compounds. For other compounds included in this study, agricultural use of biogas plant end products is unlikely to cause risk to food safety in Finland. - Highlights:

  11. Ecotoxicological assessment of residues from different biogas production plants used as fertilizer for soil.

    Science.gov (United States)

    Stefaniuk, Magdalena; Bartmiński, Piotr; Różyło, Krzysztof; Dębicki, Ryszard; Oleszczuk, Patryk

    2015-11-15

    Residues from biogas production (RBP) are a relatively new materials, which may be an interesting resource for the improvement of soil fertility. Nevertheless, in spite of the potential benefits from the agricultural utilization of RBP, there is a need of comprehensive estimation of their toxicity. This information is needed to exclude potential negative environmental impacts arising from the use of RBP. Samples of RBP obtained from six biogas production plants with varied biogas production methods were analysed. The samples with and without separation on solid and liquid phases were investigated. The physicochemical properties of the RBP, heavy metals content (Cr, Cu, Ni, Cd, Pb i Zn) and toxicity on bacteria (Vibrio fischeri, MARA test - 11 different strains), collembolans (Folsomia candida) and two plant species (Lepidium sativum and Sinapis alba) was investigated. Toxicity of RBP was examined using Phytotoxkit F (root growth inhibition), collembolan test (mortality, inhibition of reproduction), Microtox® (inhibition of the luminescence of V. fischeri) and MARA test (growth of microorganisms). An especially negative effect on the tested organisms whereas was noted for the liquid phase after separation. In many cases, RBP without separation also showed unfavourable effects on the tested organisms. Liquid phase after separation and non-separated materials caused inhibition of root growth of L. sativum and S. alba at the level of 17.42-100% and 30.5-100%, respectively, as well as the inhibition of reproduction of F. candida with the range from 68.89 to 100%. In most cases, no ecotoxicological effect was observed for solid phase after separation for tested organisms. The solid phase after separation presented the most favorable properties between all investigated RBP. Therefore, it can be a potential material for the improvement of soil properties and for later use in agriculture. Copyright © 2015 Elsevier B.V. All rights reserved.

  12. Screening Escherichia coli, Enterococcus faecalis, and Clostridium perfringens as Indicator Organisms in Evaluating Pathogen-Reducing Capacity in Biogas Plants

    DEFF Research Database (Denmark)

    Watcharasukarn, Montira; Kaparaju, Prasad Laxmi-Narasimha; Steyer, Jean-Philippe

    2009-01-01

    This study was conducted to identify an indicator organism(s) in evaluating the pathogen-reducing capacity of biogas plants. Fresh cow manure containing 10(4) to 10(5) colony forming unit (CFU) per milliliter of Escherichia coli and Enterococcus faecalis along with an inoculated Clostridium...... as indicator organisms to evaluate pathogen-reducing capacity in biogas plants at high temperatures of 55A degrees C and 70A degrees C while at 37A degrees C E. coli could also be included as indicator organism....

  13. Techno-economic assessment of biogas plant upgrading by adsorption of hydrogen sulfide on treated sewage–sludge

    International Nuclear Information System (INIS)

    Aguilera, P.G.; Gutiérrez Ortiz, F.J.

    2016-01-01

    Highlights: • Three processes were considered: desulfurization by adsorption, in-situ sorbent regeneration and its production. • The steam for regeneration was studied considering it as a bought external utility and as an in-situ produced utility. • From the cash flow analysis, the cost of the overall desulfurization process was between 2.5 and 4.0 c€/Nm 3 . • A sensitivity analysis was carried out to consider the uncertainty of the methodology. • The competitiveness of the technology seems to be promising versus other biogas H 2 S removal technologies. - Abstract: Biogas plant upgrading by adsorption of hydrogen sulfide on treated sewage–sludge was techno-economically assessed. Three different processes were included in the study: the desulfurization of biogas by adsorption, the in-situ regeneration of the adsorbent and its production from sewage-sludge. Biogas plant upgrading was performed for a flow rate of 1000 Nm 3 /h of biogas with a H 2 S concentration of 2000 ppmv and a breakthrough concentration of 200 ppmv, which is the technical limit value for internal combustion engines. The cost due to the steam required for the in-situ regeneration was evaluated in two different scenarios: as a bought external utility and as an in-situ produced utility, installing an electric or a biogas steam boiler. According to the cash flow analysis carried out, all the options require a similar minimum selling price for the upgraded biogas (about 0.27–0.29 €/Nm 3 ), with a cost of the overall desulfurization process between 2.5 and 4.0 c€/Nm 3 .

  14. Acoustic noise background and sound transmission tests in a slurry line at the HYGAS Pilot Plant

    Energy Technology Data Exchange (ETDEWEB)

    Raptis, A.C.; Sheen, S.H.; Roach, P.D.; Mech, J.F.

    1979-01-01

    A State-of-the-Art report on instrumentation needs for coal conversion demonstration plants indicated that acoustic/ultrasonic techniques may be applied to measure two-phase flows found in coal conversion processes. Later theoretical feasibilities studies on the feasibility of acoustic/ultrasonic techniques to measure mass flow in coal conversion process streams were reported. These studies were based on limited theoretical and experimental results found in the literature. In the present work actual experimental results necessary to design a flowmeter for coal/liquid streams are presented. Acoustic data obtained from tests at the low pressure slurry line of the HYGAS char conversion pilot plant are presented. The data consist of the acoustic noise background and the sound transmission loss for the cases of 0, 18, and 33% char by weight in toluene and benzene. Spectra of noise background were scanned from 10 kHz to 1 MHz. Most acoustic energy of the noise background was shown to be below 500 kHz. Isolated acoustic events were also observed; such events represent either the acoustic resonance of the pipe or the resonant response of the transducer. Relative sound transmission losses were measured by the pitch catch pulse mode operation over the frequency range of 100 kHz to 1 MHz. Strong char concentration dependence with attenuation was observed. Results are discussed in terms of the sonar equation to indicate the feasibility of an ultrasonic or acoustic device applied to char conversion processes.

  15. Deployment of a bio-economic 'hub' in rural Thailand by means of a Centralized biogas plant

    DEFF Research Database (Denmark)

    Lybæk, Rikke

    2017-01-01

    by cascading. The paper further reveals that large amount of appropriate and available feedstock for the suggested biogas plants are assessable within the community, and currently pose an environmental problem, or re-used inefficiently. The centralized biogas plant will thus provide a development ‘hub’ for bio...... of nitrogen, low milk yield and inappropriate cattle diets etc., can be improved in the cattle farms, by better housekeeping, as well as supply of manure to the local dairy. Here, fossil fuels use could be substituted by renewable energy from biogas, and the energy used at various temperature levels......-economic solutions to evolve, and constitute to a platform for new income and product outputs opportunities, as renewable energy production as well as various environmental benefits within rural Thailand....

  16. Siting Conflicts in Renewable Energy Projects in Sweden: Experiences From the Siting of a Biogas Plant

    Energy Technology Data Exchange (ETDEWEB)

    Khan, Jamil

    2001-05-01

    This paper seeks to contribute to an increased understanding of what characterises conflicts regarding the siting of renewable energy facilities. The paper starts out with a brief introduction to different types of renewable energy and the conflicts they might generate as well as a discussion about the differences and similarities in comparison with conflicts over more controversial issues, such as nuclear plants, chemical factories and the construction of roads. The main part of the paper discusses the results from a case study on a failed attempt to site a biogas plant in southern Sweden. The results show that there was a lack of public participation in the early stages of planning, and that peoples negative perceptions of the possibilities to influence the decision-making and of the attitude of the developer, contributed to the development of a public opposition and a polarisation of the conflict. There is also a discussion about the reasons for a shift in the political support for the project and about the role of the legislation in shaping planning processes that either handle conflicts or make them worse. The paper concludes with the observation that the biogas case, in many ways, resembled traditional siting conflicts and that further research is needed to explore the nature of different renewable energy siting conflicts.

  17. Investigation of the prospect of energy self-sufficiency and technical performance of an integrated PEMFC (proton exchange membrane fuel cell), dairy farm and biogas plant system

    International Nuclear Information System (INIS)

    Guan, Tingting; Alvfors, Per; Lindbergh, Göran

    2014-01-01

    Highlights: • A PEMFC stack with a 40% of electrical efficiency will make the integrated PEMFC-CHP, biogas plant and dairy farm self-sufficient. • The quality of the reformate gas is good enough to support normal operation of the PEMFC-CHP. • The methane conversion rate and the content of the CH 4 in the biogas need to be balanced in order to obtain the best system performance. • Compared with a coal-fired CHP plant, the integrated system can avoid coal consumption and CO 2 emissions. - Abstract: A PEMFC fuelled with hydrogen is known for its high efficiency and low local emissions. However, the generation of hydrogen is always a controversial issue for the application of the PEMFC due to the use of fossil fuel and the possible carbon dioxide emissions. Presently, the PEMFC-CHP fed with renewable fuels, such as biogas, appears to be the most attractive energy converter–fuel combination. In this paper, an integrated PEMFC-CHP, a dairy farm and a biogas plant are studied. A PEMFC-CHP fed with reformate gas from the biogas plant generates electricity and heat to a dairy farm and a biogas plant, while the dairy farm delivers wet manure to the biogas plant as the feedstock for biogas production. This integrated system has been modelled for steady-state conditions by using Aspen Plus®. The results indicate that the wet manure production of a dairy farm with 300 milked cows can support a biogas plant to give 1280 MW h of biogas annually. Based on the biogas production, a PEMFC-CHP with a stack having an electrical efficiency of 40% generates 360 MW h electricity and 680 MW h heat per year, which is enough to cover the energy demand of the whole system while the total efficiency of the PEMFC-CHP system is 82%. The integrated PEMFC-CHP, dairy farm and biogas plant could make the dairy farm and the biogas plant self-sufficient in a sustainable way provided the PEMFC-CHP has the electrical efficiency stated above. The effect of the methane conversion rate and the

  18. Basic Data on Biogas

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2012-07-01

    Renewable gases such as biogas and biomethane are considered as key energy carrier when the society is replacing fossil fuels with renewable alternatives. In Sweden, almost 80 % of the fossil fuels are used in the transport sector. Therefore, the focus in Sweden has been to use the produced biogas in this sector as vehicle gas. Basic Data on Biogas contains an overview of production, utilisation, climate effects etc. of biogas from a Swedish perspective. The purpose is to give an easy overview of the current situation in Sweden for politicians, decision makers and interested public. 1.4 TWh of biogas is produced annually in Sweden at approximately 230 facilities. The 135 wastewater treatment plants that produce biogas contribute with around half of the production. In order to reduce the sludge volume, biogas has been produced at wastewater treatment plants for decades. New biogas plants are mainly co-digestion plants and farm plants. The land filling of organic waste has been banned since 2005, thus the biogas produced in landfills is decreasing.

  19. Innovative reuse of concrete slurry waste from ready-mixed concrete plants in construction products.

    Science.gov (United States)

    Xuan, Dongxing; Zhan, Baojian; Poon, Chi Sun; Zheng, Wei

    2016-07-15

    Concrete slurry waste (CSW) is generated from ready-mixed concrete plants during concrete production and is classified as a corrosive hazardous material. If it is disposed of at landfills, it would cause detrimental effects for our surrounding environment and ecosystems due to its high pH value as well as heavy metal contamination and accumulation. A new method in this study has been introduced to effectively reuse CSW in new construction products. In this method, the calcium-silicate rich CSW in the fresh state was considered as a cementitious paste as well as a CO2 capture medium. The experimental results showed that the pH values of the collected CSWs stored for 28 days ranged from 12.5 to 13.0 and a drastic decrease of pH value was detected after accelerated mineral carbonation. The theoretically calculated CO2 sequestration extent of CSWs was from 27.05% to 31.23%. The practical water to solid ratio in the fresh CSW varied from 0.76 to 1.12, which had a significant impact on the compressive strength of the mixture with CSWs. After subjecting to accelerated mineral carbonation, rapid initial strength development and lower drying shrinkage for the prepared concrete mixture were achieved. Copyright © 2016 Elsevier B.V. All rights reserved.

  20. Transferable antibiotic resistance plasmids from biogas plant digestates often belong to the IncP-1 epsilon subgroup

    Czech Academy of Sciences Publication Activity Database

    Wolters, B.; Kyselková, Martina; Krögerrecklenfort, E.; Kreuzig, R.; Smalla, K.

    2015-01-01

    Roč. 5, January (2015), Article 765 ISSN 1664-302X R&D Projects: GA MŠk(CZ) EE2.3.30.0032 Institutional support: RVO:60077344 Keywords : IncP-1 epsilon plasmid * class 1 integrons * biogas plant digestate * antibiotic resistance * exogenous plasmid isolation Subject RIV: EE - Microbiology, Virology Impact factor: 4.165, year: 2015

  1. CONVERSION OF ORGANIC MANURE INTO BIOGAS

    Directory of Open Access Journals (Sweden)

    Dario Brdarić

    2009-12-01

    Full Text Available Production of biogas with anaerobic degradation from organic waste is one of the pledge alternative energetic solutions, especially from organic manure made from animal farming and other residuals of agricultural production. According to 2005 livestock manufacture data daily quantity of animal excrements in Croatia, based on LSU number, is 784 015.26 m3. The aim of this paper is to determine the possibility of production of biogas from the most common types of domestic animals in Croatia. Anaerobic fermentation period of 40 days in mesophilic conditions produced from 1 kg of beef, 31 litres of biogas slurry and from pig slurry 14.83 litres of biogas. From our study it follows that the Republic of Croatia (based on the number of UG could produce 426,995,250.00 Nm3 biogas annually. Exploitation of biogas can decrease import of the referred energents, especially electric energy.

  2. The effect of hygienic treatment on the microbial flora of biowaste at biogas plants

    Energy Technology Data Exchange (ETDEWEB)

    Bagge, E.; Sahlstroem, L.; Albihn, A. [National Veterinary Institute, Uppsala (Sweden). Dept. of Bacteriology

    2005-12-15

    In Sweden, full-scale, commercial biogas plants (BGP), which process low-risk animal waste, operate a separate pre-pasteurisation at 70{sup o}C for 60 min as required by EEC regulation 1774/2002. The purpose of this study was to establish if, during pasteurisation and further processing and handling in full-scale BGPs, pathogens in biowaste could be sufficiently reduced to allow its use on arable land. Four BGPs were sampled on six occasions during 1 year. Sampling was performed from six locations during biogas production. The samples being analysed quantitatively to detect indicator bacteria (Escherichia coli, Enterococcus spp. and coliforms) and spore-forming bacteria (Clostridium spp. and Bacillus spp.) and qualitatively for bacterial pathogens (salmonella, listeria, campylobacter and VTEC O157). Salmonella was the most frequently isolated pathogen before pasteurisation In general, the treatment adequately reduced both indicator and pathogenic bacteria. Spore-forming bacteria were not reduced. However, recontamination and regrowth of bacteria in biowaste was frequently noted after pasteurisation and digestion. (author)

  3. Farm Biogas Handbook; Gaardsbiogashandbok

    Energy Technology Data Exchange (ETDEWEB)

    Christensson, Kjell; Bjoernsson, Lovisa; Dahlgren, Stefan; Eriksson, Peter; Lantz, Mikael; Lindstroem, Johanna; Mickelaaker, Maria

    2009-04-15

    A very large share of the total raw material potential for biogas production will be found within the agriculture. The raw material potential of manure in Sweden amounts to 4 - 6 TWh. Within the agriculture there is moreover a big potential in the form of residues from plant cultivation and non-food crops (approximately 7 TWh) that can to be used for biogas production. The potential for biogas production from only residues and manure is around 8-10 TWh. An increased biogas production within the agriculture would give significant environmental effects. Among other things manure, that today is leaking methane gas to the atmosphere, can be fermented, and trough this process the methane losses will be reduced. When the produced biogas replaces fossil fuel, an overall environmental effect will be reached, that is highly significant. This manual deals with biogas plants for agriculture and such plants that do not have extensive transports of different raw materials, as manure, wastes etc. One of the starting points for this manual's set-up is a course plan that Biogas Syd made for the courses they give to farmers, advisors and others. The manual illustrates important aspects in planning and construction of biogas plants, from raw material and technology to dimensioning of plant, use of biogas and planning of local gas grids. We also think it is important to illustrate the legislation that encompasses construction work and operation of a biogas plant. Investment costs are also illustrated, but the book does not give any extensive economic calculations, since we believe that such calculations need their own manual in the form of calculation examples, based on various conditions. The final section is called 'Biogas on farm - from idea to reality' where the entire process from analysis and pre-planning to monitoring and control of plant during operation is briefly described

  4. Biogas technology on farms 1; Biokaasuteknologiaa maatiloilla 1. Biokaasulaitoksen hankinta, kaeyttoeoenotto ja operointi - kaeytaennoen kokemuksia MTT:n maatilakohtaiselta laitokselta

    Energy Technology Data Exchange (ETDEWEB)

    Luostarinen, S. (ed.)

    2013-11-01

    Biogas technologies can be applied for several different purposes in agriculture. It is a means to utilise the energy content of manure and other organic materials, to recycle their nutrients into plant production, enhance utilisation of nitrogen and to mitigate emissions from agriculture. Of the two end-products, biogas can be utilised in the production of heat, electricity and/or vehicle fuel and digestate as fertiliser on fields. Agricultural biogas plants digest mainly animal manure in Finland. Several co-substrates are also used, including different plant biomasses and suitable by-products from especially food production. The aim of using co-substrates is usually to increase the amount of energy produced but they also affect the nutrient content and ratios in the digestate. Planning agricultural biogas plants starts from available fee materials, their amounts and characteristics. The biogas plant is designed for these materials and the technologies used are chosen to suit them. There are several options for plant design and how it can be attached into existing farm structures and it is wise to discuss these matters with an expert. In this way, correct farm-specific decisions can be made. When permitting the plant (permission for construction, environmental permit, safety issues, fertiliser legislation), it is important to make contact with the respective authority. Profitability of the biogas plant should be considered carefully. Things to consider include e.g. available financial incentives, investment cost, energy production and utilisation (own use or sale), nutrient recycling and potential avoidance of mineral fertilisers, co-substrates with gate fee, improved hygiene and less odours. Experiments at MTT Maaninka farm-scale biogas plant showed that dairy cow slurry produces 12-14 m{sup 3} of methane per ton of fresh weight. In this specific biogas plant this results potentially in methane production with an energy content of 400 MWh (3500 m{sup 3} of slurry

  5. Plant response to FBC waste-coal slurry solid mixtures. Technical report, 1 March--31 May 1994

    Energy Technology Data Exchange (ETDEWEB)

    Darmody, R.G.; Dunker, R.E. [Univ. of Illinois, Urbana, IL (United States); Dreher, G.B.; Roy, W.R.; Steel, J.D. [Illinois State Geological Survey, Champaign, IL (United States)

    1994-09-01

    The goal of this project is to test the feasibility of stabilizing coal slurry solids (CSS) wastes by directly seeding plants into the waste. This is not done conventionally because the waste can generate toxic amounts of sulfuric acid. The approach is to neutralize the potential acidity by mixing fluidized bed combustion (FBC) waste into the slurry. If successful, this approach would both help dispose of FBC wastes while providing a more economical slurry stabilization technique. The project involves growing forage plants in CSS-FBC mixtures in the greenhouse. In the first two quarters the authors designed the experiment, secured greenhouse space, purchased the seeds, collected, dried, analyzed the FBC and CSS samples. The samples represent a typical range of properties. They retrieved two FBC and two CSS samples. One CSS sample had a relatively high CaCO{sub 3} content relative to the pyrite content and required no FBC to neutralize the potential acidity. The other CSS sample required from 4.2 to 2.7% FBC material to neutralize its potential acidity. This report covers the third quarter of the project. The authors produced the CSS-FBC mixtures, analyzed the soil fertility parameters of the mixtures,, planted the crops, and monitored their growth. All mixtures support at least some plant growth, although some plants did better than others. It is too early to analyze the results statistically. Next quarter the plants will be harvested, yields calculated, mineral uptake evaluated, and a final report will be written on plant response to CSS-FBC mixtures.

  6. Plant response to FBC waste-coal slurry solid mixtures. [Quarterly] technical report, December 1--February 28, 1994

    Energy Technology Data Exchange (ETDEWEB)

    Darmody, R.G. [Illinois Univ., Urbana, IL (United States); Dunker, R.E. [Illinois Univ., Urbana, IL (United States). Dept. of Agronomy; Dreher, G.B.; Roy, W.R.; Steel, J.D. [Illinois State Geological Survey, Champaign, IL (United States)

    1994-06-01

    The goal of this project is to test the feasibility of stabilizing coal slurry solids (CSS) wastes by directly seeding plants into the waste. This is not done conventionally because the waste can generate toxic amounts of sulfuric acid. Our approach is to neutralize the potential acidity by mixing fluidized bed combustion (FBC) waste into the slurry. If successful this approach would both help dispose of FBC wastes while providing a more economical slurry stabilization technique. The project involves growing forage plants in CSS-FBC mixtures in the greenhouse. This is the second quarter of the project. We have designed the experiment, secured greenhouse space, purchased the seeds, collected, dried, and are analyzing the FBC and CSS samples. The samples represent a typical range of properties. We retrieved two FBC and two CSS samples. One CSS sample had a relatively high CaCO{sub 3} content relative to the pyrite content and will require no FBC to neutralize the potential acidity. The other CSS sample will require from 4.2 to 2.7% FBC material to neutralize its potential acidity.

  7. Life Cycle Environmental Impacts of Electricity from Biogas Produced by Anaerobic Digestion.

    Science.gov (United States)

    Fusi, Alessandra; Bacenetti, Jacopo; Fiala, Marco; Azapagic, Adisa

    2016-01-01

    The aim of this study was to evaluate life cycle environmental impacts associated with the generation of electricity from biogas produced by the anaerobic digestion (AD) of agricultural products and waste. Five real plants in Italy were considered, using maize silage, slurry, and tomato waste as feedstocks and cogenerating electricity and heat; the latter is not utilized. The results suggest that maize silage and the operation of anaerobic digesters, including open storage of digestate, are the main contributors to the impacts of biogas electricity. The system that uses animal slurry is the best option, except for the marine and terrestrial ecotoxicity. The results also suggest that it is environmentally better to have smaller plants using slurry and waste rather than bigger installations, which require maize silage to operate efficiently. Electricity from biogas is environmentally more sustainable than grid electricity for seven out of 11 impacts considered. However, in comparison with natural gas, biogas electricity is worse for seven out of 11 impacts. It also has mostly higher impacts than other renewables, with a few exceptions, notably solar photovoltaics. Thus, for the AD systems and mesophilic operating conditions considered in this study, biogas electricity can help reduce greenhouse gas (GHG) emissions relative to a fossil-intensive electricity mix; however, some other impacts increase. If mitigation of climate change is the main aim, other renewables have a greater potential to reduce GHG emissions. If, in addition to this, other impacts are considered, then hydro, wind, and geothermal power are better alternatives to biogas electricity. However, utilization of heat would improve significantly its environmental sustainability, particularly global warming potential, summer smog, and the depletion of abiotic resources and the ozone layer. Further improvements can be achieved by banning open digestate storage to prevent methane emissions and regulating

  8. Life Cycle Environmental Impacts of Electricity from Biogas Produced by Anaerobic Digestion

    Science.gov (United States)

    Fusi, Alessandra; Bacenetti, Jacopo; Fiala, Marco; Azapagic, Adisa

    2016-01-01

    The aim of this study was to evaluate life cycle environmental impacts associated with the generation of electricity from biogas produced by the anaerobic digestion (AD) of agricultural products and waste. Five real plants in Italy were considered, using maize silage, slurry, and tomato waste as feedstocks and cogenerating electricity and heat; the latter is not utilized. The results suggest that maize silage and the operation of anaerobic digesters, including open storage of digestate, are the main contributors to the impacts of biogas electricity. The system that uses animal slurry is the best option, except for the marine and terrestrial ecotoxicity. The results also suggest that it is environmentally better to have smaller plants using slurry and waste rather than bigger installations, which require maize silage to operate efficiently. Electricity from biogas is environmentally more sustainable than grid electricity for seven out of 11 impacts considered. However, in comparison with natural gas, biogas electricity is worse for seven out of 11 impacts. It also has mostly higher impacts than other renewables, with a few exceptions, notably solar photovoltaics. Thus, for the AD systems and mesophilic operating conditions considered in this study, biogas electricity can help reduce greenhouse gas (GHG) emissions relative to a fossil-intensive electricity mix; however, some other impacts increase. If mitigation of climate change is the main aim, other renewables have a greater potential to reduce GHG emissions. If, in addition to this, other impacts are considered, then hydro, wind, and geothermal power are better alternatives to biogas electricity. However, utilization of heat would improve significantly its environmental sustainability, particularly global warming potential, summer smog, and the depletion of abiotic resources and the ozone layer. Further improvements can be achieved by banning open digestate storage to prevent methane emissions and regulating

  9. Life cycle environmental impacts of electricity from biogas produced by anaerobic digestion

    Directory of Open Access Journals (Sweden)

    Alessandra eFusi

    2016-03-01

    Full Text Available The aim of this study was to evaluate life cycle environmental impacts associated with the generation of electricity from biogas produced by the anaerobic digestion of agricultural products and waste. Five real plants in Italy were considered, using maize silage, slurry and tomato waste as feedstocks and co-generating electricity and heat; the latter is not utilized. The results suggest that maize silage and the operation of anaerobic digesters, including open storage of digestate, are the main contributors to the impacts of biogas electricity. The system which uses animal slurry is the best option, except for the marine and terrestrial eco-toxicity. The results also suggest that it is environmentally better to have smaller plants using slurry and waste rather than bigger installations which require maize silage to operate efficiently. Electricity from biogas is environmentally more sustainable than grid electricity for seven out of 11 impacts considered. However, in comparison with natural gas, biogas electricity is worse for seven out of 11 impacts. It also has mostly higher impacts than other renewables, with a few exceptions, notably solar photovoltaics. Thus, for the AD systems and mesophilic operating conditions considered in this study, biogas electricity can help reduce greenhouse gas (GHG emissions relative to a fossil-intensive electricity mix; however, some other impacts increase. If mitigation of climate change is the main aim, other renewables have a greater potential to reduce GHG emissions. If, in addition to this, other impacts are considered, then hydro, wind and geothermal power are better alternatives to biogas electricity. However, utilization of heat would improve significantly its environmental sustainability, particularly global warming potential, summer smog and the depletion of abiotic resources and the ozone layer. Further improvements can be achieved by banning open digestate storage to prevent methane emissions and

  10. Survival of salmonella and Ascaris suum eggs in a thermophilic biogas plant

    Energy Technology Data Exchange (ETDEWEB)

    Plym-Forshell, L. [Swedish Univ. of Agricultural Sciences, Dept. of Animal Hygiene, Faculty of Veterinary Medicine, Skara (Denmark)

    1995-11-01

    In a continuous biogas plant, receiving manure from 200 dairy cows and 400 calves and young stock, survival of salmonella and Ascaris suum eggs was studied. The bacteria and parasite eggs were kept in filter sacs in the manure that ha a temperature of 55 deg. C. No viable salmonella or Ascaris suum eggs could be found after 24 h in the digester. Survival of salmonella and Ascaris suum eggs was also studied in the manure pit where the manure was stored after digestion. The temperature in the manure pit varied between 22-27 deg. C. Salmonella survived 35 but not 42 days. On day 56, when the experiments had to be stooped, 60% of the Ascaris eggs were viable. (au) 30 refs.

  11. Basic data biogas Germany. Solid fuels, biofuels, biogas; Basisdaten Bioenergie Deutschland. Festbrennstoffe - Biokraftstoffe - Biogas

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2012-08-15

    The brochure ''Basic data biogas Germany'' gives statistical information about (a) renewable energies: primary energy consumption, power generation, energy supply, avoidance of greenhouse gases; (b) Solid fuels: energetic utilization, wood pellets, energy consumption, comparison to heating oil; (c) Biofuels: consumption, bioethanol, biodiesel, vegetable oils; (d) Biogas: biogas power plants, energy content, production, legal aspects.

  12. Basic data biogas Germany. Solid fuels, biofuels, biogas; Basisdaten Bioenergie Deutschland. Festbrennstoffe, Biokraftstoffe, Biogas

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2011-09-15

    The brochure ''Basic data biogas Germany'' gives statistical information about (a) renewable energies: primary energy consumption, power generation, energy supply, avoidance of greenhouse gases; (b) Solid fuels: energetic utilization, wood pellets, energy consumption, comparison to heating oil; (c) Biofuels: consumption, bioethanol, biodiesel, vegetable oils; (d) Biogas: biogas power plants, energy content, production, legal aspects.

  13. Sustainability Biogas Production from Ensiled Plants Consisting of the Transformation of the Digestate into a Valuable Organic-Mineral Granular Fertilizer

    Directory of Open Access Journals (Sweden)

    Hubert Prask

    2018-02-01

    Full Text Available The research concerned the elaborate of non-waste biogas production technology based on the development of digestate from anaerobic digestion. In the anaerobic digestion process, the substrates of plant origin in the form of silage were used. The digestate obtained after biogas production was processed using the ORTWED method into a valuable granulated organic-mineral fertilizer, which contains a solid fraction of digestate, calcium and biogenic elements. This method can be successfully applied in agriculture in the context of its sustainable development due to the growing problem of utilization of digestate forming in agricultural biogas plants.

  14. The safe construction and management of co-fermentation biogas plants. Existing knowledge, legislation and practical experiences; Het veilig bouwen en beheren van co-vergistingsinstallaties voor de productie van biogas. Bestaande kennis, regelgeving en praktijksituaties

    Energy Technology Data Exchange (ETDEWEB)

    Heezen, P.A.M.; Mahesh, S.; Gooijer, L.

    2012-01-15

    For the production of biogas by co-fermentation, manure is mixed with organic waste products that can be fermented, such as harvesting residues and food remains. Since biogas possesses both flammable and toxic properties, large-scale production systems are always associated with potential safety risks. Biogas is a mixture of gases and has flammable properties due to the presence of methane (CH4). It is less well known that biogas also has toxic properties when it contains high levels of hydrogen sulfide (H2S). In a previous study, the RIVM recommended that standards pertaining to the minimum safety level be applied for the construction and operation of biogas production plants. A subsequent study by the RIVM concluded that the guideline 'Handreiking (co-)vergisting van mest' (InfoMil, 2010) provides a basic framework to achieve this recommended minimum safety level. The RIVM therefore recommends that this latter document be used and further supplemented with specific information for inspection and licensing authorities, the main users of this document. The composition of the biogas determines whether or not a specific installation falls within or outside the scope of certain (safety) legislation and, consequently, which specific safety regulations and safety inspections are mandatory. As a clear, consistent and predictable composition of biogas does not exist, stricter monitoring of biogas composition in the different compartments of the production plant is recommended. The current assessment of potential safety risks associated with the production of biogas is that these risks principally relate to those working at the biogas installation and are much less relevant to local residents. Further investigations are needed to determine if this is indeed the case [Dutch] Voor de productie van biogas door co-vergisting wordt mest vermengd met restanten van bijvoorbeeld oogsten of voedsel die kunnen vergisten. Biogas heeft brandbare en giftige eigenschappen

  15. The safe construction and management of co-fermentation biogas plants. Existing knowledge, legislation and practical experiences; Veilig bouwen en beheren van (co-)vergistingsinstallaties voor de productie van biogas. Bestaande kennis, regelgeving en praktijksituaties

    Energy Technology Data Exchange (ETDEWEB)

    Heezen, P.A.M.; Mahesh, S.; Gooijer, L. [Rijksinstituut voor Volksgezondheid en Milieu RIVM, Bilthoven (Netherlands)

    2012-01-15

    For the production of biogas by co-fermentation, manure is mixed with organic waste products that can be fermented, such as harvesting residues and food remains. Since biogas possesses both flammable and toxic properties, large-scale production systems are always associated with potential safety risks. Biogas is a mixture of gases and has flammable properties due to the presence of methane (CH4). It is less well known that biogas also has toxic properties when it contains high levels of hydrogen sulfide (H2S). In a previous study, the RIVM recommended that standards pertaining to the minimum safety level be applied for the construction and operation of biogas production plants. A subsequent study by the RIVM concluded that the guideline 'Handreiking (co-)vergisting van mest' ('Manual co-fermentation of manure') provides a basic framework to achieve this recommended minimum safety level. The RIVM therefore recommends that this latter document be used and further supplemented with specific information for inspection and licensing authorities, the main users of this document. The composition of the biogas determines whether or not a specific installation falls within or outside the scope of certain (safety) legislation and, consequently, which specific safety regulations and safety inspections are mandatory. As a clear, consistent and predictable composition of biogas does not exist, stricter monitoring of biogas composition in the different compartments of the production plant is recommended. The current assessment of potential safety risks associated with the production of biogas is that these risks principally relate to those working at the biogas installation and are much less relevant to local residents. Further investigations are needed to determine if this is indeed the case [Dutch] Voor de productie van biogas door co-vergisting wordt mest vermengd met restanten van bijvoorbeeld oogsten of voedsel die kunnen vergisten. Biogas heeft

  16. Pilot-scale field study for ammonia removal from lagoon biogas using an acid wet scrubber.

    Science.gov (United States)

    Lin, Hongjian; Wu, Xiao; Miller, Curtis; Zhu, Jun; Hadlocon, Lara Jane; Manuzon, Roderick; Zhao, Lingying

    2014-01-01

    The anaerobic activities in swine slurry storage and treatment generate biogas containing gaseous ammonia component which is a chemical agent that can cause adverse environmental impacts when released to the atmosphere. The aim of this pilot plant study was to remove ammonia from biogas generated in a covered lagoon, using a sulfuric acid wet scrubber. The data showed that, on average, the biogas contained 43.7 ppm of ammonia and its concentration was found to be exponentially related to the air temperature inside the lagoon. When the air temperature rose to 35°C and the biogas ammonia concentration reached 90 ppm, the mass transfer of ammonia/ammonium from the deeper liquid body to the interface between the air and liquid became a limiting factor. The biogas velocity was critical in affecting ammonia removal efficiency of the wet scrubber. A biogas flow velocity of 8 to 12 mm s(-1) was recommended to achieve a removal efficiency of greater than 60%. Stepwise regression revealed that the biogas velocity and air temperature, not the inlet ammonia concentration in biogas, affected the ammonia removal efficiency. Overall, when 73 g L(-1) (or 0.75 M) sulfuric acid solution was used as the scrubber solution, removal efficiencies varied from 0% to 100% with an average of 55% over a 40-d measurement period. Mass balance calculation based on ammonium-nitrogen concentration in final scrubber liquid showed that about 21.3 g of ammonia was collected from a total volume of 1169 m(3) of biogas, while the scrubber solution should still maintain its ammonia absorbing ability until its concentration reaches up to 1 M. These results showed promising use of sulfuric acid wet scrubber for ammonia removal in the digester biogas.

  17. Rye-grass as an energy crop using biogas technology

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2005-11-15

    The viability of using rye-grass in the UK as a wet energy crop was investigated in this project. The harvesting of rye-grass, the operation of pilot-scale digesters fed with cut rye-grass, and the operation of a biogas plant are described. Use of the digestate as a fertilizer for the grass was examined and the need for added farm manure or slurry to enrich the nutrient content of the grass and produce better yields is noted. Details are given of the digester design and the design of a commercial-scale biogas plant able to take a variety of liquid and solid feeds. Energy balance, the economics of the commercial design, the ensiling of the grass, and methane yields are considered.

  18. Microbial Consortium with High Cellulolytic Activity (MCHCA for enhanced biogas production.

    Directory of Open Access Journals (Sweden)

    Krzysztof ePoszytek

    2016-03-01

    Full Text Available The use of lignocellulosic biomass as a substrate in agricultural biogas plants is very popular and yields good results. However, the efficiency of anaerobic digestion, and thus biogas production, is not always satisfactory due to the slow or incomplete degradation (hydrolysis of plant matter. To enhance the solubilization of the lignocellulosic biomass various physical, chemical and biological pretreatment methods are used.The aim of this study was to select and characterize cellulose-degrading bacteria, and to construct a microbial consortium, dedicated for degradation of maize silage and enhancing biogas production from this substrate.Over one hundred strains of cellulose-degrading bacteria were isolated from: sewage sludge, hydrolyzer from an agricultural biogas plant, cattle slurry and manure. After physiological characterization of the isolates, sixteen strains (representatives of Bacillus, Providencia and Ochrobactrum genera were chosen for the construction of a Microbial Consortium with High Cellulolytic Activity, called MCHCA. The selected strains had a high endoglucanase activity (exceeding 0.21 IU/mL CMCase activity and a wide range of tolerance to various physical and chemical conditions. Lab-scale simulation of biogas production using the selected strains for degradation of maize silage was carried out in a two-bioreactor system, similar to those used in agricultural biogas plants.The obtained results showed that the constructed MCHCA consortium is capable of efficient hydrolysis of maize silage, and increases biogas production by even 38%, depending on the inoculum used for methane fermentation. The results in this work indicate that the mesophilic Microbial Consortium with High Cellulolytic Activity has a great potential for application on industrial scale in agricultural biogas plants.

  19. Part load or switching? Efficient load management for combined heat and power units at biogas plants; Teillast oder Takten? Effizientes Lastmanagement fuer Blockheizkraftwerke von Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Jung, U. [Institut fuer Energetik und Umwelt, Leipzig (Germany). Biogastechnologie; Mueller, R. [Hochschule fuer Technik, Wirtschaft und Kultur Leipzig (HTWK) (Germany). Energiewirtschaft/Kraftwerkstechnik

    2008-07-01

    Biogas has been developed to a successful alternative in the field of electricity supply. By the end of 2007 more than 3,700 biogas plants in Germany produced the equivalent current portion of two big coal power or nuclear power plants. However, further increase of efficiency is possible with regard to the operation of the CHP. The performance can be increased up to 10% by realizing an adequate load management. (orig.)

  20. Villacidro solar demo plant: Integration of small-scale CSP and biogas power plants in an industrial microgrid

    Science.gov (United States)

    Camerada, M.; Cau, G.; Cocco, D.; Damiano, A.; Demontis, V.; Melis, T.; Musio, M.

    2016-05-01

    The integration of small scale concentrating solar power (CSP) in an industrial district, in order to develop a microgrid fully supplied by renewable energy sources, is presented in this paper. The plant aims to assess in real operating conditions, the performance, the effectiveness and the reliability of small-scale concentrating solar power technologies in the field of distributed generation. In particular, the potentiality of small scale CSP with thermal storage to supply dispatchable electricity to an industrial microgrid will be investigated. The microgrid will be realized in the municipal waste treatment plant of the Industrial Consortium of Villacidro, in southern Sardinia (Italy), which already includes a biogas power plant. In order to achieve the microgrid instantaneous energy balance, the analysis of the time evolution of the waste treatment plant demand and of the generation in the existing power systems has been carried out. This has allowed the design of a suitable CSP plant with thermal storage and an electrochemical storage system for supporting the proposed microgrid. At the aim of obtaining the expected energy autonomy, a specific Energy Management Strategy, which takes into account the different dynamic performances and characteristics of the demand and the generation, has been designed. In this paper, the configuration of the proposed small scale concentrating solar power (CSP) and of its thermal energy storage, based on thermocline principle, is initially described. Finally, a simulation study of the entire power system, imposing scheduled profiles based on weather forecasts, is presented.

  1. Production of biogas at wastewater treatment plants and its further application

    Directory of Open Access Journals (Sweden)

    Makisha Nikolay

    2018-01-01

    Full Text Available This article covered a wide range of questions on the topic of production and use of biogas as alternative energy source. Biogas is produced by anaerobic digestion of biomass due to the breakdown of fats, proteins and carbohydrates, which constitute the bulk of organic matter. The article describes the most common methods of biogas production, their stages and characteristics. In addition, the article describes some of the possible areas of application of biogas on example of different countries. The article also provides information about key environmental and economic benefits in the case of use of biogas: prevention of methane emissions and lower emissions of carbon monoxide and nitrogen oxides into the atmosphere; the possibility of using secondary raw materials to generate electricity.

  2. CO2 balance in production of energy based on biogas

    DEFF Research Database (Denmark)

    Nielsen, Per Sieverts; Holm-Nielsen, J.B.

    1997-01-01

    Biogas is an essential biomass source for achieving a reduction of CO2 emission by 50% in year 2030 in Denmark. The physical potential for biogas production in Denmark is more than 10 times the present biogas production in Denmark. In Denmark the largest part of the biogas production is produced...... at 19 decentralised joint biogas plants involving a varying number of farms (5-100). All of these plants use to some extent co-fermentation with industrial organic waste to increase biogas yield.A fuel chain approach for utilisation of biogas for energy purposes is carried out for determining the role...... of increased transportation distances at large biogas plants on the total CO2 balance of the biogas plant. The advantage of constructing large biogas plants is the cost-effective possibility of using industrial organic waste to increase biogas production. In some cases co-fermentation increases biogas...

  3. A fuzzy approach to a multiple criteria and geographical information system for decision support on suitable locations for biogas plants

    DEFF Research Database (Denmark)

    Franco de los Rios, Camilo Andres; Bojesen, Mikkel; Hougaard, Jens Leth

    The purpose of this paper is to model the multi-criteria decision problem of identifying the most suitable facility locations for biogas plants under an integrated decision support methodology. Here the Geographical Information System (GIS) is used for measuring the attributes of the alternatives...... according to a given set of criteria. Measurements are taken in interval form, expressing the natural imprecision of common data, and the Fuzzy Weighted Overlap Dominance (FWOD) procedure is applied for aggregating and exploiting this kind of data, obtaining suitability degrees for every alternative....... The estimation of criteria weights, which is necessary for applying the FWOD procedure, is done by means of the Analytical Hierarchy Process (AHP), such that a combined AHP-FWOD methodology allows identifying the more suitable sites for building biogas plants. We show that the FWOD relevance-ranking procedure...

  4. Comparative use of different emission measurement approaches to determine methane emissions from a biogas plant.

    Science.gov (United States)

    Reinelt, Torsten; Delre, Antonio; Westerkamp, Tanja; Holmgren, Magnus A; Liebetrau, Jan; Scheutz, Charlotte

    2017-10-01

    A sustainable anaerobic biowaste treatment has to mitigate methane emissions from the entire biogas production chain, but the exact quantification of these emissions remains a challenge. This study presents a comparative measurement campaign carried out with on-site and ground-based remote sensing measurement approaches conducted by six measuring teams at a Swedish biowaste treatment plant. The measured emissions showed high variations, amongst others caused by different periods of measurement performance in connection with varying operational states of the plant. The overall methane emissions measured by ground-based remote sensing varied from 5 to 25kgh -1 (corresponding to a methane loss of 0.6-3.0% of upgraded methane produced), depending on operating conditions and the measurement method applied. Overall methane emissions measured by the on-site measuring approaches varied between 5 and 17kgh -1 (corresponding to a methane loss of 0.6 and 2.1%) from team to team, depending on the number of measured emission points, operational state during the measurements and the measurement method applied. Taking the operational conditions into account, the deviation between different approaches and teams could be explained, in that the two largest methane-emitting sources, contributing about 90% of the entire site's emissions, were found to be the open digestate storage tank and a pressure release valve on the compressor station. Copyright © 2017. Published by Elsevier Ltd.

  5. Biogas plants with 300 GWh yearly production - system, technology and economy; Biogasanlaeggningar med 300 GWh aarsproduktion - system, teknik och ekonomi

    Energy Technology Data Exchange (ETDEWEB)

    Benjaminsson, Johan; Linne, Marita [BioMil AB, Lund (Sweden)

    2007-09-15

    Systems, techniques and economy have been analysed for biogas plants with more than 300 GWh annual energy productions. There is so far no such concept in Sweden but in Germany, a so called biogas park with 450 GWh annual biogas production will be set in operation by autumn 2007. Substratum for 300 GWh gas production are crops which corresponds to a acreage need of 6,000-11,000 hectares for silage crops such as maize or grass. If the gas production is based on corn, the acreage need is about 14 000 hectares. That means that biogas production from silage gives a higher energy outcome per hectare in comparison to grain. According to calculations, grain affects the gas price more than silage. However, grain is easy available at the world market which can be related to digestion of silage that means long term contracts with farmers nearby the biogas plant in addition to a complex logistic system for supply. The grain price by end of 2006 affects the gas price with about 0,38 kr/kWh. Large scale harvesting and transportation of silage in addition to a system for different crops to be harvested and transported directly to the digestion chamber admit reduced handling cost. Silage is expected to affect the gas price with about 0,28 kr/kWh. The price development of grain and silage can be expected to follow each other. The grain prices for 2008 seems to be higher than the notations for 2006/2007. Developed technique for digestion of grain admits 6 kg DMo/m{sup 3} chamber volume, 24 hours. That means reduced size of the digestion chamber in comparison to conventional digestion technique. In Germany where silage is the main substratum, two stage digestion with a first laying chamber admits 4 kg DMo/m{sup 3} chamber volume, 24 hours and DM-content of 12 %. The specific digestion cost for crops is about 0,13 kr/kWh. Huge amounts of digestion residue have to be handled. Dewatering makes sense since the digestion process needs additional water. The phosphorous solid fraction can

  6. Distributed power generation using biogas fuelled microturbines

    International Nuclear Information System (INIS)

    Pointon, K.; Langan, M.

    2002-01-01

    This research sought to analyse the market for small scale biogas fuelled distributed power generation, to demonstrate the concept of a biogas fuelled microturbine using the Capstone microturbine in conjunction with an anaerobic digester, and undertake a technico-economic evaluation of the biogas fuelled microturbine concept. Details are given of the experimental trials using continuous and batch digesters, and feedstocks ranging from cow and pig slurries to vegetable wastes and municipal solid waste. The yields of methane are discussed along with the successful operation of the microturbine with biogas fuels, and anaerobic digestion projects

  7. Distributed power generation using biogas fuelled microturbines

    Energy Technology Data Exchange (ETDEWEB)

    Pointon, K.; Langan, M.

    2002-07-01

    This research sought to analyse the market for small scale biogas fuelled distributed power generation, to demonstrate the concept of a biogas fuelled microturbine using the Capstone microturbine in conjunction with an anaerobic digester, and undertake a technico-economic evaluation of the biogas fuelled microturbine concept. Details are given of the experimental trials using continuous and batch digesters, and feedstocks ranging from cow and pig slurries to vegetable wastes and municipal solid waste. The yields of methane are discussed along with the successful operation of the microturbine with biogas fuels, and anaerobic digestion projects.

  8. Mineralization-immobilization and plant uptake of nitrogen as influenced by the spatial distribution of cattle slurry in soils of different texture

    DEFF Research Database (Denmark)

    Sørensen, P.; Jensen, E.S.

    1995-01-01

    and from an equivalent amount of NH4+-N in ((NH4)-N-15) SO4 (control) was measured during 6 months of growth in pots. After this period the total recovery of labelled N in the top soil plus herbage was similar in the slurry and the control treatments. This indicated that gaseous losses from slurry NH4+-N......The effect of incorporating cattle slurry in soil, either by mixing or by simulated injection into a hollow in soil, on the ryegrass uptake of total N and (NH4+)-N-15-N was determined in three soils of different textrue. The N accumulation in Italian ryegrass (Lolium multiflorum L.) from slurry N...... were insignificant. Consequently, the availability of slurry N to plants was mainly influenced by the mineralization-immobilization processes. The apparent utilization of slurry NH4+-N mixed into soil was 7%, 14% and 24% lower than the utilization of (NH4)(2)SO4-N in a sand soil, a sandy loam soil...

  9. Emissions of carbon dioxide and methane from fields fertilized with digestate from an agricultural biogas plant

    Science.gov (United States)

    Czubaszek, Robert; Wysocka-Czubaszek, Agnieszka

    2018-01-01

    Digestate from biogas plants can play important role in agriculture by providing nutrients, improving soil structure and reducing the use of mineral fertilizers. Still, less is known about greenhouse gas emissions from soil during and after digestate application. The aim of the study was to estimate the emissions of carbon dioxide (CO2) and methane (CH4) from a field which was fertilized with digestate. The gas fluxes were measured with the eddy covariance system. Each day, the eddy covariance system was installed in various places of the field, depending on the dominant wind direction, so that each time the results were obtained from an area where the digestate was distributed. The results showed the relatively low impact of the studied gases emissions on total greenhouse gas emissions from agriculture. Maximum values of the CO2 and CH4 fluxes, 79.62 and 3.049 µmol s-1 m-2, respectively, were observed during digestate spreading on the surface of the field. On the same day, the digestate was mixed with the topsoil layer using a disc harrow. This resulted in increased CO2 emissions the following day. Intense mineralization of digestate, observed after fertilization may not give the expected effects in terms of protection and enrichment of soil organic matter.

  10. Isolation of acetic, propionic and butyric acid-forming bacteria from biogas plants.

    Science.gov (United States)

    Cibis, Katharina Gabriela; Gneipel, Armin; König, Helmut

    2016-02-20

    In this study, acetic, propionic and butyric acid-forming bacteria were isolated from thermophilic and mesophilic biogas plants (BGP) located in Germany. The fermenters were fed with maize silage and cattle or swine manure. Furthermore, pressurized laboratory fermenters digesting maize silage were sampled. Enrichment cultures for the isolation of acid-forming bacteria were grown in minimal medium supplemented with one of the following carbon sources: Na(+)-dl-lactate, succinate, ethanol, glycerol, glucose or a mixture of amino acids. These substrates could be converted by the isolates to acetic, propionic or butyric acid. In total, 49 isolates were obtained, which belonged to the phyla Firmicutes, Tenericutes or Thermotogae. According to 16S rRNA gene sequences, most isolates were related to Clostridium sporosphaeroides, Defluviitoga tunisiensis and Dendrosporobacter quercicolus. Acetic, propionic or butyric acid were produced in cultures of isolates affiliated to Bacillus thermoamylovorans, Clostridium aminovalericum, Clostridium cochlearium/Clostridium tetani, C. sporosphaeroides, D. quercicolus, Proteiniborus ethanoligenes, Selenomonas bovis and Tepidanaerobacter sp. Isolates related to Thermoanaerobacterium thermosaccharolyticum produced acetic, butyric and lactic acid, and isolates related to D. tunisiensis formed acetic acid. Specific primer sets targeting 16S rRNA gene sequences were designed and used for real-time quantitative PCR (qPCR). The isolates were physiologically characterized and their role in BGP discussed. Copyright © 2016 Elsevier B.V. All rights reserved.

  11. Scenedesmus dimorphus (Turpin) Kützing growth with digestate from biogas plant in outdoor bag photobioreactors.

    Science.gov (United States)

    Barbato, F; Venditti, A; Bianco, A; Guarcini, L; Bottari, E; Festa, M R; Cogliani, E; Pignatelli, V

    2016-01-01

    Digestate coming from an Anaerobic Digestion unit in a Biogas Plant, feeded on cow manure and vegetable waste from markets, has been used. About 8-35 L polyethylene transparent bags have been employed as cultivation container, outdoor. Different aliquots of digestate, alone or mixed with commercial liquid fertiliser, were employed to cultivate in batch Scenedesus dimorphus, a freshwater green microalga, in the ENEA facilities of Casaccia Research Center, near Rome, Italy. The cultivation period was June-July 2013. The average daily yields of dry microalgae biomass varied from 20 mg/L/d to 60 mg/L/d, mean 38.2 mg/L/d. Final dry biomass concentration varied from 0.18 to 1.29 g/L, mean 0.55 g/L. S. dimorphus proved to be very efficient in removing N and P from the culture medium. Another fact emerged from these trials is that S. dimorphus inner composition resulted to be variable in response to the tested different culture conditions.

  12. Digestate from Biogas Plants is an Attractive Alternative to Mineral Fertilisation of Kohlrabi

    Directory of Open Access Journals (Sweden)

    Tomas Losak

    2014-12-01

    Full Text Available This study examined the potential for the use of digestate from biogas plants for the fertilisation of kohlrabi. Kohlrabi was grown in two pot experiments in consecutive years using digestate, mineral fertiliser (urea with a nitrogen (N content equivalent to that in the digestate, mineral fertiliser with N, phosphate (P, potassium (K and magnesium (Mg contents equivalent to the digestate, and an unfertilised control. At harvest, the soil receiving the digestate application had higher P, K and Mg contents than the control and the urea treatment. The soil Nmin content was balanced in all fertilised treatments. Soil pH was unaffected by all treatments. Kohlrabi bulbs from the unfertilised control had the lowest weight, nitrate content and ascorbic acid content. Digestate and NPKMg fertiliser treatments increased bulb weight compared with the N-only urea treatment. Ascorbic acid content did not differ between fertilised treatments. There were no differences in bulb nitrate content between the mineral fertiliser treatments, but digestate application gave a low nitrate content. Bulb macroelement contents varied irregularly among treatments.

  13. Purification of anaerobic digestion biogas from a wastewater treatment plant for its use as bio fuel; Purificacion del biogas de digestion anaerobia de una depuradora de aguas residuales para uso como biocombustible

    Energy Technology Data Exchange (ETDEWEB)

    Osorio Robles, F.; Torres Rojo, J. C.; Sanchez Bas, M.; Moya Sanchez, N.

    2009-07-01

    The first phase of the investigation whose results are presented in this article, consists on the optimization of the biogas desulphurization. In our case this process was made by chemical way. Besides the scrubbing towers, the pilot plant used included filters of activated carbon at the end of the line. The H{sub 2}S inflow concentrations were quite high. After the carried out rehearsals, the effluent biogas from the scrubbing towers presents a H{sub 2}S concentration less than 1 ppm and zero or undetectable values of up to fifty eight analyzed trace elements. (Author) 12 refs.

  14. Mechanical Pretreatment to Increase the Bioenergy Yield for Full-scale Biogas Plants

    DEFF Research Database (Denmark)

    Tsapekos, Panagiotis; Kougias, Panagiotis; Angelidaki, Irini

    % compared to the untreated one. The digestion of meadow grass as an alternative co-substrate had positive impact on the energy yield of full-scale biogas reactors operating with cattle manure, pig manure or mixture of both. A preliminary analysis showed that the addition of meadow grass in a manure based...... biogas reactor was possible with biomass share of 10%, leading to energy production of 280 GJ/day. The digestion of pretreated meadow grass as alternative co-substrate had clearly positive impact in all the examined scenarios, leading to increased biogas production in the range of 10%-20%.......This study investigated the efficiency of commercially available harvesting machines for mechanical pretreatment of meadow grass, in order to enhance the energy yield per hectare. Excoriator was shown to be the most efficient mechanical pretreatment increasing the biogas yield of grass by 16...

  15. Electricity from biogas

    International Nuclear Information System (INIS)

    Augenstein, D.; Benemann, J.; Hughes, E.

    1994-01-01

    Biogas is a medium-Btu methane and carbon dioxide mix produced by bacterial decomposition of organic matter. Its sources include landfills, waste water sludges, and animal wastes. It can fuel energy applications, of which electricity generation is a frequently-preferred option. The greatest current U.S. biogas recovery and energy use is at landfills, where biogas at about 80 landfill sites fuels a total of approximately 300 MWe. Wastewater treatment plants and confined animal waste management systems support additional electric power production. Generation of electricity from biogas can present difficulties due to the generally small scale of the generating facility, variable energy content of the gas, fluctuating availability, contaminant problems, and often-demanding control needs. However, such difficulties are being successfully addressed and economics for electricity generation are often favorable as biogas can be essentially open-quotes freeclose quotes fuel. Biogas recovery and use has the additional advantage of mitigating a potent greenhouse gas. Biogas from U.S. landfills alone could fuel about 1% of U.S. electrical generation while giving climate change benefit equivalent to reducing CO 2 emissions in the electricity sector by more than 10%. Growth in landfill gas use will be facilitated by recent regulations, advances in equipment, and improved management techniques such as open-quotes controlled landfillingclose quotes. The potential for biogas recovery and electricity production from sewage sludges, animal wastes and other organic resources such as agricultural residues is uncertain but probably exceeds the estimate for landfills

  16. Exploring the adoption of renewable energy: the case of biogas plants in Greek agriculture

    International Nuclear Information System (INIS)

    Kousis, M.

    1992-01-01

    With a focus on renewable energy, an evaluation of the current literature on the adoption of new technologies is given and a review of biogas options in Greece presented. A preliminary test of the significance of some factors that influence the acceptance of biogas technology by Greek hog farmers is constructed. Although the evidence appears to support a model which emphasises individual characteristics in the adoption process, the overall data qualify the position which stresses the institutional role to that end. (author)

  17. Biogas container - mobile plant concept for the decentralized power generation; Biogascontainer. Mobiles Anlagenkonzept zur dezentralen Energiegewinnung

    Energy Technology Data Exchange (ETDEWEB)

    Warncke, Jessica; Orth, Maik [Innovations- und Bildungszentrum Hohen Luckow e.V., Hohen Luckow (Germany); Schlegel, Mathias [Rostock Univ. (Germany); Steinhagen, Katrin [ROSOMA GmbH, Rostock-Marienehe (Germany)

    2011-07-01

    In the framework of a cooperation project of the Federal Ministry of Economics and Technology was developed a small biogas system, that is concepted in the order of a 40-foot standard container, that is modular structured, works energy-independent and optional can be used mobile. First rank the system was designed for biogas production in developing and emerging countries. Now there are inter alia also concrete inquiries of german partners. (orig.)

  18. Ice slurry accumulation

    Energy Technology Data Exchange (ETDEWEB)

    Christensen, K.G.; Kauffeld, M.

    1998-06-01

    More and more refrigeration systems are designed with secondary loops, thus reducing the refrigerant charge of the primary refrigeration plant. In order not to increase energy consumption by introducing a secondary refrigerant, alternatives to the well established single phase coolants (brines) and different concepts of the cooling plant have to be evaluated. Combining the use of ice-slurry - mixture of water, a freezing point depressing agent (antifreeze) and ice particles - as melting secondary refrigerant and the use of a cool storage makes it possible to build plants with secondary loops without increasing the energy consumption and investment. At the same time the operating costs can be kept at a lower level. The accumulation of ice-slurry is compared with other and more traditional storage systems. The method is evaluated and the potential in different applications is estimated. Aspects of practically use of ice-slurry has been examined in the laboratory at the Danish Technological Institute (DTI). This paper will include the final conclusions from this work concerning tank construction, agitator system, inlet, outlet and control. The work at DTI indicates that in some applications systems with ice-slurry and accumulation tanks have a great future. These applications are described by a varying load profile and a process temperature suiting the temperature of ice-slurry (-3 - -8/deg. C). (au)

  19. Experiences with biogas in Denmark

    DEFF Research Database (Denmark)

    Bundgaard, Sirid Sif; Kofoed-Wiuff, Anders

    This report is primarily based on the work of the Danish biogas task force, which was established as a result of the Energy Agreement of 22 March 2012. The purpose of the task force is to examine and support concrete biogas projects in order to facilitate the projected biogas development up to 2020....... The focus of the task force was on the practical integration of the new biogas production in energy system, including the utilization of gas, the necessary infrastructure and contractual relationships. The aim was to ensure effective and appropriate integration of biogas in the Danish energy supply, which...... was consistent with the policy objectives, both in regards to current challenges for specific biogas plants and the role of biogas flexible renewable energy form on longer term. The task force's final report was published in 2014....

  20. The use of biogas plant fermentation residue for the stabilisation of toxic metals in agricultural soils

    Science.gov (United States)

    Geršl, Milan; Šotnar, Martin; Mareček, Jan; Vítěz, Tomáš; Koutný, Tomáš; Kleinová, Jana

    2015-04-01

    Our department has been paying attention to different methods of soil decontamination, including the in situ stabilisation. Possible reagents to control the toxic metals mobility in soils include a fermentation residue (FR) from a biogas plant. Referred to as digestate, it is a product of anaerobic decomposition taking place in such facilities. The fermentation residue is applied to soils as a fertiliser. A new way of its use is the in situ stabilisation of toxic metals in soils. Testing the stabilisation of toxic metals made use of real soil samples sourced from five agriculturally used areas of the Czech Republic with 3 soil samples taken from sites contaminated with Cu, Pb and Zn and 2 samples collected at sites of natural occurrence of Cu, Pb and Zn ores. All the samples were analysed using the sequential extraction procedure (BCR) (determine the type of Cu, Pb and Zn bonds). Stabilisation of toxic metals was tested in five soil samples by adding reagents as follows: dolomite, slaked lime, goethite, compost and fermentation residue. A single reagent was added at three different concentrations. In the wet state with the added reagents, the samples were left for seven days, shaken twice per day. After seven days, metal extraction was carried out: samples of 10 g soil were shaken for 2 h in a solution of 0.1M NH4NO3 at a 1:2.5 (g.ml-1), centrifuged for 15 min at 5,000 rpm and then filtered through PTFE 0.45 μm mesh filters. The extracts were analysed by ICP-OES. Copper The best reduction of Cu concentration in the extract was obtained at each of the tested sites by adding dolomite (10 g soil + 0.3 g dolomite). The concentration of Cu in the leachate decreased to 2.1-18.4% compare with the leachate without addition. Similar results were also shown for the addition of fermentation residue (10 g soil + 1 g FR). The Cu concentration in the leachate decreased to 16.7-26.8% compared with the leachate without addition. Lead The best results were achieved by adding

  1. Perspectives on Spatial Decision Support Concerning Location of Biogas Production

    DEFF Research Database (Denmark)

    Bojesen, Mikkel

    Biogas production is a contemporary important topic in many agri-intensive countries, among these Denmark, where biogas has received increasingly political and scholarly awareness during recent years. The Danish government has set an ambition that 50% of the livestock slurry should by 2020 by used...... biomass resource availability is expected to decline by 10% until 2020 but with regional variation. We find that large scale biogas producers enjoy 16% lower transportation costs than small biogas producers. It is argued that biogas producers need to see themselves as agro-based retailers and accordingly...

  2. Thermic model to predict biogas production in unheated fixed-dome digesters buried in the ground

    DEFF Research Database (Denmark)

    Terradas-Ill, Georgina; Cuong, Pham Hung; Triolo, Jin Mi

    2014-01-01

    buried in the soil to study heat transfer between biogas digester and its surroundings. The predicted temperatures in the dome, biogas and slurry inside the digester and the resulting biogas production are presented and validated. The model was well able to estimate digester temperature (linear slope...

  3. Planning of biogas plants. A question of co-operation and negotiation; Planering av biogasanlaeggningar. En fraaga om samverkan och foerhandling

    Energy Technology Data Exchange (ETDEWEB)

    Khan, Jamil

    2003-04-01

    During the last years there has been an increased interest in Sweden to build biogas reactors. The planning of a biogas plant brings about the need for co-operation between a variety of actors. Furthermore, there are a number of different issues that need to be dealt with. To build a biogas plant is thus a rather complicated thing to do. The aim of this report is to increase the knowledge about the processes that precede a decision to build a biogas plant, in order to try to facilitate the planning of future projects. The report is based on case studies of the planning of two biogas plants in Sweden and the empirical material consists of interviews with key persons as well as written documents. In the study, three parallel processes are identified and analysed, which are all crucial to carry through a project. These are the project planning process, the political process and the application process. The most important result of the study is that there is not only one way to carry through a project and that the choice of strategy depends on the character of the project and the different questions that need to be handled. Examples of other results are: the importance of an early and continuous dialogue with the political leadership, the necessity to build an organisation for the co-operation between key actors and that the project leaders should be flexible and open to changes in the project throughout the planning process.

  4. Biogas production from renewable lignocellulosic biomass

    Directory of Open Access Journals (Sweden)

    Venkatachalam Sundaresan Gnanambal

    2015-06-01

    Full Text Available Effect of raw and biologically treated lignocellulosic biomass using cow dung slurry for biogas production is reported. Biomass is an energy source. Water containing biomass such as sewage sludge, cow dung slurry and lignocellulosic waste, has several important advantages and one of the key feature is renewability. Cow dung slurry has the potential to produce large amounts of biogas. Four categories of bacteria viz., hydrolytic, fermentative, fermentative acidogenic and acidogenic-methanogenic bacteria are involved in the production of biogas. The different characteristics of the cow dung slurry were determined according to standard methods. Hemicellulose, cellulose and lignin content of the lignocellulosic waste were also determined in our earlier studies. The substrates were digested under anaerobic condition for 5 days. The total biogas and methane produced during anaerobic digestion were estimated on 5th day. The total biogas produced during digestion was estimated by water displacement method. Biological methane production was estimated by using Saccharometer. DOI: http://dx.doi.org/10.3126/ije.v4i2.12662 International Journal of Environment Vol.4(2 2015: 341-347

  5. Biogas in the natural gas distribution network; Biogas til nettet

    Energy Technology Data Exchange (ETDEWEB)

    Kvist Jensen, T.

    2009-05-15

    With the Danish 'Thorsoe Biogas Plant' as reference case, an assessment of the possibility of using the existing natural gas distribution network for distributing biogas was carried out. Technologies for and cost of upgrading biogas to natural gas quality are presented. Furthermore, a socio-economic analysis has been performed, including the Danish financial conditions, the market models, and the role of the natural gas distribution companies.

  6. Biogas Production from Vietnamese Animal Manure, Plant Residues and Organic Waste: Influence of Biomass Composition on Methane Yield

    Directory of Open Access Journals (Sweden)

    T. T. T. Cu

    2015-02-01

    Full Text Available Anaerobic digestion is an efficient and renewable energy technology that can produce biogas from a variety of biomasses such as animal manure, food waste and plant residues. In developing countries this technology is widely used for the production of biogas using local biomasses, but there is little information about the value of these biomasses for energy production. This study was therefore carried out with the objective of estimating the biogas production potential of typical Vietnamese biomasses such as animal manure, slaughterhouse waste and plant residues, and developing a model that relates methane (CH4 production to the chemical characteristics of the biomass. The biochemical methane potential (BMP and biomass characteristics were measured. Results showed that piglet manure produced the highest CH4 yield of 443 normal litter (NL CH4 kg−1 volatile solids (VS compared to 222 from cows, 177 from sows, 172 from rabbits, 169 from goats and 153 from buffaloes. Methane production from duckweed (Spirodela polyrrhiza was higher than from lawn grass and water spinach at 340, 220, and 110.6 NL CH4 kg−1 VS, respectively. The BMP experiment also demonstrated that the CH4 production was inhibited with chicken manure, slaughterhouse waste, cassava residue and shoe-making waste. Statistical analysis showed that lipid and lignin are the most significant predictors of BMP. The model was developed from knowledge that the BMP was related to biomass content of lipid, lignin and protein from manure and plant residues as a percentage of VS with coefficient of determination (R-square at 0.95. This model was applied to calculate the CH4 yield for a household with 17 fattening pigs in the highlands and lowlands of northern Vietnam.

  7. Biogas production from vietnamese animal manure, plant residues and organic waste: influence of biomass composition on methane yield.

    Science.gov (United States)

    Cu, T T T; Nguyen, T X; Triolo, J M; Pedersen, L; Le, V D; Le, P D; Sommer, S G

    2015-02-01

    Anaerobic digestion is an efficient and renewable energy technology that can produce biogas from a variety of biomasses such as animal manure, food waste and plant residues. In developing countries this technology is widely used for the production of biogas using local biomasses, but there is little information about the value of these biomasses for energy production. This study was therefore carried out with the objective of estimating the biogas production potential of typical Vietnamese biomasses such as animal manure, slaughterhouse waste and plant residues, and developing a model that relates methane (CH4) production to the chemical characteristics of the biomass. The biochemical methane potential (BMP) and biomass characteristics were measured. Results showed that piglet manure produced the highest CH4 yield of 443 normal litter (NL) CH4 kg(-1) volatile solids (VS) compared to 222 from cows, 177 from sows, 172 from rabbits, 169 from goats and 153 from buffaloes. Methane production from duckweed (Spirodela polyrrhiza) was higher than from lawn grass and water spinach at 340, 220, and 110.6 NL CH4 kg(-1) VS, respectively. The BMP experiment also demonstrated that the CH4 production was inhibited with chicken manure, slaughterhouse waste, cassava residue and shoe-making waste. Statistical analysis showed that lipid and lignin are the most significant predictors of BMP. The model was developed from knowledge that the BMP was related to biomass content of lipid, lignin and protein from manure and plant residues as a percentage of VS with coefficient of determination (R-square) at 0.95. This model was applied to calculate the CH4 yield for a household with 17 fattening pigs in the highlands and lowlands of northern Vietnam.

  8. Optimal integration of energy at the Combined Energy Plant in Norrkoeping -Integration of steam, hot water and district heat to biogas plants; Optimal integrering av energianvaendningen vid energikombinatet i Norrkoeping -Integrering av aanga, hetvatten och fjaerrvaerme till biogasanlaeggningar

    Energy Technology Data Exchange (ETDEWEB)

    Benjaminsson, Johan; Goldschmidt, Barbara; Uddgren, Roger

    2010-09-15

    The background of this report is to investigate and highlight the benefits of establishing a biogas plant nearby a combined energy plant where steam and district heat is available. By using heat from the combined energy plant, more biogas can be produced as vehicle fuel instead of being used as fuel to heat the digester, the biogas upgrading plant or the dryer. The project's objective is to analyze where it is interesting with integration of heat to the biogas plant and to compare alternative technologies and possible integration options. The stakeholders of the study are industries with access to organic matter for biogas production and heat producers who can deliver thermal energy into biogas plants. The project was implemented by collection of information from the Haendeloe combined energy plant outside Norrkoeping where there is a cogeneration plant, an ethanol plant and a biogas plant. Case studies for the study have been carried out with proposals regarding how heat flows from the power plant and ethanol plant can be further integrated with the biogas plant. As case studies, both the current design of the biogas plant, as well as a fictional case in which half of all distillery residues was digested, have been evaluated. The case studies show that in today's biogas plant it is not economical to replace the existing biogas upgrading unit with water absorption to chemical absorption. The upgrading cost with water absorption at today's smaller facility is 0.11 kr/kWh and in order to obtain the same total cost of chemical absorption a steam price of 0.15 kr/kWh is required. For large gas flows, chemical absorption is an advantage since the technology is more suitable for upscaling in comparison with water absorption that must be delivered in multiple lines. Nevertheless, a possibility to recover waste heat from chemical absorption is necessary if the technology shall be competitive. If waste heat from both water absorption and chemical absorption

  9. State of the art for noise reduction in biogas plants. Sound technical analyses, research, investigations; Stand der Technik zur Laermminderung bei Biogasanlagen. Schalltechnische Analysen, Recherchen, Untersuchungen

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2014-05-15

    Approximately 480 biogas plants are currently being built in Mecklenburg-Vorpommern, which were mainly built in an agricultural context. At the beginning of 2014 about 15 percent of the country's electricity was generated by domestic biogas plants. This publication is intended to serve as a guide to the authorities, planners and engineers, in order to be able to plan, erect and operate biogas plants in the most conflict-free manner. [German] In Mecklenburg-Vorpommern werden derzeit ca. 480 Biogasanlagen betrieben, die vorwiegend in einem landwirtschaftlichen Kontext errichtet wurden. Anfang des Jahres 2014 wurde etwa 15 Prozent des Stroms im Land durch einheimische Biogasanlagen erzeugt. Diese Veroeffentlichung soll den Behoerden, Planern und Ingenieurbueros als Handlungsleitfaden dienen, um Biogasanlagen unter Beruecksichtigung des Standes der Technik moeglichst konfliktfrei planen, errichten und betreiben zu koennen.

  10. Presence of Siloxanes in the Biogas of a Wastewater Treatment Plant Separation in Condensates and Influence of the Dose of Iron Chloride on its Elimination

    International Nuclear Information System (INIS)

    Mariano, García; Daniel, Prats; Arturo, Trapote

    2015-01-01

    The siloxanes present in the biogas produced during anaerobic digestion damage the mechanism of cogeneration equipment and, consequently, negatively affect the energy valorization process. For this reason, the detection and elimination of these silicon-derived chemical compounds are a priority in the management of cogeneration facilities. In this regard, the objectives of this paper are, firstly, to characterize the siloxanes in the biogas and, secondly, to qualitatively evaluate the influence of the dose of iron chloride on its elimination. The research was performed at the Rincón de León Wastewater Treatment Plant (Alicante, Spain). The outflow biogas of the digesters and of the pressurized gasometers was sampled and analyzed. The results obtained made it possible to demonstrate, firstly, the absence of linear siloxanes and that, of the cyclic siloxanes, the predominant type was decamethylcyclopentasiloxane, and, secondly, that the addition of iron chloride in the digesters significantly reduces the siloxane content in the biogas. Additionally, it was demonstrated that the process of compression of the biogas, with the elimination of condensates, also produces significant reductions in the concentration of siloxanes in the biogas

  11. Presence of Siloxanes in the Biogas of a Wastewater Treatment Plant Separation in Condensates and Influence of the Dose of Iron Chloride on its Elimination

    Energy Technology Data Exchange (ETDEWEB)

    Mariano, García [Empresa Mixta de Aguas Residuales de Alicante, S.A. (EMARASA) (Spain); Daniel, Prats; Arturo, Trapote, E-mail: atj@ua.es [University Institute of Water and Environmental Sciences, University of Alicante (Spain)

    2015-12-21

    The siloxanes present in the biogas produced during anaerobic digestion damage the mechanism of cogeneration equipment and, consequently, negatively affect the energy valorization process. For this reason, the detection and elimination of these silicon-derived chemical compounds are a priority in the management of cogeneration facilities. In this regard, the objectives of this paper are, firstly, to characterize the siloxanes in the biogas and, secondly, to qualitatively evaluate the influence of the dose of iron chloride on its elimination. The research was performed at the Rincón de León Wastewater Treatment Plant (Alicante, Spain). The outflow biogas of the digesters and of the pressurized gasometers was sampled and analyzed. The results obtained made it possible to demonstrate, firstly, the absence of linear siloxanes and that, of the cyclic siloxanes, the predominant type was decamethylcyclopentasiloxane, and, secondly, that the addition of iron chloride in the digesters significantly reduces the siloxane content in the biogas. Additionally, it was demonstrated that the process of compression of the biogas, with the elimination of condensates, also produces significant reductions in the concentration of siloxanes in the biogas.

  12. Potential biogas production from sewage sludge: A case study of the sewage treatment plant at Kwame Nkrumah university of science and technology, Ghana

    Energy Technology Data Exchange (ETDEWEB)

    Arthur, Richard [Energy Systems Engineering Department, Koforidua Polytechnic, Box KF 981, Koforidua (Ghana); Brew-Hammond, Abeeku [Faculty of Mechanical and Agricultural Engineering, Kwame Nkrumah University of Science and Technology, Private Mail Bag, Kumasi (Ghana)

    2010-07-01

    Biogas generation is one of the most promising renewable energy sources in Ghana. Anaerobic digestion is one of the effective ways of generating biogas. Anaerobic digestion is also a reliable method for wastewater treatment and the digestion the effluent can be used as fertilizer to enhance the fertility of the soil. This paper looks at the possibility of constructing a biogas plant at the KNUST sewage treatment plant tapping its feedstock the sludge at the Primary Sedimentation Tank to generate biogas. A laboratory experiment was done to determine the faecal sludge quality. The flowrate of the sludge was estimated based on the number of times the penstocks (valves) are operated to desludge the sewage which also depends on whether the university is on vacation (35.72 m3/day) or in session (71.44 m3/day). These parameters were used to determine the biogas potential of the sewage using 10, 20 and 30 days retention time for plant sizes of 540 m3, 1100m3 and 1600 m3 respectively. It was estimated that 170,719 m3, 341,858 m3 and 419,458 m3 of methane can be produced in a year and the power production was estimated to be 50 kW, 100 kW and 120 kW for the 540 m3, 1100m3 and 1600 m3 digester sizes respectively.

  13. Successfull operation of biogas plants. Data acquisition as a basis of successful optimization measures; Erfolgreicher Betrieb von Biogasanlagen. Datenerfassung als Grundlage erfolgreicher Optimierungsmassnahmen

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2012-09-19

    Within the 2nd Bayreuth expert meeting on biomass at 6th June, 2012 in Bayreuth (Federal Republic of Germany), the following lectures were held: (1) Presentation of the activities in the bio energy sector of the Landwirtschaftliche Lehranstalt Bayreuth (Rainer Prischenk); (2) State of the art of utilizing biogas in Oberfranken from the view of FVB e.V. (Wolfgang Holland Goetz); (3) Optimization of the plant operation by means of an intelligent control (Christian Seier); (4) Process optimization by means of identification of losses of biogas and evaluation of the load behaviour and emission behaviour of gas engines (Wolfgang Schreier); (5) Data acquisition and implementation of optimization measures from the point of view of an environmental verifier (Thorsten Grantner); (6) Economic analysis and optimization by means of the Lfl program BZA Biogas (Josef Winkler); (7) Detailed data acquisition as a necessary basis of the process optimization (Timo Herfter); (8) Case examples of the biologic support of biogas plants and their correct evaluation (Birgit Pfeifer); (9) A systematic acquisition of operational data as a basis for the increase of efficiency using the Praxisforschungsbiogasanlage of the University Hohenheim (Hans-Joachim Naegele); (10) Practical report: The biogas plant Sochenberg towards 100% utilization of energy (Uli Bader).

  14. Combined utilization of biogas and natural gas

    International Nuclear Information System (INIS)

    Jensen, J.; Tafdrup, S.; Christensen, J.

    1997-01-01

    The Danish natural gas network has been established during the past 10 years. Running parallel with this a small but growing production of biogas from centralized biogas plants and landfills has been developed. The annual biogas production is expected to keep growing and increase tenfold in the next 25 year period with a reduction of green house gas emissions as one of the important incentives. The last years' development and expansion of the Danish biogas sector has shown a need for combined utilization of biogas and natural gas. If larger volumes of biogas are present, upgrading and distribution by the natural gas network may be an alternative to combined utilization. (au) 12 refs

  15. Biogas digestate and its economic impact on farms and biogas plants according to the upper limit for nitrogen spreading—the case of nutrient-burdened areas in north-west Germany

    Directory of Open Access Journals (Sweden)

    Sebastian Auburger

    2015-11-01

    Full Text Available At the end of 2012, an expert group presented its evaluation of the forthcoming amendment of the German Fertilizer Ordinance (DüV. The new proposal intends to include manure of plant origin in the calculation of the upper limit for nitrogen spreading, determined to be 170 kg per hectare. This would particularly affect regions of north-west Germany that are characterized by intensive animal husbandry and biogas production. This would lead to increased costs of the disposal of manure and the use of agricultural land, especially for pig farms and biogas producers. A spatial model of nutrient distribution demonstrates the regional impacts of the amendment, and example calculations at an enterprise level show that many farmers would no longer be able to suitably pay for the factors used. Monte Carlo analysis shows a relatively high probability that only successful pig farmers and biogas producers would be able to compensate for the rising costs of transport and land use in a sustainable manner. Successful piglet producers would improve their relative competitiveness compared to biogas producers and especially to pig-fattening enterprises. The adoption of new strategies should factor in both the water protection requirements and the ability of the affected farms to evolve and grow on a sustainable basis.

  16. Co-digestion of municipal sludge and external organic wastes for enhanced biogas production under realistic plant constraints.

    Science.gov (United States)

    Tandukar, Madan; Pavlostathis, Spyros G

    2015-12-15

    A bench-scale investigation was conducted to select external organic wastes and mixing ratios for co-digestion with municipal sludge at the F. Wayne Hill Water Resources Center (FWHWRC), Gwinnett County, GA, USA to support a combined heat and power (CHP) project. External wastes were chosen and used subject to two constraints: a) digester retention time no lower than 15 d; and b) total biogas (methane) production not to exceed a specific target level based on air permit constraints on CO2 emissions. Primary sludge (PS), thickened waste activated sludge (TWAS) and digested sludge collected at the FWHWRC, industrial liquid waste obtained from a chewing gum manufacturing plant (GW) and dewatered fat-oil-grease (FOG) were used. All sludge and waste samples were characterized and their ultimate digestibility was assessed at 35 °C. The ultimate COD to methane conversion of PS, TWAS, municipal sludge (PS + TWAS; 40:60 w/w TS basis), GW and FOG was 49.2, 35.2, 40.3, 72.7, and 81.1%, respectively. Co-digestion of municipal sludge with GW, FOG or both, was evaluated using four bench-scale, mesophilic (35 °C) digesters. Biogas production increased significantly and additional degradation of the municipal sludge between 1.1 and 30.7% was observed. Biogas and methane production was very close to the target levels necessary to close the energy deficit at the FWHWRC. Co-digestion resulted in an effluent quality similar to that of the control digester fed only with the municipal sludge, indicating that co-digestion had no adverse effects. Study results prove that high methane production is achievable with the addition of concentrated external organic wastes to municipal digesters, at acceptable higher digester organic loadings and lower retention times, allowing the effective implementation of CHP programs at municipal wastewater treatment plants, with significant cost savings. Copyright © 2015 Elsevier Ltd. All rights reserved.

  17. Comparative use of different emission measurement approaches to determine methane emissions from a biogas plant

    DEFF Research Database (Denmark)

    Reinelt, Torsten; Delre, Antonio; Westerkamp, Tanja

    2017-01-01

    A sustainable anaerobic biowaste treatment has to mitigate methane emissions from the entire biogas production chain, but the exact quantification of these emissions remains a challenge. This study presents a comparative measurement campaign carried out with on-site and ground-based remote sensin...

  18. Slurry reactor design studies

    Energy Technology Data Exchange (ETDEWEB)

    Fox, J.M.; Degen, B.D.; Cady, G.; Deslate, F.D.; Summers, R.L. (Bechtel Group, Inc., San Francisco, CA (USA)); Akgerman, A. (Texas A and M Univ., College Station, TX (USA)); Smith, J.M. (California Univ., Davis, CA (USA))

    1990-06-01

    The objective of these studies was to perform a realistic evaluation of the relative costs of tublar-fixed-bed and slurry reactors for methanol, mixed alcohols and Fischer-Tropsch syntheses under conditions where they would realistically be expected to operate. The slurry Fischer-Tropsch reactor was, therefore, operated at low H{sub 2}/CO ratio on gas directly from a Shell gasifier. The fixed-bed reactor was operated on 2.0 H{sub 2}/CO ratio gas after adjustment by shift and CO{sub 2} removal. Every attempt was made to give each reactor the benefit of its optimum design condition and correlations were developed to extend the models beyond the range of the experimental pilot plant data. For the methanol design, comparisons were made for a recycle plant with high methanol yield, this being the standard design condition. It is recognized that this is not necessarily the optimum application for the slurry reactor, which is being proposed for a once-through operation, coproducing methanol and power. Consideration is also given to the applicability of the slurry reactor to mixed alcohols, based on conditions provided by Lurgi for an Octamix{trademark} plant using their standard tubular-fixed reactor technology. 7 figs., 26 tabs.

  19. Microbial-chemical indicator for anaerobic digester performance assessment in full-scale wastewater treatment plants for biogas production.

    Science.gov (United States)

    Traversi, Deborah; Romanazzi, Valeria; Degan, Raffaella; Lorenzi, Eugenio; Carraro, Elisabetta; Gilli, Giorgio

    2015-06-01

    Anaerobic digestion was introduced into wastewater treatment plants several years ago, but anaerobic digestion performance has not yet been achieved. The variability of the microbial community in digesters is poorly understood, and despite the crucial role of anaerobic digestion reactors, the microbial equilibrium that yields the best performance in these reactors has only recently been hypothesised. In this study, two full-scale continuous anaerobic reactors, placed in Torino's main wastewater treatment plant in northern Italy, were followed to develop a summary indicator for measuring anaerobic digestion performance. A total of 100 sludge samples were collected. The samples were characterised chemically and physically, and microbial groups were quantified by qRT-PCR. A chemical biological performance index strictly correlated to specific biogas production (rho=0.739, panaerobic digestion in wastewater treatment plants. Copyright © 2015 Elsevier Ltd. All rights reserved.

  20. Consequences of flexible electricity production from biogas on the conventional power plant fleet and the CO{sub 2} emission; Auswirkung der flexiblen Stromproduktion aus Biogas auf den konventionellen Kraftwerkspark und dessen CO{sub 2}-Emissionen

    Energy Technology Data Exchange (ETDEWEB)

    Holzhammer, Uwe [Fraunhofer Institut fuer Windenergie und Energiesystemtechnik (IWES), Kassel (Germany). Gruppe Bedarfsorientierte Energiebereitstellung; Nelles, Michael [Rostock Univ. (Germany). Lehrstuhl Abfall- und Stoffstromwirtschaft; Scholwin, Frank [Institut fuer Biogas, Kreislaufwirtschaft und Energie, Weimar (Germany)

    2013-07-01

    Electricity production using biogas is rather homogeneous throughout the year due to the compensational regulations. As a consequence of the fluctuating energy production from renewable energy sources a more flexible electricity production is needed. The contribution deals with the regulations and measures of the new renewable energy law 2012 and their impact on the conventional power plant fleet and the carbon dioxide emissions and their impact on an improvement of demand-oriented electricity production.

  1. Biogas barometer

    International Nuclear Information System (INIS)

    2014-01-01

    The energy recovery of biogas has kept on increasing in the European Union in 2013: +10.2%. Almost 13.4 million tep (tonnes of oil equivalent) of biogas primary energy was produced but the growth of the biogas sector is decreasing (it was 16.9% between 2011 and 2012). The growth for the coming years is expected to fall further because of political decisions in some countries to limit the use of land for farming purposes and to manage the biogas sector more efficiently. Germany ranks first for the production of biogas primary energy with 6717 ktep followed by United Kingdom with 1824 ktep. 2 tables give the production of electricity and heat from biogas in the E.U. member states in 2012 and 2013. The total production of electricity and heat from biogas in the E.U. in 2013 reached 53327 GWh and 432 ktep respectively. A list reviews the most significant companies working in Europe in the sector of methanation, 10 companies are listed among which 2 are Italian: AB Energy (Gruppo AB), BTS Italia and 8 are German: MT Energie, Envitec Biogas AG, Biogas Weser-Ems, Planet Biogastechnik, Schmack Biogas GmbH, Weltec Biopower GmbH, UTS Biogastechnik (Anaergia Group), Bioconstruct and BTS Italia. (A.C.)

  2. Content of the essential and other elements in residues left over after fermentation in a biogas plant

    Directory of Open Access Journals (Sweden)

    Tešić Miloš

    2012-01-01

    Full Text Available The chemical composition of the residues left over after fermentation in a biogas plant depended on the source material that was used. The dry matter content in the liquid residue ranged from 4.83 to 6.82%, pH from 7.80 to 8.20, whereas the content of organic matter in the dry matter of the liquid residue varied from 72.33 to 80.30%. Ash content varied from 19.70 to 27.67%, nitrogen from 2.84 to 3.92%, phosphorus from 0.51 to 0.62%, potassium from 5.07 to 6.86%, calcium from 1.77 to 2.35%, and magnesium from 0.26 to 0.30%. Concentrations of essential micronutrients (Fe, Cu, Mn, Zn and Ni and Cd and Pb varied within the limits laid out to dry matter of manure. Concentrations of heavy metals were significantly lower than the MAC in the dry matter of fertilizers. Based on the above it can be concluded that the residue left over after fermentation in a biogas plant is, by its chemical properties, suitable organic fertilizer that may be used not only in conventional but also in organic crop production.

  3. Trend chart: biogas. First quarter 2016

    International Nuclear Information System (INIS)

    Cavaud, Denis

    2016-05-01

    This publication presents the biogas industry situation of continental France and overseas territories during the first quarter 2016: total connected load of biogas power plants, new connected facilities, regional distribution of facilities, evolution of quarterly production, distribution of facilities versus power and type, evolution forecasts of biogas power generation, detailed regional results, biomethane injection in natural gas distribution systems, methodology used

  4. Trend chart: biogas. Forth quarter 2016

    International Nuclear Information System (INIS)

    Cavaud, Denis

    2017-02-01

    This publication presents the biogas industry situation of continental France and overseas territories during the forth quarter 2016: total connected load of biogas power plants, new connected facilities, regional distribution of facilities, evolution of quarterly production, distribution of facilities versus power and type, evolution forecasts of biogas power generation, detailed regional results, biomethane injection in natural gas distribution systems, methodology used

  5. Trend chart: biogas. Second quarter 2016

    International Nuclear Information System (INIS)

    Cavaud, Denis

    2016-08-01

    This publication presents the biogas industry situation of continental France and overseas territories during the Second quarter 2016: total connected load of biogas power plants, new connected facilities, regional distribution of facilities, evolution of quarterly production, distribution of facilities versus power and type, evolution forecasts of biogas power generation, detailed regional results, biomethane injection in natural gas distribution systems, methodology used

  6. Trend chart: biogas. Third quarter 2016

    International Nuclear Information System (INIS)

    Cavaud, Denis

    2016-11-01

    This publication presents the biogas industry situation of continental France and overseas territories during the third quarter 2016: total connected load of biogas power plants, new connected facilities, regional distribution of facilities, evolution of quarterly production, distribution of facilities versus power and type, evolution forecasts of biogas power generation, detailed regional results, biomethane injection in natural gas distribution systems, methodology used

  7. Biogas technology in Pakistan

    International Nuclear Information System (INIS)

    Ahmed, M.

    1997-02-01

    Although biomethanation is a mature technology its implementation is paradoxically only partly a success in Pakistan. Biogas plants on family farms can be economical but seldom are so in Pakistan. Either the investment cost has been high or satisfactory performance of the process could not be maintained or in some case for a short period of time only. It is, however, concluded that biogas plants, if correctly operated and maintained, may prove to be appropriate to the technical abilities and economic capacity of Pakistani farmers. It can get a change to be disseminated in rural areas. Biogas technology is appropriate to the ecological and economic demands of the future. With the potential from existing cattle population only, 3 to 4 million family size biogas plants may be installed in Pakistan which can substitute of considerable part of rural fuel wood demand for their daily household energy requirements. A large amount of dung is burnt every year by households which if put in the biogas plant, may provide a considerable amount of energy along with organic fertilizer could be saved from being burned at the same time. On the basis of available data from the livestock excluding agriculture residue (50% collectivity-1991), in terms of fuel substitution, this would be equivalent to 1200 million litres of kerosene at worth economic value of 9021 million rupees saving in the form of gas and 821 million rupees as additional fertilizer value annually. (LN)

  8. Electric Energy Consumption of the Full Scale Research Biogas Plant “Unterer Lindenhof”: Results of Longterm and Full Detail Measurements

    Directory of Open Access Journals (Sweden)

    Thomas Jungbluth

    2012-12-01

    Full Text Available This work thoroughly evaluates the electric power consumption of a full scale, 3 × 923 m3 complete stirred tank reactor (CSTR research biogas plant with a production capacity of 186 kW of electric power. The plant was fed with a mixture of livestock manure and renewable energy crops and was operated under mesophilic conditions. This paper will provide an insight into precise electric energy consumption measurements of a full scale biogas plant over a period of two years. The results showed that a percentage of 8.5% (in 2010 and 8.7% (in 2011 of the produced electric energy was consumed by the combined heat and power unit (CHP, which was required to operate the biogas plant. The consumer unit agitators with 4.3% (in 2010 and 4.0% (in 2011 and CHP unit with 2.5% (in 2010 and 2011 accounted for the highest electrical power demand, in relation to the electric energy produced by the CHP unit. Calculations show that 51% (in 2010 and 46% (in 2011 of the total electric energy demand was due to the agitators. The results finally showed the need for permanent measurements to identify and quantify the electric energy saving potentials of full scale biogas plants.

  9. Biogas utilization

    Energy Technology Data Exchange (ETDEWEB)

    Moser, M.A. [Resource Conservation Management, Inc., Berkeley, CA (United States)

    1996-01-01

    Options for successfully using biogas depend on project scale. Almost all biogas from anaerobic digesters must first go through a gas handling system that pressurizes, meters, and filters the biogas. Additional treatment, including hydrogen sulfide-mercaptan scrubbing, gas drying, and carbon dioxide removal may be necessary for specialized uses, but these are complex and expensive processes. Thus, they can be justified only for large-scale projects that require high-quality biogas. Small-scale projects (less than 65 cfm) generally use biogas (as produced) as a boiler fuel or for fueling internal combustion engine-generators to produce electricity. If engines or boilers are selected properly, there should be no need to remove hydrogen sulfide. Small-scale combustion turbines, steam turbines, and fuel cells are not used because of their technical complexity and high capital cost. Biogas cleanup to pipeline or transportation fuel specifications is very costly, and energy economics preclude this level of treatment.

  10. Biogas: A renewable source of energy

    Directory of Open Access Journals (Sweden)

    Houdkova Lucie

    2008-01-01

    Full Text Available First part of the paper deals with biogas produced in the process of anaerobic digestion. Possibilities of biogas utilization are commented briefly. Laboratory fermentation unit that was built at the Institute of Process and Environmental Engineering is described further on. The laboratory fermentation unit is used for digestion of new types of substrate and for process optimization. Finally, the biogas plant built in Sweden is described. Biogas produced there is treated and used as a fuel for public transport vehicles.

  11. Use of bio-enzymatic preparations for enhancement biogas production

    OpenAIRE

    Tomáš Vítěz; M. Haitl; Z. Karafiát; P. Mach; J. Fryč; T. Lošák; M. Szostková

    2011-01-01

    Biogas is a renewable energy resource with high increasing developed in last few decades. It’s big opportunity for stabilization rural areas, concretely agriculture sector. This technology can decentralize supply of energy. The number of operated biogas plants is rapidly increasing. Biogas plants require a high level of intensity and stableness of the process of anaerobic fermentation with biogas production for efficiency treatment, also for good quality of development biogas and fertilizatio...

  12. Optimizing the supply chain of biomass and biogas for a single plant considering mass and energy losses

    DEFF Research Database (Denmark)

    Jensen, Ida Græsted; Münster, Marie; Pisinger, David

    2017-01-01

    to represent capital and operational expenditures at the biogas plant; considers the chain from the farmer to the end market; and includes changes of mass and energy content along the chain by modeling the losses and gains for all processes in the chain. Biomass inputs are scheduled on a weekly basis whereas...... energy outputs are scheduled on an hourly basis to better capture the changes of energy prices and potentially take advantage of these changes. The model is tested on a case study with co-digestion of straw, sugar beet and manure, considering natural gas, heat, and electricity as end products. The model...... finds a production and investment plan for a predefined location of the plant within half an hour of central processing unit (CPU) time. The resulting project turns out to be profitable and gives a production plan for each process, which underlines the possibilities of optimizing the processes...

  13. Use of wastewater treatment plant biogas for the operation of Solid Oxide Fuel Cells (SOFCs).

    Science.gov (United States)

    Lackey, Jillian; Champagne, Pascale; Peppley, Brant

    2017-12-01

    Solid Oxide Fuel Cells (SOFCs) perform well on light hydrocarbon fuels, and the use of biogas derived from the anaerobic digestion (AD) of municipal wastewater sludges could provide an opportunity for the CH 4 produced to be used as a renewable fuel. Greenhouse gas (GHG), NO x , SO x , and hydrocarbon pollutant emissions would also be reduced. In this study, SOFCs were operated on AD derived biogas. Initially, different H 2 dilutions were tested (N 2 , Ar, CO 2 ) to examine the performance of tubular SOFCs. With inert gases as diluents, a decrease in cell performance was observed, however, the use of CO 2 led to a higher decrease in performance as it promoted the reverse water-gas shift (WGS) reaction, reducing the H 2 partial pressure in the gas mixture. A model was developed to predict system efficiency and GHG emissions. A higher electrical system efficiency was noted for a steam:carbon ratio of 2 compared to 1 due to the increased H 2 partial pressure in the reformate resulting from higher H 2 O concentration. Reductions in GHG emissions were estimated at 2400 tonnes CO 2 , 60 kg CH 4 and 18 kg N 2 O. SOFCs were also tested using a simulated biogas reformate mixture (66.7% H 2 , 16.1% CO, 16.5% CO 2 , 0.7% N 2 , humidified to 2.3 or 20 mol% H 2 O). Higher humidification yielded better performance as the WGS reaction produced more H 2 with additional H 2 O. It was concluded that AD-derived biogas, when cleaned to remove H 2 S, Si compounds, halides and other contaminants, could be reformed to provide a clean, renewable fuel for SOFCs. Copyright © 2016 Elsevier Ltd. All rights reserved.

  14. Biogas production and biogas as vehicle fuel - Swedish experiences

    Energy Technology Data Exchange (ETDEWEB)

    Lindberg, A.E. [VBB Viak AB, Stockholm (Sweden)

    1997-08-01

    In Sweden there are totally about 220 biogas plants in operation. The major part of these plants (134) are represented by sewage sludge treatment facilities at waste water treatment plants. At 60 sites the biogas is generated from landfills or cell digesters at landfills. In 1996, the amount produced had a total energy content of about 1,35 TWh (or 4 900 PJ). (EG)

  15. Sample prefractionation with liquid isoelectric focusing enables in depth microbial metaproteome analysis of mesophilic and thermophilic biogas plants.

    Science.gov (United States)

    Kohrs, F; Heyer, R; Magnussen, A; Benndorf, D; Muth, T; Behne, A; Rapp, E; Kausmann, R; Heiermann, M; Klocke, M; Reichl, U

    2014-10-01

    Biogas production from energy crops and biodegradable waste is one of the major sources for renewable energies in Germany. Within a biogas plant (BGP) a complex microbial community converts biomass to biogas. Unfortunately, disturbances of the biogas process occur occasionally and cause economic losses of varying extent. Besides technical failures the microbial community itself is commonly assumed as a reason for process instability. To improve the performance and efficiency of BGP, a deeper knowledge of the composition and the metabolic state of the microbial community is required and biomarkers for monitoring of process deviations or even the prediction of process failures have to be identified. Previous work based on 2D-electrophoresis demonstrated that the analysis of the metaproteome is well suited to provide insights into the apparent metabolism of the microbial communities. Using SDS-PAGE with subsequent mass spectrometry, stable protein patterns were evaluated for a number of anaerobic digesters. Furthermore, it was shown that severe changes in process parameters such as acidification resulted in significant modifications of the metaproteome. Monitoring of changing protein patterns derived from anaerobic digesters, however, is still a challenge due to the high complexity of the metaproteome. In this study, different combinations of separation techniques to reduce the complexity of proteomic BGP samples were compared with respect to the subsequent identification of proteins by tandem mass spectrometry (MS/MS): (i) 1D: proteins were tryptically digested and the resulting peptides were separated by reversed phase chromatography prior to MS/MS. (ii) 2D: proteins were separated by GeLC-MS/MS according to proteins molecular weights before tryptic digestion, (iii) 3D: proteins were separated by gel-free fractionation using isoelectric focusing (IEF) conducted before GeLC-MS/MS. For this study, a comparison of two anaerobic digesters operated at mesophilic and at

  16. An evaluation of a farm scale biogas plant with a micro turbine for combined heat and power production; Utvaerdering av gaardsbiogasanlaeggning med mikroturbin foer kraftvaermeproduktion

    Energy Technology Data Exchange (ETDEWEB)

    Brown, Nils; Edstroem, Mats; Hansson, Mikael (Swedish Inst. of Agricultural and Environmental Engineering, Uppsala (Sweden)); Algerbo, Per-Anders (HIR Malmoehus, Bjaerred (Sweden))

    2010-03-15

    The purpose of this study was to: To evaluate a farm scale biogas plant digesting energy and nutrient rich substrates at a high organic loading rate and biogas production using the biogas for combined heat and power production with a micro turbine. Put together technical, biological and economical documentation which can help farmers to investigate presumption to invest in a farm scale biogas plant for heat and power production. The farm scale biogas plant has an active digester volume of 450 m3 and the process temperature is ca 37 deg C. A micro turbine with 105 kW electrical and 160 kW thermal power is used for heat and power production. The produced electricity is sold to the grid and the heat is used on the farm for drying grain and heating two houses. The plant is digesting poultry manure and 2 substrates from the agriculture industry. All together the plant is digesting 3140 metric tons of substrates/yr and the substrates costs 160 k SEK/yr. Total investment for the plant is 4.7 M SEK. Produced head reduces the oil consumption at the farm with 15 m3 (value 100 k SEK/yr). There is a surplus of heat production of 600 MWh/yr. The production cost for the electricity is close to 0,66 SEK/kWh based on a value of the digestate of 100 SEK/ton together with an investment subsidy of 30 %. The production cost for the electricity is strongly depending on the value of the digestate. Hagavik is a crop production farm based on organic farming. If the valuation of the digestate is reduced to 50 SEK/ton, the production cost for the electricity increases to approx. 0.84 SEK/kWh (1 SEK is about 0.14 USD)

  17. Realtime control of biogas reactors. Technical report

    Energy Technology Data Exchange (ETDEWEB)

    Poulsen, Allan K.

    2010-12-15

    In this project several online methods were connected to a biogas pilot plant designed and built by Xergi A/S (Foulum, Denmark). The pilot plant was composed of two stainless steel tanks used as substrate storage and as digester, respectively. The total volume of the reactor tank was 300 L, the working volume 200 L and the headspace volume 100 L. The process temperature in the biogas reactor was maintained at 52 {+-} 0.5 deg. C during normal operating conditions. The biogas production was measured with a flow meter and a controller was used for automatic control of temperature, effluent removal, feeding and for data logging. A NIRS (near infrared spectrometer) was connected to a recurrent loop measuring on the slurry while a {mu}-GC (micro gas chromatograph) and a MIMS (membrane inlet mass spectrometer) enabled online measurements of the gas phase composition. During the project period three monitoring campaigns were accomplished. The loading rate of the biogas reactor was increased stepwise during the periods while the process was monitored. In the first two campaigns the load was increased by increasing the mass of organic material added to the reactor each day. However, this increasing amount changed the retention time in the reactor and in order to keep the retention time constant an increasing amount of inhibitor of the microbial process was instead added in the third campaign and as such maintaining a constant organic load mass added to the reactor. The effect is similar to an increase in process load, while keeping the load of organic material and hence retention time constant. Methods have been developed for the following online technologies and each technology has been evaluated with regard to future use as a tool for biogas process monitoring: 1) {mu}-GC was able to quantitative monitor important gas phase parameters in a reliable, fast and low-maintenance way. 2) MIMS was able to quantitative monitor gas phase composition in a reliable and fast manner

  18. Slurry pipeline technology: an overview

    Energy Technology Data Exchange (ETDEWEB)

    Chapman, Jay P. [Pipeline Systems Incorporated (PSI), Belo Horizonte, MG (Brazil); Lima, Rafael; Pinto, Daniel; Vidal, Alisson [Ausenco do Brasil Engenharia Ltda., Nova Lima, MG (Brazil). PSI Div.

    2009-12-19

    Slurry pipelines represent an economical and environmentally friendly transportation means for many solid materials. This paper provides an over-view of the technology, its evolution and current Brazilian activity. Mineral resources are increasingly moving farther away from ports, processing plants and end use points, and slurry pipelines are an important mode of solids transport. Application guidelines are discussed. State-of-the-Art technical solutions such as pipeline system simulation, pipe materials, pumps, valves, automation, telecommunications, and construction techniques that have made the technology successful are presented. A discussion of where long distant slurry pipelines fit in a picture that also includes thickened and paste materials pipe lining is included. (author)

  19. Slurry flow principles and practice

    CERN Document Server

    Shook, C A; Brenner, Howard

    2015-01-01

    Slurry Flow: Principles and Practice describes the basic concepts and methods for understanding and designing slurry flow systems, in-plan installations, and long-distance transportation systems. The goal of this book is to enable the design or plant engineer to derive the maximum benefit from a limited amount of test data and to generalize operating experience to new situations. Design procedures are described in detail and are accompanied by illustrative examples needed by engineers with little or no previous experience in slurry transport.The technical literature in this field is extensive:

  20. Anaerobic digestion as a slurry management strategy : a consequential life cycle assessment

    Energy Technology Data Exchange (ETDEWEB)

    Hamelin, L.; Wesnaes, M.; Wenzel, H.; Petersen, B.M. [Southern Denmark Univ. (Denmark). Inst. of Chemical Engineering, Biotechnology and Environmental Technology

    2010-07-01

    Anaerobic digestion of slurry represents an environmental opportunity for both slurry management and renewable energy production in countries with high animal density. This study evaluated the environmental impacts of 4 biogas production alternatives in which slurry was the only input in the process, without supplementary addition of easily degradable carbon. This was achieved by exposing the slurry to different separation technologies. The biomass mixture input for biogas production included solid fraction from slurry separation as well as raw slurry, proportioned in order to achieve economical methane yield. The separation processes considered in this study were mechanical separation; mechanical separation combined with the addition of flocculants; and mechanical separation combined with a thermal treatment. Four biogas alternatives were compared to a reference slurry management scenario, notably to use the slurry as a fertilizer without prior treatment. The modelling was based on Danish conditions and used the consequential life cycle assessment methodology. The produced biogas was used for production of heat and power and the degassed slurry was used as an organic fertilizer.

  1. The implementation of decentralised biogas plants in Assam, NE India: The impact and effectiveness of the National Biogas and Manure Management Programme

    International Nuclear Information System (INIS)

    Raha, Debadayita; Mahanta, Pinakeswar; Clarke, Michèle L.

    2014-01-01

    The Indian Government's National Biogas and Manure Management Programme (NBMMP) seeks to deliver renewable energy services to households across the country by facilitating the deployment of family-sized (<6 m 3 ) anaerobic (biogas) digesters. NBMMP policy is implemented at three levels, from government and state nodal agency, via private contractors to households, creating multiple institutional arrangements. We analysed the scheme in Assam, north-east India, focusing on how policy was implemented across two districts and interviewing stakeholders in rural households, state and non-state institutions. The top-down, supply-side approach to policy enables government to set targets and require individual states to deploy the scheme, which benefits households who can afford to participate. NBMMP delivered improved energy service outcomes to a majority of households, although the level of knowledge and understanding of the technology amongst users was limited. Training and education of householders, and particularly women, is needed in relation to the maintenance of digesters, feedstock suitability and the environmental and potential livelihood benefits of digestate. A revised bottom-up approach to policy, which highlights the contextual and demand-side issues around adopting the technology, may deliver monetary benefits from market competition and enable development of community-focused microfinance schemes to improve the affordability of biogas systems. - Highlights: • In India, biogas policy is supply-driven and based on technology implementation. • NBMMP policy needs revision to engage with market forces to drive down costs and improve services and delivery. • Community empowerment, awareness, training and education, particularly of women, plays a critical role in accelerating the deployment of biogas technology

  2. Biofertilizer manual - biofertilizer from large-scale bio-gas plants; Biogoedselhandbok - Biogoedsel fraan storskaliga bio-gasanlaeggningar

    Energy Technology Data Exchange (ETDEWEB)

    2010-09-15

    Biofertilizer from biogas plants must be managed in a cost effective manner based on current legislation and certification requirements from the food industry. This manual focuses on liquid biofertilizer and the requirements and costs associated with this product. At an early stage analyze market (beneficiaries of biofertilizers), dissemination area and thus the disposal of biofertilizer is very crucial to reduce the costs of the whole biofertilizer management. Certifying biofertilizers under Swedish Waste Management system of 'Certified recycling' (SPCR 120) increases the possibility of outlets and thus the value of biofertilizer. Nutrient and heavy metal content of biofertilizer affects the size (ha) on the estate. Maximum of phosphorus may not exceed 22 kg / ha. Often, the contents of plant nutrients limit the distribution size, but sometimes even the heavy metals are the limiting factors (for certified biofertilizers). Normally, the distribution size is 20-40 tonnes / ha, but must be adapted to crop needs, soil conditions and the diffusion limitations mentioned above. Biofertilizers are typically handled in three stages: storage, distribution and dissemination. Storage containers must have a stable floating crust or roof and the storage volume to cope with 80-10 months of production of biofertilizer. The cost of storage varies between 15 and 40 SEK/m{sub 3} storage volume depends on storage technology. Distribution of biofertilizer from the larger biogas plants is usually by truck, but there are also a few examples where the fertilizer is pumped out to the farm. The cost of distribution by truck is somewhat lower when compared with pumping and ranges between 20 and 30 SEK/m{sub 3} within a radius of 10-20 km. If conditions (high proportion of arable land, high interest, low level of infrastructure, etc.) are right pumping can be more cost effective than truck. Spreading cost is usually about 20-28 USD / tonnes and is done either with a tractor and

  3. Green-house gas mitigation capacity of a small scale rural biogas plant calculations for Bangladesh through a general life cycle assessment.

    Science.gov (United States)

    Rahman, Khondokar M; Melville, Lynsey; Fulford, David; Huq, Sm Imamul

    2017-10-01

    Calculations towards determining the greenhouse gas mitigation capacity of a small-scale biogas plant (3.2 m 3 plant) using cow dung in Bangladesh are presented. A general life cycle assessment was used, evaluating key parameters (biogas, methane, construction materials and feedstock demands) to determine the net environmental impact. The global warming potential saving through the use of biogas as a cooking fuel is reduced from 0.40 kg CO 2 equivalent to 0.064 kg CO 2 equivalent per kilogram of dung. Biomethane used for cooking can contribute towards mitigation of global warming. Prior to utilisation of the global warming potential of methane (from 3.2 m 3 biogas plant), the global warming potential is 13 t of carbon dioxide equivalent. This reduced to 2 t as a result of complete combustion of methane. The global warming potential saving of a bioenergy plant across a 20-year life cycle is 217 t of carbon dioxide equivalent, which is 11 t per year. The global warming potential of the resultant digestate is zero and from construction materials is less than 1% of total global warming potential. When the biogas is used as a fuel for cooking, the global warming potential will reduce by 83% compare with the traditional wood biomass cooking system. The total 80 MJ of energy that can be produced from a 3.2 m 3 anaerobic digestion plant would replace 1.9 t of fuel wood or 632 kg of kerosene currently used annually in Bangladesh. The digestate can also be used as a nutrient rich fertiliser substituting more costly inorganic fertilisers, with no global warming potential impact.

  4. Biogas Technology Application in Western Kenya-A Field Investigation in Nandi and Bomet Counties

    Science.gov (United States)

    Venort, Taisha

    The integration of biogas technology into Kenyan farming systems is becoming more common since the launch of the Kenya National Biogas Programme (KENDBIP). A comprehensive assessment of the status, operation of biogas plants constructed through KENDBIP, and their role within rural farming systems, is undertaken in two important dairy herds of Kenya (i.e., Nandi and Bomet counties), towards understanding factors affecting applications, for energy and agronomic use. Data on farming systems, operation and application were collected from 242 farm households in both counties. A Binary Linear Regression model was developed to pinpoint constraint factors most influential to plants operation. Descriptive statistics were used to compare users' experiences, and capture farm households' trends in energy and fertilizer use. Higher operational rate in Bomet (77%) than Nandi (59%), reveal that plants' viability are impacted by subsidies 'liability schemes of local supporting programs. Records of partial substitution to biogas and bio-slurry seem to contribute to the reinforcement of local agro-forestry traditions through an increase in the adoption of zero-grazing practices, wood/tree lots retention, and more efficient agricultural land attribution in the smallholder context. These changes are all having a positive impact on farm households' livelihoods and food security. Key recommendations to biogas programs stakeholders are that local subsidy schemes take better account of liability towards local technicians, Quality Control responsibilities are decentralized to local enterprises, and Research & Development strategies further investigate biogas technology application in agriculture, and its role in directly impacted value chains (i.e., Dairy, African Leafy vegetables, Feed & Fodder), for better experiences by farmers.

  5. Energy plants increasingly important. Scientific results and practical experiences on the production of biogas plants and short rotation coppices. Symposium; Energiepflanzen im Aufwind. Wissenschaftliche Ergebnisse und praktische Erfahrungen zur Produktion von Biogaspflanzen und Feldholz. Fachtagung

    Energy Technology Data Exchange (ETDEWEB)

    Heiermann, M.; Scholz, V.; Foltan, H. (comps.)

    2007-05-15

    The conference proceedings contain 15 contributions on energy plants: energy plant production in Germany - developments and research activities; potentials and constraints of cultivating energy crops; environmental aspects of production and utilization of energy plants; costs of energy crop supply; crops for the biogas production in the territory of Brandenburg; mixed cropping systems on sandy soils - alternative cropping strategies; impact of ensiling process on biogas production - recent research results; solid state anaerobic digestion of renewable biomass sources - state of research and development; energy crops as feedstock in a biogas plant; proffer and demand of wood fuel in the State of Brandenburg; regulatory framework of growing short rotation coppice; mechanization of SRC production; 20 years of short rotation coppice; willow production and marketing in Denmark; short rotation coppice production in Italy.

  6. Energy crops for biogas plants. Baden-Wuerttemberg; Energiepflanzen fuer Biogasanlagen. Baden-Wuerttemberg

    Energy Technology Data Exchange (ETDEWEB)

    Butz, A.; Heiermann, M.; Herrmann, C. [and others

    2013-05-01

    For agriculturists in Baden-Wuerttemberg (Federal Republic of Germany), the brochure under consideration provides recommendations on alternative crop rotation systems. With the help of these alternative cultivation systems, crop rotation with high yields in combination with high diversity, diversification and sustainability can be realized. Subsequently to the presentation of energy crops for the production of biogas, recommendations for the design of crop rotation are given. Other chapters of this booklet deal with ensilage and gas yields as well as the economics of energy crop cultivation.

  7. Energy crops for biogas plants. Mecklenburg-Western Pomerania; Energiepflanzen fuer Biogasanlagen. Mecklenburg-Vorpommern

    Energy Technology Data Exchange (ETDEWEB)

    Aurbacher, J.; Bull, I.; Formowitz, B. (and others)

    2012-06-15

    For agriculturists in Mecklenburg-Western Pomerania (Federal Republic of Germany), the brochure under consideration provides recommendations on alternative crop rotation systems. With the help of these alternative cultivation systems, crop rotation with high yields in combination with high diversity, diversification and sustainability can be realized. Subsequently to the presentation of energy crops for the production of biogas, recommendations for the design of crop rotation are given. Other chapters of this booklet deal with ensilage and gas yields as well as the economics of energy crop cultivation.

  8. Energy crops for biogas plants. Saxony-Anhalt; Energiepflanzen fuer Biogasanlagen. Sachsen-Anhalt

    Energy Technology Data Exchange (ETDEWEB)

    Boese, L.; Buttlar, C. von; Boettcher, K. (and others)

    2012-07-15

    For agriculturists in Saxony-Anhalt (Federal Republic of Germany), the brochure under consideration provides recommendations on alternative crop rotation systems. With the help of these alternative cultivation systems, crop rotation with high yields in combination with high diversity, diversification and sustainability can be realized. Subsequently to the presentation of energy crops for the production of biogas, recommendations for the design of crop rotation are given. Other chapters of this booklet deal with ensilage and gas yields as well as the economics of energy crop cultivation.

  9. Biogas: A renewable energy source

    International Nuclear Information System (INIS)

    Imiere, E.E.; Ojih, V.B.; Esiekpe, L.E.; Okafor, M.C.; Attoh, V. A.

    2011-01-01

    Biogas refers to a gas produced by the biological breakdown of organic matter in the absence of oxygen. Biogas can be used as a fuel in any country for any heating purpose such as cooking. By means of digesters, the energy in the gas can be converted to electricity and heat. Biogas like natural gas can also be used to power motor vehicle. Biogas is a renewable fuel which qualifies it for a renewable energy subsidy. It is non-toxic, environment-friendly and serve as a means of combating global warming. Biogas is presently being used in U.S.A, U.K, China, Sweden, Brazil, and India amongst others for domestic purposes, transportation and power generation. In this regard, this paper discusses biogas production. It also presents a model design of domestic biogas plant suitable for Nigerian households. The paper recommends that Nigerian Government should intensify efforts in educating the masses on this novel technology for a sustainable global development. A biogas plant designed for Nigerian household discussed in this paper is also recommended.

  10. A fuzzy approach to a multiple criteria and Geographical Information System for decision support on suitable locations for biogas plants

    DEFF Research Database (Denmark)

    Franco, Camilo; Bojesen, Mikkel; Hougaard, Jens Leth

    2015-01-01

    The purpose of this paper is to model the multi-criteria decision problem of identifying the most suitable facility locations for biogas plants under an integrated decision support methodology. Here the Geographical Information System (GIS) is used for measuring the attributes of the alternatives...... according to a given set of criteria. Measurements are taken in interval form, expressing the natural imprecision of common data, and the Fuzzy Weighted Overlap Dominance (FWOD) procedure is applied for aggregating and exploiting this kind of data, obtaining suitability degrees for every alternative....... The estimation of criteria weights, which is necessary for applying the FWOD procedure, is done by means of the Analytical Hierarchy Process (AHP), used jointly with the LLSM-AHP for the estimation of upper and lower bounds for the weights. Then, a combined AHP-FWOD methodology allows identifying the more...

  11. Optimized production of vehicle gas - an environmental and energy system analyses of Soederaasens biogas plant.; Systemoptimerad produktion av fordonsgas - En miljoe- och energisystemanalys av Soederaasens biogasanlaeggning

    Energy Technology Data Exchange (ETDEWEB)

    Lantz, Mikael; Ekman, Anna; Boerjesson, Paal

    2009-06-15

    In this study, an environmental and energy system analysis for a specific biogas plant is presented as well as suggestions and cost calculations for measures that could be implemented in order to optimise the system. The overarching purpose is also to present a model for similar studies of specific biogas plants. The analysis performed includes direct effects such as use of energy and emissions from the production of biogas, upgrading to vehicle gas, transport of substrate and digestate and storage and handling of digestate. Furthermore, indirect effects such as reduced methane leaching from conventional storage of manure, replacement of mineral fertilizers with digestate etc. are included as well. The energy balance for production and distribution of vehicle gas from Soederaasens biogas plant is calculated to 5,5 which could be compared to the energy balance for ethanol from wheat which is normally between 2 and 3. The greenhouse gas emissions are 16 gram CO{sub 2}-ekv./kWh, approximately 95 % lower compared to gasoline. In comparison, ethanol from wheat and RME reduce the emissions with some 80 % and 65 % respectively. The result is mainly affected of the methane leakage from the upgrading plant, reduced emissions of N{sub 2}O when digestate replaces mineral fertilizers and the assumptions made of how the electricity used in the system was produced. Regarding eutrophication, the emissions are calculated to 6 gram NO{sub 3}--ekv./kWh, primarily originating from storage and handling of digestate, which is somewhat lower than the reported emissions from production of ethanol and RME. Covering the digestate storages and produce process heat with wood chips, measures estimated to be cost neutral or even profitable for the biogas producer, is calculated to reduce the emissions of greenhouse gases to -13 gram/kWh. If all measures identified would be implemented, the emissions are reduced with 120 % with an extra cost of some 0.01 SEK/kWh vehicle gas

  12. The Development of Biogas Technology in Denmark: Achievements & Obstacles

    OpenAIRE

    Sannaa, Mohamed Najib

    2004-01-01

    Denmark is one of the most advanced countries in biogas technology. This country added several improvements to the biogas process in order to increase the biogas yield and thereby improve the economical profitability. Consequently, this project studied the developments of biogas technology in Denmark. The study includes a historical progress of biogas plants since 1970s; the different problems interrupted the expansion of this technology and the actions taken to overcome these obstacles. This...

  13. Analysis of bacterial communities and bacterial pathogens in a biogas plant by the combination of ethidium monoazide, PCR and Ion Torrent sequencing.

    Science.gov (United States)

    Luo, Gang; Angelidaki, Irini

    2014-09-01

    The present study investigated the changes of bacterial community composition including bacterial pathogens along a biogas plant, i.e. from the influent, to the biogas reactor and to the post-digester. The effects of post-digestion temperature and time on the changes of bacterial community composition and bacterial pathogens were also studied. Microbial analysis was made by Ion Torrent sequencing of the PCR amplicons from ethidium monoazide treated samples, and ethidium monoazide was used to cleave DNA from dead cells and exclude it from PCR amplification. Both similarity and taxonomic analysis showed that the bacterial community composition in the influent was changed after anaerobic digestion. Firmicutes were dominant in all the samples, while Proteobacteria decreased in the biogas reactor compared with the influent. Variations of bacterial community composition in the biogas reactor with time were also observed. This could be attributed to varying composition of the influent. Batch experiments showed that the methane recovery from the digested residues (obtained from biogas reactor) was mainly related with post-digestion temperature. However, post-digestion time rather than temperature had a significant effect on the changes of bacterial community composition. The changes of bacterial community composition were also reflected in the changes of relative abundance of bacterial pathogens. The richness and relative abundance of bacterial pathogens were reduced after anaerobic digestion in the biogas reactor. It was found in batch experiments that bacterial pathogens showed the highest relative abundance and richness after 30 days' post-digestion. Streptococcus bovis was found in all the samples. Our results showed that special attention should be paid to the post-digestion since the increase in relative abundance of bacterial pathogens after post-digestion might reflect regrowth of bacterial pathogens and limit biosolids disposal vectors. Copyright © 2014 Elsevier

  14. The health aspects of biogas as an energy source

    International Nuclear Information System (INIS)

    Srinivasan, H.R.

    1982-01-01

    Data on the positive health impacts of biogas as fuel for rural household cooking have been collected from three villages near Bombay, one of which used traditional firewood as cooking fuel, one used biogas plants, and the third used biogas plants connected to latrines. The study illustrates the advantages of the use of biogas compared to wood, dung-cakes and crop residues. The biogas plants in the villages selected for study have been in operation for three or four years. Short-time studies show positive advantages of the use of biogas as fuel. (author)

  15. Decentralized power generation from biogas

    International Nuclear Information System (INIS)

    2008-01-01

    Areva Bioenergies proposes ready-to-use biogas production and valorization units that use industrial effluents (liquid effluents, spent water, solid wastes). Biogas valorization is performed through cogeneration plants with an output power of 500 kW to 10 MW. This brochure presents Areva's global offer in methanation projects (support, engineering, optimization). Areva Bioenergies counts 20 dual-purpose power plants in operation or under construction in the world which represent an installed power of 220 MW

  16. Foam formation in a downstream digester of a cascade running full-scale biogas plant: Influence of fat, oil and grease addition and abundance of the filamentous bacterium Microthrix parvicella.

    Science.gov (United States)

    Lienen, T; Kleyböcker, A; Verstraete, W; Würdemann, H

    2014-02-01

    The microbial community composition in a full-scale biogas plant fed with sewage sludge and fat, oil and grease (FOG) was investigated over a 15-month period, including two foam formation events. Addition of FOG as a substrate in the biogas plant together with high abundances of Microthrix parvicella were found to promote foam formation in the downstream digester of a cascade of two biogas digesters. Genetic fingerprinting and quantitative PCR (qPCR) indicated a higher abundance of M. parvicella in the digester, when the digestion process was accompanied by excessive foaming relative to the reference digesters without disturbance. The creation of foam depended on the introduced proportion of FOG and the abundance of M. parvicella. Furthermore, shifts in the abundance of M. parvicella in the biogas plant were observed within the 15-month monitoring period corresponding to its seasonal abundance in the sludge of the wastewater treatment plant (WWTP). Copyright © 2013 Elsevier Ltd. All rights reserved.

  17. Effect of enzyme addition on the methane yields of effluents from a full-scale biogas plant; Einfluss einer Enzymzugabe auf die Methanertraege von Gaersubstraten einer Praxis-Biogasanlage

    Energy Technology Data Exchange (ETDEWEB)

    Brule, Mathieu [Hohenheim Univ., Stuttgart (Germany). Landesanstalt fuer Agrartechnik und Bioenergie; European Institute for Energy Research (EIFER), Karlsruhe (Germany); Vogtherr, Jochen [Methavis GmbH, Ketsch (Germany); Lemmer, Andreas; Oechsner, Hans; Jungbluth, Thomas [Hohenheim Univ., Stuttgart (Germany). Landesanstalt fuer Agrartechnik und Bioenergie

    2011-07-01

    Biogas plants fed with a high share of fibre-rich energy crops (e.g. ensiled grass) often resort to enzyme additives in order to increase substrate degradation as well as the resulting methane yield. In order to evaluate the effect of enzyme additives on the digestion process, effluents were collected from the first and second reactor of a full-scale on-farm biogas plant. The sampled effluents were digested again in batch anaerobic digestion assays at the biogas laboratory of the University of Hohenheim. Enzyme addition even at high dosage could not yield any significant increase of the methane yields of effluents. (orig.)

  18. Growth responses of selected freshwater algae to trace elements and scrubber ash slurry generated by coal-fired power plants

    Energy Technology Data Exchange (ETDEWEB)

    Vocke, R.W.

    1979-01-01

    The development and implementation of standard toxicity tests is a necessity if consistent and reliable data are to be obtained for water quality criteria. The adapted EPA AAPBT is an ideal static algal toxicity test system. The algal test medium has a chemical composition similar to natural unpolluted waters of low ionic strength. It is appropriate to use MATC water quality criteria when assessing the potential impact of pollutants generated by coal-fired power stations because these energy-generated pollutants typically enter aquatic systems in small quantities over long periods. The MATC water quality criteria are estimates of trace element and SASE levels, based on the most sensitive alga investigated, that will not cause significant changes in naturally-functioning algal populations. These levels are 0.016f mg L/sup -1/ As(V), 0.001 mg L/sup -1/ Cd(II), 0.004 mg L/sup -1/ Hg(II), 0.006 mg L/sup -1/ Se(VI), and 0.344% SASE. To provide viable working water quality criteria, an extrapolation from the laboratory to the natural environment must be made. Therefore, those oxidation states of the trace elements were selected which are the dominant states occurring in natural, unpolluted, slightly alkaline freshwaters. It must be pointed out that these MATC values are based on algal responses to single toxicants and no allowance is made for synergistic, additive, or antagonistic relationships which could occur in natural aquatic systems. Additionally, natural chelation may influence toxicity. The highly toxic nature of potential pollutants from coal-fired generating plants emphasizes the need for minimizing stack effluent pollutants and retaining scrubber ash slurry for proper disposal in an effort to maintain trace elements in concentration ranges compatible with naturally-functioning ecosystems.

  19. Closing CO2 Loop in Biogas Production: Recycling Ammonia As Fertilizer.

    Science.gov (United States)

    He, Qingyao; Yu, Ge; Tu, Te; Yan, Shuiping; Zhang, Yanlin; Zhao, Shuaifei

    2017-08-01

    We propose and demonstrate a novel system for simultaneous ammonia recovery, carbon capture, biogas upgrading, and fertilizer production in biogas production. Biogas slurry pretreatment (adjusting the solution pH, turbidity, and chemical oxygen demand) plays an important role in the system as it significantly affects the performance of ammonia recovery. Vacuum membrane distillation is used to recover ammonia from biogas slurry at various conditions. The ammonia removal efficiency in vacuum membrane distillation is around 75% regardless of the ammonia concentration of the biogas slurry. The recovered ammonia is used for CO 2 absorption to realize simultaneous biogas upgrading and fertilizer generation. CO 2 absorption performance of the recovered ammonia (absorption capacity and rate) is compared with a conventional model absorbent. Theoretical results on biogas upgrading are also provided. After ammonia recovery, the treated biogas slurry has significantly reduced phytotoxicity, improving the applicability for agricultural irrigation. The novel concept demonstrated in this study shows great potential in closing the CO 2 loop in biogas production by recycling ammonia as an absorbent for CO 2 absorption associated with producing fertilizers.

  20. Enhancement of biogas production at the municipal wastewater treatment plant by co-digestion with poultry industry waste

    International Nuclear Information System (INIS)

    Budych-Gorzna, Magdalena; Smoczynski, Marcin; Oleskowicz-Popiel, Piotr

    2016-01-01

    Highlights: • Laboratory and full-scale trials on co-digestion of sludge and poultry waste were performed. • Successful scaling-up of the results from laboratory to full-scale was accomplished. • Incremental addition of poultry waste to the full-scale anaerobic digesters did not cause any inhibition of the process. • WWTP energy dependency can be reduced significantly by co-digestion of sludge and external source of waste. - Abstract: Municipal wastewater treatment plants (WWTPs) are energy-intensive and thus cost-intensive facilities; therefore, it is crucial to increase energy production directly at the WWTP. Enhancement of biogas production by addition of external substrates is one of the solutions to increase energy self-sufficiency of the WWTPs with an additional benefit of cutting down the greenhouse gas emission. The main aim of the work was to investigate full utilization of the capacity of full-scale digesters at the municipal WWTP by addition of poultry industry waste. At first, laboratory trials were conducted in order to identify the most suitable dose for co-digestion with primary and waste activated sludge and finally, based on the achieved laboratory results, full-scale trials were carried out directly at the municipal WWTP. Poultry industrial waste yielded between 0.39 and 0.88 m 3 of methane per kg of volatile solids during laboratory trials, depending on the added concentration. During full-scale investigation yield of 0.81 m 3 /kg VS was achieved. Enhanced biogas production improved WWTP energy self-sufficiency bringing closer to the aim of increasing the share of self-produced energy up to 80%.

  1. Sicilian potential biogas production

    Directory of Open Access Journals (Sweden)

    Antonio Comparetti

    2013-09-01

    Full Text Available This study is aimed at predicting the Sicilian potential biogas production, using the Organic Fraction of Municipal Solid Waste (OFMSW, animal manure and food industry by-products, in a region where only one biogas plant using MSW and one co-digestion plant are nowadays available. The statistical data about OFMSW, the number of animals bred in medium and large farms and the amounts of by-products of food processing industries were evaluated, in order to compute the Sicilian potential biogas and energy production. The OFMSW produced in Sicily, that is 0.8 million tons ca. per year (37% of MSW, could be used in a bio-reactor, together with other raw materials, for Anaerobic Digestion (AD process, producing biogas and “digestate”. Moreover, 3.03 million tons ca. of manure, collected in medium and large animal husbandry farms (where cows, pigs and poultry are bred, and 350 thousand tons ca. of by-products, collected in food processing industries (pomace from olive oil mills and grape marc from wineries, might be used for AD process. The Sicilian potential biogas production from the AD of the above raw materials is 170.2 millions of m3, that is equal to 1023.4 GWh of energy per year, of which 484 GWh from animal manure, 303 GWh from OFMSW and 236.4 GWh from food industry by-products. The highest biogas production is in the province of Palermo (35.6 millions of m3, Ragusa (30.8 millions of m3 and Catania (22.8 millions of m3, having a potential energy production of 213.8, 185 and 137 GWh, respectively.

  2. Energy Balance of Biogas Production from Microalgae: Effect of Harvesting Method, Multiple Raceways, Scale of Plant and Combined Heat and Power Generation

    Directory of Open Access Journals (Sweden)

    John J. Milledge

    2017-01-01

    Full Text Available A previously-developed mechanistic energy balance model for production of biogas from the anaerobic digestion of microalgal biomass grown in open raceway systems was used to consider the energetic viability of a number of scenarios, and to explore some of the most critical parameters affecting net energy production. The output demonstrated that no single harvesting method of those considered (centrifugation, settlement or flocculation produced an energy output sufficiently greater than operational energy inputs to make microalgal biogas production energetically viable. Combinations of harvesting methods could produce energy outputs 2.3–3.4 times greater than the operational energy inputs. Electrical energy to power pumps, mixers and harvesting systems was 5–8 times greater than the heating energy requirement. If the energy to power the plant is generated locally in a combined heat and power unit, a considerable amount of “low grade” heat will be available that is not required by the process, and for the system to show a net operational energy return this must be exploited. It is concluded that the production of microalgal biogas may be energetically viable, but it is dependent on the effective use of the heat generated by the combustion of biogas in combined heat and power units to show an operational energy return.

  3. ASSESSMENT OF THE BIODIVERSITY OF SAMPLES USED FOR ISOLATION OF MICROBIAL STRAINS CAPABLE OF CONVERTING STRAW DESTINED AS A SUBSTRATE FOR BIOGAS PLANT

    Directory of Open Access Journals (Sweden)

    Krystyna Cybulska

    2016-01-01

    Full Text Available In biogas plants, almost any type of organic matter can be used as a substrate to produce biogas. To make the process of methane fermentation more effective, these materials are pretreated. This applies in particular to a group of difficult substrates. Straw, due to its hemicellulose structure and saturation, is hardly fermented by biogas reactor microorganisms. The methods of post-harvest residue preparation for anaerobic digestion being applied so far are expensive, while their application has a negative effect on methanoegenic bacteria. Therefore, the microorganisms being able to degrade straw hemicellulose structure, utilisation of which could precede the proper fermentation process, have been searched for. This paper presents the results of microbial biodiversity analysis in the environmental samples being lupin, cereal, rape and maize straw as well as hay and haylage at different degradation stages. The analysis of biodiversity will help at a further stage of study to isolate active microbial strains showing cellulolytic, hemicellulolytic or ligninolytic activity which are desirable in the process of straw biodegradation. Analysis of the microbial count was performed by the method of deep inoculation on different microbiological culture media. The conducted tests include determination of the number of fungi, bacteria and actinomycetes. The results obtained confirm the usefulness of the analysed samples for isolation of microbial strains capable of converting straw preceding the biogas production.

  4. Thermodynamic Performance Analysis of a Biogas-Fuelled Micro-Gas Turbine with a Bottoming Organic Rankine Cycle for Sewage Sludge and Food Waste Treatment Plants

    Directory of Open Access Journals (Sweden)

    Sunhee Kim

    2017-02-01

    Full Text Available In the Republic of Korea, efficient biogas-fuelled power systems are needed to use the excess biogas that is currently burned due to a lack of suitable power technology. We examined the performance of a biogas-fuelled micro-gas turbine (MGT system and a bottoming organic Rankine cycle (ORC. The MGT provides robust operation with low-grade biogas, and the exhaust can be used for heating the biodigester. Similarly, the bottoming ORC generates additional power output with the exhaust gas. We selected a 1000-kW MGT for four co-digestion plants with 28,000-m3 capacity. A 150-kW ORC system was selected for the MGT exhaust gas. We analysed the effects of the system size, methane concentration, and ORC operating conditions. Based on the system performance, we analysed the annual performance of the MGT with a combined heat and power (CHP system, bottoming ORC, or both a bottoming ORC and CHP system. The annual net power outputs for each system were 7.4, 8.5, and 9.0 MWh per year, respectively.

  5. Mass flow and energy balance plus economic analysis of a full-scale biogas plant in the rice-wine-pig system.

    Science.gov (United States)

    Li, Jiang; Kong, Chuixue; Duan, Qiwu; Luo, Tao; Mei, Zili; Lei, Yunhui

    2015-10-01

    This paper presents mass flow and energy balance as well as an economic analysis for a biogas plant in a rice-wine-pig system at a practical rather than laboratory scale. Results showed feeding amount was 65.30 t d(-1) (total solid matter (TSM) 1.3%) for the normal temperature continuous stirred tank reactor (CSTR), and 16.20 t d(-1) (TSM 8.4%) for the mesophilic CSTR. The digestion produced 80.50 t d(-1) of mass, with 76.41 t d(-1) flowing into rice fields and 4.49 t d(-1) into composting. Energy consumption of this plant fluctuated with seasons, and surplus energy was 823, 221 kWh/year. Thus, biogas plant was critical for material recycling and energy transformation of this agro-ecosystem. The economic analysis showed that the payback time of the plant was 10.9 years. It also revealed application of biogas as a conventional energy replacement would be attractive for a crop-wine-livestock ecosystem with anaerobic digestion of manure. Copyright © 2015 Elsevier Ltd. All rights reserved.

  6. The economics of biogas in Denmark

    DEFF Research Database (Denmark)

    Jacobsen, Brian H.; Laugesen, Frederik Møller; Dubgaard, Alex

    2013-01-01

    Denmark has been one of the leading European Countries in using Biogas for Combined Heat and Power (CHP), since the 1980’ties. However, in the last two decades, the increase has been limited. A new energy policy aimed at increasing the profitability of Biogas was introduced in the spring of 2012....... The analysis here shows that the new agreement will improve the profitability of biogas plants and increase the biogas production although the political ambition of an increase from 4 PJ to 14 PJ by 2020 seems unlikely. The analysis shows that biogas plants can be profitable even if the input is a mix....... Even without an investment subsidy of 30%, the case 2012, is profitable. Financing the biogas plants is a challenge. The interest used of 4.25% requires bank guaranties which in practice can be hard to get. Using a more likely interest of 7-8% reduces the yearly profit to 400.000 €. The socioeconomic...

  7. Process technique investigations for the optimisation of reaction conditions of unheated biogas plants. Verfahrenstechnische Untersuchungen zur Optimierung der Reaktionsbedingungen von unbeheizten Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Aklaku, E.D.

    1989-01-01

    Heated biogas plants in the mesophil temperature range guarantee safe operation and produce high gas yields. As the installation of heating systems requires a great investment, this installation is uneconomical, particularly for small plants. In countries with tropical and sub-tropical climates, unheated plants of various types were produced. The construction, functioning and method of operation of the most common types of plant are described. In the context of his own work, the author described the most important factors affecting the energy yield of anaerobic decomposition of chicken manure and mixtures of chicken manure and Guinea grass in unheated plants examined on the laboratory scale, and the transferability of the results obtained to plants on the technical scale is discussed. The comparison between the results of the laboratory experiments and findings in plant on the semi-technical scale on the one hand, and the data from the literature on the other hand, leads to the conclusion that plants on the technical scale will provide comparable outputs of gas to the laboratory plant examined. The differentiated process parameters introduced make it possible to optimise the process for the substrates examined in reactors with stirrer device. On the basis of the extensive results of experiments, an unheated 10 m{sup 3} biogas plant with stirrer mechanism was designed for the climatic conditions in Ghana and the potential yield was calculated. (orig./EF).

  8. Toxicity Evaluation of Pig Slurry Using Luminescent Bacteria and Zebrafish

    Directory of Open Access Journals (Sweden)

    Wenyan Chen

    2014-07-01

    Full Text Available Biogas slurry has become a serious pollution problem and anaerobic digestion is widely applied to pig manure treatment for environmental protection and energy recovery. To evaluate environmental risk of the emission of biogas slurry, luminescent bacteria (Vibrio fischeri, larvae and embryos of zebrafish (Danio rerio were used to detect the acute and development toxicity of digested and post-treated slurry. Then the ability of treatment process was evaluated. The results showed that digested slurry displayed strong toxicity to both zebrafish and luminescent bacteria, while the EC50 for luminescent bacteria and the LC50 for larvae were only 6.81% (v/v and 1.95% (v/v respectively, and embryonic development was inhibited at just 1% (v/v. Slurry still maintained a high level of toxicity although it had been treated by membrane bioreactor (MBR, while the LC50 of larvae was 75.23% (v/v and there was a little effect on the development of embryos and V. fischeri; the results also revealed that the zebrafish larvae are more sensitive than embryos and luminescent bacteria to pig slurry. Finally, we also found the toxicity removal rate was higher than 90% after the treatment of MBR according to toxicity tests. In conclusion, further treatment should be used in pig slurry disposal or reused of final effluent.

  9. Rheology of tetraphenylborate precipitate slurry

    International Nuclear Information System (INIS)

    Goren, I.D.; Martin, H.D.; McLain, M.A.

    1985-01-01

    The rheological properties of tetraphenylborate precipitate slurry were determined. This nonradioactive slurry simulates the radioactive tetraphenylborate precipitate generated at the Savannah River Plant by the In-Tank Precipitation Process. The data obtained in this study was applied in the design of slurry pumps, transfer pumps, transfer lines, and vessel agitation for the Defense Waste Processing Facility and other High Level Waste treatment projects. The precipitate slurry behaves as a Bingham plastic. The yield stress is directly proportional to the concentration of insoluble solids over the range of concentrations studied. The consistency is also a linear function of insoluble solids over the same concentration range. Neither the yield stress nor the consistency was observed to be affected by the presence of the soluble solids. Temperature effects on flow properties of the slurry were also examined: the yield stress is inversely proportional to temperature, but the consistency of the slurry is independent of temperature. No significant time-dependent effects were found. 4 refs., 4 figs., 3 tabs

  10. Use of biogas biscuit meal EKPO-EB for agricultural biogas plant for substitution of energy crops utilization with organic waste

    Directory of Open Access Journals (Sweden)

    Chamrádová Kateřina

    2015-09-01

    Full Text Available A laboratory experiment of two-stage mesophilic, low-dry mass, anaerobic digestion was carried out, focused on verifying the benefit of processing the biscuit meal EKPO-EB instead of triticale silage Agostino (GPS and corn silage LG3266 in a regular batch for the agricultural biogas station in Pustějov. While anaerobic digestion of ensilages is largely difficult due to the content of lignocellulose, biscuit meal provides a high yield of biogas or methane, respectively, thanks to its high content of simple saccharides and lipids. When the original GPS (or the replacement EKPO-EB, respectively represented 0.81% of weight of the daily input mixture dose for the first stage, the rise in volumetric methane production was 20% which is significant. The biscuit meal EKPO-EB decomposes almost completely in the first stage. Later, when the EKPO-EB represented 1.63% of weight of the daily input mixture dose for the first stage, the rise in volumetric methane production was 54% in the first stage and 16% in the second stage.

  11. Application of the membrane technology on the exhaustive fermentation of renewable raw materials in biogas plants; Einsatz von Membrantechnik zur erschoepfenden Vergaerung von nachwachsenden Rohstoffen in Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Schreiber, Anja; Vollmer, Gerd-Rainer; Breuer, Uta; Nelles, Michael [Fachhochschule Nordhausen (Germany). Fachbereich Ingenieurwissenschaften

    2013-10-01

    In the University of Applied Sciences Nordhausen the possibility to increase the degradation of organic substances, especially maize silage as model substrate, in biogas plants by using membrane technology was investigated. This project started in 9/2010 and is founded by the Federal Ministry of Food, Agriculture and Consumer Protection (BMELV) on the Agency for Renewable Resources (FNR). The innovation of the method is the link between tubular membranes and the 1 m{sup 3} fermenter of the pilot biogas plant of the University. The installed membrane modules separate the fermenter materials in a solid (retentate) and a liquid phase (permeate). The solids are recycled in the fermenter while the permeate is fermented separately. The method based on the idea of decoupling the hydraulic retention time readily biodegradable and of difficult or non-biodegradable fermenter ingredients and a therefore continued degradation of organic matter. The separated permeate contains fatty acids and with it a significant residual gas potential. In parallel investigations the project partner BTN Biotechnologie Nordhausen GmbH evaluates different fermenter designs to optimal gain the gas potential of the separated permeate. If the method should be verified biogas plant operators could achieve higher gas yields with the same substrate amount or the same gas yield with less substrate amounts, respectively. (orig.)

  12. The role of transportation and co-fermentation in the CO2 balance for utilisation of biogas for energy

    DEFF Research Database (Denmark)

    Nielsen, Per Sieverts; Karlsson, Kenneth Bernard; Holm-Nielsen, Jens Bo

    1998-01-01

    Biogas is an essential biomass source for achieving a reduction of CO2 emission by 50% in year 2030 in Denmark. The physical potential for biogas production in Denmark is more than 10 times the present biogas production in Denmark. In Denmark the largest part of the biogas production is produced...... at 19 decentralised joint biogas plants involving a varying number of farms (5-100). All of these plants use to some extent co-fermentation with industrial organic waste to increase biogas yield.A fuel chain approach for utilisation of biogas for energy purposes is carried out for determining the role...... of increased transportation distances at large biogas plants on the total CO2 balance of the biogas plant. The advantage of constructing large biogas plants is the cost-effective possibility of using industrial organic waste to increase biogas production. In some cases co-fermentation increases biogas...

  13. Comparative evaluation of different types of biogas suitable for tropical country

    International Nuclear Information System (INIS)

    Sahu, S.N.; Gbagbo, J.K.N.; Aneke, F.U.

    1997-04-01

    The biogas technology - anaerobic digestion - is described together with different types of biogas plants suitable for tropical countries. Cost-benefit analysis of establishing biogas plants, financial support options, and the benefits of using biogas as an energy source in rural areas are presented. (LN)

  14. Nitrification limitation in animal slurries at high temperatures

    NARCIS (Netherlands)

    Willers, H.C.; Derikx, P.J.L.; Have, ten P.J.W.; Vijn, T.K.

    1998-01-01

    Nitrification rates in two types of animal slurry were measured at temperatures between 20 and 60°C. The rates were assessed in rapid laboratory assays using samples from aeration tanks of large scale treatment plants for pig or veal-calf slurry. Maximum nitrification rates for the two slurries were

  15. GAS TURBINE ENGINES CONSUMING BIOGAS

    Directory of Open Access Journals (Sweden)

    Е. Ясиніцький

    2011-04-01

    Full Text Available A problem of implementation of biofuel for power plants of big capacity was considered in thisarticle. Up to date in the world practice a wide implementation of biogas plants of low and medialcapacity are integrated. It is explained by the big amount of enterprises in which relatively smallvolumes of organic sediment excrete in the process of its activity. An emphasis of article is on thatenterprises, which have big volumes of sediments for utilizing of which module system of medialcapacity biogas plants are non-effective. The possibility of using biogas and biomethane as a fuelfor gas turbine engine is described. The basic problems of this technology and ways of its solutionsare indicated. Approximate profitability of biogas due to example of compressor station locatednearby poultry factory was determined also. Such factors as process characteristics of engine withcapacity of 5 MW, approximate commercial price for natural gas and equipment costs due toofficial sources of “Zorg Ukraine” company was taken into consideration. The necessity forproviding researches on influence of biogas on the process characteristics of gas turbine engine andits reliability, constructing modern domestic purification system for biogas was shown.

  16. Factors Affecting Process Temperature and Biogas Production in Small-scale Rural Biogas Digesters in Winter in Northern Vietnam

    Directory of Open Access Journals (Sweden)

    C. H. Pham

    2014-07-01

    Full Text Available This study investigated the main factors influencing digester temperature and methods to reduce heat losses during the cold season in the subtropics. Four composite digesters (two insulated and two uninsulated were buried underground to measure their internal temperature (°C at a depth of 140 cm and 180 cm, biogas production and methane (CH4 concentration in biogas from August to February. In parallel the temperature of the air (100 cm above ground, in the slurry mixing tank and in the soil (10, 100, 140, and 180 cm depth was measured by thermocouple. The influent amount was measured daily and the influent chemical composition was measured monthly during the whole experimental period. Seasonal variations in air temperature significantly affected the temperature in the soil, mixing tank and digester. Consequently, biogas production, which is temperature dependent, was influenced by the season. The main factors determining the internal temperature in the digesters were insulation with Styrofoam, air temperature and temperature of slurry in the mixing tank. Biogas production is low due to the cold climate conditions in winter in Northern Vietnam, but the study proved that storing slurry in the mixing tank until its temperature peak at around 14:00 h will increase the temperature in the digester and thus increase potential biogas production. Algorithms are provided linking digester temperature to the temperature of slurry in the mixing tank.

  17. Biogas Technology on Supporting “Sustainable” Coffee Farmers in North Sumatera Province, Indonesia

    Science.gov (United States)

    Ginting, N.

    2017-03-01

    A study has been conducted in an area of coffee plantation in Samosir District, North Sumatera Province. The study was conducted in August until September 2016. The objective of this study is to investigate the benefits of using biogas technology in supporting coffee farmers’ productivity to be sustainable, i.e. methane as energy source for coffee roasting proceed instead of fired wood and slurry as organic fertilizer. Coffee cherry causes environmental problem when it is dumped openly, hence it is used to mix with buffalo feces in biodigesters to produce methane and organic fertilizer. Five biodigesters were used with 5 differents designs of composition: T1) 100% buffalo feces, T2) 75% buffalo feces + 25% coffee cherry, T3) 50% buffalo feces + 50% coffee cherry, T4) 25% buffalo feces + 75% coffee cherry, and T5) 100% coffee cherry. The key parameters measured were methane production and slurry chemical compositions including NPK, pH, and C/N. It is found that designs T1 and T2 were superior in methane production, and about 400 liters of methane were used in roasting 3 kg coffee bean as opposed to 6,6 kg fired wood. Designs T1 and T2 were also better in slurry chemical compositions than the other 3 designs. It is recommeded that local coffee farmers utilize coffee cherry based biogas technology in order for their productivity to be sustainable. It is noteworthy that this study is continued with the next one in which the resulting slurries are implemented to foster the growth of the coffee plants during the period of October until December 2016.

  18. Identification of different species of Bacillus isolated from Nisargruna Biogas Plant by FTIR, UV-Vis and NIR spectroscopy

    Science.gov (United States)

    Ghosh, S. B.; Bhattacharya, K.; Nayak, S.; Mukherjee, P.; Salaskar, D.; Kale, S. P.

    2015-09-01

    Definitive identification of microorganisms, including pathogenic and non-pathogenic bacteria, is extremely important for a wide variety of applications including food safety, environmental studies, bio-terrorism threats, microbial forensics, criminal investigations and above all disease diagnosis. Although extremely powerful techniques such as those based on PCR and microarrays exist, they require sophisticated laboratory facilities along with elaborate sample preparation by trained researchers. Among different spectroscopic techniques, FTIR was used in the 1980s and 90s for bacterial identification. In the present study five species of Bacillus were isolated from the aerobic predigester chamber of Nisargruna Biogas Plant (NBP) and were identified to the species level by biochemical and molecular biological (16S ribosomal DNA sequence) methods. Those organisms were further checked by solid state spectroscopic absorbance measurements using a wide range of electromagnetic radiation (wavelength 200 nm to 25,000 nm) encompassing UV, visible, near Infrared and Infrared regions. UV-Vis and NIR spectroscopy was performed on dried bacterial cell suspension on silicon wafer in specular mode while FTIR was performed on KBr pellets containing the bacterial cells. Consistent and reproducible species specific spectra were obtained and sensitivity up to a level of 1000 cells was observed in FTIR with a DTGS detector. This clearly shows the potential of solid state spectroscopic techniques for simple, easy to implement, reliable and sensitive detection of bacteria from environmental samples.

  19. Identification of different species of Bacillus isolated from Nisargruna Biogas Plant by FTIR, UV-Vis and NIR spectroscopy.

    Science.gov (United States)

    Ghosh, S B; Bhattacharya, K; Nayak, S; Mukherjee, P; Salaskar, D; Kale, S P

    2015-09-05

    Definitive identification of microorganisms, including pathogenic and non-pathogenic bacteria, is extremely important for a wide variety of applications including food safety, environmental studies, bio-terrorism threats, microbial forensics, criminal investigations and above all disease diagnosis. Although extremely powerful techniques such as those based on PCR and microarrays exist, they require sophisticated laboratory facilities along with elaborate sample preparation by trained researchers. Among different spectroscopic techniques, FTIR was used in the 1980s and 90s for bacterial identification. In the present study five species of Bacillus were isolated from the aerobic predigester chamber of Nisargruna Biogas Plant (NBP) and were identified to the species level by biochemical and molecular biological (16S ribosomal DNA sequence) methods. Those organisms were further checked by solid state spectroscopic absorbance measurements using a wide range of electromagnetic radiation (wavelength 200 nm to 25,000 nm) encompassing UV, visible, near Infrared and Infrared regions. UV-Vis and NIR spectroscopy was performed on dried bacterial cell suspension on silicon wafer in specular mode while FTIR was performed on KBr pellets containing the bacterial cells. Consistent and reproducible species specific spectra were obtained and sensitivity up to a level of 1000 cells was observed in FTIR with a DTGS detector. This clearly shows the potential of solid state spectroscopic techniques for simple, easy to implement, reliable and sensitive detection of bacteria from environmental samples. Copyright © 2015 Elsevier B.V. All rights reserved.

  20. Use of digestate from a decentralized on-farm biogas plant as fertilizer in soils: An ecotoxicological study for future indicators in risk and life cycle assessment

    DEFF Research Database (Denmark)

    Pivato, Alberto; Vanin, Stefano; Raga, Roberto

    2016-01-01

    Over the last decade, the number of decentralized farm biogas plants has increased significantly in the EU. This development leads not only to an increasing amount of biogas produced, but also to a higher amount of digestate obtained. One of the most attractive options to manage the digestate...... is to apply it as biofertiliser to the soil, because this gives the opportunity of recovering the nutrients, primarily nitrogen and phosphorus, and of attenuating the loss of organic matter suffered by soils under agricultural exploitation. Studies have claimed that digestates can present a residual...... biodegradability, and contain complex organic elements, salts or pathogenic bacteria that can damage terrestrial organisms. However few ecotoxicological studies have been performed to evaluate the ecological impact of digestate application on soil.In this study, the use of digestate as biofertiliser in agriculture...

  1. Biogas Koczala. Biogas project in Koczala. Feasibility study. Technical report

    International Nuclear Information System (INIS)

    2004-08-01

    The present production of district heating in Koczala is based on coal. The district heating system is worn out technically and economically and according to the 2001 Energy Plan of Koczala the district heating plant shall be converted to a combination of a biogas fired CHP and a wood chip boiler. The overall objective of this project is to access the feasibility and viability construction an operation of a biogas plant owned by the co-operative agricultural company, Poldanor S.A. The feasibility study includes: 1) Availability of organic waste in the Koczala area, 2) Possibilities of using energy crops in the biogas plant, 3) Possibilities of receiving grants from the Polish National Fund for Environmental Protection, the new EU regional funds and through the joint implementation market (CO 2 quotas), 4) Alternative locations of the biogas plant and the CHP unit, 5) Alternative strategies for selling electricity and heat, 6) Organisational issues (ownership). This report concludes that implementing the biogas project is environmentally and financially feasible and viable. If organic waste and/or maize silage can be provided and gasified without problems, the plant can supply as well the Koczala farm as the fodder mill with steam and heat, and also supply Koczala district heating system with approx. 75% of yearly heat consumption. Furthermore, electricity is supplied to the fodder mill and the public grid. (BA)

  2. Farm-based biogas plants with 75 kW. Opportunities and limits; Hof-Biogasanlagen bis 75 kW. Moeglichkeiten und Grenzen

    Energy Technology Data Exchange (ETDEWEB)

    Weber, Andreas; Schober, Josef [Bayerische Landesanstalt fuer Landwirtschaft, Freising (Germany). Inst. fuer Landtechnik und Tierhaltung

    2012-11-15

    The compensation for a period of twenty years as governed by the Renewable Energy Law (EEG) is an important factor in the planning security in the construction of small farm-based biogas plants with an installed performance of 75 kW. A minimum thermal utilization is not obligatory within this class of power plants. The utilization of liquid manure and renewable raw materials from the own holding reduces the dependency of the operator from the supply and costs of substrates. Thus, the demand on leased areas for the cultivation of substrates significantly is reduced, and the rental market is not burdened additionally. Furthermore, short transport distances result from the company-owned cultivation of substrate. Furthermore, the livestock factories are experienced in the conservation of feedstuff especially in the silage management, and thus may govern the silage management. Small farm-based biogas plants are economically interesting, if the investment costs are moderate and cost-effective substrate are available. Farm-based biogas plants being operated only by means of liquid manure are economically advantageous. Thereby, the necessary amounts of liquid manure are available to single farms only in few cases. Supra-company solutions such as communal facilities with the neighboured farms are considered. In the case of liquid manure supply, the arising costs have to be moderate in order not to threaten the profitability. Farm-based biogas plants being operated with respect to the 80/20 rule only are profitable if the lowest limit of earnings of 75 kW is exhausted. In that case however, the expected profits are moderate. In addition to the investment costs, the costs for substrates are decisive for the economic success. In extreme situations in winter, the heat balance of small farm-based biogas plants being operated with respect to the 80/20 rule only is positive in the case of a good thermal insulation of the fermentation plant and in the construction with a concrete

  3. Online monitoring and control of the biogas process

    Energy Technology Data Exchange (ETDEWEB)

    Boe, K.

    2006-07-01

    The demand for online monitoring and control of biogas process is increasing, since better monitoring and control system can improve process stability and enhance process performance for better economy of the biogas plants. A number of parameters in both the liquid and the gas phase have been suggested as process indicators. These include gas production, pH, alkalinity, volatile fatty acids (VFA) and hydrogen. Of these, VFA is the most widely recognised as a direct, relevant measure of stability. The individual, rather than collective VFA concentrations are recognised as providing significantly more information for diagnosis. However, classic on-line measurement is based on filtration, which suffers from fouling, especially in particulate or slurry wastes. In this project, a new online VFA monitoring system has been developed using gas-phase VFA extraction to avoid sample filtration. The liquid sample is pumped into a sampling chamber, acidified, added with salt and heated to extract VFA into the gas phase before analysis by GC-FID. This allows easy application to manure. Sample and analysis time of the system varies from 25-40 min. depending on the washing duration. The sampling frequency is fast enough for the dynamic of a manure digester, which is in the range of several hours. This system has been validated over more than 6 months and had shown good agreement with offline VFA measurement. Response from this sensor was compared with other process parameters such as biogas production, pH and dissolved hydrogen during overload situations in a laboratory-scale digester, to investigate the suitability of each measure as a process indicator. VFA was most reliable for indicating process imbalance, and propionate was most persistent. However, when coupling the online VFA monitoring with a simple control for automatic controlling propionate level in a digester, it was found that propionate decreased so slow that the biogas production fluctuated. Therefore, it is more

  4. Using of biogas for combined cycle of heat and electricity in City Waste Water Treatment Plant in the city of Varna

    International Nuclear Information System (INIS)

    Stankov, N.; Ovcharov, A.; Nikolov, Ch.; Petrov, P.

    2013-01-01

    This report contains a good practice example of energy production by means of biogas utilization in a Bulgarian city waste water treatment plant in Varna city (WWTP). Sewage gas production is included in the waste water and deposits treatment technological scheme of the plant before their further disposal or utilization. Sewer gas is used to fuel a combined heat and power production module which is based on reciprocating gas engines technology. This article contains data from a real site and its purpose is to present the stages of the examined process as well as the technical, economical and environmental benefits from introduction of such technology in a city WWTP. (authors)

  5. Application of titration methods for measuring the contents of ammonium nitrogen and volatile fatty acids in agricultural biogas plants.

    Science.gov (United States)

    Piątek, Michał; Lisowski, Aleksander; Lisowska, Barbara

    2017-12-20

    The aim of our research was to assess a relatively new method of estimating ammonium nitrogen concentration in anaerobic digestion of plant substrates. We analysed our own data, received from the anaerobic digestion of maize silage (PM), as well as data published by Purser et al. (2014) who measured energy crops and slurry (ECS), and food waste (FW). In our study, the process was monitored for VFA content that was determined by gas chromatography, and for the content of ammonium nitrogen determined using the HACH LANGE LCK 303 cuvette test. We created polynomial regression models that bind the content of ammonium nitrogen with the volume of H 2 SO 4 used to titrate the sample from initial pH to pH 5. To estimate parameters of model, the PM dataset was used. The obtained models were positively validated using ECS and FW datasets. Our results confirmed the effectiveness of the Purser et al. method with an average absolute error of less than 223mgl -1 of the VFA concentration, which was approximately 20-times less than the level that caused inhibition. In conclusion, we can affirm the suitability of using titration methods to assess the ammonium nitrogen content of bioreactors with a stable composition. Copyright © 2017 Elsevier B.V. All rights reserved.

  6. BIOGAS PRODUCTION FROM CATCH CROPS

    DEFF Research Database (Denmark)

    Molinuevo-Salces, Beatriz; Larsen, Søren U.; Ahring, Birgitte Kiær

    2014-01-01

    Catch crop cultivation combined with its use for biogas production would increase renewable energy production in the form of methane, without interfering with the production of food and fodder crops. The low biomass yield of catch crops is the main limiting factor for using these crops as co......-substrate in manure-based biogas plants and the profit obtained from the sale of biogas barely compensates for the harvest costs. A new agricultural strategy to harvest catch crops together with the residual straw of the main crop was investigated to increase the biomass and thereby the methane yield per hectare...... biomass. Leaving the straw on the field until harvest of the catch crop in the autumn could benefit biogas production due to the organic matter degradation of the straw taking place on the field during the autumn months. This new agricultural strategy may be a good alternative to achieve economically...

  7. Biogas production in Denmark - Assessments of the operational and societal economy; Biogasproduktion i Danmark - Vurderinger af drifts- og samfundsoekonomi

    Energy Technology Data Exchange (ETDEWEB)

    Jacobsen, Brian H.; Laugesen, F.M.; Dubgaard, A.; Bojesen, M.

    2013-06-15

    In the mid 1990's, the increase in the biogas production came from 20 centralised biogas plants. Since then the increase in biogas production has come mainly from farm biogas plants and it is estimated that around 8% of all slurry today is used to produce biogas. With the energy agreement from 2012 and a new political ambition of using up to 50% of all slurry and manure in the production of biogas, new targets, as well as a new framework have been set up for the future biogas production in Denmark. The aim of this report is to assess the business and socio-economics of biogas in Denmark under the new conditions given by the 2012 energy agreement. It is the aim to highlight many of the different parameters which, in effect, decides the economic outcome. Furthermore, it is the aim to look at the socio-economic gains and costs related to biogas production, including the positive side effects which come from biogas. The analysis of farm biogas indicates that the business profit is positive of around 0.4 million DKK per year, while the result for the organic plant is a deficit of around 4 million DKK per year despite the assumption that the farms are located relatively near the biogas plant. In the socio-economic analysis, the value of replaced natural gas is included as well as the value of increased fertiliser value and reduced nitrogen leaching. In the calculations, a net tax factor of 35% has been used to change the factor prices to consumer prices. A tax distortion factor (dead weight loss factor) of 20% has been used to account for the subsidies given and the change in taxation required. This is done even though the Danish PSO levy ensures that the subsidies given do actually affect the price of the energy bought by the consumer. The interest is set at 4.25% following the recommendation by the Ministry of Finance and The Environment Agency. The analyses show that the direct socio-economic costs are 39.5 million DKK and that the tax distortion effect costs 5

  8. The progress and prospects of rural biogas production in China

    International Nuclear Information System (INIS)

    Chen, Ling; Zhao, Lixin; Ren, Changshan; Wang, Fei

    2012-01-01

    Biogas production is an important aspect of China's energy strategy. After decades’ application and research, China biogas has achieved considerable accomplishments. This study presents the progress and prospect of biogas technologies and industry in China. Two biogas patterns exist in China, that is, household-scaled digester for scattered farmers and biogas plant for centralized biogas production. Household-scaled digester which is simple and practical has been widely used and fully developed. Biogas plants have being sprung up with different materials, process and biogas utilization technologies. By the end of 2010, 38.51 million household-scaled digesters, and 27,436 large- and medium-scaled biogas plants for agricultural wastes were built. The calculation result of biogas potential from agricultural wastes shows that those used raw materials account for only 1.90% of the total availability. Chinese government promulgated several laws and policies, and gave financial supports to promote the development of biogas. However, some problems such as inferior equipment technology, imperfect policy incentive hamper its wide application and promotion. With the rapid development of economy and the improvement of rural living condition, China biogas industry is expected to advance toward orientation of scalization, industrialization and commercialization. - Highlights: ► Developing progress of biogas production in China is evaluated comprehensively. ► Status of biogas industrialization is estimated. ► New problems which occurred during rural biogas construction were analyzed. ► Biogas production potentials from agricultural wastes in China were calculated. ► Prospect of China rural biogas is expected.

  9. Coal-CO[subscript 2] Slurry Feed for Pressurized Gasifiers: Slurry Preparation System Characterization and Economics

    OpenAIRE

    Botero, Cristina; Herzog, Howard J.; Ghoniem, Ahmed F.; Field, Randall

    2013-01-01

    Gasification-based plants with coal-CO[subscript 2] slurry feed are predicted to be more efficient than those with coal-water slurry feed. This is particularly true for high moisture, low rank coal such as lignite. Nevertheless, preparation of the CO[subscript 2] slurry is challenging and the losses associated with this process have not been accounted for in previous analyses. This work introduces the Phase Inversion-based Coal-CO[subscript 2] Slurry (PHICCOS) feeding system, in which coal-CO...

  10. Terpenes removal from biogas; Terpenenverwijdering uit biogas

    Energy Technology Data Exchange (ETDEWEB)

    Schulze, P.; Holstein, J.; De Haan, HR.; Vlap, H. [DNV KEMA, Arnhem (Netherlands)

    2013-06-15

    Biogas may contain unwanted and harmful components, including aromatic hydrocarbons such as terpenes. These terpenes (organic oils) are mainly present in citrus peel and plant residues; that is why especially raw biogas from organic waste digestion plants contains high concentrations of terpenes. If terpenes end up in the gas grid (with the injected biomethane) there is a risk that plastics (PE pipes) lose their mechanical properties by absorbing liquids or extracting ethereal plasticizers. This can lead to embrittlement greatly lowering the reliability of the piping. In addition, soft components are als o affected (gaskets and rubber O-rings). Besides the impact on the integrity of the gas grid, terpenes also mask the odor of natural gas odorants such as THT. This impedes the detection of gas leaks which is a significant security risk. Furthermore, the presence of terpenes in biogas leads to fouling of equipment used for the drying of biomethane, as well as contamination of adsorption liquids and membranes used in the upgrading process. Currently, terpenes are removed by activated carbon filters. The tool life of such a filter can be relatively short if terpene concentrations are high in the biogas; this results in a significant increase of the operational costs, due to the replacement of the carbon. This study looked at alternative techniques for removing much of the terpenes from biogas in a simple, efficient and cheap way. In a workshop with stakeholders two techniques were chosen to be tested on laboratory scale in order to demonstrate the proof of principle. These techniques are photo-oxydation and a gas scrubbing. Of all investigated techniques for the removal of limonene the application of UV radiation seems to be the most promising option because of the simplicity of the process, the high efficiency (up to 94%), the comparable operational costs with activated carbon (6.7 to 9.5 euro/kg limonene removed, compared to 10 euro/kg limonene removed for activated

  11. Pilot-scale anaerobic co-digestion of sewage sludge with agro-industrial by-products for increased biogas production of existing digesters at wastewater treatment plants.

    Science.gov (United States)

    Maragkaki, A E; Fountoulakis, M; Gypakis, A; Kyriakou, A; Lasaridi, K; Manios, T

    2017-01-01

    Due to low degradability of dry solids, most of the digesters at wastewater treatment plants (WWTP) operate at low loading rates resulting in poor biogas yields. In this study, co-digestion of sewage sludge (SS) with olive mill wastewater (OMW), cheese whey (CW) and crude glycerol (CG) was studied in an attempt to improve biogas production of existing digesters at WWTPs. The effect of agro-industrial by-products in biogas production was investigated using a 220L pilot-scale (180L working volume) digester under mesophilic conditions (35°C) with a total feeding volume of 7.5L daily and a 24-day hydraulic retention time. The initial feed was sewage sludge and the bioreactor was operated using this feed for 40days. Each agro-industrial by-product was then added to the feed so that the reactor was fed continuously with 95% sewage sludge and 5% (v/v) of each examined agro-industrial by-product. The experiments showed that a 5% (v/v) addition of OMW, CG or CW to sewage sludge significantly increased biogas production by nearly 220%, 350% and 86% as values of 34.8±3.2L/d, 185.7±15.3L/d and 45.9±3.6L/d respectively, compared to that with sewage sludge alone (375ml daily, 5% v/v in the feed). The average removal of dissolved chemical oxygen demand (d-COD) ranged between 72 and 99% for organic loading rates between 0.9 and 1.5kgVSm -3 d -1 . Reduction in the volatile solids ranged between 25 and 40%. This work suggests that methane can be produced very efficiently by adding a small concentration (5%) of agro-industrial by-products and especially CG in the inlet of digesters treating sewage sludge. Copyright © 2016 Elsevier Ltd. All rights reserved.

  12. Forecasting the potential of Danish biogas production

    DEFF Research Database (Denmark)

    Bojesen, Mikkel; Skov-Petersen, Hans; Gylling, Morten

    , except for those farms which are in the largest state class. Regional differences in development trends were documented. The strategic objective of the model is to provide data for the spatial assessment of the potential of biogas production which can form the basis for a location analysis for future...... biogas plants....

  13. Cultivation of vancomycin-resistant enterococci and methicillin-resistant staphylococci from input and output samples of German biogas plants.

    Science.gov (United States)

    Glaeser, Stefanie P; Sowinsky, Olivia; Brunner, Jana S; Dott, Wolfgang; Kämpfer, Peter

    2016-03-01

    Vancomycin-resistant enterococci (VRE) and methicillin-resistant staphylococci (MRS) were detected in two mesophilic German biogas plants (BGPs) using selective pre-enrichment methods combined with cultivation on CHROMagar media and antibiotic resistance gene screening. Genetic fingerprinting and 16S rRNA gene sequencing showed the presence of enterococci isolated by the VRE selective cultivation (67 isolates) in input and output samples of BGPs. In contrast, MRS (44 isolates) were detected in input, but in none of the output samples. Enterococcus isolates showed highest 16S rRNA gene sequence similarity (>99.8%) to E. lemanii, E. casseliflavus/E. gallinarium or E. devriesei/E. pseudoavium/E. viikkiensis and carried vanA, vanB and/or vanC1 genes. Enterococcus faecium and E. faecalis VRE were not detected, but isolates closely related to those species (>99.9% 16S rRNA gene sequence similarity) were detected by the MRS selective cultivation methods. Staphylococcus isolates shared highest 16S rRNA gene sequence similarity (>99.9%) with S. haemolyticus, S. lentus and S. sciuri and carried mecA genes. Methicillin-resistant S. aureus (MRSA) were not detected. In summary, manure from livestock husbandry contained both, VRE and MRS. VRE were also detected in output samples, indicating that enterococci with vancomycin resistance genes could be release into the environment by the application of BGP output material as biofertilizers. © FEMS 2016. All rights reserved. For permissions, please e-mail: journals.permissions@oup.com.

  14. Coal-water slurries containing petrochemicals to solve problems of air pollution by coal thermal power stations and boiler plants: An introductory review.

    Science.gov (United States)

    Dmitrienko, Margarita A; Strizhak, Pavel A

    2018-02-01

    This introductory study presents the analysis of the environmental, economic and energy performance indicators of burning high-potential coal water slurries containing petrochemicals (CWSP) instead of coal, fuel oil, and natural gas at typical thermal power stations (TPS) and a boiler plant. We focus on the most hazardous anthropogenic emissions of coal power industry: sulfur and nitrogen oxides. The research findings show that these emissions may be several times lower if coal and oil processing wastes are mixed with water as compared to the combustion of traditional pulverized coal, even of high grades. The study focuses on wastes, such as filter cakes, oil sludge, waste industrial oils, heavy coal-tar products, resins, etc., that are produced and stored in abundance. Their deep conversion is very rare due to low economic benefit. Effective ways are necessary to recover such industrial wastes. We present the cost assessment of the changes to the heat and power generation technologies that are required from typical power plants for switching from coal, fuel oil and natural gas to CWSPs based on coal and oil processing wastes. The corresponding technological changes pay off after a short time, ranging from several months to several years. The most promising components for CWSP production have been identified, which provide payback within a year. Among these are filter cakes (coal processing wastes), which are produced as a ready-made coal-water slurry fuel (a mixture of flocculants, water, and fine coal dust). These fuels have the least impact on the environment in terms of the emissions of sulfur and nitrogen oxides as well as fly ash. An important conclusion of the study is that using CWSPs based on filter cakes is worthwhile both as the main fuel for thermal power stations and boiler plants and as starting fuel. Copyright © 2017 Elsevier B.V. All rights reserved.

  15. Cost analysis of concepts for a demand oriented biogas supply for flexible power generation.

    Science.gov (United States)

    Hahn, Henning; Ganagin, Waldemar; Hartmann, Kilian; Wachendorf, Michael

    2014-10-01

    With the share of intermittent renewable energies within the electricity system rising, balancing services from dispatchable power plants are of increasing importance. Highlighting the importance of the need to keeping fuel costs for flexible power generation to a minimum, the study aims to identify favourable biogas plant configurations, supplying biogas on demand. A cost analysis of five configurations based on biogas storing and flexible biogas production concepts has been carried out. Results show that additional flexibility costs for a biogas supply of 8h per day range between 2€ and 11€MWh(-1) and for a 72h period without biogas demand from 9€ to 19€MWh(-1). While biogas storage concepts were identified as favourable short term supply configurations, flexible biogas production concepts profit from reduced storage requirements at plants with large biogas production capacities or for periods of several hours without biogas demand. Copyright © 2014 Elsevier Ltd. All rights reserved.

  16. Different organic loading rates on the biogas production during the anaerobic digestion of rice straw: A pilot study.

    Science.gov (United States)

    Zhou, Jun; Yang, Jun; Yu, Qing; Yong, Xiaoyu; Xie, Xinxin; Zhang, Lijuan; Wei, Ping; Jia, Honghua

    2017-11-01

    The aim of this work was to investigate the mesophilic methane fermentation of rice straw at different organic loading rates (OLRs) in a 300m 3 bioreactor. It was found that biogas production increased when the OLR was below 2.00kg VS substrate /(m 3 ·d). The average volumetric biogas production reached 0.86m 3 /(m 3 ·d) at an OLR of 2.00kg VS substrate /(m 3 ·d). Biogas production rate was 323m 3 /t dry rice straw over the whole process. The pH, chemical oxygen demand, volatile fatty acid, and NH 4 + -N concentrations were all in optimal range at different OLRs. High-throughput sequencing analysis indicated that Firmicutes, Fibrobacteres, and Spirochaetes predominated in straw samples. Chloroflexi, Proteobacteria, and Planctomycetes were more abundant in the slurry. The hydrogenotrophic pathway was the main biochemical pathway of methanogenesis in the reactor. This study provides new information regarding the OLR and the differences in the spatial distribution of specific microbiota in a rice straw biogas plant. Copyright © 2017 Elsevier Ltd. All rights reserved.

  17. BIOGAS STATIONS AND THEIR ENVIRONMENTAL IMPACTS

    Directory of Open Access Journals (Sweden)

    Vladimir Lapčik

    2011-12-01

    Full Text Available The article summarizes the authors’ experience with environmental impact assessment in branch of biogas plants. The introductory part of the paper describes legislative obligations of the Czech Republic concerning the fulfilment of the European Union’s limits as for utilization of renewable energy resources. The next parts of the paper deal with an impact analysis of biogas plants on the environment. The final part of the paper deals with experience with implementation of the environmental impact assessment process in the field of biogas plants in the Czech Republic.

  18. The production and use of biogas in 2012; Produktion och anvaendning av biogas aar 2012

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2013-07-01

    This report presents an annual survey on the production and use of biogas. The survey aims to provide policy makers, industry associations, researchers, journalists, municipalities and the general public information on annual production and use of biogas. Statistics are used as the basis for Sweden's overall reporting of renewable energy to the EU and as a basis in various government investigations. In the present study, a total of 242 biogas-production plants have been identified in Sweden. These produced a total of 1,589 GWh of energy. The 242 biogas-producing plants were distributed by 135 wastewater treatment plants, 55 landfills, 26 farm biogas plants, 21 co-digestion plants and five industrial plants. The main substrates for biogas production were different types of waste such as sewage sludge, manure, source separated food waste and waste from butchers and food industries. Energy crops constituted a very small fraction of the total substrate similarly no. The geographic distribution shows that most of the biogas production was centered in a few counties. Skaane, Stockholm and Vaestra Goetaland accounted for over 50 % of the country's biogas production.

  19. Biogas Production Using Anaerobic Biodigester from Cassava Starch Effluent

    Directory of Open Access Journals (Sweden)

    S. Sunarso

    2010-12-01

    Full Text Available IKMs’ factory activity in Margoyoso produces liquid and solid wastes. The possible alternative was to use the liquid effluent as biogas raw material. This study focuses on the used of urea, ruminant, yeast, microalgae, the treatment of gelled and ungelled feed for biogas production, pH control during biogas production using buffer Na2CO3, and feeding management in the semi-continuous process of biogas production that perform at ambient temperature for 30 days. Ruminant bacteria, yeast, urea, and microalgae was added 10% (v/v, 0.08% (w/v, 0.04% (w/v, 50% (v/v of mixing solution volume, respectively. The pH of slurry was adjusted with range 6.8-7.2 and was measured daily and corrected when necessary with Na2CO3. The total biogas production was measured daily by the water displacement technique. Biogas production from the ungelling and gelling mixture of cassava starch effluent, yeast, ruminant bacteria, and urea were 726.43 ml/g total solid and 198 ml/g total solid. Biogas production from ungelling mixture without yeast was 58.6 ml/g total solid. Biogas production from ungelling mixture added by microalgae without yeast was 58.72 ml/g total solid and that with yeast was 189 ml/g total solid. Biogas production from ungelling mixture of cassava starch effluent, yeast, ruminant bacteria, and urea in semi-continuous process was 581.15 ml/g total solid. Adding of microalgae as nitrogen source did not give significant effect to biogas production. But adding of yeast as substrate activator was very helpful to accelerate biogas production. The biogas production increased after cassava starch effluent and yeast was added. Requirement of sodium carbonate (Na2CO3 to increase alkalinity or buffering capacity of fermenting solution depends on pH-value

  20. Application of a qualitative image analysis on the evaluation of microbial process parameters of biogas plants; Einsatz einer quantitativen Bildanalyse zur Beurteilung mikrobieller Prozessparameter von Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Kim, Yong Sung; Scherer, Paul [Hamburg Univ. of Applied Sciences, Hamburg-Bergedorf (Germany). Faculty of Life Sciences

    2013-10-01

    To evaluate efficiency and microbial activity of biogas or anaerobic waste water treatment plants, the number of microorganisms per gram or per milliliter is supposed to be a crucial factor. Since some years ago our research group at HAW-Hamburg has struggled to develop a simple and rapid technique for quantification and classification of environmental microbes with a semi-automatic digital image analysis. For detection of methanogens, the methanogenic fluorescence coenzyme F420 was used, which represents the vitality of methanogens. Furthermore this technique has been supplemented with morphological classification resulting in a Quantitative Microscopic Fingerprinting (QMF). The technique facilitates to find out microbial reasons for some problems of reactor performances. In addition QMF allows differentiating between H{sub 2}-CO{sub 2} and acetate consuming methanogens according to their morphology. At the moment, this study focusses on some relationships between QMF and plant operation parameters. As an example, a thermophilic biogas plant fed by 65% liquid cow manure, maize silage, grass silage and solid cow manure was analyzed for more than 22 weeks. Here some basic background and methodical procedures were presented as well as validation of this technique. (orig.)

  1. Transferable antibiotic resistance plasmids from biogas plant digestates often belong to the IncP-1ε subgroup

    Directory of Open Access Journals (Sweden)

    Birgit eWolters

    2015-01-01

    Full Text Available Manure is known to contain residues of antibiotics administered to farm animals as well as bacteria carrying antibiotic resistance genes (ARGs. These genes are often located on mobile genetic elements. In biogas plants (BGPs, organic substrates such as manure and plant material are mixed and fermented in order to provide energy, and resulting digestates are used for soil fertilization. The fate of plasmid carrying bacteria from manure during the fermentation process is unknown. The present study focused on transferable antibiotic resistance plasmids from digestates of seven BGPs, using manure as a co-substrate, and their phenotypic and genotypic characterization. Plasmids conferring resistance to either tetracycline or sulfadiazine were captured by means of exogenous plasmid isolation from digestates into Pseudomonas putida KT2442 and Escherichia coli CV601 recipients, at transfer frequencies ranging from 10-5 to 10-7. Transconjugants (n = 101 were screened by PCR-Southern blot hybridization and real-time PCR for the presence of IncP-1, IncP-1ε, IncW, IncN, IncP-7, IncP-9, LowGC and IncQ plasmids. While 61 plasmids remained unassigned, 40 plasmids belonged to the IncP-1ε subgroup. All these IncP-1ε plasmids were shown to harbor the genes tetA, sul1, qacE∆1, intI1 and integron gene cassette amplicons of different size. Further analysis of 16 representative IncP-1ε plasmids showed that they conferred six different multiple antibiotic resistance patterns and their diversity seemed to be driven by the gene cassette arrays. IncP-1ε plasmids displaying similar restriction and antibiotic resistance patterns were captured from different BGPs, suggesting that they may be typical for this environment. Our study showed that BGP digestates are a potential source of transferable antibiotic resistance plasmids and in particular the broad host range IncP-1ε plasmids might contribute to the spread of ARGs when digestates are used as fertilizer.

  2. Production and use of biogas year 2009; Produktion och anvaendning av biogas aar 2009

    Energy Technology Data Exchange (ETDEWEB)

    2010-11-15

    In the present study, a total of 230 biogas-producing sites were identified. These produced a total of 1363 GWh of energy. The 230 biogas-producing plants were distributed in 136 sewage treatment plants, 57 landfills, 21 co-digestion plants, four industries and 12 farm sites. The number of upgrading plants amounted to 38 and at seven locations injection of upgraded biogas into the natural gas network took place. 44% of the biogas generated in sewage treatment plants, 25% were produced in landfills, 22% of co-digestion plants, 8% in industrial plants and 1% on farm installations. The total biogas production in 2009 was slightely higher than last year, but the division between the different plant types has changed. Production increased for co-digestion plants and farm installations, while production was relatively unchanged for sewage treatment plants. Production in landfills and industrial sites decreased compared with 2008. A larger proportion of the biogas came to use in 2009 compared with previous years. 667 GWh (49%) was used for heating, which also includes heat loss, 488 GWh (36%) were upgraded, 64 GWh (5%) of electricity was generated and 135 GWh (10%) was torched. The main substrates for biogas production were different types of waste such as sewage sludge, source separated food waste and waste from food industry. In addition to biogas, co-digestion plants and the farm plants together produced 537 403 tonnes (wet weight) biofertilizer, and the waste water treatment plants 214 000 tonnes (dry weight) sludge. The provincial breakdown shows that biogas production was greatest in metropolitan areas

  3. Biogas - the calculable energy

    Science.gov (United States)

    Kith, Károly; Nagy, Orsolya; Balla, Zoltán; Tamás, András

    2015-04-01

    EU actions against climate change are rising energy prices, both have emphasized the use of renewable energy,increase investments and energy efficiency. A number of objectives formulated in the EC decree no. 29/2009 by 2020. This document is based on the share of renewable energies in energy consumption should be increased to 20% (EC, 2009). The EU average is 20% but the share of renewables vary from one member state to another. In Hungary in 2020, 14.65% renewable energy share is planned to be achieved. According to the latest Eurostat data, the share of renewable energy in energy consumption of the EU average was 14.1%, while in Hungary, this share was 9.6% in 2012. (EUROSTAT, 2014). The use of renewable energy plant level is influenced by several factors. The most important of these is the cost savings and efficiency gains. Hungarian investments in renewable energy production usually have high associated costs and the payback period is substantially more than five years, depending on the support rate. For example, the payback period is also influenced by the green electricity generated feed prices, which is one of the lowest in Hungary compared the Member States of the European Union. Consequently, it is important to increase the production of green energy. Nowadays, predictable biogas energy is an outstanding type of decentralized energy production. It follows directly that agricultural by-products can be used to produce energy and they also create jobs by the construction of a biogas plant. It is important to dispose of and destroy hazardous and noxious substances in energy production. It follows from this that the construction of biogas plants have a positive impact, in addition to green energy which is prepared to reduce the load on the environment. The production of biogas and green electricity is one of the most environment friendly forms of energy production. Biogas production also has other important ecological effects, such as the substitution of

  4. The effect of maize silage as co-substrate for swine manure on the bacterial community structure in biogas plants

    Czech Academy of Sciences Publication Activity Database

    Fliegerová, Kateřina; Mrázek, Jakub; Kajan, M.; Podmirseg, S.M.; Insam, H.

    2012-01-01

    Roč. 57, č. 4 (2012), s. 281-284 ISSN 0015-5632 R&D Projects: GA ČR GPP503/10/P394; GA MZe QI92A286 Institutional research plan: CEZ:AV0Z50450515 Keywords : biogas * maize silage * swine manure Subject RIV: DM - Solid Waste and Recycling Impact factor: 0.791, year: 2012

  5. Implementation of online volatile fatty acids sensor for control and optimization of anaerobic process for low cost biogas production from manure. Project report

    Energy Technology Data Exchange (ETDEWEB)

    Boe, K.; Angelidaki, I.

    2010-10-15

    Proper monitoring and control can improve process stability and enhance process performance for better economy of the biogas plants. Volatile fatty acid (VFA) is the most widely recognized as a direct, relevant measure of stability. Classic on-line measurement of individual VFA is based on filtration, which suffers from fouling when applied with manure slurries. A VFA sensor developed at DTU Environment, based on headspace chromatography technique could avoid the problems from particulate matters. In this work, the sensor had been implemented for online monitoring of the lab-scale and the pilot-scale manure digester. The industrial prototype of the VFA sensor and sample acquisition system has been constructed and implemented at a pilot scale biogas plant, located at Lundtofte, DTU. The VFA sensor has shown very satisfying results in terms of sensitivity and reliability for monitoring the biogas process. Moreover, the online VFA and biogas registration data were used as process indicators for automatic control of the biogas reactor. The results from control experiments confirmed that the combination of biogas production, total VFA concentration and propionate concentration could effectively reflect the dynamic state of the process which was very crucial for automatic control. Due to the standardized analyzing condition (pH<2, temperature>70 deg. C), the sensor responses were not affected by the manure composition (TS, VS or the addition of extra organics), which made these results representative for implementing in the full-scale biogas plant where some industrial organic wastes were added to increase the biogas production. During the project period, the sensor design and construction had been modified and tested several times to improve the robustness. However, the implementation of the sensor in full-scale biogas plant would need some further development such as improvement of mechanical design and further up-scaling depending on the dry solid content in the

  6. Hygienic aspects of livestock manure management and biogas systems operated by small-scale pig farmers in Vietnam

    DEFF Research Database (Denmark)

    Luu, Huong Quynh; Madsen, Henry; Anh, Le Xuan

    2014-01-01

    in effluent as compared with raw slurry. Biogas effluent was commonly used to fertilize vegetables or discharged directly into the garden or aquatic recipients. Reduced problems with bad smells and flies were reported as main reasons for establishing a biogas digester. Further studies are needed to assess...

  7. Use of the effluent from biogas production for cultivation of Spirulina.

    Science.gov (United States)

    Hultberg, Malin; Lind, Olle; Birgersson, Göran; Asp, Håkan

    2017-04-01

    The effluent from the biogas process was tested as a nutrient source during cultivation of the protein-rich and edible microalgae Spirulina (Arthrospira platensis) and compared with conventional Spirulina medium. Equal biomass production was observed until late exponential phase and no significant differences could be observed between the treatments in protein amount, amino acid composition, and total lipid concentration. The concentration of the pigment phycocyanin differed significantly between Spirulina medium and the effluent-based medium (63.3 ± 11.7 and 86.2 ± 1.9 mg g -1 , respectively). Slightly higher concentrations of saturated fatty acids, mainly palmitic acid, were observed in the biomass produced in Spirulina medium than in that produced in the effluent-based medium. In the biomass produced in the effluent-based medium, the cadmium concentration was 0.07 ± 0.05 mg kg -1 of dry weight, whereas it was below the detection limit in the biomass produced in Spirulina medium. There is a need to identify new food and feed resources and a possible future scenario is to integrate Spirulina production into the biogas plant for protein production as it contains more than 60% of protein on dry weight basis. In that scenario, it is important to control heavy metal concentrations in the biogas slurry fed to Spirulina.

  8. Solar Biogas Digester with Built-In Reverse Absorber Heater

    Directory of Open Access Journals (Sweden)

    Khasan S. Karimov

    2013-01-01

    Full Text Available In this work the design, fabrication and investigation of a solar biogas digester with built-in RAH (Reverse Absorber Heater is presented. The maximum temperature (50 o C inside of the methane tank was taken as a main parameter at the design of the digester. Using energy balance equation for the case of a static mass of fluid being heated; the parameters of thermal insulation of the methane tank were counted. The biogas digester is consisting of methane tank with built-in solar RAH to utilize solar energy for the heating of the slurry prepared from the different organic wastes (dung, sewage, food wastes etc. The methane tank was filled up to 70% of volume by organic wastes of the GIK Institute sewage, firstly, and secondly, by sewage and cow dung as well. During three months (October-December, 2009 and two months (February-March, 2010 the digester was investigated. The solar irradiance incident to the absorber, slurry's temperature and ambient temperature were measured. It was found that using sewage only and sewage with cow dung the retention times was 4 weeks and two weeks respectively and biogas quantity produced was 0.4 and 8.0 m 3 respectively. In addition, biogas upgradation scheme for removal of carbon dioxide, hydrogen sulphide and water vapor from biogas and conversion of biogas energy conversion into electric power is also discussed.

  9. Persistence of Mycobacterium avium subsp. paratuberculosis at a Farm-Scale Biogas Plant Supplied with Manure from Paratuberculosis-Affected Dairy Cattle▿

    Science.gov (United States)

    Slana, I.; Pribylova, R.; Kralova, A.; Pavlik, I.

    2011-01-01

    In this study, products from all steps of anaerobic digestion at a farm-scale biogas plant supplied with manure from paratuberculosis-affected dairy cattle were examined and quantified for the presence of the causal agent of paratuberculosis, Mycobacterium avium subsp. paratuberculosis, using culture and quantitative real-time PCR (qPCR). Viable M. avium subsp. paratuberculosis cells were detected using culture in fermentors for up to 2 months; the presence of M. avium subsp. paratuberculosis DNA (101 cells/g) was demonstrated in all anaerobic fermentors and digestate 16 months after initiation of work at a biogas plant, using IS900 qPCR. F57 qPCR was able to detect M. avium subsp. paratuberculosis DNA (102 cells/g) at up to 12 months. According to these results, a fermentation process that extended beyond 2 months removed all viable M. avium subsp. paratuberculosis cells and therefore rendered its product M. avium subsp. paratuberculosis free. However, M. avium subsp. paratuberculosis DNA was found during all the examined periods (more than 1 year), which could be explained by either residual DNA being released from dead cells or by the presence of viable cells whose amount was under the limit of cultivability. As the latter hypothesis cannot be excluded, the safety of the final products of digestion used for fertilization or animal bedding cannot be defined, and further investigation is necessary to confirm or refute this risk. PMID:21398476

  10. Farm scale biogas concepts in Europe

    Energy Technology Data Exchange (ETDEWEB)

    Wellinger, A. [Nova Energie, Ettenhausen (Switzerland)

    1997-08-01

    The near future of farm scale biogas production looks bright as long as the high electricity prices are maintained by political will and subsidies remain higher than approx. 20%. If in all the number of biogas plants is growing as it is in Germany (Within the last two years about 200 new plants have been built) then biogas will add its share to a nuclear power free electricity production, as does wind energy in Germany, Holland or Denmark. The standard for manure digesters is set. There is still some way to go for solid waste digesters. However, first inputs have been given. (EG) 10 refs.

  11. PROSPECTS FOR THE DEVELOPMENT OF THE AGRICULTURAL BIOGAS SECTOR IN POLAND

    Directory of Open Access Journals (Sweden)

    Magdalena Zubrzycka

    2017-03-01

    Full Text Available This article presents the legal regulations relating to Renewable Energy Sources, including the biogas sector. It discusses biogas production technologies, the current state and perspectives of agricultural biogas production in Poland, the production capabilities of Polish biogas plants and factors contributing to the attractiveness of the biogas sector. The following economic and ecological aspects of biogas production were considered in the study: profitability and environmental impacts, including reduction in carbon dioxide emissions. Despite numerous problems, the Renewable Energy Sources Act provides an opportunity for the growth and development of the biogas industry in Poland.

  12. Nonlinear Autoregressive Exogenous modeling of a large anaerobic digester producing biogas from cattle waste.

    Science.gov (United States)

    Dhussa, Anil K; Sambi, Surinder S; Kumar, Shashi; Kumar, Sandeep; Kumar, Surendra

    2014-10-01

    In waste-to-energy plants, there is every likelihood of variations in the quantity and characteristics of the feed. Although intermediate storage tanks are used, but many times these are of inadequate capacity to dampen the variations. In such situations an anaerobic digester treating waste slurry operates under dynamic conditions. In this work a special type of dynamic Artificial Neural Network model, called Nonlinear Autoregressive Exogenous model, is used to model the dynamics of anaerobic digesters by using about one year data collected on the operating digesters. The developed model consists of two hidden layers each having 10 neurons, and uses 18days delay. There are five neurons in input layer and one neuron in output layer for a day. Model predictions of biogas production rate are close to plant performance within ±8% deviation. Copyright © 2014 Elsevier Ltd. All rights reserved.

  13. Renewable Hydrogen Potential from Biogas in the United States

    Energy Technology Data Exchange (ETDEWEB)

    Saur, G.; Milbrandt, A.

    2014-07-01

    This analysis updates and expands upon previous biogas studies to include total potential and net availability of methane in raw biogas with respect to competing demands and includes a resource assessment of four sources of biogas: (1) wastewater treatment plants, including domestic and a new assessment of industrial sources; (2) landfills; (3) animal manure; and (4) a new assessment of industrial, institutional, and commercial sources. The results of the biogas resource assessment are used to estimate the potential production of renewable hydrogen from biogas as well as the fuel cell electric vehicles that the produced hydrogen might support.

  14. High-temperature pretreatment of biogas substrate by using district heating to increase the biogas production; Hoegtemperaturfoerbehandling av biogassubstrat med fjaerrvaerme foer oekad biogasproduktion

    Energy Technology Data Exchange (ETDEWEB)

    Del Pilar Castillo, Maria; Ascue, Johnny [JTI, Uppsala (Sweden); Olsson, Marcus; Henriksson, Gunilla; Nordman, Roger [SP, Boraas (Sweden)

    2011-12-15

    In this study, we have shown that pre-heating sludge from a waste water treatment plant can give a higher biogas production rate. However, pretreatment showed no effect on substrate from a biogas plant at the conditions tested in this study. The study has also shown that there is potential of using district heating in the biogas industry for thermal pretreatment of sludge.

  15. Hygienic aspects of livestock manure management and biogas systems operated by small-scale pig farmers in Vietnam.

    Science.gov (United States)

    Huong, Luu Quynh; Madsen, Henry; Anh, Le Xuan; Ngoc, Pham Thi; Dalsgaard, Anders

    2014-02-01

    Biogas digesters are widely promoted and increasingly used to treat and generate gas from pig slurry worldwide. The objective of this study was to describe manure management practices with focus on biogas digestion among small scale pig farmers in Hue (50 farmers) and Hanoi (96 farmers) and to assess fecal contamination levels in biogas effluent. Results showed that 84% of the farmers in Hanoi and 42% in Hue used both pig slurry and human excreta for biogas production. Biogas digestion only reduced E. coli concentrations by 1 to 2 log units to 3.70 ± 0.84 Escherichia coli (log10) cfu/ml on average in effluent as compared with raw slurry. Biogas effluent was commonly used to fertilize vegetables or discharged directly into the garden or aquatic recipients. Reduced problems with bad smells and flies were reported as main reasons for establishing a biogas digester. Further studies are needed to assess human and animal health hazards associated with the discharge and use of biogas effluent from small-scale biogas systems. © 2013.

  16. Methane oxidation in industrial biogas plants-Insights in a novel methanotrophic environment evidenced by pmoA gene analyses and stable isotope labelling studies.

    Science.gov (United States)

    May, Tobias; Polag, Daniela; Keppler, Frank; Greule, Markus; Müller, Liane; König, Helmut

    2018-03-20

    A broad methanotrophic community consisting of 16 different operational taxonomic units (OTUs) was detected by particulate methane monooxygenase A (pmoA) gene analyses of reactor sludge samples obtained from an industrial biogas plant. Using a cloning-sequencing approach, 75% of the OTUs were affiliated to the group of type I methanotrophs (γ-Proteobacteria) and 25% to type II methanotrophs (α-Proteobacteria) with a distinct predominance of the genus Methylobacter. By database matching, half of the total OTUs may constitute entirely novel species. For evaluation of process conditions that support growth of methanotrophic bacteria, qPCR analyses of pmoA gene copy numbers were performed during a sampling period of 70 days at varying reactor feeding scenarios. During the investigation period, methanotrophic cell counts estimated by qPCR fluctuated between 3.4 × 10 4 and 2 × 10 5 cells/mL with no distinct correlation to the organic loading rate, the amount of CH 4 , O 2 and NH 4 -N. Methanotrophic activity was proofed even at low O 2 levels (1%) by using stable carbon isotope labelling experiments of CH 4 in batch experiments inoculated with reactor sludge. Supplementation of 13 C labelled CH 4 in the headspace of the reaction vials unambiguously confirmed the formation of 13 C labelled CO 2 . Thus, industrial biogas reactors can be considered as a further methanotrophic habitat that exhibits a unique methanotrophic community which is specifically adapted to high CH 4 and low O 2 concentrations. To the best of our knowledge, our study is the first accurate detection and quantification of methanotrophic bacteria in industrial biogas reactors. Copyright © 2018 Elsevier B.V. All rights reserved.

  17. Biogas upgrading to biomethane. Proceedings; Biogasaufbereitung zu Biomethan. Tagungsband

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2008-12-05

    Within the 6th Hanauer Dialogue 'Biogas upgrading to biomethane' at 21st February, 2008, the following lectures were held: (a) Processing of biogas - an introduction (Michael Beil); (b) The climate protecting targets of the Federal Republic of Germany: Which role will play the upgrading of biogas, and which legal boundary conditions are created by the Federal Government? (Uwe Holzhammer); (c) Future strategy: CH{sub 4} grids (Juergen Schmid); (d) Biogas upgrading and biomethane utilization in Sweden (Anneli Petersson); (e) Biogas upgrading and utilization of bio methane in Switzerland (Arthur Wellinger); (f) Biogas upgrading by means of pressure swing adsorption (Alfons Schulte-Schulze Berndt); (g) Biogas upgrading by means of pressurized water washing (Ulf Richter); (h) Biogas upgrading for feeding in public grids. The case of biogas plant Bruck a.d. Leitha (Michael Harasek); (i) Biogas upgrading by means of chemical absorption according to the LP Cooab process (Jerome van Beek); (j) Practical experiences in unpressurized amine washing MT bio methane (Karsten Wuensche); (k) Biogas upgrading by means of organic physical washing with HAASE biogas amplifiers (Roland Kahn); (l) Upgrading using cryogenic technology; the GPP registered -system (Jeroen de Pater); (m) Micro Gas Distribution Systems: Alternatives to biogas upgrading and grid injection (Michael Beil, Bernd Krautkremer); (n) Feeding of exchange gas. The case of project Straelen and Kerpen (Frank Schaefer); (o) Feeding of biogas from the view of grid operators (Norbert Nordmeyer); BIOGASMAX: Biogas as Vehicle Fuel - Market Expansion to 2020 Air Quality (Michael Beil, Uwe Hoffstede); (p) Study: Feeding of biogas into the natural gas distribution system (Fachagentur Nachwachsende Rohstoffe).

  18. Biogas production from catch crops

    DEFF Research Database (Denmark)

    Molinuevo-Salces, Beatriz; Larsen, Søren U.; Ahring, Birgitte Kiær

    2013-01-01

    Manure-based biogas plants in Denmark are dependent on high yielding biomass feedstock in order to secure economically feasible operation. The aim of this study was to investigate the potential of ten different catch crop species or mixtures as feedstock for biogas production in co......, being in the ranges of 1.4–3.0 t ha−1 and 0.3–1.7 t ha−1 for Holstebro and Aabenraa, respectively. Specific methane yields were in the range of 229–450 m3 t−1 of VS. Methane yields per hectare of up to 800 m3 ha−1 were obtained, making catch crops a promising source of feedstock for manure-based biogas...

  19. Methanogenesis in Thermophilic Biogas Reactors

    DEFF Research Database (Denmark)

    Ahring, Birgitte Kiær

    1995-01-01

    Methanogenesis in thermophilic biogas reactors fed with different wastes is examined. The specific methanogenic activity with acetate or hydrogen as substrate reflected the organic loading of the specific reactor examined. Increasing the loading of thermophilic reactors stabilized the process...... as indicated by a lower concentration of volatile fatty acids in the effluent from the reactors. The specific methanogenic activity in a thermophilic pilot-plant biogas reactor fed with a mixture of cow and pig manure reflected the stability of the reactor. The numbers of methanogens counted by the most...... against Methanothrix soehngenii or Methanothrix CALS-I in any of the thermophilic biogas reactors examined. Studies using 2-14C-labeled acetate showed that at high concentrations (more than approx. 1 mM) acetate was metabolized via the aceticlastic pathway, transforming the methyl-group of acetate...

  20. A biogas plant for the digestion of distillery residue in combination with waste water treatment; Biogasanlage fuer die Vergaerung von Destillationsrueckstaenden in Kombination mit der Abwasserreinigung

    Energy Technology Data Exchange (ETDEWEB)

    Voigtlaender, A.; Vetter, H.

    2001-07-01

    This report for the Swiss Federal Office of Energy (SFOE) describes a project at a Swiss food-processing company that produces fruit juices and beverages containing fruit components. The company uses an anaerobic pre-treatment plant to treat effluents before they are discharged to a local municipal waste water treatment plant (WWTP). The report describes the installation, which generates biogas that is used to provide heating energy for the processes used in the extraction process. The monitoring and measurement system is described and figures are quoted for energy production in the company's facilities. Also, the energy savings in the local WWTP resulting from the reduced energy consumption of the aeration blowers as a result of the pre-treatment of the wastes are discussed. Operational aspects of the installation are examined. including temperature effects on the digestion process, control strategies and waste air treatment.

  1. A review of the biogas industry in China

    International Nuclear Information System (INIS)

    Jiang Xinyuan; Sommer, Sven G.; Christensen, Knud V.

    2011-01-01

    This article presents an overview of the development and future perspectives of the Chinese biogas industry. The development of the industry has the potential to improve the rural environment and produce significant amounts of sustainable energy for China. Barriers to the development are the relatively weak environmental policies, imperfect financial policies and lack of long-term follow-up services. The rapid economic development of China has also seen a development in the scales of biogas plants constructed. Although the technology has been improved, this review has identified problems in the construction and operation of Chinese biogas plants, particularly in the efficiency of household systems. All levels of China's government acknowledge this and recent biogas projects have more focus on quality and less on the quantity. The intention is to gradually introduce stricter environmental policies, to provide better service systems, improve the financial policies that support the construction and follow-up service of biogas projects, promote the use of standardized engineering equipment and materials and standards for plant construction and production. This will promote the development of biogas projects at various scales further, and reduce the dependency on fossil fuels and emissions of greenhouse gases. - Highlights: → The biogas industry in China has great developing potential and necessity. → Barriers to the development of biogas industry in China were included in the article. → All scales of Biogas plants in China have developed rapidly in recent years. → Measures to promote the development of biogas projects further in China were proposed.

  2. Improvement of the Biogas Production Process : Explorative project (EP1)

    OpenAIRE

    Karlsson, Anna; Björn, Annika; Sepehr, Shakeri Yekta; Svensson, Bo

    2014-01-01

    There are several ways to improve biogas production in anaerobic digestion processes and a number of strategies may be chosen. Increased organic loading in existing plants will in most cases demand the introduction of new substrate types. However, to substantially increase the Swedish biogas production new, large-scale biogas plants digesting new substrate types need to be established. Better utilization of existing digester volumes can be linked to:  Increase of organic loading rates and/or ...

  3. Availability of phosphorus in cow slurry using isotopic labelling technique

    International Nuclear Information System (INIS)

    Pongsakul, P.; Bertelsen, F.; Gissel-Nielsen, G.

    1988-01-01

    A pot experiment was conducted to evaluate the influence of cow slurry on P uptake by corn and to estimate the readily available P in the slurry by using an isotopic labelling techique. Water-soluble P in soil was increased and isotopic equilibrium of available P was attained after labelled slurry was mixed thoroughly throughout the soil. Labelled slurry applied at planting increased the P uptake by corn, whereas the same amount applied one week before harvest did not affect the P uptake. It was estimated that 46-54% of the total P uptake in plants is derived from the slurry. The readily available P (the L-value) in the slurry was at least 26 mg/kg which equals 3.7% of the total P. (author)

  4. Energetic, exergetic, thermoeconomic and environmental analysis of various systems for the cogeneration of biogas produced by an urban wastewater treatment plant UWTP

    Energy Technology Data Exchange (ETDEWEB)

    Coble, J.J. [Nebrija Univ., Madrid (Spain). Industrial Engineering Dept.; Contreras, A. [Industrial Engineering College, Madrid (Spain). Chemistry Dept.

    2010-07-01

    General awareness that the world's energy resources are limited has meant that it is increasingly important to examine energy-saving devices and fuels more closely, in order to use our limited available resources in a more sustainable manner. With this in mind, we studied biogas from a UWTP, because it is a renewable fuel with a neutral contribution to CO2 emissions. We compared two technologies for using biogas as an energy source: cogeneration using either motor-generators or phosphoric acid fuel cells. The comparison was made from the energetic, exergetic, thermo-economic and environmental points of view, internalizing all the costs involved in each case. We used data supplied by the UWTP at the City of Madrid Plant Nursery, which uses motor-generators, and the UWTPs in Portland, Oregon, and in Red Hook, New York, which use a phosphoric acid fuel cell. The joint work carried out has been divided into three parts for publication purposes, and we present here the first of these, which refers to the energy analysis. (orig.)

  5. The bypass solution as a capacity enhancing measure in connecting biogas plants to the grid; Die Bypass-Loesung als kapazitaetserhoehende Massnahme beim Netzanschluss von Biogasanlagen

    Energy Technology Data Exchange (ETDEWEB)

    Grassmann, Nils [PwC Legal AG, Frankfurt am Main (Germany). Bereich Energierecht in der Region Sued; Reinhardt, Anja [PwC Legal AG, Muenchen (Germany)

    2012-07-01

    In spite of repeated amendments to the laws governing the connection of biogas plants to the grid there still remain unresolved disputes in practice. A significant issue in this regard concerns what is referred to as the bypass solution, where a connection to the general supply grid of the receiving grid operator is created and at the same time technical equipment is installed which provides a connection to an upstream grid to which biogas can be backfed in times of low grid load. The Upper Regional Court of Duesseldorf classifies constellations of this kind as a combined grid connection to two different grids. It argues that since the legislature has provided no regulations on this constellation there can be no legitimate right to obtaining a connection of this configuration. However, this line of argumentation does not appear compelling. The meaning and purpose of Articles 31 ff. of the Gas Network Access Ordinance and the wording of the relevant norms both speak in favour of considering bypass solutions as capacity-enhancing measures. The receiving (downstream) grid operator would then be obliged, under the general requirements, to create a grid connection and to draw the bypass solution into consideration as a special means of backfeeding. This would provide legal certainty for all involved and allow technically meaningful solutions to be implemented.

  6. BIOCONVERSION OF CELLULOSE INTO HYDROGEN, BIOGAS AND ORGANIC ACIDS USING MICROBIAL CONSORTIUM FROM A PULP AND PAPER MILL WASTEWATER TREATMENT PLANT

    Directory of Open Access Journals (Sweden)

    Camila Abreu B. Silva Rabelo

    Full Text Available This study evaluated the potential of a microbial consortium collected from a pulp and paper mill wastewater treatment plant (WWTP for converting cellulose to hydrogen, biogas and organic acids. Fermentation tests were conducted in batch reactors fed with different concentrations of cellulose as substrate: (C1 2.0 g L -1; (C2 5.0 g L -1 and (C3 10.0 g L -1. The parameters investigated were hydrogen, biogas, organic acids, carbohydrates and pH. The maximum hydrogen production was 14.77, 39.25 and 22.53 mmol L -1, and the maximum methane was 4.40, 3.72 and 9.56 mmol L -1, for C1, C2 and C3, respectively. Butyric acid was the main metabolite generated, with maximum concentrations of 2.2, 1.8 and 2.2 g L -1 for C1, C2 and C3, respectively. The decrease in hydrogen production was accompanied by the production of methane, acetic acid and hydrogen sulfide in the three tests, probably related to hydrogenotrophic methanogenesis, homoacetogenesis and sulfidogenesis, respectively. The phylogenetic characterization of the bacterial community was performed by cloning and sequencing analysis. The microorganisms identified in the consortium were similar (> 95% to Clostridium sp., Klebsiella sp., Routella sp. and Desulfovibrio sp. These genera were associated with hydrogen production, degradation of cellulosic substrates, and/or hydrogen-consuming microorganisms.

  7. Biogas from algae, seaweed and seagrass?; Biogas aus Algen, Tang und Seegras?

    Energy Technology Data Exchange (ETDEWEB)

    Schneider, Holger [Fachhochschule Flensburg (Germany)

    2011-07-01

    Algae, seaweed and sea grass are discussed again and again as alternative sources for raw materials for agricultural biogas plants. The author of the contribution under consideration reports on the identification and optimization of the biogas potential of microalgae, macroalgae and flotsam (mixture of seaweed, seaweed, and so on). Algae, seaweed and sea grass can be fermented into biogas by means of an anaerobic process. The specific yield of biogas is small. The processing of these substrates requires a technical adjustment of the biogas plants. Thus, the effective use of these substrates will continue to fall. The achievable benefit highly depends on the location of the facilities and on the available substrates with the corresponding specific gas yields. The economic efficiency of these substrates in agricultural systems must be examined in each case.

  8. Identification and genome reconstruction of abundant distinct taxa in microbiomes from one thermophilic and three mesophilic production-scale biogas plants.

    Science.gov (United States)

    Stolze, Yvonne; Bremges, Andreas; Rumming, Madis; Henke, Christian; Maus, Irena; Pühler, Alfred; Sczyrba, Alexander; Schlüter, Andreas

    2016-01-01

    Biofuel production from conversion of biomass is indispensable in the portfolio of renewable energies. Complex microbial communities are involved in the anaerobic digestion process of plant material, agricultural residual products and food wastes. Analysis of the genetic potential and microbiology of communities degrading biomass to biofuels is considered to be the key to develop process optimisation strategies. Hence, due to the still incomplete taxonomic and functional characterisation of corresponding communities, new and unknown species are of special interest. Three mesophilic and one thermophilic production-scale biogas plants (BGPs) were taxonomically profiled using high-throughput 16S rRNA gene amplicon sequencing. All BGPs shared a core microbiome with the thermophilic BGP featuring the lowest diversity. However, the phyla Cloacimonetes and Spirochaetes were unique to BGPs 2 and 3, Fusobacteria were only found in BGP3 and members of the phylum Thermotogae were present only in the thermophilic BGP4. Taxonomic analyses revealed that these distinctive taxa mostly represent so far unknown species. The only exception is the dominant Thermotogae OTU featuring 16S rRNA gene sequence identity to Defluviitoga tunisiensis L3, a sequenced and characterised strain. To further investigate the genetic potential of the biogas communities, corresponding metagenomes were sequenced in a deepness of 347.5 Gbp in total. A combined assembly comprised 80.3 % of all reads and resulted in the prediction of 1.59 million genes on assembled contigs. Genome binning yielded genome bins comprising the prevalent distinctive phyla Cloacimonetes, Spirochaetes, Fusobacteria and Thermotogae. Comparative genome analyses between the most dominant Thermotogae bin and the very closely related Defluviitoga tunisiensis L3 genome originating from the same BGP revealed high genetic similarity. This finding confirmed applicability and reliability of the binning approach. The four highly covered

  9. The economics of biogas in Denmark

    DEFF Research Database (Denmark)

    Jacobsen, Brian H.; Laugesen, Frederik Møller; Dubgaard, Alex

    2014-01-01

    Denmark has been one of the leading European Countries in using Biogas for Combined Heat and Power (CHP), since the 1980s. However, in the last two decades, the increase has been limited. A new energy policy aimed at increasing the profitability of biogas was introduced in the spring of 2012....... The analysis here shows that the new agreement will improve the profitability of biogas plants and increase the biogas production although the political ambition of an increase from 4 PJ to 17 PJ by 2020 seems unlikely. The analysis shows that biogas plants can be profitable even if the input is a mix....... The analysis shows that the profit from upgrading biogas is only to be preferred if the sales price of heat or the amount sold are relatively low. The socioeconomic analyses show that the costs of biogas as a measure to reduce CO2 emissions are around €151 per tonne CO2 (€85‐266 per ton) and that using maize...

  10. Design of laboratory cyclone separator for biogas purification

    Directory of Open Access Journals (Sweden)

    Marián Fodora

    2013-01-01

    Full Text Available This article deals with calculation of a cyclone separator for biogas purification using physical and chemical methods. There is presented a methodology for determination of operating dimensions of the cyclone separator and description of principal features of the cyclone separator model. Calculations have been performed for the diameter of the cylindrical part of cyclone separator 175 mm and for the biogas volume flow rate 6.9∙10−5 m3∙s−1. The calculations can be used in practice for the design of cyclone separator depending on the flow rate of biogas, size of the biogas plants respectively. The developed cyclone separator has been used for the cleaning of biogas in operating conditions at the biogas plant in Kolinany (Slovakia. The presented method of biogas purification has been used for the removing of hydrogen sulphide, particulate matter and carbon dioxide from the raw biogas at the biogas plant. Removal of these undesirable impurities from the biogas is an important step in the production of a fully valued fuel, biomethane.

  11. Biogas Digester with Simple Solar Heater

    Directory of Open Access Journals (Sweden)

    Kh S Karimov

    2012-10-01

    Full Text Available ABSTRACT: In this research work, the design, fabrication and investigation of a biogas digester with simple solar heater are presented. For the solar heater, a built-in reverse absorber type heater was used. The maximum temperature (50°C inside the methane tank was taken as a main parameter for the design of the digester. Then, the energy balance equation for the case of a static mass of fluid being heated was used to model the process. The parameters of thermal insulation of the methane tank were also included in the calculations. The biogas digester consisted of a methane tank with built-in solar reverse absorber heater to harness the radiant solar energy for heating the slurry comprising of different organic wastes (dung, sewage, food wastes etc.. The methane tank was initially filled to 70% of its volume with organic wastes from the GIK institute’s sewage. The remaining volume was filled with sewage and cow dung from other sources. During a three month period (October-December, 2009 and another two month period (February-March, 2010, the digester was investigated. The effects of solar radiation on the absorber, the slurry’s temperature, and the ambient temperature were all measured during these investigations. It was found that using sewage only and sewage with cow dung in the slurry resulted in retention times of four and two weeks, respectively. The corresponding biogas produced was 0.4 m3 and 8.0 m3, respectively. Finally, this paper also elaborates on the upgradation of biogas through the removal of carbon dioxide, hydrogen sulphide and water vapour, and also the process of conversion of biogas energy into electric powerABSTRAK: Kajian ini membentangkan rekabentuk, fabrikasi dan penyelidikan tentang pencerna biogas dengan pemanas solar ringkas. Sebagai pemanas solar, ia dilengkapkan dengan penyerap pemanas beralik. Suhu maksimum(50oC di dalam tangki metana telah diambil sebagai parameter utama rekabentuk pencerna. Dengan menggunakan

  12. Biogas in agriculture. Status and prospects. Proceedings; Biogas in der Landwirtschaft. Stand und Perspektiven. Tagungsband

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2011-07-01

    Within the congress of the Agency for Renewable Resources (Guelzow, Federal Republic of Germany) and the Association for Technology and Structures in Agriculture (Darmstadt, Federal Republic of Germany) at 20th-21st September, 2011 in Goettingen (Federal Republic of Germany) the following lectures and posters were presented: (1) Perspectives of using biogas as a part of the German power supply (Stefan Rauh); (2) Development of biogas in Europe (Marc Fleureck); (3) Biology of methanogenic archaea and its significance for the microbial process control in biogas plants (Helmut Koenig); (4) Efficiency and behaviour of enzymes in the biogas process (Monika Heiermann); (5) Trace elements in NaWaRo biogas plants for balancing substrate limited deficiency symptoms and stabilizing the fermentation process (Hans Oechsner); (6) EEG - Actual developments for biogas (Ulrich Keymer); (7) Utilization of thermal energy from cogeneration in the practice - Experiences from the view of an environmental expert (Michael Hub); (8) Innovations in the legal aspects of the production and utilization of biogas (Hartwig von Bredow); (9) Damages and deficiencies at biogas plants (Waldemar Gruber); (10) Learning from accidents, damages and their causes as well as their correctives in the operation of biogas plants - Reports from the practice (Wolfgang Horst Stachowitz); (11) Causes and avoidance of container damages by means of biocorrosion (Jan Kuever); (12) Anaerobic degradation of cellulosic substrates - Bionic implementation of the forestomach sysem of a ruminant (Dirk Weichgrebe); (13) Fermentation of renewable raw materials in the up flow procedure (Jan Mumme); (14) Two-phase pressure fermentation for feeding into natural gas grids (Andreas Lemmer); (15) Requirements and potential of sugar beets for fermentation (Christa Hoffmann); (16) Innovation in the area of power beets (Andreas von Felde); (17) Optimization of manuring with fermentation residues in order to reduce the nitrogen

  13. Microwave and thermal pretreatment as methods for increasing the biogas potential of secondary sludge from municipal wastewater treatment plants

    DEFF Research Database (Denmark)

    Kuglarz, Mariusz; Karakashev, Dimitar Borisov; Angelidaki, Irini

    2013-01-01

    In the present study, the sludge was pretreated with microwave irradiation and low-temperature thermal method, both conducted under the same temperature range (30–100°C). Microwave pretreatment was found to be superior over the thermal treatment with respect to sludge solubilization and biogas pr...... experiments indicated that pre-treated sludge (microwave irradiation: 900W, temperature: 60–70°C) gave 35% more methane, compared to untreated sludge. Moreover, the results of this study clearly demonstrated that microwave pretreated sludge showed better degree of sanitation....

  14. 10. Biogas conference Dresden. Anaerobic treatment of biological wastes. Proceedings

    International Nuclear Information System (INIS)

    Dornack, Christina; Liebetrau, Jan; Fassauer, Burkhardt; Nelles, Michael

    2015-01-01

    The biogas conference in Dresden will be held for the tenth time and is still the only conference in Germany, which focuses on the production of biogas solely from waste. This year, the implementation of paragraph 11 of the Recycling and Waste Management Act and the amendment of the Renewable Energies Act (EEG) in 2014, the chances of the waste management biogas technology will be spotlighted here. The efficiency and wise use of the end products of the biogas production - the biogas and fermentation residues are equally critical for the success of biogas technology as the emission reduction of biogas plants. In this context, the biogas technology will also be dependent in the future on legal requirements and funding instruments such as the EEG. For the technical implementation, the development of reliable system concepts with specific sinking biogas and electricity supply costs and with greater flexibility in terms of launching needs-based biogas and electricity production. The contributions in this paper discuss possible solutions and implementations from the perspective of politics, associations, research and practice. Innovative topics will be discussed, which will be decisive for the future of biogas production from organic wastes. [de

  15. Investigation of thermal integration between biogas production and upgrading

    International Nuclear Information System (INIS)

    Zhang, Xiaojing; Yan, Jinying; Li, Hailong; Chekani, Shabnam; Liu, Loncheng

    2015-01-01

    Highlights: • Identify thermal characteristics of amine-based biogas upgrading for waste heat recovery. • Identify thermal characteristics of AD biogas production as sink for heat recovery. • Evaluation of thermal integration between biogas production and upgrading to improve overall energy efficiency. • Cost analysis applied for the economic feasibility of the thermal integration. • Using the principles of target design and system integration for connected thermal processes. - Abstract: Thermal integration of anaerobic digestion (AD) biogas production with amine-based chemical absorption biogas upgrading has been studied to improve the overall efficiency of the intergraded system. The thermal characteristics have been investigated for industrial AD raw biogas production and amine-based chemical absorption biogas upgrading. The investigation provides a basic understanding for the possibilities of energy saving through thermal integration. The thermal integration is carried out through well-defined cases based on the thermal characteristics of the biogas production and the biogas upgrading. The following factors are taken into account in the case study: thermal conditions of sub-systems, material and energy balances, cost issues and main benefits. The potential of heat recovery has been evaluated to utilise the waste heat from amine-based upgrading process for the use in the AD biogas production. The results show that the thermal integration has positive effects on improving the overall energy efficiency of the integrated biogas plant. Cost analysis shows that the thermal integration is economically feasible

  16. Economic, Environmental and Moral Acceptance of Renewable Energy: A Case Study-The Agricultural Biogas Plant at Pěčín.

    Science.gov (United States)

    Vochozka, Marek; Maroušková, Anna; Šuleř, Petr

    2018-02-01

    The production of renewable energy in agricultural biogas plants is being widely criticized because-among other things-most of the feedstock comes from purpose-grown crops like maize. These activities (generously subsidized in the Czech Republic) generate competitive pressure to other crops that are used for feeding or food production, worsening their affordability. Unique pretreatment technology that allows substitution of the purpose-grown crops by farming residues (such as husk or straw) was built 6 years ago on a commercial basis in Pěčín (Czech Republic) under modest funding and without publicity. The design of the concept; financial assessment and moral viewpoint were analyzed based on practical operating data. It showed that the apparatus improves economic, environmental and moral acceptance as well. However, according to the government's view, public funding for this type of processing was shortened, "because waste materials represent a lower cost". The impact of such governance was analyzed as well.

  17. Technical and economical analysis of concepts for using the heat of biogas plants in rural areas; Technische und betriebswirtschaftliche Analyse von Konzepten zur ganzjaehrigen Nutzung der Abwaerme einer Biogasanlage im dezentralen laendlichen Raum

    Energy Technology Data Exchange (ETDEWEB)

    Kaths, Friederike Annette

    2012-08-15

    Since the implementation of the EEG in Germany the biogas production becomes an independent branch of industry in the agriculture. At this time more than 90 percent of the biogas plants work with co-generation plant for heat and power with a thermal engine efficiencies of more than 50 percent. Because of the location in the rural area heat costumers with a continuous demand of heat over the whole year are rare. This research had a closer look how to use the heat of biogas production efficiently and also generating profit. The aim of the study was to use heat over the whole year, a profitable heat concept without counting the KWK-bonus and an added value on the farm. During the study the following concepts were analyzed: asparagus production using soil heating, drying equipment for different products, the production of fish in aquaculture, the poultry production and the heated production of tomatoes. The results showed different concepts using heat of biogas plants as efficient for farmers. However with only one concept the aims - to use the heat over the whole year, generating a profitable heat concept without counting the KWK-bonus, add an value on the farm - mostly can not be achieved. The combination of different heat concepts is necessary. In this analysis the poultry production in combination with the dryer can be considered as the most efficient concept. Bearing in mind the benefit which can be generated with a heat concept as well as the higher income and the higher technical efficiency of biogas plants operators should implement an individual concept for their heat.

  18. Biogas from lignocellulosic biomass

    Energy Technology Data Exchange (ETDEWEB)

    Berglund Odhner, Peter; Schabbauer, Anna [Grontmij AB, Stockholm (Sweden); Sarvari Horvath, Ilona; Mohseni Kabir, Maryam [Hoegskolan i Boraas, Boraas (Sweden)

    2012-01-15

    Grontmij AB has cooperated with the University of Boraas to evaluate the technological and economical possibilities for biogas production from substrates containing lignocellulose, such as forest residues, straw and paper. The state of knowledge regarding biogas production from cellulosic biomass has been summarized. The research in the field has been described, especially focusing on pretreatment methods and their results on increased gas yields. An investigation concerning commercially available pretreatment methods and the cost of these technologies has been performed. An economic evaluation of biogas production from lignocellulosic materials has provided answers to questions regarding the profitability of these processes. Pretreatment with steam explosion was economically evaluated for three feedstocks - wood, straw and paper - and a combination of steam explosion and addition of NaOH for paper. The presented costs pertain to costs for the pretreatment step as it, in this study, was assumed that the pretreatment would be added to an existing plant and the lignocellulosic substrates would be part of a co-digestion process. The results of the investigation indicate that it is difficult to provide a positive net result when comparing the cost of pretreatment versus the gas yield (value) for two of the feedstocks - forest residues and straw. This is mainly due to the high cost of the raw material. For forest residues the steam pretreatment cost exceeded the gas yield by over 50 %, mainly due to the high cost of the raw material. For straw, the production cost was similar to the value of the gas. Paper showed the best economic result. The gas yield (value) for paper exceeded the pretreatment cost by 15 %, which makes it interesting to study paper further.

  19. Appraisal of biogas potential of biogas from animal dung in saeedabad, pakistan

    International Nuclear Information System (INIS)

    Shah, A.A.; Sahito, A.R.

    2017-01-01

    Pakistan is facing energy scarcity. The biogas is one of the renewable substitutes. It does not only overcome the energy scarcity but also harness the energy from animal dung which causes the CO/sub 2/ emissions. The present study was done on the appraisal of potential of biogas from the dung of animals (Buffaloes, Cows, Goats and Sheep) within the villages surrounded by Taluka Saeedabad. The purpose of the study was the energy potential of the biogas and the selection of the most suitable design and size of the biogas plant for the villagers. The present study also includes the domestic biogas plant economics. As per the estimation, total quantity of animal dung generated was about 129 tons/day, which can produce 3859 m/sup 3/ of biogas per day. On the contrary, for cooking villagers require only 2748 m3 of biogas per day. Moreover, the surplus biogas of 1111 m/sup 3/ per day can be used to produce electricity of 6666 kWh per day, which can fulfill the demand of about half of the population of villages under study. People are using firewood, cotton stalks, kerosene oil and LPG (Liquefied Petroleum Gas) for cooking. Converting animal dung into the biogas not only reduces the consumption of the traditional fuels used (Firewood, Cotton Stalks, Kerosene Oil and LPG), but also prevents about 900 thousand tons of CO/sub 2/ emissions into the environment. Additionally, a fixed dome biogas plant of 8-10 m/sup 3/ size was recommended for each of the houses under study. (author)

  20. Appraisal of Biogas Potential of Biogas from Animal Dung in Saeedabad, Pakistan

    Directory of Open Access Journals (Sweden)

    AMJAD ALISHAH

    2017-07-01

    Full Text Available Pakistan is facing energy scarcity. The biogas is one of the renewable substitutes. It does not only overcome the energy scarcity but also harness the energy from animal dung which causes the CO2 emissions. The present study was done on the appraisal of potential of biogas from the dung of animals (Buffaloes, Cows, Goats and Sheep within the villages surrounded by Taluka Saeedabad. The purpose of the study was the energy potential of the biogas and the selection of the most suitable design and size of the biogas plant for the villagers. The present study also includes the domestic biogas plant economics. As per the estimation, total quantity of animal dung generated was about 129 tons/day, which can produce 3859 m3 of biogas per day. On the contrary, for cooking villagers require only 2748 m3 of biogas per day. Moreover, the surplus biogas of 1111 m3 per day can be used to produce electricity of 6666 kWh per day, which can fulfill the demand of about half of the population of villages under study. People are using firewood, cotton stalks, kerosene oil and LPG (Liquefied Petroleum Gas for cooking. Converting animal dung into the biogas not only reduces the consumption of the traditional fuels used (Firewood, Cotton Stalks, Kerosene Oil and LPG, but also prevents about 900 thousand tons of CO2 emissions into the environment. Additionally, a fixed dome biogas plant of 8-10 m3 size was recommended for each of the houses under study.

  1. Biogas from ley crops

    International Nuclear Information System (INIS)

    Dalemo, M.; Edstroem, M.; Thyselius, L.; Brolin, L.

    1993-01-01

    This report describes the cost of producing biogas from energy crops. Five process systems, sized 0.25-8 MW are studied. The cultivation of biogas-crops is made in three regions in Sweden. Also valued are the positive cultivation effects obtained when cereal dominated crop rotation is broken by biogas crops. 8 refs, 40 figs, 10 tabs

  2. Aspects of biogas utilisation

    International Nuclear Information System (INIS)

    Luning, L.

    1992-01-01

    Utilisation of biogas has received considerable attention over the last decade, its full potential has not been reached however. The paper discusses various options for utilisation of biogas and the limitations that may occur as far as they are associated with the characteristics of biogas. As a result the prospects for the future are presented. (au)

  3. Theoretical analysis of biogas potential prediction from agricultural waste

    Directory of Open Access Journals (Sweden)

    Spyridon Achinas

    2016-09-01

    Full Text Available A simplistic theoretical study of anaerobic digestion in order to predict the biogas amount of agricultural waste is proposed. A wide variety of models exist, but most of them rely on algebraic equations instead of biochemical equations and require many input parameters as well as computation time. This work provides a simplified model that predicts the biogas amount produced and could be applied for agricultural energy feasibility studies for instance dimensioning bioreactors digesting animal waste slurries. The method can be used for other feedstock materials and repeated for other similar applications, in an effort to expand anaerobic digestion systems as a clean energy source.

  4. Coal slurries: An environmental bonus?

    International Nuclear Information System (INIS)

    Basta, N.; Moore, S.; Ondrey, G.

    1994-01-01

    Developers and promoters of coal-water slurries and similar CWF (coal-water fuel) technologies have had a hard time winning converts since they unveiled their first commercial processes in the 1970s. The economic appeal of such processes, marginal at best, varies with the price of oil. Nevertheless, the technology is percolating, as geopolitics and environmental pressures drive new processes. Such fuels are becoming increasingly important to coal-rich, oil-poor nations such as China, as they attempt to build an onshore fuel supply. Meanwhile, improvements are changing the way coal-fired processes are viewed. Where air pollution regulations once discouraged the use of coal fuels, new coal processes have been developed that cut nitrous oxides (NOx) emissions and provide a use for coal fines, previously viewed as waste. The latest developments in the field were all on display at the 19th International Technical Conference on Coal Utilization and Fuel Systems, held in Clearwater, Fla., on March 21--24. At this annual meeting, sponsored by the Coal and Slurry Technology Association, (Washington, D.C.) and the Pittsburgh Energy Technology Center of the US Dept. of Energy (PETC), some 200 visitors from around the work gathered to discuss the latest developments in coal slurry utilization--new and improved processes, and onstream plants. This paper presents highlights from the conference

  5. Biogas. Present situation and future potential; Biogas. Nulaege och framtida potential

    Energy Technology Data Exchange (ETDEWEB)

    Nordberg, Ulf [Swedish Inst. of Agricultural and Environmental Engineering, Uppsala (Sweden)

    2006-12-15

    The report contains a general overview of present technology concerning production of biogas through anaerobic breakdown of easily recycled organic material as well as implementation areas for biogas. The work has been done in three parts: description of present situation, technical limitations and development efforts, synthesis. In Sweden there are more than 220 biogas plants for handling crops, sludge and organic residue material. Production of biogas occurs primarily at sewage treatment plants and landfills. Total capacity in 2004 was approx. 300,000 m{sup 3} anaerobic chamber volume, of which approx. 73% was utilised. Planned increase in capacity was approx. 125,000 m{sup 3} or approx. 42%.The substrate brought to the plants was comprised of approx. 45% manure, 30% offal, 10% biowaste from households and 15% other substrates. Calculations based on the energy content of input substrate indicate that approx. 10% of the gas was from manure, 65% from offal, 25% from household waste and 5% from other substrates. In 2005 a total of 1,5 TWh of biogas was produced in Sweden. Biogas is used primarily for heating purposes followed by use as vehicle fuel and in electricity production. More than 55 GWh is torched away. Sewage treatment plants are not included. Interest in using biogas as fuel has increased. The theoretical biogas potential in Sweden has been calculated to be 14-17 TWh per year, of which approx. 80% is found in agriculturally related biomass. Approximately 3 TWh originates from various types of household and industrial waste. Generally it can be said that there is a large potential for improvement and increased efficiency within the whole chain of substrate collection, preparatory treatment of substrates, operational control of biogas plants, upgrade/treatment and use of gas as well as spreading and use of biofertilizer. The greatest increase in substrate will come from the amount of crops from the agricultural sector. The contacts between farmers and plant

  6. Sludge storage lagoon biogas recovery and use

    Energy Technology Data Exchange (ETDEWEB)

    Muller, D.; Norville, C. (Memphis and Shelby County Div. of Planning and Development, TN (United States))

    1991-07-01

    The City of Memphis has two wastewater treatment plants. The SWTP employs two large anaerobic digestion sludge lagoons as part of the overall sludge treatment system. Although these lagoons are effective in concentrating and digesting sludge, they can generate offensive odors. The SWTP uses aerobic digesters to partially stabilize the sludge and help reduce objectionable odors before it enters the lagoons. The anaerobic digestion of sludge in the lagoons results in the dispersion of a large quantity of biogas into the atmosphere. The City realized that if the lagoons could be covered, the odor problem could be resolved, and at the same, time, biogas could be recovered and utilized as a source of energy. In 1987, the City commissioned ADI International to conduct a feasibility study to evaluate alternative methods of covering the lagoons and recovering and utilizing the biogas. The study recommended that the project be developed in two phases: (1) recovery of the biogas and (2) utilization of the biogas. Phase 1 consists of covering the two lagoons with an insulated membrane to control odor and temperature and collect the biogas. Phase 1 was found to be economically feasible and offered a unique opportunity for the City to save substantial operating costs at the treatment facility. The Memphis biogas recovery project is the only application in the world where a membrane cover has been used on a municipal wastewater sludge lagoon. It is also the largest lagoon cover system in the world.

  7. Slurry pipeline design approach

    Energy Technology Data Exchange (ETDEWEB)

    Betinol, Roy; Navarro R, Luis [Brass Chile S.A., Santiago (Chile)

    2009-12-19

    Compared to other engineering technologies, the design of a commercial long distance Slurry Pipeline design is a relatively new engineering concept which gained more recognition in the mid 1960 's. Slurry pipeline was first introduced to reduce cost in transporting coal to power generating units. Since then this technology has caught-up worldwide to transport other minerals such as limestone, copper, zinc and iron. In South America, the use of pipeline is commonly practiced in the transport of Copper (Chile, Peru and Argentina), Iron (Chile and Brazil), Zinc (Peru) and Bauxite (Brazil). As more mining operations expand and new mine facilities are opened, the design of the long distance slurry pipeline will continuously present a commercially viable option. The intent of this paper is to present the design process and discuss any new techniques and approach used today to ensure a better, safer and economical slurry pipeline. (author)

  8. Pressurized Vessel Slurry Pumping

    International Nuclear Information System (INIS)

    Pound, C.R.

    2001-01-01

    This report summarizes testing of an alternate ''pressurized vessel slurry pumping'' apparatus. The principle is similar to rural domestic water systems and ''acid eggs'' used in chemical laboratories in that material is extruded by displacement with compressed air

  9. Energy systems analysis of biogas systems; Energianalys av biogassystem

    Energy Technology Data Exchange (ETDEWEB)

    Berglund, Maria; Boerjesson, Paal

    2003-05-01

    The aim of this study was to calculate the net energy output and energy efficiency, from a life-cycle perspective and for Swedish conditions, in anaerobic digestion of various raw materials. Our calculations are based on literature reviews concerning the total primary energy input required for the production of biogas (i.e. direct and indirect energy inputs, e.g. when producing and distributing diesel fuels, electricity, fertilisers) as well as the biogas yield from various raw materials. Our analyses include handling and transportation of raw materials, operation of the biogas plants, and transportation and spreading of digested residues, as well as the biogas yield from manure, ley crops, tops and leaves of sugar beets, straw, municipal organic waste, slaughter waste, and grease separator sludge. All calculations concern individual raw materials. The net energy input required to run a biogas system (i.e. centralised biogas plant) typically corresponds to approximately 20-40% of the energy content in the produced biogas. Theoretically, the raw materials could be transported for some 200 km (manure) up to 700 km (slaughter waste) before the net energy output becomes negative. The variations in energy efficiency between studied biogas systems depend mainly on the type of raw material studied and the calculation methods used. Raw materials with high water content and low biogas yield (e.g. manure) require rather large energy inputs compared to the amount of biogas produced. Energy demanding handling of the raw materials, such as ley crops, could correspond to as much as approximately 40% of the net energy input. Varying energy efficiency in different parts of the biogas system, but most of all, changes in the biogas yield, could considerably affect the total net energy output. In general, operation of the biogas plant is the most energy demanding process in the biogas systems, corresponding to some 40-80% of the net energy input in the biogas systems. This implies

  10. Valuating report on radionuclide concentrations in the waste water and mixed slurry from the Vienna main clarifying plant for 1988

    International Nuclear Information System (INIS)

    Henrich, E.; Weisz, J.; Zapletal, M.; Haider, W.

    1989-03-01

    Sample preparation- and measuring methods, and results on 16 nuclides from the Vienna clarifying plant for 1988 are presented. Comparisons with the 1987 values are made and hypotheses about the sources of radionuclides - natural, atmospheric atomic weapons tests, Chernobyl accident and medical applications - are presented. An estimation of the activity transferred to the surface waters (Danube) over 1988 is also made. 16 refs., 8 figs., 6 tabs. (qui)

  11. Biogas utilization as flammable for internal combustion engine

    International Nuclear Information System (INIS)

    Cardenas, H.

    1995-01-01

    In this work the energetic potential stored in form of generated biogas of organic industrial wastes treatment is analyzed. Biogas utilization as flammable at internal combustion engine coupled to electrical energy generating is studied in the Wastewater Treatment Plant of Bucaramanga city (Colombia). This Plant was designed for 160.000 habitants treatment capacity, 1300 m3/h wealth, 170 BDO/m3 residues concentration and 87% process efficiency. The plant generate 2.000 m3/d of biogas. In laboratory trials was worked with biogas originating from Treatment Plant, both without purifying and purified, and the obtained results were compared with both yields determined with 86-octanes gasoline and natural gas. The analysis of pollutant by-products generated in combustion process as leak gases, present corrosive compounds and not desirable. elements in biogas composition are included

  12. Feed-in of biogas into the natural gas distribution system. Legal topics, insurance topic and financial topics; Einspeisung von Biogas in das Erdgasnetz. Rechts-, Finanzierungs- und Versicherungsfragen

    Energy Technology Data Exchange (ETDEWEB)

    Degenhart, Heinrich; Hohlbein, Bernhard; Schomerus, Thomas (eds.)

    2012-11-01

    The book under consideration consists of the following contributions: (1) Legal topics, insurance topic and financial topics of the feed-in of biogas (I. Bleuel); (2) Feed-in of biogas in natural gas distribution systems - market and economic efficiency (J. Krassowski); (3) The Feed-in of biogas in the context of the environmental energy law (T. Mueller); (4) Regulation issues for the grid connection of biomass conversion plants (D. Konrad); (5) Design of contracts for the feed-in of biogas (H. von Bredow); (6) Liability insurance for biogas processing plants (K. Thiesen); (7) Procurement of equity capital (B. Drescher); (8) Opportunities and limits of external financing (A. Schuenemann).

  13. Progress in biogas. Biogas production from agricultural biomass and organic residues. Pt. 1 and 2. Proceedings (oral presentations and poster presentations); Fortschritt beim Biogas. Biogas aus landwirtschaftlicher Biomasse and organischen Reststoffen. T. 1 und 2. Tagungsband. Vortraege and Poster

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2007-07-01

    Within the International Conference ''Progress in Biogas - Biogas production from agricultural biomass and organic residues'' at the University Hohenheim (Stuttgart, Federal Republic of Germany) from 18th to 21st September, 2007, the following lectures were held: (1) Global relevance and potential of bioenergy for regional development; (2) Biogas electricity for France feed-in tariff and some other things to know before entering French market; (3) Policy drivers and future prospects for on-farm anaerobic digestion in Northern Ireland; (4) Biogas in Belgium, a swot analysis; (5) Status and prospects of biogas energy use in Ukraine; (6) Recent developments in Chinese agricultural biogas production; (7) Opportunities for agricultural based biogas systems in the province of Ontario, Canada; (8) Pre-treatment and digestion of separated collected household waste in Sweden; (9) To the problem of monitoring measures and prophylaxis measures with the utilization of organic residual substances in biological gas facilities from hygienic view; (10) Fermenting residues from biological gas facilities - nutrients and pollutants, possibilities of application in the agriculture; (11) Treatment and utilization of fermentation residues; (12) Potential of residual gas of NaWaRo feeded biogas plants in Baden-Wuerttemberg; (13) Operating analytics of biogas plants to improve efficiency and to ensure process stability; (14) The potential of biogas and electric power production from subproducts in the sugar and alcohol industries by the application of anaerobic digestion; (15) Co-digestion plant in dairy cattle farm in Emilia Romagna region (Italy); (16) Facing operational problems in a biodigeser in Yuvientsa - Amazonian Region of Ecuador; (17) Biogas plant instead of milk cow - payment and occupation with the use of grassilage; (18) Biogas in ecologic agriculture - experiences from 3 years of fermentation of grass-clover ley; (19) Combined solar-biogas basis for the

  14. Storage of catch crops to produce biogas

    DEFF Research Database (Denmark)

    Molinuevo-Salces, Beatriz; Ahring, Birgitte Kiær; Uellendahl, Hinrich

    2014-01-01

    Catch crop biomass is a promising co-substrate for manure-based biogas plants in Denmark since the cultivation of catch crops is mandatory to retain nutrients in the soil, contributing to protect the aquatic environment. In general, the growth period for catch crops is from harvest of the previous...... crop in July-August to the end of the growing season and harvest in late October. Hence, for use of the biomass in biogas production there is a need for storage of the biomass. Storage as silage would guarantee the availability of the feedstock for biogas production during the whole year. A proper...... ensiling process determines the storage loss and the quality of the final silage and, thus, the possible use of it as a substrate for biogas production. Moreover, silage has been considered as a pre-treatment since it partially hydrolyses organic matter improving cellulose convertibility. Since a large...

  15. Value Chain Optimisation of Biogas Production

    DEFF Research Database (Denmark)

    Jensen, Ida Græsted

    With an increased focus on climate change and an increasing number of unpredictable and fluctuating renewable energy sources, a predictable renewable energy carrier is needed to stabilise energy production. Biogas can potentially be used for this but biogas projects struggle with becoming...... economically feasible. In this PhD thesis, the focus is to create models for investigating the profitability of biogas projects by: 1) including the whole value chain in a mathematical model and considering mass and energy changes on the upstream part of the chain; and 2) including profit allocation in a value......, the costs on the biogas plant has been included in the model using economy of scale. For the second point, a mathematical model considering profit allocation was developed applying three allocation mechanisms. This mathematical model can be applied as a second step after the value chain optimisation. After...

  16. Factors affecting process temperature and biogas production in small-scale rural biogas digesters in winter in northern Vietnam

    DEFF Research Database (Denmark)

    Cuong, Pham Hung; Vu, C.C.; Sommer, Sven G.

    2014-01-01

    This study investigated the main factors influencing digester temperature and methods to reduce heat losses during the cold season in the subtropics. Four composite digesters (two insulated and two uninsulated) were buried underground to measure their internal temperature (°C) at a depth of 140 cm...... and the influent chemical composition was measured monthly during the whole experimental period. Seasonal variations in air temperature significantly affected the temperature in the soil, mixing tank and digester. Consequently, biogas production, which is temperature dependent, was influenced by the season....... The main factors determining the internal temperature in the digesters were insulation with Styrofoam, air temperature and temperature of slurry in the mixing tank. Biogas production is low due to the cold climate conditions in winter in Northern Vietnam, but the study proved that storing slurry...

  17. Biomass for biogas plants in Denmark - in the short and long term; Biomasse til biogasanlaeg i Danmark - pae kort og langt sigt

    Energy Technology Data Exchange (ETDEWEB)

    Birkmose, T.; Hjort-Gregersen, K.; Stefanek, K.

    2013-04-15

    In the short term, it is one of the major challenges for the developments of the biogas sector that resources of organic waste of the type (organic industrial wastes) that have heretofore been used, generally are estimated to be nearly exhausted. This has led to a number of new biogas projects based on the use of corn (energy crops) as additional biomass to livestock manure. However, Danish policy now has implemented a restriction on the use of corn and other energy crops for biogas production. It is with the restriction clarified that there is a need to use other additional biomass for biogas production. There is a need in the short term to clarify how alternative biomasses such as straw, nature preservation biomass, household waste, etc. in a technically and economically reliable and satisfactory way can be used for biogas production, so that the dependence of energy crops can be reduced. Additionally, it will be essential if the yield of using manure can be increased to reduce economic dependence on energy crops. In the longer term it is essential to strengthen the assessment of the resource potential of biomass available for the production of biogas, and thus what the contribution of biogas in the long term is estimated to be in the future energy supply based on renewable energy. The present report presents the current and future biomass resources potential and biogas production potential. The biomass resources are primarily agricultural and municipal wastes. (LN)

  18. Prestudy: Anaerobic digestion with primary hydrolysis from increased methane production in waste water treatment plants band biogas plants; Foerstudie: Roetning med inledande hydrolyssteg foer utoekad metanutvinning paa avloppsreningsverk och biogasanlaeggningar

    Energy Technology Data Exchange (ETDEWEB)

    Persson, Emelie; Ossiansson, Elin (BioMil AB, Lund (Sweden)); Carlsson, My; Uldal, Martina; Olsson, Lars-Erik (AnoxKaldnes AB, Lund (Sweden))

    2010-04-15

    Anaerobic degradation of organic matter is a multi-step process through the action of various groups of microorganisms whose optimum conditions can differ considerably regarding e.g. nutrient and pH demand, sensitivity for changes and patterns for growth and nutrient uptake. One way of optimizing the anaerobic digestion process, and thereby increase the biogas production and the reduction of organic matter, can be to physically divide the anaerobic digestion process in two steps consisting of an initial hydrolysis and acid production step followed by a methane production step in an anaerobic digester. One problem with the biogas processes of today is that not all organic matter that is added to the process becomes available for conversion into biogas. This is particularly evident in digestion of waste water treatment sludge where almost half of the organic matter added remains after anaerobic digestion. More efficient utilization of substrate in biogas plants is an important element to increase the profitability of biogas production. The possibility to use different pre-treatment methods is being discussed to increase the degree of conversion of organic matter into biogas in the digester. Pre-treatment methods are often energy as well as cost demanding and can require the addition of chemicals. To use the microbiological steps in the biogas process more efficiently by adding an initial hydrolysis step is a method that does not require the usage of chemicals or increased energy consumption. This pre-study is based on literature studies related to anaerobic digestion with initial biological hydrolysis and collected knowledge from full-scale plants, universities and suppliers of equipment. Nearly 70 published scientific articles relevant to the subject have been found in the performed literature searches. The articles have been subdivided according to the purpose of each article. A large part of the articles have concerned modelling of anaerobic digestion why a

  19. Potential for sustainable energy with biogas from sewage purification

    International Nuclear Information System (INIS)

    Coenen, J.; Van Gastel, M.; De Jong, K.

    2005-04-01

    Insight is given into the possibility to produce biogas from sewage purification plants in the Netherlands. Attention is paid to the estimated potential of sustainable energy from biogas, the economic effectiveness of several scenarios, the critical success factors and bottlenecks [nl

  20. Future European biogas

    DEFF Research Database (Denmark)

    Meyer, A. K.P.; Ehimen, E. A.; Holm-Nielsen, J. B.

    2018-01-01

    Biogas is expected to play an important role in reaching the future energy policy targets of the European Union (EU). The sustainability of biogas substrates has however been recently critically discussed due to the increasing shares of agricultural land used for energy crop production.The aim...... of this study was to project and map the biomass and biogas energy potential from a selection of potentially sustainable agricultural residues, which have been documented to improve in biogas yields when co-digested in biogas production, for the EU28 in year 2030. The investigated types of residual biomasses...... were animal manure, straw by-products from cereal production, and excess grass from rotational and permanent grasslands and meadows. The biogas energy potential from the investigated biomass was projected to range from 1.2·103 to 2.3·103 PJ y-1 in year 2030 in the EU28, depending on the biomass...

  1. PRELIMINARY STUDY ON BIOGAS PRODUCTION OF BIOGAS FROM MUNICIPAL SOLID WASTE (MSW LEACHATE

    Directory of Open Access Journals (Sweden)

    WAN AZLINA WAN AB KARIM GHANI

    2009-12-01

    Full Text Available Laboratory-scale digesters were operated to study the effect of leachate chemical oxygen demand strength on biogas (methane production. Three sets of experiment were performed using municipal solid waste leachate slurry with two different chemical oxygen demand strength strengths namely 3000 and 21000 mg/L (referred as low and high strength, respectively. The experiments were conducted at a controlled temperature of 35°C and pH ranging from 6.8 to 7.3 over 20 days period. The process performance was evaluated based on the biogas production and pollutants removal efficiencies. Results showed that the high and low strength samples performed quite similarly but with different biogas production rate observed. The biochemical oxygen demand in the effluent removed up to 80%, but the performance of other parameters such as chemical oxygen demand, total suspended solid and volatile suspended solid was slightly decreased which contributes 33 to 46%, 21 to 37% and 20 to 35%, respectively. From this study, it can be concluded that this method not only contributed to renewable biogas production but also improved the effluent quality.

  2. Design considerations for a farm-scale biogas plant based on pilot-scale anaerobic digesters loaded with rice straw and piggery wastewater

    International Nuclear Information System (INIS)

    Mussoline, Wendy; Esposito, Giovanni; Lens, Piet; Garuti, Gilberto; Giordano, Andrea

    2012-01-01

    Two pilot-scale (1 m 3 ) digesters filled with untreated rice straw and co-digested with raw pig wastewater were operated to obtain design parameters for a farm-scale biogas plant. Both digesters contained 50 kg of dry straw mixed with diluted pig wastewater to create dry digestion conditions (20% TS) and operated for 189 days with leachate recirculation. Digester A was designed for optimum performance (150 L of pig wastewater and mesophilic temperatures) while Digester B was designed to establish minimum inputs (60 L of pig wastewater at ambient temperatures). The pig wastewater provided sufficient buffering capacity to maintain appropriate pH values (between 7.0 and 8.1) and nutrient balances (TOC to TKN ratios of 20 in Digester A and 32 in Digester B). Total biogas production was 22,859 L in Digester A and 1420 L from Digester B, resulting in specific methane yields of 231 and 12 L CH 4 /kgVS added, respectively. Gas production in Digester A was directly correlated with temperature, but the overall lack of methanogenic activity was caused primarily by the reduced wastewater volume. Two theoretical farm-scale scenarios (considering both untreated and pretreated rice straw) were developed for a 100-ha rice farm. Either scenario can produce 100,000 m 3 CH 4 per year, yielding 328 MWh. Major differences including heat input, space requirements, loading frequency, digester volume, engine size, wastewater quantities, and additives are quantitatively defined. The appropriate choice for a farm-scale operation is the simplest model using untreated rice straw without additives, although six times more heat and twice as much reactor volume is required. -- Highlights: ► The co-digestion of untreated rice straw and piggery wastewater is investigated. ► Gas production increases with the volume of pig wastewater added and temperature. ► Pig wastewater alone can provide appropriate buffering capacity and nutrient balance. ► Pilot-scale results are used to establish

  3. 15. Annual Meeting on biogas and bioenergy in agriculture. Proceedings; 15. Jahrestagung Biogas und Bioenergie in der Landwirtschaft. Tagungsband

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2006-07-01

    The volume contains besides the general statements on environmental protection and energy savings in the future and biogas as great potential for the rural development the following contributions in four parts: 1. political enveloping conditions: biogas usage within the frame of the the new EEG; state of biogas usage in Baden-Wuerttemberg; practical experiences end perspectives for the biogas development; renewable raw materials from the view of environmenmental protection; 2. gas utilization: the bioenergy village Mauenheim - model for the rural area; compression ignition gas engines with biogenic ignition oils; realization and economic performance of gas engines with biogas; microgasturbines - engineering and chances, gas processing and feeding into the gas network; 3. substrate: influence of the energy plant agriculture on the regional structures; biogas plants: substrate control by TS sensing; fermentation of fusaria contaminated corn; substrate contracts in the view of revenue and contract legacy; energy plants agriculture in Baden-Wuerttemberg; 4. process biology: comparison of dry and wet fermentation; fundamentals, process stability analytical possibilities; start-up of a biogas plant; biogas process with external hydrolysis; problems in the fermenter - inhibitors and auxiliaries.

  4. Biogas in the agriculture. State of the art. Proceedings; Biogas in der Landwirtschaft. Stand und Perspektiven. Tagungsband

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2009-07-01

    Within the meeting of the Association for Technology and Structures in Agriculture (Darmstadt, Federal Republic of Germany) and the Agency for Renewable Resources (Guelzow, Federal Republic of Germany) between 15th and 16th September, 2009, in Weimar the following lectures were held: (1) Results of the actual biogas measurement II (Peter Weiland); (2) Agitators in biogas plants - Technology with central significance (Kay Rostalski); (3) How much energy is needed by a biogas fermenter? (Ludwig Heinloth); (4) The fermentation concept of Rueckert NatUrgas GmbH (Claus Rueckert, Dominique Pfeufer); (5) Experiences from the construction for the practice of the company MT-Energie GmbH (Bodo Drescher); (6) Fermenter/technology concept of Schmack Biogas AG (Thomas Moeeslinger); (7) Transport of biomass - How much does the logistics of Guelle and Co. cost? (Thore Toews); (8) Which factors determine the efficiency of biogas plants? (Gerd Reinhold); (9) Microbial diversity in biogas reactors in the fermentation of renewable raw materials (Michael Klocke et al.); (10) What do additives and ingredients contribute to the optimisation of the production of biogas? (Udo Hoelker); (11) Process optimisation - An interaction between technology and microbiology (Andreas Gronauer et al.); (12) Emissions at the production of biogas - an analysis if the environmental relevance (Joachim Clemens et al.); (13) Support systems for energy plants - Consequences to soil and environment (Matthias Willms et al.); (14) How ecological is biogas? (Sven Gaertner); (15) Biogas plant - Analysis of construction and operation from licensing view (Hans-Walter Schneichel); (16) Biogas plants - Analysis of construction and operation from contractual legal view (Florian Valentin); (17) Biogasplants - Analysis of construction and operation from remuneration legal view (Helmut Loibl); (18) Process and costs of treatment of residues of fermentation (Sebastian Wulf, Helmut Doehler); (19) How do residues of

  5. Mineralenconcentraten uit dierlijke mest : monitoring in het kader van de pilot mineralenconcentraten = Mineral concentrates from animal slurry : monitoring of the pilot production plants

    NARCIS (Netherlands)

    Hoeksma, P.; Buisonjé, de F.E.; Ehlert, P.A.I.; Horrevorts, J.H.

    2011-01-01

    Processing of animal manure is considered as an opportunity to reduce the pressure on the manure market in the Netherlands. One of the options is to separate the slurry and to use the mineral concentrate, that is produced from the liquid phase by reverse osmosis, as a substitute for mineral

  6. Agricultural biogas systems. Quality and security

    International Nuclear Information System (INIS)

    Serafimova, K.

    2007-01-01

    This article takes a look at agricultural biogas installations and how improved basic conditions and incentives offered by industry and commerce are showing initial effects. The author is of the opinion that more dynamics in the market are necessary in order to allow contributions to be made to the protection of the climate whilst creating value locally at the same time. The article reviews the current market situation and examines questions which are to be answered in the quality assurance area for agricultural biogas systems in Switzerland. Co-fermentation is proposed as a standard technology. Market development, plant locations and plant management aspects are discussed.

  7. Environmental perspectives on using cast seaweed for biogas production

    DEFF Research Database (Denmark)

    Fredenslund, Anders Michael; Møller, Henrik Bjarne; Christensen, Thomas Budde

    Solrød Municipality, Denmark is working towards building a biogas plant utilizing locally available organic wastes including cast seaweed, which is collected each year, since the local inhabitants see this material as a nuisance. A preliminary study suggested favorable conditions for contstructing...... a mixed substrate biogas plant. Continuously fed reactor experiments showed that the intended mix of substrate including cast seaweed could be used as raw material for a biogas plant in thermophilic operation. The environmental analysis suggests existence of several positive benefits of utilizing cast...

  8. Biogas in Burkina Faso. Influential factors of biogas projects in rural areas of Burkina Faso

    Energy Technology Data Exchange (ETDEWEB)

    Aschaber, Andreas

    2010-07-01

    Full text: Burkina Faso is among the poorest countries in the world. The energy situation in Burkina Faso is among the most critical issues which need to be addressed in the country. The electrical power grid is insufficient and only available in urban centers. Consequently wood and charcoal is used in order to meet the basic needs for heating, cooking, and lightning by the majority of the population. The resulting overuse of natural energy resources in Burkina Faso has been causing massive deforestation and desertification on the one hand and on the other hand scarcity in fuel wood availability. According to a recent feasibility study of the GTZ, biogas is thought to be one of the most sustainable solutions for developing energy self sufficiency in rural areas of Burkina Faso. Biogas is not a new concept in Burkina Faso, as the first biogas plants were already installed in the 70's. Recently a national biogas program and the activity of various NGOs lead to a rejuvenation of attempts to establish biogas in Burkina Faso. Although biogas has a long history in Burkina Faso, no significant breakthrough of this technology has happened so far. None of the biogas plants built during the last 40 years have been operational for a long time. This contribution presents a study aimed to analyze the partial success and failures of the attempts to install biogas plants so far. The study was conducted in May 2009 as part of a project for a model application of the technology in the frame of University cooperation between Austria (University of Innsbruck) and Burkina Faso (Universite Polytechnique du Bobo Dioulasso). During the field study four sites of existing biogas plants were visited, five interviews with experts conducted and two focus groups with potential users in a rural setting were conducted. The systemic approach, including technical as well as socioeconomic aspects, yielded a wealth of factors which can potentially influence the success of biogas projects in

  9. Improved detection of extended spectrum beta-lactamase (ESBL-producing Escherichia coli in input and output samples of German biogas plants by a selective pre-enrichment procedure.

    Directory of Open Access Journals (Sweden)

    Thorsten Schauss

    Full Text Available The presence of extended-spectrum beta-lactamase (ESBL-producing Escherichia coli was investigated in input (manure from livestock husbandry and output samples of six German biogas plants in 2012 (one sampling per biogas plant and two German biogas plants investigated in an annual cycle four times in 2013/2014. ESBL-producing Escherichia coli were cultured by direct plating on CHROMagar ESBL from input samples in the range of 100 to 104 colony forming units (CFU per g dry weight but not from output sample. This initially indicated a complete elimination of ESBL-producing E. coli by the biogas plant process. Detected non target bacteria were assigned to the genera Acinetobacter, Pseudomonas, Bordetella, Achromobacter, Castellaniella, and Ochrobactrum. A selective pre-enrichment procedure increased the detection efficiency of ESBL-producing E. coli in input samples and enabled the detection in five of eight analyzed output samples. In total 119 ESBL-producing E. coli were isolated from input and 46 from output samples. Most of the E. coli isolates carried CTX-M-type and/or TEM-type beta lactamases (94%, few SHV-type beta lactamase (6%. Sixty-four blaCTX-M genes were characterized more detailed and assigned mainly to CTX-M-groups 1 (85% and 9 (13%, and one to group 2. Phylogenetic grouping of 80 E. coli isolates showed that most were assigned to group A (71% and B1 (27%, only one to group D (2%. Genomic fingerprinting and multilocus sequence typing (MLST showed a high clonal diversity with 41 BOX-types and 19 ST-types. The two most common ST-types were ST410 and ST1210. Antimicrobial susceptibility testing of 46 selected ESBL-producing E. coli revealed that several isolates were additionally resistant to other veterinary relevant antibiotics and some grew on CHROMagar STEC but shiga-like toxine (SLT genes were not detected. Resistance to carbapenems was not detected. In summary the study showed for the first time the presence of ESBL-producing E

  10. Improved Detection of Extended Spectrum Beta-Lactamase (ESBL)-Producing Escherichia coli in Input and Output Samples of German Biogas Plants by a Selective Pre-Enrichment Procedure

    Science.gov (United States)

    Schauss, Thorsten; Glaeser, Stefanie P.; Gütschow, Alexandra; Dott, Wolfgang; Kämpfer, Peter

    2015-01-01

    The presence of extended-spectrum beta-lactamase (ESBL)-producing Escherichia coli was investigated in input (manure from livestock husbandry) and output samples of six German biogas plants in 2012 (one sampling per biogas plant) and two German biogas plants investigated in an annual cycle four times in 2013/2014. ESBL-producing Escherichia coli were cultured by direct plating on CHROMagar ESBL from input samples in the range of 100 to 104 colony forming units (CFU) per g dry weight but not from output sample. This initially indicated a complete elimination of ESBL-producing E. coli by the biogas plant process. Detected non target bacteria were assigned to the genera Acinetobacter, Pseudomonas, Bordetella, Achromobacter, Castellaniella, and Ochrobactrum. A selective pre-enrichment procedure increased the detection efficiency of ESBL-producing E. coli in input samples and enabled the detection in five of eight analyzed output samples. In total 119 ESBL-producing E. coli were isolated from input and 46 from output samples. Most of the E. coli isolates carried CTX-M-type and/or TEM-type beta lactamases (94%), few SHV-type beta lactamase (6%). Sixty-four bla CTX-M genes were characterized more detailed and assigned mainly to CTX-M-groups 1 (85%) and 9 (13%), and one to group 2. Phylogenetic grouping of 80 E. coli isolates showed that most were assigned to group A (71%) and B1 (27%), only one to group D (2%). Genomic fingerprinting and multilocus sequence typing (MLST) showed a high clonal diversity with 41 BOX-types and 19 ST-types. The two most common ST-types were ST410 and ST1210. Antimicrobial susceptibility testing of 46 selected ESBL-producing E. coli revealed that several isolates were additionally resistant to other veterinary relevant antibiotics and some grew on CHROMagar STEC but shiga-like toxine (SLT) genes were not detected. Resistance to carbapenems was not detected. In summary the study showed for the first time the presence of ESBL-producing E. coli in

  11. Relationships among slurry characteristics and gaseous emissions at different types of commercial Spanish pig farms

    Energy Technology Data Exchange (ETDEWEB)

    Becaccia, A.; Ferrer, P.; Ibañez, M.A.; Estellés, F.; Rodríguez, C.; Moset, V.; Blas, C. de; Calvet, P.; García-Rebollar, P.

    2015-07-01

    This study aimed to analyse several factors of variation of slurry composition and to establish prediction equations for potential methane (CH4) and ammonia (NH3) emissions. Seventy-nine feed and slurry samples were collected at two seasons (summer and winter) from commercial pig farms sited at two Spanish regions (Centre and Mediterranean). Nursery, growing-fattening, gestating and lactating facilities were sampled. Feed and slurry composition were determined, and potential CH4 and NH3 emissions measured at laboratory. Feed nutrient contents were used as covariates in the analysis. Near infrared reflectance spectroscopy (NIRS) was evaluated as a predicting tool for slurry composition and potential gaseous emissions. A wide variability was found both in feed and slurry composition. Mediterranean farms had a higher pH (p<0.001) and ash (p=0.02) concentration than those located at the Centre of Spain. Also, type of farm affected ether extract content of the slurry (p=0.02), with highest values obtained for the youngest animal facilities. Results suggested a buffer effect of dietary fibre on slurry pH and a direct relationship (p<0.05) with fibre constituents of manure. Dietary protein content did not affect slurry nitrogen content but decreased (p=0.003) total and volatile solids concentration. Prediction models of potential NH3 emissions (R2=0.89) and CH4 yield (R2=0.61) were obtained from slurry composition. Predictions from NIRS showed a high accuracy for most slurry constituents (R2>0.90) and similar accuracy of prediction of potential NH3 and CH4 emissions (R2=0.84 and 0.68, respectively) to models using slurry characteristics, which can be of interest to estimate emissions from commercial farms and establish mitigation strategies or optimize biogas production. (Author)

  12. The Role of Municipalities, Energy Companies and the Agricultural Sector in Denmark as Drivers for Biogas

    DEFF Research Database (Denmark)

    Lybæk, Rikke; Andersen, Jan; Christensen, Thomas Budde

    2014-01-01

    and identifies the most important current barriers for the biogas technology namely, difficulties in providing organic industrial waste, unfavorable funding options and low plant profitability. An element in overcoming these barriers concerns the inclusion of stakeholders from the energy sector and engaging....... We identify trends in biogas development and provide suggestions for new stakeholder actions. Municipalities must, for example, facilitate access to new sources of raw materials, enhance energy planning by targeting biogas in their e.g. municipal heat planning. Energy companies should also benefit...... from the new market opportunities that biogas poses e.g. supply biogas for transportation purposes. Farmers must look for alternative ways of implementing biogas plants using new corporate design concepts rather than traditional centralized and farm biogas plants.....

  13. Distribution forms for biogas and natural gas in Sweden

    International Nuclear Information System (INIS)

    Benjaminsson, Johan; Nilsson, Ronny

    2009-11-01

    Since biogas and natural gas basically have the same characteristics, they can be distributed in the same system. In the parts of the country where there is an extensive natural gas distribution network, the infrastructure for natural gas can be used for distribution of biogas. In order to increase the use of renewable energy, it is a political ambition to increase the share of biogas in the natural gas network, and, in the long run, entirely replace natural gas with biogas. Much of biogas production in the country is, however, not reached by the existing natural gas network, and this is also the case for a large part of the potential for future biogas production. In these areas the gas is transported in more or less extensive local gas distribution networks and by truck in compressed or liquid form. Transport of compressed and liquefied gas is efficient in some cases and development of these systems is an ongoing process. A number of facilities are planned for production of large quantities of biogas, several hundred GWh/year, through digestion and gasification processes. These plants will be located either in conjunction with major gas consumers or in the vicinity of the existing natural gas grid. The potential for biogas production is, however, present throughout the country and in order to meet market demand biogas requires efficient distribution systems

  14. Optimal production of power in a combined cycle from manure based biogas

    International Nuclear Information System (INIS)

    León, Erick; Martín, Mariano

    2016-01-01

    Highlights: • Manure based biogas is a promising renewable source to add value to waste. • Mathematical optimization is used to design a process including gas and steam turbines. • Two schemes for steam production and the effect of animal headcount are compared. • Direct use of flue gas for steam production is recommended. • Digestate economics is key for a competitive price of electricity. - Abstract: In this work, the production of power using a combined cycle gas turbine/steam turbine, which operates with biogas as fuel, is evaluated. The process begins with the production of biogas from pig and/or cattle slurry manure(s) using anaerobic digestion. Afterwards, the gas is cleaned up to remove humidity, hydrogen sulfide, carbon dioxide and ammonia. The cleaned gas (biomethane) is then used in a Brayton cycle (gas turbine) to produce energy. The flue gas that exits the Brayton cycle is typically at high temperature and it is further utilized to produce steam that generates power in a regenerative Rankine cycle (steam turbine). Two alternative steam production schemes are evaluated: either splitting the flue gas to have high temperature gas for the reheating step of the steam or sequential heating up. The model is formulated as a Mixer Integer Nonlinear Programming (MINLP) solved in GAMS® for the optimal production of power. For a typical production capacity of manure in farms, 2.6 MW are produced. The investment for the plant turns out to be 26 M€ and the production cost of the electricity is 0.35 €/kW h before including the credit from the conditioned digestate, that could be sold as fertilizer. The electricity cost goes down to 0.15 €/kW h considering a reasonable credit from the digestate, whose composition depends on the feedstock processed in the facility.

  15. Slurry walls and slurry trenches - construction quality control

    International Nuclear Information System (INIS)

    Poletto, R.J.; Good, D.R.

    1997-01-01

    Slurry (panel) walls and slurry trenches have become conventional methods for construction of deep underground structures, interceptor trenches and hydraulic (cutoff) barriers. More recently polymers mixed with water are used to stabilize the excavation instead of bentonite slurry. Slurry walls are typically excavated in short panel segments, 2 to 7 m (7 to 23 ft) long, and backfilled with structural materials; whereas slurry trenches are fairly continuous excavations with concurrent backfilling of blended soils, or cement-bentonite mixtures. Slurry trench techniques have also been used to construct interceptor trenches. Currently no national standards exist for the design and/or construction of slurry walls/trenches. Government agencies, private consultants, contractors and trade groups have published specifications for construction of slurry walls/trenches. These specifications vary in complexity and quality of standards. Some place excessive emphasis on the preparation and control of bentonite or polymer slurry used for excavation, with insufficient emphasis placed on quality control of bottom cleaning, tremie concrete, backfill placement or requirements for the finished product. This has led to numerous quality problems, particularly with regard to identification of key depths, bottom sediments and proper backfill placement. This paper will discuss the inspection of slurry wall/trench construction process, identifying those areas which require special scrutiny. New approaches to inspection of slurry stabilized excavations are discussed

  16. Biogas : fuel source for a renewable future

    Energy Technology Data Exchange (ETDEWEB)

    Buijk, J. [GE Energy, Toronto, ON (Canada)

    2006-07-01

    The current status of Ge Energy's Jenbacher gas engines was presented in terms of its product line, electrical output, thermal output and exhaust gases. The unique feature of the engine is that it can operate on natural gas, biogas, landfill or other gaseous fuels. The most important applications for this high efficiency gas engine include on-site power generation, cogeneration, tri-generation, and carbon dioxide fertilization in greenhouses. A map illustrating Canada wide sales and service networks was presented along with a review of opportunities to use biogas for electric power generation. Biogas can be generated from organic matter such as municipal organic waste, manure, yard waste, wood waste, expired food, slaughterhouse waste and energy crops. A graph depicting biogas yields of different feedstocks was presented. It was noted that biogas conversion through anaerobic digestion generates more energy from organic matter than any other technology, while recycling the nutrients. A schematic of a typical biomass anaerobic digestion process was illustrated. In 2005, Germany was among the leaders in biogas production, with 775 biogas utilization plants in operation, producing 550 MW of power. This presentation listed other leaders and highlighted some project examples of biomass conversion plants in Austria, Germany, and Alberta. The opportunities for Ontario were emphasized. Ontario has 5.6 million hectares of agricultural land. Based on the German example, the integrated use for production of food, feed and energy crops could generate 3,700 cubic metres of methane per hectare per year, enough for nearly 9,000 MW of electrical capacity. Biogas power plants with gas storage can operate as peaking plants. It was noted that energy plans should be value driven rather than cost driven, with the objective of reducing overall energy consumption, improving energy efficiency and initiating replacement of fossil fuels by renewable energy sources such as wind, water

  17. Progress on radioactive waste slurry incineration with oxygen and steam

    International Nuclear Information System (INIS)

    Hoshino, M.; Hayashi, M.; Oda, I.; Nonaka, N.; Kuwayama, K.; Shigeta, T.

    1988-01-01

    The radioactive waste (radwaste) slurry generated from the nuclear power plant operation, such as spent ion-exchange resins (powdered, bead), fire-retardant oils including phosphate ester and concentrated laundry (by the wet method) liquid waste, has been stored in an untreated condition on the plant site. Recently, since the Condensate Filter Demineralizer (CFD) has been applied in advanced BWR plants, the discharged volume of untreated spent powered resin slurry has been increasing steadily. TEE and NCE have been developing an effective new volume reduction system to treat this radwaste slurry based on an innovative incineration concept. The new system is called the IOS process, the feature of which is incineration with oxygen and steam admixture instead of conventional air. The IOS process, which consists mainly of high heat load incineration with slurry atomization, and combustion gas cooling and condensation by the wet method, has several advantages which are summarized in this paper

  18. Slurry pump compatibility testing

    International Nuclear Information System (INIS)

    Mickalonis, J.I.

    2000-01-01

    The SRTC/Materials Technology Section (MTS) performed an evaluation of the compatibility of four slurry pump materials of construction in high level waste supernate environments. These tests were performed because of recent binding of the pump shafts after exposure to supernate in Tank 8F

  19. The Determinants Factors of Biogas Technology Adoption in Cattle Farming: Evidences from Pati, Indonesia

    Directory of Open Access Journals (Sweden)

    Jatmiko Wahyudi

    2017-11-01

    Full Text Available Even though biogas technology has been introduced in Indonesia since 1990’s and having the potential, the rate of biogas adoption in Indonesia runs slowly. It is important to understand factors encouraging or discouraging potential adopters to build biogas plant. The development of livestock sector especially cattle farming in Indonesia can be seen as the opportunity to increase the rate of biogas adoption. This study investigated the factors affecting households of cattle farmer to adopt or not to adopt biogas technology. A cross-sectional research survey was carried out by using structured questionnaires as the primary tool to collect data from both biogas adopters and non biogas adopters in Pati regency, Indonesia. Socioeconomic characteristic of potential biogas adopters plays an important role to ensure the adoption of biogas technology sustainable. Socioeconomic characteristic regarding having high social status determines individual to adopt biogas relatively earlier than other members of a social system. Having high income and education enables traditional farmers to finance biogas plant by their own money or access aid from the government or other agencies. Among other attributes of innovation, relative advantage of installing biogas plant is the most determinant attribute to speed the rate of biogas adoption. Having biogas plant was perceived as better option and generated more benefits compared to previous technology or method. Article History: Received May 17th 2017; Received in revised form August 5th  2017; Accepted Sept 6th 2017; Available online How to Cite This Article: Wahyudi, J. (2017 The Determinant Factors of Biogas Technology Adoption in Cattle Farming: Evidences from Pati, Indonesia, 6(3, 235-240. https://doi.org/10.14710/ijred.6.3.235-240

  20. Sulphur fate and anaerobic biodegradation potential during co-digestion of seaweed biomass (Ulva sp.) with pig slurry.

    Science.gov (United States)

    Peu, P; Sassi, J-F; Girault, R; Picard, S; Saint-Cast, Patricia; Béline, F; Dabert, P

    2011-12-01

    Seaweed (Ulva sp.) stranded on beaches were utilized as co-substrate for anaerobic digestion of pig slurry in three-month co-digestion tests in pilot scale anaerobic digesters in the laboratory. The methanogenic potential of Ulva sp. was low compared to that of other potential co-substrates available for use by farmers: 148 N m3CH4/t of volatile solids or 19 N m3CH4/t of crude product. When used as a co-substrate with pig manure (48%/52% w/w), Ulva sp. seaweed did not notably disrupt the process of digestion; however, after pilot stabilisation, biogas produced contained 3.5% H2S, making it unsuitable for energy recovery without treatment. Sequentially addition of the sulphate reduction inhibitor, potassium molybdate, to a final concentration of 3mM, temporarily reduced H2S emissions, but was unable to sustain this reduction over the three-month period. According to these pilot tests, the use of seaweed stranded on beaches as co-substrate in farm-based biogas plants shows some limitations. Copyright © 2011 Elsevier Ltd. All rights reserved.

  1. Monitoring and controlling the biogas process

    Energy Technology Data Exchange (ETDEWEB)

    Ahring, B.K.; Angelidaki, I. [The Technical Univ. of Denmark, Dept. of Environmental Science and Engineering, Lyngby (Denmark)

    1997-08-01

    Many modern large-scale biogas plants have been constructed recently, increasing the demand for proper monitoring and control of these large reactor systems. For monitoring the biogas process, an easy to measure and reliable indicator is required, which reflects the metabolic state and the activity of the bacterial populations in the reactor. In this paper, we discuss existing indicators as well as indicators under development which can potentially be used to monitor the state of the biogas process in a reactor. Furthermore, data are presented from two large scale thermophilic biogas plants, subjected to temperature changes and where the concentration of volatile fatty acids was monitored. The results clearly demonstrated that significant changes in the concentration of the individual VFA occurred although the biogas production was not significantly changed. Especially the concentrations of butyrate, isobutyrate and isovalerate showed significant changes. Future improvements of process control could therefore be based on monitoring of the concentration of specific VFA`s together with information about the bacterial populations in the reactor. The last information could be supplied by the use of modern molecular techniques. (au) 51 refs.

  2. BiogasMotor; BiogasMotor

    Energy Technology Data Exchange (ETDEWEB)

    Roubaud, A.; Favrat, D.

    2002-07-01

    This final report for the Swiss Federal Office of Energy (SFOE) presents the results of tests made at the Swiss Federal Institute of Technology in Lausanne with an unscavenged prechamber ignition system on a 150 kW co-generation engine fuelled with biogas. The engine's performance in terms of fuel conversion efficiency was observed and the reduction potential for exhaust emissions to a level below the Swiss limits was verified. The tests made, which used natural gas mixed with CO{sub 2} as simulated biogas fuel, are described. The results of the tests, including figures on NO{sub x}, CO and HC emissions, are presented and discussed. The authors conclude that biogas engines with unscavenged prechamber ignition could provide a significant boost in energy conversion efficiency whilst keeping emissions within the tough Swiss limits.

  3. Evaluation and optimization of nutritional and environmental impact of biogas residues

    International Nuclear Information System (INIS)

    Lichti, Fabian Heribert

    2013-01-01

    On the basis of the dynamic growth of biogas plants in Germany the fertilization with biogas residues has obtained an important role for recirculation of plant nutrients, particularly with regard to nitrogen. In this work the effect of N nutrition with biogas residues was assessed in a 3-year on-field trial conducted at four sites throughout Bavaria. The fertilizing effects were tested by varying rate and time of biogas residues application, using different application techniques and the addition of nitrification inhibitors on several crops. The biogas residues achieved mineral fertilizer equivalents of 30 - 45 %. Overall, the untreated biogas residues showed a slightly increased N efficiency compared to cattle manure, whereas particularly site-dependent differences resulted in large differences in N efficiency of biogas residues.

  4. Use of digestate from a decentralized on-farm biogas plant as fertilizer in soils: An ecotoxicological study for future indicators in risk and life cycle assessment.

    Science.gov (United States)

    Pivato, Alberto; Vanin, Stefano; Raga, Roberto; Lavagnolo, Maria Cristina; Barausse, Alberto; Rieple, Antonia; Laurent, Alexis; Cossu, Raffaello

    2016-03-01

    Over the last decade, the number of decentralized farm biogas plants has increased significantly in the EU. This development leads not only to an increasing amount of biogas produced, but also to a higher amount of digestate obtained. One of the most attractive options to manage the digestate is to apply it as biofertiliser to the soil, because this gives the opportunity of recovering the nutrients, primarily nitrogen and phosphorus, and of attenuating the loss of organic matter suffered by soils under agricultural exploitation. Studies have claimed that digestates can present a residual biodegradability, and contain complex organic elements, salts or pathogenic bacteria that can damage terrestrial organisms. However few ecotoxicological studies have been performed to evaluate the ecological impact of digestate application on soil. In this study, the use of digestate as biofertiliser in agriculture was assessed by a battery of ecotoxicological tests considering the potential pollutants present in the digestate as a whole by using the "matrix-based" approach (also known as "whole effluent toxicity" for eluates or wastewater effluents). The direct and indirect tests included plant bioassays with Lepidium sativum, earthworm bioassays with Eisenia fetida, aquatic organisms (Artemia sp. and Daphnia magna) and luminescent bacteria bioassays (Vibrio fischeri). Direct tests occurred to be more sensitive than indirect tests. The earthworm bioassays did not show serious negative effects for concentrations up to 15% (dry weight/dry weight percent, w/w dm) and the plant bioassays showed no negative effect, but rather a positive one for concentrations lower than 20% (w/w dm), which encourages the use of digestate as a biofertiliser in agriculture provided that proper concentrations are used. The indirect tests, on the eluate, with the using aquatic organisms and luminescent bacteria showed an LC50 value of 13.61% volume/volume percent, v/v) for D. magna and no toxicity for

  5. Recovery of Nutrients from Biogas Digestate with Biochar and Clinoptilolite

    DEFF Research Database (Denmark)

    Kocatürk, Nazli Pelin

    necessitates the subsequent distribution of nutrients. The liquid fraction of digestate can be used as fertiliser in agricultural crop production systems and the most common practice of utilising the liquid fraction of digestate is direct field application in the vicinity of the biogas plant. However, direct......The increasing number of biogas plants over the last decades has brought the need to improve techniques to handle digestate, the by-product of anaerobic digestion in biogas plants. Separation of digestate into liquid and solid fractions is often applied in centralised biogas plants, which...... application may result in practical problems such as need for high storage volume, and environmental problems as a result of nutrient losses in the environment. To overcome such problems, recovery and concentration of nutrients from the liquid fraction may be a desirable option which, would also result...

  6. The effect of landfill biogas on vegetal growth

    Directory of Open Access Journals (Sweden)

    Sanchez-Yañez Juan Manuel

    2012-08-01

    Full Text Available The plants carry out the gaseous exchange during the photosynthesis and the respiration, however the stomal opening of the leaves or the flow through lenticels in the root are not selective, the anthropogenic biogas emissions enter to vegetable tissues altering its normal physiology. In landfill sites roots plants are exposed to a flow of a variable concentration of biogas, mainly composed by methane (CH4 50-60% and carbon dioxide (CO2 40-55%, product of the anaerobic digestion of the organic fraction of municipal solid waste (MSW. Biogas, according to its concentration and exposure time is likely to exert a negative effect on plant root growth; however, the mechanism is largely unknown. The aim of this revision was to revise the state of the art of the negative effect of biogas on plants that are close to landfill sites.

  7. Progress in biogas II - Biogas production from agricultural biomass and organic residues. Pt. 1. Proceedings; Progress in Biogas II - Biogasproduktion aus landwirtschaftlicher Biomasse und organischen Reststoffen. T. 1. Tagungsband

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2011-08-12

    Within the International Congress at the University of Hohenheim (Stuttgart, Federal Republic of Germany) from 29th March to 1st April, 2011, the following lectures were held: (1) Biogas in Europe (F. Scholwin); (2) Biogas development in China: International Cooperation to up-scale the technology (Z. Li); (3) The methane to markets initiative and opportunities for livestock manure digesters in the United states (C. Voell); (4) Biogas for sanitation in Africa - experiences from creating a sustainable market 2003 to 2010 (M. Lebofa); (5) Are biogas plants in Baden-Wuerttemberg efficient? (M. Stanull); (6) The Estonian theoretical and practical biogas production potential and economically feasible feed-in-tariff for renewable electricity for micro CHP using biogas (A. Oja); (7) Biomass potentials for biogas utilization and the effects on sustainability in Kalugo (P. Fiedler); (8) An Integrated Energy System applied to Milking Dairy Cows (I. Bywater); (9) WINUBIO-Alternative technology to improve Austria's biogas capacity (V. Steinmueller); (10) Interdisciplinary approaches to advances in sustainable biogas production in Europe (S. Kusch); (11) Problems encountered in disseminating biogas technology in Uganda (G. Mabudo); (12) reasons to the success to biogas program in Nepal (K. Dawadi); (13) Effects of increasing biomass production for energetic utilization on soil fertility in the German Federal State on Brandenburg (J. Zimmer); (14) Biogas plants as part of sustainable development within peasant family farms in Germany - Interim results of an empirical field study (A. Bischoff); (15) Life cycle assessment of heat and power generation in biogas fed combined heat and power plants under German conditions (J. Lansche); (16) Biogas from lignocellulosic biomass: interest of pretreatments (H. Carrere); (17) Effect of physical and thermal pre-treatments on biogas yield of some agricultural by-products (P. Balsari); (18) Extrusion pre-treatment of green waste for

  8. Climate gas balances of biogas and their significance; Klimagasbilanzen von Biogas und ihre Aussagekraft

    Energy Technology Data Exchange (ETDEWEB)

    Dressler, Daniela [HAWK Hildesheim Holzminden Goettingen, Goettingen (Germany). Fachgebiet Nachhaltige Energie- und Umwelttechnik NEUTec; Loewen, Achim; Nelles, Michael

    2012-07-01

    The greenhouse-gas balances of production and use of biogas strongly depend on specific parameters such as the input material, the system technology and/or the way the biogas is used. These parameters can vary from region to region and from plant to plant. Considering regional, local and plant-specific factors, in the district of Celle greenhouse-gas emissions are more than 3 times higher than in the district of Goettingen (0.2 resp. 0.06 kg CO{sub 2}-eqv./kWh{sub el}). Including further parameters such as indirect land use changes or an open storage of fermentation residues increases the differences of these specific results even more. Consequently a derivation of general values to calculate a climate protection potential for the production and use of biogas for all regions and/or countries is almost impossible. Climate protection potentials, created on the basis of general values, may therefore be considerably imprecise. (orig.)

  9. Biogas production with the use of mini digester

    OpenAIRE

    P. Vindis; B. Mursec; C. Rozman; M. Janzekovic; F. Cus

    2008-01-01

    Purpose: of this paper is to present the construction of a mini digester for biogas production from different energy plants and organic wastes. With the mini digester the amount of biogas production (methane) is observed.Design/methodology/approach: Firstly, the mini digester consisting of twelve units was built and secondly some measurements with energy plants were performed. The measurements were performed with mini digester according to DIN 38414 part 8. Four tests simultaneously with...

  10. Current aspects and new options of biogas production and utilisation; Aktuelle Aspekte und neue Moeglichkeiten der Biogaserzeugung und -nutzung

    Energy Technology Data Exchange (ETDEWEB)

    Weiland, P. [Bundesforschungsanstalt fuer Landwirtschaft (FAL), Inst. fuer Technologie und Biosystemtechnik - Abt. Technologie, Braunschweig (Germany)

    2003-07-01

    Biogas production has become increasingly important for renewable energy production and climate protection in Germany. Around 2000 biogas plants with a total electric capacity of 250 MW are in operation, but only 5% of the available substrate potential is used today. Nearly 95% of all plants are operated with co-fermentation using numerous energy rich organic wastes from food and agro-industry or special cultivated energy crops as co-substrates. Ensiled forage maize and grass silage are the most often preferred energy crops. For biogas production mainly wet-fermentation systems are used. In nearly all biogas plants the produced biogas is utilised in combined heat and power stations. (orig.)

  11. Operational experinece with large scale biogas production at the promest manure processing plant in Helmond, the Netherlands

    International Nuclear Information System (INIS)

    Schomaker, A.H.H.M.

    1992-01-01

    In The Netherlands a surplus of 15 million tons of liquid pig manure is produced yearly on intensive pig breeding farms. The dutch government has set a three-way policy to reduce this excess of manure: 1. conversion of animal fodder into a product with less and better ingestible nutrients; 2. distribution of the surplus to regions with a shortage of animal manure; 3. processing of the remainder of the surplus in large scale processing plants. The first large scale plant for the processing of liquid pig manure was put in operation in 1988 as a demonstration plant at Promest in Helmond. The design capacity of this plant is 100,000 tons of pig manure per year. The plant was initiated by the Manure Steering Committee of the province Noord-Brabant in order to prove at short notice whether large scale manure processing might contribute to the solution of the problem of the manure surplus in The Netherlands. This steering committee is a corporation of the national and provincial government and the agricultural industrial life. (au)

  12. Density of biogas digestate depending on temperature and composition.

    Science.gov (United States)

    Gerber, Mandy; Schneider, Nico

    2015-09-01

    Density is one of the most important physical properties of biogas digestate to ensure an optimal dimensioning and a precise design of biogas plant components like stirring devices, pumps and heat exchangers. In this study the density of biogas digestates with different compositions was measured using pycnometers at ambient pressure in a temperature range from 293.15 to 313.15K. The biogas digestates were taken from semi-continuous experiments, in which the marine microalga Nannochloropsis salina, corn silage and a mixture of both were used as feedstocks. The results show an increase of density with increasing total solid content and a decrease with increasing temperature. Three equations to calculate the density of biogas digestate were set up depending on temperature as well as on the total solid content, organic composition and elemental composition, respectively. All correlations show a relative deviation below 1% compared to experimental data. Copyright © 2015. Published by Elsevier Ltd.

  13. Integration of biogas in municipal energy planning and supply

    Energy Technology Data Exchange (ETDEWEB)

    Nedergaard, N.; Oertenblad, H. [Herning Municipal Utilities, Herning (Denmark)

    1997-08-01

    The first biogas plants in Denmark were based on local initiatives and a great deal of idealism. The break through with technically well functioning plants came at the end of the 80`ies. The plants were based on animal manure, and the development came together with the growing environmental demands and the legislation concerning storage capacity and distribution of the manure. This contributed to an increasing interest in joint biogas plants, mainly from the agricultural sector, but also from the industry. Today Denmark has 19 biogas plants in operation, all based on manure co-digested with wastes from the food industry, and 15 farm-scale plants. Only three of the joint plants are owned by a municipality, one plant in Aarhus and two in Herning. (au)

  14. Where AD plants wildly grow: The spatio-temporal diffusion of agricultural biogas production in the Czech Republic

    Czech Academy of Sciences Publication Activity Database

    Martinát, Stanislav; Navrátil, J.; Dvořák, Petr; Van der Horst, D.; Klusáček, Petr; Kunc, Josef; Frantál, Bohumil

    2016-01-01

    Roč. 95, September 2016 (2016), s. 85-97 ISSN 0960-1481 Institutional support: RVO:68145535 Keywords : agricultural anaerobic digestion plants * Czech Republic * spatial determinants * Spatial analysis Subject RIV: DE - Earth Magnetism, Geodesy, Geography Impact factor: 4.357, year: 2016 http://www.sciencedirect.com/science/article/pii/S0960148116302610

  15. Use of bio-enzymatic preparations for enhancement biogas production

    Directory of Open Access Journals (Sweden)

    Tomáš Vítěz

    2011-01-01

    Full Text Available Biogas is a renewable energy resource with high increasing developed in last few decades. It’s big opportunity for stabilization rural areas, concretely agriculture sector. This technology can decentralize supply of energy. The number of operated biogas plants is rapidly increasing. Biogas plants require a high level of intensity and stableness of the process of anaerobic fermentation with biogas production for efficiency treatment, also for good quality of development biogas and fertilization effect of the rest of fermentation. If this is not completed the operator has problem to keep the process in optimal condition for anaerobic fermentation. Researchers have tried different techniques to enhance biogas production. In order to achieve the aforementioned state, it is essential to ensure increased activity of microorganisms that contribute to the anaerobic fermentation. The metabolic activity of microorganisms is preconditioned by availability of easily decomposable solids. Adding of bacterial and enzymatic cultures into a fermented substrate represents one of the possibilities. The enzymes contained in this preparation are responsible for better exposing methanogenic bacteria to the material. The tested bio-enzymatic preparation, APD BIO GAS, is a mixture that contains bacteria and enzymes which are essential for the efficient progress of anaerobic fermentation. The reference biogas laboratory of the Mendel University in Brno was used for the purpose of testing of APD BIOGAS in mesophilic conditions of anaerobic fermentation on a substrate consisting of a mixture of maize silage and liquid manure. The producer of this preparation declare enhancement of quality and quantity of developed biogas, elimination of smell level of the rest of fermentation its higher homogenity. For the test were used lab scale fermenters of batch type with work volume 0.12 m3. An increase of biogas production by 15% was determined in connection with addition of the

  16. Pump transients in FGD slurry systems

    International Nuclear Information System (INIS)

    Ponce-Campos, C.D., Thoy, C.T.

    1990-01-01

    In this paper, the start-up transient of a limestone slurry system used for a power plant scrubber is discussed. Particular characteristics of these kind of systems are pointed out and incorporated into an ad-hoc numerical model. Three possible start-up scenarios are discussed and compared with field experimental data. The results illustrate well the importance of air pocket purging prior to system start-up

  17. Developing biogas as the hub of rural economical and energy construction

    Energy Technology Data Exchange (ETDEWEB)

    Renwu Zhang; Xiuwei Cheng; Zhiqiang He; Weirong Dong; Guizhen Sun

    2000-07-01

    In 1980's, in order to improve the agricultural environment and to increase rural economical, ecological and social benefits, Machangjian Village has undertaken various efforts on introduction and utilization of biogas, solar energy, ecosystems etc. and achieved good results. Until 1989, 616 family-scale biogas plants have been installed in this village. Not only is biogas used as daily fuel for farmers, but also digested effluent and residues which are beneficial to pigs, fish and plants. In addition, developing biogas has significantly improved rural sanitary conditions. On top of an underground biogas plant, a biogas and solar greenhouse was installed, in which solar energy was used to increase the temperature. A biogas lamp was used for lighting, and the carbon dioxide released was used as fertilizer for the plants in the greenhouse. In addition, since the greenhouse covered the biogas plant which maintained the plant temperature, the biogas plant could operate throughout the year. Until the end of 1989, there have been constructed 100 solar water heaters and 2 wind energy pumps in this village. Here water conserving types of agriculture, animal husbandry, forestry, orchards and agricultural production processes were comprehensively developed. This promoted local agriculture and husbandry production quality and quantity and accumulated a wealth of experience for suburban type of agricultural development. (orig.)

  18. COMPARISON BETWEEN BIOGAS PRODUCTION FROM MANURE OF LAYING HENERS AND BROILERS

    Directory of Open Access Journals (Sweden)

    Srećko Kukić

    2010-06-01

    Full Text Available Biogas plants that process raw materials from agriculture, such as poultry manure, are one of the most significant applications of anaerobic fermentation. In Asian countries, particularly in China, India, Nepal and Vietnam, there are several million very simple, small biogas plants that produce gas for household cooking and lighting. In Europe and North America a number of agricultural biogas plants now, are increasing daily, a few thousand biogas plants exist, most of which use modern technologies, anaerobic fermentation. The aim of this paper is to determine the possibility of biogas production from poultry manure with 10% of total solids and through the segments of the quality and quantity, determine the content of total solids (DM, volatile solids (OM, and the amount and composition of biogas. The aim was also to justify the use of poultry manure in biogas production and its application for specific purposes Laboratory research showed that 1 kg of poultry 10% of poultry manure produced 47.01 l of biogas during the 40 days of anaerobic fermentation under mezofilic conditions. Production of biogas has a good potential for development in Croatia, especially in the continental part. Usages of this technology are multiple because of the fact that the Republic of Croatia imports most of the energy. Usage of biogas would reduce the import of certain energy and thus reduce energy dependence; it would increase the number of employers and ease the obligation of Croatia toward EU in replacing some fossil fuels with renewable ones.

  19. Profiling of the metabolically active community from a production-scale biogas plant by means of high-throughput metatranscriptome sequencing

    DEFF Research Database (Denmark)

    Zakrzewski, Martha; Goesmann, Alexander; Jaenicke, Sebastian

    2012-01-01

    , it was shown that the most abundant species dominating the community also contributed the majority of the transcripts. In the future, key transcripts for the biogas production process will provide valuable markers for evaluation of the performance of biogas-producing microbial communities with the objective...... and to identify key transcripts for the biogas production process, the metatranscriptome of the microorganisms was sequenced for the first time. The metatranscriptome sequence dataset generated on the Genome Sequencer FLX platform is represented by 484,920 sequence reads. Taxonomic profiling of the active part...... of the community by classification of 16S ribosomal sequence tags revealed that members of the Euryarchaeota and Firmicutes account for the dominant phyla. Only smaller fractions of the 16S ribosomal sequence tags were assigned to the phyla Bacteroidetes, Actinobacteria and Synergistetes. Among the m...

  20. Ammonia abatement by slurry acidification

    DEFF Research Database (Denmark)

    Petersen, Søren O.; Hutchings, Nicholas J.; Hafner, Sasha D.

    2016-01-01

    Livestock production systems can be major sources of trace gases including ammonia (NH3), the greenhouse gases methane (CH4) and nitrous oxide (N2O), and odorous compounds such as hydrogen sulphide (H2S). Short-term campaigns have indicated that acidification of livestock slurry during in...... sections with 30-32 pigs with or without daily adjustment of slurry pH to below 6. Ammonia losses from reference sections with untreated slurry were between 9.5 and 12.4% of N excreted, and from sections with acidified slurry between 3.1 and 6.2%. Acidification reduced total emissions of NH3 by 66 and 71...

  1. Flexible Biogas in Future Energy Systems—Sleeping Beauty for a Cheaper Power Generation

    Directory of Open Access Journals (Sweden)

    Markus Lauer

    2018-03-01

    Full Text Available The increasing proportion of intermittent renewable energies asks for further technologies for balancing demand and supply in the energy system. In contrast to other countries, Germany is characterized by a high installed capacity of dispatchable biogas plants. For this paper, we analyzed the total system costs varying biogas extension paths and modes of operation for the period of 2016–2035 by using a non-linear optimization model. We took variable costs of existing conventional power plants, as well as variable costs and capital investments in gas turbines, Li-ion batteries, and pumped-storage plants into account. Without the consideration of the costs for biogas plants, an increasing proportion of biogas plants, compared to their phase out, reduces the total system costs. Furthermore, their flexible power generation should be as flexible as possible. The lowest total system costs were calculated in an extension path with the highest rate of construction of new biogas plants. However, the highest marginal utility was assessed by a medium proportion of flexible biogas plants. In conclusion, biogas plants can be a cost-effective option to integrate intermittent renewable energies into the electricity system. The optimal extension path of biogas plants depends on the future installed capacities of conventional and renewable energies.

  2. Assessment of energy performance in the life-cycle of biogas production

    International Nuclear Information System (INIS)

    Berglund, Maria; Boerjesson, Pal

    2006-01-01

    Energy balances are analysed from a life-cycle perspective for biogas systems based on 8 different raw materials. The analysis is based on published data and relates to Swedish conditions. The results show that the energy input into biogas systems (i.e. large-scale biogas plants) overall corresponds to 20-40% (on average approximately 30%) of the energy content in the biogas produced. The net energy output turns negative when transport distances exceed approximately 200 km (manure), or up to 700 km (slaughterhouse waste). Large variations exist in energy efficiency among the biogas systems studied. These variations depend both on the properties of the raw materials studied and on the system design and allocation methods chosen. The net energy output from biogas systems based on raw materials that have high water content and low biogas yield (e.g. manure) is relatively low. When energy-demanding handling of the raw materials is required, the energy input increases significantly. For instance, in a ley crop-based biogas system, the ley cropping alone corresponds to approximately 40% of the energy input. Overall, operation of the biogas plant is the most energy-demanding process, corresponding to 40-80% of the energy input into the systems. Thus, the results are substantially affected by the assumptions made about the allocation of a plant's entire energy demand among raw materials, e.g. regarding biogas yield or need of additional water for dilution

  3. Assessment of energy performance in the life-cycle of biogas production

    Energy Technology Data Exchange (ETDEWEB)

    Berglund, Maria; Boerjesson, Paal [Environmental and Energy Systems Studies LTH, Lund University, Gerdagatan 13, SE-223 62 Lund (Sweden)

    2006-03-15

    Energy balances are analysed from a life-cycle perspective for biogas systems based on 8 different raw materials. The analysis is based on published data and relates to Swedish conditions. The results show that the energy input into biogas systems (i.e. large-scale biogas plants) overall corresponds to 20-40% (on average approximately 30%) of the energy content in the biogas produced. The net energy output turns negative when transport distances exceed approximately 200km (manure), or up to 700km (slaughterhouse waste). Large variations exist in energy efficiency among the biogas systems studied. These variations depend both on the properties of the raw materials studied and on the system design and allocation methods chosen. The net energy output from biogas systems based on raw materials that have high water content and low biogas yield (e.g. manure) is relatively low. When energy-demanding handling of the raw materials is required, the energy input increases significantly. For instance, in a ley crop-based biogas system, the ley cropping alone corresponds to approximately 40% of the energy input. Overall, operation of the biogas plant is the most energy-demanding process, corresponding to 40-80% of the energy input into the systems. Thus, the results are substantially affected by the assumptions made about the allocation of a plant's entire energy demand among raw materials, e.g. regarding biogas yield or need of additional water for dilution. (author)

  4. Sewage biogas conversion into electricity; Conversao do biogas de tratamento de esgoto em eletricidade

    Energy Technology Data Exchange (ETDEWEB)

    Coelho, Suani Teixeira; Velazquez, Silvia Maria Stortini Gonzalez; Martins, Osvaldo Stella; Abreu, Fernando Castro de [Universidade de Sao Paulo (CENBIO/IEE/USP), Sao Paulo, SP (Brazil). Inst. de Eletrotecnica e Energia. Centro Nacional de Referencia em Biomassa], e-mails: suani@iee.usp.br, sgvelaz@iee.usp.br, omartins@iee.usp.br, fcabreu@iee.usp.br

    2006-07-01

    This article intend to present some considerations directed to electricity generation with small systems (micro turbine and conventional engines ), using biogas generated by sewage treatment process in SABESP (Basic Sanitation Company of Sao Paulo State), located at Barueri, Brazil. This project, pioneer in Latin America, is being accomplished together with BUN - Biomass Users Network of Brazil (proponent), in association with CENBIO - Biomass Reference National Center (executer), with patronage of FINEP / CT-ENERG (financial backer), by means of Convention no: 23.01.0653.00, regarding to ENERG BIOG Project - 'Installation and Tests of an Electric Energy Generation Demonstration Unit from Biogas Sewage Treatment'. The study is being done at Barueri Sewage Treatment Plant. This plant operate with anaerobic digestion process, which has as mainly products biogas (composed mainly by methane) and sludge. Part of the methane produced at the anaerobic process is burnt in a boiler being used to increase digesters temperature. The rest of the methane is burnt in flare to reduce the impacts caused by gases emissions. This article presents some technical, financial and environmental project results, related to the exploitation of sewer biogas for power generation, as well as bigger details about generation systems (biogas micro turbine), used in the facility. (author)

  5. Analysis of problems with dry fermentation process for biogas production

    Science.gov (United States)

    Pilát, Peter; Patsch, Marek; Jandačka, Jozef

    2012-04-01

    The technology of dry anaerobic fermentation is still meeting with some scepticism, and therefore in most biogas plants are used wet fermentation technology. Fermentation process would be not complete without an optimal controlled condition: dry matter content, density, pH, and in particular the reaction temperature. If is distrust of dry fermentation eligible it was on the workplace of the Department of Power Engineering at University of Zilina built an experimental small-scale biogas station that allows analysis of optimal parameters of the dry anaerobic fermentation, in particular, however, affect the reaction temperature on yield and quality of biogas.

  6. Bioconversion of poultry droppings for biogas and algal production

    Energy Technology Data Exchange (ETDEWEB)

    Mahadevaswamy, M.; Venkataraman, L.V.

    1986-01-01

    An integrated system for the bioconversion of poultry droppings for biogas production and utilization of the effluent for the production of the blue-green alga Spirulina platensis was studied. Poultry droppings produced 0.54 cubic m of biogas per kilogran of Total Solids (TS). The 2% TS biogas plant effluent as sole nutrient medium for Spirulina yielded 7-8 g dry algae a day. The biomass was harvested by filtration. The sundried algal biomass has been used as a poultry feed component. In economic terms the system appears promising. 18 references.

  7. New stakeholder actions and cooperate-design concepts for enhancing a future development and dissemination of the biogas technology in Denmark

    DEFF Research Database (Denmark)

    Lybæk, Rikke; Andersen, Jan; Christensen, Thomas Budde

    2013-01-01

    This paper emphasizes the barriers of implementing biogas plants in Denmark and highlights the many advantages of the technology as far as environmental, energy and agricultural related benefits, and showing the importance of a further biogas development. The most important current barriers are d......-design concepts, as opposed to the traditional centralized and farm biogas plants established. Suggestions are provided in this paper....

  8. Physical properties, fuel characteristics and P-fertilizer production related to animal slurry and products from separation of animal slurry

    DEFF Research Database (Denmark)

    Thygesen, Ole; Johnsen, Tina; Triolo, Jin Mi

    to high water content, suggesting a drying of the manure fibre would be favourable. The mean P concentration in the ashes was 112, 123, 157, and 51 g kg-1 for AD, pigs, mink and cattle respectively. Manure fibre ashes derived from cattle slurry and AD plants, which used feed with a high percentage...... from slurry separation and phosphorus (P) fertilizer production from recycling of the ash. Manure fibre has a positive calorific value and may be used as a CO2-neutral fuel for combustion. The ashes from combustion are rich in P, an essential fertilizer compound. The study is based on samples of animal...... of cattle slurry, contained too little P to be suitable for fertilizer production, as did pig slurry, to which sulphuric acid had been added prior to separation. Low solubility of P means the ashes should be treated before being used as a fertilizer. The acid consumption in a simple fertilizer production...

  9. Biogas of manure and sludge

    Science.gov (United States)

    Kraemer, F.; Gundermann, J.; Kofoed, E.; Nielsen, J.

    1981-01-01

    Biogas production from farmyard manures and sewage sludges is based on anaerobic processes (methane-bacteria) and aerobic processes (fermentative bacteria). Biogas product has high calorific value and a number of small, pilot-scale and full-scale municipal systems of biogas production is described inclusive technological solutions and cost-benefit analysis. Experience of electric power generators fueled by biogas is evaluated from the view point of competitiveness with other fuels.

  10. Sustainable sunlight to biogas is via marginal organics.

    Science.gov (United States)

    Shilton, Andy; Guieysse, Benoit

    2010-06-01

    Although biogas production from algae offers higher sunlight to biomass energy conversion efficiencies its production costs simply cannot compete with terrestrial plants. Unfortunately terrestrial plant cropping for biogas production is, in its own right, neither particularly sustainable nor profitable and its ongoing application is only driven by energy security concerns resulting in taxpayer subsidies. By comparison, scavenging the organic energy residual/wastes from food production offers a far more profitable and sustainable proposition and has an energy potential that dwarfs anything biogas production from dedicated energy crops can realistically offer. Thus researchers wanting to assist the development of sustainable biogas systems with viable process economics should forget about terrestrial and algal energy cropping and focus on the realm of scavengers. Copyright 2010 Elsevier Ltd. All rights reserved.

  11. Socio-economic evaluation of selected biogas technologies

    Energy Technology Data Exchange (ETDEWEB)

    Moeller, F.; Martinsen, L.

    2013-05-15

    Financial and welfare economic analyses are conducted of 15 different biogas production scenarios that vary in terms of plant size and type of input. All considered scenarios lead to welfare economic losses. Overall welfare economic GHG reduction costs seem to increase with increasing crop/crop material share of input, and although the costs vary significantly across scenarios they are quite high for all scenarios. The financial analyses suggest that biogas production generally will be financially profitable for the agricultural sector and local CHP facilities but unprofitable for the biogas plants and the State. Seen from a policy perspective the results highlights the importance of designing regulatory instruments in a way that create incentives for private actors to engage in welfare economically desirable biogas production activities while discouraging the expansion of welfare economically undesirable activities. (Author)

  12. Use of the Sabatier Process for Dynamic Biogas Upgrading in Northern Germany

    DEFF Research Database (Denmark)

    Jurgensen, Lars; Ehimen, Ehiazesebhor Augustine; Born, Jens

    2014-01-01

    Approximately 8000 farm scale biogas plants are present in Germany which produce electricity (mainly using energy crops as substrates) . The potential role of biogas plants in energy systems penetrated by high amounts of fluctuating renewable energy production is discussed in this paper. Today th...

  13. Spatial competition for biogas production using insights from retail location models

    DEFF Research Database (Denmark)

    Bojesen, Mikkel; Birkin, M.; Clarke, G.

    2014-01-01

    analysis framework developed in this paper, facilitate the analysis and discussion of how national policies can be fulfilled. The capacity expansion of the Danish biogas sector should be centred on large-scale biogas production since large biogas plants are found to have 16% lower transportation costs than...... small biogas plants. Consequently, this minimizes the single most important production cost factor, transportation. The developed framework can be used and further developed in an analysis of how the spatial availability of, and competition for, different types of biomass can supplement each other...... in the development towards a bio-based economy....

  14. Methodology for the determination of optimum power of a Thermal Power Plant (TPP) by biogas from sanitary landfill.

    Science.gov (United States)

    Silva, Tiago Rodrigo; Barros, Regina Mambeli; Tiago Filho, Geraldo Lúcio; Dos Santos, Ivan Felipe Silva

    2017-07-01

    This study aimed to determine theoretically, the electrical optimum power of LFG using the maximum net benefit (MNB) methodology, and taking into consideration the economic, demographic, and regional aspects of the Inter municipal Consortium of the Micro-region of the High Sapucaí for Sanitary Landfill (CIMASAS, as acronym in Portuguese), that is located in the southern part of the State of Minas Gerais, Brazil. To this end, the prognosis for a 20-year period of household solid waste generation in this region was estimated and quantified based on population data, in order to estimate the LFG production and the energy that can be generated. From this point, the optimum power for thermal power plant (TPP) by LFG was determined. The results indicated that the landfill in this region could produce more 66,293,282m 3 CH 4 (with maximum power of 997kW in 2036) in twenty years and that there would be no economic viability to generate energy from LFG, because the Net Present Value (NPV) would not be positive. The smallest population to that can achieve a minimum attractiveness rate (MAR) of 15% should be 3,700,000 inhabitants under the conditions studied. Considering the Brazilian National Electric Energy Agency (ANEEL) Resolutions, it would be 339,000 inhabitants with an installed power of 440kW. In addition, the outcome of the CIMASAS case-study demonstrated the applicability of MNB methodology for the determination of TPP optimum power. Copyright © 2017 Elsevier Ltd. All rights reserved.

  15. International scientific conference biogas science 2009. Vol. 1. Lectures; Internationale Wissenschaftstagung Biogas Science 2009. Bd. 1. Vortraege

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2009-12-15

    Within the international conference of the Bavarian State Research Center for Agriculture (Munich, Federal Republic of Germany) at 2nd to 4th December, 2009, in Erding (Federal Republic of Germany), the following lectures were held: (1) Significance of the sector biogas within the scope of renewable energies (P. Schuesseler); (2) Anaerobic digestion, a superior renewable energy degradation method (G. Lettinga); (3) Trends of the biogas technology - Challenges for the practice (J. Pellmeyer); (4) Extensification of cultivation procedures for the production of biogas substrates (K. Deiglmayer et al.); (5) Approaches for the optimization of crop rotations for biogas plants at Bavarian conditions of cultivation (E. Sticksel et al.); (6) Development and comparison of site specific production systems for energy crops (Ch. Strauss et al.); (7) Which type of maize is useful for the production of biogas? (B. Eder et al.); (8) Fermentation of interim fruits, food stocks and residues of harvest: Review on the possibilities of power generation and avoidance of direct and indirect emissions of climatic gases (W. Stinner et al.); (9) Optimization of anaerobic fermentation by means of mineral additives (H. Heuwinkel et al.); (10) The accuracy of the measurement of gas yields of substrates using the batch method (H. Heuwinkel et al.); (11) Combined mechanical-enzymatic pre-treatment of an improved digestion of substrates during the fermentation of renewable raw materials (D. Schiedr et al.); (12) Anaerobic semi-continuous co-digestion of dairy cattle manure and agricultural residues: Effect of operational parameters (E. Alkaya et al.); (13) Do hydrolytic enzymes enhance methane formation of agricultural feedstock? (T. Suarez Quinones et al.); (14) DAUMEN-Energy ''Design fo Separation and Augmented Methanisation of Fibres Substrates - Contribution to sustainable biogas production'' (P. Stopp et al.); (15) Continuous two-phase solid-state anaerobic digestion

  16. Trend chart: biogas for electricity production. First quarter 2017

    International Nuclear Information System (INIS)

    2017-05-01

    This publication presents the situation of biogas-fueled power plants in continental France and overseas territories during the first quarter 2017: total connected load, new connected facilities, power range distribution of facilities, evolution of park facilities and projection, distribution by type of facilities, regional distribution of facilities, total connected load by region, overall national power generation from biogas, evolution of newly connected methanation facilities for power generation, power range distribution of methanation facilities, regional distribution of methanation facilities, methodology used

  17. Trend chart: biogas for electricity production. Fourth quarter 2017

    International Nuclear Information System (INIS)

    Moreau, Sylvain

    2018-02-01

    This publication presents the situation of biogas-fueled power plants in continental France and overseas territories during the fourth quarter 2017: total connected load, new connected facilities, power range distribution of facilities, evolution of park facilities and projection, distribution by type of facilities, regional distribution of facilities, total connected load by region, overall national power generation from biogas, evolution of newly connected methanation facilities for power generation, power range distribution of methanation facilities, regional distribution of methanation facilities

  18. Trend chart: biogas for electricity production. Second quarter 2017

    International Nuclear Information System (INIS)

    2017-08-01

    This publication presents the situation of biogas-fueled power plants in continental France and overseas territories during the second quarter 2017: total connected load, new connected facilities, power range distribution of facilities, evolution of park facilities and projection, distribution by type of facilities, regional distribution of facilities, total connected load by region, overall national power generation from biogas, evolution of newly connected methanation facilities for power generation, power range distribution of methanation facilities, regional distribution of methanation facilities

  19. Trend chart: biogas for electricity production. Third quarter 2017

    International Nuclear Information System (INIS)

    Moreau, Sylvain

    2017-11-01

    This publication presents the situation of biogas-fueled power plants in continental France and overseas territories during the third quarter 2017: total connected load, new connected facilities, power range distribution of facilities, evolution of park facilities and projection, distribution by type of facilities, regional distribution of facilities, total connected load by region, overall national power generation from biogas, evolution of newly connected methanation facilities for power generation, power range distribution of methanation facilities, regional distribution of methanation facilities

  20. Pretreaments of Chinese Agricultural residues to increase biogas production

    OpenAIRE

    Wang, Yu

    2010-01-01

    Development of biological conversion of lignocellulosic biomass to biogas is one approach to utilize straw comprehensively. However, high lignin contents of lignocellulosic materials results in low degradation. The main aim of this study was to investigate the appropriate pre-treatment to increase biogas production from Chinese agricultural residues. In this study, Chinese corn stalk, rice plant and wheat straw were evaluated as substrates by applying three different pre-treatments. The inves...

  1. Proceedings of the 1. annual Canadian farm and food biogas conference and exhibition

    International Nuclear Information System (INIS)

    2009-01-01

    This conference provided a forum for researchers, farmers, and electric utility operators to discuss issues related to the growth of Canada's biogas industry. Many farmers are now exploring methods of producing biogas from agricultural wastes using anaerobic digestion technologies. However, regulatory problems continue to stall the growth of the fledgling biogas industry. In addition, many biogas plants face challenges related to ensuring reliable grid connections. European and American perspectives on biogas development were presented at the conference along with issues related to provincial and federal regulations and policies. Technologies and strategies for connecting biogas systems with other power systems were presented. The conference was divided into 11 sessions and 2 plenary sessions: (1) B1 grid connection solutions; (2) B2D energy crops and other plant-based co-substrates; (3) B2E Ontario biogas today; (4) B3D mixed materials; (5) B3E siting, odour and safety; (6) B4D economics and policy issues; (7) B4E genset performance and efficiency panel; (8) B5D case studies of food or farm biogas systems; (9) B5E case studies of farm-based systems; (10) B6D biogas next steps; and (11) B6E biogas in an urban setting. The conference featured 42 presentations, of which 5 have been catalogued separately for inclusion in this database. A set of 12 poster presentations were also presented, as well as several networking forums. tabs., figs

  2. Sludge storage lagoon biogas recovery and use. Volume 2

    Energy Technology Data Exchange (ETDEWEB)

    Muller, D.; Norville, C. [Memphis and Shelby County Div. of Planning and Development, TN (United States)

    1991-07-01

    The City of Memphis has two wastewater treatment plants. The SWTP employs two large anaerobic digestion sludge lagoons as part of the overall sludge treatment system. Although these lagoons are effective in concentrating and digesting sludge, they can generate offensive odors. The SWTP uses aerobic digesters to partially stabilize the sludge and help reduce objectionable odors before it enters the lagoons. The anaerobic digestion of sludge in the lagoons results in the dispersion of a large quantity of biogas into the atmosphere. The City realized that if the lagoons could be covered, the odor problem could be resolved, and at the same, time, biogas could be recovered and utilized as a source of energy. In 1987, the City commissioned ADI International to conduct a feasibility study to evaluate alternative methods of covering the lagoons and recovering and utilizing the biogas. The study recommended that the project be developed in two phases: (1) recovery of the biogas and (2) utilization of the biogas. Phase 1 consists of covering the two lagoons with an insulated membrane to control odor and temperature and collect the biogas. Phase 1 was found to be economically feasible and offered a unique opportunity for the City to save substantial operating costs at the treatment facility. The Memphis biogas recovery project is the only application in the world where a membrane cover has been used on a municipal wastewater sludge lagoon. It is also the largest lagoon cover system in the world.

  3. Challenges in biogas production

    DEFF Research Database (Denmark)

    Rennuit, Charlotte

    2017-01-01

    Anaerobic digestion (AnD) is a sustainable process combining waste treatment, nutrient recycling and energy production which can contribute to limit climate change and environmental problems. However, in order for this technique to be more widely used, production of biogas from available wastes...... from a mixture of pig manure and other waste materials by separating the solid fraction of digestate and recycling it back to the digester. It is shown that separation and recycling of the dry matter rich solid fraction could successfully increase biogas production and a preliminary economic evaluation...... showed a potential increase of 1.9 to 6.8€ per ton of biomass treated. In the second part of this study, a biological treatment to improve energy production from wastewater sludge was investigated. Wastewater sludge was subjected to thermophilic aerobic digestion (TAD) from 2h to 5d. Increase in biogas...

  4. Anaerobic co-digestion of the organic fraction of municipal solid waste with FOG waste from a sewage treatment plant: Recovering a wasted methane potential and enhancing the biogas yield

    International Nuclear Information System (INIS)

    Martin-Gonzalez, L.; Colturato, L.F.; Font, X.; Vicent, T.

    2010-01-01

    Anaerobic digestion is applied widely to treat the source collected organic fraction of municipal solid wastes (SC-OFMSW). Lipid-rich wastes are a valuable substrate for anaerobic digestion due to their high theoretical methane potential. Nevertheless, although fat, oil and grease waste from sewage treatment plants (STP-FOGW) are commonly disposed of in landfill, European legislation is aimed at encouraging more effective forms of treatment. Co-digestion of the above wastes may enhance valorisation of STP-FOGW and lead to a higher biogas yield throughout the anaerobic digestion process. In the present study, STP-FOGW was evaluated as a co-substrate in wet anaerobic digestion of SC-OFMSW under mesophilic conditions (37 o C). Batch experiments carried out at different co-digestion ratios showed an improvement in methane production related to STP-FOGW addition. A 1:7 (VS/VS) STP-FOGW:SC-OFMSW feed ratio was selected for use in performing further lab-scale studies in a 5 L continuous reactor. Biogas yield increased from 0.38 ± 0.02 L g VS feed -1 to 0.55 ± 0.05 L g VS feed -1 as a result of adding STP-FOGW to reactor feed. Both VS reduction values and biogas methane content were maintained and inhibition produced by long chain fatty acid (LCFA) accumulation was not observed. Recovery of a currently wasted methane potential from STP-FOGW was achieved in a co-digestion process with SC-OFMSW.

  5. Life cycle assessment of coupling household biogas production to agricultural industry: A case study of biogas-linked persimmon cultivation and processing system

    International Nuclear Information System (INIS)

    Chen, Bin; Chen, Shaoqing

    2013-01-01

    Biogas plant construction has been boosted in rural China not only due to the immediate merit from biogas production but also the succeeding benefit from by-product utilization in agro-industry, both of which are significant strategies to address energy shortage and global warming issues. However, little work has been done to evaluate the coupling of biogas projects to traditional agrosystems from a life-cycle perspective, which is most important in process and system optimization in different senses. By taking persimmon cultivation and processing with supports from a household biogas plant as a case study, this study conducts a life cycle assessment of coupling biogas production to agro-industry in terms of energy, environmental and economic performance. The results suggest that each production stage following the biogas/digestate utilization chain (biogas operation-persimmon cultivation-product processing) is beneficial across all three aspects. However, a tradeoff only exists in utilizing digestate as top-dressing and employing biogas utilization as engine fuel, while biogas application in fresh-keeping and digestate reuse as base fertilizer fails to increase either energy production or greenhouse gas mitigation. The coupled system can be hopefully optimized through increasing fermentation efficiency and joint operation of biogas digesters. -- Highlights: •Biogas/digestate utilization is overall beneficial in all production stages. •Each bioresource application may not be profitable in all respects. •Tradeoffs in using biogas and digestate vary among different utilization ways. •Multi-user operation and fermentation efficiency elevation optimize system

  6. Vitrification of SRP waste by a slurry-fed ceramic melter

    International Nuclear Information System (INIS)

    Wicks, G.G.

    1980-01-01

    Savannah River Plant (SRP) high-level waste (HLW) can be vitrified by feeding a slurry, instead of a calcine, to a joule-heated ceramic melter. Potential advantages of slurry feeding include (1) use of simpler equipment, (2) elimination of handling easily dispersed radioactive powder, (3) simpler process control, (4) effective mixing, (5) reduced off-gas volume, and (6) cost savings. Assessment of advantages and disadvantages of slurry feeding along with experimental studies indicate that slurry feeding is a promising way of vitrifying waste

  7. Utilization of Kitchen Waste inside Green House Chamber: A Community Level Biogas Programme

    OpenAIRE

    Ravi P. Agrahari

    2013-01-01

    The present study was undertaken with the objective of evaluating kitchen waste as an alternative organic material for biogas production in community level biogas plant. The field study was carried out for one month (January 19, 2012– February 17, 2012) at Centre for Energy Studies, IIT Delhi, New Delhi, India. This study involves the uses of greenhouse canopy to increase the temperature for the production of biogas in winter period. In continuation, a semi-continuous study was conducted ...

  8. Beets for biogas. News from the laboratory and practice; Rueben fuer Biogas. Neues aus Labor und Praxis

    Energy Technology Data Exchange (ETDEWEB)

    Jeche, Ulrike [KWS Saat AG, Einbeck (Germany). Vertrieb Zuckerruebe Deutschland und Oesterreich; Schaffner, Sebastian

    2011-07-01

    Being a multi-talented crop, sugar beets are increasingly convincing biogas plant owners with their positive properties. In a mixture of substrates, they are a perfect partner for biogas production as they can push gas yield. In breeding, the experts mainly focus on increasing dry matter yield. There is a close correlation with sugar yield. The market already offers a multitude of highly performing sugar beet varieties for most diverse cropping conditions. The beets are harvested and transported from the field to the biogas plant with harvesting and transport technology which has proved its efficiency for many years. Other than harvested for other purposes, sugar beet for biogas production are stripped of their leaves instead of being topped. Stocking sugar beet at the biogas plant is a quite demanding issue. Sugar beets may be stocked as ensiled, whole beet, as pulp, or as crushed beet in mixed silage. There is a whole range of most diverse storage and crushing concepts. When used as a substrate for biogas production, sugar beet mostly need to be cleaned and stones need to be discarded before feeding the beets into the digester. In the meanwhile, the market offers a large choice of cleaning technique to pave the ways for sugar beets as a substrate. (orig.)

  9. Short-term effect of acetate and ethanol on methane formation in biogas sludge.

    Science.gov (United States)

    Refai, Sarah; Wassmann, Kati; Deppenmeier, Uwe

    2014-08-01

    Biochemical processes in biogas plants are still not fully understood. Especially, the identification of possible bottlenecks in the complex fermentation processes during biogas production might provide potential to increase the performance of biogas plants. To shed light on the question which group of organism constitutes the limiting factor in the anaerobic breakdown of organic material, biogas sludge from different mesophilic biogas plants was examined under various conditions. Therefore, biogas sludge was incubated and analyzed in anaerobic serum flasks under an atmosphere of N2/CO2. The batch reactors mirrored the conditions and the performance of the full-scale biogas plants and were suitable test systems for a period of 24 h. Methane production rates were compared after supplementation with substrates for syntrophic bacteria, such as butyrate, propionate, or ethanol, as well as with acetate and H2+CO2 as substrates for methanogenic archaea. Methane formation rates increased significantly by 35 to 126 % when sludge from different biogas plants was supplemented with acetate or ethanol. The stability of important process parameters such as concentration of volatile fatty acids and pH indicate that ethanol and acetate increase biogas formation without affecting normally occurring fermentation processes. In contrast to ethanol or acetate, other fermentation products such as propionate, butyrate, or H2 did not result in increased methane formation rates. These results provide evidence that aceticlastic methanogenesis and ethanol-oxidizing syntrophic bacteria are not the limiting factor during biogas formation, respectively, and that biogas plant optimization is possible with special focus on methanogenesis from acetate.

  10. Use of biogas in PEM fuel cells; Einsatz von Biogas in PEM-Brennstoffzellen

    Energy Technology Data Exchange (ETDEWEB)

    Scholz, Volkhard; Schmersahl, Ralf; Ellner, Janine (comps.)

    2009-06-15

    This research project was dedicated to two problems: 1. What demands must biogas meet in order to conform to the specifications of PEM fuel cell systems and permit safe operation? 2. How must a fuel cell system be designed and operated in order to be well-adapted to the special features of biogas as opposed to natural gas? For this purpose biogas samples were taken from laboratory-scale and commercial plants and analysed by gas chromatography using various substrates and methods. By combining this with the use of a mass spectroscopy detector (GC-MS system) it was possible to perform a qualitative and quantitative analysis of sulphurious trace gases in the biogas which might cause damage to the fuel cell system. Investigations were performed on an experimental reformer using either modelled or native biogas of different compositions, the intent being to obtain information for the design of the individual process stages. The two operating parameters steam-methane ratio (or S/C ratio) and reforming temperature were varied to optimise parameter settings in terms of energy efficiency. By linking the reformer to a 500 W fuel cell it was possible confirm the suitability of the reformed biogas for use in fuel cells. [German] In diesm Forschungsvorhaben werden zwei Fragestellungen bearbeitet: 1. Welche Anforderungen ergeben sich an das Biogas, um den Spezifikationen von PEM-Brennstoffzellensystemen zu genuegen und eine sicheren Betrieb zu ermoeglichen? 2. Wie muss das Brennstoffzellensystem ausgelegt und gefuehrt werden, um den Besonderheiten von Biogas im Vergleich zu Erdgas Rechnung zu tragen? Dazu wurden Biogasproben aus Labor- und Praxisanlagen unter Beruecksichtigung unterschiedlicher Substrate und Verfahren gaschromatisch analysiert. Die Kopplung mit einem massenspektroskopischen Detektor (GC-MS System) ermoeglicht dabei die Qualifizierung und Quantifizierung der vorhandenen schwefelhaltigen Spurengase, die eine Schaedigung von Brennstoffzellenanlagen verursachen. Die

  11. Life cycle assessment of agricultural biogas production systems

    International Nuclear Information System (INIS)

    Lansche, J.; Muller, J.

    2010-01-01

    Agricultural activities are large contributors to anthropogenic greenhouse gas emissions. This paper discussed the effectiveness of reducing agricultural emissions by using liquid manure to produce biogas. When using this technique, greenhouse gas emissions from manure storage are avoided and renewable energy is generated as heat and electricity in combined heat and power plants. The purpose of this study was to evaluate the environmental impacts of biogas production systems based on the methods of life cycle assessment. The traditional use of agricultural manures was compared with conventional energy production. The Gabi 4.3 software was used to create a model to evaluate the biogas production systems according to their environmental impact. In addition to the global warming potential, other impact categories were also used to evaluate the effects of the systems in eutrophication and acidification. It was concluded that environmental benefits can be obtained in terms of greenhouse gas emissions compared to electricity production from biogas with the typical German marginal electricity mix.

  12. Life cycle assessment of agricultural biogas production systems

    Energy Technology Data Exchange (ETDEWEB)

    Lansche, J.; Muller, J. [Hohenheim Univ., Stuttgart (Germany). Inst. of Agricultural Engineering, Tropical and Subtropical Group

    2010-07-01

    Agricultural activities are large contributors to anthropogenic greenhouse gas emissions. This paper discussed the effectiveness of reducing agricultural emissions by using liquid manure to produce biogas. When using this technique, greenhouse gas emissions from manure storage are avoided and renewable energy is generated as heat and electricity in combined heat and power plants. The purpose of this study was to evaluate the environmental impacts of biogas production systems based on the methods of life cycle assessment. The traditional use of agricultural manures was compared with conventional energy production. The Gabi 4.3 software was used to create a model to evaluate the biogas production systems according to their environmental impact. In addition to the global warming potential, other impact categories were also used to evaluate the effects of the systems in eutrophication and acidification. It was concluded that environmental benefits can be obtained in terms of greenhouse gas emissions compared to electricity production from biogas with the typical German marginal electricity mix.

  13. The secondary slurry-zinc/air battery

    Science.gov (United States)

    Sierraalcazar, H. B.; Nguyen, P. D.; Mason, G. E.; Pinoli, A. A.

    1989-07-01

    The rechargeability of the slurry-Zn/air battery was demonstrated with a practical recharge cell that requires minimal hydraulic and mechanical energy for operation. A dendritic Zn was deposited on a Mg plate substrate from which it was easily, periodically and automatically scraped to regenerate dendritic Zn slurries. Excellent discharge results were obtained with the regenerated dendritic Zn slurry, comparable to those obtained with slurries made with mixtures of Zn powder. The dendritic Zn slurry allowed, however, twice the utilization of Zn.

  14. Microalgae as substrates for fermentative biogas production in a combined biorefinery concept.

    Science.gov (United States)

    Mussgnug, J H; Klassen, V; Schlüter, A; Kruse, O

    2010-10-01

    Most organic matter can be used for bioenergy generation via anaerobic fermentation. Today, crop plants like maize play the dominant role as substrates for renewable biogas production. In this work we investigated the suitability of six dominant microalgae species (freshwater and saltwater algae and cyanobacteria) as alternative substrates for biogas production. We could demonstrate that the biogas potential is strongly dependent on the species and on the pretreatment. Fermentation of the green alga Chlamydomonas reinhardtii was efficient with a production of 587 ml(±8.8 SE) biogas g volatile solids(-1) (VS(-1)), whereas fermentation of Scenedesmus obliquus was inefficient with only 287 ml(±10.1 SE) biogas g VS(-1) being produced. Drying as a pretreatment decreased the amount of biogas production to ca. 80%. The methane content of biogas from microalgae was 7-13% higher compared to biogas from maize silage. To evaluate integrative biorefinery concepts, hydrogen production in C. reinhardtii prior to anaerobic fermentation of the algae biomass was measured and resulted in an increase of biogas generation to 123% (±3.7 SE). We conclude that selected algae species can be good substrates for biogas production and that anaerobic fermentation can seriously be considered as final step in future microalgae-based biorefinery concepts. Copyright © 2010 Elsevier B.V. All rights reserved.

  15. Guide biogas. From production to utilization. 5. compl. rev. ed.; Leitfaden Biogas. Von der Gewinnung zur Nutzung

    Energy Technology Data Exchange (ETDEWEB)

    NONE

    2010-07-01

    The book under consideration is a guide for biogas and consists of the following contributions: (a) Targets of the guide (M. Kaltschmitt); (b) Fundamentals of anaerobic fermentation (J. Friehe); (c) Systems engineering for supplying biogas (J. Postel); (d) Description of selected substrates (J. Friehe); (e) Operation of biogas plants (J. Liebetrau); (f) Gas processing and possibilities of utilization (M. Wetthaeuser); (g) Legal and administrative framework conditions (H. von Bredow); (g) Economy (S. Hartmann); (h) Company organisation (G. Reinhold); (i) Quality and utilization of fermentation residues (H. Doehler); (j) Implementation of a project (E. Fischer); (k) Position and significance of biogas as a renewable energy resource in Germany (M. Kaltschmitt); (l) Project examples (J. Friehe).

  16. Medical ice slurry production device

    Science.gov (United States)

    Kasza, Kenneth E [Palos Park, IL; Oras, John [Des Plaines, IL; Son, HyunJin [Naperville, IL

    2008-06-24

    The present invention relates to an apparatus for producing sterile ice slurries for medical cooling applications. The apparatus is capable of producing highly loaded slurries suitable for delivery to targeted internal organs of a patient, such as the brain, heart, lungs, stomach, kidneys, pancreas, and others, through medical size diameter tubing. The ice slurry production apparatus includes a slurry production reservoir adapted to contain a volume of a saline solution. A flexible membrane crystallization surface is provided within the slurry production reservoir. The crystallization surface is chilled to a temperature below a freezing point of the saline solution within the reservoir such that ice particles form on the crystallization surface. A deflector in the form of a reciprocating member is provided for periodically distorting the crystallization surface and dislodging the ice particles which form on the crystallization surface. Using reservoir mixing the slurry is conditioned for easy pumping directly out of the production reservoir via medical tubing or delivery through other means such as squeeze bottles, squeeze bags, hypodermic syringes, manual hand delivery, and the like.

  17. Comparative testing of slurry monitors

    International Nuclear Information System (INIS)

    Hylton, T.D.; Bayne, C.K.; Anderson, M.S.; Van Essen, D.C.

    1998-05-01

    The US Department of Energy (DOE) has millions of gallons of radioactive liquid and sludge wastes that must be retrieved from underground storage tanks, transferred to treatment facilities, and processed to a final waste form. The wastes will be removed from the current storage tanks by mobilizing the sludge wastes and mixing them with the liquid wastes to create slurries. Each slurry would then be transferred by pipeline to the desired destination. To reduce the risk of plugging a pipeline, the transport properties (e.g., density, suspended solids concentration, viscosity, particle size range) of the slurry should be determined to be within acceptable limits prior to transfer. These properties should also be monitored and controlled within specified limits while the slurry transfer is in progress. The DOE issued a call for proposals for developing on-line instrumentation to measure the transport properties of slurries. In response to the call for proposals, several researchers submitted proposals and were funded to develop slurry monitoring instruments. These newly developed DOE instruments are currently in the prototype stage. Before the instruments were installed in a radioactive application, the DOE wanted to evaluate them under nonradioactive conditions to determine if they were accurate, reliable, and dependable. The goal of this project was to test the performance of the newly developed DOE instruments along with several commercially available instruments. The baseline method for comparison utilized the results from grab-sample analyses

  18. Ash study for biogas purification

    International Nuclear Information System (INIS)

    Juarez V, R. I.

    2016-01-01

    This work evaluates the ashes generated from the wood and coal combustion process of the thermoelectric plant in Petacalco, Guerrero (Mexico) in order to determine its viability as a filter in the biogas purification process. The ash is constituted by particles of morphology and different chemical properties, so it required a characterization of the same by different analytical techniques: as was scanning electron microscopy and X-ray diffraction, in order to observe the microstructure and determine the elemental chemical composition of the particles. Prior to the analysis, a set of sieves was selected to classify as a function of particle size. Four different types of ashes were evaluated: one generated by the wood combustion (wood ash) and three more of the Petacalco thermoelectric generated by the coal combustion (wet fly ash, dry fly ash and dry bottom ash). (Author)

  19. PEMETAAN POTENSI BIOGAS DI KOTA METRO

    Directory of Open Access Journals (Sweden)

    Riswanto Riswanto

    2017-09-01

    Full Text Available Metro City is a developing city that attracts many new citizens to come and live in the city of Metro. It affects the density and population growth in the city of Metro so it boils down to the increasing need for energy for fuel such as gas and electricity needs. UU No. 33 of 2007 the government seeks to optimize the role of PEMDA and communities and academics to be able to take advantage of the various potential that may be developed in their respective city in meeting energy needs. The survey results show the picture that the city of Metro has potential in the utilization of biogas energy. The availability of this organic material is quite common in Metro city. But the availability of the material has not been classified in number and variety. For that, we need to do research in mapping biogas potential in every area in Metro city. The research method used is the method of documentation, observation, and interview. As for data analysis techniques, conducted qualitatively and quantitatively through the findings of observations in the form of descriptions, calculation analysis, and tabulation. The results obtained show that the North Metro sub-district has the highest potential for biogas development. The most common materials are animal waste derived from cow dung as much as 84% and biogas from plants that are from rice straw (54% and Tahu/tempe processing waste (38%. Other organic ingredients found are chicken, goat, buffalo, and banana peels. This result shows that the biogas potency of Metro City is best developed that is through the use of cow dung

  20. A methodology for financial evaluation of biogas technology in India using cost functions

    International Nuclear Information System (INIS)

    Rubab, S.; Kandpal, T.C.

    1996-01-01

    A methodology for financial evaluation of biogas technology for domestic use in India using recently developed cost functions is reported. Analytical expressions for the unit cost of biogas and cost per unit of useful energy delivered by a biogas plant in combination with other suitable technologies have been developed. Net present value and discounted pay-back period have been calculated. The sensitivity of the unit cost of biogas, the cost per unit of useful energy, and the net present value with respect to a number of variables is also reported. (author)

  1. Solutions for Foaming Problems in Biogas Reactors Using Natural Oils or Fatty Acids as Defoamers

    DEFF Research Database (Denmark)

    Kougias, Panagiotis; Boe, Kanokwan; Angelidaki, Irini

    2015-01-01

    Foaming is one of the most common and important problems in biogas plants, leading to severe operational, economical, and environmental drawbacks. Because addition of easily degradable co-substrates for boosting the biogas production can suddenly raise the foaming problem, the full-scale biogas...... results from our previous extensive research along with some unpublished data on defoaming by rapeseed oil and oleic acid in manure-based biogas reactors. It was found that both compounds exhibited remarkable defoaming efficiency ranging from 30 to 57% in biogas reactors suffering from foaming problems...... promoted by the addition of protein, lipid, or carbohydrate co-substrates. However, in most cases, the defoaming efficiency of rapeseed oil was greater than that of oleic acid, and therefore, rapeseed oil is recommended to be used in biogas reactors to solve foaming problems....

  2. Analysis of small-scale biogas utilization systems on Ontario cattle farms

    International Nuclear Information System (INIS)

    White, Andrew J.; Kirk, Donald W.; Graydon, John W.

    2011-01-01

    The production of biogas through the anaerobic digestion of cattle manure and its subsequent use in the generation of electricity on larger farms in Ontario is currently economically attractive. This is a result of the Ontario Feed-In Tariff (FIT) program, which provides incentivized rates for the production of electricity from biogas. Although larger farms can take advantage of the higher rates for electricity, there are substantially more smaller farms for which individually designed and engineered biogas systems would be prohibitively expensive. By employing the concept of modular biogas plants, this analysis evaluates the economics of small-scale biogas utilization systems. Dairy farms with at least 33 animals and beef farms with at least 78 animals can operate economically attractive biogas systems. This analysis shows that approximately 9000 additional Ontario cattle farms would be able to take advantage of the FIT program, which would add 120 MW e of renewable energy capacity to the Ontario electrical grid. (author)

  3. Application of biogas for combined heat and power production in the rural region

    International Nuclear Information System (INIS)

    Kozak, T.; Majchrzycka, A.

    2009-01-01

    The paper discusses combined production of heat and power (CHP) from biogas in a small-scale power plant placed in the rural region. Based on power and heat demands of the rural region and biomass supply, the CHP system was selected. Keywords: biogas, cogeneration

  4. MATHEMATIC MODELING IN ANALYSIS OF BIO-GAS PURIFICATION FROM CARBON DIOXIDE

    Directory of Open Access Journals (Sweden)

    Y. A. Losiouk

    2009-01-01

    Full Text Available The paper considers a possibility to involve bio-gas generated at testing grounds of hard domestic garbage in power supply system in the Republic of Belarus. An example of optimization using mathematical modeling of plant operation which is used for bio-gas enrichment is given in the paper. 

  5. Improving biogas yields using an innovative pretreatment concept for conversion of the fiber fraction of manure

    DEFF Research Database (Denmark)

    Biswas, Rajib; Uellendahl, Hinrich; Ahring, Birgitte Kiær

    A new concept to enable economically feasible operation of manure based biogas plants was tested in lab-scale. Wet explosion (WEx) was implemented as treatment of the residual manure fibers separated after the anaerobic digestion process for enhancing the biogas production before reintroducing in...

  6. Hydrogen assisted biological biogas upgrading

    DEFF Research Database (Denmark)

    Bassani, Ilaria

    Wind and biomass are promoted worldwide as sustainable forms of energy. Anaerobic digestion of biomass produces biogas with ∼50−70% CH4 and 30−50% CO2. However, biogas with >90% CH4 content has higher heating value, can be injected into the natural gas grid or used as alternative to natural gas...... as vehicle fuel. Methods currently available for biogas upgrading mainly consists of physicochemical CO2 removal, requiring the use of chemical substances and energy input and, thus, increasing process costs. This PhD project proposes an alternative to existing biogas upgrading technologies, where H2......, produced by water electrolysis, using excess of electricity from wind mills, is coupled with the CO2 contained in the biogas to convert them to CH4. This process is defined as biological biogas upgrading and is carried out by hydrogenotrophic methanogenic archaea that couples CO2 with H2 to produce...

  7. Quantitative estimation of biogas produced from the leaves and stem ...

    African Journals Online (AJOL)

    The concept of using aquatic plants for the production of energy (methane) is gaining attention in tropical and sub-tropical regions of the world, where warm climate is connected to the plant growth throughout the year. This research work investigated the overall quantity of biogas produced by the leaves, stem and the ...

  8. Biogas Application Options within Milk Dairy Cooperatives in Thailand

    DEFF Research Database (Denmark)

    Lybæk, Rikke; Sommart, Kritapon

    2016-01-01

    cooperative, etc. The biogas plant substitutes the use of fossil fuels, and surplus electricity can be exported to the power grid and provide extra income. Local crop farmers and ago-industries could benefit economically from sale of biomass residues to the energy plant. The environment will benefit from e...

  9. Increased biogas production at wastewater treatment plants through co-digestion of sewage sludge with grease trap sludge from a meat processing plant.

    Science.gov (United States)

    Luostarinen, S; Luste, S; Sillanpää, M

    2009-01-01

    The feasibility of co-digesting grease trap sludge from a meat-processing plant and sewage sludge was studied in batch and reactor experiments at 35 degrees C. Grease trap sludge had high methane production potential (918 m(3)/tVS(added)), but methane production started slowly. When mixed with sewage sludge, methane production started immediately and the potential increased with increasing grease trap sludge content. Semi-continuous co-digestion of the two materials was found feasible up to grease trap sludge addition of 46% of feed volatile solids (hydraulic retention time 16d; maximum organic loading rate 3.46 kgVS/m(3)d). Methane production was significantly higher and no effect on the characteristics of the digested material was noticed as compared to digesting sewage sludge alone. At higher grease trap sludge additions (55% and 71% of feed volatile solids), degradation was not complete and methane production either remained the same or decreased.

  10. Biogas Opportunities Roadmap Progress Report

    Energy Technology Data Ex